communications receiver vr-500...the vr-500 circuitry includes three modules: (1) the rf unit, (2)...

COMMUNICATIONS RECEIVER

VR-500 Technical Supplement

©2001 VERTEX STANDARD CO., LTD. Printed in Japan.

Introduction This manual provides technical information necessary

for servicing the Yaesu VR-500 Communications Receiver. Information on its installation and operation can be found in the VR-500 Operating Manual, which is provid

ed with the receiver, and Accessory information may be found in the documents accompanying the optional equipment.

The VR-500 is a high-performance miniature communications receiver providing general coverage reception from 100kHz to 1300 MHz on the CW, SSB (LSB and USB), AM, and FM (Wide and Narrow bandwidths) modes (this coverage includes the AM and FM broadcast bands, HF Short-wave Bands up to 16 MHz, VHF and UHF TV bands, the VHF AM aircraft band, and a wide range of commercial and public safety frequencies!) .

Servicing this equipment requires expertise in handling

surface mount chip components. Attempts by unqualified persons to service this equipment may result in permanent damage not covered by warranty. For the major circuit boards, each side of the board is identified by the type of the majority of components installed on that side. In most cases one side has only chip components, and the other has either a mixture of both chip and lead campo-

VERTEX STANDARD CO., LTD. 4-8·8 Nakameguro. Meguro-Ku, Tokyo 153·8644, Japan

VERTEX STANDARD US Headquarters 17210 Edwards Rd . Cerr itos. CA 90703, U S A. International Divis ion 8350 N.W 52nd Terrace, Su11e 201, M1am1, FL 33166, US A

YAESU EUROPE B.V. P 0 . Box 75525, 1118 ZN Sch1phol. The Netherlands

YAESU UK L TO. Unit 12. Sun Valley Bus1ness Park, WiMall Close Winchester, Hampshore, S023 OLB. U K.

YAESU GERMANY GmbH Am Kronberger Hang 2. D-65824 Schwalbach, Germany

VERTEX STANDARD HK LTD. Unot 5, 20/F, Seav1ew Centre, 139·141 H01 Bun Road, Kwun Tong. Kowloon, Hong Kong

0 ~]

nents (trimmers, coils, electrolytic capacitors, packaged ICs, etc.), or lead components only.

While we believe the technical information in this manual is correct, VERTEX STANDARD assumes no liability for damage that may occur as a result of typographical or other errors that may be present. Your cooperation in pointing out any inconsistencies in the technical information would be appreciated. VERTEX STANDARD reserves

the right to make changes in this receiver and the alignment procedures, in the interest of technological improve

ment, without notification of owners.

-------------Contents------------Specifications ........................................................................................................................................ 2

Exploded View & Miscellaneous Parts ............................................................................................ 3

Circuit Description .............................................................................................................................. 5

Alignment .................. .................................................... ............... ..................... .................................... 7

Block Diagram .................................................................................................................................... 14

Board Unit (Schematics, Layouts & Parts) J.1COM Unit .......... .................................... .................................. ........................................................ ............................. 15

AFUnit .......................................... ................................................... .................................................. ...... ....................... 27

RFUnit .................................................................. ............................................ ................. ........................ ............ ......... 37

VCO Unit ............................................. ............... ............ , .................................................... ........................................ ... 53

SW Unit ......................... ...... ............................................................................................................. , .............................. 57

Specifications Frequency Range: USA

Receiving Mode: Antenna Impedance: Channel Step: Operating Temp.: Sensitivity:

Memory Channels:

Supply Voltage:

0.1000 MHz- 1299.9995 MHz (Cellular Blocked) EXP

0.1000 MHz- 29.9995 MHz 50.0000 MHz- 53.9995 MHx 88.0000 MHz- 107.9995 MHz 144.0000 MHz- 147.9995 MHz

430.0000 MHz- 449.9995 MHz 1240.0000 MHz- 1299.9995 MHz

NFM/WFM/ AM/SSB/CW 50 n unbalanced, BNC receptacle 0.05/ 0.1/ 1/5/6.25/9 / 10/ 12.5/ 15/ 20/ 30/ 50/ 100 kHz - 10 oc- +50 oc 0.1- 5 MHz:

5-370 MHz:

AM SSB/ CW AM SSB/ CW NFM WFM

370-520 MHz: SSB / CW NFM WFM

520- 1300 MHz: SSB/CW NFM WFM

1.5 pV (10 dB S/N) 0.6 pV (10 dB S/ N) 1.0 pV (10 dB S/ N) 0.5 pV (10 dB S/ N) 0.5 pV (12dB SINAD) 1.5 pV (12 dB SINAD) 0.5 pV (10 dB S/ N) 0.5 pV (12 dB SINAD) 1.8 pV (12 dB SINAD) 0.8 pV (10 dB S/ N) 1.2 pV (12dB SINAD) 3.0 pV (12 dB SINAD)

Regular Memories: 1000 Channels "Skip" Memories: 100 Channels Search Band Memories: 10 Channels Dual Watch Memories: 10 Channels Priority Memory: 1 Channel 2.2 - 3.5 V DC; Inner Battery (Nominal: 3.0 V DC) 9.0 V DC -16.0 V DC (EXT DC)

Current Consumption: 115 rnA (Receive) 55 rnA (Standby, Saver off) 15 rnA (Standby, Saver on)

AF Output: 90 mW (@Battery) 125 mW (@EXT DC)

Case Size: Weight:

58 x 95 x 30 mm (W x H x D) w I o knob Approx. 220 g w / battery & antenna

Specifica tio11s are subject to change without !lot ice or obi iga tion.

2

~-S800178( LCD PANEL

S8001726 LCD TAPE

S8001725 TAPE

S8100788 CONNECTOR

88100789 POT.

SWUnit

~

------- ~~~~~785 (Lot 1-) SPEA~~~A (Lot 11 -)

S8001 719 RUBBER PACKING

S8001707 KNOB SPRING

S8001713 SQLKNOB

S8001708 RUBBER CONT. VOLUME NUT ACT

\

S8001718

S8001710 FRONTCA (WISP NE~E ASS'Y

Exp loded v· zew & M " tscellaneous Parts

P0091251 CONNECTOR

58001729 REAR CASE

S8001737 RUBBER CUSHION

/.- / ··-~cv_.C~ . / ~

.. _-::·· ~'--n·""' </l (2) .· .

-;.~:.··::~2' dJ - ~

\

S8001715 ~ BATTERY COVER

S8001734 CONTACTC

88001738 RUBBER CUSHION

3

The VR-500 circuitry includes three modules: (1) the RF Unit, (2) the CNTL Unit, and (3) the AF Unit.

The RF Unit is a module consisting of the front-end unit, 1st IF amplifier, 2nd IF amplifier, PLL circuit, and power supply. The AF Unit consists of the 3rd IF amplifier, detector circuit, audio amplifier, and power supply. The CNTL unit includes the CPU, LCD, LCD driver, and EEPROM.

RF Unit Incoming RF signal from the antenna jack is fed through the A TT circuit to a diode switch, then to one of the nine band-pass filters and RF amplifiers selected by the receive

frequency data from the microprocessor.

c·_ Fre®ency Range RF a~Jiier Banet·· 0.10000- 1.99995 MHz 0508 (2SC5006)

~~r; 2.00000 - 49.99995 MHZ 0513 (2SC4215Y)

:: q~J ,~, 50.00000 - 109.99995 MHz 0508 (2SC5006)

'Eiji til(,.. 110.00000- 159.99995 MHz 0518 (2SC5006)

·Bii iid;B; 160.00000- 259.99995 MHz 0517 (2SC5006)

260.00000 - 369.99995 MHz 0523 (2SC5006)

Band~7- 370.00000 - 469.99995 MHz 0520 (2SC5006)

BandS 470.00000 - 779.99995 MHz 0524 (2SC501 0) SllJI(t; 780.00000- 1299.99995 MHZ 0526 (uPC2748T)

The amplified RF signal is delivered to the 1st IF mixer Q528 (J.1PC2757T) along with the 1st local signal from the PLL circuit, which prod uces the 248.45 MHz or 429.15 MHz 1st IF signal.

The 248.45 MHz 1st IF signal is fed through the roofing filter, F502 (LSF819-248-220KO), to the 1st IF amplifier Q532 (2SC5006). In the case of the 429.15 MHz 1st IF, the signal is fed through filter F501 (LSFB19-429-800KO) to IF amplifier Q530 (2SC5006).

The filtered and amplified 1st IF signal is delivered to the 2nd IF mixer Q534 (3SK318) along with the 2nd local signal from the PLL circuit, which produces the 10.7 MHz

2nd IF signal. The 10.7 MHz 2nd IF signal is fed through ceramic filter F503 (SFECV10.7MA5-Z) and 2nd IF amplifier Q535 (2SC4215Y) to the IF subsys tem IC Q302 (TA31136FN) on the AF Unit, which contains the 3rd IF

mixer, 3rd local signal oscillator, and FM detector.

The 1st local VCO Q705 (2SC5010) and Q711 (2SC5006) oscillates between 371.55 and 880.90 MHz according to the programmed receiving frequency. The 1st local signal is fed through buffer amplifiers Q702 and Q709 (both J.IPA811T) to the 1st IF mixer Q528. The 2nd local VCO Q537 (2SC5006) oscillates at 237.75

MHz or 259.15 MHz, according to the programmed receivin g frequency. The 2nd local signal is fed through

Circuit Description buffer amplifier Q536 (2SC5006) to the 2nd IF mixer Q534.

PLL IC Q541 (M815F02PFV) consists of a data shift register, reference frequency divider, phase comparator, and charge pump. Serial PLL data from the microprocessor is converted into parallel data by the shift register in the PLL IC and latched into the comparative frequency divider and reference frequency divider to set a frequency dividing ratio for each. A 15.2 MHz reference signal produced by X501 and Q542 (2SC4617) is delivered to the PLL IC. The

internal reference frequency divider divides the 15.2 MHz reference by 3040 (or 2432) to obtain a reference frequency of 5kHz (or 6.25 kHz), which is applied to the phase compara tor for the 1st local PLL loop. Meanwhile, the internal reference frequency divider divides the 15.2 MHz reference by 1520 (or 1216) to obtain a reference frequency of 10kHz (or 12.5 kHz), which is applied to the phase comparator for the 2nd local PLL loop.

AF Unit The 10.7 MHz 2nd IF signal from the RF Unit is delivered to the 3rd IF mixer section in the IF subsystem IC Q302 along with the reference signal generated by 10.245 MHz crystal X301, which results in the 455kHz 3rd IF signal.

If the signal is a (455 kHz) NFM s ignal, it is fed through ceramic filter F302 (KBF-455RS-15A), to strip away any unwanted mixer products, and is then applied to the dis

criminator in the IF subsystemIC Q302, which produces the demodulated audio.

In the case of a 455kHz WFM signal, it is applied directly to the discriminator in the IF subsystem IC Q302, which produce the demodulated audio.

For AM signals, the IF energy is fed through ceramic filter F302 (KBF-455RS-15A), and is then applied to the 3rd IF amplifier Q343, Q31 1 and Q314 (all 2SC4617R). The amplified 455kHz AM signal is delivered to the AM detector Q315 (MA729), which produces the demodulated audio.

SSB/ CW signals are fed through ceramic filter F301 (KBF-455RS-4AS), then applied to the 3rd IF amplifier Q343, Q311 and Q314 (all 2SC4617R). The amplified 455kHz

SSB/ CW signal is delivered to the ring demodulator Q319 and Q320 (both MA729) along with the 456.5 kHz (LSB/ CW) or 453.5 kHz (USB) BFO local, generated by ceramic oscillator X302 and Q317 (2SC4617R), thus producing the demodulated audio.

The demodulated audio is fed through analog switch Q323 (8U40948CFV) to the audio pre-amplifier Q333 (UMX2N).

5

Circuit Description The amplified audio signal is fed through audio volume potentiometer RISI on the CNTL Unit to the AF amplifier Q336 (2SA1588Y), and the amplified audio signal is ultimately fed through the EAR jack to the internal speaker or an external earphone.

6

Required Test Equipment The following test equipment (and thorough familiarity with its correct use) is necessary for complete realignment. Correction of problems caused by misalignment resulting from use of improper test equipment is not covered under the warranty policy. While most steps do notre

quire all of the equipment listed, the interactions of some adjustments may require that more complex adjustments

be performed afterwards. Do not attempt to perform only a single step unless it is clearly isolated electrically from all other steps. Have all test equipment ready before beginning, and follow all of the steps in a section in the or

der presented.

1. RF Signal Generator with calibrated output level at 1300 MHz

2. Deviation Meter (linear detector) 3. AF Millivoltmeter 4. SINAD Meter 5. Regulated DC Power Supply adjustable from 3 to 15

DC, 1A 6. Frequency Counter: >0.1 ppm accuracy at 1300 MHz

7. AF Signal Generator 8. DC Voltmeter: high impedance 9. DC Ammeter 10. 8 n AF Dummy Load

11. Spectrum Analyzer

Alignment Preparation & Precautions Correct alignment requires that the ambient temperature

be the same as that of the receiver and test equipment, and that this temperature be held constant between 20°

and 30° C (68°- 86° F). When the receiver is brought into the shop from hot or cold air it should be allowed some time for thermal equalization with the environment before alignment. If possible, alignments should be made

with oscillator shields and circuit boards firmly affixed in place. Also, the test equipment must be thoroughly warmed up before beginning.

Note: Signa/levels in dB referred to in this procedure are based on 0 dB11 = 0.5 ftV( closed circuit).

Alignment Test Setup Set up the test equipment as shown below for receiver alignment.

RF Signal Frequency Generator Counter

1°1m a ...- AF Dummy Load

TDJ~ e SINAD Meter

I ~(§'§~ 9·s·<G>~ sss® 1...---

Regulated 13.8 V PSU

1st Local Frequency 0 Set the VR-500 to 100.050 MHz, NFM mode. 0 Connect the RF probe of the Frequency Counter to TP3,

and adjust C620 for a reading 529.15 MHz (±200Hz) on the Frequency Counter.

3rd Local Frequency 0 Set the VR-500 to 100.000 MHz, LSB mode. 0 Insert the RF probe of the Spectrum Analyzer into the

nest at the left side of the chassis, as shown below.

0 Adjust R303 for a reading 10.2465 MHz (±100 Hz) on

the Spectrum Analyzer.

BF01 0 Set the VR-500 to 10.050 MHz, LSB mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Inject a 100.050 MHz 10 dBp signal from the RF Signal

Generator, and adjust R358 to the point where the AF

output level is minimized.

BF02 0 Set the VR-500 to 10.050 MHz, USB mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Inject a 100.050 MHz, 10 dBp signal from the RF Signal

Generator, and adjust R357 to the point where the AF

output level is minimized.

7

A lignment

8

TP1

R303

TP2

R357

TP5

C620

TP4

L306

TP3

TP6 R358

AF NFM Detector Coil 0 Set the VR-500 to 100.050 MHz, NFM mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Inject a 100.050 MHz, 60 dBp (1kHz tone@ ±3.5 kHz

deviation) signal from the RF Signal Generator, and adjust 1306 to the point where the AF output signal has minimum distortion.

RF Voltage 0 Connect the DC voltmeter to TPl, and confirm a DC

voltmeter reading of 2.9 - 3.2 V. 0 Connect the DC voltmeter to TP2, and confirm a DC

voltmeter reading of 2.7- 3.0 V. 0 Connect the DC voltmeter to TP6, and confirm a DC

voltmeter reading of 9.7- 10.7 V.

1st VCO VCV 0 Connect the DC voltmeter to TP4, and referring to ta

ble below, tune the VR-500 to each frequency listed. Then confirm that the correct voltage is present.

620.000~ e~ 1.4-2.3V

668.350 MHz 2.5-4.2 v 668.450 MHz 0.8- 1.6 v 778.350 MHz 3.0 - 5.0 v 778.450 MHz 0.6- 1.3 v 280.800 MHz 6.4- 7.0 v 280.900 MHz 0.7 - 1.4 v 1299.500 MHz 3.2-3.9 v

Idle Current 0 Connect the 3.0 VDC power source, via the DC amme

ter, to the battery terminal (not the EXT DC jack) on the VR-500.

0 Set the SQL knob fully clockwise, and set the radio to the NFM mode.

0 Disable the Battery Saver via MENU #5 (Save). 0 Referring to table below, tune the VR-500 to each fre

quency listed, then confirm that the correct Idle Current is present.

~:. ·.;:-i .;1;·:,,;"),~:"-_F..:.T~f~~it.O::~ •• ~"' ·' , - f 1o.,. '•' I "'

1.050 MHz less than 60 mA


100.050 MHz less than 60 mA 150.050 MHz less than 60 mA


300.050 MHz less than 60 mA 400.050 MHz less than 60 mA



Alignment 2nd VCO VCV 0 Connect the DC voltmeter to TPS, and referring to ta

ble below, tune the VR-500 to each frequency listed . Then confirm that the correct voltage is present.

~l;"l.:t\luen¢.1~ l~tcVGV'• lt.;

320.000 MHz 0.7-1.4V

1000.000 MHz 1.4-2.1V

Sensitivity 0 0 0

Connect the RFSignal Generator to the Antenna jack. Set the VR-500 to NFM mode. Referring to table below, tune the RF Signal Generator and VR-500 to each frequency listed, then confirm that at least12 dB SIN AD is observed at the lev-el shown.

