50gcq 04-06 weathermaster series high ...2001/04/06 · • thru-the-bottom power entry capability...
Post on 15-Nov-2020
1 Views
Preview:
TRANSCRIPT
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.Printed in U.S.A. Form 50GCQ-4-6-01SB Pg 1 10-2020 Replaces: NEW
50GCQ 04-06 WEATHERMASTER® SERIES HIGH EFFICIENCY SINGLE PACKAGE
ROOFTOPHEAT PUMP, WITH FIELD-INSTALLED ELECTRIC HEAT, PURON® (R-410A)
REFRIGERANT
— PERFORMANCE DATA
— CERTIFIED DIMENSION PRINTS
— CERTIFIED ROOF CURB DETAILS
2
JOB NAME: LOCATION:
BUYER: BUYER PO #: CARRIER#:
UNIT NUMBER: MODEL NUMBER:
PERFORMANCE DATA CERTIFIED BY:
DESCRIPTION
50GCQ units are high-efficiency, single-packaged heat pump units with Ecoblue™ Technology that are pre-wired and pre-charged with Puron® refrigerant. Electric heat is available as a field-installed accessory. The units are fully factory tested andagency certified. These units have field convertible supply and return openings and are intended for installation on a roof curbaccessory (ordered separately), or for slab mounting (for horizontal duct connections). Units may be ordered with variousfactory-installed options. Field-installed accessories are also available.
FEATURESStandard Base Unit• Puron® (R-410A) HFC refrigerant• SEERs up to 16.2• HSPFs up to 8.3 (COPs to 3.9)• ASHRAE 90.1 compliant and Energy Star qualified • Rated in accordance with AHRI Standards 210/240• Designed in accordance with Underwriters
Laboratories Std 1995• Listed by UL and UL-Canada• Non-corrosive composite sloping design; side or center
drain condensate pan. Meets ASHRAE Standard 62• Two-stage cooling capacity control on all models• Standard cooling operating range up to 125°F (52°C)
and down to 40°F (4°C). • Convertible from vertical to horizontal airflow for slab
mounting• Two-inch disposable return air filters• Thru-the-bottom power entry capability• Single point electric connections on field-installed
electric heat units• 24-volt control circuit protected with resettable circuit
breaker and 75-VA transformer• Direct Drive - EcoBlue ™ Technology indoor fan sys-
tem uses Vane Axial fan design and electronically com-mutated motor. Multi speed design
• Totally enclosed condenser motors with permanently lubricated bearings
• State-of-the-art defrost control board, easily configured for defrost cycles of 30, 60, 90, or 120 minutes
• New Unit Control Board with intuitive quick fan adjustment
• Loss of charge, high-pressure, and freeze protection switches
• Full perimeter base rail with built-in rigging adapters and fork truck slots
Cabinet• Access panels with easy grip handles and replaceable
no-strip screw collar• Pre-painted exterior panels and primer-coated interior
panels tested to 500 hours salt spray protection• Fully insulated cabinet• Tool-less filter access doorRefrigerant System• TXV refrigerant metering system on all models• Liquid line filter drier• Scroll compressors with internal line-break overload
protection• Indoor and outdoor coils constructed of aluminum fins
mechanically bonded to seamless copper tubes• Removable gauge line plugs for reading refrigerant
pressure with unit panels in place• Four-way reversing valve operation• Suction Line Accumulator standard - prevents exces-
sive liquid flood back of refrigerant to the compressor even during the start of the defrost cycle
Standard Limited Parts Warranty• 5-year electric heater (field-installed)• 3-year SystemVu Controller• 5-year compressor • 1-year parts
3
PERFORMANCE DATAUnit Operating Weight ____________________________ lbCurb Weight ____________________________________ lbCOOLINGNet Total Capacity _____________________________ BtuhNet Sensible Capacity ___________________________ BtuhCompressor Power Input _________________________ kW
at Outdoor Air Temperature ______________________ °FIndoor Entering: db __________ °F / wb ____________ °FAirflow _____ CFM External Static Pressure _______ in. wg
HEATINGHeating Capacity:Power Input to Unit _____________________________ kWIntegrated Capacity ____________________________ BtuhIndoor Operating Air Temperature ________________ °F dbOutdoor Air Temperature ____________ °F (Winter Design)Rating at 70% R. H. Outdoors ________ kW Heater selected
________________________________ Heat/Cool Ratio Electrical Capacity Required _____________________ Btuh
ELECTRICAL DATA
Power Supply to Unit ____________________________________Volts _________________________________________________Phase _________________________________________________HzMinimum Circuit Amps __________________________________Maximum Overcurrent Protection (fuse only) ________________
SUBMITTAL DATAJob Name _____________________________________________Architect ______________________________________________Engineer _____________________________________________Contractor _____________________________________________Unit Designation ________________________________________
4
FACTORY-INSTALLED OPTIONS
Economizer with DRY BULB Sensing and BarometricReliefULTRA LOW LEAK Air Dampers —
Models with W7220 controller meet California Title24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er X system).Models with RTU Open controller meet California Ti-tle 24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er 2 system).
