~iw ') - avclaims mpi (major periodic inspection.pdf · 6 2 deep cycle no. 2 battery saft...
TRANSCRIPT
"~iW_') 0Airframe Entries
CBSCD/11 Maintenance Transaction Record
MTR ID# 1848731
Page 1of2
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
0 Eng. #2 Serial No. ------
Aircraft Identification and Status
OAPU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
NC Serial# NC Unit # I NC Registration # Date City ID I Total NC Hours I Total NC Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 TU Cycles I Engine 2 TU Cycles I APU Hrs I APU Events I Freon Hrs
650-7063
Item
5-12-03 0512003
5-12-28 0512028
8262201 0512003 : A
8262201 0512003 : F
D243006 0512003 : L
7063 N877G 10-Aug-2011 KALN 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworth iness Directives Accomplished
Transaction No. Type Item Name
2 INSPECTION DOCUMENT 3
Position Part Number I Alternate Part
Comments: Accomplished the Inspection Document 3 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-03.
Mod Level Part Serial
4386 4398 2608
Removal Installed Part Reason Status TSN/TSO/TSR
Reviewed the MTR/log entry dated 14FEB2011 for the 3 aircraft batteries ID 3 Inspections/Checks. (LH & RH main Nicad and the L3 emergency gyro power supply) These batteries have a next due date of FEB2012.
2 2 INSPECTION DOCUMENT 28
Comments: Accomplished the Inspection Document 28 of lhe Cessna 650 Maintenance Manual REV.33 chapter 5-12-28.
3 2 FUNCTIONAL CHECK CABIN HALON EXTINGUISHER : INSPECTION DOCUMENT 3
Weight Check Date: 09-Aug-2011
CABIN C352TS
Comments: Accomplished the Inspection Document 3 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-03.
4 2 FUNCTIONAL CHECK COCKPIT HALON EXTINGUISHER : INSPECTION DOCUMENT 3
Weight Check Date: 09-Aug-2011
COCKPIT C352TS
Comments: Accomplished the Inspection Document 3 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-03.
5 2 DEEP CYCLE NO. 1 BATTERY SAFT NI-CAD BATTERY RESTORATION: INSPECTION DOCUMENT3
NO. 1 20950
Comments: Deep Cycle of the #1 Battery SN 081403 was accomplished 14FEB2011 and is next due 28FEB2012.
X466777
X465514
081403
1.00 0
Material Man Costs Hours
Trans_ Type: 1 - component, 2 - Inspection, 3- SB, 4-AO, - - Misc_ Removal Reasons: WO - Worn to Limits, SC- Scheduled, UN - Unscheduted, CO - Convenience, N- Other(note In corrments) Installed Part Status: N- New, R - Repaired/Rebuitt. S-Serviceable, 0- Overhauled
Repair Facility
PREMIER D/B/A WEST STAR AVIATION INC Certified Repair ---------------·--·- Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in accordance with the current regulations of the
0 Federal Aviation Administration 0 Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91 .409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facil ity under the above Work/Service Order Number as applicable.
Section Pa e rlilH§~'i
l!'.JAirframe Entries
CBSC0/11 Maintenance Transaction Record
MTR ID# 1848731
Page 2 of 2
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
D Eng. #2 Serial No.
Aircraft Identification and Status
0 APU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
NC Serial# NC Unit# NC Registration # I Date City ID Total NC Hours I Total AJC Landings I Engine 1 Total Hrs I Engine 2 Total Hrs Engine 1 TII Cycles Engine 2 TU Cycles APU Hrs APU Events I Freon Hrs
650-7063
Item
D243006 0512003 : R
B342001
7063 N877G I 10-Aug-2011 KALN 5562.1 I 444 7 I 5458.3 I 5372
Component Changes. Inspections. Service Bulletins. or Airworth iness Directives Accomplished
Transaction No. Type Item Name
6 2 DEEP CYCLE NO. 2 BATTERY SAFT NI-CAD BATTERY RESTORATION: INSPECTION DOCUMENT3
Position Part Number I Alternate Part
NO. 2 20950
Comments: Deep Cycle of the #2 Battery SN 00058247 was a=mplished 14FEB2011 and is next due 28FEB2012.
7 2 FUNCTIONAL CHECK L3 COM STANDBY POWER SUPPLY: INSPECTION DOCUMENT 3
Mod Level Part Serial
00058247
Comments: Capacity and Functional check of the Standby Instrument Battery SN 7741 was accomplished 14FEB2011 and is next due 28fEB2012.
