commercial gas water heaters smith bt… · bth-120/150/199/250 series 100 & 101 installation -...
TRANSCRIPT
COMMERCIAL GAS WATER HEATERSInstruction Manual
PRINTED 1012 197727-003
PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.
����������� ������������������������������������������������������������������������������
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
MODELSBTH-120/150/199/250
SERIES 100 & 101INSTALLATION - OPERATION - SERVICE - MAINTENANCE - LIMITED WARRANTY
WARNING: If the information in theseinstructions is not followed exactly, a fireor explosion may result causing propertydamage, personal injury or death.
Do not store or use gasoline or otherflammable vapors and liquids in thevicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch any electrical switch; donot use any phone in your building.
Immediately call your gas supplierfrom a neighbor’s phone. Follow thegas supplier’s instructions.
If you cannot reach your gas supplier,call the fire department.
Installation and service must beperformed by a qualified installer,service agency or the gas supplier.
��
�
�
�����������������������������������!���"��#�$%�&�
www.hotwater.com
2
'������(����)�������������������������������������������������������������������������������� 25(�����������*�������)������������������������������������������������������������������ 27+�����������*�������)���������������������������������������������������������������� 29!������������*�������)������������������������������������������������������������� 30/�)����!������������*�������)�������������������������������������������������� 31(��������������*�������������������������������������������������������������������������� 34���*�������!����������+�������������(������������������������������������� 36���*�������!����������+��������'������(�������������������������������������� 37
WATER HEATER INSTALLATION��������������������������������������������������������� 38!���������'�����)�������������������������������������������������������������������� 38Supply Gas Line Installation������������������������������������������������������������� 39Gas Line Leak Testing���������������������������������������������������������������������� 40Purging��������������������������������������������������������������������������������������������� 40:������������������������������������������������������������������������������������������������ 41������;����!��������������������������������������������������������������������������� 42�<��(��=��'����������������������������������������������������������������������������� 42
TEMPERATURE REGULATION����������������������������������������������������������� 43>������*��������;�*���!�����?:!@B��������������������������������������������� 43����*�����!������������������������������������������������������������������������������� 43
!@#�C@;�+J+�:K�@�:C��)@#������������������������������������������������������� 44@=��=���������������������������������������������������������������������������������������������� 44!�����+����*�#�=��������������������������������������������������������������������� 44Q����+��������<�!�����+����*�K���������������������������������������������� 47
START UP��������������������������������������������������������������������������������������������� 52Prior to Start up�������������������������������������������������������������������������������� 52Initial Start Up����������������������������������������������������������������������������������� 52!������������V������C�������������������������������������������������������������������� 55>������������)���������������������������������������������������������������������������� 55
LIGHTING THE WATER HEATER�������������������������������������������������������� 56Lighting & Operation Labels������������������������������������������������������������� 56
TROUBLESHOOTING�������������������������������������������������������������������������� 58)�����������!��������������������������������������������������������������������������������� 58+�Z�����@��@��������������������������������������������������������������������������� 58+�Z�����@��@��������V���!����������������������������������������������������� 59@������������ ��*������������������������������������������������������������������������ 60V��������������!����������������������������������������������������������������������� 61
K�)#�:#�#!:������������������������������������������������������������������������������������ 64General��������������������������������������������������������������������������������������������� 64K�����������+��������������������������������������������������������������������������� 64'������������V���������������������������������������������������������������������������� 64V�����������������>������������������������������������������������������������������������ 65+���*����C�*=����������������������������������������������������������������������������� 65;�*��+�����C�*=��������������������������������������������������������������������������� 65������������C������������������������������������������������������������������������� 66'�����(��=��������������������������������������������������������������������������� 66(����+����*������������������������������������������������������������������������������������� 66
DIAGRAMS������������������������������������������������������������������������������������������� 67!![�\�!�������!�����[����;��������������������������������������������������� 67[�>�&]��<�&����������'�����*������������������������������������������������������� 68[�>�&^^�<�]����������'�����*������������������������������������������������������� 69!����������*���������'�����*���������������������������������������������������� 70�������������'�����*���������������������������������������������������������������������� 71
;)K)�:'���CC�#�J��������������������������������������������������������������������������� 78
TABLE OF CONTENTS+�V:�)#+��;;��)@#"�Q+:��#'�+:C()!:������������������������������������������ 3���C@(�;+������������������������������������������������������������������������������������������� 3_:#:C�;�+�V:�J�)#V@CK��)@#������������������������������������������������������� 4
�������������������������������������������������������������������������������������������������� 4_C@Q#')#_�)#+�CQ!�)@#+��������������������������������������������������������� 4>�������_���V��**� �������������������������������������������������������������������� 4
)#�C@'Q!�)@#������������������������������������������������������������������������������������� 6� ��=�������Q������������������������������������������������������������������������������� 6`������������������������������������������������������������������������������������������������ 6�!@KKq�<�[�!����!*���� ���������������������������������������������������������� 6����������V������)���������������������������������������������������������������������� 6
V:��QC:+��#'�!@K�@#:#�+���������������������������������������������������������� 7[�����@����������������������������������������������������������������������������������������� 7���(����������������������������������������������������������������������������������������������� 8+����(�������������������������������������������������������������������������������������������� 10
)#+��;;��)@#�!@#+)':C��)@#+�����������������������������������������������������11C���)��'�*������������������������������������������������������������������������������11;�����������������>�������������������������������������������������������������������� 12:x�������(�������*�������������������������������������������������������������������� 13@�������!������������*������������������������������������������������������������ 13>������������������������������������������������������������������������������������������������ 13!����������*������������������������������������������������������������������������������ 13Insulation Blankets��������������������������������������������������������������������������� 13
INSTALLATION REQUIREMENTS������������������������������������������������������� 14_���+�����+����*������������������������������������������������������������������������� 14Supply Gas Regulator���������������������������������������������������������������������� 14�����+��������������������������������������������������������������������������������������� 14K�x����(��=�������������������������������������������������������������������������������������� 15'�����������K���������������������������������������������������������������������������� 15!�����������+����*���������������������������������������������������������������������� 15����*���:x��������������������������������������������������������������������������������� 15��*�������\��������C������(��=��������������������������������������������������� 16!���������'��������������������������������������������������������������������������������� 17!* ��� ���K��������+��������������������������������������������������������������� 17!���*���������������������������������������������������������������������������������������� 17����C�Z���*���������������������������������������������������������������������������������� 18Q��������+�������������������������������������������������������������������������������� 18!������+������������������������������������������������������������������������������������ 18V���������@��������V��!������+��������������������������������������������� 19@�����������������@�������������������������������������������������������� 19@��������������@���@��������������������������������������������������������� 19@�����������������>��������'����������������������������������������� 19@�����������������(��������'���������������������������������������������� 20����V�*�@�����)����+��������������������������������������������������������������� 20
)#+��;;��)@#�C:`Q)C:K:#�+�\�!@KK@#�:�;�>�@V�K�++�!>Q+:��+������������������������������������������������������������������������������� 21(:#�)#_�)#+��;;��)@#�������������������������������������������������������������������� 22
_�������(�������)���*����������������������������������������������������������������� 22_�������(�������)��������������������������������������������������������������������� 22[�>�&^^�<�]���)����������!����������������������������������������������������� 23(�������C�Z���*�������������������������������������������������������������������������� 24(�������)�����������+�Z�������������������������������������������������������������� 25�����(����)������������������������������������������������������������������������������� 25
3
SAFE INSTALLATION, USE AND SERVICE
���������������������"�����������=������������������������������x���*�����*������������������������������������������K����������\��������*�������������������������=�� ������=�������������*����������������������������������������������������������������{������������C�������� ��������������*�����������������������������������*�������)�����=�����*����������������*���������������������*������������������ ������������������������"���"������=����������������������
�����������*������������������������������� �������������������"�������������������������������������������*������"�����������=����������������{�������!���������+����'�������������������x���:�����*����������Z���������_=�������!������������ ��������������� ������������� �� ����+�������!��������� �������������"� ������������"�������� ��������=�����*"����� ��Z����� ��������� �������������������x������������ ��������������������������������*����������������+�������!����������������������"� ������������"����������������=�����*����������������������������������=����x��������*��������� ��������������������������
DANGER
WARNING
CAUTION
CAUTION
DANGER indicates an imminentlyhazardous situation which, if not avoided,will result in injury or death.
This is the safety alert symbol. It is used to alert you topotential personal injury hazards. Obey all safetymessages that follow this symbol to avoid possibleinjury or death.
WARNING indicates a potentially hazardoussituation which, if not avoided, could resultin injury or death.
CAUTION indicates a potentially hazardoussituation which, if not avoided, could result inminor or moderate injury.
CAUTION used without the safety alertsymbol indicates a potentially hazardoussituation which, if not avoided, could result inproperty damage.
APPROVALS
NOTE:� �+K:� ���������� ��� ������� �� ���� ���������������=�������������*�����
4
PRECAUTIONS'@�#@��Q+:��>)+����:C�>:��:C�)V��#J���C��>�+�[::#�Q#':C����:C��)**����������������Z����������=������������� �������� ��������������������� ��*�����������*������������������������� ����������x��)��������������x������������������"������������������������� ���� �������=�� ������ ��=�� ���� *���� �� �� Z�����������=�����������
&�� :x�����������
]�� '�*����
$�� V������������������
GROUNDING INSTRUCTIONS������������������*��� �������������������������������#�������:����������!������~�������������������*��� ��������� ��� ���� ������� V������ �� ����� ����� ������ ���������������*�������������������������������*����������
������������������*��� ����������� �����������*����"����*������ ������� �����*�� �� ��� �Z��*���� ��������������� *��� �� ��� ����� ���� ������� �������� ������������� �� ���� �Z��*���� �������� ���*����� �� ����� �������������������
HYDROGEN GAS FLAMMABLE
Explosion Hazard
Flammable hydrogen gasesmay be present.
Keep all ignition sources awayfrom faucet when turning onhot water.
>������� ���� ���� �� ������� ��� �� ��� ������ �����*� ���=��� �� ������������������ ������������ �������� ����� ��������������*�� ?���������� ��� ������ �� *��B�� >������� ���� ��� �x���*������**� �������������������������{����������������������"����������**�������������������������������=��� �������������������� �������������=�����*������ ����������������������������������������������������������������*��)���������������������������������� � ��� �������������������������������������������������������������� ������������THERE SHOULD BE NO SMOKING @C�@�:#�V;�K:�#:�C��>:�V�Q!:������>:��)K:�)��)+�@�:#��
GENERAL SAFETY INFORMATION
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
Explosion Hazard
Overheated water can causewater tank explosion.
Properly sized temperature andpressure relief valve must beinstalled in the opening provided.
Verify the power to the water heater is turned off before performing any service procedures.
Improper installation, use and service may resultin property damage.
Do not operate water heater if flood damaged.Inspect anode rods regularly, replace if damaged.Install in location with drainage.Fill tank with water before operation.Properly sized thermal expansion tanks are required on allclosed water systems.
Refer to this manual for installation and service.
CAUTION
5
GENERAL SAFETY INFORMATION
Fire Hazard
Do not install water heater oncarpeted floor.Do not operate water heater ifflood damaged.
For continued protection againstrisk of fire:
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
Property Damage Hazard
All water heaters eventually leak.
Do not install without adequate drainage.
CAUTION
Fire and Explosion Hazard
Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.
Use joint compound or Teflon tapecompatible with propane gas.
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
Turn off power to the water heaterbefore performing any service.
Electrical Shock Hazard
Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.
Verify proper operation after servicing.
Failure to follow these instructions canresult in personal injury or death.
Jumping out control circuits or components canresult in property damage, personal injury or death.
Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.
Any bypass or alteration of the waterheater controls and/or wiring will result
in voiding the appliance warranty.
Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.
6
������J� ��� ���������� ����� ������ �������� �������� ��������������*���������"�����������=�������������� �����������=����
ABBREVIATIONS USED
� ��=�������������������)���������K��������������� �#+)�\��*�������#�������+���������)��������� �+K:�\��*�������+��������K����������:���������� �>C)�\�����!���������"�>�����������C������������)��������� #:!�\�#�������:����������!���� #V���\�#�������V������������������������ Q;�\�Q������������;� ������� !+��\�!��������+������������������
QUALIFICATIONS
QUALIFIED INSTALLER OR SERVICE AGENCY)����������� ���� ���=���� �� ����� ������ ������� ��Z����� � �������Z�=������ �� ����� �� �� `�������������� ?��� ������� ���#+)� ���B���������������=�=����)���������������������������* ���"����������"�=������"��������������������������������������Z������������������������������������������������������*�������=����ANSI Z223.1 2006 Sec. 3.3.83:� �`������� �������� \� ���������=����"���*"�������������*������������������������������������������������=������������������������������ ������?�B����� �����������"� ���������� �������*������������������� ? B� ������������"������������"��������"�������������=������������������������Z��*��������������x��������������������������������*���������������������������Z��������������������*���������������������Z���*���������������������=����{�����������)�����������Z�������?���������� ���#+)�� =�B���������������� ��������� ��� ��Z����� �� ���� �������� ��=���� {������������ �����*� �� ��=��� ����� �� ��� ����*��� �� �����*� ���� �� ������������������� ��� ��� �����*������ )����������������������� �������������=��� ��� �����*��������������*��� �������*�����������������������������*�����
ICOMM™ & BACNET COMPATIBLE
����� ������ ������� ��� �*���� ��� ����� ���� �!@KKq� ��*���*�������� �����*�� ���� �!@KKq� �����*� ��������� ����*�������� � ���=���� ������������������������ )�� ����������� ��*����� ��������� ���������"� ���������� ���� ������� ����� �������*����������� ����������� �!@KKq� �����*� ���� ��*��������� ������ ������������������ =��� �*���� ���~�� �������� ����� ��x�� *�������� ��������������� ��*���������������������!�������������!@KKq������*��������������*���� ��������[�!�����*�����������=����� ������� ���� ������� *�����*���� �����*��� V��*�������*��������������^]�\$%�]�
PREPARING FOR THE INSTALLATION
&�� C���������������*����� ���������*�������������������������������������������������������������������_�������+������)���*������������/�������� )��������� ����� ���������������"������������������*���������������������)���������������������*���"���{������~������������� *����� �������� ����������� ��� ���� �����������"��������"� ���� *����������� �� ���� ������ �������� )�� ��������������������������������*������������*������������ ���������������������������������������������������������������������������������������������������������������
INTRODUCTION'��������������������������*����������������������*������������ ������*�� ����� ���=�� �� ��=���� ���� ���������� ����� ������������� )�� ��� ���������� ����� ���� =������"� ������ ������"� ���������������������� ������������������������������ ��������� ����� �� ��=��� �� ���� �������������� ����**������ ��� ���� �������� ���������� ��� ���� �������������*�����������������������������������������������������������������������������������*�������������������������������������������V�����������!*��������������%���������*������Q���������������������������������������=������*��������������������������+�������)�����������!��������������� ��������������������[������������������������������*��� ��� �����*����*�������������� ��{��*����� ���� �=��� ����������� ���=����������� >��=��"� ���=���� ���� ���������� ��������� ��������� �������*��� ����`�������+��=�����������NOTE:� !���� �� ������� ������������ ������ ���� ��� �=����������������*��������������
]�� [�� ���� �� ���� ��� ����� ����� ������� �� �� ����� ��������������������*���������������������#�=�������������������*�����������������������������������������������
$�� ����������������*�������*�����������������������������������*��������������������������������=����{����������������� ������ �� ��������� ������� ��� ���� ������� ������������=���� {���������� ����� �� �������� ����� ������������ �����������������������Z������������������*�����������������"����������������������)�� ����� �������� ���������"� ���� ������������*����*����������������������������������#�������V���_���!��"��#+)��]]$�&~#V����/���������#�������:����������!��"�#V���%����!�#~!+�\[&/^�&"�����#������_��������������)�����������!��� ���� !+�� !]]�&"� ���� !�������� :���������� !���� ������*����� ���� �=���� ��� ��*� ���� !�������� +������������������"����&�:�������������(������C��"�!��=�����"�@>�//&$&��#V�����*��������������=���� �����*�����#�������V���� ��������� ���������"� &� [������*����� ����"� `����"�K���]]�^�
/�� )�� ������ �������� ����� *����� �� ��=�� ���� Z������� �� ����� ���������� ���� ������ �� ���� ����������"� ����� ���� ����������* ��������� �����=����� �����*����� ��� ����������������������)����������x������������Z���"����������=����������K���"�+����������+�������* �����������������������������������������=���� �������������������������������*��������������������������������������������� ���
��� !������������� ���������*������ ������������������:x�*��������������������������������*�����������������Z���*�������� ;����������� ������ >������ �� ����� &]� ���� ���� C���)��'�*��������������&&�
��� V�����������������!���������������������������*��� �� �������������������=�������������*=������������������Z�����+��� ����������� ��� ������� ������������ ����������)���������� *��� �� ������� ��*� !��������� @����� �� ����+��������������"�&&�]�`�+�����"�+�����&��"�+����*���"�!��^��&&�
%�� K������������ !��� ��Z����� ����� ������ ������� �� ������������������������������K������������]/�\!KC�]�����+�������* ����!�������]/�\!KC����+���!**����������K�������������������]&�
7
BASIC OPERATION
���� ������ �������� �=����� ��� ����� *����� ��=�� �� �������� �����������������x�������� ����� ���� *������ ��� ��������������������� ������ ��������� K���� [����� ��� �� ������� ������� ����"� ������ *����� �� ���� ��� ���� ����� �������� ������ ���� ������x������������������������������� ��������� ���������������������� ������ ���� ����� �x�������� ����� �������� ���� �x��������������x����~=��������������������������� ��*���������������������+���V�����&�����V�����]�
BLOWERBURNERASSEMBLY
MAINBURNER(radial design)
HEATEXCHANGER
INTAKE AIR(combustion air)CONNECTION3 INCH PVC
HELICALCOIL
VENT (exhaust)OUTLET
Figure 1
FEATURES AND COMPONENTSBLOWER/BURNER ASSEMBLY DETAIL
199,000 & 250,000 Btu/hr MODELS
HOT SURFACEIGNITER
120,000 & 150,000 Btu/hr MODELS
COMBUSTIONBLOWER
FLAMESENSOR
MAINBURNER(radial design)
BLOWERFLANGE
INTAKE AIR(combustion air)CONNECTION3 INCH PVC
HOT SURFACEIGNITER
COMBUSTIONBLOWER ASSEMBLY
FLAMESENSOR
MAINBURNER(radial design)
BLOWERFLANGE
INTAKE AIR(combustion air)CONNECTION3 INCH PVC
Figure 2
Hot Surface Igniter���������������*����������� ����>��+������ )������������&]��(�!� ������ ���� �������� ���*� �� ������� ����� ���� �������� ������������������������������������"��&����V�?�^�]�!B"��������������K����[�����NOTE:�!����*��� ���������������������������������������=���� ��������Flame Sensor���������������*�����*������������*��������������*�����*��������������������K����[������)������*��������=�������������������������������������?$\��������B����������������*������ �**��������� ��\��������� ���� ]/� (��� _��� (��=��� +��� ����+�Z�����@��@��������V���!�������������^�
8
&���(�������������?�x������� �B�\�$�������(!�&&��!* �����[�����&]��[������:x�����?=���B���������#�*������������������������
��������������������������������������������������������:x����� ?=���B����������������� �� ����������������� ���������������������������������*�*������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������
&$��[�������=�����������#�*�������������������������������������������������������������������������������!* �����[����� ��� ��������� ��������� ���� ������ �����*� *������������������������������� ������������������� ��� ���������������� ������ ����� ���� !* ����� [����� ��� ���������� ������ ���� ��*�� ������ �� �������� ������� +��� +�Z����� @��@������������������
&/����*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��
&���Q�������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*�������������������������������������������������Q�������*���������� ���������������:!@�?���������� �B� ������������� ��� �� ��� ��{��� ��� ����� ��*����������*��� ������������ :!@� ������� �������� ���� ��*����� �������������������������*��������������+���>������*��������;�*���!�����?:!@B��������/$�
&�����������������������&�&~]��#���&%��Q)K�?���� ����������*���B������Q)K� �������� ������������
������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�
TOP VIEWS
3
2
4
5
6 8
10
12
112
13
14
16117
15
97
FRONT
120,000 & 150,000Btu/hr MODELSTOP VIEW
BTH 120 & 150 COMPONENTS&�� ������>��������&]��(�!��~����������]�� ������� ����� ����� ���� ������ ��������� �=����� ��� �����
*����� ���� �Z������ ����� ������� ?��� ����������B� �������?�B������[�>�&]��������������������"����������*������������=�������������=���������������� �����������������*�������������*�������������������������������������������������� ���� ������ ���������� �� ����������=�����������������������������������������*�����������������=���������?������B������������������*������������������������
$�� !������� !����� [���� ?!![B� ��������� ����� ������������� ���� ������ �����*��� *���� ������� ����� ���� !![���������� ������ ��*�������� ���� ������� ���� ������ ��������������"�����!�����+����*�@���������������//�
/�� )�������������������\�$�������(!���� &]��(�!� {������ x�� )��*������������������������
��������������*����������+��������+������������&/���� ���������������]/�(���_���(��=��%�� +����� ���� ����� ���������� +��� ���� ��Z���*����� ��� ����
_���+�����+����*���������&/���� ;�� _��� �������� �������� #�*����� ���� �������� �����
����� �� �� ����� ��� ��������� ����� ������� ��� ���� �� ������������ ���� �������� ��� � =�� *���**� ��Z���*���������������������*�*������������������������������� �����������������������������������������������������������������+���_�����������C�Z���*����������� ���$��������&]�
^�� [������ )������ ���� �������� #�*����� ������ �������� ��������������������������������������������������������������?�* ����B� ���� �� ���� ������ ������� ��� ��� ������������ ���������������*�*������������������������������� ����������������������������������������������������������������
Figure 3
9
_�����������C�Z���*����������� ���$��������&]�&���(�������������?�x������� �B�\�$�������(!�&&��)�������������������\�$�������(!�&]��[������:x�����?=���B���������#�*������������������������
��������������������������������������������������������:x����� ?=���B����������������� �� ����������������� ���������������������������������*�*������ ������������������������� ��� �������� �������� ��� ���� �������� ���� ���� ������ ����������������
&$��[�������=�����������#�*�������������������������������������������������������������������������������!* �����[����� ��� ��������� ��������� ���� ������ �����*� *������������������������������� ������������������� ��� ���������������� ������ ����� ���� !* ����� [����� ��� ���������� ������ ���� ��*�� ������ �� �������� ������� +��� +�Z����� @��@������������������
&/����*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��
&���Q�������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*�������������������������������������������������Q�������*���������� ���������������:!@�?���������� �B� ������������� ��� �� ��� ��{��� ��� ����� ��*����������*��� ������������ :!@� ������� �������� ���� ��*����� �������������������������*��������������+���>������*��������;�*���!�����?:!@B��������/$�
&�����������������������&�&~]��#���&%��Q)K�?���� ����������*���B������Q)K� �������� ������������
������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�
3
2
4
5 6
8 10
12
11
2
13
14
16117
15
97
FRONT
199,000 & 250,000Btu/hr MODELSTOP VIEW
BTH 199 & 250 COMPONENTS&�� ������>��������&]��(�!��~����������]�� �������������������������������������=�������������
*����� ���� �Z������ ������� ?��� �����������B� ���������� ���� [�>� &]�� ���� ��� ������� ����"� ���� �����*����� ����� ��=�� ���� �������=�� ������� ��� ���� �� ���������� �����*� �� ���� ������*� ���������� ��� ���� ���� ������������������������������������������������������� ������=�� �������� ������� ���� ������� ����� ��������*�����������������=���������?������B������������������*������������������������
$�� !������� !����� [���� ?!![B� ��������� ����� ������������� ���� ������ �����*��� *���� ������� ����� ���� !![���������� ������ ��*�������� ���� ������� ���� ������ ��������������"�����!�����+����*�@���������������//�
/�� :[K�!* �����[���������* ��� ��������(V'�?=���� ������Z��������=�B"�_���(��=������(��������������������*�
��� &]��(�!� {������ x�� )��*��������������������������������������*����������+��������+������������&/�
��� ���������������]/�(���_���(��=��%�� [������ )������ ���� �������� #�*����� ������ �������� �����
���������������������������������������������������������?�* ����B� ���� �� ���� ������ ������� ��� ��� ������������ ���������������*�*������������������������������� ����������������������������������������������������������������
��� +����� ���� ����� ���������� +��� ���� ��Z���*����� ��� ����_���+�����+����*���������&/�
^�� ;�� _��� �������� �������� #�*����� ���� �������� ���������� �� �� ����� ��� ��������� ����� ������� ��� ���� �� ������������ ���� �������� ��� � =�� *���**� ��Z���*���������������������*�*������������������������������� �����������������������������������������������������������������+���
TOP VIEWS (CONT)
Figure 4
10
^�� ��*�������\��������C������(��=�����������������\������<��(��=��'��������������C�Z���*�������������&��
&���;������*���������� �"�&���]� ��*���������� ����������������������������������*�*������������� �������������������*��������������������������������������������
&&�������������������\�&�&~]��#������������&]���������������������=��=��&$��+����� ���� ����� ���������� +��� _��� +����� +����*�� ��
�����&/�&/��;��_�����������������"��������������������� ���������
�� ����� ��� +��� _��� �������� C�Z���*����� ���� �� ���$��������&]�
&���(�������������?�x������� �B�\�$�������(!�&���!�������������������&~]�������(!�����������������+���V�����
^��������&%�����!���������'�����)������������������$��
SIDE VIEWS
&�� !������ ������� �����"� �=���� ������ ������� ��������������
]�� !![���������\����� ��������������������������������
$�� )�������������������\�$�������(!�
/�� �������������]/�(���_���(��=��
��� !* �����[�����
��� ����������������\�&�&~]��#������������
%�� Q)K�?���� ����������*���B������Q)K� �������� ������������������� ���"� ���� ������ �����*��� ;!'� �������� �������������� ������Q��������{���=����������������������=������������������*������+���!�����+����*�@���������������//�
��� ��*�������\�������� C������ (��=��� +��� ��*�������\��������C������(��=���������&��
1
2
23
4 56
7
8
9
10
11
12
LEFT SIDE120,000 & 150,000 Btu/hr MODELS
RIGHT SIDE199,000 & 250,000 Btu/hr MODELS
45 1314
15
16
3
Figure 5
11
ROUGH IN DIMENSIONS
INSTALLATION CONSIDERATIONS
FRONT BACK
CLEANOUT
T & P VALVE
3/4” NPT DRAIN
1 1/2” NPTWATER INLET
VENT CONNECTION3 INCH PVC
(exhaust elbow)
CONDENSATEDRAIN CONNECTION
1/2 INCH PVC
INTAKE AIR CONNECTION3 INCH PVC
SUPPLY GASCONNECTION
E
H
D
CA
I
G
FB
WATER OUTLETHEIGHT
These designs comply with the current edition of the American National Standard for Gas Water Heaters, Volume III, ANSI Z21.10.3 / CSA 4.3as an automatic circulating tank water heater, and automatic storage water heaters.
120,000 & 150,000Btu/hr
MODELS
199,000 & 250,000Btu/hr
MODELS
* Center line of water outlet on top of the water heaters is approximately 7 inches from the front edge of the water heater.
