denon dnx1500 mix

of 60 /60
SERVICE MANUAL MODEL DN-X1500 DJ MIXER For U.S.A., Canada, Europe, Oceania & Asia model 16-11, YUSHIMA 3-CHOME, BUNKYO-KU, TOKYO 113-0034 JAPAN X-0196V.01 DE/CDM 0401 注 意 サービスをおこなう前に、このサービスマニュアルを 必ずお読みください。本機は、火災、感電、けがなど に対する安全性を確保するために、さまざまな配慮を おこなっており、また法的には「電気用品安全法」に もとづき、所定の許可を得て製造されております。 従ってサービスをおこなう際は、これらの安全性が維 持されるよう、このサービスマニュアルに記載されて いる注意事項を必ずお守りください。 ● 本機の仕様は性能改良のため、予告なく変更すること があります。 ● 補修用性能部品の保有期間は、製造打切後 8年です。 Some illustrations using in this service manual are slightly different from the actual set. Please use this service manual with referring to the operating instructions without fail. For purposes of improvement, specifications and design are subject to change without notice. 修理の際は、必ず取扱説明書を参照の上、作業を行って , ください。 ● 本文中に使用しているイラストは、説明の都合上現物 と多少異なる場合があります。 Ver. 1

Author: gndlee

Post on 03-Apr-2015

481 views

Category:

Documents


6 download

Embed Size (px)

TRANSCRIPT

For U.S.A., Canada, Europe, Oceania & Asia model

SERVICE MANUAL

Ver. 1

MODEL

DN-X1500DJ MIXER

For purposes of improvement, specifications and design are subject to change without notice. 8

Please use this service manual with referring to the operating instructions without fail.

,

Some illustrations using in this service manual are slightly different from the actual set.

16-11, YUSHIMA 3-CHOME, BUNKYO-KU, TOKYO 113-0034 JAPAN

X-0196V.01 DE/CDM 0401

DN-X1500

2

SAFETY PRECAUTIONSThe following check should be performed for the continued protection of the customer and service technician.

LEAKAGE CURRENT CHECKBefore returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check. If the leakage current exceeds 0.5 milliamps, or if the resistance from chassis to either side of the power cord is less than 460 kohms, the unit is defective.

LASER RADIATIONDo not stare into beam or view directly with optical instruments, class 3A laser product.

500V

1M

(1)

(2)

(1) (2)

2

DN-X1500

3

DISASSEMBLY(Follow the procedure below in reverse order when reassembling.)

1. Top Panel Unit(1)Remove 9 screws and pull up Top Panel Unit. (2)Disconnect FFC cable and Connector. (3)Detach Top Panel Unit. Note: Do not pull out aslsnt to prevent FFC cable damage. Do not fail to pull AC cord from wall outlet before disconnect the FFC cable. if AC cord is remained plugged into wall outlet, power is kept supplied in the unit, which may cause danger.

Top Panel Unit

2. Cross Feder Unit(1)Remove 2 screws and pull up Cross Feder Unit. (2)Disconnect Connector.

Cross Feder Unit

Connector Label face

3

DN-X1500

4

3. CH Fader Unit(1)Remove 4 knobs. (2)Remove 4 screws and pull up CH Fader Panel. (3)Remove 2 screws for each CH. (4)Disconnect Connector. (5)Detach CH Fader Unit.

4. Front Panel(1)Pull out the knobs. (2)Remove 8 screws. (3)Pull up Front Panel.

Front Panel

4

DN-X1500

5

SERVICE MODE SPECIFICATION*How the product performs when the operation buttons for com control are pressed (including control input) is described in the table below.

1. POWER ONFunction POWER Description (1)Turns power ON/OFF. (2)Switches power ON when OFF. Enters in the service mode when power on while pressing MIC POST ON/OFF button and EFFECT LOOP ON/OFF but ton. For canceling the service mode, turn power off/on. Displays Service. Refer to CH GAIN VR. Refer to MASTER LEVEL VR. Refer to SAMPER ASSIGN. Refer to CROSSFADER ASSIGN. Display Remarks

Service Mode

2. CH GAIN VRFunction CH LEVEL METER Description (1) When you turn this VR, LED of CH level meter is lit. Display VR position is 0 : LED is not lit. VR position is 10 : All LED is lit. Remarks

3. MASTER LEVEL VRFunction MASTER LEVEL METER Description (1) When you turn this VR, LED of master level meter is lit. Display VR position is 0 : LED is not lit. VR position is 10 : All LED is lit. Remarks

4. (SAMPLER) CROSSFADER ASSIGN switchFunction Description (1) You can select FL display mode. FL mode Display A : FL tube is not lit. B : All FL tube is lit. POST : Displays VR checking or LED checking. Remarks

5

DN-X1500

6

5. SAMPLER ASSIGN switchFunction FADER VR CHECK OFF Description (1)When CROSSFADER ASSIGN switch is set to POST, you can check the fader VR and LED. (1)When selected OFF, it becomes the LED off modde. (1)When selected CH1, it becomes the mode of reading/displaying CH1 fader VR value. (1)When selected CH2, it becomes the mode of reading/displaying CH2 fader VR value. (1)When selected CH3, it becomes the mode of reading/displaying CH3 fader VR value. (1)When selected CH4, it becomes the mode of reading/displaying CH4 fader VR value. (1)When selected MAIN MIC, it becomes the LED on mode. (1)When selected MASTER, it becomes the mode of reading/displaying crossfader VR value. Displays LED OFF . Displays 0 100 . Fader position is 0 : 0 Fader position is 10 : 100 Displays 0 100 . Fader position is 0 : 0 Fader position is 10 : 100 Displays 0 100 . Fader position is 0 : 0 Fader position is 10 : 100 Displays 0 100 . Fader position is 0 : 0 Fader position is 10 : 100 Displays LED ON . Displays . 0 100 Fader position is Left side : 0 Fader position is Right side : 100 Display Remarks Refer to CROSSFAER ASSGIN.

CH1

CH2

CH3

CH4 MAIN MIC MASTER

6. COM VERSION CHECKYou can check the com version at "Preset Functions". Please refer to the Instructions Manual.

6

DN-X1500

7

SEMICONDUCTORSOnly major semiconductors are shown, general semiconductors etc. are omitted to list.

IC'sNote: Abbreviation ahead of IC No. indicates the name of P.W.B., etc.

MN102H74D (IC101)76 75 51 50

100 1 25

26

MN102H74D Terminal FunctionNo. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 Pin Name P50,WAIT P51,_RE P52,_WEL P53,_WEH P60,_CS0 P61,_CS1 P62,_CS2 P63,_CS3 P64,TM0IO,_BREQ P65,TM1IO,_BRACK P66,_WR _WORD P20,A00 P21,A01 P22,A02 P23,A03 Vdd P54,BOSC,SYSCLK Vss XI XO Vdd OSCI OSCO MODE P24,A04 P25,A05 P26,A06 P27,A07 P30,A08 P31,A09 P32,A10 P33,A11 Vdd P34,A12 P35,A13 P36,A14 P37,A15 Symbol _WAIT _RD _WEL _DSP_REQ _CS0 _CS_DSP _HBR _DSP_ACK _BREQ _BRACK _DAC_RST _WORD A00 A01 A02 A03 Vdd RESERVE1 Vss XI XO Vdd OSCI OSCO MODE A04 A05 A06 A07 A08 A09 A10 A11 Vdd A12 A13 A14 A15 Int I/O DET PU I O O O O O O I I O O I A/O A/O A/O A/O O I O I A/O A/O A/O A/O A/O A/O A/O A/O A/O A/O A/O A/O ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON Ext Res Pu H Pu H Pu H - Hi-z Pu H Pu H Pu H - Hi-z Pu Pu L H H H H L Hi-z Hi-z Hi-z Hi-z L H Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Hi-z Ini H Function

HI R/W timing wait signal Read signal Write signal System DSP REQ signal Chip select signal 1st address of Flash ROM: Chip select of expansion port DSP select signal Host Interface System DSP ACK signal Panel ucom control: When DSP boot, system bus - open. 'L': open - When bus open, 'L' output. H Reset of ADC, DAC, and DIT - Select width of data bit bus 'L': 16bit - Address bus - Address bus - Address bus - Address bus - Power supply(+3.3V) H Signal for test - GND(0V) - Not used - Not used - Power supply(+3.3V) - This Need 12MHz for USB communication - Output OSCI Mode set - 'H': Memory expansion/single chip mode - Address bus - Address bus - Address bus - Address bus - Address bus - Address bus - Address bus - Address bus - Power supply(+3.3V) - Address bus - Address bus - Address bus - Address bus

Internal Pull Up is 1090 ( K ), Ave : 30 ( K )

7

DN-X1500Int I/O DET PU A/O A/O A/O A/O O O O O I O O I I I O I I O O O O O O O O O I Ad ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON

8

No. 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 P40,A16 P41,A17 P42,A18

Pin Name

Symbol A16 A17 A18 A19 Vss _CDDEC_LC _CDDEC_LC _DAC_CS _DIT_CS DIT_DIN CLOCK_A DATA_A PLGIN_L PLGIN_R USBMODE Vdd D+ DVss RxD TxD _MONO Vss ATT _STB_CLR CLOCK_B DATA_B Vdd _FPLAY1 _FCUE1 _FPLAY2 _FCUE2 _FPLAY3 _FCUE3 SBD4 SBT4 _NMI _DSP_BPM DSP_COM RESERVE4 MUTE _FPLAY4 _FCUE4 _RESET Vdd D00 D01 D02 D03 D04 D05 D06 D07 Vss D08 D09 D10 D11 D12 D13 D14 D15

Ext Res Hi-z Hi-z Hi-z

Ini -

Function

P43,(TM2IO),A19 Vss P44,(TM3IO),A20 P45,(TM4IO),A21 P46,(TM5IO),A22 P47,_CS0S,(TM6IO),A23 P70,_CS1S,(TM7IO),SBI3 P71,_CS2S,(TM8IO),SBO3 P72,_CS3S,(TM9IO),SBT3 P80,TM10IOA,WDOUT P81,TM10IOB,STOP USBMODE Vdd D+ DVss P82,SBI2 P83,SBO2,TM11IOA P84,SBT2,TM11IOB Vss P90,AN0,TM12IOA P91,AN1,TM12IOB P92,AN2,TM13IOA P93,AN3,TM13IOB Vdd PA0,SBI1,AN4 PA1,SBO1,AN5,SDA1 PA2,SBT1,AN6,SCL1 PA3,SBI0,AN7 PA4,SBO0,SDA0 PA5,SBT0,SCL0 TEST1 TEST2 _NMI PB0,_IRQ0 PB1,_IRQ1 PB2,_IRQ2 PB3,_IRQ3 PB4,_IRQ4 PB5,_IRQ5 _RST Vdd P00,D00 P01,D01 P02,D02 P03,D03 P04,D04 P05,D05 P06,D06 P07,D07 Vss P010,D08,(TM2IO) P011,D09,(TM3IO) P012,D10,(TM4IO) P013,D11,(TM5IO) P014,D12,(TM6IO) P015,D13,(TM7IO) P016,D14,(TM8IO) P017,D15,(TM9IO)

Pu H - Hi-z - Hi-z - Hi-z Pd L - Hi-z Pd Pu Pu Pu L Hi-z H H -

Pu H Pu H - Hi-z Pd L

Pd L - Hi-z Pu H Pu H Pu H Pu H Pu H Pu H Pu Pu Pu Pu Pu Pu Pu H H H H H H L Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z Hi-Z

I I Lv I Ed O I O O O I Lv D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O D/O -

Address bus Address bus Address bus Address bus - Need pull up to extension for DSP boot control - GND(0V) H Latch to codec1 'L': available H Latch to codec2 'L': available H DAC chip select 'L': available DIT chip select H 'L': available (be pull down in DSP) H DIT data input CODEC(AD1838A)/DAC(PCM1791A)/DIT(AK4103) L data output clock signal CODEC(AD1838A)/DAC(PCM1791A)/DIT(AK4103) L data signal Lch SEND/RETURN connection status H 'H': connect Rch SEND/RETURN connection status H 'H': connect - USB mode selectable terminal, connect to GND - Power supply(+3.3V) Connect USB terminal D+. 24 resistance is - connected in series. Connect USB terminal D-. 24 resistance is - connected in series. - GND(0V) - 75000bps Need to convert level H 75000bps Need to convert level - MONO/STEREO SW 'L': MONO - GND(0V) - Adjust VR for Master output (BAL/UNBAL) TC94A32/TC9162 ALL STB set to L L 'L': L set , CODEC reset Electric VR(TC94A32)/SelectorTC9162 data output L clock signal L Electric VR(TC94A32)/SelectorTC9162 data signal - Power supply(+3.3V) H Ch1 Fader PLAY output 20msec 'L' pulse H Ch1 Fader CUE output 20msec 'L' pulse H Ch2 Fader PLAY output 20msec 'L' pulse H Ch2 Fader CUE output 20msec 'L' pulse H Ch3 Fader PLAY output 20msec 'L' pulse H Ch3 Fader CUE output 20msec 'L' pulse Pull up 4.7k 10k Connection output for - onboard write of internal form. Pull up 4.7k 10k Connection output for - onboard write of internal form. H - Trigger terminal for BPM counter by DSP - System DSP REQ2 signal - Signal for test H Analog/Digital mute 'H': Mute ON H Ch4 Fader PLAY output 20msec 'L' pulse H Ch4 Fader CUE output 20msec 'L' pulse - Reset signal 'L': Reset - Power supply(+3.3V) - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus - GND(0V) - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus - Data bus

