hybrid electric vehicle
TRANSCRIPT
HYBRID ELECTRIC VEHICLE
Chapter-1
INTRODUCTION
1.1 INTRODUCTION OF HYBRID ELECTRIC VEHICLE
A hybrid vehicle, abbreviated HEV, is one that uses both an internal combustion engine
(ICE) and an electric motor to propel the vehicle. Most hybrids use a high-voltage battery
pack and a combination electric motor and generator to help or assist a gasoline engine.
The ICE used in a hybrid vehicle can be either gasoline or diesel, although only gasoline-
powered engines are currently used in hybrid vehicles. An electric motor is used to help
propel the vehicle, and in some designs, capable of propelling the vehicle alone without
having to start the internal combustion engine.
The presence of the electric power train is intended to achieve either better fuel economy
than a conventional vehicle or better performance. There are a variety of HEV types, and
the degree to which they function as EVs varies as well. The most common form of HEV
is the hybrid electric car, although hybrid electric trucks (pickups and tractors) and buses
also exist. Modern HEVs make use of efficiency-improving technologies such as
regenerative braking, which converts the vehicle's kinetic energy into electric energy to
charge the battery, rather than wasting it as heat energy as conventional brakes do. Some
varieties of HEVs use their internal combustion engine to generate electricity by spinning
an electrical generator (this combination is known as a motor-generator), to either
recharge their batteries or to directly power the electric drive motors. Many HEVs reduce
idle emissions by shutting down the ICE at idle and restarting it when needed; this is
known as a start-stop system. A hybrid-electric produces less emissions from its ICE than
a comparably-sized gasoline car, since an HEV's gasoline engine is usually smaller than a
comparably-sized pure gasoline-burning vehicle (natural gas and propane fuels produce
lower emissions) and if not used to directly drive the car, can be geared to run at
maximum efficiency, further improving fuel economy.
1
HYBRID ELECTRIC VEHICLE
Chapter-2
HISTORY OF HYBRID ELECTRIC VEHICLE
2.1 HISTORY OF HYBRID ELECTRIC VEHICLE
In 1900 Ferdinand Porsche developed the Lohner-Porsche Mixte Hybrid, the first
gasoline-electric hybrid automobile in the world, a 4WD series-hybrid version of "System
Lohner-Porsche" electric carriage previously appeared in 1900 Paris World Fair. The
Mixte included a pair of generators driven by 2.5-hp Daimler IC engines to extend
operating range and it could travel nearly 65 km on battery alone. It was presented in the
Paris Auto Show in 1901. The Mixte broke several Austrian speed records, and also won
the Exelberg Rally in 1901 with Porsche himself driving. The Mixte used a gasoline
engine powering a generator, which in turn powered electric hub motors, with a small
battery pack for reliability. It had a top speed of 50 km/h and a power of 5.22 kW during
20 minutes.George Fischer sold hybrid buses to England in 1901; Knight Neftal produced
a racing hybrid in 1902.
Fig. 2.1 The first gasoline-electric hybrid vehicle
In 1905, Henri Pieper of Germany/Belgium introduced a hybrid vehicle with an electric
motor/generator, batteries, and a small gasoline engine. It used the electric motor to
charge its batteries at cruise speed and used both motors to accelerate or climb a hill. The
Pieper factory was taken over by Imperia, after Pieper died. The 1915 Dual Power, made
by the Woods Motor Vehicle electric car maker, had a four-cylinder ICE and an electric
motor. Below 15 mph (24 km/h) the electric motor alone drove the vehicle, drawing
power from a battery pack, and above this speed the "main" engine cut in to take the car
2
HYBRID ELECTRIC VEHICLE
up to its 35 mph (56 km/h) top speed. About 600 were made up to 1918. The Woods
hybrid was a commercial failure, proving to be too slow for its price, and too difficult to
service. The United States Army's 1928 Experimental Motorized Force tested a gasoline-
electric bus in a truck convoy. In 1931 Erich Gaichen invented and drove from Altenburg
to Berlin a 1/2 horsepower electric car containing features later incorporated into hybrid
cars. Its maximum speed was 25 miles per hour (40 km/h), but it was licensed by the
Motor Transport Office, taxed by the German Revenue Department and patented by the
German Reichs-Patent Amt. The car battery was re-charged by the motor when the car
went downhill. Additional power to charge the battery was provided by a cylinder of
compressed air which was re-charged by small air pumps activated by vibrations of the
chassis and the brakes and by igniting oxy-hydrogen gas. An account of the car and his
characterization as a "crank inventor" can be found in Arthur Koestler's autobiography,
Arrow in the Blue, pages 269-271, which summarize a contemporaneous newspaper
account written by Koestler. No production beyond the prototype was reported. The
hybrid-electric vehicle did not become widely available until the release of the Toyota
Prius in Japan in 1997, followed by the Honda Insight in 1999.While initially perceived
as unnecessary due to the low cost of gasoline, worldwide increases in the price of
petroleum caused many automakers to release hybrids in the late 2000s; they are now
perceived as a core segment of the automotive market of the future. More than 5.8 million
hybrid electric vehicles have been sold worldwide by the end of October 2012, led by
Toyota Motor Company (TMC) with more than 4.6 million Lexus and Toyota hybrids
sold by October 2012, followed by Honda Motor Co., Ltd. with cumulative global sales
of more than 1 million hybrids by September 2012, and Ford Motor Corporation with
more than 200 thousand hybrids sold in the United States by June 2012. Worldwide sales
of hybrid vehicles produced by TMC reached 1 million units in May 2007; 2 million in
August 2009; and passed the 4 million mark in April 2012.As of October 2012,
worldwide hybrid sales are led by the Toyota Prius liftback, with cumulative sales of 2.8
million units, and available in almost 80 countries and regions.The United States is the
world's largest hybrid market with more than 2.5 million hybrid automobiles and SUVs
sold through October 2012, followed by Japan with more than 2 million hybrids sold
through October 2012 The Prius is the top selling hybrid car in the U.S. market,
surpassing the 1 million milestone in April 2011. Cumulative sales of the Prius in Japan
reached the 1 million mark in August 2011.