0 Set the VR-500 to WFM mode. 0 Referring to the table below, tune the RF Signal Gen

erator and VR-500 to each frequency listed, then confirm that at least12 dB SINAD is observed at the lev

el shown.

~"""' IEii!f!)· ~a>t:!I'-!Jt.n ·i·.•j

107.950 MHz Better than +BdBu

224.950 MHz Better than +9dBu 459.950 MHz Better than +12dBu

619.950 MHz Better than +15dBu



9

Alignment 0 Set the VR-500 to the AM mode. 0 Referring to the table below, tune the RF Signal

Generator and VR-500 to each frequency listed, then confirm at leastlO dB S/N is observed at the frequency shown.

F.requency 10.dB SJN









0 Set the VR-500 to the LSB mode.

0 Referring to table below, tune the RF Signal Generator and VR-500 to each frequency listed, then confirm that at leastlO dB S/N is observed.

F.reguency 10 dB SIN


28.950 MHz Better than -2d Bu

0 Set the VR-500 to the USB mode. 0 Referring to table below, tune the RF Signal Genera

tor and VR-500 to each frequency listed, then confirm that at leastlO dB S/N is observed.

,Jfrequeooy 10 dB S/N . 2.050 MHz Better than +6dBu

28.950 MHz Better than -2dBu

0 Set the VR-500 to the CW mode. 0 Referring to table below, tune the RF Signal Genera

tor and VR-500 to each frequency listed, then confirm that at leastlO dB S/N is observed.

~FregUe{lcy 10 dB SIN


28.950 MHz Better than -2dBu

S-meter & Squelch Presetting (used in steps to follow) 0 Disable the ATT function, if activated. 0 Disable the Battery Saver, OFF Timer, and RF Squelch

via MENU #5 (Save), MENU #6 (OFF Timer), and MENU

#19 (RF Squelch) respectively, if these functions are activated.

0 Set MENU# 1 (Receive Mode) to "MANUAL."

0 Set these frequencies into the PMS memories: Low band edge frequency (l:L): 1250.3750 MHz Start Frequency (2:S): 123.1250 MHz High Band edge Frequency (3:U): 448.2500 MHz

0 Presetting is now completed; the "Battery" icon will blink.

10

NFM S-meter 0 Preset the VR-500 via the previous steps. 0 Set the VR-500 to 100.050 MHz, NFM mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [9] key while pressing the [FUNC] key to ac-

tivate the S-meter adjustment process ("S Meter Set" will appear).

0 Inject a 100.050 MHz, 20 dBp (1kHz tone@ ±3.5 kHz deviation) signal from the RF Signal Generator. Press the [1] key while pressing the [FUNC] key, then press the [B.S] key until the beep is heard; this saves the new

setting. This routine is the S-meter "Full-Scale" adjustment.

0 Reduce the RF Signal Generator output level to -1 dBp.

Press the [2] key while pressing the [FUNC] key, and then press the [B.S] key until the beep is heard; this saves the new setting. This routine is the S-meter "S-

2" adjustment. 0 Press the [CLR] key to return to normal operation. 0 Increase the RF Signal Generator output level so that

the VR-500 S-meter deflection is "Full-Scale," and confirm that the RF Signal Generator output level is 20 dBp ±4 dB.

0 Reduce the RF Signal Generator output level so that the VR-500 S-meter deflection is just "S-2," and confirm that the RF Signal Generator output level is - 1 dBp ±4 dB.

WFMS-meter 0 Preset the VR-500 via the procedure described above. 0 Set the VR-500 to 100.050 MHz, WFM mode.

0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [9] key while pressing the [FUNC] key to ac-


0 Inject a 100.050 MHz, 40 dBp (1kHz tone@ ±75kHz deviation) signal from the RF Signal Generator. Press the [1] key while p ressing the [FUNC] key, and then press the [B.S] key until the beep is heard; this saves the new setting. This routine is the S-meter "Full-Scale"

adjustment. 0 Reduce the RF Signal Generator output level to 10 dBp.

Press the [2] key while pressing the [FUNC] key, then press the [B.S] key. This routine is the S-meter "S-2"

adjustment. 0 Press the [CLR] key to return to normal operation. 0 Increase the RF Signal Generator output level so that

the VR-500 S-meter deflection is "Full-Scale," and confirm that the RF Signal Generator output level is 40

dBp ±4 dB.

0 Reduce the RF Signal Generator output level so that the VR-500 S-meter deflection is just "S-2," and confirm that the RF Signal Generator output level is 10

dBJ.l ±4 dB.

AM S-meter 0 Preset the VR-500 per the procedure described previ-

ously. 0 Set the VR-500 to 1.050 MHz, AM mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [9] key while pressing the [FUNC] key to ac-


0 Inject a 1.050 MHz, 25 dBp (1 kHz tone@ 30% modulation) signal from the RF Signal Generator. Press the [1] key while pressing the [FUNC] key, and then press the [B.S] key until the beep is heard; this saves the new setting. This routine is the S-meter "Full-Scale" adjustment.

0 Reduce the RF Signal Generator output level to -2 dBJ.l; press the [2] key while pressing the [FUNC] key, then press the [B.S] key. This routine is the S-meter "S-2" adjustment.

0 Press the [CLR] key to return to normal operation. 0 Increase the RF Signal Generator output level so that

the VR-500 S-meter deflection is "Full-Scale," and confirm that the RF Signal Generator output level is 25

daJ.l ±4 dB. 0 Reduce the RF Signal Generator output level so that

the VR-500 S-meter deflection is just "S-2," and confirm that the RF Signal Generator output level is - 2

dBJ.l ±4 dB.

SSB S-meter 0 Preset the VR-500 using the procedure described pre-

viously. 0 Set the VR-500 to 10.050 MHz, LSB mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Press the (9] key while pressing the [FUNC] key to ac-

tivate the 5-meter adjustment process ("S Meter Set" will appear).

0 Inject a 10.050 MHz, 30 dBJ.l signal from the RF Signal Generator. Press the [1) key while pressing the [FUNC] key, and then press the [B.S] key to until the beep is

heard; this saves the new setting. This routine is the Smeter "Full-Scale" adjustment.

0 Reduce the RFSignal Generator output level to -2 dBJ.l, then press the [2] key while pressing the [FUNC] key. This routine is the S-meter "S-2" adjustment.

0 Press the [CLR) key to return to normal operation.

Alignment 0 Increase the RF Signal Generator output level so that

the VR-500 S-meter deflection is "Full-Scale," and confirm that the RF Signal Generator output level is 30 dBJ.l ±4 dB.

0 Reduce the RF Signal Generator output level so that the VR-500 S-meter deflection is just "S-2," and confirm that the RF Signal Generator output level is -2 dBp ±4 dB.

NFM Squelch 0 Preset the VR-500 using the procedu re described p re-

viously. 0 Set the VR-500 to 100.050 MHz, NFM mode.

0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [8] key while pressing the [FUNC] key to ac-

tivate the S-meter adjustment process ("Squelch Set" will appear).

0 Inject a 100.050 MHz, 0 dBp (1 kHz tone@ ±3.5 kHz deviation) signal from the RF Signal Generator. Press the [2] key while pressing the [FUNC] key, and then press the [B.S) key; this routine is the Squelch "Tight" adjustment.

0 Reduce the RF Signal Generator output level to -15 dBJ.l. Press the [1] key while pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "threshold" adjustment.

0 Press the [3] key while pressing the [FUNC] key, then press [BS] key until the beep is heard; this saves the new Squelch setting.

0 Press the [CLR] key to return to normal operation. 0 Turn off the RF Signal Generator and set the SQL knob

so that the background noise is just silenced. 0 Turn on the RF Signal Generator and increase the RF

Signal Generator output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is - 15 dBp ±4 dB.

0 Set the SQL knob fully clockwise, then increase the RF Signal Generator output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is 0 dBp ±4 dB.

WFMSquelch 0 Preset the VR-500 using the procedure described pre-

viously. 0 Set the VR-500 to 100.050 MHz, WFM mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [8] key while pressing the [FUNC] key to ac-

tivate the S-meter adjustment process ("Squelch Set"will appear).

0 Inject a 100.050 MHz, 20 dBp (1 kHz tone@ ±3.5 kHz

11

Alignment d evia tion) signal from the RF Signal Genera tor. Press the [2] key w hile pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "Tight" adjustment.

0 Reduce the RFSignal Generator output level to - 3 dBp. Press the [1] key while pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "Threshold" adjustment.

0 Press the [3] key while pressing the [FUNC] key, then press the [BS] key untilthe beep is heard; this saves the new Squelch setting.

0 Press the [CLR] key to return to normal operation. 0 Turn off the RF Signa l Generator and set the SQL knob

so that the background noise is just silenced. 0 Turn on the RF Signal Generator and increase the RF

Signal Generator output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Gen

era tor output level is 20 dBp ±4 dB. 0 Set the SQL knob fully clockwise, then increase the RF

Signal Generator ou tpu t level so that the VR-500 Squelch is just opened; confirm that the RF Signal Genera tor output level is -3 dBp ±4 dB.

AM Squelch 0 Preset the VR-500 per the procedure described previ-

ously. 0 Set the VR-500 to 1.050 MHz, AM mode. 0 Connect the RF Signa l Generator to the Antenna jack. 0 Press the [8] key while pressing the [FUNC] key to ac-

tivate the S-meter adjustment process ("Squelch Set" will appear).

0 Inject a 1.050 MHz, 0 dBp (1 kHz tone@ 30% modula

tion) signal from the RF Signal Generator. Press the [2] key v.rhile pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "Tight" adjustment.

0 Reduce the RF Signal Generator output level to -15 dBp. Press the [1] key while pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "Threshold" ad justment.


0 Press the [CLRj key to return to normal operation.

0 Turn off the RF Signal Generator and set the SQL knob so that the background noise is just silenced.

0 Turn on the RF Signal Generator and increase the RF Signal Generator ou tput level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is 0 dBp ±4 dB.

12

0 Set the SQL knob fully clockwise, then increase the RF Signal Generator output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is - 15 dBp ±4 dB.

LSB Squelch 0 Preset the VR-500 per the procedure described previ-

ously. 0 Set the VR-500 to 10.050 MHz, LSB mode. 0 Connect the RF Signal Generator to the Antenna jack. 0 Press the [8] key while pressing the [FUNC] key to ac-

tiva te the S-meter adjustment process ("Squelch Set" will appear).

0 Inject a 10.050 MHz, - 1 dBp signal from the RF Signal Generator. Press the [2] key while pressing the [FUNC] key, and then press the [B.S] key; this routine is the Squelch "Tight" adjustment.

0 Reduce the RF Signal Generator output level to -14 dBp. Press the [1] key while pressing the [FUNC] key,

and then press the [B.S] key; this routine is the Squelch "Threshold" adjustment.


0 Press the [CLR] key to return to normal operation. 0 Turn off the RF Signal Generator and set the SQL knob

so that the background noise is jus t silenced.

0 Turn on the RF Signa l Generator and increase the RF Signa l Genera tor output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is -1 dBp ±4 dB.

0 Set the SQL knob fully clockwise, then increase the RF Signal Genera tor output level so that the VR-500 Squelch is just opened; confirm that the RF Signal Generator output level is - 14 dBp ±4 dB.

AF Output 0 Connect the RF Signal Generator to the Antenna jack,

and connect the DC volt meter and 8 n dummy load to the SP jack.

0 Connect the 13.8 VDC power source to the EXT DC jack.

0 Set the VR-500 to 100.050 MHz NFM mode, and rotate the VOL knob fully clockwise.

0 Inject a 60 dBp from the RF Signal Generator; confirm that the DC voltmeter reading is more than 1.10V (150 mW with 8 n load).

0 Disconnect the 13.8 VDC power source from the EXT DC jack, then connect the 3.0 VDC power source to the Battery terminal; confirm that the DC voltmeter

reading is more than 0.85 V (90 mW with 8 Q load).

0 Repeat the above steps in the WFM, AM, LSB, USB, and CW modes, and confirm that the AF output level is more than 150 mW@ 13.8 VDC and 90 mW@ 3.0

VDC.

AIT 0 Set the VR-500 to 100.050 MHz, NFM mode. 0 Connect the RF Signal Generator to the Antenna jack.

0 Inject a 100.050 MHz, NFM signal from the RF Signal

Generator; confirm that the 12 dB SINAD difference between the A TT "ON" and "OFF" conditions is 15-25 dB.

Alignment

13

...lo.

~

YR I~A

SAC lii!-11 chu

g

91TA

ucot1 l\.OCK

""'

If

IOV

510V

3V

YRIH

l'i100T 5I'!(

3V

r#EI.OCK

Jr

IIAITI:RT

2.2Y .. J.5V

l.s. SP JACk

11"0 2

11"0 511

m11.oc Sl'

le 1 I ,o.ssu

IQV DOC

00 DC REG

H.J'telliOA

S-ill23DSOf1C-D£- 12 bfCI .. 4Lt DTA144£(

rn DC Jno:

9.0V-lliY

510

RI~RI03 1 A S- Bil3CI~

l V

~ -0 (}

f:\'l t::) N .

~

~ ~

~

Circuit Diagrnm rtCOM Unit (Lot - 10)

>>>>>>>>>>>>>>>>>>>> > ';' r; ~ ~ :ri ;r, := ? ~ ~ ~ ~ ;' ~ :;; ~ ~ ~ ~ :: ~ > - .- N 0 - M "l Ill Ill Lll - • J .- -t N C"• - .- - - - 0

ST~ on1 '-p.!J 'l)®f'ci!..IU+-1--+-+-+--l-

Lsoc.. j<Y ..-.®P"IBF=+02--t-1-f-f-J 1 ov >@!' ~~ Nwt.J..Il<"T+-t-!-+-1h

Y--+-t-r-.1Wll."""-ti"'Gl• 31'1 ~<=.L~~T+-'H--rt-tVllntiT :~ (j~

V11IN iffi@tL .,IIIO!........_n--+-+-L._ _ ___,VI>Ullijr.QJ, I • TT

·~~~ ~ ~~nP l ~~~~++n l'i' ~ STER~S

I"' r+---'GN"-'D"-1•@@1" .a.IP"'-s _ _ _,

r.~n lonoro

I

R140

> > > > > > > > > > > > > > M 0 0 0 0 0 0 0 0 0 0 0 0 ~ o o ~ o ~ rn m m rn h ~ ~ h m > > > > > > > > N N ~ N N N ~ N N - - - - N 0 0 0 0 0 0 0 0

rh

I

Ill uooc,ruw-,

~ ~ ~ ~I:

H I 0

Rl54

11 oot.:"1~

rn ~ !!

}~I ~f~l ~ ~· ;;:~

....--- ~ i ~ i N

tD lnV" f"'1N - O ~ i) ~a:a:a:a: a:

~ ~:§~ '--l----3-0v~ LCDRESET

'--!---~ LCDCS

'---t---0v~ LCDRS

'---- -t---{0) LCDSCL

N

~ § "' U1 '<' ::::J > > 0 0

3 ov

,;~ -x

"!!! ~ 2 5\/

2 57V Rl11 0 07V R O ' "1 "") IJjj,,., • m ':Ill: 0 04GV

~~· ~ :! ~~":

"'~ rf

0 0~1!·~~ ~ ~ I I

~~ I ,n,~~-I I N ~ r;;

0

u U1 0 .... Ul ~

a.

E;

0 ... co

fl ~ ~ .. -

E; ;,;

N M LAHPK 0 "' .... "' co ' ~ ! FUNK

HONI 30V ~

ATT ov

STBRFS ov

PS ov

3 0V IKil Rl20 KY03

3 0V KY02

3 ov

] 1lliiz

FUNC L........---J-t~+-1-1

SI<O<:AB I m

,rr-wR ~

B. S _..., CL

SQLOFF ,s.w..

