m-35 vin:2hscnaer3yc024669 dot:3/1/17 … · #2 axel front seal wet reseal 4/24/2008 887,406 ......

38
M-35 VIN:2HSCNAER3YC024669 DOT:3/1/17 tires:295/75 R22.5" eng#11959655, 500HP / 1650'# trans:FRO16210C YEAR: 2000 MAKE: INTL 9400 rear end: DS404, 3.55 PROBLEM DESCRIPTION OF REPAIR DATE MILEAGE R. STEER BRAKE CRACKED replaced shoes #1 axel 1/2/2008 848,708 steers hard at low speed R&R steering gearbox warranty from steernberg 1/2/2008 848,708 front drive axel leaking (cracked) R&R reman from trucks&parts of Ohio 1/2/2008 848,708 R&R bearings &races #1 axel " " A-SERV. T/A Livingston,CA. 1/9/2008 851,339 A-SERV. T/A North bend WA. 2/21/2008 867,043 R&R air filter 2/21/2008 867,043 R&R batteries (Petro Farrgo, ND.) 2/27/2008 868,441 R. W/S wiper arm not working R&R L&R wiper asc. 3/5/2008 870,530 B-SERV. 3/5/2008 870,530 removed busted bugshield " " B-SERV. 3/14/2008 876,122 A-SERV. 4/4/2008 882,218 R&R ALT. BELTS " " B-SERV. 4/24/2008 887,406 CAB SHOCK R&R BOTH L&R 4/24/2008 887,406 INSTALLED PONY PAK 4/24/2008 0 hr dash valves busted BRACE DASH 4/24/2008 887,406 exh. Bracket broke under L. door remove bracket R&R flex &clamps 4/24/2008 887,406 #2 axel front seal wet reseal 4/24/2008 887,406 oil leak bolt mising in cam follower R&R 4/24/2008 887,406 check steer tires R&R both tires & balance (hoosier tire) 4/29/2008 887,406 B-SERV. 5/16/2008 892,801 A-SERV. 6/3/2008 897,942 install wheel balancers #1 axel 6/3/2008 897,942 service pony pak 6/3/2008 200hr clutch is bad (897,942) R&R clutch,pilot,&brake ,turn fly wheel@motor service 7/10/2008 897,943 clean int. 7/14/2008 897,948 a/c in-op charged system 7/14/2008 897,948 change door signs to RW trans. 7/14/2008 897,948 coolant leak R&R water pump 7/15/2008 898,038 R&R fan & high press. Switch on pony 8/8/2008 200 hr. trans grinds when going to lo range(7/08) R&R trans (reman from truck &parts of ohio) 8/21/2008 901,459 fuel leak R&R return line from back of head 8/21/2008 901,459 a/c inop R&R a/c comp & pulley 8/27/2008 902,181

Upload: vudien

Post on 14-May-2018

220 views

Category:

Documents


1 download

TRANSCRIPT

M-35 VIN:2HSCNAER3YC024669 DOT:3/1/17

tires:295/75 R22.5" eng#11959655, 500HP / 1650'# trans:FRO16210C

YEAR: 2000 MAKE: INTL 9400 rear end: DS404, 3.55

PROBLEM DESCRIPTION OF REPAIR DATE MILEAGER. STEER BRAKE CRACKED replaced shoes #1 axel 1/2/2008 848,708

steers hard at low speed R&R steering gearbox warranty from steernberg 1/2/2008 848,708front drive axel leaking (cracked) R&R reman from trucks&parts of Ohio 1/2/2008 848,708

R&R bearings &races #1 axel " "A-SERV. T/A Livingston,CA. 1/9/2008 851,339A-SERV. T/A North bend WA. 2/21/2008 867,043R&R air filter 2/21/2008 867,043R&R batteries (Petro Farrgo, ND.) 2/27/2008 868,441

