defluoridation by bioadsorbents
TRANSCRIPT
![Page 1: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/1.jpg)
1
WELCOME
![Page 2: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/2.jpg)
2
DEFLUORIDATION BY LOW COST BIO-ADSORBENTS
PRESENTED BY, NAYANA.D 11144229
GUIDED BY ,SIVA BALA PASST. PROFESSOR,CECOLLEGE OF ENGINEERING,PATHANAPURAM
![Page 3: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/3.jpg)
CONTENTS3
1. FLUORIDE-ILLEFFECTS,CONTAMINATION IN INDIA
2. METHODS OF DEFLUORIDATION
3. ADSORPTION-ADVANTAGES
4. LOW COST ADSORBENTS
5. CASE STUDY-MORINGA OLEIFERA A NATURAL
BIO-ADSORBENT
![Page 4: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/4.jpg)
FLUORIDE4
Compound form of fluorine(F)
SOURCES OF FLUORIDE 1.Ground water –Fluoride bearing
rocks &industrial discharges 2.Food products 3.Medicaments & cosmetics
![Page 5: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/5.jpg)
The permissible limits of fluoride concentration in drinking water
5
NAME OF ORGANISATION PERMISSIBLE LIMIT
Bureau of Indian standards(BIS) 0.6-1.2 mg/lit
World Health Organisation (WHO) 1-1.5 mg/lit
Indian Council of Medical Research(ICMR)
1 mg/lit
![Page 6: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/6.jpg)
6
FLUORIDE CONTAMINATION IN GROUNDWATER
Excessive fluoride concentration reported in 28 developed and developing countries
India – 19 states are affected by fluoride problem
was first reported in 1937 in the state of U.P
The desert-ridden water scarce state of Rajasthan tops the affected states
![Page 7: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/7.jpg)
7
7
FIG :Fluorosis prevalent states
MOST AFFECTED STATESRAJASTHANGUJARATANDHARA PREDESH
7
![Page 8: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/8.jpg)
FLUORIDE-”A DOUBLE EDGED SWORD”8
ADEQUATE INTAKE prevent tooth decay and cavities
Maintenance of healthy bones
EXCESSIVE INTAKE
Dental fluorosisMuscular –skeletal fluorosisDamages pineal glandAffects reproductive system and intelligenceThyroid disorderNeurological damage
FLUORIDATION DEFLUORIDATION
![Page 9: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/9.jpg)
DEFLUORIDATION
DEFLUORIDATION9
Adjustment of level of fluoride in drinking water to the optimal level
![Page 10: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/10.jpg)
METHODS OF DEFLUORIDATION
10
Precipitation methodsIon exchange processMembrane filtration processNano-filtrationElectro-coagulationAdsorption
![Page 11: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/11.jpg)
1. PRECIPITATION METHODS11
Addition of chemicals (coagulants) and precipitation of soluble salts of fluoride
Limestone,alum,lime,Poly Aluminium chloride,Poly aluminium Hydroxy sulphate
Eg: Nalgonda Technique
Limitations-Time consuming, requires more diligence, large dosage of aluminium sulphate,sludge transfer issue
![Page 12: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/12.jpg)
2.ION EXCHANGE PROCESS12
Materials 1.Bone exchange of carbonate radicals with fluoride 2.Bone char consists of calcium phosphate and carbonate 3.Ion exchange resins anion exchangers-Eg. Polyanion(NCL) cation exchangers-Eg.Carbion,Polystyrene 4.Activated alumina consists of aluminium oxide (Al2O3).
![Page 13: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/13.jpg)
3.MEMBRANE FILTRATION PROCESS 13
Reverse osmosis (RO) the pressure is exerted on one side of the semi-
permeable membrane which forces the water across the membrane leaving the pollutants behind
Electro dialysis the membranes allow the ions to pass but not the
water
![Page 14: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/14.jpg)
4.NANO FILTRATION14
Nano filtration membranes have high retention of charged particles.
