intermittent no start and/or rough tsb 12-11-12 … · 2013. 5. 6. · ford: 2011-2013 mustang...

INTERMITTENT NO START AND/OR ROUGH TSB 12-11-12 RUNNING—BLOWN FUSE 13—DTC P0627 FORD: 2011-2013 Mustang ISSUE Some 2011-2013 Mustangs vehicles may exhibit an intermittent drivability condition, crank/no start, a blown fuse 13 in the battery junction box and may have Diagnostic Trouble Code (DTC) P0627 stored in the Powertrain Control Module (PCM). ACTION Follow the Service Procedure steps to correct the condition. SERVICE PROCEDURE 1. Remove the rear seat cushion. Refer to Workshop Manual (WSM), Section 501-10. Figure 2 - Article 12-11-12 2. Inspect the fuel pump module wire harness for 4. Install the rear seat cushion. Refer to WSM, a chafing. Is chafing found? (Figure 1) Section 201-10. PART NUMBER PART NAME F2UZ-14526-N 15 Amp Mini-fuse WARRANTY STATUS: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage Warranty/ESP coverage limits/policies/prior approvals are not altered by a TSB. Warranty/ESP coverage limits are determined by the identified causal part and verified using the OASIS Figure 1 - Article 12-11-12 part coverage tool. a. No - this article does not apply. Refer to OPERATION DESCRIPTION TIME Powertrain Control/Emissions Diagnosis 121112A 2011-2013 Mustang: 0.8 Hr. (PC/ED) manual for normal diagnosis. Check DTCs, Inspect And Repair Wire Harness (Do b. Yes - repair the wiring harness. Refer to the Not Use With Any Other Wiring Diagram (WD), Section 5. Labor Operations) 3. Route the harness so that it will lie in the DEALER CODING recess area of the rear seat when the seat CONDITION cushion is installed. (Figure 2) BASIC PART NO. CODE 14A005 30 NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in proper vehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact a Ford or Lincoln dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article.The information in this Technical Service Bulletin (TSB) was current at the time of printing. Ford Motor Company reserves the right to supercede this information with updates.The most recent information is available through Ford Motor Company’s on-line technical resources. Copyright 2012 Ford Motor Company Online Publication Date November 16, 2012 PAGE 1

Upload: others

Post on 30-Sep-2020

0 views

Category:

Documents

0 download

Report

Download

Embed Size (px):

TRANSCRIPT

INTERMITTENT NO START AND/OR ROUGH TSB 12-11-12RUNNING—BLOWN FUSE 13—DTC P0627

FORD:2011-2013 Mustang

ISSUESome 2011-2013 Mustangs vehicles may exhibit anintermittent drivability condition, crank/no start, ablown fuse 13 in the battery junction box and mayhave Diagnostic Trouble Code (DTC) P0627 storedin the Powertrain Control Module (PCM).

ACTIONFollow the Service Procedure steps to correct thecondition.

SERVICE PROCEDURE

1. Remove the rear seat cushion. Refer toWorkshop Manual (WSM), Section 501-10.

Figure 2 - Article 12-11-122. Inspect the fuel pump module wire harness for

4. Install the rear seat cushion. Refer to WSM,a chafing. Is chafing found? (Figure 1)

Section 201-10.

PART NUMBER PART NAME

F2UZ-14526-N 15 Amp Mini-fuse

WARRANTY STATUS: Eligible Under Provisions OfNew Vehicle LimitedWarranty CoverageWarranty/ESP coveragelimits/policies/prior approvalsare not altered by a TSB.Warranty/ESP coveragelimits are determined by theidentified causal part andverified using the OASISFigure 1 - Article 12-11-12part coverage tool.

a. No - this article does not apply. Refer toOPERATION DESCRIPTION TIME

Powertrain Control/Emissions Diagnosis121112A 2011-2013 Mustang: 0.8 Hr.

(PC/ED) manual for normal diagnosis.Check DTCs, Inspect AndRepair Wire Harness (Dob. Yes - repair the wiring harness. Refer to theNot Use With Any OtherWiring Diagram (WD), Section 5.Labor Operations)

3. Route the harness so that it will lie in the DEALER CODINGrecess area of the rear seat when the seat CONDITIONcushion is installed. (Figure 2) BASIC PART NO. CODE

14A005 30NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge, tools, and equipment to dothe job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or provides information that could assist in propervehicle service. The procedures should not be performed by “do-it-yourselfers”. Do not assume that a condition described affects your car or truck. Contact aFord or Lincoln dealership to determine whether the Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determineWarranty and/or Extended Service Plan coverage unless stated otherwise in the TSB article.The information in this Technical Service Bulletin (TSB) wascurrent at the time of printing. Ford Motor Company reserves the right to supercede this information with updates.The most recent information is availablethrough Ford Motor Company’s on-line technical resources.

Intermittent Compression

I DON’T · Alloy Wheels (Dark Grey, Dual Tone) x x x x Wiper Front Mist Mist Intermittent + Mist Intermittent + Mist Intermittent + Mist Intermittent + Mist Intermittent + Mist

Mastering the complexity of drivability, driving ... · Energy Management: performance, consumption, drivability Development, adjustment and parameterization of models and controllers

Forecasting Workshop: Intermittent Demand Forecasting · PDF fileForecasting Workshop: Intermittent Demand Forecasting Software and Freeware for Intermittent Demand Nikolaos Kourentzes

Intermittent Claudication

Intermittent xt

Objective Drivability Calibration · 3 Key Takeaways Powertrain Blockset is capable of simulating low frequency drivability behavior Model re-use from early planning phase can be

Drivability Development for Parallel Hybrid Electric Vehicle (Hyundai Motor Company

PLEM pile drivability

Intermittent coating

Ride Quality and Drivability of a Typical Passenger Car …liu.diva-portal.org/smash/get/diva2:430005/FULLTEXT01.pdfIII Ride Quality and Drivability of a Typical Passenger Car subject

Intermittent exotropia