· x x x. paccar mx engine extended coverage guide - 2010 epa. rev. major component. 72 months /...
TRANSCRIPT
Air Compressor X
Air Inlet Clamps, Hose/Pipe (Before & After Turbocharger) X X
Air Inlet Pipe (Mixer) X X
Air Inlet Pipes (Before & After Turbocharger) X X
Alternator X
Back Pressure Control (BPV) - Air / Fuel Manifold Assembly (Replaceable Filter not Covered): X X
Back Pressure Control Valve - (BPV) (REGEN Valve) X X
Back Pressure Control Valve (BPV) - Control Cylinder X X
Bearings - Camshaft, Connecting rod, and Main caps X
Camshaft X X
Camshaft Follower X X
Charge Air Cooler X X
Charge Air Cooler, Hoses and Pipes X X
Connecting Rods, Caps and Bolts X X
Crankcase Ventilation Assembly X X
Crankshaft X X
Cylinder Block Casting, Main Bearing Caps and Bolts X X
Cylinder Block Expansion Plugs X
Cylinder Block Heater X
Cylinder Head Casting and Bolts X X
Cylinder Head Expansion Plugs X
Cylinder Head Gasket X
Diesel Exhaust Fluid (DEF) Tank X X
Diesel Exhaust Fluid (DEF) Lamp X X
Diesel Exhaust Fluid (DEF) Pump Module X X
Diesel Exhaust Fluid (DEF) Dosing Module with Injection Nozzle X X
Diesel Exhaust Fluid (DEF) Dosing Module - Wiring Harness X X
Diesel Exhaust Fluid (DEF) Solution Level/Temperature Sensor X X
Diesel Exhaust Fluid (DEF) Heater Control Relay X X
Diesel Exhaust Fluid (DEF) Heater Coolant Control Valve X X
Diesel Exhaust Fluid (DEF) Heated Lines (3) X X
Diesel Exhaust Fluid (DEF) Heating Elements X X
Diesel Exhaust Fluid (DEF) Heating Fittings (3 on Supply Module) X X
Diesel Oxidation Catalyst X X
Diesel Particulate Filter (DPF) X X
DPF Air/ Fuel Injector (aka Hydrocarbon Doser Injector) (Requires cleaning at 160k miles) X X
DPF Air/ Fuel Injector Air, Fuel, and Coolant Lines(Hydrocarbon Doser Lines supplied w Engine) X X
DPF Air/ Fuel Manifold Assembly Air, Fuel, and Coolant Lines(Fuel/Air Shutoff Valve) X X
EGR (Exhaust Gas Recirculation) Control Valve X X
EGR (Exhaust Gas Recirculation) Cooler X X
EGR (Exhaust Gas Recirculation) Connecting Bellows & Clamps X X
Electrical Harness Supplied with Engine X
Electronic Control Modules (ECM):
Aftertreatment ECM X X
DEF Dosing ECM X X
Engine ECM (PMCI) X X
Emission System Wiring Harnesses X X
Engine Brake System (PACCAR) X
Exhaust Manifold Casting-Front X X
Exhaust Manifold Casting-Middle X X
Exhaust Manifold Casting-Rear X X
Exhaust Manifold Joint Seals, Gaskets, or Rings X
Exhaust Manifold Wraps or Heat Shields X
Exhaust Piping, Clamps, & Gaskets - (Piping After S-Pipe/High Route Pipe to inlet of SCR w/o Decomp Pipe) X X
Exhaust Piping S-Pipe/High Route Pipe After BPV X X
Exhaust Throttle Valve (aka BPV) X X
Fan Belt Tensioner Assembly & Bracket X
Flywheel X
Flywheel Housing X X
Flywheel Ring Gear X
Fuel Common Rail X X
Fuel Unit Pumps (2) X X
Fuel Hand Primer Pump X
Fuel Lift Pump X
PACCAR MX Engine Quick Reference Guide - 2017 EPAVehicle - 12 Months 100,000 Miles/160,000 Kilometers
Emissions - 60 Months 100,000 Miles/160,000 Kilometers
Major Components - 60 Months 500,000 Miles/800,000 Kilometers/12,500 Hours
Basic Engine - 24 Months 250,000 Miles/400,000 Kilometers/6,250 Hours
Fuel Filter Module X
Fuel Injectors (Cylinder Injectors) X X