4386 4398 2608 1.00 I o
Removal Installed Part Material Man Reason Status TSN/TSO/TSR Costs Hours
Trans. Type: 1 - Component, 2- Inspection, 3 - SS, 4 - AO, - - Misc. Removal Reasons: WO - Wom to Limits, SC - Scheduled, UN - Unscheduled, CO -Convenience, N - Other(note in comments) Installed Part Status: N - New. R - Repake~ebuilt. S - Serviceable, O - Ovemauled
Repair Facility
PREMIER D/B/A WEST STAR AVIATION, INC. Certified Repair Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in a=rdance with the current regulations of the
0Federal Aviation Administration D Other (Specify) and
Date 10-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Worl</Service Order Number as applicable.
Section Pa e rdM'·*':ci
"~iig) 0 Airframe Entries
CBSCD/11 Maintenance Transaction Record
MTR ID# 1848577
Page 1 of 6
This Maintenance Report is To Be Used Solely For (Check One)
O Eng. #1 Serial No. _ _____ _
O Eng. #2 Seriai No. ------'-'---
Aircraft Identification and Status
0 APU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
A/C Serial# A/C Unit# I A/C Registration # Date City ID I Total A/C Hours I Total A/C Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 TU Cycles I Engine 2 Ttl Cycles I APU Hrs I APU Events I Freon Hrs
650-7063
Item
5-12-01 0512001
5-12-08 0512008
5-12-09 0512009
D262003 0512010 : R
5-12-20 0512020
5-12-21 0512021
7063 N877G 1 O-Aug-201 1 KALN 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Transaction No. Type Item Name
2 INSPECTION DOCUMENT 1
Position Part Number I Alternate Part
Comments: Accomplished the Inspection Document 1 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-01 .
2 2 INSPECTION DOCUMENT 8
Comments: Accomplished the Inspection Document 8 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-08.
3 2 INSPECTION DOCUMENT 9
Comments: Accomplished the Inspection Document 9 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-09.
4 2 HYDROSTATIC TEST RIGHT ENGINE EXTINGUISHER : INSPECTION DOCUMENT 10
Hydro Check Date: 25-Jul-2011
RIGHT ENGINE
32700012
Comments: Accomplished the Inspection Document 10 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-10.
Mod Level Part Serial
OB37BC1
4386 4398 2608
Removal Installed Part Reason Status TSN/TSO/TSR
Reinstalled the hydro tested RH engine fire bottle SN 08378C1 Reference FAA Fann 8130-3 from Ameren CRS# RU2R148L WO# A11-8162 dated 26JUL2011 .
5 2 INSPECTION DOCUMENT 20
Comments: Accomplished the Inspection Document 20 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-20.
6 2 INSPECTION DOCUMENT 21
Comments: Accomplished the Inspection Document 21 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-21 .
1.00 0
Material Man Costs Hours
,..---------------------------------------------------------------------'-"-~-~_led_P_•"-~-•_tu_s:_N_-_N_ew, R - Rep~red.IRebuitt, S-Serviceable, 0-~au~d
r'iN.!W*!?,',., Trans. Type: 1 - Component, 2 - Inspection. 3 - SB, 4 - AD. - - Misc. Removal Reasons: WO - Worn to Limits, SC - Scheduled, UN - Unscheduled, CO - Convenience, N - Other(note in cooments)
Repair Facility
PREMIER D/B/A WEST STAR AVIATION, INC. Certified Repai r Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
31 8957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in accordance with the current regulations of the
0 Federal Aviation Administration D Other (Specify) and
Date 1 D-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Work/Service Order Number as applicable.
c..~eu l?'.JAirframe Entries
CBSCDITI Maintenance Transaction Record
MTR ID# 1848577
Page 2 of 6
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
0 Eng. #2 Serial No.
OAPU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
Aircraft Identification and Status
NC Serial# NC Unit # I NC Registration # Date City ID I Total NC Hours I Total A/C Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 Ttl Cycles I Engine 2 Ttl Cycles I APU Hrs I APU Events I Freon Hrs
650-7063
Item
7063
Transaction No. Type
N877G 10-Aug-2011 KALN 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Item Name Position Part Number I Alternate Part Mod Level Part Serial
4386 4398 2608
Removal Installed Part Reason Status TSN/TSO/TSR
8 237001 7 2 FUNCTIONAL CHECK COCKPIT VOICE RECORDER UNDERWATER LOCATOR BEACON
DK100 OT3076
0512030 : CVR
5-12-42 0512042
5-12-MI 05120MI
5-12-MA 05120MA
5-12-MO 05120MD
1848577012
1848577013
(PINGER TEST): INSPECTION DOCUMENT 30
Comments: Accomplished the Inspection Document 30 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-30. Beacon S/N OT3076 II Battery Due AUG. 2013
8 2 INSPECTION DOCUMENT 42
Comments: Accomplished the Inspection Document 42 of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-42.