TOP VIEWS
45°
18°
CLEANOUT
T & P VALVE
DRAIN
VAL VE
45°
35°
64°
*1 1/2” NPTWATEROUTLET
SUPPLY GASCONNECTION
VERTICAL
FRONT
INTAKE AIR3 INCH PVC
VENT
3 IN
CHPV
C
35°
22°
68°
45°
18°
45°
CLEANOUT
T & P VALVE
DRA
IN VALVE
*1 1/2” NPTWATEROUTLET
FRONT
INTAKE AIR3 INCH PVC
GAS
VENT
3 IN
CHPV
C
MODEL
DIMENSIONS SHIP
WEIGHT
STD
SHIP
WEIGHT
ASMEA B ! D E V G H I
)#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K )#!>:+~!K ;[+~�_ ;[+~�_
BTH 120 $~%��] ]%�%�~%��� ��$~&� $�~���^ ����~&/& /�~&]&�^ &&~]%�^ /]~&���% /%��~&]��� /��~]�� /^�~]]]
BTH 150 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� ����~&%/ &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�
BTH 199 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� %���~&^&�� &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�
BTH 250 $~%��] ]%�%�~%��� ��$~&� ����~&/& %���~&^&�� %���~&^&�� &&~]%�^ �$~&�� �^~&%��$ ���~]�] �^�~]%�
Figure 6
12
STORAGE CAPACITIESTABLE 2MODEL Q��+��_�;;@#+ LITERSBTH 120 60 227
BTH 150 100 379BTH 199 100 379BTH 250 100 379
GAS LINE CONNECTION SIZETABLE 1† MODEL SERIES NATURAL GAS PROPANE GASBTH 120 &��~&�& $~/��#�� $~/��#��BTH 150 &��~&�& $~/��#�� $~/��#��BTH 199 &��~&�& $~/��#�� $~/��#��BTH 250 &��~&�& $~/��#�� $~/��#��
��'��������������������������Z�=������������"����~�������* ������������������������"�������������������������*�����=���� ������������ ���������*���**���Z�����������\�����_���;����+�������������$^�
��� ;����������������������������������Z���������������������� ����* ���������=�������������� �� ��������+�������C�Z���*������������&��
^�� ;��������������������������������=�������������������������"������ ���������"� ����� ��*���� ������� ���� *�x�**� �Z�=����������������������+���(�������C�Z���*������������]/�
&���'� ��� ������ ���� ������ ������� ������ ����� ?���� ������� !* ����� [����B� ������ ��*��� �������� ����� �� {������ ��������{������������
&&��'� ��� ������ ���� ������ ������� ������ ���� � ��Z���������������� �� ���� =���� ?�x����B� �� ������� ���� ���*������������ �� {������ ��� ��� �� ����� ��� ���� ���*������?�B����������������������������������������*�����������������+���(�������)������������������]]�
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
LOCATING THE WATER HEATER
!�������� ����� �� ������� ��� ���� ���� ������ �������� ���������*���������=�����*������������������������������������������������������ ������������������*������*����������������������������
Property Damage Hazard
All water heaters eventually leak.
Do not install without adequate drainage.
CAUTION
����������������������x������������������������������������������������������������������ ���=�����������������������������&�� �����������������*��� ���������������]�� �����������������*������ ����������������������������������
��� {�����������������*���������$�� ;����������������������������������������������� {������
�����������*���� ����*=����=�������/�� ;����������������������������=������������� ;�������������������������������������������������������������
����������������������������������������������������������������������������*�����������������{���������������������������������������������������������������������������� ���=����"����������**�������������*��������������"����Z�������������"� ����������������������������������
��� ;����������������������������������������*�{����������������%�� ;����� ���������������������� ����&]��(�!�������������
+��������+������������&/������Z���*�����
GAS PRESSURE REQUIREMENTSTABLE 3MODEL K�#)V@;'��C:++QC: K)#)KQK�+Q��;J��C:++QC: K��)KQK�+Q��;J��C:++QC:
NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GAS NATURAL GAS PROPANE GASBTH 120 /�����!��?&������B &������!��?]�/^����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B
BTH 150 /�����!��?&������B &������!��?]�/^����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B
BTH 199 ������!��?�����B ������!��?�����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B
BTH 250 ������!��?�����B ������!��?�����B /�^�����!��?&�]]����B &&�����!��?]�%/����B &��������!��?]��]����B &/�����!��?$�/^����B
RECOVERY CAPACITIESTABLE 4
U. S. GALLONS/HR & LITTERS/HR AT TEMPERATURE RISE INDICATED
K��� Type ofGas
Input �V $��V /��V ���V ���V %��V ���V ^��V &���V &&��V &]��V &$��V &/��V[�~�� kW �! &%�! ]]�! ]��! $$�! $^�! //�! ���! ���! �&�! �%�! %]�! %��!
BTH 120 Natural &]�"��� 35 GPH 461 345 276 230 197 173 154 138 126 115 106 99Propane LPH 1744 1308 1046 872 747 654 581 523 476 436 402 374
BTH 150 Natural &��"��� 44 GPH 576 432 345 288 247 216 192 173 157 144 133 123Propane LPH 2179 1635 1308 1090 934 817 726 654 594 545 503 467
BTH 199 Natural &^^"^�� 58 GPH 767 575 460 384 329 288 256 230 209 192 177 164Propane LPH 2904 2178 1743 1452 1245 1089 968 871 792 726 670 622
BTH 250 Natural ]��"��� 73 GPH 960 720 576 480 411 360 320 288 262 240 221 206Propane LPH 3632 2724 2179 1816 1557 1362 1211 1090 991 908 838 778
C��=������������������� �������^�������*�������������
13
���������������������������� ����������������������������������������������*�"�����������������������������������"��������**� ��� ��Z���� �� ������� ���=��� �Z��*���� �� =�������� ���������"���������������������V��**� ���=������������=���������=�������������������*��� ���������� �������������������������������K����[�������*�����������������x�������V��**� ������*�"���������������������������������������������������������������*�����=��� ���������������{������ �������������������CLEARANCE TO COMBUSTIBLE MATERIALS���� ������ �������� �=����� ��� ����� *����� ���� ����=��� ������������������* ��� ���������������������������* ��� �����������* ��� �������������*��������� ����� ��������� ���� ������������������������������������������������������������������=���������������������������=��NOTE:����Z��������������������=����������� ��*������������������������������+���+��=����!��������� ����
TOP VIEW
0
00
ALCOVE
FRONT VIEW
CLEARANCES TO COMBUSTIBLEAND NON COMBUSTIBLE
CONSTRUCTION MATERIALS
WATERHEATERFRONT
TOP COVER
FRONT
Figure 7
SERVICE CLEARANCE�����=����������������]/��������?�&��*B������ ��*������������*� ���=���� ��� ������ ���� ��� �����<�� =��=�"� ������ �����*��*������"�����=��=�"���������������"�������=��=�"������=�������������?�x������� �B��������������������������;��=�����*��� �*� ��� ���� ��� � =�� ���� ������ ������� ���� ����� �����x������� �����������������+���V�����^��������&%�INTAKE AIR AND VENT PIPE CLEARANCES����*���**�������������*��* ��� ���*����������������=����?�x����B����������������������������� ������������(�����������������������������������������* ��� ������������������*��� ��������������?��{����B�
EXTENDED VENT TERMINATIONS
�������������������=����� �������*��������� �����������������$��������������������������������~��=�����������������*�x�**�������Z�=�����������?&��]�*B���������������������~��=��������������� ���x�����������&]���Z�=�����������?$����*B� �������������/������������+�������(�������C�Z���*������������]/������ ������ ������� ������ ��*� ���� ������� ����� ��� ?]B� $� ��������*�������� ����� ���� /��� �(!� �� ��� ����� �� �� ���� �����������������������/�������������������=���������������������"����������������/���������*��������*��� �������!�������������������� ��������������������������*����������* ���������������� �����=����������*������������/���������*������?�B�
OPTIONAL CONCENTRIC TERMINATIONS
�������������������=�������������*��������� �����������������'������(������������������������������������������*���������+���!������������*�������)������������������$��
HARD WATER������ ����� ������ ��������� �x���"� ������ ��������� �� ������������� ����� �� ������ �����*���� ��� ���**������� ����� ������������ ���� �����������"� ������ ���"� ������ �������"� �����������������������Z��*�����+���K�������������������/� �������*����������*����������*=������������
CIRCULATION PUMPS��������������*���������������������*���Z�������������������������������������������������������{�����������������������������+��� �����������������'�����*�� ����������������%&�������������������������������������*����
+��� !��������� �*�� ������� '�����*�� �� ����� %�� �������������� ���� ����*������ )������� ��� ���������� ����� �������������������� ����#�������:����������!��"�#V���%���� ����!��������:����������!��"�!+��!]]�&�
���\ ����� ����������� �*��� ���� ���**������ ��� ���� ������**���������������������
+*��������������*�������*���������������������� ����������������� ��Z���� ������� � ���������+*��������������*���*��� �� ������������ ������ C����� �� ���� �*�� *��������������������������� ����������Z���*�����
INSULATION BLANKETS
Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
)�������� �������������=���� ������������������ ��������x���������� �� ���� ������ �������� �� ���� ��� ���������� ����� �������������������������������������� ��������������������������� ������� �������������������������� ���������������������������������=����� �������*�����*�������x���������:����������������������������������������������������������� �������������Z���*����"�*������������������ ������������������
+���� �� ����� �� ������ ��� ��������� ������� �� �����������"� ������� ����� ������ ������������+��� ����V����������� !*������� ������� �� ����� *����� ��� ������������� ���*�������*�������� �����V��������������������������������������������������������Z���������������* ����"���������������������������"������x�����"�����������������{�����������
�� DO NOT�������������������������������������������"������������������������������������������������ ���������* ���
�� DO NOT��=������������������*�;!'��������������������������� DO NOT��=���������*�������\��������C������(��=���� DO NOT��=�����������������*�������������������������������
������������������� ���������������������� DO� ����� ���� �������� ���� ���������� �� ���� ��*� ����
*���������� ��� �����*���� �� ���� ������� ��������� =��� �����x��������� ����
�� DO� �������� ���� ��������� ������� ���Z������ ��*������������ �������������"������ �� ����������* ������������
14
&�� �����=�����\�����������������������*��� �������������� =�����������[�~����������������������������������������
]�� +��������������������������=��������������������������������������������*���**�����������������������������������������������������+����� ����"������]$�
$�� �����=�����\���������������������?�B������ �������������������������$������?&�*����B���������������������������?]�/�*�����B���*���������������������������������������
/�� ������ ����������� ���������=�� ���\�������������� �������?�B�������������*�����������������������������%������!�������������������������������������������**���������������������������=�����������������������������+*������������{��*����*�� ����Z�������������*�����������������������������������
��� ����� ����������� *������� ������ �������� ��� ���� ��*�� ���������� �����*� ��� ��� ���**������ ����� ����=����� �����=�����\�� ���� �������� ��������� �� ���������� ��� ����� ������*�������������������������������������������
POWER SUPPLY�������������������=����� ��� �����*����� ��Z������&]��(�!"�&��?������������B"���>�"�&���*�����������������*������� ���������������������������������������������������"��������� �����������������"����������#�������:����������!��"��#+)~#V���%��������!��������:����������!��"�!+��!]]�&�
POWER FLUCTUATIONS AND ELECTRICAL NOISE���������� ��������� ������ �����*� ��Z������� ������� ��� ���������������������������������������!������������������������������ ���������������������� {������������������=��������=���������������������������������:K)�?�������*��������������������B���CV)�?��������Z�����������������B�*���������������������������*�������������*����������
�������Z����������������������~��������������������������;����*����+:;V~�\&��+������+!\;����Z�=������*��� �������������������� =������������x�����!������������������������������* ���������������� �����=����������*��������*�������*������
NOTE:�K���������������� ������������������������������������������������������������������=����������������*��������������
DEDICATED POWER WIRING AND BREAKERS'��������� ����� ������ �����"� ����� ������� ���� ����������������� ����������������=���������������������������������� ���������������������������������������������
POLARITY SENSITIVE���������������*����������������������=�������������*�������� �������� �������=��� ���������� ��*�� �������� ��Z����� ���������������� ���� ������ �����*� ��� �����**��� �� *����� �������*����������������)������>������#�������������������&]��(�!������������������=�����"����������������*����������������V���������������������"���������������������� ������ ����������������������������������������������������������*��������������������!�C�=�������V����*�������������;!'�
+���:������������������������/&���������������������������
GAS SUPPLY SYSTEMS;���������� ����������������������*��������������������������*�� ����� ������ ����� ���� ����*�������� �x����� &/����!��?&~]��+)�_���B�������������*���������Z���������������������� K�����*����� ����� �� ������ �� ������ ����� �������������������� �������������������������Z���*���������������������������������������������C������������� ��������������������� �������Z��*�������?��������������B������������������ �������Z��*���� ������� ��� *�x�**� ����� ?����*��� �������B�� ����������������������*��� ����� ����������&������!����*���������� ����*��� �������� �� ��=���� ��� �����*������ ������������� ����� �x����� &���� ��!�� *��� ����� ���� ��������"� ������* ������� ��������������� )����������� ������� ��� �������������������������������*�������������������������������=���������� ��*���� �� ���������� ���� =��=���� )�� ��� ��� �������������*� ���� #@�� *���� ������ ��Z���*����"� ���� ���������� ���������� ��������������������
>���� �������� ������� ������ �����*�� ��� ��������� ������x�����&/����!��?&~]��+)�_���B�������������*��*������������������� ��������� �� ����� ���������������� �� ����� �����&/����!��?&~]��+)�_���B������������������Z�������������������������������������������������������������������������=���������������������������������������_��������������*�����������������x���������+)��������Z����*�����������������������=��������������������+����*������x����������+)� �������������������� ����������� ����������=������������������� ���������*����������������������������������������������*��������x�����&/����!��?&~]��+)�_���B����������*��*��� ���Z�������������������������������
����*�������Z������*���**���������������������/�^����!��������������������&&������!�� �������������������*���**������� �������� ��� *������� ������ ���� ��� ������ ?����*����������B�� ���� ������ �������� ����� ��=��� ����� ���� /�^����!��������������������&�������!����������������������������������� ����� �� *������� ����� ���� ���� ����� ���������������������������**��*���������������������������)�������������������� ����� *��� ����� &���� ��!�� ��� ���� ������ �� ��� ������������������� ������������������������*����������������������� ���~�� ���� ���� �������� *��� �� ����������� �� �����������+��� +����� _��� C������� ������� ���� _��� ������� ������� �������*��������������=��=��������*�����������*�x�**���������������������*�����&/����!������*�x�**������������������*�����������������������������?��������������B�
&/����!������*�x�**������������������*�����������������������������?��������������B�
SUPPLY GAS REGULATOR���� *�x�**� ����� ��� ���� ������ �������� ��� ����� ������������� ���&�������������!��?]��]����B�������������������&/������������!��?$�/^����B������������)��������������=�����\����������������������������������������������������������������������x�����������������������������*��
)���������=�����\���������������Z���������������������������
INSTALLATION REQUIREMENTS
15
HOT WATEROUTLET
TO TANKINLET
CHECKVALVE
MIXINGVALVE
COLDWATERINLET
TEMPERED WATEROUTLET
12” TO 15”(30-38 cm)
CHECKVALVE
Figure 8
����#�������+���������V��������������**�����������������&���V�?�]�!B�������������������������"�������������������� �� =���� ������� �� ����� ��� ���� ��� ����� ���� ������������� �������������������������������������������������� ��{������������=����&���V�?�]�!B�������������������������\���������������������*��������
��{��� ��� �� ���������� �� ���� ���� ���� =��=�� ���������� ��� �������������������������������������������*���#�=������������������������������������*���+��������������������'�����*�� ����������������%&�
NOTE:����*���������#+V�+������������������������Z���*��������� ��*��������������������*��� ��������������������������������� ������������������=��������������� =���������
CLOSED WATER SYSTEMS
������ ������ �����*�� *��"� ������ �� ���� ��Z���*������� ���� ��������� ��� ����� ����� �������"� �*��� �����"� ��=������������ ��=����� ���� ��� �������� �������� =��=��"� ������=��=��"����� ����������=��������'�=��������������������������������������*��� ���������������*�
THERMAL EXPANSION
��� ������ ��� ������"� ��� �x������ ?����*��� �x������B�� )�� �������������*�����=�*���������������������������������������������=�*�������������������������� ���������������������������������������������������*����x������������*����x�������������������*�����������������?�������B������������ �� ������� ��� ��� �=����� ����� ���� ��*����� ��������������*����x�������������������������*���������*�������\��������C������(��=���������������������������� ��*�����=��=����� ���x�����=���������� �������������������� ������ �=����� ����� ���� ��*����� ���������� ���� ��*�������\��������C������(��=�� ������ ������������ �������������������������*����x�������
�� �������� ������ ����*��� �x������� ����� *��� �� ���������� ������ ������ �����*�� �� ������ ���� ���*��� �������� �� ����*����x��������!�������� �������* �������=����������� ����=��������*����x����������������������
+���������;����!����������������/]����������������������'�����*�� ����������������%&�
MIXING VALVES
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
�������������������*�����������������������������������������"�������������"�������������������������������������������������*������ ��{��� ��� �������� +���� ��������� �������� ������������� ���*����������������������������*�����������������������������x��������������������������*���������������� ������]��V�?&&�!B�+*�� ������ ���� *��� ������� �� �� ���*�������� ��{���� ����� ������ ����� ������������� ������� ���� �������"� ��������"� ��������*� ���� ���� ����������~*�������� ���� ������� ��� �� ����� ��������x�*���� ��*�\�\ ��� ������������ ��� ��*��� ����� ������)�� ������ ����� ��� ������ ��=����� �� ���� ������ ������� ������������������������������������������������������������������������������Z������������������������*������������������������"������������������������*��� ��������)������������������������������� �����*������������������������������������*�����������������������K�x����(��=������� ��������������� �����������������?����V������B������ ��������������������������������������*���������*��������K�x����=��=��������=���� ��������* �����������������!������� `������� )��������� �� +��=���� �������� V���� *�x���� =��=��*��������������������������������������������=��=���TABLE 6
��������*������� �V�?�!B
��*�����&���'������[�� ?;����+�=����[���B
��*��������*������[��� ]���<�$���'�����
?K���+�=����[���B&&��?/$B ?��*�����������*��B&&��?/%B ?�������������B&&��?/%B $��*����� /��*�����&]]�?��B &�*���� ��*�����&$&�?��B �������� ]��������&/��?��B ]������� ��������&/^�?��B &������ ]�������&�/�?��B instantaneous &������
?Q�+��_=���*����K�*����*"�!���+�!�"�������;����*�����"�+�����&�"�&^%�B
DISHWASHING MACHINES
���� ������������ *�������� *������� ���� #������� +���������V������� ��Z���*����� ���� ��������� �� ������� ����� ������������������ �������&������]������������Z���������?&�$���������&%$����B��V������������� =��]������������Z���������?&%$����B"��� ����&������������Z���������?&�$����B"����������������*�������������������������������������������������"����������������������������������������������=��=������� �� ���� ��� ���� &���V� ?�]�!B� ����� �� ���� ������������*������� ���� ����� �� ��{����� �� ����=��� ������ �������� ���������������*����
16
������ ������Z����Z��������� ����� ����*����������*����� )��������������������������������������������������������� ���*����"��������������*������������������*����
Water Damage Hazard
Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.
CAUTION
T&P Valve Discharge Pipe Requirements:�� +�������� ���*������ �������� �������������������������� ����
=��=�"�����=������������������������������������������� +�������� ����������� �������� +�������� ���x������������������*����������� +����� ����*��������������������������������� ������ +����� �������������������������*����������������� �������
��*�������\��������C������(��=��������������������������� K������*��������*�x�**�����x��������� =�������������
���x������������� ��������)���������*����"����������**������������������������������ �����*����������������Z��������������������� �������
�� +����� ��� ��=������ =��=���� ����� �������� ������� �����������=��=����������������
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
���� ��*�������\�������� C������ (��=�� *��� �� *��������������� ��� ������ ������ �� ������ !����� ����� �� ������ �������������?&B��������� ��� ������������������������� ������*�������\�������� C������ (��=�� ���������� ����"� ���� ?]B� ���������� *������� ����������� ����� ��� ����� ���� ����� ��{��� ���������� ��*���� ������ ���� ������ *��� �� �x���*���� ���� )�������� *������� ��������� ���� =��=�"� ��� ������ �� �*�������� ���������������������������������"��**���������������������������������� �� ����������������"� ����� ������������� ����������� ��� �����*����"�������������������*�������\��������C������(��=����������������������~�������������NOTE:�����������������*�������\��������C������(��=����������=�����x�����=����*������������������������������������������ ���� �<�� =��=�� ��� ��� ��������� ��� ���� �������� ������� ������*����x����������������������������*����x������������*��� �����������������������������*��������������*����x������"�����!�����������+����*����������*���:x��������������&��)�� �� �� ��� ���������� ������ ����������� �� ��=�� ����Z�����������������������*�������\��������C������(��=���������������������* ���������������� �����=����������*�����������������������������
TEMPERATURE-PRESSURE RELIEF VALVE
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
����� ������ ������� ��� ��=����� ����� �� �������� �����~������ ������������� �* ������� ��*�������\�������� C������ (��=�� ?�<��=��=�B� ������*���������������=��=�������������� ���������������������������������� �����������*����������������������������� �������� �� ������� �Z��*���� �� *��������� ��� *������� ������Z���*����� ���C������(��=��� ���>��������+�����+����*�"��#+)��]&�]]���!+��/�/"���������������Z���*��������+K:�)�� ��������"� ���� ���� �<�� =��=�� *��� *���� ���� ��Z���*������� ����� ����"� �� ��� ����� ����� �� �* ������� ��*�������\�������� C������ (��=�� �����~������ ���� ��������� ��� ���������� ������� � =�� ����������� ���� ���� =��=�� *��� �� *������ ����� ��*�x�**� ���� �������� ��� �� �x����� ���� *������ ���������������������������������������������?&������� �&"�$�����B��������������������������������������������������������[�~�����������������������������������������������*������������� ���NOTE:�)�����������������������������������*�������\��������C������(��=��������������������"��������*��������������������*��� ��������������������������������������������������*���������=�� ��������������������"� ��������������=�����*�������\�������� C������ (��=�� ����������� !���� ���� ���� ����� ����������������������* ��� ������������� �����=����� �����*�������������������������������������������*�������\��������C������(��=�������*����������������V���������������������������������"�������*�������\��������C������(��=��*������ ����*=�����*�������������������������� �������� ���� ��*�������\�������� C������ (��=�� *��� ������������������������������������������������������������������������������=��=���)���������������������������������������������������x����������������������������?&��]��*B�� =��������Z������������"����x������� �� ���� �������� )���������*����� ��� ��� ���**�������������� �����*����������������Z��������������������� ��������[���������������������������*���������������=����������������������������������������*������ �� ������������������������������������*���������:x�����=��������"�=���$�������?^�&/�*B"��������*������������� ��������������������������������������������������������������=��=��#� =��=�� �� ����� �������� ��� �� �� ������� ������� ������*�������\��������C������(��=����������������'��������������������� ������� ��������� �� ���� ������ ������ �� ��� ?&��]� �*B����� ���� ��� ��=������ �� ���=���� ����� ��{��"� ������� �� ����"� ������������*���"������������=��=��*��� ���������������������
17
CONDENSATE DRAIN���� ������ �������� �=����� ��� ����� *����� ���� ��������������������� ���� ��Z���� �� ������� ������ �� �� ������� ��� �������x�*�����������������������������������������
!������������������*��������������������������x������� ������������ ���� ��*����������� �������������������������� �����*��� ��� �� ���=����� � =�� ���� ���������� ������ ����������� �������������� ����"� ����V�����^�� )�� ��������������������� ������ �������� ��� ����� ���� �� ��� ���� �x����� ?=���B� �� ������������� ��������� ��������� ������������������ ����[������:x������������������������������������������������������*�*������ ���� �������� ��������"� ��� ���� [������ :x����� +���������������������� ���������������*������ �������������� ����������� ��������� ���� �[������ :x������ V���� *������� ����� �����������������������������*���;!'"�����V��������������!�������� �����������������&�
NOTE:�)�������[������:x�������V����*�����������=������������������������������*�;!'"��������������������������������������������������� ������
CONDENSATE DRAINLINE - FIELD INSTALLED
CONDENSATE DRAINLINE CONNECTION
EXHAUST (VENT)ELBOW
BUILDINGDRAIN
FACTORY INSTALLEDCONDENSATE TRAP
CLEANOUTPLUG ISREMOVEDTO CLEARDRAIN
Figure 9CONDENSATE DRAIN WATER TRAP
Ensure a functioning water trap isinstalled in the condensate drain.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
DO NOT� ��*=�� ���� ������� �������������������� ����� ������������"� ���� V����� ^�� ���� ������ ��������� =���� ����� ��� ������� ������� �����=�� ������������� ������ ����� ���=����� ��� ��������*���������� ���� ���� �����������������+���!���������'�����)������������������$��
CONDENSATE PH LEVEL���� ���������� ������� ��*� ���� ������ ��������� �=����� �������� *����� ��=�� �>� ��=���� ������� /�$� ���� ����� )������� ���**����������=���� ������������������������Z����� ������������
NOTE:�;�����>���=����������������'�������������*���������������"� ���� ��� �����"� �� ���� ������ ������� ��� ����� ������� +���!���������'�����)������������������$��
COMBUSTIBLE MATERIAL STORAGE
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
Avoid all ignition sources if you smell gas.
Do not store or use gasoline or other flammable vapors andliquids in the vicinity of this or any other appliance.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
Maintain required clearances to combustibles.
Do not expose water heater controls to excessive gaspressure.