Fuel Lines (High Pressure) X X
Fuel Lines (Low Pressure) X X
Gaskets, Seals, O Rings, Silicon Sealant (For Engine Supplied Components) X
Gears - All (Camshaft, Crankshaft, Idlers, and Oil Pump) X X
Hoses and Lines (Supplied with Engine) X
Hydrocarbon Doser Valve (aka Voss valve) X X
Hydrocarbon Doser Injector - (aka DPF Injector) (Requires cleaning at 160k miles) X X
Hydrocarbon Doser Valve - Inline Air Filter X
Hydrocarbon Doser Valve - Air, Fuel, and Coolant Lines X X
Ladder Frame X
Malfunction Indicator Lamp (MIL) X X
Oil Cooler Module (Replaceable Filter Not Covered) X
Oil Fill Tube and Cap X
Oil Pan X
Oil Pump X
Pistons, Rings and Liners X
Power Steering Pump X
Pressure Protection Valve and Plumbing to DPF Fuel Injector (aka BPV valve) X X
Pulleys - Engine Belt X
PTO drive / FEPTO & REPTO (Front and Rear Engine Mounted PTO Drive) X
Rocker Arm Assembly and Shafts X
Selective Catalytic Reduction (SCR) Catalyst X X
Selective Catalytic Reduction (SCR) Decompostion Pipe X X
Selective Catalytic Reduction (SCR) Decompostion Pipe Elbows X X
Sensor, Ambient Air Temp - Engine Only (Not Outside Air Temp) X X
Sensor, Ammonia X X
Sensor, Camshaft (Engine Position) X X
Sensor, Coolant Temperature X X
Sensor, Crankcase Pressure X X
Sensor, Crankshaft Speed (Engine Timing) X X
Sensor, Delta P (DPF Pressure Sensor) X X
Sensor, DOC (Pre) Temperature X X
Sensor, DOC (Post) Temperatue X X
Sensor, DPF Backpressure X X
Sensor, DPF Fuel Pressure X X
Sensor, DPF Air Supply Pressure X X
Sensor, DPF Temperature and Signal Conditioner (aka Temperature Sensor after Turbocharger) X X
Sensor, DPF Pressure (2) X X
Sensor, EGR Differential Pressure X X
Sensor, EGR Temperature X X
Sensor, Engine Oil Pressure and Temperature X X
Sensor, Exhaust Manifold Pressure X X
Sensor, Fuel Pressure and Temperature X X
Sensor, Intake Boost Pressure (aka Intake Manifold & Temperature) X X
Sensor, Intake Temperature X X
Sensor, Intercooler Temperature X X
Sensor, Lambda X X
Sensor, Nox X X
Sensor, Outside Air Temp X X
Sensor, Particulate Matter (PM) X X
Sensor, Pressure After Hydrocarbon Doser Valve (After BPV) X X
Sensor, Pressure/Temperature/Humidity before Turbocharger X X
Sensor, SCR Pre - Temperature X X
Sensor, SCR Post - Temperature X X
Sensor, Turbocharger Speed X X
Sensor, Water Pump Speed X X
Sensor, Water in Fuel (WIF - Engine Mounted) X
Starter X
Thermostat (Coolant) X
Thermostat Housing (Coolant) X X
Towing - To The Nearest Authorized Dealer, or Other PACCAR Authorized Facility X
Turbocharger Assembly X X
Valves, Engine Exhaust and Intake X
Valve Cover X
Vibration Dampers and Bolts X
Wiring Harnesses - Emission System X X
Water Pump Impeller Assembly X
Water Pump Housing X X
PACCAR MX Engine Extended Coverage Guide - 2010 EPA Rev
Major Component
72 Months / 600,000 mi/960,000 km
84 Months / 700,000 mi/1,120,000 km
Vocational
60 Months / 150,000 mi/240,000 km
72 Months / 250,000 mi/400,000 km
84 Months / 250,000 mi/400,000 km
Modified
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Comprehensive
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Aftertreatment (Does not cover Vehicle AFT Components; Must Purch w/Comp. Pkg.)