9 2 INSPECTION DOCUMENT Ml (CHAPTER 4 REQUIREMENT)
Comments: Accomplished the Inspection Document Ml of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-MI. Performed eddy current inspection of forward and aft pressure bulkheads. All results indicated no defects. See attached NOT reports dated 8/2111 .
1Q 2 INSPECTION DOCUMENT MA (CHAPTER 4 REQUIREMENT)
CC)mments: Accomplished the Inspection Document MA of the Cessna 650 Maintenance Manual REV .33 chapter 5-12-MA.
11 2 INSPECTION DOCUMENT MO (CHAPTER 4 REQUIREMENT)
Comments: Accomplished the Inspection Document MO of the Cessna 650 Maintenance Manual REV.33 chapter 5-12-MD.
12 - ATA 11 PLACARDS & MARKINGS
Comments: Replaced the worn nose wheel inflation placard with a new unit PN 6200181-121 . Replaced the worn RH wng fuel filler placard with a new unit PN 6200181 -104. All work done IAWthe 650 M.M. CH 11.
13 - ATA 23 COMMUNICATIONS
Comments: Replaced the worn LH & RH wing tip static wick bases with new units PN's 15347. Bond check good. All work done IAW the 650 M.M. CH 23.
1.00 0
Material Man
Costs Hours
Trans. Type: 1 - Component, 2 - Inspection, J- SB, 4 - AD, - - M~c. Removal Rea.sons: WO - Worn to LWnits, SC - Scheduled, UN - Unscheduled, CO - Convenience, N - Other(note ifl comments) Installed Part Status: N - New, R - Repaired/Rebuilt, S - Serviceable, O - Overhau~
Repair Facility
PREMIER 0 /B/A WEST STAR AVIATION INC Certified Repair ---------------·--·- Station Number
Work Performed By PREMIER O/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in accordance with the current regulations of the
0 Federal Aviation Administration D Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) ANO WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED ANO IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the abcve Work/Service Order Number as applicable.
Section Pa e r!l!!S1il1il";ci
~~i!U (i'.JAirframe Entries
CBSCD/77 Maintenance Transaction Record
MTR ID# 1848577
Page 3 of 6
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
0 Eng. #2 Serial No. ------
OAPU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 315-462-2267/ Fax: 31S-462-0791
Aircraft Identification and Status
A/C Serial# A/C Unit# I A/C Registration # Date City ID I Total A/C Hours I Total AJC Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 TU Cycles I Engine 2 TU Cycles I APU Hrs I APU Events I Freon Hrs
650-7063 7063 N877G 10-Aug-2011 KALN 5562.1 4447 5458.3 5372 4386 4398 2608 1.00 0
Item
1848577014
1848577
1848577
1848577017
284201
1848577020
1848577
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Transaction No. Type Item Name
14 - ATA 24 ELECTRICAL POWER
Position Part Number I Alternate Part Mod
level Part Serial
Comments: Replaced the worn #1 battery temp indicator digits light bulb with a new unit PN KW105G. All work done IAW the 650 M.M. CH 24.
15 - ATA 25 EQUIPMENT & FURNISHINGS
Removal Installed Part Reason Status TSN/TSO/TSR
Comments: Made a SRM/Minor repair to the cabin door forward royalite/plastic close out panel by adding a plastic doubler to the affected area. Reinstalled the repaired galley switch panel PN SP-339-38 SN 07960537 Reference FAA Form 8130-3 from Goodrich CRS# 11 IR779B WO# NADJ20A dated 27 JUL2011 . Completed a functional check with no faults found. All work done IAW the 650 M.M. CH 25.
16 - ATA 27 FLIGHT CONTROLS
Comments: Replaced the worn rudder bias rod end with a new unit PN 6260465-1. Replaced the worn RH wing trailing edge outboard flap panel gap seal with a new unit PN R860049. Replaced the LH & RH flap panels (6ea) worn elastomer bearings with new units PN's LBJ-1112-1-1 . Replaced the worn LH wing inboard speed brake actuator hoses with new units PN'sAS117-04K0074 & AS117-04K0132. Replaced the following worn flight control system cables with new units: Elevator LH aft cable PN 6260232-58, LH wing aileron inboard forward cable PN 6260106-15, & LH wing aileron outboard forward cable PN 6260106-25. Completed a laek & functional check with no faults found. All work done IAW the 650 M.M. CH 27.
