eshine install manual eshine install manual - negative + positive through pole to control board...
TRANSCRIPT
eSHINE Install Manual
1. Base Section2. Battery & Control Access hatch3. Pole Dress Ring4. Top section5. Light arm6. LED lamp7. Glassless solar panels8. Battery location9. Control board �ts in base section ( 1 )10 Solar tilt bracket assembl y11. Batteries �t in base section ( 1 )
7
B1
B2
B3
B4
BatteryS olar Lamp
B1 B2 B3 B4 S1 L1 L2 L3 BatteryS olar Lamp
B1 B2 B3 B4 S1 L1 L2 L3
FIELD WIRE TERMINATION
Solar ( Yellow +, Black - )Batteries ( red +, Black - )
LED ( Orange +, Black - )
12
3
4
8
9
11
12
NOTE- Install pole dress ring before light arm orsolar tilt bracket assembly
12
SOLAR CONTROLLER
CIRCUIT BREAKERS
LED DRIVERS
+ - + - + - + - + - + - + - + -
To Load
eSHINE POWER STATION S1, S2, S3 & S4
1. Layout base (1) and Top (4 ) sections2. Use M16 socket bolts & washers 3. Slide on square dress ring 3)4. Run solar cable and load cable5. Bolt Light arm (5) using M12 socket bolts 6. Slide on Square light arm dress ring (10)7. Connect solar tilt assembly to solar tray8. Connect Solar Tilt Bracket assembly (11) 9. rotate to face True north ( South Hemi )10. Mount Load and terminate wiring11. Crane into position12. Solar panels can be installed on the ground or after the pole is craned into position *
©2014-2015 Valen energy , L L C. All rights reserved.
Factory 98-10 Pioneer Dr.Woonona, NSW 2517
+1 512-222-5550
2101 east st elmo rd Suite 310
Austin, TX 78744 +61 2 8005-6858
Valen energY
eSHINE Install Manual
- Negative
+ PositiveThrough Pole To Control Board
Solar panel wiring assembly ( 2 panels )
Solar Tilt Bracket assembly
Slide the solar tray over the Panel/s and centre it to the solar panel/sThe tray has holes which intercept the solar panel frame use the self drilling screws to secure solar panel to solar tray ( 4 self drilling screws )Slide solar tilt bracket onto the solar tray and secure with 4 boltsFeed wire into the tilt bracket and out into the solar panel and connect+ and - wire. Place backing sheets onto the solar panel and screw down
©2014-2015 Valen energy , L L C. All rights reserved.
8-10 pioneer driveWoonona, NSW 2517
+1 512-222-5550
2101 east st elmo rd Suite 310
Austin, TX 78744 +61 2 8378 5917
Valen energY Factory 9,
eSHINE Shadowing
Midday Sun
Trees blocking sunlight all morning
East
6 Hr RUN TIME ORREDUCE LUMEN VALUE
Midday Sun
Trees blocking sunlight until mid morning
East
9 Hr RUN TIMEORREDUCE LUMEN VALUE
When selecting solar power it is important to position the system to optimise sunlight exposure. Trees and buildings are a common issue for solar systems but there is always a solution. You can reduce run time orreduce wattage ( Lumen value ) of the system.
Below are some examples of shadowing and how to adjust the system to function in these situations.When reducing run time the system can always run all night ( but you need to dim during the mid part of the night) you simply split the time so you receive full power during peak periods, reduce the lumen value
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE Shadowing
SUMMER SUN
WINTER SUN
Santa Barbara latitude is 35oNSUMMER- June 21 solar noon zenith angle = 35 - 23.5 = 11.5o (sun angle = 78.5o)WINTER- Dec. 21 solar noon zenith angle = 35 - (-23.5) = 58.5o (sun angle = 31.5o)
Winter sun angle calculation
31.5 degrees
78.5 degreesSUMMER
WINTER
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE Shadowing
Midday Sun
Trees blocking sunlight mid afternoon
East
9 Hr RUN TIMEORREDUCE LUMEN VALUE
Trees blocking sunlight to 3 bollards
East
Solution- Utilise a Vertaic or eSHINE power system to elevate above trees and run low voltage cable to bollards
Low voltage cable is run in shallow underground conduit to power the lighting systems surrounded by trees
Remote power stations- Trees blocking solar powered vertaic bollards
vERTAIC and eSHINE power systems
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S1 Diagrams
A - A B - B C - C
AA
CCC
B
B
200x200mm (7.87” x 7.87”)
TW x TW
150mm ( 5.91”)
ø60m
m (2
.36”
)
1900
mm
( 74
.80”
)
1300
mm
(51.
