hp designjet 430, 450c, and 455ca printers service manual ... service manual.pdf · hp designjet...

208
Service Manual HP DesignJet 430 HP DesignJet 450C HP DesignJet 455CA Printers

Upload: dangdien

Post on 14-Apr-2018

228 views

Category:

Documents


0 download

TRANSCRIPT

Page 1: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service ManualHP DesignJet 430HP DesignJet 450CHP DesignJet 455CAPrinters

Page 2: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

For HP Internal Use Only

� Copyright Hewlett-Packard Company 1997

This document containsproprietary information that isprotected by copyright. Allrights are reserved. No part ofthis document may bephotocopied, reproduced, ortranslated into anotherlanguage without the priorwritten consent of Hewlett-Packard Company.

First edition, September 1997

Warranty

The information contained inthis document is subject tochange without notice.

Hewlett-Packard makes nowarranty of any kind withregard to this material,including, but not limited to,the implied warranties ofmerchantability and fitnessfor a particular purpose.

Hewlett-Packard shall not beliable for errors containedherein or for incidental orconsequential damages inconnection with the furnishing,performance, or use of thismaterial.

WARNING

The procedures described inthis manual are to beperformed by HP-qualifiedservice personnel only.

Electrical Shock Hazard

Serious shock hazard leadingto death or injury may result ifyou do not take the followingprecautions:

� Ensure that the ac poweroutlet (mains) has aprotective earth (ground)terminal.

� Disconnect the Printer fromthe power source prior toperforming anymaintenance.

� Prevent water or otherliquids from running ontoelectrical components orcircuits, or through openingsin the enclosure.

Electrostatic Discharge

Refer to the beginning ofChapter 8 of this manual, forprecautions you should take toprevent damage to the Printercircuits from electrostaticdischarge.

Safety Symbols

General definitions of safetysymbols are givenimmediately after the table ofcontents.

Product Support, Barcelona Division

Hewlett-Packard Española, S.A.Avda. Graells, 50108190 Sant Cugat del VallèsSpain

Page 3: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Manual

HP DesignJet 430HP DesignJet 450CHP DesignJet 455CAPrinters

Page 4: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

$$ �-$("�.#$-���(/�& HP DesignJet 430, 450C and 455CA Printers

�-$(" .#$- ��(/�&

������

�#$- '�(/�& �)(.�$(- $(!),'�.$)( ( � --�,2 .) . -.� ��&$�,�. �(� - ,0$� �

� �� � -$"(� . � *,$(. ,- �')� &- � �� �(� ����

� �� � -$"(� . ��� *,$(. ,- �')� &- � ��� �(� �����

� �� � -$"(� . ���� *,$(. ,- �')� &- ������ �(� ��������

�), $(!),'�.$)( ��)/. /-$(" .# - *,$(. ,-� , ! , .) .# �),, -*)(�$(" /- ,�(� +/$�%3, ! , (� "/$� -�

�������

�# *,)� �/, - � -�,$� � $( .#$- '�(/�& �, .) � * ,!),' � �2 ��3� ,.$!$ �- ,0$� * ,-)(( & )(&2�

���� ������

��,. (/'� ,- !), *&).. , )*.$)(-� ��� --),$ - �(� - ,0$� *�,.- �, &)��. � $(�#�*. , �

�� � ��� �

�#$- '�(/�& �)(.�$(- $(!),'�.$)( !), .# �)&), �� � -$"(� . �� ��� �(����� *,$(. ,-�

� -'�&& �,,)1 � $- /- � .) $(�$��. ).# , *�,.- )! .# � ,0$� ��(/�& ),�- ,�- �/$� 1# , 2)/ ��( !$(� $(!),'�.$)( , &�. � .) .# .)*$� 2)/ �, �)(-/&.$("�

Page 5: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

)))�/.3%.32HP DesignJet 430, 450C and 455CA Printers

�/.3%.32

�2).' 3()2 �!.4!, ))� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��!&%38 �8-"/,2 7� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ��������������

�2 3(% �1).3%1 �2).' 3(% �!3%23 �)1-6!1% �%5)2)/. �9�� � � � � � � � � � � � � � � � � � � � � � ��-0/13!.3 �.&/1-!3)/. �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 �!. � $/ 6(%. ! �823%- �11/1 �/$% �00%!12 /. 3(%�1/.39�!.%, �)20,!8 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��!5% 8/4 0%1&/1-%$ ! �%15)#% �%23 /. 3(% �!),%$ �/-0/.%.3��22%-",8 �9�� � � � � � ��!5% 8/4 �%1&/1-%$ 3(% �##41!#8 �!,)"1!3)/. �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ 3/ �/,5% �1).39�4!,)38 �1/",%-2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �).% �%.2/1 (!2 �1/",%-2 �%3%#3).' �%$)! �9�� � � � � � � � � � � (!3 #!. � $/ )& 3(% �!11)!'% )2 �/)28 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �/5%1 �%.2/1 )2.�3 /1+).' �9�� � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �!11)!'% �22%-",8 (!2 01/",%-2 0!1+).' ).3(% �%15)#% �3!3)/. �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �1).3%1 #/.3).4/42,8 1%*%#32 �!131)$'%2 �9� � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �%$)! #/.3).4/42,8 #1!2(%2 �9� � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �1).3%1 $/%2 ./3 �/6%1 �� �9� � � � � � � � � � � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �1).3%1 (!2 01/",%-2 6)3( �%$)! �/!$).' �9�� � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �1).3%1 (!2 01/",%-2 6)3( 3(% �433%1 �9�� � � � � � � � � � � � � � � � � (!3 #!. � $/ )& 3(% �!), �%#(!.)2- �!),2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � (!3 )2 !. ����� %11/1 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ������ ����� �� ��

�-0/13!.3 �.&/1-!3)/. /. �1/4",%2(//3).' �11/1 �/$%2 �9�� � � � � � � � � � � � � � � � � � ��823%- �11/1 #/$%2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ��� ��������

�2%1 �%22!'%2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 6: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

+7 �105'054 HP DesignJet 430, 450C and 455CA Printers

� ���� ����

�0531&6%5+10 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��18'3<�0 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'.( �'45 #0& �13/#. �0+5+#.+;#5+10 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�'37+%' �'454 <� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � *+%* �'37+%' �'45 51 �'3(13/ <� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�'37+%' �'454 ��+#)0145+%4� <� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'37+%' �1&' � <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��5122+0) # �'45 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��05'3+0) �'37+%' �1&' � <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��+'8+0) �'45 �65265 7+# 5*' �'3+#. �135 < � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��#+. �:%.' �'45 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��3105 �#0'. �'45 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��#33+#)' �9+4 �"<#9+4� �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��#33+#)' �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'04134 �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'&+#<�9+4 �!<�9+4� �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'0%* �60 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��1&6.#3 �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��.'%5310+%4 �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�'37+%' �1&' � <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��5122+0) # �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��05'3+0) �'37+%' �1&' � <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��#+. �'45 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��.'%53+%#. �'45 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'371��0%1&'3 �'45 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'37+%' �10+513 ��#5# �+42.#:� <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

����� �1&'. �� �10(+)63#5+10 �31%'&63' <� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'37+%' �10(+)63#5+10 �.15 <��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��3+05+0) 5*' �'37+%' �10(+)63#5+10 �.15 <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��05'323'5+0) 5*' �'37+%' �10(+)63#5+10 �.15 <�� � � � � � � � � � � � � � � � � � � � � � � � � � �

�.'#3+0) 5*' ����� <�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ���� ���������� �

�%%63#%: �#.+$3#5+10 �<�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��63214' �<�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � *#5 +4 5*' �0&<�1+05 �%%63#%: �2'%+(+%#5+10 � �<�� � � � � � � � � � � � � � � � � � � � � � � � *#5 %#0 �(('%5 5*' �0&<�1+05 �%%63#%: � �<�� � � � � � � � � � � � � � � � � � � � � � � � � � � � ��'(13' �'3(13/+0) 5*' �%%63#%: �#.+$3#5+10 �<� � � � � � � � � � � � � � � � � � � � � � � � � � ��'3(13/+0) 5*' �%%63#%: �#.+$3#5+10 �<� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�&,645+0) 5*' �#33+#)'<51<�'&+# �+45#0%' �<�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��1 %*'%- 5*' %#33+#)'<51</'&+# &+45#0%' �<�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��1 #&,645 5*' %#33+#)'<51</'&+# &+45#0%' �< � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 7: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

;�549,498HP DesignJet 430, 450C and 455CA Printers

� � � �������

�7049 �:(209> "75:)2,8/55904. �/,*12089 �@�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��7049@�:(209> �259 �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�4975+:*9054 �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �#804. 9/, �7049@�:(209> �259 �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��704904. 9/, �7049@�:(209> �259 �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��4(2>?04. 9/, �7049@�:(209> �259 �@�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 �� �(7970+., %(73@:6 �@�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 �� �5??2, �7049 ",89 �@�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 � $,790*(2 �04, !97(0./94,88 ",89 �@ � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 � �5257 �20.43,49 �:(209> ",89 �@�� � � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 �� �5257 $(70(9054 ",89 �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �",89 �(99,74 �� �(4+04. ",89 �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��5 �704904. �,-,*98 �5:4+ 04 9/, �7049@�:(209> �259 �@��� � � � � � � � � � � � � � � � � � ��,+0( �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�7049@�:(209> �,-,*98 "75:)2,8/55904. �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �!9(7</,,2 �(718 �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �#4,;,4 �022 �,4809> �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �!67(> �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��2,,+04.� �255304. (4+ %0*104. �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��41 !3,(704. �@� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��:, �/(4.,8 �@��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ����� ����

�=*/(4., �88,3)20,8 @�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ,62(*,3,49 �(798 @�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�0.:7, � @ �,4,7(2 $0,< @� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, � @ �7049,7 !:66579 @� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, @ 522-,,+ �88,3)2> @�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, @ �5;,78 @�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, � @ �7549 �(4,2� !6099554 (4+ �2,*97540*8 �5+:2, @��� � � � � � � � � � � � � � � ��0.:7, � @ & (4+ ' (=08 �59578 (4+ �4*5+,7 !9706 @��� � � � � � � � � � � � � � � � � � � � � ��0.:7, @ �703,7 �88,3)2> (4+ !,7;0*, !9(9054 �88,3)2> @�� � � � � � � � � � � � � ��0.:7, � @ �(770(., �88,3)2> (4+ "7(0204. �()2, @��� � � � � � � � � � � � � � � � � � � � � � ��0.:7, � @ �(02 (4+ �;,7+70;, �,*/(40838 @��� � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, �� @ �04*/(73 �88,3)2> @��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��0.:7, �� @ �497> �2(9,4� �70;, 522,7� �(02 (4+ �;,7+70;, �88,3)2> @��� � � � ��7049,7 �(),28 @�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �#8,78 �:0+, (4+ �:0*1 ,-,7,4*, �:0+, �:4+2, @��� � � � � � � � � � � � � � � � � � � � � � ��7549 �(4,2 �;,72(>8 @��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��536(90)2, �5*:3,49(9054 @��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��2:.@04 3,357> � �� !���� @��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��(7970+.,8 @��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��=9,74(2 �7049 !,7;,78 @� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 8: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6* �/.4&.43 HP DesignJet 430, 450C and 455CA Printers

� ������ �� ����� �����

�.42/%5$4*/. �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&"33&-#,8 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��"'&48 �2&$"54*/.3 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��,&$42/34"4*$ �*3$)"2(& ����� �2&$"54*/.3 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&15*2&% �//,3 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��.34",,*.( " ��� /2 ��� ���� �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �"*, �33&-#,8 �9 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �/0 �/6&2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �/,,'&&% �33&-#,8 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �&'4 �.%9�/6&2 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �*()4 �.%9�/6&2 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2/.49�".&, �33&-#,8 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �,&$42/.*$3 �/%5,& �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �.$/%&2 �42*0 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �*()4 �2"$+&4 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �"22*"(& �/4/2 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �0*44//. �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �544&2 �33&-#,8 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2*6&9�/,,&2 �&"2 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �&%*" �/4/2 �33&-#,8 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �*.$)9�2- �&$)".*3- �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2*-&2 �33&-#,8 �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �&26*$& �4"4*/. �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �"*,9�*'4 �&$)".*3- �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �.("(*.(9�&6&2 �500/24 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2"*,*.( �"#,& �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2"*,*.(9�"#,& �5*%& �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �"22*"(& �33&-#,8 �9 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2*6& �&,4 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2*6&9�&,4 �5,,&8 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �2*6& �/,,&2 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&*.34",,*.( 4)& �2*6& �/,,&2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �*.$)9�2- �*'4 �&$)".*3- �9 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �6&2%2*6& �33&-#,8 �*.$,5%*.( 4)& �6&2%2*6& �/,,&2��&%*" �&0"2"4/2� �&%*" �&',&$4/23 ".% �&%*" �&.3/2� �9��� � � � � � � � � � � � � � � � � � � � ��&-/6*.( 4)& �.428 �,"4&. �9��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� ���������� ����������

�/*3452& /. �2*.4&2 �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&6&, /' �2*.4&2 3"(& �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��2*$4*/. /. �,*%&2 �/% �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/*38 �"22*"(& !)&&, �9�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��.+ �0*,,*.( �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��&,4 �7&,,*.( �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��,&".*.( 4)& �2*.4&2 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�&.&2", �,&".*.( �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��,&".*.( 4)& �2*6& �/,,&2 �9� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 9: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

3((�-,1$,10HP DesignJet 430, 450C and 455CA Printers

�� �������� ��� ���

�,1/-#2"1(-, ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��-** �$#( ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��$+-3(,& �1 1(" �' /&$ %/-+ 1'$ �$#( ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/(..(,& 1'$ �$#( ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�(,"'6�/+ �$,0-/ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/-3(#(,& �-/"$ -, �-. -% 1'$ �$#( ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� (* ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �� (*6�(%1 �$"' ,(0+ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�$1$"1(,& 1'$ �(,$0 ,# �$#( �#&$0 ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��(,$ �$,0-/ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�-3(,& 1'$ � //( &$ ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �� //( &$6�/(3$ �$"' ,("0 ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��-1-/� �$*1 ,# �2**$5 ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �� //( &$ �2(# ,"$ ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��-0(1(-, * �$$#! ") ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

� //( &$ ��� ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/-3(#(,& �,) ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�/(,1 � /1/(#&$0 ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��(01 ,"$ !$14$$, � //( &$ ,# �$#( ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�/-#2"(,& , �+ &$ ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/(,16�-#$ �' / "1$/(01("0 ��6� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�$/3("(,& 1'$ � /1/(#&$0 ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��$/3("$ �1 1(-, ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��.(11--, ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��/(+$/ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�*$"1/-,("0 �-#2*$ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��$,0-/0 ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ���� ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ���� ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ������ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��,.21��21.21 �,1$/% "$0 ��6 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��(6�/-,("0 ��6 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ���6���6� ��6 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��-4$/ �2..*5 ��6 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �� 1$/ �-,#$,0 1(-, ��6 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�$+-/5 �0 &$ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � ��*-1 �/($,1 1(-, ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �� 01$/ �+ &$ �/-"$00-/ ��6�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 10: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

���� �������� HP DesignJet 430, 450C and 455CA Printers

General Definition of Safety Symbols

International caution symbol (refer to manual): the product ismarked with this symbol when it is necessary for the user to refer to the instruction manual in order to protect against damage to theinstrument.

Indicates dangerous voltage (terminals fed from the interior byvoltage exceeding 1000 volts must also be marked).

Protective conductor terminal. For protection against electricalshock in case of a fault. Used with field wiring terminals toindicate the terminal that must be connected to ground beforeoperating equipment.

Low-noise or noiseless, clean ground (earth) terminal. Used for asignal common, as well as providing protection against electricalshock in case of a fault. A terminal marked with this symbol mustbe connected to ground in the manner described in the installation(operating) manual, and before operating the equipment.

Frame or chassis terminal. A connection to the frame (chassis) of the equipment, which normally includes all exposed metal.

Alternating current

Direct current

Alternating or direct current

The WARNING sign denotes a hazard. It calls attention to aprocedure, practice, or the like, which, if not correctly performedor adhered to, could result in personal injury.

The CAUTION sign denotes a hazard. It calls attention to anoperating procedure, practice, or the like, which, if not correctlyperformed or adhered to, could result in damage to or destructionof part or all of the product.

�����������

��

��

�������������

Take care not to cut yourself on the encoder strip inside the plotter.

Page 11: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

1-1 HP DesignJet 430, 450C and 455CA Printers

�������� ��

Page 12: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

1-2 TroubleshootingHP DesignJet 430, 450C and 455CA Printers

�(-+)�.�-$)(

�#$, �#�*- + 0$&& ".$� 2). -#+)."# -# + & /�(- ,- *, -) -�% 0# (-+).�& ,#))-$(" -# *+$(- +�

�� ��� ������� ���� ��� ����� ������� ���������

� !)+ ,* (�$(" -$' -+).�& ,#))-$(" -# *+)�& ' �2 �)$(" -# /�+$)., - ,-,)+ + *&��$(" *�+-, �0#$�# '�2 ()- ( � + *&��$("�� �# �% 0#$�# !$+'0�+ + /$,$)( -# *+$(- + $, .,$("� �) �# �% 0#$�# !$+'0�+ + /$,$)( -# *+$(- + $,.,$("� ��� � �� ������� �� �������� ���� � *�" 3��� �)' *+)�& ',0#$�# )��.++ � $( �+&$ + !$+'0�+ + & �, , '�2 #�/ � ( ,)&/ � $( &�- ++ /$,$)(,� �) $! -# + $, � ( 0 !$+'0�+ + /$,$)( -# ( + *&�� -# �$+'0�+ ���� � !)+ + *&��$(" �(2 *�+-,�

�������� ����������

�# �+$(- + !$+'0�+ $, �)(-�$( � $-# + )( � !&�,# ��� ���� �- -# ���%)! -# �+$(- + )+ )( � '�,% � ��� $(,$� -# & �-+)($�, ')�.& � �# !$+'0�+ 3+ /$,$)( & / &� !)+ 1�'*& ������� $, *+$(- � �2 -# �+$(- + )( -# , -.* ,# - �(� )( -# , +/$� �)(!$".+�-$)( *&)-� �# + /$,$)( & / & $, �&,)*+$(- � )( � &�� & )( �(2 !&�,# ��� ����� �) ()- )* ( -# & �-+)($�,')�.& �

�������� �# ( + *&��$(" -# & �-+)($�, ')�.& � �&0�2, + ' '� + -)�# �% -# !$+'0�+ + /$,$)( & / & )! -# ��� & �-+)($�,')�.& � �# + /$,$)( & / & 0$&& � *+$(- � )( -# -)* ,.+!�� )!-# ')�.& � �&,)� �# �% -# !$+'0�+ + /$,$)( & / & )! -# ������� $(,-�&& � $( -# �� & �-+)($�, ')�.& � �$-# -#$,$(!)+'�-$)( 2). '.,- �) -# !)&&)0$("

�� �! -# !$+'0�+ + /$,$)( & / & )! -# ��� ���� $( -# )&� & �-+)($�, ')�.& $, ����� -#�( -# !$+'0�+ + /$,$)( & / & )!-# ( 0 & �-+)($�, ')�.& � -# ( 2). ���� ��� $(,-�&& -# ��� ���� $(-) -# ')�.& �

�� �! -# !$+'0�+ + /$,$)( & / & )! -# ��� ���� $( -# )&� & �-+)($�, ')�.& $, �� ��� -#�( -# !$+'0�+ + /$,$)( & / &)! -# ( 0 & �-+)($�, ')�.& � -# ( 2). ���� $(,-�&& -# ������� $(-) -# ')�.& �

�1�'*& � �# ��� ���� !$+'0�+ + /$,$)( & / & $, �������(� -# !$+'0�+ + /$,$)( & / & )! -# & �-+)($�, ')�.& $,������� �). 0).&� ., -# & �-+)($�, ')�.& ������� -# ��� ���� $(,-�&& ��

�1�'*& � �# ��� ���� !$+'0�+ + /$,$)( & / & $, ��������(� -# !$+'0�+ + /$,$)( & / & )! -# & �-+)($�, ')�.& $,������� �). 0).&� ., -# & �-+)($�, ')�.& ���� -# ������� $(,-�&& ��

Page 13: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Troubleshooting 1-3HP DesignJet 430, 450C and 455CA Printers

���# ��� � �� &��� � �'"#�� !!�! ���� � ��!" �� #��

!��#(����� ��" ��'�

�"�*.�, � �)(.�#(- � &#-. ) -2-.�' �,,), �)��- �(� ."�#, ,�-*��.#0���-�,#*.#)(- �(� ,��)''�(��� �),,��.#0� ��.#)(-� �(&2 .,2 )(� ,��)''�(�����.#)( �. � .#'� �(� �"��% # ."� �,,), �)�� "�- �#-�**��,���

� 2)/ "�0� �( �,,), �)�� 1"#�" #- (). �)�/'�(.�� #( ."#- ��,0#�� ��(/�& ),2)/ "�0� �( �,,), 1"#�" 2)/ ��((). ,�-)&0�� ."�( ,�*),. ."� �,,), .) ."� ����-*)(-� ��(.�, ), ."� (��,�-. �� �/**),. � #��� �"�( ,�*),.#(! ."� �,,),�"�0� ."� )&&)1#(! #( ),'�.#)( ,���2�

� �)��& �(� ��,#�& �/'��, ) ."� *,#(.�,�

� �"#�" #,'1�,� ,�0#-#)( ."� *,#(.�, #- /-#(!�

� �"� �)'*&�.� �,,), �)���

� �"� ��,0#�� �)( #!/,�.#)( �&).�

� �"� �/,,�(. �)( #!/,�.#)( -"��.�

� �"#�" -) .1�,� �**&#��.#)( ."� �/-.)'�, #- /-#(! �(�'�� 0�,-#)(� �.����

� �- ."� *,)�&�' ,�*,)�/�#�&� �2 2)/�

� ��#.#)(�& �)''�(.- ��)/. ."� /-�!�� ."� -�..#(!� �.���

��%� '�$ �!��!��� � ��!%��� ��"# �� #�� �����

��� ����#��""����'�

� *)--#�&�� �&1�2- *�, ),' � ��,0#�� ��-. )( ."� �)'*)(�(.��--�'�&2 ."�.2)/ �,� ��)/. .) ,�*&���� $/-. .) '�%� -/,� ."�. #- ."� �)'*)(�(.��--�'�&2."�. "�- �#&��� �� #�� #�"# �� #��# ��� ����#��""����' �""�"� '�$"��$�� �� !� ���� �#� �), #( ),'�.#)( )( ."� ��,0#�� ��-.- �(� ")1 .)/-� ."�' � �"�*.�, ��

��%� '�$ ��!��!��� #�� ���$!��' �����!�#����

�- ."� *,#(.�, ��&#�,�.�� �),,��.&2 � .�, ,�*&��#(! � �)'*)(�(.� �� �, .)�"�*.�, .) �"��% 1"�( ."� ��/,��2 ��&#�,�.#)( #- ,�+/#,���

���# ��� � �� #� ���%� �!��#(�$���#' �!�����"�

�"�(�0�, �( �,#(.3�/�&#.2 *,)�&�' �**��,-� #. #- ��0#-��&� .) *,#(. ."��,#(.3�/�&#.2 �&). .) "�&* �#�!()-� ."� *,)�&�'� �"� �,#(.3�/�&#.2 �,#(. 1#&&"�&* 2)/ �# �,�(.#�.� ��.1��( *)--#�&� ��,.,#�!� �,,),- �(� )."�, *,)�&�'--/�" �- #(�),,��. ,)(.3*�(�& -�&��.#)(� �,#0�, ), ��� �)( #!/,�.#)( ),'��"�(#��& *,)�&�'-� �), #( ),'�.#)( )( -)&0#(! �,#(.3�/�&#.2 *,)�&�'- ��"�*.�, �

Page 14: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

1-4 TroubleshootingHP DesignJet 430, 450C and 455CA Printers

���$ ��� � � �� $�� ��� ���# " ��# �" ����# ��$��$��� ������

� �6"$11(4$ (-* #$/.1(21 .- 2'$ #0(4$80.++$0 130% "$ " - %..+ 2'$ 1$-1.0 !70$%+$"2(-& 2'$ +(&'2� �+$ - 2'$ #0(4$80.++$0 � �' /2$0 ��

� ��� #��# " ��� ""��$�& �����"�$��� �'$ ""30 "7 " +(!0 2(.- (-"+3#$1" +(!0 2(.- .% 2'$ +(-$ 1$-1.0 .- 2'$ " 00( &$� �.3 ,312 31$ �� � 22$ %(+,5'$- /$0%.0,(-& 2'$ ""30 "7 " +(!0 2(.- ��$2 (+1 � �' /2$0 ����2'$05(1$ 2'$ +(-$ 1$-1.0 5(++ ' 4$ /0.!+$,1 +. #(-& 1.,$ 27/$1 .% ,$#( �

� �'$ �(-$ �$-1.0 (1 % 3+27� �$/+ "$ 2'$ � 00( &$ �11$,!+7 � / &$ 8��

���$ ��� � � �� $�� �""���� �# � �#&�

� �(027 � 00( &$ !31'(-&1� �$,.4$ #312 / 02("+$1 %0., 2'$ � 00( &$!31'(-&1 -# %0., 2'$ 1+(#$0 0.# +.-& 5'("' 2'$ � 00( &$ ,.4$1� �%-$"$11 07� //+7 +3!0(" -2 2. 2'$ 1+(#$0 0.#�

� � *$ 130$ 2' 2 2'$ !$+2 (1 ".00$"2+7 /.1(2(.-$# .- 2'$ �8 6(1 ,.2.0�

� �$,.4$ #312 / 02("+$1 %0., 2'$ � "* �$ , -#� (% -$"$11 07� //+7 &0$ 1$�

� �'$"* %.0 % 3+27 � 00( &$� �$0%.0, 2'$ � 00( &$ �6(1 �$12 � / &$ 8���

���$ ��� � � �� $�� %�" ���# " �#��$ � "�����

�� ����� �� ��� � ���� �� �� ��� ���� �� ���������

� �$%.0$ 20.3!+$1'..2(-&� , *$ 130$ 2' 2 7.3 0$ -.2 (- �$04("$ �.#$ �!$" 31$ 2'$ �.4$0 1$-1.0 (1 #(1 !+$# -# �0(-2$0 5(++ 2'(-* 2' 2 2'$ ".4$0(1 +5 71 "+.1$#� �.5$0 ��� 2'$ �0(-2$0 -# 15(2"' (2 ! "* �� & (- -#"'$"* (% 2'$ �.4$0 1$-1.0 5.0*1�

� �'$"* (% 2'$ " !+$ %.0 2'$ %0.-28/ -$+ 11$,!+7 (1 ".--$"2$# ".00$"2+7 2.2'$ $+$"20.-("1 ,.#3+$�

� �$/+ "$ 2'$ %0.-28/ -$+ 11$,!+7 � / &$ 8���

���$ ��� � � �� $�� �""���� ##����& ��# !" ����# !�"���� �� $��

��"%��� �$�$� ��

� ��#! #�$� ��� $"������ ������ �'$ 20 (+(-& " !+$ , 7 !$ /0$4$-2(-& 2'$" 00( &$ %0., 0$ "'(-& 2'$ +$%28' -# 12./� � *$ 130$ 2' 2 2'$ 20 (+(-&" !+$ (1 /.1(2(.-$# 3-#$0 2'$ /+ 12(" 2 !1 2 2'$ ! "* .% 2'$ " 00( &$ ".4$0� -# -.2 !.4$ 2'$,�

� �'$ � 00( &$ (1 -.2 2 2'$ ".00$"2 '$(&'2� �'$"* -#� (% -$"$11 07� #)3122'$ � 00( &$ '$(&'2 ��$2 (+1 � "' /2$0 ���

� �'$ �$+2 (1 -.2 ".00$"2+7 /.1(2(.-$# .4$0 2'$ (#+$0 /3++$7�

� �'$"* %.0 % 3+27 ! (+ +$4$0 ,$"' -(1, !$" 31$ 2'$ � 00( &$ , 7 ' 4$20.3!+$ / 11(-& .4$0 (2�

Page 15: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Troubleshooting 1-5HP DesignJet 430, 450C and 455CA Printers

���$ ��� � � �� $�� �"��$�" � �$��% %#�' "����$# ��"$"����#�

If you are in Service Mode 1, the cover sensor is disabled. In order to test anew Cartridge set, the Printer must be powered OF and and ON again.

� ��� &� $�!� ��� ����� ��"$"����# �,# $0#/3#,2 !�31# -$ !�020'"%#.0- *#+1 '1 2&�2 2&# 31#0 &�1 $-0%-22#, 2- 0#+-4# 2&# 2�.# $0-+ ,#5!�020'"%#1� �#+-4# 2&# 2�.#�

� �"$' !��# �&# !-,,#!2'-, #25##, 2&# !�00'�%# ��� �," 2&# !�020'"%#$*#6 !-,,#!2-0 '1 +�"# 7 +#�,1 -$ � %-*" 3 *# -, 2&# $*#6 !-,,#!2-02&�2 2-3!&#1 � %-*" .�" -, 2&# ���� �&# ��00'�%# �#12 �"#2�'*1 � .�%#�9�� ',!*3"#1 � 2#12 -$ 2&'1 !-,,#!2'-,� �&#, ,-88*# $�'*30#1 -!!30� !*#�,2&# $*#6 !-,2�!21 -, 2&# !�020'"%# �," ', 2&# ��00'�%#�

� � �$��%�$' �" ���� �#+-4# �** 2&# !�020'"%#1 $0-+ 2&# ��00'�%# �,"207 ',12�**',% (312 2&# 0#(#!2#" !�020'"%#� �$ 2&# !�020'"%# '1 12'** 0#(#!2#"2&#, 0#.*�!# 2&# !�020'"%# 5'2& � ,#5 -,#� �$ 2&# ,#5 !�020'"%# '1 ,-20#(#!2#" 2&#, !&#!)� -,# 7 -,#� '$ 2&# -2&#0 !�020'"%#1 �0# 0#(#!2#" -0 ,-2�

� ��%�$' ��"$"���� �-+# *�!) !�020'"%#1 ��� ���� 5'2& ��� ������"�2#1 -$ �.0'* �� �," #�0*'#0 +�7 &�4# 2&',9$'*+ "�+�%#� �&'1 +#�,12&�2 2&# +�2#0'�* 31#" $-0 !&�,,#*',% ',) #&'," 2&# ,-88*#1 !�, !0�!)5'2& �%',%� �&#, 2&'1 &�..#,1� ',) 1##.�%# +�7 !�31# +�,7 ,-88*#1 2-$�'* �#'%&2 -0 +-0#�� �#.*�!# 2&# *�!) !�020'"%# 5'2& -,# 5'2& ��������� "�2# -$ ��7 �� -0 *�2#0�

� �$ 2&# ��020'"%#1 �0# ,-2 ',1#02#" !-00#!2*7 ',2- 2&# ��00'�%#� 2&#��020'"%#1 5'** # 0#(#!2#"� ��)# 130# 2&�2 2&# 1.0',%1 2&�2 &-*" 2&#��020'"%#1 ', 2&# ��00'�%# �0# ,-2 0-)#, -0 +'1.*�!#"�

� �#0$-0+ 2&# ��00'�%# �#12 � .�%# �9��

� �#.*�!# 2&# �0�'*',% �� *# � .�%# �9��

�#.*�!# 2&# ��00'�%# �11#+ *7 � .�%# �9��

Page 16: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

1-6 TroubleshootingHP DesignJet 430, 450C and 455CA Printers

���" ��� �� �� "�� ����� ���"��#�#!�% � �!��!

� � ��# !� + � %��!� $'���� !* �� �(()'-��� �� + � %��!� !* &'+ ���(()'-��� ��-!*� + � �,*+'%�) +' ,*� �� %��!� �&� � ��# +' *�� !� + �()'�$�% !* &'. *'$-���

� ��"�&!"�"�� � #!� �� + !* �),* �$'��+�� ,&��) + � �&+)/ ($�+�&� !*��%���� ') )�%'-��� *+�+!� � �)�� ��& �,!$� ,( '& + � %��!�� � � �)����& ��,*� + � %��!� +' *+!�# +' !+*�$� �&� "�% + � �)!&+�)�

� � � ��))!��� !* �+ + � !&�'))��+ �!� + !& )�$�+!'& +' + � )!-� �'$$�)�� ��# �&� !� &���**�)/ ��",*+ + � ��))!���0+'0%��!� �!*+�&�� � (��� 0�&� +)/ +' $'�� + � %��!� ���!&�

� � � )!-� �'$$�) !* !&*+�$$�� !&�'))��+$/� ��%'-� + � )!-� �'$$�) �&� !&*+�$$!& + � �'))��+ ('*!+!'& � (��� 0�� �&� +)/ +' $'�� + � %��!� ���!&�

� � � '-�)�)!-� . ��$* +,)& �)�� !& �'+ �!)��+!'&*� �)��+!&� �,��$�* !& + �%��!�� ��#� *,)� + �+ + � �$,+� �**�%�$/ !* !&*+�$$�� �'))��+$/ �&� !*&'+ ��,$+/�

� ��!!��� � ������� !"� $����!� ��#� *,)� + �+ �$$ + � *+�). ��$* '&+ � ��!$ �**�%�$/ �)� �'))��+$/ !&*+�$$�� �&� +,)& ()'(�)$/�

� ��!!��� ����� ������"� !� ��#� *,)� + �+ �$$ + � ���!� ���$��+')* �)�!&*+�$$�� '& + � �)!&+�)� '+ �).!*� + �)� �',$� �� %��!� �)�* �*�

���" ��� �� �� "�� � ��"� ���! ��" ��$� ��

� � ��# + �+ + � ('.�) �')� !* �'&&��+�� �'))��+$/�

� � ��# + �+ + � ��� ���� ��!)%.�)�� !* !&*+�$$�� �'))��+$/ !& + � �'))��+*$'+ �+ � *$'+ �,)+ �*+ �)'% /',� �+ + � ���# '� + � �)!&+�)�

� �)/ +' �!*�'&&��+ �$$ + � ���$�*� �(�)+ �)'% + � �)'&+ ��&�$ ���$�� �)'% + ��$��+)'&!�* �'�,$� �&� + �& +)/ +' ('.�) �� + � �)!&+�) ���!&� �� &'+ !&��((��)* '& + � �)'&+0(�&�$ �!*($�/� + �& )�($��� + � �$��+)'&!�* �'�,$� �(��� 0��� �� + � �)!&+�) �'�* �'.�) �& .!+ + � ���$�* �!*�'&&��+��� + �&+ � ()'�$�% %,*+ �� .!+ �&'+ �) �'%('&�&+ '� + � �)!&+�)� �' �!&� + ���,$+/ �'%('&�&+� ('.�) ��� + � �)!&+�) �&� �'&&��+ '&� '� + � ���$�* �&�('.�) �� ���!&� �&�� + � ��,$+/ �'%('&�&+ !* �'&&��+��� !+ .!$$ &'+ �$$'.+ � �)!&+�) +' ('.�) ��� � !* �'%('&�&+ * ',$� + �& �� )�($�����

Page 17: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Troubleshooting 1-7HP DesignJet 430, 450C and 455CA Printers

��� ��� � �� �� �� ���� �� ��� �������� "� � ���� �������

� �!��$ ,!�, ,!� ���"� ��'+(* "+ "'+,�%%�� �(**��,%0�

� �!��$ "� ,!� ���%� �(* ,!� ���"� ��'+(* "+ �(''��,�� �(**��,%0�

� �!��$ "� ,!� �"'�!�*&+ �*� �(/' �,!� �"'�!�*& %�.�* +!(-%� �� !���

� �� ,!� &��"� "+ �(',"'-(-+%0 *�#��,�� �-*"' ,!� &��"� �� � �!��$� ,!�'&�$� +-*� ,!�, ,!� �"'� ��'+(* "+ "'+,�%%�� �(**��,%0� �� '���++�*0� )�*�(*&,!� ��**"� � ��+, � )� � 1���

� ��$� +-*� ,!� %"'� +�'+(* "+ ��%"�*�,��� ��*�(*& ,!� ���-*��0 ��%"�*�,"('� )� � �1��

� ��)%��� ,!� ���"� ��'+(* �)�*, (� ,!� (.�*�*".� �++�&�%0� � )� � 1���

� ��)%��� ,!� ��**"� � �++�&�%0 � )� � 1��

���� ����� �� �������� �� � � � ��� ���� �� ��������� �� ����� ��� ����� �� ������ ��������� �� ���� � ������� ��� � �� � ��� �� ���� � ������ �� ���������� � ���

��� ��� � �� �� �� ���� �� ��� �������� "� � �� ! ��

� �� ,!� ��**"� � �++�&�%0 !�+ )*(�%�&+ )"�$"' -) ,!� �-,,�*�

� �!��$ ,!�, ,!� ���%� �(* ,!� �*(',1��'�% �++�&�%0 "+ "+ '(, %((+� �'� "+*(-,�� �(**��,%0 "' ,!� �(.�* �%")+� � %((+� ���%� ��' �� ,*�))�� �0 ,!��-,,�*� )*�.�',"' ,!� �-,,�* �*(& &(."' �

� ��$� +-*� ,!�, ,!� �)",,((' �++�&�%0 "+ �(**��,%0 "'+,�%%�� �'� "+�%" '�� /",! ,!� �.�*�*".� �++�&�%0� �� ,!� �)",,((' "+ %((+� (*&"+)(+","('��� ,!� �-,,�* /"%% !�.� )*(�%�&+ )�*$"' "' ,!� *" !, �(.�*�

� �� ,!� &��"� �*�+!�+ /!�' &(."' ,!� �-,,�*�

� ��$� +-*� ,!�, ,!�*� "+ '( &��"� ,*�))�� "'+"�� ,!� �-,,�*&��!�'"+&� ��&(.� ,!� �-,,�* ,( "'+)��, ", �(**��,%0�

� ��&(.� ,!� �-,,�* �'� &�$� +-*� ,!�, �(,! *(,�*0 �%���+ �*� ,(-�!"' ���! (,!�* �0 ,!� �%�, +"��+ �'� '(, ,!� +%()"' +"��+� �� ,!� *(,�*0 �%���+�*� ,(-�!"' ���! (,!�* �0 ,!� +%()"' +"��+� 0(- &-+, *�+��, ,!�&�

� �� ,!� �*"',�* "+ )%���� (' � ,��%�� ", &-+, �� )%���� �+ �%(+� ,( ,!� �� ��+ )(++"�%� ,( &�$� +-*� ,!�, ,!� &��"� ,!�, "+ �(&"' (-, ��%%+�(**��,%0� �� ,!� �*"',�* "+ "' ,!� &"��%� (� ,!� ,��%�� ,!� &��"� ,!�, "+�(&"' (-, /"%% �� %"�,�� -) ��-+"' ,!� �-,,�* ,( �*�+! "',( ",�

Page 18: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

1-8 TroubleshootingHP DesignJet 430, 450C and 455CA Printers

���$ ��� � � �� $�� ��� �������#� ���#�

� ��#$"%�$� �#� ����! *��* *��(� �(� $% %�)*(+�*�%$) �$ *�� -�/ %� *�����" ))�#�"/�

� ���"��� � !�"$#� ��� ��# ���( �$� �$����$� ���( #�/ $%* #�!��%((��* �%$*��* -�*� *�� "��* �(�,�2(%""�( ���( �,�$ *�%+�� *�� ��((���� �)��*+�*�$� *�� �$����$� "�,�(� ���) ��$ ��&&�$ �+� *% �.��))�,� -��(�$� %�&�(*)� $%*��( &(%�"�# #�/ �� *��* *�� ���" ���"� ��) �(%!�$�

� ��""���� � $ " � �$" �� ��� ��((���� #�/ $%* &(%&�("/ "%��*� *���$����#�$* "�,�(� &(�,�$*�$� *�� ���() �(%# �$����$�� $/ &(%�"�#)-�*� *�� ��((����2#%*%( �%$*(%" )/)*�# ��%( �.�#&"�� *�� �$�%��( )*(�&� %(�))%���*�� #����$��) �%+"� ��+)� *��) &(%�"�#� ")%� �� *�� ��((������$$%* ��$� *�� *(+� "��* )*%& �+(�$� �$�*��"�0�*�%$ ���+)�� �/�$*�(��(�$���� *�� �$����$� "�,�( ��$$%* �� "%��*���

� ��� ���� ��� ���" #�/ ��"" �(%# *�� +& &%)�*�%$� ���) ��$ ��&&�$ �� *����# �) %,�( %( +$��(2(%*�*��� ��� $%*�� %$ *�� ��#� +)�� *% �$���� *��"��* ���" �(��!�*� �) $%* &(%&�("/ "%��*�� �%( *�� 1���" +&� �%$��*�%$� �$�*�� ���" ��"") ��(+&*"/� ��(�%(# � ���" �/�"� *�)*�

� ��%#$ ��""����� �� *�� ��((���� #%,�) %,�( *�� �$����$� "�,�( -�*�%+*(��)�$� �*� /%+ #�/ $��� *% �� +)* *�� ��((���� �$�"� %$ *�� )"���( (%��� �*��") � &��� �2��� �%-�,�(� �� ��(��+" $%* *% �%&�(��0� *�� &(�$*'+�"�*/� -���� �) ,�(/ )�$)�*�,� *% *�� ��((���� �$�"��

����� �((%()

���$ �# �� ����� �"" "�

$ ����� �((%( #��$) *��* )%#� %� *�� �$*�($�" *�)*) *��* *�� ��(#-�(�&�(�%(#) ��,� ��*��*�� *��*� -��$ (�2(����$� �$�%(#�*�%$ �(%# *�� �������* �%�)$�* �%((�)&%$� *% *�� �$�%(#�*�%$ *��* ��� &(�,�%+)"/ ���$ -(�**�$*��(�� %( *��* *�� ����!)+# %� �"" *�� �$�%(#�*�%$ �) �$�%((��*� ���) ���"+(���) ��,� &%))��"� ��+)�)

� ��+"*/ �"��*(%$��) #%�+"��

� �%$*��* &(%�"�#) -�*� *�� *(��"�$�2���"� �%$$��*�%$)�

� ��+"*/ *(��"�$� ���"��

� ��+"*/ ��((�����

� ��� �(�$*�( -�) *+($�� %�� -��"� � *�)* -�) -(�*�$� *% *�� ������ *�+)"��,�$� �%((+&* �$�%(#�*�%$ �%( � �%##+$���*�%$ ���"� -�) ��)�%$$��*��-��"� )�$��$� �$�%(#�*�%$ *% *�� ����� +)�$� )%�*-�(� ����$%)*�� *%%")��

�* �) ��$�(�""/ $%* ��)/ *% ��)�%,�( *�� ��+)�� �+� *% *�� �$*�(#�**�$* ���(��*�( %�*�� ���"+(� #%��)�

Page 19: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Troubleshooting 1-9HP DesignJet 430, 450C and 455CA Printers

� 2(. �+� ,.+� -"�- -"� �#%.+� (��.++�� $.,- � -�+ �' �%��-+#�#-2 )(0�+4�.-� (+� -�+ -.+'#'! ( -"� �+#'-�+ �.+#'! -"� ��'�" +.' (+ (-"�+ ,�+/#�� -�,-,� -"�'-"� �+#'-�+ #, '(- �.%-2� �(. $.,- '��� -( +�,�- -"� ������ �' (-"�+ ��,�,�2(. '��� -( #'� -"� ��.,�

� �"�+� #, �%0�2, �' ����� �++(+ 0"�' 2(. ,0#-�" (' -"� �+#'-�+

� � #- #, ��,2 -( +�)+(�.�� � ���� ��� �++(+� -"�' -+2 ('� (+ �%% ( -"� (%%(0#'! ,-�), (+ � )(,,#�%� ,(%.-#('

� �(' #!.+� -"� ����� 0#-" -"� �(++��- &(��% �� �#',-+.�-#(', � )�!� 4����

� � 2(. ��''(- �(' #!.+� -"� ����� 0#-" -"� �(++��- &(��% �� � -�+,�/�+�% �--�&)-, �'� 2(. �('-#'.� !�--#'! -"� ,�&� �++(+ �(��� +�)%���-"� �%��-+('#�, &(�.%� � )�!� �4���

� �"�+� #, ,(&�-#&�, �' ����� �++(+ 0"�' 2(. ,0#-�" (' -"� �+#'-�+�'(+&�%%2 ,"(0, .) �, � ���� �� �++(+�

� �0#-�" (' -"� �+#'-�+� �%%(0 #- -( #'#-#�%#3� .'-#% #- "�, �(&)%�-�� -"�)(0�+4(' ��� ,�*.�'��� �'� ,0#-�" ( -"� �+#'-�+� ��(. �+� '(0 ,.+�-"�- -"� ����� "�, '(- ���' �(++.)-��� � � ���� �� �++(+ �))��+���#- �%,( �(++��-, -"� ����� �('-�'-,� �'� -"� '�1- -#&� 2(. ,0#-�" -"��+#'-�+ ��� -"� �++(+ ,"(.%� '(- (��.+ #' !((� .'#-,��

� ���/� -"� .'#- ( (+ � &#'.-�, -( ��-��- # -"� ����� #, %(,#'! #-,#' (+&�-#('� �"�' -.+' #- (' �!�#' �'� �%%(0 #- -( #'#-#�%#3�� � � ������ �++(+ �))��+, �.+#'! -"� #'#-#�%#3�-#(' ,�*.�'��� �'� -"� ��++#�!� �(�,'(- ��!#' -( &(/�� -"�' -"� ����� #, )+(���%2 �.%-2� ��)%��� -"��%��-+('#�, &(�.%��

Page 20: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 21: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-1 HP DesignJet 430, 450C and 455CA Printers

� ���� � ����

Page 22: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-2 System Error CodesHP DesignJet 430, 450C and 455CA Printers

�,'(�" �&&$& �$��'

�� ,$) ��*� �# �&&$& �$�� +���� �' #$( �$�)"�#(�� �# (��' ��&*��� ��#)�! $&,$) ��*� �# �&&$& +���� ,$) ��##$( &�'$!*�� (��# &�%$&( (�� �&&$& ($ (�� ���'%$#'� ��#(�& $& (�� #��&�'( � �)%%$&( ������� ���# &�%$&(�#� (�� �&&$&���*� (�� �$!!$+�#� �#�$&"�(�$# &���,�

� �$��! �#� ��&��! �)"��& $� (�� %&�#(�&�

� ����� ��&"+�&� &�*�'�$# (�� %&�#(�& �' )'�#��

� ��� �$"%!�(� �&&$& #)"��&�

� ��� ��&*��� �&�#( ��������� � �� ��� �������

� ��� �)&&�#( �$#���)&�(�$# '���(�

� ����� '$�(+�&� �%%!���(�$# (�� �)'($"�& �' )'�#� �#�"�� *�&'�$#� �(����

� �' (�� %&$�!�" &�%&$�)���!� �, ,$)�

� ���(�$#�! �$""�#(' ��$)( (�� )'���� (�� '�((�#�� �(���

��������� ������� �� �� ����������� �� ����� ����

��$&� '%�#��#� (�"� (&$)�!�'�$$(�#� (�� %&$�!�" �, �$�#� (�� *�&�$)' (�'('$& &�%!���#� %�&(' �+���� "�, #$( #��� &�%!���#��� ���� +���� ��&"+�&�&�*�'�$# (�� %&�#(�& �' )'�#� $& ���� �� � '�&*��� #$(� ���!' +�(� (��'%�&(��)!�& %&$�!�"� �$"� %&$�!�"' +���� $��)&&�� �# ��&!��& ��&"+�&�&�!��'�' "�, ��*� ���# '$!*�� �# !�(�& &�*�'�$#'� �$ �� (��&� �' � #�+ ��&"+�&�&�*�'�$# (��# )%��(� (�� ��� ���� ���$&� &�%!���#� �#, %�&('� ����& ($���%(�& � �$& (�� %�&( #)"��& $� (�� ��� �����

Page 23: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

System Error Codes 2-3HP DesignJet 430, 450C and 455CA Printers

SETUP FORM FEED REPRINT CANCEL

1 2 3 4

5 6 7

READY

ALIGN MEDIA

LOAD MEDIA

STATUSGROUP

CARTRIDGES

DATA

MEDIA

ERRORGROUP

PRINT QUALITY MEDIA TYPE MEDIA SOURCE

DEF

KLM

FAST

NORMAL

BEST

ABC

PAPER

FILM

COATED

GHI

ROLL

SHEET

NO

GLOSSYJ

Flashing

Off

On (Steady)

�� �"������ �� ������� ��#���� �! ������

������ ���� ��� �� �� �� �� ������

��� �� � �� �� ������������

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

������ ����� ����

��� ����� ��� � ��� ���� �� ��� �������� ����� ����� �� ��� ������������������ �" �� ����� ��� ��������

Page 24: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-4 System Error CodesHP DesignJet 430, 450C and 455CA Printers

�((%( %��) �%( *�� �� ��)��$��* ���� ��� �$� ��� �(�$*�()

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

���������� � ���� � ������

$ �((%( -���� *�� �+)*%#�( �%+"� &(%���"/ )%",�� "�!� �&�&�( �#� #�$%( ��(*(���� &(%�"�# �*�� �$ %(��( *% ��* #%(��$�%(#�*�%$ %$ *�� �((%(� *�� ����� !�/ #+)* �� &(�))��-���� -�"" ��)&"�/ � �������� �)� *�� �((%( �%��) ��"%- *%��$� �$�%(#�*�%$ %$ *�� )+��%���

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

����������

���������� � ���� � ������

���) �((%( �%�� �$����*�) � )�,�(� &(%�"�# -���� -�"" (�'+�(�� ��(,��� �$��$��( *% *(%+�"�)�%%*� �$ %(��( *% ��* #%(��$�%(#�*�%$ %$ *�� �((%(� *�� ����� !�/ #+)* �� &(�))��-���� -�"" ��)&"�/ � �������� �)� *�� �((%( �%��) ��"%- *%��$� �$�%(#�*�%$ %$ *�� )+��%���

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

���� � ����������� ��� �� ���� *�)* ���"���

�%))��"� ��+)�)�

� �� ���� �$)*�""�� �) $%* �$ %(���$�" �� )+&&%(*�� &�(*�

� �� ���� ���"/ �%$$��*���

� �+"*/ �� �����

� �+"*/ �"��*(%$��) #%�+"��

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

���� � ����� �(*(���� %$*�$+�*/ ��)* ��"+(��

�%))��"� ��+)�)�

� �(*(����) ��+"*/ %( ���"/ )��*���

� �+"*/ %( ���"/ �%$$��*�� *(��"�$� ���"��

� ��(*/ ��((���� �"�. ��(�+�*�

� �+"*/ ��((�����

� �+"*/ �"��*(%$��) #%�+"��

Page 25: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

System Error Codes 2-5HP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� � ������ �-�+�& ��('�"*!�

�"&&���� ��(&�&�

� ��&'���� "% �%��'�"! �! �-�+�&�

� �(�', "% ����, �"!!��'�� �-�+�& !�"��% ������

� �(�', ���� "'"%� "% "'"% ����� #�!�����

� �(�', ����'%"!��& "�(���

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���������

����� � ����� ����� � ��� ����� � ����������� � "%, "% ���(%��, �����%�'�"! �%"��� &�

�"&&���� ��(&�&�

� �"' �!"(�� � "%, �"% '�� �(%%�!' #�"'� ��� �+'%� � "%, �, �!&'����!� � �����% �� �� � ����% '"���#'�% � �"% '�� �"%%��' #�%' !( ��%& "� '�� �� �� &�

�� '��& �%%"% �"�� �##��%�� *���� #�%�"% �!� '�� ���(%��,�����%�'�"!�

� ����� '��' '�� $(���', "� '�� ���(%��, �����%�'�"! #%�!'�& �""�� �� '�� $(���', �& ���� '%, '" ����! '�� �������%'%���� "% %�#���� �'�

� ��� &(%� '��' ,"( �"�� '�� ���(%��, �����%�'�"! #%�!' �!'�� �"%%��' #"&�'�"! �!� "%��!'�'�"!� �!� ��� &(%� '��',"( &����' '�� �"%%��' ���� ',#��

� ��� &(%� '��' '�� ��!� &�!&"% "! '�� ��%%���� �& ����!� ��'�� ��!� &�!&"% �& ��%', "% !"' �(!�'�"!�!� �"%%��'�,� �' *�����)� #%"��� & %����!� '�� ���(%��, �����%�'�"! #%�!'�

� �(�', �%����!� ������

� �(�', ��%%���� �&&� ��,�

� �(�', ���'%"!��& "�(���

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� � ��� ����� � ����������� ����!���� �%"��� �

�"&&���� ��(&�&�

� ����� '�� ���� �&&� ��,�

� ����� '�� ��##�!� �"&�'�"! �! '�� ��%)��� �'�'�"!�

Page 26: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-6 System Error CodesHP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� �����

�� � � ����� � �� � ��� � �� � � ��� �))') "&��"$1$"�+ %��!�&"*%� �!� ��"$1$"�+ *0*+�% "* ,&��$� +' )�"*� ')$'.�) +!� ��"$� ��+ "* +!� ��))"� � +!�+ +�*+* +' *�� .!�+!�) +!���"$ "* "& +!� �'))��+ ('*"+"'& �0 +)0"& +' #&'�# � �"&*+ "+��

�'**"�$� ��,*�*

� !��# +!� ��"$1$"�+ *0*+�% +' *�� "� "+ "* .')#"& �'))��+$0�

� �*� +!� ��"$ �0�$� +�*+ +' !�$( +)',�$�*!''+�

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ����

�� � � ���� � � ��� �))') "& �1�/"* ��$"�)�+"'&�

�'**"�$� ��,*�*

� �* �1�/"* ��$"�)�+"'& �'&�� ���+�"$* � !�(+�) ��

� �"� 0', $'�� %��"� "& �'))��+ ')"�&+�+"'&�

� �)� +!� %�)#* -"*"�$� '& +!� ($'+� �� &'+� �!��# ��)+)"� �*�

� �)� ��)+)"� �* �'))��+$0 �$" &��� �� *'� +!� ()'�$�% %�0 ��"& +!� �$��+)'&"�* %'�,$�� %��"� %'+') ') �)"-�1)'$$�) ��) "��$" &%�&+ "* "&�'))��+� +!� ()'�$�% %�0 �� "& +!� ��))"� ��

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ����

��� � �� � ����� �")%.�)� !�* � ()'�$�% "&+�)��+"& ."+! *'%� '� +!� �!�)��+�)"*+"�* '� +!� ()"&+�

�!� �)"&+�) "* ,*"& �& '$� �")%.�)� )�-"*"'& 1 �&*+�$$ +!�$�+�*+ �")%.�)� )�-"*"'&�

� �� +!"* �))') )�%�"&*� )�(')+ +!� ()'�$�% +' 0',) ����*('&*� �&+�)� �'+� �'&�"+"'&* �&� ��+"'&* ���')��))') '��,))��� �&�$,�� *�+,( *!��+ �&� *�)-"���'&�" ,)�+"'& ($'+ "& )�(')+�

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ������

�� � � ����� � �� � ��� � �� � ����� �!"* "* � �&�)"� �0*+�% �))') +!�+ �'-�)* ��',+ ��� �))') �'��*�

� ��(')+ +!� ()'�$�% +' 0',) �� ��*('&*� �&+�)� �'+��'&�"+"'&* �&� ��+"'&* ���')� �))') '��,))��� �&�$,�� *�+,(*!��+ �&� *�)-"�� �'&�" ,)�+"'& ($'+ "& )�(')+�

Page 27: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

System Error Codes 2-7HP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� � ����� ����� � ����� �'%%,&!��+!'& ()'�$�%.!+ ��1��� ���)!�$ �')+��

�'**!�$� ��,*�*

� �&�'))��+ �'&�!�,)�+!'& !& �'%%,&!��+!'&* *(����()'+'�'$�

� �&�'))��+ �'%%,&!��+!'&* ���$��

� �))') !& '*+ �'%(,+�)�

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� � ��� ����� � ����� � �)� !* � �'%%,&!��+!'&()'�$�% ��+.��& + � ��!& �� �&� + � !&+�)&�$%!�)'()'��**')*�

� � ��!& �� !* ��,$+0 1 ��($��� + � �$��+)'&!�* �'�,$��

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

�������

����� � ���������� � �������)# �&�'��) &'+ ��+��+���

�'**!�$� ��,*�*

� � � $!&� '& + � %�)# �&�'��) !* �!)+0 ') %!**!&��

� �,$+0 ') ���$0 �'&&��+�� +)�!$!&� ���$��

� �,$+0 ') ���$0 �'&&��+�� ��))!��� *�&*')�

� �,$+0 ') ���$0 �'&&��+�� �1�/!* �&�'��) ���$��

� � � �)!-� )'$$�) �* * !�+�� *$!� +$0 �)'% + � �/(��+��('*!+!'& �%�� �&!�*�� � ��# + �+ + � ��))!��� *�&*') $!� +*",*+ '-�) + � . !+� %�)# '& + � �)!-� )'$$�) . �& *+�)+!&��

� �,$+0 ��))!��� ���

� �,$+0 �1%'+')�

� �,$+0 �1%'+')�

� �,$+0 �$��+)'&!�* %'�,$��

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� ����� � ��� ����� � ����� �))') )���!&���&+)'&!�* ���

�)'�$�%* !& + � ��&+)'&!�* �'%%,&!��+!'&*� �)'���$0 �,�+' + � ��� �'&+��+* '� + � �'&&��+')�

� �� + !* �))') )�%�!&*� )�(')+ + � ()'�$�% +' 0',) ����*('&*� ��&+�)� �'+� �'&�!+!'&* �&� ��+!'&* ���')��))') '��,))��� �&�$,�� *�+,( * ��+ �&� *�)-!���'&�!�,)�+!'& ($'+ !& )�(')+�

Page 28: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-8 System Error CodesHP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��� ����

� � ���� � � �������� � � � � �,*�'"(- 1%")&)&.&�'&3&)$ .%" �,,&�$"�

�*--&�'" �/-"-�

� ��,,&�$" �--"(�'2 &- )*. +,"-").�

� ��/'.2 *, ��!'2 *))" ."! .,�&'&)$ ��'"�

� ��/'.2 �,,&�$" ����

� ��/'.2 "'" .,*)& - (*!/'"�

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��� ����

����� ���� � � �������� � � � � �*!"' �� )*. *)#&$/,"!�

� �#.", ,"+'� &)$ � )"1 "'" .,*)& - (*!/'"� &. (/-. �" *)#&$/,"! "&.%", �- � �"-&$)�". �� ��� *, ����� �# �)"1 (*!/'" !*"- )*. -%*1 .%&- ",,*,� &. ("�)- .%�. &. %�-�"") &)-.�''"! +,"0&*/-'2 �)! 1�- +,*���'2 �'&�,�."! 1&.%*.%", +�,�(".",-� �#.", *)#&$/,&)$ .%" (*!/'" �,,*, *!" ��� �� �� 1&'' �++"�, 1%& % ("�)- .%" � /,� 2 �'&�,�.&*) (/-. �" !*)"� �#.", .%" � /,� 2 �'&�,�.&*) &-!*)"� �'' *.%", �'&�,�.&*)- (/-. �" !*)"� �# *)#&$/,&)$.%" (*!/'" !*"- )*. ,"(*0" .%" ",,*,� "0") �#.",-1&. %&)$ .%" �,&).", ��� �)! ��� .%") .%" ����� &).%" (�&) ��� &- +,*���'2 !"#" .&0"� �"#*," .,2&)$ .*,"+'� " .%" "'" .,*)& - (*!/'" .,2 '"�,&)$ .%" ������)! +",#*,( �'' .%" �'&�,�.&*)- �$�&) �)! -"" &# .%�.-*'0"- .%" +,*�'"(�

�"#", .* +�$" 4�� &) *,!", .* *)#&$/," .%" *,," . (*!"' ���

�*, (*," &)#*,(�.&*) � +�$" �4 �

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��� ����

����� ���� � � ��������� ����� ."-. ",,*,�

�*--&�'" �/-"-�

� �1&. % .%" �,&).", ��� �)! �� �$�&) �)! -"" &# .%" ",,*,,"(�&)-� �# .%" ",,*, �++"�,- *).&)/*/-'2� ,"+'� " .%"�'" .,*)& - �*!/'"�

� �%" ��'&�,�.&*)- &) .%" ����� %�0" �"") '*-.��",#*,( .%" � /,� 2 ��'&�,�.&*) �,"#", .* �%�+.", ���

Page 29: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

System Error Codes 2-9HP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

�������

��� ����� � ����������� �' �.,*)$�- �*�/' ��$'/, �

�*--$�' ��/- -�

� ��) !�/'.3 *, ���'3 �*)) �. ��

� ��/'.3 ��� �����

� ��/'.3 ��� �����

� ��/'.3 �' �.,*)$�- �*�/' �

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

��������

����� ����� � ������ �4�2$- �#/.�*1)�

�*--$�' ��/- -�

� �,*�' (- 1$.# .# �/.. , �-- (�'3�

� �' �, �)3 �$)�$)" �/ .* � ( �$� %�(�

� �/,) .# �,$). , *!!� ��)/�''3 (*0 .# ��,,$�" �'*)".# ��,,$�" �2$-� �# �& !*, �)3 �, �- 1# , .# ��,,$�" (�3 � �$)�$)"�

� �)-/, .#�. .# � '. �)� � '. +/'' 3 �, $) �*,, �.1*,&$)" *,� ,� � (*0 �$,. !,*( .# +/'' 3 .#�. �*/'���/- .# � '. .* -'$+�

� � ,!*,( .# ��,,$�" 4�2$- . -. �)� .# - ,0*� )�*� , . -..* �# �& !*, +,*�' (- 1$.# .# ��,,$�" (*.*,� )�*� ,-.,$+� �)� ' �.,*)$�- (*�/' �

� � (*0 �$,. !,*( .# -'$� , ,*� �)� �#�--$- � �(� �++'3*$' ��)� ,*' �� � �� +�,. )/(� ,� ���4� � .* .# ��,,$�" �/-#$)"-�

� �. #$"# . (+ ,�./, -� �)� $! .# !�) $- )*. 1*,&$)"�*,, �.'3� .# $). ,)�' , -$-.�)� *! .# (*.*, �,$0 , (�3$)�, �- � ��/-$)" � � �, �- $) .# 0*'.�" � .1 ) .# (*.*, �*).��.-� �)� � -#/.�*1) *! .# (*.*,�

� �)-/, .#�. .# )�*� , -.,$+ $- )*. $)0 ,. �� ��(�" � *,��- ).�

� � �*)) �. *, , +'�� .# .,�$'$)" ���' � +�" 4 �

� � +'�� .# ��,,$�" �-- (�'3 � +�" 4���

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���������

����� � ����� ����� � ������ �4�2$- �*0 ( ). �,,*,�

�*--$�' ��/- -�

� �*( .#$)" $- ��/-$)" 2� --$0 !,$�.$*) $) .# �4�2$-���,,$�" �2$-��

� �# ��,,$�" .*/�# - .# ��$' �- $. (*0 -�

Page 30: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

2-10 System Error CodesHP DesignJet 430, 450C and 455CA Printers

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ����

�� � � ��� � �� � � ��� �## # �� �+�)�$ ��� ��#"&��#�%&#��

$$���� ��&$�$�

� �� ##��% # &%��� � %�� � % # �����$�

� ����%#���� � �$� �� � % #$�

� �&�%* � % # ��� ��#�

� � % # #����'�� �� ����%# $%�%�� ��$���#�� (���� !�#�%����

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ����

����� � �� � ��� � �� � � ��� �## # �� �+�)�$��� ��# "&��#�%&#��

$$���� ��&$�$�

� ������� # �# ��� ��� ��# $%#�!�

� �&�%* # ����* � ����%�� %#������ ������

� �� ##��% # &%��� � %�� � % # �����$�

� ����%#���� � �$� �� � % #$�

� �&�%* � % # ��� ��#�

� �#������ ����� #����'�� �� ����%# $%�%�� ��$���#�� (����%�� #��%�# (�$ !�#�%���� ��!���� %�� �#������ ������ !��� �+��

D

E

F

K

LM

A

B

C

G

H

I

N

O

J

���� ����

����� � �� � ����� ��#%#���� ��������% �## #�

$$���� ��&$�$�

� �&�%* ��#%#����$�

� ��#%* # ��� ##��% ������

� �&�%* ���� ���$ #�

� �&�%* ��##���� �$$����*�

� �&�%* ����%# ���$ � �&���

Page 31: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

3-1 HP DesignJet 430, 450C and 455CA Printers

��� �����

Page 32: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

3-2 User MessagesHP DesignJet 430, 450C and 455CA Printers

���� ��������

�� ������ �� �� ����� �� � ������ �� � �� ��� ���� �� �� ���������������� ���� �� ����� �� �� � � �� ��� �� ����� ��� ���� �� �������� �� �� � �� � ����� �� ���� �� �� ����� �� ��� � �� ��� ����� �� � ���� �� �� ��������� �� ������� ��� ������ �� �� �� �� �� �������� � �� � �� ��� �� ��� ����� �� � ����� ��� ���� �� � ��� ���� ������ �� ��� �� ����� ���������

This graphic ... means ...

The fifteen lights on the printer’s frontpanel. The sequence of explanations inthe table is:

This light is ON and STEADY.

This light is ON and FLASHING.

This light is OFF or this is the relevantlight.

The state of this light is not relevant.

Lights Explanation and Action

All lights off If no lights are on, you may have a powerproblem, or the printer may be switchedoff.

Key to tablestarting below

1:Statusgroup

2:Errorgroup

3:Printqualitygroup

4:Mediatypegroup

5:Mediasourcegroup

No lights

Page 33: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

User Messages 3-3HP DesignJet 430, 450C and 455CA Printers

Lights Explanation and Action

The printer is not ready to print.

Check the state of the other lights andlook them up in this table.

The printer is ready to print.

Send your print from your computer or,for a special internal print, press theappropriate key combination.

The printer is busy with a task or isreceiving a file.Wait.If combined with one of the four mediatype group lights flashing. The printer iswaiting for the media to dry. This can beterminated by pressing Form Feed .

You are loading media and need torealign it, even if it seems perfectlyaligned.

Lower the media lever, realign the media,and raise the media lever.

The printer is ready, but you need to loadmedia.

When you are ready to print, load media.

The printer has a file in memory, which itis waiting to print, but no media is loaded.

Load media.

READY light offStatus group

READY

READY

PAPER

ALIGN MEDIA

LOAD MEDIA

LOAD MEDIA

Page 34: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

3-4 User MessagesHP DesignJet 430, 450C and 455CA Printers

Lights Explanation and Action

Either: one of the color or black printcartridges is faulty, misplaced or missing.������ �� �� ���� �� ���������

Or: you have loaded a print cartridge ofthe wrong type for this printer.For the correct part numbers of thecartridges supported by this printer, seeChapter 7.

Either: the current print is too large forthe printer’s memory.Look on your computer screen for anyerror message: some drivers, forexample the Microsoft Windows driversupplied with your printer, allow you tochoose a different printing mode and tryto send the file again. In the case of theMicrosoft Windows 95 driver shippedwith the printer, the relevant field is called“Process document” in the Options dialogbox.

Otherwise, you may need to install morememory to print this print. Forinformation on available memoryexpansion modules, see Chapter 7.

Or: there is a problem with the serialinterface.The printer’s settings for baud rate andparity must be the same as those of thecomputer sending the data.

Either: the sheet you loaded ismisaligned.Realign it again. See the Users Guidefor a short tutorial on loading media.

Or: it is an invalid size.For supported media sizes, refer to theUsers Guide.

Or: the media lever is lowered.Raise the lever.

Or: the cover is open when the printer isinitializing.Lower the cover.

CARTRIDGESError Group

DATA

MEDIA

Page 35: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-1 HP DesignJet 430, 450C and 455CA Printers

������� ��

Page 36: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-2 Service TestsHP DesignJet 430, 450C and 455CA Printers

�"(&#�)�(�#"

���' ���$(�& �,$ ��"' �#+ (# )'� (�� �)� (/�" ��&*��� ��'(' ����"#'(��'� �"�+��( (# �# �� (�� (�'(' ��� � �� $#''�� �� � +�-' $�&�#&! � ��&*��� ��'( #" (���#!$#"�"( (��( -#) �&� ��#)( (# &�$ ���� �)'( (# !��� ')&� (��( �' (���#!$#"�"( (��( ��' ��� ��� �� (�� (�'( #" (��( �#!$#"�"( $�''�'� (��&� �' "#"��� (# &�$ ��� �(�

�#+�&/�"

��� �&�"(�&' �)(#!�(��� - $�&�#&! � '�&��' #� �"(�&"� '� � (�'(' �"� !����"��� �"�(�� �.�(�#" '�%)�"��' +��"�*�& (�� )'�& '+�(���' (�� �&�"(�& #"� �� � ��� )&�#��)&'� �" �&&#& �' �"����(�� #" (�� �&#"(/$�"� �'� �#) ��" $�&�#&! � ��� )&��"� -'�' �- �"(�&$&�(�"� (�� � �&&#& �#��� ��(�� ' � ���$(�& ���

���� ���� ��� ����� ��������������

��� $#+�&/#" '� � (�'( �"� �"�(�� �.�(�#" $&#���)&� �#�' (�� �# #+�"��

� �"�(�� �.�' (�� '�&*# $&#��''#&�

� �"�(�� �.�' (�� !��" $&#��''#&�

� ��'(' �#!!)"���(�#" ��(+��" (�� !��" $&#��''#& �"� (�� '�&*# $&#��''#&�

� ��'(' (�� �� �����')!�

� ��'(' (�� '�&*#/$&#��''#& (&�"'��& �)���& �"� �"(�&&)$( (&����"��

� ��'(' (�� �� �����')!�

��)'�' (�� !��" $&#��''#& (# �"�(�� �.� ��&(��" ��&!+�&� !#�) �'�

��&�#&!' � ')�'�( #� (�� � ��(&��� '�&*��� (�'(�

� �����' (�� �#*�& '�"'#&�

� �� ���� � ���� ���� �� ����� ������ ��� � ��� ���� ��

�� �"�(�� �.�' (�� ��&&���� �,�' ��/�,�'��

�� �'�' (�� !�&� �"�#��& (# ����� (�� '(�&( #� (�� �&�*� &# �&�

�� ���(' �"- #���� '���(�

��� ��� ��� ���� �� � ������

�� �����' (�� !���� '�"'#&�

�� ��(' (�� �&�"(�& (# ����$( !�����

Page 37: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-3HP DesignJet 430, 450C and 455CA Printers

����� ����

�� �� ��� ���� �� �� �� �

�� � ��������� ���� �� � ���� ����

Assembly/Feature Tested by ...

Bail system Bail cycle test, Bench run, Modular Test

Carriage Carriage test, Electrical test, Modular test

Carriage motor and drive system (including belt,pulley and slider rod)

Carriage-axis test, Bail cycle test, Modular test,Bench run

Cartridge identification Carriage test, Modular test

Cartridge nozzles Carriage test, Modular test

Communication between computer and Printer Service monitor

Cover sensor Sensors test, Modular test

DRAM SIMM Electrical test, Power-on tests, Bench run

EEROM Electrical test, Power-on tests, Bench run

Electronics module Electrical test, Power-on tests, Servo/Encoder test,Sensors test, Bail cycle test, Front-panel test,Media-axis test, Carriage test, Carriage-axis test,Bench run, Modular test

Encoder strip Carriage-axis test, Servo/Encoder test,Modular test, Bench run

Front-panel keys and LEDs Front-panel test, Modular test

Media-axis encoder and cable Servo/Encoder test, Media-axis test, Modular test,Bench run

Media motor and drive system (including driveroller and overdrive)

Media-axis test, Modular test, Bench run

Media sensor Sensors test, Modular test

Pinch-arm sensor Sensors test, Modular test

Optical sensor (on carriage) Carriage test, Modular test

ROM Electrical test, Power-on tests, Bench run

Service station Bail cycle test

Trailing cable Electrical test, Power-on tests, Bench run

Page 38: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-4 Service TestsHP DesignJet 430, 450C and 455CA Printers

�#.2'!# �#/0/ ��'�%+,/0'!/�

�&# $,)),3'+% '/ � )'/0 ,$ �)) '+0#.+�) /#.2'!# 0#/0/ �2�')� )# '+ 0&# �.'+0#./��+/0.1!0',+/ $,. #+0#.'+% /#.2'!# *,"# � �.# %'2#+ ,+ -�%# 6�� �+/0.1!0',+/$,. #+0#.'+% /#.2'!# *,"# �.# %'2#+ ,+ -�%# 6�

� ��') �5!)# �#/0 � -�%# 6

�&'/ 0#/0/ 0&# ,-#.�0',+ ,$ 0&# �') /5/0#*� �#.2'!# �0�0',+ �+" 0&# �6�4'/ 5 #+%�%'+% �+" "'/#+%�%'+% 0&# �')6)'$0 *#!&�+'/* �+"!�--'+%�1+!�--'+% 0&# !�.0.'"%#/ 0, #+/1.# � !,..#!0 )'$0'+% �!0',+�

� �.,+0 ��+#) �#/0 � -�%# 6�

�&# -1.-,/# ,$ 0&'/ 0#/0 '/ 0, 2#.'$5 0&# ,-#.�0',+ ,$ 0&# $.,+06-�+#) (#5/�+" ���/�

� ��..'�%# �4'/ ��6�4'/� �#/0 � -�%# 6��

�&# -1.-,/# ,$ 0&'/ 0#/0 '/ 0, 2#.'$5 0&# ,-#.�0',+ ,$ 0&# !,*-,+#+0/ ,$ 0&#��..'�%# �4'/�

� ��..'�%# �#/0 � -�%# 6�

�&# -1.-,/# ,$ 0&'/ 0#/0 '/ 0, 2#.'$5 0&# ,-#.�0',+ ,$ 0&# ��..'�%#/1 /5/0#*/� )'(# 0&# �'+# �#+/,. �+" �+�),% *1)0'-)#4#.� �&'/ 0#/0 �)/,!&#!(/ 0&# !,++#!0',+ #03##+ 0&# !�..'�%# $)#4 !'.!1'0 �+" 0&# !�.0.'"%#/�

� �#+/,./ �#/0 � -�%# 6��

�&'/ 0#/0/ 0&# ,-#.�0',+ ,$ 0&# !,2#. /#+/,.� -'+!&�.* /#+/,. �+" *#"'�/#+/,.�

� �#"'�6�4'/ ��6�4'/� �#/0 � -�%# 6��

�&# -1.-,/# ,$ 0&'/ 0#/0 '/ 0, 2#.'$5 0&# ,-#.�0',+ ,$ 0&# !,*-,+#+0/ ,$ 0&#�#"'� �4'/�

� �#+!& �1+ � -�%# 6�

�&'/ 0#/0 &�/ ##+ "#/'%+#" 0, # 1/#" "1.'+% 0&# *�+1$�!01.'+% /0�%# �+"+,0 '+ 0&# $'#)"� ", +,0 �0 �+50'*# #+0#. 0&'/ 0#/0 3&#+ 0.,1 )#/&,,0'+% 0&#�.'+0#.�

� �,"1)�. �#/0 � -�%# 6��

�&'/ 0#/0 &�/ ##+ !.#�0#" 0, !&#!( 0&# '+0#.�!0',+ #03##+ 2�.',1/!,*-,+#+0/ ,$ 0&# �.'+0#.� �0 !,* '+#/ 0&# $,)),3'+% 0#/0/�

� ��..'�%#6�4'/ 0#/0�

� ��..'�%# 0#/0�

� �#"'�6�4'/ 0#/0�

� �.,+06-�+#) 0#/0�

� �#+/,./ 0#/0�

Page 39: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-5HP DesignJet 430, 450C and 455CA Printers

� �,&$31/.*$2 �&23 � 0"(& �9�

�)& 0410/2& /' 3)*2 3&23 *2 3/ 5&1*'8 3)& /0&1"3*/. /' 3)& ����� �/,4-."%%1&22 ".% 3)& 2)4'',&1�

�� �"*, �&23 � 0"(& �9

�)*2 3&232 3)& /0&1"3*/. /' 3)& #"*, 2823&-� �&15*$& �3"3*/. ".% 3)& !9"7*2#8 &.("(*.( ".% %*2&.("(*.( 3)& #"*,9,*'3 -&$)".*2- ".%$"00*.(�4.$"00*.( 3)& $"131*%(&2�

�� �,&$31*$", �&23 � 0"(& �9�

�)*2 3&232 3)& /0&1"3*/. /' 2/-& /' 3)& &,&$31*$", $/-0/.&.32 /' 3)&&,&$31/.*$2 -/%4,&�

�� �&15/��.$/%&1 �&23 � 0"(& �9�

�)& 2&15/�&.$/%&1 3&23 0&1'/1-2 3)& '/,,/6*.(�

� �&%*"9"7*2 &.$/%&1 3&23� &1*'*&2 3)& /0&1"3*/. /' 3)& 2&15/ ,//0�-&%*"9"7*2 '&&%#"$+��

� �"11*"(&9"7*2 &.$/%&1 3&23� &1*'*&2 3)& /0&1"3*/. /' 3)& 2&15/ ,//0�$"11*"(&9"7*2 '&&%#"$+��

� �&$/1%2 3)& -"7*-4- '1*$3*/. %&3&$3&% *. 3)& ������ !/4 $". 5*&63)*2 *.'/1-"3*/. /. 3)& 2&15*$& $/.'*(41"3*/. 0,/3�

�� �&15*$& �/.*3/1 � 0"(& �9

�)& 2&15*$& -/.*3/1 *2 42&'4, 3/ '*.% /43 6)8 3)& �1*.3&1 *2 ./3 0,/33*.(6)"3 8/4 &70&$3 *3 3/ 0,/3� �3 &."#,&2 8/4 3/ 1&"% 3)& (1"0)*$29,".(4"(&*.2314$3*/.2 3)"3 3)& �1*.3&1 *2 1&$&*5*.( '1/- 3)& $/-043&1� �.23&"% /'0,/33*.( 3)& %1"6*.( 3)"3 8/4 2&.%� 3)& �1*.3&1 01*.32 3)& #&(*..*.( ".%&.% /' 3)& $/%& 3)"3 6/4,% /3)&16*2& )"5& #&&. 42&% 3/ 0,/3 3)& %1"6*.(�

�� ����� �/%&, �� �/.'*(41"3*/. �1/$&%41& � 0"(& �9�

�)*2 01/$&%41& *2 .&$&22"18 *' 3)& �1*.3&1 .&&%2 3/ #& 1&$/.'*(41&% "2 "�&2*(.�&3 ��� ���� /1 ������

�� �&15*$& �/.'*(41"3*/. �,/3 � 0"(& �9�

�*5&2 " 2&15*$& 1&0/13 /' 3)& �1*.3&1�

�� �,&"1*.( 3)& ����� � 0"(& �9

�.2314$3*/.2 /. )/6 3/ $,&"1 3)& ������

Page 40: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-6 Service TestsHP DesignJet 430, 450C and 455CA Printers

��&*��� �$�� �

��&*��� �$�� � �$#(��#' (�'(' (��( �" !"& #��� � �$"%!�(� �#�(��!�.�(�$# $�(�� �&�#(�&� ���' "��#' �� (��&� �' � '-'(�" �&&$& �# #$&"�! "$��� �( �' '(�!!%$''��!� ($ �#(�& �#($ ��&*��� �$�� �� !'$� (�� ��#'$&' �&� ��'��!�� �#��&*��� �$�� �� +���� "��#' �( +�!! #$( �� %$''��!� ($ !$�� "����� ��� $#!-(�"� (��( (�� '�#'$&' +�!! �� �)#�(�$#�! �' �)&�#� (�� ��#'$&' ��'(�

�� ���� ����� � � ����� ��� � ��� � ��� �� �� ���� �� � ��� �� � � �� ��� ���� �� ���� ������ � ��� ����� ��� �� ��� ���� ����� �� ��

�$"� $� (�� (�'(' �# '�&*��� "$�� � '�#� (�'( �#�$&"�(�$# ($ (�� %&�#(�&�''�&��! %$&(� �$ *��+ (�� �#�$&"�(�$# %�&�$&" (�� %&$���)&� $# %��� �/�

��� ���!����� �� ! � ���!��"�" �% ���� �� !�� �������"�� �"�������#��� ��� �� �� %�" ��� #��$��� �������!��� #�� !�� ����� ���!� %�"$��� �� �"!�"! ������ !� !�� �����$����

Test Mode EE test: 0

Test Mode EE test: 1

�����������

�&"##�!� � ��%&

��� '�&*��� (�'(' �&� �$#(�#)$)'!- &�%��(�� )#(�! -$) '($% (��"� �$ �,�( � (�'(�%&�'' (�� ��!�� �!� ����� �"'$�� �-' �'$"� (�'(' "�- (� � � '�$&( +��!����$&� �,�(�#��� �$ �,�( ��&*��� �$�� �� -$) ")'( %$+�& � (�� �&�#(�&�

!&�$�!� ��$(��� �"�� �

� ���!� �$!��#� (�� ��#$�!& �- �$+#� '+�(�� (�� �&�#(�& ���

� �#�� (�� (�� ���' ����# ($ !���( )% $#� �- $#�� &�!��'� (�� ��#$�!& �-�

��� ����!�� ������� !�� ����!����� ��$��'�� !� ! ��� !��� !�� ��� !"�� �� ��� ������ ��� ��� � ������ ��� ��� � ��$ ����� � ����� ���� ����� !� ��� �� $��!��� ��� %�" !� ������� � !� !�

�� !���� ��� ��% % !�� ����"�� �"���� ���#��� ��� � ���!����&�!����!�� ����! � ���� �� $��� �� ��!� ��� ����"�� ���� !��! !�����!����� ��"�� �� ������ ��� ���� !� �� ���������

��%&�#(

+��� �������

Page 41: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-7HP DesignJet 430, 450C and 455CA Printers

�# .#&! � *+ �,+(,+ -#� +" � )#�$ �')+

�-+$ -% 1'$ 1$010 (, 0$/3("$ +-#$ � 0$,# 1$01 (,%-/+ 1(-, 1- 1'$ ./(,1$/�00$/( * .-/1� �- 3($4 1'$ (,%-/+ 1(-, 3( 1'$ �$/( * �-/1

�*#&! �#&�'.* ���

� �2/, 1'$ ./(,1$/ ,# �� ����

� �-,,$"1 1'$ �/(,1$/ 1- 1'$ �� 20(,& 0$/( * (,1$/% "$ " !*$ ,# 04(1"' 1'$�� ���

� �$*$"1 1'$ � )%#&�$ �"-, (, 1'$ ��� **')# * �)',( (, �(,#-40�

� �, � )%#&�$� 0$*$"1 � ++#&!* ,# 1'$, 0$*$"1 '%%,&#��+#'&* %/-+1'$ .2** #-4, +$,2�

� � )$ 02/$ 5-2 20$ 1'$ %-**-4(,& "-,%(&2/ 1(-,

� � 2# � 1$ � ���

� � 1 �(10 � �

� �1-. �(10 � �

� � /(15 � �-,$

� �*-4 �-,1/-* � �-,$

� �-,,$"1-/ � �$*$"1 1'$ �-++2,(" 1(-,0 �-/1 1' 1 5-2 /$ 20(,&�

� �$*$"1 �� ,# �4(1"' 1'$ �/(,1$/ ���

�$/%-/+ 1'$ 0$/3("$ 1$010 -, 1'$ �/(,1$/�

�*#&! �& �� ��$%+'( �

� �0$ �� " !*$ ,2+!$/ ����6����� ,# # .1$/ ,2+!$/ ���6�� 1-"-,,$"1 1'$ � *+1-. 1- 1'$ �/(,1$/�0 0$/( * (,1$/% "$ .-/1�

���� ���� ��� ������� ��� �� ����� �� ��� ������ ����� ������ � ��

� �2/, 1'$ �/(,1$/ -, (, 0$/3("$ +-#$ ��

� �2/, 1'$ � *+1-. -,�

� �.$, 1'$ ��+� '%% ..*(" 1(-, -, 1'$ � *+1-. ,# ./$00 �����

� �-3$ 1- 1'$ '&& �+ +$,2 ,# ./$00 ������

� �,02/$ 1' 1 � ++#&!* /$ 1'$ 0 +$ %-/ !-1' �/(,1$/ ,# � *+1-.�

�& (, +-3$ 1- 1'$ '&& �+ +$,2 ,# ./$00 �����.