Requires Comprehensive Coverage to the same time/miles
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Air Compressor
Air Inlet Clamps, Hose/Pipe (Berfore & After Turbocharger)
Air Inlet Pipe (Mixer) X X X
Air Inlet Pipes (Berfore & After Turbocharger) X X X
Back Pressure Control (BPV) - Air / Fuel Manifold Assembly (Replaceable Filter not Covered): X
Back Pressure Control Valve - (BPV) (REGEN Valve) X
Back Pressure Control Valve (BPV) - Control Cylinder X
Bearings - Camshaft, Connecting rod, and Main caps X X X
Camshaft X X X X
Camshaft Follower X X X X
Charge Air Cooler
Charge Air Cooler, Hoses and Pipes
Connecting Rods, Caps and Bolts X X X X
Crankcase Ventilation Assembly X X X
Crankshaft X X X X
Cylinder Block Casting, Main Bearing Caps and Bolts X X X X
Cylinder Block Expansion Plugs X X X
Cylinder Block Heater
Cylinder Head Casting and Bolts X X X X
Cylinder Head Expansion Plugs X X X
Cylinder Head Gasket X X X
Diesel Exhaust Fluid (DEF) Tank
Diesel Exhaust Fluid (DEF) Lamp
Diesel Exhaust Fluid (DEF) Pump Module X
Diesel Exhaust Fluid (DEF) Dosing Module with Injection Nozzle X
Diesel Exhaust Fluid (DEF) Dosing Module - Wiring Harness X
Diesel Exhaust Fluid (DEF) Solution Level/Temperature Sensor
Diesel Exhaust Fluid (DEF) Heater Control Relay
Diesel Exhaust Fluid (DEF) Heater Coolant Control Valve
Diesel Exhaust Fluid (DEF) Heated Lines (3)
Diesel Exhaust Fluid (DEF) Heating Elements
Diesel Exhaust Fluid (DEF) Heating Fittings (3 on Supply Module)
Diesel Oxidation Catalyst (DOC) X
Diesel Particulate Filter (DPF) X
DPF Air/ Fuel Injector (aka Hydrocarbon Doser Injector) (Requires cleaning at 160k miles) X
DPF Air/ Fuel Injector Air, Fuel, and Coolant Lines (Hydrocarbon Doser Lines Supplied w/Eng) X
DPF Air/ Fuel Manifold Assembly Air, Fuel, and Coolant Lines (Fuel/Air Shutoff Valve) X
EGR (Exhaust Gas Recirculation) Control Valve X X X
EGR (Exhaust Gas Recirculation) Cooler X X X
EGR (Exhaust Gas Recirculation) Connecting Bellows & Clamps
Electrical Harness Supplied with Engine X X X
Electronic Control Modules (ECU):
Aftertreatment ECM X
9/9/2013
PACCAR MX Engine Extended Coverage Guide - 2010 EPA Rev
Major Component
72 Months / 600,000 mi/960,000 km
84 Months / 700,000 mi/1,120,000 km
Vocational
60 Months / 150,000 mi/240,000 km
72 Months / 250,000 mi/400,000 km
84 Months / 250,000 mi/400,000 km
Modified
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Comprehensive
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Aftertreatment (Does not cover Vehicle AFT Components; Must Purch w/Comp. Pkg.)