8

DN-X1500TMP86CM47U (IC301)

9

33

23

34

22

TOP VIEW44 12

1TMP86CM47U Terminal Function

11

Pin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

VSS XIN XOUT TEST VDD P21 P22 RESET_ P20 P00 P01 RXD TXD SO P05 SCK P07 P17 P16 P15 P14 P13 P12 P11 P10 AIN0 AIN1 AIN2 AIN3 AIN4 AIN5 AIN6 AIN7 VAREF AVDD AVSS P40 P41 P42 P43 P44 P45 P46 P47

Pin Name Symbol I/O DET Ext Res Ini Function VSS - GND (0V) - Oscillation input 16MHz XIN XOUT - Oscillation output - Fixed to GND TEST VDD - Power (+5.0V) O Pu H Address decode signal 1 ADR1 ADR2 O Pu H Address decode signal 2 - Reset input RESET_ DSPBSY I Pu H - Boot flag (L: during boot) O Pu H Address decode signal 3 ADR3 ADR4 O Pu H Address decode signal 4 I H - Serial receive signal RXD TXD O Pu H H Serial send signal O Pu H H M66005AFP-SDATA FLSD FLCS O Pu H H M66005AFP-CA O Pu H H M66005AFP-CLK FLCLK TEST1 O H Not used O Pd L L M66005AFP reset signal (L: Reset) FLRST DRST O Pd L L DSP reset (L: Reset) O Pu H H System ucom stop signal BREQ LDLCH O Pu H H LED driver latch signal O Pu H Clock for LED driver data sending LDCLK LDDAT1 O Pd L LED driver data 1 LDDAT2 O Pd L LED driver data 2 LDDAT3 O L L L LED driver data 3 KEYIN0 I - Key input 0 (Volume) KEYIN1 I - Key input 1 (Volume) KEYIN2 I - Key input 2 (Volume) KEYIN3 I - Key input 3 (Volume) KEYIN4 I - Key input 4 (Volume) KEYIN5 I - Key input 5 (Volume) KEYIN6 I - Key input 6 (Volume) I - Key input 7 (Volume) KEYIN7 VARFF - Power (+5.0V), Analog ref.V for A/D conversion - Power (+5.0V) AVDD AVSS - GND (0V), Analog GND for A/D conversion I Pu H Key input 8 (Key matrix) KEYIN8 KEYIN9 I Pu H Key input 9 (Key matrix) I Pu H Key input 10 (Key matrix) KEYIN10 KEYIN11 I Pu H Key input 11 (Key matrix) I Pu H Key input 12 (Key matrix) KEYIN12 KEYIN13 I Pu H Key input 13 (Key matrix) I Pu H Key input 14 (Key matrix) KEYIN14 KEYIN15 I Pu H Key input 15 (Key matrix)

9

DN-X1500ADSST-MEL100 (DSP:IC101)14 12 10 8 6 4 2 15 13 11 9 7 5 3 1 A B C D E F G H J K L M N P R

10

TOP VIEW

BOTTOM VIEWADSST-MEL100 Terminal Function

No. A 1 A 2 A 3 A 4 A 5 A 6 A 7 A 8 A 9 A 10 A 11 A 12 A 13 A 14 A 15 No. F 1 F 2 F 3 F 4 F 5 F 6 F 7 F 8 F 9 F 10 F 11 F 12 F 13 F 14 F 15 No. L 1 L 2 L 3 L 4 L 5 L 6 L 7 L 8 L 9 L 10 L 11 L 12 L 13 L 14 L 15

Pin Name NC BMSTR BMS_ SPIDS_ EBOOT LBOOT SCLK2 D3B L0DAT[4] L0ACK L0DAT[2] L1DAT[6] L1CLK L1DAT[2] NC Pin Name FLAG5 FLAG7 FLAG9 FLAG6 VDDINT GND GND GND GND GND VDDINT DATA[37] DATA[40] DATA[38] DATA[36] Pin Name ADDR[19] ADDR[17] ADDR[21] ADDR[2] VDDEXT VDDINT VDDEXT VDDINT VDDEXT VDDINT VDDEXT CAS_ DATA[20] DATA[16] DATA[18]

No. B 1 B 2 B 3 B 4 B 5 B 6 B 7 B 8 B 9 B 10 B 11 B 12 B 13 B 14 B 15 No. G 1 G 2 G 3 G 4 G 5 G 6 G 7 G 8 G 9 G 10 G 11 G 12 G 13 G 14 G 15 No. M 1 M 2 M 3 M 4 M 5 M 6 M 7 M 8 M 9 M 10 M 11 M 12 M 13 M 14 M 15

Pin Name TRST_ TDI RPBA MOSI FS0 SCLK1 D2B D3A L0DAT[7] L0CLK L0DAT[1] L1DAT[4] L1ACK L1DAT[0] RSTOUT_ Pin Name FLAG1 FLAG2 FLAG4 FLAG3 VDDEXT GND GND GND GND GND VDDEXT DATA[34] DATA[35] DATA[33] DATA[32] Pin Name ADDR[16] ADDR[12] ADDR[18] ADDR[6] ADDR[0] MS1 BR6 VDDEXT WR SDA10 RAS_ ACK DATA[17] DMAG2 DMAG1

No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 No. H 1 H 2 H 3 H 4 H 5 H 6 H 7 H 8 H 9 H 10 H 11 H 12 H 13 H 14 H 15 No. N 1 N 2 N 3 N 4 N 5 N 6 N 7 N 8 N 9 N 10 N 11 N 12 N 13 N 14 N 15 C C C C C C C C C C C C C C C

Pin Name TMS EMU_ GND SPICLK D0B D1A D2A FS2 FS3 L0DAT[6] L1DAT[7] L1DAT[3] L1DAT[1] DATA[45] DATA[47] Pin Name FLAG0 IRQ0_ VDDINT IRQ1_ VDDINT GND GND GND GND GND VDDINT DATA[29] DATA[28] DATA[30] DATA[31] Pin Name ADDR[14] ADDR[15] ADDR[10] ADDR[5] ADDR[1] MS0 BR5 BR2 BRST SDCKE CS_ CLK_CFG1 CLK_CFG0 AVDD DMAR1

No. D 1 D 2 D 3 D 4 D 5 D 6 D 7 D 8 D 9 D 10 D 11 D 12 D 13 D 14 D 15 No. J 1 J 2 J 3 J 4 J 5 J 6 J 7 J 8 J 9 J 10 J 11 J 12 J 13 J 14 J 15 No. P 1 P 2 P 3 P 4 P 5 P 6 P 7 P 8 P 9 P 10 P 11 P 12 P 13 P 14 P 15

Pin Name TD0 TCK FLAG11 MISO SCLK0 D1B FS1 VDDINT SCLK3 L0DAT[5] L0DAT[3] L1DAT[5] DATA[42] DATA[46] DATA[44] Pin Name IRQ2_ ID1 ID2 ID0 VDDEXT GND GND GND GND GND VDDEXT DATA[26] DATA[24] DATA[25] DATA[27] Pin Name ADDR[13] ADDR[9] ADDR[8] ADDR[4] MS2 SBTS_ BR4 BR1 SDCLK1 SDCLK0 REDY CLKIN DQM AVSS DMAR2

No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 No. K 1 K 2 K 3 K 4 K 5 K 6 K 7 K 8 K 9 K 10 K 11 K 12 K 13 K 14 K 15 No. R 1 R 2 R 3 R 4 R 5 R 6 R 7 R 8 R 9 R 10 R 11 R 12 R 13 R 14 R 15 E E E E E E E E E E E E E E E

Pin Name FLAG10 RESET_ FLAG8 D0A VDDEXT VDDINT VDDEXT VDDINT VDDEXT VDDINT VDDEXT L0DAT[0] DATA[39] DATA[43] DATA[41] Pin Name TIMEXP ADDR[22] ADDR[20] ADDR[23] VDDINT GND GND GND GND GND VDDINT DATA[22] DATA[19] DATA[21] DATA[23] Pin Name NC ADDR[11] ADDR[7] ADDR[3] MS3 PA BR3 RD CLKOUT HBR HBG CLKDBL XTAL SDWE_ NC

10

DN-X1500128M-SDRAM (DSP:IC102)

11

VDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 NC VDD DQM0 WE# CAS# RAS# CS# A11 BA0 BA1 A10 A0 A1 A2 DQM2 VDD NC DQ16 VSSQ DQ17 DQ18 VDDQ DQ19 DQ20 VSSQ DQ21 DQ22 VDDQ DQ23 VDD

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43

86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44

VSS DQ15 VSSQ DQ14 DQ13 VDDQ DQ12 DQ11 VSSQ DQ10 DQ9 VDDQ DQ8 NC VSS DQM1 NC NC CLK CKE A9 A8 A7 A6 A5 A4 A3 DQM3 VSS NC DQ31 VDDQ DQ30 DQ29 VSSQ DQ28 DQ27 VDDQ DQ26 DQ25 VSSQ DQ24 VSS

Note: The # symbol indicates signal is active LOW.

Block Diagram

CKE

CLK CS#WE#CONTROL LOGIC

COMMAND DECODE

CAS# RAS#

BANK3 BANK2

BANK1BANK0

MODE REGISTER

REFRESH 12 COUNTER

12 12

ROWADDRESS MUX

12

BANK0 ROWADDRESS LATCH & DECODER

4096

BANK0 MEMORY ARRAY (4,096 x 256 x 32)

4

4

DQM0 DQM3

SENSE AMPLIFIERS32

8192

DATA OUTPUT REGISTER

2

A0A11, BA0, BA1

14

ADDRESS REGISTER

2

BANK CONTROL LOGIC

I/O GATING DQM MASK LOGIC READ DATA LATCH WRITE DRIVERS

32

DQ0 DQ31

256 (x32)

32

DATA INPUT REGISTER

COLUMN DECODERCOLUMNADDRESS COUNTER/ LATCH

8

8

11

DN-X1500

12

128M-SDRAM Terminal FunctionPin NO.68 67 20 17, 18, 19 16, 71, 28, 59 22, 23 21, 24-27, 60-66 2, 4, 5, 7, 8, 10, 11, 13, 31, 33, 34, 36, 37, 39, 40, 42, 45, 47, 48, 50, 51, 53, 54, 56, 74, 76, 77, 79, 80, 82, 83, 85 14, 30, 57, 69, 70, 73 3, 9, 35, 41, 49, 55, 75, 81 6, 12, 32, 38, 46, 52, 78, 84 1, 15, 29, 43 44, 58, 72, 86 CLK CKE CS# WE#, CAS#, RAS# DQM0-DQM3 BA0, BA1 A0-A11 DQ0-DQ31

Symbol

TypeI I I I I I I I/O Clock Clock Enable Chip Select Command Inputs Input/Outout Mask

Description

Bank Address Input(s) Address Inputs Data I/Os

NC VDDQ VSSQ VDD VSS

Supply Supply Supply Supply

No Connect DQ Power Supply DQ Ground Power Supply: +3.3V 0.3V Ground

12

DN-X1500AD1838A (IC401,501)AAUXDATA3 DSDATA3 DSDATA2 DSDATA1 ASDATA ALRCLK ODVDD ABCLK

13

DGND

52

51

50

49

48

47

MCLK

COUT

CCLK

46

45

44

43

42

41

40

DGND39 DVDD 38 DBCLK 37 DLRCLK 36 DAUXDATA 35 M/S 34 AGND 33 N/C 32 N/C 31 N/C 30 AGND 29 AVDD 28 OUTRP3 27 OUTRN326

DVDD CLATCH CIN

1 2 3

PD/RST 4 AGND OUTLN1 OUTLP1 OUTRN1 OUTRP15 6 7 8 9

AD1838ATOP VIEW (Not to Scale)

AGND 10 AVDD 11 OUTLN2 12 OUTLP2 1314 15 16 17 18 19 20 21 22 23 24 25

OUTRN2

OUTRP2

PIN FUNCTION DESCRIPTIONS

Pin No. 1, 39 2 3 4 5, 10, 16, 24, 30, 34 6, 12, 25 7, 13, 26 8, 14, 27 9, 15, 28 11, 19, 29 17 18 20 21 22 23 3133 35 36 37 38 40, 52 4143 44 45 46 47 48 49 50 51

Mnemonic DVDD CLATCH CIN PD/RST AGND OUTLNx OUTLPx OUTRNx OUTRPx AVDD FILTD FILTR ADCLN ADCLP ADCRN ADCRP N/C M/S DAUXDATA DLRCLK DBCLK DGND DSDATAx AAUXDATA3 ABCLK ALRCLK MCLK ODVDD ASDATA COUT CCLK

Input/ Output I I I O O O O

Description Digital Power Supply. Connect to digital 5 V supply. Latch Input for Control Data. Serial Control Input. Power-Down/Reset. Analog Ground. DACx Left Channel Negative Output. DACx Left Channel Positive Output. DACx Right Channel Negative Output. DACx Right Channel Positive Output. Analog Power Supply. Connect to analog 5 V supply. Filter Capacitor Connection. Recommended 10 F/100 nF. Reference Filter Capacitor Connection. Recommended 10 F/100 nF. ADC Left Channel Negative Input. ADC Left Channel Positive Input. ADC Right Channel Negative Input. ADC Right Channel Positive Input. Not Connected. ADC Master/Slave Select. Auxiliary DAC Output Data. DAC LR Clock. DAC Bit Clock. Digital Ground. DACx Input Data (Left and Right Channels). Auxiliary ADC3 Digital Input. ADC Bit Clock. ADC LR Clock. Master Clock Input. Digital Output Driver Power Supply. ADC Serial Data Output. Output for Control Data. Control Clock Input for Control Data.