C IOI~C I 32

RI O I~RI70 L1 O I ~LI 03 OIO I ~OI27 S!OI ~SI03 XIO I~XI02 EIOI JIOI JPI 01 ~JP I 02

BLANK Cl l7,RIO I ,Ril7 Rl36 ,R l45 ,Rl 53 Cl l6,C l 06, Rl 08, Rl 09

PCB BLANK Rl 09,RIOB, R165 , Rill 0124,0123,Rl62 , Rl57 Rl60,Rl56 ,Rl58 ,RI63 C127 ,C129,R159,RI40

n LCDSDA

,J1 :::h cl.;; I '--~-u-t-~-u-t-<>-tbwl< l'-t-' ,t' OV or 3 OV

r---r-r--~'---r~~r--~~SHI H--+-+-----..._-tw.t-~>?--1. riHSHZ

KYO ! KYOO ~3~o~v ----l~-------1~-t~~~~M~i~2---------+-t-~

OV ffil RIIB ClOS ;tJo/ OV

Ir-- zr-- 3r-- 0 ~-

BUSY 3 ov or ov ~ " ~~ 9 0 HCK ov

"' ~ RJ4& 0. 001 RI 4J IRil 3 ov

--- IK 3 ov

0 2V-J OV

0101

lllli43lSJ7X I~ Rl l~ lOCK 30vm r-rr-r--r-1

ROHSDA ov ~ll' lK t---1 ov l m ROMSCL ov

OV IK r-Lt1 ;::: li; ). ,!, /ROMV 3 0V LUI.. ~G'~~ ~~ QI O~ ~ ~ I

_ 1 l DT~ ~~II ::: (_ X241 2BSl<H.5

4_c_~- sr~- sr~- ~-

7r~- s r~- g~~-ENT

~-

l HINi lol~ 'P>Pl HI NI I~ ~:::: ~@t"CKt.l:ll---,

SOLVR 1 c>--LX..~:: u ~ ,f,

~-t-t-+-+--l----t--'-'-'-----'-'------+-+"""~01 RSSI MTX;v I mu:V Rll2 R)l~ ;.r, ;.r, ;r, ;r, ;r, ;r, ;r, , : :: "" . , ""'" .,.. ... ... , " ~m-·

i~Ol ~~5±~ ~

a si

+D

30V

I

1 0V

2 4V

,..5EKli:;.:: ~ --l yp1i!02,1 li001Ji! I IV .c::;li,~-

~J DrrJP-cl>--01-++-H---'hl ,-~a ~.;:L &wE JPto2 ~

Typ•l02S:ll00012 ~ !=!!!_,0.)

~ ~ ·;l~ ';3

J;"" "'J!

m;; ov T~MP ;;, !:.';! ::::J ~ "' ov lK I ~u n~ ov Ql05 r :: ?; ?; 6 l;:! I= :S 0 ~ :1i iE 6 6 TONEW C)-~ _ rh ov ,.J., 0 6 6 l"l ..... :> U l/l ....J U1 ..... M M 3.)!.':! (i • > 0V J QV .- QV

x1o1 ' ~ · l~~·~ tr'~::t ' E;l ~ E;T E; ~T ~ ~ ~ ,1: • " " ~ ~~;),"'"'" ~~

n.ml<lh ~Df ~ ~Df- ~,),· ~L ~ :J L -;., ·~ ;: !:~-f~-:l; ~:b,-ffu OV - ::; n....._+-+---J--j-------j---- ----j---j-----' Ururh Um ... U-:num ~ r-- :: ~·

.... M.+---+-+-~F~ ~ ~ ~~ ~ ~'-11---1--+-------t----------+--t----' ~~---::'Rl":icS:~--......1 :J_.= i;;l+-+---'+--1r 0102 ,.,_ :.:: !;::'---r--r----t--- - -----+-t----' tfv 0=-- Ql27

CHAR}-GE-+---1--+--~-i l ~ ;_ "o ~ Cl25

L+--+----~m------~-------------J------------------------~------------------~----------t-~~-=-_,~3~0V~----~-+---~~ --~~O.O~

ifr"• RNS\0\.20M :.:: '------'2~9~7V'-._~0VWOdJ:F!:J.F\~Ry.;l2~2 _,.O!!JB~1V!.f-T{'I....) ¥~d~~9<CLI . ~ m __Qj_Ol_ 1

l.s• '-"~ L++----+--------.!!..!...--''.!.f._-+_ !..!.!_ ____ __J I r-t--L-f-1.4 .,..,1+-h ~ : ~; 16V

L---j--J-----+------------ -1------ -----' 1.---I:R""'to,--< +---,-..J ,,4

av I II I 4Hk ~ . J, ;:::: r. rl

470K

Rli~

15

Parts Layout

c""~"'''

Anode 1 Anode 2

155382 (A1) (Q103)

pCOM Unit (Lot -10)

Side A

17

pCOM Unit (Lot - 10)

"' [ill

§ [TI~

IR1291 ~

rn]~ {gt~

w ~Gd~ ~~~ [i] IR124I IR1221

§

18

~~~ IR1sol IR165I

0 :;:; [gJ i!] a:

IR143I lc12ol IR14el

~

~ co ~ £

Pin 1

00.. . ~ P,o60

P1n 20 ' Pm 41

~~ - ~ c c ii: ii:

HD6433637A14X (USA:Lot 1-) HD6473637X(R0352)(USA:Lot 3-) HD6433637 A 13X (81, 82) (Q101)

0101

NC NC

Gn OUT Vdd GNO

RN5VL20AA (80) (Q102)

~ -M-

~ ID-* ffi -* -M-

~

~~ ~liD~ 1g1o~l

ID ~ rm

0 .,_,o rr-r-r-r-r-'T"T"T"T""'T"

Side B

v .. NC s Pin~~ 'Pin 7

......... Pm 1 OUT Vdd

S-8081 BALNP (EAF) X2412BS141 (Q105) (Q109)

Emitter Common Collector Base 1 I Base 2 Collector

~ Collector Cathode 1 Cathode 2

~ ~ ~ k Base t Emitter

Collector 1 Collector 2 Base Emitter Collector Base Em1tter Anode 1 Anode 2

UMG2N (G2) DTA144EE (16) 280 999 (CL) DTC114TE (04) 1SS382 (A1) (Q104) (Q1 0B, 113) (Q1 14, 120, 126) (Q127) (Q106, 107, 110, 111)

Circuit Diagram

Rl<O ~ !!1

IOC(_

:~ ~ ~ .. ' r-~

1.0

1l'y~ ~

(

~~ H

~Iii ~

rt-+-Hfert-+-+--n <~~j!·~~ !Ia ~

M

;;; .. .,...

~ ~ N ;;: 0 "' ;;;: 0

"" "" "" a: "" ~ "' "' "' "' "' Q c :r w w ~ "' "' DA7

::J ::J

DAB

LCDRESET

LCDCS

LCDRS

~ 0 ~~~+4~~~

I I

' ' "' - N _., ... 0 0 :r "" ... u_ "' w w w ' Q.

/ FUNK

HONI

ATT STBRFS

PS

KY03

KY02

KYO !

KYOO

ROHSDA

ROHSCL

IROHV

11TX2

BATT

HTX~

~ TONE IN Q.

'

~ :~ ~

LAHPK

. I~ 41Ct(

RJIO

>--- -

I I OliO ISSJIZ~ 'm'r'

I I

_;j riLf5~~-~~ 47Ct< ~Jt-

Ol0lli¥0Z" ~~

~ ~ ~~-r-r---r-;--------+-----------------r-+-~ ; ~ -~=r---r--r-------1-----------------r-+---~ - ~ ~ ~ ~:~--r--r-------;-----------------r-;------~

"' ·~I w l j

~ I ~ffi L+--~~~----~-------------L--------------------~----------------~~--------~~~--+-------~~--J---~~CI~

4/ _CI<

RIC!

pCOM Unit (Lot 11-)

~~ ~

SOLOFF ,SJ.!Z.. '=1.

IfiwR B.S

CL

' ~"'- 2 r""-

4r- sr--71- sr~-

l

I

RIZZ

l . l K

m

Cl Ot~C t 33 Rl 01 ~R t70 u o 1 ~u OJ O!O t~Ot 27 S ! O t~St03 X l O!~X102 El 01 J !Ol JP!OJ~JP!02

BLANK Cl !7,R! Ol ,R!I7 Rl36 , Rl45 ,RI53 C!l6 ,Cl 06 , Rl OB,R l 09

PCB BLANK Rl 09 ,RIOB , Rl65 , Rll l O l 2~ , 0 1 23,R ! 62,R l 57 R!60,R!S6 , Rl5B, Rl63 Cl27,Cl29,Rl59,R l40

3r- or-6r- ·r--9j- ENr-

19

Parts Layout

c,lhod•2 Anode 1 Anode 2

188382 (A1) (0103)

Side A

~tCOM Unit (Lot 11-)

jr

21

pCOM Unit (Lot 11-)

00 ~~~

22

~~~ IR150I

IR165I

~ in ~ ~ a:

I lcml

Pin 1 , Pin 60

~ Pin 20 ~~1i.imiWJlP~ Pin 41

~ 0 N oq-C C a: a:

HD6433637A14X (USA:Lot 1-) HD6473637X(R0352)(USA:Lot 3-)

HD6433637A20X(R0352)(USA:Lot 11 -) HD6433637A13X (81 , 82) (0101)

NC NC

GO OUT Vdd GND

RN5VL20AA (80) (0102)

~

~ ~ ~ ~ ~ i&Lo~l

m ~ [!]

0 '-rr--10 .-rr-rr-,........,.,...

Side B

v •• NC s Pin~~ "--Pin 7

"'-Pin 1 OUT Vdd

S-80818ALNP (EAF) X24128S 141 (0105) (0109)

Emitter Common Collector Base 1 I Base 2 Collector

~ Collector Cathode 1 Cathode 2

~ ~ ~ k Base 1 Emitter

Collector 1 Collector 2 Base Emitter Collector Base Emitter Anode 1 Anode 2

UMG2N (G2) DTA144EE (16) 250999 (CL) DTC114TE (04) 1SS382 (A1 ) (0104) (0108, 113) (0114, 120, 126) (0127) (0106, 107, 110, 111 )

pCOM Unit Parts List

REF. DESCRIPTION VALUE V/W TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAYADR

***IJCOM UNIT··· PCB with Components (USA) 07000364 VERSION USA PCB with Components (EXP) 07000365 VERSION B1 PCB with Components (EXP) 07000366 VERSION 82

C101 CHIP CAP. 22pf 50V CH GRM39CH220J50PT K2217421 9 1- 8 C102 CHIP CAP. 22pf 50V CH GRM39CH220J50PT K22174219 1- 8 C103 CHIP CAP. 12pf 50V CH GRM39CH120J50PT K22174213 1- 8 C104 CHIP CAP. 12pF 50V CH GRM39CH120J50PT K22174213 1- B C105 CHIP CAP. 0.001 uF 50V 8 GRM39B1 02K50PT K22174821 1- B C107 CHIP CAP. 0.001 uf 50V B GRM39B102K50PT K22174821 1- 8 C108 CHIP CAP. 0.001 uf 50V B GRM39B 1 02K50PT K22174821 1- 8 C109 CHIP CAP. 0.001uf 50V B GRM39B102K50PT K22174821 1- B C110 CHIP CAP. 0.22uf 10V 8 GRM39B224K 1 OPT K221 04801 1- A C111 CHIP CAP. 0.22uf 10V B GRM39B224K 1 OPT K22104801 1- A C112 CHIP CAP. 0.22uf 10V B GRM39B224K 1 OPT K22104801 1- A C113 CHIP CAP. 0.22uf 10V B GRM39B224K 1 OPT K22104801 1- A C114 CHIP CAP. 0.22uf 10V B GRM39B224K1 OPT K22104801 1- A C115 CHIP CAP. 1uF 10V 8 GRM40B1 05K1 OPT K221 00802 1- A C118 CHIP CAP. 0.22uf 10V B GRM39B224K1 OPT K22104801 1- 8 C119 CHIP CAP. 0.22uf 10V 8 GRM39B224K1 OPT K22104801 1- A C120 CHIP CAP. 0.001uf 50V 8 GRM39B 1 02K50PT K22174821 1- B C121 CHIP CAP. 0.001uF 50V B GRM398 1 02K50PT K22174821 1- 8 C122 CHIP TA.CAP. 68uF TEMSVB20G686M-8R K78060033 1- B C123 CHIP CAP. 0.001 uF 50V B GRM3981 02K50PT K22174821 1- B C124 CHIP CAP. 0.001 uF 50V B GRM3981 02K50PT K22174821 1- B C125 CHIP CAP. 0.001 uF 50V 8 GRM3981 02K50PT K22174821 1- 8 C126 CHIP CAP. 1uF 10V 8 GRM40B 1 05K 1 OPT K22100802 1- A C129 CHIP CAP. 0.01uF 25V 8 GRM3981 03K25PT K22144803 1- 8 C130 CHIP CAP. 0.01uF 25V 8 GRM39B1 03K25PT K22144803 1- 8 C131 CHIP CAP. 0.22uF 16V 8 GRM40B224M16PT K22120806 1- B C131 CHIP CAP. 0.33uF 16V B GRM40B334K 16PT K22120807 11- B C132 CHIP TA.CAP. 4.7uF 6.3V TEMSVAOJ475M-8R K78080017 1- B C133 CHIP CAP. 0.1 uF 25V B GRM40B1 04M25PT K22140811 USA 11-C133 CHIP CAP. 0.1uF 16V B GRM39B104K16PT K22124805 81 7-C133 CHIP CAP. 0.1uF 16V B GRM39B1 04K16PT K22124805 82 7-C133 CHIP CAP. 0.1uF 25V 8 GRM4081 04M25PT K22140811 8 1 9-C133 CHIP CAP. 0.1uF 25V B GRM40B 1 04M25PT K22140811 82 9-E101 SPEAKER T032S23AOOOO S8100785 1- A J101 CONNECTOR 53307-3091 P1091066 1- B JP101 SHIELD FINGER 2026 3100012 S5000196 1- A JP102 SHIELD FINGER 2026 3100012 S50001 96 1- A L101 M.RFC 1uH MLF1608A 1 ROKT L1690930 1- 8 L102 M.RFC 1uH MLF1608A 1 ROKT L1690930 1- B L103 M.RFC 1uH MLF1608A 1 ROKT L1690930 1- A 0101 IC HD6433637A14X S8100820 USA 1- B b3 0101 IC H D64 7363 7X(R0352) S8100884 USA 3- 8 b3 0101 IC HD6433637 A20X(R0352) S81 0090B USA 11- 8 b3 0101 IC HD6433637A13X S81 00819 81 1- 8 b3 0101 IC HD6433637A13X S81 00819 82 1- 8 b3 0102 IC RN5VL20AA-TR G1093071 1- 8 b5 0103 DIODE 1 SS382(TE85R) G2070732 1- A C2 0104 TRANSISTOR UMG2N TR G3070088 1- 8 b5 0105 IC S-8081 8ALNP-EAF-T2 G1093073 1- 8 c5 0106 DIODE 1 SS382(TE85R) G2070732 1- 8 d3 0107 DIODE 1 SS382(TE85R) G2070732 1- 8 d3 0108 TRANSISTOR DTA144EE TL G3070074 1- 8 c5 0109 IC ~ftT~4'00C -1..2~)' X24128S 141-2.5 G1093079 c-"1os:>~-1 1- B d5 0109 IC CAT24WC128JI-TE13 G1093247 8- B d5 011 0 DIODE 1 SS382(TE85R) G2070732 1- 8 e3 0111 DIODE 1 SS382(TE85R) G2070732 1- 8 e2 0112 LCD HLM7343 S8100787 1- A 83 0113 TRANSISTOR DTA144EE TL G3070074 1- 8 b2 0114 TRANSISTOR 2SD999-T1 CL G3409998L 1- B d2 0115 LED AY1111C-TR G2070740 1- A E5 0116 LED AY1111C-TR G2070740 1- A G4 0117 LED AY1111C-TR G2070740 1- A H4 011 B LED AY1111C-TR G2070740 1- A G2

23

JLCOM Unit

REF. DESCRIPTION VALUE VM/ TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

0119 LED AY1111C-TR G2070740 1- A G2 0120 TRANSISTOR 2SD999-T1 CL G3409998L 1- 8 b1 0121 LED LU81 063X(SLE0423x1) S8100777 1- A 83 0122 DIODE MA729-(TX) G2070320 1- A A2 0125 DIODE MA729-(TX) G2070320 1- 8 b5 0126 TRANSISTOR 2SD999-T1 CL G3409998L 1- B e1 0127 TRANSISTOR DTC114TE TL G3070225 1- B d2 0128 DIODE 1 SS387(TPL3) G2070606 81 7-8 B c3 0128 DIODE 1 SS387(TPL3) G2070606 82 7-8 8 c3 R102 CHIP RES. 1M 1/16W 5% RMC1/16 105JATP J24185105 1- B R103 CHIP RES. 1k 5% TSM808WJ102V S8100792 1- 8 R104 CHIP RES. 4701\ 1/16W 5% RMC1/16 474JATP J24185474 1- 8 R105 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- 8 R106 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 8 R107 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- 8 R110 CHIP RES. 1k 1/16W 5% RMC1 /16 102JATP J24185102 1- 8 R111 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- 8 R111 CHIP RES. 0 1/16W 5% RMC 1/16 OOOJA TP J24185000 81 5- 8 R112 CHIP RES. 470k 1/16W 5% RMC1/16 474JATP J24185474 1- 8 R113 CHIP RES. 470k 1/16W 5% RMC1 /16 474JATP J24185474 1- B R114 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- B R115 CHIP RES. 1k 5% TSM808WJ102V S8100792 1- 8 R116 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- B R118 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J241B5104 1- 8 R11 9 CHIP RES. 1k 1/16W 5% RMC1 /16 102JATP J24185102 1- 8 R120 CHIP RES. 1k 5% TSM808WJ1 02V S8100792 1- A R121 CHIP RES. 1k 5% TSM808WJ1 02V S8100792 1- 8 R122 CHIP RES. 3.9k 1/16W 5% RMC 1/16 392JATP J24185392 1- 8 R123 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- B R1 24 CHIP RES. 4.7 1/16W 5% RMC1/16 4R7JATP J24185479 1- 8 R125 CHIP RES. 1k 5% TSM808WJ102V S8100792 1- 8 R126 CHIP RES. 1k 5% TSM808WJ102V S8100792 1- 8 R127 CHIP RES. 5.6k 1/16W 5% RMC1 /16 562JATP J24185562 1- 8 R128 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J241B5222 1- 8 R129 CHIP RES. 4.7 1/16W 5% RMC1 /16 4R7JATP J241B5479 1- 8 R130 CHIP RES. 1k 5% TSM808WJ1 02V S8100792 1- 8 R1 31 CHIP RES. 200k 2% TSMB08WG204V S8100791 1- 8 R132 CHIP RES. 100k 2% TSM808WG104V S8100790 1- B R133 CHIP RES. 100k 1/16W 1% RMC1 /16104FTP J241B3104 1- 8 R134 CHIP RES. 200k 2% TSM808WG204V S8100791 1- 8 R135 CHIP RES. 200k 1/16W 1% RMC1/16 204FTP J241B3204 1- 8 R137 CHIP RES. 100k 2% TSM808WG 1 04 V S8100790 1- 8 R138 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J241B5102 1- 8 R138 CHIP RES. 330k 1116W 5% RMC1/16 334JATP J241B5334 8 1 7- 8 R138 CHIP RES. 330k 1/16W 5% RMC1/16 334JATP J241B5334 82 7- 8 R138 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J241B5102 8 1 9- B R138 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 82 9- B R139 CHIP RES. 1k 5% TSM808WJ1 02V S8100792 1- 8 R141 CHIP RES. 390k 1/16W 5% RMC1/16 394JATP J24185394 1- A R142 CHIP RES. 1k 5% TSM808WJ1 02V S8100792 1- 8 R143 CHIP RES. 470k 1/16W 5% RMC1/16 474JATP J241B5474 1- 8 R144 CHIP RES. 100 1/16W 5% RMC1/16101JATP J24185101 1- A R146 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J241B5102 1- 8 R147 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- A R148 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- A R1 49 CHIP RES. 1k 1/8W 5% TSM808WJ102V SB100792 1- 8 R150 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- 8 R151 POT. TP76N00-1 OKA S8100789 1- 8 R152 THERMISTOR NT732A104K G9090125 1- 8