3
HYBRID ELECTRIC VEHICLE
Chapter-3
TYPES BY DEGREE OF HYBRIDIZATION
3.1 FULL HYBRID
Full hybrid, sometimes also called a strong hybrid, is a vehicle that can run on just the
engine, just the batteries, or a combination of both. It use a gasoline engine as the primary
source of power, and an electric motor provides additional power when needed. In
addition, full hybrids can use the electric motor as the source of population for low-speed,
low acceleration driving, such as stop-and-go traffic or for backing up.Ford's hybrid
system, Toyota's Hybrid Synergy Drive and General Motors/Chrysler's Two-Mode
Hybrid technologies are full hybrid systems The Toyota Prius, Ford Escape Hybrid, and
Ford Fusion Hybrid are examples of full hybrids, as these cars can be moved forward on
battery power alone. A large, high-capacity battery pack is needed for battery-only
operation. These vehicles have a split power path allowing greater flexibility in the drive-
strain by inter-converting mechanical and electrical power, at some cost in complexity.
Fig. 3.1 Full hybrid vehicle-Toyota Prius (2nd generation)
3.2 MILD HYBRID
Mild hybrid, sometimes also called a stop-start hybrid is a vehicle that cannot be driven
solely on its electric motor, because the electric motor does not have enough power to
4
HYBRID ELECTRIC VEHICLE
propel the vehicle on its own. Stop-start technology conserves energy by shutting off the
gasoline engine when the vehicle is at rest, such as at a traffic light, and automatically re-
starting it when the driver pushes the gas pedal to go forward. Mild hybrids only include
some of the features found in hybrid technology, and usually achieve limited fuel
consumption savings, up to 15 percent in urban driving and 8 to 10 percent overall cycle
A mild hybrid is essentially a conventional vehicle with oversize starter motor, allowing
the engine to be turned off whenever the car is coasting, braking, or stopped, yet restart
quickly and cleanly. The motor is often mounted between the engine and transmission,
taking the place of the torque converter, and is used to supply additional propulsion
energy when accelerating. Accessories can continue to run on electrical power while the
gasoline engine is off, and as in other hybrid designs, the motor is used for regenerative
braking to recapture energy. As compared to full hybrids, mild hybrids have smaller
batteries and a smaller, weaker motor/generator, which allows manufacturers to reduce
cost and weight. Honda's early hybrids including the first generation Insight used this
design, leveraging their reputation for design of small, efficient gasoline engines; their
system is dubbed Integrated Motor Assist (IMA). Starting with the 2006 Civic Hybrid,
the IMA system now can propel the vehicle solely on electric power during medium
speed cruising. Another example is the 2005-2007 Chevrolet Silverado Hybrid, a full-size
pickup truck. Chevrolet was able to get a 10% improvement on the Silverado's fuel
efficiency by shutting down and restarting the engine on demand and using regenerative
braking. General Motors has also used its mild BAS Hybrid technology in other models
such as the Saturn Vue Green Line, the Saturn Aura Greenline and the Mailbu Hybrid.
5
HYBRID ELECTRIC VEHICLE
Fig. 3.2 Mild hybrid vehicle-Honda Civic
Chapter-4
TYPES OF HYBRID ELECTRIC VEHICLE
4.1 SERIES TYPE HEV
In series hybrids, only the electric motor drives the drive-strain, and the ICE works as a
generator to power the electric motor or to recharge the batteries. The battery pack can be
recharged through regenerative braking or by the ICE. Series hybrids usually have a
smaller combustion engine but a larger battery pack as compared to parallel hybrids,
which makes them more expensive than parallels. This configuration makes series
hybrids more efficient in city driving. The Chevrolet Volt is a series plug-in hybrid,
although GM prefers to describe the Volt as an electric vehicle equipped with a "range
extending" gasoline powered ICE as a generator and therefore dubbed an "Extended
Range Electric Vehicle" or EREV. Means In a series driveline, only an electric motor is
connected to drive the wheels. In it gasoline motor turns a generator, ggenerator may
either charge the batteries or power an electric motor that drives the transmission and at
low speeds is powered only by the electric motor. In a series-hybrid design, the engine
turns a generator, which can charge batteries or power
an electric motor that drives the transmission. The internal combustion engine
never powers the vehicle directly.
6
HYBRID ELECTRIC VEHICLE
Fig. 4.1 Series type HEV
Fig. 4.2 Series type HEV
This diagram shows the components included in a typical series hybrid design. The solid-
line arrow indicates the transmission of torque to the drive wheels. The dotted-line arrows
indicate the transmission of electrical current.
7
HYBRID ELECTRIC VEHICLE
Fig. 4.3 Power flow in series type HEV
4.2 PARALLEL TYPE HEV
In parallel hybrids, the ICE and the electric motor are both connected to the mechanical
transmission and can simultaneously transmit power to drive the wheels, usually through
a conventional transmission. Honda's Integrated Motor Assist (IMA) system as found in
the Insight, Civic, Accord, as well as the GM Belted Alternator/Starter (BAS Hybrid)
system found in the Chevrolet Malibu hybrids are examples of production parallel
hybrids. Current, commercialized parallel hybrids use a single, small (<20 kW) electric
motor and small battery pack as the electric motor is not designed to be the sole source of
motive power from launch. Parallel hybrids are also capable of regenerative braking and
the internal combustion engine can also act as a generator for supplemental recharging.