�(1' '&& �+ '(&'*(&'1$# (, 1'$ '&& �+ +$,2� ./$00 �����.

� �$/%-/+ 1'$ 0$/3("$ 1$010 -, 1'$ �/(,1$/�

�- 01-. "-++2,(" 1(-, !$14$$, 1'$ �/(,1$/ ,# 1'$ � *+1-.� '(&'*(&'1��&!,( (, 1'$ '&& �+ +$,2 ,# ./$00 ������

Page 42: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-8 Service TestsHP DesignJet 430, 450C and 455CA Printers

��� �&��� ��"#

���' (�'(' (�� $%�&�(�$# $� (�� ���! '-'(�"� ��&*��� �(�(�$# �#� (�� �.�,�' �-�#����#� �#� ��'�#����#� (�� ���!.!��( "����#�'" �#� ��%%�#��)#��%%�#� (����&(&����'�

��� (�'( +�!! %�&�$&" (�� #)"��& $� �-�!�' �' '%������� �# (�� ������ �)( ��(�� ����� �' �!��&�� (��' (�'( +�!! #$( �)#�(�$#�

���" ��"# ��" ���� ��"����� #� �� $"�� �$!��� #�� ���$���#$!���"#��� ��� ��# �� #�� ������ �� #�� ��� ����" #� �� #�"#��� ���"� $"�#�� ��� ��"# �� ��!%��� ���� �� �� � "&"#�� �!!�! !�%��#" &�$ �!��

��#�!��� ��#� ��!%��� ���� �� &�$ ��& #!& #��" #�"# ��"#����

��&�$&" (�� ��! -�!� (�'( �' �$!!$+'�

� # '�&*��� "$�� �� %&�'' ��� �&��� ��"# ���()% ��-��

� ��� (�'( +�!! '(�&( �#� (�� �&&���� +�!! "$*� $)( $� (�� ��&*��� �(�(�$#�#� ��(�*�(� (�� �#����#� !�*�& +���� ��)'�' (�� ��! �''�"�!- ($ ����#(!- &��'�� �#� (��# !$+�&���

� ��� (�'( &�%��(' (�� #)"��& $� �-�!�' �' ����#�� �# (�� ������ )#!�''-$) %&�'' (�� ������ ��� ����� ��$!�� �-'�

� � (�� (�'( %�''�'� (�� �'( ��� �� � �� +�!! !���( )% ��(�& (�� ��&'( �-�!��

� � (��&� �' � '�)(�$+# �# (�� �.�,�'� (�� �'( ��� �� � �� +�!! '(�&( ($�!�'��

� (�� �&�#(�& �$�' #$( &��'� (�� ��! �''�"�!- (��# (�� (�'( ��' ���!���

� ��� �� ��� ��� ����� ��� �������� ��� �������� ����������

� ������ � �������� � ��� �����

Page 43: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-9HP DesignJet 430, 450C and 455CA Printers

���� ����� ����

��� $! �"� �� #��" #�"# �" #� %�!��' #�� � �!�#��� �� #�� �!��#( ���� ��'" ����"�

��!��!� #�� �!��# ����� #�"# �" �����&"�

� �� "�!%��� ���� �� !�"" ���� ����� ���� ���!� ���� �'��

� )!& �#� '��(� � � �!#��%�! '�� %�� $�#��� "!#%� )!& (��� $�� !&%"&%$�����# %! %�� �!��!(� ��

1. - Front Panel Test

���$ ��$$��� ! �) � �!#�$ )!& %��% %�� %�$% ��$ $%�#%��� � � � ��$$���(��� ��� �""��# �� %�� %�$% "�$$�$ !# ����$�

� ��� #�"# &��� "#�!# ��� ��� #�� �" &��� ���"� ��! � "�����" ��#�! &����#��' &��� ��� �� #$!��� ���� ����� #��# ��� �" �!� �$��#������ ��!!��#�'&��� #��' ���"��

� �� ����� #��# #�� �!��#( ���� ��'" �$��#��� ��!!��#�'� !�"" #��� ��� �'���� ��� #��� � ��' �" !�""��� #�� ���#�� � ��� �� &��� �� ��#�

� �� � ��' �" ��# �$��#������� #�� ���#�� � ��� �� &��� !����� ����

� ��� #�"# ���#��$�$"�' !� ��#" �#"��� $�#�� '�$ !�"" #�� ������ ��� ���� ������ ��'"�

� %�� %�$% ����$� %! #�$!�'� %�� "#!����� %#) ! � !� %�� �!��!(� ��

� ���� %��% %�� ����� �!# %�� �#! % �� �� $$����) �$ �! ��%�� %! %������%#! ��$ �!�&��� �$! ���� $&#� %��% %�� ����� �$ ��� ������� !#%(�$%���

� ��"���� %�� �#! % �� �� $$����) � "��� �*���

� ��"���� %�� ����%#! ��$ �!�&�� � "��� �*���

Page 44: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-10 Service TestsHP DesignJet 430, 450C and 455CA Printers

�������� �!�� ��"�!��� ����

��� "&#"!$� !� %��$ %�$% �$ %! '�#��* %�� !"�#�%�! !� %�� �!�"! � %$ !� %����##���� �)�$�

��� ������� �� � ��� ��� ����� � ������"��� �������!����� ����� ������ ����� ��������� ��� �� ��� ������� ������� �� ���� ������ �����"�� �� � �� ��� ������� ���� ��� ���� ������� � ��� �������� ���� ��� � ��� ���� ��� ��� ������ �� ���� �� ��� �������

������ ������ ������� ���� �����

��#�!#� %�� ��##���� �)�$ %�$% �$ �!��!($�

� ���� $&#� %��% %�� ��##���� �$ "�#��� � %�� $�#'��� $%�%�! �

� � $�#'��� �!�� �� "#�$$ ��������"�!�� ���� ���"#� % �*��

� ��� %�$% (��� $%�#% � � %�� ��##���� �!'�$ %!(�#�$ %�� #���%+�� � $��� !� %��"#� %�#� �% %�� ���� $ �*���$ !� �!'� � �#!� $��� %! $��� !'�# %�� �#�'� #!���#�

� �� %�� %�$% "�$$�$� %�� ��$% � ��� �� (��� ����% &" ��%�# %�� ��#$% �*����

�� ��� ��� ������ ����� ����� ��� �� ������ ����� ��� ���� ��� �������� ���� �� �� ���������

2. - Y-AXIS TEST

Test Mode Y-axis cycle: 26.67 speed and 66 pwm

Test Mode Y-axis cycle 50.00 speed and 100 pwm

Test Mode Y-axis cycle: 26.67 speed and 68 pwm

���������������

�� %��#� �$ � �+�)�$ $�&%�!( � %�� ��$% � ��� �� (��� $%�#% %! ���$��

�� ��� ��� ������ ����� ����� ��� �� ������ ����� ��� ���� ��� �������� ���� �� �� ���������

2. - Y-AXIS TEST

Test Mode Y-axis cycle: 26.67 speed and 0 pwm

Test Mode Error: 2 on y-axis test

��� %�$% �! %� &!&$�* #�"��%$ �%$��� & %�� *!& "#�$$ %�� ������ �������� �� ��� ��*$�

�� ���� �� �������� �� ��� ���� ����

Page 45: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-11HP DesignJet 430, 450C and 455CA Printers

�� �� ���� ������ �� ������� �� ������ � ��� ��� �� �� ���������

� �!��& �#- ��#��#� �)� ($ � "���� ��"�

� �)&# (�� �&�#(�& $��� ��#)�!!- "$*� (�� ��&&���� �!$#� (�� ��&&���� �,�'����� �$& �#- �&��' +��&� (�� ��&&���� "�- �� ��#��#��

� �#')&� (��( (�� ��!( �#� ��!( %)!!�- �&� �# �$&&��( +$& �#� $&��&� ��"$*���&( �&$" (�� %)!!�- (��( �$)!� ��)'� (�� ��!( ($ '!�%�

� ��"$*� ��&( �&$" (�� '!���& &$� �#� ���''�' ���"� �%%!- $�! ��#��&$!���� �� %�&( #)"��& ���.���� ($ (�� ��&&���� �)'��#�'�

� �( ���� (�"%�&�()&�'� �#� �� (�� ��# �' #$( +$& �#� �$&&��(!-� (�� �#(�&#�!&�'�'(�#�� $� (�� "$($& �&�*�& "�- �#�&��'�� ��)'�#� � ���&��'� �# (��*$!(��� ��(+��# (�� "$($& �$#(��('� �#� � '�)(�$+# $� (�� "$($&�

� �#')&� (��( (�� �#�$��& '(&�% �' #$( �#*�&(��� ��"���� $& ��'�#(�

� ���$##��( $& &�%!��� (�� (&��!�#� ���!� � %��� �.��

� ��%!��� (�� ��&&���� �''�"�!- � %��� �.���

���� ����� �� �������� �� � � � ��� ����� �� ������ � ��� ����� �� ������ ��������� �� �� �� � ���������� � �� � ��� �� ���� � ������ �� �� �������� � ���

Page 46: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-12 Service TestsHP DesignJet 430, 450C and 455CA Printers

��� � ���

��� "&#"!$� !� %��$ %�$% �$ %! '�#��* %�� !"�#�%�! !� %�� ��##���� $&�$*$%��$����� %�� � � �� $!# � � � ��!� �&�%�"��)�#� ���$ %�$% ��$! �����$ %���! ��%�! ��%(�� %�� ��##���� ���) ��#�&�% � � %�� ��#%#����$�

��#�!#� %�� ��##���� %�$% �$ �!��!($�

� � $�#'��� �!�� �� "#�$$ ��� � ��� ��#� % �&���%* ��*��

� ��� %�$% (��� $%�#% � � ��� %�� �$ (��� %&# �� ���#� (��� �� !�!'��� % � %�� �#� %�# � � *!& �&$% (��% �!# %�� #! %+�� �� %!� ����%� �� %�� %�$% ��$ "�$$�� !# �������

� ����# %! %�� �!��!(� � ���&#� %! ����� (���� � �$ �$$!���%�� (�%� (����%�$%� �� %�� %�$% ����� %�� �!��!(� � �$ (��� �� ��% ����� �� %�� %�$%� ��� %�� �!��!(� � �$ (��� �� ���$�� ��

�� ��� ��� ��� � ������� �� �� ����� ����� ��� ��� ��� ����������� �� �� ������ � � �� ���� �������

4. - Carriage Test

0x57c7c350 (carrPCBTest): Forcing use of R10X method for Calvin: 13643 19600x57c7c350 (carrPCBTest): Forcing use of R10X method for Yellow: 11361 19530x57c7c350 (carrPCBTest): Forcing use of R10X method for Cyan: 11361 19530x57c7c350 (carrPCBTest): Forcing use of R10X method for Magenta: 11361 1953 Pen BLACK continuity: WORKSPen CYAN continuity: WORKSPen MAGENTA continuity: WORKSPen YELLOW continuity: WORKSPen BLACK has 1cd4 identification.Pen CYAN has 400 identification.Pen MAGENTA has 1f00 identification.Pen YELLOW has 1900 identification.Optical sensor samples: 253 255 255 254 253 252 252 250 249 248 247246 245 244 243 241Optical Sensor: WORKSCarriage MUX : WORKSPen BLACK continuity: WORKS ...........

�� ���� �� � ������� � �� ���� ����

Page 47: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-13HP DesignJet 430, 450C and 455CA Printers

�� &�" ��� #��$��� �������!��� #�� !�� ����� ���!� &�" $��� �� �"!�"! ������ !� !�� �����$��� �� !�� ��� ������

4. - Carriage Test

0x57c7c350 (carrPCBTest): Forcing use of R10X method for Calvin: 13643 19600x57c7c350 (carrPCBTest): Forcing use of R10X method for Yellow: 12160 18990x57c7c350 (carrPCBTest): Forcing use of R10X method for Cyan: 12160 18990x57c7c350 (carrPCBTest): Forcing use of R10X method for Magenta: 12160 1899 Pen BLACKcontinuity: FAILSPen CYAN continuity: FAILSPen MAGENTA continuity: FAILSPen YELLOW continuity: FAILSPen BLACK has 3ffe identification.Pen CYAN has 3ffe identification.Pen MAGENTA has 3ffe identification.Pen YELLOW has 3ffe identification.Optical sensor samples: 215 252 243 232 221 208 194 179 166 151 135119 103 87 71 54Optical Sensor: WORKSCarriage MUX : FAILSPen BLACK continuity: FAILS ................

� ��� ���� � ���� ���� ������� ����� ���� � � ����� ��� ����� ���� � ����� ����

����� �� ���� �� �� ���� �� ����

�� ��& ���!����� ��!��"�!& !� ! ���� � !� �� ��#� !�� �������� !�& ��� ��!�� �����$����

� ����#� !�� ������� ��!����� ��� ����� !�� ���% ���!��! �� !��������� ��� !�� ��!������ �� ��! !�� ��!����� ��� !�& !�� !� ! ������

� ������� !�� ��!����� �� !�� ����#��! ������� ����� ��� ������� !�� !� !������

� ���� ��� �� ���� ��& ������� !�� �������� ���� � ���� �'��

� ������� !�� ������� ����& � ���� �'���

� ������� !�� ����!����� ��"�� � ���� �'���

�� ������� ��� ��������� �� � ���� ��� ������� ��� ��������� ����� ��������� ������� ���������� ����� ���� ��������� �� ���� � � �� �� ��������� ������ ����� ��������� �������

�� ���� �� ��������� �� ��� ���� �����

Page 48: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-14 Service TestsHP DesignJet 430, 450C and 455CA Printers

�� � ��� ��� ������

�� +!� �"&� ��&*') +�*+ ��"$*� +' )�*'$-� +!� ()'�$�%� +)0 '&� '� +!��'$$'."& �

� ���� ������ �� ���� ��� ���������� �!� ���,)��0 ��$"�)�+"'&"&�$,��* ��$"�)�+"'& '� +!� $"&� *�&*') '& +!� ��))"� �� �', %,*+ ,*��� ��++� �"$% .!�& (�)�')%"& +!� ���,)��0 ��$"�)�+"'& ���+�"$* � !�(+�) ��� �+!�)."*� +!� $"&� *�&*') ."$$ !�-� ()'�$�%* $'��"& *'%�+0(�* '� %��"��

� !��# �&� "� &���**�)0 )�($��� +!� �)�"$"& ��$� � (� � 1�

� ��($��� +!� �))"� � �**�%�$0 � (� � 1��

� ��($��� +!� �$��+)'&"�* �'�,$� � (� � 1���

��� ����� � ��� �������� �� � ���� ��� ������� ��� ��������� ������ ����� ��� ������� ��������� ���� ���� ��� �������� ���� �� ���� �� ��������� ��� ��� ��� � �������� �������

� ��� ��������� ��� ������

�� +!� �&�$' �,$+"($�/�) +�*+ ��"$*� +' )�*'$-� +!� ()'�$�%� +)0 '&� '� +!��'$$'."& �

� !��# �&� "� &���**�)0 )�($��� +!� �)�"$"& ��$� � (� � 1�

� ��($��� +!� �))"� � �**�%�$0 � (� � 1��

� ��($��� +!� �$��+)'&"�* �'�,$� � (� � 1���

��� ����� � ��� �������� �� � ���� ��� ������� ��� ��������� ������ ����� ��� ������� ��������� ���� ���� ��� �������� ���� �� ���� �� ��������� ��� ��� ��� � �������� �������

Page 49: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-15HP DesignJet 430, 450C and 455CA Printers

������� ����

���% &�%&% &�� "#�$�&�"! "� &�� �"(�$ %�!%"$� #�!���$ %�!%"$ �!� ���� %�!%"$�

��$�"$ &�� ��!%"$% &�%& �% �"��")%�

� �! %�$(��� "�� �� #$�%% ������� ���� ������ �*#� �*��

� ��&�(�&� &�� !���%%�$* %�!%"$ �!� ����� &��& &�� $���(�!& � %&�&'%���!��% ��������� ����$ &" &�� �"��")�!� ���'$� &" ����� )���� � �%�%%"���&�� )�&� )���� %�!%"$�

� ��� &�%& �"!&�!'"'%�* $�#��&% �&%��� '!&�� *"' #$�%% &�� ���� ����� ����� ��*%�

�� %�" ��� #��$��� �������!��� #�� !�� ����� ���!� %�" $��� �� �"!�"! ������ !� !�� �����$���

5. - SENSORS TEST

��� �� ��� ���% ������ %�" !��! !�� !� ! �� !��!��� ��� � �� ���$��� ��� ������ �� !�� !� ! �� � �� ���� �

�� !�� !� ! ���� � !� �� ��#� !�� �������� !�% ��� �� !�� �����$���

� �� !�� ��#�� �� �� ���� � ����� !��! !�� ����!&����� � ����% � ������!�%������!�� !� !�� ����!����� ���"��� ��% ��������� !�� ����!&����� � ����%�

� �� !�� ������� �� �� ���� � ����� !��! !�� �� �� ����� � ������!�%������!�� !� !�� ����!����� ���"��� ��% ��������� !�� �������� �� ���

� �� !�� ����� �� �� ���� � ����� !��! !�� �� �� ����� � ������!�%������!�� !� !�� ����!����� ���"��� ��% ��������� !�� �#�����#� � ����%�!�� ����� �� �� � ����"��� � ���! �� !�� �#�����#� � ����%��

� ������� !�� ���!����� ���"�� � ���� �&���

���� � ��� �� ������ �� � ��� �� � ����� �� � ����� ��� � ������ ���� � ������ ��� ����� ���� ���� ��� ��� ���� � �� � � ���� ����� ����� ������ �� ��� ��

Page 50: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-16 Service TestsHP DesignJet 430, 450C and 455CA Printers

����� ��� �� ���� ����

��� �# ��!� �� "��! "�!" �! "� $� ��' "�� ��� �"��� �� "�� ��������"! �� "������� �&�!�

�� �� � "�� �����(�&�! "�!" �! �����%!�

� �� !� $��� ���� �� � �!! ����� ��� ���� ������ ��� �#""����

� ��� "�!" %��� !"� " ��� "�� � �$� ���� �"�"�! �� !"��!� ���� ��#�$����" "���� !%�"� ��$�����

� �� "�� "�!" ��!!�!� "�� ���!!' ���� � %��� ����" #� ��"� "�� �� !" �'����

�� ��� ��� ��� � ������� �� �� ����� ����� ��� ��� ��� ����������� �� �� ������ ��

3. - X-AXIS TEST

Test Mode X-Axis Cycle: 92 pwm

���������������

Test Mode X-Axis Cycle: 65 pwm

Test Mode X-Axis Cycle: 66 pwm

� �� "�� � �! � !�#"��%�� "�� ���!!' ���� � %��� !"� " "� ���!� ��"� "���� !" �'����

�� ��� ��� ��� � ������� �� �� ����� ����� ��� ��� ��� ����������� �� �� ������ ��

3. - X-AXIS TEST

Test Mode X-Axis Cycle: 79 pwm

Test Mode X-Axis Cycle: 115 pwm

Test Mode X-Axis Cycle: 127 pwm

Test Mode Error: 1 on X-axis test

� ��� "�!" ���"��#�#!�' ����"! �"!��� #�"�� '�# � �!! "�� ����� �������� ������ ��'!�

�� ���� � �������� �� �� ���� ����

Page 51: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-17HP DesignJet 430, 450C and 455CA Printers

�� #�� #�"# ����"� #� !�"��%� #�� !������ #!( ��� �� #�� �����&����

� �&�#�� �� #�� �!��#�! ��� ���$���( ��%��� #�� ��!!���� ����� #��"����! !��� ����� ��! ��"#���� �! �!��#��� �� #�� �)�'�"�

� ���� ��! � ��$�#( �! ����( ������#�� �)�'�" �����! �����

� �� ���� ����� ��#�! � ��� �)���

� �� ���� ����#!����" ���$�� � ��� �)���

���� � ��� �� ������ �� � ��� �� � ����� �� � ����� ��� � ������ ���� � ������ ��� ����� ���� ���� ��� ��� ���� � �� � � ���� ����� ����� ������ �� ��� ��

Page 52: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-18 Service TestsHP DesignJet 430, 450C and 455CA Printers

��%� �+%

�� ��� ��� �� ������ ��� �� ����� � � ������ ��� �� � � � �� ����������� ��� � �� �� ���� �� ���� � ��� ����� �� ��� ����� �� � ��� � ����� �� �� ���� �� ������������ �� ��� ��� � ��� �� �� ����� �� �� � ��������� ����� ��� ���� �� � �� ��� ���� �� �� ����� ������� �� � ���� �������

�� ��� ��� �� � ����� � � �� ����������� ��� � � ����� �� ���������� �� �� ����� � �� �� � �� ����� �� ������ � ����� �� � � ���

�� ��� ������� �� ������� ��� ����� ��� ����� ��� �������� �� ���� �� ������ � ������ ��� ��� ����� ������ ���������� �� ������� ���� ����� ��� ����� �� �� �������� �

���� ���� ��� ���� ������� �� �� ���� �������� ����������� ���� ��� ��� �� ��� �� ��

�� ��� �� ������� ����� ���� ���� ��������� �������� ��� ��������

� �� �� �� �� � �� ��%� �+% �� �� �� �� �� ���!� �&+(�� �� &($��� � �� �� � ���� ��� �� �� �� � � �� � ���� ���� �� �� �� -&+$+)* !$$��!�*�#- ���� * � ��%� �+% �- ),!*� !%� � * ��(!%*�( �%� '&,�(!%� �� ���!% , !#� '(�))!%� * � �(!%* �+�#!*-�%� ���!� �&+(�� "�-)�

Page 53: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-19HP DesignJet 430, 450C and 455CA Printers

������� ��

���# $�#$ ��# ���� �"��$�� $ ����� $�� ��$�"��$� � ��$'��� &�"� %#� �! ���$# � $�� �"��$�"� �$ � �����# $�� � �� '��� $�#$#�

� ��""����*�(�# $�#$�

� ��""���� $�#$�

� �����*�(�# $�#$�

� " �$*!���� $�#$�

� ���# "# $�#$�

��� ������� �� � ��� ��� ����� � ������"��� �������!����� ����� ������ ����� ��������� ��� �� ��� ������� ������� �� ���� ������ �����"�� �� � �� ��� ������� ���� ��� ���� ������� � ��� �������� ���� ��� � ��� ���� ��� ��� ������ �� ���� �� ��� �������

������ ������ ������� ���� �����

�� �� !�"$ � $�� $�#$ ����#� $�� $��" !�"$# � �$��%� "���"���##�

��"� "� $�� � �%��" $�#$ �# � �� '#�

� ���� #%"� $��$ $�� ��""���� �# !�"��� �� $�� #�"&��� #$�$� ��

� �� #�"&��� � �� �� !"�## ������� �� ������ � %"�� ��)��

� ��� !"��$�" ��"#$ !�"� "�# $�� " �$*!���� ��#$ ��� ��� �$ �# �%��)� �!��$�� � ��� ��� $�� ��)# �"� !"�##��� $��� � �$��%�# '�$� $�� "�#$ �$�� �� &� $�#$# �� !�"������

� ����" $ $�� � �� '��� ���%"� $ ����� '���� � �# �## ���$�� '�$� '����$�#$� �� $�� $�#$ ���� �� $�� � �� '��� �# '��� �� ��$ ���� �� $�� $�#$������ $�� � �� '��� �# '��� �� ���#�����

�� ���� �� �������� �� ��� ���� ����

Page 54: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-20 Service TestsHP DesignJet 430, 450C and 455CA Printers

� ��� ���� � ���� ���� ������� ����� ���� � � ����� ��� ����� ������ � ��� ����

�% 5,1 .$ 2($3(+& (+%,.* 0(,+ 2( 0'$ /$.( ) -,.0� 5,1 3()) /$$ ,10-10/(*() . 0, 0'$ %,)),3(+& (% 0'$ ���� �������

1. - FRONT PANEL TEST2. - Y AXIS TEST3. - X AXIS TEST4. - CARRIAGE TEST5. - SENSORS TESTTest Mode X–axis cycle : 87 pwm.�4�"�"�� �" ..����$/0�� �,."(+& 1/$ ,% ���� *$0',# %,. � )2(+� ���� ����

�4�"�"�� �" ..����$/0�� �,."(+& 1/$ ,% ���� *$0',# %,. �$)),3� ����� ���

�4�"�"�� �" ..����$/0�� �,."(+& 1/$ ,% ���� *$0',# %,. �5 +� ����� ���

�4�"�"�� �" ..����$/0�� �,."(+& 1/$ ,% ���� *$0',# %,. � &$+0 � ����� ���

Test Mode Y-axis cycle : 26.67 speed and 68 pwm.Test Mode X-axis cycle : 67 pwm.Test Mode Y-axis cycle : 50.00 speed and 100 pwm.Test Mode X-axis cycle : 66 pwm.Test Mode Y-axis cycle : 26.67 speed and 66 pwm.Test Mode X-axis cycle : 65 pwm.Test Mode Y-axis cycle : 50.00 speed and 98 pwm.Pen BLACK continuity: WORKSPen CYAN continuity: WORKSTest Mode X-axis cycle : 64 pwm.Pen MAGENTA continuity: WORKSPen YELLOW continuity: WORKSPen BLACK has 1cd4 identification.Pen CYAN has 400 identification.Pen MAGENTA has 1f00 identification.Pen YELLOW has 1900 identification.Optical sensor samples: 255 255 255 255 255 254 254 253 253 252 252 251251 250 250 249Optical Sensor: WORKSEncoder sensor: WORKSPen BLACK continuity: WORKSTest Mode Y-axis cycle : 26.67 speed and 68 pwm.............

�'$ .$/1)0 ,% 0'$ �+",#$. /$+/,. 0$/0 (/ ,+)5 .$-,.0$# 2( 0'$ /$.( ),10-10 +# +,0 2( 0'$ %.,+06- +$)� �+ ,.#$. 0, -$.%,.* 0'$ $+",#$./$+/,. 0$/0� 5,1 *1/0 *,2$ 0'$ " ..( &$ ��� ���� /, 0' 0 0'$ $+",#$./$+/,. " + #$0$"0 0'$ "' +&$ (+ /0 01/� �% 0'$ " ..( &$ (/ +,0 *,2$# 0 ))� 0'$ �+",#$. �$+/,. 0$/0 3()) )3 5/ % ()� �% 0'$ " ..( &$ (/ *,2$# +# ���� 0'$ �+",#$. �$+/,. 0$/0 % ()/� 0'$+ 5,1 +$$# 0, .$-) "$ 0'$� ..( &$ �//$*!)5 � - &$ 6���

�� ��� �� ��� ����� ����� ����� �� ��� �������� ���� ������� ������ ������ ��� ��� ����� �������������� ��������

Page 55: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-21HP DesignJet 430, 450C and 455CA Printers

�#!�(&%$"�' �!'(

��� #'$#"%� "� &��% &�%& �% &" (�$��* &�� "#�$�&�"! "� &�� ����� �"�' !���$�%% �!� &�� %�'����$�

���� ���� ��� ��� ���� �� � ���� ������� ��� ������ ����������� ������ ���� � ��� ���������� ��� ��������� ������� �� �� ��������� ����������� ���� ���� ���� ������� �������� � ��� ��������

��$�"$ &�� ���&$"!��% &�%& �% �"��")%�

� �! %�$(��� "�� �� #$�%% �#!�(&%$"�' �!'( ������ �"'$�� �!� ��#$�!& �*%��

� ��� &�%& )��� %&�$& �!� ��� &�� �% )��� &'$! ���� ���$� )��� �� !" "(� �!& �! &�� �$�!&�$ �!� *"' '%& )��& �"$ &�� �$"!&+��!�� &"�!����&� �� &�� &�%& ��% #�%%�� "$ �������

� �� &�� &�%& #�%%�%� &�� ����& � ���� �� )��� ����& '#�

� �� &�� &�%& ����%� &�� ����& � ���� �� )��� %&�$& &" ���%��

� ��� &�%& �"!&�!'"'%�* $�#��&% �&%��� '!&�� *"' #$�%% &�� �$�!# �$ �! "� �%)&�! ��*%�

� ��� ���� ����� ��� ����� ��� ����� ��� ��� ��������� ���������

� ��� ����� � ����� � ���� �����

Page 56: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-22 Service TestsHP DesignJet 430, 450C and 455CA Printers

��'+ �� �%�� �

��'+ �� �%�� � �%$)� $( )�()( )��) �� $��� � �%#&"�)� $ ) �" /�) %$ %� )���' $)�'� �� ( #��$( � )��'� ( � (.()�# �''%' $ $%'#�" #%��� ) ( &%(( �"� )% �$)�' $)% ��'+ �� �%�� �� �� &%(( �"� )'. �$)�' $� $)% ��'+ ���%�� � �$� &�'�%'# $� )�� )�()( )��'��

��� )�()( $ (�'+ �� #%�� � �� ��� (�$� )�() $�%'#�) %$ )% )�� &' $)�'�((�' �" &%')� �%' (%#� %� )�� )�()( .%* , "" $��� )% &' $) )�� ��'+ ���%$� �*'�) %$ �"%) ���)� "( � &��� 0�� $ %'��' )% ����! )�� '�(*")(�

�������� � ���

��� (�'+ �� )�()( �'� �%$) $*%*(". '�&��)�� *$) " .%* ()%& )��#� �% �- ) �)�()� &'�(( �$. %� )�� �'%$)0&�$�" !�.(� �% �- ) ��'+ �� �%�� �� .%* #*()&%,�' ��� )�� �' $)�'�

�������� ������� ���� �

� �� "� �%"� $� )�� ����� ������ !�. �%,$� (, )�� )�� &' $)�' ���

� �$�� )�� )�� � �( ��� $ )% " ��) *& %$� �. %$�� '�"��(� )�� ����������� !�.�

�� ������� �������� ��� ���������� ��"��&�� ����� ��� ��������%�� ������������ �� �� ������ ��� �����

���� $� ��� �� ���!��� ��� �� ��� ��� ��� "��� �� ��� �#���� ��� �������� ��!� ���� ��������� ���� ������ � ����� ��� ��� ���� �#���� ��� ������ �� ��� ����� ��� �� "��� ����� �� ������

��� ���%*'��

+

�������������

Page 57: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-23HP DesignJet 430, 450C and 455CA Printers

��� ��

���! "�!"! "�� ��� �"��� �� "�� ���� !'!"��� �� $��� �"�"��� ��� "�� �(�&�! �'�������� ��� ��!�������� "�� ����(���" �������!� ��� ��������#�������� "���� " ����!�

� �� � "�� ��� "�!" �! �����%!�

� �� !� $��� ���� �� � �!! ��� �� ���"#� ��'��

� ��� "�!" %��� !"� " ��� "�� � ���� %��� ��$� �#" �� "�� �� $��� �"�"������ ��"�$�"� "�� �������� ��$� %���� ��#!�! "�� ��� �!!����' "� �����"�' ��!�� ��� "��� ��%� ���

� �� "�� ��"� ���! ��" ��!� "�� ��� �!!����' "��� "�� "�!" ��! �������

� ��� "�!" ���"��#�#!�' ����"! �"!��� #�"�� '�# � �!! ��' �� "�� � ��"(�������'!�

� ��� �� ��� ��� ����� ��� �������� ��� �������� ����������

� ������ � �������� � ��� �����

Page 58: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-24 Service TestsHP DesignJet 430, 450C and 455CA Printers

��#!��� ��"#

���� �� � �� ����� ��� �� ���� �� �� ���� ����� �������� � �� ������ ������ ���!���

� �� ��� �� �� ���� �� � ��� ������� � ����� ����������� ���� ��� �� � ���������

�� � ��������� ����� �� �� ������� ����������� ��� � �� ��� ��� ��� ����� ��� ��� � �������

������ �� ��� ����� �� �� �����#��

� �� ���"��� ���� �� ����� ��#!��� ��"# ���� ��� ��$��

� ��� �� #��� � �� ��� �� ��� �� #��� ����� ���� �� �� ���� ����� ��� ��

� �� �� �� ������ �� ����� ���� #��� ������ �� �� ���� %������ ����� ����� �� � �� ����� � ������ �$ ��!������� �� ����!���

Page 59: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-25HP DesignJet 430, 450C and 455CA Printers

������� ���� ���

�!� *�)-'��&�'��) +�*+ (�)�')%* +!� �'$$'."&

� ���"�1�/"* �&�'��) +�*+ ��)"�"�* +!� '(�)�+"'& '� +!� *�)-' $''(�%��"�1�/"* �������#��

� ��))"� �1�/"* �&�'��) +�*+ ��)"�"�* +!� '(�)�+"'& '� +!� *�)-' $''(���))"� �1�/"* �������#��

� ���')�* +!� %�/"%,% �)"�+"'& ��+��+�� "& +!� ������ �', ��& -"�. +!"*"&�')%�+"'& '& +!� *�)-"�� �'&�" ,)�+"'& ($'+�

��)�')% +!� ��)-'��&�'��) +�*+ �* �'$$'.*

� & *�)-"�� %'�� �� ()�** ������� ���� ��� ����"� �0(� ��0��

� �!� +�*+ ."$$ *+�)+ �&� +!�)� ."$$ �� *$" !+ %'-�%�&+* "& +!� � �&� �1�/"*��+�) �-�)0 � %'-�%�&+*� +!� �")��+"'& '� +!� %'-�%�&+ ."$$ �!�& � "&�'+! �/"*� �!� %�/"%,% ��� '� �'+! �/"* ."$$ �� *�-�� "& +!� ������

� �' -"�. +!� )�*,$+* '� +!� +�*+� 0', %,*+ ()"&+ +!� ��)-"�� �'&�" ,)�+"'&�$'+ ��)"&+ �,�$"+0 �&� ���"� �0(� #�0*��

� � +!� +�*+ ��"$*� �& �))') �'�� ."$$ �((��) '& +!� �)'&+1(�&�$� ����) +'�!�(+�) � "& ')��) +' �'))��+$0 +)',�$�*!''+ +!� ��"$,)��

Page 60: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-26 Service TestsHP DesignJet 430, 450C and 455CA Printers

������� ������ � � ���� ��

��� %�$(��� "!�&"$ �% '%��'� &" ��!� "'& )�+ &�� �$�!&�$ �% !"& #�"&&�!� )��&+"' �*#��& �& &" #�"&� �& �!����% +"' &" $��� &�� �$�#���%-��!�'����!%&$'�&�"!% &��& &�� �$�!&�$ �% $����(�!� �$" &�� �" #'&�$� �!%&��� "�#�"&&�!� &�� �$�)�!� &��& +"' %�!�� &�� �$�!&�$ #$�!&% &�� ����!!�!� �!� �!�"� &�� �"�� &��& )"'�� "&��$)�%� ��(� ���! '%�� &" #�"& &�� �$�)�!��

�"' !��� � ��%�� �!")����� "� &�� �$�#���%-��!�'��� �!%&$'�&�"!% &" �� ����&" #��� "'& &�� � #"$&�!& �!�"$ �&�"! �$" &�� #$�!&�� �"���

��$�"$ &�� ��$(��� �"!�&"$ �% �"��")%�

� �! %�$(��� "�� �� �"�� � %���& "� ���� ��� %�,� "$ %�,� �!� ' ��! #"$&$��& "$��!&�&�"!�

� �$�%% ������� ������ ������ �+#� �!� ����� �"'$�� �+%��

� ��!� &�� ���� �$" &�� �" #'&�$ &�$"'�� &�� %�$��� "$ #�$����� #"$&%�

��� ����� � ����� !� ��� ��

� ���& '!&�� &�� �������� ��% �!����&�� &��& �& ��% %�!& &�� �����

��� ����� � ���!��"� !� ��� ��

� ����� &�� �� �� �� �% ���%��!�� #$�%% ������� ������ ������ �+#��!� ����� �"'$�� �+%� ����!�

��� ����� � ���!��"� !� ��� �� ��!�� � ���"!�� !�� ��� !"�� ������ !�� �������� ��#� !� !�� ����! ��� �� !�� ����!���

� !��� �� ����!��� !�� ���$��� !��! &�" ��!� !�� ����!�� ����! !�� ��� !��� �� ! ��&!� �� !�� ���� ��� !��! ���$���� ��� ���� � ����!�� ����%�������� ��� ��� �����!� �� !�� !�!�� �'� �� !�� ����� � ��! � ��!������ !��� ��� ��&!�� ���& !�� ��� ! �"���� � ����!���� ��� ����!�� �%�! !�� ��#��� ����!�� ���� �� !�� ����� � ��! ���!��� �� "��#�� �� �%�! ����"����

Page 61: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-27HP DesignJet 430, 450C and 455CA Printers

��� �!��� �� �! ���&#�%�! �#!���&#�

�!� ����� %'��$ � �'&�" ,)�+"'& ()'���,)� '&$0 &���* +' �� ��))"�� ',+ "�

� ()�1�'&�" ,)�� �'�)� "* ��"& )�,*���

� �!� �,))�&+ �'�)� "* "&�'))��+$0 �'&�" ,)�� +' +!� .)'& %'��$ � �

� �!� �)"&+�) *!'.* �& ,&�'&�" ,)�� %'��$ � *0*+�% �))') ��%���' ����

�� � ���� ���� ���� ��� � ������� �� ���� ������

�'&�" ,)� +!� �)"&+�) %'��$ � �* �'$$'.*

� ��%'-� +!� )" !+1�&� �'-�) � (� � �1���

� "*�'&&��+ +!� %��"� %'+') �&�'��) ���$� �)'% +!� %�"& �� ��'&&��+')��� ���

� �,)& +!� �)"&+�) �� .!"$� !'$�"& +!� ��"#� % #�0 �'.&�

� �)�** +!������ �!&#�� �&������ �'"� #�0* +' �+!�) +' �&+�) +!����! ���&#�%�! �!��� �!� ��*+� �')%�$ �&� ��*+ �� * �� �$ ��."$$ $" !+ ,(�

� �*"& � *,"+��$� +''$� *!')+1�")�,"+ ("&* � �&� � �+!� �")*+ +.' ("&* '& +!�)" !+� '� +!� %��"� %'+') �&�'��) �'&&��+') ���� ��� �!� ��)+)"� �*� �+� �&� ���"� �� * �� �$ ���� *!',$� $" !+ ,( �* 0', *!')+1�")�,"++!� +.' ("&*�

� �&�� 0', !�-� *!')+1�")�,"+�� +!� +.' ("&*� +!� ��*+� �')%�$ �&� ��*+�� * �� �$ �� *!',$� $" !+ ,( � �"&�

� �)�** +!� �� ��� �&������ �!&#�� #�0* +' �+!�) +' �/"+ +!����! ���&#�%�! �!���

�� ���������� ��� �������� �� �� ���� ����

Page 62: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-28 Service TestsHP DesignJet 430, 450C and 455CA Printers

(' #!-*� ,"� �*#',�* .#," ,"� �(**��, &(��% �� �+ (%%(.+�

���$ ��� ����� !�� $ �� ��"�� � ������� ��� ������!�� ��� ���� �� �������� ��� �� � #�� �!������!��

� ,"� �*#',�* #+ ,( �� �(' #!-*�� �+ � ��+#!'��, � � (%(*� �*#',�*� "(%�,"� ����� ��!��� $�/ �(.' �'� )*�++ ,"� ,.( ����� ������!�� �������� �!��� " � ����� �"��� $�/+ �, ,"� +�&� ,#&��

� ,"� �*#',�* #+ ,( �� �(' #!-*�� �+ � ��+#!'��, �� ��('(�"*(&���*#',�*�"(%� ,"� ����� ��!��� $�/ �(.' �'� )*�++ ,"� ,.( ����������!�� ��� ����� �!��� " � �� !�� $�/+ �, ,"� +�&� ,#&��

� ,"� �*#',�* #+ ,( �� �(' #!-*�� �+ � ��+#!'��, � ����� �*#',�*� "(%�,"� ����� ��!��� $�/ �(.' �'� )*�++ ,"� ,.( �� ������!�� �������� �!��� " � ������ � $�/+ �, ,"� +�&� ,#&��

�-*' ,"� �*#',�* ����

�� ���(''��, ,"� &��#� &(,(* �'�(��* ���%� ,( ,"� &�#' � � ��(''��,(*�� ���

�� �-*' ,"� �*#',�* ��� � ,�* #'#,#�%#0#'!� �**(* �(�� 1���� .#%% �))��*����-+� ,"� ���-*��/ �%#�*�,#(' &-+, +,#%% �� )�* (*&���

�� �*�++ ,"� ������ $�/ �'� )*#', ,"� ��&( �%(, ,( �"��$ # ,"� �*#',�* "�+���' �(**��,%/ �(' #!-*�� �+ � ��+#!'��, ��� � (* ��

�� �� ��� �� �� � ��� �������� �$ ������!��� ��� ����� ���� %�� #����� ������$�� �� �� ���� ������ �!�� �� ��� �� ��� ��� ������� ������� ����� �� ������!�� ��� ������!�� ����� ���� � �� ��

�� ��* (*& ,"� ���-*��/ ��%#�*�,#(' �*� �* ,( "�),�* ��

Page 63: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-29HP DesignJet 430, 450C and 455CA Printers

������ � ������ � �� �

�� ������ �� ������� ���� �� �� � �� ������ � ������� �

DesignJet 4XX Service Configuration PlotFirmware Release: X.XX.XXSPROC release: X.X (Servo-Processor Code revision number.)

EEROM Contents

NOTE: All EEPROM Parameters are since last EEROM Reset.

Number of Power Cycles: 19

Number of Color Plots: 13

Number of Black Plots: 15

Number of Pens: 7 6 6 6

Factory Spittoon: 0% used

Number of Bail Errors: 0

Number of System Errors: 2

Last System Error: 0x00000550 (errno = 0x3c0001)

Last System Error at file media_load.c line 2810

Bench Run:

Bench Run Maximum Y-Axis (Carriage-Axis) PWM: 127

Bench Run Maximum X-Axis (Media-Axis) PWM: 87

Encoder-Tests Maximum Y-Axis (Carriage-Axis) PWM: 62

Encoder-Tests Maximum X-Axis (Media-Axis) PWM: 62

X-axis Calibration: Amp1 = 7.467, Phase1 = –0.450, Amp2 = 8.956, Phase2 = 2.325, Factor = –0.000500

EEROM CONTENTS(This is for the Printer design engineers to interpret.)

Page 64: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-30 Service TestsHP DesignJet 430, 450C and 455CA Printers

����!��� !�� ���#��� ������"��!��� ���!

�$ %&�#( (�� '�&*��� �$#���)&�(�$# %!$(�

� �# '�&*��� "$�� �� !$�� � '���( �# %$&(&��( $&��#(�(�$#�

�� ������ ��� ��� � � � �� �������� �����������

� ����� ������������� ���� ��� � ����� ��� ��� � � �� ���� ����� ��� � �� �� ����� � ������� ���� � ����� �� ����� ����� ������������� ���� �� ���� � ���� � ��������������������� �� ���� �� ��� ��� ������ � ����� ���

� ���# (�� ���% �� !���(' )%� %&�'' (�� ����! �"���!% ��� �����%�� �,'�

� ��� ���% !���( ����#' ($ �!�'� �#� (��# &�"��#' $# �'(���,����� �&�#(�& %!$(' (�� '�&*��� �$#���)&�(�$# %!$( �#� ����(' (�� "�����

� �#!$�� (�� "�����

��!�����!��� !�� ���#��� ������"��!��� ���!

��� %�&�"�(�&' $# (�� ��&*��� �$#���)&�(�$# �!$( ��# ��!% ,$) ($(&$)�!�'�$$( (�� �&�#(�& "$&� �����(�*�!,� �&� �' � '�$&( ��'�&�%(�$# $� (�� �!!(�� %�&�"�(�&'�

"���� �� ��$�� �%���

$+ "�#, (�"�' (�� �&�#(�& ��' ���# %$+�&�� ���

"���� �� ����� ���!

$+ "�#, �$!$& %!$(' ��*� ���# %&$�)��� '�#�� (�� �� +�' !�'( �&�'���

"���� �� ����� ���!

$+ "�#, "$#$ %!$(' ��*� ���# %&$�)��� '�#�� (�� �� +�' !�'( �&�'���

Page 65: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-31HP DesignJet 430, 450C and 455CA Printers

�%���" � ��#

�# (.'� + )! -$' , ��# ��+-+$�" #�, � ( + *&�� �� �# (.'� +, + ! + -)�!+)' & !- -) +$"#-�� �2�(� ��" (-�� � &&)0� �&��%�

��$ "' �!�$$ �

�# ,-$'�- � & / & )! $(% $( -# ,*$--))(� �#$, & / & 0$&& � $(�)++ �- $! -# ����� #�, � ( �& �+ ��

�%���" � ���� �"" "#

�)0 '�(2 ,#.-�)0(, -# + #�/ � ( � ��., )! -# ��$&3&$! ' �#�($,'�

�%���" � �'#$�� �"" "#

�)0 '�(2 �2,- ' �++)+, #�/ )��.++ ��

�#$ �'#$�� �"" "

�# &�,- �2,- ' ++)+ -#�- )��.++ ��

���� ���������� ���� �� ��������� �� ��� ����� � �� ���� ����� ������� �� ���������� ��� ���� ����

�#$ �'#$�� �"" " ��$�

�(!)+'�-$)( )( 1��-&2 0#$�# &$( )! -# !$+'0�+ -# ++)+ )��.++ � $(�

���� ���������� ���� �� ��������� �� ��� ����� � �� ���� ����� ������� �� ���������� ��� ���� ����

����� �%�

�# -# + -# � (�# �.( #�, � ( * +!)+' ��

����� �%� ��&��%� �(�&�# ���""����(�&�#� ��

�#$, ��&. ,#).&� � ��## -#�( ���� �2*$��& ��&. �� 3 ����

����� �%� ��&��%� �(�&�# ������(�&�#� ��

�#$, ��&. ,#).&� � ��## -#�( ���� �2*$��& ��&. � 3 ��

��� ��" (��#$# ��&��%� �(�&�# ���""����(�&�#� ��

�#$, ��&. ,#).&� � ��## -#�( ���� �2*$��& ��&. �� 3 ����

��� ��" (��#$# ��&��%� �(�&�# ������(�&�#� ��

�#$, ��&. ,#).&� � ��## -#�( ���� �2*$��& ��&. � 3 ��

�(�&�# �����"�$� �

�#$, ,#)0, -# $(!)+'�-$)( + &�- � -) -# ���.+��2 ��&$�+�-$)(�

���� ���������� ���� �� ��������� �� ��� ����� � �� ���� ����� ������� �� ���������� ��� ���� ����

Page 66: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

4-32 Service TestsHP DesignJet 430, 450C and 455CA Printers

����!��� #�� � �

� ,$) �!��& (�� ��!��&�(�$# %�&�"�(�&'� ,$) +�!! (��# #���($ %�&�$&" (�� �&�#(�& ��!��&�(�$#'� ��(��!' � ���%(�& ���!��&�#� (�� ����� �!'$ &�'�(' (�� ���($&, '%�(($$# *�!)�($ �� )'��� ���% �# "�#� (��( (�� *�!)� %&�#(�� $# (��'�&*��� �$#���)&�(�$# %!$( "�, �&��(!, )#��&�'(�"�(� (���"$)#( $� �# �# (�� '%�(($$#�

� � � � � �

����!��� �$"# #�� �����!$� ��� �����!�#��� ��!���#�!"

� �+�(�� (�� �&�#(�& ����

� ���!� �$!��#� �$+# (�� �!� ���� ������ �#� ����� �% � �,'�$+#� '+�(�� (�� �&�#(�& ���

� �#�� (�� (�� ��' ����# ($ !���( )% $#� �, $#�� &�!��'� (�� �,'�

����!��� �$"# #�� �"�!&������� ��#$ ��!���#�!"

� �+�(�� (�� �&�#(�& ����

� ���!� �$!��#� �$+# (�� �� !��#� ������� ����� �% � �#� �������$!�� �,' �$+#� '+�(�� (�� �&�#(�& ���

� �#�� (�� (�� ��' ����# ($ !���( )% $#� �, $#�� &�!��'� (�� �,'�

Page 67: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Tests 4-33HP DesignJet 430, 450C and 455CA Printers

�������� ��� ���������

� ������ ��� ������ ���

� ����� ������� ���� ��� ����� ���� ����� �������� ���� ������� �� ���� ���� ���� ����� ������ ��� ������ ��

� ��� ��� ��� ���� ����� �� ����� �� ��� �� ���� ���� �� ��� ����

Page 68: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 69: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

5-1 HP DesignJet 430, 450C and 455CA Printers

����� �� ����������� ���������

Page 70: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

5-2 Service CalibrationsHP DesignJet 430, 450C and 455CA Printers

��)' /�1',+0

�&# ,+)6 ��)' /�1',+ 1&�1 1&# �/'+1#/ /#.2'/#0 '0 1&# ������� ��������4&'!& *201 # -#/$,/*#" 2+"#/ !#/1�'+ !,+"'1',+0�

������� ��������

������

�&# �!!2/�!6 !�)' /�1',+ ��7�5'0 !�)' /�1',+� -/,!#"2/# '0 20#" 1, !,//#!1 1&##+"7-,'+1 �!!2/�!6 ,$ 1&# *#"'� �5'0� �&# !�//'�%# �5'0 ",#0 +,1 /#.2'/#!�)' /�1',+ �+" '0 20#" 1, !�)' /�1# 1&# *#"'� �5'0� �&# �!!2/�!6 !�)' /�1',+�)0, '+!)2"#0 !�)' /�1',+ ,$ 1&# ,-1'!�) )'+# 0#+0,/ ,+ 1&# !�//'�%#�

�&# �!!2/�!6 !�)' /�1',+ '0 �)0, 20#" 1, !,//#!1 1&# #//,/ ,$ 1&# �7�5'0*,3#*#+1 1, �3,'" �+"'+%�

�#/$,/* 1&# �!!2/�!6 !�)' /�1',+ 4&#+#3#/ 1&#�

� ����� '0 #/�0#"�

� �)#!1/,+'!0 *,"2)# '0 /#-)�!#"�

� �/'3# /,))#/ '0 /#*,3#" ,/ /#-)�!#"�

� �#"'� ��7�5'0� *,1,/ '0 /#*,3#" ,/ /#-)�!#"�

� �/'3#7/,))#/ %#�/ '0 /#*,3#" ,/ /#-)�!#"�

� ��/1/'"%# !�//'�%# '0 /#-)�!#"�

� ��/( #+!,"#/ '0 /#*,3#" ,/ /#-)�!#"�

� �-1'!�) 0#+0,/ '0 /#*,3#" ,/ /#-)�!#"�

��� �� �� ��������� ������� �� ��������� �

�&# #+"7-,'+1 �!!2/�!6 0-#!'$'#0 &,4 �!!2/�1#)6 � �/'+1#/ !�+ "/�4 � %'3#+)#+%1& ,$ )'+#� �&# #+"7-,'+1 �!!2/�!6 0-#!'$'!�1',+ $,/ 1&# �/'+1#/0 '0 ± ����** ����� '+� ,/ ± ��� ,$ 1&# 0-#!'$'#" 3#!1,/ )#+%1&� 4&'!&#3#/ '0 %/#�1#/� �1��� ������� �1 ��7 �� /#)�1'3# &2*'"'16 ,+ �� *�11# $')*� �0# 1&# $,)),4'+%$,/*2)� 1, !�)!2)�1# 1&# �/'+1#/�0 �!!2/�!6�

Measured length – Desired lengthDesired length

x 100 = %Error

��� �� ��� �� �� ��������� ������� �

��/',20 -�/1 1,)#/�+!#0 '+0'"# 1&# �/'+1#/ �$$#!1 1&# �!!2/�!6 �'+ -�/1'!2)�/1&# "/'3# /,))#/�� �1&#/ ,210'"# '+$)2#+!#0 '+!)2"#�

� �#"'� 1&'!(+#00� �&'!(#/ *#"'� !/#�1#0 ),+%#/ )'+#0�

� �#"'� #5-�+0',+� �0 1&# *#"'� %/,40� 0, ", 1&# )'+#0�

� �&# �--)'!�1',+ 0,$14�/# *�6 # '+01/2!1'+% 1&# �/'+1#/ 1, "/�4 �+'+!,//#!1 )'+# )#+%1&�

� �&# ����� &�0 ##+ !)#�/#"� �&# �!!2/�!6 !,+01�+10 �/# 01,/#" '+ 1&'0+,+73,)�1')# *#*,/6 !,*-,+#+1�

Page 71: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Calibrations 5-3HP DesignJet 430, 450C and 455CA Printers

����!� ��!��!���� "�� ���#!��& ����!�"���

� �) !, )*,(�' !)0%,*)(!).�' �*) %.%*)- �) *) �� ��..! �%'( ���5-%3!(! %�� +'*. � ,�1%)# .$�. �*).�%)- .1* 4�� (�,&- )*(%)�''2 +*-%.%*)! ��� (( � �� %)�� �+�,.�

� �!�-/,! .$! %-.�)�! �!.1!!) .$! �!).!,- *" .$! 4�� (�,&- *) .$! +'*.�

���-*��1 ��%"�*�,"(' "+ '����� "� ,!"+ �"+,�'�� "+ '(, �� && ����� "'��� && ����� "'��

�� ,!� &��+-*�� ���-*��1� &��"� ,!"�$'�++� (* �'."*('&�',�% �('�","('+.�*1 *��,%1 �*(& ,!� ���,(*1 +,�'��*�+� *���%"�*�,� ,!� �*"',�* �1�(',"'-"' /",! ,!� �(%%(/"' )*(���-*��

��!��!���� "�� ���#!��& ����!�"���

� �'��! � -$!!. *" �� ��..! �%'( *0!, .$! .*+ *" .$! �,%).!, "*, � (%)/.!-.* '!. .$! -$!!. -.��%'%3! .* .$! !)0%,*)(!).�' �*) %.%*)-�

�+� � +!��, (� �))*(0"&�,� +"2� �� (* ��

�� ���� ��� �� ���� � ��� �,!�*/"+� ,!� (),"��% +�'+(* (' ,!���**"� � /"%% �� ��%"�*�,�� "'�(**��,%1� �'� ,!� �*"',�* /"%% !�.�)*(�%�&+ %(��"' +(&� ,1)�+ (� &��"��

� �).!, %).* ��!$��� ���� �� �2 +*1!,%)# �� .$! �,%).!, 1$%'! $*' %)# *1) .$!����� ��#!�� &!2�

� �!. .$!����� �& � *) .$! ",*). +�)!' .* ��"�� �� �!�

� �*� .$! "%'(� 1%.$ .$! (�..! � /''� -% ! *1)� %) +*,.,�%. *,%!).�.%*) %).*.$! �,%).!,�

� �$!) .$! ����& ��� '%#$.- /+� +,!-- �� !��" &!2.

�!� ���� ��� �� "'+ ,( �%�+! �'� ,!� �*"',�* ,�$�+ +�.�*�% &"'-,�+ ,()%(, ,!� ��%"�*�,"(' )%(, �+�� �" -*� ��� �!� �*"',�* �#��,+ ,!� +!��,� �'� ,!���� ��� ��� %" !,+ -)�

� �)'*� .$! -$!!.�

� ��%. /).%' .$! %)& *) .$! -$!!. %- ,2�

�/. .$! -$!!. �'*)# .$! *..! '%)! �) ,!'*� .$! -$!!. ������%� %).*.$! �,%).!,� %) .$! %,!�.%*) %) %��.! �2 .$! �,,*1- *) .$! ��'%�,�.%*) +'*.�-!! �%#/,! ��

�!� ���� ��� �� "'+ ,( �%�+!� �!� �*"',�* ,�$�+ %�++ ,!�' ��&"'-,�+ ,(� *��� ,!� ��%"�*�,"(' +!��, ��%�-%�,� ,!� ��%"�*�,"(' ��,� +�.� ,!� ��,� "' ,!� ����� �'� �#��, ,!� +!��,�

�)'*� .$! -$!!.�

Page 72: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

5-4 Service CalibrationsHP DesignJet 430, 450C and 455CA Printers

����� �

����� �

Page 73: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Service Calibrations 5-5HP DesignJet 430, 450C and 455CA Printers

���(&'�"� '�� �%%����-'#-����� �&'�"��

' �& )�%+ �!$#%'�"' '��' '�� ��&'�"�� ��'*��" '�� ��%%���� �"� '�� !���� �&*�'��" ��%'��" �!�'&� � '�� ��&'�"�� ��'*��" '�� ��%'%���� "#,, �& �"� '��!���� �& ��� ����� �"� &!��%& #" '�� !����� � '�� ��&'�"�� �& ��� ���("*�"'�� &$%�+ �$$��%& �%#("� '�� �"� �#'&� �"� )�%'��� �"�& �%� "#' &'%����'��� ��� ��&'�"�� !�+ � &# $%�)�"' '�� ��%%���� �%#! ��'(�'�"� '�� ��� �)�%��

���"�)�% +#( %�!#)� '�� %�)� �# �% #% '�� �%'%���� �%%����� '��� ��%�'# %��"&'� '��! �#%%��' +� "�#%%��' �"&'� �'�#" !�+ %�&( ' �" '�� ��%%�������"� '## � #&� #% '## ��% �%#! '�� !����� �#% '�� �#%%��' �"&'� �'�#"$%#���(%� � ��$'�% ��

�� �� �� �� ����� ����� �� ������

� ����� ��"� (��� *�'� '�� ��%%���� �&&�!� +� ��& ���" $%#�(��� '# �����'�� ��%%����-'#-!���� ��&'�"�� '# !��� &(%� �' �& *�'��" '�� '# �%�"��&� #*��� �&� '��& ��(�� '# ����� '�� ��%%����-'#-!���� ��&'�"�� �& �# #*&�

� �$�" '�� '#$ �#)�%�

� �#)� '�� ��%%���� #(' #� '�� &�%)��� &'�'�#"�

� ��!#)� '�� � ���� ��%'%���� �%#! '�� ��%%�����

� ���� '�� ��(�� '# ��'�%!�"� '�� �� �"� �� �� &���&�

���� ��

� � ��� '�� ��(�� #" '�� �%�)� %# �% #" '�� ��'-��"� &��� #� '�� ��%%�����*�'� '�� �� &��� ����"� '�� ��%%����� �" '�� $#&�'�#" &�#*" �� #*�

Page 74: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

� � � � � � �

��� ���� ���� ��� ���������� �� ��� ��� �������� �� �������� ���� ������� ���� ���������

����

5-6 Service CalibrationsHP DesignJet 430, 450C and 455CA Printers

�!�%�������!

��$��

��$����$"#���� �!������#��#������#�!(�������#����!�%�������!

� ��#� #�� ��$�� ���� �� ����� ���$���' ��%� #�� ��!!���� �%�! #�� ��"��� �� #�� ��$��� ��� ������ ������#�� ����&� "��$�� ��"��' �"" �%�! #���� "��� �� #�� ��$���

� #�� ����� ��� ��� �� �%�! #�� �� "��� �� #�� ��$��� ���$"# #����!!����(#�(����� ��"#���� � ��� �(��

� ����%� #�� ��$�� ��� !� ���� �# �� #�� �!�%� !����! &�#� #�� � � "��������� #�� ��!!�����

� ��#� #�� ��$�� ���� �� ����� ���$���' #!' #� �"" #�� ��!!���� �%�! #���� �� "��� �� #�� ��$��� ��� ������ ������#�� ���%�� "��$�� � � �""�%�! #�� �� �� "��� �� #�� ��$���

� #�� ����� ��� �� �%�! #�� �� �� "��� �� #�� ��$��� ���$"# #����!!����(#�(����� ��"#���� � ��� �(��

� �� ���� #�� ����� ��!#!���� �� #�� ��!!�����

�� ��%� #�� ��!!���� ���� ��#� #�� "�!%��� "#�#����

�� ���"� #�� #� ��%�!�

Page 75: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

��� ��� ��� � �� ���������� �� � ���������� ��� �� ���� � ������

Service Calibrations 5-7HP DesignJet 430, 450C and 455CA Printers

�� ����� � �������������� ������

��� ���� � � �� ����� �� ����� ����� �� ������ ���

� �� � �� �� �� ����� � ��� ��� �� � �� �� ��� �� �� ��� ����� � �� ��� �� ����� �� �������� � ��� ���� �� �� ���� ���� ��

� �� � �� �� �� ����� � ��� �� � �� �� �� ��� �� �� ��� � ����� �� ��� �� ����� �� �������� � ��� �� ���� �� ���� ���� ��

������ �� ����� ����� �� ������ � ��������

� � � � �� ��� ������ � ����� �� �� ��� �� �� ������� ����� �������� �� � �������� ��������

� ���� �� ��� �� �� ����� ���

Page 76: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

5-8 Service CalibrationsHP DesignJet 430, 450C and 455CA Printers

� ������ �� ������ ��� �� ���� ����� �� ��� ������� ��� ���� ���� ��������� ���� �� ��� ��� �� �� � ���� ��������� �� �������� ��������� �� �� � �������

ÎÎÎÎ

GapIncreases

RotatingClockwise

ÎÎ

Torx-8

� ����� ��� ������ �� �� � ������ � ��� � ��

� �������� ��� ��� �� ��� �������

� ����� ��� ������� ���� �� ��� ���� ��� �� �� ��������� �� �� ��������� ��� � ��� ��� �� ��� ������ ������ � ��� ���� �����

Trailing cableunder tabs !

���������� ��� ������� ���� ��� �� ��� �� �� �� ��

Page 77: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-1 HP DesignJet 430, 450C and 455CA Printers

��� ������

Page 78: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-2 Print QualityHP DesignJet 430, 450C and 455CA Printers

�-%)/ �0�'%/4 �-*0�'!.$**/%)# �$!�&'%./

�$!) "��! 2%/$ � �-%)/ �0�'%/4 +-*�'!(� 0.! /$! "*''*2%)# �$!�&'%./ �. �#0% ! %) /-*0�'!.$**/%)# /$! +-*�'!(�

� �-*�'!( -!+-* 0�/%*)

� �!+-* 0�! /$! +-*�'!( /$�/ /$! �0./*(!- %. .!!%)# 0.%)# /$!%- *-%#%)�'.!//%)#.�

� �-%)/!- �*)"%#0-�/%*)�

� �-%)/ �* !� �!/ /* 6 !./� �%) /$! +-%)/!- �) %) /$! -%1!-.��

� �!'!�/ /$! �*--!�/ (! %� .!//%)# 2$!) '*� %)# /$! (! %��

� ��- 2�-! �$!�& '%./

� �$!�& %" /$! '�/!./ 1!-.%*) *" /$! "%-(2�-! %. %)./�''! � �" )*/ �)./�''/$! '�/!./ "%-(2�-! -!1%.%*)�

� ��-/-% #!.

��-/-% #! �-*0�'!.$**/%)# �-*�!..�

� �" 4*0 *)�/ $�1! �)4 .�(+'!. 4!/� -!+-* 0�! /$! *-%#%)�' +-*�'!( 2%/$/$! �*--!�/ +-%)/!- .!//%)#.�

� �-%)/ /$! �-%)/7�0�'%/4 �'*/ 0.%)# /$! !3��/ .!//%)#. �) �! %� /$�/ /$!�0./*(!- 0.! 2$!) "��! 2%/$ /$! �-%)/ �0�'%/4 +-*�'!( � +�#! 7��

��-/-% #! �'%#)(!)/�

� �!-"*-( /$! ��-/-% #! �'%#)(!)/ +-*�! 0-! � !/�%'. � �.!-�. �0% !��

� �! %�

� ��&! .0-! /$�/ 4*0 0.! �� *- ��7�++-*1! (! %��

� �!'!�/ /$! �*--!�/ (! %� /4+! /$-*0#$ /$! "-*)/7+�)!' 2$!) '*� %)# %/�

� �-%1!- +-%)/ ,0�'%/4 �*)"%#0-�/%*)�

�* �'�-%"4 %" /$! -!�.*) *" /$! +-*�'!( %. -!'�/! 2%/$ /$! +-%)/ (* ! !"%)! 2%/$ /$! �*)7�� �-%1!- /-4 /$! "*''*2%)#�

� �-%)/ /$! .�(! .�(+'! 0.%)# /$! �*)7�� -%1!- �) /$!%- )*-(�' (! %��

� �-%)/ /$! %)/!-)�' !(* *- +-%)/ /$! �-%)/ �0�'%/4 �'*/ � !/�%'. � +�#!7�� 0.%)# �� �! %� �) �*)"%#0-%)# /$! +-%)/!- �. %) %��/! +-!1%*0.'4�

�" /$! *0/+0/ *�/�%)! 0.%)# /$! �� �*'0/%*) %. #** �) /$! *)! *�/�%)! /$-*0#$ /$! �- +�-/4 .*'0/%*) %. �� � �� .0++*-/ *-#�)%5�/%*) .$*0' �

� �*((0)%��/! /* /$! �0./*(!- /$�/ /$! +-*�'!( %. )*/ %) /$! +-%)/!- �) /$�/ $! .$*0' � -!.. %/ /$-*0#$ /$! �- +�-/4 1!) *- .0++*-/ ./-0�/0-!�

� ���0-��4 ��'%�-�/%*) � !/�%'. � �$�+/!- �

� �!-"*-( 6���0-��4 ��'%�-�/%*)� 0.%)# �� ��//! �%'(�

Page 79: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-3HP DesignJet 430, 450C and 455CA Printers

�'�#)/�*�!�)- �!$)

������������

���#�+�' � �'�#) �*�!�)- %'$�!�" �%%��'(� �) �( ��+�(��!� )$ %'�#) )���'�#)/�*�!�)- �!$) )$ ��!% ����#$(� )�� %'$�!�"� ��� �'�#)/�*�!�)- �!$) ,�!!��!% -$* �����'�#)��)� ��),��# %$((��!� ��')'���� �''$'( �#� $)��' %'$�!�"((*�� �( �#�$''��) �'$#)/%�#�! (�!��)�$#� �'�+�' $' ��� �$#���*'�)�$# $'"����#���! %'$�!�"(�

�� ������ ��� ��� ��� ������ ��� ��� �������� ������ ���������� �� ���� ��� ������� �� ��������� ��� ��������� ��������������� ��� ��� ������ ���� ��� ���������� ������ �� ����������� ��� ��� ������ ��� ����������� �������

����� ��� ���� ������ ���

� ��� (�.� $� )�� �'�#)/�*�!�)- �!$) �( �� �#� � ($ -$* "*() *(� "���� �'$!!$' (���)� )��) �( )��( (�.� $' !�'��'�

� �(� )�� (�"� )-%� $� "���� )��) )�� �*()$"�' ,�( *(�#� ,��# )�� �'�#)&*�!�)- %'$�!�" ,�( ��(�$+�'���

� �)*�- ���� $� )�� )�() %�))�'#( �# )�� $'��' !�()�� )$ ��)�'"�#� )�� )-%� $��'�#) &*�!�)- %'$�!�"�

� �� )�� �*()$"�' ,�( '�%$')�#� %'$�!�"( $� �'�#) �*�!�)- *(�#� #$#/��"���� �#� ��)�' )�� �'�#)/�*�!�)- �!$) )�() )�� (�"� &*�!�)- %'$�!�"(�%%��'� ��+�(� )�� �*()$"�' )$ *(� ��#*�#� �� "����� ��%��) )���'�#)/�*�!�)- �!$) )�() *(�#� ��#*�#� �� ������

������� ��� ���� ������ ���

� ���$'� %'�#)�#� )�� %!$)� �# �$'"�! "$��� (�) )�� ����� ��� �#� ���������� $# )�� �'$#) %�#�! )$ )�� (�))�#�( )��) -$* ,�#) )$ )�()�

� $�� � (���) $� "���� �# %$')'��) $'��#)�)�$#�

� ���# )�� ����� !���)( *%� %'�(( )�� ���� ���� �#� ����������� �-( )$��)��'�

The ����� light begins to flash, and the media moves slightly forward. Thecarriage moves to the right side of the Printer, and the fan turns on. The Printerplots the print-quality plot and ejects the media.

� �#!$�� )�� "�����

Page 80: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-4 Print QualityHP DesignJet 430, 450C and 455CA Printers

��� ������ ���

��� � ��"&�#���"% ���" �� "�� �� ��!��� �" ����������� �! �� �!��"������$� �!� � ��� �������� "� ���� ����"��% ���"&�#���"% � �����!�

Test 6

Page 81: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-5HP DesignJet 430, 450C and 455CA Printers

�������� ��� ������������� ����

�%" �,&).5�/�'&.3 �'*. 1&'' *).�&) -&2 +�..",)- �- #*''*1-�

� ��,.,&!$" ��,( �+ ��"" �"'*1��

� �*44'" �,&). �"-. ��"" �"'*1��

� �",.& �' �&)" �.,�&$%.)"-- �"-. � +�$" �5��

� �*'*, �'&$)("). �/�'&.3 �"-. � +�$" �5 �

� �*'*, ��,&�.&*) �"-. � +�$" �5���

� ��)!&)$ �"-. � +�$" �5���

��� ������� �� ������� ��� ���

�%&- +�..",) 1�,(-5/+ .%" �,.,&!$"-� '"�0&)$ .%"( &) � +",#" . *+",�.&)$ *)!&.&*)� �*/ �) &$)*," .%&- +�..",) �)! *).&)/" 1&.% �"-. ��..",) ��

��� ������� �� ����� ����� ���

�) .%&- ."-. �'' .%" � )*44'"- *# "� % �,.,&!$" �," ."-."!� �*, "� % *# .%" *'*,-3*/ 1&'' -"" .%" )/(�",- � .* � *0", .%" !&�$*)�''3 -."++"! '&)"- &) &) ,"(").-*# � �%"-" )/(�",- *,,"-+*)! .* .%" )*44'" )/(�", .%�. +,&).- "� % -."+�

�%"," �," .1* �,.,&!$" )*44'" ",,*,- �-"" �&$/," ���

� �*44'"- )*. +,&).&)$�

� �*44'"- (&-!&," ."!�

����� �

Page 82: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-6 Print QualityHP DesignJet 430, 450C and 455CA Printers

������ ��� �������� ������� ����

� �� (�� ����#"� , '(�$$�� �"�' �&� �&#��" �" #"� #& !#&� '(�$' �( �"����(�'(��( (��' '$������ "#-- ��'� !�, �� � #���� �"� �&� "#( $&�"(�"��

������ �����������

�� � (�� '(�$$�� �"�' �&� *�'�� � �" (�� $�((�&"� (��" � (�� ��&(&���� "#-- �'�&� $&�"(�"�� �#+�*�& (�� "#-- �' �#) � '(� �� !�'��&��(��� $#''�� , �)� (#'#!� �&��� �"� �&#)"� (�� "#-- �'�

� �" (�� (#$ $�((�&"� !�&��� +�(� ")!��&'� �� (�� ����#"� , '(�$$�� �"�'�&� "#( �%)� , $#'�(�#"�� �" �*�&, '(�$ �( �"����(�' (��( (��' '$������"#-- ��'� !�, �� !�'��&��(���

������ ��� ��� �� �#!� ��&(&���� "#-- �'� �" �", #"� �# #&� �&� "#(

$&�"(�"��

������ ��� ��� �� ��&(&���� "#-- �' �&� !�'��&��(�� �" �", #"� �# #&�

��������� ������� �&, (�� �# #+�"� '(�$'

� �&�!� (�� ��&(&����' �"� $&�"( (���&�"(.�)� �(, � #( ����" (# '�� �� (��&� ��' ���"�", �!$&#*�!�"(�

� �� (�� �&&#& �' '(� $&�'�"(� &�$ ��� (�� ��� �"���&(&���� �"� $&�"( (�� �&�"(.�)� �(, � #( ����"�

� �� (�� �&&#& �#"(�")�' (&, (�� �# #+�"�

� ��$ ��� (�� �&�� �"� ��� � � $��� .�

� ��$ ��� (�� ��&&���� �''�!� , � $��� .���

� ��$ ��� (�� ��(&#"��' �#�) � � $��� .���

���� ����� �� �������� �� � � � ���

���� �� ������ ��� ��� ���

����� �� ������ ��������� �� �� �� �

������� ��� � �� � ��� �� ���� �

������ �� �� �������� � ���

Page 83: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-7HP DesignJet 430, 450C and 455CA Printers

��� ������ �� �������� �� � ������ ��� ����

��"$����+���� #$"����$��## �# � ���#%"� � $�� � "�* �$�� ��#$���� ��$'��� $��#�����$# � � &�"$���� ���� !� $$�� �� $' � �#��%$�&� #'�$�#� �� $�� �"��$�" �#' "���� � ""��$�)� $��# ��#$���� #� %�� �� ��## $��� � ���# �#�� ���%"� ��

Swath Printing Direction

Maximum allowable VLS Error = 2 mils.