R. W/S wiper arm not working R&R L&R wiper asc. 3/5/2008 870,530B-SERV. 3/5/2008 870,530removed busted bugshield " "B-SERV. 3/14/2008 876,122A-SERV. 4/4/2008 882,218R&R ALT. BELTS " "B-SERV. 4/24/2008 887,406

CAB SHOCK R&R BOTH L&R 4/24/2008 887,406INSTALLED PONY PAK 4/24/2008 0 hr

dash valves busted BRACE DASH 4/24/2008 887,406exh. Bracket broke under L. door remove bracket R&R flex &clamps 4/24/2008 887,406#2 axel front seal wet reseal 4/24/2008 887,406oil leak bolt mising in cam follower R&R 4/24/2008 887,406check steer tires R&R both tires & balance (hoosier tire) 4/29/2008 887,406

B-SERV. 5/16/2008 892,801A-SERV. 6/3/2008 897,942install wheel balancers #1 axel 6/3/2008 897,942service pony pak 6/3/2008 200hr

clutch is bad (897,942)R&R clutch,pilot,&brake ,turn fly wheel@motor service 7/10/2008 897,943clean int. 7/14/2008 897,948

a/c in-op charged system 7/14/2008 897,948change door signs to RW trans. 7/14/2008 897,948

coolant leak R&R water pump 7/15/2008 898,038R&R fan & high press. Switch on pony 8/8/2008 200 hr.

trans grinds when going to lo range(7/08) R&R trans (reman from truck &parts of ohio) 8/21/2008 901,459fuel leak R&R return line from back of head 8/21/2008 901,459a/c inop R&R a/c comp & pulley 8/27/2008 902,181

p/s hard to turn R&R filter 8/27/2008 902,181fuel guage R&R sending unit 10/15/2008 902,188drive tire blow out R&R used steer 10/23/2008

R&R side box cable left 11/4/2008 907,987p/s hard to turn R&R filter 11/4/2008 907,987

B-SERV. 11/7/2008 908,677p/s hard to turn R&R p/s pump 11/10/2008 908,677pony no heat pump in wrong heater hose (switched) 11/10/2008 908,677

install cardinal door signs 11/10/2008

ac-inoplines loose at comp tighten lines & recharge(t/a wildwood,fl.) 12/16/2008 914,157A-SERV. (t/a claton,in.) 12/13/2008 913,151service pony pak 12/27/2008 422hrservice pony pak 1/17/2009 658hrB-SERV. 1/21/2009 922,002A-SERV. (t/a roanoke,va) 2/14/2009 928,027R&R air filter 2/14/2009 928,027B-SERV. 2/23/2009 929,500

p/s leak tightened return line 2/23/2009 929,500hole in muffler remove muffler,install straight pipe 2/23/2009 929,500

B-SERV. 3/21/2009 933,863service pony pak 3/21/2009 1068hrinstall new muffler 4/7/2009 937,355R&R susp level valve 4/7/2009 937,355R&R RRI tire (used steer tire) 4/7/2009 937,355B-SERV. 4/7/2009 937,355

batteries dead R&R all 3 batteries (Petro fargo,nd.) 4/26/2009 942,393A-SERV. (t/a rogers,mn) 5/11/2009 944,100B-SERV. 5/28/2009 949,160

coolant leak R&R radiator (used from M-47) 6/15/2009 955,126B-SERV. 6/15/2009 955,126R&R brakes & drums #2 & #3 axels (did not do seals) 6/15/2009 955,126R&R steer tires mount at MF shop did not balance 6/15/2009 955,126R&R u-joint in steer shaft 6/15/2009 955,126R&R 2 tires rt side #3 axel (used recaps) 6/15/2009 955,126degrease eng 6/15/2009 955,126replace missing cover on lower mirror brkt Lft side 6/15/2009 955,126

w/s wash in-op R&R washer pump 6/15/2009 955,126Left king pin loose R&R king pins 6/24/2009 956,017oil and grease leak DOT 6/1/09 needs #1 cam cover resealed