17 - ATA 28 FUEL
Comments: Reinstalled the repaired fuel temp gauge PN 9914095-30 SN 121. Completed a functional check with no faults found. All work done IAW the 650 M.M. CH 28.
18 1 FUEL TEMP INDICATOR 10583N01TOO 9914095-30 121 WO R Comments: CESCOM TRACKING II Reference FAA Form 8130-3 from Aero-Mach CRS# NU2R044L WO# 0378799 dated 1AUG2011. Removed part no: DDL-OC119C Removed serial no: 121.
19 - ATA 32 LANDING GEAR
Comments: Replaced the worn NLG lower & upper barrel bearings with a new units PN's MS27642-68G & MS27642-47. Completed a leak & functional check with no faults found. All work done IAW the 650 M.M. CH 32 & CMM.
20 - ATA 33 LIGHTS
Comments: Replaced the RH taxi inoperative light bulb with a new unit PN 4594. Replaced the RH tail navigation inoperative light bulb with a new unit PN 1683. Replaced one lavatory indirect inoperative light bulb with a new unit PN 7300251-001 . Completed a functional check with no faults found. All work done IAW the 650 M.M. CH 33.
Material Man Costs Hours
Trans. Type: 1 - Component, 2 - lnspedion. 3 - SB. 4 - AD. - - Misc. Removal Reasons: WO - Worn to Linits, SC - Scheduled, UN- Unscheduled. CO-Convenience, N - Other(note in corrvnents) Installed Part Status: N- New. R - Repaired.fRebuilt, S- Serviceable, 0- Overhauled
Repair Facility
PREMIER D/B/A WEST STAR AVIATION, INC. Certified Repair
Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in a=rdance with the current regulations of the
0 Federal Aviation Administration D Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Work/Service Order Number as applicable.
r··"4!~~
~~ Ii':] Airframe Entries
cescam Maintenance Transaction Reco rd
MTR ID# 1848577
Page 4 of6
This Maintenance Report is To Be Used Solely For (Check One)
O Eng. #1 Serial No. ______ _
D Eng. #2 Serial No.
D APU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 315-462-2267/ Fax: 315-462-0791
Aircraft Identification and Status
NC Serial # NC Unit# I NC Registration # Date City ID I Total NC Hours I Total NC Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 TU Cycles I Engine 2 TU Cycles I APU Hrs I APU Events I Freon Hrs
650-7063
Item
1848577
1848577
291020 291005 : L
291020 291005 : R
291021
291006 : R
291021 291006 : L
291022 291007 : L
7063
Transaction No. Type
N877G
21 - ATA 36 PNEUMATICS
1 O-Aug-2011 KALN 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Item Name Position Part Number I Alternate Part Mod
Level Part Serial
4386 4398 2608
Removal Installed Part
Reason Status TSN/TSO/TSR
Comments: Replaced the following pneumatic air filters with new units: Primary Outflow Valve Filter PN 99141 83-7 & Cabin Door Seal Air Filter PN 050-05BX. Replaced the LH & RH APU bleed air check valves with new units PN's 4011-7. Replaced the RH bleed air master valve with a new unit PN 99141 24-4 SN 0547. Completed a leak & functional check with no faults found. All work done
IAW the 650 M.M. CH 36, 21, & 5.
22 - ATA 29 HYDRAULICS
Comments: Replaced the following hydraulic filters with new units (all filters are new from a kit PN CPD650-6) LH and RH hydraulic pressure filters, LH and RH hydraulic return filters, LH and RH hydraulic case drain filters, & hydraulic aileron boost filter. Replaced the LH wing spoiler hold down valve worn hydraulic line with a new unit PN 6207024-116. Completed a leak & functional check with no faults found. All work done per the 650 M.M. CH 5 & 29.
23 1 LEFT HYDRAULIC PRESSUR E FILTER LEFT 7509130 991 4077-5 NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 7509130 Removed serial no: NSN.
24 1 RIGHT HYDRAULIC PRESSURE FILTER RIGHT 7509130 9914077-5 NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 7509130 Removed serial no: NSN.