Swath (n–1)

Swath (n)

Swath (n+1)

Swath Printing Direction

Swath Printing Direction

�� ��� �

�������� �����������

�$� %�� $�� � � #!�������$� � #�$�#���# $�� �(!��$�$� �# � � #$ �%#$ ��"#�# �� ��) � �!���� �&�� '��� $�� �"��$�" �# ' "���� '�$��� $��# #!�������$� ���� $�� � � �"" " �# ��"���) ��## $��� � ���#� � � $ $") $ ��!" &� �$�

��� � � �"" " �# � �! #�� � $' !�"$# �#�� ���%"� ���

� ���$�+��$� �"" "

� ���"��$� ��� �"" "

�� ��� �

Page 84: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-8 Print QualityHP DesignJet 430, 450C and 455CA Printers

����������� �����

��$ ��� "�� �� �'�� �� �� � ����!��#����� �!!�! �� ��$!� �� �� (�$ !��# #��"��� ��# $"��� � $����!��#����� !��# ����� #�� �!!�! "��$�� ��# � ��!�

���" �!!�! ��� ���$! ��! %�!��$" !��"��"� ����$�����

� ����!!��# ��"#���� ��#&��� ��))��" ��� ������ ���$"#���# � ��� #�! ���

� ������!*"#!� "��#" �!� ������� �! ��!#(�

� ��!# �� #�� $���( �" ��$"��� #�� ���# #� "�� �

� !��#��� ��#&��� ��!!���� �$"����" ��� "����! !���

� �������� �����

��$ ��� "�� �� �'�� �� �� � ���#�*��#� �!!�! �� ��$!� �� ���( � ��! &��� #��!�&" �� ��))��" �� � ��!#!���� �!� ��# �! �����$��! #� #�� ��!!���� �'�" ��*�'�"��

���" �!!�! ��� ���$! ��! %�!��$" !��"��"� ����$�����

� ���( "��#�� ��!#!�����

� �$�#( ��!#!�����

� �$�#( ��!!�����

������ �

Page 85: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-9HP DesignJet 430, 450C and 455CA Printers

�� �������� �$ 0&# )'+# '/ +,0 -#.$#!0)5 /0.�'%&0 �0 ��� � '+ 0&#

0#/0 '*�%# �/## �'%1.# ��

��������� ������� �.5 0&# $,)),3'+% /0#-/�

� �#.$,.* 0&# ��.0.'"%# �)'%+*#+0 ��)' .�0',+��#0�')/ � �/#./ �1'"#� 1/'+% %#+1'+# ��*#"'� 0&#+ -.'+0 0&# �.'+07�1�)'05 �),0 �%�'+0, /## '$ 0&#.# &�/ ##+ �+5 '*-.,2#*#+0�

� �$ 0&# -., )#* !,+0'+1#/ -#.$,.* 0&# �!!1.�!5��)' .�0',+ ��#0�')/ � -�%# 7�� �+" -.'+0 0&#�.'+07�1�)'05 �),0 �%�'+ 0, /## '$ 0&#.# &�/ ##+�+5 '*-.,2#*#+0�

� �$ 0&# #..,. '/ /0')) -.#/#+0� .#-)�!# 0&# $�')'+%!�.0.'"%# �+" -.'+0 0&# �.'+07�1�)'05 �),0 �%�'+�

� �$ 0&# #..,. !,+0'+1#/ 0.5 0&# $,)),3'+%�

� �#-)�!# 0&# �.�')'+% �� )# � -�%# 7 �

� �#-)�!# 0&# ��..'�%# �//#* )5 � -�%# 7���

� �#-)�!# 0&# �)#!0.,+'!/ �,"1)# � -�%# 7���

���� ����� �� �������� �� � � � ���

���� �� ������ ��� ��� ���

����� �� ������ ��������� �� �� �� �

������� ��� � �� � ��� �� ���� �

������ �� �� �������� � ���

���� ������� �� � � ������� ����� ����

����� ����� �&# $'./0 ,$ 0&#/# -�00#.+/ 0#/0/ �)'%+*#+0 #03##+ 0&# !5�+ �+"*�%#+0� !�.0.'"%#/� '0 /&,1)" # )1# 3'0& +, !5�+ ,. *�%#+0� /&�",3/� �&#/#!,+" 0#/0/ �)'%+*#+0 #03##+ 0&# !5�+ �+" 5#)),3 !�.0.'"%#/� '0 /&,1)" # %.##+3'0& +, !5�+ ,. 5#)),3 /&�",3/� �&# 0&'." 0#/0/ �)'%+*#+0 #03##+ 0&# *�%#+0��+" 5#)),3 !�.0.'"%#/� '0 /&,1)" # .#"� 3'0& +, *�%#+0� ,. 5#)),3 /&�",3/�

����� ����� �&'/ 0#/0 -�00#.+ '/ 0, !&#!( 0&# !,),. �)'%+*#+0� �+" -.,"1!#/��-�00#.+/ #�!& 3'0& � "'$$#.#+0 -.'*�.5 !,),./� �+ #�!& -�00#.+ 5,1 3')) /##-.'*�.5 !,),. !'.!)#/� �$ 0&#.# '/ *'/�)'%+*#+0 #03##+ 0&# -.'*�.5 !,),./ 0&#!,*-,/'0# !,),. 3')) # -.#/#+0 '+ ,+# -�.0 ,$ 0&# !'.!)# �+" 3&'0# 3')) #2'/' )# �0 0&# ,--,/'0# /'"# ,$ 0&# !'.!)#�

�&#.# �.# 03, 05-#/ ,$ *'/�)'%+*#+0 �/## �'%1.#/ �+" ���

� �,.'6,+0�) 7 3&#+ 0&# *'/�)'%+*#+0 '/ '+ 0&# &,.'6,+0�) �4'/�

� �#.0'!�) 7 3&#+ 0&# *'/�)'%+*#+0 '/ '+ 0&# 2#.0'!�) �4'/�

Page 86: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-10 Print QualityHP DesignJet 430, 450C and 455CA Printers

���� �

���� �

������ �� ���� �� ���$� �"�"$ #$�%�!&� �%����! �!& �! ��&��$ &��

�"*�% "$ ��$���% "� &�� &�%& � ��� �%�� ���'$�% � � ��

���� ���� ������� �$+ &�� �"��")�!� %&�#%

� ��$�"$ &�� ��$&$���� ����! �!& �����$�&�"!� �&���% � �%�$% �'���� '%�!� ��!'�!� �� ���� &��! #$�!& &�� �$�!&,�'���&+ ��"& ����!&" %�� �� &��$� ��% ���! �!+ � #$"(� �!&�

� �� &�� �$$"$ �% %&��� #$�%�!&� $�#���� &�� �����!���$&$���� �!� #$�!& &�� �$�!&,�'���&+ ��"& ����!�

Page 87: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-11HP DesignJet 430, 450C and 455CA Printers

� �! -# *+)�& ' �)(-$(. , * +!)+' -# ���.+��2��&$�+�-$)( �� -�$&, � *�" �4� �(� *+$(- -# �+$(-4�.�&$-2 �&)- �"�$( -) , $! -# + #�, � (�(2 $'*+)/ ' (-�

� �! -# ++)+ �)(-$(. , -+2 -# !)&&)0$("�

� � *&�� -# �+�$&$(" ���& � *�" �4��

� � *&�� -# ��++$�" �,, '�&2 � *�" �4 �

� � *&�� -# �4�1$, �,, '�&2 � *�" �4�

���� ����� �� �������� �� � � � ���

���� �� ������ ��� ��� ���

����� �� ������ ��������� �� �� �� �

������� ��� � �� � ��� �� ���� �

������ �� �� �������� � ���

���� ������ � ��� ����� � ���

�#$, - ,- *+)�.� , !).+ �)1 ,� �&��%� �&. � �2�( �(� 2 &&)0� �( ��# �)1 -# + �+ -0) #)+$3)(-�& ��(�,� -# &)0 + ��(� $, ���� ,#�� � -# .** + ��(� $,,#�� � !+)' ���� ,��&$(" -) ����

�# *.+*), )! -#$, - ,- $, -) � - +'$( �- 0#�- * +� (- -# .** + ,#��$("� �)' , /$,$�& !+)' -# &)0 + ��(�� �# � ,- 0�2 -) �) -#$, $, -) �)/ + -# �)1 0$-# � *$ � )! *�* + �(� ,&$� -# *�* + #)+$3)(-�&&2 ��+),, -# �)1� �-)*�, ,))( �, 2). , � �$!! + (- ,#�� $( -# .** + �)1� �). ��( -# ( � - +'$( -# * +� (-�" ,��&$(" !+)' -# !$".+ �- -# -)* )+ �)--)' )! -# �)1�

������ � ��������

������ � �����������

Page 88: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-12 Print QualityHP DesignJet 430, 450C and 455CA Printers

�������� ������� �� &�� '##�$ �"* %����!� �% ����� (�%���� "$ �%

(�%���� �& � (�$+ �") #�$��!&���� �& �% �! �!����&�"!

&��& &�� ��$&$���� �% #$"�'��!� �!�"$$��& %�,� �!�

�$"#% �%�� ��'$� ���

���������� ������� �$+ &�� �"��")�!� %&�#%

� ��#���� &�� �����!� ��$&$���� �!� #$�!& &���$�!&-�'���&+ ��"& ����!�

� �� &�� �$$"$ �"!&�!'�% &$+ &�� �"��")�!�

� ��#���� &�� �$����!� ����� � #��� �-��

� ��#���� &�� ��$$���� %%� ��+ � #��� �-���

���� ����� �� �������� �� � � � ���

���� �� ������ ��� ��� ���

����� �� ������ ��������� �� �� �� �

������� ��� � �� � ��� �� ���� �

������ �� �� �������� � ���

���� ������ �� ����� ���

���% ��%& #�&&�$! �% � �"!� ��$� %&$�#� �!� �% ��� !' ��$�� "! &���$�!&-�'���&+ #�"&� �& ��! �� �"'!� "! &�� ���& ��!�-%��� "� &�� "&��$ &�%& #�&&�$!%�

��������

��!�" ��$� "$ ����& ��!�% �! �$�� ����%� ���$� �$� &)" &+#�% "� ��!��!�

� ����&�(� ��!��!� - ���% ��!% &��& �"!%��'&�(� %)�&�% "(�$��# ����"&��$� �$��&�!� ��$� ��!�%�

� �"%�&�(� ��!��!� - ���% ��!% &��& �"!%��'&�(� %)�&�% �" !"& &"'��� &�'%���(�!� � % ��� ��# ��&)��! ���� "&��$� ���% &��! ��'%�% )��&� �"$����&�$� ��!�%�

����� �

Page 89: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-13HP DesignJet 430, 450C and 455CA Printers

�� � �� �����

� &'22$� !+ �$'�#�� '* ��-$,1 �&� !+ &', �!*!&� !&#4�*'(+�

� � � !&# �*'(+ '� '&� &'22$� �*� '� +%�$$�* .'$-%� , �& , '+� '� , � ', �*&'22$�+�

� &'22$��+ !&# �*'( .'$-%� .�*!�+ / !$� ($',,!&��

� &'22$��+ !&# �*'(+ �*� %!+�!*��,���

� �����, !& %�&-���,-*� '� ��*,*!����

� �!*, '* ���*!+ '& , � &'22$� ($�,��

� �&# (-��$!&� '& , � &'22$� ($�,��

� & �$��,*!��$ �'&,��, !+ %!+�$!�&�� '* ��%���� '& , � ��*,*!���� +' , �, !,�'�+&�, %�#� �'**��, �'&,��, /!, , � �!*�-!, '& , � ��**!���� ���� � (����4� � �������� ����

� ��� �����

� �&�'**��, +/�, 4��.�&�� �&�$� '� , � �*!.� *'$$�*� � !+ �'-$� �� ��-+�� �1 ��

� ��-$,1 *'$$�* �!**��-$�* *'$$�* *��!-+ � �����,!.� ���*!&�+�

� ���!�4�0!+ !&���-*��1 ������,!.� %��!� %','* '* �*!.�* �!*�-!, ���$!�*�,!'& $'+,�

� & �$��,*!��$ �'&,��, !+ ��-$,1 !& '&� '� , � �*!&,�* ��*,*!��� � -,�+� +', �, !, �'�+&�, %�#� �'**��, �'&,��, /!, , � �!*�-!, '& , � ��*,*!���� ����� (��� �4� � �������� ����

� �'22$�+ ,'-� , � +�*.!�� +,�,!'&� , -+ ��-+!&� (-��$!&� ,' '��-* '& , �(*!&,4 ����

� �'%� '� , � +%�$$ +$',+ '& , � �&�'��* +,*!( �*� ��%����� � �*��'*� , ��*!&,�* ��&&', ('+!,!'& , � ��**!��� �'**��,$1 �-*!&� ��*,*!��� +�*.!�!&��

� ��*,*!���+ �*� %!+�$!�&�� /!, *�+(��, ,' ��� ', �*�

� ��$!�*�,!'& .�$-�+ $'+, '* !&�'**��,�

���� �����

�'%� ,1(�+ '� %��!� �.� � �'�,!&� , �, (*�.�&,+ , �% ��,,!&� 3/�,� �*'%, � !&# �*'(� � � !&# �'�+&�, +(*��� '-, +-��!�!�&,$1 �*'-&� , � ('!&, / �*�, � �', !+ ($�����

��&�!&� %�1 &', '��-* '& +'%� (''*4)-�$!,1 %��!�� / �*� !, !+ �'-&,�*��,���1 �&', �* (*'�$�%� $�*�� �', ��!&� � !+ !+ / �*� , � !&# +(*���+ '-,�0��++!.�$1 '& , � %��!� �*'-&� , � ��+!*�� �', ('+!,!'&� �' ���-*�,�$1 ,�+,�'* ��&�!&�� -+� �� ('$1�+,�* !&#"�, �!$%�

Page 90: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-14 Print QualityHP DesignJet 430, 450C and 455CA Printers

������ ��� ���� �" -$!+! %, (!#�-%/! )+ *),%-%/! ��( %(# %( -$! -!,-

%'�#! �,!! �%#.+! ���

��������� ������� �+2 -$! ")&&)0%(# ,-!*,

� �!+")+' -$! ��+-+% #! �&%#('!(- ��&%�+�-%)(��!-�%&, � �,!+, �.% !� .,%(# #!(.%(! ��'! %� -$!( *+%(- -$! �+%(-3�.�&%-2 �&)- �#�%(-) ,!! %" -$!+! $�, �!!( �(2 %'*+)/!'!(-�

� �" -$! *+)�&!' �)(-%(.!, *!+")+' -$! ���.+��2��&%�+�-%)( ��!-�%&, � *�#! 3�� �( *+%(- -$!�+%(-3�.�&%-2 �&)- �#�%( -) ,!! %" -$!+! $�, �!!(�(2 %'*+)/!'!(-�

� �!')/! -$! �&& ��+-+% #!, �( �&!�( -$! "&!1�)(-��-, )( -$! ��++%�#! �( -$! ��+-+% #!,��!,!�- -$! ��+-+% #!, �( -+2 -$! -!,- �#�%(�

� �" -$! !++)+ %, ,-%&& *+!,!(-� +!*&��! -$! ��+-+% #!,�( *+%(- -$! �+%(-3�.�&%-2 �&)- �#�%(�

� �" -$! !++)+ �)(-%(.!, -+2 -$! ")&&)0%(#

� �!*&��! -$! �(�) !+ �-+%* � *�#! �3��

� �!*&��! -$! �+�%&%(# ���&! � *�#! �3��

� �!*&��! -$! ��++%�#! �,,!'�&2 � *�#! �3��

� �!*&��! -$! �&!�-+)(%�, �) .&! � *�#! �3���

���� ����� �� �������� �� � � � ���

���� �� ������ ��� ��� ���

����� �� ������ ��������� �� �� �� �

������� ��� � �� � ��� �� ���� �

������ �� �� �������� � ���

Page 91: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-15HP DesignJet 430, 450C and 455CA Printers

�� ������� ������ ���� �� ��� ������������� ����

�� ��� $�� $�#$ �$$�"�# �"�� $�� "��$*�%���$) ��$ �"� ��""��$ ��� )�% #$����( �"����� "��$ !%���$) "�����#� ��"� �"� #��� �� $�� �$��" ��%#�# $� ������

� ��� "��$ ���� %#�� �� )�%" "��$�" �# ����""��$ �$��# �# ������� �) $�� "��$�"�# �"��$* ���� ���% #����$���#��

� ���* �"�&�"�

� ��� �� ��� )�% �"� %#��� �����

� ��� #��$'�"� � ����$���# )�% �"� %#����

����" $� $�� ������ ����� ��" �%"$��" ����"��$��� �� ��' $� ������%"� $��#)#$�� '�$� ��""��$ #�$$���#�

����

��'�)# ���� #%"� $��$ $�� �%#$���" �# %#��� $�� � "� "��$� ����� ��" $��"�!%�"�� ����� ��� $��$ �$ �# ���#�#$��$ '�$� $�� #��$'�"� � ����$��� �����%#��� �� ��#%"� ����" ���%"��) ��� "��$ !%���$) �"��"����� �� $�� "��$�"����) ����� $) �# $��$ ��&� ���� ��"$����� ��" $�� "��$�" #��%�� �� %#��� �#��� ���* ����� �" ����� ��$ ��"$����� ��" $�� $�� "��$�" ��)#���������$�) "��%�� $�� ����" ��� "��$ !%���$) �� $�� "�!%�"�� �����#� �"��$���# �� ������ "���" $� $�� ������ ����� �" $����� ������

�� � � ���� �� ������� ��� ���� �������� ���� � ��� ��� �"�� ������ �� ��� �� ��� ��������

�� ��� �������� �� ����� ���#� ���� !��� � ��� ���� ��� ������ ����� �������� ����� � " ��� �� ���� ��� �� ��� ��� �������� �� ���� ���� �� ���" ! �� �� ����� � ��� ���� �" �� ��� �������

Page 92: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-16 Print QualityHP DesignJet 430, 450C and 455CA Printers

�%�!'-�(���', �����'& �%"(���&�""'�!�

��� ���� � ��

�! &" � �%�*�!�& ��"% �+� #��� �� �%�*�!�& ��)�!� � '����-��!�� �%� ��%"(!� '�� � "! &" � ',#�& "� ����� ,"( �, !"'��� &" � & ��� �%�& ��� �, '�� &'�%*����&� ���&� ��!!"' �� �)"�����

������ �� �������

�"�� ���

�"'��, �%�� ����&�

����!� ��!�

� �! �!�"%%��' ����-',#� &�''�!� ��& ���! &����'�� "! '�� �%"!' #�!�� �!��"�& !"' �"%%�&#"!� '" '�� ���� ���!� (&���

���� ��!�

��� �!� �& �!�" #�'���� *�'� '�� ���� �!� �"�& !"' &#%��� (!��"% �,'�%"(�� '�� �%�� �����

���! ����

�!� "% �"'� "� '�� �"��"*�!� ��'�"!& �, �� �##%"#%��'� '" &"�)� �!(!�)�!-����-��!&�', #%"��� �

� ��!�� '�� ����-',#� &�''�!� "! '�� �%"!' #�!���

� �&� � "%� &(�'���� ���� ',#��

� ��#���� '�� ��(�', ��%'%�����&��

� �� '�� #%"��� �& "��(%%�!� �! ����� �%�� ����& "! �"�"% #�"'& #%�!'�� �! "% �� #%�!'-$(���', "��� '��! (&� �&' #%�!'-$(���', "�� �!&'����

�� ��

�"�� ���

� ����% �"'& "� &#%�,�� �!� �"��'�� �%"(!� '�� #"�!' �' *���� '�� %�$(�%���"' �& #������

����!� ��!�

��� ��%'%����& �%� #"&�'�"!�� '"" ��% �%" '�� �����

���! ���

���� '�� ��%%����-'"- ���� ��&'�!��� ���'���& � ���#'�% ���

��#���� '�� ��(�', ��%'%�����&��

Page 93: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Print Quality 6-17HP DesignJet 430, 450C and 455CA Printers

� ������ � ����� ��� ������

�%� #��"

�-633&% -*/&4� ��&& "-40 � 4&3�4 �6*%&� $)"15&3 ���

� ��������� �*''&3&/5 $0-03 */,4� 13*/5&% 4*%& #9 4*%&� 36/ */50 &"$) 05)&3�

� ��������� �/, "#403#4 */50 5)& 1"1&3� 413&"%*/( #&90/% 5)& %&4*3&% */, %05�

� �������� �/, 413&"%4 "-0/( " '*#&3 03 '*#&34 */ 5)& 1"1&3� $3&"5*/( ":41*%&3 8&#� &''&$5�

�!��$�# �$�#

�3*/5*/( */ '"45 .0%&�

����� �$�#

� �)& */, *4 */$0.1"5*#-& 8*5) 5)& .&%*" 591&�

� �/7*30/.&/5"- $0/%*5*0/4 ."9 "''&$5 5)& .&%*"� ��&.1&3"563& 03)6.*%*59 -&7&-4 "3& 500 )*()��

���$#���"

�/& 03 .03& 0' 5)& '0--08*/( "$5*0/4 ."9 #& "113013*"5& 50 40-7& 5)& 130#-&.�

� �)"/(& 5)& 1-05;26"-*59 .0%&� �-055*/( */ ��"# .0%& 4-084 1-055*/( #65*.1307&4 26"-*59�

� 4& #&55&3 26"-*59 .&%*"�

� �' 906 "3& 1-055*/( 0/ 7&--6. 03 53"/4-6$&/5 .&%*"� 539 64*/(�&8-&55;�"$,"3% .&%*"�

� �&$0..&/%&% &/7*30/.&/5"- $0/%*5*0/4 '03 015*.6. 1-05 26"-*59 "3& */5)& 3"/(& 0' ; � %&(3&&4 �&-4*64 � � ; � %&(3&&4 �")3&/)&*5� 8*5) � ;� � 3&-"5*7& )6.*%*59�

� �&/ 130#-&.� ���� ��)&3."- �63/;�/ �/&3(9� )"4 /05 #&&/ 1&3'03.&%#&$"64& 0' */$033&$5 $"353*%(& $)"/(&� !*5) 5)& 108&3 ��� 01&/ 5)& 501$07&3 "/% 3&4&"5 5)& $"353*%(&�

��� �������

�%� #��"

�/, 4.&"34 0/ 5)& .&%*"� ��&& "-40 � 4&3�4 �6*%&� $)"15&3 ���

�!��$�# �$�#

�)& .&%*" 506$)&4 5)& 13*/5 )&"%4� �)*4 $"/ 0$$63 #&$"64&�

� �)& .&%*";)0-%*/( .&$)"/*4. *4 /05 )0-%*/( 5)& .&%*" $033&$5-9� "/% 5)&.&%*" #6$,-&4�

� �)& $"33*"(&;50;.&%*" %*45"/$& *4 500 4."--� ��%+645.&/5 � $)"15&3 ��

Page 94: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

6-18 Print QualityHP DesignJet 430, 450C and 455CA Printers

�� ������

�������

������ � ��� �� ������ ���� �������� �� �����

�������� �����

��� �� ���� � ��� ����� �������� �� ������� ��� � ���� �������� ��� ����� ��� ��� �������� �� ���� � �� ����� ������

�������

����� ��� ����� ������� ���� ��� ����

Page 95: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-1 HP DesignJet 430, 450C and 455CA Printers

��� � �� �������

Page 96: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-2 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

�.� �$�� �))�#�"!�)

�.� �$�� �))�#�"!�) �(� ���*%(/0(�&�!(�� �$� *�)*�� �))�#�"!�) * �* /%+ ��$%(��( * �/ �(� "!)*�� !$ * � �%""%-!$� *��"�� �.� �$�� �))�#�"!�) �(��,�!"��"� %$"/ %$ � *(���0!$ ��)!) * �(��%(�� /%+ #+)* (�*+($ * � �����*!,��))�#�"!�) �%( �(��!*�

�.� �$�� �))�#�"!�)

�� ��(* �+#��( �*/ �)�(!&*!%$

����0���� � �"��*(%$!�) �%�+"�

��&"���#�$* ��(*)

��(*) ) %-$ !$ * � �(�-!$�) !$ * !) � �&*�( �(� "!)*�� !$ * � �%((�)&%$�!$�&�(* "!)*)� ��*� * � �&&(%&(!�*� $+#��( %$ * � �(�-!$� -!* * � )�#�$+#��( !$ * � &�(*) "!)* �%( !$�%(#�*!%$ %$ * �* &�(*� � � *%*�" '+�$*!*/ �%(��� &�(* %$ * � �(�-!$� !) �!,�$ �) -�"" �) * � &�(* $+#��(�

�% %�*�!$ (�&"���#�$* &�(*)� �%$*��* * � $��(�)* �� �+&&%(* ���!��� �%+#+)* !$�"+�� * � &�(* $+#��( �$� &�(* ��)�(!&*!%$ !$ * � %(��( /%+ )�$���")% !$�"+�� * � �(!$*�( #%��" �$� )�(!�" $+#��(�

Page 97: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-3HP DesignJet 430, 450C and 455CA Printers

#)�%&������,

�����,��%�"'�%��($$#%'

�����,�*�&��#'#%&������,��

�%%������&&�!� +������,��

�����,��# ������&&�!� +

�����,��

�%#"',��"� ��$�''##"��� ��'%#"��&��#�( �

�%�!�%��&&�!� +��

������,����%)�����'�'�#" ��� ����)�%�%�)�������"�&!&

������,�

��"���%!��&&�!� +������,��

�� �� � � ������ ���

Page 98: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-4 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

������ � � ��� �� �����

�$%$-$*"$+*

�- 2'*&

�� � -/ �0)!$- �0 */'/4 �$."-',/'+*

� ���6���� � � -#2 -$ �'/ ��*"(0#$. �"-$2�-'1$-.�

� ���6��� � � �++/ �..$)!(4

� ���6���� � �$&. �..$)!(4

���6��� � �- 4 �..$)!(4

�����6����� � �6 3'. �- "$ �����6.'5$�

���6����� � �6 3'. �- "$ �����6.'5$�

� �����6���� � �*# � , �����6.'5$�

���6���� � �*# � , �����6.'5$�

� �����6����� � � � - �..$)!(4 �����6.'5$�

���6���� � � � - �..$)!(4 �����6.'5$�

���6����� � � ,$- �++, �..$)!(4

Page 99: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-5HP DesignJet 430, 450C and 455CA Printers

��

��

��

������ � � ��� �� �����

Page 100: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-6 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

����� � � ������� ���� ���

� ! + (� )(

�+�/$("

�� ��+- �.'� + �.�(-$-1 � ,�+$*-$)(

� � � 3���� � �)&&! � ��+�/�+ �$-

� � � � � �)&&! � �,, '�&1 �����3,$2 ���(�&.� , �*$(�& � ��+�/�+ %$-�(� �.�,�

� ��� � �)&&! � �,, '�&1 �����3,$2 ���(�&.� , �*$(�& � ��+�/�+ %$-�(� �.�,�

� � 3���� � �*$(�& �����3,$2 �

� ��3���� � �*$(�& �����3,$2 �

� � 3��� � �*$(�& �.�

� �3����� � �*$(�& �.� �$- �!)+ �#$( , �*$(�& , )(&1�

� � �3���� � �0- (,$)(, �$- �,, '�&1

Page 101: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-7HP DesignJet 430, 450C and 455CA Printers

��

����� � � ������� ���� ���

Page 102: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-8 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

����� � ����

�%&%0%-#%.-

�0!5)-'

�� �!02 �3,"%0 �3!-2)27 �%1#0)/2).-

� � �9���� � �./ �.4%0 �����91)8%�

� �9���� � �./ �.4%0 �����91)8%�

� � �9���� � �%&2 �-$ �.4%0

� �9��� � �5)2#( �322.-

� �9���� � �)'(2 �-$ �.4%0

� � �9���� � �!#* �.4%0 �����91)8%�

� �9���� � �!#* �.4%0 �����91)8%�

� ����9��� � �#0%5 �.06 �

����9��� � � �!"+% �)/ �11%,"+7

� � �9����� � ���� �.4%0 �+!2%

� �%% �!'% 9�� � ��� ����

�� � �9����� � ��� ���� � %01).- �������

Page 103: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-9HP DesignJet 430, 450C and 455CA Printers

��

��

����� � ����

Page 104: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-10 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

�� ��� � � ����� ����� �������� �� ��������� ������

� ! * '� ('

�*�.$'"

�� ��*, �-&� * �-�',$,/ � +�*$),$('

� �����0�� � � �*(',0��' % �++ &�%/

� ��0���� � ��* .

� 0 � ��+# * ��'�%-� � .$,# �, & ��

� �����0���� � �)$,,((' �++ &�%/

��0���� � ��* .

0 � ��+# * ��'�%-� � .$,# �, & �

� �����0���� � �% �,*('$�+ �(�-%

Page 105: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-11HP DesignJet 430, 450C and 455CA Printers

���

�� ��� � � ����� ����� �������� �� ��������� ������

Page 106: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-12 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

�� ��� � � � �� � ��� ������ �� ������ �����

�%&%0%-#%.-

�0!4)-'

�� �!02 �3,"%0 �3!-2)26 �%1#0)/2).-

� ���8��� � �32

���8��� � !1(%0

� � �8����� � �-#.$%0 �20)/ �����81)7%�

� �8����� � �-#.$%0 �20)/ �����81)7%�

����8����� � �-#.$%0 �/0)-'

����8� �� � �#0%4 ��� 5 � �!- �.05 12+

� � �8��� � �)'(2 �0!#*%2

� ����8���� � �)'(2 �20!/ �#+)/�

� �8����� � �!00)!'%8�.2.0 �11%,"+6

� ����8�� � �#0%4 � 5 � �!#( ���

� ����8��� �#0%4

�� 8 !1(%0 ��-#+3$%$ 4)2( �2%, ��

�� � �8���� � �%$)!8�.2.0 �11%,"+6 ��-#+3$%1�%+)#!+ �%!0�

�� ����8����� � �%$)!8�.2.0 �!"+%

8 ���8���� �� �3"0)#!-2

8 ����8����� �� �3"0)#!-2 �0%!1%

Page 107: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-13HP DesignJet 430, 450C and 455CA Printers

��

��

�� � � � �� � ��� ������ �� ������ �����

Page 108: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-14 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

� ���� � � �� ��� �������� �� ���� � ���� �� ��������

�$%$/$,"$-,

�/ 4(,&

�� � /1 �2+!$/ �2 ,1(16 �$0"/(.1(-,

� ����8� � �"/$4 � 5 � � . ��

� ����8���� � �$/3("$ �1 1(-, �00$+!*6

� �8���� � �/(+$/ �00$+!*6

���8� � � �"/$4 �8�� � � �* 0 ���

� ���8��� � � 0'$/

� � �8����� � �,"-#$/ �1/(. �����80(7$�

� �8����� � �,"-#$/ �1/(. �����80(7$�

����8� �� � �"/$4 ��� 5 � � , �-/5 01*

� ����8��� � �$%1 �/ ")$1

� ����8����� � �$%1 �1/ . �"*(.�

8 � �8��� � �/(+$/ �-3$/ ��$0(&,�$1 ��

Page 109: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-15HP DesignJet 430, 450C and 455CA Printers

��

� ���� � � �� ��� �������� �� ���� � ���� �� ��������

Page 110: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-16 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

����� � � ������� ����� � �� ���� ��� ���

�!"!*!'�!('

�*�/$'#

�� ��*, �-&�!* �-�',$,0 �!+�*$),$('

� ����2��� � ��**$�#! �()

� �����2��� � � �*�$%$'#2���%! �!,�% �%$)

� �����2���� � �*�$%$'# ���%! �++!&�%0�����2+$1!�

�����2���� � �*�$%$'# ���%! �++!&�%0�����2+$1!�

����2����� � ��**$�#! �++!&�%0

���2��� � � ��**$�#! �!%, �����2+$1!�

����2��� � � ��**$�#! �!%, �����2+$1!�

� ����2���� � �*�$%$'# ���%! �-$ ! �����2+$1!�

����2���� � �*�$%$'# ���%! �-$ ! �����2+$1!�

� ���2���� �*�$%$'# ���%! �%�+,$� �%$)

����2���� � �-,,!* �++!&�%0

2 ����2���� � ��*,*$ #! �(.!* ��!+$#'�!, ���

Page 111: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-17HP DesignJet 430, 450C and 455CA Printers

��

� �

����� � � ������� ����� � �� ���� ��� ���

Page 112: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-18 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

� ��� � � �� � �� ���� � ����� ���

�%&%/%,#%-,

�/!4),'

�� �!/1 �2+"%/ �2!,1)16 �%0#/).1)-,

� �����7����� � �2**%6 �00%+"*6

� �����7���� � �,'!'),' �%3%/

� ��7��� � �#/%4 � 5 �� �!. ���

7 � !0(%/ ��,#*2$%$ 4)1( �1%+ ��

��7���� � �#/%4 �� 5 �!. ���

� 7 � !0(%/ ��,#*2$%$ 4)1( �1%+ �

� ���7 ���� � �%!/7�2..-/1 �./),'

����7���� � �,'!'),'7�%3%/ �2..-/1

� ���7���� � �#/%4 �7� ���� �*!01 ��

�� �����7���� � �!+ �%!/

�� ���7�� � �#/%4

�� ���7���� � !0(%/

�� �����7���� � �,'!'),' �%!/

� �����7���� � �!)*7�)&1 �!+

� �����7����� � �!)* �!"*%

�� �����7 ���� � �!"*% �./),'

�� �����7���� � �%!/ �2..-/1

� �� �7����� � �(-2*$%/ �#/%4

�� �����7���� � �3%/$/)3% �%!/

�� ��7�� � � �),' �%1 ��� ��

�� �����7����� � �*21#( �00%+"*6

�� ����7���� � �)$%.*!1% �20(),'

Page 113: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-19HP DesignJet 430, 450C and 455CA Printers

��

��

�����

��

��

������

��

��

� ��� � � �� � �� ���� � ����� ���

Page 114: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-20 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

� ��� �� � � ����� �������

�$%$.$+"$,+

�. 3(+&

�� � .0 �1*!$. �1 +0(05 �$/".(-0(,+

� ���7���� � �".$3 �� 4 �� � "' ���

� ����7��� � �(+"' .* �$2$.

� ��7�� � � �".$3

7 � � /'$. ��+")1#$# 3(0' �0$* ��

����7���� � �(+"' .* �$+/,. �//$*!)5

� ����7 ���� � �(+"' .* �$"' +(" ) �-.(+&

� ����7����� � �(&'0 � * �,1.+ ) �//$*!)5

�����7���� � �$%0 � * �,1.+ ) �//$*!)5

� �� �7���� � �(+"' .* � . � * �����7/(6$�

�����7����� � �(+"' .* � . � * �����7/(6$�

�� �����7�� � �(+"' .* � . �1/'(+&�����7/(6$�

�����7�� � � �(+"' .* � . �1/'(+&�����7/(6$�

�� �����7 ��� �(+"' .* � . �-.(+& �����7/(6$�

�����7 ��� � �(+"' .* � . �-.(+& �����7/(6$�

�� ����7��� � �(+"' .* �//$*!)5 �����7/(6$�

����7��� � � �(+"' .* �//$*!)5 �����7/(6$�

Page 115: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-21HP DesignJet 430, 450C and 455CA Printers

��

��

��

��

� ��� �� � � ����� �������

Page 116: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-22 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

������ �� � ����� ������ ����� ������� ���� ��� �������� ����� ��

�#$#-#*!#+*

�-�2'*%

�� ��-/ �0) #- �0�*/'/3 �#.!-',/'+*

� � �5���� � ��'( �..#) (3 �����5.'4#�

� �5���� � ��'( �..#) (3 �����5.'4#�

� ������ � �!-#2 �+*% �+%,+'*/

������ �� � �!-#2

����5����� � �('%*)#*/ �!-#2

� � �5����� � �1#-"-'1# �..#) (3 �����5.'4#�

� �5����� � �1#-"-'1# �..#) (3 �����5.'4#�

� ����5���� � �!-#2 ��#"'� �0//+* �..3�

� �5���� � �#"'� �0//+* �..#) (3

� ����5���� � �!-#2 ��#"'� �#$(#!/+-�

� � �5���� � �#"'� �#$(#!/+-

�� ����5���� � �-'1#- �+((#- �..3 �����5.'4#�

� ��5���� � �-'1#- �+((#- �..3 �����5.'4#�

�� � �5��� � �'"# �-') �#$/

�� ��� 5� �� � �!-#2

� � �5���� � �'"# �-') �'%&/

� ����5����� � �('%*)#*/ �!-#2

�� � �5���� � �*/-3 �(�/#* �..3 �����5.'4#�

� �5���� � �*/-3 �(�/#* �..3 �����5.'4#�

�� ����5� � �!-#2

Page 117: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-23HP DesignJet 430, 450C and 455CA Printers

��

��

��

���� �

��

��� ��

��

��

��

��

������ �� � ����� ������ ����� ������� ���� ��� �������� ����� ��

Page 118: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-24 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

���� ������

� ! + (� )(

�+�0$("

�� ��+- �.'� + �.�(-$-1 � ,�+$*-$)(

� �2��� � � +$�& ��� & ��$"#- �(� �)/ +�

� �����2����� � ��++$�" ��� &�� ,$"(� -, ��� �(� �����

�����2���� � ��++$�" ��� & �� ,$"(� -, ����

� ��� �2���� � �.$�% � ! + (� �.$� �)&� +

� �����2����� � ��' *&�- �� ,$"(� -, ����

����2����� � ��' *&�- �� ,$"(� -, ����

����2����� � ��' *&�- �� ,$"(� -, ����

����2����� � ��+-+$�" �(, +-$)( ��� &�� !- �(� �)/ +�

Page 119: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-25HP DesignJet 430, 450C and 455CA Printers

� �� ���� �� ����� � � � �� ���� �����

�� ��)+ �,%� ) � *�)#(+#'&

���0����� �&!$#*" ��&,�$ �,&�$

���0����� �') �& ��&,�$ �,&�$

���0����� ��#.�& * ��&,�$ �,&�$

���0����� � )%�& ��&,�$ �,&�$

���0����� �) &�" ��&,�$ �,&�$

���0����� �(�&#*" ��&,�$ �,&�$

���0���� �+�$#�& ��&,�$ �,&�$

���0���� ��(�& * ��&,�$ �,&�$

���0����� �')+,!, * ��&,�$ �,&�$

���0����� "#& * ��&,�$ �,&�$

����� �� � �� ����

�� ��)+ �,%� ) � *�)#(+#'&

���0����� �&!$#*" �)'&+ ��& $ �- )$�/

���0����� �') �& �)'&+ ��& $ �- )$�/

���0����� ��#.�& * �)'&+ ��& $ �- )$�/

���0����� � )%�& �)'&+ ��& $ �- )$�/

���0����� �) &�" �)'&+ ��& $ �- )$�/

���0����� �(�&#*" �)'&+ ��& $ �- )$�/

���0���� �+�$#�& �)'&+ ��& $ �- )$�/

���0���� ��(�& * �)'&+ ��& $ �- )$�/

���0����� �')+,!, * �)'&+ ��& $ �- )$�/

���0����� "#& * �)'&+ ��& $ �- )$�/

Page 120: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

7-26 Parts and DiagramsHP DesignJet 430, 450C and 455CA Printers

������� �� �������������

�� �!02 �3,"%0 �%1#0)/2).-

� �6����� �.&24!0% �//+)#!2).- �.2%1

����6�� �##%11.0)%1 �3)$%

����6� �%$)! �4!2#( �..*

����6� ��6���� !-$ ��� �0.'0!,,%0�1 �%&%0%-#%�3)$% ��-'+)1(�

����6� �(% /0.$3#2 �.,/!0)1.- �3)$% &.0 ��6����!-$ �� ��� �%0)/(%0!+1 ��-'+)1(�

����6�� ��� �%#(-)#!+ �%&%0%-#% �!-3!+ ��-'+)1(�

������ ������ ��� �����

�� �!02 �3,"%0 �%1#0)/2).-

���� �� ��� ����

��� ��� ��� ����

���� ���� ��� ����

�� �� ��� ��� ����

���� ��� � ������� �� � ������� ����� � ��� ����

����������

�� �!02 �3,"%0 �%1#0)/2).-

����� �+!#*

���� �5!-

���� �!'%-2!

��� %++.4

Page 121: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Parts and Diagrams 7-27HP DesignJet 430, 450C and 455CA Printers

������ ��� �� ��

�� �� " #��� �!� ��"���

������ ��"�� ��" � ��#! "�� ��"

������ ��"�� ��" � ��#! � "�� ��"

������ ��"�� ��" � ��#! � ����� ����

Parallel (Bi-Tronics/Centronics) Interface Cables

Computer HP PartNumber

Cable length Connector type atcomputer end of cable

HP 9000 workstations, series 300, 400, 700.

IBM AT, IBM PS/2, IBM PC/XT andcompatible computers.

C2950A

C2951A

2.0 m (6.9 ft)

3.0 m (9.8 ft)

25-pin male

25-pin male

Serial (RS-232-C) Interface Cables

Computer HP PartNumber

Cable length Connector type atcomputer end of cable

HP Vectra or HP 24541A/B serial interfacecard (9-pin connector).

HP 9000 workstations using 9-pin connectors.

IBM AT and compatible computers using 9-pinserial connectors.

24542G 3.0 m (9.8 ft) 9-pin female

HP Vectra PC with HP 24541A/B dual serialinterface card using the 25-pin connector.

HP Apollo workstation using an SPE(Serial/Parallel Expansion) option andsupplied adapter cable.

DEC VAX.

Sun workstation.