�����������������������������������������* ��� ���*��������"��������������������**� ���=�����������Z����
CONTAMINATED AIR
Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
!������������������������=���������*�*������������������* ����� �������� �������� ���*����� =������ +��� �������*�����������������������������������x������
!* ����� ���� ����� ��� ����*������� ���� �������� ��*������ ��������� ����� �� ���� ������ ������� ���� ������ ������� �*������������������������������������� ��������������������������������"� ����� ���� �������"� ������ �������� ���*������ �������*������������������������������������������������������������* ����"�=�������������* ������������������������*����
'��������������������������������������������������������������� �������������������������������������������������������������������*�������)�����������"������*���������������� �� ���������*���*����������������������*����������������� =����� ����� ������� �� ������ ������� ��� ��� �� �� �����=����*�������� ?+��� ��*����� ��������� ��� �*������ ���*�� ������������B�
)������������������������ ��������� ���������"� �� �������"���������� ���� ����*����"� �� ����\���=���� ��������� ����� ��������������Z��*���"���� ����*������=�����������������������?�B� �����������������'������(���������������������������������* ������������=��������������*�����������*���������������������������������������+���(�������)������������������]]�
18
UNUSUALLY TIGHT CONSTRUCTION)����������������� ��� �������"� �����������*��� �����Z������ ��=���� ���� ��� �* ����"� =���������� ���� ������� �� ����������>��=��"���� ���������������������������������?����x�*���"� �������� ���������"� ���=���� ��������"� ������"� =���� ������"�����B���������������*��� ����=��������������*������������ ����������!������+�����������������������
CONFINED SPACE��!������+����������������=�*��IS LESS THAN����� ������������&"����[�~���?/����*�������B����������������������������������������������������������������
@��������*��� ����������������=������������������* ����"�=���������������������������������������������Z��������������������������������������������*�������������=���������������������������������AND����������[�~�������������������������������������������������������
DIRECT VENT APPLIANCES��������������������������'������(�����������������������=��������������* �������*�����������*��������������������������������������������������������������������������������[�~�������������������������*�������������������������=����������������������������������
EXHAUST FANS�������x�����������������������"��������������������� ����=������� �������� �����x���������������������x����� ���� ��� ������������� ���� ��*�� ������ ����� �� ������ ������"� ��������� �������� ����=���� ������ ���� *��� �� ��=����� ����� ���**����� ������Z���*�������������������������������*����������x����������Q����������������������� ��������� �� �������� ���� ���� �*��������������������������=���������*������������* ������+����"���������*���������������������������������������������x������*����������)�������������������������������x������
LOUVERS AND GRILLES��������������������������������������������������������������������������������������������������������=���"����������������������������������
���� ��Z����� ����� �� �������� ��� �* ����"� =���������� ��������������������� �� ��������������������������������������������������������������������������������=������������������������ ����"� ��� ������ �� ���� ��� ����������� ���� ����� �� ���������Z���������=���������������������������������������=����������������������������������������������"� ��������� �����*������������=�����������=��]�����������������*������=�����������������������=��%��������������#��*��������=���������������������� ���x���������������������
AIR REQUIREMENTS
Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
V���������������������Z�����������������������*���������������* ���������=����������*��� ����=�����
��� ����������� ������ �� ���� ���� ����� ������������ ���* ����� ������� ��������� ��� ����*������� ����� *��� ������������������+���������������������������������������"��*���� ����� ��*�"� ������� ������ �� ���� �* ��������* ��"� ������ ���� ��� � ��� ���� �������� �� ����� �������x������
'������������ �����������������������������������������������Z��������������������* ���������=������������� ������������������������������*������������ ����������!������+������������������������
#�=��� ���������������=���������������)������=������� �����Z�������������"����������������������V����������=���������������*������* �������������������������������x�������������������������*���"������� �������{�����������
UNCONFINED SPACE���Q��������+����������������=�*��IS NOT LESS THAN ���� ������������&"����[�~���?/���� ���*������������B�����������������������������������������������������������������C*���**��������������������������������"����������������������������� ���������"� ������ �������� ��� ��������� ����� ���"� �����������������������������������������
K����� ���� ��Z���*����� ��� ���� �������� �� �x����� ����"���������=���������������*�"��������������������������������������� ������������ ��������*������ �������Z�������������� ����=�����* ����"�=�������������������������
19
���������=����������������*������������"��**��������������&]��������?$���**B�����������������������"������� ����=������+��� V����� &&�� ���� ������ ������� ������ ��=�� ����������� �� ���������&������?]��**B���*��������������� �����������������?����**B���*���������������������������������������������������������**������������������������������**���������������=����������������������� �� ����������������������� ��������**���������������������������������=����*���**�������������������������&�� &��Z�������������$����[�~���?%$$�**]�������B������������
��������������������������������������������������"����]�� #�����������������*�������������������=����������������
����������
OUTDOOR AIR THROUGH TWO HORIZONTAL DUCTS
Figure 12
���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*�����������������������������������������**�������������������������������+���V�����&]�:�����������������������=����*���**�������������&��Z�������������]"����[�~���?&&���**]�������B����������������������������������������������������������������������������������������"������������ ����������*��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������*���**���*���������������������������������� ���������������$���������
FRESH AIR OPENINGS FOR CONFINED SPACES
���� �������� ����������� ������ �� ���� �� ��������� ���� ����"��* ��� ���� �����*���� �� �������� ��=������ ������ ���� ����* ����"� =���������� ���� ������� ��� ������� �������� ������������������������������������������*������������������������ ���� �������� ����� ��=���� ������ ���� ���� ������� ������������DO NOT������������������������������������������=����������������� +��� (������� )����������� �� ����� ]]� ��� �*������=������������������������������
OUTDOOR AIR THROUGH TWO OPENINGS
Figure 10
���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*�����������������������������������**�������������������������������+���V�����&��:�������������������=����*���**�������������&��Z�������������/"����[�~���?����**]�������B���������������������������������������������� ���������� ��� �������������:�������������������� ������������&����Z�����������?�/���*]B��
OUTDOOR AIR THROUGH ONE OPENING
Figure 11
20
�����������������"������������ ����������*��������������������� ��� ���� ����� ����� �� ���� �������� �� ������ ����� ������������*���**���*���������������������������������� ���������������$��������?%��]��*B�
AIR FROM OTHER INDOOR SPACES
Figure 14
���� ������� ������ ������ �� ��=����� ����� ��� ���*�������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*����������������+���V�����&/�:���� ������� ������ �**������� ��������� ����� ��� �����������*?�B������������=�*��������������* �����=�*���������������*������������������������Q��������+�����:�������������������=����*���**�������������&��Z������������� &"���� [�~��� ?]]��� **]� ���� ��B� �� ���� ���������� �������������������������������������������������������:�������������������� ������������&����Z�����������?�/���*]B��
OUTDOOR AIR THROUGH TWO VERTICAL DUCTS
���� ������������ ����� ��� ����� ������� �� ���� *����� ���� ������������ ��� ���� �������� ����� ��=���� ������ ���� ���� ������������������DO NOT� ������ �� ������ ������������ ��� ���� ������ �� =����������������� +��� (������� )����������� �� ����� ]]� ��� �*������=������������������������������
Figure 13
����������������������� ����=����������������*������=������������"�����**��������������&]��������?$���**B������������������**��������������&]��������?$���**B������� ��*��������������������=��������������������**�������������������������������+���V�����&$�:�����������������������=����*���**�������������&��Z�������������/"����[�~���?����**]�������B������������������������������������������������������������������������
21
COMMONWEALTH OF MASSACHUSETTS
V�������������������*������"������������=�����������=���"��������=���"�����������������=������������������������������������������=������������"� ������������������������������������������������������������"������������������������������ ������!**���������������������������������x�����=�������*���������� ����� �������=���?%B� ������ =���������������� ��� ���������������=������"���������� �������*�����������������������"���������������Z���*����������� �����������
INSTALLATION OF CARBON MONOXIDE DETECTORS
��� ���� ��*�� �� ������������ �� ���� ����� ����� ��������� =���������� �������Z��*���"� ���� �������������* �������������������� ���=�� ����� �� ����� ������ ��� �� *�x���� �������� ����� �������*����� ������� ���\��������������������������=������������������Z��*��������� �������������)���������"������������������* ��� �� ��������� ������ ���=�� ����� �� ������� �������� ���������������� ��*�x������������������������*���������������� ����� ���������� ��=��� �� ���� ��������"� ������� �� �����������=��� ������������������������=�����������������Z��*�����)�������� ������������� ����������������������������������������=�������Z��������������������������������������������������������������� ��*�x�������������
)�� ���� �=���� ����� ���� ����� ����� ����������� =������ ���� �������Z��*��������������������������������������������"������������������� ��*�x���������������������*����� ������� ���\��*��� ��������������������x����{�����������=���
)�� ���� �=���� ����� ���� ��Z���*����� �� ����� � ��=����� ���� ��� ��*������������*�����*��������������������"������������������=�� �� ������ �� ������� ?$�B� ����� �� �*���� ����� ���� � =����Z���*�������=����������������������������?$�B����������"��� ������������������ ��*�x������������������������*������� ������������
APPROVED CARBON MONOXIDE DETECTORS
:������� ��*�x�����������������Z���������������������������� =����=�������������*���������#V���%]������ ���#+)~Q;�]�$/������������!+�����������
SIGNAGE
�� *����� �� �������� ������������� ������ ������ �� ���*��������*����� �� �����x�������� ���� ������������*���**����������������?�B������� =�����������������������������������x�����=�������*�����������������������=�������������������������������������Z��*������������������������"�����������������������������\�����?&~]B�������������"�“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OBSTRUCTIONS.”
INSTALLATION REQUIREMENTS - COMMONWEALTH OF MASSACHUSETTSINSPECTION
���� ������ �� ����� ���� ��������� �� ���� ����� ����� �����������=���������� �������Z��*�����������������=�� ���� �����������������"� ��� ���������"� ���� ��������� ���=��� ��� ��*�x�����������������������������������������������������������=��������]/��!KC�����?]B?�B�&�������/�
EXEMPTIONS
���� ���������Z��*���� ����x�*��� ��*�]/��!KC�����?]B?�B&�������/�
&�� �����Z��*��������������!�������&������������:Z��*����#��C�Z�������[��(��������������*�������������������#V����/����������� ������[��������
]�� ����������=��� ����� ����� ����������� =������ ���� �������Z��*��������������������*����������������������*�������������"� ������"� �� ������������ ���������� ��� ����� ����������������������
MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM PROVIDED
����� ���� *���������� �� ������ ����=��� ����� ���������������� =������ ���� �Z��*���� ��=����� �� =������� �����*����������=������������*��*������������ �����Z��*���"� �����������������=����� ������*���������� ��� �������������� �����Z��*������������=������������*��������������
&�� '��������������������������������������������=������������*��������������=������������*��*�����������
]�� ���*������������������������=������������*����������=������������*�
MANUFACTURER REQUIREMENTS - GAS EQUIPMENT VENTING SYSTEM NOT PROVIDED
����� ���� *���������� �� �� ������ ����=��� ����� ����������������=���������� �������Z��*�������������=���� ���������� ��� =������� ���� ��� �����"� �� ���������� ��������� =������������*�"�� ���� �������� ��Z���*����� ������ �� ��������� �� ����*����������
&�� ���� ����������� ��������� =������� �����*�� ����������� ������ �� �������� ����� ���� ���������� �� �Z��*���� ����������� �����������������
]�� �������������=������������*��������� ������������=��� ������[���"���������������������������������*����������������������������������������������������������������
�� ���� �� ���� ������������ ����������� ��� ���� ����������=������������������������=���������� �������Z��*���"����� =�����������������"� ���� ������ ������ ��� =������� ����������"� ���~�� ����=������� ������� ����������� ������ ��*���� ����� ���� ���������� �� �Z��*������������*�������������������������
22
]�� )�� ���� ������ ������� ��� �� �� ���������� ��� �� ����� ���"� �� ��� ���"� ��������� ���� ����*���"� �� ������� ����� ��������������Z��*�������������������������*������������������*������=�� ����� ���� ������ ������?�B� �� ���������� ��� �� '������(���� ���������� �� ����� ���� ���� ��� �* ����� ��� ����=�����*�����������*�������
$�� ����=��������������������������*������*�����������
/�� ����*���**�������������*��* ��� ���*��������� ��� ����=����?�x����B����������������������������� ������������(����������������������������* ��� ������������������*��� ��������������?��{����B�
��� �����������������*��� �������������*����������������������������������������
��� ����=����?�x����B������*������ ���* ���������������������������������������=���������*������*����
%�� ���� ����������������*������ ���* ���������������� �����������������������������������������
��� ;��������������������������������=����?�x����B������������������������������*���������������*�x�**��Z�=����������������������+���(�������C�Z���*������������]/�
^�� '����������������=�����������������������������*����������������������������� ������������������������
&���(����������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�
&&��'��������������=������ ������������������������������*��������"����������������������� �������������������������������������=����=� �������������*� ����������*������
&]��Q�����������=���=���~��������������������������*����������+���(�������C�Z���*������������]/�
&$��Q������� ���������������=�������� ��������������������������*���������+�������(�������C�Z���*������������]/�
&/��'� ��� ������ ���� =���� ?�x����B� �� ������� ���� ���*�������������� ����� ���� �� {������ ��� ��� �� ����� ��� �������*������?�B����������������������������������������*����������������
&���'������=����������������������������������������"�����*�"����� ������� ������� ���� ����� ������������ �� ��� �������C����������� �� ��� ������ ����� ����� �����"� ���*������������ �� ���� ����� �x�������� ���� ������ �� ���� �* ��������� ������� ������ ��=���� ���� ��������� �� ���=���� ���������������� �� ��� �����"� *�������� ��� *��� ��������� ������� ��� ��������������������������=�������*��������
&���'��������������=�������*�������=������ ���������������������������=������������������������������������
&%��:������������������������������������������*�����������������������������������=���� ��������������=���������*�
&���+��������=�����������~������������ ������������������������� ���*������ ������������� )�� ������ ����� ���*��� ���� ���� �� ���������������������"���������������������*=��������������������������������"����������*��� ����������"������������*������������*��� ����*������������������������������x�������)��������������������*���*�����������������
&^��:�������������������������������������������������������������[�>�&^^~]���*����"����������]$���������������
]���!�����������������(�������C�Z���*������������]/�����������������������(�������)�����������+�Z������������]��
VENTING INSTALLATION
Breathing carbon monoxide can cause brain damage or death.Always read and understand the instruction manual.
Install vent system in accordance with codes. Do not operate water heater if flood damaged.Special consideration must be taken with installationsabove 10,000 feet (3,048 m) refer to high altitudesection of this manual.
Breathing Hazard - Carbon Monoxide Gas
Do not operate if soot buildup.
Do not obstruct water heater air intake with insulatingjacket or blanket.
Do not place chemical vapor emitting products nearwater heater.
Gas and carbon monoxide detectors are available.
Never operate the heater unless it is vented to theoutdoors and has adequate air supply to avoid risksof improper operation, fire, explosion or asphyxiation.
Analyze the entire vent system to make sure thatcondensate will not become trapped in a section ofvent pipe and therefore reduce the open crosssectional area of the vent.
#�=���������������������������������������=������������������
������������������������������������*�����*��� ������������=����������* �������������������������������+������������ ����� ������ �� ���� �* ����� ���* ��"� �������������� �����������������������������x������
GENERAL VENTING INFORMATION���� ������ �������� �=����� ��� ����� *����� ���� �������������Z�=������ �� !������� )(� ����������� ���� *��� �� ���������� �����������������(������'������(��������������
CATEGORY IV APPLIANCE!������� )(� ����������� ������� ����� �� �����=�� =���� ?�x����B�������������������������=�������� ��*��������� �������� �������������������������=�����������POWER VENT CONFIGURATION����� (���� ����������� ����=�� ���� �* ����� ���� ��*� �����*� ������ ����� ���� ���������� ���� ���������� ���� ��� ������ ������������*������� ���������������=���� ?�x����B������������=�����������������=�����=����������������������������������������������� �����*������������=��������������������������*�����+���V�����/������V�����/&��������$/�DIRECT VENT CONFIGURATION'������(�������������������=�������* ��������������������*����� ���� ��*������� ������ �� ������� ������� ���� ����� �������������� ���� ��� ������ �� ���� ���� ��*������� ������ ���������=����?�x����B�������'������(�����������������=����������� ��������� �� ���� ������ ������"� ��� =���� ����� ���� ��������������������'������(������������������� �����*������������� �� ��x� ���������� �������*������ +��� V����� /]� �� ����� $/�������V�����/%��������$��
GENERAL VENTING INSTRUCTIONS�����������������*��� ����������������������������
&�� DO NOT������������������������������������(�������������������� ������ ��� ���Z���� ������ �� ������ ���"� ���� ����C�Z���*����� �� ����� &��� )�� ���� ������������ ������ ���������=����������Z���������������������������������������*��� �����������������'������(��������������
23
���� ������� ���� ���� ������� ��� ������� ���������� ����� ���� &~]� ����� �������������� �� ���������������������������x�*������&$�������� =������ ��*� ���� ���"� ���� V����� &��� ���� ���� ���������&~]� ����� �������������� �� �*��� ��� ������������� �����?������� ���� ����B� ����� ����� ������� ������������� ��������������"��� ����^���������"�����������=������������������������������������ ���INSPECT/ADJUST INTAKE AIR TEE FITTING)������� ������������ �����������������&~]� ����� �������������� �� �������=���������*������������������"�����V�����&���)�������������� ���������������&~]� ����� �������������� �� � ��� ��������������"���{��*��������� �����������������{��������������������������������������������������������� ����Adjustment Procedure:&�� :������������������������������������������~������������
����������������������������]�� '�������������[������)�������������������������� �"�����
V�����/��������^�����������$�� ;���� ���� ������ ���� ���*�� �� ���� V����� ������� �����
�������� ���� ����������� �������������� �� ����!* ����� ����"�����V�����&%�
/�� ��{�����������������������������������������&~]������ �������������� �� �����������������������������������V�����&��
��� C��������� ���� �������������*��������!* �����[����������������V�����������"
��� C������������[������)�������������������������� ��*����������������������� ������������������������� �������������������������
INTAKE AIR CONNECTION PIPE199,000 & 250,000 Btu/hr MODELS
LARGE HOSECLAMP
3 INCH PVCINTAKE AIRTEE FITTING
FERNCOCOUPLING
Figure 17
BTH 199 & 250 INTAKE AIR CONNECTION
[�>� &^^� ���� ]��� *����� ���� ������� �Z������ ����� �� ��Z��!* �����[������������������������������������������������������$��x�$��x�&~]������������������������������������������������������� �� ������������������&~]������ �������������������[������)�������������������������� �"�����V�����&��
FACTORY INSTALLEDINTAKE AIR TEE FITTING
COMBUSTION BLOWER ASSEMBLY199,000 & 250,000 Btu/hr MODELS
COMBUSTION BLOWER
1/2 INCHBRANCH
HOSE BARB FITTING FORBLOCKED INTAKE AIRSWITCH SENSING TUBE
FERNCOCOUPLING
Figure 15
:������������� �� � ���������� ������������������ IS NOT� ���������������������������?&����\���������������B� �����=������������������� ����������� �� ��������*��� ��������� �������^���������*��������&$��������������V�����&����)������ �� ����������� ����������"� �������� ���������� ���������������� ��*�� ������� �������������������������� ���� ����[������ )��������������������������������������������� ��������*��������������������������������������������[������)�������������������������������������������������*��������
90° TO 130°
CORRECT ORIENTATIONINTAKE AIR TEE FITTING
END VIEW
Figure 16
24
�Z�=������ ����� ?$���� *B�� ):�� @�� '������ (���� ������������� ������������� ������&]���Z�=�����������?$����*B�
MINIMUM EQUIVALENT LENGTHSThree Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� �� ��*���**� ������� �� $� ����� ����� ��� ���� =���� ?�x����B� �� %��Z�=������ ����� ?]�&� *B�� ������ ��� �� *���**� �Z�=������ �������Z���*���������������������������Four Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *���**� ������� �� /� ����� ����� ��� ���� =���� ?�x����B� �� ����Z�=������ ����� ?&��]�*B�������� �����*���**��Z�=������ �������Z���*���������������������������MAXIMUM NUMBER OF ELBOWSThree Inch Pipe����=���������*�����=����*�x�**������̂ ����� ������������������$� ���������� ��� �������������� ����������������*���������=����*�x�**��� ���^����� ��� ����������� ):�� �����'������(������������������������������=���� �� ���^����� �������������Four Inch Pipe����=���������*�����=����*�x�**�����x�^����� ������������������/� ���������� ��� �������������� ����������� �����*���������=����*�x�**�����x�^����� ��������������):�������'������(������������������������������=��������x�^����� �������������FACTORY SUPPLIED FITTINGS���� ������ ������� ������ ����� ��� ?]B� ������� �������� $� ��������*�������� ?�(!� /��� �� ��� ����� �� ���� ������B�� V�������������� =���� ���� ������� ���� ���*�������� �� �������������*�������� *��� �� ����� V������ �������� ���*�������� ����������������������?�x������� ������ �������������������B����������Z�=�����������������=��������������������������
TABLE 7Number of 90° Elbows Installed
3 Inch Pipe 4 Inch PipeMaximum Feet (Meters) Maximum Feet (Meters)
@���?&B /�������?&$�%�*�����B &&�������?$����*�����B���?]B /�������?&]�]�*�����B &&�������?$$���*�����B������?$B $�������?&��%�*�����B &��������?$]���*�����BV��?/B $�������?^�&�*�����B &��������?$����*�����BV�=��?�B #~� ^�������?]^���*�����B+�x�?�B #~� ^�������?]%�/�*�����B
4 INCH EXTENDED VENT TERMINATIONS
�����/�������������������=���������������������"����������������/���������*��������*��� �������!�������������������� ��������������������������*����?������* ���������������� �����=����������*����B��������/���������*������?�B�OPTIONAL CONCENTRIC TERMINATIONS�������������������=����� �������*�����*��� �����������������'������(���������������������/�������������������*��������!��������� ���*�������� *��� �� ������� ������������ !�������������������� ��������������������������*����������* ���������������� �����=����������*������������Concentric Vent Termination Part Numbers:
�� /��!������������*�������¡�^���$]����
VENTING REQUIREMENTS
APPROVED MATERIALS����=���=������������������������*��������������*��� �������������Q������+������
�� �(!�+�������/��?�+�K�'�]]/&�~�!+��[&�&�]"��+�K�'�&%���~�!+��[&$%�$
�� !�(!�+�������/��?�+�K�V\/&&�~�!+��[&$%��B�� �[+�?�+�K�'\]��&B
����=���=������������������������*��������������*��� ���������!������
�� Q;!�+�$���(!�~�!�(!
FIELD SUPPLIED FITTINGSV�������������������������� ���Z�=�������������������*�������� ����������������V��������������~��������������������������Z�=�����������������=������ ��������������������� ���������� ���������������������~���������� �������� ���� ������� *��� �� �������� ���� �����Z�=�����������������������
�� ^����� ���?����������������B������Z�=����������������������?&�]��*B���������
�� /����� ���?����������������B������Z�=��������]���������������?%���*B��������
PRIMER AND CEMENT�������������� ?�>VB� ���*��� ����� �� ���� �� �������� ������������������������������������=�������������)��!�(!����[+�������������������������"������������������*����*��� ��������� ���� {����"� ��������� {������ ���� ����� �� ���� ������� ��=��������*�������� ?�(!� *�������B�� �(!� K��������� ����� ����+�K�'\]��/�_�����!�*�����!�(!�K������������������+�K�V\/^$�_����� !�*���� ���� �[+� K��������� ����� ��� �+�K� '\]]$��_�����!�*����
PIPE SIZE REQUIREMENTS�������������������=�������������*������������������������������$�����/������������������=����?�x����B������������������������)�����������������Z�=���������������������������������=���������������� ����������?&��]�*B�������"�$�����������*��� �������)�����������������Z�=������������������ ��*����������������?&��]�*B"�/�����������*��� ������
NOTE:�)�����������������������Z�����������������������Z�=���������������������������������������� ):��)�� ���� ��������������������� ������Z�=��������������������������=��������������*������������Z�=��������������������������������*��� �����������������$�������������������=����*��� �����������������/�����������
MAXIMUM EQUIVALENT LENGTHSThree Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *�x�**� ������� �� $� ����� ����� ��� ���� �x����� =��������������*���� �� ��� �Z�=������ ����� ?&��]� *B�� ���� ���������*�x�**� ���������$� ���������� ��� ������������������ �����������Z�=������ ����� ?&��]� *B�� ):�� @�� '������ (���� ������������� ������������� ����������Z�=�����������?&��]�*B��
Four Inch Pipe���� ������ �������� �=����� ��� ����� *����� ���� ��������� ���� *�x�**� ������� �� /� ����� ����� ��� ���� �x����� =��������������*���� �� &]�� �Z�=������ ����� ?$���� *B�� ���� ���������*�x�**����������/���������������������������������������&]��
25
^�� ����=����?�x����B�������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�
&���)�� ����������� $� ����� =���� ����� ������� ���� =���� ����� �� �����x������� ���������������������
&&��)�������������/�����������������������$�������������������x������� ��������������������������������V�����&���������������������� $�� ����� ������� ���� �x����� �� �� ���� ���� /�� x�$��������������������� ��&���������?/���*B��� ���������������
DIRECT VENT INSTALLATION
&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ������������������������������������� ��Z���*�����*��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� '������ (���������������
]�� '����*���� ������ '������ (���� �������*���� ����� �� ���� ������� ������������� ������ ���� ��x� ?�B� '������ (���� �������*�����������+����V�����/]�<�V�����/$��������$/�����V�����//�������V�����/%��������$��
$�� '����*����=�������� ��������������������� �� ������ ��� ���������������������(�������C�Z���*������������]/�
/�� ��������������������=�������������������������� �����������*� ���� ���*������� ����� ����� �� ���� ������ ��������;���� ����=�������� ������������������ �������*���**�������������� ���
��� )��������������*��������������)�� ��������� ���*�������� ���� ����� ���� ���� ���� ������� ������ =���� ������� ����� ���*������ =���������"� ������ �� ��"� ����(�����������*�������)������������������]%��)��������������*������������ ������������������������������=�������������������*����������������"�����������������"�����+�����������*�������)������������������]^��)�� �� ���������� ���*������?�B� ����� �� ���� ���� !������������*�������)������������������$��
��� ����� ������������ �� ���� ���*������?�B� ��� �*������ )�������������������������������������������������������������=����������� �����������������������
%�� ���� ���������������=�����������*��� ���������������������=��� ��������� �������������������������*�������������**��������������=�������������������������� �����������=�����������?&�]��*B���=����������������=����$������?^&��*B���������������
��� '����������������=�����������������������������*����������������������������� ������������������������
^�� ������������������������������������������������������� �����������������������������������������������������������������������*�������������=���������*������������������������� ��������� �x��������� ����� �*������� ���� ������ ��������� �� ����� ��������Z���������������������� ��*����������������������������+���V�����]&��������]��NOTE:�+��� ����������������������������������������������*�������������������x�����=���*���������������*������������*������������������*�����������*"��*�����������������������x�����=����������������������������������������������*���������*������������������*�������
&����������������������=����?�x����B��������*��� ������������*���**�����&~/������������� �����������������������?���������������������������B�
VENTING INSTALLATION SEQUENCE
&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ��������������������������������� ���� ��Z���*����� *��� �� ������� �� �����������������
]�� '����*���� �������� ���� ������ ������� ����� �� ���������� ����� ����� (���� �� '������ (���� ���������� ���� ������ =���������*��������*��������� ��������������������������+�������=�����=��������������*�������������$/�����$��
$�� �������������������� ���������������� �����(����)������������������]���� '������(����)������������������]��
POWER VENT INSTALLATION
&�� C���� ���� _������� (������� )���������� �� ����� ]]� ����(�������C�Z���*������������]/� ������������������������������������� ��Z���*�����*��� �� ������� ������������� ���� ����������� ���� ����� ���� �������� ��� ����� (���������������
]�� '����*���������������(�����������*��������� ������ ��������������������=����������������������*��������+���V�����/������V�����/&��������$/�
$�� '����*��������=��������������������������������"�����(�������C�Z���*������������]/�
/�� ����� ���� ����� �� ���� =���� ������� ��������� ��*� �������*������� ����� ����� �� ���� ������ �������� ;���� ����=������������������*���**�������������� ���
��� )��������������*������������)������=�������������������*������=���������"�����������"�����(�����������*�������)������������������]%��)�� ���� =���� ������� ����� ���*������ ����������"� ������ ����������"�����+�����������*�������)������������������]^��
��� ����� ������������ �� ���� ���*������� ��� �*������ �����������������������������������������������=����������� �����������������������
%�� ����=���������*��� ���������������������=��� ����������������������������������*�������������**��������������=��������� �����������=�����������?&�]��*B���=����������������=����$������?^&��*B���������������
��� '����������������=����������������*����������������������������� ������������������������
3” PIPE FIELDSUPPLIED
EXHAUST ELBOWVENT CONNECTIONFACTORY INSTALLED
4” PIPE FIELDSUPPLIED
4” x 3” REDUCERFIELD SUPPLIED
VENT (EXHAUST) CONNECTION
Figure 18
26
&/��)�������������$����������������������������������������������������������������������������������������������
&���)�������������/����������������������������������$������������������ ����������� ����������� ���������� ������� ��� ����� ���V�����]����������������������$������� ������������������������������� ���� ���� /�� x� $�� ������� ������� ����� �� &���������?/���*B������������������
3” PIPE FACTORYINSTALLED
4” PIPE FIELDSUPPLIED
3” PIPE FIELDSUPPLIED
4” x 3” REDUCERFIELD SUPPLIED
3” COUPLING OR TEEFACTORY INSTALLEDINTAKE AIR CONNECTION
INTAKE AIR CONNECTION
INTAKE AIR
COMBUSTIONBLOWER
Figure 20
INSTALL TEE FITTING AS CLOSE TO WATER HEATERINTAKE AIR CONNECTION AS POSSIBLE
INTAKE AIR CONDENSATE TEE INSTALLATION
FIELD SUPPLIED3” x 3” x 1/2” TEEWITH HOSE BARBFITTING INSTALLED
FACTORYINTAKE AIRCONNECTION
INTAKEAIR
PIPING
CONNECT FIELDSUPPLIED FLEXIBLEDRAIN HOSE TO BARBFITTING AND FORM ALOOP WATER TRAP INDRAIN HOSE
RUN DRAIN HOSETO SUITABLE FLOORDRAIN SEPARATELYFROM OTHERCONDENSATE DRAINS
Figure 21
&&��)�� ����������� $� ����� =���� ����� ������� ���� =���� ����� �� �����x������� ���������������������
&]��)�� �����������/� �����=��������� ���������� ��$� ������������� �����x������� ��������������������������������V�����&���������]����������������������$������� ������������x������� ����������/��x�$��������������������� ��&���������?/���*B������������������
&$��:���������)����������+������������)����������!��������������������������������*=��� �������������������������������������������������������+���V�����&^��
Do not obstruct water heater air intake.
