GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Helping The World Bounce Back
Magnum Board®
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
©2011, Magnum Board® All rights reserved.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
CURRENT INDUSTRY PROBLEM
Wood based products: Swells, rots, susceptible to insects such as termites and carpenter ants, flammable, can feed mold and mildew and when chemically treated may be toxic.
Portland cement based products: Respirable dust can be carcinogenic , difficult to work with (heavy), excessive expansion and contraction challenges.
Gypsum Based products: Susceptible to water and fire damage, known to feed mold and mildew, and is currently experiencing high rates of litigation due to chemical compounds that contribute to respiratory diseases and is corrosive to metals
Fiber resin based products: Susceptible to fire and its resultant off-gassing.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
COST TO UNITED STATES RESULTING FROM KNOWN INDUSTRY PROBLEMS
Fire: According to a 2010 National Fire Protection Agency report, $18.6 billion in property damage was caused by fire.
Water: According to AMI, water intrusion is the primary reason for mold and mildew. In addition to this cost, as noted below, billions more are spent annually on water damage repair.
Insects: Western Pest Services reports that over $2 billion are spent annually on pest control and another $5 billion on pest damage and this covers TERMITES ONLY.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
COST TO UNITED STATES RESULTING FROM KNOWN INDUSTRY PROBLEMS
Mold and Mildew: According to AMI, as far back as 2002, building material damage exceeded $25 billion and another $15 billion was attributed to illnesses associated with Mold and Mildew.
Toxins: According to Bob Connor and the Seattle PI Health and Fitness News, billions are spent annually as a result of toxin exposure.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Gypsum: Drying process utilizes over 1% of the power generatedin the US today and contributes greatly to global warming.
Portland Cement:Manufacturing process emits a great deal of CO2 into theatmosphere and releases particulate carcinogens into the air.
Wood Based Products: Every old growth forest cut down takes hundreds of years to fully regenerate the ECO system. Some of the adhesives used to make OSB contribute to respiratory issues due to out-gassing.
©2011, Magnum Building Products. All rights reserved.
NEGATIVE ENVIRONMENTAL IMPACT FOR USING THESE COMPETITIVE PRODUCTS
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
SOLUTION (continued)
Magnum Board® (Trademark) is a GREEN product and is superior to its competitors for the following reasons:
Virtually impervious to fire• Non combustible• Zero flame spread• Zero smoke developed• UL approved
Virtually impervious to water• Can be submerged for long periods of time with no dimensional affects
Virtually impervious to all insects• Termites• Carpenter Ants
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
SOLUTION (continued)
Magnum Board® Products
• Do not feed mold or mildew• Are non-toxic – asbestos and formaldehyde free• Have no toxic VOCs• Absorbs CO2 from the air
Magnum Board® Products are gaining World recognition• Highest quality• Most tested MgO product on the market today
— Fully tested to AC386 published by the ICC-ES— Tested to US - ASTM standards— Underwriters Laboratory (UL) approved in US and Canada
• Strong R & D program to bring on newer, more competitive products• Most trusted MgO sheathing, siding and trim product supplier
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
MAGNUM® BOARD PRODUCT LINE
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Sheathing
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
OTHER MAGNUM® PRODUCT APPLICATIONS
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Exterior Insulation and Finish Systems
Skins for Structural Insulated Panels (SIPS) and Light Gauge Structural Steel Systems.