remove & reseal cam follower covers,R&R acc drive seal 6/24/2009 956,017

R&R front blower mtr(dimond IH little rock Ar) 7/10/2009 957,860

A-SERV. (seville, oh) 7/16/2009 959,059B-SERV. 8/16/2009 970,208A-SERV. (T/A Earl,Ar) 9/1/2009 974,874B-SERV. 9/9/2009 974,419B-SERV. (T/A prescott,Az) 9/10/2009 980,211B-SERV. (t/a alda,Ne) 9/24/2009 984,725R&R air filter 9/24/2009 984,725A-SERV. (t/a Hampshire,il.) 10/8/2009 990,233B-SERV. (t/a branford,ct) 11/7/2009 999,604

alternater in-op R&R alternater (C. Chambers)

A-SERV. 11/24/2009 1,004,221

front of #2 axel leakR&R pinion seal,pull front nose section off & reseal 12/1/2009 1,004,221

heat not good R&R clip on blend door under seat 12/1/2009 1,004,221add 1pt pen cool 12/1/2009 1,004,221R&R fill plug front rear end 12/1/2009 1,004,221R&R press relief valve for air ride 12/1/2009 1,004,221

tractor prot valve in-opchecked worked OK both popped out @ 25-30psi 12/2/2009 1,004,221install reflective rear of sleeper 12/2/2009 1,004,221R&R lft side box cable 12/2/2009 1,004,221A-SERV. (t/a whitestown, in) 1/29/2010 1,019,428B-SERV ( ) 3/7/2010 1,029,644

A-SERV. (t/a Valley Grove,WV) 3/24/2010 1,034,501

B-SERV. 4/26/2010 1,045,125dash busted replace left side of dash 5/4/2010 1,045,746

drive tiresR&R drive tires 295/75 R22.5" (new TOYO m-627 hoosier) 5/4/2010

left headlight chrome used off M-44 5/5/2010tail light bar rotten R&R tail light bar 5/5/2010

R&R P-clamp fuel line #3 head 5/5/2010#3 axle, R&R left wheel seal, and steam clean brake shoes 5/5/2010

wheel seals and brakes wet grease??

#2 axle, R&R wheel seals, s-cam bushings & steam clean brake shoes 5/5/2010

B-SERV. 5/5/2010degrease eng. 5/6/2010R&R a/c belt 5/6/2010

check fuel lines at pump, wet tighten loose fitting 5/6/2010added 1 gal a/f, 1/2 gal water 5/7/2010

oil leak left side of eng, cam followers degrease, and silicone around covers 5/7/2010

test batteries OK 5/11/2010replace broken batt cable 5/11/2010 1,045,746

R&R alt belts 5/11/2010test alt OK 5/11/2010

R&R steer tires new low pro Yokohama(mounted & ballanced @ Georges) 5/11/2010 1,045,746

calibrate speedo 3mi off in 100mi,(crossroads) 5/28/2010 1,048,546

A-SERV. (t/a Kingman, Az) 5/31/2010 1,050,301

B-SERV. (t/a Lake park, Ga) 6/22/2010 1,058,169R&R a/c comp & pulley 6/24/2010

A-SERV.(t/a Willcox, Az.) 7/15/2010 1,065,913R&R air filter 7/15/2010

B-SERV.degrease eng. 7/28/2010 1,068,152

leak rear of trans R&R seal rear of trans 7/29/2010 1,068,152oil leak front of eng. R&R front crank seal #3020183 7/29/2010 1,068,152oil leak side of eng reseal oil cooler 7/29/2010 1,068,152

