aircraft cabin: water system
TRANSCRIPT
![Page 1: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/1.jpg)
Malaysian Institute of Aviation Technology
PASSENGER WATER
SUPPLY SYSTEM
ATA 38
![Page 2: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/2.jpg)
Malaysian Institute of Aviation Technology Lavatory
![Page 3: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/3.jpg)
Malaysian Institute of Aviation Technology
PASSENGER WATER SUPPLY SYSTEM
ATA 38 # to supply water for drinking to galleys must be high standard of cleanliness and quality.
# for hand wash basin
# for galleys system and making hot beverages
# humiditifier
# aircond pack heat exchanger additional cooling
# water / methanol injection to engines
![Page 4: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/4.jpg)
Malaysian Institute of Aviation Technology
PASSENGER WATER SUPPLY SYSTEM
# Can be one or two water systems in an aircraft.
# Galleys and toilet compartments water allow to drain to atmosphere
(drain mask) or toilet waste tank
# Drain Masks are electrically heated.
# Waste water is finely atomised as it leaves the drain mask.
# Drinking water name - Potable Water:
- storage - heating - cooling (drinking fountain)
- distribution (piping and pressurized)
![Page 5: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/5.jpg)
Malaysian Institute of Aviation Technology
Passenger Water System
![Page 6: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/6.jpg)
Malaysian Institute of Aviation Technology
![Page 7: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/7.jpg)
Malaysian Institute of Aviation Technology
![Page 8: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/8.jpg)
Malaysian Institute of Aviation Technology
![Page 9: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/9.jpg)
Malaysian Institute of Aviation Technology
![Page 10: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/10.jpg)
Malaysian Institute of Aviation Technology Lavatory
![Page 11: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/11.jpg)
Malaysian Institute of Aviation Technology
![Page 12: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/12.jpg)
Malaysian Institute of Aviation Technology
![Page 13: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/13.jpg)
Malaysian Institute of Aviation Technology
![Page 14: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/14.jpg)
Malaysian Institute of Aviation Technology
![Page 15: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/15.jpg)
Malaysian Institute of Aviation Technology
PASSENGER WATER SUPPLY SYSTEM
• Tank -fiberglass reinforced plastic
- older aircraft stainless steel.
• Warm air from aircond system use to prevent tank
water freezing, or fitted with an electric heater blanket
or ribbon heaters. Single phase ac supply via a CB
and thermostat(prevent over heating)
• situated below the cabin floor.
• 747 322litres 2tanks, filled from own external
passenger water service panel.
![Page 16: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/16.jpg)
Malaysian Institute of Aviation Technology
![Page 17: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/17.jpg)
Malaysian Institute of Aviation Technology
Water Tank Heating System
![Page 18: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/18.jpg)
Malaysian Institute of Aviation Technology
Water pressure control
- tank is pressurized by the engine bleed air and use an electrically driven compressor automatically start when the pneumatic pressure falls below a predetermined value.
- a paper element filter, a pressure regulator to reduce the air pressure to about 30 lbs/sq.in and a pressure relief valve.
![Page 19: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/19.jpg)
Malaysian Institute of Aviation Technology
![Page 20: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/20.jpg)
Malaysian Institute of Aviation Technology
![Page 21: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/21.jpg)
Malaysian Institute of Aviation Technology
![Page 22: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/22.jpg)
Malaysian Institute of Aviation Technology
WATER SYSTEM DISTRIBUTION
- Main water distribution line runs from the tank into the space above the cabin ceiling individual supply
lines go to the galleys and toilets.
- Distribution line are usually of reinforced
plastic tubing enclosed in an aluminum
shroud to prevents leaking water dripping
on to the ceiling.
- A quick disconnect fitting is located above
each toilet and galley to allow the water
supply line to be disconnected when the
toilet or galley is to be removed.
![Page 23: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/23.jpg)
Malaysian Institute of Aviation Technology
![Page 24: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/24.jpg)
Malaysian Institute of Aviation Technology
![Page 25: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/25.jpg)
Malaysian Institute of Aviation Technology
DRINKING WATER COOLING
• Drinking fountain require cooling.
• Water temperature control at below 10 degree C by a
200V 3phase ac motor fan which will be on and drive
a fan and blows air across the Thermoelectric units
and reduce the temperature of water.
• Motor is control by Thermal Switch.
• Transformer rectifier switch is used to change the
115v ac to 28v for use by Thermo-eletric units.
• Should the control switch failed an Over Heat Switch
will break the circuit at higher temperature.
![Page 26: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/26.jpg)
Malaysian Institute of Aviation Technology
Water tank and associated line must be drained if aircraft is to be park for a long periods in cold to avoid damage caused by frozen pipes and all weather switch.
A vent valve to prevent vapor lock occurring In the wash basin taps by opening the tap lines to atmosphere.
WATER HEATING SYSTEM
![Page 27: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/27.jpg)
Malaysian Institute of Aviation Technology
Water Cooler
![Page 28: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/28.jpg)
Malaysian Institute of Aviation Technology
DRINKING WATER COOLIONG
![Page 29: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/29.jpg)
Malaysian Institute of Aviation Technology
![Page 30: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/30.jpg)
Malaysian Institute of Aviation Technology
![Page 31: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/31.jpg)
Malaysian Institute of Aviation Technology
Hot Water
Heating System
![Page 32: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/32.jpg)
Malaysian Institute of Aviation Technology
![Page 33: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/33.jpg)
Malaysian Institute of Aviation Technology
WATER HEATING
• A water heater with a capacity of about 1.7 liters is installed under each toilet sink in the supply
plumbing to the hot water tank.