17255M 1.2 m (3.9 ft) 25-pin male

IBM PC, PC/XT, IBM PS/2 and compatiblecomputers

C2913A 1.2 m (3.9 ft) 25-pin female

DEC VAX using DEC BC22D, BC03M, orequivalent

17355M 3.0 m (9.8 ft)

Apple Macintosh Plus, SE, II Series, Classic,LC family, Quadra family, PowerBook,PowerMac

17302A 1.5 m (4.9 ft) 8-pin male mini-DIN

Apple Macintosh 128K and 512K 92219M 1.5 m (4.9 ft) 9-pin male

Extension cable 31391A 5 m (16.4 ft) 25-pin female

Page 122: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 123: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-1 HP DesignJet 430, 450C and 455CA Printers

����� ��� �� �������

Page 124: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-2 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��� � � � � �����*0.+!1 0&+* 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�"�//")�(3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

��#"03 �." �10&+*/ 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�(" 0.+/0�0& �&/ %�.$" ����� �." �10&+*/ 4� � � � � � � � � � � � � � � � � � � � �

�"-1&."! �++(/ 4� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�*/0�((&*$ � ��� +. ��� ���� 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" ��&( �//")�(3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �+, �+2". 4 � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �+((#""! �//")�(3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �"#0 �*!4�+2". 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �&$%0 �*!4�+2". 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.+*04��*"( �//")�(3 4��� � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �(" 0.+*& / �+!1(" 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �* +!". �0.&, 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �&$%0 �.� '"0 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" ��..&�$" �+0+. 4� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �,&00++* 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �100". �//")�(3 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.&2"4�+((". �"�. 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �"!&� �+0+. �//")�(3 4��� � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �&* %4�.) �" %�*&/) 4�� � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.&)". �//")�(3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �".2& " �0�0&+* 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" ��&(4�&#0 �" %�*&/) 4� � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �*$�$&*$4�"2". �1,,+.0 4��� � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.�&(&*$ ���(" 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.�&(&*$4���(" �1&!" 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" ��..&�$" �//")�(3 4��� � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.&2" �"(0 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.&2"4�"(0 �1(("3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �.&2" �+((". 4� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�"&*/0�((&*$ 0%" �.&2" �+((". 4� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �&* %4�.) �&#0 �" %�*&/) 4�� � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �2".!.&2" �//")�(3 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � �

�")+2&*$ 0%" �*0.3 �(�0"* 4�� � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � � �

Page 125: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-3HP DesignJet 430, 450C and 455CA Printers

!'%"�(�'�"!

���& ���#'�% �& � &'�# �, &'�# �(��� '" '�� %� ")�� �!� �!&'����'�"! "� '�� ��,�" #"!�!'& �! '�� #%�!'�%� �"( �, ��!� �' (&��(� '" '��� "�� '�� &'�#& �& '��,�%� #�%�"% ��� �&� '�� ���(&'%�'�"! �' '�� �!� "� ���� #%"���(%� '" ���!'��,'�� #�%'& %���%%�� '" �! '�� '�+'�

��� #%"���(%�& �##��% �! "%��% "� %� ")��� �" '�� *�"�� ����!� ��! ��&'%�##�� �"*! �, &'�%'�!� �' '�� ����!!�!� "� '��& ���#'�% �!� *"%��!�'�%"(�� '�� &(�&�$(�!' #%"���(%�&�

������ !���� ��� ���� �� � ����"� ��� ��� ��� � ��# �������� ���#�$� ���� �!�� �� $�! ��"� ��������� �� ����"�� ���"��� �� ���� ��� �� �� �� �� �� ������ $�! #��� �� ���� � ������� ���������� �

���&&� ��,

�"&' "� '�� #%"���(%�& �! '��& ���#'�% ��&�%��� �"* '" ����"� #�%'& �%" '�� �%�!'�%� �!��&& "'��%*�&� &#�������� ����� ��� '�� #�%'& �! '�� %�)�%&�"%��% "� %� ")�!� '�� �

����', �%���('�"!&

�����', &, �"�& � ����'��, ��'�% '�� '���� "� �"!'�!'&��

��)��* ����� �!� ���� � &, �"�& �!� �!&'%(�'�"!& ���"%� ,"(&�%)��� '�� �%�!'�%&� �"��"* '��&� *�%!�!�& �!� ��('�"!& �"% ,"(% #%"'��'�"!�!� '" �)"�� �� ���!� '�� �%�!'�%�

����!� ����� ��%��� ������� � ��� � �� ���!�$��$ ���!� �� $�! �� �� ��� �� �����#��������! �����

��!�� �� �� �� ��#�� �! �� ������� ��� ���� �� �"� ��� � ����!��� ��������

#� �� �� ���� �� ���� ��� ��������� � ���� ����#�� ��!��� ����� � ���������� ��$ ���� �������

���"�� #� �� �� � ��� ���!��� ���� �!����� �� ����� ����� �������� � �� ����!� �� �� ���!���������� �� �� ���!���

�������������

Page 126: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-4 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�!��(&$'(�(�� ��'���&�� ����� �&���)(�$#'

�$ %&�*�#( ��"��� ($ (�� �&�#(�& ��&�)�(' �&$" ����-*$!(��� �!��(&$'(�(����'���&�� ������

�� �$ #$( +��& �!$(��#� (��( �' ')����( ($ '(�(�� �)�!�-)%�

�� �$ #$( ��#�!� �#(��&�(�� ��&�)�(' ���'� �# ��&%�(�� �&��'�

�� �$ #$( &�"$*� �# �� $& � %&�#(�� ��&�)�( �''�"�!, ��� � �&$" �('�$#�)�(�*� �$�" %�� $& �$#�)�(�*� %�� ���#� )#(�! ,$) �&� &���, ($ �#'(�!!�(�

� �&$)#� ���&(�� ,$)& �$�, +��!� ��'�''�"�!�#� �#� +$& �#� $# (���&�#(�&�

� �(�& &�"$*�#� � �$*�& �&$" (�� �&�#(�&� �((��� �# ��&(��#� ��&$)#�� !�����(+��# (�� �� �$""$# �#� ��&(� �&$)#�� �$)�� �!! ($$!' ($ ��&(��&$)#� ($ &�"$*� '(�(�� ���&��' ���$&� )'�#� (��" $# (�� �&�#(�&�

�� �(�& &�"$*�#� �#, �� �&$" (�� �&�#(�&� %!��� �( $# � �$#�)�(�*� �$�"%�� $& �#($ �(' �$#�)�(�*� %�� ���#� ($ %&�*�#( ��� ��"��� ($ �#, ��' $#(�� �� �

Page 127: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-5HP DesignJet 430, 450C and 455CA Printers

�������� ����

�� ��������� ����� ��� �������� �� ������ ��� ������� ��� ��������

T8 T9 T10 T20T15 T25

3/16inch

5.5mm

and

���� �� � ��������� ���� ��� ���� �������� �������

��!������ �� � ����������

����� ����"����� � ����������

��� ������ ���� ��� ���� ���� ���� �������

Page 128: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-6 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�$()�"" $� � � � %' ��� ����

� �� ��� �������� ��� ������� ��� �!��� �����"� � �� ����������� �� ���� ��� ���� �� �������� ��� �������� ���� ��� �����

�� ��!� (*'� )��) )�� �' $)�' ( (, )���� ��� �$� )��) $� )��' )�� &%,�'�%'� $%' �$ $)�'���� ���"� ( �%$$��)���

�� �$(�'�, )�� �%+�' &"�)� �$� )�� ���"� �" & �) )�� ���! %� )�� �' $)�'� �$�'�#%+� )�

Torx-10 or Flat

������ �� ���� ���� ������ ��� �� ����� ��� ����� ���� � ���� ��� �� �� ��� ���� ������ �� ��� �������� �� ����� ��� ��������� ������ �� ��� ������� ���� ���� �� � ���������� ���������������� ���� ���� �� � ���� ��� ��� ����

� ��!� )�� ���� %*) %� )( ���� �%"� $� )�� ���� %$"- �- )�� ����(�

� � )� )�� �����( (#�"" $%)�� %$ )�� "��) �$� )�� #�)�"" � ���� �,�- �'%#-%*� "%�� )�� ���� $)% )�� ("%)�

� $��'�() )% -%* �� � ������

� �*')��() �'%# -%* ���� ������

�� �� ����� ����� ���� ��� ��� �� �� ������ ��� ���� ��������" ���� �� ��� ����� �� ������ ���������" ���� ������

1

2

�����

�� ��&"��� )�� �%+�' &"�)�� )�� ���"� �" & ���"� �- )�� "��) (�'�,� �$� )�� (�'�,(�

Page 129: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-7HP DesignJet 430, 450C and 455CA Printers

��� &��� $�� ���� ##����(

������

�� �!�� $�� � ! � &�"�

�� ���%���( � &� $�� ��""���� �##����( $ $�� ���$ #��� � $�� �"��$�"�

�� �%#� �� � $�� !��#$�� ���# � $�� ���� �##����( $ '�"�# $�� ���$�" � $���"��$�" $ "����#� �$ �" � $�� � �� �� $�� #���!��$�� ��� ���$ $�� ���� %$ �$�� �"��$�"�

� "�� �� � ������ �"�� %��"� ���!"�� �� " ��!"����� �� "�� ���" ����!��� �� "�� � �$� ����� � � �$��"! '�# � �� ���$��� "�� ��� !!����'�#!� "�� �����(&�! ��!" ���"���! � ���� �(��� "� "# � "�� � �$� ����� "�� ��!�"��� %�� � "�� ��� !!����' ��� �� ���$�� ��!��'�

� ��� &� $�� #$�" '���� �##������# ��$�� �� �( !%#���� $ ��$��" $��"�$������ ���!# ��� !%����� $��� ��

����������

�� �#$��� $�� ���� �##����( �( ��#$������ $�� ���$ #��� ��"#$� $��� ��#$��� $������ �##����( ��$ � ��# �� $�� ���$ ��� "���$ ���� #��� ���##�#�

�� �� #� $�� � ! � &�"�

�� ��"� "� ���� ��"&��� ��#$ � !��� )���

Page 130: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-8 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

����!��� ��� �� ��!��

�� ��� ��� ��� ��!���

�� �� ��� �����#���� ���� �� ��� ��!�� �������" ����� �� ���� ��� �������������� ��� �����

�� ����� ��� ��!�� �� ��� ����� �� ���� ��� ����� ������ ��� ����

����������� ����� �� ����� � � ���� ��� �� �� ������

�� ����!� ��� ��!�� ���� ��� �������

Page 131: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-9HP DesignJet 430, 450C and 455CA Printers

������� ��� ������� ������!

���� � ����� ��

������

�� ����� ��� ���� ���� �� ���� ��� ���� ���� �������� ��� ���� �������������! ���� �� �� ��� ��������

�� ����� ��� ���� ������� ������! ���� �� ��� ��� ��� ������ �� ������� ��������

�� ����� ��� ���� ���� �� ���� ��� ���� ���� �������� ��� ���� �������������! ���� �� �� ��� ��������

�� ����� ��� ���� ������� ������! ���� �� ��� ��� ��� ������ �� ���� �����������

� ��� �� ����� �������

Page 132: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-10 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

����$��� "�� ���" ��&��$�

�����

�� ����$� "�� "�� ��$� � ���� �&��

�� ����$� "�� ���" �������� �!!����% � ���� �&�

�� �����!� "�� "� �� ����! �" "�� ��""�� �� "�� ���&��$� �� !" "�� !��� �����"��� "�� � ��" ��� ���� ����!�

���� �� �� ������

��

�� �#�� "�� ���&��$� #�� ��� ���$� �" � �� "�� � ��"� �

����������� ���� ��� ��� �� ��������� ��� ���! ����� �� ��� ����������� ���� ��� �� �� �� ������ ����� ��� ��� �� �� � ������ ������ ������� � �� ���! ����� ���� � ���� �� ��� ������� ���� �� ��� ������� ���������� ����� ��� ��� �� ��� ��������

���� ���� ���� ��� ������ ������� �� ��������� ������� ���������������� ��� ���! �����

Page 133: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-11HP DesignJet 430, 450C and 455CA Printers

��#%+ $� )�� � ��) �$�.�%+�'

���� �� ���� ��

�����

�� ��#%+� )�� )%& �%+�' � &��� �.��

�� ��#%+� )�� � ��) �%""���� �((�#�"- � &��� �.��

� �*"" )�� �' $)�' %$�%�� (, )�� � )�# �� %*) %� )�� ' ��) �$�.�%+�' � )�# ���

� ��"��(� )�� )�'�� �" &( �) )�� �%))%# %� )�� ' ��) �$�.�%+�'� � '() )�� ( ���" &� )��$ )�� �'%$) �$� ���! �" &(�

����� �� �� ����

�� �*"" )�� �$�.�%+�' *&� )�! $� ��'� $%) )% ��#��� )�� �'%$).&�$�" ���"�(�

�� �$( �� )�� �$�.�%+�'� &'�(( )�� ),% )��( %� )�� �'%$).&�$�" )%,�'�( ����%)��'� �$� '�#%+� )�� �'%$).&�$�" �((�#�"- �'%# )�� �$�.�%+�'�

� �% �� ��"� )% ��( "- *(� )�� �'%$).&�$�"� ,��$ )�� ' ��) �$�.�%+�' ��( ���$'�#%+��� (" �� )�� �'%$).&�$�" �((�#�"- %$)% )�� #�)�" ��(� %� )�� �' $)�'�( (�%,$�

�� ��� �� � �� ���������

Page 134: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-12 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��%'-"& +!� �)'&+0��&�$ �**�%�$/

��!#)�

�� ��%'-� +!� $��+0�&� �'-�) � (� � 0���

� �!�& )�%'-"& +!� �)'&+ (�&�$� $"�+ ��,+ �' &'+ )�%'-�� +!� �)'.& ')�$��# �$"( "& +!� �� �'&&��+') ���')� )�%'-"& +!� �)'&+ (�&�$ ���� ���$���', �'&�+ &��� +' ,*� �&/ �')�� �+ �$$�

� -�)/ ��)��,$ .!�& �"*�'&&��+"& +!� �)'&+ (�&�$ �'&&��+') �)'% +!� ��"&���� �� +!� ���$� "* (,$$�� +'' !�)� .!�& )�%'-"& +!� �)'&+ (�&�$ "+ ��&��%� � +!� �� �)'&+ (�&�$ �'&&��+') "& +!� ��"& ��� .!"�! %��&* +!�+ +!��'%($�+� �$��+)'&"�* %'�,$� !�* +' �� )�($����� �� /', �'$$'. +!� "&*+),�+"'&*��'-�� /', ."$$ &'+ ��%� � +!� �� �'&&��+')�

��!�!��% '��' '�� � �$ !(&' "#' �� %�!#)�� �#!$ �'� +� �� %�!#)��

�#!$ �'� +� '�� � �$ *� �� ��&'%#+���

�"&'� �'�#"

�� �!�& "&*+�$$"& +!� �)'&+ (�&�$� (,$$ +!� �)'.& ') �$��# �$"( �&� "&*�)++!� ���$� "&+' +!� �� �'&&��+')� �&�� +!� ���$� "* "&*"�� +!� �'&&��+')�(,*! +!� �)'.& ') �$��# �$"( �'.& +' !'$� +!� ���$� "& ($���� �!��'&�,�+"-� (�)+ �%�+�$$"� (�)+� '� +!� ���$� %,*+ ���� +!� ��"& ����

�������� ��� �� �� �� ��� � ������

�� ����� �� ����� �� � ��� � �� ��

����� �� ��������� �� ��� ���� �� ��

������� �� ���� ��� � ��������� ���� ��

� ��#� *,)� +!�+ +!� �)'&+ ��&�$ ���$� "* ()'(�)$/ )',+�� �/ +!� �$"(* "&*"��+!� �" !+0�&� �'-�) �&� )�%�"&* ,&��)&��+! +!� �("++''& �+ �$$ +"%�*� ��+!� ���$� "* &'+ )',+�� �'))��+$/� +!� �,++�) �**�%�$/ ��& +)�( +!� ���$��&� ��%� � "+�

Page 135: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-13HP DesignJet 430, 450C and 455CA Printers

� ')/$(" -# �& �-+)($�, �)�.&

� � � �� ����� � � *�" ��

������� � � �������

�# �+$(- + !$+'0�+ $, �)(-�$( � $-# + )( � !&�,# ��� ���� �- -# ���%)! -# �+$(- + )+ )( � '�,% � ��� $(,$� -# & �-+)($�, ')�.& � �# !$+'0�+ 3+ /$,$)( & / &� !)+ 1�'*& ������� $, *+$(- � �2 -# �+$(- + )( -# , -.* ,# - �(� )( -# , +/$� �)(!$".+�-$)( *&)-� �# + /$,$)( & / & $, �&,)*+$(- � )( � &�� & )( �(2 !&�,# ��� ����� �) ()- )* ( -# & �-+)($�,')�.& �

������� � �# ( + *&��$(" -# & �-+)($�, ')�.& � �&0�2, + ' '� + -)�# �% -# !$+'0�+ + /$,$)( & / & )! -# �� & �-+)($�,')�.& � �# + /$,$)( & / & 0$&& � *+$(- � )( -# -)* ,.+!�� )!-# ')�.& � �&,)� �# �% -# !$+'0�+ + /$,$)( & / & )! -# ������� $(,-�&& � $( -# ��� & �-+)($�, ')�.& � �$-# -#$,$(!)+'�-$)( 2). '.,- �) -# !)&&)0$("

�� �! -# !$+'0�+ + /$,$)( & / & )! -# ��� ���� $( -# )&� & �-+)($�, ')�.& $, ����� -#�( -# !$+'0�+ + /$,$)( & / & )!-# ( 0 & �-+)($�, ')�.& � -# ( 2). ���� �� $(,-�&& -# ��� ���� $(-) -# ')�.& �

�� �! -# !$+'0�+ + /$,$)( & / & )! -# ��� ���� $( -# )&� & �-+)($�, ')�.& $, ��� -#�( -# !$+'0�+ + /$,$)( & / &)! -# ( 0 & �-+)($�, ')�.& � -# ( 2). ���� $(,-�&& -# ������� $(-) -# ')�.& �

�1�'*& � �# ��� ���� !$+'0�+ + /$,$)( & / & $, �������(� -# !$+'0�+ + /$,$)( & / & )! -# & �-+)($�, ')�.& $,������� �). 0).&� ., -# & �-+)($�, ')�.& ����� -# ��� ���� $(,-�&& ��

�1�'*& � �# ��� ���� !$+'0�+ + /$,$)( & / & $, ��������(� -# !$+'0�+ + /$,$)( & / & )! -# & �-+)($�, ')�.& $,������� �). 0).&� ., -# & �-+)($�, ')�.& �� -# ������� $(,-�&& ��

�������

�� � �������� ����� �� �� ���� ��� � ���� ��� �� ��� � � ���� � ��� �� �� �� ������ ����� �� ��� � � �� �

�� � ')/ -# +$"#- (�3�)/ + � *�" �3���

�� �$,�)(( �- -# !+)(-3*�( & �,, '�&2 !+)' -# '�$( ����

� �(,�+ 0 -# �)/ + *&�- �- -# ���% )! -# �+$(- +� �(� + ')/ $-�

� � ')/ )( ,�+ 0 �$- ' �� �(� 0�,# + �$- ' �� !+)' -# ���% �)/ +�

Page 136: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-14 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�� ��$&,� &%� )�(�- �!*�$ � �%� -�) �( �!*�$ � �(&$ * � �#&&( &� * ��#��*(&%!�) $&�+#� �!*�$ ���

�� �%)�(* � �#�*/ ��� )�(�-�(!,�( !% *& * � )#&* �* * � ���" &� * � �(!%*�( *&+%#�*� * � �#��*(&%!�) $&�+#� �(&$ * � ���" �&,�(�

� �* * � ���" &� * � �(!%*�(� �%)+(� * �* * � *-& )$�## -!(� �#�$') &� * �'�(�##�# '&(* �(� '&)!*!&%�� �#+) ���!%)* * � �#��*(&%!�) $&�+#�

�� �+) * � �#��*(&%!�) $&�+#� *&-�(�) * � �(&%* &� * � �(!%*�(�

�� �+## * � �#��*(&%!�) $&�+#� *& * � (!� * *& ��)!#. ����)) * � �&%%��*&()�

��� �!)�&%%��* �## ���#�) �(&$ * � ,!)!�#� '�(* &� * � $�!% ����

������� ���� �� ��� ������ �� ��� ����� � ���������� �� ������ ���� ������� ��� ���������� ��� ��� ������

��� �+## * � �#��*(&%!�) $&�+#� �+(* �( *& * � (!� * �%� &+* &� * � �(!%*�(�

��� �� .&+ �(� � �%�!%� * � �#��*(&%!�) $&�+#� �&( � %�- &%�� (�$&,� * � ������� �!� !%)*�##��� �(&$ * � &#� $&�+#� �%� !%)*�## !* !%*& * � %�- &%������( *& '��� �/� ���&(� !%)*�##!%� * � ��� ���� �(&$ * � &#� $&�+#�!%*& * � %�- $&�+#��

��

���� �� ������ ��� �����

Page 137: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-15HP DesignJet 430, 450C and 455CA Printers

� ')/$(" -# �(�)� + �-+$*

���� � ����� � � *�" ���

������

�� �)/ -# ��+-+$�" ��++$�" -) -# & !-� )/ + -# , +/$� ,-�-$)(�

�� � ')/ -# +$"#- (�2�)/ + � *�" �2���

� � ')/ -# & !- (�2�)/ + � *�" �2���

� �$,�)(( �- -# -+�$&$(" ���& !+)' -# '�$( ��� �(� !+)' -# ".$� , )(-# +$"#- �+��% -� �)&� -# -+�$&$(" ���& .*0�+�, �(� ,-)+ $- )( -# -+�$&$("2���& ".$� �

�� �( -# +$"#-2#�(� ,$� � + ')/ -# -0) (.-, �$- ' �� -#�- , �.+ -# (�)� + ,-+$* �$- ' �� -) -# (�)� +2,-+$* ,*+$(" �$- ' ��

�� � ')/ -# ,�+ 0 �$- ' � �(� 0�,# + �$- ' �� -#�- , �.+ -# (�)� + ,-+$*-) -# & !- �+��% - �$- ' ���

� �)'*+ ,,$(" -# (�)� +2,-+$* ,*+$(" -) + & �, - (,$)( )( -# (�)� +,-+$*� ��+ !.&&1 + & �, -# (�)� + ,-+$* !+)' -# *$( )( -# ,*+$("�

�� ��+ !.&&1 + & �, -# (�)� + ,-+$* !+)' -# & !- �+��% -�

�� ��+ !.&&1 *.&& -# (�)� + ,-+$* -) -# +$"#-� -#+)."# �(� ).- )! -# ��++$�" �,, '�&1 �(� &�1 $- )( � !&�- ,.+!�� �

����������

�� �)/ -# ��+-+$�" ��++$�" -) -# & !-� )/ + -# , +/$� ,-�-$)(�

�� �(,.+ -#�- -# (�)� + ,-+$* $, )+$ (- � 0$-# -# -+�(,*�+ (- �+ � .*�

� � � -# (�)� + ,-+$* -#+)."# -# ��+-+$�" ��++$�" !+)' +$"#- -) & !-�

� � '*)+�+$&1� + ,- -# &)), ,-+$* ,�! &1 )( -# �+$/ +)&& +�

�� �&$* -# & !- (� )! -# ,-+$* )/ + -# *&�,-$� *$( )( -# & !- �+��% - �$- ' ����(� *+ ,, $- +$"#- -) -# ��, )! -# *$(�

�� �)), &1 !$-� �.- �) ()- -$"#- (� -# 0�,# + �$- ' �� �(� ,�+ 0 �$- ' � -)+ -�$( -# (�)� + ,-+$*�

� �&$* -# +$"#- ,$� )! -# (�)� + ,-+$* �$- ' �� )/ + -# -0) *$(, )( -# (�)� +2,-+$* ,*+$(" �$- ' � �(� + *&�� -# -0) (.-, �$- ' �� )( -# +$"#- ,$� � �(� ,&$"#-&1 -$"#- ( -# (.-,�

�� �&$"#-&1 -$"#- ( -# ,�+ 0 �$- ' � )( -# & !- ,$� �

�� �&$� -# ��++$�" ���% �(� !)+-# -# & ("-# )! $-, -+�/ & -) (,.+ !+ ')/ ' (-� �# (�)� + ,-+$* ,#).&� ()- �$(� )+ +.� )( -# ��++$�" �

Page 138: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-16 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��

���� �� ��� �� �����

Page 139: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-17HP DesignJet 430, 450C and 455CA Printers

���!��� ��� ���� �������

���� � ����� ��

������

�� ���!� ��� ������� ����� � ���� #��

�� ���!� ��� ����" ����� �� ���� �������� ��� ����� ������� ����� �� �� ���������� ��������

�� � �� ��� ����� ������� �� ��� ������ ��� ����!� �� ���� ��� ��������

���� �� ���� ���� �

Page 140: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-18 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��"$*�#� (�� ��&&���� �$($&

������

�� ��"$*� (�� &���( �&�� �( � %��� �-���

�� ��'�$##��( (�� ��&&����-"$($& ���!� �&$" (�� "��# �� ��$##��($& ���

��� �#� �&$" (�� �!�% �( (�� ��� $� (�� �&�#(�&�

�� ��� ������� ����� �� � ���� ��� �� ���� ��� ���� ���������� �� ��� � ��� ������

�� �&�'' (�� ��&&���� "$($& ($+�&�' (�� !��(� �#� &�"$*� (�� ��!( �&$" (��"$($& '���(�

� ��� �� ����� �������� � �� � �� ������ ���� �� ����� ����� ���� �� ��� ���� ������� ����������

� �!���(!, &$(�(� (�� "$($& $# �(' ��#�� )#(�! (�� �#����(�� %�&( $� (�� �!�� %!�'(�� �' %�&�!!�! +�(� (�� '��� $� (�� ���''�' ���"�

���

���� ������

� �)!! (�� "$($& $)( ($ (�� &���( $� (�� �&�#(�&�

Page 141: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-19HP DesignJet 430, 450C and 455CA Printers

� ����� ��� � ������

���������

�� � � �� �� ������ �� � ����� ������� � �� ���� ���� � ���������������� ���� �� ��� �� � ������ �������� � �� ���� ����� � � ���������

����� ��� ��� � ��� �� �������� �������� �� � ������ �� � � ����

Page 142: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-20 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�������� ��� ��������

���� � ����� ��

�������

�� ������ ��� ����� ��� ����� � � �� ���

�� ������ ��� ����� ����� �� �� � ���� ����� �� �� � �� ���� ��� ������������� �� �� ��� ����� ���� �� ���

�� ��� �� ��� �������� �������� �� ����� �� �� ��� ������ �� ������ �� ������� �������

��

���� �� ������

Page 143: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-21HP DesignJet 430, 450C and 455CA Printers

����#��� !�� "!!�� � ����$

���� � ����� ��

�����

�� ����#� !�� ���!!��� � ���� %���

�� ����#� !�� ����! ������! � ���� %��

�� ����� !�� "!!�� � ����$ ��!�� �� �����"���� !�� "!!�� �" ����� �"! ��!�� ����! ��� �� !�� ����!���

����� �� ����� ���� �

Page 144: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-22 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

������� ��� ����������� ���

�������

�� ����� ��� �������� � ���� �����

�� ����� ��� ��� ������ ���� ������ ��� ����������� ���� �� ��� �����������������

Torx-10

�� ����� ��� ����������� ���� ���� ��� ����������� ������

��� �� � � " �� ������

������ ����� ��� ��� ������ �� �����#������ �� � ���� �������"������ ���� ���� ���� �� �� ����� �� � ��� �� �� �� ���� ���� �������� �� ��� ��� �� �� ��� �� ����� ����" ��� ��� �� �� ������ ��� ��� �� ����� �� ��� ��� ������ �� �����#������ �� ��

������ ����� ��� ��� �� � ���� ��� �� �� � � � � �� ��� ��� �������� ����� �� ��� �� � ��� ��� ����� �� ��� �� ���

�� "� � ���� �� ��� �# !�� ���� �� ��������� ��� ����� �� ��� �� � �� �� �#��

Page 145: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-23HP DesignJet 430, 450C and 455CA Printers

��%'-"& +!� ���"� �'+') **�%�$0

���� �� ��� �� ��

�������

�� ��%'-� +!� *("++''& � (� � �1���

�� ��%'-� +!� �)"-�1�'$$�) ���) � (� � �1���

� �"*�'&&��+ +!� %��"�1%'+') ���$� �&� +!� �$�+ %��"�1�/"*1�&�'��) ���$��)'% +!� %�"& �� ��'&&��+')* $���$�� ��� � �&� ��� � )�*(��+"-�$0�� �&��)'% +!� �$"( �+ +!� ���# '� +!� �)"&+�)�

� ��%'-� +!� +!)�� *�)�.* �"+�% �� �&� .�*!�)* �"+�% �� +!�+ *��,)� +!�%',&+"& �)��#�+ �"+�% � +' +!� �)"&+�) �!�**"*�

�� ��%'-� +!� �',&+"& �)��#�+ �'%($�+� ."+! +!� ���"� �'+') **�%�$0�

������ ��� ��� "��� ������ ��� ���!�$������ ���� ���� �������#� ���� ��� ����� ������� � ��" ����� ��� �� ��� ����� �� !��� !��������� �� �� ���� ���� ���� �� ������ ���# ��� ������ ��������� "��� ��� ��" ����� �� ��� "��� ������ ��� ���!�$������ �����

�� ��������� ���� ��!��� ����������� ��� �������� ������� ������ ���# ����������� �������� � ������� ���

��

� ���� �� �� � ����� �������

Page 146: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-24 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��#%+ $� )�� � $��.�'# �����$ (#

���� � ����� ��

������

�� ��#%+� )�� ��� � �%)%' � &��� �.��

�� ��#%+� %$� (�'�, � )�# �� �$� ,�(��' � )�# �� )��) �))����( )��& $��.�'# (�$(%' � )�# � )% )�� ' ��) ( �� &"�)�� ��#%+� )�� � $��.�'#(�$(%' � )�# ��

� ��#%+� )�� (&' $� ��)�# ��

� ��#%+� %$� (�'�, � )�# �� )��) �))����( )�� � $��.�'# "�+�' � )�# �� )% )��"��) & ��� %� )�� ' ��) ��# !%*'$�" �((�#�"- � )�# �� ��#%+� )�� � $��.�'#"�+�' � )�# ���

�� �%%(�$ %$� (�'�, � )�# �� )��) �))����( )�� ' ��) ��# !%*'$�" �((�#�"-� )�# �� )% )�� � $��.�'# ��' ��# � )�# ����

�� ��#%+� )�� )�'�� &�')( %� )�� ' ��) ��# !%*'$�" �((�#�"- � )�#( � � �$� ����

��

��

� ��� �� � ������ ���� ��

Page 147: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-25HP DesignJet 430, 450C and 455CA Printers

���"��� �� ������ ������$

�������

�� ���"� �� ��� ���%��"�� � ���� %���

�� ��������� �� ��!� ��� !��� ���� �� ��� ������ ���

�� ���"� �� ����# �� � ����� �� ������ � �� ��� ����%��� ��

Torx-20

�� ����� �� ������ � �� ��� � ��� ����"� � ���� �� ���� ���

Page 148: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-26 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

������� ��� ���� � ������

�������

�� ����� ��� ���� ��� ���� � ���� � ���

�� ��� ���� � ��� ���� ��� ����� ���� ��� ������ ��� ����������

�� ����� ��� � ��� ���� ���� ��� ��� ����� � ������� �� ��� ���� ���� ������

Torx-20

Page 149: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-27HP DesignJet 430, 450C and 455CA Printers

�� �� �� ��� � ���� �� �� �� ���� �� ���� � ���� �� �� ����

� � ������ ������� �� ��� �������� ��������� �� ��� ���� ���

����������� ������ � �� � � ������� ��� ��� ����� � � ������������ �� �� � � �������� �����

Page 150: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-28 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�� "(�!� &�� ����+���& �����!�%

� ����

�� �� "(� &�� ���� %%� ��* � #��� �+�

�� �� "(� &�� �$� �$ %%� ��* � #��� �+���

�� �� "(� &�� ��$(��� �&�&�"! � #��� �+��

�� ��� #'%��!� &�� &"# "� &�� ����+���$ �%%� ��* &")�$�% &�� �$"!& "� &���$�!&�$�

�� &�� �"��")�!��

�� �! &�� �!����!� ��(�$� "(� &�� ����� ���� %����&�* &")�$�% &�� ���� "�&�� �$�!&�$�

�� ��") &�� �!����!� ��(�$ &" "(� &")�$�% &�� ���& "� &�� �$�!&�$� %"&��& &�� ����� �" �% �$�� "� &�� ��(�$�

Page 151: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-29HP DesignJet 430, 450C and 455CA Printers

�� ���� �� ���� ��� �� ���� ������ ��������

�� ���� �� ���� ��� �� �� ����� ��������

Page 152: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-30 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�� ������ ��� �� � �� ������

�� ������ ��� ����� ���� ��� ���� ��� ��������

�� ������ ��� ���� ���� ��� ��� �� ��� ���� ��� ��������

Torx-8

Page 153: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-31HP DesignJet 430, 450C and 455CA Printers

��� ���� � ��� ���� � ������ ���� ����

��� ��� � �� �� � ���� ��� ���� ���� � ������� �� � ��� ���� ��� ��� ����� � ��� � ���� � �� ������ � ��������

Torx-15

��� ���� � ���� ��� ������� ��� ���� � �������

� ��� ����� �� � ����� �� � �������

Page 154: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-32 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�������� ��� ������� ����� ������

�������

�� ������ ��� ������ � ���� ���

�� ������ ��� ������� ������� � ���� ���

�� ������� ��� ����� ���� ��� �������� ����� ������� � ���� ��

�� ������ ��� �������� ������

Page 155: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-33HP DesignJet 430, 450C and 455CA Printers

�� ������ ��� ����� ���� ��� �� � �� � ����� ��������

�� ������ ��� ����� ����� ���� ����� ��� ������� �� ��� ���� ����������

Torx-10 Torx-20+

�� ���� ��� ������� ������ �� ������ �� ���� ��� ��������

Page 156: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-34 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

����#��� !�� �������� ����

�����

�� ����#� !�� ����! ���&��#�� � ���� �&���

�� �� ������! !�� !������� ����� ���� !�� ������!�� ������ � �� !�� ���� � ��� ���� !�� �"��� �� !�� ����! ������!�

��

�� ��#� !�� �������� �"! �� !�� ��#��� !�!����

�� ����� � !�� !$� ������!�� ���� �� !�� !�� �� !�� ���!����� �������� �%�"����� !��� ����!�% �"!$��� ��� �"�� !�� !�� �� !�� �������� "��

Page 157: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-35HP DesignJet 430, 450C and 455CA Printers

�� ������� �� �� ������� �� ���� �� ���� ���� �� �� ����� �

�� � � � �� ������� �� ���� �� ����� �� �� ���������� ���� � ��� ��� �� ������� �� ���� �� ����� ��

Page 158: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-36 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

����%��� #�� �!������&����� $���

�������

�� ����%� #�� !���# �!����# � ��� �&��

�� ����%� #�� ���� ��%�!�

�� ����%� #�� #!������ ����� � ��� �&���

�� ����� #�� #!������&����� �$��� #� #�� !���#� !����"��� �# �!�� #�����#&�!����# #���

�� ��#�#� #�� #!������&����� �$��� ���� �� �#" ������ $�#�� �# �����" ��� �!��#�� ���""�" �����

� ����%� #�� #!������&����� �$��� �!�� #�� �!��#�!�

Page 159: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-37HP DesignJet 430, 450C and 455CA Printers

��� ��� ��� �������� ������"

������

�� ��� � ��� ������� ����� � ���� #���

�� ��� � ��� ����� ������� � #���

�� � ��������� ���� ��� �� ��� �� ���� � ���� ��������� �� ��� �� � ������

�� ����� ��� �������� ����� ��!���� ��� ����� ��� ���� � ��� ���� ���� �������� ������

�� ��� � ����� ������������� �� � ������ ���� � ����� ���������� �� � ��� ��� ���� ��� ��������

����������� ��� ��� � ��� �� �������� �������� �� � ������ �� � � ����

Page 160: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-38 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�� ������ ��� ����� �� ��� ����� ��� ������� ��� �� � ��� ��������

�� ������� ��� ��� ��� ��� ������ �� ��� �� � � ��� ��������

����������� �� � ���� ��� ���� �� ��������� ���������� �� ��������� � ��� �������

�� ������� ��� ��� �������� ���� �� ��� ��� � ��� �������� ������� �������� ���� �������� ���������

Page 161: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-39HP DesignJet 430, 450C and 455CA Printers

�� ���� �� ��� �� �� ����� ���

�� ������� �� �� ������� �� ���� �� ���� ���� �� �� ����� �

�� � �� �� ��� �� �� ����� �� �� ���������� ���� �

Page 162: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-40 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��� ����� ��� ������� �� ��� ������ ��� ������ �� ���� ��� ��� ��� ��� ��������

����������� ��� ��� �� ��� ����� �� ���� �# �!���� �� �����������

���� �!�� �� $�! ������ �$ �������� �� ������� ����� � ���� �%��

� �� ������������� ���� �!�� �� $�! ����� �� ��������% �%�������� ���� � ���� �%��

������ �� � �� ��"��� ����������� �� ��� ��� ������� �� �������� �����%�������� � �� ���� � ������ �!�����

Page 163: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-41HP DesignJet 430, 450C and 455CA Printers

�������� ��� ����� ���

�������

�� ������ ��� ��� �� ������� � � �� �!���

�� ���� �� ��� ���� ���� ��� ����� �� ��� ��������� �� ��� � ��� ���

����������� ���� ��� ���� �� ��� ����� �� ���� ��� ���� ���� �� ������� �� ��� ��� ������ ���� ����� ���� ��� ������� ����� �� ��� �������� ��� ������� ������ �� ��� ����� �� ��� ���������� ����� �� ������� ��� ��������

Page 164: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-42 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��� ��� ��� �� �#��� �����"

������

�� ��� � ��� ������� ����� � ���� �#���

�� � ��������� ���� ��� ��� ��� �� ���� � ����� ������� ��� �� ����� � ������

�� ����� ��� �������� ����� ��!���� ��� ����� ��� ���� � ��� ���� ���� �������� ������

�� ��� � ����� ������������� �� � ������ ���� � ����� ���������� �� ��� �� � ����� ��������

����������� ��� ��� � ��� �� �������� �������� �� � � ����������

�� �� ��� ���� �� ��� �������� ���� � ��� ���� ���� ��� �����"�

Page 165: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-43HP DesignJet 430, 450C and 455CA Printers

����������� ���� ���� �� �� � �� ������� � ���������� �� �� �� ���������

�� ��� �� �� �� � �� ��� �� �� ������ �� � � � �� ��� ������ ������ ���� �� ���� � ���� �������

�� � ��� �� ���� �� ����� �� ������ ���� �� ����� ��

Page 166: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-44 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��#%+ $� )�� �' +� �%""�'

�������

�� ��#%+� )�� �' +�.'%""�' ���' � &��� �.���

�� ��#%+� )�� ��� � �%)%' ((�#�"- � &��� �.���

�� ��#%+� )�� �+�'�' +� ((�#�"- � &��� �.��

�� ��#%+� )�� �$��� $�."�+�' �*&&%') � &��� �.���

� ��#%+� )�� "�'�� �"��! &"�() � ���' �'%# )�� "��) ( ��.&"�)��

Torx-20

� ��#%+� )�� %+�'�' +� �((�#�"- � &��� �.��

�� �(� )�� � $���'# ��+�' )% '� (� )�� & $��.,���"(� �$� " �) )�� ' ��) ( ��%� )�� �' +� '%""�' *&�

�� � �) )�� '%""�' %*) %� )�� �' $)�'�

Page 167: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-45HP DesignJet 430, 450C and 455CA Printers

����� ������ �� ���"� ������

�� ��� ������� ���������� ���� ���� ��� �� �� ��� ���� ������ ��� ��� ��� ����� ������ ���� ���� ������

�� �� � �� ��� �� �������

� ��� ���� �� � ������ �� ����� ������ ��� ���� �� � ���� !���� �����"� �������

� ��� ���� �� �� ���� �� �� ����� ������ �� ���� �� ������ ���!���� �!����� �� �� ���"� �������

�� ���� ��� �� ���"� ������ �� �� �� �� ����� #������

�� ��� �!�� �� �� ���� �� �� ��� ���� �� �� ������ �� ���� ������������ ��$ � �� ��� �� �� ����%��� ��

�� ��� �� �������� �"�� � ��� �� �����%#������ ��� �� �� ������ ������ � ������

Page 168: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-46 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

�� ��� �� ���� ��� ������� �������# �� ��� ����� ��� �� ��� ���!� ������ �� �������� ��� ����� ��������� ��� ���������# �� ��� ����� ���� �� ��� �"��� ���� ������

�� ������� ��� !�����!� ������# � ���� $���

�� ������� ��� ����� ����� ������# � ���� $���

�� �� ���� �� �� � �� ����� � ��� � ��� �� ��� ��� ��� ���� ���� ���� ���� �� ������ �� � �� ���� ���� � �� �� ������� ����� ��

���������� � ����� �� ������ �������� �� � � �� ����� �� ����� �� �� ���� � ���� � ���

Page 169: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-47HP DesignJet 430, 450C and 455CA Printers

��!#)�"� '�� ��"��,�%! ���' �����"�&!