R154 CHIP RES. 100k 1/16W 1% RMC1/1 6 104FTP J24183104 1- 8 R155 CHIP RES. 200k 1/16W 1% RMC1/16 204FTP J24183204 1- 8 R161 CHIP RES. 6.8k 1/16W 5% RMC1/16 682JATP J24185682 1- A R164 CHIP RES. 47k 1116W 5% RMC1/16 473JATP J24185473 1- 8

R165 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R166 CHIP RES. 6BOk 1/16W 5% RMC1 /16 684JATP J24185684 1- 8 R167 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- 8 R168 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- B

24

pCOM Unit

REF. DESCRIPTION VALUE V/W TOL. MFR'S DESIG VXSTD PIN VERS. LOT. SIDE LAY ADR

R169 CHIP RES. 470k 1/16W 5% RMC1/16 474JATP J24185474 1- B R170 CHI P RES. 10 1/16W 5% RK73K2AS100J S8100793 1- B S103 ROTARY SWITCH TP76D242E20 S8100784 1- B

X101 XTAL 32.768KHz C-002RX-ZA-32. 768KHz S8100778 1- B

X102 XTAL 4.9152MHz 38CHT 4.9152MHz S8100780 1- B

X102 XTAL 4.9152MHz AT-38 4.9152MHz S8100882 8- B LCD COVER S8001724 1-TAPE S8001725 1-

25

flCOMUnit Note:

26

Circuit Diagram

C30I~C395 R30I ~R405 L30t~L311 030!~03<\7 J30t~J305 X30t~X302 F30I~F302

BLANK C344 1 C345 I 034210347 I R387 I R332 C3431 C3461 R388 I C383. 0345 R39 01 R391, R392 1 R393 1 R394, R395 PCB BLANK ~52 1 C363

R3~~:2m

J305 T)11oZOZ6oll OOOIZ

AF Llnit

I

RJZ4 RJZJ

2 BV

~r-----------------ti-------------------------------------------------------------+----------------------------------+-_j r-=:- ~ ~' s-M~\m

~zi;J~~~~3~ ~1-1--++-----.. 3 ov 1---r or:; ~~liA Bf~ I ~ c; ~~:zs 054 .+. :e "

n Qlll

" I DTCI44!I ov

OT.; u- ~ 100/&.JVT "' S! !!: rh ~ o o.l-ol~-+__._-'iiRJV.I;....I ..--''w"K\.-----~

- ~61 IM RJIZ ·-:-~ rh 0 RJ6! 0 0

Q]JZ

DTAIZJY£

2 6V 2.2K

~0 0 7V 1 3V

06V

l.lll l.ll4 llli21AIZIS llli21AIZIS JJOJ

~~~======~==========================~_JJL-LlllJ~x~~~==~l.l~ll~~~~~~~~ am am ~sv ~.!' o ~ l.l l2 · ' ~ J.OV ZSA;:_aam J.OV ZSII~ rl~r\~':101,!,4~ •1V!...._ __________________________ _j llli2IAI2 l5 llli21Al21S ~~ 1611501-0IOOU

~~~o ~~i 1 J, l~v ' ~ S!.r,.J,l:"'~l ~_/"":~1 ,--- i;; 1 44 2 3V Qlll 1 44V 2 6V 1 v "' TAl lOSEr RJ!I

';~~ - : 1 44V'i"~H~EI 1 33V I OT.; S! !:! r-'.,.r:• .... ~I!> (13.5V) RJ9 (1.24V) rh ., r. 0~ ~JOo -r .-'-

~ "' 1 98V~ 1 ~ "; ..; - I ~-

S! i;: ~01.0 0 :;: ~ Ql40 To.6V)I S! N HJ!i2]6 ONi /

o. ~~ Fib. RJBZ I "' ,.f . :; i:;

(13.5V) QJ41

EPOSQOl l

RJIS

30V -,h aebWISI11CS U T > u- ~

~--~~~==========================::~~4~.4~0~VL) +-Q]l<l]l-• .1---ltr~ 5_1_~ 0

a ! ~ : aJ~ ) EP~QOJL (4.75V) ;;l

1om?m / 5i'L__=fa ........ _:~_:§;~~~-+-_.__.__J (4 71V)

1 ) Use External Power Supply

- .~. (1 3 8V) l.l01 lOu~ l.lOB llli21RIZIS fEO&S D-010010

oro ,

27

AF Unit Parts Layout

28

lc38al IR320I

l~fogl [!] [m

IR352I

8

~ lc331l

IR351I

rnlrnJ

IR350I

IR349I 0

IR347I 1m IR348I IC333I

Side A

NJM2360AM (0340)

TA31136FN (0302) BU4094BCFV (0323)

DTA144EE (16) (0303)

Collector

~ Base Em1tter

2SC4617 (BR) (0311, 314, 316, 317, 343)

Collector

~ LH

Base Em1tter

DTC144EE (26) (0312, 344)

Cathode 1, Anode 2

~ Anode 1 Cathode 2

MA742 (M1U) (0319, 320)

8 Voul f Vln

GNO

S-81330HG (0326)

Em1t1er Common Base 1 I Base 2

Collector 1 Collector 2

UMG2N (G2) (0321 )

Em1tter Common Base 1 I Base 2

UMA2N (A2) (0324)

Voul Vdd NC

S-8323050MC (E3E) (0330)

G Voo 1 L.x

OUT

RH5RH331A (1A) (0328)

Em1tter Common

"'~]' Collector 1 Collector 2

UMW1 (W1 ) (0335)

Collector

~ Base Emitter

2SA 1588 (ZY) (0334)

F302

F301

EJ

IL314I !HI IC394l

~ IC395l

Side B

Collector

~ Base Emitter

2501823 (1 ZS) (0313)

Collector

~ ~

Base Em1tter

DTC144EE (26) (0331 )

Collector

~ Base Em1tter

2SA 1588 (ZY) (0336)

~ LH Base Em1tter

DTA 123YU (53) (0325) DTA123YE (62) (0332)

Em111cr 1

tmf' Colle<lor 1 I Collclor 2

Base 1

UMX2N (X2) (0333)

V• OUTPUT u •INPUT V· ·INPUT

NJM2130F (0301)

Pin1~~

~1.""'-. Pm 7 ...........

Pm 1

TC4066BFT (0322)

P1n B

........._~"-Pin 4 Pin 1

TA31056F (0337)

AF Unit

29

AF Unit Pm·ts List

REF. DESCRIPTION VALUE VM/ TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

••• AF UNIT •••

PCB with Components 07000367 C301 CHIP CAP. 0.001uF 50V 8 GRM39B 1 02K50PT K22174821 1- A C302 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- 8 C303 CHIP CAP. 3pF 50V UJ GRM39UJ030850PT K22174337 1- 8 C304 CHIP CAP. BpF 50V CH GRM39CHOBOD50PT K22174209 1- 8 C305 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- 8 C306 CHIP CAP. 0.01uF 25V 8 GRM398103K25PT K22144803 1- A C307 CHIP CAP. 0.01uF 25V 8 GRM39B103K25PT K22144803 1- A C308 CHIP CAP. 0. 1uF 16V 8 GRM39B1 04K16PT K22124805 1- A C309 CHIP CAP. 220pF 50V CH GRM39CH221 J50PT K22174243 1- 8 C310 CHIP CAP. 220pF 50V CH GRM39CH221 J50PT K22174243 1- 8 C311 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- 8 C312 CHIP CAP. 0.047uF 16V 8 GRM398473K16PT K22124804 1- 8 C313 CHIP CAP. 33pF 50V CH GRM39CH330J50PT K22174223 1- A C314 CHIP CAP. 0.01 uF 25V 8 GRM398 1 03K25PT K22144803 1- A C315 CHIP CAP. 0.1uF 16V 8 GRM398104K16PT K22124805 1- A C315 CHIP CAP. 0.047uF 16V 8 GRM398473K16PT K22124800 81 7- A C315 CHIP CAP. 0.047uF 16V 8 GRM398473K16PT K22124800 82 7- A C316 CHIP TA.CAP. 22uF 6.3V TEMSVAOJ226M-8R K78080047 1- 8 C316 CHIP TA.CAP. 22uF 4V TEMSVAOG226M-8R K78060023 2- 8 C317 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- 8 C318 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A C319 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C320 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C321 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C322 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A C323 CHIP CAP. 0.047uF 16V 8 GRM39R473K16PT K22124810 1- A C324 CHIP CAP. 0.047uF 16V 8 GRM39R473K16PT K22124810 1- A C325 CHIP CAP. 1uF 10V 8 GRM408105K10PT K22100802 1- 8 C326 CHIP CAP. 1uF 10V 8 GRM408105K10PT K22100802 1- A C327 CHIP CAP. 0.001 uF 50V 8 GRM39B 1 02K50PT K22174821 1- A C328 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 1- A C329 CHIP CAP. 0.047uF 16V 8 GRM398473K16PT K22124804 1- 8 C330 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C331 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C332 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A C333 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C334 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 1- A C335 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C336 CHIP CAP. 470pF 50V 8 GRM398 1 02K50PT K22174821 1- A C336 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 USA 5- A C336 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 81 5- A C336 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 82 5- A C337 CHIP CAP. 0.0033uF 50V 8 GRM398332K50PT K22174831 1- A C338 CHIP CAP. 47pF 50V CH GRM39CH4 70J50PT K22174227 1- 8 C338 CHIP CAP. 68pF 50V CH GRM39CH680J50PT K22174231 4- 8 C339 CHIP CAP. 470pF 50V CH GRM39CH471 J50PT K22174249 1- 8 C340 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 1- A C341 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 1- 8 C342 CHIP CAP. 0.0047uF 50V 8 GRM398472K50PT K22174833 1- 8 C347 CHIP CAP. 1uF 10V 8 GRM408105K10PT K22100802 1- A C348 CHIP CAP. 0.001 uF 50V 8 GRM398 1 02K50PT K22174821 1- 8 C349 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A C350 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C351 CHIP TA.CAP. 100uF 4V TEMSVCOG107M12R K78060021 1- 8 C351 CHIP TA .CAP. 220uF 4V SK4-0G227M-RD K78060014 11 - 8 C353 CHIP CAP. 0.1uF 16V 8 GRM398104K16PT K22124805 1- A C354 CHIP TA.CAP. 100uF 6.3V TEMSVCOJ107M12R K78080049 1- A C355 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C356 CHIP TA.CAP. 10uF 16V TEMSV821 C1 06M-8R K78120025 1- A C357 CHIP CAP. 0.1uF 16V 8 GRM3981 04K16PT K22124805 1- A C358 CHIP TA .CAP. 10uF 6.3V TEMSVAOJ 1 06M-8R K78080027 1- A C359 CHIP CAP. 0.047uF 16V 8 GRM39R473K16PT K22124810 1- 8 C360 CHIP CAP. 0.047uF 16V 8 GRM39R473K16PT K22124810 1- 8 C361 CHIP CAP. 0.01 uF 25V 8 GRM398103K25PT K221 44803 1- 8 C362 CHIP TA.CAP. 22uF 6.3V TEMSVAOJ226M-8R K78080047 1- 8

31

AF Unit

REF. DESCRIPTION VALUE VIW TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAYADR

C362 CHIP TA.CAP. 22uF 4V TEMSVAOG226M-8R K78060023 2- B C364 CHIP CAP. 0.0022uF 50V B GRM3gB222K50PT K22174822 1- B C365 CHIP CAP. 0.047uF 16V B GRM3gR473K16PT K22124810 1- B C366 CHIP CAP. 0.01uF 25V B GRM3gB 1 03K25PT K22144803 1- B C367 CHIP CAP. 0.1uF 16V B GRM3gB104K16PT K22124805 1- B C368 CHIP CAP. 0.1uF 16V B GRM3gB104K16PT K22124805 1- A C36g AL.ELECTRO.CAP. 220uF 4V UZSOG221 MCR 1GB K48060006 1· B C370 CHIP CAP. 0.047uF 16V B GRM3gB4 73K 16PT K22124804 1- B C372 CHIP TA.CAP. 4.7uF 6.3V TEMSVAOJ475M-8R K78080017 1- B C373 CHIP TA.CAP. 2.2uF 16V TEMSVA 1 C225M-8R K78120015 1- B C374 CHIP CAP. 100pF 50V CH GRM3gCH101J50PT K22174235 1- B C375 CHIP CAP. 0. 1 uF 16V B GRM3gB104K16PT K22124805 1- B C376 AL.ELECTRO.CAP. 220uF 4V UZSOG221 MCR 1GB K48060006 1- B C377 CHIP TA.CAP. 100uF 6.3V TEMSVCOJ107M12R K78080Q4g 1- A C378 AL.ELECTRO.CAP. 100uF 6.3V UZSOJ101MCR1GB K48080QOg 1- A C37g CHIP CAP. 0.01uF 25V B GRM3gB1 03K25PT K22144803 1- A C380 CHIP CAP. 330pF 50V CH GRM3gCH331 J50PT K22174253 1- A C381 AL.ELECTRO.CAP. 100uF 16V ECEV1CA101WP K48120012 1- A C382 CHIP CAP. 0.01uF 25V B GRM3gB1 03K25PT K22144803 1- A C384 CHIP CAP. 0.001uF 50V B GRM3gB1 02K50PT K22174821 1- A C385 CHIP CAP. 0.001uF 50V B GRM3gB 1 02K50PT K22174821 1- A C386 CHIP CAP. 0.001uF 50V B GRM3gB 1 02K50PT K22174821 1- A C386 CHIP CAP. 0.047uF 16V B GRM3gB473K16PT K22124804 USA 8- A C386 CHIP CAP. 0.047uF 16V B GRM3gB473K16PT K22124804 B1 g. A C386 CHIP CAP. 0.047uF 16V B GRM3gB473K16PT K22124804 B2 g. A C387 CHIP CAP. 1uF 10V B GRM40B 1 05K 1 OPT K22100802 1· B C388 CHIP CAP. 82pF 50V CH GRM3gCH820J50PT K22174?33 1- A C389 CHIP CAP. 0.0022uF 50V B GRM3gB222K50PT K22174822 1- B C390 CHIP CAP. 0.01uF 25V B GRM3gB1 03K25PT K22144803 1- B C3g1 CHIP CAP. 0.01uF 25V B GRM39B103K25PT K22144803 1- A c3g3 CHIP CAP. 100pF 50V CH GRM39CH 101 J50PT K22174235 USA 5- B c3g3 CHIP CAP. 100pF 50V CH GRM3gCH 101 J50PT K22174235 81 5- B c3g3 CHIP CAP. 100pF 50V CH GRM3gCH 101 J50PT K22174235 82 5- B c3g4 CHIP CAP. 100pF 50V CH GRM39CH 101 J50PT K22174235 USA 5- B c3g4 CHIP CAP. 100pF 50V CH GRM3gCH 101 J50PT K22174235 B1 5- B c3g4 CHIP CAP. 100pF 50V CH GRM39CH101J50PT K22174235 B2 5- B C395 CHIP CAP. 0.001uF 50V B GRM39B1 02K50PT K22174821 5- B F301 CERAMIC FILTER KBF-455RS-4AS H3900529 1- B F302 CERAMIC FILTER KBF-455RS-15A H3g00406 1- B J301 CONNECTOR 52465-1691 Poog1251 1- B J302 CONNECTOR 52588-3ogo PQOg1250 1- A J303 CONNECTOR HSJ1501-010010 P1091068 1- B J304 CONNECTOR HEC3650-01 001 0 PQQg1252 1- B J305 SHIELD FINGER 2026 3100012 S5000196 USA 5- B J305 SHIELD FINGER 2026 3100012 S5000196 81 5- B J305 SHIELD FINGER 2026 3100012 S5000196 82 5- B L301 M.RFC ELJ-FC 1 OOJF L1690935 1- B L302 M.RFC ELJ-FC100JF l16gQ935 1- B L303 RF TRANS. S-167-377g S8100775 1- A L304 M.RFC CM5N-101 S8100776 1- A L305 M.RFC CDRH74-151MC5 L1 6gog32 1- A L306 RF TRANS. 303LC-1773BS::P1 S8100774 1- B L307 M.RFC ELJ-PC1 OOKF L1690933 1- B L308 FERRITE BEADS BLM21A121SPT Lg1g0108 5- B L308 FERRITE BEADS BLM11A121SPT Lg1g0110 8- B L3og FERRITE BEADS BLM11A121SPT Lg1901 10 USA 5- B L309 FERRITE BEADS BLM11A121SPT L91g0110 B1 5- B L3og FERRITE BEADS BLM11A121SPT Lg1g01 10 B2 5- B L310 FERRITE BEADS BLM11A121SPT Lg1g0110 USA 5- B L310 FERRITE BEADS BLM11A121SPT Lg1g0110 B1 5- B L310 FERRITE BEADS BLM11A121SPT Lg190110 B2 5- B L311 FERRITE BEADS BLM11A121SPT Lg1g0110 USA 5- B L311 FERRITE BEADS BLM11A121SPT Lg1g0110 B1 5- B L311 FERRITE BEADS BLM11A121SPT Lg1g0110 B2 5- B L312 FERRITE BEADS BLM11A121SPT L91g0110 USA 5- A L312 FERRITE BEADS BLM11A121SPT L91gQ110 B1 5- A L312 FERRITE BEADS BLM11A121SPT Lg1g0110 B2 5- A