Parallel hybrids are more efficient than comparable non-hybrid vehicles especially during
urban stop-and-go conditions and at times during highway operation where the electric
motor is permitted to contribute. Means in a parallel system, both the gasoline and the
electric motor are connected to the drive wheels. Gasoline motor,batteries which powers
8
HYBRID ELECTRIC VEHICLE
an electric motor,both can power the transmission at the same time and electric motor
supplements the gasoline engine. In a parallel-hybrid design, multiple propulsion sources
can be combined, or one energy source alone can drive the vehicle. The battery and
engine are both connected to the transmission. The vehicle can be powered
by internal combustion alone, by electric motor alone, (full hybrids), or a combination. In
most cases, the electric motor is used to assist the internal combustion engine.
Fig. 4.4 Parallel type HEV
9
HYBRID ELECTRIC VEHICLE
Fig. 4.5 Parallel type HEV
Diagram showing the components involved in a typical parallel-hybrid vehicle. The solid-
line arrows indicate the transmission of torque to the drive wheels, and the dotted-line
arrows indicate the flow of electrical current.
10
HYBRID ELECTRIC VEHICLE
Fig. 4.6 Power flow in parallel type HEV
4.3 SERIES-PARALLEL TYPE HEV
Series-Parallel type also called Power-split hybrids have the benefits of a combination of
series and parallel characteristics. As a result, they are more efficient overall, because
series hybrids tend to be more efficient at lower speeds and parallel tend to be more
efficient at high speeds; however, the cost of power-split the hybrid is higher than a pure
parallel. Examples of power-split (referred to by some as "series-parallel") hybrid power-
strains include current models of Ford, General Motors, Lexus, Nissan, and Toyota.
Means a series-parallel hybrid design allows the vehicle to operate in electric motor mode
only or in combination with the internal combustion engine. In it characteristics of both
series and parallel type hybrid electric vehicle are used, it’s cost is more than both single
type HEV’s.
11
HYBRID ELECTRIC VEHICLE
Fig. 4.7 Series- parallel type HEV
Chapter-5
PARTS OF HYBRID ELECTRIC VEHICLE
5.1 ENGINE
It’s much same as other vehicles engine, but the size of hybrid electric vehicle engine is
small and it’s more fuel efficient.
Higher energy density than batteries,
1,000 pounds of batteries = 1 gallon (7 pounds) of gas.
It has three types
5.1.1 Gasoline engine
Gasoline engines are used in most hybrid electric designs, and will likely remain
dominant for the foreseeable future. While petroleum-derived gasoline is the
primary fuel, it is possible to mix in varying levels of ethanol created from
renewable energy sources. Like most modern ICE powered vehicles, HEVs can
typically use up to about 15% bio-ethanol. Manufacturers may move to flexible
fuel engines, which would increase allowable ratios, but no plans are in place at
present.
5.1.2 Diesel engine
Diesel-electric HEVs use a diesel engine for power generation. Diesels have
advantages when delivering constant power for long periods of time, suffering less
wear while operating at higher efficiency. The diesel engine's high torque,
combined with hybrid technology, may offer substantially improved mileage.
Most diesel vehicles can use 100% pure bio-fuels (biodiesel), so they can use but
do not need petroleum at all for fuel (although mixes of bio-fuel and petroleum are
more common). If diesel-electric HEVs were in use, this benefit would likely also
apply. Diesel-electric hybrid drive-strains have begun to appear in commercial
12
HYBRID ELECTRIC VEHICLE
vehicles (particularly buses); as of 2007, no light duty diesel-electric hybrid
passenger cars are currently available, although prototypes exist.
5.1.3 Hydrogen engine
Hydrogen can be used in cars in two ways: a source of combustible heat, or a
source of electrons for an electric motor. The burning of hydrogen is not being
developed in practical terms; it is the hydrogen fuel-cell electric vehicle (HFEV)
which is garnering all the attention. Hydrogen fuel cells create electricity fed into
an electric motor to drives the wheels. Hydrogen is not burned, but it is consumed.
This means molecular hydrogen, H2, is combined with oxygen to form water.
2H2(4e-) + O2 --> 2H2O(4e-). The molecular hydrogen and oxygen's mutual
affinity drives the fuel cell to separate the electrons from the hydrogen, to use
them to power the electric motor, and to return them to the ionized water
molecules that were formed when the electron-depleted hydrogen combined with
the oxygen in the fuel cell. Recalling that a hydrogen atom is nothing more than a
proton and an electron; in essence, the motor is driven by the proton's atomic
attraction to the oxygen nucleus, and the electron's attraction to the ionized water
molecule.
An HFEV is an all-electric car featuring an open-source battery in the form of a
hydrogen tank and the atmosphere. HFEVs may also comprise closed-cell
batteries for the purpose of power storage from regenerative braking, but this does
not change the source of the motivation. It implies the HFEV is an electric car
with two types of batteries. Since HFEVs are purely electric, and do not contain
any type of heat engine, they are not hybrids.
13
HYBRID ELECTRIC VEHICLE
Fig. 5.1 Cost per mile EV v/s Gasoline Engine
5.2 BATTERY
It store the energy generated from gasoline engine or during regenerative braking, from
the electric motor. It’s power the vehicle at low speed, it’s size is larger and holds much
more energy than non-hybrid electric vehicle.
