kde55xbr950
TRANSCRIPT
KDE55XBR950SERVICE MANUALUS Model Canadian Model
MBD55XBR950
PDM-5510
MR2 CHASSISSPECIFICATIONSPanel System Display resolution Antenna Television System Channel Coverage Plasma Display panel 1366 pixels (horizontal) 768 pixels (vertical) 75 ohm external terminal for VHF/UHF NTSC, American TV Standard VHF UHF DTV CATV Power Requirements Inputs/Outputs DVI-HDTV 1 terminal, 3.3V T.M.D.S., 50 ohms The DVI-HDTV input terminal is compliant with the EIA-861 standard and is not intended for use with personal computers. 3 total (1 on front panel) 3 to tal (1 on front panel) 6 total (1 on front panel) 2 (Y, PB, PR) 1 Vp-p, 75 ohms unbalanced, sync negative Y: 1 Vp-p, 75 ohms unbalanced, sync negative C: 0.286 Vp-p (Burst signal), 75 ohms 500 mVrms (100% modulation) Impedance: 47 kilohm Y: 1.0 Vp-p, 75 ohms unbalanced, sync negative; PB: 0.7 Vp-p, 75 ohms PR: 0.7 Vp-p, 75 ohms Mini jack Mini jack Optical rectangular (1) 4-pin S400 i.LINK terminal 120V, 60 Hz 2-13 14-69 1-999 1-125
Video (IN) S Video (IN) Audio (IN) Component Video Input
CONTROL S (IN) CONTROL S (OUT) Digital Audio Optical Output (PCM/Dolby Digital) i.LINK
1 1 1 3 total (1 on front panel)
FLAT PANEL COLOR TV
Variable/Fixed Audio (OUT)
1
More than 408 mVrms at the maximum volume setting (Variable) More than 408 mVrms (Fixed) Impedance (output): 2 kilohms Phono jack
Sub woofer (OUT) RF Inputs Screen Size (measured diagonally) Speaker Output Dimensions (W H D)
1 2 55 inches 15W 2 Display unit: PDM-5510 Media receiver unit: MBD55XBR950
1710 870 109 mm (67 3/8 34 3/8 4 3/8 in) 430 79 342.8 mm (17 3 1/8 13 1/2 in) 62 kg (132 lbs 5 oz) 6.5 kg (14 lbs 8 oz) Display unit PDM-5510: 520 W Media receiver unit MBD55XBR950: 53 W
Mass
Display unit: PDM-5510 Media receiver unit: MBD55XBR950 In Use
Power Consumption
In Standby i.LINK standby Supplied Accessories Remote Control (1) AA (R6) Batteries (2) AC power cord (2) AC plug holder (1) Display interface cable (1) Antenna cable (1) Cleaning cloth (1) Operating Instructions (1) Warranty Card (1) Frame bars (2) Screws (4)
Under 1.5 W Under 22 W RM-Y1000
Design and specifications are subject to change without notice.
KDE55XBR950 (UC)
2
SAFETY CHECK-OUTAfter correcting the original service problem, perform the following safety checks before releasing the set to the customer: 1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder splashes and bridges. 2. Check the interboard wiring to ensure that no wires are pinched or contact high-wattage resistors. 3. Check that all control knobs, shields, covers, ground straps, and mounting hardware have been replaced. Be absolutely certain that you have replaced all the insulators. 4. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. 5. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement. 6. Check the line cords for cracks and abrasion. Recommend the replacement of any such line cord to the customer. 7. Check the antenna terminals, metal trim, metallized knobs, screws, and all other exposed metal parts for AC Leakage. Check leakage as described right. WARNING!! SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY SHADING AND MARK ! ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER CRITICAL COMPONENTS ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED.
LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The limit indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOMs that are suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)
AVERTISSEMENT!! ATTENTION AUX COMPOSANTS RELATIFS LA SCURIT!! LES COMPOSANTS IDENTIFIS PAR UNE TRAME ET UNE MARQUE ! SONT CRITIQUES POUR LA SCURIT. NE LES REMPLACER QUE PAR UNE PICE PORTANT LE NUMRO SPECIFI. LES RGLAGES DE CIRCUIT DONT LIMPORTANCE EST CRITIQUE POUR LA SCURIT DU FONCTIONNEMENT SONT IDENTIFIS DANS LE PRSENT MANUEL. SUIVRE CES PROCDURES LORS DE CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU LORSQUUN MAUVAIS FONCTIONNEMENT EST SUSPECT.
To Exposed Metal Parts on Set
0.15 F
1.5 k
AC Voltmeter (0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
KDE55XBR950 (UC)
3
DIAGNOSIS (Reliability Self Diagnostic Display Specifications for MEDIA RECEIVER) Error message by blink of LED1) If abnormalities are detected inside a unit, POWER LED blinks in RED automatically. A failure part can be expected by the number of times of blink of LED. When two failures occur, the failure item generated previously is detected. When failure occurs simultaneously, an item with little number of times of blink is detected.Blink times Error message Error point Fan in BOX DD converter on DP Board Panel abnormal detection Detection Normal : LOW detection, abnormal : HIGH detion Normal : HIGH detection, abnormal : LOW detectio At the time of communication with panel Repair part Fan or Fan connecter Q1612, Q1613, Q1614 on DP Board Panel display unit
4 Fan Error 8 Digital OVP 9 Panel Error
In other than Fan Error, the unit is in standby state and blink LED at intervals of regulation. In Fan Error, the unit is in a standby state after display for 1 minute about the message of Fan problem Powering down Timing of LED blink (example of 4 times blink) ON about 3s OFF every about 0.3s
2) In the following case, POWER LED of Media Receiver Box blinks at a fixed interval in ORANGE When the cable which connects between Media Receiver Box and Panel Display has fallen out. When the AC code for Panel Display has fallen out. In the following case, POWER LED of Panel Display blinks at a fixed interval in ORANGE When the cable which connects between Media Receiver Box and Panel Display has fallen out. When the AC code for Media Receiver Box has fallen out. 3) The example which judges whether it is failure POWER LED of Media Receiver Box: Blink 9 times in RED, and of Panel Display blink, and No picture or Power circuit does not work Large possibility that Panel Display is out of order. When turn on Media Receiver Box, and NO LED of Box shine Large possibility that Media Receiver Box is out of order. When NO Blue LED of Box shine Large possibility that Media Receiver Box is out of order. Check SET5V or IIC line on H1 board. When turn on Media Receiver Box, and Fan does not work Large possibility that Media Receiver Box is out of order
KDE55XBR950 (UC)
4
The screen display of self-diagnostic history
The case of failure which cannot check condition of Power supply is sometimes shut off , or Picture sometimes disappearing etc, we can check on the screen whether failure has occurred (whether the detection circuit has operated) before.
The display method of diagnostic resultFrom STANDBY state, push Remote Control quickly DISPLAY, CH5, VOL-, POWER in order. * 0 means no abnormalities, and it means that 1 had one detection or more. * 101:WDT ;LED dose not blink. 0 means the number of times of detection.
Self Diagnosis DisplayPower/Standby LED Media Rceiver(Box) Unit Display Unit
Symptom Blinking Red and Green by tums Blinking Red 7 times Blinking Red 6 times Blinking Red 4 times
Panel Module Error
Errors on Display Unit
Audio Error
Blinking Red 9 times
Power Supply Error
Thermal Error Over Voltage Error of ATSC Module Over Voltage Error of DC/DC Converter
Errors on Box Unit
Blinking Red 10 times Blinking Red 8 times Blinking Red 6 times Blinking Red 4 times
Lighting Red +B Power Error Fan Error Tum Off Blinking Orange Disconnect Power Cable of Display Unit or Disconnect I/F Cable Disconnect Power Cable of Box Unit or Disconnect I/F Cable
Cable Error
Blinking Orange Tum Off
KDE55XBR950 (UC)
5
TABLE OF CONTENTS1. DISASSEMBLY ............................................ 1-11-1. DISPLAY UNIT (PDM-5510) ........................... 1-1-1. REAR COVER REMOVAL ......................... 1-1-2. GF1 AND GF2 BOARDS REMOVAL ........ 1-1-3. GF3 AND KF1 BOARDS REMOVAL ........ 1-1-4. DEF BOARD REMOVAL ............................ 1-1-5. KF2 BOARD REMOVAL ............................. 1-1-6. SPEAKER ASSY REMOVAL ...................... 1-1-7. FILTER GLASS BRACKET ASSY REMOVAL ..... 1-1-8. RF1 BOARD REMOVAL ............................. 1-1-9. RF2 BOARD REMOVAL ............................. 1-1-10. DISPLAY PANEL REMOVAL .................... 1-2. MEDIA RECEIVER UNIT (MBD55XBR950) 1-2-1. TOP COVERS REMOVAL .......................... 1-2-2. QH BOARD REMOVAL .............................. 1-2-3. H1, H2, H3 AND H4 BOARDS REMOVAL 1-2-4. G BOARD REMOVAL ................................. 1-2-5. A BOARD REMOVAL ................................. 1-2-6. M AND UD BOARDS REMOVAL ............. 1-1 1-1 1-2 1-2 1-3 1-3 1-4 1-5 1-6 1-6 1-7 1-8 1-8 1-8 1-9 1-9 1-10 1-11 (9) Schematic Diagrams of UD Board ................ 3-55 3-4. SEMICONDUCTORS ....................................... 3-57
4. EXPLODED VIEWS ...................................... 4-14-1. 4-2. 4-3. 4-4. 4-5. 4-6. 4-7. 4-8. DISPLAY UNIT-1 (PDM-5510) ....................... 4-2 DISPLAY UNIT-2 (PDM-5510) ....................... 4-3 DISPLAY UNIT-3 (PDM-5510) ....................... 4-4 MEDIA RECEIVER UNIT-1 (MBD55XBR950) ....... 4-5 MEDIA RECEIVER UNIT-2 (MBD55XBR950) ....... 4-6 MEDIA RECEIVER UNIT-3 (MBD55XBR950) ....... 4-7 PACKING MATERIALS FOR DISPLAY UNIT (PDM-5510) ................ 4-8 PACKING MATERIALS FOR MEDIA RECEIVER UNIT (MBD55XBR950) .............. 4-9
5.
ELECTRICAL PARTS LIST ........................ 5-1
2. ADJUSTMENT .............................................. 2-12-1. White Balance Adjustment ................................ 2-1 2-1-1. Measuring instruments ................................... 2-1 2-1-2. Adjustment procedure .................................... 2-1
3. DIAGRAMS ................................................... 3-13-1. BLOCK DIAGRAMS ........................................ 3-1-1. DISPLAY UNIT (PDM-5510) ...................... 3-1-2. MEDIA RECEIVER UNIT (MBD55XBR950) ............. 3-2. FRAME DIAGRAMS ........................................ 3-3. CIRCUIT BOARDS LOCATION ..................... 3-3-1. DISPLAY UNIT (PDM-5510) ...................... 3-3-2. MEDIA RECEIVER UNIT (MBT55XBR950) .............. 3-4. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS ..... 3-4-1. DISPLAY UNIT (PDM-5510) (1) Schematic Diagrams of DEF Board .............. (2) Schematic Diagrams of GF1 Board ............... (3) Schematic Diagrams of GF2 Board ............... (4) Schematic Diagrams of GF3 Board ............... (5) Schematic Diagrams of KF1 Board ............... (6) Schematic Diagrams of KF2 Board ............... (7) Schematic Diagram of RF1 and RF2 Boards 3-4-2. MEDIA RECEIVER UNIT (MBD55XBR950) ............. (1) Schematic Diagrams of A Board ................... (2) Schematic Diagrams of DIC2 Board ............. (3) Schematic Diagrams of G Board ................... (4) Schematic Diagrams of H1 Board ................. (5) Schematic Diagrams of H2 Board ................. (6) Schematic Diagram of H3 and H4 Boards .... (7) Schematic Diagrams of IF Board .................. (8) Schematic Diagrams of M Board .................. 3-1 3-1 3-6 3-11 3-12 3-12 3-12 3-12 3-13 3-21 3-23 3-25 3-26 3-28 3-29 3-30 3-30 3-35 3-42 3-44 3-45 3-47 3-48 3-49 KDE55XBR950 (UC) 6
SECTION 1 DISASSEMBLY1-1. DISPLAY UNIT (PDM-5510)1-1-1. REAR COVER REMOVAL
2 Six screws (+BVTP 4x16)
1 Four screws (+PSW 5x16)
2 Two screws (+BVTP 4x16)
2 Two screws (+BVTP 4x16)
2 Six screws (+BVTP 4x16)
3 Five screws (+PSW 3x8)
4 Rear cover assy
KDE55XBR950 (UC)
1-1
1-1-2. GF1 AND GF2 BOARDS REMOVAL 2 GF2 board 3 Four screws (+BVTP 3x12) 4 GF1 b
1 Three screws (+BVTP 3x12)
1-1-3. GF3 AND KF1 BOARDS REMOVAL 1 Two screws (+PSW 3x8) 2 KF1 board 3 Two screws (+PSW 3x8) 4 GF3 bo
KDE55XBR950 (UC)
1-2
1-1-4. DEF BOARD REMOVAL 3 Two screws (+PSW 3x8) 4 DEF board
2 Two connector screws 1 Two screws (M2.6 S HEAD)
1-1-5. KF2 BOARD REMOVAL2 Screw (+PSW 3x8)
3 KF2 board
1 Two screw (+BVTP 3x
KDE55XBR950 (UC)
1-3
1-1-6. SPEAKER ASSY REMOVAL 2 Six screws (+BVTP 4x16) 3 Four screws (+PSW 4x14) 4 Box (55RL), speaker 9 Box (55RR), speaker Bracket (B), speaker box 6 Ten screws (+BTP 4x18) 8 Four screws (+PSW 4x14) Bracket (A), speaker box 7 Six screws (+BVTP 4x16)
1 Ten screws (+BTP 4x18)
5 Assy,speaker box (L)
Bracket (A), speaker box 0 Assy, speaker box (R)
Bracket (B), speaker box
KDE55XBR950 (UC)
1-4
1-1-7. FILTER GLASS BRACKET ASSY REMOVAL1 Two Screws (+PSW 4x14) 2 Plate V (55), FGB 7 Four Screws (+PSW 4x14) 8 Plate H (55), FGB
6 Plate V (55), FGB 4 Plate H (55), FGB 3 Four Screws (+PSW 4x14) qh Bar V (55), INNER qg Two screws (+KTP 3x8) 1 Two Screws (+PSW 4x14) qj Assy, filter glass bracket (55)
qa Six screws (FIXED)
qs Bar H (55)
9 Six screws (FIXED)
0 Bar H (55)
! Two screws (+KTP 3X8)
qf Bar V (55), inner
KDE55XBR950 (UC)
1-5
1-1-8. RF1 BOARD REMOVAL
4 Spacer, rocking card 1 Screw (+PSW 4x14) 2 Coner bracket
5 RF1 board 2 Coner bracket (55) 1 Screw (+PSW 4x14) 3 Assy, filter bracket V (55R)
1-1-9. RF2 BOARD REMOVAL1 Screw (+PSW 4x14) 2 Coner bracket (55) 1 Screw (+PSW 4x14) 4 Assy, filter bracket H (55BT) 5 Spacer, rocking card
3 Assy, filter bracket V (55L)
2 Coner bracket (55)
6 RF2 board
KDE55XBR950 (UC)
1-6
1-1-10. PLASMA DISPLAY PANEL REMOVAL
1 Assy, filter bracket H (55TP) 2 Display panel (55)
Glass, optical filter (55)
KDE55XBR950 (UC)
1-7
1-2. MEDIA RECEIVER UNIT (MBD55XBR950)1-2-1. TOP COVERS REMOVAL
1 Four screws (M3, SW)
3 Screw (M3, SW) 4 Screw (+BVTP 3x12)
3 Two screws (M3, SW) 4 Screw (+BVTP 3x12)
3 Two screws 3 Screw (M3, SW) (M3, SW)
2 Top cover
5 Four screws (HEX) 4 Five screws 6 Two screws (+BVTP 3x12) (GRIP, M2.6 S HEAD)
7 Rear panel assy
8 Front panel assy
1-2-2. QH BOARD REMOVAL
3 Two screw (+BVTP 3x12)
2 QH board
1 Screw (+BVTP 3x12)
Front panel assyKDE55XBR950 (UC) 1-8
1-2-3. H1, H2, H3 AND H4 BOARDS REMOVAL1 Two screws (+BVTP 3x12) 2 H1 board 3 Four screws (+BVTP 3x12) 5 Two screws (+BVTP 3x12)
6 H3 board
4 H2 board
7 Three screws (+BVTP 3x12) 8 H4 board
1-2-4. G BOARD REMOVAL1 Seven screws (+PSW 3x8)
2 G board
KDE55XBR950 (UC)
1-9
1-2-5. A BOARD REMOVAL2 Two screws (+PSW 3x8)
2 Two screws (+PSW 3x8) 3 D block assy 1 RFcable
4 Two screw (+PSW 3x8)
4 Two screw (+PSW 3x8)
5 Case(UP) M block shield 6 Three screws (+PSW 3x8) 8 RFcable
7 A board
KDE55XBR950 (UC)
1-10
1-2-6. M AND UD BOARDS REMOVAL3 Five screw (+PSW 3x8) 4 M board 1 Four screws (+PSW 3x8) 2 UD board
KDE55XBR950 (UC)
1-11E
SECTION 2 ADJUSTMENTS2-1. White Balance Adjustment 2-1-1. Measuring instruments1. 2. Color analyzer (Minolta CA-100) Signal oscillator VG-828D 6. Adjust R_GAIN_OFFSET, G_GAIN_OFFSET, and B_GAIN_OFFSET in the service mode menu so that the following specified values are satisfied. Always adjust one of R_GAIN, G_GAIN, and B_GAIN to 225, and adjust parameters for the others to meet the following specified values.W/B 6500K+8MPCD 8000K+8MPCD 9300K+8MPCD 0 1 2 3 X 0.3133 0.003 0.2944 0.003 0.2838 0.003 0.2684 0.003 Y 0.3297 0.003 0.3100 0.003 0.2981 0.003 0.2700 0.003
2-1-2. Adjustment procedure1. Plug the AC cable into the panel unit, and check the fade-in effect of the SONY LOGO LED.