��� �� ����� �� � $��� ��

������

�� ��!#)� '�� �%�)� %# �% � $��� ,�

�� ��'' � �+ �'' �� ("&�%�* '�� ��!,�#(%"� &�%�* ��'�! �� #" '�� %���' &�����' '�� &�!� '�!� �#"'�"(� + $(&��"� '�� &�%�* �" '#*�%�& '�� ��"'�% #�'�� �%�"'�%� ("'� +#( ��� '��' +#( ��)� $(&��� '�� ��!,�#(%"� �� #('#� '�� �#(%"� �

�� �( '�� %���' ��!,�#(%"� ��'�! �� #(' #� '�� ��% ��! ��'�! ���

� �%�&$ '�� ��' ��!,�#(%"� ��'�! � #" '�� ��' &��� #� '�� �%�"'�%�

� ����� �%#("� '# '�� �%#"' #� '�� �%�"'�% �"� $(&� '�� '#$ #� '�� ��% ��!& ���' + '#*�%�& '�� %��% #� '�� �%�"'�%� &�!( '�"�#(& + $( �"� '�� ��'��!,�#(%"� '# '�� ��'� &# '��' '�� ��% ��! ��" ����" '# & ��� #(' #� '�� ��'&���$ �'��

�� � ��� '�� ��% ��! ��'�! �� '# '�� ��' ("'� �' � ��%& '�� $�"��,�%!�&&�!� + ��'�! � +#( *�"' '# %�$ ����

�� ��!#)� '�� $�"��,�%! �&&�!� + �"� &$%�"� �%#! '�� ���&&�&�

��� ��� � �� � ������ �� ��� �����

���� �

�� ��

������

Page 170: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-48 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

������������

�� ������� �� �����$��� ���������� �� � �� �������� ��� �!�� �� ���!������ ��� ������ �# ����� �� �� �� ������

�� ����� �� ��� ��� �� �� �� � �� ���� � �! �!� ���� ��� � ������� � ��� �� ��� � ��������� �� � ���� �� ����� ���� ��� �����

�� � ��������� ���� � ��� ������ �� � ����������� ����� ������� ���� ���� � �������� ���� � ��� ��� �� ��� � ������� ��� �� � �� ������� � ������ �� � ���� ���� ����

�� ����� ������ ������ �� ���� ���$��!���� �� �� ��� ��� �� � � �! �!� � �� ���� "���� �� �! �� ������ �� ��!����� ����� ��� �� ��!���� �������� �# ��� �� �� ����" �� �� ���

Page 171: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-49HP DesignJet 430, 450C and 455CA Printers

��

�� ��� ��� ������� ���� �������

Page 172: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-50 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

��%'-#&! +"� �-�)�)#-� �**�%�$/ �#&�$,�#&! +"� �-�)�)#-��'$$�)� ���#� ��(�)�+')� ���#� �� $��+')* �&� ���#� ��&*')�

���� � ����� �� � (�!� ���

�������

�� ��%'-� +"� �(#++''& � (�!� �0���

�� ��%'-� +"� �)#%�) �**�%�$/ � (�!� �0���

� ��%'-� +"� ��)-#�� �+�+#'& � (�!� �0���

� �#*�'&&��+ +"� %��#�0*�&*') ���$� )'% +"� %�#& ��� ��'&&��+') $���$���������

�� ��%'-� +"� �$,+�" )�+�#&#&! )#&! �#+�% �� +"�+ *��,)�* +"� '-�)�)#-��$,+�" �#+�% �� +' +"� '-�)�)#-� )'$$�) �#+�% ��

�� �$#�� +"� '-�)�)#-� �$,+�" �#+�% �� +' +"� $� + �&� )�%'-� #+ )'% +"�'-�)�)#-� )'$$�) �#+�% ��

� ��%'-� +.' *�)�.* �#+�% � )'% +"� )#!"+ *#�� ' +"� ()#&+�) �&� '&�*�)�. �#+�% �� )'% +"� $� + *#���

�� �''*�& '&� *�)�. �#+�% �� '& +"� $� + *#��� �,+ �' &'+ )�%'-� #+�

�� �# + +"� �'%($�+� �-�)�)#-� �**�%�$/ �#+�% � �."#�" #&�$,��* +"�'-�)�)#-� )'$$�)� %��#� *�(�)�+')� %��#� �� $��+')* �&� %��#� *�&*')� )'%+"� ()#&+�)�

Page 173: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-51HP DesignJet 430, 450C and 455CA Printers

��

���� ��� ������� ��� ���

Page 174: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-52 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

����#��� !�� �!�% ���!��

���� � ����� �� � ����

�������

�� ����#� !�� �#�����#� � ����% � ���� �'��

�� ����#� !�� ���$ ��!�� �� !��! �!!���� !�� ��!�% ���!�� ��!�� �� !� !������! ���'���!��

�� ����#� !�� ���$ ��!�� �� !��! �!!���� !�� ��!�% ���!�� ��!�� �� !� !�����! ���'���!��

� ����� � !�� ������!�� ��!�%'���!�� ���� �% �" ���� !�� ��!!�� ����!������ �� !�� ��!�% ���!�� "��

� �"�� !�� ��!�% ���!�� ����&��!���% �"! ���� !�� ����!���

Page 175: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Removal and Installation 8-53HP DesignJet 430, 450C and 455CA Printers

������������

�� ������� ��� ����� �� ��� ������� ��� ��� ������� ����

�� ����� ��� ��� �� ��� ����� �� ��� ��� �� ��������� �������� �� �� ��� �������� � �� ������� ���

� �� ��������� � ����� ��� �� � ����� ���� � ��� ���� ���� �� � � � ���� �� � ����� ���� � ��� ���� ���� ���

��������

������� ���

���������

�� �� ���� ��� ����� ��� �������� ��� ������

Page 176: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

8-54 Removal and InstallationHP DesignJet 430, 450C and 455CA Printers

� ��������� � ����!��� �� ����� ��� ����#����� �� ��� ����� �� ��� ����"������� �� �� ��� ����" ������ � �� �� ��� ����� �� ���� �� �� ����� ������� ������� ����#������

��� ���� � �� ���� ���� �� ���� ����� �� �� ������ ������ �� ����� ����� � ��� � � ����� ���� ���� �� ��������� �� �� ���� � ������

� ������� ��� ����! ����� �� �� ��� �����#���� ���� ��� ��� ����! ����� ���� ��� ����#���� �����

�� ������ ��� ����!�� ������ ���� ���� ��� ����" ������ �� ������� ������������ ��� ����� ����#������

���� ��� � ��� ����

Page 177: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

9-1 HP DesignJet 430, 450C and 455CA Printers

�������� ��������

Page 178: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

9-2 Preventive MaintenanceHP DesignJet 430, 450C and 455CA Printers

�.)1230% .- �0)-2%0

�1%01 1(.3+$ 31% 2(% �0)-2%0 )- !- %-4)0.-,%-2 "%25%%- �� !-$ ���0%+!2)4% (3,)$)26� �. 0%#.4%0 &0., ,.)1230% #.-$%-1!2).-� 230- 2(% �0)-2%0.&&� !-$� 31)-' 2(% ,!)- 0.++%0 !1 ! 0%&%0%-#%� 5!)2 3-2)+ 2(% �0)-2%0 )1#.,/+%2%+6 $06 "%&.0% 31)-' )2 !'!)-�

�%4%+ .& �0)-2%0 �1!'%

�. !#()%4% '..$ /%0&.0,!-#% !-$ +.-' +)&%2),% .& 2(% ����%1)'-�%2������������� �0)-2%01� 31%01 1(.3+$ +),)2 31% 2. 2(% &.++.5)-'0%#.,,%-$!2).-1 �$326 #6#+%��

Average number of plots per day Maximum number of plots per day

10 E/A0 CAD plots 20 E/A0 CAD plots

�(% 1%04)#% #.-&)'30!2).- /+.2 ')4%1 !- )-$)#!2).- .& (.5 ,3#( 2(% �0)-2%0(!1 "%%- 31%$� -3,"%0 .& /+.21� -3,"%0 .& #!020)$'%1� -3,"%0 .& 2),%1 2(%�0)-2%0 (!1 "%%- 230-%$ .-� ��%2!)+1 � /!'% �7���

�0)#2).- .- �+)$%0 �.$

�(% #!00)!'% "31()-'1 !0% ,!$% .& ! /.0.31 #.,/.1)2% ,!2%0)!+� �)+ 12!61)-1)$% 2(%, "6 ,%!-1 .& #!/)++!06 !#2).-� �%4%0 /+!#% 2(% "31()-'1 .- !-!"1.0"!-2 ,!2%0)!+� �. /0%4%-2 &0)#2).- .& 2(% "31()-'1 .- 2(% 1+)$%0 0.$�0%,.4% $)02 &0., 2(% 1+)$%0 0.$ !-$ #(!11)1 "%!,� �//+6 .)+ ��-$%0.+ �� ���� /!02 -3,"%0� ���7����� 2. 2(% 1+)$%0 0.$ �� $0./1� !-$ 2. 2(%"31()-'1 )& 2(%6 !0% 03--)-' $06�

�.)16 �!00)!'% (%%+

�. /0%4%-2 -.)16 ,.4%,%-2 .& 2(% #!00)!'%� 0%,.4% !+3,)-3, .0 $312/!02)#+%1 &0., 2(% 5(%%+ !2 2(% "!#* .& 2(% #!00)!'%� !-$ &0., 2(% 1+)$%0 /!2(!+.-' 5()#( 2(% 5(%%+ ,.4%1�

Page 179: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Preventive Maintenance 9-3HP DesignJet 430, 450C and 455CA Printers

�&# �("$$"&

�!� *�)-"�� �'&�" ,)�+"'& ($'+ "-�* �& �*+"%�+"'& '� +!� �%',&+ '� "&# "& +!��)"&+�)�* *("++''&� ���+�"$* � (� � 0��� �' ()�-�&+ "&# *("$$"& � )�($����'+! +!� *("++''& �&� +!� "&#0*�(�)�+') .!�& +!� *("++''& "* �$%'*+ �,$$� �',+ ��� ()"%�* �)� &����� +' �"$$ ,( +!� "&#0*�(�)�+')�

�'+� +!�+ "� /', �$��) +!� ����� ') )�($��� +!� �$��+)'&"�* %'�,$�� +!����+')/ *("++''& -�$,� "* )�*�+ +' �� ,*��� ���( "& %"&� +!�+ +!� -�$,�()"&+�� '& +!� *�)-"�� �'&�" ,)�+"'& ($'+ %�/ )��+$/ ,&��)�*+"%�+� +!��%',&+ '� "&# "& +!� *("++''&�

��$+ �.�$$"&

�' ()�-�&+ &�. ��$+* �)'% *.�$$"& "&�'))��+$/� #��( +!�% "& +!�") �� * ."+!�"**"��&+ ,&+"$ /', &��� +' "&*+�$$ +!�%�

Page 180: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

9-4 Preventive MaintenanceHP DesignJet 430, 450C and 455CA Printers

!��#�#� (�� �&�#(�&

�$ "��#(��# (�� �&�#(�& �# �$$� $%�&�(�#� �$#��(�$#� ��% �( �&�� $� �)'(���)")!�(�$#� �# � �#� $(��& �$#(�"�#�(�$#� !��#�#� �#(�&*�!' �&���(�&"�#�� �, (�� �&�#(�& �#*�&$#"�#( �#� �, (�� (,%�' $� �&�#(�& ')%%!��')'���

��'�#""��( (�� �&�"(�& �&#! (�� $#+�& '#)&�� $&�#&(# $�&�#&!�"� �", � ��"�"�� �� ��� � #+ �%)�� (#&)" #" (# � ��(&��� �#!$#"�"(' #& ��&�)�('� #&(�&#)�� #$�"�"�' �" (�� �"� #')&�� �' (��' ��"�&��(� � '�#�� ��-�&� ����"� (# ���(� #& �"�)&,�

W A R N I N G

��"�&� � ��"�"�

�&$%�& ��#�&�! �!��#�#� '�$)!� �#�!)�� (�� �$!!$+�#��

� !$+ �+�, �)'( ���)")!�(�$# +�(� �$"%&�''�� ��& �� �*��!��!��

� !��# (�� $)(�& ')&���� $� (�� �&�#(�& +�(� � ��"% '%$#�� $& �!$(�� �'� �"�!� '$�% �#� +�(�& '$!)(�$# �� #���''�&,� �$ #$( )'� ��&�'�*� �!��#�&'�

� ��%� (�� �&�#(�& �&, +�(� � '$�( !�#(.�&�� �!$(��

� ��"�"� (�� �&�*� �# �&

�)� ($ (�� �# �' &��!��(�#��� �# '%�!!�� $# (�� &$!!�& ��# ��'&)%( (�� �&�#(�&�'����.'�#'�#� �)#�(�$#� �$ &�"$*� �#, �# �&$" (�� &$!!�&� %�&�$&" (���$!!$+�#� %&$���)&��

� $##��( (�� �&�#(�& ($ (�� �� %$+�& '$)&���

� �+�(�� (�� �&�#(�& ��� �#� +��( �$& �( ($ ��#�'� �#�(��!�-�(�$#�

� �%�# (�� ($% �$*�&�

� ���% (�� �$*�& '+�(�� %&�''�� +��!� %&�''�#� Form Feed &�%��(��!, )#(�! (��'(��#�� �&�� $� (�� �&�*� &$!!�& �' %$'�(�$#�� �( (�� ($% +��&� �( ��# ���!��#���

�)&# (�� �&�#(�& ���� �#� ��'�#""��( �( �&$" (�� �� %$+�& '$)&���

�%%!, �� ��!�$�$!� ($ � '$�(� !�#(.�&�� &���

� �'� (�� &�� ($ �!��# (�� &$!!�& ')&�����

� �!!$+ (�� �&�*� &$!!�& ($ �&,�

� $(��& �&��' $� (�� &$!!�& ��*� ���# '(��#�� �, �# � &�%��( (�� ��$*�'(�%'�

�� ���$##��( (�� �&�#(�& ($ (�� �� '$)&��� ()&# (�� �&�#(�& $#� �#� !$��%�%�& ($ (�'( (��( #$ �# &��!��(�$#' ��'&)%( $%�&�(�$# $� "���� !$���#��

Page 181: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

10-1 HP DesignJet 430, 450C and 455CA Printers

��

�������� ��� ���

Page 182: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

10-2 Functional OverviewHP DesignJet 430, 450C and 455CA Printers

�-20.#3"2(.-

�'$ �� �$1(&-�$21 ��� ���� -# ����� %.++.5 .- %0., -# 0$/+ "$ 2'$�$1(&-�$2 � -# ���� �'$ �� �$1(&-�$21 ��� ���� -# ����� �+(*$ 2'$�$1(&-�$21 �� �� ��� -# ���� ' 4$ (-'$0(2$# ,3"' .% 2'$ 1612$, 0"'(2$"230$ -# %$ 230$1 .% 2'$ �$1(&-�$2 �� �'$(0 50(2(-& 1612$,�'.5$4$0� (1 ! 1$# .- 2' 2 .% 2'$ �$1(&-�$2 ����

�'(1 "' /2$0 #$1"0(!$1 1.,$ .% 2'$ , (- %$ 230$1 .% 2'$ �� �$1(&-�$21 ������� -# ������ �$%.0$ 0$ #(-& (2� 0$ # 2'$ %3-"2(.- + .4$04($5 .% 2'$�$1(&-�$2 � � !�� ��������� ��� ��� �� ��������� ��� �������� � ��� ����������� / 02 -3,!$0 ����8������

��-%.0, 2(.- .- 2'$ �$1(&-�$2 ��� � !�� ���� ���� ��������� �� ��� ��� �������� / 02 -3,!$0 ����8����� �$4 ���

�.++ �$#(

�'$- 0.++8%$$# 11$,!+6 (1 (-12 ++$# .- 2'$ �0(-2$0� 0.++ ,$#( " - !$ 31$#��'$ 0.++8%$$# 11$,!+6 ".-1(121 .%�

� �5. 0.++8%$$# ".,/.-$-21�

� � 1/(-#+$�

� �5. ,$#( 12./1�

�'$ 0.++8%$$# 11$,!+6 (1 (-12 ++$# !$+.5 2'$ 1'$$2 ,$#( $-206 / 2'� 2. ++.52'$ $ 1$ .% +. #(-& %.0 1'$$2 ,$#( � �'$- 0.++ ,$#( (1 +. #$# (-2. 2'$�0(-2$0� (2 (1 / 11$# 0.3-# #(4$02$0 0.++� 5'("' ./2(,(7$1 2'$ (-%$$# / 2' 2.2'$ �0(-2$0� �-"$ /+.2�/0(-2 (1 ".,/+$2$#� !3(+28(- "322$0 32., 2(" ++61+(#$1 "0.11 2'$ / /$0 2. "32 2'$ /+.2�/0(-2 %0., 2'$ 0.++�

�$,.4(-& �2 2(" �' 0&$ %0., 2'$ �$#(

�- -2(812 2(" !031' +." 2$# 3-#$0 2'$ $-206 /+ 2$- /0$4$-21 12 2(" "' 0&$%0., !3(+#(-& 3/ .- 2'$ ,$#( � � "' 0&$ " - " 31$ 2'$ ,$#( 2. 12("* 2. (21$+% -# ) , 2'$ �0(-2$0�

Page 183: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Functional Overview 10-3HP DesignJet 430, 450C and 455CA Printers

�'�%%�#� )�� �����

���# .$* !$�� )�� "����� �) �( �'�%%�� �. )�� %�#��/�'"(�

� ������ �����

��� %�#��/�'" (�#($' �( � (,�)�� (�#($' )��) �( �))����� )$ )�� �'�#)�'��((�(� �) ��)��)( )�� %$(�)�$# $� )�� %�#��/�'" !�+�'� ��# ���� �))����#� )��!�+�' )$ � ��"� ��*(�( )�� ��" )$ '�!��(� )�� (,�)�� �( )�� %�#��/�'"( �'�'��(��� ��� %�#��/�'" (�#($' �( �!��)'���!!. �$##��)�� )$ )�� "��# ��

�'$+���#� � $'�� $# �$% $� )�� �����

�� �

��� ���! %'$+���( � #$'"�! �$'�� $# )$% $� )�� "����� ���'� �( #$ ���! (�#($'$# )�� �'�#)�' )$ ��)��) �� )�� ���! �( *% $' �$,#�

�� ��� �� ���� ��

��� ���! ���)*'�( �# �*)$"�)�� !��) "����#�(" �'�+�# �. )�� "���� "$)$'*(�#� � (�'��( $� ���'( �#� ��)*�)�� �. )�� ��')'���� ��''����� ��� ���!�/��(����(��# �!�"�#�)�( )�� )$'&*� $# )�� �-!� $� )�� ���!/!��) ��" �#� )�*( �"%'$+�('�!����!�).� ���( "����#�(" �( �!($ "$'� ����((��!�� ���"$+�! � %��� �/����

��)��)�#� )�� ��#�( �#� ����� ����(

� � �����

��� !�#� (�#($' $# )�� ��')'���� ��''���� �( *(�� )$�

� ��)��) )�� !��) �#� '���) "���� ����(�

� ��)��) �#� "��(*'� !�#�( �'�,# $# "���� ,��# %�'�$'"�#� ���*'��.��!��'�)�$#�

� ���# )�� (�)*% �#� �!��#"�#) (���)(�

� �#� )�� %!�)�# '$!!�' '���'�#�� "�' �

Page 184: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

10-4 Functional OverviewHP DesignJet 430, 450C and 455CA Printers

�(/"' -!� ��++"� �

������������ ��������

������ ���� � �����

� �!� ��++"� � ��4�1",� �+"/� �(',",-, (� � �� &(-(+ �"+��-%2 �+"/"' � ,"' %���%- �'� -!� ��++"� ��

� �!� &(-(+ �,,�&�%2 "-,�%� )+(/"��, -!� -�',"(' '����� (' -!� ��%-��%"&"'�-"' -!� '��� �(+ � ,�)�+�-� ).%%�2 -�',"('�+�

� �!� ��%- �%�&), "-,�%� -( -!� ��++"� � -!�+� �+� '( ,�)�+�-� ��%- �%�&),�

� �!� "'-�+���� ��-0��' -!� &(-(+ ,!��- �'� ��%- ", �+"�-"(' ��,���

� �(. ��' +�&(/� -!� ��%- 0"-!(.- !�/"' -( +�&(/� -!� ).%%�2 (' -!� %��-�'� (� -!� ��%-�

������ ��� ���

�!� ��++"� � &(/�, �%(' (' #.,- ('� ,-�"'%�,, ,-��% ,%"��+ +(�� �- ", ."��� �2-0( "'-� +�-�� �+('3� �.,!"' ,� 0!"�! �+� ,�%�4%.�+"��-"' � �'� � ���$ 0!��%�

�������� ��� ���

�' �'�(��+ ,-+") )+(/"��, �������$ (' -!� )(,"-"(' (� -!� ��++"� �� �!� ,-+")�(�, '(- +�*."+� ��#.,-&�'-�

��++"� � ���

�!� ��++"� � ��� ", ��,�� (' -!�- (� -!� ��," '��- ���� �- �(''��-, -( -!�&�"' ��� -!+(. ! � %(' ��4�('�.�-(+ ��1��� -+�"%"' ���%�� �!� ��++"� ���� �('-�"',�

� �)-"��% %"'� ,�',(+

� �!�+&",-(+ �"+�."-

� �"'��+ �'�(��+

� ��+-+"� � '(33%� �"+"' �"+�."-

�(&� �%��-+('"� �(&)('�'-, (' -!� ��," '��- �� �'� ��� ��++"� � ����+� '(- )+�,�'- (' -!� ��," '��- �� ��++"� � ���� �- )(0�+4(' -!� �+"'-�+�"+&0�+� "��'-"�"�, 0!�-!�+ -!� ��++"� � ", �(+ � �(%(+ (+ � &('(�!+(&�&(��%� �'� ��!�/�, ���(+�"' %2�

Page 185: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Functional Overview 10-5HP DesignJet 430, 450C and 455CA Printers

�$"(���!� �!�

�� �� ����� ��

��� � ��%��!��&% ���� ��� �!� �� '%� &�� %� � ��$&$����% �% �"�% &�� � ��%��!��&% ��� �!� ����

� ����� ���� ���� �� �� � �

��� ��%&�!�� ��&)��! &�� ��$$���� �!� &�� )$�&�!� %'$���� ��! ��&�$ �!� � ���%��$#!�%%� % &�� ��%&�!�� �!�$��%�%� &�� �$"# %��#� �!� ��$��&�"!���&* ���$����!� �$� "$� ������'�& &" #$����&� �"' ��! ���!�� &�� ��%&�!�� '%�!� &�� ���'%&�!�%�$�) "! &�� ��$$���� ���&���% � #��� ,��

Bail-LiftEngaging Tab

IntegratedLine Sensor

ÎÎÎÎ

Adjusting Screw

Back Slider

BeamCross–section

������ ���� �� �

�$"�'��!� �! � ���

�� ����� �������� �� ��

�"&� &��& &�� ��$ )�$� ��! $��"�!�+� �$" &�� #�"& ��&� )��&��$ � #�"& �%�"�"$ "$ "!"��$" �� �"' �" !"& %�& &��% #�$� �&�$ "! &�� �$"!& #�!���

Page 186: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

10-6 Functional OverviewHP DesignJet 430, 450C and 455CA Printers

��'+ � $� )�� ��')' ���(

������� � � �

� ��� (�'+ �� ()�) %$ ( ��(- )% ����(( �$� '�#%+�� �$� ( '�&"�����"� �( %$�*$ )�

� ��� ��(�$�� %� � �'%& ��)��)%' #&" �( � � ���'�$) ��')' ���/#� $)�$�$���"�%' )�# )% �*�'�$)�� �%''��) $%.."� �%$� ) %$(� ��� �' $)�' ,�'#( )��$%.."�( �$� (& )( $!�

� ���%'� ���� &"%)�

� �)�' ���� ��')' ��� ���$���

� �� "� &' $) $�� ��&�$� $� %$� ��')' ���� �*# � )-� )�#&�'�)*'�� �$�&"%) $! ��$( )-�

� ��� +�$) "�) %$ �%"�(� ,� �� ,�'� "%��)�� %$ )�� (�'+ ��/()�) %$ ("�� %$)�� ��( �$��) ��� �'� $%, "%��)�� %$ )�� $! (�&�'�)%' )% &'�+�$) )��#�'%# ���%# $� �"%�����

���

( $�"�� '���( �$�� (& ))%%$ ( "%��)�� %$ )�� ' ��) ( �� %� )�� �' $)�'�

������

��� �' $)�'( ���)*'� � #�$*�" &' #�'� ��(�� %$ )��) %� )�� ��(!��) ����� $()��� %� )�� �*)%#�) � %$� %� )�� ��( �$��) ���

� ��""%,( �((�#�"- &'%+ ��( � +��**# )% (*�! $! �'%# )�� $%.."�(� ���(*�) %$ )*��( ��+� � , ��' � �#�)�' )��$ )�%(� %� )�� ��( �$��) ��� )%��"& &'�+�$) �"%�� $��

� $ $! (�&�'�)%' (%"�)�( )�� ��""%,( �'%# )�� ��')' ���(� &'�+�$) $� $!�%$)�# $�) %$ %� )�� ��""%,(�

")�%*�� )�� &' #�'( �%' )�� ��( �$��)( ���� ��� �$� �� �$���( �$��)( ��� �$� ��� "%%! ��$) ��"� )�� ' ���'��)�' () �( �'� � ���'�$)��$()�"" $� )�� $�%''��) &' #�' ��$ ��#��� )�� ��')' ���( %' '��*�� )��(�'+ � $� %� )�� ��')' ���(� �%' )�� �%''��) &�') $*#��'( �%' )�� &' #�'( ����&)�' ��

Page 187: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Functional Overview 10-7HP DesignJet 430, 450C and 455CA Printers

�)#!1/,+'!0 �,"2)#

�&# #)#!1/,+'!0 *,"2)# '+!)2"#0 1&# *�'+ ���� -,4#/ 02--)6 �+" $�+� �1 '0 ,+##5!&�+%#� )# -�/1� 6,2 ", +,1 +##" 1, ,-#+ '1� �$ 6,2 /#-)�!# 1&# #)#!1/,+'!0*,"2)#� /#*#* #/ 1, 04�- �+6 ����0 $/,* 1&# ,)" *,"2)# 1, 1&# +#4 ,+#�

������

�&#/# '0 +, �') 0#+0,/ $,/ 1&# �� �#0'%+�#10 ��� ���� �+" ������ �&#/# '0� -'+!&8�/* 0#+0,/ 4&'!& '0 "'$$#/#+1 1, 1&# ,+# '+01�))#" ,+ 1&# ���#0'%+�#10 � �+" ���� �&# $,)),4'+% 0#+0,/0 !,++#!1 1, 1&# *�'+ ����

� �&# ���� ����� '0 � *#!&�+'!�) 04'1!& 1&�1 "#1#!10 '$ 1&# �/'+1#/ !,3#/&�0 ##+ /�'0#"� �$ 6,2 ,-#+ 1&# !,3#/ 4&')# 1&# �/'+1#/ '0 -),11'+%� 1&#-),1 '0 !�+!#))#"�

� �&#��� ����� "#1#!10 1&# -/#0#+!# ,$ *#"'�� �1 '0 �)0, 20#" 1,"#1#/*'+# *#"'� )#+%1&�

� �&# �� ����� 0#+"0 0'%+�)0 1, 1&# !�//'�%# �+" '0 20#" 1, "#1#!1 1&#*�/( #+!,"#/ �+" /#�" �)'%+*#+1 -�11#/+0� �1 '0 �)0, 20#" 1, "#1#/*'+#*#"'� 4'"1&�

� �&# ��������� ����� "#1#!10 4&#1&#/ 1&# -'+!&8�/*0 &�3# ##+ /�'0#"��&# 0#/3, -/,!#00,/ 20#0 1&# 0#+0,/ 1, "#1#/*'+# 1&# -'+!&8�/* -,0'1',+"2/'+% 1&# '+'1'�)'7�1',+ 0#.2#+!#�

���

�&# �/'+1#/ $'/*4�/# !,"# '0 !,+1�'+#" ,+ #'1&#/ �+ '+8 2')1 *�0(#" ����0,)"#/#" 1, 1&# *�'+ ���� ,/ � $)�0& ��� ���� �'+01�))#" '+ 1&# '++#/8*,010,!(#1 �1 1&# �!( ,$ 1&# �/'+1#/�� �$ ,1& �/# -/#0#+1� 1&# �/'+1#/ /#!,%+'7#01&# !,"# ,+ 1&# ��� ���� '+01#�" ,$ 1&�1 ,+ 1&# '+8 2')1 ���� �&# -,4#/8,+��� 0#.2#+!# 1#))0 6,2 4&#1&#/ 1&# �/'+1#/ '0 20'+% !,"# $/,* '+8 2')1 ��� ,/$/,* � ��� ����� �$ 1&# ���0 #%'+ 1, )'%&1 2- $/,* 1&# /'%&1� 1&#+ 1&#�/'+1#/ '0 20'+% 1&# ��� ����� �$ 1&# ���0 #%'+ 1, )'%&1 2- $/,* 1&# )#$1�1&#+ 1&# �/'+1#/ '0 20'+% 1&# 2')18'+ ���� �, $'+" ,21 1&# $'/*4�/#8!,"#/#3'0',+ )#3#) 1&�1 1&# �/'+1#/ '0 20'+%� -/'+1 � 20#/ 0#12- 0&##1 ,/ � 0#/3'!#!,+$'%2/�1',+ -),1�

���

�&# �/'+1#/0 &�3# � 01�+"�/" $,2/ *#%� 61#0 ,$ ,+8 ,�/" ���� �&#6 �)0,&�3# ,+# ���8#5-�+0',+ 0,!(#1� 4&'!& !�+ &,)" �+ ,-1',+�) �8� �8� � 8 ,/ 8*#%� 61# ���� ����� �&# 0,!(#1 '0 1&# ,21#/8*,01 ,+# �1 1&# �!( ,$ 1&#�/'+1#/�

Page 188: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

10-8 Functional OverviewHP DesignJet 430, 450C and 455CA Printers

���

����� -5 75)( %5 12182/%6-/) 5624%+) *24 '%/-&4%6-21 %1( '21*-+74%6-21 (%6%�"5)*7/ -1*240%6-21 *420 6,) ����� -5 34-16)( 21 6,) 5)48-') '21*-+74%6-213/26� !,) ����� -5 52/()4)( 62 6,) �%-1 ��� -1 &26, 1)9 %1( 4)&7-/6)/)'6421-' 02(7/)5�

�* ;27 '/)%4 6,) ����� 24 4)3/%') 6,) )/)'6421-'5 02(7/)� 3)4*240 %//'%/-&4%6-215� �/52 126) 6,%6 6,) *%'624; 53-66221 8%/7) 21 6,) '/)%4)( 24 1)9����� -5 ��� �))3 -1 0-1( 6,%6 6,) 8%/7) 34-16)( 21 6,) 5)48-')'21*-+74%6-21 3/26 0%; +4)%6/; 71()4)56-0%6) 6,) %02716 2* -1. -1 6,) 53-66221�

��!%$��%$!%$ ��$�"����#

!,) �4-16)45 ,%8) &26, % 3%4%//)/ ��-<!421-'5� %1( % 5)4-%/ �� <�<��-16)4*%')� "1/-.) 6,) �)5-+1�)6 � ��� 6,); ,%8) 12 02(7/%4 -1376�276376������ $27 '%1 '211)'6 6,) �4-16)45 62 % 1)6924. &; 0)%15 2* %1 ������ � �� 24 �� ���� � �� ����� ):6)41%/ 34-16 5)48)4�

��*�" ���#

�1 %((-6-21 62 6,) 23)4%6-1+ 02()5 2* 6,) �)5-+1�)6 �� 6,) �-<!421-'5-16)4*%')5 *)%674) 6,) ):6)1()(<'%3%&-/-6;<3246 ����� *249%4( %1( 4)8)45)23)4%6-1+ 02()5� 3428-(-1+ *24 *%56)4 '20071-'%6-21�

��*���*�

!,) 5733246)( &%7(4%6)5 %4) ��� ���� ����� ����� ��� %1( ������ 9-6,)-+,6 &-65 %1( 12 3%4-6;� 24 5)8)1 &-65 9-6, )-6,)4 2(( 24 )8)1 3%4-6;� �%4.3%4-6; -5 126 5733246)(� �26, #���#��� %1( �!� ,%1(5,%.-1+ %4)5733246)(� ������� ,%1(5,%.) -5 126 5733246)(�

� '�" �%!!�)

�1 %762<4%1+-1+ 329)4 5733/; -5 /2'%6)( -1 6,) )/)'6421-'5 02(7/)�

��� !"���") #��� � $�� ! '�" #%!!�) � �$���# "��$����� ����& �$��� $��$ ��� �� ��$��� '��� $ %���� �&�� �� $�� � ��#'�$�� �# ��

�� ��) ��#�� ) % #� %�� � $ ���� $ !�� $�� ����$" ���#� �%��� �$ �# �� �(���������� !�"$�

� � � � � � �

��$�" � ����#�$� �

�1 ,70-( )18-4210)165� 9%6)4 0%; '21()15) 21 6,) 5-()<3/%6)5� � 9-'.%66%',)( 62 6,) 71()45-() 2* 6,) 4-+,6 5-()<3/%6) 4276)5 9%6)4 (4235 %9%;*420 6,) 0%-1<��� )/)'6421-'5�

Page 189: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Functional Overview 10-9HP DesignJet 430, 450C and 455CA Printers

��!#&- �'���

�( �' ������) ( (# �� �) �(� (�� �!#)"( #� �&�"(�& !�!#&- "����� (# $ #( ��&�+�"� #� �"- ��*�" �� � '�.�� ��!#&- �' )'��� "#( �)'( (# �# � (�� �"$)(��(�� �)( � '# �#& '-'(�! #*�&����� $&#��''�"� +#&�/'$���� �"� '(#&��� #� (���"(�&"� &�$&�'�"(�(�#" #� (�� $ #(� �#!� (-$�' #� �&�$���' &�%)�&� &� �(�*� - �&�� �!#)"(' #� !�!#&-� ,�!$ �' �&� +��� �"�'� &�'(�& �� $�((�&"'�$# -�#"'� �"� )'�&/����"�� �"�'�

� �� ����������

��� #)($)( #&��"(�(�#" #� (�� �&�+�"� � '# ��' �" �!$��( #" !�!#&- )'�����#!$�&� � $ #( #� �#&�.#"(� �"�' +�(� #"� #� *�&(��� �"�'� �"�' $ #((��$�&� � (# (�� ��&&���� �,�' (��� )$ �#"'���&�� - �'' !�!#&- (��" (�#'�$ #((�� $�&$�"���) �& (# �(� ��� �&�"(�& �)� �' �&�$��� ��'$ �- #����(' #" �'+�(�/�-/'+�(� ��'�'� � �#&�.#"(� �"� ��" �� �#"(��"�� �" #"� '+�(�� �*�&(��� �"� '$�"' !�"- '+�(�' �"� (��&��#&� &�%)�&�' !#&� �"(&��' �" (���&�"(�&�' �"(�&"� ��'$ �- �'(�

����� ���� ��������

��� &�'(�& (&�"'��& �"�)��� ��� � $&#*���' � '# )(�#" (# �"')������"(!�!#&- #" (�� �&�"(�&� ���" � (�� ��(� �' '�"( (# (�� �&�"(�& �" (�� #&��& ��(/(#/&���( �"� (#$/(#/�#((#!� (�� �&�"(�& �' �� � (# $ #( (�� ��(� �' �(&����*�' �(� �#& (��' (# ��$$�"� '#�(+�&� �� &�'(�&/�!��� $&#��''#&� �" (���#!$)(�& !)'( ��&'( &�'(�&�.� � (�� ��(�� ��� '#�(+�&� �'')�' � �#!!�"��&���&&�� (# �" �� �' �� ������ ������� (� �"� (�� �&�"(�& (��( �( +� "#( &����*� ��(� �#& �"- !���� #��(�#" #" +���� �( ��' � &���- $ #((���

��� )'� #� "# "���(�*� !#(�#" �' �� �� �� ���� �(� � #+' (�&#)�� (���&�"(�& +�(�#)( ���"� '(#&�� �" � ��'$ �- �'(� '# (�� '�.� #� (�� �� � (��( -#)��" '�"� �' � !#'( )" �!�(���

Page 190: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 191: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Glossary-1 HP DesignJet 2500CP and 2000CP Printers

��������

Page 192: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Glossary-2 HP DesignJet 2500CP and 2000CP Printers

�9�3+ #0 -$ 3,'21�

��9�#%0##�1� �#*1'31�

��9�#%0##�1� ��&0#,&#'2�

�9�� �+.�1��

� �!-312'!�

��9�*2#0,�2',% !300#,2�

���$!��' �����!�#���9�:�6'1 !�*' 0�2'-,�

���!�""���� � �9� 0#1-*32'-, &'%&#0

2&�, 2&# ,-+',�* 4�*3# -$ 2&# !�020'"%#1�

%'4',% � $',#0 %0'" -, 5&'!& 2&# .*-22#0 !�,

1#*#!2'4#*7 .-1'2'-, "-21 �," '+.0-4# .0',2

/3�*'27�

����9�..*'!�2'-,:�.#!'$'! �,2#%0�2#" �'0:

!3'2�

��$� !�#�9�-0 2&# ��::� ',2#0$�!#�

2&# "�2� 20�,1+'11'-, 0�2# #25##, 2&#

!-+.32#0 �," 2&# .*-22#0 � '21 .#0 1#!-,"��

����!��#����� !��# ����9� .0',2 +-"#

', 5&'!& .*-22',% '1 .#0$-0+#" 5&'*# 2&#

!�00'�%# '1 +-4',% ', #'2&#0 "'0#!2'-,�

�������9� 1203!2'-, 2- +-4#+#,2�

��)�!����"9� .�0�**#* ',2#0$�!# 12�,"�0"�

��9�#%0##�1� �#*1'31�

��9�-+.32#0:�'"#" �#1'%,�

������9��*' 0�2'-,�

���9�-+.32#0:�'"#" ��,3$�!230',%�

��!!���� �&�"9�&# �6'1 �*-,% 5&'!& 2&#

!�00'�%# +-4#1� ��:�6'1��

��!!���� 9�',# 1#,1-0�

��!#!����9�0',2 !�020'"%# �.#,��

���#!����"9� .�0�**#* ',2#0$�!# 12�,"�0"�

������$#9�$ ,-88*#1� 2#12',% -$ ,-88*#1

7 $'0',% 2&#+ -,# 7 -,#�

�����"$�9� .0-%0�++',% +#2&-" 31#"

2- +','+'8# "�2� #00-01 5&#, "�2� �0#

20�,1$#00#"� ��� ���02 -$ � "#$','2'-, $0-+

�� ������ ������� ���������� � �� �����

��� �� � ��, �� �',!*�'0 � ���

��9�#,2'+#2#0�1��

�$"#���! ������!"9�� $'#*" 13..-02

#,%',##01�

���)"�(� ��##�!"9�-"#*1 �� �� �,"

��� ���

��#� ��" ��'9�#04'!# +-,'2-0�

��9�#!' #*�1��

��9�'0#!2 !300#,2�

�� ��#���9�&# 1#*#!2'4# 0#"3!2'-, -$ 2&#

,3+ #0 -$ "0-.1 .*�!#" -, 2&# +#"'�� ',

-0"#0 2- .0#4#,2 �, #6!#11 -$ ',) -, 2&# +#:

"'��

��" ��' ��#�9�#04'!# +-,'2-0�

��" ��' ��"#9�, ',2#0,�* *-%'!�* +�.� ',

15�2& $-0+�2� !-,2�',',% "�2� 0#.0#1#,2',%

%0�.&'!�* - (#!21�

��9���:����� �'!0-�-$2 �'1):�.#0�2:

',% �712#+�

� �9�-2�1� .#0 ',!&� 2&# .*-22#0�1 0#1-*3:

2'-, -$ 0�12#0 '+�%#1 -, 2&# +#"'��

���9�7,�+'! ��,"-+:�!!#11 �#+-07�

�!�%� !����!9�*�2#, 0-**#0�

�!�%�)!����! ���!9�#*'!�* %#�0 �2 0'%&2:

&�," 1'"# -$ "0'4# 0-**#0�

Page 193: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Glossary-3HP DesignJet 2500CP and 2000CP Printers

�'�+�'<�� �/ '-'%530/+% %+3%6+5 5*#5 130=

7+&'4 +/165 50 #/05*'3 '-'%530/+% %+3%6+5�

�(30.������� � ��� �� ����� �� � �

� ������ ��'33+#.="'$45'3 ������

� �0/(+)63#5+0/ &#5# 64'& $: 40(58#3' 50

%0/530- +/165 #/& 065165 $'58''/ 5*' %0.=

165'3 #/& 5*' 1-055'3�

���<�#5# !'3.+/#- '#&:�

�*)- �-�"�<!*' #.06/5 0( 64' # 1-055'3

4*06-& 8+5*45#/& 8+5*065 6/&6' .#+/5'=

/#/%'�

���/(�.� &"%))�'(<�0&'-4 ����� #/&

�� ����

��<�95'/&'& �#1#$+-+5: �035� �� �+=

!30/+%4 01'3#5+/) .0&'��

���<�-'%53+%#--: �3#4#$-' '#&=�/-:

�'.03:�

�"��)'%$��( #%�*"�<!*' '26+7#-'/5 0(

5*' ����� � ������ 0( 13'7+064 .0&'-4

+/ 5*' �'4+)/�'5 4'3+'4� �08'7'3� 5*' '-'%=

530/+%4 .0&6-' +4 03&'3#$-' #4 0/' 1#35� :06

4*06-& /05 01'/ +5�

����<�3#4#$-' �30)3#..#$-' '#&=

�/-: �'.03:�

��<�-'%53045#5+% &+4%*#3)'�

�<�')3''�4� �#*3'/*'+5�

��"#<� 5:1' 0( .'&+#�

�"%, #%��<!*' 1-055+/) 0( +.#)'4 5*#5

*#7' #-3'#&: $''/ 3#45'3+;'& $: %0.165'3

40(58#3' #/& &0 /05 /''& 50 $' 3#45'3+;'& $:

5*' 1-055'3 +54'-(�

�)<(005�(''5

��"�/)%$�$�<!*' 1-#%'.'/5 0( &054 50

%3'#5' # 7+46#- '(('%5 0( &+(('3'/5 %0-034 03

&+(('3'/5 4*#&'4 0( )3#:�

��"���" ���'< +)*5=*#/& &3+7'=30--'3 )'#3�

��<�'8-'55=�#%,#3&�

��/��<�3'%63403 0( ��=����

��/����<�'8-'55=�#%,#3&�4 45#/&#3&

)3#1*+%4 -#/)6#)' (03 +54 1-055'34�

��/���<�'8-'55=�#%,#3& #45'3 !3#/4=

('3 �#/)6#)'�

�.<�'35;�

�<�/5')3#5'& �+3%6+5�

<�/45+565' 0( �-'%53+%#- #/& �-'%530/=

+%4 �/)+/''34�

�$<�/%*�'4��

��<�/165��65165

��<�401301+-+% #-%0*0-�

�&(<�/%*�'4� 1'3 4'%0/&�

�<�+-0$:5'�4�

��$�/�<� �#1#/'4' %*#3#%5'3 4'5�

��$ �<� �#1#/'4' %*#3#%5'3 4'5�

��-)�<�+-0$:5'

!�<�+-0)3#.�4��

��<�+-0)3#.�4��

���<�0%#- �3'# �'5803,�

"�<�06/&�4��

��<�+)*5=�.+55+/) �+0&'�

"�$� (�$(%'<�#33+#)' ����

#<�'5'3�4�

#�'��$<�#35 0( 5*' .'&+# 0/ 8*+%* 5*'

1-055'3 +4 +/%#1#$-' 0( 13+/5+/)�

��-)�<�')#$:5'�

Page 194: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Glossary-4 HP DesignJet 2500CP and 2000CP Printers

�����;��3%$ ).34%!$ /& -%$)5-�� �(%

-!4%2)!, /. 7()#( 4(% '2!0()#3 !2% 0,/44%$�

0!0%2� 42!.3,5#%.4 -!4%2)!,� 6%,,5-� &),-� /2

30%#)!, 0!0%2�

����� �'�";�(% !8)3 !,/.' 7()#( 4(% -%<

$)! -/6%3� � <!8)3� 0!0%2 !8)3��

����� ���;� 3)45!4)/. ). 7()#( -%$)!