R&R press oil line to turbo #3899412 7/29/2010 1,068,152

front diff leaks at hog headseparate front diff & reseal, drain & fill with synthetic 75/90wash out rad, CAC, & a/c condensor 7/30/2010 1,068,152

eng miss R&R #3 inj. 7/30/2010 1,068,153R&R wind shield(Sipes auto glass) 8/2/2010 1,068,153R&R a/c high press hose, #3505161c92 8/2/2010 1,068,153R&R a/c thermostat switch 8/3/2010 1,068,153

eng miss R&R #3 inj. (bad inj from Youngs) 8/5/2010 1,068,549

B-SERV. 8/17/2010 1,073,420oil leaks sealed around #1 cam follower 8/23/2010 1,076,473

remove Cardinal signs 9/13/2010 1,079,337clean out cab 9/23/2010R&R maxi #2 axle, rt side 9/23/2010

broken hood spring R&R rt hood spring 9/24/2010left side box cable, C Chambers said it is ok R&R lft side box cable 9/24/2010

clean out cab 9/24/2010runs rough, looses prime, found cracked fitting R&R fuel fitting, at fuel pump 9/24/2010 1,079,338

install RW signs 9/24/2010 1,079,338R&R alt belts 9/24/2010 1,079,338

a/c comp loose helicoil bolt holes in front cover 9/29/2010 1,079,338

hard start, loosing primeR&R all suction fuel lines, from tanks to ECM, and I return line 10/13/2010 1,079,338

oil press lower than usual, after service 7/15/10 R&R oil press sending unit, still shows low press

R&R oil pump, (new pai from Crossroads) 10/19/2010 1,079,338

A-SERV. 10/21/2010 1,079,343adjust clutch 10/21/2010 1,079,343replace bolt in seat recline knob 11/2/2010 1,080,084

5th wheel won't stay released R&R broken spring 11/2/2010 1,080,084repair air leak at eng fan cylinoid 11/2/2010 1,080,084tighten all wheel bearings 11/19/2010 1,082,641clean & test batteries OK 12/9/2010 1,084,449cleaned w/s washer spray knosles 12/13/2010 1,084,742

light out in heater cntrl replaced bulbs in heater cntrl 12/16/2010 1,085,335exhaust leak R&R exhaust manifold (used off M-38) 12/16/2010 1,085,335

adjust overhead, valves and injectors 12/16/2010 1,085,335install headache rack 12/16/2010 1,085,335

B-SERV. 12/17/2010 1,085,335adjust brakes 12/17/2010 1,085,335R&R release cylinder on 5th wheel 12/17/2010 1,085,335

clearance light out R&R bulb 12/27/2010 1,089,094

lens on chicken light busted replace lense, used 12/27/2010 1,089,094

A-SERV. (T/A Matthews, Mo.) 1/11/2011 1,094,409R&R rt head light Mike Williams changed on road 1/13/2011

B-SERV. 1/21/2011 1,099,662R&R left tail light 1/27/2011 1,102,171

city horn in-op works at this time 1/27/2011air leak R&R left front air bag 2/9/2011 1,105,337

A-SERV. 2/24/2011 1,109,205oil leak oil filter loose 2/24/2011

R&R air filter 2/24/2011 1,109,205add 1 pt now cool 2/24/2011degrease eng 2/25/2011 1,109,205

oil press low low

Inframe engine overhaul,cylinder kits, rod bearings, main bearings, cam bearings, water pump(#7068X), air compressor(#107507X), front cover gskt, 6-piston oilers 3/15/2011 1,111,051reman cylinder heads(Youngs)R&R T-Stats

R&R gront gear cover, new from Crossroads paiR&R 6 injectors (Interstate Injection)#3411767PXR&R fuel shut off cylinoid 3/31/2011 1,111,051R&R bearing in water pump idler pulley 3/31/2011R&R w/s wiper linkage 3/31/2011

replace missing tail light 4/8/2011

eng missperform inj cut out test, no obvious miss, no fault codes 4/20/2011 1,112,734R&R fuel pump, (reman fron Interstate inj)R&R eng wire harness #3411481 4/27/2011recheck overhead adjustment 4/27/2011 1,112,734

