IPS 350/400/450/500/600, IPS 800/900, IPS 1050/1200
Joystick
Levers
8
Installation Procedure: EVC- Volvo Penta IPS QuadInstallation Procedure: EVC-E Volvo Penta IPS Quad
Document number: 47702215
Release date: 06-2012
Flybridge
Typical installation /Main station
Propulsion unit connections
IMPORTANT! This end of Y-connector must be connected directly, without extension, to levers.
IMPORTANT! Never cut or modify the Volvo Penta EVC harnesses. For extra power supply, use the Volvo Penta relay for external accessories.
IPS 350/400/ 450/500/600
Y-connector
IPS 800/900/ 1050/1200
Multiple helm stations
Oil temperature and pressure
Oil temperature and pressure
Datalink to SUS
Datalink to SUS
Reverse (SECONDARY)
Reverse (SECONDARY)
Forward (PRI-MARY)
Forward (PRIMARY)
Rev. pickup
Rev. pickup
Additional multilink features:
Multilink minimum requirements:NOTE! Minimum four 2.5” displays or two 7” display.Maximum two 7” displays on one helm station.
JoystickSteering wheel
Multilink hub
Multifunction panel(Start/Stop panel)
Buzzer
Dynamic Positioning System interface
Dynamic Positioning System antenna
7” displays
Levers
Lever connections
HCU connec-tions
Stand-alone HCU
Stand-alone HCU
Buzzer
2
6
7 7
9
3
12
27
Stand-alone HCU
Use cable ties to fix cables
11 11
11
11 11
6 6
10
Connecting multiple Multilink hubs
OK!
For information on cable lengths etc. please refer to Installation manual.
NOT OK!
27
18
15 15
10
4
Docking station
Joystick
Buzzer Multifunction panel(Docking station panel)
Stand-alone HCU
Stand-alone HCU
11
15
10
6
27
11
OK!
To next helm station
Helm station
Engines Engines
11
11
11
77 77
8
8
8
To next helm station To next helm station
ACP – Active Corrosion ProtectionIPS2 / IPS3 example
To transom unit 2
To transmission cableTo AUX-bus
To transom unit 1
Connect to the outmost IPS unit
Connect to the center IPS unit
SteeringControlsSteering unit Joystick
Use template when making holes in dashboard
Use cable ties to fix cables
Tilt adjuster bracket
Steering wheel hub
Max. 15 mm (0.59”) dashboard thickness
Battery ManagementNegative terminal
Starter motor
Remote frequency reciever with WLAN (RFW)
Continuous output 20 A
B: fused output
A: unfused output
House loads
2.5” Battery Management display
Battery sensor
To engine connector (AUX)
To external switches (optional)
Termination plug
5
8
To next helm station
Starboard e-Key panel
Multlink hub
7” displays
29
Buzzer
Port e-Key panel
Steering wheel
6
77
Termination plug
121212
7
7
7
77
21 21 2121
Engine connections
IPS 350/400/450/500/600
IPS 800/900 IPS 1050/1200
AU
X BU
SA
UX B
US
AU
X BU
S
AUX BUS
AUX BUS AU
X BU
S
SEN
DER
S
DATA
LINK
DATALINK
DATA
LINK
SENDERS SEN
DER
S
A
B C
ENGINE CONN.
DIAGNOS
Connection locations
BA C
To NMEA2000 backbone
Autopilot 4” display
9
109
7
5Battery Control Unit
(BCU)Battery Control Unit
(BCU)Battery Control Unit
(BCU)Battery Control Unit
(BCU)
2.5“ Battery Manage-ment panel
Battery sensor Battery sensorBattery sensor Battery sensor
Multisensor
1 1 1 1
Termina-tion plug 5
Engine EngineEngineEngine
Autopilot 4” display
NMEA2000 backbone
Female terminator
Male terminator
ChartplotterEVC AutopilotCompass (CCU)EVC Autopilot
Battery 12 VDC
T-connectorBackbone ex-tension cable
Fuse
Power cable
23 20
202020Use AUX relay
24 20 22 24
11
CPM
9
20
15 15
7
ADU
NMEA interface
10
1010
10
16
161616
9
2710
9
15
6 11
AUX-bus termination
Correct!Termination in the beginning and at the end of the AUX-bus
Incorrect!No end termination of the AUX-bus
Termination plug
Termination plug
55
To NMEA 2000 backbone
Compass (CCU)
20
20
7
11
47
70
22
15 0
6-2
012
Components and CablesControls
Levers
Built-in HCUs
Levers
“Palm Beach”
In combination with A-CAN
Steering wheel non tilt adjuster
Steering
Joystick
Incl. cables 1.5 m (5 ft.)
Steering wheel tilt adjuster Steering wheel hub
Incl. cables 2.5 m (8 ft.)
Fresh water level **
Diameter 52 mm (2.05”)
EVC system tachometer
Diameter 85 mm (3.35”) 110 mm (4.33”) 0–4000 rpm
Coolant temp **
Diameter 52 mm (2.05”) C°, F°
Speedometer Unitless **
Diameter 85 mm (3.35”) 110 mm (4.33”)
0–40 1/Hour 0–60 1/Hour
Alarm instrument **
Diameter 52 mm (2.05”)
Voltmeter **
Diameter 52 mm (2.05”) 12 V, 24 V
Rudder indicator **
Diameter 52 mm (2.05”)
Front ring kit (nut)
Diameter 52 mm (2.05”) Black/Chrome
Diameter 85 mm (3.25”) Black/Chrome
Diameter 110 mm (4.33”) Black/Chrome
Front ring kit (clamp)
Diameter 52 mm (2.05”) Black/Chrome
Diameter 85 mm (3.25”) Black/Chrome
Fuel level **
Diameter 52 mm (2.05”)
Engine oil pressure **
Diameter 52 mm (2.05”) bar, psi
Turbo pressure **
Diameter 52 mm (2.05”) bar, psi
4-in-1 Gauge **
Diameter 110 mm (4.33”) Coolant temperature Voltage Oil pressure Fuel level
Aux. Dimmer Unit (ADU) **
Instruments**) Only in combination with EVC system tachometer
ADU
NMEA interface
Cables
1 b. Wiring harness
IPS 800-900
Feet Meter Part no.