Checking SONY LOGO LED blinkingDisplay Repeat of red blinking (4 times) Red/green blinking Check item Defect of temperature sensor (Check DEF board CN3306 and relay connector for abnormality or disconnection.) - Harness disconnection between DEF board CN3801 and PANEL - Harness disconnection between GF1/ GF2 boards and PANEL (PANEL side: CN301, CN302, GF1/GF2 side: connectors) When no problem is found, there may be defect in NPD module. GF1 board 3.3 V output Harness disconnection between DEF board CN3304 and GF1 board GF1 board Low+B output Harness disconnection between DEF board CN3304 and GF1 board Harness disconnection between DEF board CN3301 and KF1 board
13550K
Repeat of red blinking (6 times) (Approx. 6 seconds from power ON) Repeat of red blinking (6 times) (Approx. 12 seconds from power ON) Repeat of ewd blinking (7 times)
Save the adjustment values. Execute the following from the JIG PC with the UART control. 8-1. Set WHITE_BALANCE=1, and then carry out step 6. 8-2. Set WHITE_BALANCE=2, and then carry out step 6. 8-3. Set WHITE_BALANCE=3, and PLEC=0 and then carry out step 6. 9. Input the following signals from the signal oscillator to check brightness. 9-1. When all-white signal (195/255) is input Brightness Y=42 cd/m2 or more 9-2. When 1/25Window signal (204/255) is input Brightness Y=220 cd/m2 or more 10. Detach the white balance adjustment jig CA-100 from the grass surface.
7. 8.
2. 3. 4. 5.
Press the white balance adjustment jig CA-100 against the panel grass surface. Connect the signal oscillator VG-828D to the DVI terminal. Input the magic square pattern of gradation level 211. Set the following items in the service mode menu.:1 :1 :0 :0 :1 :4 :0 : 63 :1 : 31 :1 : 31 G_GAIN_OFFSET B_GAIN_OFFSET R_BIAS_OFFSET G_BIAS_OFFSET B_BIAS_OFFSET SUBBRIGHT_R SUBBRIGHT_G SUBBRIGHT_B RKOF GKOF BKOF : 31 : 31 : 31 : 31 : 31 : 1024 : 1024 : 1024 :0 :0 :0
TEST_MODE POWER SET_FEATURE WHITE_BALANCE PLEC GAMMA DITHER CONTRAST UPCS BRIGHTNESS UBCS R_GAIN_OFFSET
CONTRAST_OFFSET : 45
PDRV_SUBCONT_R : 512 PDRV_SUBCONT_G : 512 PDRV_SUBCONT_B : 512
BRIGHTNESS_OFFSET : 31
KDE55XBR950 (UC)
2-1E
SECTION 3 DIAGRAMS3-1. BLOCK DIAGRAMS3-1-1. DISPLAY UNIT (PDM-5510)
TO MEDIA RECEIVER UNIT (BLACK)
CN3101 UART_IUART_I+ UART_OPOWER ON UART_O+ MODE JIG CABLE DET SIRCS+ RXD TXD SIRCSSPDIF+ RESET SPDIFSTBY
A1 A3 A4 B5 A6 B6 A7 B7 A8 B8 B9 A10 A11 B11 A13 B13
D3108-D3111 OVER VOLTAGE PROTECTER
2
IC3111,IC3103 LINE DRIVE 7 2 8 6 3 5 5 6 7 8 2 3
RXD0 SPDIF SIRCS TXD0
1
SCL SDA TO 2/2
TO 2/2
3 1
TO 2/2
Q3111 LEVEL SHIFT IC3107 SERIAL BUS SELECT 12 13 14 15 11 1 3 5 2 4 9 10
IC3109 TMDS RECEIVER 30 96 PROM SDA QE23 20 93 DDC SDA 95 PROM SCL QE7 10 92 DDC SCL QE8 QE15 17 G0-G7 8 IC3110 48 HSYNC 47 VSYNC 46 DE 44 0DCK 182 157 181 171 197 8 QE0 27 B0-B7 8 217-219 229 236-232 241 242 253,254 265,266 277,278 289 RV17 QE16 37 R0-R7 193-195 205-208 220
IC3501 CPU 103,104 129,130 154-156 162,166 R0-R9 178
IC3801 LVDS TRANSMITTER TATA+ TBTB+ TCTC+ TCLKTCLK+ TDTD+ TETE+ 31 30 29 28 25 24 23 22 21 20 19 18 3 4 5 6 7 8 10 11 12 13 14 15 CN3801 TATA+ TBTB+ TCTC+ TCLKTCLK+ TDTD+ TETE+
TO 2/2 IC3108 EEPROM
RV10
RAO0 RAO9
Q3120 IC3102 BUFFER 10 Q3119 3.3V-4 5 SDA 6 SCL 7 WP
PD1
9 13 +3.3V-4 MODE 12 1 RXD1 2 4
8
RES
PD0
BU10 BU17
BAO0 BAO9
11
MODE
4TO 2/2 Q3108
GY10 GY17
GAO0 GAO9
13 PXD1 TO 2/2 WP 5 TXD1
4,5 33-38 59,61 TE0,TE1 TA0-TA5 10 204,215 1,9,11 48-50 216,222 52-54 226,228 64 TE4,TE5 237-240 B0-B9 TB6 168 10 TC0-TC3 6,8 TD0,TD1 179,180 40-42 190-192 44-46 201-203 G0-G9 62,63 TE2,TE3 214 TA6 10 TB0-TB4 TD2,TD3 399 426 427 454 373 IC3802 RESET 4 OUT 55 57 58 3 12 13 TC4 TC5 TC6 TD6 CLKIN PWDN
TO PDP UNIT
SEL0
SEL1
TXD1 JIG Q3110
6
4IC3101 VOLTAGE COMP. 2 1 3 5 6 TO 2/2 DET
6TO 2/2
HSCS1 HSADOUT1 VS1 DE1 CLK1
HSO VSO DEO OFPARITY CLKO
1TO 2/2
Q3101 CN3102 DATA2DATA2+ DDC SCL DDC SDA DATA1DATA1+ +5V POWER HOTPLUG DET DATA0DATA0+ CLOCK+ CLOCK-
7TO 2/2
SCDT
8 SCDT P_MUTE VCC 2 80 81 83 84 86 87 89 90 RX2+ RX2RX1+ RX1RX0+ RX0RXC+ RXCQ3801,Q3802 +3.3V IC3602 DOUBLE DATA RATE SDRAM DQ0 DQ31 A0 A11 29 30 2 BA0 BA1 23,24 56,57 DM0-DM3 115 67 18 44 43 8 42 16 17 4 58 25 26 27 28 94 53 54 55 VREF WE CAS RAS CS DQS CKE CK CK
7
8TO 2/2
5TO 2/2
SCL SDA CPUG0 PDPG0 IRQ
TO MEDIA RECEIVER UNIT (WHITE)
1 2 6 7 9 10 14 16 17 18 23 24
19 21 23 25 27 29
SCL SDA CPUG0 PDPG0 IRQ PDWN
D3104,D3106 LIMITER
DQ00 DQ31
1-7 9-15 28-41 57,59,60,64 22-25 47-50 72-75 32 31-34,36,37 45,47-51 12
IC3104 BUS LINE BUFFER SCL SDA 2 7 3 6 Q3105 LEVEL SHIFT
A0-A11
19,45 BA0-BA1 20,21 46,71 DM0-DM3
8 Q3118 SW +5V-4 +3.3V MREF WEN CASN RASN CSN DQS CKE CKN CKP
TMDS RECEIVER, DEF(1/2) LVDS TRANSMITTER
KDE55XBR950 (UC)
3-1
IC3352 2.5V REG 2 VCC OUT +2.5V IC3305 3.3V REG 1 7 VIN VOUT 5 CONT 7 1 2 5 6 8 9 10 11 12 +3.3V +12V IC3306 I/O EX 4 7 6 5 17 22 SCL SDA +3.3V_2 CN3306 PANEL HIC HIC2 Q3106,3107 3.3V SW 1 3 5 14 THERMO PANEL 15 THERMO HIC 13 THERMO HIC2 12 WRO RD AS WR1 CS1 MCLK BUS_SW 71 70 81 72 59 79 41 19 18 16 20 21 22 47 48 1B1-1B10 2A5 2B1-2B8 2A4 2A3 2B3 2A6 2B4 2A7 2B5 2A8 2B6 2B7 1OE 2B8 2OE IC3405 BUS SW 2-7 9-14 1A1-1A10 2A1,2A2 34-40 42-46 33 31 30 29 28 27 IC3501(1/2) CPU 371 396-398 423-425 452,453 478-480 445 392 418 472 444 391 I/O00 I/O03 I/O02 I/O01 I/O14 SCL SDA I/O17 18 SCDT I/O15 14 PD1 I/O11 13 PD0 1/O10 19 WP I/O14 1 INT IC3112(1/2) 5 3 20 6 30 TEST D0 85-100 16 29-36 D0-D15 38-45 D0 D15 15 RY/BY 26 CE 28 OE 11 WE IC3112(2/2) 6 3 5 1 2 +5V-4 3.3V_4 IC3451 1.8V REG 5 VIN VOUT 4 1 CONT
IC3304 5V REG 7 VIN VOUT 5 CONT CN3304 3.3V 3.3V 12V STBY_6V POWER_ON VPR2 PANEL_MUTE OVP AC_DET
+1.8V IC3401 PANEL MCU
2
TO 1/2 82 AC SW 83 POWER ON 1-4 103-109 111-118 120 20 1-9 48 A1-A20 16-25
IC3403 FLASH MEMORY
A1 A20
A1 A20
ATO GF1 BOARD CN6005
7 4
TO 1/2
D15 40 RY/BY 58 CSO
TO 1/2 IRQ
5
12 RES
TO 1/2
22
A1-A12
CPUA1 CPUA12 12
BIC701 SIRCS +5V VCC OUT TO KF1 BOARD CN3001
CN3301 +3.3V SP DIF +12V SDA SCL AU_PROT AU_MUTE AU_RES
Q3351 SW 8 1 3 4 6 7 8 9 10
IC3351 EEPROM 6 SCL VCC 5 SDA 7 WP 49 47 46 48 42 SCL2I SCL2O SDA2O SDA2I NVM_WP
Q3304 LEVEL SHIFT
SDA SCL
CPUCS_X CPURD_X CPUWR0_X CPUWR1_X CPUAS_X CPUCLK_X
SDA SCL SPDIF SIRCS
38 SDA1 39 SCL1 54 D0-D15 XO 16
IC3406 2-7 BUS SW 9-14 16 18-20 1A1-1A10 2A1,2A2 48 1OE 48 2OE
D701 POWER Q701 Q706 D703 TIMER LED DRIVE
STBY5V
1 2 4 5 6 7 8 9
CN701 STBY5V SIRCS MUTE TIMER2 TIMER1 POWER STBY SAVING
3TO 1/2 IC3308 D/A CONVERTER 2 3 4 5 6 1 AO2 AO3 AO4 AO5 AO6 AO1 AO12 AO11 AO9 AO10 AO7 SCL SDA 12 11 9 10 7 20 21
29-31 33-40 42-46
393,398 419-422 446-450 CPUD0-15 473-477 16
CPUD0 CPUD15
X3401 10.5MHz
53 XI
CN3302 STBY5V SIRCS MUTE TIMER2 TIMER1 POWER STBY STBY 5V
IC3353 2 20 4 68 67 26 29 25 28 21 80 76
1 2 4 5 6 7 8 9
SEL0 SEL1
6Q3303 LEVEL SHIFT
TO 1/2
D705 MUTE
SCL SDA 57 LED_ON
CLS PLLBP SO0 SO1 SI0 SI1 CABLE DET SW-1 RESET
54 CL_X 27 PLLBP TXD0 TXD1 RXD0 RXD1 DET MODE RES
1TO 1/2 4 VOUT VDD IC3402 RESET 1 STBY3.3V
RF1Q751-Q754 LED SW 1 2 CN751 STBY5V LOGO TO FAN
(SIRCS,LED)
CN3303 LOGO STBY5V
2 1 Q3305,3306 5V SW
STBY5V
S3351
IC3303 FAN DRIVE CN3304 DRV DRV DRV DRV 3 2 4 6 8 1 VOUT VIN 2 CONT 4 ADJ +12V
5TO 1/2
PDPGO CPUGO
35 FHP PDPGO 36 FHP CPUGO
D751-D754 D761-D763
TEST SW-4 SW-3 12C-EN FEAT2 FEAT3
27 69 78 37 61 62
3.3V
RF2(LED)
DEF(2/2)(MCU)
KDE55XBR950 (UC)
3-2
+R -R CN7005 -L +L CN3001 +3.3V SPDIF +12V SDA2 SCL2 SP-PROT MUTE RES IC3001 DIGITAL AUDIO RECEIVER 1 3 5 6 7 8 9 10 +3.3V 44 RX1 +12V 33 SDA 34 SCL 27 MCKO2 26 BICK 25 SDTO 24 LRCK 1 MCLK_IN 17 SCLK 19 SDIN 18 LRCLK 7 RESET 31 PDN 29 37 INT1 30 X3001 24.576MHz IC3002 SP PROTECT CONTROL 13 10 11 8 12 9 2 3 4 1 6 5 38 MUTE 29 PWM_AP_R 28 PWM_AM_R 9 VALID_R 32 17 28 29 20 21 5 SHOTDOWN PVDDA2 PVDDB2 PVDDA1 PVDDA1 PVDDB1 PVDDB1 RY7002 35 PWM_AP_L 34 PWM_AM_L 23 VALID_L 1 15 2 16 14 PWM_AP PWM_BM PWM_AM PWM_BP RESET 26 OUTPUTA 27 OUTPUTA 22 OUTPUTB 23 OUTPUTB IC3003 DIGITAL AUDIO PROCESSOR IC3004 AUDIO OUT L3004 L3005 CN3003 4 3 2 1 L+ LR+ RCN7002 4 3 2 1 +12V RY7001 CN7004 L+ LRR+ SPEAKER L R
BTO DEF(2/2) BOARD CN3301
4 3 2 1
GTO GF1 BOARD CN6001
12V
CN7001 1
+12V +12V
KF2(SP
RELAY)
+3.3V
IC3004 AUDIO OUT Q3001 Q3002 Q3003-Q3005 OVER OUTPUT DETECT 1 15 2 16 14 5 PWM_AP PWM_BM PWM_AM PWM_BP RESET SHOTDOWN 26 OUTPUTA 27 OUTPUTA 22 OUTPUTB 23 OUTPUTB
ETO GF1 BOARD CN1006
CN3002 GATE-DRIVE AUDIO_VCC AUDIO_VCC
3 4 5
L3008 F3002 F3003 F3005 F3006
Q3017 VCC REG
32 PVDDA2 17 PVDDB2
28 PVDDA1 29 PVDDA1 20 PVDDB1 21 PVDDB1
(AUDIO KF1
OUTPUT)
KDE55XBR950 (UC)
3-3
Q6916,Q6915