shake in front endR&R steer tires(mounted here, not ballanced, has centramatic) 5/3/2011 1,114,459drain oil and change filter 5/3/2011 1,114,459

eng miss.R&R #2 injector (Warranty from Interstate injection) 5/12/2011R&R wire harness from ECM to fire wall (used out M-38) 5/13/2011

am/fm not picking up install antenna on roof 5/20/2011 1,116,186added 1 gal a/f 5/20/2011

speedo in-op, low pwr R&R speedo sensor(#3528003c1) 5/23/2011 1,116,381w/s wash in-op works at this time 6/1/2011 1,117,804a/c weak unhooked pony pak & recharged 6/1/2011 1,117,804

B-SERV. 6/13/2011 1,121,267pony power pannel out, green light steys on all the time, brain is bad? remove Pony Pak 6/13/2011 1,121,267rt door don’t lock latch is loose R&R strike post, and lubed lock 6/13/2011Eng Miss, runs rough, black smoke

R&R ambient air temp. R&R #2 & #3 injectors(Volvo Knoxville, Tn)

Eng Miss, runs rough, black smoke, bad valve #2 cylinder

R&R #1 cylinder head, R&R rings on #2 piston(Youngs), swap #2 - #1 injectors 6/29/2011 1,122,410

rt fuel tank leaking R&R tank(repaired at Coopers -Martinsville, In.) 7/1/2011 1,122,410driver door some times hard to open R&R latch & strike post, lube linkage 7/1/2011

A-SERV. 7/1/2011 1,122,410R&R left bumper brace 7/1/2011install headache rack 7/1/2011

cig lighter plug in sleeper in-op ran hot wire 7/5/2011 1,122,410

fan hub noisyR&R bearing in fan hub (#W5207LL), & rebuild clutch pulley 7/6/2011 1,122,410clean interior & wash ext. 7/8/2011

eng over heat tighten water pump belt 7/27/2011 1,126,901Low oil press,7/19/11 28-30psi going down road clean regulater plunger in bottom of oil pump 7/27/2011

R&R oil filter 7/27/2011

rt headlight needs adjusted, screw is stripped out R&R rt head light ascembly 7/27/2011 1,126,901

B-SERV. 7/27/2011R&R Turbo, CAC, and air filter(Floyd's Truck Repair,Sabetha, Ks.) 8/1/2011

exhaust leak R&R exhaust gasket for #5-#6 cylinder 8/5/2011 1,128,626install flashing light on head ache rack 9/7/2011 1,135,959

A-SERV. 9/13/2011 1,137,935cd player in-op R&R am/fm (used) 9/13/2011

rotate drive tires X 9/13/2011add 1 pt pen cooldot insp. 9/13/2011

a/c in-opR&R a/c compressor, and line from compressor to evaporater(used outM-38) 9/13/2011 1,137,9353.5# freon

king pins loose R&R king pins and bushings 9/13/2011 1,137,935exhaust leak R&R 1' flex pipe, at muffler 9/20/2011 1,139,376

R&R u-joint in steer shaft at gear box 9/20/2011R&R rt tail light 9/20/2011 1,139,3763 axle allignment 9/28/2011 1,142,609R&R TPS 9/28/2011

needs steering wheel repair broken wire on chicken lights 9/28/2011 1,142,609

truck died, everything is deadrepair broken wire at alternator (John & Brad's truck repair) 10/3/2011

L window reg. R&R l window regulator 10/11/2011 1,145,950

B-SERV. 10/11/2011a/c in bunk is in-op blend door was off 10/11/2011 1,145,950wheel bearings locked up, rt side #1 axle called service truck, could not fix 10/12/2011 1,146,794

towed back to shop 10/12/2011R&R rt steer knuckle(axle spindel) used off M-38 10/13/2011R&R seal, bearings, and races 10/13/2011bearings

R&R steering wheel 10/13/2011 1,146,794oil leak R&R o-ring on #1 piston oiler 10/25/2011 1,149,039batt dead had to jump, test batteries R&R all 3 batteries 11/1/2011 1,151,415