Requires Comprehensive Coverage to the same time/miles
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
9/9/2013
DEF Dosing ECM X
Engine ECM (PMCI) X X X
Emission System Wiring Harnesses (Chassis Aftertreatment Harness, DEF Tank Harness)
Engine Brake System (PACCAR) X X X
Exhaust Manifold Casting-Front X
Exhaust Manifold Casting-Middle X
Exhaust Manifold Casting-Rear XExhaust Manifold Joint Seals, Gaskets, or Rings XExhaust Manifold Wraps or Heat Shield
Exhaust Piping, Clamps, & Gaskets - (Piping From Cobra Pipe After Turbo to Inlet of SCR w/o Decomp Pipe)
Exhaust Throttle Valve (aka DPF Doser and BPV Valve) X
Fan Belt Tensioner Assembly & Bracket
Flywheel X X X
Flywheel Housing X X X X
Flywheel Ring Gear
Front Cover X X X
Fuel Control Valve X X X
Fuel Hand Primer Pump X X X
Fuel Lift Pump X
Fuel Filter Housing X
Fuel Injectors (Cylinder Injectors) X
Fuel Lines (High Pressure) X
Fuel Lines (Low Pressure) X
Fuel Lines (Return) X
Fuel Unit Injection Pumps X
Gaskets, Seals, O Rings, Silicon Sealant X
Gears - All (Camshaft, Crankshaft, Idlers, and Oil Pump) X X X X
Hoses and Lines (Supplied with Engine)
Hydrocarbon Doser Valve (Voss valve) X
Hydrocarbon Doser Injector - (aka DPF Injector) (Requires cleaning at 160k miles) X
Hydrocarbon Doser Valve - Inline Air Filter
Hydrocarbon Doser Valve - Air, Fuel, and Coolant Lines X
Ladder Frame X X X
Oil Cooler Module (Replaceable Filter Not Covered) X X X
Oil Fill Tube and Cap X X X
Oil Pan X X X
Oil Pump X X X
Pistons, Rings and Liners X X X
Power Steering Pump
Pressure Protection Valve and Plumbing to DPF Fuel Injector (aka BPV valve) X
Pulleys - Engine Belt
PTO drive / FEPTO & REPTO (Front and Rear Engine Mounted PTO Drive)
Rocker Arm Assembly and Shafts X X X
PACCAR MX Engine Extended Coverage Guide - 2010 EPA Rev
Major Component
72 Months / 600,000 mi/960,000 km
84 Months / 700,000 mi/1,120,000 km
Vocational
60 Months / 150,000 mi/240,000 km
72 Months / 250,000 mi/400,000 km
84 Months / 250,000 mi/400,000 km
Modified
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Comprehensive
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Aftertreatment (Does not cover Vehicle AFT Components; Must Purch w/Comp. Pkg.)
Requires Comprehensive Coverage to the same time/miles
36 Months / 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months / 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months / 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
9/9/2013
Selective Catalytic Reduction (SCR) Catalyst X
Selective Catalytic Reduction (SCR) Decompostion Pipe X
Selective Catalytic Reduction (SCR) Decompostion Pipe Elbows
Sensor, Ambient Air Temp - Engine Only (Not Outside Air Temp) X X X
Sensor, Camshaft (Engine Position) X X X
Sensor, Coolant Temperature X X X
Sensor, Crankshaft Speed (Engine Timing) X X X
Sensor, Delta P (DPF Pressure Sensor) X
Sensor, DOC (Pre) Temperature X
Sensor, DOC (Post) Temperatue X
Sensor, DPF Backpressure X
Sensor, DPF Fuel Pressure X
Sensor, DPF Air Supply Pressure X
Sensor, DPF Temperature and Signal Conditioner (aka Temperature Sensor after Turbocharger) X
Sensor, DPF Pressure (2) X
Sensor, EGR Differential Pressure X X X
Sensor, EGR Temperature X X X