Economizer with ENTHALPY Sensing and BarometricReliefULTRA LOW LEAK Air Dampers —
Models with W7220 controller meet California Title24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er X system).Models with RTU Open controller meet California Ti-tle 24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1-2013) requirements — plus 5-year lim-ited parts warranty (EconoMi$er 2 system).
HACR Breaker Foil Faced Insulation MERV 8 Filters
SystemVu ControlsLarge full text - multi line displayUSB Flash Port for data transferBuilt in i-Vu®, CCN and BACnetRefrigerant pressure from displayQuick LED Status - Run, Alert, FaultConventional stat or sensor capabilitiesHistorical component runtime and startsSupply Air TemperingEquipment / System Touch CompatibilityDemand Limiting and ZS Sensor Compatibility
RTU Open multi-protocol controller communicates toLonWorks1, MODBUS2, BACnet3, and Johnson N2protocols
Through-the-base connectors for electric conduit Non-fused disconnect (80A max) Powered 115-volt convenience outlet Non-powered 115-volt convenience outlet High static evaporator fan motor Return air smoke detector Supply air smoke detector Smoke detectors — return and supply air Pre-coated Al/Cu condenser coil E-coated Al/Cu condenser coil E-coated Al/Cu condenser and evaporator coil Cu/Cu condenser coil Cu/Cu condenser coil and evaporator coil Condenser hail guard - louvered style4
CO2 sensor Hinged access doors Condensate overflow switch Phase Monitor/Protection
Optional Warranties Complete unit parts only, up to 5 years Complete unit parts and labor, up to 5 years
Many other optional warranties are available. See theCommercial Start-Up and Optional Extended WarrantyPrice pages for further information.
1. LonWorks is a registered trademark of Echelon Cor-poration.
2. MODBUS is a registered trademark of Schneider Electric.
3. BACnet is a registered trademark of ASHRAE (Ameri-can Society of Heating, Refrigerating and Air-Condi-tioning Engineers).
4. Not available on single phase (–3) voltage models.
5
FIELD-INSTALLED ACCESSORIES
Economizer with DRY BULB Sensing and BarometricRelief 1Standard Leak Air Dampers —
Models with W7212 controller provide standard non-di-agnostic control (EconoMi$er IV system).Models with W7220 controller meet California Title 24(Section 120.2) Fault Detection and Diagnostic (FDD)requirements (EconoMi$er X system).Models with RTU Open controller meet California Title24 (Section 120.2) Fault Detection and Diagnostic(FDD) requirements (EconoMi$er 2 system).
Economizer with ENTHALPY Sensing and BarometricRelief 1Standard Leak Air Dampers —
Models with W7212 controller provide standard non-di-agnostic control (EconoMi$er IV system).Models with W7220 controller meet California Title 24(Section 120.2) Fault Detection and Diagnostic (FDD)requirements (EconoMi$er X system).Models with RTU Open controller meet California Title24 (Section 120.2) Fault Detection and Diagnostic(FDD) requirements (EconoMi$er 2 system).
Economizer with DRY BULB Sensing and BarometricRelief 1ULTRA LOW LEAK Air Dampers —
Models with W7220 controller meet California Title24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er X system).Models with RTU Open controller meet California Ti-tle 24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er 2 system).
Economizer with ENTHALPY Sensing and BarometricRelief 1ULTRA LOW LEAK Air Dampers —
Models with W7220 controller meet California Title24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er X system).Models with RTU Open controller meet California Ti-tle 24 (section 120.2) Fault Detection and Diagnostic(FDD) requirements, have return, outside air and reliefdamper leakage that meet Title 24 (section 140.4 andASHRAE 90.1) requirements — plus 5-year limitedparts warranty (EconoMi$er 2 system).