4.3 1.3 21851490 5.6 1.7 21851491 7.2 2.2 21851492 8.5 2.6 21851493 10.2 3.1 21851494 11.5 3.5 21851495 18 5.5 21851496
1c. Wiring harness
IPS 1050-1200
Feet Meter Part no.
4.3 1.3 21759842 5.6 1.7 21759840 7.2 2.2 21758217 8.5 2.6 21758219 10.2 3.1 21758220 11.5 3.5 21758221 18 5.5 21858754
2. Multisensor Y-split*
Feet Meter Part no.
1.9 0.6 21825662
*) Wiring harness AUX-bus.
3. BM-display Y-split*
Feet Meter Part no.
1.9 0.6 21825656
*) Wiring harness AUX-bus.
4. CPM Y-split*
Feet Meter Part no.
1.9 0.6 21825665
*) Wiring harness AUX-bus.
1 a. Wiring harness
IPS 350-600
Feet Meter Part no.
1.9 0.6 21865860 4.3 1.3 21260204 5.6 1.7 21260205 6.2 1.9 21865861 8.5 2.6 21260207 10.2 3.1 21260208 11.5 3.5 21395663
7. Standard EVC bus cable, 6-pin*
Feet Meter Part no.
16 5.0 874789 23 7.0 889550 30 9.0 889551 36 11.0 889552 42 13.0 888013
*) One cable per engine has to be ordered.
8. Y-connector, 6-pin
Feet Meter Part no.
1.6 0.5 3588972
10. Multilink cable, 6-pin
Feet Meter Part no.
5 1.5 3886666
6. Y-split steering, 6-pin
Feet Meter Part no.
1.3 0.4 21421941
9. 7” display cable, 6-pin
Feet Meter Part no.
5.5 1.7 21514712*
*) Incl. in display kit
5. Termination plug
Part no.
21825714
11. Extension cable, 6-pin
Feet Meter Part no.
5 1.5 3889410 10 3.0 3842733 16 5.0 3842734 23 7.0 3842735 30 9.0 3842736 36 11.0 3842737 66 20.0 21172469 131 40.0 21172470
16. Extension cable, 3-pin
Feet Meter Part no.
3 1.0 874759 10 3.0 3807043
12. Sender cable, 6-pin
Feet Meter Part no.
16 5.3 3807229
15. Extension cable, 6-pin
Feet Meter Part no.
5 1.5 21480272
14. Extension cable, 6-pin
Feet Meter Part no.
23 7.0 21166002 30 9.0 21166003 43 13 .0 21166004
19. Display cable, 5/6-pin
Feet Meter Part no.
5 1.5 21640400
Incl. in display kit
20. NMEA2000 Extension cable
Feet Meter Part no.
1 0.3 21812185 6.6 2 21812194 13 4 21867150 19 6 21867151 33 10 21867152
21. Battery sensor cable
Feet Meter Part no.
9.8 3 21840060
17. Steering adapter, 12/6-pin
Feet Meter Part no.
0.6 0.2 21421945
18. Y-split multilink, 6-pin
Feet Meter Part no.
1.6 0.5 3588206
22. NMEA2000 T-connector
Part no.
21812195**
e-Key (standard)
Locking/unlocking the boat system
e-Key System
e-Key remote (optional)
Locking/unlocking the boat system. Controls main circuit breaker and two aux relays
Components
Stand-alone HCU e-Key panel
Ignition, start/stop and remote sensor
Multilink hub
6 cable sockets
2.5” display
Not in combination with 7” display.
Multifunction panel
Function configured at startup
7” display
Not in combination with 2.5” display
7” display power supply for 12 V systems
Incl. cables 0.5 m (1.4 ft.)
Autopilot 4” display
Color display
ACP Kit
CPM unit, two transom units IPS 800-1200
Remote frequency reciever
with WLAN
Battery Control Unit Battery sensore-KeyCompass (CCU) Autopilot interface NMEA 0183 interface NMEA 2000 interface
Dynamic Positioning System interface
Multisensor
Transom mounted
A-CAN
Analog lever interface
Multisensor
Hull mounted
Sender
Fuel level sender 3–180 ohm
Fuel level sender 240–30 ohm
Sender
Water level sender 3–180 ohm
Clear Wake Exhaust System
Only for IPS800-1200
Dynamic Positioning System antenna
ACP Kit
Transom unit
ACP Kit
CPM unit, one transom unit IPS 350-600
e-Key Remote
13. Aux. relay cable, 6-pin
Feet Meter Part no.
3.3 1.0 21427463
Kit with cable & relay 12V: 21475508 24V: 21475509
24. NMEA2000 Termination plugs
Type Part no.
Male 21812196** Female 21812203**
23. NMEA2000 Powercable
Feet Meter Part no.
6.6 2 21812205**
**) Incl. in Autopilot kit
27. Y-split Hub triple & Quad, 6 pin
Feet Meter Part no.
3.2 1.0 21287072
29. e-Key harness Quad
Feet Meter Part no.
5 1.5 21876876
10
1010
10
16
161616
9
2710
9