Sensor, Engine Oil Pressure and Temperature X X X
Sensor, Exhaust Manifold Pressure X X X
Sensor, Fuel Pressure and Temperature X X X
Sensor, Intake Boost Pressure (aka Intake Manifold & Temperature) X X X
Sensor, Intake Temperature X X X
Sensor, Intercooler Temperature X X X
Sensor, Lambda X
Sensor, NOx (2) X
Sensor, Outside Air Temp
Sensor, Pressure After Exhaust Throttle Valve (After BPV) X
Sensor, Pressure/Temperature/Humidity before Turbocharger X X X
Sensor, SCR Pre - Temperature X
Sensor, SCR Post - Temperature X
Sensor, Turbocharger Speed X X X
Sensor, Water Pump Speed X X X
Thermostat (Coolant) X X X
Thermostat Housing (Coolant) X X X X
Towing -To the Nearest Authorized Dealer, or Other PACCAR Authorized Facility
Turbocharger Assembly X
Valves, Engine Exhaust and Intake X X X
Valve Cover X X X
Valve Yokes (Bridge) and Pins X X X
Vibration Dampers and Bolts X X X
Wiring Harnesses - Emission System
Water Pump Impeller Assembly X
Water Pump Housing X X X X
PACCAR MX Engine Extended Coverage Guide - 2013 EPA Rev
Major Component
72 Months // 600,000 mi/960,000 km
84 Months // 700,000 mi/1,120,000 km
Modified
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
72 Months // 250,000 mi/400,000 km
84 Months // 250,000 mi/400,000 km
Comprehensive
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 kmAftertreatment (Does not cover Vehicle AFT Components)
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
Air Compressor X
Air Inlet Clamps, Hose/Pipe (Berfore & After Turbocharger)
Air Inlet Pipe (Mixer) X X
Air Inlet Pipes (Berfore & After Turbocharger) X X
Back Pressure Control (BPV) - Air / Fuel Manifold Assembly (Replaceable Filter not Covered): X
Back Pressure Control Valve - (BPV) (REGEN Valve) X
Back Pressure Control Valve (BPV) - Control Cylinder X
Bearings - Camshaft, Connecting rod, and Main caps X X
Camshaft X X X
Camshaft Follower X X X
Charge Air Cooler
Charge Air Cooler, Hoses and Pipes
Connecting Rods, Caps and Bolts X X X
Crankcase Ventilation Assembly X X
Crankshaft X X X
Cylinder Block Casting, Main Bearing Caps and Bolts X X X
Cylinder Block Expansion Plugs X X
Cylinder Block Heater
Cylinder Head Casting and Bolts X X X
Cylinder Head Expansion Plugs X X
Cylinder Head Gasket X X
Diesel Exhaust Fluid (DEF) Tank
Diesel Exhaust Fluid (DEF) Lamp
Diesel Exhaust Fluid (DEF) Pump Module X
Diesel Exhaust Fluid (DEF) Dosing Module with Injection Nozzle X
Diesel Exhaust Fluid (DEF) Dosing Module - Wiring Harness X
Diesel Exhaust Fluid (DEF) Solution Level/Temperature Sensor
Diesel Exhaust Fluid (DEF) Heater Control Relay
Diesel Exhaust Fluid (DEF) Heater Coolant Control Valve
Diesel Exhaust Fluid (DEF) Heated Lines (3)
Diesel Exhaust Fluid (DEF) Heating Elements
Diesel Exhaust Fluid (DEF) Heating Fittings (3 on Supply Module)
Diesel Oxidation Catalyst (DOC) X
Diesel Particulate Filter (DPF) X
DPF Air/ Fuel Injector (aka Hydrocarbon Doser Injector) (Requires cleaning at 160k miles) X
DPF Air/ Fuel Injector Air, Fuel, and Coolant Lines (Hydrocarbon Doser Lines Supplied w/Eng) X
DPF Air/ Fuel Manifold Assembly Air, Fuel, and Coolant Lines (Fuel/Air Shutoff Valve) X
EGR (Exhaust Gas Recirculation) Control Valve X X
EGR (Exhaust Gas Recirculation) Cooler X X