Power exhaust — vertical or horizontal Electric heat Single point kitTwo-position motorized outdoor air damperManual outside air damper 25%Manual outside air damper 50%Roof curb — 14 inch (356 mm) tallRoof curb — 24 inch (610 mm) tall
Thru-the-bottom utility connection kit Time Guard II compressor anti-cycle protection Thru-the-bottom connections, electrical and gas Outdoor coil hail guard — louvered style Programmable setback thermostat Phase monitor (loss of phase/phase reversal) Thermostats and Sensors Condensate overflow switch
Economizer SensorsSingle dry bulb controlDifferential dry bulb controlSingle enthalpy controlDifferential enthalpy controlCO2 — wall mountedCO2 — duct mountedCO2 — unit mounted20 Amp non powered convenience outlet
1. Not available for single phase (-3 voltage) models.
6
UN
IT D
IME
NS
ION
PR
INT
Fig
. 1 —
50G
CQ
* 04
-06
Bas
e U
nit
Dim
ensi
on
s
7
UN
IT D
IME
NS
ION
PR
INT
Fig
. 1 —
50G
CQ
* 04
-06
Bas
e U
nit
Dim
ensi
on
s (c
on
t)
8
UN
IT D
IME
NS
ION
PR
INT
Fig
. 1 —
50G
CQ
* 04
-06
Bas
e U
nit
Dim
ensi
on
s (c
on
t)
9
AC
CE
SS
OR
Y D
IME
NS
ION
S P
RIN
T
Fig
. 2 —
50G
CQ
* 04
-06
Ro
of
Cu
rb D
imen
sio
ns
EE
7/16
"[1
1]
4 9/
16"
[115
.5]
1/4"
[7.0
]
5' 7
-3/8
"[1
711.
3]
1' 4
-13/
16"
[4
27] I
NSI
DE
1-3/
4"[4
4.4]
2-3/
8"[6
1]
1-3/
4"[4
4.5]
1.00
"[2
5.4]
"A"
1-3/
4"[4
4.4]
21.7
4"[5
52.2
]5.42
"[1
37.7
]11
.96"
[303
.8]
4.96
"[1
26.0
]70
.87"
[180
0.2]
40.6
9"[1
033.
5]
21.8
4"[5
54.7
]
16.0
3"[4
07.2
]
1.75
"[4
4.5]
20.4
1"[5
18.3
]3.
00"
[76.
2]13
.78"
[350
.0]
14.0
0"[3
55.6
]
3.00
"[7
6.2]
15.1
9"[3
85.8
]
32.1
9"[8
17.6
]
3'-1
3/1
6"[9
44.6
]
"A"
1-3/
4"[4
4.5]
CR
BTM
PWR
001A
013/
4" [1
9] N
PT3/
4" [1
9] N
PT1/
2" [1
2.7]
NPT
CR
RFC
UR
B002
A01
CO
NN
ECTO
R P
KG. A
CC
.G
AS C
ON
NEC
TIO
N T
YPE
GAS
FIT
TIN
GPO
WER
WIR
ING
FI
TTIN
GC
ON
TRO
L W
IRIN
G
FITT
ING
ACC
ESSO
RY
CO
NVE
NIE
NC
E O
UTL
ET W
IRIN
G C
ON
NEC
TOR
THR
U T
HE
CU
RB
1/2"
[12.