• Heating the water to -
110-120 degree F(43-49degree C).
• Heater contains electrical elements inserted on the bottom of the tank.
• The heater can be isolated from the portable water system if it should require replacement.
Heater Tank has:
# on warning light # on / off control switch
# overheat reset switch # pressure relief valve.
# supply and feed connection
![Page 34: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/34.jpg)
Malaysian Institute of Aviation Technology
WATER HEATING • Heater switch on a light will illuminate and a “Cyclic
Switch” will regulate water temperature at 50 degree C.
• If “Cyclic Switch” malfunction and water reach
90 degree C the “Over Heat” switch will
operate to switch off the heater and light.
- After cooling heater can be manually reset
by pressing a button on top of the water heater.
- Reset switch cover with rubber “Bubble”.
- A core plug type pressure relief valve is fitted
to relief excessive pressure due to “Over Heat”.
- Heater can be isolated from the system for
replacement.
![Page 35: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/35.jpg)
Malaysian Institute of Aviation Technology
WATER CONTENTS GAUGE - IN GALLEY AND SERVICE PANELS
- Gallons or Litres
![Page 36: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/36.jpg)
Malaysian Institute of Aviation Technology
Water Tank Contents Measurement System
![Page 37: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/37.jpg)
Malaysian Institute of Aviation Technology
![Page 38: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/38.jpg)
Malaysian Institute of Aviation Technology
![Page 39: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/39.jpg)
Malaysian Institute of Aviation Technology
WATER CONTENTS GAUGE
• Located at lower fuselage water service panels,
attendants panels and galleys.
• Gauge feed from float and electrical transmitter.
• Transmitter is a probe which is a REED Switches,
as float/magnets moves pass a reed switch it
closes and this signal is sent to signal conditional
for transmission. (next slide)
![Page 40: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/40.jpg)
Malaysian Institute of Aviation Technology
![Page 41: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/41.jpg)
Malaysian Institute of Aviation Technology
Replenishment
• After each flight, be full or if less passenger
lesser quantity.
• To vent tank pressure air before open fill valve a
handle is pulled.
• In cold condition when aircraft need to park for
longer period/ over night water system need to
be drained to prevent fractures caused by
Frozen Lines.
• Tank with a vent valve to prevent vapour lock.
![Page 42: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/42.jpg)
Malaysian Institute of Aviation Technology
HEALTH PROTECTION
• Water System is susceptible to bacterial contamination.
• Having high standard of cleanliness during servicing
operation is important and need to apply very high
Hygiene Standards
• Once water systems has been disturbed during
maintenance it has to be sterilized.
• The Sterilize Solution ( chlorine)
is added to the flow of water during filling operation
sign of puregene in water is Milky colour with
chlorinated smell, left in system for some time
then fully flushed before water is refilled.
![Page 43: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/43.jpg)
Malaysian Institute of Aviation Technology
![Page 44: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/44.jpg)
Malaysian Institute of Aviation Technology
HEALTH PROTECTION -process
• Require disinfected at intervals as per AMM.
• After disinfected system is emptied and refilled with
Chlorinated Water
Disinfecting Passenger System
A. General.
• As per following:
A. 50 parts per million of chlorine acidified with vinegar
B. 100 PPM of chlorine - not acidified
C. 50 PPM of chlorine – not acidified
Note: Disinfection time for A & B is 1 hour. C is 4 hrs.
![Page 45: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/45.jpg)
Malaysian Institute of Aviation Technology
Disinfecting Passenger System
2. Recommended chlorine solution (concentrated)
- 50 PPM of acidified chlorine solution added to 30-
gallons water tank.
- This will minimize the objectionable taste due to
disinfectants and requires only shorter disinfecting time.
a. 9 fluid ounces(266ml) chlorine dioxide stabilized 2 %.
b. 9 fluid ounces (266ml) acetic acid(vinegar)
c. Approximately 1 gallon(4 litres) clean water.
Note: Let mixture stand for 5 minutes to complete
activity
•
![Page 46: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/46.jpg)
Malaysian Institute of Aviation Technology
Disinfecting Passenger System
B. Remove all filter cartridge from water system
and Re-installed filter cap.
- Excessive amount of disinfectant gave an
objectionable taste of chlorine water.
(A2 minimized)
C. Drain system as per AMM.
![Page 47: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/47.jpg)
Malaysian Institute of Aviation Technology
Disinfecting Aircraft Passenger Water System
D. Fill system with chlorinated water contains
50 or 100 PPM of chlorine.
1. Water chlorinated in 3 ways.
a. Concentrated chlorine solution be introduced first
and then system fill with water.
b. Concentrated chlorine mixed with drinkable water
first then pumped into system.
c. Concentrated solution may be added while
system is being filled.
![Page 48: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/48.jpg)
Malaysian Institute of Aviation Technology
SERVICING SYSTEM
• Water service point located under aircraft
fuselage below the tank.
• But away from Toilet Servicing panel.
• Water flow under pressure from Tank Rig.
• When tank reach full water overflow from
Over Flow Port or near water service panel.
• Tank draining point at bottom of system
![Page 49: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/49.jpg)
Malaysian Institute of Aviation Technology
![Page 50: Aircraft Cabin: Water System](https://reader034.vdocuments.net/reader034/viewer/2022042521/554a3704b4c905863d8b45b9/html5/thumbnails/50.jpg)
Malaysian Institute of Aviation Technology
END OF WATER SYSTEM