Batteries rule the performance of the vehicle
They dictate how much power you get (kW)
They dictate how much energy you get (kWh)
A single cell dictates the battery voltage each cell mates two dissimilar materials
Fig. 5.1 Battery types
5.2.1 Batteries packaging
Cylindrical
14
HYBRID ELECTRIC VEHICLE
Fig. 5.2 Cylindrical type battery packaging
Prismatic
Fig. 5.3 Prismatic type battery packaging
Button
15
HYBRID ELECTRIC VEHICLE
Fig. 5.4 Button type battery packaging
Pouch
Fig. 5.5 Pouch type battery packaging
5.2.2 Basic Characteristics
16
HYBRID ELECTRIC VEHICLE
State of Charge (SOC)
Measured as a percentage of total battery energy (0-100%)
Typically should not go below 20%
Depth of Discharge (DoD)
Inverse of SOC
Power (kW)
Energy (kWh)
A-h
Typically used for power batteries
Cells often described in mA-h
C Rate
A normalized rate of power use to qualify testing
100% discharge divided by the time in hours
C2 means the discharge rate was 100% in ½ hour
C/2 means the rate was less aggressive – over 2 hours
Cycle Life
Always measured based on DoD
Ex. 1000 cycles at 80% DoD
17
HYBRID ELECTRIC VEHICLE
Fig. 5.6 Cycle life
Weight/Volume
Measures in terms of
W/kg and W-h/kg
W/l and W-h/l
18
HYBRID ELECTRIC VEHICLE
Fig. 5.7 Energy Densities
5.3 ELECTRIC MOTOR
It’s power the vehicle at low speed and assist the gasoline engine when additional power
is needed, it’s also convert otherwise wasted energy from braking into electricity and
store it in battery. Most of the electric machines used in hybrid vehicles are brushless DC
motors (BLDC). Specifically, they are of a type called an interior permanent magnet
(IPM) machine (or motor). These machines are wound similarly to the induction motors
found in a typical home, but (for high efficiency) use very strong rare earth magnets in
the rotor. These magnets contain neodymium, iron and boron, and are therefore called
Neodymium magnets. The magnet material is expensive, and its cost is one of the limiting
factors in the use of these machines.
5.3.1 Motor components
Rotating components
[1] Shaft
[2] Rotor
[3] Rotor fins
[4] Fan
19
HYBRID ELECTRIC VEHICLE
Housing components
[5] End bells / bearing housings
[6] Stator housing
[7] Cooling fins
[8] Junction box
[9] Fan shroud
Fixed components
[10] Seals
[11] Stator windings
[12] Core iron / lamination stack
[13] Bearings
Fig. 5.8 Motor Parts
20
HYBRID ELECTRIC VEHICLE
5.3.2 Components: Electric Motor – DC
Fig. 5.9 Components: Electric Motor – DC
5.3.3 Components: Electric Motor – AC
Fig. 5.10 Components: Electric Motor – AC
5.4 CONTROLLER
The controller is used to charge the battery or to supply the power to electric motor.
Converts Battery DC to a chopped DC power
Can chop in amplitude (DC) or frequency (AC)
Power is based on low voltage input signal
21
HYBRID ELECTRIC VEHICLE
4-20 mA or 0-5V
In other fields this is called a drive or inverter
Variable Frequency (AC)
Pulse Width Modulation (AC)
Buck Conversion (Reduce - DC)
Boost Conversion (Increase - DC)
5.5 GENERATOR
It convert mechanical energy from engine into electrical energy, which can be used by
electric motor stored in the battery. It’s also used to start the gasoline engine instantly.
5.6 POWER SPLIT DEVICE
It’s a gearbox connecting the gasoline engine, electric motor and generator. It allows the
engine and motor to power the car independently or in tandem and allows the gasaoline
engine to charge the batteries or provide power to the wheels as needed
22
HYBRID ELECTRIC VEHICLE
Fig. 5.11 Parts of HEV
Chapter-6
FEATURES OF HYBRID ELECTRIC VEHICLE
6.1 IDLE STOP
Idle stop turns off engine when the vehicle is stopped. When the brake is released, the
engine immediately starts. This ensures the vehicle is not using fuel, not creating CO2
emissions, when the engine is not required to propel the vehicle. At this time battery
supply the power to all accessories of vehicle like AC, DVD Player etc.
6.2 REGENERATIVE BRAKING
Regenerative braking converts otherwise wastage energy from braking into electricity and
store it in the battery. In regenerative braking the electric motor is reversed so that,
instead of using electricity to turns the wheels, the rotating wheels turns the motor and
23
HYBRID ELECTRIC VEHICLE
create electricity. Using energy from the wheels to turn the motor slows the vehicle down.
When decelerating, the braking system captures energy and stores it in the battery or
other device for later use, helping to keep batteries charged.
In motor case “Eb = V - IaRa“ Generally Eb < V
Here, Eb = Back emf of motor
V = Terminal voltage/Load side voltage
Ia = Armature current and
Ra = Armature resistance
But in regenerative braking system Eb > V, means the load supplies the power to motor.
6.3 POWER ASSIST
The electric motor provides extra power using current drawn from the battery to assist
ICE during acceleration. This power-assist mode enables the vehicle to use a smaller,
more fuel-efficient engine without giving up performance.
6.4 ENGINE-OFF DRIVE ELECTRIC VEHICLE MODE
In this mode the electric motor propels the vehicle at lower speeds. The ICE is not being
used during low acceleration, no fuel is being used and no emissions are being released.
When the hybrid is in this mode, it is essentially in an electric vehicle.
6.5 PLUG-IN HYBRIDS (PHEV)
A plug-in hybrid electric vehicle (PHEV), also known as a plug-in hybrid, is a hybrid
electric vehicle with rechargeable batteries that can be restored to full charge by
connecting a plug to an external electric power source. A PHEV shares the characteristics
of both a conventional hybrid electric vehicle, having an electric motor and an internal
combustion engine; and of an all-electric vehicle, also having a plug to connect to the
electrical grid. PHEVs have a much larger all-electric range as compared to conventional
gasoline-electric hybrids, and also eliminate the "range anxiety" associated with all-
24
HYBRID ELECTRIC VEHICLE
electric vehicles, because the combustion engine works as a backup when the batteries are
depleted.
Plug-in hybrid vehicles (PHEV) present a cleaner alternative to traditional vehicles, as
they use less oil and have lower emissions. PHEVs also use less oil than standard hybrid
electric vehicles (HEV), and at first glance seem to have lower emissions than HEVs.