IC6403 REG D6908 IC6301 DRIVER 8 VC1 D6308 7 SS Q6303 SS 2 F/B 1 2 4 D6307 3 13 4 12 IC6405 12V REG D1321 PH6903 ISOLATER 4 1 2 IC6901 PH6902 ISOLATER 1 2 CN6002 POWER STBY6V 4 3 D6904 IC6904 OVP,LVP 1 STBY6V 1 2 Q6904 Q6903 CN001 RLY VCC PH6901 ISOLATER 4 3 D6910 LATCH D6907 1 2 4 5 13 11 10 9 8 +5V 14 IC6905 BUFF 12 13 Q6912 14 D6903 D6909 LATCH D6905 7 6 4 3 CN002 PFC LVP INRUSHT PH6902 ISOLATER 1 2 Q6403 Q6404 D1307 Q1305 CONV 2 3 4 5 9 10 10 CN6009 VSAGO VCEGO VRS VRA VPR2 VCC VCC O I IC1303 +5V REG 3 1 VCC OUT 2 CTL 2 VCC 1 2 3 6 VC D1304 Q1304 CONV 26V STBY6V VS 13V 12 VG(L) 9 OCP D6310 CN003 VCC 18V GND PFC OUT Q6302 CONVERTER 2 8 Q1309 VCC CONTROL 9 D1301 7 6 12V 1 VIN SW OUT 2 1 2 5 6 8 9 10 11 12 IC1302 REG CN6005 3.3V 3.3V FAN 12V STBY 6V POWER ON VPR2 PANEL MUTE OVP THERM-G 1 2 3 VG(H) 15 16 Q6301 CONVERTER 1 T1201 PIT D1302 11 Q1308 VCC SW CN1006 AUDIO Vcc AUDIO Vcc 26V VCC OUT
ETO KF1 BOARD CN3002
CTO GF2 BOARD CN6004
ATO DEM(2/2) BOARD CN3304
IC1306 DRIVE TH6901 5 HDRV 1 FB 3 LDRV
DTO GF2 BOARD CN6003
TO PANEL BLOCK
HTO GF3 BOARD CN604
2 3
FTO GF2 BOARD CN6002
Q6503 SW
IC6501 DRIVER Q6501 CONVERTER 3 Q6502 CONVERTER 6 T6501 PIT 15 12 10 PH6601 ISOLATER RV6902 VD_ADJ D6601 60V
D6604
IC6903 V REF
2 3
1
1 16 VSENSE VG(H) D6501 15 8 VC1 VS 12 7 SS VG(L) 2 F/B 9 OCP Q6504 SW
IC6902 1 2 3 4 8 9 10 CN6010 VA VA VCC VCC VS VS VS
D6605 Q6602
Q6602 DISCHARGE
TO PANEL BLOCK
D6804 PH6802 ISOLATER Q6801,Q6802 Q6905 Q6907 Q6908 Q6914 Q6906 SW T6701 PIT 3 D6701 1 VSENSE VG(H) 8 Q6704 SW VC1 7 SS 2 F/B VG(L) Q6706 9 OCP 10 VC2 D6706 6 PH6901 ISOLATER 12 7 RV6901 VD_ADJ 5 6 IC6907 IC6906 CONTROL VS 12 Q6702 CONVERTER 3 15 Q6707 IC6701 DRIVER 16 Q6701 CONVERTER T6702 PIT 16 Q6804 6 16 12 Q6803 DISCHARGE 8 9 10 Q6913
D6801,D6802 80V
GF1(POWER)
Q6703 SS RES
KDE55XBR950 (UC)
3-4
AC INLET AC AC
CN601 2 1
F601
RY601
T601,T602 2 1
CN603 AC AC
CN6001 AC AC
D6002 D6005 RECT RY6001 2 1
D6002,D6005 L6001 L6201-L6203 D6207 1 2 4
CN6004 VCC 18V PFC GND PFC OUT
CTO GF1 BOARD CN003
FQ601 RELAY DRIVE D601 T604 LFT TH601 1 3 5 6 D604 L602 10 7 2 3 CN604 POWER ON ST-BY 6V TO GF1 BOARD CN001
CN6002 RLY VCC RLY GND
Q6201-6203 PFC SW 1 4 D6001 IC6203 18V REG Q6206,Q6208 PFC DRIVE 3 OUT 1 VCC 2 CTL Q6209 1 2
CN6003 PFC LVP INRUSH T
DTO GF1 BOARD CN002
HTO GF1 BOARD CN6002
Q6215 OVP Q6216 Q6217 LATCH IC6202 PROTECT 12 14 13 3 2
IC601 DRIVE 7 SOURCE 8 SOURCE 2 VCC 4 FB PH601 IC6204 VREF IC6201 DRIVE Q6212 LVP 5 6 10 9 Q6247 SS RV6201 Q6211 OVP D603
1
IC612 VREF
GF3
(LINE FILTER,STBY6V)
16 OUT 15 VCC 9 VREF 3 I ERR
7
8
13 SS 11 VFB
Q6204 Q6205 D6209 SS
GF2(POWER SUPPLY)
KDE55XBR950 (UC)
3-5
3-1-2. MEDIA RECEIVER UNIT (MBD55XBR950)TO G BOARD CN6004 TO G BOARD CN6002 TO G BOARD CN6003
J
K
ATSC 9V ATSC 9V SET 9V SET 6.5V ATSC 5V ATSC 5V
SET 11V SET 11V REG SW
D 5V A 5V 33V STBY 5V
L
TU8001 MAIN TUNER
TU8000 SUB TUNER
CN8401 SET 5V 1.8V DD2a 4b 6b 8b
10b 12b
AUDIO R
AUDIO L
15a
3.3V DD SCL SDA 2.5V DD
20b 22b 25a 27a 38b
Q8001
Q8000
SUB-AFT
IC9301 3.3V REG 1 SET 11V 5
2 3.3V DD40b 41a 42b
Q8006 J9407 D1_Y D1_Y D1_CB D1_CB R D1_CR D1_CR L R J9406 L D1_L R D1_R HD/DVD IN V1 Y1 C1 L1 R1 S_SW1 V3 Y3 C3 L3 R3 S_SW3 V2 Y2 C2 L2 R2 S_SW2 Y1 15 17 19 16 18 21 8 10 12 9 11 14 22 24 26 23 25 28 58 V3 Y3 C3 LV3 RV3 S3 V2 Y2 C2 LV2 RV2 S2 V4 Y4 C4 LV4 RV4 S4 COUT1 Q9405,9417 44 Y/VOUT2 Q9416,9404 47 COUT2 12 C2 10 Y2 61 RV6 59 LV6 Q9415,9403 56 YOUT1 Q9406,9402 5 C1 3 Y1 L 62 LTV 64 RTV IC9400 AV SW1 VIDEO AUDIO L AUDIO R 22 23 25 15 16 18 V4 LV4 RV4 V3 LV3 RV3
IC8200 AV SW2 1 IC8402 VIDEO SW
IC9302 2.5V REG 2 2.5V DD SET 9V 5 CR 9 3 1 16 14 11 6 7 3 12 5 2 Q8407 SW Q8201 56 Q8410 BUFFER Q8411 BUFFER VIDEO Q8412 BUFFER 1 5 IC9303 1.8V REG 2 1.8V DD VIDEO
43a 44b 45a 46b 47a 48b 49a
5V 5V 1.8V 1.8V 1.8V I_BINT I_MICON_VP 3.3V 3.3V B_12C_SCL_5V B_12C_SDAL_5V I_BOARD_RESET 2.5V I_SUB_C/CB 2.5V I_SUB_Y_CV 2.5V I_MAIN_CR 9V I_MAIN_C/CB 9V I_MAIN_Y/CV CN9406
DE-EM OUT
DET OUT 2
DET OUT 2
CN9405
CN9403
SDA SCL SAP IND AFT OUT
DET OUT
MODE F MONO
RF AGC
R OUT
L OUT
SDA SCL AFT OUT
1 2 5 7 9 10
CN9404
SDA SCL
VIDEO
SDA SCL
SET 9V SET 6.5V ATSC 5V
SET 11V
ATSC 9V
Q8002 INVERTER
D 5V A 5V 33V STBY 5V
1 3 5 7
1 2 5
Q8003 BUFFER
SUB-HSYNC
Q6201, Q6202 BUFFER
Q8210, Q8202 BUFFER
HTO IF BOARD CN9851
Q8206 44 Y/VOUT2 Q8205 47 COUT2 VIDEO
Y
CB
1 2 3 4 5 8 9 10
AC_DET P SW(-) AC RELY FAN PROT iLINK STBY 9V_OVP FAN ON/OFF FAN HIGH/LOW CN9407
ITO G BOARD CN6005
J9405 D2_Y D2_Y
YOUT1 Q8200 58 COUT1 IC8506 A/D CONV. 2 AUDIO L 3 5 AUDIO R 6 IC8510 1 AUDIO L 2 AINL 10 LRCK 45 ROUT2 7 AUDIO R 11 MCLK 11 5 10 31 BCKO 12 SCLK 8 9 XI 11 XO 9 SDT0 25 SDI0 3 SDO0 STBY 5V X8501 36.864MHz 10 1 AINR 4 30 MCK 5 SLC/SCK 6 SDA/SDOUT Q8501 LEVEL SHIFT SCL SDA ATSC 5V ATSC 9V 6 2 RESET 13 IC8502 BUFFER 32 LRC IC8504
D2_CB D2_CB D2_CR D2_CR
52 LOUT1 54 ROUT1 43 LOUT2 45 ROUT2 33 SCL 34 SDA SCL 12C_M SDA
2 LV1 4 RV1 LOUT2 9 LV2 11 RV2
43
A1 B1 A2 A3 A4 A5 A6
TV_TXD TV_RXD BOX_RST AC_INT TO OM BOARD +5V +9V +9V CN8001
J9404 L D2_L R D2_R
J9402
62 LTV 64 RTV 29 LV5 31 RV5 SCL SDA 33 SCL 34 SDA
11a 11b 12a 13a 13b 14b 15a
C1 3 S VIDEO 1 2 S_SW1 VIDEO1 V1 VIDEO L1 L AUDIO R1 R D2_CR D2_CB D2_Y D1_CR D1_CB D1_Y 4
IC8400 COMPONENT-I/F 1 27 IN3-1 SELYOUT 2 IN3-2 3 26 IN3-3 SELCBOUT 41 25 IN2-1 SELCROUT 42 IN2-2 43 IN2-3 Y CB CR
12C_M
16a 17a 17b
IC8503 BUS BUFFER 13 12 11 2 DRCK 11 AOUTL IC8507 D/A CONV. IC8509 2 1 3 IC8600 VIRTUAL DOLBY 72 LIN LIN 42 IC8805 SURROUND 64 LIN 62 FLIN 63 RIN 61 FRIN 60 RLIN 58 OUTA IC8804 2 1 3
19b 21a 22b
Y3 C3 3 S VIDEO 1 2 S_SW3 VIDEO2 V3 VIDEO L3 L 20 AUDIO R3 R SCL SDA CN9401 R2 L2 V2 C2 Y2 S2-2 S_SW2 CN8400 PR PB Y L R CN8403 5V D_PR D_PB D_Y CN8402 1 3 5 7 1 3 5 7 9 2 4 6 8 10 11 12 R2 L2 V2 C2 Y2 S_SW2 2 2.5V DD VDD RESET 30 SCL 31 SDA IC8501 RESET EXTCLK/XTAL X8400 PD 9 8 4 SDAT 4 ATSC_CR 33 IN1-1 ATSC_CB 34 IN1-2 ATSC_Y 35 IN1-3 DVI_PR DVI_PB DVI_Y 7 IN4-1 8 IN4-2 9 IN4-3 1 2 4 5 10 6 3 BICK 3 6 MCLK AOUTR
IC8508 3 1 2 6 5
IC8806 3 1 AUDIO L 2 6 5
24a 24b 26a 26b
10
5 6
7
73 RIN RIN
43
7
OUTB
5 6
7 AUDIO R
27a 27b 28a
7
SCL SDA X8601 14MHz
16 SCLK 17 28 SDAT LPF1OUT 44 19 COUT CLK2 20 CLK1 VCC 23
22 SDA 23 SCL
28b
SDA SCL IC8601 4 5 3 SET 11V SDA SCL
29a 29b
BINT RESET_DEL VP RESET STBY 5V FAN_PWR_SW FAN_SPEED LINE_MUTE WOOFER MUTE CONTROL_S SUR_R_OUT SUR_L_OUT VAR-R VAR-L NT-SW MAIN-HSYNC SUB-HSYNC MAIN-AFT SUB-AFT AGC O-SAP I-SAP FMONO
MTO M BOARD CN4404
5
32a 32b 35a 35b
1
Q8810 BIAS SET 9V 6 7
IC8803 1 3 2
GTO H2 BOARD CN9601
IC8072 BUFFER 1 5 6
36a 36b
J940337a
7 WOOFER Q8806 AUDIO L L IC8801 BUFFER 3 2 6 5 2 3 1 Q9301 OVP 7 STBY 5V SET 5V Q8803 Q880440a 42b 43b 44b 45b 46b 47b 48b 37b 38a 38b 39a
5 Q8807 D8806 7 IC8800 BUFFER 5 1 6 AUDIO R
Q8809 MUTE CTRL
-
R
39b
CTO UD BOARD CN7003
SET 6.5V SET 9V Q9408-Q9414
49b 50b
SDA-MAIN SCL-MAIN /AC_INT TV-RXO /BOX-RST P-SW(-) TVT-XD AC_RLY_iLINK ATSC_OVP AC_RLY_STBY OVP FAN_PROT AC_DET STBY 5V STBY 5V SET 5V SET 5V SET 6.5V SET 6.5V SET 6.5V SET 6.5V SET 9V J9401 SIRCS IN
BTO UD BOARD CN7003
D_L D_R
1 3
A(AV
SW,COMPONENT-I/F,TUNER,AUD O AMP)
SIRCS OUT
KDE55XBR950 (UC)
3-6
CN9401
J9601 CN9601AUDIO L R
S VIDEO VIDEO 2 IN VIDEO L AUDIO R LED DRIVE D9805, D9806 D9812 Q9801 Q9807 1 3 4 10 11 IC9801 LED CTRL A01 A03 A04 DA10 DA11 20 SCL 21 SDA STBY5V 5V
2 4 6 8 10 12
R2 L2 V2 C2 Y2 S_SW2 CN9802
GTO A BOARD CN9401
TO A BOARD CN8402
CN7003 D-R D-L D-Y D-PB D-PR 5V CN7002 2 4 6 8 10 12 FL7000-7002 IC7004 DVI DRIVER 10 46 10R/Y RX2+ 13 47 10G/PB RX216 10G/PR 53 RX152 RX1+ 2 3 4 5 6 7 DVI5V 59 RX058 RX0+ 61 RXC+ 62 RXCIC7003 ESD IC7002 MCU 18 10 VGA AIN7 21 MUTE 8 RESET 24 SCL 28 SDA 7 WP SDA IC7006 NVM 6 5 35 DVI-SCL 36 DVI-SDA 95 XTALOUT 94 TCLK X7000 14.318MHz 1 2 1 2 5 6 1 2 IC7001 ESD 5 6 CN7001 1 2 6 7 9 10 14 16 17 18 23 24 RX2RX2+ SCL SDA RX1RX1+ 5V HPO RX0RX0+ RXC+ RXC-
B1 2 4 5 6 7 8 9 11 12 STBY5V 5V P_SW P ON TIMER LED iLINK LED STBY LED POWER LED SCL SDA
CTO A BOARD CN8403
BPF DV15V
SCL SDA
ETO M BOARD CN4401
DTO M BOARD CN4301
D9521 TIMER STBY5V 5V D9520 POWER/STBY Q9511-9517 LED SW 5V S9501 POWER 5V D9525 iLINK STBY
VGA MUTE DVI-NRST UD-BINT SCL SDA
TO PDP UNIT
32 SDA 31 SCL
CN9503 1 3 4 5 6 7 8 STBY5V P_SW P ON TIMER LED iLINK LED STBY LED POWER LED
CN9803 1 3 4 5 6 7 8 5V
IC7003 ESD 5 6
H2 H1
2 OSCOUT 3 OSXCIN X7001 12MHz
UD(DVI
DRIVER)
KDE55XBR950 (UC)
3-7
IC6750 DC-DC CONV. 21 20 19 18 6 1 D6755 16 18 VD 8 VC1 7 F/B RY6001 RY6002 STBY6.5V D6006 2 9 OCP 15 VS 12 CG(L) Q6003 CONVERTER 3 13 14 11 12 15 16 8 17 7 D6024 18 PH6002 Q6014 D6017-D6019 1 I VC O IC6009 +5V REG 2 D6022 1 I O IC6007 +9V REG 2 VG(H) Q6004 CONVERTER 5 T6004 PIT FOR VCC D6020 10 VDD VDD VDD VDD VDD VDD VOUT VOUT VOUT OCL+ OCL+ 11 12 13 25 27
IC6751 FAN DRIVE L6750 1 2 3 CN6005 1 2 3 4 5 8 9 D6753 1 2 5 7 5 6 AC DET(NC) P SW(-) AC RELAY FAN PROT iLINK STBY 9V OVP FAN ON/OFF CN6002 ASTC 9V ASTC 9V SET 9V SET ASTC 5V ASTC 5V CN6003 1 3 5 7 D 5V A 5V 33V STBY 5V CN6004
D6005 AC INLET CN6001 AC IN AC IN 3 2 1 T6001 D6004 F6001 IC6002 DRIVER
Q6751
Q6010, Q6011 SW
ITO A BOARD CN9406
Q6001 RELAY DRIVE PH6004
IC6006 +5V REG 1 I O 2
KTO A BOARD CN9403
D6033
LTO A BOARD CN9404
IC6010 +5V REG IC6005 1 I D6026 Q6012 +33V REG 1 2 4 5 VC O 2 1 2 5