Fencing for Subdivisions, individual homes, farms ranches, by interstates and many other Fencing applications. Strong, long lasting,aesthetically pleasing and unaffected by any known insects.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
MAGNUM® PRODUCT STORAGE, HANDLING & INSTALLATION GUIDELINES
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338, Issue 3
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338, Issue 3
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Storing & Handling Magnum® Products Refer to MBP Storage and handling Guidelines No.: 083007-1338, Issue 3
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Step 4Installing Magnum® Ceiling Board Refer to MBP Installation Guideline No.: 090509-1405, Issue 4
Step 1
Step 2
Step 3
Step 4
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Sheathing - Standard Tape and Joint Compound Finish Refer to MBP Installation Guideline No.: 090509-1405, Issue 4
Using Tapered Product
Step 1
Step 2
Step 3
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Sheathing - Standard Tape and Joint Compound Finish Refer to MBP Installation Guideline No.: 090509-1405, Issue 4
Step 4
Step 5
Step 6
Step 7
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Sheathing - Standard Tape and Joint Compound Finish Refer to MBP Installation Guideline No.: 090509-1405, Issue 4
Step 8
Step 9
Step 10
Step 11
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Step 13
Installing Magnum® Sheathing – Standard Tape and Joint Compound Finish Refer to MBP Interior Painting Guidelines No.: 071509-1235, Issue 1 (Sherwin Williams)
Step 12 - Optional
Step 14
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Sheathing Refer to MBP Interior Butt Joint Installation Guideline No: 051411-1412, Issue 1 or Exterior Butt Joint Installation Guideline No.: 111309-1108, Issue 3
Using Magnum Beveled Edge Product
Step 1
Step 2
Step 3
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Shower Installation
Installing Magnum® Backer Board and Underlayment Refer to MBP Installation Guideline No: 090508-1545, Issue 2, prepared and endorsed by Mapei.
Standard installation
Tiling the Tub
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Coming Soon
Installing Magnum® Wood Veneer Paneling Refer to MBP Installation Guideline No: 10010900, Issue 4
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Wall Frame A
Wall Sheathing B
Weather Resistant
Barrier
C
“Z” Flashing D
Starter Strip E
Ledger Board F
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Wall Frame A
Wall Sheathing B
Weather Resistant
Barrier
C
Step Flashing with 2”
Clearance
D
Starter Strip E
Roof Underlayment F
Roof Framing G
Roof Sheathing H
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Wall Frame A
Wall Sheathing B
Weather Resistive
Barrier
C
Treated Bottom Plate D
Moisture Barrier E
Starter Strip F
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Blind NailWe highly recommend installation of Magnum® Lap Siding by the blind nailing technique, such that fasteners are hidden by the course above (pic.1). Fasteners shall be installed between 1in and 1-1/8 in. from the top edge and no closer than 3/8 in. from the ends of the plank (pic.2).
Fasteners must be corrosion resistant, galvanized or stainless steel.
Overlap gauges help ensure straight and level Magnum® Siding installation
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Pin BacksPinning the Magnum® Siding down at the bottom edge is a common practice called “pin back.” It is used to correct “high nailing”, loose planks, gaps or rattling. Pinning of the butt joints is not intended to increase wind load values; and shall be installed 3/8” from end and between 3/4” and 1” from bottom edge (pic.3). The fastener shall be installed flush to the surface (not countersunk), must be corrosion resistant (e.g. galvanized or stainless) and does not provide structural support. For best aesthetics nail heads should be touched up to color match.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Lap Siding Refer to MBP Installation Guideline No: 112809-1203, Issue 4
Face NailingFace nailing is applicable where dictated by building code, in high wind areas, and when fastening is to OSB or equivalent sheathing without penetrating into studs.Face nailing exposes the fastener head to the elements and allows for the fastener to penetrate through two sheets of overlapped plank (pic.4
Fasteners shall be installed between 3/4” and 1” from the bottom edge of the board (pic.5) and the head must be snug, not counter-sunk or overdriven.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Soffit is available ventilated and non-ventilated; and, in both wood grain and smooth profiles.
