Hino Motors,Ltd. TOKYO,JAPAN

Spec. No. SS-FS314Drawing No. CDRFS340

RATINGS & AXLE LOAD LIMIT (kg) ( ) Maker design

RatingsFront: 315/80R22.5-156/153Rear : 295/80R22.5-153/150Front: 12R22.5-16PRRear : 11R22.5-16PR

CHASSIS DIMENSIONS (mm) : All dimensions are to standard specifications and unladen chassisModelProduction Code FS1EMKD FS1EMKM FS1ETKAApplication For dump For mixer For cargoWheelbase 3,920 + 1,310 5,075 + 1,310Overall length 8,040 10,760Overall widthOverall HeightCab to rear axle centerRear overhang (at frame end) 1,290Front Chassis Height 1,090Rear Chassis HeightRoad clearance (at diff. case) 245Front Tread 2,035Rear Tread 1,855Turning radius on tire 8,500 10,300Turning radius on wall to wall 9,200 11,100

CHASSIS MASS (kg) : Chassis mass quoted is to standard specifications without spare tire & std. tool set(Total)(Front)(Rear)

PERFORMANCE & GEAR RATIOS : Calculations based on 26.0 ton GVM, 295/80R22.5 tireMax. Speed (km/h)Gradeability tanθ (%)

Model1st2nd3rd4th

Transmission Gear Ratio 5th6th7th8th

Rev.ModelGear Ratio

- 1 -

CAOH

HR 1,110

Below 90 (controlled by speed limiter)

4,5603,955

HF1,070

SPECIFICATIONS

HHIINNOO 770000 SSeerriieess6x4, Truck Chassis

- RHD- 380 PS (Euro-4)- 28.3 ton GVMR

Rear AxleFront AxleGVM

2,490

6,500

7,500

HINO 72638

60.0

4.565 / 3.8163.023 / 2.527

ZF 16S22113.804 / 11.5399.487 / 7.9306.529 / 5.458

12.923 / 10.803

4.100

3,095

2.078 / 1.7371.430 / 1.1951.000 / 0.835

ROH

(Low/High)

FT

21,800

21,800

26,000 (28,300)

(STD)

(OPT)

8,515

Axle Load Limit

3,8652,915

WBOL

7,500

Chassis Mass

5,020

8,1854,6503,530

8,2004,6653,535

Rear AxleTHD17

EQUIPMENTS SS-FS314 ENGINE SERVICE BRAKE

1.Model HINO E13C UK 1.Type 2.Max. output;(Net) 279 kW {380 PS} at 1,800

r/min 3.Max. torque;(Net) 1,814 N-m {185 kgf-m} at 2.Wheel brake ass'y

1,100 r/min Drum diameter x Lining 4.Max. engine speed 2,000 r/min width 5.Type Front 406.4 x 152 mm

Rear 406.4 x 216 mm 3.Air drier Equipped 4.ABS system Equipped

6.Combustion system Direct injection type 5.Auto brake shoes adjuster Equipped 7.Bore and stroke 137 x 146 mm SECONDARY AND PARKING BRAKE 8.Piston displacement 12.913 L 1.Type, for FS1EMKD/MKM Spring brake acting on front 9.Compression ratio 17.0 and rear frontward wheels,10.Engine oil capacity 37.0 L for emergency and parking11.Engine coolant capacity 28.5 L purpose, manual control12.Fuel injection pump for FS1ETKA Type

Governor Electric governor13.Intake system STEERING Air cleaner Dual paper elements 1.Type14.Air compressor Type Single cylinder, water-

cooled Bore and stroke 85 x 60 mm15.Fly wheel P.T.O. 2.Gear ratio 21.4 - 23.816.Engine control link Equipped RETARDER17. Insect protection Equipped 1.Type Hino engine retarder

CLUTCH FRONT SUSPENSION 1.Type Dry single plate with damper 1.Type Semi-elliptic tapered leaf

springs springs with shock 2.Clutch disc ass'y CS-430 series absorbers and stabilizer 3.Facing material Semi-mold 2.Dimensions of springs 4.Facing outside diameter 430 mm Span 1,500 mm 5.Clutch cover ass'y DSP-430 series Width 90 mm 6.Control Hydraulic with air booster REAR SUSPENSION

TRANSMISSION 1.Type Semi-elliptic leaf springs 1.Type 16S221 with torque rods

2.Dimensions of springs Span 1,310 mm

2.Control Width 90 mmWHEEL AND TIRE

PROPELLER SHAFT 1.Wheel type 1.Propeller shaft ass'y T/M R/A Tube type 2.Rim size, front 22.5 x 9.00 - offset 175 mm R/A R/A Solid type rear 22.5 x 8.25 - offset 165 mm 2.Universal joints Round bearing type 3.Tire size, front 315/80R22.5-156/153 3.Center bearing 1-piece rear 295/80R22.5-153/150

FRONT AXLE 4.Number of tires Ten (10) numbers 1.Front axle ass'y MF78 series FUEL TANK 2.Type Reversed Elliot, " " section 1.Capacity

beam 2.Fuel pre-filter and Equipped REAR AXLE sedimenter

1.Type 3.Fuel tank cap key Equipped

- 2 -

ZF, sixteen forward and tworeverse speeds, overdrive,synchromesh 1st - 16th

Tandem axle,dual drive withinter axle differential, full flotingsingle reduction, single speedby hypoid gearings with interaxle differetial lock, "No SPIN"

Mechanical control withpower shift

300 L

Full air, dual circuit, taperroller type, leading & trailingshoes for front and rear