SET 11V SET 11V REG SW CN6101 FAN FAN FAN FAN POWER PROT1 POWER PROT2
JTO A BOARD CN9405
D6032
D6101 T6003 ST-BY TRANSFORMER Q6005,6006 LATCH 1 3 D6015 D6007 7 SOURCE 8 4 VCC SOURCE 5 2 DRAIN FB 1 VDD IC6003 DRIVER 5 PH6003 4 10 8 D6016 D6102
TO FAN
IC6004
G(POWER)
KDE55XBR950 (UC)
3-8
IC1202 MAIN-Y/V CV/Y Q1200 FL1201 B.P.F 5 6 7 CV/Y Q1209 8 AIN1 13 VRT 14 VRB
UC1203 COP 131-133 YOUT2 124-127 YOUT9 140-144 COUT2 147-149 AIN2 C/B-Y COUT9 157 CLKO 155 HSO 156 VSO IC1603 DRC-MF 122 MY0-MY7 8 IC1900 NVM 5 DAT 6 CLK 7 WP MC0-MC7 8 DIYD0 DIYD7 DYO2 129 DYO9 133 Y0_1-Y7_1 8 C DATA Y DATA MY0-MY7 8
IC1703 MID DTVYIN0 DTVYIN7 DSPYOUT2 DSPYOUT9 Y DATA Y0-Y7 8
IC1201 MAIN-CB/C C/B-Y Q1201 FL1202 B.P.F 3 2 Q1205 1 16 MC0-MC7 8 DTVCIN0 DTVCIN7 G25 DTVCLKIN C23 DTVHSINB A24 DTVVSIN DSPCOUT2 DSPCOUT9 DSPYOUT1 DSPYOUT0 DSPCOUT1 DSPCOUT0 DSPCLK DSPHSOUT DSPVSOUT C DATA C2 B1 B5 A5 G3 G4 F3 C0-C7 8 Y1/2 Y1/4 C1/2 C1/4 CLK HD VD
CN9851 5V 2b 4b 6b 8b 10b 12b 15a 2b 6b 8b 10b 12b 15a 5V
1.8V I_BINT I_MICON_VP
1.8V I_BINT O_MID_BUSY I_MICON_VP
CN1000 B2 B4 B6 B8 B10 B12 B14 A15
MAIN-CR +5V R-Y +1.8V Q1904
Q1202 FL1203 B.P.F
5 6
Q11204 7 R-Y 20 ANI3
MCLK M-HS M-VS
IC1910 MID-MICON 57 I_B_INT 53 O_SUB_BUSY 55 I_VP_MAIN 95 D0 97 C0 33 NVM_WP 65 4 45 O_BINT RST
IC1003 LVDS TRANSMITTER 10-12 14-16 TD+ 18,19 TB2-TB6 TDTD3-TD5 TCLK+ TCLK2-4 6,52 TC+ 54-56 TA1-TA6 TCTD1,TB0 TB+ 8 TD2 TB7 TB1 TA+ 22 TC1 TA20 TC0 31 CLKIN /PDWN 50 TD0 25 TD6
37 38 39 40 41 42 45 46 47 48 32
1 2 4 5 7 8 10 11 13 14
CN003 TX1OUT3+ TX1OUT3TX1CLK+ TX1CLKTX1OUT2+ TX1OUT2TX1OUT1+ TX1OUT1TX1OUT0+ TX1OUT0-
TO PDP UNIT
DRCYIN0 DRCYIN7 +3.3V IC1002 RESET 1 VDD OUT 12 13 IC1006 (NC) 11 9 10 8 CN1001 B25 B27 I_MS_Y0 B28 B30 B31 I_MS_Y7 B33 B34 B36 A24 A25 A27 A28 I_MS_C0 B28 A30 A31 I_MS_C7 A33 A34 A22 I_MS_VS B24 I_MS_HS B22 I_MS_CLK A36 B_MS_USB_D+ TO A37 B_MS_USB_DPDP A39 O_MS_AC_DET UNIT A40 O_MS/CNM_RESET A42 B_I2C_SCL_5V A43 B_I2C_SDA_5V A45 I_CNM_UART_TX A47 O_CNM_UART_RX A51 O_MS_M_CV B52 O_MS_S_CV A53 O_MS_AU_L A55 O_MS_AU_R A57 I_MS_AU_L A59 I_MS_AU_R B38 B39 B40 B41 3.3V B42 B43 B44 B45 B54 5V B55 B58 9V B59
DICD0 DICD7
3.3V IC1901 RESET 5V VCC RST
DRO2 140 DRO9 102 HD2 100 V90 117 C540
C01-C07 8 DRC_HS DRC_VS DRC_DCLK
DRCCIN0 DRCCIN7 L1 C19 DRCHSIN B20 DRCVSIN A19 DRCCLKIN DXT1OUT K1 DXT1IN H1 DXT2IN X1702 18.543956MHz L2 Q1701 Q1702 LEVEL SHIFT
3 W1310 4 IHD0 5 IVD0 Q1941 Q1903 SHIFT SDT0 D0-D7 8 A0-A12 13 D8-D31 24 89 90 91 92 93 94 68 CLK_1S DAT_1S SDT7 SDAD0 DAT1 SDAD12 CLK1 SDDT8 SDDT31 SDCLKR SDCLK SDRAS SDCKE SDCAS SDWE A12 DA8 DA31 CLK IC1204 SDRAM DA0 DA7 A0
DAT_1S CLK_1S
J1
B_I2C_SCL_5V B_I2C_SDA_5V
25a 27a
25a 27a
B_I2C_SCL_5V B_I2C_SDA_5V
A25 A27
SCL SDA
Q1902 Q1909
TO A BOARD CN8401
IC1702 X1701 4 1 5 +3.3V
HCHECK_A2.5V PAL_FILM_MOD 33a 33b 33a 33b CHECK_A2.5V PAL_FILM_MOD A33 B33 96 D1 99 D2 98 C1 100 C2
SDDAT32 SDDAT39 SDDAT40 SDDAT63 SDADR0 SDADR11 SDDQM0 SDDQM3 SDBA0,SDBA1 SDWE SDCAS SDRAS SDCS
D32-D39 8 D40-D63 24
IC1704 64M SDRAM 2,4,5 7,8,10 11,13 DQ0 DQ7 DQ9 DQ31 A0
I_BOARD_RESET 2.5V I_MAIN_CR I_MAIN_C/CB I_MAIN_Y/CV 3.3V 9V
38b 40b 42b 44b 45a 47a 49a 20b 22b 46b 48b
38b 40b 42b 44b 45a 47a 49a 20b 22b 46b 48b
I_BOARD_RESET 2.5V I_MAIN_CR I_MAIN_C/CB I_MAIN_Y/CV 3.3V 9V
B38 B40 B42 B44 A45 A47 A49 B20 B22 B46 B48 1,2
Q1012,1013 +2.5V Q1000,1002,1007 R-Y C/B-Y Y/CV +3.3V +9V IC1200 2.5VREG 3 VCC OUT A2.5V IC1000 RESET 1 OUT VCC 2 +3.3V
19 RAS 67 CKE 18 CAS 17 WE 16,28, 97 59,71 SDQM DQM0-3 86 20 SDCS CS 39 RSTX IC1602 SDRAM 19-24 35-42 ADDR0 27-32 46-49 ADDR0 12 ADDR11 ADDR11 DQ0 DQ15 LDQM WE CAS RAS CS VDQM 16 14 15 16 17 18 36 10 9 7 8 11 DQ0 DQ15 DQM XWE XCAS XRAS XCS
1
SD_A0-SD_A11
IF
12 16,28 A11 DQM0,DQM2,DQM3 59,71 DMQ0-DMQ3 4 BA0,BA1 22,23 BA0,BA1 2 SD_WE 17 WE SD_CAS 18 CAS SD_RAS 19 RAS SD_CS 20 CS IC1705 64M SDRAM 20 19 18 17 22,23 16,28,59,71 DMQ0-DMQ3 SD_A0-SD_A11 12 A0 A11 +5V DQ0 +9V DQ7 DQ9 DQ31 CS RAS CAS WE BA0,BA1 MS3.3V
IC1002 12 13 9 10
11 8
2 1 5 4
3 6
89 SDATA 90 SCLK 96 RPLLHD 95 HREF
SDA SCL
67 XRST 97 C541
IC1600 PLL Q1600 12 6 5 4
SDDAT0 SDDAT7
SD_D0-SD_D7 8 SD_D16-SD_D31 24
3
BIAS CTRL RING OSC
DETECT CHARGE PUMP
H25 XRESET B21 DRCPSDVP
ADDAT16 SDDAT31
DIC2(MID,DRC,LVDS)
KDE55XBR950 (UC)
3-9
IC4000 RECEIVER CN4000 RXIN0RXIN0+ RXIN1RXIN1+ RXIN2RXIN2+ RXCLKRXCLK+ RXIN3RXIN3+ 1 2 4 5 7 8 10 11 13 14 9 10 11 12 15 16 17 18 19 20 RXIN0RXIN0+ RXIN1RXIN1+ RXIN2RXIN2+ RXCLKRXCLK+ RXIN3RXIN3+ 3.3V 26 RXCLKOUT 31,41-43 45-47,49 RXOUT9 RXOUT18 29,30 32-35 RXOUT1 37,38 53,54 RXOUT8 RXOUT19 RXOUT20 RXOUT27 RXOUT23 166-169 183-185 189-191 YGIN0 YGIN9 IC4001 199 CLK
IC4006 DCP 93-97,99 ROUT2 100,103 ROUT9 79-82 GOUT2 84-87 GOUT9 64,65 BOUT2 69-74 BOUT9 63 GBRHOUT 61 GBRVOUT 68 GBRCLKO 62 DEN IC4004 147 R5-R7 149 OSD1RIN5 OSD1RIN7 136,137 OSD1GIN5 140 OSD1GIN7 125,129 OSD1BIN5 130 OSD1BIN7 157 YS1 158 YM1 111 OSD1HOUT 106 OSD1VOUT 128 OSD1CLK 4 RESET +3.3VDD 5 SDA 6 SCL Q4000,Q4001 7 159 SCL 160 SDA WP LEVEL SHIFT (3V 5V) SCL SDA IC2-DEV 10 9 SDA SCL +3.3VDD 1 2 13 12 5 IC4304 15 4 3 5 1 2 LEVEL SHIFT 7 8 4 RESET IC4005 +2.5VDD SCL_BUF SDA_BUF IC4301 NVM IC4401 7 6 LV SV 2 3 LX SX IC4303 Q4100 LEVEL SHIFT Q4101 14 15 R2-R9 8 36-43
IC4100 TMDS TRANSMITTER 30 31 27 28 24 25 22 21
D4100 D4103 CN4100
R2-R9 G2-G9 8 44-47 50-53 G2-G9 B2-B9 8 54,55 58-63 B2-B9
Y0-Y9 10
LIMITTER
TO PDP UNIT
C0-C9 10
192-196 200-204 CBIN0 CBIN9
TX2 TX2 TX1 TX1 TX0 TX0 TX0+ TX0-
T2T2+ T1T1+ T0T0+ TC+ TC-
1 2 9 10 17 18 23 24
DATA2DATA2+ DATA1DATA1+ DATA0DATA0+ CLOCK+ CLOCK-
DISPLAY SIGNAL OUT (WHITE)
HS VS
164 HIN 165 VIN
4 HS 5 VS 57 CLK 2 DEN M_SENSE
Q4105 9 SCL_BUF SDA_BUF TMDS 3.3V 66 13 Q4103 Q4104 CN4406 SDA SCL ROM_SDA ROM_SCL 2 3 4 5 6 7 8 9 BINT SDA SCL ROM_SDA ROM_SCL ROM_WP BUS_SEL TMDS_RST 16 6 7 HOT_PLUGDET DDC SCL DDC SDA
G5-G7
B5-B7 YS YM 01HS 01VS CLK
Q4102
Q4300 Q4301
15 14 IC4300 4 3 6 11 12
X4000 24MHz 172 BUS
CN4301 13 8 9 10 Q4303 Q4424 Q4425 SDA SCL 1 2 3 4 5 6 SDA SCL UD-BINT DVI-NRST MUTE VGA CN4300 B13 A11 A13 A8 A10 A1 A3 A4 A6 RESERVER3 SPDIF+ SPDIFSIRCS+ SIRCSUART_0UART_0+ UART_1UART_1+
IC4202 AUDIO CTRL 3 AINL 2 AINR IC4201 2 1 3 CN4404 13b STBY5V 42b 43b 44b SET5V 45b 46b 47b SET6.5V 48b 49b SET9V 50a SDA_STBY 30a SCL_STBY 30b SDA_MAIN 32a SCL_MAIN 32b BINT 11a RESET_DL 11b VP 12a RESET 13a FAN_PWR_SW 14a FAN_SPEED 15a LINE_MUTE 16a WOOFER_MUTE 17a CONTROL_S 17b SUR_R_OUT 19b SUR_L_OUT 21a VAR_R 22b VAR_L 24a NT_SW 24b MAIN_HSYNC 26a SUB_HSYNC 26b MAIN_AFT 27a SUB_AFT 27b AGC 28a O_SAP 28b I_SAP 29a FMONO 29b GRANT 34b TV_RXD 35b /BOX-RST 36a P-SW(-) 36b TV_TXD 37a AC_RLY_ILINK 37b ATSC_OVP 38a AC_RLY_STBY 38b OVP 39a FAN_PROT 39b STBY5V 7 5 6 SDATO SDATI CLK0 BICK LRCK PD CS CCLK CDTI 13 14 21 12 11 19 17 16 15
IC4203 PCM-SPDIF 9 10 11 34 SCL 33 SDA 28 DAUX 20 XTI 26 BICK 24 LRCK /CS CLK DAT 57 AUDIO_PDN 56 AUDIO_DATP 55 AUDIO_CLKP 54 AUDIO_CSM IC4302 TMDS RECEIVER 15 14 13 9 2 1 5 4 1 2 11 IC4306 10 3 7 6 Q4428 Q4429 3
@TO UD BOARD CN7002
2 1
25 AOUTL26 AOUTL+ 28 AOUTR27 AOUTR+
TX1 IC4204 1 RESET 5V
SET5V
IC4410 ANALOG-UCOM DAT CLK /CS 4 TXD_PDP 3 RXD_PDP SIRCSIN Q4402 5,32 89 10,33,90 11,34,91 21 22 64 19 62
D4306-D4309 L4300-L4303
SET6.5V
SET9V SDA_STBY SCL_STBY SDA SCL
X4400 66.1565MHz 3 3.3V
1
IC4405 5 CK Q R5-R7 G5-G7 B5-B7 YS YM 01VS CLK R0-R2 G0-G2 B0-B2 YS YM OSD_V OSD_CLK OSD_H CABLE_ERRORP TMDS_RSTP M_SENSEP DVI_RST DVI_VGA DVI_MUTE 76 84 56 86 87 88 IC4406 31 DAT1 4 17 OSDOSC CLK1 81 63 58 60 61 67 85 B_INT DIC_RGT FAN_ILG_PROT FAN_PWR-SW FAN_SPEED LINE_MUTE SUBW_MUTE MAIN_HIN SUB_HIN MAIN_AFT SUB_AFT AGC_ATT 0_SAP I-SAP FMONO ATSC_GRANT BOX_RST BS_REC ATSC_OVP CV_COMP_SW CNVSS O_OVP SET POWER CONTROL 40 BUS_SW1 Q4404 Q4406 10 9 28 12 10 6 8 11 9 4 15 IC4402 5 3 2 1
IC4305 3 2 5 6 SET5V STBY5V B3 B1 B7 B9 B11 B5 CH STATUS FIELD_DET CABLE_DET RESERVER1 RESERVER2 P_ON
DISPLAY SIGNAL OUT (BLACK)
A
7
IC4400 3 7 5 9 01HS
IC4404 2 1
SDA SCL
MTO A BOARD CN8001
M
DCP,TMDS TRANSMITTER AUDIO CONTROL,CPU
SDA_STBY SCL_STBY 42 BUS_SW3 IC4601 CN4401 94 KEY1 75 NC 47 46 45 44 35 36 7 6 1 2 KEY1 KEY2 CN9707 Q4400 S9701,9703 S9705,9707 S9709,9711
H4S9702,9704 S9706,9708 S9710,9712 CN9704 1 KEY3 CN9705 1
H3
IC4406 TXD RXD 1 3 3 2 5 4 TXD RXD 25 23 93 92 19 73 74 79 52 43 51 50 37 8 49 44
Q4419
ILINK_STBY_LED STB_LED TIMER_LED POWER_LED ATSC_TXD ATSC_RXD
STBY5V SET5V
LATCH 04413 04415
Q4414
SCL_STBY SDA_STBY
4 5 7 8 9 10 11 12 14 15
STBY 5V 5V P_SW P_ON TIMER LED ILINK LED STBY LED POWER LED SCL_STBY SDA_STBY
ETO H2 BOARD CN9802
KDE55XBR950 (UC)
3-10
3-2. FRAME DIAGRAMSAUDIO R L VIDEO S VIDEO VIDEO2 IN
GND 1
1
1
1
GND
GND
J9601
3 4 2
1 2 3 4 5 6 FAN 3 2 1
FAN POWER FAN-PROT1 CN6101 GND 6P WHT FAN POWER :1.5DH FAN-PROT2 GNDCN6003 8P
CN6011 1P TAB(CONTACT)
CN6010 1P TAB(CONTACT)
CN6009 1P TAB(CONTACT)
CN6004 7P
GFAN On/OffFAN High/Low
H1CN6005 10PiLINK STBY
CN9503 9P WHT :1.5DL
CN6002 12P
FAN PROT AC RELY P SW(-) AC DET