EGR (Exhaust Gas Recirculation) Connecting Bellows & Clamps
Encapsulated Engine Electrical Harness X X
OEM Engine Harness Installed in Chassis
Electronic Control Modules (ECU):
Aftertreatment ECM X
10/27/2015
PACCAR MX Engine Extended Coverage Guide - 2013 EPA Rev
Major Component
72 Months // 600,000 mi/960,000 km
84 Months // 700,000 mi/1,120,000 km
Modified
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
72 Months // 250,000 mi/400,000 km
84 Months // 250,000 mi/400,000 km
Comprehensive
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 kmAftertreatment (Does not cover Vehicle AFT Components)
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
10/27/2015
DEF Dosing ECM X
Engine ECM (PMCI) X X
Emission System Wiring Harnesses (Chassis Aftertreatment Harness, DEF Tank Harness)
Engine Brake System (PACCAR) X X
Exhaust Manifold Casting-Front X
Exhaust Manifold Casting-Middle X
Exhaust Manifold Casting-Rear XExhaust Manifold Joint Seals, Gaskets, or Rings XExhaust Manifold Wraps or Heat Shield
Exhaust Piping, Clamps, & Gaskets - (Piping from turbocharger to inlet of SCR w/o Decomp Pipe)
Exhaust Throttle Valve (aka DPF Doser and BPV Valve) X
Fan Belt Tensioner Assembly & Bracket
Flywheel X X
Flywheel Housing X X X
Flywheel Ring Gear
Front Cover X X
Fuel Common Rail X
Fuel Common Rail Injection Pump (2) X
Fuel Control Valve X X
Fuel Hand Primer Pump X
Fuel Lift Pump XFuel Filter Module X
Fuel Injectors (Cylinder Injectors) XFuel Lines (High Pressure) X
Fuel Lines (Low Pressure) X
Fuel Lines (Return) X
Gaskets, Seals, O Rings, Silicon Sealant X
Gears - All (Camshaft, Crankshaft, Idlers, and Oil Pump) X X X
Hoses and Lines (Supplied with Engine)
Hydrocarbon Doser Valve (Voss valve) X
Hydrocarbon Doser Injector - (aka DPF Injector) (Requires cleaning at 160k miles) X
Hydrocarbon Doser Valve - Inline Air Filter
Hydrocarbon Doser Valve - Air, Fuel, and Coolant Lines X
Ladder Frame X X
Oil Cooler Module (Replaceable Filter Not Covered) X X
Oil Fill Tube and Cap X X
Oil Pan X X
Oil Pump X X
Pistons, Rings and Liners X X
Power Steering Pump
Pressure Protection Valve and Plumbing to DPF Fuel Injector (aka BPV valve) X
Pulleys - Engine Belt
PTO drive / FEPTO & REPTO (Front and Rear Engine Mounted PTO Drive)
Rocker Arm Assembly and Shafts X X
PACCAR MX Engine Extended Coverage Guide - 2013 EPA Rev
Major Component
72 Months // 600,000 mi/960,000 km
84 Months // 700,000 mi/1,120,000 km
Modified
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
72 Months // 250,000 mi/400,000 km
84 Months // 250,000 mi/400,000 km
Comprehensive
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km 60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 kmAftertreatment (Does not cover Vehicle AFT Components)
36 Months // 300,000 mi/480,000 km; 350,000 mi/560,000 km; 400,000 mi/640,000 km
48 Months // 400,000 mi/640,000 km; 450,000 mi/720,000 km; 500,000 mi/800,000 km
60 Months // 100,000 mi/160,000 km; 200,000 mi/320,000 km; 300,000 mi/480,000 km; 400,000 mi/640,000 km; 500,000 mi/800,000 km
10/27/2015
Selective Catalytic Reduction (SCR) Catalyst X
Selective Catalytic Reduction (SCR) Decompostion Pipe X
Selective Catalytic Reduction (SCR) Decompostion Pipe Elbows
