ベトナム産コーヒー豆から分離されたAspergillus sectionsNigri及びCircumdatiのカビ毒産生性とコーヒー豆のカビ毒
汚染
誌名誌名 JSM Mycotoxins
ISSNISSN 02851466
巻/号巻/号 651
掲載ページ掲載ページ p. 1-6
発行年月発行年月 2015年1月
農林水産省 農林水産技術会議事務局筑波産学連携支援センターTsukuba Business-Academia Cooperation Support Center, Agriculture, Forestry and Fisheries Research CouncilSecretariat
JSM M ycotoxins 65 ( l) , 1 - 6 (20 15) http:/ /dx.doi.org/ 1 0.2520/myco.65.1
Research Pa~er
JSM Mycotoxins
www.jstage.jst.go.jp/browse/myco
Mycotoxin contamination of Vietnamese coffee beans caused by Aspergillus sections Nigri and Circumdati
Ruiko Hashimoto 1, Hiroyuki Nakagawa2, Yoshiki Onji3, Katsuyoshi Asano3,
Koji Yokoyama4, Haruo Takahashi4·5
1Chiba Prefectural Institute of Public Health, 666-2 Nitona·cho, Chuou·ku, Chiba 260-8715, Japan 2National Food Research Institute, National Agriculture and Food Research Organization, 2·1-12 Kannondai , Tsukuba, lbaraki 305-8642, Japan 3Nara Prefectural Institute of Public Health, 1 000 Ohdono, Sakurai, Nara 633-0062, Japan 4Medical Mycology Research Center (MMRC), Chiba University, 1-8-1 lnohana, Chuou-ku, Chiba 260-8673, Japan 5Nationallnstitute of Health Science, 1-18-1 Kamiyoga, Setagaya-ku, Tokyo 158-8501 , Japan
Keywords
Aspergillus section Circumdati; Aspergillus section Nigri; fumonisin; mitochondorial cytochrome b gene; ochratoxin; ~-tubulin gene; Vietnamese coffee
Correspondence Ruiko Hashimoto, Chiba Prefectural Institute of Public Health, 666-2 Nitona-cho, Chuou-ku, Chiba 260-8715, Japan E-mail: [email protected]
(Received April 19, 2014, accepted March 12, 2015)
Introduction
Abstract Sixteen samples of Vietnamese coffee beans were examined for the
presence of mycotoxigenic fungi that produce ochratoxins and fumonisins. Species of the strains isolated from the beans were tentatively identified by morphology as Aspergillus niger species complex (isolation frequencies of the beans: 56.6%), Aspergillus carbonarius (3.3%), and Aspergillus species in section Circumdati (2.9%). The strains randomly selected from the species were correctly identified by sequencing of the ~-tubulin and/ or mitochondrial cytochrome b gene. All of the strains of A. carbonarius and Aspergillus
westerdijkiae, identified in section Circumdati, produced ochratoxin A (OTA). On the other hand, only one out of the 41 strains of A. niger produced a detectable level of OTA. Therefore, A. carbonarius and A. westerdijkiae, rather than A. niger, are likely to be the main sources of OTA contamination in the beans. With regard to A. niger, 37 out of the 41 strains produced fumonsin B2 (FB2). LC-MS/ MS analysis of the 16 bean samples showed that 3 samples were contaminated with OTA and/ or FB2; one Arabica sample with OTA (2.3 1-Jg/ kg), another with FB2 (55 1-Jg/ kg), and one Robusta sample with both OTA (6.3 t-Jg/ kg) and FB2 (49 1-Jg/ kg) . These results demonstrate that Vietnamese coffee beans are commonly infected with OTA- and FBrproducing fungi and occasionally co-contaminated with these mycotoxins.