A-SERV. 11/7/2011 1,153,281needs guide pole install guide poles 11/7/2011

work lights in-op repair broken wire 11/7/2011

squeels , may have loose belt tighten a/c belt 11/7/2011exhaust leak R&R exhaust manifold gasket 11/7/2011 1,153,281

R&R wiper blades 11/22/2011oil leak R&R rubber hose on oil fill tube 11/23/2011 1,159,640a/c belt is gone replace a/c belt 11/23/2011 1,159,640

needs wiper mtr, wont park R&R wiper motor 12/6/2011 1,160,963R&R wheel seal #1 axle rt side 12/6/2011

B-SERV. 12/6/2011 1,160,963shocks rusty (#2018987c2 $63.16 R&R rear shocks 12/20/2011 1,165,663air leak repair air line 12/20/2011

R&R alt belts 12/20/2011

B-SERV. 12/20/2011

A-SERV. 1/2/2012 1,169,358rt brake light out R&R both tail lights 1/2/2012air leak R&R left maxi #2 axle 1/8/2012 1,170,555

tighten shock bolt #2 axleair leak when push brake pedal replace end on blue air hose 1/9/2012 1,170,579

clean out cab 1/25/2012oil leak R&R o-ring on #1 piston oilerblower mtr in-op R&R blower motor 1/30/2012 1,174,481

resistor

2 prongs, broke in black plug trailer lights rear of cab R&R 7 way plug rear of cab(non ABS) 2/1/2012 1,174,4815th whell sloppy R&R 5th wheel plate(from KW) 2/14/2012 1,174,677

BushingsR&R dimmer switch 2/17/2012 1,176,564

w/s wash weak undo kink in washer lineleft door latch does not latch good took apart and lubed

A-SERV. 3/16/2012 185,824replace left mudflap and hanger

t/s has to be held down when turning left repair w/used parts

wheel seal leak #1 axle rt sideR&R bearings , races, brakes and seal #1 axle rt side brake shoes seal inner bearing inner race

outer bearing outer race

lost all power, click to start, bump battery box and it goes away

tightened loose wire at starter cylinoid, and tightened battery cables 3/30/2012 189,984R&R air hoses to trailerR&R fresh air filter 4/12/2012

cab stinksremove carpet and pad clean and reinstall, air out seat and matress 4/13/2012

B-SERV. 4/18/2012 191,852R&R left side box cable 5/11/2012 191,956

clutch brake not working adjust clutch, and linkage 5/18/2012 193,297clutch bad R&R clutch 6/26/2012 197,201

brake pilot bearing resurface flywheelR&R rear crank seal

bad air leak under cab when u shut it off R&R rt cab air bag

repair exhaust leak under bunk, 2 clamps and 4' flex pipeclean int. / wash ext 6/29/2012

A-SERV. 7/11/2012 200,199annual dot inspreplace triangles

truck died, may have overheated, acc drive broke

hauled back to shop on drop deck, service call and wrrecker to load truck on trailer 7/19/2012R&R acc drive(pai from crossroads) 7/25/2012 202,044 gasket, acc drive mount gasket, acc drive to air comp acc drive seal, w/o wear sleeve fan belt a/c belt water pump belt, cummins#3076492

blower kicks off, comes back on its own R&R freeze switch, had wrong style switch in ita/c comp leaking R&R a/c comp, (air source from crossroads)power windows in-op found and repaired broken wire in left doorA/C comp locked up R&R a/c comp (Chicago International) 7/26/2012 202,287

R&R HVAC dash cntrl (Chicago International) 7/27/2012

B-SERV. 8/24/2012 211,347R&R mud flaps and hangers

P/S gear box is leaking R&R steering gear box

high press p/s line need R&R R&R p/s hoses shake in steer wheel R&R steer tires

R&R brakes #2 and #3 axle

bolt fell out of shift isolater replace with bolt (service call, Battle Mtn, Nv) 9/6/2012air bag leak R&R rt rear air bag(Tukon Diesel Repair 9/6/2012 214,679