I I I I I O I/O I/O I I I/O I/O I O O I

FUNCTIONAL BLOCK DIAGRAMDVDD DVDD ODVDD ALRCLK ABCLK ASDATA CCLK CLATCH CIN COUT MCLK PD/RST M/S AVDD AVDD

AAUXDATA3 DLRCLK DBCLK DSDATA1 DSDATA2 DSDATA3 DAUXDATA SERIAL DATA I/O PORT

OUTLN3

OUTLP3

FILTD

FILTR

ADCLN

ADCLP

ADCRN

AGND

AVDD

ADCRP

AGND

CONTROL PORT VOLUME VOLUME VOLUME VOLUME VOLUME

CLOCK OUTLP1 OUTLN1 OUTRP1 OUTRN1 OUTLP2 OUTLN2 OUTRP2 OUTRN2 OUTLP3 OUTLN3 OUTRP3 OUTRN3 FILTD FILTR

DIGITAL FILTER

DAC

DIGITAL FILTER

DAC

ADCLP ADCLN

ADC

DIGITAL FILTER

VOLUME

DIGITAL FILTER

DAC

ADCRP ADCRN

ADC

DIGITAL FILTER

VREF

AD1838A

DGND DGND AGND AGND AGND AGND

13

DN-X1500AK4103A (IC502) Block DiagramTRANS MCLK CKS0 CKS1 DIF2 DIF1 DIF0 VDD VSS BLS

14

V1 TRANS PDN MCLK SDTI BICK LRCK FS0/CSN FS1/CDTI FS2/CCLK FS3/CDTO C1

1 2 3 4 5 6 7 8 9 10 11 12

24 23 22 21 20

U1 DIF2 DIF1BICK

DIF0 TXP

LRCK SDTI

Audio Serial Interface

Prescaler

C1

Top View

19 18 17 16 15 14 13

TXN VSS VDD CKS1 CKS0 BLS ANS

RS422 Line Driver

U1 V1 Register

Biphase Encoder

TXP TXN

FS0 FS1 FS2 FS3 Host Serial Interface CRCC Generator

MUX

CDTI

CDTO

CCLK

CSN

AK4103A PIN/FUNCTIONNo. 1 2 3 Pin Name V1 TRANS PDN I/O I I I Description Validity Bit Input Pin Audio Routing Mode (Transparent Mode) Pin at Synchronous mode 0: Normal mode, 1: Audio routing mode (transparent mode) Power Down & Reset Pin (Pull-up Pin) When L, the AK4103A is powered-down, TXP/N pins are L and the control registers are reset to default values. Master Clock Input Pin Audio Serial Data Input Pin Audio Serial Data Clock Input/Output Pin Serial Clock for SDTI pin which can be configured as an output based on the DIF2-0 inputs. Input/Output Channel Clock Pin Indicates left or right channel, and can be configured as an output based on the DIF2-0 inputs. Sampling Frequency Select 0 Pin at Synchronous mode (Pull-down Pin) Host Interface Chip Select Pin at Asynchronous mode (Pull-down Pin) AK4112B Mode Pin at Audio routing mode (Pull-down Pin) 0: Non-AKM receivers mode, 1: AK4112B mode Sampling Frequency Select 1 Pin at Synchronous mode (Pull-down Pin) Host Interface Data Input Pin at Asynchronous mode (Pull-down Pin) Sampling Frequency Select 2 Pin at Synchronous mode (Pull-down Pin) Host Interface Bit Clock Input Pin at Asynchronous mode (Pull-down Pin) Sampling Frequency Select 3 Pin at Synchronous mode (Pull-down Pin) Host Interface Data Output Pin at Asynchronous mode (Pull-down Pin) Channel Status Bit Input Pin Asynchronous/Synchronous Mode Select Pin (Pull-up Pin) 0: Asynchronous mode, 1: Synchronous mode Block Start Input/Output Pin (Pull-down Pin) In normal mode, the channel status block output is H for the first four bytes. In audio routing mode, the pin is configured as an input. When PDN pin = L, BLS pin goes H at Normal mode. Clock Mode Select 0 Pin (Pull-up Pin) Clock Mode Select 1 Pin (Pull-down Pin) Power Supply Pin, 4.75V5.25V Ground Pin, 0V Negative Differential Output Pin Positive Differential Output Pin Audio Serial Interface Select 0 Pin (Pull-down Pin) Audio Serial Interface Select 1 Pin (Pull-down Pin) Audio Serial Interface Select 2 Pin (Pull-down Pin) User Data Bit Input Pin for Channel 1 (Pull-down Pin)

4 5 6

MCLK SDTI BICK

I I I/O

7

LRCK

I/O

8

FS0 CSN AKMODE FS1 CDTI FS2 CCLK FS3 CDTO C1 ANS BLS

I I I I I I I I O I I I/O

9 10 11 12 13 14

15 CKS0 I 16 CKS1 I 17 VDD 18 VSS 19 TXN O 20 TXP O 21 DIF0 I 22 DIF1 I 23 DIF2 I 24 U1 I Notes: 1. Internal pull-up and pull-down resistors are connected on-chip. The value of the resistors is 43k (typ). 2. All input pins except internal pull-down/pull-up pins should not be left floating.

14

PDN

ANS

DN-X1500 PCM1791A (IC402)FUNCTIONAL BLOCK DIAGRAM(TOP VIEW)LRCK BCK Current Segment DAC and I/V Buffer 8 Oversampling Digital Filter and Function Control

15

LRCK BCK DATA MUTE SCK RST VDD DGND AGNDF VCCR AGNDR VOUTR VOUTR+ VCOM

1 2 3 4 5 6 7 8 9 10 11 12 13 14

28 27 26 25 24 23 22 21 20 19 18 17 16 15

MS MC MDI MDO MSEL ZEROL ZEROR VCCF VCCL AGNDL VOUTL VOUTL+ AGNDC VCCC

DATA

Audio Data Input I/F

VOUTL VOUTL+

D/S and Filter Advanced Segment DAC Modulator Bias and Vref VCOM

MUTE RST MSEL

MDO MDI MC MS Function Control I/F Current Segment DAC and I/V Buffer VOUTR+ VOUTR

ZEROL ZEROR

D/S and Filter Zero Detect System Clock Manager Power Supply

SCK

AGNDF

AGNDL

VCCF

AGNDC

AGNDR

DGND

Terminal FunctionsTERMINAL NAME AGNDC AGNDF AGNDL AGNDR BCK DATA DGND LRCK MC MDI MDO MS MSEL MUTE RST SCK VCCC VCCF VCCL VCCR VCOM VDD VOUTL+ VOUTL VOUTR+ VOUTR ZEROL PIN 16 9 19 11 2 3 8 1 27 26 25 28 24 4 6 5 15 21 20 10 14 7 17 18 13 12 23 I/O I I I I I/O O I/O I I I I O O O O O DESCRIPTIONS Analog ground (internal bias and current DAC) Analog ground (DACFF) Analog ground (L-channel I/V) Analog ground (R-channel I/V) Bit clock input. Connected to GND for DSD mode (1) Serial audio data input for normal operation. L-channel audio data input for external DF and DSD modes (1) Digital ground Left and right clock (fS) input for normal operation. WDCK clock input in external DF mode. R-channel audio data for DSD mode (1) Shift clock for function control register (1) Serial data input for function control register (2) Serial data output for function control register (3) Mode control chip select and latch signal (4) I2C/SPI select (1) Analog output mute control for normal operation. R-channel audio data input for external DF mode (1) Reset (1) System clock input. BCK (64 fS) clock input for DSD mode (1) Analog power supply (internal bias and current DAC), 5 V Analog power supply (DACFF), 5 V Analog power supply (L-channel I/V), 5 V Analog power supply (R-channel I/V), 5 V Internal bias decoupling pin Digital power supply, 3.3 V L-channel analog voltage output + L-channel analog voltage output R-channel analog voltage output + R-channel analog voltage output Zero flag for L-channel

ZEROR 22 O Zero flag for R-channel (1) Schmitt-trigger input, 5-V tolerant (2) Schmitt-trigger input and output. 5-V tolerant input. In I2C mode, this pin becomes an open-drain 3-state output; otherwise, this pin is a CMOS output. (3) 3-state output (4) Schmitt-trigger input and output. 5-V tolerant input and CMOS output

15

VCCC

VCCR

VCCL

VDD

DN-X1500 PCM1804 (IC301,305,309,313)VREFL AGNDL VCOML VINL+ VINLFMT0 FMT1 S/M OSR02 3 4 5 6 7 8 9 28 27 26 25 24 23

16

VREFR AGNDR VCOMR VINR+ VINRAGND VCC OVFL OVFR RST SCKI LRCK/DSDBCK BCK/DSDL DATA/DSDR

SCKI VINL+ VINLVCOML AGNDL VREFL VREFR AGNDR VCOMR VINR+ VINR-

CLK Control

OSR0 OSR1 OSR2Decimation Filter (L) HPF

Delta-sigma Modulator (L)

VREFL Serial Output Interface VREFR

TOP VIEW

22 21 20 19 18 17 16 15

S/M FMT0 FMT1 LRCK/ DSDBCK BCK/DSDL DATA/DSDR

OSR1 10 OSR2 11 BYPAS 12 DGND 13 VDD 14

Delta-sigma Modulator (R)

Decimation Filter (R)

HPF

OVFL OVFR BYPAS

Power Supply

RST

VCC AGND

DGND VDD

PCM1804 Terminal FunctionPin No.1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28

Pin NameVREFL AGNDL VCOML VINL+ VINL FMT0 FMT1 S/M OSR0 OSR1 OSR2 BYPAS DGND VDD DATA/DSDR BCK/DSDL LRCK/DSDBCK SCKI RST OVFR OVFL VCC AGND VINR VINR+ VCOMR AGNDR VREFR

I/O I I I I I I I I I O I/O I/O I I O O I I

FunctionL-channel voltage reference output, requires capacitors for decoupling to AGND. Analog ground for VREFL. L-channel analog common mode output. L-channel analog input, positive pin. L-channel analog input, negative pin. Audio data format 0. See TABLE V. * Audio data format 1. See TABLE V. * Master/slave mode selection. See TABLE IV. * Oversampling ratio 0. See TABLE I. TABLE II. * Oversampling ratio 1. See TABLE I. TABLE II. * Oversampling ratio 2. See TABLE I. TABLE II. * HPF bypass control. HIGH: HPF disable, LOW: HPF enable. *** Digital ground. Digital power supply. L-channel and R-channel audio data output in PCM mode. R-channel Audio data output in DSD mode.(DSD output, when DSD mode) Bit clock input/output in PCM mode. L-channel audio data output in DSD mode. *** Sampling clock input/output in PCM and DSD mode. *** System clock input; 128fs, 256fs, 384fs, 512fs or 768fs. ** Reset, power down input, active LOW. * Overflow signal of R-channel in PCM mode. This is available in PCM mode only. Overflow signal of L-channel in PCM mode. This is available in PCM mode only. Analog power supply. Analog ground. R-channel analog input, negative pin. R-channel analog input, positive pin. R-channel analog common mode output. Analog ground for VREFR. R-channel voltage reference output, requires capacitors for decoupling to AGND.

* Schmitt trigger input with internal pull-down (51kW typically), 5V tolerant. ** Schmitt trigger input, 5V tolerant. *** Schmitt trigger input.