The coffee bean is one of the most important agricultural products in tropical and subtropical countries such as Brazil and Indonesia. In recent decades, Vietnam has become a major coffee-producing country, especially for the Robusta (Coffea canephora var. robusta) 1l_ The product is exported worldwide to countries including Japan, USA and EU. Ochratoxin A (OTA) is a natural contaminant in green coffee beans and causes a negative economic impact to the coffee industry 2l because it exhibits nephrotoxic, carcinogenic, teratogenic, genotoxic, and immunosuppressive effects on humans and animals1l,3l.4l_
section Circumdati (Aspergillus ochraceus group, yellow aspergilli)3l,4l. A. niger and Aspergillus carbonarius are ochratoxigenic species in section Nigri. A. carbonarius
has been considered as one of the main sources of OTA contamination because it produces relatively larger amounts of OTA2'·3L4l. Ilic et al. reported that A. niger
was the sole ochratoxigenic species isolated from Vietnamese coffee beans and that 8.7% of these isolates produced OTA 1l. However, their identification of the species is based on only morphology, and A. niger may be considered as a species complex5
' ·6
' . Molecular techniques are necessary for correct identification of the species.
A. ochraceus was previously considered as another main source of OTA contamination. Section Circumdati
was recently revised by Frisvad et al_?l, and some new ochratoxigenic species, such as Aspergillus westerdi-
Previous reports demonstrated that OTA contamination in coffee beans was caused by Aspergillus section Nigri (Aspergillus niger group, black aspergilli) and
2 H ASHIMOTO eta!.
jkiae and Aspergillus steynii, have been described within
the section. Noonim et al. reported that A. ochraceus
was not detected in Thai coffee beans with reference to
the recent classification of section Circumdati4l. There
fore, correct identification of the fungi is of great
importance to clarify the species responsible for OTA
contamination in coffee beans. In addition to OTA, A. niger has been reported to
produce fumonisins8l, which were firstly discovered in
corn as carcinogenic mycotoxins produced by Fusarium
proliferatum. Previous study showed that approxi
mately 67% of A. niger isolates from Thai coffee beans
produced fumonisin B2 (FB2) and fumonisin B4 (FB4)9l.
Since A. niger often infects coffee beans, fumonisin
contamination is also of great concern in Vietnamese
coffee beans.
The objective of this study is to clarify the causative
fungi of the mycotoxin contamination after correct
identification by molecular techniques and to know the
level of contamination in Vietnamese coffee beans for
reducing human health risk.
Materials and Methods
Sample of coffee bean
We collected the green coffee bean samples with
the cooperation of the Western Highland Ag ricultural
and Forestry Science Institute (WASI) in Buon Ma Thout
at Dac Lac plateau in the central highlands of Vietnam
in October 2010. Sixteen coffee samples, consisting of
13 Robusta samples and 3 Arabica samples, were col
lected in total.
Detection of black and yellow aspergilla from
the sample
One-hundred beans from each coffee sample were
taken, disinfected with alcohol, and distributed to 10
petri dishes (5 beans on each dish) of dichloran rose
bengal chloramphenicol (DRBC) agar and dichloran
18% glycerol (DG18) agar. These plates were incubated
at 25 ·c for 7 days. Black (section Nigri) and yellow
(section Circumdati) aspergilla were isolated on Czapek
agar plates. The isolates were tentatively identified as
A. niger or A. carbonarius by morphological criteria (Pitt
and Hocking10l and Samson et al. 11 l, especially in orna
mentation of conidial wall24l). Yellow aspergilli was
inoculated to the plates of malt extract agar (MEA) and
Czapek yeast autolysate agar (CYA), and incubated at
25 •c and 37 •c for 7 days for the tentative identifica
tion 7L10l·11 l. Representative isolates of both aspergilla
were transferred to potato dextrose agar (PDA) slant for
the further studies.
JSM Mycotoxins
Species identification of the strains by DNA analyses
Yellow aspergilli and A. carbonarius were examined
for the species identification by sequencing of ~-tubulin 13)·25) and cytb genes12l·23l. The putative A. niger
strains were identified by the cytb gene analysis. After
culturing in potato dextrose broth, DNA was extracted from the isolates using the Gen Toru Kun DNA extrac
tion kit for yeast (TaKaRa Bio Inc., Japan) according to the manufacturer's instructions. PCR amplification of
the ~-tubulin gene was performed with primers Bt2a and Bt2b 13)·25) and the cytb gene with primers E1m4
and rE2m412l. The amplified DNA fragments were
sequenced with the Dye Terminator Cycle Sequencing
Ready Reaction Kit (Applied Biosystems Division of Perkin-Elmer, Japan Co., Ltd.) and the ABI Prism 3700 DNA
Sequencer. Sequences were aligned using CLUSTALW in Molecular Evolutionary Genetics Analysis (MEGA) v. 4,
and phylogenetic trees were prepared by the neighborjoining method and un-weighted pair group method. For the gene analyses, the following strains were used as reference; A. westerdijkiae (IFM 60979, CBS 112803),
Aspergillus melleus (IFM 60743, CBS 546.6), A. ochraceus (IFM 60744, CBS 547.65), A. carbonarius (IFM 47662)
and Aspergillus foetidus (IFM 57758, CBS 101708).