7] N
PT1/
2" [1
2.7]
NPT
CR
BTM
PWR
003A
01TH
RU
TH
E BO
TTO
M
RO
OF
CU
RB
ACC
ESSO
RY
#A
CR
RFC
UR
B001
A01
14"
[356
]
24"
[610
]
ECN
NO
.AP
P'D
CH
K'D
BYD
ATE
REV
ISIO
N R
ECO
RD
REV
1067
898
--
MM
C04
/22/
13O
VER
ALL
DIM
. 5'-7
3/8
" WAS
5'-7
7/8
; 18G
A M
ATER
IAL
WA
16 G
A.; N
AIL
FIEL
D S
UPP
LIED
WAS
W
ITH
CU
RB
A
DR
AWIN
G R
ELEA
SE L
EVEL
:PR
OD
UC
TIO
NTH
IRD
AN
GLE
PRO
JEC
TIO
N
UN
LESS
OTH
ERW
ISE
SPEC
IFIE
DD
IMEN
SIO
NS
ARE
IN IN
CH
ESTO
LER
ANC
ES O
N:
1 D
EC2
DEC
3 D
ECAN
GM
ATER
IAL
--
--
- - -
AUTH
OR
IZAT
ION
NU
MBE
RTI
TLE
1041
738
CU
RB
ASY,
RO
OF
ENG
INEE
RIN
GM
ANU
FAC
TUR
ING
ENG
INEE
RIN
G R
EQU
IREM
ENTS
--
--
SIZE
DR
AWIN
G N
UM
BER
REV
T-00
5, Y
-002
DR
AFTE
RC
HEC
KER
D48
TC40
0427
BW
EIG
HT:
-M
MC
06/1
7/11
--
SHEE
T 5
OF
5
SUR
FAC
E FI
NIS
HM
FG/P
UR
CH
MO
DEL
(IN
TER
NAL
USE
ON
LY)
NEX
T D
RAW
ING
SCAL
ED
ISTR
IBU
TIO
N
-PU
RC
H-
N/A
MM
C
NO
TES:
1. R
OO
FCU
RB
ACC
ESSO
RY
IS S
HIP
PED
DIS
ASSE
MBL
ED.
2. IN
SULA
TED
PAN
ELS:
25.
4 [1
"] TH
K. P
OLY
UR
ETH
ANE
FOAM
, 44.
5 [1
-3/4
] # D
ENSI
TY.
3. D
IMEN
SIO
NS
IN [
] AR
E IN
MIL
LIM
ETER
S.4.
RO
OFC
UR
B: 1
8 G
AGE
STEE
L.5.
ATT
ACH
DU
CTW
OR
K TO
CU
RB.
(FLA
NG
ES O
F D
UC
T R
EST
ON
CU
RB)
.6.
SER
VIC
E C
LEAR
ANC
E 4
FEET
ON
EAC
H S
IDE.
7.
DIR
ECTI
ON
OF
AIR
FLO
W.
8. C
ON
NEC
TOR
PAC
KAG
E C
RBT
MPW
R00
1A01
IS F
OR
TH
RU
-TH
E-C
UR
B G
AS T
YPE
PA
CKA
GE
CR
BTM
PWR
003A
01 IS
FO
R T
HR
U-T
HE-
BOTT
OM
TYP
E G
AS C
ON
NEC
TIO
NS.
TYPI
CAL
(4) S
IDES
SUPP
LY A
IRR
ETU
RN
AIR
RO
OFI
NG
MAT
ERIA
L(F
IELD
SU
PPLI
ED)
CAN
T ST
RIP
(FIE
LD S
UPP
LIED
)
RO
OFI
NG
FEL
T(F
IELD
SU
PPLI
ED)
CO
UN
TER
FLA
SHIN
G(F
IELD
SU
PPLI
ED)
UN
ITG
ASKE
T(S
UPP
LIED
WIT
H C
UR
B)
RIG
ID IN
SULA
TIO
N(F
IELD
SU
PPLI
ED)
DU
CT
(FIE
LD S
UPP
LIED
)
NAI
L (F
IELD
SU
PPLI
ED)
CER
TIFI
ED D
RAW
ING
VIEW
"B"
CO
RN
ER D
ETAI
L
SEE
VIEW
"B"
RET
UR
N A
IRSU
PPLY
AIR
SUPP
LY A
IRO
PEN
ING
RET
UR
N A
IRO
PEN
ING
GAS
SER
VIC
E PL
ATE
THR
U T
HE
CU
RB
DR
ILL
HO
LE
2"
[50.
8] @
AS
SEM
BLY
(IF
REQ
UIR
ED)
(SEE
NO
TE #
8)
SEE
NO
TE #
2
11 3
/4"[2
98.5
] WID
EIN
SULA
TED
DEC
K PA
NEL
S
8 9/
16"[2
17.5
] WID
EIN
SULA
TED
DEC
K PA
NEL
1/3/
4"[4
4.5]
SCAL
E 0
.250
E-E
SEC
TIO
N
Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations.Printed in U.S.A. Form 50GCQ-4-6-01SB Pg 10 10-2020 Replaces: NEW
© 2020 Carrier
top related