25 1 RIGHT HYDRAULIC RETURN FILTER RIGHT 7511130 9914077-8 NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 7511130 Removed serial no: NSN.
26 1 LEFT HYDRAULIC RETURN FILTER LEFT 7511130 NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 7511130 Removed serial no: NSN.
27 1 LEFT HYDRAULIC CASE DRAIN FILTER LEFT 7507130 9914077-2 NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 7507130 Removed serial no: NSN.
1.00 0
Material Man
Costs Hours
Trans. Type: 1 - Component, 2 - Inspection, 3- SS, 4 -AD, - - Misc. Removal Reasons: WO- Worn to Linits, SC - Scheduled, UN - Unscheduted, CO - Convenience, N - other(note in corrments) Installed Part Status: N- New, R- Repaired/Rebuilt, S- Serviceab&e, 0- Overhauled
Repair
Facility PREMIER D/B/A WEST STAR AVIATION INC Certified Repair ----------- ----·--·- Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.1 45.5079 Work
Order No. 318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in a=rdance with the current regulations of the
0 Federal Aviation Administration D Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 10-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Work/Service Order Number as applicable.
rii@A·!i·Mtt.,
(#i'liiff) Ii'] Airframe Entries
CBSCD/11 Maintenance Transaction Record
MTR ID# 1848577
Page 5 of 6
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
O APU Serial No. --- - --
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
Engine 1 Ttl Cycles I Engine 2 Ttl Cycles I APU Hrs I APU Events
Item
291022 291007: R
291023 291012
1848577032
361007 361007 : E2-R
1848577033
361020 361004
1848577034
N877G 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Transaction No. Type Item Name Position Part Number I Alternate Part
28 1 RIGHT HYDRAULIC CASE DRAIN FILTER RIGHT 7507130 9914077-2
Comments: CESCOM TRACKING II Removed part no: 7507130 Removed serial no: NSN.
29 1 HYDRAULIC AILERON BOOST FILTER 7507130 9914077-2
Comments: CESCOM TRACKING II Removed part no: 7507130 Removed serial no: NSN.
30 - ATA 36 PN EUMATICS
Mod Level Part Serial
NA
NA
4386 4398 2608
Removal Installed Part Reason Status TSN/TSO/TSR
SC N 0 MTH 0 HRS
SC N 0 MTH 0 HRS
Comments: Replaced the following pneumatic air filters with new units: Primary Outflow Valve Filter PN 9914183-7 & Cabin Door Seal Air Filter PN 050-05BX. Replaced the LH & RH APU bleed air check valves with new units PN's 4011-7. Replaced the RH bleed air master valve with a new unit PN 9914124-4 SN 0547. Completed a leak & functional check with no faults found. All work done IAW the 650 M.M. CH 36, 21, & 5.
31 1 RIGHT HIGH PRESSURE SHUTOFF VALVE RIGHT 5155-00-1 9914124-4 0547 WO N O MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 229885-3 Removed serial no: 49.
32 1 REPLACE PRIMARY OUTFLOW VALVE FILTER 9914183-7 SC N O MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 9914183-7 Removed serial no: - .
33 1 CABIN ENRTY DOOR PNEUMATIC SEAL FILTER 050-05BX NA SC N 0 MTH 0 HRS
Comments: CESCOM TRACKING II Removed part no: 050-05BX Removed serial no: -.
34 - ATA52 DOORS
Comments: Replaced the main cabin doorwom secondary door seal with a new unit PN 6611287-12. Replaced the main cabind door spade door worn felt strip with a new unit PN 6221335-54. All work done IAW the 650 M.M. CH 52.
1.00
Material Man Costs Hours
Trans. Type: 1 - Component, 2 - lnspedion, 3 - SB, 4 -AD, - - Misc. Removal Reasons: 'WO - Worn to Limits, SC - Scheduled, UN - Unscheduled, CO- Convenience, N - Other(note in convnents) lnstaned Part Status: N - New, R- Repaired/Rebuilt, S- Serviceab'8 , 0 - Overhauled
Repair Facility
PREMIER D/B/A WEST STAR AVIATION INC Certified Repair ---------------· __ ·_ Station Number
Work Perfonned By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
31 8957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in a=rdance with the current regulations of the
0 Federal Aviation Administration 0 Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91.409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.1 45.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Work/Service Order Number as applicable.
Section Page r""·lld§ltf~
<...~¥~ G1]Airframe Entries
CBSCD/11 Maintenance Transaction Record
MTR ID# 1848577
Page 6 of 6
This Maintenance Report is To Be Used Solely For (Check One)
OEng. #1 Serial No. ______ _
D Eng. #2 Serial No.