Mycotoxin production of fungal strains
For ochratoxigenic species, conidial suspension of
the strain (1 x 108 CFU/mL) was prepared in sterile
water containing 0.01% (v/v) Tween 80 after incubation on PDA slant at 25 ·c for 7 days, and the suspension
was inoculated on 15 g of autoclaved barley grains in a
200-mL Erlenmeyer flask . Then the flask was incubated at 20 •c for 7 days 14)·15). After the incubation, 60 mL of
acetonitrile/water mixture (3:2, v/ v) was added to the culture, and the mycotoxin was extracted as described previouslyl 5l. The mycotoxin was analyzed by LC-MS/
MS according to a previous report8l. Aspergillus foetidus (IFM 57758) was examined as a reference strain.
For examination of fumonisin production, conidial
suspension of the A. niger strain was prepared as mentioned above and inoculated on 20 g of autoclaved rice
grains in a 200-mL Erlenmeyer flask, and the flask was incubated at 2s•c for 7 days8l·15l·16l. Then, 50 mL of
methanol/water mixture (3:1, v/v) was added to the cul
ture, and the mycotoxin was extracted and analyzed by
LC-MS/MS as described below. Fusarium proliferatum (IFM 58832) was used as a reference strain.
LC-MS/MS analysis of mycotoxins in culture
extract
Chromatographic separation was performed using
a Waters alliance liquid chromatograph coupled with a SCIEX API 3000 triple mass spectrometer with a turbo
spray ion source (ESI) . For ochratoxins, a 150 x 2.1 mm
Vol. 65, No. l, l - 6 (2015)
i.d. (31-1m) Inertsil ODS-3 V column (GL Sciences, Tokyo) was used for separation. The mobile phase was programmed with a 30-90% acetonitrile in 5 mM ammonium acetate linear ramp for 10 min at a flow rate of 0.20 mL/min. MS/MS measurement was carried out with ESI at negative polarity in multiple reaction monitoring (MRM) mode with the following transitions; OTA quantifier m/z 402.1 -> 357.9 and qualifier m/z 402.1-> 166.9; OTB quantifier m/z 368.1 -> 324.0 and qualifier m/z 368.1 - > 280.1, respectively. For fumonisins, a 150 x 2 mm i.d. (3 !Jm) TSK gel ODS 100 V column (Tosoh, Tokyo) was used. The mobile phase was programmed with a 30-90% acetonitrile in 0.1% formic acid linear ramp for 10 min at a flow rate of 0.20 mL/ min. MS/MS was with ESI positive and in MRM mode; FB1 quantifier m/z 722.5 - > 334.5 and qualifier 722.5 ->
352.2; FB2 quantifier m/z 706.3 -> 336.4 and qualifier m/z 706.3 -> 318.4; and FB4 quantifier m/z 690.5 ->
320.5 and qualifier 690.5 -> 338.5, respectively26l.