Requires less pressure and capitalLimitations- 1.expensive 2.complicated
![Page 15: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/15.jpg)
5.ELECTRO-COAGUlATION15
Utilizes electricity and sacrificial anodes to form the active coagulants
Advantages-less space, no chemical storage, no pH adjustments
Disadvantages-expensive and complicated
![Page 16: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/16.jpg)
LIMITATIONS16
1. High operational cost2. Maintenance cost3. Low fluoride removal capacities4. Lack of selectivity for fluoride5. Undesirable effects on water quality6. Generation of large volumes of sludge7. Complicated procedures involved in the
treatment.
![Page 17: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/17.jpg)
ADSORPTION17
Adsorption is the bond of molecules species from bulk solution for a surface of a solid by physical or chemical forces.
Applications in water treatment1. Removal of taste and odour causing compounds2. Synthetic organic chemicals(SOCs)3. Colour forming organics4. Disinfection by products(DBPs)5. Heavy metals
![Page 18: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/18.jpg)
18
Fig: Various adsorbents used for defluoridation 18
![Page 19: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/19.jpg)
19
3 phases of adsorption of fluoride.
1. diffusion or transport of fluoride ions to the external surface of the adsorbent
2. adsorption of fluoride ions on to particle surfaces
3. the adsorbed fluoride ions probably exchange with the structural elements inside adsorbent particles
![Page 20: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/20.jpg)
ADVANTAGES OF ADSORPTION20
1. High selectivity of adsorbents.
2. Low cost in installation and maintenance thus economic compared to other methods of defluoridation
3. High efficiency, high productivity of fluoride removal and can remove up to 90% of fluoride.
4. Easy post-treatment after adsorption.
5. Adsorption units are simple in their operation and design
![Page 21: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/21.jpg)
Contn.............21
6. Eco-friendly nature
7. Lack of sludge production
8. It is applicable in removal of fluoride even at low concentration.
9. This method is also popular due to wide range of availability of adsorbents.
10. Adsorption technique is efficient and can remove ions over an extensive variety of pH to a lower leftover concentration than precipitation
![Page 22: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/22.jpg)
VARIOUS LOW COST ADSORBENTS
22
Industrial, agricultural wastes ,natural plant products used as adsorbents
![Page 23: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/23.jpg)
23
Name of adsorbent
pH Dosage(g/L)
Contact time(hr)
Removal percentage
Reference
Clay material
2 5 to 10 3 40-50 Ravikumar and Nazeebkhan(2015)
Granular activated carbon and sewage sludge
neutral GAC-4SS-3
3 Poundyl and Sandhya (2015)
Tea ash 6 0.8 1 51.3-77.6 Mondal.et.al.,(2011)
Pumic 7 20 3 74.64 Malakootian et.al.,(2011)
![Page 24: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/24.jpg)
24
Neem leaves 2 10 1 90 Goswami(2015)
Bark of Babool
8 5 8 77.4 Mamdawan
Baggase Dust
6 1-20 5 84.4 Gupta.et.al.,
Rice husk 2-10 10 2 75 Deshmukh et.al(2009)
Citrus limonum(lemon)leaf
2-8 1-10 2.4 70 V.Jomae.et.al(2014)
Devadaru leaf powder
7 7-8 3 77 Bharali &Bhattacharya
![Page 25: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/25.jpg)
25
Eggshell powder 2-6 5 2 94 R Bhavnik&N K
Mondal
Chalk powder 2-7 2 2 86
Maize husk fly ash
2 0.04 2 86 Jadhav A V
Neem stem charcoal
5 .1-.6 3 94 Chakrabarty &Sharma(2012)
![Page 26: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/26.jpg)