Installing Magnum® Ventilated and Non-Ventilated Soffit Refer to MBP Installation Guideline No: 112809-1202, Issue 2
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Ventilated and Non-Ventilated Soffit Refer to MBP Installation Guideline No: 112809-1202, Issue 2
Fascia A
Wood Sub-fascia B
Siding C
Brick or CMU D
Starter Strip E
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Installing Magnum® Board in Exterior Insulated Finish System (EIFS) Applications - Refer to Manufacturers Installation Guidelines
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
#8 Magnum® Products to Steel: Quik Drive or equal(Recommended steel thickness 16, 18 and 20 gauge)
Features:• #2 Undersized square drive – BIT2SU• Nibs under the head for easier countersinking• #2 drill point with wings• Ribbed flat head• Quik Guard® coating• Curved collation
Pro 200
Pro 250
Pro 300S
Model Shank Length TPI Point
Size
Carton Qty
CBSDQ158S
8 1 5/8” 18 2 1500 X X X
CBSDQ214S
10 2 ¼” 18 2 1000 X
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
#7 Magnum® Products to Wood – Quik Drive or equal
Features:• #2 Square drive – BIT2S• Nibs under the head for easier counter-sinking• Sharp point • Trim head• Available with yellow zinc
dichromate and gray phosphate
coatings• Curved collation
Pro 200
Pro 250
Pro 300S
Model Shank Length TPI
Point Size
Carton Qty
CBSDQ158S 8 1 5/8” 18 2 1500 X X X
CBSDQ214S 10 2 ¼” 18 2 1000 X
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
MAGNUM® PRODUCT INSTALLATIONS
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® ModulesBeing factory assembled for field installation.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® ModulesFabricated in the factory for jobsite installation.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Board® Modules
Magnum Board is impervious to fire, water and all insects; is non combustible and non flammable; does not feed mold or mildew; and is completely non toxic and has no toxic VOCs
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Wall Section
Being shop assembled and readied for field installation.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Wall Panels
Are rugged. These wall panels are enroute to a jobsite
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Wall Section
Being lifted into place at the jobsite.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
field erected.
Magnum® GableFactory assembled field erected.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Board®
Is always safely packaged to ensure you receive top quality material at your point of delivery, every time.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Bahama Cottage
Magnum Board® products are approved for both interior and exterior sheathing applications.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Bahama Cottage
Magnum Board® products are approved for both interior and exterior sheathing applications.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Tarpon Springs, Florida Hotel Luxuriate
Notice the level 5 factory prepared finish achieved when using Magnum® interior sheathing
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”©2011, Magnum Building Products. All rights reserved.
Magnum® Interior Sheathing
Magnum® Sheathing is durable and flexible. Notice the curvatures in the bathroom.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Interior Sheathing
Notice the curved bar in the kitchen of the Tarpon Luxuriate. Magnum® sheathing finishes easily and quickly saving installation time and money.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum® Sheathing
Being installed in the interior and exterior of a retirement cottage high in the mountains of Georgia.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Board® Interior Sheathing
Installed at the office of Invision Architects, Tampa, Florida. Notice the level 5 finish and how smooth the cut outs are for their samples and product literature. ©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Board® Receptionist Center
This beautiful receptionist center was built exclusively with Magnum Board® sheathing showing not only its beauty, but how easy it is to work with. The walls behind are also Magnum® Wall Board.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Structural Insulated Panel (SIP) Home
Magnum Board® is extremely versatile and can be substituted for most sheathing in the market place today providing a structure that is aesthetically pleasing and guaranteed to last for generations
See our website at www.magnumbp.com for more pictures of this beautiful structure.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Composite Building Structures Ltd
ALT Technologies has selected Magnum Board® products for all sheathing and trim for their home structures. This is a display home being erected in their headquarters in FL. NASA tested to > 200mph wind resistance.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Eleuthera Bahamas Luxury Home
Magnum Board® products are being installed as both interior and exterior sheathing in this luxurious Bahamas home. Unaffected by the elements, no worries about weather damage during construction.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Mobile Bay Hurricane Proof Home
Magnum Board® was selected as the interior sheathing for this Hurricane Proof Home. See installations on next three-(3) slides.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Mobile Bay Hurricane Proof Home
Magnum Board® installed in the hallway.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Mobile Bay Hurricane Proof Home
Magnum Board installed in the foyer.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Mobile Bay Hurricane Proof Home
Magnum® Ceiling Board being installed.
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
Magnum Board Products are unique.
Tested to ICC AC386 and UL Approved
Cannot be compared to any other product on the market today.
Install it once – install it for health – install it For life
LETS HELP THEWORLD BOUNCE BACK
“TOGETHER”
©2011, Magnum Building Products. All rights reserved.
GOTTA GO GREEN
HOME of MAGNUM BOARD®
“The New Generation Building Material”“Install It For Health-Install It For Life”
See our website at: WWW.Magnumbp.com
Contact us at: [email protected], or [email protected]
Or call our home office at: 813-314-2202Facsimile No.: 813-314-2203
Often copied – never duplicated. Always demand the original
Magnum Board®
On Behalf of Mother Nature – Thank You
©2011, Magnum Building Products. All rights reserved.