Analysis of mycotoxins in coffee beans
Coffee bean samples were milled with a Waring Laboratory Blender (Model 7012 S, Waring Commercial, Connecticut, USA) to yield finely ground powder. For ochratoxins, 4 g of the powder was extracted in a 50-mL plastic centrifugation tube with 20 mL of MetOH/3% NaHC03 (1:1, v/v) by homogenization. After centrifugation, a portion of the supernatant (5 mL) was diluted up to 50 mL in a measuring flask with PBS (phosphate buffer saline) containing 0.01% (v/v) Tween 20 (PBST20), and filtered with a glass filter (Whatman GF/A 110 mm). For OTA determination, 10 mL of the resulting solution was loaded on the immunoaffnity column Ochra-king (Horiba Co., Ltd., Kyoto Japan) that was constituted in advance with the same PBST20. After loading, the column was washed with the PBST20 (3 mL x 2 times) and 10 mM ammonium acetate aqueous solution (3 mL x 2 times), successively. Thereafter, the remaining solution was pushed out of the column by air stream. OTA was eluted from the immunoaffnity column with 3 mL of MeOH containing 2% acetic acid (v/v). The eluent was collected in a glass tube vial, and dried up under the nitrogen gas stream at 40 oc. The residue was re-dissolved in 0.2 mL of acetonitrile/water/acetic acid (5:94:1, v/v/v) and subjected to LC-MS/MS analysis as described above. For fumonisins, 10 mL of the filtered solution were loaded on another immunoaffnity column (Fumoni-Prep, R-Biopharm. Rhone Co., Ltd) constituted in advance with the same PBST20. After loading, the column was washed with the PBST20 and 10 mM ammonium acetate aqueous solution in the same way, and the remaining solution was pushed out by air stream. Fumonisins were eluted from the immunoaffnity column with 3 mL of MeOH. The eluent was collected, dried up, and the residue was re-dissolved in 0.2 mL of acetonitrile/water/ acetic acid (5:94:1, v/v/v) for the analysis by LC-MS/MS
3
under the conditions as described above.
Results and Discussion
Detection of black and yellow aspergilla from
the sample
Black aspergilli (section Nigri) were detected at high frequency in almost all of the Vietnamese coffee bean samples examined (Table 1). The predominant fungus was A. niger that was presumptively identified by morphology. The incidence of this fungus varied considerably among the coffee samples (6-100%, 56.6% on average), which was in agreement with the previous reports from Vietnam3l and other countries2l, 4
'. In addition to A. niger, putative A. carbonarius was occasionally found in 3.3% (averagely) of the sample beans. From the mycotoxigenic section Nigri, 49 strains of putative A. niger and 11 strains of putative A. carbon
arius were randomly chosen for further characterization (see the next section).
Yellow aspergilli, A. ochraceus and its related species in section Circumdati, were detected in 2.9% (averagely) of the sample beans (Table 1) although previous report showed that no ochratoxigenic species other than A. niger was present in the Vietnamese samples 1l. Ten strains belonging to section Circumdati were randomly chosen for further characterization (see the next section).
Our preliminary study showed that section Circum
dati (identified as A. ochraceus) was detected in 13% of beans in 13 samples from the same region in year 2,000 (unpublished data). Other reports also proved that section Circumdati was occasionally found in Vietnamese coffee beans3l. These and our present results suggest that Vietnamese coffee is commonly infected with a variety of ochratoxigenic fungi including sections of Nigri and Circumdati.
Species identification of the strains by DNA
analyses
Species identifications of yellow aspergilli (section Circumdati) and A. carbonarius were done by sequencing of the ~-tubulin 13
'·25
) and cytb genes23l. The ten yellow aspergilli strains were identified by the ~-tubulin gene analysis with the reference strains of A. westerdi
jkiae (IFM 60979), A. melleus (IFM 60743) and A. ochra
ceus (IFM 60744). The gene analysis showed that all the yellow aspergilli strains were A. westerdijkiae except one A. melleus strain (Supplementary Table 1). The cytb
gene sequencing23l also showed that the aspergilli strains were clustered into 2 clades, i.e. A0-4 and A0-3, corresponding to A. westerdijkiae and A. mel/ues,
respectively (Supplementary Table 1). A. ochraceus strain (A0-2) was not found in this study. Eleven of the
4 HASHIMOTO eta!. JSM Mycotoxins
Table1 Detection of putative sections Nigri (black aspergilli) and Circumdati (yellow aspergilli) from Vietnamese coffee sample beans, and contents of OTA and FB2 as analyzed by LC-MS/MS.