18”)
500m
m (1
9.69
”)
200mm (7.87”)
200m
m (7
.87”
)
D
Section D
TW Square Section
Solar tilt Section
Anchor Bolts
800m
m (
31.5
”)
80m
m (
3.15
”)
80mm (3.15”)
M30
TS
LH
45°
Solar Bracket
PH
2450mm (8’) 3960mm (13’) 5490mm (18’) 7000mm (23’)
3050mm (10’) 4500mm (15’) 6000mm (20’)
120mm (4.7”) 120mm (4.7”) 120mm (4.7”) 120mm (4.7”)
360mm (14.1”) 1048mm (3.5’) 2570mm(8.4’) 4095mm(13.4’)
N/A
NOTE:1. All measurements are in mm with imperial measurements shown in ( )2. Inches have the following symbol “ 3. Feet have the following symbol ‘
2000mm ( 6’ ) 3000mm ( 10’ ) 4500mm ( 15’ ) 6000mm ( 20’ )POLE HEIGHT
PH
LH
TWTS
SET ( GRUB ) Screws
Solar Tilt Section
Battery and controlAccess panel
Base plate ( see base template for anchor dimensions )
Connection Between base and top sections
4 per pole
1000mm(39”) OR 2000mm(78”)
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S2 Diagrams
AA
CCC
B
B
250mmx 250mm (9.84 x 9.84”)
TW x TW
1920
mm
(78.
75”)
1300
mm
( 51
.11”
)
D
TS
LH
45°
PH
2450mm (8’) 3960mm (13’) 5490mm (18’) 7000mm (23’)
3050mm (10’) 4500mm (15’) 6000mm (20’)
120mm (4.7”) 120mm (4.7”) 120mm (4.7”) 120mm (4.7”)
360mm (14.1”) 1048mm (3.5’) 2570mm(8.4’) 4095mm(13.4’)
N/A
NOTE:1. All measurements are in mm with imperial measurements shown in ( )2. Inches have the following symbol “ 3. Feet have the following symbol ‘
2000mm ( 6’ ) 3000mm ( 10’ ) 4500mm ( 15’ ) 6000mm ( 20’ )POLE HEIGHT
PH
LH
TWTS
8500mm (28’) 10,000mm (33’)
7500mm (25’) 9100mm (30’)
150mm (5.9”) 150mm (5.9”)
5620mm(18.4’) 7910mm(26’)
7500mm ( 25’ ) 9000mm ( 30’ )
150mm ( 5.91”)
ø60m
m (2
.36”
)
Section D
TW Square Section
Solar tilt Section
Anchor Bolts
800m
m (
31.5
”)
80m
m (
3.15
”)80mm (3.15”)
M30
SET ( GRUB ) Screws
4 per pole
A - A B - B C - C
500m
m (1
9.69
”)
250mm (9.84”)
250m
m (9
.84”
)
Battery and controlAccess panel
Base plate ( see base template for anchor dimensions )
Connection Between base and top sections
Solar Bracket
1000mm(39”) OR 2000mm(78”)
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S3Diagrams
AA
CCC
B
B
TW x TW
1920
mm
(78.
