bateria dgc100
TRANSCRIPT
-
7/28/2019 Bateria DGC100
1/2
L
HHT
W
RECHARGEABLE
DCG 12-10012 Volt 100 A.H. @20-hr.rateto1.80V
94 A.H. @10-hr.rateto1.80V
POWER-GEL SERIES
GELBATTERY
Power-Sonic Corporation
BA T
TERY
MUSTBERE
CY C L ED
Pb
NONSPILLABLE
www.power-sonic.com
MH20845
20mm
7mm
M8
Tolerances are +/- 0.04 in. (+/- 1mm) and +/- 0.08 in. (+/- 2mm)
for height dimensions. All data subject to change without notice.
Physical Dimensions: in(mm)
Features
Thixotropic gel electrolyte for enhanced performance
Valve regulated, spill proof construction allows safe
operation in any position
Superior capabilities
Power/volume ratio yielding unrivaled energy density
Rugged ABS plastic (UL94-HB) case and cover
Approved for transport by air. D.O.T., I.A.T.A., F.A.A. a
C.A.B. certied
U.L. recognized - MH 20845
CE compliant
www.power-sonic.co ensure safe and efficient operation always refer to the latest edition of our Technical Manual, as published on our website.l data subject to change without notice.
Terminals (mm)
T11: Threaded insert
w. 8 mm stud fastener
Performance Specifications
Nominal Voltage ............................................................................ 12 volts (6 ce
Nominal Capacity
20-hr. (5.0A to 10.5 volts) ............................................................ 100.0
10-hr. (9.4A to 10.5 volts) .............................................................. 94.0
5-hr. (16.5A to 10.5 volts) ............................................................ 82.5
3-hr. (24.5A to 10.5 volts) ............................................................ 73.5
1-hr. (57.5A to 9.0 volts) .......... ........... .......... .......... ........... .......... .. 57.5
Approximate Weight ................................................................ 69.5 lbs. (31.5
Energy Density (20-hr. rate) ..................................... 1.53 W-h/in3 (93.19 W-
Specic Energy (20-hr. rate) ................................ 16.23 W-h/lb (35.78 W-h/
Internal Resistance (approx.) ......................................................... 4.0 millioh
Shelf Life (% of nominal capacity at 68F (20C))
1 Month ...................................................................................................... 9
3 Months ..................................................................................................... 9
6 Months .................................................................................................... 8
Operating Temperature Range
Charge .. ........................................................... -4F (-20C) to 122F (50
Discharge ....................................................... -40F (-40C) to 140F (60
Case .....................................................................................ABS Plastic (UL94
Recommended Power-Sonic Chargers .............................................................
L: 12.99 (330) W: 6.81 (173) H: 8.35 (212) HT: 8.66 (220)
DCG12-100 12 Volt 100 AH@ 20-hr. rate94 AH@ 10-hr. rate
-
7/28/2019 Bateria DGC100
2/2CORPORATE OFFICE 7550 Panasonic Way San Diego, CA 92154 USA Tel: +1-619-661-2020 Fax: +1-619-661-3650
Charging
ycle Applications: Limit initial current to 30A. Charge until battery voltage (under
harge) reaches 13.90 to 14.20 volts at 68F (20C). Hold at 13.90 to 14.20
olts until current drops to under 1000mA. Battery is fully charged under these
onditions, and charger should be disconnected or switched to oat voltage.
Float or Stand-By Service: Hold battery across constant voltage source of 13.50
o 13.80 volts continuously. When held at this voltage, the battery will seek its own
urrent level and maintain itself in a fully charged condition.
ote: Due to the self-discharge characteristics, it is imperative that they be charged
ithin 6 months of storage, otherwise permanent loss of capacity might occur as a
esult of sulfation.
Chargers
ower-Sonic offers a wide range of chargers suitable for batteries up to 100AH.
lease refer to the Charger Selection Guide in our specication sheets for C-Series
witch Mode Chargers and Transformer Type A and F Series. Please contact our
echnical department for advice if you have difculty in locating suitable models.
Capacity
RetentionRatio(%)
Standing Period (Months)
100
80
60
40
0
0 2 4 6 8 10 12 14 16 18 20
40oC
(104oF)
30oC(86
oF)
20oC
(68oF)
5oC
(41oF)
Chargingis notnecessary unless100% of capacityis required.
Charging beforeuse is necessaryto help recoverfull capacity.
Chargemay fail
to restore fullcapacity. Do notlet batteries reachthis state.
100
80
60
40
20
0
0 1 2 3 4
Ambient Temperature 20C (68F)
Float Charging Voltage2.25 - 2.30 V/Cell
Retention
Capacity(%)
Years
Capacity(%)
120
500
100%DOD
50%DOD
30%DOD
20%DOD
1000 1500 2000 2500 30
100
80
60
40
20
0
Number of Cycles (Time)
Discharge Characteristics
Discharge Time vs. Discharge Current
Shelf Life & Storage
Life Characteristics in Stand-By Use
Life Characteristics in Cyclic Use
Further Information
Please refer to our website www.power-sonic.com for a complete range of usdownloads, such as product catalogs, material safety data sheets (MSDS), I
certication, etc..
CUSTOMER SERVICE
Tel: +1-619-661-2030
Fax: +1-619-661-3648
INTERNATIONAL SALES
Tel: +1-650-364-5001
Fax: +1-650-366-3662
DOMESTIC SALES
Tel: +1-619-661-2020
Fax: +1-619-661-3650
TECHNICAL SUPPORT
Tel: +1-619-661-2020
Fax: +1-619-661-3648
Contact Information www.power-sonic.co
06
DCG12-100 12 Volt 100 AH@ 20-hr. rate, 94 AH@ 10-hr.
10
9
8
7
6
54
3
2
60504030
20
10
8
6
0 2 5 7 8.5 9.5 11.5 15 26 60 100 150
DischargeTime
Discharge Current (A)
min
h
0C
(32F)
40C
(104F)
25C
(77F)
13
12
11
10.8
10.5
9.6
9
7.8
Load
ing
Voltage(V)
Discharge Time
0 3
min h
35 510 10 2016 30 60 2
100A 57.5A
24.5A 16.5A
9.4A5.0A