Fungi detected (%)a Contents in coffee beansb
Cultivars of beans Sample No. section Nigri section Circumdati
A. niger A. carbonarius
1 24 6
2 26 4
3 52 0
4 40 4
5 82 2
6 10 0
7 96 2
8 82 2
9 88 2
10 54 12
11 56 6
12 12 0
13 6 0
14 100 2
15 78 8
16 100 2
Average 56.6 3.3
a Based on coffee beans b Limits of detection: 0.5 119/kg, Limits of quantification: l!Jg/kg c Not detected
A. carbonarius strains, presumptively identified by morphology, were also examined. The ~-tubulin gene analysis13l indicated that all of the strains tested were A. carbonarius (Supplementary Table 2). On the other hand, the cytb gene analysis showed that 5 of them were aligned in the clade of A. carbonarius, AN-D-4, as previously reported 12l; however, the PCR amplification was not successful in the remaining 6 strains (Supplementary Table 2). The cytb primers might not be matched for some strains of A. carbonarius.
Our previous report20l indicated that strains of A. niger complex were clustered into 3 clades on the basis of the cytb sequences, i.e. AN-D-5-l, AN-D-7-1, and AN-D-9-112l, which corresponds to A. niger, A. tubingensis, and Aspergillus luchuensis, respectively. In this study, presumptive A. niger strains randomly chosen were subject to the cytb gene analysis (Supplementary Table 3). The sequencing showed that a majority of strains (41 strains out of 49 strains) were aligned to AND-5-1, i.e. A. niger, which is basically in agreement with the previous report on Thai beans4l. We also found A. luchuensis (6 strains), a black Koji mold that is used to ferment Awamori (a kind of spirit of Japan) or other alcoholic beverages in East Asian countries 18l·19l, and A. tubingensis (2 strains). Occurrence of A. luchuensis in coffee beans indicated that the fungus might also be distributed in agricultural products of Southeast Asian countries.
4
26
0
2
0
0
0
0
6
0
0
4
0
0
2
2
2.9
OTA FB2
-c Robusta
Robusta
Robusta
Robusta
Robusta
Robusta
Robusta
Robusta
Robusta
6.3 49 Robusta
Robusta
Robusta
Robusta
55 Arabica
Arabic a
2.3 Arabica
4.3 52
Mycotoxin production of identified strains
All strains of section Circumdati (A. westerdijkiae and A. melleus) (Supplementary Table 1) and A. carbonarius (Supplementary Table2) identified in this study produced OTA in barley grains in the range of 0.2-41.3 !Jg/g (10.3 !Jg/ml on average) and 4.0- 67.7 !Jg/g (29.8 !Jg/ml on average), respectively. In agreement with our result, A. westerdijkiae and A. carbonarius were previously reported as consistent OTA producers 17l·21 l. Relatively small amount of ochratoxin B (OTB) was produced by several strains of A. westerdijkiae (Supplementary Table 1). In section Circumdati, A. ochraceus was previously described as the major fungus responsible for OTA contamination in coffee beans2l. However, in recent literatures4l·26l, A. westerdijkiae rather than A. ochraceus is reported as the primary causative fungus of OTA contamination in food and feed.
All A. niger strains, except one, failed to produce OTA; the one strain formed 2.7 !Jg/g of OTA along with relatively small amount (1.5 flg/g) of OTB in barley grains (Supplementary Table 3). Previous reports showed that 7-9% of A. niger strains were OTA producers1l,2l, Sl,6l. Although A. niger is the most predominant in mycobiota of coffee beans, the ochratoxigenic species seems to be less problematic because of infrequent presence as OTA producer in the beans. On the other hand, A. carbonarius and section Circumdati seemed to play an important role in OTA contamination in agree-
Vol65, No. l, l - 6 (2015)
ment with a previous report3l. The results indicated that the major sources of OTA contamination in Vietnamese coffee beans were not A. niger, but A. westerdijkiae and A. carbonarius.
With regard to fumonisins, no typical fumonisinproducing species including Fusarium proliferatum was detected in the beans tested. The forty-nine representative strains of A. niger were examined for the fumonisin production. While none of the A. tubingensis (AN-D-7-1) and A. /uchuensis (AN-D-9-1) strains produced the mycotoxin, 90 % of A. niger strains (37 strains) produced detectable amount of FB2, and one strain (No. 37) produced both OTA and FB2 (Supplementary Table 3). These results are essentially in agreement with the result of mycotoxin analysis of Thai coffee beans by Noonim and co-workers, who reported that 76.5% of A.
niger strains were FB2 producers9l; among the A. niger strains, 11.7% produced both OTA and FB2. In addition, occurrence of FB2, OTA, and co-occurrence of FB2 and OTA, were also reported in 81%, 17%, and 10% of the industrial A. niger strains, respectively22l.