PHEV with a range of 40 miles would have approximately half the emissions of a HEV if
it were powered by a carbon-free energy source, but would have higher emissions if 50%
of its electric power was generated by coal.
The Chevrolet Volt is a plug-in hybrid able to run in all-electric mode up to 35 miles.
25
HYBRID ELECTRIC VEHICLE
Chapter-7
ENVIRONMENTAL ISSUES CONCERNED WITH HEV
7.1 ENVIRONMENTAL ISSUES
Since the dawn of the modern era, consumption and distribution of energy has quickly
become mankind’s highest priority. However, the continued apathetic attitude that was
initially taken toward energy and its side effects can no longer be used. A new more
environmentally friendly source of energy has to be utilized in order to fulfil our own
needs otherwise we self-destruction while relying on non-renewable oil based methods. In
the last few decades two new technologies have emerged; the development and
implementation of Hybrid Electric Vehicles (HEVs) and more recently the Plug-in
Hybrid Electric Vehicles (PHEVs). These emerging technologies may make it possible
for the United States to adapt these technologies on a larger scale to reduce harmful
emissions and cut our dependence on foreign oil dramatically. However, the future of the
technologies will heavily depend on the everyday American consumer’s willingness to
forgo the ‘tried and true’ combustion engine for the infantile technologies of the HEV and
PHEV. With the introduction and continued popularity of HEVs and as well as the recent
hype over the PHEVs, the future of transportation in the United States is on the brink of
change. This project has objectives relevant to the aforementioned HEVs and PHEVs.
First, verify if independence of foreign oil is truly a possibility and how to accomplish
this feat. Second, identify the major motivators for the American consumers who
purchase these vehicles and how that can be used to increase the sales of HEVs and
PHEVs respectively. The third and last objective is to determine the future impact of the
all electric vehicle (EV).Earlier civilizations relied on a number of power sources such as
water to turn wheels, to run mills, fire to heat water and create steam, or windmills to turn
grinding stones. Since roughly the 17th century various forms of oil have been used, such
as kerosene, as fuel for lanterns. Even into the 18th, 19th, and early 20th centuries whales
were hunted for their blubber which could be converted into oil among other things. In
the more recent years with the invention of the combustion engine, which has not only
increased the shear amount of oil consumed annually but also drastically augmented our
dependence upon it in our daily lives. Our oil ‘addiction’ has lead us to the realization
26
HYBRID ELECTRIC VEHICLE
that our usage has its limits, not only does the environment suffer adverse effects because
of its use but our society is so dependent upon that if it were suddenly removed, most of
modern society would cease to function properly if it all. Without a reasonable alternative
this fate is all too possible and this has caused huge concerns over how, on a large scale,
we can change our consumption habits and create a cleaner energy for our use. Hybrid
cars have come a long way in the past 20 years, but most people are unaware they have
been around since the mid 1800s. The early electric vehicles at the turn of the 20th century
were expensive, problematic and not very powerful. Given certain weather conditions or
too steep a hill the electric vehicle of yesteryear was simply unable to perform up to our
expectations. With the introduction of the Ford Model T, a revolution in vehicles was
made. The Model T was cheaper and more powerful and was made relatively simplistic,
it also ran on a then abundant source of gasoline, and the United States could meet its
own internal demand enough so that it actually exported its excess to European countries
such as France and Britain. Ultimately, the Model T made the early EVs defunct and as
such fell off the radar until events like the 1973 oil crisis and 1979 energy crisis where the
electric technologies were eventually reconsidered. The first electric car is claimed to
have been built between 1832 and 1893 by Robert Anderson of Scotland. From then until
the late 1800s, when they became efficient enough to use as taxi cabs in England, the cars
were heavy, slow and impractical. Modern batteries development in the early 1900s
pushed the development of more efficient, reliable, and practical electric cars in that
period. The Hybrid came about in 1900 in Belgium, when a small gasoline engine was
paired with an electric motor. During normal operation the electric motor charged
onboard batteries, but during acceleration and uphill stints the electric motor provided a
boost to the 3.5 horsepower motor. In 1905 H Piper patented the first hybrid in America.
In 1910 a hybrid truck was manufactured in Pennsylvania, which used a 4 cylinder to
power a generator and an electric motor. 1916 saw the production of hybrid cars claiming
35 mph and 48 mpg, however this also saw the end of the electric car era due to the
advances in combustion engine technology. Until the mid to late 1960s, there is little
commercial advance in hybrid or electric cars. As early as the mid 1960s congress
recognized the importance of reducing emissions to improve air quality, and that the use
of electric cars was a possible way to achieve this. In the late 60s and early 70s the oil
27
HYBRID ELECTRIC VEHICLE
embargo sparked a renewed interest in hybrid and electric vehicles. A few hybrids were
released by major manufacturers, but most were underpowered and small. More
importantly, three scientists patented the first modern hybrid system in 1971, much of
which closely resemble the hybrids of today. The next big push from congress come s
with the 1976 Electric and Hybrid Vehicle Research, Development, and Demonstration
Act which encouraged the commercial improvement of electric motors and other hybrid
components. The research lead toward new developments and new vehicle released in the
United States, including all electrics from GM and Honda, even including an electric
truck, the Chevrolet S-10. These vehicles reached a niche group, but still did not receive
the sales numbers to be feasible. This all changed with the release of the Toyota Prius in
Japan in 1997. With 18000 sold in the first year it becomes the first economically feasible
hybrid produced. With its import to the united stated in 2000 and the release of Hondas
Insight to the US in 1999 the hybrid age had finally arrived. However, PHEVs and HEVs
are not without limitations, which are mainly caused by the current state of battery
technology. With future research and development into creating improvements on battery
technology many of the limitations will be greatly reduced if not expunged completely.