Gas and carbon monoxide detectorsare available.
Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
NOTE:� '� ��� ���=�� ���� ������� ������� ���� )������ ����!�������� ��� '������ (���� �������������� @���� ���� ��������������������������������������������� �����������*�=��������*��� ��*���������������� ����=�����*�������������������*�������* ���������*������� ����� ��[������ )�������������������������������������������������*��������
INTAKE AIR SCREEN(remove for Direct Vent)
120,000 & 150,000Btu/hr MODELS
199,000 & 250,000Btu/hr MODELS
3 INCH INTAKE AIR CONNECTIONSFACTORY INSTALLED
INTAKE AIR SCREEN
Figure 19
27
VERTICAL TERMINATION INSTALLATION
&�� '����*�������������������������*������?�B�NOTE:��������������=����������������������*������������������������������"�����V�����]]�
]�� )�� ��������������� ����=���� ?�x����B� ������� ����������(�������������� =���������� ������ ���� ���� ������ ����� �����x������ =�������� ���������� ��Z���*����� ����� ��� V�����]$�����V�����]/��������]������ �����*������������������������������������������� ������������������������*��� ��*����������NOTE:�@��������������������������=�������*�������*��� ����*���**���]/��������?����*B�� =�������������"�=������������������������������&�������?$�*B�������������+���V�����]/��������]��
$�� )�� ����������� ��� ���������������=����������� �����'������(�������������� =���������� ������ ���� ���� ������ ����� �����x������ =�������� ���������� ��Z���*����� ����� ��� V�����]$�����V�����]/��������]������ �����*������������������������������������������� ������������������������*��� ��*����������NOTE:�@������ ��� ������������� ���� ��������������� ����=�������*��������*��� ����*���**���]/��������?����*B�� =������ �������"� =�������� ����� �� �������� ������� &�� ����� ?$� *B�������������+���V�����]/��������]��
/�� )�����������������=���������������������(��������������=����������������������������������������������*��� �������������=�������*�������*��� ������������������������������������V�����]$�����V�����]/��������]������ ��*������������=�������*�������*��� ����*���**���&]��������?$���*B"�&���������?/���*B����!�����"�� =�������=���������x�������������=��������������V�����]$��������]���
��� )�� ����������� ��� ���������������=����������� �����'������(�������������� =���������� ������ ���� ��� ���� �������������������*��� ����������������������������=����������*�������������������*���������������������������V�����]���������]���������������������=�������*��������*��� ��������������������������������������*����������������������V�����]���������]��
�������������������=�������*��������*�����=����*���**�������������]/��?�&��*B�*��������������������������������V�����]���������]��� )�����������*������������������������� �����������������������/���������?&]]��*B����� ��*� ����� �� ���� ������� ���� ���� =���� ���*��������*��� ����*���**���&]��������?$���*B"�&���������?/���*B���� !�����"� � =�� ���� �=������ �� �x������� ���� ��=��� �����������V�����]$�����V�����]���������]��
��� ����� ���� ������� ���� ���~�� =���� ������� ��*� *������������� �������� ����� ���*������ ��� ���� ��*�� ������� ���� =�������*�������� ���� �� ������ �������� ��� ����� ��x�*���� ��������~��������)�������������*���������������� ��������������������������x�*������������~������������ ��������� ������� ���� ������� =���� ���� ������� �������*�������� *��� �� �� *���**� �� ]/� ������� ?�&� �*B���� ����� ��� V����� ]�� �� ����� ]��� )�� ������ ���*������������������������� �����������������������/���������?&]]��*B�
%�� !����/������?&���*B����*������������$��������������������?&$��*B����*������������/�������������������������?�B������������������������NOTE:�[������������������������������������������������������������
��� +������ ���� ����?�B� ������ ������� �� ���� ����� �������������*������������������Z�=������������*��������������������V�����]$��������]��
^�� +����� �� ��� �� �� �Z�=������ �������� =��� ���� ����� ���������� ��� �� �� �Z�=������ �������� �� ��� ���� ���������� ���� ����������� ����� ���V�����]$"�V�����]/�����V�����]���������]��
&���)����������������������������������������~��=�������*������?�B��������������������������������������������^����� ���������� ���V�����]$��������]������������ ��������������������������� ������������������������^����� ����������������������������*�������*������ ���x�����=����������������� �x����� ������ �� ����� ����� ������ �� �� *��� ����� ]��������?���*B"�����V�����]$��������]��
&&��C����� �� ����� (���� )����������� �� ����� ]�� �� '������(���� )������������������]�� ���*������ ���� ��������������������������������~��=����������� ��������������*������?�B����������������������
STANDARD FACTORY SUPPLIED TERMINATIONS
INTAKE AIR TERMINATION45° ELBOW WITHDOME SHAPED DEBRISSCREEN
VENT TERMINATION45° ELBOW WITHRECESSED DEBRISSCREEN
Figure 22
28
2” (5 cm)MAXIMUM FACTORY SUPPLIED
STANDARD TERMINATIONPOINTED DOWN TOWARDS
THE GROUND
VERTICAL TERMINATION(S) INSTALLATIONINTAKE AIR AND/OR VENT (EXHAUST)
FIELDSUPPLIED90° ELBOW
FIELDSUPPLIEDSTRAP/SUPPORT
FIELD SUPPLIEDPLUMBINGROOF BOOTOR FLASHING
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL.
NOTE: INTAKE AIRTERMINATIONSHOWN HERE
Figure 23
INTAKE AIR AND/OR VENTTERMINATION(S) MUST BE A MINIMUM OF 24 INCES (60 cm) ABOVE ANY PARAPET, VERTICALWALL OR STRUCTURE WITHIN10 FEET (3 m) HORIZONTALLY.
VERTICAL TERMINATION(S) FLAT ROOF CLEARANCEINTAKE AIR AND/OR VENT (EXHAUST)
24 INCHES (60 cm)MINIMUM HEIGHT ABOVE
IF LESS THAN
10 FEET (3 m)
NOTE: VENTTERMINATIONSHOWN HERE
Figure 24
VERTICAL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS
24 INCHES (61 cm) MINIMUM48 INCHES (122 cm) IN COLDER CLIMATES
FACTORY SUPPLIEDSTANDARD TERMINATIONSPOINTED DOWNWARD
FIELDSUPPLIED90° ELBOW
VENT (EXHAUST)TERMINATION
INTAKE AIRTERMINATION
FIELD SUPPLIEDPLUMBINGROOF BOOTSOR FLASHINGS
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATED SNOW LEVEL.
Figure 25
29
SIDEWALL TERMINATION INSTALLATION
&�� '����*�������������������������*������?�B�NOTE:��������������=����������������������*������������������������������"�����V�����]]��������]%�
]�� )�� ����������� ���� =���� ?�x����B� ������� ��� �� ����� (�������������� ������ �� ���������� ������ ����� ���� �x���������������������������Z���*����� ��� ���� ���*������"��������� V����� /�� �� ����� $�"� ���� ����� *����������� �������������������������������� ������������������������*��� ��*����������
$�� )�� ����������� ��� ���������������=����������� �����'������(�������������� ������ �� ���������� ������ ����� ���� �x���������������������������Z���*���������������*�������"���������V�����/^��������$%"��������=����������������������*����������� �����*������������������������������������������� ������������������������*��� ��*�����������
/�� )�� ����������� ��� ��� ������� ���� ���� =���� ���*������� ��� ��'������ (���� ���������� ������ �� ��������� ������ *��� ����*���**���]/� ������� ?�&��*B����������"�*��������� =�������� ������� ����"� ������� ���� ������� ���� ���� =�������*�������"�����V�����]��NOTE:�)�����������*������������������������� �������������� ��� ������ /�� ������� ?&]]� �*B� ������� ���� ������� ���� ����=�������*����������������������������=��������������������*�����\���������� �������������������������������� ���������� ������ �� ����� =��� ��*� ����� ������ ������ �x�����=�������������������������*�����������������**���������!���������������������
��� )�� ����������� ������������������=�������*�������������'������(���� ���������� ������ �� ��������� ���� ������� ���� ����=���� ���*�������� *��� �� ���������� ��� ���� ��*�� ���=�����*������������������������������\�����V�����]��
VENT (EXHAUST)TERMINATION
INTAKE AIRTERMINATION
INSTALL ONELEVATION
CENTERLINE
24 INCHES (61 cm) MINIMUM
48 INCHES (122 cm) IN COLDER CLIMATES
KEEP INTAKE AND VENTTERMINATION SCREENS
CLEAR OF DEBRIS
SIDEWALL TERMINATION - DIRECT VENTSTANDARD TERMINATIONS
Figure 26
��� ����� ���� ��������������~��=����������� ��*�*�����������������������������*���������������*�������������������������"����� =���� ���*�������� ���� �� ������ �������� ��� �������x�*���� \� �� ������~�������� ���� ������� ���� ���*���������������� ��������������������������x�*����\���������~��������>��=��"�������������� ������������������=������������������� ���*��������*��� ����*���**���]/� ������� ?�&��*B��)�����������*������������������������� �����������������������/���������?&]]��*B��+���V�����]��
%�� !����/������?&���*B����*������������$��������������������?&$��*B����*������������/�������������������������?�B��������������������������NOTE:�[��������������������������������������������������������������
��� !�� �� ������?�B� �� ����� ����� ����������$��� ������� ?��^� �*B���^����������?]/�&��*B����������������������������������������������+���V�����]%�NOTE:� (���� ���*������� ¢� �x����� ������ �� ����� ����������������� ����������&/��V�� )���������*�����������=���� ��������x������������������������������������=��������������=�����x�������� �������������=�������������������������x������ ������� ��������� ���� =���� ���*������� ����� ��������� ������ ����� =���� ���� ���� ��������� �����������������������������:x�������������x�����=�����������������*�x�**�������������?&��]��*B����*����������������=������*� ����� �������� ����� �� ��������� ������ �� �=��� ������� ��*"�����=������������ �����*�������=����������������������"�����(�����������*�������)������������������]%�
^�� !�*����������������������~��=�������*�������������������?�B���������������������������� =��+����
&���+�����������������*���������������?�B�=�����������?�B��������������� ���� ������� ���� ���~�� =���� ���*�������� ������ �*���������� �������� ?����� �������B� �� ���� ���� �� ���� ����������?�B�����������������������
&&��������� ��*� �����"� ������ ���� ����� ���� ���*������?�B�����* ������������ =������������������������:������������*������?�B� ��� ������� ���� ������� ���� ������ +���V�����]%�
INTERIOR WALL EXTERIOR WALL
FROMWATERHEATER
COUPLING
SIDEWALL TERMINATION INSTALLATION INTAKE AIR AND/OR VENT (EXHAUST)
METAL PLATESINSTALL INSIDEAND/OR OUTSIDE
FACTORY SUPPLIEDSTANDARD TERMINATIONPOINTED DOWN TOWARDS THE GROUND
INCREASE EXPOSED VENTPIPING UP TO A MAXIMUMOF 6 INCHES (15.2 cm) FROM WALL TO HELP PREVENT VAPORFROM DISCOLORING THE WALLSURFACE IN COLDER CLIMATES
Figure 27
&]���������� ����������������������?������������B�������������� �������������������������?�B���������������������������������������� ���������������?�B����������
&$��������������������������������������������������&/��������� ��*� ���� ������������������������������������
���� ������ ���� ������������������?�B� ������ ��� ����������������������������������=���������������������?�B�
&���)������������������������������������?�B������������ ��������[����� ���� �������� �������� ���� ��*�� �� �*�������� ���� �������� ���� ������� ���� ������ ���� ���*������?�B� ��� �����������������������������������+���V�����]%�
&���C������������(����)������������������]����'������(����)������������������]�����*��������������������������������������� ���~�� =���� ������� ������� ���� ���*������?�B� ���� �����������������
30
NOTE:� )�� �������Z�����&�����?$�*B���������������������"�=�������� ����� �� �������� ������ �� *���������"� ������������*�������� *��� �� ����� +��� (�������� ���*�������)������������������]%�
��� �������������������������������*������������������������������� ����������x���������������������������Z���*����� ������� ���*������"������ ���V�����/^��������$%"����� �����*������������������������������������������� ������������������������*��� ��*����������
��� ����� ����������� *������� ���������� ���*�������� =���������������������������������������������������������������Z���������������� ����������*����������������������*������� ���*�������� ���� *����������� +��� ������ $]� ����$$����*�������*�����
%�� !�� �� �� ����� ?&$� �*B� ���*����� ���� ��� ���� /� ����� �������������*��������������������*�������������������������������������
NOTE:�[�������������������������������������������������������������������
��� ����� ����������� *������� ���������� ���*�������� =���������������� ���� ��� ��� ������*�� ������� ���� ���*��������������� ���� ���������� ���*�������� *��� �� ��� ���� ��*�� �������*���������*�������+���K�������!������������*��������������*������������$$�
^�� '����*���� ��� ���� ���������� ���*������� ����� ����� �� �����������������������������**�������Z������������������ �� ������ ���� =���� ����� ���� ��� ���� ��*�� ������� ����������������*����������*��������=��������������������������������*���������
+���V�����]^��������$&� ��� ����*�x�**�����*���**�����������������������/�������������������*�������
����� �x�������� ���� ������� �� �� ���������� ���*�������DO NOT� ��� ��������� ���� ��� �� �������� ����� ������������ ������ ���� ���*������� ���� *��� ����� �*�������* �������������*������������������������=����������*��� ���������������� ���������������� ������*�������*��������������x����������������������������*�������
Q��� ���� +'C\]�� ����� �� �x����� ���� /� ����� �������������*�������
����� ���������� ���� ������� �� ���� ���*������� ���������*������ ���� ��� ���� ������� ?������� ���B� ����� ������ !�� ������*���*��������������������*������?=���B������
&���������� �� /� )���� !��������� ���*������� )����������� �������$&�
CONCENTRIC TERMINATION INSTALLATION&�� !��������� ���*�������� *��� �� ������� ������������ [�>�
&]��\�]���*�����*����������/�������������������*�������������#* ����^���$]������!�������������������� ��������������������������*����������* ��������� �����=����������*�������������������������*��������
]�� '����*�������������������������*�������
NOTE:�C�����*�������������������������������������������� �������*���"���������������������������������*�����������=����=��������������=��� ���
$�� �������������������������������*�������=����������������������������������������x������=��������������������Z���*�������� �������������� ���*������"���������V�����$���������$&� ���� ����� *����������� ������ ����������� ���� ����������� ������������������������*��� ��*����������
/�� �������������������������������*�������=������������������������"��������*���������=��������*��� ����*���**���&�������?$�*B��������*������������"�=����������������������������������V�����]���
CONCENTRIC TERMINATION(S)MUST BE A MINIMUM OF 10 FEET(3 m) AWAY FROM ANY PARAPET,VERTICAL WALL OR STRUCTURE.
CONCENTRIC TERMINATIONFLAT ROOF CLEARANCE
Figure 28
31
4 INCH CONCENTRIC TERMINATION INSTALLATION
4 INCH CONCENTRIC TERMINATION KITFOUR PIECE KIT - FIELD ASSEMBLY REQUIRED
VENT PIPE
INTAKE AIR CONNECTION3 INCH PVC
VENT CONNECTION - 3 INCH PVC
INTAKE AIR PIPEY FITTING ASSEMBLY
VENT CAPVENT PIPE ASSEMBLY
VENT PIPE IS 2 1/2 INCH SDR-26 PIPESUPPLIED LENGTH 37 INCHES (94 cm)MAXIMUM ALLOWABLE LENGTH 73 INCHES (185 cm)MINIMUM ALLOWABLE LENGTH 25 INCHES (64 cm)
INTAKE AIR PIPE IS 4 INCH SDR-26 PIPESUPPLIED LENGTH 24 INCHES (60 cm)MAXIMUM ALLOWABLE LENGTH 60 INCHES (152 cm)MINIMUM ALLOWABLE LENGTH 12 INCHES (30 cm)
VENT CAP
INTAKE AIR PIPE
3” x 3” x 4”Y FITTING
Figure 29
����* �������������������/�������������������*��������C�������V�����]^"�V�����$������V�����$&���������������������&�� !�*��������J������������������������*���������������������]�� +�����������������������������J������������* �����*������������
������� ������ ����������� ��� ���� ���*������� ��� �������������������:������� �������*���������������� ������������*��������������������* ���
$�� +��������������������J������������* ���������������������*������������������Z�=������������*���������
/�� @�� ������������� ���������� ������ ���� ��� ������ �� ���������������* ���� ���������������=������������������J������������* �������������������������
��� +���������������* ���� ������������������ !�*��������=���������������=����������������������������\
������������������������������*��� ������������������]��*������� �������������������������* ��� ����������� ������������������������*��� ����������������������������=������*���~���������������=�����������~��=���������
%�� )�����������=�������~=�������������* ����������������������J������������* ��"�:������*�������*�����=��������������*���������� ��*����������J��������
��� ����� ����������� $� ����� ������� ���� ���� =���� ������� �������������*���� ������������������ �� �������������� ���*��������
����������������/���������������������=���������\��������������������������������������*�������������������������/��x�$�� ������������������������ ����������$� ���������� ?&���������������B�������!�*����������������������������������
^�� C�������'������(����)������������������]�����*���������������������� �� ���� ������� ���� ���� =���� ������� ������� �����������������*����������������������������
NOTE: SECURING STRAP MUST BE FIELD INSTALLED TO PREVENT MOVEMENT OF TERMINATION KIT
MAINTAIN 12” (30 cm)18” (45 cm) FOR CANADAMINIMUM CLEARANCEABOVE HIGHEST ANTICIPATEDSNOW LEVEL. MAXIMUM OF24” (60 cm) ABOVE ROOF.
ROOF FLASHING(field supplied)
STRAP(field supplied)
VENTPIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
4 INCH CONCENTRIC TERMINATIONVERTICAL INSTALLATION
Figure 30
NOTE: SECURING STRAP MUST BEFIELD INSTALLED TO PREVENTMOVEMENT OF TERMINATION KITIN SIDEWALL.
STRAP(field supplied)
VENTPIPE
INTAKEAIR PIPE
COMBUSTIONAIR
VENT
1 INCHMAXIMUM
4 INCH CONCENTRIC TERMINATIONSIDEWALL INSTALLATION
Figure 31
32
Four Concentric Terminations&�� ��������������������������������*���������������������
���������������������������x�*���������*��� �������������������������������������������V�����$/�������������������������������V�����$��
]�� V���������*�x�**��* ������������������*�������������*��� �� ���������� ��� �� ���� ������ ���� ���*�������� ���� ����������x�*���������������V�����$/�
A
A
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
V�����$/
A B A
FOUR CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
B = 24 INCHES (61 cm)OR GREATER
CONCENTRICTERMINATION
CAPS END VIEW
V�����$�Groups Of Terminations&�� ����� ����������� *������� ����� �� ���������� ���*��������
������������������������������ ����������x�*������������� �� ���������� ���� �������� ����� �� ��� ��� ����� ���V�����$���;����������������������������V�����$��*��� ����*�����=������� �������������������*���� ���*�������������������������=���� ���������
A
A B
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
EIGHT CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
B = 24 INCHES (61 cm)OR GREATER BETWEEN
GROUPS OF FOUR
V�����$�
MULTIPLE CONCENTRIC TERMINATION CLEARANCES ����������������*��������������������*��������=������������������ ��� �� ����������� ������ �� ��������� ������ ���� ��Z���������������� ?���������B� ������� ���*�������� ���� *�����������:����� *������� ���*�������� ���� ��������� �� ������ �����Z�����NOTE:� ������ ����������� *��� �� *���������� �� ���=���� ������������������=����?�x����B�������������������������!��������������*������� ������������������������������������*����������������� �����������*����������������� ���*�������� �������� ����� ����������������� �������������������� ���V�����$]�*��� ��*�����������+���K�������!������������*��������������*������������$$�Close Proximity & Standard Clearance&�� �������������� �������*����������*������������*��� ����
�������?������B�����*�x�**���]��������?���*B"���*��������\�V�����$]"������������������������������*������������������x�*�����+���V�����$%��������$$�
]�� ���� ���������� ������� *������� ���*������� ����� *��� ����������������*���**���]/��������?�&��*B"���*������[�\�V�����$]"����������������������������x�*����?� =�B����������� �����������������������������������
A
OR
B
A = 0 - 2 INCHES (0 - 5 cm)
CONCENTRICTERMINATION CAPS
END VIEW
TWO CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
B = 24 INCHES (61 cm)OR GREATER
CLOSE PROXIMITY STANDARD CLEARANCE
Figure 32
Three Concentric Terminations&�� �����������������������������������*�������������������
������������������� �������������*�������*��� ����������������������x�*����������������� ����*�����������V�����$$��
]�� )�� ����� ��x�*���� ������������ �� ���� ������ ���*������� ��� ������� ��� �������������*�������*��� �� ������������� ���������� ����*������[����V�����$$�
A = 0 - 2 INCHES (0 - 5 cm)CLOSE PROXIMITY
CONCENTRICTERMINATION
CAPS END VIEW
THIRDTERMINATION
THREE CONCENTRIC TERMINATIONS(THROUGH A ROOF OR SIDEWALL)
A
A B
B = 24 INCHES (61 cm)OR GREATER
V�����$$
33
SIDEWALL
ROOF
Figure 38Eight Concentric Terminations:����� ���������� ���*�������� *��� �� ���������� ��� ��� ��������������� ��"� ��� �������x�*���"��������� ���V�����$^��+���V�����$���������$]�����������������*�������������������;������� ����� �� ��� ��� ����� ��� V����� $�� �� ����� $]�*��� ����*�����=��������������������������*�������*�������������������������=���� ���������
SIDEWALL
ROOF
Figure 39
MULTIPLE CONCENTRIC TERMINATION ARRANGEMENTS���� ������������ �� ����� ����� ���� �*�� �� ���� �������������������*����� ��� *������� ���������� ���*�������� ����� �����������
+��� K������� !��������� ���*������� !���������� �� �����$]� ��� ��������� ����*����� �� ����������� ���� �����������������*����������
NOTE:� ����� *������� ���������� ���*�������� ���� ������������������������������*����������������*������������*��� �����������*���������*���������*�����������
Two Concentric Terminations����������������*��������*��� ����������������������x�*������� ����� ��� V����� $%� �� ����� ��������� ����������� ����� ������������*���� ��� ��� ���� ���� +��� V����� $]� �� ����� $]� ������������ ����*�������������������+���V�����$$��������$]������������������������������������*��������
SIDEWALL
ROOF
Figure 37
Four Concentric TerminationsV���������������*��������*��� ����������������������x�*������������ ���V�����$���+���V�����$/�����V�����$���������$]� ��� ��������� ����*����� �� ����������� ���� �����������������*����������
34
VENTING ARRANGEMENTS
Power Vent VerticalFigure 40
Direct Vent VerticalFigure 42
Power Vent HorizontalFigure 41
Direct Vent HorizontalFigure 43
35
VENTING ARRANGEMENTS
Direct Vent Vertical Vent Horizontal IntakeFigure 44
Direct Vent Vertical ConcentricFigure 46
Direct Vent Horizontal Vent Vertical IntakeFigure 45
Direct Vent Horizontal ConcentricFigure 47
36
TERMINATION CLEARANCES SIDEWALL POWER VENT
V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED
v
v
A
GV
FIXEDCLOSED
FIXEDCLOSED
OPERABLE
OPERABLEV
C B B
BBF
B
V
V
A J
V
H
MX
XV
VK
B
E
D
L
POWER VENT(using room air for combustion)
EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION
Figure 48
������������ ������ �������������������������������������������� ��������������������������� ��������
CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2
A!���������� =�������"�=������"�����"�������� �����
&]��������?$���*B &]��������?$���*B H!������������������������������������x�������� =��*����~�������������* ��
$������?^&��*B�����������������&�������?/���*B�� =������*����~ ������������* ��
$������?^&��*B�����������������&�������?/���*B�� =������*����~������������* ��¤
B!���������������������������*��� �������
���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B���������������� =��&��"����[�~���?$����B
/������?&�]�*B� �����������������������&����?$���*B�� =��opening
I!��������������=������������=��������
$������?^&��*B $������?^&��*B¤
C!��������������*�������������������
&]��������?$���*B¤ &]��������?$���*B¤ J!����������������*������������������������������ ����������* �����������������������������������
���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$���B"�$���������?^&�*B���������������� =��&��"����[�~���?$����B
/������?&�]�*B� �����������������������&���� ?$���*B�� =���������
D
(��������������������=����������������������� =���������*����������������������������������]������?�&��*B���*��������������������������*����
&]��������?$���*B¤ &]��������?$���*B¤ K!�������������*��������������������inlet
�������?&��$�*B
$������?^&��*B�� =������������&�������?$�*B�����������
E !������������=�������������� &]��������?$���*B¤ &]��������?$���*B¤ L
!���������� =����=����������������=������=��������������� �����������
%������?]�&$�*B� %�������?]�&$�*B
F !���������������������� ]������?����*B¤ ]������?����*B¤ M
!��������������=������"�����"�����"��� �����
&]��������?$���*B�¥ &]��������?$���*B�¥
G !����������������������� &���������?/���*B¤ &���������?/���*B¤
&�)����������������������������!+��[&/^�&"�#������_��������������)�����������!���
]�)�����������������������������#+)��]]$�&~#V����/"�#�������V���_���!���
����=����������������*���������������� =�����������������=������=�������������������� �������������������*���������������������=��� �������������� ���������*������������������������������*�����������{����������������������
¥����*�������������=������"�����"�����"��� ����������������������*���**������������ ��������������
¤�!�����������������������������������������������������������Z���*�������������������������������*�����������������������������������
37
TERMINATION CLEARANCES SIDEWALL DIRECT VENT
V XVENT TERMINAL AIR SUPPLY INLET AREA WHERE TERMINAL IS NOT PERMITTED
v
v
A
GV
FIXEDCLOSED
FIXEDCLOSED
OPERABLE
OPERABLEV
C B B
BBF
B
V
V
A J
V
H
MX
XV
VK
B
E
D
L
DIRECT VENT(using outdoor air for combustion)
EXTERIOR CLEARANCES FOR SIDEWALL VENT TERMINATION
Figure 49
������������ ������ ����������� ������������������������ ������� ������������������������������� ��������CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2 CANADIAN INSTALLATIONS 1 US INSTALLATIONS 2
A!���������� =�������"�=������"�����"�������� �����
&]��������?$���*B &]��������?$���*B H!������������������������������������x�������� =��*����~������������* ��
$������?^&��*B�����������������&�������?/���*B�� =������*����~ ������������* ��
$������?^&��*B�����������������&�������?/���*B�� =������*����~������������* ��¤
B !���������������������������*��� �������
���������?&���*B�������������������&�"����[�~���?$���B"�&]��������?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B���������������� =��&��"����[�~���?$����B
���������?&���*B�������������������&�"����[�~���?$���B"�^��������?]$��*B��������������� �������&�"����[�~���?$���B�������"����[�~���?&����B"�&]��������?$���*B���������������� =����"����[�~���?&����B
I !��������������=������������=�������� $������?^&��*B $������?^&��*B¤
C!��������������*�������������������
���������?&���*B¤ ���������?&���*B¤ J!����������������*������������������������������ ����������* �����������������������������������
���������?&���*B�������������������&�"����[�~���?$���B"�&]�������� ?$���*B��������������� �������&�"����[�~���?$���B�����&��"����[�~���?$����B"�$���������?^&��*B� ��������������� =��&��"����[�~���?$����B
���������?&���*B�������������������&�"����[�~���?$���B"�^��������?]$��*B��������������� �������&�"����[�~���?$���B�������"����[�~���?&����B"�&]��������?$���*B���������������� =����"����[�~���?&����B
D
(��������������������=����������������������� =���������*����������������������������������]������?�&��*B���*��������������������������*����
&]��������?$���*B¤ &]��������?$���*B¤ K!�������������*��������������������inlet
�������?&��$�*B $������?^&��*B�� =������������&�������?$�*B�����������
E !������������=�������������� &]��������?$���*B¤ &]��������?$���*B¤ L
!���������� =����=����������������=������=��������������� �����������
%������?]�&$�*B� %������?]�&$�*B�¤
F !���������������������� ]������?����*B¤ ]������?����*B¤ M
!��������������=������"�����"�����"��� �����
&]��������?$���*B�¥ &]��������?$���*B�¥¤
G !����������������������� &���������?/���*B¤ &���������?/���*B¤
&�)����������������������������!+��[&/^�&"�#������_��������������)�����������!���
]�)�����������������������������#+)��]]$�&~#V����/"�#�������V���_���!���
����=����������������*���������������� =�����������������=������=�������������������� �������������������*���������������������=��� �������������� ���������*������������������������������*�����������{����������������������
¥����*�������������=������"�����"�����"��� ����������������������*���**������������ ��������������
¤�!�����������������������������������������������������������Z���*�������������������������������*�����������������������������������
38
WATER HEATER INSTALLATION�����&~]�������(!���������
$�� DO NOT���*=�"�*���������������������������������������
