global ’ s environmental sustainability initiatives conform to standards iso 14001:2004 ecologo...
TRANSCRIPT
Global’s Environmental Sustainability Initiatives
Conform to Standards ISO 14001:2004 EcoLogo Certification Greenguard
ISO 14001 A Series of
International Standards on Environmental Management
The implementation and compliance are audited by a third
party (CGSB)
ISO 14001Environmental Management System
Reduce Material Waste-Sort and Divert –We diverted 87%
Reduce Energy Use
Reduce Manufacturing Errors
Use Environmentally Friendly Materials (Glues, Cleaners)
Pollution Prevention
Use Materials with Recycled Content (Particle Board, Corrugated)
Convert to Waterless Printing Process
Reduce waste: office paper, toner cartridges
ISO 14001Environmental Management System
Reduce Material Waste-Sort and Divert –We diverted 87%
ISO 14001Environmental Management System
Recycle
In 2006, we reprocessed:
3.8 million pounds of post consumer polyprop
2.1 million pounds of wood waste
And produced 5.96 pounds of molded products:
Interior seats and backs
Panel Cores
ISO 14001Environmental Management System
Recycle
In 2006, we used material that was reprocessed:
200,000 yards of panel fabric made from 100% recycled polyester
650,000 lbs of panel insulation made from a byproduct waste material from steel mills
The most important raw material used in our panel is aluminum, which is the most most recycled raw material available
ISO 14001Environmental Management System
Panel Cores
ISO 14001Environmental Management System
Additional Environmental InitiativesReplaced all factory lighting with new T8 lighting at a cost of $200,000. Payback 18-24 months
Energy reduction 60%. Increase in illumination 50%
ISO 14001Environmental Management System
Additional Environmental Initiatives
•Reduced Natural Gas Consumption by 12% by changing the chemical used to clean the aluminum prior to painting
•Reduced electrical Consumption by 25%-new lighting
•Waste reduction: Savings $100,000 per year
Before 870 Metric tons of waste to landfill per year
Now: 100 metric tons of waste to landfill per year
EcoLogoEnvironmentally Preferred Products
North America’s Most Widely Recognized and Respected Multi-Attribute Environmental Certification Mark
Helps Buyers Find Sustainable Products from environmentally conscious factories
EcoLogo
Certification Criteria
•Product end of Use Recycling Information
•VOC Emission Restrictions
•Use of Coating to Restrict Off Gassing
•Content Stamping of Plastics
•Improved Energy Efficiency
•Reduce Noise Pollution in Manufacturing
LEED and Greenguard Created By USA
Green Building Council and Adapted for Canada
A Rating System to Evaluate Green Buildings
LEED
Defines “GREEN”
Design and Construction Practices that Significantly Reduce the Negative Impact of Buildings on the Environment and the Occupants
Global products are listed on the Greenguard web site www.greenguard.org
GreenguardBoulevard Product Line
This product has been GREENGUARD Indoor Air Quality Certified® by the GREENGUARD Environmental Institute under the GREENGUARD Standard for Low Emitting Products.
Certification Details: Certification No: F10Fw93211-1Certification Status: CertifiedCertification Period(s): 09/2004- 10/2007
Greenguard
Greenguard certification:
AQS conducts a 96-hour test, during which products are placed in a sealed chamber through which purified air is poured. The resulting exhaust is then tested for formaldehyde, volatile organic chemicals, respirable particles, ozone, carbon monoxide, nitrogen oxide, and carbon dioxide emissions. Also measured are how much a product emits at a certain point in time, how the emissions change over time, and how the test results translate into a real building environment.
Greenguard
GREENGUARD Indoor Air Quality Certified Products meet the following minimum emission requirements:
Individual VOCs < 0.1 TLV
Formaldehyde < 0.05 ppm (< 0.06 mg/m³)
Total VOCs < 0.5 mg/m³
Total aldehydes < 0.1 ppm
LEED-naturally lit classrooms
-aggressive recycling program.
-solar panels
-living roofs
-greenguard furniture