In accordance with recent reports9l,nl, we also found putative FB4 in the culture of the A. niger strains by LC-MS/MS analysis although structural conformation could not be done due to the unavailability of the FB4 standard (Supplementary Table 3).
Analysis of mycotoxin in coffee beans
LC-MS/MS analysis demonstrated contamination of OTA in 2 samples (No. 10 and No. 16) with concentrations of 6.3 and 2.3 ~g/kg, respectively (Table 1). A.
carbonarius and/or A. westerdijkiae were isolated from both samples. Previous reports2l showed that OTA was detected from green coffee beans in a wide concentration range of 0.2 - 360 1-1g/kg in commercial raw coffee. The incidence of OTA contamination in the beans was relatively low in this study.
FB2 was found in 2 of the samples (No. 10 and No. 14) with concentrations of 49 and 55 ~g/kg, respectively (Table 1). Although the number of the samples was limited, the levels of FB2 contamination in Vietnamese coffee beans were generally higher than those previously reported with Thai coffee beans9l. The mycobiota of the coffee beans may thus be affected by climate conditions from year to year17l or manner of processing in each country.
Co-contamination of OTA and FB2 in Vietnamese coffee beans was reported for the first time in this study. These mycotoxins may exhibit synergistic toxicity in living tissue of animal and human although the effect has not been investigated in details. The European Commission set regulation for ochratoxin ((EC) No.123/ 2005) that a maximum limit was 5 ~g/kg in the case of the roasted coffee and ground coffee, and 10 ~g/kg in soluble coffee. For fumonisins, the Codex Alimentarius Commission (Geneva, 2014) has set the maximum levels of total fumonisin (FB1, FB2) at 4 mg/kg in raw maize
5
and 2 mg/kg in maize product. Our study demonstrated that the mycotoxin con
tamination in coffee beans should be controlled for reducing human health risk because coffee beans are likely to be infected with the mycotoxigenic fungi at high incidences.
Acknowledgements
This work was supported by The Tojyuro Iijima Foundation for Food Science and Technology. We would like to express our gratitude for their financial support. We would also like to extend our special thanks to Dr. Nguyen Tho and Mr. Masahiro Saga. We additionally thank the Western Highland Agricultural and Forestry Science Institute.
Supplementary Materials
Supplementary materials may be found in the online version of this article:
Supplementary Table 1 Species identification of putative section Circumdati (yellow aspergilli) strains by ~tubulin and cytb gene analyses, and ochratoxin production of the strains
Supplementary Table 2 Species identification of putative A. carbonarius strains by ~-tubulin and cytb gene analyses, and ochratoxin production of the strains
Supplementary Table 3 Species identification of putative A. niger strains by cytb gene analysis, and mycotoxin production of the strains
References
1) Ilic, Z., Bui, T., Tran-Dinh, N., Dang, M.H.V., Kennedy, 1., Carter, D.: Survey of Vietnamese coffee beans for the presence of ochratoxigenic aspergilli. Mycopathologia, 163, 177-182 (2007)
2) Taniwaki, M.H.: "An update on ochratoxigenic fungi and ochratoxin A in Coffee" (eds. Hocking, A.D., Pitt, J.I., Samson, R.A., Thrane, U.), pp. 189-202 (2006), Adv Exp Med Bioi, Springer, New York.
3) Leong, S.L., Hien, LT., An, T.V., Trang, N.T., Hocking, A.D., Scott, E.S.: Ochratoxin A-producing aspergilli in Vietnamese green coffee beans. Lett Appl Microbial, 45, 301-307 (2007)
4) Noonim, P., Mahakarnchanakul, W., Nielsen, K.F., Frisvad, J.C., Samson, R.A: Isolation, identification and toxigenic potential of ochratoxin A-producing Aspergillus species from coffee beans grown in two regions of Thailand. Int J Food Microbial, 128, 197-202 (2008)
5) Samson, R.A., Houbraken, J.A.M.P., Kuijpers, A.F.A.K., Frank, J.M., Frisvad, J.C.: New ochratoxin A or sclerotium producing species in Aspergiilus section Nigri. Stud Mycol, 50, 45-61 (2004)