INSTALLATION INSTRUCTIONS&�� :�������������������������~��������������������������������]�� )������� �� &~]� ����� �(!� ���������� ������ ����� ������� ����
�������������������������������!���������'�������������������� ��� ������������"�����V������������V������&�
$�� ���*������������������������������������������� ��� =�������������:������������������������������x������������������������������*�����������������?&��]��*B�� =�������� ��� ������������"����x������������� ������"�����V��������NOTE:� )���������*����� ��� ��� ���**�������������������������� �����*���������������� �������������������� �������
/�� :���������������������������������������=������ =�����������������������������������������"�����V������&�
��� [��������������������������������������*���������������=���������������
��� :����� ���� ���������� ������� ������� ������ ������ �"� ����+�����Q����������]�
CONDENSATE DRAIN INSTALLATION
)����������� *��� ����*� ����� ������ ����������� ���� ����� ������������V�������������*�����������Z���������������������������
�� ����=����(!���*���������(!����*����� &~]�������(!������\�*���**�����������Z�����������������
���������������������������������� ��� ��������������� &~]�������(!���������?�� ��������������B�������������
������������������������������� �����������!���������'��������������* ������������� ��� �������������
�� V���*���������������� ��������������������INSTALLATION NOTES&�� ��������������������� ��*���������������������=����� ��
����� ������������=���>���=���� �������/�$���������� )����������**����������=���� ������������������� �����Z����� �������������;�����>���=����������������'�������������*��������������� ������ ����"� ���� ��� ������ ����"� �� ���� ���������������������������
]�� ���� ����� ���������� ���������� ������ ����� *��� ��� �� �����
CONDENSATE DRAINLINE - FIELD INSTALLED
DRAIN LINE TOTERMINATE NOMORE THAN 6INCHES (15.2 cm)ABOVE DRAIN
BUILDINGDRAIN
FACTORY INSTALLEDCONDENSATE TRAP
CLEANOUT PLUG SHOULDFACE TOWARDS THE FRONTOF THE WATER HEATER FORSERVICE ACCESS
EXHAUST (VENT)ELBOW
CONDENSATE TRAP DETAIL
PVC PIPE PLUG1 ¼” NPT
CLEANOUT PIPEPLUG SHOULDBE ORIENTED TOTHE FRONT OF THEWATER HEATER FORSERVICE ACCESS
PVC BUSHING1 ½” SLIP x 1 ¼” NPT
PVC BUSHING1 ½” SLIP x ½” SLIP
PVC TEE FITTING1 ½” SLIP x 1 ½” SLIP x ½” NPT
PVC PIPE NIPPLE½” NPT
½” PVC 90° ELBOWCONDENSATE DRAINCONNECTION. FIELDINSTALLED DRAINLINE CONNECTS HERE
½” PVC 90° STREET ELBOW
½” PVC PIPE NIPPLE
Figure 50
Figure 51
39
SUPPLY GAS LINE INSTALLATION
!��������������������������*���������������������Z�������� ���=���� ��� �=���� ��� ���� �� ��=���� ������� ��� ����������������������������[�������������������*������������������������������������������������������������������������������������������Z���*������� ���� ����� ���� ����� �Z��*���� �������� �� ���� *������ )�� ��������*�����������������"����������*������������=��������������������������������*�����
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
K�������������������������*�������������������������������������������� ������� ������ �������� �=����� ��� ����� *����� ���� ��� ��������� ��������������������������&��������!��?]��]����B�������������������&/�������!��?$�/^����B����������������������������"������� ���$��������&]���������������������=�������������*�������Z�������������������������*����������Z������������������������:x��������������������������������*����������*�����������������������������������������������x�������)��=�������������� ������� ���� ��� ������ �*������ �������� �� ���� ������ ��*��������� �� ���� ������ �����*� ���� ������ ��������� ���� =��=��*��� �������������������������� ����̀ �������+��=������������:�������������������=�������������������������=����=��=������������������������ �������������������*��������� �������������������*"���� ������������������(���� �������*��������������������*��)�� ��� �*������� �� ����� �������� ���� =��=�� ������ ��*�����*������������������������+���������*���������*�������������"��������x�������)���������������������������������*��� �������������������������������������������=����
REGULATED GASSUPPLY LINE
MAIN GASSHUTOFF VALVE
TEE FITTING
PIPE CAP
SEDIMENT TRAP
Figure 52
:���������������������������������������� �������������������������������������������*������������������������������������*���������*��� �����������������������V������]����������*���������*��� ����������������� ����������� {�������������������������)��������������������������������**��������������������������������*�����
GAS LINE SIZING'�����������������=�������Z�=����������������~�������* ������������������������������**��*���"����������������������������*�����=���� ������������+���� ���������~*�������� ����?�B� �������������������� ��������� ���^������=��������=�������� ����������� ���^�����������������������������������������������!��?&]����B������������"����������������������*����������������������*���#������������������������� ��������������������������������������������+�������/��+�������������)�������������������������*���������������������������������������������)������*������=�����������������������**�����������������������=������������#�������V���_���!������!��������+���������+������ ����?!++�B���������������������������������������������SUPPLY GAS LINE SIZING U. S. UNITSTABLE 8LENGTH
INV::�
#@CK�;��)C@#��)�:�+)�:+�?)#!>:+B)#�Q��)#��>@Q+�#'+�[�Q~>C
&~]� $~/� &� &�&~/� &�&~]� ]�10 175 360 680 1400 2100 396020 120 250 485 950 1460 275030 97 200 375 770 1180 220040 82 170 320 660 990 190050 73 151 285 580 900 168060 66 138 260 530 810 152070 61 125 240 490 750 140080 57 118 220 460 690 130090 53 110 205 430 650 1220100 50 103 195 400 620 1150125 44 93 175 360 550 1020150 40 84 160 325 500 950175 37 77 145 300 460 850200 35 72 135 280 430 800
SUPPLY GAS LINE SIZING METRIC UNITSTABLE 9LENGTH
INMETERS
#@CK�;��)C@#��)�:�+)�:+�?)#!>:+BINPUT IN kW
&~]� $~/� &� &�&~/� &�&~]� ]�$�� 51 105 199 410 615 1160��& 35 73 142 278 428 805^�& 28 59 110 225 346 644&]�] 24 50 94 193 290 556&��] 21 44 83 170 264 492&��$ 19 40 76 155 237 445]&�$ 18 37 70 143 220 410]/�/ 17 35 64 135 202 381]%�/ 16 32 60 126 190 357$��� 15 30 57 117 182 337$��& 13 27 51 105 161 299/��% 12 25 47 95 146 278�$�$ 11 23 42 88 135 249�&�� 10 21 40 82 126 234
40
GAS LINE CONNECTION&�� ���� ������ �������� �=����� �� ����� *����� ���� ��������
��*����� ������������$~/� ���������������������������������������������*������ ���*�����������$~/�������!����������������������������������������������]/�(���_���(��=����� ���������� ����� ���� ������� ��� ����� ���� �������� ������Z���*������
]�� '��������� �� ���� ��=������ �Z�=������ ������� ���~�� �����* ������������������������������**��*���"������������ �������������� �����*�����=�� �� �� ���������"�����_���;����+�������������$^��)���������������������*��� ����\������������������**����������������������������������������*������� ����������� ��� ������� �������� ���� ����� ������������������������������������������������������V������$��NOTE: Make the transition to the larger supply gas line as ������������������������������������� ���
FIELD INSTALLEDPIPE NIPPLE
INSTALL A REDUCERCOUPLING WHEN ALARGER SUPPLY GASLINE IS REQUIRED
SUPPLY GAS LINE CONNECTION120,000 & 150,000 Btu/hr MODELS
24 VOLTGAS VALVE
TO MAINBURNER
FLOW
Figure 53
$�� ������ ������� �������� �*����� ?����� ���~����� ����B�������������������������*�����������������������{������'�������������������*���������������������������Q������������������������*��������� �������������������������������Z���������*�?;�~������B�������
LOW GAS PRESSURESWITCH
COMBUSTIONBLOWER
SUPPLY GAS CONNECTIONFACTORY INSTALLEDTEE FITTING
SUPPLY GAS LINE CONNECTION199,000 & 250,000 Btu/hr MODELS
Figure 54
/�� Q����������*���{�����{��� ����������?���������*�����������B������ ������������ ���������]/�(���_���(��=����������������������������������������������� ���������=��=���DO NOT���������������������������?+�������������B������*���������{������������*������*����������*��������=��=��
��� Q��������������������������?+�������������B������ ���������������������������������������� =������������������������������������������������������������������=��������]/�(���_���(��=�����������������������*����������������������������
��� �� ���=���� ��*���"� ����� *��� �� ������ ��� �� ������ ��*��� ��Z�� ����� ���������� ���� ������ ���� ����� �� ������������������
%�� )�������������*��������������������V������]��������$^���� )������� �� K���� _��� +����� =��=�� ��� ���� ������ ���� ����� ���
��������V������]��������$^�
NOTE:�+����=����������������������������������� ��������"������������K����_���+�����=��=���������������������
GAS LINE LEAK TESTING
Fire and Explosion Hazard
Leak test before placing thewater heater in operation.Disconnect gas piping and maingas shutoff valve before leaktesting.Install sediment trap inaccordance with NFPA 54.
Use joint compound or Teflon tapecompatible with propane gas.
������*����������������������������������*������*����������������=����������� ���������������x������&�� V�����������������x��������&~]�����?$�/�����B�����������
���� ������ ������� ���� ���� K���� _��� +����� (��=�� ��*� �������� ������ ������� �����*� ������ �������"� ���� V����� �]��� ����� $^�� ���� ���� ������ ����� *��� �� ������� �������������������*������������������
]�� V�� ����� ��������� �� &~]� ���� ?$�/�� ���B� �� ����"� ���� ��������������������� �������������"� ��*��� �� ����������*����� ������ ���� ����� �� ������� ���� K���� _��� +����� (��=����������������
$�� �������������������������{�������������������������*����������������������������������������������������������������������[ �������������������������'�������*������"��������"���*����������������������������������������
/�� C���������������� �����������������������������������������
PURGING_��������������������Z����������������������������*��������������������������������������� �������*���������������������������#V����/�����#�������V���_���!���
41
?):�����������B����������������������������*��������!![������������=����������������*��������������Connecting An External Supervisory Control������� ��~���� ���������� ������������ ��*�����!![���¦�����������������!![��������"����� ������������������������������!![����������V�*����������������������������? ����B�{*������������������� ������������������&&�������¦�����"�����V����������������%�������������¦������)���������������������������� ��~���� ����������&�� ���� ��� ����� ��� ���� ������ ��������� �~��� ������� ���� ����
��������������������������������������������]�� ;���������!![���������$�� C�*=�� ���� ������� ��*� ���� !![� �������� �=��� ����
�����������������!![����������#���������������������������������������=����� ������������=����������������������������
/�� ����=����������� ��~���� ���������������������+&�����������������!!["�����V����������������%���� ������+&�����������¡]�������������������� ������+&�����������¡$������������������
��� ;����� ���� ����� {*��������� �����������������&&�������!![�¦�����"�����V����������������%�����V������������������
��� !������ �����{*����������������*������%�� +���������x�*������&~]�������������������*�������������
������ �����{*������������ Q��������������������� ���������������������������� ��
������������������ �����{*����������������������������������������������������������
^�� �������������������������������!![�������������������������������������������������������!![����������=����:��������������������������������������������������=�����������������������:����������������� �������������
&���C�������������!![����������=����������������������&&��C��� ���� ������ ������ ������� ���� {������ x� �� ���� ���
�� ����������������"����� ������������������ �� ������ ����{������ x��Q�������=���� �������\�����������������������������{������ x�
&]��)������� ����� ������������������������������� ��� ��Z����� �� �������� ���� ����� ����� ������� ���� ������ ���������{������ x����� �����x������� ����=����� �������!�������������������*������x������������������������������������������{������ x�����������������������������������
&$��!������ ���� ������ ������� �� �� ���� �� ���� �������� �� �����x��������������V��������������*�������������������������*����������������
&/��C������������������������������NOTE:� �����=��� ���� �x������� ������ ����� ���� ���� ������ �������� ���"� �������� �������� ����� �� ���� ����������=��� ���� �x������� ������ ������ ���� ���� �� ������������ ���"� �������� �������� ����� �� ��� ����� ����������������������������������=�����������**��������������������������*��������������������������������������� �����+�������+�����)��������������������� ���&&��������/��NOTE:� :����� ���� ������ ������� ��� ��������� ��*� �����������*��������� ����� �������� �������� ��� ���� ����� '�*���� ������������������������� �������������*����������������=����������������*��������������
ELECTRICAL WIRING
���� ����������� ���� *��� �� ���������� ��� ���������� ����� ����#������� :���������� !��"� �#+)~#V��� %�� �� ���� !��������:����������!��"�!+��!]]�&������������Z���*�������������������"������������������*��� ���������������������������������������������������"��������� �����������������"����������#�������:����������!��"��#+)~#V���%��������!��������:����������!��"�!+��!]]�&�)����������������������������������������������������������*��� ����������"� ���*��� ����������������&���!���������������� �����Z�=�����"��x������������ ������������)���������������]���!������������*��� ������POWER SUPPLY CONNECTIONSC����������Z���*�����������������+������������&/� ��������������������Correct Polarity:���� ������ ��������� ������ �����*� ��� �������� �������=�� ��������� �������������� ������������������� ��� �������������� ��������� ������ ��� ��=������� ���� ������ �����*� ����� �������� ������!� C�=������� V���� *������� �� ���� ;!'������ &]�� (�!� ����������*����������������*���������������� �����������������{������ x���������&]��(�!�������������*����������������������������������{������ x����������������������������������������*��� ��*��������������&�� :����� ���� ����� ������ ��� ������ ��� ��� ���� ������� ��
�����������������]�� C�*=������{������ x��=����+��� ���������������������
{������ x���������$�� !����������&]��(�!�����������*����������������������
�����������������{������ x�����������������������������������������������������������������������������������������������������������+����������������*��V����������������������V������%���������^�
/�� !����������&]��(�!���������������*����������������������������������������{������ x������������������������������������������������������+����������������*��V����������������������V������%���������^�
��� !������ ���� ����� ����� ��*� ���� ����� ������ �� ������������ ��� ������� ���� {������ x��+����������������*��V����������������������V������%���������^�
��� C������� ���� {������ x� �=��� ����� ���������� �����*������
NOTE:�'���������������������������������� ���������������������*�����������������������������������������������ENABLE/DISABLE CIRCUIT���� ������ �������� �=����� ��� ����� *����� ���� �Z������ �������� ��� ��~���� ��� ������� ��� ��� ����� ����� �������� �x�����������=����� ������� ���� ��� ��*�� ������ �� ������� [�������K�����*����+����*���������� ��~���� ����������*��� ������������ ����������������������������������������� ���������������������������������*������������������ ��� ���� ��� ��~���� ��� ������� ��� *��� ����� �� ����=����� ���������������+&��������������������������������!![�?�������������� ���B"�����V����������������%��V����������������������� ����� ���������� ������� �������������������!![���������������������������?��=�����������B���������������������x��������������NOTE:����������������������� ��~���� ���������� ���������������������������'�����������x�������=������������������� ����
42
T&P VALVE DISCHARGE PIPE
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
����� ������ ������� ��� ��=����� ����� �� �������� �����~������ ������������� �* ������� ��*�������� \� �������� ?�<�B� �������=��=�� �� ���� *����������� +��� ��*�������\�������� C������(��=�� �� ����� &�� ��� ����*����� �� �������*���� ���� �������Z���*�����
Water Damage Hazard
Temperature-Pressure Relief Valve dischargepipe must terminate at adequate drain.
CAUTION
)������������������������ ������������<��=��=����������������������� �� ���� ��� ��� ������� '� ��� ������� ���������� ���������������� �� ��������������������� ?&��]��*B��������� �����=�����������=���� �������{��"��������������"�������������*���"������������ =��=�� *��� �� ������� �� ���������� ������ ��� ���Z����Z������������������*����������*�����)��������������������������������������������������������� ���*����"��������������*������������������*����T&P Valve Discharge Pipe Requirements:
�� +�������� ���*��������������������������������������������=��=�"�����=�����������������������������������������
�� +�������� ����������� �������� +�������� ���x������������������*����������� +����� ����*��������������������������������� ������ +����� �������������������������*����������������� �������
��*�������\��������C������(��=��������������������������� K������*��������*�x�**�����x��������� =�������
���������x������������� ��������)���������*����"����������**������������������������������ �����*����������������Z��������������������� �������
�� +����������=������=��=��������� �������� ������������������=��=����������������
WATER LINE CONNECTIONS
�����������������������������*�������*������������������������ ������ ����������������� ��������������=���� {�����������_�������������Z�����������������=��������� ����������C���� ���� ���=�� ���� ��Z���*����� ��� ���� �������� �������� ������������������������������������ ������&�� K�x����(��=����������&��]�� '�����������K���������������&��$�� ��*�������\��������C������(��=���������&��/�� !�����+����*����������*���:x��������������&����� V�� *������� ������ ������� ������������� ���� ������ �������
'�����*�� ����������������%&�WATER PIPING DIAGRAMS�����*�������=���������������������������������*�������������*���������������������������������������"������������������'�����*�� ���������%&������������������*��� �� ���������� �� ������"�������������������������� ������ ����� ���� ����� �� ��������� ������� ����"� ��������������*��� ��������� �����=������ ��*������� ������������*����������������������*��������"� ��� ��� �*����������������������������������� ������������������������ ����*���**����� ��������������������������������������������{��� ��� �� ���������� �� ���� ���� ���� =��=�� ���������� ��� �������������������������������������������*���#�=������������������������������������*���+��������������������'�����*�� ����������������%&�NOTE:�)�����������������������������������*�������\��������C������ (��=�� ?�<�� =��=�B� �� ���� ������ ������"� ����� ��*��������������������*��� �������������������������������������������������� *��� ���� ��=�� ���� ��� �������� �����"� ������ ��������=�����*�������\��������C������(��=�������������!���� ���� ���� ����� ����������������������* ��� ��������� ���� �����=����������*���������������������������������������<��=��=�������*����������������THERMOMETERS (NOT SUPPLIED)����**������ ���� ���������� ��� ���� ������ ������� �����*� ��� ��*����� �� ���������� ���� ��*�������� �� ���� ��� ������ ��������� ��������� ������ ��� ���� �����*�� V����� �������� ����**����������� �� ����������������������+����������������'�����*���������%&�WATER (POTABLE) HEATING AND SPACE HEATING&�� ������������������*�����������������������������������
�������������������������������������������� ������ ��� �������������� ���������
]�� �x��� ���*�����"� ���� ��� ����� ���� ��� ����� �����*���"�*���#:(:C� �������������������������*�
$�� ���� ������ �������� �=����� ��� ����� *����� *��� ��=��� ����������� �������x��������������������*����*�����?�B����=����������������\��� ���������������������������
/�� ����� ���� �����*� ��Z����� ������ ��� ������ �������� ������x������������*�������������*�������������x�������*�x����=��=��*��� �����������"�����K�x����(��=����������&��
��� ������ ������ �������� ������ �� ���� ��� ������ ������������������������
43
+�����������@���������+�����������&]��V�?/^�!B��������������������� �� �������� +*�� +������ ��Z���� ��������� ��� �������� �������*���������TABLE 10
��������*������� �V�?�!B
��*�����&���'������[�� ?;����+�=����[���B
��*��������*������[��� ]���<�$���'�����
?K���+�=����[���B&&��?/$B ?��*�����������*��B&&��?/%B ?�������������B&&��?/%B $��*����� /��*�����&]]�?��B &�*���� ��*�����&$&�?��B �������� ]��������&/��?��B ]������� ��������&/^�?��B &������ ]�������&�/�?��B instantaneous &������
?Q�+��_=���*����K�*����*"�!���+�!�"�������;����*�����"�+�����&�"�&^%�B
���� ������ �������� �=����� ��� ����� *����� ���� �Z������ �����������������������������*��� �������� ���������� ��*�����������������������������������������������*����������*����������*� ��� ������� ���������� ��*���������� ��"���� ���������� ������� ����� ����������� ������������ ��������������� ���� ��*"�+������(������������������V��������������&���������������� �@��������� +��� ������ ��� ��{����� �� �������� ��������*���������������������������������������������{��� ��������������� ��� ���������� �����*��� ���*���������K������������������ ������ �����*�*����������������� ������ ����Q)K� ?��������������*���B� ��������� ���� ������� ����������������"�����V������������@���������+�������������{��� �����*�^��V�?/]�!B���&���V�?�]�!B������������������������&]��V�?/^�!B��+���@���������+������������'��������������{��*�����������/%������������������������{�������@���������+������������������������������+�������@���������+���������������������������������������������������� ��������������������������������������=��������*���������������������������HIGH TEMPERATURE APPLICATIONS>������ ��������� ��*��������� ����� *��� ����� �� ���� �������������� ���� ����� ��������� ���� ����� ����� �� ���� ������ ��������!������� ����������� �� �*���� ����� ������ ������� ��� �������*�������������������"� ��������**������������������"� �������������������*����������*���������������*�������������������������������������������*��������!�������������������� ������������������������������������* ��� ������� �� ���� ���� �=��� �� ����� *����� ��� ����������������������������
Tank Temperature 103°FOperating Set Point 120°FStatus: Heating
MENU HELP
UP
DNGAS
OFFON
MANUFACTURER / MODEL INFORMATION
Figure 55
HIGH TEMPERATURE LIMIT CONTROL (ECO)
����������������������Z��������������:!@�?�����������B������{��� ����������*����������*���������������:!@��������*����������������������������?����=����B���������������*������������:!@����������������������Q�������*���������� ��?������������B"�����������������^����������������:!@��������������������� ���� ����� ���� ������ ��*�������� �������� ����x�*������]�]�V�?^/�!B�����������������x�*������&/��V�?/^�!B��)�� ���� :!@� ����=����� ?�������� ���B� ��� �� � ��*����� ����������� ��*��������� ��� ����������� ����� ���������� �����*�������**��������� ��\��������� ���� ]/� (��� _��� (��=�� ���� ���� �����������������������������������������*������������������ ������������ �������� ��������� ���� ������ �����*� ����� �������� �����:������ !�� @�� ?:!@B�� V���� *������� �� ���� ;!'� ��������)�� ��� �*������� ����� �� `������� +��=���������� �� ��������� �������*���������������������:!@�����=����� �������������������:!@��@������������������ ���������*����������������������:!@����� �����������������+��������:!@�����=���"�������������*��������*������� ����&/��V�?/^�!B� ��������������������*����� ���������@����������������*����������������� ������������������������������������������������*��� ����������������������������������������������*�
THERMOSTAT CONTROL
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and thephysically or mentally disabled are athighest risk for scald injury.
Feel water before bathing orshowering.
Temperature limiting devices such asmixing valves must be installedwhen required by codes and toensure safe temperatures at fixtures.
>����������*�����������Z����������*��������������������������������������������� ��������������������������������{��� ���~�� ������� �� ��� &�� ����� ���� ����x�*���� ��*�\�\ ��������������������*�������������������*�������������������{��������=��������������������������� ���� ������� �� �x������ ���� ������ �������� ��*�� ����������"������������������� ��������������������������������������*��)������������������������=����� ������������������� ������������������������������������������������������������������ ������ ���� ��Z�������� �������������� ��*����������� �������������"������������������������*��� ��������)������������������������������� �����*������������������������������ ���� ��*���� �� ���� ����������� �� *�x���� =��=�� ���� ��������������������������������?����V��������������&�B��������������������������������������������*���������*��������#�=���������*������������������������������������������������� �����������#�=������=���������������� ������������������������� ���� �������������������������������� ��������������������������������������� �������������=�����������������*���������
TEMPERATURE REGULATION
44
����������������������������������������� ���������*�����������"������������������������������� ��������x������������������������� =������� ����������;!'���������
THE DESKTOP SCREEN'����� ��*��� �������� ���� ������ �����*� ����� �������� �����'���������������� ����;!'������� ��� ����������������������������������*������������������'����������������������������������=��V���� �������� ���������������� ���������� ��������������������=�����*�������
�� K���������������������������*��������*���������������������������[�������������������'��������������K�������������������������������������[����������=�����������������������*�*����
�� �����������*�������������������'������������"��������*�������"����������*�����������������������������������������������������������
�� ������������*�������������������'��������������������@���������+�������������@���������+�����������������*��������������������������������*������*������������������������������������������
�� [�����������@���������+����������������+����������������+�����������������������������������������������������������*�����������*�"������� ���&]��������/������������������������=����������������������
�� ����'�����������������������������*������+�����)���������=�����������������*����"������� ���&&��������/�����������������������+�����)����
OVERVIEW
�������������������=�������������*����������Z�����������������������������������*�����������������������*������������������� ������� ������>������� ����������� ������������*������� ������ ������ �����*�� ���� :!@� ?������� ��� �B"� ��*�� �����"��������� ��������� ���� ��*�������� �� ��� ���� *������� �����������������*������!* �����[����"��������"�]/�(���_���(��=������������������������������ �����������������*��
���� *���� �*������� �� ���� ������ �����*� ���� �� Q)K� ?��������������*���B�������!![�?�������������� ���B������Q)K������������������������������������������������������!![����*���������������������������������������������=�����������+��� V������� ���� !*������� �� ����� %� ��� ������� ������������������������������*�������
CONTROL SYSTEM NAVIGATION
�������������� ����*������������������������������������������������� ��*� ����Q)K������Q)K������ ���������� �����*���;!'� ?��Z��� �������� �������B� ���� �=�� ����� ������� ?**������B����� ����� ������ ��� �"� ���� ���� ������ ?$B� *���� ������������������� ����� ��������;!'"�����V��������
User Input Buttons�� �������������� �����������������=������*��������
��{�����������������
�� �������������� ��������������������~�x���*���"��������*������*�"�����=������{��*����*������������*�
CONTROL SYSTEM OPERATION
Tank Temperature 103°FOperating Set Point 120°FStatus: Heating
MENU HELP
GAS
OFFON
MANUFACTURER / MODEL INFORMATIONLCD ScreenInformationDisplay
Status Icons
3 Operational buttons:enter/exit menus,select menu items,activate adjustment modes,confirm/cancel changes.
Up & Down buttons:navigate menus,adjust user settings
Title Bar
Operational buttons are multi functional. Their current function is defined bythe text that appears directly above each button on the LCD screen.