GND MS 11V REG SW GND GND SET 11V SET 11V
GND STBY 5V GND 33V GND A5V GND D5V
9V_OVP MS DET GND
1 2 3 4 5 6 7 8 9 10 11 12
GND R2 GND L2 GND V2 GND C2 GND Y2 S2-2 S_SW2
TO AC INLET
CN6001 3P
GND GND ATSC 5V ATSC 5V GND Set 6.5V GND Set 9V GND GND ATSC 9V ATSC 9V
AC(L) NC AC(N)
STBY 5V GND P_SW P ON TIMER LED ILINK LED STBY LED POWER LED GND
1 2 3 4 5 6 7 8 9
1 2 3 4 5 6 7 8 9
STBY 5V GND P_SW P ON TIMER LED ILINK LED STBY LED POWER LED GND
CN9803 9P WHT :1.5DL
H2CN9601 12P WHT :1.5DL
CN9802 12P WHT :1.25DL
STBY 5V 1 5V 2 GND 3 P_SW 4 P ON 5 TIMER LED 6 ILINK LED 7 STBY LED 8 POWER LED 9 GND 10 SCL 11 SDA 12
H41 2 3 KEY1 KEY2 GND
H3CN9704 2P WHT :1.5DLKEY3 GND 1 2 1 2 KEY3 GND
MBD55XBR950
PDM-5510
CN9707 3P WHT :1.5DL
CN9705 2P WHT :1.5DL
10 9 8 7 6 5 4 3 2 1
12 11 10 9 8 7 6 5 4 3 2 1
8 7 6 5 4 3 2 1
7 6 5 4 3 2 1
GND 1 R2 2 GND 3 L2 4 GND 5 V2 6 GND 7 C2 8 GND 9 Y2 10 S2-2 11 S_SW2 12
15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
10 9 8 7 6 5 4 3 2 1
12 11 10 9 8 7 6 5 4 3 2 1
10 9 8 7 6 5 4 3 2 1
FAN On/Off
iLINK STBY
SDA-STBY SCL-STBY GND POWER LED STBY LED ILINK LED TIMER LED P-ON P_SW GND 5V STBY 5V GND KEY2 KEY1
FAN High/Low
FAN PROT AC RELY P SW(-) AC_DET
GND GND ATSC 5V ATSC 5V GND Set 6.5V GND Set 9V GND GND ATSC 9V ATSC 9V
CN9404 8P
CN9405 7P
CN9406 10P :1.5MM
CN9403 12P
CN9401 12P
J9407 3P
D1-Y
GND GND GND GND GND GND GND GND GND GNDMAIN_SLICER
GND TMDS_RST BUS-SEL ROM-WP ROM-SCL ROM-SDA SCL SDA BINT GND
GND STBY 5V GND 33V GND A5V GND D5V
GND MS 11V REG SW GND GND SET 11V SET 11V
9V_OVP MS DET GND
RXIN3+ 14 RXIN3- 13 DRAIN 12 RXCLK+ 11 RXCLK- 10 DRAIN 9 RXIN2+ 8 RXIN2- 7 DRAIN 6 RXIN1+ 5 RXIN1- 4 DRAIN 3 RXIN0+ 2 RXIN0- 1
9V MS2 GND MS1
D1-CB
GND GND GNDSUB_SLICER
D1-CRJ9406
D1-L D1-R
HD/DVD IN
J9405 3P
D2-Y
GND GND GND GND GND BINT RESET_DEL VP GND RESET STBY 5V GNDFAN-PWR-SW
D2-CB
FAN-SPEED LINE-MUTE GNDWOOFER-MUTE
D2-CRJ9404 2P
D2-L
D2-R
J9402
3S VIDEO
4 2
1
VIDEO VIDEO1 L AUDIO R
A3 4 2A1 B1 A2 B2 A3 B3 A4 B4 A5 B5 A6 B6 TV_TXD TV_RXD BOX_RST GND AC_INT +33V +5V GND +9V GND +9V GND
MAIN-HSYNC
S VIDEO
1
VIDEO VIDEO2 L AUDIO R
CN8400 10P :2.0MM
J9401
PR 1 GND 2 PB 3 GND 4 Y 5 GND 6 L 7 GND 8 R 9 GND 10
QM
CN9407 12P
SIRCS IN
SIRCS OUT
SUB-HSYNC MAIN-AFT SUB-AFT AGC O-SAP I-SAP FMONO SDA-STBY SCL-STBY GND GND SDA-MAIN SCL-MAIN GND GND GND GRANT /AC_INT TV-RXD /BOX-RST P_SW(-) TVT-XDAC_RLY_ILINK
AUDIO VCC AUDIO VCC 26V AUDIO GND AUDIO GND
1 2 3 4 5
CN8001 TX25-100P-LH-H1
CONTROL-S GND GND GND SUR-R-OUT GND GND SUR-L-OUT GND GND VAR-R GND GND VAR-L NT-SW GND GND
ATSC_OVPAC_RLY_STBY
J9403 3P RCA
OVP FAN_PROT AC_DET GND GND STBY 5V GND STBY 5V GND SET 5V GND SET 5V GND SET6.5V GND SET6.5V GND SET6.5V GND SET6.5V GND SET 9V
SUB WOOFER OUT
L AUDIO R
CN8401 TX24-100R-6STH1GND GND GND 5V O_DIS_Y GND GND 5V O_DIS_CB GND GND 1.8V O_DIS_CR GND GND 1.8V O_DIS_HS GND GND 1.8V O_DIS_VS GND GND I_BINT O_DIS_YS GND GND O_MID_BUSY I_MICOM_VP GND GND O_DRC_VP B_MS/CNM_USB_D+ MS_3.3V GND MS_3.3V B_MS/CNM_USB_DGND GND 3.3V I_MS/CNM_AC_DET GND GND 3.3V I_MS/CNM_RESET GND GND I_MS_AU_L_IN B_I2C_SCL_5V GND GND I_MS_AU_R_IN B_I2C_SDA_5V GND GND O_MS_AU_L_OUT O_CNM_UART_TX GND GND O_MS_AU_R_OUT I_CNM_UART_RX GND GND O_ATHENA3_M_BLOCK GND O_PAL_FILM_MOD GND O_ATHENA3_S_BLOCK I_MS_MAIN_CV_IN GND GND GND I_MS_SUB_CV_IN GND GND I_BOARD_RESET I_SUB_CR GND GND 2.5V I_SUB_C/CB GND GND 2.5V I_SUB_Y/CV GND GND 2.5V I_MAIN_CR GND GND 9V I_MAIN_C/CB GND GND 9V I_MAIN_Y/CV GND GND GND
CN8403 8P :1.5MM
CN8402 4P WHT :1.5MM
GND VGA MUTE DVI_NRST UD_BINT SCL SDA
5V GND D_PR GND D_PB GND D_Y GND
D_L GND D_R GND
1a 1b 2a 2b 3a 3b 4a 4b 5a 5b 6a 6b 7a 7b 8a 8b 9a 9b 10a 10b 11a 11b 12a 12b 13a 13b 14a 14b 15a 15b 16a 16b 17a 17b 18a 18b 19a 19b 20a 20b 21a 21b 22a 22b 23a 23b 24a 24b 25a 25b 26a 26b 27a 27b 28a 28b 29a 29b 30a 30b 31a 31b 32a 32b 33a 33b 34a 34b 35a 35b 36a 36b 37a 37b 38a 38b 39a 39b 40a 40b 41a 41b 42a 42b 43a 43b 44a 44b 45a 45b 46a 46b 47a 47b 48a 48b 49a 49b 50a 50b
1a GND 1b GND 2a GND 2b GND 3a GND 3b GND 4a GND 4b GND 5a GND 5b GND 6a MAIN_SLICER 6b GND 7a GND 7b GND 8a SUB_SLICER 8b GND 9a GND 9b GND 10a GND 10b GND 11a BINT 11b RESET_DL 12a VP 12b GND 13a RESET 13b STBY 5V 14a GND 14b FAN-PWR-SW 15a FAN-SPEED 15b 16a LINE-MUTE 16b GND 17a WOOFER-MUTE 17b CONTROL-S 18a GND 18b GND 19a GND 19b SUR-R-OUT 20a GND 20b GND 21a SUR-L-OUT 21b GND 22a GND 22b VAR_R 23a GND 23b GND 24a VAR_L 24b NT-SW 25a GND 25b GND CN4404 26a MAIN_HSYNC TX24-100R-LT-H1 26b SUB_HSYNC 27a MAIN_AFT 27b SUB-AFT 28a AGC 28b O-SAP 29a I-SAP 29b FMONO 30a SDA-STBY 30b SCL-STBY 31a GND 31b GND 32a SDA-MAIN 32b SCL-MAIN 33a GND 33b GND 34a GND 34b GRANT 35a /AC-INT 35b TV-RXD 36a /BOX-RST 36b P_SW(-) 37a TV-TXD 37b AC_RLY_ILINK 38a ATSC_OVP 38b AC_RLY_STBY 39a OVP 39b FAN_PROT 40a AC_DET 40b 41a GND 41b 42a GND 42b STBY 5V 43a GND 43b STBY 5V 44a GND 44b SET 5V 45a GND 45b SET 5V 46a GND 46b SET 6.5V 47a GND 47b SET 6.5V 48a GND 48b SET 6.5V 49a GND 49b SET 6.5V 50a GND 50b SET 9V
GND SI1 SO1 3.3V
BUS CONNECT8 7 6 5 4 3 2 1 7 6 5 4 3 2 1
TO ANT-SW
4 3 2 1
4 3 2 1
CN3351 4PGND GND PDWN GND IRQ GNDPDPGO
CN4401 15P :1.5DL
CN4406 10P
CN4501 4P WHT :1.5MM
CN4000 FI-E14SDATA2DATA2+ GND DATA4DATA4+ DDC SCL DDC SDA NC DATA1DATA1+ GND DATA3DATA3+ +5V POWER GND HOT PLUGDET DATA0DATA0+ GND DATA5DATA5+ GND CLOCK+ CLOCK1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 DATA22 DATA2+ 3 GND 4 DATA45 DATA4+ 6 DDC SCL 7 DDC SDA 8 NC 9 DATA110 DATA1+ 11 GND 12 DATA313 DATA3+ 14 +5V POWER 15 DDC GND 16 HOTPLUG DET 17 DATA018 DATA0+ 19 GND 20 DATA521 DATA5+ 22 GND 23 CLOCK+ 24 CLOCK-
GNDCPUGO
CN4100 24P
WHITE CABLE
CN3102 24PIN :DVI-D
N-V6CN3801 31P :FI-TWE31PB-VF
CN4300 26P
M
UART_OFIELD_DET GND GND UART_O+ CH_STATUS UART_IGND GND POWER_ON UART_I+ NC GND CABLE DET SIRCS+ NC GND RESERVE1 SIRCSGND SPDIF+ RESERVE2 GND GND SPDIFRESERVE3
A1 B1 A2 B2 A3 B3 A4 B4 A5 B5 A6 B6 A7 B7 A8 B8 A9 B9 A10 B10 A11 B11 A12 B12 A13 B13
5 4 3 2 1
AUDIO_VCC AUDIO_VCC GATE-DRIVE GND GND
BLACK CABLE
A1 B1 A2 B2 A3 B3 A4 B4 A5 B5 A6 B6 A7 B7 A8 B8 A9 B9 A10 B10 A11 B11 A12 B12 A13 B13
UART_IField GND GND UART_I+ Status UART_OGND GND Power on UART_O+ MODE JIG Cable det SIRCS+ RXD GND TXD SIRCSGND SPDIF+ RESET GND GND SPDIFSTBY
DEFCN3301 11P 1.5MM CN3101 26PIN :MDR
GND SDA GND SCL GND GND GND TE+ TETD+ TDTCLK+ TCLKGND TC+ TCTB+ TBTA+ TAGND GND(NC)
31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
SPEAKER R L
5 4 3 2 1
TO PDP UNIT
CN7005R+ RN.C LL+
CN7001 :S-MICRO CN7004 :VH CN7002 :VH
12V GND
1 2
KF2+3.3V GND SPDIF GND +12V SDA2 SCL2 SP_PROT MUTE RES GND
+3.3V GND SPDIF GND +12V SDA SCL AU_PROT AU_MUTE AU_RES GND
1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10 11 11
KF1CN3001 11P 1.5MM CN3002 5P :VH
RR+ LL+
1 2 3 4
1 2 3 4
R+ RL+ L-
CN3003 4P :VH
NC VSAGO VCEGO VRS
CN1006 5P :VH
CN6009 11P
VRA GND GND GND VPR2 VCC VCC
CN4403 10P WHT :S-MICRO
3.3V 1 CNVSS 2 CE 3 TXD 4 RXD 5 SCLK 6 BUSY 7 EPM 8 G 9 RESET 10
1 2 3 4 5 6 1 2 3 4 5 6 7 8 9 10 11 12 FAN
PANEL GND HIC GND HIC2 GND GND DRV GND DRV GND DRV GND DRV GND DRV LOW GND DRV LOW
CN3306 6P 1.5MM :SENS
CN3304 13P 2.0MM
CN3305 12P 1.5MM
+3.3V +3.3V GND GND +12V STBY_6V GND POWER_ON VPR2 PANEL_MUTE OVP AC_DET GND
1 1 3.3V 2 2 3.3V 3 3 GND 4 4 GND 5 5 FAN 12V 6 6 STBY 6V 7 7 GND 8 8 POWER_ON 9 9 VPR2 10 10 PANEL MUTE 11 11 OVP 12 12 THERMO_G 13 13 GND
1 2 3 4 5 6 7 8 9 10 11
TO PDP UNIT
GF1CN6005 PHR13P CN6010 10P VH
VA VA VCC VCC GND GND GND VS VS VS
1 2 3 4 5 6 7 8 9 10
TO PDP UNIT
CN6001 PHR2P CN3302 10P 1.5MM CN3303 4P 1.5MMSTBY5V LOGO NC GND
12V GND
1 2
CN6002 PHR3PGND POWER STBY 6V
CN001 PHR4PRLY VCC NC NC RLY GND
CN002 4PPFC LVP INRUSH T NC S GND
CN003 4P :VHVCC 18V PFC GND NC PFC OUT VCC 18V PFC GND NC PFC OUT 1 2 3 4 1 2 3 4
1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 9 9 10 10
STBY5V SIRCS GND MUTE TIMER2 TIMER1 POWER STBY STBY5V GND
1 2 3 4
1 2 3
1 2 3 4
1 2 3 4
1 2 3 4
CN4301 7P
CN701 10P-L
CN751 4P-L
CN6002 PHR4P CN6001 2P :MINI-LOCK
PFC LVP INRUSH T NC S GND
STBY5V SIRCS GND MUTE TIMER 2 TIMER 1 POWER STBY SAVING GND
RLY VCC NC NC RLY GND
STBY5V LOGO NC GND
1 2 3 4
1 2 3 4
CN6003 4P
CN6004 4P :VH
RF1RX2- 1 RX2+ 2 3 4 5 SCL 6 SDA 7 8 RX1- 9 RX1+ 10 11 12 13 5V 14 15 HPD 16 RXO- 17 RXO+ 18 19 20 21 22 RXC+ 23 RXC- 24
RF2GND POWER ON ST-BY 6V 1 2 3
GF2 GF3AC INLETCN601 2P :VHAC AC 2 1
1a 1b 2a 2b 3a 3b 4a 4b 5a 5b 6a 6b 7a 7b 8a 8b 9a 9b 10a 10b 11a 11b 12a 12b 13a 13b 14a 14b 15a 15b 16a 16b 17a 17b 18a 18b 19a 19b 20a 20b 21a 21b 22a 22b 23a 23b 24a 24b 25a 25b 26a 26b 27a 27b 28a 28b 29a 29b 30a 30b 31a 31b 32a 32b 33a 33b 34a 34b 35a 35b 36a 36b 37a 37b 38a 38b 39a 39b 40a 40b 41a 41b 42a 42b 43a 43b 44a 44b 45a 45b 46a 46b 47a 47b 48a 48b 49a 49b 50a 50b