32

AF Unit


L313 FERRITE BEADS BLM11A121 SPT L9190110 USA 5- B L313 FERRITE BEADS BLM11A121 SPT L9190110 B1 5- B L313 FERRITE BEADS BLM11A121SPT L9190110 B2 5- B L314 FERRITE BEADS BLM11A121SPT L9190110 USA 5- B L314 FERRITE BEADS BLM11A121SPT L9190110 B1 5- B L314 FERRITE BEADS BLM11A121SPT L9190110 B2 5- B 0301 IC NJM2130F(TE1) G1093074 1- B d3 0302 IC TA31136FN(EL) G1091605 1- A D3 0303 TRANSISTOR DTA144EE TL G3070074 1- A C3 0304 DIODE HVU17-TL G2070736 1- B b4 0305 DIODE 1SS314 TPH3 G2070122 1- A E3 0306 DIODE 1SS314 TPH3 G2070122 1- A D3 0307 DIODE 1SS314 TPH3 G2070122 1- A E3 0308 DIODE 1SS314 TPH3 G2070122 1- A D3 0309 DIODE 1SS314 TPH3 G2070122 1- A E3 0310 DIODE 1SS314 TPH3 G2070122 1- A D3 0311 TRANSISTOR 2SC4617 TL R G3346178R 1- A D2 0312 TRANSISTOR DTC144EE TL G3070075 1- A D2 0313 TRANSISTOR 2SD1823S(TX) G341823BS 1- B b2 0314 TRANSISTOR 2SC4617 TL R G3346178R 1- A E2 0315 DIODE MA729-(TX) G2070320 1- A D1 0316 TRANSISTOR 2SC4617 TL R G3346178R 1- A D2 0317 TRANSISTOR 2SC4617 TL R G3346178R 1- A C3 0318 DIODE HVU17-TL G2070736 1- A C3 0319 DIODE MA742-(TX) G2070598 1- A D2 0320 DIODE MA742-(TX) G2070598 1- A C2 0321 TRANSISTOR UMG2NTR G3070088 1- A C2

0322 IC TC4066BFT(EL) G1093081 1- B b1

0323 IC BU40948CFV-E1 G1092128 1- A C2 0324 TRANSISTOR UMA2NTR G3070213 1- A D1 0325 TRANSISTOR DTA123YU T106 G3070038 1- B d3 0326 IC S-81330HG-K8-T1 G1093069 1- A 84

0327 DIODE MA729-(TX) G2070320 1- A 84

0328 IC RH5RH331 A-T1 G10930?2 1- A 84

0328 IC RH5RH351 A-T1 G1093195 5- A B4 0329 DIODE MA729-(TX) G2070320 1- A 82 0330 IC S-8323D50MC-E3E-T2 G1093075 1- A A2 0331 TRANSISTOR DTC144EE TL G3070075 1- 8 d2

0332 TRANSISTOR DTA123YE TL G3070094 USA 5- B d1

0332 TRANSISTOR DTA123YE TL G3070094 81 5- B d1 0 332 TRANSISTOR DTA123YE TL G3070094 82 5- B d1

0333 TRANSISTOR UMX2N TR G3070254 1- 8 a2

0334 TRANSISTOR 2SA 1588Y(TE85L) G31 15888Y 1- A C2

0335 TRANSISTOR UMW1N TR G3070078 1- A C2

0336 TRANSISTOR 2SA 1588Y(TE85L) G3115888Y 1- 8 c2

0337 IC TA31056F(TP1) G1093070 1- 8 c2

0338 DIODE EP05003L G2070734 1- A B3

0339 DIODE EP05003L G2070734 1- A A3

0340 IC NJM2360AM(TE 1) G1093076 1- A A3

0341 DIODE EP05003L G2070734 1- A A4

0343 TRANSISTOR 2SC4617 TL R G3346178R 1- A D2

0344 TRANSISTOR DTC144EE TL G3070075 1- A D1

0346 DIODE 1SV271 TPH3 G2070476 1- A D2

R301 CHIP RES. 100k 1/16W 1% RMC1/16 104FTP J24183104 1- B

R302 CHIP RES. 270k 1/16W 1% RMC1/16 274FTP J24183274 1- B

R303 POT. 220k MVR22HXBRN224 J51799224 1- B

R304 CHIP RES. 100k 1/ 16W 5% RMC1/1 6 104JATP J24185104 1- B

R305 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- 8

R306 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- B

R307 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- A

R308 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A






R314 CHIP RES. 22k 1/ 16W 5% RMC1/16 223JATP J24185223 1- A

33

AF Unit

REF. DESCRIPTION VALUE V/W T OL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAYADR

R315 CHIP RES. 150k 1/16W 5% RMC1 /16 154JATP J24185154 1- B R316 CHIP RES. 3.3k 1/16W 5% RMC1/16 332JATP J24185332 1- B R317 CHIP RES. 330k 1/16W 5% RMC1 /16 334JATP J24185334 1- B R318 CHIP RES. 10k 1/10W 5% RMC1/1 OT 103J J24205103 1- B R319 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- B R320 CHIP RES. 680 1116W 5% RMC1/16 681JATP J24185681 1- A R321 CHIP RES. 6.8k 1/16W 5% RMC1/16 682JATP J24185682 1- A R322 CHIP RES. 1k 1/10W 5% RMC1/10T 102J J24205102 1- A R323 CHIP RES. 1k 1/10W 5% RMC1/10T 102J J24205102 1- A R324 CHIP RES. 1M 1/16W 5% RMC1/16 105JATP J24185105 1- A R325 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JAT P J24185472 1- A R326 CHIP RES. 220k 1/16W 5% RMC1/16 224JATP J24185224 1- A R327 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R328 CHIP RES . 220k 1/16W 5% RMC1/16 224JATP J24185224 1- A R329 CHIP RES . 4.7k 1/16W 5% RMC1/16 472JAT P J24185472 1- A R330 CHIP RES. 4.7k 1/16W 5% RMC1 /16 472JATP J24185472 1- A R331 CHIP RES. 220 1/16W 5% RMC1 /16 221JATP J24185221 1- A R333 CHIP RES. 4.7k 1/16W 5% RMC1 /16 472JATP J24185472 1- B R334 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- B R335 CHIP RES. 10k 1/16W 5% RMC1 /1 6 103JATP J24185103 1- A R336 CHIP RES. 10k 1/1 6W 5% RMC1 /16 103JATP J24185103 1- A R337 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R338 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- A R339 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R340 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R341 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- A R342 CHIP RES . 1k 1/16W 5% RMC1/16 102JATP J24185102 1- A R343 CHIP RES. 3.3k 1/16W 5% RMC1/16 332JAT P J24185332 1- A R344 CHIP RES. 3.3k 1/16W 5% RMC1/16 332JATP J24185332 1- A R345 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R346 CHIP RES. 33k 1/16W 5% RMC1/16 333JATP J24185333 1- A R347 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R348 CHIP RES. 1k 1/16W 5% RMC1 /16 102JATP J24185102 1- A R349 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R350 CHIP RES. 22k 1/1 6W 5% RMC1 /16 223JATP J24185223 1- A R351 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- A R352 CHIP RES. 1M 1/16W 5% RMC1 /16 105JATP J24185105 1- A R353 CHIP RES. 560k 1/16W 5% RMC1/16 564JATP J24185564 1- A R354 CHIP RES. 1.5k 1/16W 5% RMC1 /16 152JATP J24185152 1- A R355 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- B R356 CHIP RES. 47k 1/16W 5% RMC1 /16 473JATP J24185473 1- B R357 POT. 220k MVR22HXBRN224 J51799224 1- B R358 POT. 220k MVR22HXBRN224 J51799224 1- B R359 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- B R360 CHIP RES. 470 1/16W 5% RMC1/16 471JATP J24185471 1- A R361 CHIP RES. 6.8k 1/16W 5% RMC 1/16 682JATP J24185682 1- B R362 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R363 CH IP RES. 33k 1/16W 5% RMC1/16 333JATP J24185333 1- A R364 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- B R365 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R366 CHIP RES. 470k 1/16W 5% RMC1/16 474JATP J24185474 1- A R367 CHIP RES. 470k 1/16W 5% RMC1 /16 474JATP J24185474 1- A R368 CHIP RES. 220 1/16W 5% RMC1 /16 221JATP J24185221 1- B R369 CHIP RES. 2.2k 1/16W 5% RMC 1/16 222JATP J24185222 1- B R370 CHIP RES. 18k 1/16W 5% RMC1 /16 183JATP J24185183 1- B R371 CHIP RES. 1M 1/16W 5% RMC1/16 105JATP J24185105 1- B R372 CHIP RES. 18k 1/16W 5% RMC1/16 183JATP J24185183 1- B R373 CHIP RES. 1.5k 1116W 5% RMC1/16 152JATP J24185152 1- B R374 CHIP RES. 120 1116W 5% RMC1/16 121JATP J24185121 1- B R375 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- B R376 CHIP RES. 1M 1/16W 5% RMC1/16 105JATP J24185105 1- B R377 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- B R378 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- A R379 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- A R380 CHIP RES. 3.3k 1/16W 5% RMC1/16 332JATP J24185332 1- A R381 CHIP RES. 15k 1/16W 5% RMC1/16 153JATP J24185153 1- A R382 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- B

34

AF Unit

REF. DESCRIPTION VALUE VN.J TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

R383 CHIP RES . 27k 1/16W 5% RMCl/16 273JATP J24185273 1- A R384 CHIP RES. 10k 1/16W 5% RMCl/16 103JATP J24185103 1- A R385 CHIP RES. 2.2k 1/16W 5% RMCl /16 222JATP J24185222 1- B R386 CHIP RES. lk 1/16W 5% RMCl/16 102JATP J24185102 1- B R396 CHIP RES. 0 1116W 5% RMC 1/16 OOOJA TP J24185000 1- 8 R397 CHIP RES. 1 1/16W 5% RMCl /16 1ROJATP J24185010 1- A R399 CHIP RES. 0 1/16W 5% RMCl /16 OOOJATP J24185000 1- 8 R400 CHIP RES. 2.2k 1/16W 5% RMCl/16 222JATP J24185222 1- B R401 CHIP RES. lOOk 1/16W 5% RMCl/16 104JATP J24185104 1- B R402 CHIP RES. lOOk 1/16W 5% RMCl/16 104JATP J24185104 1- B R403 CHIP RES. 1k 1/10W 5% RMC1/10T 102J J24205102 1- A R403 CARBON RES. 100k 1/6W 5% RD16PJ104 J01225104 3- A R403 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 4- A R404 CARBON RES. 100k 1/6W 5% RD16PJ104 J01225104 1- B R404 CHIP RES. lOOk 1/16W 5% RMC1/16 104JATP J24185104 5- B R405 CHIP RES. lOOk 1/16W 5% RMC1/16S1 04JTH J24189049 1- B R405 CHIP RES. 100k 1/16W 5% RMCl/16 104JATP J24185104 5- B X301 XTAL 10.245MHz HC-49/T_ 1 0.245MHz S8100781 1- A X302 CERAMIC OSC. 458KHz CS8F458J-TC01 H7901380 1- A

35

AF Unit Note:

36

Circuit Diagram

OV (ATT ON 2 7V)

ANT'-' ~ o~,.. o:v ';_q; ~3 ~: ~~ ~ .. 03 1 o~ I!:!:;.; 15011 ~ " 0.1 ~ ~ ~ ~ l!l l!i ~ ! ~

~::; _ 155364 K!- - !!1- I .; : JSIIIflL

i2 ~ ~ 9V m 0504 ~ ~ K!N (ATT ON OV) I ~I DTA144EE 3 ov

~7~:;T I 2.8V

~ ~l~ * ... 2.4V ::!-1-- 11515 L.bV

! ::: 1:! tsJ oo;t" ~ ~ m iii ~ frro 100 K!..; K! ~ 2.0V m 0509 1.4V

1.3V

. Cf5J6 ~ ~2 1V 1\:!07 q;1o IV IMI131

~31 4.7u ~!!; 4.7u HWI31 0.1 0 7V \!:~/21%\06 (R24 ) .5V ~ 1.5V r}

2 .7V 4-fO+ ~ ~ll-+-ill ~

0550 LIIA2N 0551 LIIA2N 11552 IK\2N

~~ 'ji ::: 2.6V ~ ~ ~ ~ m :r-::-;;; 1.1v !!! N ~~ ;:~~

2.4V ~.; !!! ~ 0514

I aw IJ 43 _ _ Cfy~46 wa. Wi. O.BV IV HW131 I H'JiJ!31 0.01 n~...~ " o'J,:r-o.2~-ro:~."' I 0513 1.8V ~l.:: ~ "': ~ ~ ~-h., 1J?2SC4215!Yl

::1i ... ... ~ ~ ~ji~ i ::l0.08V rh tti '-'tti tti 1.8V

2.8V

d_c: ~"" C520

~~ "l-:. ii!- ~~ ~ ~ 28V 11550 ~:o- 1~ ~~-~~ S{:~ w I 1.1v 1oo frr:; 5 .......... ill '* 0 '* ~ 1 a.w LSos q;11 ~.:jgz. c;;17 l.'jg(i q;19 05 11 "' ;;; '"' g ~"' ~ ~ ~ FSol m - ~31

.-- r-r udi'1l ;;] ., 0 22 ., 2 \ --tl-+-~-~ N frro K! ::: Kl f..; 1:571 I.SfiiS-429 ~~-?f ~)0530 ..........._1~11 2 ov _ 1

1 l ""u.31 0.12~'- 5SP~I3~ . u 24P.,~ ~·-0• 1 u \ SSP 155314 ~ m H.t - "'-.:_ -

1 9V 2 5V ~ 3 c ~~ ,.,...~ 2 4V N ~ 0529 lOOP ;~1 til"'- "' 25C5006(R24l 2 7V/OV Ill~ iQ ~ . . T <D ,; T 2.8V :7- ~l- ~155364 2 4V/OV ~ttl JB 0 7V ~ ~ ~:'& -2V f-TP3 1 mC544 1 1v ov12 4v o gv HH--1-

;;; ;:i ;)llg ~'"' ;::i ~ g ? c;;1: ~ <D I ..,Jc; RG04 ~;- ~ ~~'"'! g I!!: I ~c"" :;; 1.:.: ::: i::i

rfK!..; ~.; l!!::: C508 .,. _ 27V -·-•::-:24V 5 n. ... ~ ~ ;:r..J:~ . .. ~ ~>g., o •• rn) ol!! _ ~0 471( frT • N ° .. ..... ::: !I!* 0533 "' - "' -

t----1 2 7ov. tll ill~ ~ 7 cs2a !!! r.v ~~9 o. oot ::: '* F502 '* 0 ii! "" iii ___. . 155314 ~7 ~ I I "' ::J - v 115.. 3 ~ ~ l.SFB19- 2411 ~a. I ~N 0532 0V/2 6V :::

j fiW q;~2 5 --- 0 7V fv) ..,1 " 221-P-t-~tMifl-31--t-+-t-t--HH--hf-+t-t-------lO. OI 1011' - · ·"' 6ln o'.toi 25C5006!R24 l l!! ~ !