Sensor, Ambient Air Temp - Engine Only (Not Outside Air Temp) X X
Sensor, Ammonia X
Sensor, Camshaft (Engine Position) X X
Sensor, Coolant Temperature X X
Sensor, Crankshaft Speed (Engine Timing) X X
Sensor, Delta P (DPF Pressure Sensor) X
Sensor, DOC (Pre) Temperature X
Sensor, DOC (Post) Temperatue X
Sensor, DPF Backpressure X
Sensor, DPF Fuel Pressure X
Sensor, DPF Air Supply Pressure X
Sensor, DPF Temperature and Signal Conditioner (aka Temperature Sensor after Turbocharger) X
Sensor, DPF Pressure (2) X
Sensor, EGR Differential Pressure X X
Sensor, EGR Temperature X X
Sensor, Engine Oil Pressure and Temperature X X
Sensor, Exhaust Manifold Pressure X X
Sensor, Fuel Pressure and Temperature X X
Sensor, Intake Boost Pressure (aka Intake Manifold & Temperature) X X
Sensor, Intake Temperature X X
Sensor, Intercooler Temperature X X
Sensor, Lambda X
Sensor, NOx (2) X
Sensor, Outside Air Temp
Sensor, Particulate Matter (PM) X
Sensor, Pressure After Hydrocarbon Doser Valve (After BPV) X
Sensor, Pressure/Temperature/Humidity before Turbocharger X
Sensor, SCR Pre - Temperature X
Sensor, SCR Post - Temperature X
Sensor, Turbocharger Speed X X
Sensor, Water Pump Speed X X
Thermostat (Coolant) X X
Thermostat Housing (Coolant) X X X
Towing -To the Nearest Authorized Dealer, or Other PACCAR Authorized Facility
Turbocharger Assembly X
Valves, Engine Exhaust and Intake X X
Valve Cover X X
Valve Yokes (Bridge) and Pins X X
Wiring Harnesses - Emission System
Water Pump Impeller Assembly X
Water Pump Housing X X X
Aftertreatment (Does not cover Vehicle aftertreatment components. Must purchase with an MX Premium or MX PP1 plan)
Major Component
Comprehensive MX PP2
Comprehensive MX PP1
Comprehensive MX Premium
ENGINE COMPONENTSAir Compressor X X
Air Inlet Pipe (Mixer) X X
Air Inlet Pipes (Berfore & After Turbocharger) X X
Bearings - Camshaft, Connecting rod, and Main caps X X X
Camshaft X X X X
Camshaft Follower X X X X
Connecting Rods, Caps and Bolts X X X X
Crankcase Ventilation Assembly X X
Crankshaft X X X X
Crankshaft Seal Ring X X
Cylinder Block Casting, Main Bearing Caps and Bolts X X X X
Cylinder Block Expansion Plugs X X
Cylinder Head Casting and Bolts X X X X
Cylinder Head Expansion Plugs X X
Cylinder Head Gasket X X X
EGR (Exhaust Gas Recirculation) Control Valve X X X
EGR (Exhaust Gas Recirculation) Cooler X X X
Electrical Harness Supplied with Engine X
Engine ECM (PCI) X X X
Engine Brake System (PACCAR) X X
Exhaust Manifold Casting-Front X
Exhaust Manifold Casting-Middle X
Exhaust Manifold Casting-Rear X
Exhaust Manifold Joint Seals, Gaskets, or Rings X
Flywheel X
Flywheel Housing X X
Fuel Common Rail X X
Fuel Unit Pumps (2) X X
Fuel Hand Primer Pump X
Fuel Lift Pump X
Fuel Filter Module X
Fuel Injectors (Cylinder Injectors) X X
Fuel Lines (High Pressure) X
Fuel Lines (Low Pressure) X
Gaskets, Seals, O Rings, Silicon Sealant (For Covered Components) X X X
Gears - All (Camshaft, Crankshaft, Idlers, and Oil Pump) X X X X
Ladder Frame X X
Oil Cooler Module (Replaceable Filter Not Covered) X X X
Oil Fill Tube and Cap X
Oil Pan X X X
Oil Pump X X X
Pistons, Rings and Liners X X X
Rocker Arm Assembly and Shafts X X X