SN74LV244APW (IC709, DSP:IC106)1 1OE 1A1 2Y4 1A2 1 2 20 Vcc 19 2OE 18 1Y1 17 2A4 16 1Y2 15 2A3 14 1Y3 13 2A2 12 1Y4 11 2A1 1OE 2 1A1 4 1A2 6 1A3 8 1A4 12 1Y4 2A4 14 1Y3 2A3 17 3 2Y4 16 1Y2 2A2 15 5 2Y3 18 1Y1 2A1 13 7 2Y2 2OE 11 9 2Y1 19

3 4 2Y3 5 1A3 6 2Y2 7 1A4 8

2Y1 9 GND 10

16

DN-X1500 TC94A32F (IC502,505,508,511,513)

17

TC94A32F Terminal FunctionPin No.NC 1 VSS 2Tr im VR 0~+24dB/ 1dB step Tr im VR 0~+24dB/ 1dB step

Pin Name VSS VDD GND L-TVR-REF R-TVR-REF L-TVR-IN R-TVR-IN L-TVR-OUT R-TVR-OUT L-MVR-OUT R-MVR-OUT L-MVR-AGND R-MVR-AGND L-MVR-IN R-MVR-IN CS1

Function

NC 28 27 VDD

2 27 1226 TVR-REF 25 TVR-IN 24 TVR-OUT 23 MVR-OUT 22 MVR-A-GND 21 NC 20 MVR-IN 19 NC 18 CS2 17 STB

TVR-REF 3 TVR-IN 4 TVR-OUT 5 MVR-OUT 6 MVR-A-GND 7 NC 8 MVR-IN 9 NC 10 CS1 11 GND 12

3 26 4 25 5 24 6 23 7 22 9 20 11

Trim volume circuitL/R-TVR-REF L/R-TVR-IN L/R-TVR-OUT 20kohm

Main VR 0~-95dB/ 0.5dB step

Main VR 0~-95dB/ 0.5dB step

Main volume circuitL/R-MVR-OUT L/R-MVR-AGND 50kohm

20kohm L/R-MVR-IN

Chip select code switching inputCS1 CS2 Chip select code L L 0 0 0 H L 1 0 0 L H 0 1 0 H H 1 1 0

CK 13 14 NC 15 NC

16 DATA

18 13 16

CS2 CK DATA

1 1 1 1

Clock input pin for data transfer A-SW control data input pin Strobe input pin for data writing

17 STB 1, 28, 8, 21, NC 10,19, 14,15

BU2152FS (IC305,701,702,703,704)BU2152FS Terninal FunctionPin No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 Pin Name VSS CLK VSS DATA P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 P21 P22 P23 P24 S0 STB CLB VDD I/O I I O O O O O O O O O O O O O O O O O O O O O O O O O I I Function Ground pin Clock signal input Ground pin Ground pin Parallel data output

V C S S P P P P P P P P P P P P D L T 0 24 23 22 21 20 19 18 17 16 15 14 13 D B B

32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17

1 2

3 4 5 6 7 8 9 10 11 12 13 14 16 15

V C V D P P P P P P P P P P P P S L S A 1 2 3 4 5 6 7 8 9 10 11 12 S K S T A

Cascade output Strobe signal input " L " active Clear signal input " L " active Power Supply pin

17

DN-X1500 TC4051BF (IC306,307,705,706,707,708)4 1 6 2 COM 3 7 4 5 5 INH 6 VEE 7 VSS 8 16 V DD 15 2 14 1 13 0

18

12 3 11 A 10 B 9 C

18

DN-X1500 M66005AFP (IC201)D IG D IG D IG D IG D IG D IG D IG D IG D IG D IG D IG D IG R E S E C S C S D A T1 1 1 0 0 9 0 8 0 7 0 6 0 5 0 4 0 3 0 2 0 1 0 0

19

1 2 3 4 5 6 7 8 9 1 0

S E S E S E S E S E S E S E S E S E

1 1 1 2 T 1 3 S 1 4 K 1 5 A 1 6 P I 1 7 P O 1 8 V c c 1 1 9 X out 2 0 X in 2 1 V s s 2 2 G 35 2 3 G 34 2 4 G 33 2 5 G 32 2 6 G 31 2 7 G 30 2 8 G 29 2 9 G 28 3 0 G 27 3 1 V p 3 2

6 4 D 6 3 D 6 2 D 6 1 D 6 0 V 5 9 S 5 8 S 5 7 S 5 6 S 5 5 S 5 4 S 5 3 S 5 2 S 5 1 S 5 0 S 4 9 S 4 8 S 4 7 S 4 6 S 4 5 S 4 4 S 4 3 S 4 2 S 4 1 S 4 0 S 3 9 S 3 8 S 3 7 S 3 6 S 3 5 S 3 4 S 3 3 S

IG IG IG IG c c 2 E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G E G

1 2 1 3 1 4 1 5

D e c o d e r

D is p la y C o d e R e g is te r ( 8 - b it x 1 6 )c o d e w r ite

0 0 0 1 0 2 0 3 0 4 0 5 0 6 0 7 0 8 0 9 1 0 1 1 1 2 1 3 1 4 1 5 1 6 1 7 1 8 1 9 2 0 2 1 2 2 2 3 2 4 2 5 2 6

C G R O M ( 3 5 - b it x 1 6 0 ) S e g m e n t O u tp u t C ir c u it

59 S E G 33 S E G 31 S E G 23 S E G

0 0 2 6 2 7 3 5

C h ip S e le c t In p u t

C S

14 15 16

D e c o d e r

S h ift C lo c k In p u t S C K S e r ia l D a ta In p u t S D A T A

S e r ia l R e c e p tio n C ir c u it C o d e / C o m m a n d C o n tr o l C ir c u itR A M w r ite

S e g m e n t O u tp u t

C G R O M ( 3 5 - b it x 1 6 )

O u tp u t P o rt ( 2 - b it) R e s e t In p u t R E S E T13

18 17

P 0 P 1

O u tp u t P o rt

D is p la y C o n tr o l R e g is te rc o d e s e le c t

12

D IG D IG

0 0 1 1

C lo c k In p u t

X IN

21 20

C lo c k O u tp u t X O U T

C lo c k G e n e r a tio n C ir c u it

D is p la y C o n tr o lle r

D ig it O u tp u t C ir c u it

1

D ig it O u tp u t1 2 1 5

6 4 D IG 6 1 D IG

M66005AFP Terminal FunctionSymbol RESET CS SCK SDATA XIN XOUT Name Reset Input Chip Select Input Shift Clock Input Serial Data Input Clock Input Clock Output Initialzes internal state of M66005. Able to communicate with MCU in "L" mode. Command from MCU will be disregareded in "H" mode. Shifts input data at rise from "L" to "H". Inputs character code or command data needed to display from MSB. Sets oscillation frquency by connecting external resistor and capacitor (maximum oscillation frequency fosc (max)=1MHz). Also feasible to apply external clock. In this case, inject external clock to Xin terminal and open Xout terminal. Connect to digit terminal of VFD. DIG00~DIG15 correspond to the 1st figure to 16th figure respectively. Connect to segment terminal of VFD. For corresponding SEG00~SEG35 to segment terminal of VFD, refer to the figure right. Output port (static operation). Positive power supply terminal for internal logic. Positive power supply terminal for high tension output port. GND terminal. Negative power supply terminal for VFD drive. Function

DIG 00~ Digit Output DIG 15 SEG 00~ Segment Output SEG 35 P0, P1 VCC1 VCC2 Vss Vp

(Forwarding connection of segment output terminal.) in the right figure indicates 1 dot of segment, the figure in terminal number (00~35) to be connected. shows the segment output00 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

19

DN-X1500

20

BA4510F(IC302~316) NJM2068MD(IC317~320) NJM4556AD(IC708)

SN74LV02APW(DSP:IC114)

SN74LV08APW(IC104,DSP:IC115) SN74AHCT08PW (IC107)1A 1 1B 2 1Y 3 2A 4 2B 5 2Y 6 GND 7 14 Vcc 13 4B 12 4A 11 4Y 10 3B 9 3A 8 3Y

1 1A 2 1B 3

14 Vcc 13 4Y 12 4B 11 4A 10 3Y 9 3B 8 3A

A OUTPUT 1 A INPUT 2 A +INPUT 3 V4 1 2

8 V 7 B OUTPUT 6 B INPUT 5 B +INPUT

2Y 4 2A 5 2B 6 GND 7

PQ018EF01SZ (IC106)

NJM7815FA(S)(IC906)

NJM7915FA (IC907)

FRONT VIEW 1. VIN 2. VO 3. GND 4. VC Output GND Input

Output Input GND

1234

BA05T (IC901,902,905)

TC7WU04F (IC403,503)

UPC4570C (IC601,602)

FRONT VIEW

1A 1 3Y 2 2A 3 GND 4

8 Vcc 7 1Y 6 3A 5 2Y

A Output 1 A- Input 2 A+ Input 3 V- 41

8 V+++2

7 B Output 6 B- Input 5 B+ Input

GP1S094HCZ (IC401,402,403,404)2 1 1 Anode 2 Collector 3 Emitter 4 Cathode

3

4

20

DN-X1500

21

FL DISPLAY 16-ST-73GN (FL201)

90

46

1

45

PIN CONNECTION

PIN NO. CONNECTION PIN NO. CONNECTION NOTE 1) 2) 3) 4) 5) 6)

9 8888888888777777777766 0 9876543210987654321098 1 11 NNNN2 1 0 9 8 7 6 5 4 8 2 1 I NNNNNN P P P P G G GG G G G GG G GG G C C C C C C

6666666 7654321 PPPP NNN 3 3 3 3 CCC S 5 4 3

6 0 P 3 2

555 987 PP P 33 2 10 9

5 6 P 2 8 3 5 P 2 7

55555 54444 54321 09876 NNN NNN N NNN CCC CCC P PP P 33334 44444 67890 12345 NNN NN I N NF F CCC CCC P P2 2

111111111122222222223 1 234 567 89012345678901234567890 PPPPPPPPPPPPP 1 111 F F NN3 4 5 6 P PPPP P PP P 1 1 1 1 1 1 1 1 1 1 2 2 2 1 1 P P G GGG1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 0 1 2 F1 , F2 Filament NP No pin NC No connection (NC) pin should be electrically open on the PC board DL Datum Line 1G 16G Grid IC Internal conection (IC) pin should be electrically open on the PC board

3333 1234 P PP P 2 22 2 3 45 6

GRID ASSIGNMENT

1G

2G

3G

4G

5G

6G

7G

8G

1G

3b 3c

2a

1a

3a

2a

1a

16G

15G

14G

13G

12G

11G

10G

1-1 2-1 3-1 4-1 5-1 1-2 2-2 3-2 4-2 5-2 1-3 2-3 3-3 4-3 5-3 1-4 2-4 3-4 4-4 5-4 1-5 2-5 3-5 4-5 5-5 1-6 2-6 3-6 4-6 5-6 d 1-7 2-7 3-7 4-7 5-7 e f g c a b

( 1G , 9G )

( 2G8G, 10G16G )

21

DN-X1500 ANODE CONNECTION

22

1G P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12 P13 P14 P15 P16 P17 P18 P19 P20 P21 P22 P23 P24 P25 P26 P27 P28 P29 P30 P31 P32 P33 P34 P35 P36

3b , 3c 2a 2b 2f 2g 2c 2e 2d 1a 1b 1f 1g 1c 1e 1d

2G 3G 4G 5G 6G 7G 8G 11 11 11 11 11 11 11 21 21 21 21 21 21 21 31 31 31 31 31 31 31 41 41 41 41 41 41 41 51 51 51 51 51 51 51 12 12 12 12 12 12 12 22 22 22 22 22 22 22 32 32 32 32 32 32 32 42 42 42 42 42 42 42 52 52 52 52 52 52 52 13 13 13 13 13 13 13 23 23 23 23 23 23 23 33 33 33 33 33 33 33 43 43 43 43 43 43 43 53 53 53 53 53 53 53 14 14 14 14 14 14 14 24 24 24 24 24 24 24 34 34 34 34 34 34 34 44 44 44 44 44 44 44 54 54 54 54 54 54 54 15 15 15 15 15 15 15 25 25 25 25 25 25 25 35 35 35 35 35 35 35 45 45 45 45 45 45 45 55 55 55 55 55 55 55 16 16 16 16 16 16 16 26 26 26 26 26 26 26 36 36 36 36 36 36 36 46 46 46 46 46 46 46 56 56 56 56 56 56 56 17 17 17 17 17 17 17 27 27 27 27 27 27 27 37 37 37 37 37 37 37 47 47 47 47 47 47 47 57 57 57 57 57 57 57

9G 3a 3b 3f 3g 3c 3e 3d 2a 2b 2f 2g 2c 2e 2d 1a 1b 1f 1g 1c 1e 1d

10G16G 1 1 21 31 41 51 12 22 32 42 52 13 23 33 43 53 14 24 34 44 54 15 25 35 45 55 16 26 36 46 56 17 27 37 47 57

22

PRINTED WIRING BOARDGU-3591 MAIN / POWER P.W.B. UNIT ASSY COMPONENT SIDE

DN-X1500

23

23

DN-X1500

24

GU-3591 MAIN / POWER P.W.B. UNIT ASSY FOIL SIDE

24

DN-X1500

25

GU-3592 P.uCOM / INPUT P.W.B. UNIT ASSY COMPONENT SIDE

25

DN-X1500

26

GU-3592 P.uCOM / INPUT P.W.B. UNIT ASSY FOIL SIDE

26

DN-X1500

27

GU-3593 P.VR P.W.B. UNIT ASSY COMPONENT SIDE

27

DN-X1500

28

GU-3593 P.VR P.W.B. UNIT ASSY FOIL SIDE

28

DN-X1500

29

GU-3594 DSP P.W.B. UNIT ASSY COMPONENT SIDE

GU-3594 DSP P.W.B. UNIT ASSY FOIL SIDE

29

DN-X1500

30

NOTE FOR PARTS LISTl Part indicated with the mark " " are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused. l When ordering of part, clearly indicate "1" and "I" (i) to avoid missupplying. l Ordering part without stating its part number can not be supplied. l Part indicated with the mark " " is not illustrated in the exploded view. l Not including Carbon Film Resister 5%, 1/4W Type in the P.W.Board parts list. (Refer to the Schematic Diagram for those parts.) l Not including Carbon Chip Resister 1/16W Type in the P.W.Board parts list. (Refer to the Schematic Diagram for those parts.) WARNING: have critical characteristics. Parts marked with this symbol Use ONLY replacement parts recommended by the manufacturer. l Resistors Ex.: RN 14K 2E 182 G FR Type Shape Power Resist- Allowable Others and perance error formance: Carbon : Composition : Metal oxide film : Winding : Metal film : Metal mixture 2B 2E 2H 3A 3D 3F 3H : 1/8W : 1/4W : 1/2W : 1W : 2W : 3W : 5W F G J K M : 1% : 2% : 5% : 10% : 20% P NL NB FR F : Pulse-resistant type : Low noise type : Non-burning type : Fuse-resistor : Lead wire forming

5%

1/4W 1/16W

RN

14K

2E

182

G

FR

RD RC RS RW RN RK

RD RC RS RW RN RK

: : : : : :

2B 2E 2H 3A 3D 3F 3H 18 2

: : : : : : :

1/8 1/4 1/2 1 2 3 5

W W W W W W W

F : G : J : K : M:

1% 2% 5% 10% 20%

P NL NB FR F

: : : : :

] Resistance 1 8 2 s s

1800 ohm = 1.8 kohm Indicates number of zeros after effective number. 2-digit effective number.