~:12" "jL~IJ ,;L,tb~ ~J:S~~~ 0 ~ ~ ~ ;.; ~l- 1.1V l!f'C2757T ~~ .., 0.7V ~~ rh I

1 9V 2 5V ~~ ~ lQ - JIB tti rh tti ~25C5~0~K~! R2~4~l----------------~ ti-rrt-t-----------------------~1 ·~8V~-L--~----------------------------------~----------

2.8V

TP7

2.8V

~~~ ~i. ~z. ~~~ ~~ 2!." ~ r · 22n ':::1 ~v

I~ T Tl ~\ 0.7V

ClS36 r'f!Y ~ 25CSOK~~l4l ~"' ~n~

IOOK O 7V

2.6V ~~

n~0::4l

OV/2.9V

TP5

11579 R5 IK II

~ a> ~

K!~

~z !>

tz~ IS ~ ~ -

r- 1- q;~r·'-----------------------------------------

BLANK C513 , C553 , C565 , C658 C625 . C629. C657 R578 ,R577

PCB l!l..AN< CS96, C602, C642, LS21 ~~! · ~~~.R607 ,C666

C70l ~C743 R70I ~R728 L70I~L716 0701~0714 J70I ~J702

BLANK R708,R719 C717 , C738

0. 001

2.7V

ov

-

--

<

• 14V -

rh

75V

ISIIIf1l

I ISIIIFlH

11114094BCFV

"" .... ~3 ~ L®---flKH~II.}---6-_.l!J--1"""@-1 2. 9V ~ ~ . ~ ~ ~' 1~--~~---------------------------------T-T--------T! -::: , ~ ~ .Bv

OV/2.9V

ov

2.7V (2 .1V)

10V (1.3V)

0(99 / R713

1~~~-7K ~g umo

~~:c ~ ~ 10V(1 .3V) :-1 = ~ ... 1 !::if·~W ~ R727 ,~ c o.oo1 1ssai~1i 4.7K ::1 = - -!::i..; ~~g u .,; rh

2.7V (2 .1V)

i§i * t:

> > "-

~..4, ~ ~ ~,

- --> "-N

I"' 53V ~f®

I~ 5F1L

J702 ~ BSQ-9Q-007-1Q-001

~ ~T L N

... ~!> ;~ ~ :'! 7~

1523

10

RS92 IK

CS27

I~ R5ll8 .. 0.3~!1M RS90

] 22K ~'Zs jJ Jill(

0.33/JM · J9K ) ill 16

R5117 94 ~~ ~ ~ 2SK1580

!> .u. ~ RSIS .., ~

; ~ CS24 &I/ 4VT t:7

• J,

RS99

i!!l l.S55 0. 001 ~

0

~·

RF Unit (Lot -13)

TPB Q

9.9V RS91

!> 470

~ rh~

10.3V

37

Parts Layout

liJ lc523l lcs1el IR523I

IR519l

[§] ~

®[i]~ffi m

~[mID

m

(] 0

Side A

Collector

~ Base Emitter

2SC5006 (24) (0536, 537' 538)

1~ 1 Base Emttter

2SC4215Y (OY) (0513) 2SC4617R (BR) (0542)


UMA2N (A2) (0545, 546, 547, 548,

550, 55 1' 552)

BU4094BCFV (0 549, 553)

RF Unit (Lot - 13)

39

RF Unit (Lot -13)

0

EJ

40

ffiJ[i]

[!]I ID

II 1~ 1 II

IC634l IR562l

[]rnJ ~

lcsnl lc5791 lR547l lC574l

lR546l

~~g23 , lR551l lC580l 1!1 1m

J lcs39l

Side B

M~'2

Cathode 1 Anode 2

1SS302 (C3) (0501)

li[l Base Emitter

DTA144EE (16) (0504) 2SC501 0 (83) (0524)

Collector

~ Base Emitter

2SC5006 (24) (0508, 517, 518, 520,

523, 530, 532)

~ ~ Base Emitter

2SC4215Y (OY) (0535)


UMG2N (G2) (0544)

Cathode 1 2

l(r 11 Anode 1 Anode 2

1SS364 (BF) (0502, 503, 529)

GND

Input I GND s Vee I Output

GND

~PC2748T (C1T) (0526)

GND

RF Input I Lo Input

l:c~{l IF Output I PS

Vee

~PC2757T (C1 Y) (0528)

'G:]' Dram Source

3SK318 (YB) (0534)

MB15F02PFV (0541 )

Dratn

s Gate Source

2SK1580 (G13) (0543)

rnn, :;~Dnni •cnL.Il n CJ\cn Ln •L.Ilt.D m .....,ru• -en CDC.J1W

~ti!.::lfi!{;;i5:Q !?eeee~e

,(-,(-,~~(-,(-, """" ~ <.n en "' ocno ...... ru U1 .wrv ...... CD w

~ i

.. .. .. .. :on en en C> ...

""' ...,,-en <.n en"' en-

'"'"'E ~2-n;u "" ..,_ """'

nn en"' U1 en "U1

("> en U1

""

!:j~C:~£:1 ~~~~~ 'b,LJ,/-, ~.....,.....,.....,....., o--rv ... ru .. cnCDw

.., :::

~~~G~g oocnc.nNcn NWOCXIC.J1cn

~m

::