Diesel, turbo chargedintercooled, 4-cy., vertical,6-cyl., in-line, overheadcamshaft, water cooled

Electronic control commonrail type

Spring brake acting on rearwheels, for emergency andparking purpose, manualcontrol

Telescopic and tilt steeringcolumn with locking deviceRecirculating ball withhydraulic booster integraltype

10-stud disc wheels (ISOtype)

Equipped(for FS1EMKM only)

413SF-SS CHASSIS FRAME Fuel gauge

1.Type Ladder-shaped channel Coolant temperature gaugesection side rails Air pressure gauge

2.Rear chassis width 850 mm 2.Warning, pilot lamps and buzzers 3.Max. section (depth x 300 x 88 x 8.0 mm Engine oil pressure warning lamp and buzzer flange x thickness) (for FS1EMKD/MKM) Air pressure warning lamp and buzzer

302 x 88 x 9.0 mm Buck-up warning buzzer(for FS1ETKA) Charging warning lamp

4.Tensile strength 540 N/m?ｷ {55 kgf/m?ｷ} Beam indicator lamp 5. Hooks Equipped for front and rear Turn signal indicator lamp

CAB Parking brake indicator lamp 1. Type Coolant level warring lamp and buzzer

Differential lock indicator lampEngine over-run warning buzzerFuel level warning lampBattery charging pilot lampABS warning lamp

2. Seating capacity Two Engine retarder indicator lamp 3. Driver's seat Sedimenter water level warning lamp

Transmission splitter range indicator lamp 4. Side passenger's seat Urethane foam pads, high- 3.Switches

back and reclining seat with Lighting switchfabric cover and under tray Directional indicator, dimmer and passing switch

5. Center console Equipped Wiper and washer switch 6. Seat belts 3-point type on driver's & Hazard lamp switch

side passenger's seat Fog lamp switch Dome lamp switch

8. Windshield wipers Electric, triple, intermittent Warning lamp check switchand 2-speed Map lamp switch

9. Sun visor and Differential lock switchover-head console 4.Others

10.Center over-head console Equipped One-key starting-stopping11.Cigarette lighter Equipped Throttle control knob12.Ventilator Forced type by electric Horn button

blower ELECTRICAL EQUIPMENT13.Car heater and defroster Equipped 1.Type 24 volt, negative earth14.Sleeping bed Equipped 2.Batteries15.Car audio AM/FM radio with cassette Number per vehicle 12 V x 2, series-connection

tape and CD player Capacity 432 kC {120 A/h} at 20-16.Floor mat Vinyl type hour rate17.Front air spoiler Equipped(for FS1ETKA) 3.Alternator18.Cab step Equipped Type With built-in rectifier and 19.Trim voltage regulator

Capacity 24 V, 90 A20.Electrical power window Equipped with both side 4.Starter21.Electrical door lock Equipped Type Pinion shift22.Door pockets Equipped at both door side Capacity 24 V, 6.0 kW23.Tire inflator Not Equipped 5.Lamps Headlamps24. Fog lamps

License plate lamp25.Exterior Sunvisor Stop/Tail lamps26.Cushioned Rear Lamps Back-up lamp27.Speaker28.Ashtray29.Power window

INSTRUMENTS 1.Meter and gauges km-kg system

Speedometer with trip meterOdometerTachometer

- 3 -

Two, for driver and sidepassenger

Reading lamp (Fluorescentlamp)Map lampFront end outline markerlamps

Equipped with front 3

Driver and assistant

Transmission P.T.O.and P.T.O. control

Equipped(for FS1EMKD only)

Forward control, all steelwelded construction, fullfloating cab (front:air,rear:air)with electrical oil-pumptilting mechanism

Driver and assistant

EquippedEquipped

Full trim type (side, roof andback)

Directional indicator andhazard lamps (front, sideand rear)

Air Suspension seat

7. Rear view mirrors Electrically adjustable & heated

Note: All specifications of the products are with normal manufacturing allowances and tolerances.Hino Motors, Ltd. reserve the right to alter specifications at any time without previous notice.Figures of axle capacity can be changed by the operating conditions and specifications of equipments concerned.When selecting optional equipment, consult Hino technical staff as the adaptation of some of the optional equipment on production line may require an extra lead time.

- 4 -

SS-FS314 OPTIONAL EQUIPMENT

12.

.Reversing Camera System

1. 14.15.

2. Alloy Road Wheels Alcoa forged alluminium alloy roadwheels.

16.

( 22.5X8.25 rim and or 22.5X9.00 rim )

17

.

.Muckaway Steel or Hardox TipperTipper GrabAlloy AggregateAlloy InsulatedHookloaderConcrete MixerBlock/Brick Carrier

18..

Bodies: 3. Central Chssis lubrication System

5. Illuminated Headboard 6. 7. Air conditioner 8. Sleeping bed curtain 9. Night Heater10. Comfort Matress

Front Roof spoiler11.Hi-Roof Conversion

Visible “Diff Lock engaged” warning lampStainless Steel Lighting Bars: Roof and Front mount

“Handbrake not applied” audible warningVertical Exhuast in stainless steel incorporating O.EM. Muffler

4. Alloy Fuel Tank 300Ltrs

Rotating Beacons roof mounted

13.

Lighting options: Work Lamps Spot Lamps Lightbars

Cheese Wedge

.

19. Onboard Weighing Systems20. Air Horns

FOH

OW

FW

CDRFS340

FS1EMKD/MKM/TKA