We have come a long way since the nickel and lead batteries of the 1960s, more recently
the Nickel Metal Hydride and Lithium Ion battery technologies have been developed and
successfully implemented. Today’s HEVs are a far cry from the small four horse power
models of the 1800s, modern HEVs include the same power, acceleration, comfort, and
price of their counterpart conventional cars (CVs), but can reach upwards of 50 miles per
gallon depending on the model. The importance of this project is not simply limited
toward the contemporary state of the automotive industry. It is also a generalized
overview of what to expect in the near future concerning the status of the global
automotive market and the respective technologies of which it encompasses. Valuable
insight given into possible implications of using the aforementioned technologies and
how they may affect the US and its ability to reach its energy goals all while becoming
both more energy independent and environmentally conscious. Projections for the future
give an overall view of what is to come, including future vehicles available for purchase,
their collective impact on the populace, and how that technology can be built upon and
advanced. It is essentially a forecast of the automotive industry from both a national and
global level. Based on the examination of information and projection from qualified data
28
HYBRID ELECTRIC VEHICLE
sources, it gives as full as possible understanding to the reader of where, when, and how
the automotive industry is now and in the foreseeable future.
29
HYBRID ELECTRIC VEHICLE
Chapter-8
WORKING OF HYBRID ELECTRIC VEHICLE
8.1 STARTING AND LOW SPEED PROCESS
8.1.1 Starting
When hybrid electric vehicle is initially started the battery typically powers all the
accessories of vehicle. The gasoline engine only starts if battery needs to be
charged or the accessories require more power than available from the battery.
8.1.2 Low speed process
For initial acceleration and slow-speed driving, as well as reverse, the electric
motor uses electricity from the battery to power the vehicle. If the battery needs to
be recharged, the generator starts the engine and converts energy from engine into
electricity, which is stored in the battery.
Fig. 8.1 Starting and low speed process of HEV
30
HYBRID ELECTRIC VEHICLE
8.2 CRUISING
To run the vehicle at the speed of above mid range for long period ( Long drive ).
At the time of cruising both internal combustion engine and electric motor are used to
propel the vehicle. The gasoline engine provide the power to the electric vehicle directly
and to the electric motor via the generator.
The generator also convert the energy from internal combustion engine into electricity
and send it to battery for storage.
Fig.. 8.2 Cruising process of HEV
8.3 PASSING
To pass or overtake any other vehicle.
During heavy accelerating or when additional power is needed , the gasoline engine and
electric motor are both used to propel the vehicle.
Additional energy from the battery may be used to power the vehicle.
31
HYBRID ELECTRIC VEHICLE
.Fig. 8.3 Passing process of HEV
8.4 BRAKING
Regenerative braking converts otherwise wastage energy from braking into electricity and
store it in the battery. In regenerative braking the electric motor is reversed so that,
instead of using electricity to turns the wheels, the rotating wheels turns the motor and
create electricity. Using energy from the wheels to turn the motor slows the vehicle down.
When decelerating, the braking system captures energy and stores it in the battery or
other device for later use, helping to keep batteries charged.
In motor case “Eb = V - IaRa“ Generally Eb < V
Here, Eb = Back emf of motor
V = Terminal voltage/Load side voltage
Ia = Armature current and
Ra = Armature resistance
32
HYBRID ELECTRIC VEHICLE
But in regenerative braking system Eb > V, means the load supplies the power to
motor.
If additional stopping power is required we apply friction bakes like disk brakes to
stop the vehicle.
Fig. 8.3 Braking process of HEV
33
HYBRID ELECTRIC VEHICLE
Chapter-9
PREDECESSORS OF CURRENT TECHNOLOGY IN HEV
9.1 CURRENT TECHNOLOGY
A more recent working prototype of the HEV was built by Victor Wouk (one of the
scientists involved with the Henney Kilowatt, the first transistor-based electric car).
Wouk's work with HEVs in the 1960s and 1970s earned him the title as the "Godfather of
the Hybrid". Wouk installed a prototype hybrid drive-strain (with a 16 kilowatts (21 hp)
electric motor) into a 1972 Buick Skylark provided by GM for the 1970 Federal Clean
Car Incentive Program, but the program was stopped by the United States Environmental
Protection Agency (EPA) in 1976 while Eric Stork, the head of the EPA's vehicle
emissions control program at the time, was accused of a prejudicial coverup.
The regenerative braking system, the core design concept of most production HEVs, was
developed by electrical engineer David Arthurs around 1978, using off-the shelf
components and an Opel GT. However the voltage controller to link the batteries, motor
(a jet-engine starter motor), and DC generator was Arthurs'. The vehicle exhibited
75 miles per US gallon (3.1 L/100 km; 90 mpg-imp) fuel efficiency, and plans for it (as
well as somewhat updated versions) are still available through the Mother Earth News
web site. The Mother Earth News' own 1980 version claimed nearly 84 miles per US
gallon (2.8 L/100 km; 101 mpg-imp).
In 1989, Audi produced its first iteration of the Audi Duo (the Audi C3 100 Avant Duo)
experimental vehicle, a plug-in parallel hybrid based on the Audi 100 Avant quattro. This
car had a 9.4 kilowatts (12.8 PS; 12.6 bhp) Siemens electric motor which drove the rear
road-wheels. A trunk-mounted nickel-cadmium battery supplied energy to the motor that
drove the rear wheels. The vehicle's front road-wheels were powered by a 2.3 litre five-
cylinder petrol engine with an output of 100 kilowatts (136 PS; 134 bhp). The intent was
to produce a vehicle which could operate on the engine in the country, and electric mode
in the city. Mode of operation could be selected by the driver. Just ten vehicles are
believed to have been made; one drawback was that due to the extra weight of the electric
34
HYBRID ELECTRIC VEHICLE
drive, the vehicles were less efficient when running on their engines alone than standard
Audi 100s with the same engine.