1a 1b 2a 2b 3a 3b 4a 4b 5a 5b 6a 6b 7a 7b 8a 8b 9a 9b 10a 10b 11a 11b 12a 12b 13a 13b 14a 14b 15a 15b 16a 16b 17a 17b 18a 18b 19a 19b 20a 20b 21a 21b 22a 22b 23a 23b 24a 24b 25a 25b 26a 26b 27a 27b 28a 28b 29a 29b 30a 30b 31a 31b 32a 32b 33a 33b 34a 34b 35a 35b 36a 36b 37a 37b 38a 38b 39a 39b 40a 40b 41a 41b 42a 42b 43a 43b 44a 44b 45a 45b 46a 46b 47a 47b 48a 48b 49a 49b 50a 50b
GND GND GND 5V O_DIS_Y GND GND 5V O_DIS_CB GND GND 1.8V O_DIS_CR GND GND 1.8V O_DIS_HS GND GND 1.8V O_DIS_VS GND GND I_BINT O_DIS_YS GND GND O_MID_BUSY I_MICOM_VP GND GND O_DRC_VP B_MS/CNM_USB_D+ MS_3.3V GND MS_3.3V B_MS/CNM_USB_DGND GND 3.3V I_MS/CNM_AC_DET GND GND 3.3V I_MS/CNM_RESET GND GND I_MS_ALL_L_IN B_I2C_SCL_5V GND GND I_MS_ALL_R_IN B_I2C_SDA_5V GND GND O_MS_AU_L_OUT O_CNM_UART_TX GND GND O_MS_AU_R_OUT I_CNM_UART_RX GND GND O_ATHEN3_M_BLOCK GND O_PAL_FILM_MOD GND O_ATHEN3_S_BLOCK I_MS_MAIN_CV_IN GND GND GND I_MS_SUB_CV_IN GND GND I_BOARD_RESET I_SUB_CR GND GND 2.5V I_SUB_C/CB GND GND 2.5V I_SUB_Y/CV GND GND 2.5V I_MAIN_CR GND GND 9V I_MAIN_C/CB GND GND 9V I_MAIN_Y/CV GND GND GND
SDA SCL UD_BINT DVI_NRST MUTE VGA GND
CN9851 TX25-100P-LT-H1
IFCN9850 TX25-100P-12ST -H1GND GND GND 5V O_DIS_Y GND GND 5V O_DIS_CB GND GND 1.8V O_DIS_CR GND GND 1.8V O_DIS_HS GND GND 1.8V O_DIS_VS GND GND I_BINT O_DIS_YS GND GND O_MID_BUSY I_MICOM_VP GND GND O_DRC_VP B_MS/CNM_USB_D+ MS_3.3V GND MS_3.3V B_MS/CNM_USB_DGND GND 3.3V I_MS/CNM_AC_DET GND GND 3.3V I_MS/CNM_RESET GND GND I_MS_ALL_L_IN B_I2C_SCL_5V GND GND I_MS_ALL_R_IN B_I2C_SDA_5V GND GND O_MS_AU_L_OUT O_CNM_UART_TX GND GND O_MS_AU_R_OUT I_CNM_UART_RX GND GND O_ATHEN3_M_BLOCK GND O_PAL_FILM_MOD GND O_ATHEN3_S_BLOCK I_MS_MAIN_CV_IN GND GND GND I_MS_SUB_CV_IN GND GND I_BOARD_RESET I_SUB_CR GND GND 2.5V I_SUB_C/CB GND GND 2.5V I_SUB_Y/CV GND GND 2.5V I_MAIN_CR GND GND 9V I_MAIN_C/CB GND GND 9V I_MAIN_Y/CV GND GND GND 1a 1b 2a 2b 3a 3b 4a 4b 5a 5b 6a 6b 7a 7b 8a 8b 9a 9b 10a 10b 11a 11b 12a 12b 13a 13b 14a 14b 15a 15b 16a 16b 17a 17b 18a 18b 19a 19b 20a 20b 21a 21b 22a 22b 23a 23b 24a 24b 25a 25b 26a 26b 27a 27b 28a 28b 29a 29b 30a 30b 31a 31b 32a 32b 33a 33b 34a 34b 35a 35b 36a 36b 37a 37b 38a 38b 39a 39b 40a 40b 41a 41b 42a 42b 43a 43b 44a 44b 45a 45b 46a 46b 47a 47b 48a 48b 49a 49b 50a 50b
12 11 10 9 8 7 6 5 4 3 2 1
5V GND D-PR GND D-PB GND D-Y GND D-L GND D-R GND
CN7002 7P
CN604 3P :S-MICRO
CN603 2P :VH
CN7003 12P
UD
CN7001 24P
TO PDP UNIT
DIC2J7001 2P
R
L
KDE55XBR950 (UC)
AC AC
1 1 2 2
7 6 5 4 3 2 1
AC(L) AC(N)
1 2 3 4 5 6 7 8
1 2 3 4
7 6 5 4 3 2 1
3-11
3-3. CIRCUIT BOARDS LOCATION3-3-1. DISPLAY UNIT (PDM-5510)
3-4. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDSNote: All capacitors are in F unless otherwise noted. (pF: F) Capacitors without voltage indication are all 50 V. Indication of resistance, which does not have one for rating electrical power, is as follows.
Terminal name of semiconductors in silk screen printed circuit ( )Device Printed symbol
*
1 2 3 4 5 6 7 8 9 0 ! ! ! ! ! ! ! !
Terminal name Collector Base Emitter
Circuit
Transistor Collector Base Diode Cathode Anode Cathode Diode Anode (NC) Emitter
GF3 Board
Pitch: 5 mm Rating electrical power 1/4 W (CHIP : 1/10 W)
Transistor
GF2 BoardKF1 BoardGF1 Board
KF2 Board DEF Board RF2 Board RF1 Board
All resistors are in ohms. : nonflammable resistor. : fusible resistor. : internal component. : panel designation, and adjustment for repair. All variable and adjustable resistors have characteristic curve B, unless otherwise noted. : earth-ground. : earth-chassis. When replacing the part in below table, be sure to perform the related adjustment. All voltages are in V. Readings are taken with a 10 M digital multimeter. Readings are taken with a color-bar signal input. Voltage variations may be noted due to normal production tolerances. : Can not be measured. * Circled numbers are waveform references. : B + bus. : B bus.: Signal path.
Cathode Diode Anode (NC)
Common Diode Anode Diode Cathode Common Anode Diode Cathode
Common Anode Anode
Common Diode Anode Anode
Common Diode Cathode Diode Cathode Common Cathode Anode Anode Cathode Drain Cathode Cathode Anode Anode Source GateG D G S S D
Note: The components identified by shading and mark ! are critical for safety. Replace only with part number specified.
Diode Transistor (FET) Transistor (FET) Transistor (FET) Transistor
3-3-2. MEDIA RECEIVER UNIT (MBT55XBR950)
Note: Les composants identifis par un tram et une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
Drain
Source Gate Source Drain Gate Emitter Collector BaseD
D G G S
S
C1
C2 B2
Transistor
C2 B1 E1 B1 E2 B2 C1 E1 E2
Transistor
C1 B2 E2 E1 B1 C2 B1 C1 C2 B2 E1 E2
QI Board QM Board M Board G Board UD Board IF Board QT Board
! @ @ @ @
Transistor
C1 B2 E2 E1 B1 C2
E1
E2 B2
Transistor
C1 B2 E2 E1 B1 C2
B1 C1 C1(B2) C2 C2
Transistor
E2 B1 E1 C2 C1(B2)
B1 E2 E1(B2) B1 C1 E1(B2) B1 C1 C2 C2 C2 E2 E2
Transistor
(B2) B1 E1 E2 C1 C2
Transistor Discrete semiconductot
(B2) E2 E1 B1 C2 C1
(Chip semiconductors that are not actually used are included.)
Ver.1.6
H1 Board H2 Board H4 Board H3 Board DIC2 Board A Board QH Board
KDE55XBR950 (UC)
3-12
3-4-1. DISPLAY UNIT (PDM-5510) (1) Schematic Diagrams of DEF Board
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
3V-4 TO(2/7) 5V-4 TO(2/7) TO(2/7) 3.3VS
FB3107 BLM11A601S R3104 0 :1608 R3170 10k :1005 R3171 10k :1005 R3158 10k :1005 C3106 0.1 10V B:1005 R3160 1k :1005
VCC 4OE 4A 4Y 3OE 3A 3Y
B
CN3101 26PIN :MDR
TO(3/7) MODE RES 14 13 12 11 10 9 8 3.3 TMDS_ON TO(2/7)
0
Q3107 SI2301DS3.3V SW
JL3102
C3124 0.01 16V B:1005
2
R3133 10k :1005
R3139 1k :1005
C3121 C3122 0.01 4.7 R3152 4.7k 16V 6.3V B:1005 B:2012 :1005
B A GND
VCC Y
C3130 0.01 16V B:1005
3
1
3.3V3
5V
CTO MEDIA RECEIVER UNIT (BLACK)
D
STBY SPDIFGND GND RESET SPDIF+ GND SIRCSTXD GND RXD SIRCS+ Cable det JIG MODE UART_O+ Power on GND GND UART_OStatus UART_I+ GND GND Field UART_I-
B13 A13 B12 A12 B11 A11 B10 A10 B9 A9 B8 A8 B7 A7 B6 A6 B5 A5 B4 A4 B3 A3 B2 A2 B1 A1
C3133 0.1 10V B:1005 R3163 100 JL3103 :1005
Q3106 DTC114EUA IC3102 SN74LV125A3.3V CTRL RXD/TXD/MODE/RES BUFFER
3.3V75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51QO22 QO21 QO20 QO19 QO18 QO17 QO16 DGND CAP QO15 QO14 QO13 QO12 QO11 QO10 QO9 QO8 OGND OVDD QO7 QO6 QO5 QO4 QO3 QO2
IC3110 TC7SA00FU INV.
4
5
6
SPDIFSPDIF+
R3113 100 :1005 JL3104
1OE 1A 1Y 2OE 2A 2Y GND
R3109 22 :1005
TMDS TO(4/7)
1
2
3
4
5
6
7 TXD1 RXD1 TO(3/7)C3115 0.01 16V B:1005
D3108 HN1D03FU3
JL3105
R3114 100 :1005
6
SIRCSSIRCS+
Q3110 DTC114EUANORMAL/JIG SELECT R2+ R2R1+ R1-
R3107 100 :1005 JL3106
JL3111 R3117 10k :1005 R3164 100 :1005
D3109 HN1D03FU
3 6 TXD+ TXD-
Q3119 RN4902 10K/10KVCC SW 3 6 0 3.1 2 1 4 SIRCS+ SIRCSRXDRXD+R3127 100 :RN1005Y GND D
3.3V
3.3V
R3108 100 :1005
R0+ B:1005 R0RC+ B:1005 RCC3118 0.01 16V B:1005 JL3114 C3117 0.01 16V
C3116 0.01 16V
JL3125
D3110 HN1D03FU5 4
5
PD0 TO(2/7)
3JL3126
7
2
6
RXD+ RXD-
D3111 HN1D03FUR3101 0 :1608FB3106 BLM11A601S
1.4 1.1 B 1.1 A 1.5Z
0 C3110 0.1 10V B:1005JL3113
0 R 0VCC
8
1
TO(2/7) SIRCS RXD0 TO(3/7)
JL3115
6
3
RB3101 100*2
JL3127 JL3116 RB3102 100*2
IC3103 SN65LVDS179DGKR LVDS RXTX
EJL3123 R3159 10k :1005 R3162 100 :1005
IC3112 SN74LVC2G08DCUAND GATE1 8
FB3104 BLM11A601S
C3113 47 6.3V :AL-CP C3114 0.01 16V B:1005
76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99100
2.9 2.9 3.3
4
5
2.9 3.3 3.3C3132 0.1 10V B:1005
JL3124
TO(2/7) BOX_SW PC TO(2/7) TXD+ TXDSPDIFSPDIF+R3126 100 :RN1005Y Z
2
7
Q3120 RN4902 10K/10K 0VCC SW 2
3 6 3.2 5 1 4 PD1 TO(2/7)R3136 4.7k :1005 R3137 4.7k :1005 R3138 4.7k :1005
DFO PD ST PIXS DGND DVDD STAG SCDT PDO QE0 QE1 QE2 QE3 QE4 QE5 QE6 QE7 OVDD OGND QE8 QE9 QE10 QE11 QE12 QE13
R3135 4.7k :1005
OGND QO23 OVDD AGND RX2+ RX2AVDD RX1+ RX1AVDD RX0+ RX0AVDD RXC+ RXCAVDD DDC_SCL DDC_SDA DDC_SA PROM_SCL PROM_SDA PVDD1 PGND PVDD2 OCK_INV
IC3109 TFP501PZP TMDS RESEIVER
QO1 QO0 HSYNC VSYNC DE OGND ODCK OVDD RSVD CTL2 CTL1 DGND DVDD QE23 QE22 QE21 QE20 QE19 QE18 QE17 QE16 OVDD OGND QE15 QE14
50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26
TP3102 JL3117 R3155 22 :1005 R3156 22 :1005 R3157 22 :1005 C3125 0.01 16V R3153 B:1005 10k :1005 JL3118 JL3119
HS VS DE DCK
HST VSTTP3103
JL3120
RB3108 22*4 C3126 0.01 16V B:1005
R7 R6 R5 R4 R3 R2 R1 R0
RB3109 22*4 C3127 0.01 16V B:1005
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25C3123 0.01 16V B:1005
FB3105 BLM11A601S
3
6
GND
FIC3101 NJM2903VVOLTAGE COMPARATORR3110 47k :1005 R3103 4.7k :1005
DVI TO(3/7)FB3102 BLM11A601S R3172 10k :1005 R3118 47k :1005
1.4 D 1.1 3.3 B R 1.3 1.7 A VCC 1.3
0 C3131 0.1 10V B:1005JL3112
8
B0 B1 B2 B3 B4 B5 B6 B7
3.3VTO(2/7) SCDT
1
8
0
5.0 0.9 2.2
2
7
RB3103 22*4
RB3104 22*4
3.3V
G
4.9
3.2 RES TO(3/7)C3105 R3111 0.47 10k 6.3V :1005 B:1608
Q3118 RN4902 10K/10KR3120 4.7k :1005
3
6
2
VCC SW 3 6 5 1 4
C3109 0.1 10V B:1005
4
5
3.1 D1 G2 S2 G2 S2
VCC
LY
4.9 4.9 SY 4.9 4.9
NC
Q3101 DTC144EUAINV.