6 HASHIMOTO eta!.
6) Varga, J., Frisvad, J.C., Kocsube, S., Toth, B., Szigeti, G., Samson, R.A.: New and revisited species in Aspergillus section Nigri. Stud Mycol, 69, 1-17 (2011)
7) Frisvad, J.C., Frank, J.M., Houbraken, J.A.M.P, Kuijpers, A.F.A.K., Samson, R.A.: New ochratoxin A producing species of Aspergillus section Circumdati. Stud Mycol, 50, 23-43 (2004)
8) Frisvad, J.C., Smedsgaard, J., Samson, R.A., Larsen, T.O., Thrane, U.: Fumonisin B2 Production by Aspergillus niger. J Agric Food Chern, 55, 9727-9732 (2007)
9) Noonim, P., Mahakarnchanakul, W., Nielsen, K.F., Frisvad, J.C., Samson, R.A.: Fumonisin B2 production by Aspergillus niger in Thai coffee beans. Food Addit Contam, 26, 94-100 (2009)
10) Pitt, J.I., Hocking, A.D.: Fungi and Food spoilage 3rd ed., (2009), Springer; New York, Dordrecht
11) Samson, R.A., Hoekstra, E.S., Frisvad, J.C., Filtenborg, 0.: Introduction to food- and airborne fungi, 6th ed., (2000), Centraalbureau voor Schimmelcultures, Utrecht
12) Yokoyama, K., Wang, L., Miyaji, M., Nishimura, K.: Identification, classification and phylogeny of the Aspergillus section Nigri inferred from mitochondria Cytochrome b gene. FEMS Microbiol Lett, 200, 241-246 (2001)
13) Meijer, M, Houbraken, J.A.M.P, Dalhuijsen, S., Samson, R.A., Vries, R.P.de.: Growth and hydrolase profiles can be used as characteristics to distinguish Aspergillus niger and other black aspergilli. Stud Mycol, 69, 19-30 (2011)
14) Yazaki, H., Takahashi, H.: Production, Isolation and Analysis of the Ochratoxins. Chiba Pref Inst Pub! Health, 9, 6-15 (1985)
15) Ono, H., Kataoka, A., Tanaka, K., kwasugi, S., Wakazawa, M., Ueno, Y., Manabe, M.: Ochratoxin A producibility by strains of Aspergillus niger group stored in IFO culture collection. Mycotoxins, 41,47-51 (1995)
16) Mogensen, J.M., Nielsen, K.F., Samson, R.A., Frisvad, J.C., Trane, U.: Effect of temperature and water activity on the production of fumonisin by Aspergillus niger and different Fusarium species. BMC Myclobiol, 9, 281 (2009)
17) Perrone, G., Susca1, A., Cozzi1, G., Ehrlich, K., Varga. J., Frisvad, J.C., Meijer, M., Noonim, P., Mahakarnchanakul, W., Samson, R.A.: Biodiversity of Aspergillus species in some
JSM Mycotoxins
important agricultural products. Stud Mycol, 59, 53-66 (2007)
18) Hong, S.B., Lee, M., Kim, D.H., Varga, J., Frisvad, J.C., Perrone, G., Gomi, K., Yamada, 0., Machida, M., Houbraken, J., Samson, R.A.: Aspergillus luchuensis, an industrially important black Aspergillus in East Asia. PLoS ONE, 8, e63769 (2013)
19) Yamada, 0., Takara, R., Hamada, R., Hayashi, R., Tsukahara, M., Mikami, M.: Molecular biological researches of KuroKoji molds, their classification and safety. J Biosci Bioeng, 112, 233-237 (2011)