26
ADVANTAGES OF LOW COST ADSORBENTS
1. Offers efficiency of 50-96%
2. Cheap and easily available compared to conventional adsorbents
3. Need less maintenance and supervision
4. Used adsorbents can be used as filler material,thus disposed easily and safely.
![Page 27: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/27.jpg)
27
CASE STUDY:DEFLUORIDATION BY MORINGA OLEIFERA-A NATURAL ADSORBENT
![Page 28: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/28.jpg)
28
Powdered seeds
Moringa oleifera seedsMoringa oleifera
plant
![Page 29: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/29.jpg)
EXPERIMENT29
1. Materials used Moringa oleifera seed powder 1 N nitric acid 0.5 N sodium hydroxide
2. Experimental setup and procedureThe fluoride removal studies by adsorption were conducted in 250 ml conical flask using 100 ml of synthetic water sample containing different pH and initial concentrations of fluoride ion. In these conical flasks adsorbent with varied dosage was added. Then the contact period was given for different particle sizes. After giving a required contact time, the contents of the flasks were filtered using Whatmann’s filter paper number 41. The filtrate was used for fluoride ion estimation using SPADNS method. The above procedure was repeated for different pH, contact times, adsorbent doses, particle sizes and different initial fluoride ion concentrations
![Page 30: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/30.jpg)
30
1.Optimum pH
Sl.No pH Acid washed powder
Alkali washed powder
%removal efficiency
% removal efficiency
1 1 39 -2 2 31 313 4 24 374 6 20 415 8 13 49.56 10 12 51
![Page 31: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/31.jpg)
31
2. Optimal contact time
Adsorbent dosage = 2.5 gm/litpH =8
Sr. No. Contact time 600 μ 212 μ
% removal efficiency
%removal efficiency
1 30 39 53
2 60 48 62
3 90 56 68
4 120 61 70
5 150 62 70
![Page 32: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/32.jpg)
3. Optimal adsorbent dosage32
pH = 8Optimum contact time = 2.5 hrs (600µ) = 2 hrs (212 µ)
Sr. No. Absorbent
dose
(mg)
600 μ 212 μ
% removal
efficiency
%removal
efficiency
1 100 47 48
2 200 58 62
3 300 61 67
4 400 68 76
![Page 33: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/33.jpg)
OBSERVATIONS33
1. The alkali treated Moringa Oleifera seed powder was found better than acid treated Moringa Oleifera seed powder for fluoride ion removal.
2. The removal by adsorption increases as the pH value increases.
3. The removal by adsorption was found to be optimum at adsorbent dose of 400 mg/lit.
4. The optimum contact times were 2 hrs and 2.5hrs for 212 μ and 600 μ respectively.
![Page 34: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/34.jpg)
CONCLUSION34
Cost is of major consideration in developing countries like India
Hence adsorption process using low cost adsorbents that are abundant and easily available have been investigated
![Page 35: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/35.jpg)
35
SCOPE OF FUTURE WORK
The present study have to be extended for
1. Variety of other adsorbents2. Different particle size3. Mixture of adsorbents4. Large scale applications
![Page 36: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/36.jpg)
REFERENCE36
1. Suman Mann, Dr.Anubha Mandal, Performance of Low-Cost Adsorbents for the Removal
of fluoride ions – An overview , International Journal of Engineering Science and
Innovative Technology (IJESIT) Volume 3, Issue 3, May 2014
2. Prerna Kumari ,Effective bio-adsorbents for removal of fluoride from water:a
review,International Journal of Advance Research in Science and
Engineering,Vol.No.4,August 2015
3. C M Vivek Vardha and J Karthikeyan ,Removal of fluoride from water using low cost
materials,Fifteenth International Water Technology Conference,2011,Egypt
4. Suman Mann, Dr.Anubha Mandal, Performance of Low-Cost Adsorbents for the Removal
of fluoride ions – An overview, International Journal of Engineering Science and
Innovative Technology (IJESIT) Volume 3, Issue 3, May 2014
5. N. Gandhi, D. Sirisha, K.B. Chandra Shekar and Smita Asthana, Removal Of Fluoride
From Water And Waste Water By Using Low Cost Adsorbents, International Journal of
ChemTech Research CODEN( USA): IJCRGG ISSN : 0974-4290 Vol.4, No.4, pp 1646-
1653, Oct-Dec 2012
![Page 37: DEFLUORIDATION BY BIOADSORBENTS](https://reader036.vdocuments.net/reader036/viewer/2022062503/58f9af2c760da3da068baa61/html5/thumbnails/37.jpg)
37THANK
YOU