Two years later, Audi, unveiled the second duo generation, the Audi 100 Duo -likewise
based on the Audi 100 Avant quattro. Once again, this featured an electric motor, a 21.3
kilowatts (29.0 PS; 28.6 bhp) three-phase machine, driving the rear road-wheels. This
time, however, the rear wheels were additionally powered via the Torsen centre
differential from the main engine compartment, which housed a 2.0 litre four-cylinder
engine.[citation needed]
In 1992, Volvo ECC was developed by Volvo. The Volvo ECC was built on the Volvo
850 platform. In contrast to most production hybrids, which use a gasoline piston engine
to provide additional acceleration and to recharge the battery storage, the Volvo ECC
used a gas turbine engine to drive the generator for recharging.
The Clinton administration initiated the Partnership for a New Generation of Vehicles
(PNGV) program on 29 September 1993, that involved Chrysler, Ford, General Motors,
USCAR, the DoE, and other various governmental agencies to engineer the next efficient
and clean vehicle. The United States National Research Council (USNRC) cited
automakers' moves to produce HEVs as evidence that technologies developed under
PNGV were being rapidly adopted on production lines, as called for under Goal 2. Based
on information received from automakers, NRC reviewers questioned whether the "Big
Three" would be able to move from the concept phase to cost effective, pre-production
prototype vehicles by 2004, as set out in Goal 3. The program was replaced by the
hydrogen-focused FreedomCAR initiative by the George W. Bush administration in 2001,
an initiative to fund research too risky for the private sector to engage in, with the long-
term goal of developing effectively carbon emission- and petroleum-free vehicles.
1998 saw the Esparante GTR-Q9 became the first Petrol-Electric Hybrid to race at Le
Mans, although the car failed to qualify for the main event. The car managed to finished
second in class at Petit Le Mans the same year.
35
HYBRID ELECTRIC VEHICLE
ADVANTAGES AND DISADVANTAGES OF HEV
10.1 ADVANTAGES
Hybrid cars emit up to 90% less toxic emissions and half as much greenhouse-this
causes carbon dioxide as an average car(therefore drivers would not have to worry
about polluting the environment).
Hybrids can run on electricity or gas.
Less fuel consumption. Current HEVs reduce petroleum consumption under
certain circumstances, compared to otherwise similar conventional vehicles,
primarily by using three mechanisms:
1. Reducing wasted energy during idle/low output, generally by turning the
ICE off
2. Recapturing waste energy (i.e. regenerative braking)
3. Reducing the size and power of the ICE, and hence inefficiencies from
under-utilization, by using the added power from the electric motor to
compensate for the loss in peak power output from the smaller ICE.
Any combination of these three primary hybrid advantages may be used in
different vehicles to realize different fuel usage, power, emissions, weight and
cost profiles. The ICE in an HEV can be smaller, lighter, and more efficient than
the one in a conventional vehicle, because the combustion engine can be sized for
slightly above average power demand rather than peak power demand. The drive
system in a vehicle is required to operate over a range of speed and power, but an
ICE's highest efficiency is in a narrow range of operation, making conventional
vehicles inefficient. On the contrary, in most HEV designs, the ICE operates
closer to its range of highest efficiency more frequently. The power curve of
electric motors is better suited to variable speeds and can provide substantially
greater torque at low speeds compared with internal-combustion engines. The
greater fuel economy of HEVs has implication for reduced petroleum
consumption and vehicle air pollution emissions worldwide.
36
HYBRID ELECTRIC VEHICLE
The battery pack of a hybrid vehicle never needs to be charged from an external
source. It’s charged by ICE and by motor from braking system.
Hybrids have smaller engines, therefore they tend to weight less than non-
hybrids(but this can lead to problems in the future). Since hybrid cars can run on
alternative fuels, this allows us to decrease our dependency on fossil fuel and
enables us to increase fuel options.(hybrids reduce fuel costs).
A person who purchases a hybrid car is entitled to a federal tax deduction.
10.2 DISADVANTAGES
Hybrids are more expensive than non-hybrids. The cost of HEV is more because
it’s using more parts than non-HEV and these all are costly.
It require more maintenance. It’s using more parts so all require more
maintenance.
It has low towing capacity. It’s engine size is small so it’s don’t able to import and
export more things.
The parts that make up the hybrid car are more expensive and are more difficult to
acquire for one’s car.
Since a hybrid is electrical, Water cannot be used to put out a fire that starts in the
hybrid.
Hybrids(in regards to a car accident)have a much higher risk of
exploding(depending on the impact of the vehicle)because it has a combination of
gasoline and ethanol(which are both highly flammable).
37
HYBRID ELECTRIC VEHICLE
Chapter-11
MODERN HYBRIDS PRODUCTION
11.1 MODERN HYBRID PRODUCTION
Automotive hybrid technology became widespread beginning in the late 1990s. The first
mass-produced hybrid vehicle was the Toyota Prius, launched in Japan in 1997, and
followed by the Honda Insight, launched in 1999 in the United States and Japan. The
Prius was launched in Europe, North America and the rest of the world in 2000. The first
generation Prius sedan has an estimated fuel economy of 52 miles per US gallon
(4.5 L/100 km; 62 mpg-imp) in the city and 45 miles per US gallon (5.2 L/100 km;
54 mpg-imp) in highway driving. The two-door first generation Insight was estimated at
61 miles per US gallon (3.9 L/100 km; 73 mpg-imp) miles per gallon in city driving and
68 miles per US gallon (3.5 L/100 km; 82 mpg-imp) on the highway.