20) Hashimoto, R., Asano, K., Tokashiki, T., Onji, Y., Hirose-Yasumoto, M., Takara, R., Toyosato, T., Yoshino, A., Ikehata, M., Liu, Y., Kumeda, Y., Yokoyama, K., Takahashi, H.: Mycotoxin production and genetic analysis of Aspergillus niger and related species including the Kuro-Koji mold. Mycotoxins, 63, 179-186 (2013)
21) Serra, R.: "A new species of section Nigri isolated from grapes" Mycologia, (Caban-es, F. J., Perrone, G., Castella', G., Venancio1, A., Mule', G., Kozakiewicz, Z.), 98, pp. 295-306 (2006), The Mycological Society of America, Lawrence
22) Frisvad, J.C., Larsen, T.O., Thrane, U., Meijer, M., Varga, J. Samson, R.A.: Fumonisin and ochratoxin production in industrial Aspergillus niger strains. PLoS ONE 6 e23496 (2011)
23) Hashimoto, K.: Relationship between the cigarette beetle (Lasioderma serricorne) and the mycotoxin-producing fungi. PhD Thesis, Azabu University (2012)
24) Samson, R.A., Noomin, P., Meijer; M., Houbraken, J.A.M.P., Frisvad, J.C., Varga, J.: Diagnostic tools to identify black aspergilla. Stud Mycol, 59, 129-145 (2007)
25) Morello, L.G., Sartori, D., Martinez, A.L.O., Vieira, M.L.C., Taniwaki, M.H., Funfaro, M.H.P.: Detection and quantification of Aspergillus weterdijkiae in coffee beans based on selective amplification of ~-tubulin gene by using realtime PCR. Int J Food Microbiol, 119, 270-276 (2007)
26) Yanai, M., Kajihara, C., Kimura, A., Ogiso, M., Baba, H., Tsubouchi, H., Udagawa, S.: Species Identification of ochratoxin A-producing Aspergillus ochraceus isolates from Japan based on the new taxonomic system. Jpn J Food Microbiol, 29 (4), 208-214, (2014)
ベトナム産コーヒー豆から分離されたAspergル'Ssections Nigri及び。'Cumdaliのカビ毒産生性とコーヒー豆のカビ毒汚染
橋本ルイコl,中川博之2,陰地義樹3,浅野勝佳3,横山耕治4,高橋治男5
1千葉県衛生研究所(干260-8715 千葉県千葉市中央区仁戸名町666-2)2農業・食品産業技術総合研究機構食品総合研究所(干305-8642 茨城県つくば市観音台2・1・12)3奈良県保健研究センター(干633-0062 奈良県桜井市粟殿1000)4千葉大学真菌医学研究センター(干260-8673 千葉県千葉市中央区亥鼻1-8-1)5国立医薬品食品衛生研究所(〒158-8501 東京都世田谷区上用賀1-18-1)
本邦がその多くを輸入しているベトナム産コーヒー豆について,カピ毒産生菌及びカピ毒による汚染の調査を行った
採取した16サンプルからは,Aspergillus niger (種複合体,汚染粒率56_6%), Aspergillus cαrbonαrius (3_3%) ,
Aspergillus section Circumd,αti (2_9%)を含む複数のオクラトキシンA(OTA)産生菌が検出された.形態により
A nigerと関連菌種及び、sectionCircumdαtiと同定された株のうちの一部について, sチュープリン及びミトコンドリア
チトクロームb遺伝子を用いて菌種を同定し,カピ毒産生性を調べた.豆から分離された主要な菌はA nigerで、あっ
た SectionCircumdαtiの分離株はAspergillusωesterdijkiaeあるいはAspergillusmelleusと同定され,Aspergillus
ochrαceusは認められなかった LC-MSIMSによりそれらの分離株のカピ毒産生性を分析した結果, Acαrbonαrius及び、
A westerdijkiaeで、大量のOTAの産生が見られたが, A nigerで、はOTAの産生は少量で、あったことから,豆のOTA汚染の
原因はA nigerよりAcαrbonαrius及びA westerdijkiaeで、あると考えられた.また, A niger株におけるフモニシンB2
(FB2)の産生率は90%と高率であった. 2つのサンプルからはそれぞれOTA(2_3μglkg)あるいはFB2 (55μg/kg)が,
1つのサンプルからは両方のカピ毒が検出された (6_3μglkgOTA, 49μg/kg FB2) .これらの結果は,ベトナム産コー
ヒー豆にはOTA産生菌とFB2産生菌が一般的に存在しており,まれにそれらの菌によるカピ毒汚染が発生していることを
示している.
キーワード:アスペルギルスセクションサーカムダティ;アスペルギルスセクションニグリ;オクラトキシン;フモニシン;
ベトナムコーヒー;ミトコンドリアチトクロームb遺伝子