UIM (user interface module)Desktop Screen Shown
UP
DN
Figure 56
45
STATUS ICONS����+�����)������������������������'�������������������=�������������������������������*������������������������� ������������ ��� �����+���V���������������//���������+�Z�����@��@�������������������TABLE 11
Icon Description��������*��������������������������������+��������������������*���������**�������������������������������������������������*���������������������������������������*�����Q���������;������*���������� ����+��� ����������������������V��������������&����������������*���������� ���
��������*������������������������������������@���������+������������������������*������������+���� ��*���
��������������� �����������������������������������������������������=�����V������������������������ �����������������*������������:�� ��~'��� ����������������������������V��*�������*���������:�� ��~'��� ���!�������������/&�
����!* �����[�������� ���������������
����[�������=����������������������������=�������������������*�����������=���������*���������������������+��� ���������������������[�������=���+�������������
����>��+������)���������� ����������������+���V�����]��������%����>��+������)��������������
���������������� ���������������������������������*������������������Z�����*���**���������������������������*�����������=���������*�������*���**�����������������+�������+�Z�����@��@���������������������*���**��������?�!��*��B�����*�����
GAS
OFFON
����]/�(���_���(��=����� ���������������
���������������*��������������*���������K����[�������*�������*���������+�������+�Z�����@��@��������V���!�������������^�����V�����]��������%�
���������� �����*����������������V���� ������������*��� �� ���������~���=����� ����`�������+��=�����������V����*������������������� ��=�������������!������V����*����>���������������������� ����?�����B���������������������������������V�����������������������������������������*��� �����������������������������������������*��NOTE:�!�����������������������������������������*�������������������������������V����������� �������������
���������������*�����������������������������������*��� �����������~���=����� ����`�������+��=������������������������������������������������������������������������
46
OPERATING STATES�����������������������������������������������������������������'���������������������+������������**����������������������������� ������������ ��� ������+���V���������������//���������+�Z�����@��@������������������TABLE 12
State Description+���� � ���������������������������������=�����������������):�������������*����������������� =������@���������+��������
)����(��������� ���������������*�������������������������������������� ���������������������������
+����!�����'���� ���������������*��������������������\���������*�����������x����� �����������������������������������������=����������\����������������������������������������������*������������������>��+������)�����������!* �����[������NOTE:�)�����������������*�����������������������������������������'�����������������������������*���������*�����������������������������
Pre-Purge ����!* �����[�������������������������������������������*������* ��������* ������������������
)����������*�Q� ����>��+������)���������������������������������������*����������������������������+�������+�Z�����@��@���������������������*���**��������?�!��*��B�����*�����
)�����������=���� ����]/�(���_���(��=��������������������������������������������������K����[�����
)�������(��������� ���������������*����*��������������*�����������������Z�����*���**���*�����������������+�������+�Z�����@��@���������������������*���**���*�����������������?'!�*�����*��B�����*�����
Inter-Purge ����!* �����[������������������������������������������*������* ��������* ������������������������������*���
Heating )�������������������"���*��������������������� �������� ���������������������������������������� ������������
Post-Purge ����!* �����[�������������������������������������������*������* ��������* ��������������������������������
V��� ���������������*����������������V�������������>���������������������� �������������V�������������������������������������������������*��� �����������������������������������������*��NOTE:�!�����������������������������������������*�������������������������������V����������� �������������
CONTROL SYSTEM MENUSV�*�����'��������������������������@������������������� �����K����������;!'�������������������K����K���������������������������������*�*���������������������� ��� ���������� ������������������*�*����TABLE 13
Menu Description��*�������� K����**�������������*����!�����������@���������+������������'�������������������������
Heater Status �����*�������������������������������������������������������������:!@�?���~�����B�������~����������� ����!* �����[����"�����=��=�"��������"���*�����������������*���������������������*�����������������������������*���
Display Settings ��*�������������?�V����!B"�����;!'������������? ���������~�������B����� ���������������������{��� �������������������������������*���
>������)���*���� :������� ��*�����������"� ������������������� ��*�"������������������"����������� ��*������������Q)K�����!![�����������=���������� ��=��������������*���
!������V��� '���������������������������V����*��������
V����>����� ����������������*�*����������������������������������?^B�V��������������*�����������������*�����*���������������=���������������������������
V����@�������� ����������������*�*������������������������������*������*��������V�����������������������������������������������������������������
C������V������'������ ����������� �����*� ������������� �������� �� ������������� �����*�������������� �� ������ �������������� ����������'�������+���������������������C:�#@������������������������������������������
>����+������ ��x�� ���������������������������*������x���������������������������������"���=���������������������*�*������������������������
47
USER SETTINGS & CONTROL SYSTEM MENUSTEMPERATURES MENUOperating Set Point And Differential Adjustment����@���������+�������� �����{��� ��� ��*�^��V�?/]�!B� ��&���V�?�]�!B������ ��������������� ���&]��V�?/^�!B������'������������ �����{��� �����*�]����]����������������������������������������������������������������*�������*���������*���������������������������������x�������������{������������������������=���������������������*�*���������������������*��������������� �����������������*���*��������?�������������B���*���������� ���������������@���������+�����������������������*�������������������������������������������������� ������=�����������������������������������*������������� ��������@���������+��������*��������'��������������������NOTE:� ;���� '������������ ��������� *��� ����� �x�����=�� �������� ������� ?����\�������B� ������ ���� ����� ���*����� ������� ���*�������������� ����>��+������ )��������+��� ����'��������������� ������������������������������������������� �������������������+�������@���������+��������������������������������������������������� ���������������������*���������������
DESCRIPTION/ACTION DISPLAYV�*�����'������������"�����������@����������[���������K:#Q�������K����K���������������� ������������
Tank Temperature 120°FOperating Set Point 120°FStatus: Standby
MENU HELP
MANUFACTURER / MODEL INFORMATION
����K����K���������������������������*�*��������������"������� ���&$��������/��������*���������������������������������������*�*�����Q�������Q������'���[�������=�������������������*�*������*�����K����K���
�������*���������*������������?��������������� ����B��������K����K���������"�����������@����������[����������+:;:!�����������������*���������*���
)��������*���������*�������������������������Q������'���[�������������������*������*�
TemperaturesHeater StatusDisplay SettingsHeater InformationCurrent Fault
SELECT BACK HELP
Main Menu
���������@���������+��������������������������*���������*��"�����������@����������[���������������!>�#_:��������=����������{��*����*�����������*������*�
)��@���������+������������������������������Q������'���[�������������������*������*�
NOTE:�>��������*��������������������������������������������������+�������@���������+��������������������������������������������������� ��������������������������������������=��������*������������������������������������������
Operating Set Point 120°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
CHANGE BACK HELP
Temperatures
�����������{��*����*����������@���������+������������=������������������ �����������������*��� ������������� �����������
Q�������Q������'���[���������������������������������
����������@����������[����������Q�'��:������=�����������������������������@����������[����������!�#!:;���������������������������������������=�������=�����������
NOTE:�Q����������*�����������������������'�������������������������������{��� ����������������������������������*�*����
Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
UPDATE CANCEL
Temperatures
48
TEMPERATURES MENU (CONT)
DESCRIPTION/ACTION DISPLAY�� Tank Temperature�\������{��� ���\������������*�
���������*��������?�=���������*�����������������*���������� ��B�
�� Upper Temperature�\������{��� ���\������������*����������*����������*�����Q�������*���������� ��
�� Lower Temperature�\������{��� ���\������������*����������*����������*�����;������*���������� ��
�� (Heater Regulated to Tank)�\������{��� ���\���������������*�����
�� Upper Probe & Lower Probe Offset�\���{��� ��������������"�������\�����§���?�����������������B��NOTE:������������������������� ���������������������������� ��*�������� =������ �������� ��*� ���� @��������� +���������������������Q���������;������ ��@��������������� ������ ����������������*���*�������������������������� �*��=�� �����������������*�������������� ���������������������������������������������������������� ���������*����������� ������� ������������ ���� ?��� ������ ��������� �� ���������������B������*��������������������������������*���������*�������:x�*����� )�� ���� ������� ������� ��*�������� ��*� ����*���������� �����&]��V�?/^�!B���������@������������������������ �������{���������=����������������"����������������*��������� ������� �������� ����������� ��*����������*������� �����������=��������������*���������>�������������� ���� �� ����=����� ���� ������=����� ����� �� �������� ������?�����B���*�����������������������������{��������������*������������ ����������@���������+������������'��������������{��*�����������/%�
Top of Menu
Operating Set Point 140°FDifferential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°F
CHANGE BACK HELP
Temperatures
[��*���K��
Differential 8°FTank Temperature 120°FUpper Temperature 122°FLower Temperature 118°F(Heater Regulated to Tank)Upper Probe Offset 0°FLower Probe Offset 0°F
CHANGE BACK HELP
Temperatures
HEATER STATUS MENU
DESCRIPTION/ACTION DISPLAY+������ >������ +����� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*���
�� Status�\���������������������@���������+����"������� ���&]��������/��
�� ECO Contact"�Low Gas PS"�Blocked Inlet PS"�Blocked Outlet PS"�Blower Prover PS�\�������������������������������������������������������������
�� Blower On"�Igniter On"�Gas Valve On�\��������������������������������������*��������������������������������������������*������������ ����������"��� ���\����������
�� Igniter Current�\��������������������������������������*��������������������Z�����*���**�������"�����+�Z�����@��@������������������
�� Flame Detected�\��������������������������������������*��������������K����[�������*������������������*�������*��������
�� External Input Enable�\���������������������������+&���������������=�� ������������������=����������� ��~���� ���������"�����:�� ��~'��� ���!�������������/&�
�� Ignition Trials�\���������������������������+&���������������=�� �������������������&���$������������������� �������������������)�������V�������V�����������"���������!![�\�!�������!�����[����;������������%�
Top of Menu
Status StandbyECO Contact ClosedLow Gas PS ClosedBlocked Inlet PS ClosedBlocked Outlet PS ClosedBlower Prover PS OpenBlower On No
BACK HELP
Heater Status
[��*���K��
Blower On NoIgniter On NoIgniter Current NoGas Valve On NoFlame Detected NoExternal Input Enable NoIgnition Trials 3
BACK HELP
Heater Status
49
DISPLAY SETTINGS
DESCRIPTION/ACTION DISPLAY+������ '������� +�������� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*�������������{��� ��������������������=�����������*������� ���� Q)K��� ;!'� �������� Q��� ���� Q�� <� '��� [����� ����=����������*���
�� Temperature Units�\���{��� ������������������������������*�����������������������!�������!���V�����������V�
�� Backlight Delay�\���{��� �������������������������*����������������Q)K���;!'� �����������*��������*����������������������� ��������������=���� ������������������������@��"�&�"�$�������������������������@��
�� Contrast�\���{��� �������������������{�������Q)K���;!'���������������� ���������x������ ��������NOTE: ������ ��������� ���� ��{����� ��� ���� ��*�� ���������� ��� ��� ���� @��������� +��� ����� ���� '��������������{��*�����������/%�
Temperature Units °FBacklight Delay 30sContrast 60%
CHANGE BACK HELP
Display Settings
HEATER INFORMATION
DESCRIPTION/ACTION DISPLAY+������>������ )���*����� ��*� ����K����K������������� ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*�����
�� Elapsed Time�\���������*��������*�����������������*�?������������B����� ��������������
�� Burner On Time�\���������*��������*�����������������*����� ����������������������������������� ����������*��
�� Cycle Count \���������*����������������������������� CCB Version \�+�������=����������������������� ������ UIM Version \�+�������=�����������������������*����
NOTE: >������������������������������!![���*�*����)�������!![����������������������=�������������������������������!![� ������������������� ���������������������������������������� ��������� �� ������ ������� ����������� ������� �� ���������������������:���������*�"�[�����@����*������!�����!���������������"���������������)�� ���� !����� !��� ���� ���� ��� ����� ?��=���� ������ ���� ������� �������*������������������B��� ����������������� ��������?�����*���� ���������*�������*�����"���=���� ������� ��*�� ����� *������ �� ������ ���B� �������� ������� ����'������������ �������� �� �=��� ����� �������� ���� �x�����=���*����������"�����@���������+������������'��������������{��*�����������/%������ ���������� ����� ���� ���� �� ���� �� ������� �����������*�������������������������������������*�������Z��*������������=������������������������������������������������
Elapsed Time 10 day 0 hrs 0 minsBurner On Time 5 hrs 22 minsCycle Count 00000035CCB Version X.XXUIM Version X.XX
CHANGE BACK HELP
Heater Information
50
CURRENT FAULT
DESCRIPTION/ACTION DISPLAY+������ !������ V���� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� ���� ������� V���� �������� ����� *��������������*������V������������*������������������������������� ������� �������������������������������������������V������������ �������� �������� ���� ������ ��������� ���� @����������[���� ����� ��'(�#!:'�� ����� ��=�� *��� ��������� ���=��������*����������� ����������� ��������� ��� ����V���������������������+���V��������������K����������������]����*����������������*����������������������������)�� ������ �����V������������ ������������=�� �����*��������������������������*����"��?���B������� ���������x����!������V�����������K����*���
CHANGE BACK ADVANCED
Blocked ExhaustFault occurred 2 mins ago
The exhaust is blocked orrestricted. Ensurecondensate hose is draining.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
FAULT HISTORY
DESCRIPTION/ACTION DISPLAY+������ V���� >������ ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� �� ����� �� ���� ����� ����� ?^B� V���� ����������*�����������������*�����*���������������=�������������������������������������@����������[����������():�����=������������ ��������V������������*�������������
1: Blocked Air Intake (A7) 51 mins ago2: Blocked Exhaust (A8) 54 mins ago3: Low Gas Pressure (A6) 57 mins ago4: Blower Prover Failure (AC)
VIEW BACK HELP
Fault History
FAULT OCCURRENCE
DESCRIPTION/ACTION DISPLAY+������ V���� @��������� ��*� ���� K���� K��� ���� ������ ����@���������� [���� ����� �+:;:!��� �� ������ ����� *���� �����*����������������{��� �����������������*������Q�������Q��<�'���[���������=����������*�������� *��� �������� �� ������� ����� �� ��� *���� ��*��� �����V���� �������� ���� ������� ������ ���� ������ ������� ���� ���������������NOTE: >��������� ����� ��� ������ ��� ���� !![��� *�*���� )�� �����!![����������������������=�������������������������������!![� ����� �������������� �� �������������������� ��� ��������������� �������������������������������������������������������������
Ignition Failure 10ECO 0Low Gas Pressure 10Blocked Intake Air 0Blocked Exhaust 0Thermostat Input 4 0Blower Prover 3
BACK HELP
Fault Occurrence
RESTORE FACTORY DEFAULTS
DESCRIPTION/ACTION DISPLAY+������C������V������'���������*�����K����K�����������������@����������[����������+:;:!����������������*����� ������� ���� ��{��� ��� ���� ��������� �� ������ ������� ���������������� ������ ���� @���������� [���� ���������� �J:+��������������� ����� ���� ��x�� ����*���� ���� ������� ������� �����������=�� ������������������ ���� @���������� [���� ���������� �[�!��� �� �x��� ����C������V������'�������*���
YES NO
Restore Factory Defaults
Are you sure you want torestore the system to factorydefaults?
51
SERVICE CONTACT INFORMATION���������������*����������������*��������)�����������������������~�����=�����������������������������������������*�����������������*���������������������*���������� ���������������������V��������������*��������
DESCRIPTION/ACTION DISPLAYV�*�����'������+������?����V���������������//B��������������� ���� ���� *������ ?�*�����B� @���������� [���� ��� $���������������������������������� ����� ������ �� ��������� *��� ������ ������������ �����������*��������� ����������Q���������Q������'@�#� ������������?��������������� ����B������+���!������)���*������*������*�
����������@����������[����������!>�#_:��������=����������{��*����*���������������*�����
Show Contact Information NoChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
CHANGE BACK HELP
Service Contact Information
�����������{��*����*�������+���!������)���*����������=������������������ �����������������*��� ������������� �����������
Q�������Q������'���[����������������������������*��#�����J������������������@����������[���������������Q�'��:������=������������������
NOTE:������������!���������� ��*�������+��=����!������)���*������������������*������������������������������������������������������������������*�������������������������*������*��
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
UPDATE CANCEL
Service Contact Information
Q���������Q������'@�#� ������������?��������������� ����B������!������!������#�*���*������*�
����������@����������[����������+:;:!�������������!������!������#�*��*���
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:
(000) 000-0000Access Code
SELECT BACK HELP
Service Contact Information
V�����������������������������������������*����������*��������*�����������������*�x�**���]���������������������������������
�����������������������@����������[�����Q�'��:������=����������!������#�*������������������*���������������������������*���
Enter the service contact below:
NAME: _
Use the > and < keys to move betweencharacters. Use the UP and DOWN keys tochange the character.
- -
< > UPDATE- -Q���������Q������'@�#� ������������?��������������� ����B������!������!������������*������*���������������@����������[����������+:;:!���
V������������������������������������������!������������* �����������������@����������[����������Q�'��:������=����������������* ����
�������������!������#�*������!������������* �����=�� ��� ����������"�����������@����������[����������[�!�����������������'������������� BACK HELP
Show Contact Information YesChange Contact NameChange Contact PhoneCurrent Contact Info:YOUR COMPANY NAME HERE(123) 456-7890Access Code
Service Contact Information
52
PRIOR TO START UP
)����������� ���� ������ �� �� ����� ������ ������� ��Z����� � ��������������������Z�=��������������������������������*�����������������=�=��"�����`��������������������
'������������������������������������������������������ ��������� ������� )**��������� ����� �� Z������� ���=���� ����������� ���������� ������������������������������������������ ���������������*����������������������������� ����������������
;����� ���� ������ ������� ��� ���������� ����� ���� ;�������� ����@��������)����������� ����������������������������������*����� �������������������
�������������������=����� �������*����������Z������������������������ ������ �����*� ?���� � ����� //B� ������ ��*�����������Z����������!* �����[����"���������������������������* ����� ���* ��"� ����>��+������ )������"� ����]/�(���_���(��=�"� K���� [����� �������"� ���� ��*�� ��������� ���� �����������*����������������������������������������������*����
[����� ����*������ ������ �"� �������� ����� ���� ��*��������������������������x����+�Z�����@��@�������"�����������������+�Z����� @�� @�������� �� ����� ��� ���� ���� +�Z����� @��@��������V���!�������������^�
[����������������������������������������������"���������������������*��������������������������������������������������������������������������������:���������������������=��=�����������
FILLING THE WATER HEATERV������������������������������������������������������&�� !���������������������=��=��]�� @���������� ����������������������*�����������������������*�
���������$�� V����������������������������=��=�������������������������
������������������������������/�� !��������������������������������+����]�����������������
�����SUPPLY GAS LINE PURGING
Fire or Explosion Hazard
Read instruction manual beforeinstalling, using or servicing
water heater.
To avoid risk of fire or explosion purge discharge must notenter into confined areas or spaces where ignition can occur.
The area must be well ventilated and all sources of ignitionmust be deactivated or removed.
Gas line purging is required with new piping or systems inwhich air has entered.
Use only the gas shown on the water heater rating label.
Keep ignition sources away from faucets after extendedperiods of non-use.
&�� !��������K����_���+�����(��=�"�����V������]��������$^�
]�� ���������������*�������������������������������������������K����_���+�����(��=��
$�� ����� ���� ���� ���� ���� ������ ��*� ���� ������ ���� ����"���������������������������������������
/�� !�����������������"�����_���;����;�������������������/�"��������������������������
INITIAL START UP
REQUIRED TEST EQUIPMENT�� ���Q\� ��*��*�����"����**���������������\&/����!��
?�\$������B������\$�����!��?�\��%����B�������������������� �����������*��*���������� �����������������Q\� ��
*��*�����������������������C��**��������������\&/������§&/�������!��?�\$������B������������&����!�������\$�����!��?�\��%����B�����������&�����!�
NOTE:� ���� ����� �Z��*���� *��� �� �����*����� �� �* �������*�������� ��������� �������������PREPARATION&�� Q��������������������*�*���"������������@���������+���
����� �� ���� ������ ��*���������������"�����@���������+������������'��������������{��*�����������/%�
]�� ������������������������~����������������������������$�� !��������K����_���+���@���(��=�"�����V������]��������$^�/�� ������=��?�B�*������������������������������������ !���������*��*�����?������������B�������=���� ��������
�������������������������������������������������@��[�>�&]������&���*����������������&~���#������������������ ����� ������� ���������� ��� ���� ;�� _��� �������� ��������� ���� ������ ������� ����]/�(���_���(��=���������&~���������������������������C�*=������&~������������������*����� ��*�������������������������������� �� ���������������������*��*�������������� �"�����V����������������$�@��[�>�&^^�����]���*���������������������������������������*��������������������������������������=��=���Q��������*���������������������������=���\����������������=��=��������� ���� ������������������ ����� ���� ��� ���� ������������� �����������=��=�������������\��������� ������ ����=��=����+���������*��*�������������� ��=������������������������"�����V������^�����V����������������$�
��� !���������*��*����� ?����� �����B� ������=���� ��� ������������*�������������������������K����[�����[�>�&]��<�&���*��������*=������&~������������������*����� �������������=��=�������������������������������� �� ���������������������*��*�������������� �"�����V������%���������$�[�>� &^^� <� ]��� *������ Q����� �� �*���� ���� ���� ������������ ���=��� \� ���� ���� ������� =��=�� ������� ���� *����������� �������� ����� ���� ��� ���� ���� ����� ���� ���� �������=��=�������������\��������� ������ ����=��=���+����� ����*��*������������� � ��=��� ���� ����� ���� ��������"� ����V������^�����V����������������$�
%�� @��������K����_���+�����(��=����� K�������������������������������������"��������������������
������������������ ��������������� ����������������� ���������������{���������������������������������"�����+�����_�������������{��*������������/�
START UP
53
��� !*��������������������������������������������������� =�� �� ���� ��Z����� *���**~*�x�**� =����� ��=������ �� ��� $� �� ����� &]�� ��{��� ������ ���� ����������� ���������"� ���� +����� _��� ����������{��*���� ��������/�
^�� ����� �*������ ���� ��� ���� �� ���� ������ ������"� ��������������� �� ����� ���� '��������� � *��*���������� ���������������������� ��*=��� ��� ���������:��������� ����� ���� ������� =��=��� ������ ������ �������� �����*���������������
MANIFOLD GASPRESSURETEST PORT
SUPPLY GASPRESSURETEST PORT
GAS VALVE / VENTURI ASSEMBLY TOP VIEW199,000 & 250,000 Btu/hr MODELS
VENTURI
COMBUSTIONAIR INLET
GASVALVE
COMBUSTIONBLOWERCONNECTION
Figure 59
MANIFOLD GASPRESSURETEST PORT
SUPPLY GASPRESSURETEST PORT
GAS VALVE TOP DETAIL VIEW199,000 & 250,000 Btu/hr MODELS
Figure 60
GAS VALVE / VENTURI ASSEMBLY SIDE VIEW199,000 & 250,000 Btu/hr MODELS
VENTURI
LOW GASPRESSURESWITCH
SUPPLY GASCONNECTION
GASVALVE
COMBUSTIONAIR INLET
Figure 61
LIGHTING THE WATER HEATER&�� [�>� &]�� <� &��� *������ ���� ���� �~��� ������� �� ���� ����
=��=������������������"�����V������%�����V���������]�� ������������������������~���������������������������$�� �����������������������*����*���������� ������Z������
���� '������ ������� ������� ���� ������� @��������� +�������������������*������������� �����������������������������*���;!'���������� ������Z���������*������
/�� Q����� ���� ������ �����*� *���� ���� Q)K� ?���� ����������*���B"������������@���������+�������������������������������� ����������� ����� ��*�������������������� ���������������*�;!'���������'��������������������������=�����������������������+���!�����+����*�@���������������//�
ON
OFF
MANIFOLD GASPRESSURE REGULATORCOVER SCREW
GAS VALVE TOP VIEW120,000 & 150,000 Btu/hr MODELS
MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG
SUPPLY GASPRESSURE TAP1/8’ NPT PLUG
INLET OUTLET
ON/OFFSWITCH
Figure 57��� C���������*����������������������������]/�(���_���(��=��
���������������������K����[���������������"��������*���������=��=�� ���� ����� �� ���������� �� ���� '������ ������� �� ���������������*���;!'���������������������*���������������]/�(���_���(��=�"������*�������*�����������������������K���� [����� �������� ��� ��������"� ���� ���� +����� )��������������������� ���&&��������/��
GAS VALVE SIDE VIEW120,000 & 150,000 Btu/hr MODELS
MANIFOLD GASPRESSURE TAP1/8’ NPT PLUG
SUPPLY GASPRESSURE TAP1/8’ NPT PLUGBOTTOM OF TEE
1/8” NPTTEE FITTING
GAS VALVEOUTLET
ON/OFFSWITCH
LOW GASPRESSURESWITCH
Figure 58��� !*���������������*������������������������������������
� =����������Z�����*���**~*�x�**�=�������=�������� ���$� �� ����� &]����{��� *������� ���� �������� ��� ���������"�����K�������_�������������{��*������������/�
%�� C������������������������������������]/�(���_���(��=�����������������������K����[��������������������������������*���������������������������������������������������������
54
SUPPLY GAS PRESSURE ADJUSTMENT
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
+����������������������� ��*������������������������������������������?��������������B�AND�������������������������������������������������?����*����������B��)������������������������������������������������� �������������Z�����*���**�����*�x�**�=�������=�������� ���$��������&]���{�����������������������������������������{����������������� �������?�B� ���� ���� �������� *������������ ����������� �������=��������Z�����������������������*����������������������Multiple Water Heater Installations:)�� *������� ������ ������� ������������� �� ��� ������������� ���������� ����������������������?�B����������**������������*����������������������������������� ����������������������������� ��*�����������������������������������������������������������������������**��*��������������������������@�� *������� ������ ������� ������������� ���� ������ ���� �������������� ������ �� ��{����� �� ��=���� ���� �������� �� �����������������������������*���**�����*�x�**�����������������Z���*����� ������� ��� �� ��� $� �� ����� &]� ����� ���� ���� ������������������������������**������*��������������������������NOTE:�����������������*��������&�������!��?��$%����B����������K����[���������������������������������������Z���������������������������������������������"���������������~���������������)����������*��������&�������!��?��$%����B������������������������������������K����[����� �������"������� �������������������������������?�B����������������������������������+���������Z���*��������+�����_���C�����������_���+�����+����*�� �� ����� &/�� +��� +����� _��� ;���� )����������� ������� $^� ���� +����� _��� C������� �� ����� &/�� :����� ������Z���*������������������������������������*����������MANIFOLD GAS PRESSURE ADJUSTMENT
Fire and Explosion Hazard
Gas and carbon monoxide detectors areavailable.
Overfiring could result in fire orexplosion.
Under no circumstances should the input exceed the rate shown on the water heater’s rating label.
Breathing Hazard - Carbon Monoxide Gas
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.
Overfiring could result in damage tothe water heater and sooting.
Gas and carbon monoxide detectorsare available.