1800

=1.8k 0

Units: ohm 1s

2 1.2 ohm 1-digit effective number. 2-digit effective number, decimal point indicated by R. 1R 2 1 2 1.2

R

2

s

Units: ohm

R

l Capacitors Ex.: CE 04W 1H 2R2 M BP Type Shape Dielectric Capacity Allowable Others and per- strength error formanceCE CA CS CQ CK CC CP CM CF CH : : : : : : : : : : CE 04W 1H 2R2 M BP

CE : Aluminum foil electrolytic CA : Aluminum solid electrolytic CS : Tantalum electrolytic CQ : Film CK : Ceramic CC CP CM CF CH : Ceramic : Oil : Mica : Metallized : Metallized

0J : 6.3V 1A : 10V 1C : 16V 1E : 25V 1V : 35V 1H 2A 2B 2C 2D 2E 2H 2J : 50V : 100V : 125V : 160V : 200V : 250V : 500V : 630V

F : 1% G : 2% J : 5% K : 10% M : 20% Z : +80% 20% P : +100% 0% C : 0.25pF D : 0.5pF = : Others

HS : High stability type BP : Non-polar type HR : Ripple-resistant type DL : For change and discharge HF : For assuring high requency U : UL part C : CSA part W : UL-CSA type F : Lead wire forming

0J 1A 1C 1E 1V 1H 2A 2B 2C 2D 2E 2H 2J

: : : : : : : : : : : :

6.3 10 16 25 35 50 100 125 160 200 250 500

V V V V V V V V V V V V

1% 2% 5% 10% 20% +80% 20% P : +100% 0% C : 0.25pF D : 0.5pF = : F G J K M Z : : : : : :

HS BP HR DL HF U C W F

: : : : : : : : :

UL CSA UL-CSA

: 630 V

] Capacity (electrolyte only) 2 2 2 2200F s s Indicates number of zeros after effective number. 2-digit effective number. Units: F. 2s

22 2 2 F F 2200F 0 2R 2 1 2 2.2F R

R

s

2

2.2F 1-digit effective number. 2-digit effective number, decimal point indicated by R. 22 2

Units: F. ] Capacity (except electrolyte) 2 2 2 2200pF=0.0022F s s (More than 2) Indicates number of zeros after effective number. 2-digit effective number. Units: pF. 2s

2200pF=0.0022F 0 (0 2 pF 2 )

22

1 (0 2 pF AC

220pF 0 0 1 )

2

s

1

220pF (0 or 1) Indicates number of zeros after effective number. 2-digit effective number.

Units: pF. When the dielectric strength is indicated in AC, "AC" is included after the dieelectric strength value.

30

DN-X1500

31

PARTS LIST OF P.W.B. UNIT ASS'YGU-3591 MAIN / POWER P.W.B. UNIT ASSYRef. No. IC101 IC102 IC103 IC105 IC106 IC107 IC301 IC302-304 IC305 IC306-308 IC309 IC310-312 IC313 IC314-316 IC317,318 IC319-321 IC322,323 IC401 IC402 IC403 IC501 IC502 IC503 IC504-506 IC507 IC701-705 IC706,707 IC708 IC709 IC901,902 IC903,904 IC905 IC906 IC907 TR101 TR102 TR501 TR701-716 TR717 TR718 TR901 D101 D102 D703,704 D705,706 D707,708 D709,710 D711 D901 D902-907 ZD901 ZD902 Part No. 262 3350 009 GEN6591 263 0913 905 262 2801 902 263 1164 009 262 2813 903 262 3069 905 263 0934 900 262 3069 905 263 0934 900 262 3069 905 263 0934 900 262 3069 905 263 0934 900 263 0896 909 263 0934 900 263 0896 909 262 3333 000 262 3332 904 262 1953 903 262 3333 000 262 3334 902 262 1953 903 263 0934 900 263 0896 909 263 0898 907 263 0896 909 263 0995 004 262 2959 906 263 1092 003 263 1048 002 263 1092 003 263 0812 006 263 0561 001 269 0083 901 269 0082 902 273 0460 905 273 0253 918 269 0083 901 269 0082 902 272 0025 907 276 0559 909 276 0560 901 276 0559 909 276 0560 901 276 0559 909 276 0560 901 276 0432 903 276 0742 004 276 0704 903 276 0643 983 276 0762 932 MN102H74DDA 8M FLASH MEMORY(70N) PST600C TP SN74AHCT273PW-EL2 PQ018EF01SZ SN74AHCT08PW-EL2 PCM1804 BA4510F-E2 PCM1804 BA4510F-E2 PCM1804 BA4510F-E2 PCM1804 BA4510F-E2 NJM2068MD-TE1 BA4510F-E2 NJM2068MD-TE1 AD1838AAS PCM1791ADBR TC7WU04F AD1838AAS AK4103AVF TC7WU04F BA4510F-E2 NJM2068MD-TE1 NJM5532MD-TE1 NJM2068MD-TE1 NJM4556AD SN74LV244APW BA05T BA033T BA05T NJM7815FA(S) NJM7915FA DTA114EKT96 DTC114EKT96 KTC2875B-RTK 2SC2878(A/B)TPE2 DTA114EKT96 DTC114EKT96 2SB562(C)TF DAP202KT146 DAN202KT146 DAP202KT146 DAN202KT146 DAP202KT146 DAN202KT146 1SS270A TE (TAPE) D5SBA20 1SR35-400A(T93X) MTZJ5.1A T77 MTZJ33B T77 Part Name SEMICONDUCTORS GROUP

Note: The symbols in the column Remarks indicate the following destinations. E3 : U.S.A., & Canada model E2 : Europe model Remarks New * (262 3226 007)

* * * *

31

DN-X1500Ref. No. RESISTORS GROUP R713,714 R731,732 R805,806 R813,814 R835 R838 VR701 241 2377 918 241 2377 918 244 2052 973 244 2051 961 244 2052 973 244 2055 909 211 0552 019 RD14B2E750JNBST RD14B2E750JNBST RS14B3A561JNBST(S) RS14B3A101JNBST(S) RS14B3A561JNBST(S) RS14B3A910JNBST(S) V09QB103 Part No. Part Name Remarks

32New

CAPACITORS GROUP C101 C102 C103-106 C107 C108 C109 C110 C111 C112 C113-115 C116,117 C118 C119 C120 C121 C122 C123 C124 C125 C128 C129 C130 C131 C132-136 C137-139 C301,302 C303-306 C307,308 C313,314 C315,316 C317,318 C319,320 C321-323 C324 C325 C326 C327,328 C329-332 C333,334 C339,340 C341,342 C343,344 C345,346 C347-349 C350 C351 C352 C353,354 257 0512 903 254 4533 918 257 0512 903 257 0509 929 257 0512 903 254 4213 924 254 4538 900 257 0512 903 257 0506 951 257 0512 903 257 0511 904 257 0512 903 257 0501 901 254 4533 950 257 0511 904 257 0512 903 254 4533 950 257 0512 903 257 0509 929 257 0512 903 254 4213 924 254 6190 906 257 0512 903 254 6190 906 257 0512 903 254 4524 985 257 0506 951 257 0509 929 257 0511 904 254 4538 900 257 0512 903 254 4538 900 257 0509 929 254 4538 900 257 0509 929 254 4538 900 254 4524 985 257 0506 951 257 0509 929 257 0511 904 254 4538 900 257 0512 903 254 4538 900 257 0509 929 254 4538 900 257 0509 929 254 4538 900 254 4524 985 CK73F1E104ZT CE04W0J470MT SMG/RE3 CK73F1E104ZT CK73B1H102KT CK73F1E104ZT CE04W0J470MT (SRA) CE04W1C100MT SMG/RE3 CK73F1E104ZT CC73CH1H101JT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73B1H103KT (1608) CE04W0J471MT SMG/RE3 CK73F1H103ZT CK73F1E104ZT CE04W0J471MT SMG/RE3 CK73F1E104ZT CK73B1H102KT CK73F1E104ZT CE04W0J470MT (SRA) CE04W0J331MT (SRA) CK73F1E104ZT CE04W0J331MT (SRA) CK73F1E104ZT CE04W1H100MT SMG/RE3 CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CE04W1H100MT SMG/RE3 CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CE04W1H100MT SMG/RE3

32

DN-X1500Ref. No. C355-358 C359,360 C365,366 C367,368 C369,370 C371,372 C373-375 C376 C377 C378 C379,380 C381-384 C385,386 C391,392 C393,394 C395,396 C397,398 C399-401 C402 C403 C404 C405,406 C407-410 C411,412 C413,414 C415,416 C417,418 C419,420 C421,422 C423,424 C425,426 C427,428 C429,430 C431-434 C435,436 C437,438 C439,440 C441,442 C443 C444 C445 C446 C447 C448 C449,450 C451,452 C453,454 C455,456 C457,458 C459,460 C461,462 C463,464 C465,466 C467,468 C469,470 C471,472 C473,474 C475,476 C477 C479 C480 Part No. 257 0506 951 257 0509 929 257 0511 904 254 4538 900 257 0512 903 254 4538 900 257 0509 929 254 4538 900 257 0509 929 254 4538 900 254 4524 985 257 0506 951 257 0509 929 257 0511 904 254 4538 900 257 0512 903 254 4538 900 257 0509 929 254 4538 900 257 0509 929 254 4538 900 257 0509 961 257 0507 992 257 0512 903 257 0511 904 257 0507 950 257 0508 933 257 0506 919 257 0506 993 257 0509 990 257 0512 903 257 0511 904 257 0506 951 257 0509 929 257 0511 904 257 0506 977 254 4538 939 257 0506 951 254 4538 900 257 0512 903 254 4538 900 257 0512 903 257 0511 904 254 4524 943 257 0507 950 257 0508 933 257 0506 993 257 0506 919 257 0509 990 254 4524 985 257 0511 904 257 0507 950 257 0508 933 257 0506 993 257 0506 919 257 0509 990 257 0512 903 257 0511 904 257 0509 929 254 4538 900 257 0509 929 CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CE04W1H100MT SMG/RE3 CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H152KT CC73CH1H391JT CK73F1E104ZT CK73F1H103ZT CC73CH1H271JT CC73CH1H561JT CC73CH1H680JT CC73CH1H151JT CK73B1H222KT CK73F1E104ZT CK73F1H103ZT CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CC73CH1H121JT CE04W1C470MT SMG/RE3 CC73CH1H101JT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CK73F1H103ZT CE04W1H010MT SMG/RE3 CC73CH1H271JT CC73CH1H561JT CC73CH1H151JT CC73CH1H680JT CK73B1H222KT CE04W1H100MT SMG/RE3 CK73F1H103ZT CC73CH1H271JT CC73CH1H561JT CC73CH1H151JT CC73CH1H680JT CK73B1H222KT CK73F1E104ZT CK73F1H103ZT CK73B1H102KT CE04W1C100MT SMG/RE3 CK73B1H102KT Part Name Remarks