Sensor, Ambient Air Temp - Engine Only (Not Outside Air Temp) X X
Sensor, Camshaft (Engine Position) X X
Sensor, Coolant Temperature X X
Sensor, Crankcase Pressure X X
Sensor, Crankshaft Speed (Engine Timing) X X
Sensor, EGR Differential Pressure X X
Sensor, EGR Temperature X X
Sensor, Engine Oil Pressure and Temperature X X
Sensor, Exhaust Manifold Pressure X X
Sensor, Fuel Pressure and Temperature X X
Sensor, Intake Boost Pressure (aka Intake Manifold & Temperature) X X
Sensor, Intake Temperature X X
Sensor, Intercooler Temperature X X
Sensor, Pressure/Temperature/Humidity before Turbocharger X X
Aftertreatment (Does not cover Vehicle aftertreatment components. Must purchase with an MX Premium or MX PP1 plan)
Major Component
Comprehensive MX PP2
Comprehensive MX PP1
Comprehensive MX Premium
Sensor, Turbocharger Speed X X
Sensor, Water Pump Speed X X
Sensor, Water in Fuel (WIF - Engine Mounted) X X
Thermostat (Coolant) X X
Thermostat Housing (Coolant) X X X
Turbocharger Assembly X X
Valves, Engine Exhaust and Intake X X
Valve Cover X X X
Water Pump Impeller Assembly (Coolant Pump) X X
Water Pump Housing X X X
AFTERTREATMENT COMPONENTSAftertreatment ECM X
Back Pressure Control (BPV) - Air / Fuel Manifold Assembly (Replaceable Filter not Covered): X
Back Pressure Control Valve - (BPV) (REGEN Valve) X
Back Pressure Control Valve (BPV) - Control Cylinder X
Diesel Exhaust Fluid (DEF) Pump Module X
Diesel Exhaust Fluid (DEF) Dosing Module with Injection Nozzle X
Diesel Exhaust Fluid (DEF) Dosing Module - Wiring Harness X
Diesel Oxidation Catalyst (DOC) X
Diesel Particulate Filter (DPF) X
DPF Air/ Fuel Injector (aka Hydrocarbon Doser Injector) (Requires cleaning at 160k miles) X
DPF Air/ Fuel Injector Air, Fuel, and Coolant Lines (Hydrocarbon Doser Lines Supplied w/Eng) X
DPF Air/ Fuel Manifold Assembly Air, Fuel, and Coolant Lines (Fuel/Air Shutoff Valve) X
Exhaust Throttle Valve (aka DPF Doser and BPV Valve) X
Hydrocarbon Doser Valve (Voss valve) X
Hydrocarbon Doser Injector - (aka DPF Injector) (Requires cleaning at 160k miles) X
Hydrocarbon Doser Valve - Air, Fuel, and Coolant Lines X
Pressure Protection Valve and Plumbing to DPF Fuel Injector (aka BPV valve) X
Selective Catalytic Reduction (SCR) Catalyst X
Selective Catalytic Reduction (SCR) Decompostion Pipe X
Sensor, Ammonia X
Sensor, Delta P (DPF Pressure Sensor) X
Sensor, DOC (Pre) Temperature X
Sensor, DOC (Post) Temperatue X
Sensor, DPF Backpressure X
Sensor, DPF Fuel Pressure X
Sensor, DPF Air Supply Pressure X
Sensor, DPF Temperature and Signal Conditioner (aka Temperature Sensor after Turbocharger) X
Sensor, DPF Pressure (2) X
Sensor, Lambda X
Sensor, NOx (2) X
Sensor, Particulate Matter (PM) X
Sensor, Pressure After Hydrocarbon Doser Valve (After BPV) X
Sensor, SCR Pre - Temperature X
Sensor, SCR Post - Temperature X
ITEMS BELOW ARE EXCLUDED FROM EXTENDED WARRANTYEmission System Wiring Harnesses (Chassis Aftertreatment Harness, DEF Tank Harness)
Fan Belt Tensioner Assembly & Bracket
Hoses and Lines (Supplied with Engine)
Power Steering Pump
Pulleys - Engine Belt
PTO drive / FEPTO & REPTO (Front and Rear Engine Mounted PTO Drive)
Sensor, Outside Air Temp
Wiring Harnesses - Emission System