"%#/-%3 ",/#+%$ ). 4(% 0,/44%2 -%#(!.)3-3�

�����*��� ��%�!;�).#(<!2- ,%6%2�

�����*����#� �����!�#���;�%$)!<3%.3/2

#!,)"2!4)/.�

�����*"��"�! �����!�#���;�%$)!<,%.'4(

#!,)"2!4)/.�

���;�� /& !. ).#(�

�����$� ��"" #���;�(% 4)-% .%#%33!29

&/2 ).+ 4/ $29 35&&)#)%.4,9 "%&/2% 4(% 0,/44%2

#!. 0,!#% -/2% ).+ !$*!#%.4 4/ )4�

�� ;�/$5,!2 �.054�54054�

��;�),,)-%4%2�3��

����#�! ����;�%26)#% -/.)4/2�

��*� �;�)#2/�/&4 �)3+<�0%2!4).' �93<

4%-

�� ����#�%� ��#���;�. ��� #/--!.$

4(!4 ).$)#!4%3 4/ 4(% 0,/44%2 4(!4 )4 7),, 2%<

#%)6% !,, $!4! !,2%!$9 ). 4(% /2$%2 ). 7()#(

)4 3(/5,$ "% 0,/44%$�

���*�'�" ��� "("#��;� 3934%- 7(%2%"9

).+ )3 05-0%$ 4/ 4(% #!242)$'%3 &2/- ! 2%3<

%26/)2 4(!4 $/%3 ./4 -/6% 7)4( 4(% #!22)!'%�

��;�2/'2!--!",% �22!9 �/')#�

����##�; � 3%4 /& 0%.3 &/2 7()#( 7)$4( !.$

� 3(!$).' !2% $%&).%$ 53).' 4(% 3%450 3(%%4

/2 4(% '2!0()#3 3/&47!2%�

����! �'�")�%$)! !8)3 � <!8)3��

��!�#(;�. %22/2<#(%#+).' -%4(/$ &/2 ).<

&/2-!4)/. 42!.3&%2 "%47%%. ! #/-054%2

!.$ ! 0%2)0(%2!, $%6)#%� �!2)49 )3 53%$ 4/

#(%#+ 4(% !##52!#9 /& ").!29 $!4!�

��"";� -/6%-%.4 /& 4(% #!22)!'% &2/- ,%&4

4/ 2)'(4� /2 &2/- 2)'(4 4/ ,%&4� !3 )4 0,/43 4(%

'2!0()#�

��"" ��%����;�(% $)34!.#% 4(!4 4(% -%<

$)! !$6!.#%3 "%47%%. #!22)!'% 0!33%3�

��;�%23/.!, �/-054%2�

���;�2).4%$ �)2#5)4 �33%-",9�

���;�� �6%. 4(/5'( 4(% ).+*%4 0,/44%2 (!3

./ 0(93)#!, 0%.3� 4(% ,).%3 )4 $2!73 -!4#(

4(% !442)"54%3 &/2 0%.3 .5-"%2%$ � 4(2/5'(

). 4(% !00,)#!4)/. 3/&47!2%� ��%% !,3/

:0!,%44%���

�� �/-%4)-%3 53%$ ).34%!$ /& :02).4 #!2<

42)$'%��

�����*�!� ��%�!;�).#(<7(%%, ,%6%2� -%<

$)!<*!- ,%6%2�

�)�2).4%2 �/" �!.'5!'%� $%6%,/0%$ "9

�%7,%44<�!#+!2$ 4/ ')6% 3/&47!2% !00,)#!<

4)/.3 -/2% */"<,%6%, $%6)#% #/.42/, !.$ 4/

02/6)$% $%6)#% 34!453 ).&/2-!4)/. 4/ 4(% !0<

0,)#!4)/.�

���#�� !����!)�2)6% 2/,,%2�

���# $���#(;�2).4 15!,)49�

��;�2).4%2 �!.!'%-%.4 �!.'5!'%�

���;�!24 �5-"%2�

��&�! �(���;�(% 37)4#().' /& 4(% 0,/44%2

/&& !.$ 4(%. /. !'!).�

�!���!( ����!";#9!.� -!'%.4!� 9%,,/7�

",!#+�

�!��# $���#(;�,/4 15!,)49

�!��$�# ��� ��;�%7,%44<�!#+!2$�3

02/$5#4 ,).% /& ,!2'%<&/2-!4� 0%. !.$ 4(%2<

-!,<).+*%4 0,/44%23�

Page 195: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Glossary-5HP DesignJet 2500CP and 2000CP Printers

��8�1(/!9�% 0$ �+ 1(�0%+*�

�8��* +)9 ��!// �!)+.5�

%�&'�%8�� )�0.%4 +" +0/� +. ,%4!(/�

3$!.! !��$ ,%4!( %/ !"%*! �5 � �%0� �%0

0$�0 %/ 7+*� 3%(( ,.%*0 � +0 +* 0$! ,�,!.�

�%0 0$�0 %/ 7+""� 3%(( (!�2! 0$! �.!� �(�*'�

� )!0$+ "+. !"%*%*# � ,(+0 %.!�0(5 %*

0!.)/ +" 0$! ,%4!(/ .�0$!. 0$�* �/ 2!�0+./�

%�&'�% �!��� $%#��&&#%8�+"03�.! 0$�0

�+*2!.0/ #.�,$%�/ �0� 0+ ,%4!( "+.)�0�

%� �'�)� �(!���',8�$! .�0%+ +" 0$!

�)+1*0 +" 3�0!. 2�,+. ��01�((5 ,.!/!*0 %*

0$! �%. 0+ 0$! #.!�0!/0 �)+1*0 ,+//%�(! �0

0$! /�)! 0!),!.�01.!� �".+)�������

� ��� �� ����� �� � � ������

��!..%�)9�!�/0!. ������

%�&# ('�#"8 )!�/1.! +" %)�#! /$�.,*!//

!4,.!//! �/ � *1)�!. +" (%*!/ ,!. 1*%0

(!*#0$� �$!* .!"!..%*# 0+ ,(+00!./� � .!//9

��(! .!/+(10%+* )!�*/ 0$! /)�((!/0 )+2!

0$! ,(+00!. ��* )�'! ,.+#.�))�0%��((5�

%!&8�++0 )!�* /-1�.!�

�8�!� 9�*(5 �!)+.5�

%#!�"8 �$�.��0!. /!0 ��/! +* 0$! ��0%*

�(,$��!0�

�-���-� �"'�%����8 /!.%�( %*0!."��!

/0�* �. %6! �5 0$! �(!�0.+*%� �* 1/0.%!/

//+�%�0%+* �0�* �. ��99��

�8/!! 7��9�����

&��8�!�+* �/��

&��#"��%, �# #%&8�! � �(1!� #.!!*�

&�%)��� !#"�'#%8��0� %/,(�5� %/,(�5

�0�� )+*%0+. )+ !�

��8�%*#(! �*9(%*! �!)+.5 �+ 1(!�

&��*8�%/�(%#*)!*0�

&$���� $�$�%8 ,�,!. /,!�%"%��((5 !2!(9

+,! �5 ��� "+. �� %*'&!0 ,(+00!./�

�� ��8�!.2+9�.+�!//+. �+ !�

&*�'�8�$�0 ,+.0%+* +" � .�3%*# ,(+00!

�!03!!* � 2�*�!/ +" 0$! .%2! .+((!. %* ���

)+ !� ��* ��� )+ !� 0$! .%2! .+((!. � 9

2�*�!/ $�(" � /3�0$ �0 � 0%)!� %* �����

)+ !� %0 )�5 � 2�*�! � "1(( /3�0$ +. $�(" �

/3�0$� !,!* %*# +* 3$!0$!. 0$! ,(+0 %/ �+(9

+. +. )+*+�$.+)!��

������8�.�*/)%//%+* �+*0.+( �.+0+�+( �

�*0!.*!0 �.+0+�+(�

'��'�-� �%%#%8 ,.%*09-1�(%05 !..+.

��1/! 3$!* 0$! *+66(!/ +* � ��.0.% #! �.!

*+0 ,!.,!* %�1(�. 0+ 0$! ��..%�#! �4%/� �$!

!..+. /$+3/ 1, �/ &�##! 2!.0%��( (%*!/�

'%�"& (��"'8�!/�.%�!/ � 05,! +" )! %�

0$.+1#$ 3$%�$ (%#$0 ,�//!/�

����8�$!.)�( �1.*9�* �*!.#5�

�� �8�*%2!./�( /5*�$.+*+1/ �!�!%2!.

�.�*/)%00!.�

("���%��'�#"� $%�"' !#��8 ,.%*0

)+ ! %* 3$%�$ ,(+00%*# %/ ,!."+.)! 3$%(!

0$! ��..%�#! )+2!/ %* +*! %.!�0%+*� �* *+

,(+00%*# %/ ,!."+.)! 3$%(! 0$! ��..%�#!

)+2!/ %* 0$! +,,+/%0! %.!�0%+*�

)� (!8 05,! +" /0.+*# ,�,!.�

��8�!.0%��(9(%*! /0.�%#$0*!//�

�-�+�&8�! %� �4%/�

�-�+�& �� ��%�'�#"8 ��1.��5 ��(%�.�0%+*�

�-�+�&8��..%�#! �4%/�

Page 196: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 197: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-1 HP DesignJet 430, 450C and 455CA Printers

�����

Page 198: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-2 HP DesignJet 430, 450C and 455CA Printers

��(%'&)�%$� �$!� /�

� &%,�' %*)"�)� �/�

��*'��. ��"��'�)�%$� �/�� �/����%'� &�'�%'#�$�� �/�&�'�%'#�$�� �/�

�� *() ��''����� �/�

�� *()�$���''����� ��/���''����/)%/����� ��()�$��� �/�

�"��$ ��')'����(� �/�

"��$ ������ �'%$)/&�$�" "���)� �/�

�$)�/()�)�� �'*(�� �/� ��/�

�&&"���)�%$ $%)�(� &�') $*#��'� /�

�'�� ��""� �"%)��.� /�

�*)%#�)�� ���" "��) #����$�(#� ��/�

���"&�') $*#��'� /����'+��� ��()� �/��

���"� �/�� ��/���#� �/�"��) #����$�(#� ��/�

'�#%+�$�� �/��$*#��' %� �''%'(�

(�'+��� �%$���*'�)�%$ &"%)� �/��(.()�#� �/�

)�()�$�� �/�� �/�� �/�� �/��

���" ((�#�".� �/&'%�"�#� �/�

���" �.�"�� ��'+��� ��()� �/�

���" �����$�(#(� &�') $*#��'� /��

��$��$�� )�() &�))�'$� /��

��*� '�)�� �$� &�'�).� ��/�

��""%,(� &'�#�'� ��/

��")� �/��''%'� �/�� �/��#%+�$� )�� ��''����� ��/�'�#%+�$�� �/��

("�&&�$�� /�(,�""�$�� �/�

��$�� '*$� �/��� �/��&�'�#�)�'(� �"��'�$�� �/��

��/�'%$��(� �$)�'����� ��/����"�(� /�

�"��!�'�� ��""(� /�$*#��' %� &"%)(�

(�'+��� �%$���*'�)�%$ &"%)� �/��

�"����$�� /�

�"%%#�$�� /�

�"%)��. �'�� ��""(� /�

�'*(�� �$)�/()�)��� ��/�

�*(��$�(��''���� �*���$��� ��/��'��)�%$� /�

��"��'�)�%$� ��*'��.� �/�

��"��'�)�%$� �"��'�$� &�'�#�)�'(� �/��

��# ���' ,��'�$�� ���"� �/�

��''����� $%�(.� �/�

��''����� �/�� /��-�(� �$�%��' )�()� �/�� �/���*(��$�(� �/���()�$�� )% #����

�� *()� �/����!� �/�

�'�+� #����$��(� ��/����� ��/�#%)%'� �/�� ��/�

�%$)'%"� �/��''%'� �/�'�#%+�$�� �/��

$%�(�� �/��� � ��/�

��''���� ((�#�".&�') $*#��'� /�&'%�"�#� �/�

��''���� -�(� ��'+��� ��()� �/��� �/��

��''����/)%/#���� ��()�$��� /�

Page 199: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-3HP DesignJet 430, 450C and 455CA Printers

��,.,#�!��)(.#(/#.3 *,)�&�'� �41�,'4/*� 4

��,.,#�!�� ��,,#�!�� ,�')0#(!� �4��

��,.,#�!�-�)(.#(/)/-&3 ,�$��.��� �4 ,)(.4*�(�& &#!".� �4�*�,. (/'��,-� �4��,)/�&�-")).#(!� 4�

��,.,#�!�-� 4�� 4 � 4�� �/&.3� �4#��(.# #��.#)(� �4�'#-�&#!(��� 4��(/'��, ) �

-�,0#�� �)( #!/,�.#)( *&).� �4� *,#(.� ��4-�,0#�#(!� ��4

��(.,)(#�- #(.�, ��� ���&�-� �4��

�"�,!�� -.�.#�� ��4�

�"�--#- ���'� �4 � �4��

�&��(#(!��,.,#�!� �)(.��.-�*��-� �4�,#0� ,)&&�,� 4�*&)..�,� 4�

�&��,#(! ."� ������ �4��

�&)!!#(! #( -�,0#�� -.�.#)(� ��4

�)�.#(!� '��#�� 4��

�)&),�)( #!/,�.#)(� %�3� �4��"/� �"�(!�-� 4��#(%-� 4��(/'��, ) *&).-�

-�,0#�� �)( #!/,�.#)( *&).� �4�

�)&), �&#!('�(. �/�&#.3� .�-. *�..�,(� 4

�)&), ��,#�.#)(� .�-. *�..�,(� 4��

�)''/(#��.#)(� *&)..�,4�)'*/.�,� �4�

�)'*�.#�&� �)�/'�(.�.#)(� �4�

�)( #!/,�.#)(� *&).� -�,0#��� �4�

�)( #!/,�.#)( *,)���/,������� ')��& ��� �4��

�)(.#(/#.3 *,)�&�'� ��,.,#�!�� �4

�)0�, -�(-),� �4�

�)0�, ��(-),-� *,)�&�'� �4�

�)0�,-� *�,. (/'��,-� �4�

�/-.)'�, �2*��.�.#)(-� *,#(. +/�&#.3� 4�

�/..�,� *,)�&�'� �4�

��.�� ,)(.4*�(�& &#!".� �4�

��.� �#-*&�3� �4�

��.��.#(! ."� '��#� ��!�-� ��4�

�#,. )(��,,#�!� 1"��&� 4�*/&&�3� �4 � �4��-&#��, ,)�� 4�

�#,.3�(�)��, -.,#*� 4�*��-� �4*/&&�3� 4�

�#-*&�3 ��.�� �4�

�#-*&�3 &#-.� ��4

�#-.�(��� ��,,#�!�4.)4'��#�� ��4

�). !�#(� 4��

���� ����� �4�*�,. (/'��,-� �4�

�,#0� ��&.� ,�')0#(!� �4��

�,#0� �)&&�,� *�,. (/'��,� �4��

�,#0� ,)&&�,� �4�� 4�� 4�����,#(!-� 4�� �/&.3� 4��,��#/-� 4��,�#(-.�&&#(!� �4�,�')0#(!� �4��

�,#0�4��&. */&&�3� ,�')0#(!� �4��

�,#0�, �)( #!/,�.#)(� 4�

�,#0�4,)&&�, !��,� ,�')0#(!� �4��

�,)* ��.��.),� ��-�(�� ) � ��4

�,)* 0)&/'� ��/-#(! ��(�#(!� 4��

�/.3 �3�&�� 4�

��,."� �4�

���� ��4�

��!�-� ��.��.#(! '��#�� ��4�

Page 200: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-4 HP DesignJet 430, 450C and 455CA Printers

������ 3�� 3�� �3�� ��3 �& �+$("� 3���)(- (-,�

, +/$� �)(!$".+�-$)( *&)-� 3�� ++)+� �3 ')� & ��� �)(!$".+�-$)( *+)� �.+ � 3��

& �-+$��&�)(-��-� ��+-+$�" � �3��� +/$� � ,-� 3�

�& �-+)($�,� � +/$� � ,-� 3��

�& �-+)($�, �)�.& � *�+- (.'� +� �3��

& �-+)($�, ')�.& � �3�� 3�� �3�� ��3�+ ')/$("� 3��

�& �-+),-�-$� �$,�#�+" �+ ��.-$)(,� 3

(�)� +� ,-+$*� �3��+ ')/$("� 3�

�(�)� + �-+$*� *�+- (.'� +� �3��

(�)� + ,-+$*� �3 � �3�� 3�

(�)� +� ' �$�3�1$,� 3�

(�)� +,� ��++$�" �1$, � (�)� + ,-+$*�� ��3

(�)� +3,-+$* ,&)-,� �3

(�3*)$(- ���.+��2� 3�

(�3�)/ +,� + ')/$("& !-� 3��+$"#-� 3��

("�"$(" " �+� �3

("�"$(" & / +*+)�& '� �3 ,.**)+-� + ')/$("� 3��

(- +$(", +/$� ')� �� 3�, +/$� ')� �� 3��

�(-+2 �&�- (� *�+- (.'� +� �3��

(-+2 *&�- (� + ')/$("� 3�

(/$+)(' (-�& �)(�$-$)(,� �3��

++)+,� ������ �3

1�#�(" �,, '�&$ ,� �3�

�1- +(�& �+$(- � +/ +,� *�+- (.'� +,� �3��

1-+� ' ')+2� 3�

!��-)+2 ,*$--))(� 3��

!�(� ��3�

! ����%� *),$-$)(�&� ��3

!$� +,� ' �$�� �3��

!$&& � (,$-2� .( / (� �3��

!$+'0�+ � + & �, �, +/$� �)(!$".+�-$)( *&)-� 3��

!$+'0�+ �)� � 3�

�$+'0�+ � /$,$)(� &�- ,-� �3�

!&�,# ��� ����� ��3�

!&)0 ')� � ��3�

!+$�-$)(� �3 ,&$� + +)�� �3�

�+)(- ��( &� � +/$� � ,-� 3�

!+)(- *�( &% 2,� 3����,� 3�

�+)(- ��( & �/ +&�2� *�+- (.'� +,� �3�

�+)(-3��( & �,, '�&2� + ')/$("� 3��

" �+��$& ��'� �3 ("�"$("� �3

"+$**$(" -# ' �$�� ��3�

�+).(�� �& �-+$��&� 3�

#�(�,#�%$("� ��3

#)& , !)+ / (-$&�-$)(� , +/$� ,-�-$)(� ��3�

#. �#�(" ,� �3�

#.'$�$-2� + &�-$/ � �3��

$� (-$!$��-$)(� ��+-+$�" � 3�

$(�)'*�-$�& ' �$�� �3��� �3��

Page 201: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-5HP DesignJet 430, 450C and 455CA Printers

','2'�*'8�2'-,+#!&�,'!�*� 9�.0',2#0� 9�

',)!-*-0� �9� -, 0-**#0� �9.0-4'"',%� ��9�1#.�0�2-0� �91+#�0',%� �9�� �9� 1.'**',%� �91.0�7� �9��

',) 1#.�0�2-0� ��9�

',.32�-32.32 ',2#0$�!#1� ��9�

',12�**',% � ��� -0 ��� ����� �9�

',2#0$�!#1',.32�-32.32� ��9�.�0�**#*� ��9�1#0'�*� ��9�

�#2�'0#!2� ��9�

*�12 1712#+ #00-0� 9��

���� !�00'�%#� ��9

���1� 9

*#$2 #,"9!-4#0� 0#+-4',%� �9��

*#,%2& -$ *',#1� �9�

*'$#2'+#� �9�

*',#*#,%2&� �9�1#,1-0� �9�� ��9� ��9� ��9

�',# �#,1-0,-2 !�*' 0�2#"� �9.0- *#+� �9

*',# 1#,1-0� ,-2 !�*' 0�2#"� 9�

*',#�0 #,!-"#0 �-, !�00'�%#�� ��9

�'/3'"1� �9

�-�" �#"'�� $0-,29.�,#* *'%&2� 9

+�', ���� ��9

��',1� �9

+�0)1� 12�05&##*� �9��

+�1)#" ���� �9�� �9�� ��9

+#!&�,'!�* ','2'�*'8�2'-,� 9�

�#"'�� �9�� �9��!-,2',3-31*7 !0�1&#1� �9�$0-,29.�,#* *'%&2� 9

+#"'�� �9� �6'1� �9�#,!-"#0 2#12� 9�� 9��

#"%#1� "#2#!2',%� ��9#6.�,1'-,� �9�$�3*2� �9�(�+� �9�� 9��� ��9�+-2-0� 9"#$#!2'4#� �9�0#+-4',%� �9�

1#,1-0� 9� ��9 2&'!),#11� �9�27.#� ',!-00#!2� �9��

+#"'� �6'1� �#04'!# �#121� 9��

�#"'� �-�"',%� .0- *#+� �9

+#+-07� 31�%#� ��9�

���� ��9�

+-"3*�0 2#12� 9��

+-'1230#� -, .*-22#0� �9�

+-,- !-,$'%30�2'-,� )#7� 9��

+-2-0� !�00'�%#� ��9

+-4',% 2&# !�00'�%#� ��9

�- "#$#!21 $-3,"� �0',2 �3�*'27 �*-2� �9��

,- ,#%�2'4# +-2'-,� ��9�

�- �-5#0 ��� .0- *#+� �9�

,-'1#� !�00'�%# 5&##*� �9�

�-'17� ��00'�%#� �9

�-88*# �0',2� 2#12 .�22#0,� �9�

�-88*#1+'1"'0#!2#"� �9�

Page 202: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-6 HP DesignJet 430, 450C and 455CA Printers

-.3 /1)-3)-'� :

-.99+%2� �:�� :�"+.#*%$� :��&!4+38� :��,)2$)1%#3%$� :��

�"2314#3).-2� �:�

.)+� �:�� �:��2+)$%1 1.$� �:�

./3)#!+ +)-% 2%-2.1� ��:�

./3)#!+ 2%-2.1� �:�

.1)%-3!3).- .& /+.3� ��:�

.43/43 &1., 3%232� �:

.5%1$1)5%� �:�!22%,"+8� 1%,.5)-'� �:��

�5%1$1)5% 22%,"+8� /!13 -4,"%1� :��

�5%1$1)5% �%#(!-)2,2� /!13 -4,"%1� :��

�!-%+ 22%,"+8� /!13 -4,"%1� :��

/!1!++%+� )-3%1&!#%� ��:�#!"+%2� :�

/!1)38� ��:�

�!13 �4,"%12�!)+� :���!)+ �%#(!-)2,2� :���!11)!'% 22%,"+8� :��!131)$'%2� :��.5%12� :�$.#4,%-3!3).-� :��� � ����� :��1)5% �.++%1� :���+%#31.-)#2 �.$4+%� :���-#.$%1 �31)/� :���-318 �+!3%-� :��%73%1-!+ /1)-3 2%15%12� :��1.-3 �!-%+ �5%1+!8� :���5%1$1)5% 22%,"+8� :���5%1$1)5% ,%#(!-)2,2� :���!-%+ 22%,"+8� :���)-#(!1, 22%,"+8� :���1),%1 22%,"+8� :���1)-3%1 �!"%+2� :��

/1)-3%1 24//.13� :��4)#* �%&%1%-#% �4)$%� :���.++&%%$ 22%,"+8� :�%15)#% �3!3).-� :���/)33..-� :���1!)+)-' �!"+%� :��2%12 �4)$%� :���:!7)2 �.3.1� :�� :!7)2 �.3.1� :��

�� � #!11)!'%� ��:�

/%-2� -4,"%1 .&�2%15)#% #.-&)'41!3).- /+.3� �:��

/)-#(:!1,+%5%1 +)-*!'%� 1%,.5)-'� �:��+)&3 ,%#(!-)2,� 1%,.5)-'� �:�2%-2.1� ��:�� ��:

�)-#(!1, 22%,"+8� /!13 -4,"%1� :��

/)-#(:!1, 2%-2.1� �:�

/.2)3).-!+ &%%$"!#*� ��:�

/.6%1#8#+%2� -4,"%1 .&�

2%15)#% #.-&)'41!3).- /+.3� �:��24//+8� ��:�/!13 .& %+%#31.-)#2 ,.$4+%� ��:

/.6%1 .-� 2%+&:3%23� �:�

�1%#!43).-2�+%#31.23!3)# �)2#(!1'%� �:��!&%38� �:�

/1),%1� ��:1%,.5)-'� �:��

�1),%1 22%,"+8� /!13 -4,"%1� :��

/1)-3 #!131)$'%2� ��:�

/1)-3 (%!$23.4#()-' ,%$)!� :�3.4#()-' 2%15)#% 23!3).-� :��

�1)-3 �4!+)38/1."+%,2� �:�� :��1.4"+%2(..3)-' �(%#*+)23� :�

/1)-3 04!+)38� �:�/+.3� :�

�1)-3 �4!+)38 �+.3 -!+89)-'� :�-. $%&%#32 &.4-$� :��

/1)-3:,.$% #(!1!#3%1)23)#2� ��:�

�1)-3%1 �.-&)'41!3).-� :�

Page 203: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-7HP DesignJet 430, 450C and 455CA Printers

�/'+1#/ �� #)0� ��/1 �2* #/0� �7��

�/'+1#/ �2--,/1� -�/1 +2* #/0� �7�

-/'+17.2�)'16 1/,2 )#0&,,1'+%� 7�

�/, )#*��') �00#* )6� �7���//'�%# �00#* )6� �7��,3#/ �#+0,/0� �7��211#/� �7��'+# �#+0,/� �7��#"'� �,�"'+%� �7��, �,4#/ ��� �7�/'+1 �2�)'16� �7�� 7�

�/,1#!1'3# #�/1& 1#/*'+�)� �7�

-2"")'+%� 7��

-2))#6� �7 � �7�� �7��� ��7�/#*,3'+%� �7��

���!�//'�%# �5'0�

0#/3'!# !,+$'%2/�1',+ -),1� �7� *#"'� �5'0�

0#/3'!# !,+$'%2/�1',+ -),1� �7�

�2'!( �#$#/#+!# �2'"#� -�/1 +2* #/0� �7�

���*#*,/6 20�%#� ��7������ '+01�))'+%� �7

/�01#/� ��7

/�01#/ '*�%# -/,!#00,/� ��7

�#�"6� $/,+17-�+#) )'%&1� �7�

/#�00#* )6� �7�

/#'+01�))'+%� "/'3# /,))#/� �7�

/#)�1'3# &2*'"'16� 7��� 7� )##"'+%� ),,*'+%�4'!('+%� 7��4�1#/ ,+ *�'+ ���� ��7�

/#)#�0#� $'/*4�/#� �7�

�#*,3�) �+" �+01�))�1',+� ��') �00#* )6 �+"�1�/ �&##) �00#* )6� �7�

/#*,3'+% �')7)'$1 *#!&�+'0*� �7�� #)1� �7��!�//'�%# *,1,/� �7��!�/1/'"%# !�//'�%#� �7��"/'3# #)1� �7��"/'3# /,))#/� �7��"/'3#7 #)1 -2))#6� �7��"/'3#7/,))#/ %#�/� �7��#)#!1/,+'!0 *,"2)#� �7��#+!,"#/ 01/'-� �7�#+%�%'+%7)#3#/ 02--,/1� �7��#+1/6 -)�1#+� �7��/,+17��+#) �00#* )6� �7��)#$1 #+"7!,3#/� �7��*#"'� *,1,/� �7��,3#/"/'3# �00#* )6� �7�-'+!&7�/* )#3#/ )'+(�%#� �7��-'+!&7�/* )'$1 *#!&�+'0*� �7��-/'*#/� �7�-2))#6� �7��/'%&1 /�!(#1� �7��/'%&1 #+"7!,3#/� �7��/,))#/� �7���,))$##" �00#* )6� �7 0#/3'!# 01�1',+� �7�0-'11,,+� �#0'%+�#1 �������� �7��� �7��1,- !,3#/� �7�1/�')'+% !� )#� �7��1/�')'+%7!� )# %2'"#� �7�

/#-�'/#" �00#* )'#0� �7�

/#-)�!#*#+1 -�/10� �7�

/#0'01�+!# ,$ *,1,/ "/'3#/� �7 � �7��

/'%&1 /�!(#1� /#*,3'+%� �7��

/'%&1 #+"7!,3#/� /#*,3'+%� �7��

/,)) *#"'�� ��7�

/,))#//#'+01�))'+%� �7�/#*,3'+%� �7��

/,))7$##"� �00#* )6� ��7�

�,))$##" �00#* )6-�/1 +2* #/0� �7/#*,3'+%� �7

���� �7�� ��7������ '+01�))'+%� �7

��7���7�� '+1#/$�!#� ��7�!� )#0� �7��

Page 204: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-8 HP DesignJet 430, 450C and 455CA Printers

���� ��5

��"!/4��0/%*).� �5���-)%)#.� �5�

��"!/4 �-!��0/%*).� �5�

.!'" /!./� +*2!-5*)� �5�

.!).*-.� ��5��*1!-� ��5�'%)!� ��5�� ��5�� ��5�(! %�� ��5�+%)�$5�-(� ��5�� ��5��!-1%�! �!./� �5�

.!-%�'� %)/!-"��!� ��5����'!.� �5��

�!-1%�!� �!./.� �5�

.!-1%�!�*)"%#0-�/%*) +'*/� �5� � 5�%)/!-+-!/%)#� �5��+-%)/%)#� �5��

(*)%/*-� �5�./�/%*)� �5�/!./.� �5�

�!-1%�! ��'%�-�/%*).� 2$!) -!,0%-! � 5�

�!-1%�! �* ! �� �5

�!-1%�! �* ! �� �5��

�!-1%�! �/�/%*)� +�-/ )0(�!-� �5��

.!-1%�! ./�/%*)� ��5-!(*1%)#� �5�

�!-1%�! �!./� .!).*-.� �5�

�!-1%�! �!./.� �5�� �5���%'� �5����%' �4�'!� �5���--%�#!� �5����--%�#! �3%.� �5��!'!�/-%��'� �5���'!�/-*)%�.� �5���-*)/ ��)!'� �5 (! %� �3%.� �5�(* 0'�-� �5� .!-1*�!)�* !-� �5�

.!-1%�%)# ��-/-% #!.� ��5

.!-1*�!)�* !-� �!-1%�! /!./� �5�

.$�-+)!.. *" %(�#!� ��5

����� ��5�

.'% !- -* � �5�� �5 � �5�� �5��� 5�� 5�� ��5�"-%�/%*)� 5�

.'%++%)# *" �!'/� �5 � �5��� 5�

.(!�-%)# *" %)&� 5��

.*"/2�-!� ��5

.+!�%"%��/%*).���0-��4� 5�!)1%-*)(!)/�'� (*%./0-!� 5�

.+%''%)# *" %)&� 5�

�+%//**)� +�-/ )0(�!-� �5��

.+%//**)� 5�� ��5"��/*-4�

.!-1%�! �*)"%#0-�/%*) +'*/� �5� -!(*1%)#� �5��� �5��

.+-�4� 5�

.+-!� %)# *" %)&� 5��

������ -!'!�.!�.!-1%�! �*)"%#0-�/%*) +'*/� �5�

./�-2$!!' (�-&.� 5�

./�/%� �$�-#!� ��5�

./*++%)# � /!./� �5� �5��

.2�/$� � 1�)�! �)#'!� %)�*--!�/� 5��

.2!''%)# *" �!'/� 5�

�4./!( �--*- �* !.� �5�� �5�

.4./!( !--*-.� )0(�!- *"�.!-1%�! �*)"%#0-�/%*) +'*/� �5�

/�+! *) ��-/-% #!.� �5

/!./� .!-1%�!� �5�

�!./.� �!-1%�!� �5�

/$!-(%./*- �%-�0%/� ��5�

/$!/�5� !--*-� 5�

/$%)5"%'( �(�#!� �5

�**'.� �5

/*+ �*1!-� -!(*1%)#� �5�

�-�%'%)# ���'!(%.+*.%/%*)! � �5�

Page 205: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

Index-9HP DesignJet 430, 450C and 455CA Printers

+�-/ )0(�!-� 5�

/-�%'%)# ���'!� �5�� ��5�#0% !� -!(*1%)#� �5�-!(*1%)#� �5��

/-�).'0�!)/� (! %�� 5�

�-*0�'!.$**/%)#� �5���-/-% #!.� 5��--*- �* !.� �5�

/-*0�'!.$**/%)#� +-%)/ ,0�'%/4� 5�

�-*0�'!.$**/%)# �$!�&'%./� �-%)/ �0�'%/4� 5�

����� 5�

0)!1!) "%'' !).%/4� 5�

0.�#!� '!1!' *"� �5�

�.!- �!..�#!.� �5�

0.!-5 !"%)! +�-�(!/!-.� �'!�-%)#� �5��

�.!-. �0% !� +�-/ )0(�!-.� 5��

1��00(� ��5

1!''0(� 5�

1!)/%'�/%*) $*'!.� ��5

�!-/%��' �%)! �/-�%#$/)!..� /!./ +�//!-)� 5

1!-/%��'5'%)! ./-�%#$/)!..� �5�

1%!2%)# /!./ *0/+0/� �5

2�-)%)#� ��5�

��/!-� ��-)%)#� �5�

2�/!-�*) !).�/%*)� ��5�*) (�%) �� � ��5�

2!�-%)# *" +�-/.� �5�

2%�&� ��5�

2%�&%)#� 5�

2%) *2 .!).*-� ��5

�5�3%. ��'%�-�/%*)�.!-1%�! �*)"%#0-�/%*) +'*/� �5��

�5�3%. �*/*-� +�-/ )0(�!-� 5��

�5�3%. �*/*-� +�-/ )0(�!-� 5��

Page 206: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution
Page 207: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

�� � ���� �����

���� �� �� ����� ������ �� ���� � ���� �����

��� ������� ���� ��� ������ ����� ����� ����� ����� ��� ������� �������� ���� ���� ��� ����� ������� ������� � �� � � ����

Page 208: HP DesignJet 430, 450C, and 455CA Printers Service Manual ... service manual.pdf · HP DesignJet 430, 450C and 455CA Printers General Definition of Safety Symbols International caution

What’s in This Book

This manual contains information necessaryto test, calibrate and service

� HP DesignJet 430 printers(models C4713A and C4714A)

� HP DesignJet 450C printers(models C4715A and C4716A)

� HP DesignJet 455CA printers(models C6080A and C6081A)

For information about using these printers,refer to the corresponding user andquick-reference guides.

The procedures described in this manual areto be performed by HP-qualified servicepersonnel only.