Download - ……“Delivering Green” WeCare Organics LLC 9289 Bonta Bridge Road Jordan, New York 13080 315-689-1937
……“Delivering Green”
WeCare Organics LLC9289 Bonta Bridge RoadJordan, New York 13080
315-689-1937
www.wecareorganics.com
Market DrivenBiosolids Management
• Goal is to generate revenue and/or reduce cost.
• Products are blended, shred, screened, loaded trucked, spread, dozed and seeded.
• Product should have low plasticity, need to be friable.
• Products need to be dry; > 50% solids.
• Low solids biosolids require special handling considerations. “Not Third Party Friendly”.
Thin Film Drying for Enhanced Dewatering• Proposed to be used as extension of dewatering
mechanism.
• Simple, single pass, indirect drying application.
• Can be run in line with existing dewatering facilities.
• .• Reduce tonnage/volume by over 50%.
Secondary Dewatering with Thin Film Dryer
Dry Ton/Day 30
% Solids Cake 16% 20% 25% 30%
Wet Ton Per Day 188 150 120 100
Double % Solids 32% 40% 50% 60%
End Tons Per Day 94 75 60 50
lbs H20/Day 187,500 150,000 120,000 100,000
lbs H20/HR 7,813 6,250 5,000 4,167
BTURequired/lbsH2O 1250 234,562,500 187,500,000 150,000,000 125,000,000
MMBTU 235 188 150 125
$/MMBTU 8 $1,877 $1,500 $1,200 $1,000
Cost / Wet Ton $10 $10 $10 $10
WeCare Thin Film Dryer Dryer can be used as stand alone or in combination with
alkaline technology, composting technology, incineration, anaerobic digestion, gasification or landfilling
Used to dry pasty, viscous materials that are difficult to dry ( no fouling)
Dryer can receive low solids cake without back mixing.
Dryer is used to “scalp” moisture to a range of 35% to 70% solids
Removes Water at 1250 btu / # H20 removed.
Fire not issue below 65% solids.
Indirect Dryer uses thermal oil, steam or hot water
Indirect dryer uses little CFM. Little air to treat.
WeCare Thin Film Dryer
Dryer can be run of off natural gas, propane, #2 bunker fuel, landfill gas or digester gas.
Dryer can utilize waste heat off of industry or CHP systems.
Dryer does not require digestion process prior to drying, however digestion may provide renewable energy.
There are more than 80 sludge drying installations with references in Europe, USA, China, Arabia……
Dryers have been in operation for more than 20 years.
Conclusion
Stop hauling Water.
Higher solids means higher value per ton.
Higher solids means better physical properties.
Higher solids means less secondary processing.
Higher solids means higher organic content.
Higher solids means higher value/revenue.