33New

33

DN-X1500Ref. No. C481 C482 C483 C484 C485,486 C487 C488 C489 C490 C491 C492 C493 C494 C495 C497 C498 C499 C500 C501 C502 C503 C504 C508 C509 C510 C511 C512 C513 C514 C515,516 C517-520 C521,522 C523,524 C525,526 C527,528 C529 C530 C531 C532 C533 C534 C535,536 C537,538 C539,540 C541,542 C543,544 C545,546 C547,548 C553,554 C555,556 C557 C558 C559,560 C561 C562 C563-565 C566-569 C570,571 C574,575 C577,578 C701,702 Part No. 254 4538 900 257 0509 929 254 4538 900 254 4538 913 257 0512 903 254 4538 913 257 0512 903 254 4538 913 257 0509 929 257 0511 904 257 0512 903 254 4536 915 257 0503 967 257 0503 941 257 0512 903 254 4538 939 257 0509 929 254 4192 935 257 0501 901 257 0512 903 254 4538 926 257 0501 901 257 0512 903 254 4538 913 257 0512 903 254 4538 913 257 0509 929 254 4538 913 257 0512 903 257 0506 951 257 0509 929 257 0511 904 257 0506 977 254 4538 939 257 0506 951 254 4538 900 257 0512 903 254 4538 900 257 0512 903 257 0511 904 254 4524 943 257 0507 950 257 0508 933 257 0506 993 257 0506 919 257 0509 990 257 0512 903 257 0511 904 257 0512 903 254 4541 939 254 4538 939 254 4533 918 257 0512 903 254 4541 939 254 4194 946 257 0512 903 257 0511 904 257 0509 990 257 0506 951 257 0506 951 254 4541 939 CK73B1H102KT CE04W1C100MT SMG/RE3 CE04W1C220MT SMG/RE3 CK73F1E104ZT CE04W1C220MT SMG/RE3 CK73F1E104ZT CE04W1C220MT SMG/RE3 CK73B1H102KT CK73F1H103ZT CK73F1E104ZT CE04W1A470MT SMG/RE3 CC73CH1H150JT CC73CH1H120JT CK73F1E104ZT CE04W1C470MT SMG/RE3 CK73B1H102KT CE04W1A101MT (SRA) CK73B1H103KT (1608) CK73F1E104ZT CE04W1C330MT SMG/RE3 CK73B1H103KT (1608) CK73F1E104ZT CE04W1C220MT SMG/RE3 CK73F1E104ZT CE04W1C220MT SMG/RE3 CK73B1H102KT CE04W1C220MT SMG/RE3 CK73F1E104ZT CC73CH1H101JT CK73B1H102KT CK73F1H103ZT CC73CH1H121JT CE04W1C470MT SMG/RE3 CC73CH1H101JT CE04W1C100MT SMG/RE3 CK73F1E104ZT CE04W1C100MT SMG/RE3 CK73F1E104ZT CK73F1H103ZT CE04W1H010MT SMG/RE3 CC73CH1H271JT CC73CH1H561JT CC73CH1H151JT CC73CH1H680JT CK73B1H222KT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CE04W1E470MT SMG/RE3 CE04W1C470MT SMG/RE3 CE04W0J470MT SMG/RE3 CK73F1E104ZT CE04W1E470MT SMG/RE3 CE04W1E470MT (SRA) CK73F1E104ZT CK73F1H103ZT CK73B1H222KT CC73CH1H101JT CC73CH1H101JT CE04W1E470MT SMG/RE3 Part Name CE04W1C100MT SMG/RE3 Remarks

34New

34

DN-X1500Ref. No. C703,704 C705,706 C707,708 C709,710 C711,712 C713,714 C715,716 C717,718 C719,720 C721,722 C723,724 C725,726 C727,728 C729,730 C731,732 C733,734 C735,736 C737,738 C739,740 C741,742 C743,744 C745,746 C747,748 C749,750 C751,752 C753,754 C757,758 C759,760 C763,764 C765 C766 C767 C768 C770 C773 C774-781 C782-793 C798,799 C800 C901,902 C903-907 C908,909 C910,911 C912-915 C916 C917,918 C919 C920,921 C922-927 C928,929 C930 C931 C933 C935-939 C940 C941 C942 C943-945 C946 C947,948 C949,950 Part No. 257 0511 904 257 0504 982 254 4522 958 257 0509 929 254 4541 939 257 0511 904 257 0504 982 254 4522 958 257 0509 929 257 0511 904 257 0503 996 254 4522 958 257 0509 929 257 0511 904 257 0503 996 254 4522 958 257 0509 929 257 0511 904 257 0503 996 254 4522 958 257 0509 929 257 0504 908 257 0511 904 254 4522 958 257 0509 929 257 0506 951 257 0511 904 254 4522 916 257 0506 951 254 4524 943 257 0512 903 254 4524 943 257 0512 903 257 0512 903 257 0512 903 257 0511 904 257 0509 929 247 2018 903 254 4541 955 254 4536 957 257 0512 903 254 4565 708 254 4536 957 257 0512 903 254 4536 931 257 0512 903 254 4538 955 254 4541 955 257 0512 903 254 4650 008 254 4524 985 254 4525 913 254 4540 710 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 254 4536 928 257 0512 903 257 0511 920 CK73F1H103ZT CC73CH1H470JT CE04W1V101MT SMG/RE3 CK73B1H102KT CE04W1E470MT SMG/RE3 CK73F1H103ZT CC73CH1H470JT CE04W1V101MT SMG/RE3 CK73B1H102KT CK73F1H103ZT CC73CH1H200JT CE04W1V101MT SMG/RE3 CK73B1H102KT CK73F1H103ZT CC73CH1H200JT CE04W1V101MT SMG/RE3 CK73B1H102KT CK73F1H103ZT CC73CH1H200JT CE04W1V101MT SMG/RE3 CK73B1H102KT CC73CH1H220JT CK73F1H103ZT CE04W1V101MT SMG/RE3 CK73B1H102KT CC73CH1H101JT CK73F1H103ZT CE04W1V100MT SMG/RE3 CC73CH1H101JT CE04W1H010MT SMG/RE3 CK73F1E104ZT CE04W1H010MT SMG/RE3 CK73F1E104ZT CK73F1E104ZT CK73F1E104ZT CK73F1H103ZT CK73B1H102KT RM73B--0R0KT CE04W1E221MT SMG/RE3 CE04W1A471MT SMG/RE3 CK73F1E104ZT CE04W1C123MC(SMG) CE04W1A471MT SMG/RE3 CK73F1E104ZT CE04W1A221MT SMG/RE3 CK73F1E104ZT CE04W1C221MT SMG/RE3 CE04W1E221MT SMG/RE3 CK73F1E104ZT CE04W1E222MC(KMG) CE04W1H100MT SMG/RE3 CE04W1H470MT SMG/RE3 CE04W1J471MC SMG/RE3 CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CE04W1A101MT SMG/RE3 CK73F1E104ZT CK73F1H473ZT * Part Name Remarks

35New

35

DN-X1500Ref. No. C951-958 Part No. 257 0509 929 CK73B1H102KT Part Name Remarks

36New

OTHER PARTS GROUP AS106 AS901,902 CX041 CX081 CX101 CX121 CY021 CY111 CY301,302 CY351 ! ! F901 F901 F902 FB101,102 FB301-316 FB321,322 FB401-410 FB501-504 FB701,702 FF901 FH901 JK501 JK701 JK702 JK703 JK705 JK706-709 JK710-713 S701 ST101 ST901,902 T501 X101 X401 417 0532 006 417 0476 036 205 0343 045 205 1296 007 205 0275 003 205 0375 026 205 0581 056 205 0375 013 205 1291 002 205 0736 063 206 1089 000 206 1087 057 209 0008 120 235 0130 903 235 0130 903 235 0130 903 235 0130 903 235 0130 903 247 2018 903 202 0040 909 202 0040 909 204 8551 014 205 1255 006 204 8564 001 205 1255 006 205 1295 008 204 8421 005 204 8640 006 212 0443 008 205 0452 017 205 0452 017 231 8063 009 399 0038 901 399 0935 004 RADIATOR RADIATOR 4P CONN.BASE(KR-PH) 8P FFC CON.BASE 10P EH CON. BASE 12P CONN.BASE(KR-PH) 2P VH CONNECTOR BASE 11P CON.BASE(KR-PH) 30P PIN HEADER(9180B 35P FFC CON.BASE FUSE (ET0.8A) FUSE (ET0.4A) JUMPER (L=10) for E3 for E2 * *

CHIP EMIFIL(11A121) CHIP EMIFIL(11A121) CHIP EMIFIL(11A121) CHIP EMIFIL(11A121) CHIP EMIFIL(11A121) RM73B--0R0KT FUSE CLIP (TAPE) FUSE CLIP (TAPE) 1P PIN JACK (OR) XLR OUT (JY-5032A) 6P PIN JACK(FG) XLR OUT (JY-5032A) USB(B) CONNECTOR MINI JACK PHONE JACK(HTJ06404A SLIDE SW(SSAA120400) STYLE PIN STYLE PIN PULSE TRANS CST12.0MTW-TF1 X'TAL(22.5792MHZ) * *

GEN6256-5 209 0008 133 471 3304 015 473 7002 018

FUSE LABEL JUMPER 3X8 CBS-Z 3X8 CBTS (S)-Z (L=7.5)

for E2

36

DN-X1500

37

GU-3592 P.uCOM / INPUT P.W.B. UNIT ASSYRef. No. IC201 IC301 IC302,303 IC305 IC306,307 IC401-408 IC501 IC502 IC503 IC504 IC505 IC506 IC507 IC508 IC509 IC510 IC511 IC512 IC513 IC514 IC601,602 D301-316 LD301,302 LD303 LD304 LD305,306 LD307 LD308 LD309 Part No. 262 3228 908 262 3359 000 262 1708 909 262 3335 901 262 3336 900 263 0896 909 262 2033 000 262 3168 903 263 0898 907 262 2033 000 262 3168 903 263 0898 907 262 2033 000 262 3168 903 263 0898 907 262 2033 000 262 3168 903 263 0898 907 262 3168 903 263 0898 907 262 0864 006 276 0560 901 393 9641 906 393 9640 907 393 9639 905 393 9605 900 393 9640 907 393 9639 905 393 9640 907 M66005AFP TMP86CM47U-5FH5 TC74HC138AF(TP1) BU2152FS TC4051BF NJM2068MD-TE1 AD1838AAS TC94A32F NJM5532MD-TE1 AD1838AAS TC94A32F NJM5532MD-TE1 AD1838AAS TC94A32F NJM5532MD-TE1 AD1838AAS TC94A32F NJM5532MD-TE1 TC94A32F NJM5532MD-TE1 UPC4570C DAN202KT146 SLR-332MC(GRN) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SEL6427EP(TP5) SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 * * * * * * * * * Part Name Remarks New SEMICONDUCTORS GROUP

RESISTORS GROUP VR301 VR302 VR303-305 211 5630 004 211 5629 002 211 5630 004 V1420P12FB103 V1420P12FB103K V1420P12FB103

CAPACITORS GROUP C203 C204 C205 C206 C207 C208 C210 C211 C212 C213,214 C301 C302 C303 C312 C313 C314,315 254 4302 958 257 0512 903 257 0511 920 254 4302 958 257 0512 903 257 0509 929 257 0512 903 254 4302 958 257 0506 951 257 0511 920 254 4302 958 257 0512 903 257 0509 929 257 0512 903 254 4302 958 257 0512 903 CE04W1A470MT(SRE) CK73F1E104ZT CK73F1H473ZT CE04W1A470MT(SRE) CK73F1E104ZT CK73B1H102KT CK73F1E104ZT CE04W1A470MT(SRE) CC73CH1H101JT CK73F1H473ZT CE04W1A470MT(SRE) CK73F1E104ZT CK73B1H102KT CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT

37

DN-X1500Ref. No. C330 C331 C332 C333 C334 C335,336 C337 C338-343 C345,346 C347,348 C351 C352 C401-404 C405,406 C407,408 C409,410 C411,412 C413,414 C415-420 C421,422 C423,424 C425,426 C427-430 C431-436 C437,438 C439,440 C441,442 C443,444 C445,446 C447-452 C453,454 C455,456 C457,458 C459,460 C461,462 C463,464 C465,466 C471 C474 C475 C476 C477 C478 C479 C480 C501,502 C503,504 C505,506 C507,508 C509,510 C511,512 C513-516 C517,518 C519,520 C523,524 C525,526 C527,528 C529,530 C531,532 C533,534 C535-538 Part No. 257 0512 903 254 4302 958 257 0512 903 254 4302 958 257 0511 904 257 0512 903 257 0511 904 257 0512 903 254 4302 958 257 0512 903 257 0511 904 257 0512 903 257 0506 951 257 0509 929 257 0510 921 257 0512 903 254 4524 985 257 0512 903 257 0506 951 257 0509 929 257 0510 921 257 0512 903 254 4524 985 257 0506 951 257 0509 929 257 0510 921 257 0512 903 254 4524 985 257 0512 903 257 0506 951 254 4524 985 257 0512 903 254 4524 985 257 0512 903 254 4524 985 257 0512 903 254 4524 985 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0512 903 254 4524 985 254 4524 998 254 4541 939 257 0512 903 254 4524 985 254 4524 969 257 0502 971 257 0512 903 257 0512 903 254 4524 985 254 4524 998 254 4541 939 257 0512 903 254 4524 985 254 4524 969 CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CE04W1A470MT(SRE) CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CC73CH1H101JT CK73B1H102KT CK73B1H392KT CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CC73CH1H101JT CK73B1H102KT CK73B1H392KT CK73F1E104ZT CE04W1H100MT SMG/RE3 CC73CH1H101JT CK73B1H102KT CK73B1H392KT CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CC73CH1H101JT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H220MT SMG/RE3 CE04W1E470MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H3R3MT SMG/RE3 CC73CH1H5R0CT CK73F1E104ZT CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H220MT SMG/RE3 CE04W1E470MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H3R3MT SMG/RE3 Part Name Remarks