Aircraft Identification and Status
OAPU Serial No. ------
CAMP Systems International 8200 E. 34TH STREET BUILDING 1600, SUITE 1607
Wichita, KS 67226 Phone: 316-462-2267/ Fax: 316-462-0791
A/C Serial# A/C Unit# I A/C Registration # Date City ID I Total A/C Hours I Total AJC Landings I Engine 1 Total Hrs I Engine 2 Total Hrs I Engine 1 Ttt Cycles J Engine 2 Ttt Cycles I ~U Hrs I APU Events I Freon Hrs
650-7063
Item
1848577035
7063
Transaction No. Type
N877G
35 - ATA 53 FUSELAGE
10-Aug-2011 KALN 5562.1 4447 5458.3 5372
Component Changes. Inspections. Service Bulletins. or Airworthiness Directives Accomplished
Item Name Position Part Number I Alternate Part Mod Level Part Serial
4386 4398 2608
Removal Installed Part Reason Status TSN/TSO/TSR
Comments: Replaced one worn lower skin drain valve seal (lav LH) with a new unit PN CM3575-4. All work done IAW the 650 M.M. CH 53 & SRM Standard Practices.
1.00 0
Material Man Costs Hours
Trans. Type: 1 - Compone~. 2 - lnspectton, 3 - SB, 4 - AO, - • Misc. Removal Reasons: WO - Worn to Limits, SC - Scheduled, UN - Unscheduled, CO - Convenience, N- Other(note in comments) Installed Part Status: N - New, R- Repaired/Rebuilt, S- Serviceable, O - Overhauled
Repair Facility
PREMIER D/B/A WEST STAR AVIATION, INC. Certified Repair Station Number
Work Performed By PREMIER D/B/A WEST STAR AVIATION, INC.
PAZR068H, EASA.145.5079 Work Order No.
318957
Certificate No. PAZR068H, EASA.145.5079
I certify that the above stated maintenance and/or inspection was performed in accordance with the current regulations of the
0 Federal Aviation Administration D Other (Specify) and
Date 1 O-Aug-2011
THE AIRCRAFT IDENTIFIED ABOVE HAS BEEN INSPECTED IN ACCORDANCE WITH THE ABOVE INSPECTION(S) REQUIRED BY 14 CFR PART 91 .409(E)(F)(3) AND WAS DETERMINED TO BE AIRWORTHY WITH RESPECT TO THE WORK PERFORMED AND IS PRESENTLY APPROVED FOR RETURN TO SERVICE.
Work Inspected By ANDREW CROSSMAN Certificate No. PAZR068H, EASA.145.5079 Date 1 O-Aug-2011
Pertinent details of this maintenance are on file at our facility under the above Work/Service Order Number as applicable.
t::•i!·F!.'*!?,..,
Plea~e Print
cessna/olTaTllO@ Citation Product Support The Cessna Aircraft Company Post Office Box 7706/Wichita, Kansas 67277
Maintenance Note
2
3 . 4
5
6
7
8
t Type Transaction 1. Component Change 2. Inspection Accomplished 3. Service Bulletin Accomplished 4. Airworthiness Directive Accomplished
Detail Method of Compliance Under Comments Below
CbSCOm
Removal Reason Enter One
W - Worn to Limits S - Scheduled U - Unscheduled C - Convenience N - Other (Note
J t If Overtlauled Part Enter Overhaul
Jacked NC and swung gear. Found red gear "unlock" light to be illuminated when the gear was up and locked. Inspected gear components and found R/H uplock switch bracket to be out of
its correct position . Repositioned uplock bracket and performed 3 consecutive gear swings with the uplock light working normally and NOT staying on with gear up. Down jacked aircraft.
Serviced hydraulic reservoir.
Duncan Aviation Lincoln, NE Certificated Repair
JGVR194F Work
Repair Facility Station Number Order No. Q6D1A Work Performed By: Duncan Aviation Lincoln, NE Certificate No. JGVR194F Date 08119111
I certify that the above stated maintenance and/or inspecUon was performed in accordance with the wrrent regulations of the
~ Federal Aviation Administration
D Other (Specify) <... and the aircraft identified above is presently airworthy and approved for return to service.
Work Inspected By !/' ~ /V -.-? ~ llUHCAll JGVR194F 08119111 1111215 Certificate No. Date Permanent Aircraft Rerord - File in Maintenance Log