75”)
D
TS
LH
45°
600mm (23.60”)
B
B
600mm (23.60”)
PH
2450mm (8’) 3960mm (13’) 5490mm (18’) 7000mm (23’)
3050mm (10’) 4500mm (15’) 6000mm (20’)
120mm (4.7”) 120mm (4.7”) 120mm (4.7”) 120mm (4.7”)
360mm (14.1”) 1048mm (3.5’) 2570mm(8.4’) 4095mm(13.4’)
N/A
NOTE:1. All measurements are in mm with imperial measurements shown in ( )2. Inches have the following symbol “ 3. Feet have the following symbol ‘
2000mm ( 6’ ) 3000mm ( 10’ ) 4500mm ( 15’ ) 6000mm ( 20’ )POLE HEIGHT
PH
LH
TWTS
8500mm (28’) 10,000mm (33’)
7500mm (25’) 9100mm (30’)
150mm (5.9”) 150mm (5.9”)
5620mm(18.4’) 7910mm(26’)
7500mm ( 25’ ) 9000mm ( 30’ )
Solar Bracket
150mm ( 5.91”)
ø60m
m (2
.36”
)
Section D
TW Square Section
Solar tilt Section
Anchor Bolts
800m
m (
31.5
”)
80m
m (
3.15
”)
80mm (3.15”)
M30
SET ( GRUB ) Screws
4 per pole
A - A B - B C - C
600m
m (2
3.60
”)
250mm (9.84”)
250m
m (9
.84”
)
Battery and controlAccess panel
Base plate ( see base template for anchor dimensions )
Connection Between base and top sections
250mmx 250mm (9.84 x 9.84”)
1000mm(39”) OR 2000mm(78”)
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S4 Diagrams
AA
CCC
B
B
300mmx300mm (11.81 x 11.81”)
TW x TW
D
TS
LH
45°
B
B
PH
2450mm (8’) 3960mm (13’) 5490mm (18’) 7000mm (23’)
3050mm (10’) 4500mm (15’) 6000mm (20’)
360mm (14.1”) 1048mm (3.5’) 2570mm(8.4’) 4095mm(13.4’)
N/A
NOTE:1. All measurements are in mm with imperial measurements shown in ( )2. Inches have the following symbol “ 3. Feet have the following symbol ‘
2000mm ( 6’ ) 3000mm ( 10’ ) 4500mm ( 15’ ) 6000mm ( 20’ )POLE HEIGHT
PH
LH
TWTS
8500mm (28’) 10,000mm (33’)
7500mm (25’) 9100mm (30’)
150mm (5.9”) 150mm (5.9”)
5620mm(18.4’) 7910mm(26’)
7500mm ( 25’ ) 9000mm ( 30’ )
Section D
TW Square Section
Solar tilt Section
Anchor Bolts80
0mm
( 31
.5”)
80m
m (
3.15
”)
80mm (3.15”)
M30
SET ( GRUB ) Screws
4 per pole
A - A B - B C - C
600m
m (2
3.60
”)
300mm (11.8”)
300m
m (
11.8
”)
Battery and controlAccess panel
Base plate ( see base template for anchor dimensions )
Connection Between base and top sections
600mm (23.60”)
600mm (23.60”)1920
mm
(78.
75”)
150mm (5.9”) 150mm (5.9”) 150mm (5.9”) 150mm (5.9”)
Solar Bracket
150mm ( 5.91”)
ø60m
m (2
.36”
)
1000mm(39”) OR 2000mm(78”)
4. Base section dimensions 1920mm ( 78.75”) may vary depending on battery sizes ( LH will remain the same but TS will change accordingly)
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S1 Base Plate Templates
400mm / 15.75”
400m
m /
15.7
5”
31mm / 1.22ӯ
58mm / 2.31”
58m
m /
23.
1”
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S2 Base Plate Templates
450mm / 17.71”
450m
m/
1 7
7.1”
31mm / 1.22ӯ
65mm / 2.59”
65m
m/
2 5.
9 ”
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S3 Base Plate Templates
450mm / 17.71”
450m
m/
1 7
7.1”
31mm / 1.22ӯ
65mm / 2.59”
65m
m/
2 5.
9 ”
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]
eSHINE - ePole-S4 Base Plate Templates
31mm / 1.22ӯ
500mm / 19.69”
500m
m /
19.6
9”
Valen Energy reserves the right to make changes at any time in order to supply the best product possible.
2101 East Saint Elmo Drive Suite 310
Austin TX 78744Tel: +1 512-222-5550
American Office Australian OfficeFactory 98-10 Pioneer DriveWoonona NSW 2517Tel: +61 2 8378 5917
www.valenenergy.com [email protected]