A-SERV. 9/12/2012 216,891R&R steering shaft(used out of M-45)

replace bolt and plastic pieces in shift isolator

seal leaking and bearing is loose in nose of forward rear diff. lot of metal in housing

pulled diff and sent to truck parts of Ohio, replaced needed parts, reinstalled

over heat, on big pull pulled CAC, washed out radiator 9/18/2012 216,891hole in rad hose, off tank. R&R line and recharge antifreeze(T/A Florence, Ky

A-SERV. 10/27/2012 231,059repaired wires, rt tail lightrepaired wires, left top cab lightrepaired air line to 5th wheel slide cylinderdegreased engreplaced side light 11/14/2012 237,185

crack in windshield, needs replaced R&R wind shield (American auto Glass) 11/21/2012

sulpher smell, check batteries R&R 3 bateries 11/23/2012 240,048

blower motors quit working twice, then came back ck blower mtrs and resistor, ck plugs on firewallwindows quit, CB, and stereo quit for a few hours

R&R fresh air filterpass door lock in-op R&R rt door latch

R&R turbo clampturbo pipe is cracked put wrap on crack, needs new pipe

hook up power inverter cablestighten alt belt

exhaust leak, turbo pipe R&R turbo down pipe 11/30/2012 242,532 lap joint exh clamp

rear blower mtr in-op R&R rear blower motorpark lights on hood R&R bulbs in hood park lightsdriving light out R&R left driving light bulb 12/7/2012 244,813belt squeel R&R alt belts

A-SERV. 12/12/2012 245,825straighten bumper

w/s crack R&R windshield (American Eagle)oil left side of eng R&R air compressor 12/27/2012 249,964

hub spline couplingR&R temp sensor in oil pumpreplace missing dipstick in P/S res.

short in cab lightsrepaired short in wire to guide post behind bumper 1/10/2013 255,004R&R bulbs in guide post R&R tail light repair wire to strobe light back of cab

A-SERV. 1/30/2013 260,626R&R air filter

5th wheel wont slide repair air line to cylinderR&R brake shoes #1 axle left side

bumper bent R&R bumperguide pole light left guide poles off new bumper

R&R 4' flex pipe behind turbo clamp x 2

oil leak, 1/2 gal day R&R front crank seal

alternator support is loosereplace broken bolts in alt mount, R&R alternator(new 24Si) alt belts x 2

mirror loose tighten bottom mirror bolt on rt side rt rear mtr mount is broke replace support off frame

rt rear mtr mount insulator 4 nuts and bolts 414052c1/414087c1

ps leakR&R o-ring on fitting at bottom of steering gear box

still has some oil leak R&R oil pan gasket 2/7/2013 260,627degreaseR&R air governor

oil leak front of eng. Left 6" puddle in 15min. 2/12/13

found crack in gear cover,R&R front gear cover(Croossroads)pai#060086 2/19/2013 cover gasket

tooth busted on acc drive gear R&R acc drive (Crossroads)pai#180920

front crank seal acc drive seal, w/o wear sleeve a/c comp support braket ac beltR&R rt head light 2/23/2013 264,211

B-SERV. 3/16/2013 270,711instal reflector on mud flap hangers

breaker pops on cab lights, running in snow and ice

lights ok at this time, checked all park lights for possible short, drilled drain holes in park lights on hood to drain traped water, replace bulb in light on left mirror, replace light on rt mirror 3/25/2013 273,370

brake chambers on steer axle leaking

R&R brake chambers #1 axle (Pauls fleet service, NC)