RS45

IOK

100

~~ 0.001

R710

l5K

R70Z

10~

g3:~

0

0 ol-

RSS8

toOt<

R573

4./K

~~~~ o.oo

31 :;;;~~

CS04 RSUO

IQ/6 .-3VT 470

RSS7

100

RSS9

100

RS7Z

100

!!lit ~%

~

\) ..... . '""'! ~ :::: ..... . '""1-

I:::J ..... .

i ~

!l! "'

~m

~ ...lo.

~ ~

~ N. ~

~ c ~

~ ~ l ---...

Parts Layout

~ ·

l@M ~L/)Rill

Bill!

. . . c

[§] [@ 1h4ill~s;tl

0 0

Side A

RF Unit (Lot 14-)

Collector

~ Base Emitter

2SC5006 (24) (0536, 537, 538)

li[l Base Emitter

2SC4215Y (OY) (0513) 2SC4617R (BR) (0542)


UMA2N (A2) (0545, 546, 547, 548,

550, 55 1, 552)

BU4094BCFV (0549, 553)

43

RF Unit (Lot 14- )

44

IC634

Hill

w~ ~ ~m~ ~lciilflj

Side B

AAii2'iT' Cathode 1 Anode 2

1SS302 (C3) (0501)

I iii Base Emitter

DTA144EE (16) (0504) 2SC501 0 (83) (0524)

Collector

~ Base Emitter

2SC5006 (24) (0508, 517, 518, 520,

523, 530, 532)

~ ~ Base Emitter

2SC4215Y (OY) (0535)


UMG2N (G2) (0544)

Anode 1 Anode 2

1SS364 (BF) (0502, 503, 529)

GND Input I GND s Vee I Output

GND

1JPC2748T (C1T) (0526)

GND RF Input I Lo Input

I :c~x: I IF Output \ PS

Vee

1JPC2757T (C1Y) (0528)

8 ' Drain Sourco

3SK318 (YB) (0534)

P1n 16 0 " ~

• '-..Pin 8

'-..Pin 1

MB15F02PFV (0541)

Dram s Gate Source

2SK1580 (G13) (0543)

RF Unit Parts List


••• RF UNIT •••

PCB with Components 07000368 C501 CHIP CAP. 0.1uF 16V B GRM39B104K16PT K22124805 1- B C502 CHIP CAP. 0.1uF 16V 8 GRM39B104K16PT K22124805 1- B C503 CHIP CAP. 0.1uF 16V 8 GRM39B 1 04K 16PT K22124805 1- B C504 CHIP CAP. 0.1uF 16V B GRM39B 1 04K 16PT K22124805 1- 8 C505 CHIP CAP. 0.1uF 16V B GRM39B 1 04K 16PT K22124805 1- B C506 CHIP CAP. 0.1uF 16V B GRM398104K16PT K22124805 1- B C507 CHIP CAP. 220pF 50V CH GRM39CH221 J50PT K22174243 1- 8 C508 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- 8 C509 CHIP CAP. 0.1uF 16V B GRM398104K16PT K22124805 1- A C510 CHIP CAP. 0.1uF 16V B GRM398104K16PT K22124805 1- B C511 CHIP CAP. 0.1uF 16V B GRM398104K16PT K22124805 1- B C512 CHIP CAP. 0.1uF 16V B GRM398104K16PT K22124805 1- 8 C514 CHIP CAP. 56pF 50V CH GRM39CH560J50PT K22174229 1- B C515 CHIP CAP. 68pF 50V CH GRM39CH680J50PT K22174231 1- 8 C516 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- A C517 CHIP CAP. 24pF 50V CH GRM39CH240J50PT K22174220 1- B C518 CHIP CAP. 68pF 50V CH GRM39CH680J50PT K22174231 1- B C519 CHIP CAP 56pF 50V CH GRM39CH560J50PT K22174229 1- 8 C520 CHIP CAP. 10pF 50V CH GRM39CH100D5DPT K22174211 1- B C521 CHIP CAP. 5pF 50V CH GRM39CH050C50PT K22174206 1- B

C522 CHIP CAP. 18pF 50V CH GRM39CH180J50PT K22174217 1- B C523 CHIP CAP. D.001uF 50V B GRM39B 1 02K50PT K22174821 1- A C524 CHIP CAP. 68pF 5DV CH GRM39CH680J5DPT K22174231 1- B C525 CHIP CAP. 18pF 50V CH GRM39CH 180J5DPT K22174217 1- B C526 CHIP CAP. 6pF 50V CH GRM39CH060050PT K22174207 1- B C527 CHIP CAP. 5pF 50V CH GRM39CH050C50PT K22174206 1- B

C528 C HIP CAP. 22pF 50V CH GRM39CH220J50PT K22174219 1- B C529 CHIP CAP. 0.5pF 50V UJ GRM39UJOR5850PT K22174333 1- B C530 CHIP CAP. 9pF 50V CH GRM39CH090050PT K22174210 1- B C531 CHIP CAP. 27pF 50V CH GRM39CH27DJ50PT K221 74221 1- B C532 CHIP CAP. 9pF 50V CH GRM39CH090050PT K22174210 1- B C533 CHIP CAP. 3pF 50V UJ GRM39UJ030850PT K22174337 1- B C534 CHIP CAP. 0.001uF 50V B GRM398 1 02K50PT K22174821 1- 8 C535 CHIP CAP. 1.5pF 50V UJ GRM39UJ1 R5850PT K22174335 1- B C535 CHIP CAP. 6pF 50V CH GRM39CHD60050PT K22174207 USA 5- B

C535 CHIP CAP. 6pF 50V CH GRM39CH060050PT K22174207 81 5- B

C535 CHIP CAP. 6pF 50V CH GRM39CH060D50PT K22174207 82 5- B C536 CHIP CAP. 10pF 50V CH GRM39CH1 OOD50PT K22174211 1- B C536 CHIP CAP. 39pF 50V CH GRM39CH390J5DPT K22174225 USA 5- 8

C536 CHIP CAP. 39pF 50V CH GRM39CH390J50PT K22174225 81 5- B C536 CHIP CAP. 39pF 50V CH GRM39CH390J50PT K22174225 82 5- B

C537 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- B C538 CHIP CAP. 7pF 50V CH GRM39CH070050PT K22174208 USA 1- B

C538 CHIP CAP. 7pF 50V CH GRM39CH070050PT K22174208 81 1- B

C538 CHIP CAP. 7pF 50V CH GRM39CH070050PT K22174208 82 1- B C538 CHIP CAP. 5pF 50V CH GRrvi39CHD50050PT K22174206 USA 5- B C538 CHIP CAP. 5pF 50V CH GRM39CHD50050PT K22174206 81 5- B

C538 CHIP CAP. 5pF 50V CH GRM39CHD5005DPT K22174206 82 5- B

C539 CHIP CAP. 6pF 50V CH GRM39CH060050PT K22174207 1- B

C540 CHIP CAP. 6pF 50V CH GRM39CH060050PT K22174207 1- B C541 CHIP CAP. 22pF 50V CH GRM39CH220J50PT K22174219 1- B C542 CHIP CAP. 10pF 50V CH GRM39CH1 OOD50PT K22174211 1- B

C543 CHIP CAP. 0.01uF 25V 8 GRM39B 1 03K25PT K22144803 1- 8

C544 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- B

C545 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- B C546 CHIP CAP. 6pF 5DV CH GRM39CH060050PT K22174207 1- B

C547 CHIP CAP. 24pF 50V CH GRM39CH240J50PT K22174220 1- B

C548 CHIP CAP. 1.5pF 50V UJ GRM39UJ 1 R5850PT K22174335 1- 8

C549 CHIP CAP. D.001uF 50V B GRM39B 1 02K50PT K22174821 1- B

C550 CHIP CAP. 24pF 50V CH GRM39CH240J50PT K22174220 1- B

C551 CHIP CAP. 5pF 50V CH GRM39CH050C50PT K22174206 1- B C552 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- B

C554 CHIP CAP. 0.001 uF 5DV B GRM398102K50PT K22174821 1- B

C555 CHIP CAP. 6pF 50V CH GRM39CH06005DPT K22174207 1- B

C556 CHIP CAP. 0.001uF 50V 8 GRM398102K5DPT K22174821 1- A

45

RFUnit

REF. DESCRIPTION VALUE VNV TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

C557 CHIP CAP. 3.5pF 50V UJ GRM39UJ3R5B50PT K22174338 1- B C558 CHIP CAP. 6pF 50V CH GRM39CH060D50PT K22174207 1- B C559 CHIP CAP. 4pF 50V CH GRM39CH040C50PT K22174205 1- B C560 CHIP CAP. 9pF sov CH GRM39CH090D50PT K22174210 1- B C561 CHIP CAP. SpF sov CH GRM39CH050C50PT K22174206 1- B C562 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- B C563 CHIP CAP. 0.001 uF SOV B GRM39B102K50PT K22174821 1- A C564 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- A C566 CHIP CAP. 3.5pF sov UJ GRM39UJ3R5B50PT K22174338 1- B C567 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- B C568 CHIP CAP. 2pF sov UJ GRM39UJ020B50PT K22174336 1- B C569 CHIP CAP. 3.5pF sov UJ GRM39UJ3R5B50PT K22174338 1- B C570 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- 8 C571 CHIP CAP. 0.001 uF sov 8 GRM39B102K50PT K22174821 1- A C572 CHIP CAP. 100pF sov CH GRM39CH101J50PT K22174235 1- B C573 CHIP CAP. 0.001 uF sov 8 GRM39B102K50PT K22174821 1- 8 C574 CHIP CAP. 100pF sov CH GRM39CH1 01 JSOPT K22174235 1- B C575 CHIP CAP. BpF sov CH GRM39CH080D50PT K22174209 1- B C576 CHIP CAP. 0.001 uF sov 8 GRM39B102K50PT K22174821 1- B C577 CHIP CAP. 7pF sov CH GRM39CH070D50PT K22174208 1- B C578 CHIP CAP. 0.01uF 25V 8 GRM39B103K25PT K22144803 1- B C579 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- 8 C580 CHIP CAP. 100pF sov CH GRM39CH1 01 JSOPT K22174235 1- B C581 CHIP CAP. 0.001 uF sov B GRM39B102K50PT K22174821 1- B C582 CHIP CAP. 12pF sov CH GRM39CH120J50PT K22174213 1- B C583 CHIP CAP. 0.001uF sov B G RM 39B 1 02 KSOPT K22174821 1- B C584 CHIP CAP. 7pF 50V CH GRM39CH070D50PT K22174208 1- A C585 CHIP CAP. 14pF 50V CH GRM39CH140J50PT K22174264 1- A C586 CHIP CAP. 7pF 50V CH GRM39CH070D50PT K22174208 1- A C587 CHIP CAP. 18pF sov CH GRM39CH180J50PT K22174217 1- A C588 CHIP CAP. 0.001uF sov B GRM39B102K50PT K22174821 1- A C589 CHIP CAP. 3pF sov UJ GRM39UJ030B50PT K22174337 1- A C590 CHIP CAP. 0.001uF sov B GRM39B102K50PT K22174821 9- A C591 CHIP CAP. 0.001uF sov B GRM39B102K50PT K22174821 1- B C592 CHIP CAP. 2pF 50V UJ GRM39UJ020B50PT K22174336 1-C593 CHIP CAP. 14pF 50V CH GRM39CH140J50PT K22174264 1- A C593 CHIP CAP. 9pF 50V CH GRM39CH090D50PT K22174210 USA 5- A C593 CHIP CAP. 9pF 50V CH GRM39CH090D50PT K22174210 B1 5- A C593 CHIP CAP. 9pF 50V CH GRM39CH090D50PT K22174210 B2 5- A C594 CHIP CAP. 3pF 50V UJ GRM39UJ030B50PT K22174337 1- A C594 CHIP CAP. 6pF 50V CH GRM39CH060D50PT K22174207 USA 5- A C594 CHIP CAP. 6pF sov CH GRM39CH060D50PT K22174207 B1 5- A C594 CHIP CAP. 6pF sov CH GRM39CH060D50PT K22174207 B2 5- A C595 CHIP CAP. 0.001uF sov B GRM39B 1 02K50PT K22174821 1- A C597 CHIP CAP. 18pF sov CH GRM39CH180J50PT K22174217 1- A C598 CHIP CAP. 10pF sov CH GRM39CH1 OODSOPT K22174211 1- B C599 CHIP CAP. 0.001uF sov B GRM39B 1 02K50PT K22174821 1- A C600 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K22174821 1- A C601 CHIP CAP. 0.1 uF 16V B GRM39B104K16PT K22124805 1- A C603 CHIP TA.CAP. 0.22uF 35V TESVA 1 V224M 1-BR K78160027 1- B C604 CHIP TA.CAP. 10uF 6.3V TEMSVAOJ106M-8R K78080027 1- B C605 CHIP CAP. 0.001uF SOV B GRM39B 1 02K50PT K22174821 1- A C606 CHIP CAP. 10pF sov CH GRM39CH1 OODSOPT K22174211 1- B C607 CHIP CAP. 0.01uF 25V B GRM39B 1 03K25PT K22144803 1- B C608 CHIP CAP. 0.001uF sov B GRM39B 1 02K50PT K22174821 1- B C609 CHIP CAP. 0.01uF 25V B GRM39B 1 03K25PT K22144803 1- B C610 CHIP CAP. 18pF sov CH GRM39CH180J50PT K22174217 1- B C611 CHIP CAP. 0.001uF sov B GRM39B1 02K50PT K22174821 1- B C612 CHIP CAP. 0.01 uF 25V B GRM39B1 03K25PT K22144803 1- B C613 CHIP CAP. 0.01uF 25V B GRM39B103K25PT K22144803 1- B C614 CHIP CAP. 0.001 uF sov B GRM39B1 02K50PT K22174821 1- B C615 CHIP CAP. 0.001 uF sov B GRM39B1 02K50PT K22174821 1- A C616 CHIP CAP. 100pF 50V CH GRM39CH101J50PT K22174235 1- A C617 CHIP CAP. 100pF sov CH GRM39CH101J50PT K22174235 1- A C618 CHIP CAP. 0.01uF 25V B GRM39B1 03K25PT K22144803 1- A C619 CHIP CAP. BpF 50V UJ GRM39UJ080D50PT K2217430B 1- B C620 TRIMMER CAP. 10pF CTZ2S-1 OA-W2-P K91 000256 1- B

46

RF Unit

REF. DESCRIPTION VALUE vrw TOL. MFR'S DESIG VXSTD PIN VERS. LOT. SIDE LAYADR

C620 TRIMMER CAP. 5pF CTZ2S-05A-W2-P K9100026B B- 8

C621 CHIP CAP. 0.001 uF 50V 8 GRM408102K50PT K22170825 1- 8

C622 CHIP CAP. 0.001uF 50V 8 GRM3981 02K50PT K22174B21 1- A C623 CHIP TA.CAP. 10uF 6.3V TEMSVAOJ 1 06M-BR K7BOB0027 1- A C624 CHIP TA.CAP. 6BuF TEMSVB20G686M-8R K78060033 1- A C626 CHIP TA .CAP. 0.33uF 16V TESVSP1 C334M-8R K78120029 1- 8 C627 CHIP TA .CAP. 0.33uF 16V TESVSP1 C334M-8R K78120029 1- 8 C628 CHIP TA.CAP. 0.47uF 35V TEMSVA1V474M-8R K78160029 1- 8 C630 CHIP TA.CAP. 3.3uF 16V TEMSVA 1 C335M-8R K78120021 1- 8 C631 CHIP CAP. 0.1uF 16V 8 GRM398104K16PT K22124805 1- 8

C632 CHIP CAP. 0.1uF 16V 8 GRM398 1 04K16PT K22124805 1- 8

C633 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A

C634 CHIP CAP. 0.001uF 50V 8 GRM3981 02K50PT K22174821 1- 8

C635 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- 8 C636 CHIP CAP. 0.001uF 50V 8 GRM3981 02K50PT K22174821 1- 8 C637 CHIP CAP. 0.001uF 50V 8 GRM3981 02K50PT K22174821 1- 8

C638 CHIP CAP. 5pF 50V CH GRM39CH050C50PT K22174206 1- B

C639 CHIP CAP. 4pF 50V CH GRM39CH040C50PT K22174205 1- 8

C640 CHIP TA.CAP. 100uF 4V TEMSVCOG 107M 12R K78060021 1- A

C64 1 CHIP CAP. 2pF 50V UJ GRM39UJ020850PT K22174336 1- 8

C643 CHIP CAP. 0.01uF 25V 8 GRM39B 1 03K25PT K22144803 1- A

C644 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- A

C645 CHIP CAP. 470pF 50V 8 GRM398471 K50PT K22174832 1- A C646 CHIP CAP. 0.01uF 25V 8 GRM398 1 03K25PT K22144803 1- A C647 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- A C648 CHIP CAP. 82pF 50V CH GRM39CH820J50PT K22174233 1- A C649 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- A C650 CHIP CAP. 0.01 uF 25V 8 GRM398 103K25PT K22 144803 1- A

C652 CHIP CAP. 47pF 50V CH GRM39CH470J50PT K22174227 1- 8 C653 CHIP CAP. 0.001uF 50V 8 GRM39B 1 02K50PT K22 174821 1- 8 C654 CHIP CAP. 10pF 50V CH GRM39CH1 OOD50PT K22174211 1- B

C655 CHIP CAP. 0.01uF 25V 8 GRM39B 1 03K25PT K22144803 1- 8

C656 AL.ELECTRO.CAP. 220uF 4V UZSOG221MCR1G8 K48060006 1- A

C659 CHIP CAP. 0.001uF 50V 8 GRM398 1 02K50PT K22174821 1- 8

C660 CHIP CAP. 0.001uF 50V B GRM39B 1 02K50PT K221 74821 1- 8

C66 1 CHIP TA.CAP. 2.2uF 4V TESVSPOG225M-8R K78060025 1- A

C662 CHIP TA.CAP. 2.2uF 4V TESVSPOG225M-8R K78060025 1- B

C664 CHIP CAP. 0.5pF 50V UJ GRM39UJOR5850PT K22174333 USA 5- 8

C664 CHIP CAP. 0. 5pF 50V UJ GRM39UJOR5850PT K22174333 81 5- B

C664 CHIP CAP. 0.5pF 50V UJ GRM39UJOR5850PT K22174333 82 5- B

C665 CHIP CAP. 0.001uF 50V 8 GRM39B 1 02K50PT K22174821 5- A

C666 CHIP CAP. 0.001uF 50V 8 GRM39B 1 02K50PT K22174821 USA 5- A

C666 CHIP CAP. 0.001uF 50V 8 GRM39B 1 02K50PT K22174821 81 5- A

C666 CHIP CAP. 0.001 uF 50V B GRM39B 1 02K50PT K22174821 82 5- A

C667 CHIP TA.CAP. 2.2uF 4V TESVSPOG225M-8R K78060025 USA -10

F501 SAW FILTER LSF8 19-429-800KO S8100782 1- B F502 SAW FILTER LSF819-248-220KO S8100783 1- 8

F503 CERAMIC FILTER SFECV10.7MA5-Z H3900530 1- 8

J501 CONNECTOR 8NCR-S Z2 S8100788 1-

J502 CONNECTOR 53353-1691 P1091 067 1- A

L501 M.RFC 2.2uH MLF1608A2R2KT L1 690931 1- 8

L502 M.RFC 4.7uH ELJ-FC4R7 JF L1690934 1- B L503 M.RFC 4.7uH ELJ-FC4R7 JF L1690934 1- B L504 M.RFC 4.7uH ELJ-FC4R7 JF L1 690934 1- A

L505 CHIP COIL 0.12uH LQN21 AR 12J04 L1 69062 1 1- B L506 M.RFC 0.068uH ELJ-RE68NJF3 L1690724 1- B L507 CHIP COIL 0.22uH LQN21 AR22J04 L1 690600 1- B L508 M.RFC 0.068uH ELJ-RE68NJF3 L1 690724 1- B L509 CHIP COIL 0.12uH LQN21 AR 12J04 L1 69062 1 1- B L510 M.RFC 0.22uH ELJ-NDR12JF L1 690936 1- B L511 M.RFC 0.022uH ELJ-RE22NJF2 L1 690718 1- B L51 2 CHIP COIL 0.12uH LQN21 AR12J04 L1 690621 1- 8

L513 CHIP COIL 0.1 uH LQN21AR10J04 L1690620 1- 8

L514 CHIP COIL 0.1uH LQN21 AR 1 OJ04 L1690620 1- 8

L515 M.RFC 0.068uH ELJ-RE68NJF3 L1690724 1- 8

L516 M.RFC 0.01 8uH ELJ-RE18NJF2 L1 690717 1- 8


47

RFUnit

REF. DESCRIPTION VALUE VfW TOL. MFR'S DESIG VXSTD P/N VERS. LOT . SIDE LAYADR

L518 M.RFC 0.047uH ELJ-RE47NJF2 L1 690722 1- 8 L519 CHIP COIL 0.22uH LON21AR22J04 L1690600 1- A L520 M.RFC 0.12uH ELJ-NDR12JF L1 690936 1- 8 L520 M.RFC 0.056uH ELJ-ND56NJF L1 690982 USA 5- 8

L520 M.RFC 0.056uH ELJ-ND56NJF L1690982 81 5- B L520 M.RFC 0.056uH ELJ-ND56NJF L1690982 82 5- 8 L521 CHIP COIL 0.0056uH LOG11A5N6SOOT1 L1690749 USA 5- B L521 CHIP COIL 0.0056uH LOG11A5N6SOOT1 L1690749 81 5- 8 L52 1 CHIP COIL 0.0056uH LOG11A5N6SOOT1 L1690749 82 5- 8 L522 M.RFC 0.12uH ELJ-NDR12JF L1690936 1- 8 L522 M.RFC 0.056uH ELJ-ND56NJF L1690982 USA 5- 8 L522 M.RFC 0.056uH ELJ-ND56NJF L1690982 81 5- 8

L522 M.RFC 0.056uH ELJ-ND56NJF L1690982 82 5- 8




L526 M.RFC 0.033uH ELJ-RE33NJF2 L1690720 1- B L527 M.RFC 0.0056uH ELJ-RE5N6JF2 L169071 1 1- 8 L528 CHIP COIL 0.068uH LON21A68NJ04 L1690605 1- 8 L529 M.RFC 0.0056uH ELJ-RE5N6JF2 L1690711 1- 8 L530 M.RFC 0.033uH ELJ-RE33NJF2 L1690720 1- 8


L532 CHIP COIL 0.012uH LOG11A12NJOOT1 L1690753 1- B L533 CHIP COIL 0.012uH LOG11A12NJOOT1 L1690753 1- 8 L534 CHIP COIL 0.012uH LOG11A12NJOOT1 L1690753 1- 8 L535 CHIP COIL 0.012uH LOG1 1A12NJOOT1 L1690753 1- B L536 CHIP COIL 0.015uH LOG11A 15NJOOT1 L1690754 1- 8 L537 CHIP COIL 0.0068uH LOG11A6N8JOOT1 L1690750 1- 8 L538 CHIP COIL 0.0068uH LOG11A6N8JOOT1 L1690750 1- 8


L541 CHIP COIL 0.01uH LOG11A10NJOOT1 L1690752 1- 8 L542 M.RFC 0.068uH ELJ-RE68NJF3 L1690724 1- 8 L543 M.RFC 0.068uH ELJ-RE68NJF3 L1690724 1- 8

L544 CHIP COIL 0.033uH LOG11A33NJOOT1 L1690758 1- 8

L545 M.RFC 10uH ELJ-FC100JF L1 690935 1- B L546 M.RFC 0.022uH LL 1608-FH22NJ L1690865 1- A

L547 M.RFC 0.022uH LL 1608-FH22NJ L1 690865 1- A L548 M.RFC 0.047uH LL 1608-FH47NJ L1690869 1- A L549 CHIP COIL 0.0033uH LON21 A3N3D04 L1690606 1- A L550 CHIP COIL 0.022uH LON21 A22NJ04 L1 690613 1- A L551 M.RFC 0.047uH ELJ-RE47NJF2 L1690722 1- 8 L552 CHIP COIL 0.0082uH LOG11A8N2JOOT1 L1 690751 1- 8

L553 M.RFC 4.7uH ELJ-FC4R7 JF L1690934 1- A

L554 CHIP COIL 0.22uH LON21 AR22J04 L1690600 1- A

L555 M.RFC 0.022uH LL 1608-FH22NJ L1690865 1- B L556 M.RFC 0.047uH LL 1608-FH47NJ L1690869 1- A L557 M.RFC 1uH MLF1608A 1 ROKT L1690930 1- A L558 M.RFC 1uH MLF1608A1 ROKT L1690930 1- A 0501 DIODE 1 SS302 TE85R G2070088 1- 8 c1

0502 DIODE 1 SS364(TE85R) G2070730 1- B c2

0503 DIODE 1 SS364(TE85R) G2070730 1- 8 c2

0504 TRANSISTOR DTA144EE TL G3070074 1- 8 c1 0505 DIODE HVU131TRF G2070462 1- B c2 0506 DIODE HVU131TRF G2070462 1- B c2 0507 DIODE HVU131TRF G2070462 1- 8 c3 0508 TRANSISTOR 2SC5006-T1 G3350068 1- 8 c3

0509 DIODE HVU131TRF G2070462 1- 8 c3

0510 DIODE HVU131TRF G2070462 1- 8 c2 0511 DIODE 1SS314 TPH3 G2070122 1- B c3 0512 DIODE HVU131TRF G2070462 1- A 81

0513 TRANSISTOR 2SC4215Y TE85R G3342 157Y 1- A 82

0514 DIODE HVU1 31TRF G2070462 1- A 83

0515 DIODE 1SS314 TPH3 G2070122 1- B b1

0516 DIODE HVU131TRF G2070462 1- B c1

0517 TRANSISTOR 2SC5006-T1 G3350068 1- B b2

0518 TRANSISTOR 2SC5006-T1 G3350068 1- 8 b2

0519 DIODE HVU1 31TRF G2070462 1- 8 b3

48

RF Unit

REF. DESCRIPTION VALUE VIVV TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