The Toyota Prius sold 300 units in 1997, 19,500 in 2000, and cumulative worldwide Prius
sales reached the 1 million mark in April 2008. By early 2010, the Prius global
cumulative sales were estimated at 1.6 million units. Toyota launched a second generation
Prius in 2004 and a third in 2009. The 2010 Prius has an estimated U.S. Environmental
Protection Agency combined fuel economy cycle of 50 miles per US gallon
(4.7 L/100 km; 60 mpg-imp).
The Audi Duo III was introduced in 1997, based on the Audi B5 A4 Avant, and was the
only Duo to ever make it into series production. The Duo III used the 1.9 litre
Turbocharged Direct Injection (TDI) diesel engine, which was coupled with an 21
kilowatts (29 PS; 28 bhp) electric motor. Unfortunately due to low demand for this hybrid
because of its high price, only about sixty Audi Duos were produced. Until the release of
the Audi Q7 Hybrid in 2008, the Duo was the only European hybrid ever put into
production. The Honda Civic Hybrid was introduced in February 2002 as a 2003 model,
based on the seventh generation Civic. The 2003 Civic Hybrid appears identical to the
non-hybrid version, but delivers 50 miles per US gallon (4.7 L/100 km; 60 mpg-imp), a
40 percent increase compared to a conventional Civic LX sedan. Along with the
38
HYBRID ELECTRIC VEHICLE
conventional Civic, it received styling update for 2004. The redesigned 2004 Toyota Prius
(second generation) improved passenger room, cargo area, and power output, while
increasing energy efficiency and reducing emissions. The Honda Insight first generation
stopped being produced after 2006 and has a devoted base of owners. A second
generation Insight was launched in 2010. In 2004, Honda also released a hybrid version
of the Accord but discontinued it in 2007 citing disappointing sales.
The Ford Escape Hybrid, the first hybrid electric sport utility vehicle (SUV) was released
in 2005. Toyota and Ford entered into a licensing agreement in March 2004 allowing
Ford to use 20 patents[citation needed] from Toyota related to hybrid technology,
although Ford's engine was independently designed and built.[citation needed] In
exchange for the hybrid licenses, Ford licensed patents involving their European diesel
engines to Toyota.[citation needed] Toyota announced calendar year 2005 hybrid electric
versions of the Toyota Highlander Hybrid and Lexus RX 400h with 4WD-i, which uses a
rear electric motor to power the rear wheels negating the need for a transfer case.
In 2006, General Motors Saturn Division began to market a mild parallel hybrids in the
form of the 2007 Saturn Vue Green Line which utilized GM's Belted Alternator/Starter
(BAS Hybrid) System combined with a 2.4 litre L4 engine and a FWD automatic
transmission. The same hybrid power-strain was also used to power the 2008 Saturn Aura
Greenline and Malibu Hybrid models. As of December 2009, only the BAS equipped
Malibu is still in (limited) production.
In 2007, Lexus released a hybrid electric version of their GS sport sedan, the GS 450h,
with a power output of 335 bhp. The 2007 Camry Hybrid became available in Summer
2006 in the United States and Canada. Nissan launched the Altima Hybrid with
technology licensed by Toyota in 2007.
Commencing in the fall of 2007 General Motors began to market their 2008 Two-Mode
Hybrid models of their GMT900 based Chevrolet Tahoe and GMC Yukon SUVs, closely
followed by the 2009 Cadillac Escalade Hybrid version. For the 2009 model year,
General Motors released the same technology in their half-ton pickup truck models, the
2009 Chevrolet Silverado and GMC Sierra Two-Mode Hybrid models.
39
HYBRID ELECTRIC VEHICLE
The Ford Fusion Hybrid officially debuted at the Greater Los Angeles Auto Show in
November 2008, and was launched to the U.S. market in March 2009, together with the
second generation Honda Insight and the Mercury Milan Hybrid.
Fig. 11.1 1997 Toyota Prius (first generation)
Fig. 11.2 2000 Honda Insight (first generation)
Fig. 11.3 2010 Honda Insight (second generation)
40
HYBRID ELECTRIC VEHICLE
Fig. 11.3 2010 Ford Fusion Hybrid
CONCLUSION
Means a hybrid vehicle is a vehicle that uses two or more distinct power sources to move
the vehicle. The term most commonly refers to hybrid electric vehicles (HEVs), which
combine an internal combustion engine and one or more electric motors.
Modern HEVs make use of efficiency-improving technologies such as regenerative
braking, which converts the vehicle's kinetic energy into electric energy to charge the
battery, rather than wasting it as heat energy as conventional brakes do. Some varieties of
HEVs use their internal combustion engine to generate electricity by spinning an
electrical generator (this combination is known as a motor-generator), to either recharge
their batteries or to directly power the electric drive motors. Many HEVs reduce idle
emissions by shutting down the ICE at idle and restarting it when needed; this is known
as a start-stop system. A hybrid-electric produces less emissions from its ICE than a
comparably-sized gasoline car, since an HEV's gasoline engine is usually smaller than a
comparably-sized pure gasoline-burning vehicle (natural gas and propane fuels produce
lower emissions) and if not used to directly drive the car, can be geared to run at
maximum efficiency, further improving fuel economy.
41
HYBRID ELECTRIC VEHICLE
REFERENCES
1. Hybrid electric vehicle - Wikipedia, the free encyclopedia
http://en.wikipedia.org/wiki/Hybrid_electric_vehicle
2. Ford – Escape Hybrid – SUV – 35mpg – price unannounced
http://www.fordvehicles.com/escapehybrid/home/index.asp?bhcp=1
3. Toyota – Prius – $20,810 – 55mpg –
http://www.toyota.com/prius/
4. How Hybrids Work - Fuel Economy
www.fueleconomy.gov/feg/ hybrid tech.shtml
5. Hybrid-electric vehicle financial definition of Hybrid-electric vehicle
financial-dictionary.thefreedictionary.com/ Hybrid - electric + vehicle
6. Electric Car
http://www.hybridcars.com/electric-car
42