C3107 R3119 C3108 R3121 0.1 10k 0.47 4.7k 10V :1005 6.3V :1005 B:1005 B:1608
D1 8 7 6 5
GND
NC
LX
H
I
JL3109 JL3110 R3105 10k :1005
VD3102 1608SGXA VD3106 1608SGXA
TO MEDIA RECEIVER UNIT (WHITE)
DATA2DATA2+ GND DATA4DATA4+ DDC SCL DDC SDA NC DATA1DATA1+ GND DATA3DATA3+ +5V POWER DDC GNDHOTPLUG DET
10 9
2
J
DATA0DATA0+ GND DATA5DATA5+ GND CLOCK+ CLOCK-
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24JL3101
VD3101 1608SGXA VD3105 1608SGXA
D3101 UDZS5.6B D3103 UDZS5.6BJL3107 JL3108
3.1
CN3102 24PIN :DVI-D
R3102 0 :1608
SX
IC3104 BA8274F IIC BUFFS1 G1 D2
D3105 DAN202U
Q3105 SSM6N15FU LEVEL SHIFT
Q3111 SSM6N15FU LEVEL SHIFTFB3103 BLM11A601S
1
2
3
4
3.3V
R3115 R3116 4.7k 4.7k :1005 :1005
S1
G1
D2 3.1 SDA SCL TO(2/7)
D3104 RCLAMP0504M6Line 4 NC GND Line 2 NC NC Line 3 Vcc NC Line 1
SERIAL BUS SELECT
7
4
R2+ R2-
6
5
16 15 14 13 12 11 10 9VCC 1Y2 1Y1
IC3107 SN74LV4052A
3 R1+ R1-
D3112 UDZS5.6B
1
2
3
3.1 2Y3 1C 3.1 3.1 2Y1 1Y0 0 1.3 INH 1Y3 3.1 GND A 0 GND B 0
8
10 9
2
3
2Y0
3.1
2Y2
1
2C
4
5
6
7
8
R3167 R3168 10k 10k :1005 :1005 R3141 10k :1005
D3106 RCLAMP0504M6 5
VD3103 1608SGXA VD3107 1608SGXA
6
Line 4 NC GND Line 2 NC
NC Line 3 Vcc NC Line 1
7
4
R0+ R03 RC+ RC-
Q3108 DTC114EUAVCC
8
3
GND
NC
A1
GND
1
2
3
A2
TP3101
VD3104 1608SGXA VD3108 1608SGXA
R3106 0 :1608
3.2 SCL 3.1 SDA 3.1
C3112 0.1 10V B:1005
8
7WC
6
5
READ/WRITE SEL
1
HDCP
A00
G0 G1 G2 G3 G4 G5 G6 G7
TO(3/7) CABLE_DET
IC3111 SN65LVDS179DGKR LVDS RXTX
1
TO(3/7) TXD0 SPDIF TO(2/7)
R3142 10k :1005 C3120 0.01 16V B:1005 R3144 0 :1005 R3146 0 :1005 R3147 0 :1005 R3150 22 :1005
5
6
3
4
C3128 C3129 0.1 47 10V 6.3V B:1005 :AL-CP
7
2
RB3105 22*4
RB3106 22*4
SEL1 SEL0 WP
TO(2/7)
4
IC3108 M24C04-WNM6TPSERIAL BUS EEPROM
DEF(1/7)(TMDS RECEIVER)B-SS12016-DEF-P1
K
KDE55XBR950 (UC)
3-13
1 A
2
3TO GF1 BOARD CN6005+3.3V +3.3V GND GND +12V STBY_6V GND POWER_ON VPR2 PANEL_MUTE OVP AC_DET GND
4
5
6TO FAN
7
8
9
10
11
12
13
14
15
GND DRV GND DRV GND DRV GND DRV GND DRV LOW GND DRV LOW
CN3304 13P 2.0MM
CN3305 12P 1.5MM
1 2 3 4 5 6 7 8 9 10 11 12 13
1 2 3 4 5 6 7 8 9 10 11 12
3.3
3.3
1.2JL3324 JL3328
JL3305 TP3301
GNDJL3312 JL3314 JL3316 JL3317 JL3318 JL3319 JL3313 JL3320 JL3315 JL3323
CONT
VOUT
VIN
ADJ
7.9 2.6
GND
B
IC3303 PQ20WZ1U 1.0A FAN DRV5C3318 22 R3310 16V 6.2k :RN1005 :AL-CP
0R3358 0
1 2 3 4 5 6
PANEL GND HIC GND HIC2 GND
CN3306 6P 1.5MM :SENS
P_MUTE OVP AC_DET
+3.3V
+12V
FB3305 BLM11P300S
1
2
3
4
SCL2 SDA2 TO(1/7)(3/7) 3.3V-4 0R3352 4.7k :1005 R3351 10k :1005 RB3352 100*2
THERMO_HIC2
TO(3/7) WP
C
TP3305
R3309 1.5k :RN1005 JL3321 R3314 10k :1005
TO(3/7)
3.3VC3321 100 6.3V :AL-CP JL3333
3 6 5
1 4
VCC WP SCL SDA
L3303 4.7H 1.6A :CHIP
C3320 C3309 0.47 22 16V 16V :AL-CP B:2012
R3308 10k :1005 R3307 4.7k :1005
D3303 1.8k :RN1005 MA111
R3311
THERMO_HIC
THERMO_P
2C3351 0.1 10V B:1005
8
7
6
5
0
A00NC NC NC GND
IC3351 M24C64-WNVM 4
FAN_ERR TO(3/7)
Q3351 RN4902 10K/10K
FAN
2.5
1
2
3
3.3V
D3.3V
IC3301 SN74LVC2G08DCU1A VCC
FB3304 BLM11A601S
3.3 1B 1Y 3.3 0 2Y 2B 3.3 3.3 GND 2A 3.3
5
3
6
4
5
R3304 10k :1005
1
E3.3VCN3301 11P 1.5MMGND AU_RES AU_MUTE AU_PROT SCL SDA +12V GND SPDIF GND +3.3V 11 10 9 8 7 6 5 4 3 2 1JL3301
C3302 0.1 10V B:1005
RB3304 100*2
AC_SW POWER PANEL
TO(3/7)
C3312 22 6.3V :AL-CP
C3307 22 16V :AL-CP
1
C3303 22 6.3V :AL-CP
R3305 10k :1005
C3304 0.47 16V B:2012 C3305 22 16V :AL-CP
C3311 2.2 6.3V B:2012
C3306 0.47 16V B:2012
1.3GND VIN GND NC VOUT
4
R3303 47k :1005
D3302 MA111
BOX_SW TO(1/7)
2
7
L3301 4.7H 0.21A
IC3304 MM1565A 0.5A 5V REGCONT GND VIN CN GND NC VOUT
ST5VTP3302
TO(1/7) 5V-4C3310 470p B:1005 L3304 4.7H 0.21A
IC3305 MM1563D 0.5A 3.3V REGCONT CN
ST3.3VTP3303 S3351 8P
C3313 470p B:1005 C3314 2.2 6.3V B:2012 C3315 47 6.3V :AL-CP
DIPSW TO(3/7) TEST T_SW RATE1 RATE0 MODE I2CEN FEAT3 FEAT2
1
8
TEST P_SW RATE1 RATE0 MODE I2CEN FEAT3 FEAT2 1
4
5
6
3
6
7
2
7
3.3V3.3V TO(3/7)(4/7)(5/7)R3331 R3332 4.7k 4.7k :1005 :1005
F
G2
+12VFB3301 BLM11P300S
G1
TO KF1 BOARD CN3001
5.0 5.0 3.2 3.0 3.0 14.3 1.6 3.2
JL3302
AU_RES AU_MUTE AU_PROT
Q3304 SSM6N15FUR3317 10k :1005 R3318 10k :1005 R3321 10k :1005
2
3
3.3VIC3306 PCA9555 I/O EX. (40)FB3306 BLM11A601S FB3352 BLM11P300S C3323 0.01 16V B:1005 R3338 10k :1005
JL3303 JL3304
SCL SDA
3.3VTO(3/7) INTJL3325
IC3352 BA25BC0FP 1.0A 2.5V REG1C3353 22 6.3V :AL-CPVCC OUT GND
TO(4/7)(5/7) 2.5V 2
S2
D2
D1
S1
2
SPDIF TO(1/7) +3.3VFB3302 BLM11P300S
13 14 15 16 17 18 19 20 21 22 23 24
INT
VDD SDA
1
RB3314 100*2
SDATP3306 TP3307
3.2A1 A2 I/O00
3C3354 0.47 6.3V B:1608 C3355 C3356 0.1 220 10V 4V :AL-CP B:1005
RB3302 100*4
3.3 SCL 3.3A0 I/O17
SDA SCL
3
GP_MUTE TO(7/7)C3301 22 6.3V :AL-CP
CN3302 10P 1.5MMGND STBY5V STBY POWER TIMER1 TIMER2 MUTE GND SIRCS STBY5V 10 9 8 7 6 5 4 3 2 1 5.0 5.0 0.3 5.0 5.0 5.0
RB3303 100*4S
12 11 10 9
AU_PROT AC_DET OVP P_MUTE P0 P1 (NC) P2 P3
3.2 0.3 3.9 I/O03 3.9 I/O04 0 I/O05 0 I/O06 0 I/O07 0I/O01 I/O02 VSS
RB3308 100*4
SCLJL3326
4
2.8 0 I/O15 3.1 I/O14 3.3 I/O13 3.3 I/O12 3.3 I/O11 3.3 I/O10 3.3I/O16
PC TO(1/7) WP SCDT TMDS_ON TO(1/7) PD3 (NC) PD2 (NC) PD1 TO(1/7) PD0RB3309 100*4
R3335 0 :1005 JL3306 JL3307 JL3308 JL3309 JL3310
HTO RF1 BOARD CN701
LED_R1 LED_G1 LED_R2 LED_G2 LED_B SIRCS TO(1/7)
R3337 10k :1005
8
7
6
5
CN3251 8P :JIG JL3259
Q3305 SI2301DS 0 Q3306 DTC114EUALED_ON TO(3/7)
JL3260
RB3264 100*4
IC3308 MB88141A D/A CONV. (90)LED_W LED_B LED_G2 LED_R2 LED_G1 LED_R1 FAN SEL0 TO(1/7) SEL1 AU_MUTE AU_RESAO1 GND VSS1 VDD1 SDA
Q3301 DTA143EUA-T106R3301 220
ICN3303 4P 1.5MMGND NC LOGO STBY5V 4 3 2 1
D3301 SML-020MLTT87R G
3
RB3306 100*4
6
RB3312 100*4
8
R3302 220
JL3327 RB3313 100*4
1.0 5.1 5.1 AO4 5.1 AO5 5.1 AO6 5.1 AO7 4.3AO2 AO3 AO8 AO9
13 14 15 16 17 18 19 20 21 22 23 24
4.7 5.0
C3322 0.01 16V B:1005
FB3308 BLM11A601S R3327 R3326 4.7k 4.7k :1005 :1005
JL3261 JL3262 JL3263
Q3303 SSM6N15FUS2 D2
JL3264 FB3253 BLM11P300S
8 7 6 5 4 3 2 1
GND MODE TCK TMS TD0 TDI TRST VCC
FOR JIG
4
2
1
4.9 SCL 4.8MOD CS2 CS1 CS0 VDD2 VSS2 VCC
5
3.2G2 G1 S1
4.8
7
D1
Q3302 DTA143EUA-T106
12 11 10 9
SDA 3.2 SCL TO(1/7)
TO RF2 BOARD CN751
JL3311
0 AO10 0 AO11 5.1 AO12 5.1
4.9
LED_W 0.3 5.0
J
DEF(2/7)(D/A CONVERTER,NVM)B-SS12016-DEF-P2
KKDE55XBR950 (UC) 3-14
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
IC3451 NJM2870F18 0.15A 1.8V REGS3402 KEY BOARD SWITCHCONT GND N.B VOUT VIN
3.3VDIPSW TO(2/7)
IC3403 MBM29LV800TA -70PFTN-DEF55FLASH MEMORY
FB3402 BLM11A601S
FB3403 BLM11A601S
IC3405 SN74CBTLV16210GR BUS-SWNC 1A1 1A2 1A3 1A4 1A5 1A6 GND 1A7 1A8 1A9 1A10 2A1 2A2 VCC 2A3 GND 2A4 2A5 2A6 2A7 2A8 2A9 2A10 1OE 2OE 1B1 1B2 1B3 1B4 1B5 GND 1B6 1B7 1B8 1B9 1B10 2B1 2B2 2B3 GND 2B4 2B5 2B6 2B7 2B8 2B9 2B10
CPU-CORBU TO(6/7)
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
B
4
5
IC3402 PST3629U RESET
6
R3428 10k :1005
7
8
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
C
C3408 0.01 16V B:1005
GND VDD
OUT CO
R3423 0 :1005 R3424 #
2
3
WR0 :1005
R3330 0
FAN_ERR 3.3V-4 TO(2/7)R3457 10k :1005 R3458 10k :1005 R3459 10k :1005
TO(2/7)
C3415 0.1 10V B:1005 D11
R3411 10k :1005 R3406 10k :1005
C3409 0.47 6.3V B:1608
R3357 0 :1005
3.3V
FB3404 BLM11A601S
R3419 47k :1005
D
R3323 10k :1005 R3325 10k :1005
R3460 10k :1005 R3461 10k :1005
A19 A18 A8 A7 A6 A5 A4 A3 A2 FEAT3 FEAT2 CS0
R3404 10k :1005 R3414 10k :1005
R3403 10k :1005 R3405 10k :1005
D3 D10 D2 D9 D1 D8 D0 RD
AS B:1005 RD WR0 WR1 CS1 CLK
C3416 0.1 10V
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
A7 A8 A9 A10 A11 A12
8
7
6
5
4
C3451 0.047 10V B:1005
C3453 4.7 6.3V B:2012
MODE
MODE TO(1/7) PANEL TO(2/7) POWER AC_SW PLLBP TO(6/7) CL_X RES TO(1/7)
A16 A15 BYTE A14 VSS A13 A12 D15/A-1 A11 D7 A10 D14 A9 D6 A8 D13 NC D5 NC D12 WE D4 RES VCC NC D11 NC D3 RY/ BY D10 A18 D2 A17 D9 A7 D1 A6 D8 A5 D0 OE A4 VSS A3 CE A2 A1 A0
3
4
3
D15 D7 D14 D6 D13 D5 D12 D4
A3 A4 A5 A6
3
A1 A2
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
C3452 0.1 10V B:1005
2
2
2
RATE1 RATE0
A16 A15 A14 A13 A12 A11 A10 A9 A20
1
5
1
1
A17
CPUA1 CPUA2 CPUA3 CPUA4 CPUA5 CPUA6 CPUA7 CPUA8 CPUA9 CPUA10 CPUA11 CPUA12 CPUAS_X CPURD_X CPUWR0_X CPUWR1_X CPUCS_X CPUCLK
1
4
CLK
WR1 WR0 RD
CS1 CS0
D5 D4 D3 D2 D1 D0
AS
A1
90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
D5 D4 D3 D2 D1 D0 PANEL ON POWER ON AC SW AS SW_1 MCLK SW_3 SYSCLK RESET VSS VCCI NMI WR1 WR0 RD SW_4 SW_2 CLS PLLBP
FLASH_RST VCCI FAN ERR FEAT3 FEAT2
E
1
R3442 X3401 0 :1005 16.5MHz R3436 10k :1005 R3437 10k :1005 D3402 1SS383
F
A1 A2 A3 A4 A5 A6 A7C3401 0.1 10V A8 B:1005
400kHzz
IC3401 MB91306RPFV MCU
R3445 2.2k :1005 R3446 4.7k :1005
R3447 R3455 R3456 10k 2.2k 10k :1005 :1005 :1005 R3448 4.7k :1005
SCL2 SDA2 WP
D12 B:1005 TO(2/7) D13 D14 D15
C3417 0.1 10V
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
D6 D7 D8 D9 D10 D11 D12 D13 D14 D15
G
A17 A18 A19 A20 API Reserved API Reserved
FLASH AVCC AVRH AVSS/AVRL 3.3V DET THERMO HIC2 THERMO PANEL THERMO HIC INTVS1 INTVS2 INTVSO ALARM WAKE UP CABLE DET
A9 A10 A11 A12 A13 A14 A15 A16
VCC SI0 SO0 TEST SI1 SO1 TEST SW
91 D6 92 D7 93 D8 94 D9 95 D10 96 D11 97 D12 98 D13 99 D14 100 D15 101 VSS 102 A0 103 A1 104 A2 105 A3 106 A4 107 A5 108 A6 109 A7 110 VCC 111 A8 112 A9 113 A10 114 A11 115 A12 116 A13 117 A14 118 A15 119 VSS 120 A16
CS2 CS1 CS0 LED_ON BL_ON VCC XO XI VSS FEAT1 FEAT0 SCL2_I SDA2_I SCL2_O SDA2_O MOD2 MOD1 MOD0 NVM_WP BUS_SW RY/ BY SCL1 SDA1 I2C EN FHP CPUGO FHP PDPGO VSS P_ALARM SO2 SI2
60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31
R3334 10k :1005 R3333 10k :1005 C3410 0.1 10V B:1005
3.3VLED_ON TO(2/7)
D6 D7 D8 D9 D10 D11
8
7
D0 D1 D2 D3 D4 D5
BUS_SW SCL TO(1/7) SDA
100kHzz