:����� ���� �����*���� ������ ���� �������� ��� � =�� ����*���**� ��Z���*����� ��� �� ��� $� �� ����� &]� ����� ������{��*���������*����������*������������������������*��������{���*��������������������������������������������������������������������=����������������������������������������������*����+���+�����_�������������{��*����������������
NOTE:�K������������������������\��{��� �����[�>�&^^�����[�>�]���*����������*���������������������������*����������������������������� ���������{������)������*������������������������������������������*����������� ��*��������±���$�����!����*������������=���������� ���$��������&]��������������������������������* ���������������� �����=����������*���������������������������
V�������������� ��������{�������*���������������������[�>�&]������&���*�����
&�� V���� ���� ����������� ��� )������� +����� Q�� �� ����� �]����������*��*����������������������*�����������������������������������������������������
]�� C�*=�� ���� *������� ���� �������� �������� �=��������"�����V������%���������$�
$�� Q��������*���� ����� �������������=��� ���� ������{��*������������������������������*�������������������������������������������������*�������������������
NOTE:� ���� ���� *������� ���� �������� ��{��*��������������*���� �����*�����?��*��������&~/����B��������������*������������������������ �����������=�����*������ �����*���������������{��*�����
/�� C��������������������������������=���������
��� !����� ���� ����� �� ���� ��� ��=����� ��*��� �� ��������������
55
CHECKING THE FIRING RATE
)�� ������ �������{��*���� ��� ��Z����� ����� ������ ����������� �������*��������������������������������������������&�� :�����������������������������������������������������
��������*���������������������������]�� !�����������������������������*����������������=���"� ���
[������� �����"�����������������$�� !������ �� *��*����� �� ���� *������� ���� �������� �����
V����������������������)�������+�����Q����������]�/�� +����������������������������������������������� !���������*������������������"������� ���� ���$��������
&]� ��� ������� ��������� +��� K������� _��� ����������{��*������������/������{��*�����������������
��� ;�������������*��������=���������������������%�� ��*���������?���������B����������������� ������������
�� ���������������������������������������������������������� Q���������*��� ���������������������*��������������*����
���������������������������������������� �������������������=����?[������� �����B�����������������
x H = Btu/hr3600T
x 1050 = 300,000 Btu/hr (87.9 kW)360012.6
Example:
�� $���� ������������������� �� ���*�"����������"��� ������� �������������� >� ���������=�������������[������� ��������� [�~��� �������������������������������������
NOTE:�&����[������� ��������������������=�������������������+�������������������[������������]����[������� �������[��=�����*������������������������������������������=�������!�������������������������������*�����
TO TURN OFF GAS&�� !������ ����@���������+�������� �� ���� ������ ��*��������
�������"�����@���������+������������'��������������{��*�����������/%�
]�� ���������������������������*���������������������Z������������������������� ��*��"�������������������������~����������������������������
$�� !��������K����_���+�����(��=�"�����V������]��������$^�
HIGH ALTITUDE INSTALLATIONS
Fire and Explosion Hazard
Gas and carbon monoxide detectors areavailable.
Overfiring could result in fire orexplosion.
Under no circumstances should the input exceed the rate shown on the water heater’s rating label.
Breathing Hazard - Carbon Monoxide Gas
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Under no circumstances shouldthe input exceed the rate shownon the water heater’s rating label.
Overfiring could result in damage tothe water heater and sooting.
Gas and carbon monoxide detectorsare available.
[�>�&]������&���*������������������������������*�������������������������%"%��������?]"$/%�*B�[�>�&^^�����]���*������������������������������*�������������������������&�"&��������?$"�%��*B�K�������������� �*���������\����� ���������� ����������������"�*���������������������������������������������������V�� �������������� =������������������=�������������� =���������������������������������* ���������������� �����=����������*�������������������������������������!���������������������������*�������=������[������� ������������� �������������������������������������������=�����������*������=���� ���NOTE:�����������������������������������������*�������x��������� ����� ������� �� ���� ������ ��������� ������� �� ��� ����� ��������*��������NOTE:� '�� �� ���� ����� ������� �������� ��� ����� ��������"� ��������������������������������������������������������� ���*���������������������������������Z��*�������������������
56
LIGHTING THE WATER HEATER
OFF
RE
GA
DJU
ST
ON
FLOW
FOR YOUR SAFETY READ BEFORE OPERATING
TO TURN OFF GAS TO APPLIANCE
OPERATING INSTRUCTIONS
Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.
IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
A.
B.
1.
2.
C.
D.
This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.
STOP! Read the safety information above on thislabel.
Do not try to light any appliance.
Do not touch any electrical switch; do not use any telephonein your building.
Immediately call your gas supplier from a neighbor’s
telephone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the firedepartment.
Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.
Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.
BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.
Set thermostat to lowest setting.
1. Set the thermostat to lowest setting.
8. Set thermostat to desired setting.
9. If the appliance will not operate, follow the instructions“To Turn Off Gas To Appliance” and call your servicetechnician or gas supplier.
3. Turn off all electrical power to the appliance.
2. Turn off all electrical power to the appliance if service is to be performed.
7. Turn on all electrical power to the appliance.
6.
3. MOve “Off/On” switch to the “Off” position. Do not force.
4. This appliance is equipped with an ignition device whichautomatically lights the burner. Do not try to light theburner by hand.
5. Move “Off/On” switch to the “Off” position.
Move “Off/On” switch to the “On” position.
“WHAT TO DO IF YOU SMELL GAS”
WARNING
On/Off Switch
LIGHTING & OPERATION LABELS
���������������� ��� ����������x�������������������������=����� �������*�����������������������*��� �����������������������������������������������������
BTH 120 AND 150 MODELS ONLY
57
Tank Temperature 103°FOperating Set Point 120°FStatus: Heating
MENU HELP
UP
DNGAS
OFFON
MODEL INFORMATION
ON/OFF SWITCH
FOR YOUR SAFETY READ BEFORE OPERATING
TO TURN OFF GAS TO APPLIANCE
OPERATING INSTRUCTIONS
IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY A FIRE OR EXPLOSIONMAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.
A.
B.
C.
D.
This appliance does not have a pilot. It is equipped withan ignition device which automatically lights the burner.Do not try to light the burner by hand.
Do not try to light any appliance.
Do not touch any electrical switch; do not use any telephonein your building.
Immediately call your gas supplier from a neighbor’s
telephone. Follow the gas supplier’s instructions.
If you cannot reach your gas supplier, call the firedepartment.
Use only your hand to push in or turn the gas controlknob. Never use tools. If the knob will not push in orturn by hand, don’t try to repair it, call a qualified servicetechnician. Force or attempted repair may result in fireor explosion.
Do not use this appliance if any part has been under water.Immediately call a qualified service technician to inspectthe appliance and to replace any part of the control systemand any gas control which has been under water.
BEFORE OPERATING smell all around the appliance areafor gas. Be sure to smell next to the floor because somegas is heavier than air and will settle on the floor.
2. Set the ON/OFF switch on the control panel tothe “ON” position.
8. Set the ON/OFF switch on the control panel tothe “ON” position.
1. Set the thermostat to lowest setting.
3. Set the thermostat to the lowest setting.
3. Turn off all electrical power to the appliance if service is to be performed.
7. Turn on all electrical power to the appliance.
2. Set the ON/OFF switch on the control panel to the “OFF” position.
Wait five (5) minutes to clear out any gas. If you thensmell gas, STOP! Follow “B” in the safety informationabove on this label. If you don’t smell gas, go on tothe next step.
6.
4. Set the ON/OFF switch on the control panel to the“Off” position.
10. If the appliance will not operate, follow the instructions“TO TURN OFF GAS TO APPLIANCE” and call your servicetechnician or gas supplier.WARNING: TURN OFF ALL ELECTRICALPOWER BEFORE SERVICING.
9. Set thermostat to desired setting.CAUTION: Hotter water increases the risk ofscald injury. Consult the instructionmanual before changing temperature.
“WHAT TO DO IF YOU SMELL GAS”
5. This appliance is equipped with an ignition device whichautomatically lights the burner. DO NOT TRY TO LIGHT THE BURNER BY HAND.
WARNING
BEFORE OPERATING: ENTIRE SYSTEM MUST BE FILLED WITH WATER AND AIR PURGED FROM ALL LINES
1. STOP! Read the safety information above on thislabel.
LIGHTING & OPERATION LABELS
���������������� ��� ����������x�������������������������=����� �������*�����������������������*��� �����������������������������������������������������
BTH 199 AND 250 MODELS ONLY
LIGHTING THE WATER HEATER
58
SEQUENCE OF OPERATION
C���� ���� +�Z����� �� @�������� ���� ����� ����*������ ��������� ���� ���������� �� ��*��� C����� �� ���� V������� ����!*������� ������� ��������� �� ����� %� ��� ���� ���������=�������������������*������������� ��� �����+��� ����+�Z�����@��@��������V���!�������������^�����&�� ����� ���� ������ �����*� ��� ����� ������"� ������ ��
�"� ��� ����� �������� ������ ������� *���� ����*����� ����������������������������� ����**����� ���������������*�;!'���������������������Q)K�?��������������*���B���������������������������������������������'��������������
]�� )�� ���� ������ �����*� �����*����� ����� ���� ������ ��������*�������� ������� ���� ����� ��� ���� ���� �����**���@���������+��������*��������'�������������������"������������������������=�����
$�� ���������������*�����������*��������������������������*��������� ����� �������� ����*���� ���� ��� ���� �������"� ������ �x����"� ������ ������� ���� :!@� ?������� ����B�������������������������������[�������=���+����������������������*�������
/�� )��������������������������������������������"����������������*���������������!* �����[�����������\�����
��� ���������������*�*�������*�����[�������=���+�����������������������������!* �����[������������������
��� )�� ����[�������=���+������ ������������ ����*������������������������*���������������>��+������)�������������������������*\��������
%�� ���� ������ �����*� *������ ���� �������� ������� ���� *�����������*���**���]����!��*������������������������*���������?&]\&%�������B�
��� )�� �������� �*������� ��� ����*��� ��� �� � =�� ���� ��Z�����*���**����������������*���������������]/�(���_���(��=�������������������������K����[������
^�� ���������������*���\��������������>��+������)�������&������������������*�*������������*��������������*���
��*��������������������K����[������)������*��������=����������������� �����������������������������������*������ ���� ������������������*�����*����)����*��������� ��=������������������� ������� ��� �������"� ���������������*������ �����������������������)�������V�������V����*�������
&&��)�� �� ��*�� ��� =������"� ���� ������ �����*� ����� ������ ������������*��������� �������� ��������������� �������������������@���������+��������������������������������"����������������*��������\�������������]/�(���_���(��=�������������������\�����������?����x�*������$��������B�
&]������!* �����[������������������������������������\����� ������ �� ����� ���� ������ ������� �� ���� �* �������������������������\���������������*�����"����� ����������\��������������������������������
&$������ ������ �����*� ��� ������� ���� ����� �� *��� ��������������� �� *����� ���� ��������� ������� ����� ��������*�������� ���� ���� ������ �� ����� �����*� ��=������ )�� �����������*������������� ��������@���������+��������*��������'�������������������"������������������*�����������������+����]�������������������������������
TROUBLESHOOTINGINSTALLATION CHECKLIST
���� ����� ���� ������������*���� ����*��� ��������� ��������������Z���*���������"������=������"������������ ��������������� ��*�"� ���� ��*�� ���� ��������� ������ �������*����� �������� ��� �� �*������ ������ [����� �����*���� ���� �� ������������������ ��� ���� ����� ���� �� ������ ��� ������������ �������!���� �� ������� ������������ ������ ���� ��� �=����� ����� ������*����� ���������� :����� ���� ������������ ��Z���*����� �����������������������*�������=�� ����*���������������������WATER HEATER LOCATION&�� :����� ������ ����������� �� �* ��� ���� ���� *����������
�����������������������*������=����������������������+���!�����������!* ��� ���K����������������&$�
]�� :�����������������������������=�����*�����������**� ���*����������+������������������������&%�
VENTING$�� :�����������������������~��=����?�x����B����������������������
����� ��� ���� ���������� ��������+���(�������C�Z���*������������]/�
/�� :����� ����*�x�**��Z�=������ ������������������� �����x����������������������������~��=����������+����� ���%��������]/�
��� :����� ���� *�x�**� �* ��� �� �� ��� ���� ��� �����x������� ��� ���� ������� ���� ���~�� =���� ������ +��� (�������C�Z���*������������]/�
��� :����� ���� ������� ���� ������� ���� ���� ��*=��� ��*� ���������������������������������������������������������������������������� �����'������(���� �����������+���V�����&^��������]��
%�� :����� ���� �x������ ����������� ��� ���� ������� ���"� =���� �������������� ���*�������� ���� *����������� +��� (�����������*������� )����������� �� ����� ]%"� +�������� ���*�������)������������������]^�����!������������*�������)������������������$����������������������������������� ������������������������*��� ��*����������
GAS SUPPLY AND PIPING��� :����� �� ������ ���� �������� ���� ���� ���������� ��� �����
��������������+���������Z���*����������+�����_���C��������������&/�����+�����_���C��������������&/�
^�� :����� ���� ������ ���� ����� �� ����� ������ ������� *��������� *���**� ������ ���� ����� ����� ��Z���*������ +��� ������Z���*����� ��� ����_���+�����+����*���������&/���������������������������������������$^�����/��
CONDENSATE DRAIN&���:����� ���� ���������� ������ ��� �������� ��������� �� ����
�x������� ������������������������������������������������� �������������+���V�����̂ ��������&%�����!���������'�����)������������������$��
ELECTRICAL CONNECTIONS&&��:�����������������������������������������������������
����������������+���������Z���*�����������������+������������&/�����:������������������������/&�
&]��:�����������������������������������������V��*������������Z�����������Z����������������)�����������������������������������������������������)�������V������
59
SEQUENCE OF OPERATION FLOW CHART
YES NO
Water is heated to set point
24 Volt Gas Valvede-energized
30 secondInter-Purge cycle
24 Volt Gas Valvede-energized
Retries up totwo more times
30 secondPost-Purge cycle
Control System Locks Out
“Ignition Failure” Fault Msg is displayed
Water heater goes into standby mode
If tank temperature drops below Operating Set Point minus Differential setting a heating cycle is activated
Blower Prover switch contacts confirmed closed by control system
Igniter is energized for warm up period
24 Volt Gas Valve is energizedgas flows to Main Burner
Is flame sensed at the Main Burner?(control system monitors the flame sensor)
Control System Locks OutDisplays Fault MsgNO
Control System Locks Out“Blower Prover Open”Fault Msg is displayed
NO
Control System Locks Out “Low Igniter Current”
Fault Msg is displayedNO
Combustion Blower is energizedPre-Purge cycle
Does Control System sense minimum Igniter amps?
Control System performs diagnostic checksNormal State of all pressure switches and ECO are checked
Blower Prover pressure switch verified openAll other pressure switches and ECO are verified closed
2.0 minimum AC amps
Figure 62
60
�� :x�����=��*�������������������\������� ���$��������&]�����K�������_�������������{��*������������/�
�� (����?�x����B������������������������=���������������������������*����������'������(�����������������\�����'������(����)������������������]��
�� :x�����=���Z�=������������������������������~��=����?�x����B������������������\�����(�������C�Z���*������������]/�
�� '� �����������~ ����������������������������?�B�\�����V�����&^��������]������V�����]���������]^�
�� '� �����������~ �����������K����[�����\�����V�����]��������%�
MOMENTARY IGNITION
Burn Hazard
Do not reach into the burner housing orcombustion chamber if the water heateris still hot.
Allow the water heater to cool and always usegloves when handling the main burner.
The combustion chamber and burner sleeve and housing become very hot during operation.
CAUTION
)�� ���� K���� [����� �������� **��������� �� ���� ��� ��������������� ����� ���� ������ ������� �� ���� �� ������� �� �� ��� *�����*�������������������*����������������)�������V������V����*�������������������������������������*���;!'��)�����������������������x����������������������\�����C���+�������"�C���@���������������������V��**����������������� ��*���������������������������������������
�� )��������*������� ������������ \� ������ ��� $�������� &]�����K�������_�������������{��*������������/�
�� Q�������������������������?���=�*�������������B�\�����_���+�����+����*���������&/�
�� +����� ���� �������� ��� ��� ���������� ���� ��������������Z���*����� ?�������� ���� ������ =�*�~��������B� \� ����+�����_���C��������������&/�
�� +������������������ ����������������������������������������������)�������V������V����*���������������]�
�� '� �����������~ ����������������������������?�B�\�����V�����&^��������]������V�����]���������]^�
�� '� �����������~ �����������K����[�����\�����V�����]��������%�
NOT ENOUGH OR NO HOT WATER�� #������������������������"������� ������"��������������
��������������~������������ >��������������=��=�?�B����x������������� @���������+�������������������"�'���������������������������
��������+���!�����+����*�@���������������//��� Q��������~��;������ ��@������������������������������
��������������������*���������*�������\�������*���������K���?���B��������/��
�� :����������������������x�����������=�����������?������������ ��~���� ���������B����� ����������������������+���:�� ��~'��� ���!�������������/&�
�� �������������������������������������������� �����x������"����������������������� �����*������*����
OPERATIONAL PROBLEMS
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
������������������*������������������� �����������������������**�������������� ��*�"��������������������=�����������������*��� �� � ��� �� ���=�� ���� ������� �������� �� ��*�� ������*���������������� ����������������� ����������� ������������������� ��� ��� ��\����� ������ �� �������� �������� >��=��"� ����Z������� ���=���� ������"� ��� ������� ��� `����������� �� ������"� ����� ����������� ����� �Z��*���"� ����� �����*� �������=���������������������������������NOTE:� !���� ���� ���������� ������ ����� �* ��� ������� �� ���� �����=����������*������������������������������������������������Z����������=���������������������INSTALLATION ERRORS@������������ ��*��������������������������������������������������������Z���*������������=�� ����=�������������������������� �*�������� ):�� �� �;�� _��� ��������� V���� �����������*�������������� ��������������������������������������������=��;��_�������������������C���������������� ��������������������������� �������������������������������~������� ����������������������������������������������������� �� �����*���� ���� ���������� ������� �������� ���� ������������� ������������ �� ������ ���� ������������ ��Z���*����� ��������������� ��=�� ���� *���������� ���� �������� +��� ����)�����������!������������������NOTE:�!���������������������������������������=����������������*��������������ROUGH STARTING, ROUGH OPERATION
Fire and Explosion Hazard
Turn off gas lines during installation.Contact a qualified installer or serviceagency for installation and service.
Excessive gas pressure to gas valve cancause serious injury or death.
Do not use water heater with any gasother than the gas shown on the ratinglabel.
�� Q�������������������������?���=�*�������������B�\�����_���+�����+����*���������&/��
�� +���������������������������������������������������Z���*�����?������������������=�*�~��������B�\�����+�����_���C��������������&/�
�� :x�����=��������������������\������� ���$��������&]�����+�����_�������������{��*������������/�
61
ALERT CONDITIONS��������������������*����������������������������������������������������*������������������������*���;!'��������Z�������¶��*������������������������������������������������������������������ �� �����������������*��� �����=����� ����Z����������=����������������������� ���RESETTING CONTROL SYSTEM LOCK OUTS�� ������ ���������������*� ��*��� ��������������� ���� �������������������������x�*������]������������������ ���������������*�����������������������������������V����������� ������������"����������������*���������������������DIAGNOSTIC CHECKS
Turn off power to the water heaterbefore performing any service.
Electrical Shock Hazard
Label all wires prior to disconnectingwhen performing service. Wiring errorscan cause improper and dangerousoperation.
Verify proper operation after servicing.
Failure to follow these instructions canresult in personal injury or death.
���� �������� ������"� V�������������� K�������� �� ����� �]"��������*��������*�����������������������*��������������������;!'���������������������������� ��*�����������������*���������������������������������V��������������*�������������� �������������� ���� ����������� ������������� ������� �������������������@���� Z������� ���=���� ������"� ��� ������� ��� `����������� ��������"����������������� ������Z��*���"� ����������*��������=���������������������������������NOTE:� )�� �� ���� ��� Z������� ���� ��������� �� ��������� �����Z����� �� ��������������=���� {���������� �������*�����=�����������������*����������*��������������������������=������������������� ��������������������������)�����������������������������������������������������������������*����������*��������������!������������������������������* ���������������� �����=����� ����� *����� ��� ������� ���������� ����������� �� �� ������ ��Z����������=���������������������
Jumping out control circuits or components canresult in property damage, personal injury or death.
Service should only be performed by a qualified serviceagent using proper test equipment.Altering the water heater controls and/or wiring in any waycould result in permanent damage to the controls or waterheater and is not covered under the limited warranty.
Any bypass or alteration of the waterheater controls and/or wiring will result
in voiding the appliance warranty.
Altering the water heater controls and/or wiring in any waycould result in altering the ignition sequence allowing gas toflow to the main burner before the hot surface igniter is atignition temperature causing delayed ignition which cancause a fire or explosion.
�� !��������*������������*��������������������������*����Z������������������������������*��������
�� >��������������������"�����������"��������������������=��=����������������
�� +���*��������*�����������*������*��� ����������������������������������+���K�������������������/��������*����������*����������*=������������
�� ������������������������������������������!�����*������������������"������������������������/��!����������������������������������������"��������������������������
WATER IS TOO HOT�� @���������+�����������������������+���@���������+��������
����'��������������{��*�����������/%��� Q��������~��;������ ��@����������������*������������\�
������*���������K���?���B��������/���� )*�������������������\�����������*�� ����������������%&�
NOISY OPERATION�� +���*��������*�����������*�����������������* �����
���������������������������������������+�������K�������������������������*����� �����������������/��������*����������*����������*=������������
�� #�*�������������������������������*��������!* �����[����"��������*����*"��������������������
WATER LEAKAGE IS SUSPECTED�� :����������������������������=��=��������������������� !����������������������������\�����V��������������&���� !����������~������������������������������*���������� !�����������*�������\��������C������(��=��
�� :x�����=����������*���������� :x�����=������������������ '������=����*�������\��������C������(��=��
NOTE:�:x�����=�����������������������*����**�����������*�������\�������� C������ (��=�� ��������� :x�����=�� �����������*��������� ���*�������������� �� �����*����x�������������������������*���+�������*���:x�����������!�����������+����*���������&���������*�������\��������C������(��=���������������������������������������������*����x���������*�������\��������C������(��=����������������������� ����������������������*���������������=��������*����x�����������������������������=����������������*�������������������*����x�������������*��� �����������������������������������*��REPLACEMENT PARTSC������*���� ������ *��� �� ������� ��*� ���� *���������"�������������=��������������������� ������������������������ ����������=�������*�������������������K����#* ��"�+������#* �������+������#* ����=���� ��������� ����*��������� ��������������������� ������x����������������������C����� �� ���� ������ ����� �������� ����� ���� ������ ������� ��*� ����������� ��� *��� ����*����� �� ����� ���� ������ ������*���� ������������������������* ���������������� �����=����������*��������������������������
FAULT AND ALERT CONDITIONS
FAULT CONDITIONS��������������������*������������V������������������������������V����*������������������������*���;!'����������x���*������·�� *��������� ������ �����*� ����� ���� �� ���� ���� ��� ���������������������������������������������������������������*��� �����=����� ����Z����������=���������� ����������������� ����������
62
FAULT AND ALERT MESSAGES!������������������������������* ���������������� �����=����������������������������������������������Z����������=���������������������
POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ������������������������������*�������������������=���������������
���������� ��������������������������������������������������������=����������������������*��������������������!�C�=�������V����*�������������;!'������������������+��������+�����!����������������/&����������������������������������������������������NOTE:�:�����������*������������Z��������������������������������#'�����������������������������������������������K����[���������������������*��������=����������������� ������������ ���������������������������������������+�������)�������V������V����*�����������*����� ���� CHANGE BACK ADVANCED
AC ReversedFault occurred 2 mins ago
Power supply to water heaterhas reversed polarity.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*�������������������������K����[������� ���������������������������������"���������������������
������K����[�����\����������+�����!����������������/&��� !��������*�������"���������*��������������������������
?�������������*����B�\�����V�����]��������%��� ;������������������������*���������� ;����������������������]/�(���_���(��=���� ]/�(���_���(��=���~�����������������������������\�����V������%�
����V����������������$��� +�����������������"��������=�*��\����������$^��� )�������������~��=����������������������������*������������������\�
����(�������)������������������]]��� ;������*�������������������������K����[�����\�����)�������
+�����Q����������]�
CHANGE BACK ADVANCED
Ignition FailureFault occurred 2 mins ago
The water heater has failed toignite the burner.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������;��_�����������+����������������������
�� ;����������������������;��_�����������+������\����� ����������������������������
�� +�������������������� ����������Z�����*���**���������\������� ���$��������&]��
�� +����������������������������K����+�����(��=���� +����������������������������������������������������������
�����**�������������������������������� ;��=�*��������������\�����+�����_���;����)�������������
�����$^�����������Z���*������������_���+�����+����*���������&/�����+�����_���C��������������&/�
CHANGE BACK ADVANCED
Low Gas PressureFault occurred 2 mins ago
The supply gas pressure to thewater heater is low.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������������?�!��*��B���*�����>��+������)�����������������������*�*�������������������������������������������V�������������������������������������� =�����������**���*���**���Z���*����\���������+�Z�����@��@���������������������*���**����������*����Z���*�����
�� ;����������������������>��+������)�������\�����V�����]��������%�������������������
�� '�*����"������������������>��+������)�������NOTE:�>�����������������������������������������������������������������������������������>��������������������� ��=�������������>������)���*�����*���\�����>������)���*������������/^��)��������������'���������������������������������������������\�����@���������+������������'��������������{��*�����������/%�
CHANGE BACK ADVANCED
Low Igniter CurrentFault occurred 2 mins ago
Igniter current is low.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������[������:x�����+����������������������
�� ����������������������� ������������������x������� �������������\���������������������������\�����V�����^��������&%�
�� ;����������������������[������:x�����+������\����� �����������������������������������
�� C���������~ ������=�����������\�������������������������������� :x�����=���Z�=�����������������"��x�����������*�x�**��* ���
��^����� �������������������������������=����������������*�\�����(�������C�Z���*������������]/�
�� :x�����=����������������������������=���������*���������� :x�����=��������=�������������������������������������
CHANGE BACK ADVANCED
Blocked ExhaustFault occurred 2 mins ago
The exhaust is blocked orrestricted. Ensurecondensate hose is draining.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
63
FAULT AND ALERT MESSAGES (CONT)!������������������������������* ���������������� �����=����������������������������������������������Z����������=���������������������
POSSIBLE CAUSES - CHECK/REPAIR DISPLAYED FAULT/ALERT MESSAGE�� ���������������*������������������[�������=���+������
��������������������������������� ������������� ���������������������������\���������+�Z�����@��@������������������
�� �������~�������[�������=���+�������������\����� �����������������������������������
�� ¦*������������������������[�������=���+������\���*=��{*����������¦*����������*�����=��� �����"���������������������������&�
�� :x�����=����������������������������=���������*���������� :x�����=��������=������������������������������������� CHANGE BACK ADVANCED
Blower Prover FailureFault occurred 2 mins ago
The blower prover switch isclosed out of sequence.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������[�������=���+��������������������*��������������������������������*�������������������!* �����[�����\���������+�Z�����@��@������������������
�� ;����������������������[�������=���+������\����� �����������������������������������
�� [�������=���+������������������� �������������"�������"��������������������"���*���������������\������������������� ��
�� !* �����[����������������������������������� ;����������������������������������!* �����[����� CHANGE BACK ADVANCED
Blower Prover OpenFault occurred 2 mins ago
The blower prover switch remainsopen after the blower has beenenergized.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������[������)����������+����������������������
�� ;����������������������[������)����������+������\����� �����������������������������������
�� :x�����=���Z�=�����������������"��x�����������*�x�**��* �����^����� ������������������������������������������������������*�\�����(�������C�Z���*������������]/�
�� )��������������������������*=��������������������������������������������������������������������������~ ������������� ����\�����V�����&^��������]��
�� [�>�&^^�<�]���*����������������������������������������[������)������������������������������������ �"�����[�>�&^^�<�]���)����������!���������������]$�
�� :x�����=��������=�������������������������������������
CHANGE BACK ADVANCED
Blocked Air IntakeFault occurred 2 mins ago
The combustion air intake isrestricted.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*������������������:!@�?�����������B�+����������������������
�� ����:!@���������������*����������������������������������*������������������=�����x�����=����������*��������������������������������:!@����������������������Q�������*���������� ��?������������B�\����� ���������������������Q������� ���������
�� ;����������������������:!@���������������Q�������*���������� ��\��������������
�� )*�����������������*�����������~���x�����=���������������?�����������B������������*��������\����������������������'�����*�� ����������������%&�
CHANGE BACK ADVANCED
Energy Cut Out (ECO)Fault occurred 2 mins ago
Tank temperature is excessive.The water heater has beendisabled.
Call a service professional:Your Company Name Here(press [DOWN] for more....)
�� ���������������*���������������������=��������*���������������������\����� ����������������������������
�� #���������������������������� ;������������������������������������������������\�����
������������������������������ �������������������������������������� ��������������������������������������\����������+�����
!����������������/&��� ;���������������������� ����������?$~/������ �����B����������������������������
��������������������������������������\��������������������������������������"������������*=��������������������� �����?�B�
CHANGE BACK ADVANCED
No Anode VoltageAlert:
Alert occurred 2 mins ago
No voltage detected fromPowered Anode(s).
