ebms & optimal audit 19 july 2011

Overall Contents of This Session

Part 1: General Lessons Learnt in Energy Management Transformation – Prof Dr Zainuddin Abdul Manan

Part2: Implementation of Sustainable Energy Management System - The Case of Universiti Teknologi Malaysia. Masilah Bandi, Ahmad Khairul Nizam , Prof Dr Wahid

UTM In-House Products (10 minutes) Online Energy Billing and Monitoring System - AK Optimal Audit Software for Macro and Technical

Level Energy Management – Prof Zain

Electrical Billing Electrical Billing Management SystemManagement System

http://161.139.20.111/Defaultebms.aspx

2

HistoryHistory

Based on CMMS engine developed by in-house expertise.

EBMS was launched in the year 2010. Data from way back from year 2004. Before we took about 3 days average to

report energy consumption report to the EAC/PTJ.

After installation it took only two hours to generate report to the EAC/PTJ.

Top 10 Energy Consumers Top 10 Energy Consumers (Colleges)(Colleges)

FAB Data From Jan 2009 till FAB Data From Jan 2009 till June 2011June 2011

Energy Consumption for UTM Energy Consumption for UTM CampusCampus

Utility Page – Gross Floor Utility Page – Gross Floor Area DataArea Data

…your fine chemical partner...

Supported by

Presented by:

©Copyright PROSPECT, UTM MWR- 8Maximum Water Recovery Targets

Prof Dr Zainuddin Abd MananIr Dr Sharifah Rafidah Wan Alwi

Optimal Audit – A 3 in 1 Optimal Audit – A 3 in 1 software for energy, software for energy, wastewater and gas wastewater and gas

emission auditemission audit

©Copyright PROSPECT, UTM Maximum Water Recovery Targets MWR - 9

13

(i) Macro/Company level (i) Macro/Company level Utility AnalysisUtility Analysis

Energy Management Energy Management MatrixMatrix


Utility Type AllocationUtility Type Allocation


Utility Cost AllocationUtility Cost Allocation


Utility Bill EvolutionUtility Bill Evolution


Sectional/unit utility load Sectional/unit utility load distributiondistribution


Trend AnalysisTrend Analysis


Energy Efficiency Index Energy Efficiency Index (EEI)(EEI)


21

(ii) Macro level Improvement(ii) Macro level Improvement

Tariff Switching AnalysisTariff Switching Analysis


Fuel Switching AnalysisFuel Switching Analysis


24

(iii)Technical Level (iii)Technical Level Improvement (Energy Improvement (Energy Accounting Centres Accounting Centres

(EAC) Level)(EAC) Level)

(a) Electricity Reduction (a) Electricity Reduction SchemeScheme


Load ManagementLoad Management


Power Factor Analysis & Power Factor Analysis & ImprovementImprovement


Lighting AnalysisLighting Analysis


Self-Generation AnalysisSelf-Generation Analysis


(b) Electricity Consumer (b) Electricity Consumer ReductionReduction


Motor/Fan AnalysisMotor/Fan Analysis


(c) Steam Generation & (c) Steam Generation & DistributionDistribution


Boiler AnalysisBoiler Analysis


(d) Heat system (d) Heat system improvementimprovement


Heat Pump AnalysisHeat Pump Analysis


Heat Exchanger AnalysisHeat Exchanger Analysis


37

(iv)Wastewater Analysis(iv)Wastewater Analysis

Wastewater AnalysisWastewater Analysis


39

(v) Gas Emission Analysis(v) Gas Emission Analysis

Gas Emission AnalysisGas Emission Analysis


Greenhouse Gases Greenhouse Gases CalculationCalculation


@Copyright PROSPECT, UTM Network Design ND - 44

ebms & optimal audit 19 july 2011

Business