R3464 100 :1005 R3465 100 :1005 R3470 10k :1005 R3329 10k :1005 R3328 10k :1005 R3441 10k :1005 R3440 10k :1005
SCL SDA I2CEN CPUGO PDPGO TO(7/7) IRQ
NC 1A1 1A2 1A3 1A4 1A5 1A6 GND 1A7 1A8 1A9 1A10 2A1 2A2 VCC 2A3 GND 2A4 2A5 2A6 2A7 2A8 2A9 2A10
1OE 2OE 1B1 1B2 1B3 1B4 1B5 GND 1B6 1B7 1B8 1B9 1B10 2B1 2B2 2B3 GND 2B4 2B5 2B6 2B7 2B8 2B9 2B10
25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48
2
1
CPUD0 CPUD1 CPUD2 CPUD3 CPUD4 CPUD5 CPUD6 CPUD7 CPUD8 CPUD9 CPUD10 CPUD11 CPUD12 CPUD13 CPUD14 CPUD15
1
2
3
4
5
6
7
8
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 T_SW
D3307 MA111DVI TO(1/7)
PANEL_CONT TO(7/7)
HA17 A18 A19 A20
C3402 0.1 10V B:1005
TESTC3407 0.1 10V B:1005 R3468 10k :1005 R3469 10k :1005
3.3VJL3329 JL3330 JL3331 JL3332
R3412 1k :1005 R3413 100 :1005 R3415 100 :1005 R3416 100 :1005
RXD0 TXD0 TXD1 RXD1R3348 100 R3349 100
D3401 UDZS3.9BR3471 10k :1005 C3404 1 6.3V B:1608 C3405 1 6.3V B:1608 C3406 1 6.3V B:1608 R3408 10k :RN1005 R3409 10k :RN1005 R3410 10k :RN1005
TO(1/7)
I
R3422 R3425 R3427 R3429 10k 10k 10k 10k :1005 :1005 :1005 :1005
IC3353 SN74AHC1G04DCKINT TO(2/7) INTVSO TO(6/7) INTVS2 INTVS1 TO(4/7) NC A GND VCC Y
1
5
C3357 0.1 10V B:1005
3
4
DEF(3/7) BOARD WAVEFORM
2
TO(2/7)3.3V
CABLE_DET TO(1/7)
15C3358 0.1 10V B:1005
THERMO_HIC2 TO(2/7)
IC3354 SN74AHC1G04DCKNC A GND VCC Y
J
THERMO_P THERMO_HICR3320 RB3402 10k 10k*4 :RN1005
1
6
5
4
3
IC3406 SN74CBTLV16210GR BUS-SW
0.4Vp-p ( 16.5MHz )
DEF(3/7)(MCU,BUS SW)B-SS12016-DEF-P3
3
2
4
GND SI1 SO1 3.3V
4 3 2 1CN3351 4P
KKDE55XBR950 (UC) 3-15
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
15
TO(2/7) 3.3VFB3504 BLM11P300S
C3586 10 6.3V B:3216
IC3502 MAX1644EAE 2.0A 1.5V REGL3501 4.7H 1.6A :CHIPSHDN LX PGND LX PGND VCC
TO(6/7) 1.5V
3.2IN LX IN SS COMP
9 10 11 12 13 14 15 16
1
B
5
C3587 0.1 10V B:1005 C3588 470p B:1005 R3510 220k :1005
R3513 0.1 1/2W :4532
1.7 FBSEL 2.3 TOFF REF 1.1 1.1 FB GND 1.1
C3590 220 2.5V :AL-CP R3514 0.1 1/2W :4532
6
4
3
2
C3589 1 6.3V B:1608
8
7
R3511 24k :RN1005 R3512 47k :RN1005
R3515 #
R3509 10 :1005
C3585 2.2 6.3V B:2012
C
D
E
G0 G1 G2 G3 G4 G5 G6 G7 B0 B1 B2 B3 B4 B5 B6 B7 R0 R1 R2 R3 R4 R5 R6 R7 DCK VS HS DE
GY10 GY11 GY12 GY13 GY14 GY15 GY16 GY17 BU10 BU11 BU12 BU13 BU14 BU15 BU16 BU17 RV10 RV11 RV12 RV13 RV14 RV15 RV16 RV17 CLKI1 VS1 HSCS1 DE1
CORBU IN11
CORBU IN22FB3501 BLM11P300S
CORBU POWERRC3534 4.7 6.3V B:2012 C3535 4.7 6.3V B:2012
TO(2/7) 2.5V
FB3502 BLM11P300S
FB3503 BLM11P300S
IC3501(1/8) CXD9762AGFCPU GY10 GY11 GY12 GY13 GY14 GY15 GY16 GY17 BU10 BU11 BU12 BU13 BU14 BU15 BU16 BU17 RV10 RV11 RV12 RV13 RV14 RV15 RV16 RV17 CLKI1 VS1 HSCS1 289 278 277 266 265 254 253 242 241 229 232 231 230 217 218 219 220 205 206 207 208 193 194 195 197 181 182 184 53 R3505 170 22 :1005 157 171 169 183 5 7 3 1 243 83 122 124 6 8 4 2 269 66 RB3503 10k*4 84 87 88 93 97 117 118 121 142 149 151 164 334 335 337 345 355 362 365 370 GY10 GY11 GY12 GY13 GY14 GY15 GY16 GY17 BU10 BU11 BU12 BU13 BU14 BU15 BU16 BU17 RV10 RV11 RV12 RV13 RV14 RV15 RV16 RV17 CLKI1 VS1 HSCS1 SOG1 IFLD1 HSADIN1 HSADOUT1 DE1 COAST1 INTVS1 VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 TO(3/7) INTVS2 292 301 302 351 352 293 315 377 313 280 291 268 378 327 316 403 353 328 404 429 379 354 455 430 405 380 456 431 457 356 381 406 432 382 407 458 383 408 433 459 384 409 434 460 435 385 410 461 436 462 411 386 437 463 412 438 464 387 413 439
IC3501(2/8) CXD9762AGFCPU INTVS2 WUENB2 ECO2 COAST2 DE2 HSADOUT2 HSADIN2 IFLD2 SOG2 HSCS2 VS2 CLKI2 RVB27 RVB26 RVB25 RVB24 RVB23 RVB22 RVB21 RVB20 BUB27 BUB26 BUB25 BUB24 BUB23 BUB22 BUB21 BUB20 GYB27 GYB26 GYB25 GYB24 GYB23 GYB22 GYB21 GYB20 RVA27 RVA26 RVA25 RVA24 RVA23 RVA22 RVA21 RVA20 BUA27 BUA26 BUA25 BUA24 BUA23 BUA22 BUA21 BUA20 GYA27 GYA26 GYA25 GYA24 GYA23 GYA22 GYA21 GYA20
C3501 4.7 6.3V B:2012 C3502 0.01 16V B:1005 C3503 0.01 16V B:1005 C3504 0.01 16V B:1005 C3505 0.01 16V B:1005 C3506 0.01 16V B:1005 C3507 0.01 16V B:1005 C3508 0.01 16V B:1005 C3509 0.01 16V B:1005 C3510 0.01 16V B:1005 C3511 0.01 16V B:1005 C3512 0.01 16V B:1005 C3513 0.01 16V B:1005 C3514 0.01 16V B:1005 C3515 0.01 16V B:1005 C3516 0.01 16V B:1005 C3517 0.01 16V B:1005 C3518 0.01 16V B:1005 C3519 0.01 16V B:1005 C3520 0.01 16V B:1005 C3521 0.01 16V B:1005 C3522 0.01 16V B:1005 C3523 0.01 16V B:1005 C3524 0.01 16V B:1005 C3525 0.01 16V B:1005 C3526 0.01 16V B:1005 C3527 0.01 16V B:1005 C3528 0.01 16V B:1005 C3529 0.01 16V B:1005 C3530 0.01 16V B:1005 C3531 0.01 16V B:1005 C3532 0.01 16V B:1005 C3533 0.01 16V B:1005 R3506 0 :1005
IC3501(3/8) CXD9762AGFCPU 158 304 256 55 65 101 114 123 176 189 212 222 225 261 303 297 317 319 329 339 343 344 357 359 361 363 372 394 112 258 94 135 282 62 257 145 255 82 111 113 143 146 152 175 177 198 210 211 213 221 233 249 267 285 294 305 318 331 332 333 VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC NC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC VDDC_SEP VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2 VSS2
IC3501(4/8) CXD9762AGFCPU 98 150 91 92 95 116 120 140 148 139 85 110 69 61 138 90 96 119 144 86 246 126 163 185 188 196 200 209 224 234 236 248 260 271 283 295 306 307 330 336 358 360 364 366 367 368 369 389 270 187 199 223 235 247 259 272 284 296 308 320 VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD VDD2 VDD2 VDD2 VDD2 VDD2 VDD2 VDD2 VDD2 VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS VDDS_SEP VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS VSS
F
G
H
B0 B1 B2 B3 B4 B5 B6 B7 G0 G1 G2 G3 G4 G5 G6 G7 R0 R1 R2 R3 R4 R5 R6 R7
B0 B1 B2 B3 B4 B5 B6 B7 G0 G1 G2 G3 G4 G5 G6 G7 R0 R1 R2 R3 R4 R5 R6 R7
RB3251 22*4
RB3252 22*4
RB3253 22*4
DE1 INTVS1 TO(3/7)RB3254 22*4
RB3255 22*4
RB3256 22*4
DCK DE VS HS
DCK DE VS HS
R3251 0 :1005
C3536 0.01 16V B:1005 C3537 0.01 16V B:1005 C3538 0.01 16V B:1005 C3539 0.01 16V B:1005 C3540 0.01 16V B:1005 C3541 0.01 16V B:1005 C3542 0.01 16V B:1005 C3543 0.01 16V B:1005 C3544 0.01 16V B:1005 C3545 0.01 16V B:1005 C3546 0.01 16V B:1005 C3547 0.01 16V B:1005 C3548 0.01 16V B:1005 C3549 0.01 16V B:1005 C3550 0.01 16V B:1005 C3551 0.01 16V B:1005 C3552 0.01 16V B:1005 C3553 0.01 16V B:1005 C3554 0.01 16V B:1005 C3555 0.01 16V B:1005 C3556 0.01 16V B:1005 C3557 0.01 16V B:1005 C3558 0.01 16V B:1005 C3559 0.01 16V B:1005 C3560 0.01 16V B:1005 C3561 0.01 16V B:1005 C3562 0.01 16V B:1005 C3563 0.01 16V B:1005 C3564 0.01 16V B:1005 C3565 0.01 16V B:1005 C3566 0.01 16V B:1005 C3567 0.01 16V B:1005 C3568 0.01 16V B:1005 C3569 0.01 16V B:1005 C3570 0.01 16V B:1005 C3571 0.01 16V B:1005 C3572 0.01 16V B:1005 C3573 0.01 16V B:1005 C3574 0.01 16V B:1005 C3575 0.01 16V B:1005 C3576 0.01 16V B:1005 C3577 0.01 16V B:1005 C3578 0.01 16V B:1005 C3579 0.01 16V B:1005 C3580 0.01 16V B:1005 C3581 0.01 16V B:1005 C3582 0.01 16V B:1005 C3583 0.01 16V B:1005 C3584 0.01 16V B:1005 R3507 0 :1005
I
RB3257 22*4
TMDS TO(1/7)
J
DEF(4/7)(CPU)
B-SS112016-DEF-P4
KKDE55XBR950 (UC) 3-16
1 AIC3501(5/8) CXD9762AGFCPU WEN CASN RASN CSN DQS DM3 DM2 DM1 DM0 DQ31 DQ30 DQ29 DQ28 DQ27 DQ26 DQ25 DQ24 DQ23 DQ22 DQ21 DQ20 DQ19 DQ18 DQ17 DQ16 DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ09 DQ08 DQ07 DQ06 DQ05 DQ04 DQ03 DQ02 DQ01 DQ00 BA1 BA0 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 CKE CKN CKP MREF TREF 67 18 44 43 8 21 46 71 20 41 15 40 14 13 39 12 38 11 37 64 10 36 9 35 34 7 33 6 32 60 5 31 59 4 30 3 57 29 2 1 28 45 19 25 50 24 75 49 74 23 73 48 22 72 47 42 16 17 115 141
2
3
4
5
6
7
8
9
10
11
12
13
14
15
B
C
D
E
F
G
31 A0 32 A1 33 A2 34 A3 35 VDD 36 A10 37 A11 38 NC 39 NC 40 NC 41 NC 42 NC 43 NC 44 NC 45 A9 46 VSS 47 A4 48 A5 49 A6 50 A7
WEN CASN RASN CSN DQS DM3 DM2 DM1 DM0 DQ31 DQ30 DQ29 DQ28 DQ27 DQ26 DQ25 DQ24 DQ23 DQ22 DQ21 DQ20 DQ19 DQ18 DQ17 DQ16 DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ09 DQ08 DQ07 DQ06 DQ05 DQ04 DQ03 DQ02 DQ01 DQ00 BA1 BA0 A11 A10 A9 A8 A7 A6 A5 A4 A3 A2 A1 A0 CKE CKN CKP
AUR2
AUR53
AUR31 AUR30
DM3 DM2 DM1 DM0 CKP CKN DQ31 DQ30 DQ29 DQ28 DQ27 DQ26 DQ25 DQ24 DQ23 DQ22 DQ21 DQ20 DQ19 DQ18 DQ17 DQ16 DQS DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ09 DQ08 DQ07 DQ06 DQ05 DQ04 DQ03 DQ02 DQ01 DQ00
RB3604 22*4
AUR58 AUR57 AUR56 AUR55 AUR51 AUR52 AUR31 AUR30 AUR29 AUR28 AUR27 AUR26 AUR25 AUR24 AUR23 AUR22 AUR21 AUR20 AUR19 AUR18 AUR17 AUR16 AUR53 AUR15 AUR14 AUR13 AUR12 AUR11 AUR10 AUR9 AUR8 AUR7 AUR6 AUR5 AUR4 AUR3 AUR2 AUR1 AUR0
RB3605 22*4
RB3606 22*4
AUR29
AUR1 AUR0
C3613 0.1 10V B:1005
C3615 0.1 JL3851 10V B:1005 C3619 0.1 10V B:1005
R3602 47 :1005
RB3607 22*4
+2.5V
RB3608 22*4
RB3609 22*4
RB3610 22*4
RB3611 22*4
AUR18 AUR19C3608 0.1 10V B:1005 C3609 0.1 10V B:1005
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9
AUR16 AUR17
C3607 0.1 10V B:1005
7
AUR6 AUR7
5
4
AUR4 AUR5
RB3612 22*4
AUR20 AUR21 AUR22 AUR23 AUR55 AUR57 AUR49 AUR48 AUR47 AUR46 AUR44 AUR45
RB3613 22*4
C3610 0.1 10V B:1005
BA1 CKE BA0 RASN CSN CASN WEN
RB3614 22*4
RB3615 22*4
AUR45 AUR50 AUR44 AUR47 AUR46 AUR48 AUR49
DQ3 VDDQ DQ4 DQ5 VSSQ DQ6 DQ7 VDDQ DQ16 DQ17 VSSQ DQ18 DQ19 VDDQ VDD VSS DQ20 DQ21 VSSQ DQ22 DQ23 VDDQ DM0 DM2 WE CAS RAS CS BA0 BA1
IC3602 K4D263238F-UC50TDOUBLE DATA RATE SDRAM
DQ28 VDDQ DQ27 DQ26 VSSQ DQ25 DQ24 VDDQ DQ15 DQ14 VSSQ DQ13 DQ12 VDDQ VSS VDD DQ11 DQ10 VSSQ DQ9 DQ8 VDDQ VREF DM3 DM1 CK CK CKE MCL A8(AP)
51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80
1
AUR3
DQ2 100 VSSQ 99 DQ1 98 DQ0 97 VDD 96 VDDQ 95 DQS 94 RFU 93 VSSQ 92 NC 91 NC 90 NC 89 NC 88 NC 87 VDDQ 86 VSS 85 DQ31 84 DQ30 83 VSSQ 82 DQ29 8