Call a service professional:Your Company Name Here(press [DOWN] for more....)
64
MAINTENANCE SCHEDULE
TABLE 14COMPONENT OPERATION INTERVAL REQUIRED
Tank +���*����C�*=�� +�*��������� V������
Tank ;�*��+�����C�*=�� +�*��������� UN-LIME®
�����C�� )���������!������� Annually !�����+�����
Deposits�<��(��=� Test Operation +�*��������� Test
(����+����* )�������� Annually���*�������
+�������!����C�����~C�����
DRAINING AND FLUSHING)��������**���������������������������������������� �������������� ������ �=���� �� *����� �� ������ ����*���� ������ ���������������������� ������������� ������������������������������*���������� +��� V������� ���� !*������� �� ����� %� ����������������������������������*������������� ��� ����
Burn harzard.
Hot water discharge.
Keep hands clear of drainvalve discharge.
To drain the water heater storage tank:&�� �����������������������������������������������]�� ����������������������������K����_���+�����(��=���������
����������������������� �����������������x��������������$�� :�������������������������=��=���������/�� @���������� �����������������������������������������������
����������������������� !�������������������������������������=��=���������*������
�����������Z������������� !������������������������=��=��%�� @���������������������������=��=���������������������������
��������*�������������������� !���� ���� ������ ������� ������ =��=�� ����� ���� ������ ��� ����
������������������������^�� !��������������������������������+����/�&���)����������������������������� �����������������x�������
�����"�����������=��=������� �����������To Flush the tank perform the following steps:&�� �����������������������������������������������]�� :�������������������������=��=���������$�� @���������� ����������� ���������� ���� ���������� ��������
������������������������������������������������������/�� !������ �� ���� �� ���� ������ =��=�� ���� ���*������ ��� �� ���
���Z����������
MAINTENANCEGENERAL
����� ������ ������� ����� ������ ���� ����� ��*� �* ��� ���*��������"��������������������**� ���=�����������Z�����+���;�����������������>�������������&]��������������*����������� ���������������� ������������������������"����� ��*=����� ��*������������������������������� �� ���������� ���� ��{����� �� *�������� ������ �* ������+��� )������� +����� Q�� �� ����� �]���� �������� ���������� �� ����=������������*������ ��*��������������"�������������������*�?�B������ �����������������������*��*��������������**���������
PRECAUTIONS
Do not operate the water heater if it has been exposed to or exhibits the following:
Flooding at or above the level of the burner or controls.External damage.Firing without water.Sooting.
Do not operate the water heater until all corrective stepshave been made by a qualified service agent.
CAUTION
#�=��� ������� ���������� ������������� ����� ����� �������� ��� ��������� ����� ������ ���� �� �������� ������ ���� ������ ��*�������\��������C������(��=�����������������������������=��=��������������� ������ �������� +��� ��*�������\�������� C������ (��=�� �������&��
Explosion Hazard
Overheated water can causewater tank explosion.
Properly sized temperature andpressure relief valve must beinstalled in the opening provided.
+����=�������������������������������������������"�����������K����_���+�����=��=���+���V������]��������$^�
�������������*���������������������������������������������������"�������*=�������*������������������������������� �� ���������� ���� ��{����� �� *�������� ������ �* ������C��������������������� ������������������������������=������������*� ����� �� *����� ������ ���"� ���� ������ ������������*������� ���������������� �� �����*��*���������������**���������
65
TANKCLEANOUTOPENING
CLEANOUTCOVER
CLEANOUTGASKET
CLEANOUTACCESS PANEL
Figure 63
MANUAL LIME SCALE REMOVALNOTE:�!�������������������� ��������������������������*����������* ��������� �����=����������*���������������������������������>�=������������������=���� ��� �������*=����������������=������� ������� ������� ��� ����� ��� V����� �$�� �� ��*=�� ��*��������*�����������������������������������������������&�� �����������������������������������������������]�� �����������������*��� ���������"�����'������������V�������
��������/"���������������������������������������������������
$�� C�*=����������������������������*������������������������������{������
/�� C�*=��������������=�����*������������������ C�*=�� ��*�"� ������ ���~�� ����*���� ����� ����� ��� ��
��*�������������\���������� )��������������������������������Z�����%�� C���������������������=�����[���������������������������
������������������������������� !���������������������������=��=��^�� V���������������������\�����V�����������������>��������������]�&������������������������������������������������������� ����
������������+���)�������+�����Q����������]�&&���������������������������*��������=����������������������
�����������������������������&]��!����������������������&$��C���������������������������������CHEMICAL LIME SCALE REMOVAL�������=��������*=��*����� �����*���������������"�Q#\;)K:¹������������'���*�������� �������Q#\;)K:¹������������'���*����������������������������������� ������ ����� ��*������ ������������ ��� ��*�� ������ ��*=�����*�������������������������Z��*�����>���������� ����������*��� ��� �� ���� �� ����*�� ���� ������ �������� �=����� ��� �����*�����V���� ���� ����������� �� ���� Q#\;)K:¹� �� ����*�� ���� �������������NOTE:� !���� ���� ������ ������*���� ����� �* ��� �� ���� �����=����� �����*����� �������Q#\;)K:¹������������'���*����+�����[;:�&���������������������* ����
��� :����������������������������� ������������������������������������������V���������������*�������������*�������������������������������������������
��� @���������������������������=��=�������������������������%�� V�������������������������������������*=������*��������
����������������������������������������� !���������������������������=��=������������������*�������^�� C�*=����������������&���V���������������������\�����V�����������������>��������������]�&&������������������������������������������������������ ����
������������+���)�������+�����Q����������]�&]���������������������������*��������=����������������������
�����������������������������
FILLING THE WATER HEATER
+���V�����������������>��������������]�
SEDIMENT REMOVAL
����� ���� �*����������������� ���������������� ���� ������������������������������*���������������*���������� ��*������������V�� ��=�������"� ����*���� ��*=��� ���� ��*�� ������ ��*=�������� �������*������������*����*��
LIME SCALE REMOVAL
����������� ���������������=���*�������� ��� ����������������������*� ���� *������*� ��� ����� ?��*�� �����B� ��*�� ������� ���� ��� ���� ������ ��*�������� ������ ������ *�������� ���������������������������������������� �*��� �� ��*�� ������ ��������� ��*� ������ ��� ��� �������������������������*�����������������������������������������*��������������������"�����*�����*�������������������������������������������������������������� ��*�����������*������������ ������*����������������� �����������*�"�������������������������*�����*�������������������������;�*������������������������������������ ������*������ ��������������� ��������>������� ��������� �������� ��*���������������*�� ������ �������� ������ ���������� ���� ����� �� ������� ���������� �������� ;�*�� ������ �������� ���� ���� ����� �* �����������������������������*������������������������*����������������������������;�*�����������*������������������������������������������������V���������������������������������������*��������� ������������ ������ �� ��*�� ���*������ ��� ���� ��*� �� ���� ������������� ����� �� *������� ������������� )������� �� ��*=�������� ������� �=��� ���� �=���� �� *����� ��� ������ '���*����*����������� ����� ����� �� �����*��� ����� �� ���� ��*�� ������������&������?]����*B�����*�������*������������ ��*��������������������+���*����������*����������*=���*��� �����*��������*����������������������������������������������������������"�����V������$��
66
DISCHARGE PIPE
TEMPERATURE-PRESSURERELIEF VALVE
V������/)�� ���� ��*�������\�������� C������ (��=�� �� ���� ������ ������������� �� ����������� �����������"� ����� *��� �� ��� �� ����*����x�������NOTE:�:x�����=�����������������������*����**�����������*�������\�������� C������ (��=�� ��������� :x�����=�� �����������*��������� ���*�������������� �� �����*����x�������������������������*���+�������*���:x�����������!�����������+����*���������&���������*�������\��������C������(��=���������������������������������������������*����x���������*�������\��������C������(��=����������������������� ����������������������*���������������=��������*����x�����������������������������=����������������*�������������������*����x�������������*��� �����������������������������������*��DO NOT PLUG THE TEMPERATURE-PRESSURE RELIEF VALVE OPENING. THIS CAN CAUSE PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.
Explosion Hazard
Temperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.
Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.
Can cause serious injury or death.
VENT SYSTEM
:x�*��������=���������*��������������������������������������������&�� !�������� ������������~�������������������������������
���~��=����������������������������������=�������*���������C��������**����������������������
]�� ���� �� ���� �������� ��� ���� ������� ���� ���� =���� ���*������������� �� ����� �� �������� �� ������� *�������� ���� ����+���V�����]���������]^�NOTE:�'���������������������=�������������������������������������
$�� !���������=���������*�������������������������������������������������������
TABLE 15
UN-LIME® PROFESSIONAL DELIMERPart Number Description9005416105 /�\�&�������?����B9005417105 1 - 5 gallon
POWERED ANODE RODS�� ������ �� ���"� �� ��\����� ��������� ����"� ���� ������ ���������=����� ��� ����� *����� ���� ������� �Z������ ����� �� �����������������*��������������� ?]B������������*����������������� �� ��� ����� ���������� ������ ��*������ )��������� ������������������ �������*��������������
NOTE:�V�������������������������������������������������������� �� ����� �/� ������ C�*=�� ���� ������� ������ ��*� ����������������� ��������������$~/��#��� �������������*��������� �� ���� ������� '� ��� �������* ��� ���� ���������� ��� ������������*�������*�������������������������������������������"������������ ��������� *��� ����� ������� ���� ������ C�*=�� ���� ���������������� ��*����������������������� �� �����������!����� ��������������������������������������������V������������������������������������������������������]��������������
DRAIN VALVE AND ACCESS PANELS�������������������=����� ��� �����*����������Z������������������� =��=�"� ���� V������� ���� !*������� �� ����� %� ����������� ���� ������ �������� �=����� ��� ����� *����� ���� �����Z��������������������������� �������*�������� ��*����������*=����+���V������$�����������
TEMPERATURE-PRESSURE RELIEF VALVE TEST
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
)�� ��� ���**������ ����� ������*�������\��������C������(��=������� �� �������� �� ������ ����� ��� ��� ��� ��������� ���������=������*�������������������������*�������\��������C������(��=���������"�*�������������?&B�������������������������������������������*�������\��������C������(��=������������ ����"�����?]B� ����������������������������������������������������*���"��������������*��� ���x���*��������Q����������������������=��=���������=��=��*��� ������� ������ ���� ������� =��=�"� ����� ���� ��=��� ��� ���� ���� �� ���� =��=����=�������*��"�����V������/������=��=��������������������������������������)��������*��������������������=��=�"�������������*������������������ �������� �� �������� �����"� �**��������� ����� ���� ���������� ������ �� ��������������������������� ����������������"�����'������������ V������� �� ����� �/�� C������� ������*�������\��������C������(��=����������������������~������������"�������*�������\��������C������(��=���������&�������������������������*����
67
DIAGRAMSCCB - CENTRAL CONTROL BOARD LAYOUT
1 Retry
Use Yes
Type Tstat
Spare
ExtInput
3Retries
No
Vent
Spare
OPE
N
1
2 3
4
3
2
1
6
5
4
9
8
7
12
11
10
15
14
13
J6
J7 3 24 1
1
2
J15
84
5
6
7
1
2
3
J13
3
4
1
2
J10
1
3
5
2
4
J1
1
3
4
2
J2
1
4
2 1
2
J3 J5 J4
S1 DIPSWITCH
J16
J9
J11
S1 DIPSWITCH DETAIL
CCB (CENTRAL CONTROL BOARD)
1 Retry
Use Yes
Type Tstat
Spare
ExtInput
3Retries
No
Vent
Spare
OPE
N
1
2 3
4
Dipswitch Operation:Along one side of the dipswitch array there are numbers, 1-4. On the other side of the dipswitchis the word “OPEN.” The dipswitches are rocker type switches, if one side of the rocker is down the other side will be up. Pressing a rocker down on the side of the array labeled “OPEN,” opens the switch.Pressing a rocker down on the side of the array labeled with the numbers 1-4 closes the dipswitch.
CHANGING NUMBER OF IGNITION TRIALS BEFORE LOCK OUT
NOTE: Always turn off power to the water heater before changing dipswitch settings.
Set dipswitch #4 to the open position for 1 trial for ignition before Ignition Failure lock out. Set dipswitch#4 to the closed position for 3 trials for ignition before Ignition Failure lock out.
Figure 65
68
BTH 120 & 150 WIRING DIAGRAM
2 GREEN
WHITE
RED BLACK
1
1
2
BLACK
3
WHITE
COMBUSTIONBLOWER
UPPER TEMPERATURE PROBE
1 RED (ECO)
4 RED (ECO)
2 BLACK3 BLACK
1 BLACK120 VAC HOT
3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC
4 YEL 24 VAC
LOWER TEMPERATURE PROBE
HOT SURFACE IGNITER
FLAME SENSOR
BLOCKED AIR INTAKE
BLOCKED EXHAUST
BLOWER PROVER
24 VAC GAS VALVE
B (C
EN
TR
AL C
ON
TR
OL B
OA
RD
)C
C6J
5J4J
7J51
J
61J
01J
31J
2J3J
1J
TRANSFORMER INSIDE CCBENCLOSURE50VA
GROUND STRIPBURNER GROUND(BURNER BOLT)
ON/OFFSWITCH
GROUND
120 VAC NEUTRAL
120 VAC HOT
LOW GASPRESSURE SWITCH
1 BLACK2 WHITE
RED
1 BLACK
2 BLACK
1 BLACK
2 WHITE
MU
SE
R IN
TER
FAC
E M
OD
ULE
IU
1
21541451067
8
13
11
LN
ANODE 1
ANODE 2
1 GREEN
2 BLUE
2 RED
GREENWHITE
NOIT
CN
UJX
OB
GREEN
NE
ER
G
NE
ER
G
ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG
120 VAC 1 Ø POWER
Figure 66
69
BTH 199 & 250 WIRING DIAGRAM
2 GREEN
WHITE
RED BLACK
1
1
2
BLACK
3
WHITE
COMBUSTIONBLOWER
UPPER TEMPERATURE PROBE
1 RED (ECO)
4 RED (ECO)
2 BLACK3 BLACK
1 BLACK120 VAC HOT
3 WHITE 120 VAC NEUTRAL4 YEL 24 VAC
4 YEL 24 VAC
LOWER TEMPERATURE PROBE
HOT SURFACE IGNITER
FLAME SENSOR
BLOCKED AIR INTAKE
BLOCKED EXHAUST
BLOWER PROVER
24 VAC GAS VALVE
B (C
EN
TR
AL C
ON
TR
OL B
OA
RD
)C
C6J
5J4J
7J51
J
61J
01J
31J
2J3J
1J
TRANSFORMER INSIDE CCBENCLOSURE50VA
GROUND STRIPBURNER GROUND(BURNER BOLT)
ON/OFFSWITCH
GROUND
120 VAC NEUTRAL
120 VAC HOT
LOW GASPRESSURE SWITCH
1 BLACK2 WHITE
RED
1 BLACK
2 BLACK
1 BLACK
2 WHITE
MU
SE
R IN
TER
FAC
E M
OD
ULE
IU
1
21541451067
8
13
11
LN
ANODE 1
ANODE 2
1 GREEN
2 BLUE
1 4 5
3 WHITE/GREEN
7 WHITE/BLUE
8 WHITE/BROWN
2 RED
GREENWHITE
NOIT
CN
UJX
OB
GREEN
NE
ER
G
NE
ER
G
ENABLE/DISABLE CIRCUITJUMPER WIRE BETWEEN PINS8 AND 11 ON J6 PLUG
NOTE: COMBUSTION BLOWERASSEMBLY CONSISTS OF MOTOR, BLOWER AND INTEGRALVFD (variable frequency drive).
120 VAC 1 Ø POWER
PWM (pulse width modulation)SPEED INSTRUCTION SIGNALWIRES FROM CCB TO BLOWERMOTOR VFD (variable frequency drive).
Figure 67
70
CIRCULATION PUMP WIRING DIAGRAMS
Figure 68
Figure 69
CIRCULATING PUMP WIRING DIAGRAMSTORAGE TANK OR BUILDING RECIRCULATION
FIELD SUPPLIED TEMPERATURE CONTROLINSTALLED IN THE STORAGE TANKOR CIRCULATING LOOP RETURN LINE
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWER SUPPLY FOR PUMP CIRCUIT. DO NOT SHARE POWER WITH WATER HEATER AS THIS MAY CAUSE ELECTRICAL LINE NOISE AND LEAD TO ERRATIC CONTROL SYSTEM OPERATION.
CIRCULATING PUMP WIRING DIAGRAMDISHWASHER LOOP WITH TOGGLE SWITCH
FIELD SUPPLIED TEMPERATURECONTROL INSTALLED IN THECIRCULATING LOOP RETURN LINE
DISHWASHERTOGGLESWITCH
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWER SUPPLY FOR PUMP CIRCUIT. DO NOT SHARE POWER WITH WATER HEATER AS THIS MAY CAUSE ELECTRICAL LINE NOISE AND LEAD TO ERRATIC CONTROL SYSTEM OPERATION.
71
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
BU
ILD
ING
RE
CIR
CU
LAT
ION
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
EX
PAN
SIO
NTA
NK
HO
T W
ATE
R O
UTL
ET
PIP
E T
&P
TO
OP
EN
DR
AIN
CO
LDW
ATE
RS
UP
PLY
HO
T W
ATE
RR
ETU
RN
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
72
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
ON
E W
AT
ER
HE
AT
ER
, TW
O T
EM
PE
RA
TU
RE
WIT
H H
IGH
TE
MP
ER
AU
RE
LO
OP
RE
CIR
CU
LAT
ION
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
N
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
E
MIX
ING
VA
LVE
WA
RN
ING
: TH
IS D
RAW
ING
SH
OW
S S
UG
GE
STE
DP
IPIN
G C
ON
FIG
UR
ATIO
N A
ND
OTH
ER
DE
VIC
ES
;C
HE
CK
WIT
H L
OC
AL
CO
DE
S A
ND
OR
DIN
AN
CE
SFO
R A
DD
ITIO
NA
L R
EQ
UIR
EM
EN
TS.
HO
T W
ATE
R
OU
TLET
HO
12” T
O 1
5”M
INIM
UM
T
CO
LD
TEM
PE
RE
DW
ATE
RTO
FIX
TUR
ES
CO
LD W
ATE
RS
UP
PLYTE
MP
ER
ED
WAT
ER
RE
TUR
N
HO
T W
ATE
RR
ETU
RN
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
MIX
ING
VA
LVE
73
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
VE
RT
ICA
L S
TOR
AG
E T
AN
K F
OR
CE
D R
EC
IRC
ULA
TIO
NW
ITH
BU
ILD
ING
RE
CIR
CU
LAT
ION
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
ALT
. CO
LD W
ATE
RC
ON
NE
CTI
ON
PIP
E T
&P
TO
OP
EN
DR
AIN
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
TAN
K T
EM
PE
RA
TUR
EC
ON
TRO
L
NO
TE:
The
wat
er h
eate
r’s O
pera
ting
Set
Poi
nt s
houl
d be
set
5°
high
er th
an th
e Ta
nk T
empe
ratu
re C
ontro
l in
the
auxi
liary
sto
rage
tank
.
AOSSTORAGE TANK
74
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
ON
E W
AT
ER
HE
AT
ER
, SIN
GLE
TE
MP
ER
AT
UR
EW
ITH
HO
RIZ
ON
TA
L S
TO
RA
GE
TA
NK
FO
RC
ED
RE
CIR
CU
LAT
ION
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
N
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
E
MIX
ING
VA
LVE
WA
RN
ING
: TH
IS D
RAW
ING
SH
OW
S S
UG
GE
STE
DP
IPIN
G C
ON
FIG
UR
ATIO
N A
ND
OTH
ER
DE
VIC
ES
;C
HE
CK
WIT
H L
OC
AL
CO
DE
S A
ND
OR
DIN
AN
CE
SFO
R A
DD
ITIO
NA
L R
EQ
UIR
EM
EN
TS.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
ALT
ER
NA
TE T
AN
KTE
MP
ER
ATU
RE
CO
NTR
OL
LOC
ATI
ON
EX
PA
NS
ION
TAN
K
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
TAN
K T
EM
PE
RA
TUR
EC
ON
TRO
L
NO
TE:
The
wat
er h
eate
r’s O
pera
ting
Set
Poi
nt s
houl
d be
set
5°
high
er th
an th
e Ta
nk T
empe
ratu
re C
ontro
l in
the
auxi
liary
sto
rage
tank
.
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
AO
SS
TOR
AG
E T
AN
K
75
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
TW
O W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
TAN
K O
R L
INE
TEM
PER
ATU
RE
CO
NTR
OL
LIN
E T
EM
PE
RA
TUR
EC
ON
TRO
L
76
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
TH
RE
E W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
77
/��
+��
�!�
����
+��
��*
����
����
��*
���:
x���
���
���
����
�&��
���
+��
����
���;
����
!�
����
���
���
����
�/]�
���
)����
�*
����
� ��
�����
����
����
���
����
���
����
����
�����
����
���
�����
���
����
��
�����
����
����
���
���
��
�����
����
���
����
�V��
���
���
����
���%
���
%��
)����
�*
����
� ��
�����
����
����
����
����
����
���
���
��
���
����
����
���
����
����
����
����
�*
*��
����
����
����
�����
�����
���
����
���V
���
����
���V
���
���^
���
����
�%��
WAT
ER P
IPIN
G D
IAG
RA
MS
[��
���
����
����
����
���
����
����
����
��=�
�����
���
���
����
&��
+��
�K�x
����
(��=
���
����
���&
��]�
�+
���'
����
����
���K
����
����
���
����
&��
$��
+��
���*
����
���
\���
���
��C
����
��(��
=��
����
���&
��
FOU
R W
AT
ER
HE
AT
ER
S, S
ING
LE T
EM
PE
RA
TU
RE
WIT
H B
UIL
DIN
G R
EC
IRC
ULA
TIO
NLE
GE
ND
TEM
PE
RAT
UR
E &
PR
ES
SU
RE
RE
LIE
F VA
LVE
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
OU
TLET
HO
T W
ATE
RR
ETU
RN
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
LIN
E TE
MPE
RATU
RECO
NTR
OL
TAN
K O
R L
INE
TE
MP
ER
ATU
RE
CO
NTR
OL
78
LIMITED WARRANTY���@��+*����!�������"�������������"��x������������������;)K)�:'���CC�#�J��������������������������������&��THE TANK)�����������\����������������������������������������=������x�*������� �������������������=������������������������������*���� ����������������"�����������������>C::��������������������������������"����������������������������������*�������������� ���������������������*�������������@��+*��������������������Z�=����������������������*����������������������������+*���=���*�������������������Z��������������������������������������������������)�������=������������������ ������������*�������Z�=������������������������"�����@��+*�����������=������*�����������*����������������������������������"����������������������*�������� ���������������������������������� �����������������������*����������������������������*������Z��������������������������������*���������������������� ����*�������������x���������*������������������������]��ALL OTHER PARTS
)���������@#:���������������������������������������������������"��������������������������=������x�*������� ����������������� ���������=�����*�������������*������"�����������������������������������������������������������������$��!@#')�)@#+��#'�:�!:��)@#+������������������������������������������������������������������������������������������* �������� �����������"������������������������"��������������������������=����������������������������������������)���������"�����*���������������������������=��=�"���������� ��!+����������=��� �������*�������+��������K����������:��������"�*�����=�� ��������������� ����������������������������������������������������������� � ?&B������ ������������������������ � ?]B����������*�������������x������������*�x�**�������������������*������ � ?$B��������������������������x���������������������������������������������� � ?/B�������������������������������*����������������������������������**���� � ?�B������������������������ ��������"��������������������������*����� � ?�B������������\�����=��������\����*���������*�������� � ?%B���������������������=�������?�B������������ � ?�B������������������������������������ � ?^B��������Q������+�����"���������������������������"�����!������� � ?&�B��������������������������������������������Z�������**���������������������� � ?&&B� ����������������������������������� �����������"�������������*=����x����������Z����� ���������������� � ?&]B����������������������������������������������������������������������� � ?&$B�*����������������������������������������������������������*������������������������������������ ���������������������������������"�����*����"�� ���?�����������������B�����������������"�����������������������*��������*"�����������*���
�������������������������=������������������ ��������������������=����������=���������������� ���������=��������=����?������=��=�������B���������������������������������������������������
����������"�����������������=��*���������������������*����x�������������������������������������?�B������������������������*��� � � ������*���������������������������=��=����������������������������not����������� ���*����� /��+:C()!:��#'�C:��)C�:��:#+:+Q�����������*����������������������������������=�����������������*���������������������������������������������������� ���������������������+��������*���������� �����������*�������� ���;� ����������������=������*=��"��������������������������������������������������*������������ ��+�������"�����=���"���������"�������*���������=�����������������������������������������������*�����������*������������������� ���������������
������������*����������=���������������������������� ���� �����������������������������������������*�����������~�����*������Z���������������������������������*�������LIMITATIONS ON IMPLIED WARRANTIES)*����������������"�������������������������*�������� �������*���������������������������������������������������*����������?&B����������������������������������������������+*���������������������*���������������������*��������������������"�������� =����*�������*�������������������!;�)K��C@!:'QC:���� ����*� ����� ���� ��������� ����� �� ���������� ����� ���� ������� ��� ���� ���� ������ ������"� �� ����� ���� ����� ������� ��������� ���� ���������� ��������)��������������������� ��"���������������������� Q�+��!��*��� !��������!��*���� � � � � ���@��+*����!�������� ���@��+*����:�����������;���� � � � � ���������������������������� ���@��[x"�$&��\�%���:����+������ � � � � ��������!���"��#�$%�&�� +��������?@�����B��#�����$� � � � � ����������&\?���B\$]$\]�$�� ����������&\?���B�]��\��]�� ������������������������������������*�����������������������*�������������������������������������������*������������������ ���� ���������������� ��'�������������*���������*����� {��������\���������=��������� �����������%��')+!;�)K:C+#@�@�>:C�:��C:++���CC�#�J�>�+�[::#�@C��);;�[:�K�':�)#�[:>�;V�@V��>:���CC�#�@C��)�>�C:+�:!���@��>:�K:C!>�#��[);)�J�@V���>:��>:��:C��@C��>:�)#+��;;��)@#"�@�:C��)@#"�C:��)C�@C�C:�;�!:K:#��@V��>:����:C��>:��:C���>:���CC�#�@C�+>�;;�#@��[:�C:+�@#+)[;:�V@C����:C�'�K�_:"�;@++�@V�Q+:�@V��>:�Q#)�"�)#!@#(:#):#!:"�;@++�@C�'�K�_:��@��:C+@#�;��C@�:C�J�@C�@�>:C�!@#+:`Q:#�)�;�'�K�_:���>:���CC�#�@C�+>�;;�#@��[:�;)�[;:�[J�()C�Q:�@V��>)+���CC�#�J�@C�@�>:C�)+:�V@C�'�K�_:��@��#J��:C+@#+�@C��C@�:C�J"��>:�>:C�')C:!��@C�)#')C:!�"��#'��>:�>:C��C)+)#_�)#�!@#�C�!��@C��@C��� ���+*������������������������x����������*������������������������������Z���������*���"�������� =����*�����������x�������*����������������� ������������������=�������������������������"�������*���������=��������������������=������*���������������
V����������������������������������������Keep it���C�������������������������������������������*����������������* ���������������������������������������
'����)��������»»»»»»»»»»»»»»»»»»»»»»»»K����#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»+������#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»
'��������#�*� »»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»�����#�»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»
'���������������»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»!��������+����»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»»����!��»»»»»»»»»»»»»»»»
FILL IN WARRANTY AND KEEP FOR FUTURE REFERENCE.
79
�����������������������������������!���"��#�$%�&�
www.hotwater.com