38New

38

DN-X1500Ref. No. C539,540 C541,542 C545,546 C547,548 C549,550 C551,552 C553,554 C555,556 C557-560 C561,562 C563,564 C567,568 C569,570 C571,572 C573,574 C575,576 C577,578 C579-582 C583,584 C585,586 C589,590 C591,592 C593,594 C595-598 C599,600 C601-603 C604 C605 C606,607 C608,609 C610,611 C612,613 C614 C615 C616 C617 C618 C619 C620 C621-624 C625,626 C627,628 C629 C630,631 C632 C801 C802 C803 C804 C851 Part No. 257 0502 971 257 0512 903 257 0512 903 254 4524 985 254 4524 998 254 4541 939 257 0512 903 254 4524 985 254 4524 969 257 0502 971 257 0512 903 257 0512 903 254 4524 985 254 4524 998 254 4541 939 257 0512 903 254 4524 985 254 4524 969 257 0502 971 257 0512 903 254 4541 939 257 0512 903 254 4524 985 254 4524 969 257 0502 971 257 0512 903 257 0511 904 257 0512 903 254 4524 985 257 0503 983 254 4524 985 257 0503 983 257 0512 903 254 4524 985 257 0512 903 254 4524 985 257 0512 903 254 4524 985 257 0512 903 254 4524 985 254 4541 939 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0511 904 257 0512 903 257 0511 904 257 0509 929 253 8022 707 CC73CH1H5R0CT CK73F1E104ZT CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H220MT SMG/RE3 CE04W1E470MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H3R3MT SMG/RE3 CC73CH1H5R0CT CK73F1E104ZT CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H220MT SMG/RE3 CE04W1E470MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H3R3MT SMG/RE3 CC73CH1H5R0CT CK73F1E104ZT CE04W1E470MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1H3R3MT SMG/RE3 CC73CH1H5R0CT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CE04W1H100MT SMG/RE3 CC73CH1H180JT CE04W1H100MT SMG/RE3 CC73CH1H180JT CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CK73F1E104ZT CE04W1H100MT SMG/RE3 CE04W1E470MT SMG/RE3 CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73B1H102KT CK45F2EAC103MC Part Name Remarks

39New

OTHER PARTS GROUP CX021 CX022 CX042 CX111 CX221,222 CX351 CY081 205 0581 056 205 0581 001 205 0234 044 205 0480 018 205 1293 000 205 0736 063 205 1297 006 2P VH CONNECTOR BASE 2P VH CONNECTOR BASE 4P EH SIDE BASE 11P KR CON BASE(L) 22P SOCKET(9892S) 35P FFC CON.BASE 8P FFC CON.BASE(S) * *

39

DN-X1500Ref. No. FB301,302 FB601,602 FL201 JK402-405 JK601 JK602 JK801 L851 S301,302 S303-305 S306-311 S312 S313 S314 S315 S316 S317 S401-403 S851 X301 Part No. 235 0130 903 235 0130 903 393 8074 008 204 8540 009 205 1171 009 204 8640 006 204 8264 000 235 0159 007 212 5604 907 212 1165 000 212 5604 907 212 0511 008 212 0510 009 212 0512 007 212 0511 008 212 4786 004 212 0512 007 212 0443 008 212 1176 015 399 0805 914 461 1159 016 Part Name CHIP EMIFIL(11A121) CHIP EMIFIL(11A121) FL TUBE (16-ST-73GN) 4P PIN JACK 3PCANNON(NCJ6FI-H) PHONE JACK(HTJ06404A H/P JACK (AU) PLH10AN3711ROP2B TACT SWITCH-TA(ALPS) SLIDE SW (1-2) TACT SWITCH-TA(ALPS) ROTARY SW (1-8) ROTARY SW (1-7) ROTARY ENCODER ROTARY SW (1-8) SLIDE SWITCH ROTARY ENCODER SLIDE SW(SSAA120400) POWER SWITCH(TV-5) CSTLS16M0X51-A0 FL SPACER * * * * * * * Remarks

40New

40

DN-X1500

41

GU-3593 P.VR P.W.B. UNIT ASSYRef. No. IC401-404 IC701-704 IC705-708 D701-715 LD701 LD702-705 LD706-712 LD713 LD714-717 LD718-724 LD725 LD726-729 LD730-736 LD737 LD738-741 LD742-748 LD749 LD750-753 LD754-760 LD761 LD762-765 LD766-772 LD773 LD774 LD775 LD776 LD777 LD778 LD779 LD780 LD781 LD782,783 LD784,785 LD786-789 LD790,791 LD792,793 LD795 Part No. 269 0220 007 262 3335 901 262 3336 900 276 0560 901 393 9642 905 393 9643 904 393 9644 903 393 9642 905 393 9643 904 393 9644 903 393 9639 905 393 9640 907 393 9641 906 393 9639 905 393 9640 907 393 9641 906 393 9639 905 393 9640 907 393 9641 906 393 9639 905 393 9640 907 393 9641 906 393 9640 907 393 9639 905 393 9640 907 393 9639 905 393 9640 907 393 9639 905 393 9640 907 393 9639 905 393 9640 907 393 9639 905 393 9644 903 393 9641 906 393 9639 905 393 9604 901 393 9612 906 GP1S094HCZ(JP) BU2152FS TC4051BF DAN202KT146 SEL4214S(RED) TP1 SEL4914A(ORG) TP1 SEL4414E(GRN) TP1 SEL4214S(RED) TP1 SEL4914A(ORG) TP1 SEL4414E(GRN) TP1 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332MC(GRN) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332MC(GRN) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332MC(GRN) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332MC(GRN) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SLR-332YC(YEL) TE7 SLR-332VC(RED) TE7 SEL4414E(GRN) TP1 SLR-332MC(GRN) TE7 SLR-332VC(RED) TE7 SEL6227S(TP5) SELU5E20C(TP15) * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * * Part Name Remarks New * * * SEMICONDUCTORS GROUP

RESISTORS GROUP VR401-404 VR701 VR702-704 VR705 VR706-708 VR709 VR710-713 VR714 VR715-717 VR718 VR719-721 VR722 VR723-725 VR726,727 211 5651 009 211 5630 004 211 5629 002 211 5630 004 211 5629 002 211 5630 004 211 5629 002 211 5630 004 211 5629 002 211 5630 004 211 5629 002 211 5630 004 211 5629 002 211 5630 004 J4520P20B103 V1420P12FB103 V1420P12FB103K V1420P12FB103 V1420P12FB103K V1420P12FB103 V1420P12FB103K V1420P12FB103 V1420P12FB103K V1420P12FB103 V1420P12FB103K V1420P12FB103 V1420P12FB103K V1420P12FB103 *

41

DN-X1500Ref. No. CAPACITORS GROUP C401-404 C701 C702 C703 C704 C705 C706 C707 C708 C709-712 C713,714 C715 C716 C717 C718 C719 C720,721 C722 C723-726 C731 C732 C733 C734 C735 C736 257 0512 903 257 0512 903 254 4302 958 257 0512 903 254 4302 958 257 0512 903 254 4302 958 257 0512 903 254 4302 958 257 0512 903 254 4302 958 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0512 903 257 0511 904 257 0512 903 257 0511 904 257 0512 903 257 0511 904 CK73F1E104ZT CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CE04W1A470MT(SRE) CK73F1E104ZT CE04W1A470MT(SRE) CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT CK73F1E104ZT CK73F1H103ZT Part No. Part Name Remarks

42New

OTHER PARTS GROUP CX043-046 CY221,222 S701-713 S714-717 S718 S719-722 205 0355 046 205 1294 009 212 5604 907 212 4786 004 212 0388 008 212 0511 008 4P KR CON BASE(L) 22P PLUG(9892B) TACT SWITCH-TA(ALPS) SLIDE SWITCH ROTARY SW (1-5) ROTARY SW (1-8) * *

146 2343 100 146 2344 109

LED HOLDER (CH) LED HOLDER (MASTER)

* *

42

DN-X1500

43

GU-3594 DSP P.W.B. UNIT ASSYRef. No. IC101 IC102 IC103-105 IC106 IC107,108 IC113 IC114 IC115 D101 Part No. 262 3245 004 262 3307 007 262 2640 901 262 2959 906 262 2640 901 262 2516 909 262 2729 903 262 2517 908 276 0750 902 Part Name ADSST-MEL100-DVD 128M SDRAM(32B TSOP) SN74LV245APW-EL2 SN74LV244APW SN74LV245APW-EL2 SN74LV32APW-EL2 SN74LV02APW-EL2 SN74LV08APW-EL2 RB521S-30TE61 Remarks New SEMICONDUCTORS GROUP

CAPACITORS GROUP C101,102 C103,104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C116,117 C118-122 C128-130 C133 C134 C135 C136,137 C138 C139 C140 257 5009 974 257 5006 993 257 5009 974 257 5006 993 254 4614 905 257 5009 974 257 5006 993 254 4601 918 257 5009 974 257 5006 993 254 4603 916 257 5009 932 257 5009 974 257 5009 974 257 5009 974 257 5009 929 257 5009 974 257 5009 929 257 5009 974 257 5006 993 257 5009 974 CK73F1C104ZT CK73B1H102KT CK73F1C104ZT CK73B1H102KT CA67C0J221MT(SVP) CK73F1C104ZT CK73B1H102KT CE67W0J471MT(P.CAP) CK73F1C104ZT CK73B1H102KT CE67W1E100MT(P.CAP) CK73F1E223ZT CK73F1C104ZT CK73F1C104ZT CK73F1C104ZT CK73F1H103ZT CK73F1C104ZT CK73F1H103ZT CK73F1C104ZT CK73B1H102KT CK73F1C104ZT

OTHER PARTS GROUP CX301,302 FB101,102 X101 205 1292 001 235 0158 901 399 0946 909 30P SMT SOCKET(9180S CHIP BEADS(18PG121) CSTCW25M0X51-R0 * *

43

EXPLODED VIEW45

DN-X1500

44

Parts List

44 46 28 109 112 109 112 14 109 22 21

102 102 37 47 102 44 45 102 46 45 102 44 44 43 45 46 105 42 103 1-2 103

5

112

109 38 110 112 109 112

2-2

112

102

36 13 4 102 113 48 27 105 6 33 39 31 32 31 101 5 30 29 2-4 8 23 110 64 108 107 110 110 108 61 7 15 105 105 2-3 19 32 18 31 108 11 5 41 60 106 16 1-1

34 32 40 31 35 25 35 25 110 3-2 3-2 3-2 3-2 62 63 3-1 9 10 110 108 109 65 110 24 9 25 20 110 17 1-3

2-1 105

26 105

44

DN-X1500

45

PARTS LIST OF EXPLODED VIEWRef. No. 1 1 1-1 1-2 1-3 1-3 2 2-1 2-2 2-3 2-4 3 3-1 3-2 3-2 3-2 3-2 4 5 6 7 8 9 10 11 13 13 14 15 16 ! 17 18 19 20 ! ! 21 21 22 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 Part No. GU-3591 GU-3591-A GU-3591-1 GU-3591-2 GU-3591-3 GU-3591-3A GU-3592 GU-3592-1 GU-3592-2 GU-3592-3 GU-3592-4 GU-3593 GU-3593-1 GU-3593-2 GU-3593-3 GU-3593-4 GU-3593-5 GU-3594 412 4859 007 441 1980 003 441 1987 006 105 1447 006 461 0706 127 449 0077 050 412 5075 000 GEN6583 105 1448 005 105 1448 018 205 1116 006 412 2814 002 449 0033 023 233 6465 003 412 5071 101 412 5070 005 449 0202 032 206 2155 001 206 2089 106 445 0084 009 445 0056 008 441 1986 007 119 0125 001 122 0244 001 412 5095 006 144 2868 003 146 2341 005 146 2340 006 146 2342 004 113 1988 100 113 1989 002 113 1990 004 146 2339 004 112 0925 006 112 0928 100 144 2870 004 105 1449 004 144 2869 002 211 5652 008 113 1987 004 Part Name MAIN&POW. P.W.B. UNIT ASS'Y MAIN&POW. P.W.B. UNIT ASS'Y MAIN UNIT POWER UNIT TRANS UNIT TRANS UNIT P.UCOM&IN P.W.B. UNIT ASS'Y P.UCOM UNIT INPUT UNIT P.SW UNIT H/P UNIT P.VR P.W.B. UNIT ASS'Y P.VR UNIT CH FADER UNIT 1 CH FADER UNIT 2 CH FADER UNIT 3 CH FADER UNIT 4 DSP P.W.B. UNIT ASS'Y EARTH PLATE EARTH PLATE EARTH BRACKET BOTTOM COVER FOOT SHEET CARD SPACER (H=10) RADIATOR F.CAUTION LABEL BACK PANEL BACK PANEL TERMINAL ASS CARD SPACER (L=8) LOCKING CARD SPACER POWER TRANS H/P BRACKET P.SW.BRACKET LOCKING CARD SPACER AC CORD W/CON.E3 AC CORD W/CON.E2 CORD BUSH CORD BUSH SUB PANEL TAP BUTTON BLIND SHEET (SW) SHIELD PLATE TOP PANEL SHEET POWER KNOB GUIDE KNOB RING BUTTON BUTTON BASE BUTTON BASE (2) WINDOW SENSOR LEVER BLIND SHEET CH FADER PANEL PLATE CROSSFADER PANEL CROSSFADER(P&G) POWER KNOB

Note: The symbols in the column Remarks indicate the following destinations. E3 : U.S.A., & Canada model E2 : Europe model Remarks for E3 for E2 Q'ty 1 1 New

for E3 for E2 1

1

1 6 2 1 1 4 3 1 for E3 for E3 for E2 1 1 1 1 1 1 1 1 1 2 for E3 for E2 for E3 for E2 1 1 1 1 1 1 8 1 1 1 1 1 20 11 9 1 4 1 1 1 1 1 1 * * * * * * * * * * * * * * * * * * * * * * * * * * *