0520 TRANSISTOR 2SC5006-T1 G3350068 1- 8 d3 0521 DIODE HVU131TRF G2070462 1- 8 b1 0522 DIODE HVU131TRF G2070462 1- 8 b3 0523 TRANSISTOR 2SC5006-T1 G3350068 1- 8 b2 0524 TRANSISTOR 2SC5010-T1 G3350108 1- 8 d3 0525 DIODE 1SS314 TPH3 G2070122 1- 8 c2 0526 IC UPC2748T-E3 G1093077 1- 8 c3 0527 DIODE 1SS314 TPH3 G2070122 1- 8 c3 0528 IC UPC2757T-E3 G1093078 1- 8 c3 0529 DIODE 1 SS364(TE85R) G2070730 1- 8 d4 0530 TRANSISTOR 2SC5006-T1 G3350068 1- 8 c5 0531 DIODE 1SS314 TPH3 G2070122 1- 8 c5 0532 TRANSISTOR 2SC5006-T1 G3350068 1- 8 d5 0533 DIODE 1SS314 TPH3 G2070122 1- 8 c5 0534 FET 3SK318 TL G4803188 1- 6 c5 0535 TRANSISTOR 2SC4215Y TE85R G3342157Y 1- 6 b4 0536 TRANSISTOR 2SC5006-T1 G3350068 1- A 84 0537 TRANSISTOR 2SC5006-T1 G3350068 1- A C4 0538 TRANSISTOR 2SC5006-T1 G3350068 1- A C4 0539 DIODE 1 SS371 (TPH3) G2070728 1- A C5 0540 DIODE HVC3508-TRF G2070596 1- A 85 0541 IC M615F02PFV G1093080 1- 6 a4 0542 TRANSISTOR 2SC4617 TL R G3346178R 1- A D4 0543 FET 2SK1580-T1 G3815808 1- 6 a5 0544 TRANSISTOR UMG2N TR G3070088 1- 6 b5 0545 TRANSISTOR UMA2N TR G3070213 1- A 83 0546 TRANSISTOR UMA2N TR G3070213 1- A C3 0547 TRANSISTOR UMA2N TR G3070213 1- A 63 0548 TRANSISTOR UMA2N TR G3070213 1- A 63 0549 IC 6U40946CFV-E1 G1092128 1- A 83 0550 TRANSISTOR UMA2N TR G3070213 1- A C5 0551 TRANSISTOR UMA2N TR G3070213 1- A 63 0552 TRANSISTOR UMA2N TR G3070213 1- A 64 0553 IC 6U40946CFV-E1 G1092128 1- A 84 0554 DIODE HVC3508-TRF G2070596 1- A 65 0555 DIODE HVU131TRF G2070462 1- 8 b3 0556 DIODE HVU131TRF G2070462 1- 6 d2 0557 DIODE HVU131TRF G2070462 1- 6 d3 0558 DIODE HVU131TRF G2070462 1- 6 d2 0559 DIODE HVU131TRF G2070462 1- 6 d3 0560 DIODE 1SS387(TPL3) G2070606 USA 11-0560 DIODE 1SS387(TPL3) G2070606 8 1 9-0560 DIODE 1SS387(TPL3) G2070606 82 9-R501 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 6 R502 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 6 R503 CHIP RES. 39 1/16W 5% RMC1/16 390JATP J24185390 1- 6 R504 CHIP RES. 10 1/16W 5% RMC1/·16 100JATP J24185100 1- 6 R505 CHIP RES. 39 1/16W 5% RMC1/16 390JATP J24185390 1- 8 R506 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 8 R507 CHIP RES. 10k 1/16W 5% RMC 1/16 1 03JATP J24185103 1- 6 R508 CHIP RES. 2.2k 1/16W 5% RMC 1/16 222JATP J24185222 1- 6 R509 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- 6 R510 CHIP RES. 10k 1/16W 5% RMC1 /1 6 103JATP J24185103 1- 8 R511 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- A R512 CHIP RES. 47k 1/16W 5% RMC1 /16 473JATP J24185473 1- 6 R513 CHIP RES. 10k 1/16W 5% RMC1 /16 103JATP J24185103 1- 6

R514 CHIP RES. 470 1/16W 5% RMC1116 471JATP J24185471 1- 6 R515 CHIP RES. 100 1/16W 5% RMC1 /16 101JATP J24185101 1- 6 R516 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A

R517 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- A

R518 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- A R519 CHIP RES. 100k 1/16W 5% RMC 1116 1 04JATP J24185104 1- A R520 CHIP RES. 10k 1/16W 5% RMC1/16 1 03JATP J24185103 1- B

R521 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- B

R522 CHIP RES. 330 1/16W 5% RMC1/16 331 JATP J24185331 1- B

R523 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R524 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- B

49

RF Unit

REF. DESCRIPTION VALUE vrw TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAYADR

R525 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241851 01 1- 8 R526 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R527 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R528 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R529 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R530 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R531 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- A R532 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R533 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R534 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- A R535 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- 8 R536 CHIP RES. 100 1/16W 5% RMC1/16101JATP J24185101 1- 8 R537 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R538 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R539 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- 8 R540 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R541 CHIP RES. 100 1/16W 5% RMC1/16101JATP J24185101 1- 8 R542 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R543 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R544 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R545 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 8 R546 CHIP RES. 10k 1/16W 5% RMC 1/16 1 03JATP J24185103 1- 8 R547 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R548 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R549 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- 8 R550 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R551 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R552 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- 8 R553 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R554 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R555 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 8 R556 CHIP RES. 120k 1/16W 5% RMC1/16 124JATP J24185124 1- 8 R557 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R558 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R559 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R560 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R561 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R562 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R563 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- 8 R564 CHIP RES. 100k 1/10W 5% RMC1/10T 104J J24205104 1- 8 R565 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R566 CHIP RES. 100 1/16W 5% RMCr/16 101JATP J24185101 1- 8 R567 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R568 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R569 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R570 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J24185104 1- A R571 CHIP RES. 470 1/16W 5% RMC1/16 471JATP J24185471 1- A R572 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R573 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R574 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- A R575 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R576 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R579 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- 8 R580 CHIP RES. 470 1/16W 5% RMC1/16 471JATP J24185471 1- 8 R581 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- 8 R582 CHIP RES. 1.5k 1/16W 5% RMC1/16 152JATP J24185152 1- A R583 CHIP RES. 470k 1/16W 5% RMC1/16 474JATP J24185474 1- A R584 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- 8 R584 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 USA 11- 8 R584 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 81 7- 8 R584 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 82 7- 8 R585 CHIP RES. 10 1/16W 5% RMC1/16 100JATP J24185100 1- A R586 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- A R587 CHIP RES. 10k 1/16W 5% RMC1/16103JATP J24185103 1- 8 R588 CHIP RES. 22k 1/16W 5% RMC1/16 223JATP J24185223 1- 8 R589 CHIP RES. 2.21< 1/16W 5% RMC1/16 222JATP J24185222 1- 8 R590 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- 8

50

RF Unit

REF. DESCRIPTION VALUE VIW TOL. MFR'S DESIG VXSTD P/N VERS. LOT. SIDE LAY ADR

R591 CHIP RES. 470 1/16W 5% RMC1/1 6 471JATP J24185471 1- B R592 CHIP RES. 1k 1/16W 5% RMC1/ 16 102JATP J24185102 1- B R593 CHIP RES. 1k 1/16W 5% RMC1/ 16 102JATP J24185102 1- B R594 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J241 851 02 1- B R595 CHIP RES. 1k 1/16W 5% RMC1/16 102JATP J24185102 1- B R596 CHIP RES. 8.2 1/16W 5% RMC1/16 8R2JATP J24185829 1- A R597 CHIP RES. 150 1/16W 5% RMC1/16 151JATP J24185151 1- A R598 CHIP RES. 8.2 1/16W 5% RMC1/16 8R2JATP J24185829 1- A R599 CHIP RES. 4.7k 1/16W 5% RMC1 /16 472JATP J24185472 1- B R600 CHIP RES. 220k 1/16W 5% RMC1 /16 224JATP J24185224 1- B R601 CHIP RES. 220k 1/16W 5% RMC1/ 16 224JATP J24185224 1- B R602 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- B R603 CHIP RES. 470 1/ 16W 5% RMC1/16 471JATP J24185471 1- B R604 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- B R605 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- A R606 CHIP RES. 0 1116W 5% RMC1 /16 OOOJATP J24185000 1- A R608 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- B R609 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- A R610 CHIP RES. 100k 1/16W 5% RMC1 /16 104JATP J24185104 1- A R611 CHIP RES. 47k 1/16W 5% RMC1/ 16 473JATP J24185473 1- A R612 CHIP RES. 33 1/16W 5% RMC1/ 16 330JATP J241 85330 1- A R613 CHIP RES. 470 1/ 16W 5% RMC1/ 16 471JATP J241 8547 1 1- A R614 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R615 CHIP RES. 2.2k 1/16W 5% RMC1/16 222JATP J24185222 1- B R616 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 1- B R617 CHIP RES. 2.2k 1/16W 5% RMC1 /16 222JATP J241 85222 1- B R618 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- B R619 CHIP RES. 150 1/16W 5% RMC1/16 151JATP J24185151 1- B R620 CHIP RES. 0 1/16W 5% RMC1/16 OOOJATP J24185000 1- A R621 CHIP RES. 330 1/16W 5% RMC1/16 331JATP J24185331 1- 8 R622 CHIP RES. 33k 1/16W 5% RMC1/16 333JATP J24185333 1- B R622 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 USA 5- B R622 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 81 5- B R622 CHIP RES. 47k 1/16W 5% RMC1/16 473JATP J24185473 82 5- B R623 CHIP RES. 10 1/16W 5% RMC1/16 100JATP J24185100 1- A R624 CHIP RES. 330k 1/16W 5% RMC1/16 334JATP J24185334 9-R625 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 81 14-R625 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241 85101 82 14-X501 XTAL 15.2MHz 38CHT 15.2MHz S8100779 1- A X501 XTAL 15.2MHz HT-38 15.2MHz S8100883 8- A

RF SHIELD CASE S8001731 1-SHIELD PLATE S8001723 1-

51

RF Unit Note:

52

VCO Unit Parts Layout

Side A

Side B

Emillcr 1

Bil!>C 1 ~ Emillcr 2

G Collector Collector Cathode 1,2

~ ~ [Q Colleclor 1 f Coltoctor 2

k

Ba~c 2 Base Emitter Base Emitter Anode 1 Anode 2

IJPAB11T (XY) 25C5006 (24) DTC144EE (26) 155364 (BF) (0702, 709) (0711) (0704, 710) (0701)

25C5010 (83) (0703, 705)

53

VCO Unit Parts List

REF. DESCRIPTION

PCB with Components C701 CHIP CAP. C702 CHIP CAP. C703 CHIP CAP. C704 CHIP CAP. C705 CHIP CAP. C706 CHIP CAP. C707 CHIP CAP. C70B CHIP CAP. C709 CHIP CAP. C710 CHIP CAP. C711 CHIP CAP C712 CHIP CAP. C713 CHIP TA.CAP. C714 CHIP CAP. C716 CHIP CAP. C718 CHIP CAP. C719 CHIP CAP. C720 CHIP CAP. C721 CHIP CAP. C722 CHIP CAP. C723 CHIP CAP. C724 CHIP CAP. C725 CHIP CAP. C726 CHIP CAP. C727 CHIP CAP. C728 CHIP CAP. C729 CHIP CAP. C730 CHIP CAP. C731 CHIP CAP. C732 CHIP CAP. C733 CHIP CAP. C734 CHIP CAP. C735 CHIP CAP. C736 CHIP CAP. C737 CHIP CAP. C739 CHIP CAP. C739 CHIP CAP. C740 CHIP CAP. C741 CHIP CAP. C742 CHIP CAP. C743 CHIP CAP. J701 CONNECTOR J702 CONNECTOR L701 CHIP COIL L702 CHIP COIL L703 M.RFC L704 M.RFC L705 M.RFC L706 M.RFC L707 CHIP COIL L708 CHIP COIL L709 M.RFC L71 0 M.RFC L71 1 M.RFC L7 12 M.RFC L713 M.RFC L714 CHIP COIL L715 CHIP COIL L71 6 CHIP COIL 0701 DIODE 0702 TRANSISTOR 0 703 TRANSISTOR 0 704 TRANSISTOR 0 705 TRANSISTOR 0 706 DIODE

54

VALUE V/W

0.001uF sov 5pF 50V BpF 50V 3pF 50V 0.001uF SOV 3pF 50V 0.001uF sov 3pF sov 1pF sov 0.001uF 50V 1pF 50V 0. 1uF 16V 2.2uF 4V 0.001uF 50V SpF 50V 0.001uF 50V 16pF 50V 15pF 50V 0.001uF 50V 0.001uF sov 7pF sov 15pF sov 10pF 50V 5pF 50V 0.001 uF 50V 0.001 uF 50V 7pF sov 1pF 50V 1pF 50V 0.001uF 50V 1pF 50V 0.001uF 50V 0.1uF 16V 12pF 50V 10pF 50V 9pF 50V 11pF 50V 0.001uF 50V 0.001uF 50V 0.001uF 50V 2pF 50V

0.0 12uH 0.012uH 0.047uH 0.022uH 1uH 1uH 0.0033uH 0.006BuH

0.022uH 0.022uH 0.047uH 0.033uH 1uH 0.006BuH 0.0068uH 0.0047uH

TOL. MFR'S DESIG YAESU PIN VERS. LOT . SIDE LAYADR

••• VCO UNIT •••

07000308 B GRM3981 02K50PT K22174821 1- A CH GRM39CH050C50PT K22174206 1- A CH GRM39CHOBOD50PT K22174209 1- A UJ GRM39UJ030850PT K22174337 1- A B GRM3981 02K50PT K22174821 1- A UJ GRM39UJ030850PT K22174337 1- A B GRM398 1 02K50PT K22174821 1- A UJ GRM39UJ030850PT K22174337 1- A UJ GRM39UJ01 0850PT K22174334 1- A B GRM398102K50PT K22174821 1- A UJ GRM39UJ01 0850PT K22174334 1- A B GRM3981 04K16PT K22124805 1- A

TESVSPOG225M-BR K78060025 1- A B GRM398 1 02K50PT K22174821 1- A CH GRM39CH050C50PT K22174206 1- A B GRM398 1 02K50PT K22174821 1- A CH GRM39CH160J50PT K22174216 1- A CH GRM39CH150J50PT K22174215 1- A B GRM398102K50PT K22174821 1- A B GRM398102K50PT K22174821 1- A CH GRM39CH070D50PT K22174208 1- A CH GRM39CH150J50PT K22174215 1- A CH GRM39CH1 OOD50PT K22174211 1- A CH GRM39CH050C50PT K22174206 1- A B GRM398102K50PT K22174821 1- A B GRM398102K50PT K22174821 1- A CH GRM39CH070D50PT K22174208 1- A UJ GRM39UJ01 OBSOPT K22174334 1- A UJ GRM39UJ01 OB50PT K22174334 1- A B GRM398 1 02K50PT K22174821 1- A UJ GRM39UJ01 OB50PT K22174334 1- A B GRM398 1 02K50PT K22174821 1- A B GRM398104K16PT K22124805 1- A CH GRM39CH120J50PT K22174213 1- A CH GRM39CH1 OOD50PT K22174211 1- A CH GRM39CH090DSOPT K22174213 -1 A CH GRM39CH11 OJSOPT K22174212 2- A B GRM39B 1 02K50PT K22174821 1- A B GRM39B 1 02K50PT K22174821 1- A 8 GRM39B102K50PT K2217~821 1- A UJ GRM39UJ020B50PT K22174336 1- A

850-90-002-10-001 P0091248 1- A 850-90-007-10-001 P0091249 1- A LOG 11 A 12NJOOT1 L1690753 1- A LOG 11 A 12NJOOT1 L1690753 1- A LL 1608-FH47NJ L1690869 1- A LL 1608-FH22NJ L1690865 1- A MLF160BA 1 ROKT L1690930 1- A MLF1608A 1 ROKT L1690930 1- A LOP21A3N3C14 L1690928 1- A LOP21A6NBC14 L1690929 1- A LL 1608-FH22NJ L1690865 1- A LL 1608-FH22NJ L1690865 1- A LL 1608-FH4 7NJ L1690869 1- A ELJ-RE33NJF2 L1690720 1- A MLF1608A 1 ROKT L1690930 1- A LON21A6NBD04 L1690607 1- A LON21 A6N8D04 L1690607 1- A LOG11A4N7SOOT1 L1690748 1- A 1 SS364(TE85R) G2070730 1- A UPA811T-T1 G3070253 1- A 2SC5010-T1 G3350108 1- A DTC144EE TL G3070075 1- A 2SC5010-T1 G3350108 1- A HVE355TRF G2070738 1- A

VCO Unit

REF. DESCRIPTION VALUE VIW TOL. MFR'S DESIG YAESU P/N VERS. LOT. SIDE LAY ADR

0707 DIODE HVE355TRF G2070738 1- A 0708 DIODE 1 SS371 (TPH3) G2070728 1- A 0709 TRANSISTOR UPA811T-T1 G3070253 1- A 0710 TRANSISTOR DTC144EE TL G3070075 1- A 0711 TRANSISTOR 2SC5006-T1 G3350068 1- A 0712 DIODE HVC350B-TRF G2070596 1- A 0713 DIODE HVC350B-TRF G2070596 1- A 0714 DIODE 1 SS371 (TPH3) G2070728 1- A R701 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J241 85103 1- A R702 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- A R703 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241 85101 1- A R704 CHIP RES. 150k 1/16W 5% RMC1/16 154JATP J241 85154 1- A R705 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241851 01 1- A R706 CHIP RES. 150k 1/16W 5% RMC 1/16 154JATP J24185154 1- A R707 CHIP RES. 100k 1/16W 5% RMC1/16 104JATP J241 85104 1- A R709 CHIP RES. 1Bk 1/16W 5% RMC1/16 183JATP J24185183 1- A R710 CHIP RES. 15k 1/16W 5% RMC1/16 153JATP J24185153 1- A R711 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R712 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R713 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R714 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R715 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R716 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- A R717 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241851 01 1- A R718 CHIP RES. 150k 1/16W 5% RMC1/16 154JATP J241 85154 1- A R720 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J241851 01 1- A R721 CHIP RES. 150k 1/16W 5% RMC1/16 154JATP J24185154 1- A R722 CHIP RES. 470 1/16W 5% RMC1/16 471JATP J24185471 1- A R723 CHIP RES. 3.9k 1/16W 5% RMC1/16 392JATP J24185392 1- A R724 CHIP RES. 10k 1/16W 5% RMC1/16 103JATP J24185103 1- A R725 CHIP RES. 100 1/16W 5% RMC1/16 101JATP J24185101 1- A R726 CHIP RES . 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R727 CHIP RES. 4.7k 1/16W 5% RMC1/16 472JATP J24185472 1- A R728 CHIP RES. 270 1/16W 5% RMC1/16 271JATP J24185271 1- A

SHIELD CASE S8001730 1- A

55

VCO Unit Note:

56

SWUnit Parts Layout

5 101

Side A

Side B

Parts List REF. I DESCRIPTION I VALUE I VIW I TOL. I MFR'S DESIG IYAESU PIN I VERS. ILOT.ISIDEILAY ADR

••• SW UNIT··· PCB with Components 07000306

S101 I TACT SWITCH I I I

I SKQGAB I N5090113 I I ~ ~ I I S102 TACT SWITCH SKQGAB N5090113

57

~~YAESU

Copyright 200 1 VERTEX STANDARD CO., LTD. All rights reserved

No portion of this manual may be reproduced without the permission of VERTEX STANDARD CO., LTD.

Printed in Japan.

0104N-BE 11111111111111111111111111111111 11111 111111111111111111 E 1 3 4 2 9 0 0 1

communications receiver vr-500...the vr-500 circuitry includes three modules: (1) the rf unit, (2)...

Documents