45

DN-X1500Ref. No. 42 43 44 45 46 47 48 60 61 62 63 64 65 Part No. 112 0927 004 112 0926 005 112 0888 004 112 0888 017 112 0889 003 113 1920 003 113 1986 005 513 1581 008 513 1642 002 513 2303 007 513 3384 009 513 2521 009 513 3159 001 513 3253 004 009 0247 006 203 5331 001 009 0247 019 204 6350 055 461 1133 001 461 1184 007 MODE KNOB KNOB (MARU) KNOB (MARU) ASSIGN KNOB (MARU) CH FADER KNOB CROSSFADER KNOB SERIAL NO. SHEET NO. SHEET VERSION LABEL C-UL MARK US (813) CE LABEL FCC/CLASS B CAUTION C-TICK LABEL 35P FFC 3P VH-VH CON.CORD 8P FFC (1.25) 11P KR-KR RIBBON 150 EMI GASKET GAP PAD for E3 for E2 for E3 for E2 for E3 for E2 Part Name MASTER KNOB Remarks Q'ty 1 2 23 8 8 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 *

46New * *

SCREWS 101 102 103 104 105 106 107 108 109 110 111 112 113 471 1810 019 471 2303 020 471 3204 018 471 3303 016 473 7002 018 473 7002 034 473 7004 016 473 7007 013 473 7015 005 473 8007 083 475 1184 006 477 0064 107 471 2801 030 2X3 CPS 3X6 CFS-B 2.6X8 CBS-Z 3X6 CBS-Z 3X8 CBTS (S)-Z 3X6 CBTS (S)-B 4X6 CBTS (S)-Z 4X10 CBTS (S)-B 3X6 CBTS(S)-B 3X8 CUP SCREW 12 W FIXING SCREW 3X5 CFS-B 8 14 6 2 10 5 2 4 8 12 5 13 2

46

DN-X1500

47

PACKING VIEWContents 203 204 ~ 206

202

201

202

207

PARTS LIST OF PACKING & ACCESSORIESRef. No. 201 202 203 204 205 206 207 Part No. 505 0350 019 503 1480 005 505 0038 030 515 0945 007 511 4143 007 515 0923 207 501 2237 015 CUSHION POLY COVER WARRANTY (COM.) INST.MANUAL S.S.LIST COM.(EX) CARTON CASE CONT.CARD(L)SUB ASSY BAR CODE LABEL ASS'Y Part Name STYLEN PAPER

Note: The symbols in the column Remarks indicate the following destinations. E3 : U.S.A., & Canada model E2 : Europe model Remarks Q'ty 1 2 1 for E3 1 1 1 1 1 1 * * * New

47

BLOCK DIAGRAM AUDIO PART

DN-X1500

48

MUTE

MASTER OUT (BAL)

MUTE MASTER OUT (UNBAL)

MUTE

RIAA PHONO 1/ LINE 1 LINE 2

SIG. SELECTOR TC9273N-004

E.VOL TC94A32F

MUTEA/D CONV. PCM1804 D/A CONV. PCM1791ADBR

BOOTH OUT

A/D

MUTE

REC OUT

D/A

RIAA PHONO 2/ LINE 3 LINE 4

SIG. SELECTOR TC9273N-004

CODEC (MASTER)E.VOL TC94A32F A/D CONV. PCM1804

AD1838AASMUTEH/P OUT

A/D

MUTESIG. SELECTOR TC9273N-004

SEND

PHONO 3/ LINE 5 LINE 6

RIAA

E.VOL TC94A32F

A/D CONV. PCM1804

DSP ADSST MEL100

A/D

SIG. SELECTOR TC9273N-004

E.VOL TC94A32F

LINE 7 LINE 8

A/D CONV. PCM1804

A/D

DIT AK4103AVF PULSE TRANS

DIT CODEC (SLAVE) RETURN AD1838AAS

MUTE

DIGITAL OUT

E.VOL TC94A32F

MAIN MIC

AUX MIC

48

BLOCK DIAGRAM SYSTEM PART

DN-X1500

49

D/A CONV. PCM1791ADB

MASTER OUT (XLR)

PHONO1/ LINE1 LINE2 PHONO2/ LINE3 LINE4 PHONO3/ LINE5 LINE6

SIG.SELECTOR TC9273N -004

E.VOL TC94A32F

A/D CONV. PCM1804

CODEC (MASTER) AD1838AAS D/A

SN74LV02APW

RESET IC PST600C

MASTER OUT (RCA)

SIG.SELECTOR TC9273N -004

D/A E.VOL TC94A32F A/D CONV. PCM1804 A/D SN74LV32APW D/A SN74LV08APW BOOTH OUT

SN74AHCT08PW SIG.SELECTOR TC9273N -004 E.VOL TC94A32F A/D CONV. PCM1804

H/P OUT SYSTEM uCOM MN102H74D SEND

DSP ADSST MEL100

SN74LV244

LINE7

SIG.SELECTOR TC9273N -004

E.VOL TC94A32F

A/D CONV. PCM1804 CODEC (SLAVE) AD1838AAS

SN74LV245APW 8M FLASH MEMORY SN74AHCT08PW REC OUT

LINE8 E.VOL TC94A32F

128M SDRAM

SN74LV245APW

A/D

D/A

MAIN MIC

SN74LV245APW

SN74AHCT273PW

SN74LV08APW AUX MIC DIT AK4103AVF

SN74LV245APW

SN74LV245APW

RETURN DIGITAL OUT +5V LED +5V MAIN +3.3V MAIN 3.3V REG. BA033T +3.3V DSP 1.8V REG. PQ018EF01SZ VR CIRCIT +15V REG. NJM7815FA +15V AUDIO VR CIRCIT +1.8V DSP VR CIRCIT 3.3V REG. BA033T SELECTOR TC4051BF SELECTOR TC4051BF SELECTOR TC4051BF SELECTOR TC4051BF SELECTOR TC4051BF SELECTOR TC4051BF FL DRIVER M66005AFP PANEL uCOM TMP86CM47U LED DRIVER BU2152FS LED DRIVER BU2152FS LED DRIVER BU2152FS LED DRIVER BU2152FS LED DRIVER BU2152FS LED CIRCUIT TC74HC138 KEY MATRIX CIRCIT TC74HC138

5V REG. BA05T 5V REG. BA05T

5V REG. BA05T

LED CIRCUIT

LED CIRCUIT

-15V REG. NJM7915FA

-15V AUDIO

VR CIRCIT

FLT 16-ST-73GN

LED CIRCUIT

FLT POWER

VR&SENSOR CIRCIT -HB VR&SENSOR CIRCIT F1 F2

LED CIRCUIT

49

LEVEL DIAGRAM

DN-X1500

50

INPUT TERMINAL

SEL.

ELE.VR A/D CH.F. VR CONT.

DSP MST.F. VR CONT. D/A MUTE OUTPUT TERMINAL

MST (XLR) MST (RCA) BOOTH H/P

MASTER OUT (XLR) +4dBu(1.23Vrms) MASTER OUT (RCA) BOOTH OUT H/P OUT 0dBV(1Vrms)

LINE INPUT -14dBV(200mVrms) LINE -6dB -3dB -3dB SEND

SEND -14dBV(200mVrms)

PHONO INPUT -50dBV(3mVrms) M.MIC INPUT -54dBV(2mVrms) A.MIC INPUT -60dBV(1mVrms)

PHONO M.MIC

A.MIC

50

WIRING DIAGRAM

DN-X1500

51

GU-3593-1 P.VR UNIT GU-3592-2 INPUT UNIT

CY221

CY222

CX351

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22

CX221

CX222

CY351 CY301 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 GND +3.3V_DSP A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 /CS0 /CS_DSP /HBR STB_CLK ABCLK ALRCLK DSDATA ASDATA GND +3.3V_DSP GND +1.8V +1.8V DSP_COM D00 D01 D02 D03 D04 D05 D06 D07 D08 D09 D10 D11 D12 D13 D14 D15 /RD /WEL DSP_ACK DSP_REQ /DACRST DSP_BPM WAIT /BRACK /DRST DSPBSY 1 30P SMT SOCKET 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 1 30P SMT SOCKET 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

CX043 GU-3593-2 CH FADER UNIT 1

1 2 3 4

+5V GND CH1 FADER CH1 FADER S

1 2 3 4

CW043

CX044 GU-3593-3 CH FADER UNIT 2

1 2 3 4

+5V GND CH2 FADER CH2 FADER S

1 2 3 4

CW044

CY081 GU-3592-1 P.uCOM UNIT

CX045 GU-3593-4 CH FADER UNIT 3

1 2 3 4

+5V GND CH3 FADER CH3 FADER S

1 2 3 4

CW045

8 7 6 5 4 3 2 1

GND /RESET BREQ /DRST TXD RXD DSPBSY GND

1 2 3 4 5 6 7 8

CX081

35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 GU-3591-1 MAIN UNIT .

GND CLOCK_B DATA_B /DSEL_STB0 /DSEL_STB1 /DSEL_STB2 /DSEL_STB3 /VOL_STB0 /VOL_STB1 +15V +15V GND GND -15V -15V TRIM_CH4_L GND TRIM_CH4_R GND TRIM_CH3_L GND TRIM_CH3_R GND TRIM_CH2_L GND TRIM_CH2_R GND TRIM_CH1_L GND TRIM_CH1_R GND TRIM_M.MIC GND TRIM_A.MIC GND

+5V_L +5V_L GND_L GND_L ADR1 ADR2 ADR3 ADR4 KEYIN0 KEYIN1 KEYIN2 KEYIN3 KEYIN8 KEYIN9 KEYIN10 KEYIN11 KEYIN12 KEYIN13 KEYIN14 KEYIN15 +5V GND

+5V_L +5V_L +5V_L GND_L GND_L /FLRST LDLCH LDCLK LDDAT1 LDDAT2 S0 S1 S2 S3 S4 S5 S6 S7 +5V +5V GND GND

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35

GU3594-1 DSP UNIT

CY302

CX046 GU-3593-5 CH FADER UNIT 4

1 2 3 4

+5V GND CH4 FADER CH4 FADER S

1 2 3 4

CW046

CX042

CX111

CW121

CX041

11 10 9 8 7 6 5 4 3 2 1

1 +5V 1 2 +5V 2 3 GND_D 3 4 GND_D 4 5 +3.3V_DSP 5 6 +3.3V_DSP 6 7 +3.3V 7 8 +18V 8 9 +15V 9 10 GND_A 10 11 GND_A 11 12 -15V 12

1 2 3 4

C.F. N.C. GND +5V

11 10 9 8 7 6 5 4 3 2 1

-HB F1 F2 GND_L GND_L +5V_L +5V_L +5V +5V GND GND

Penny & Giles CROSSFADER

CY111

CX121 GU-3592-4 H/P UNIT

CW101 CX021 GU-3592-3 P.SW UNIT CX022 1 2 1 AC 2 AC 1 2 CY021 GU-3591-3 TRANS UNIT

1 2 3 4 5 6 7 8 9 10

DC 7.3V DC 7.3V DC 7.3V DC 7.3V DC+18.5V GND DC-18.5V DC-34.0V AC3.5V AC3.5V

1 2 3 4 5 6 7 8 9 10

CX101

GU-3591-2 POWER UNIT

51

1 2 3 4

HPL HPG HPR FG

1 2 3 4

DN-X1500

52

NOTE FOR SCHEMATIC DIAGRAM1. WARNING:Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer.

2. CAUTION:Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check. If the leakage current exceeds 0.5 milliamps, or if the resistance from chassis to either side of the power cord is less than 460 kohms, the unit is defective.

1. M M 2. F F 3. 4.

3. WARNING:DO NOT return the unit to the customer until the problem is located and corrected.

4. NOTICEALL RESISTANCE VALUES IN OHM. k=1,000 OHM M=1,000,000 OHM ALL CAPACITANCE VALUES IN MICRO FARAD. p=MICRO-MICRO FARAD EACH VOLTAGE AND CURRENT ARE MEASURED AT NO SIGNAL INPUT CONDITION. CIRCUIT AND PARTS ARE SUBJECT TO CHANGE WITHOUT PRIOR NOTICE.

SIGNAL LINE

SIGNAL LINE

52

SCHEMATIC DIAGRAMS (1/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

53

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (1/8)GU-3591-1 MAIN UNIT (1/3)

H

53

SCHEMATIC DIAGRAMS (2/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

54

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (2/8)GU-3591-1 MAIN UNIT (2/3)

H

54

SCHEMATIC DIAGRAMS (3/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

55

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (3/8)GU-3591-1 MAIN UNIT (3/3)

H

55

SCHEMATIC DIAGRAMS (4/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

56

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (4/8)GU-3591-2 POWER UNIT GU-3591-3 TRANS UNIT

H

56

SCHEMATIC DIAGRAMS (5/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

57

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (5/8)GU-3592-1 P. uCOM UNIT GU-3592-3 P. SW UNIT GU-3592-4 P. uCOM UNIT

H

57

SCHEMATIC DIAGRAMS (6/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

58

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (6/8)GU-3592-2 INPUT UNIT

H

58

SCHEMATIC DIAGRAMS (7/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

59

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (7/8)GU-3593-1 P. VR UNIT GU-3593-2 CH FADER UNIT 1 GU-3593-3 CH FADER UNIT 2 GU-3593-4 CH FADER UNIT 3 GU-3593-5 CH FADER UNIT 4

H

59

SCHEMATIC DIAGRAMS (8/8)1 2 3 4 5 6 7 8 9 10

DN-X1500

60

11

A

B

C

D

E

F

G

SCHEMATIC DIAGRAMS (8/8)GU-3594 DSP UNIT

H

60