A-SERV. 3/29/2013 274,744tail lights in-op, J Franklin fixed it 4/26/2013A-SERV. 5/10/2013 290,888

adjust clutch linkage, for brake and free travelwheel seal leak #2 axle left side R&R wheel seal #2 axle left side

brake shoesrepaired wires to city horn

a/c weak tighten a/c belt 5/16/2013 292,372clean out cab 5/17/2013 292,377ck adjustment on drive brakes, OK not more than 1"R&R grab handle on left door

left king pin has movement up and down added shims to king pin

R&R wheel bearings #1 axle left side brng brng brng wheel sealR&R lower u-joint in steer shaft

oil leak left side of eng R&R gasket between air comp and fuel pumpoil leak on trans R&R shift tower gasket

drain plug leaking on #3 axle drain rearend and replace plugannual dot insp 5/21/2013 292,377degrease eng areaclean interior 6/25/2013R&R matress 6/28/2013 296,006

a/c is weak added 6oz freon, and 1 oz oil 7/19/2013 296,006remove headache rack, move air lines 7/29/2013 296,007wipe down interior

rt front air bag leak R&R air bag #2 axle rt side 8/1/2013 297,946left steer and all 4 tires on #2 axle are flat

service call to replace 4 drive tires and patch steer(Whiteland tire) 8/5/2013R&R 2 steer tires #1 axle (new Yokohama) 8/6/2013 299,523B-SERV. 8/7/2013 299,523

A-SERV. 9/14/2013 306,407R&R tail lightreplace chain on rt hood spring 10/17/2013 306,443install new alt belt

tighten fenders behind hood, ues big washersreplace 2 bulbs in side marker lights

left side exhaust pipe is rusted out R&R left lower stack pipe 1/16/2014 311,341

w/s wiper quitting?? rt side splined hub that comes thru cawl was broke, robbed one off M52R&R wiper bladescleaned interior 1/23/2014 311,341swap driver seattighten loose batey cable 2/3/2014

trailer left turn signal in-op R&R power cord (bought at TA) 2/7/2014no tail lights repaired broken wires 2/9/2014 317,161

power steer dip stick missing replace p/s dip stick 2/14/2014 318,774rt tail light in-op replace rt tail light bulbhood rattle tighten center support

replace bolt in hood spring cableA-SERV. 3/1/2014 318,889

drain leaking oil bad R&R quick drain on oil panoil leaks R&R oil dip stick tube

ferrel asmblyreplace hose on oil fill tubeR&R oil cooler sealsR&R air line to 5th wheelinstalled headache rack air line tender kitcleaned interiorinstalled flashing light on roof B-SERV. 3/29/2014 329,673adj. clutchreplace brake light press switchreplace red coil air line 3/31/2014 330,015

brake air leak R&R chamber, #3 axle left side 4/5/2014 332,423B-SERV.A-SERV. 4/9/2014 333,707R&R air filterR&R air tank drainR&R wiper bladesannual dot insp 4/12/2014R&R 4 drive tires rear axle, moved 4 rear tires to front axle 4/14/2014 337,401

B-SERV. 5/17/2014 346,432A-SERV. 5/24/2014 349,040R&R air filterR&R cab light

a/c in-op recovered 2# 2oz, recharged 3# 5/31/2014 350,444batteries dead R&R all 3 batteries 6/2/2014 350,444

replace left wiper blade 6/2/2014 350,768a/c in-op R&R t-stat switchneeds allignment, and steer tires 3 axle allignment (Neal Tire) 6/23/2014 356,934

repair left axle eye (axle surgeon)R&R left king pin and bushingsR&R steer tires

rough idlepulled 6 injectors, sent to Interstate to be tested. 4 failed Replaced 4 injectors, #1,3,4,5

jake hangs up rebuild jake brakes replaced master piston #2 jakeR&R a/c HP line, recover and recharge

fan hub leaking air R&R fan hub (new kaiser, Horton brand)air leak R&R cab air bag, left side 7/15/2014 359,592

B-SERV. 7/25/2014 361,762cleaned interiorchecked all steering components, OK 8/20/2014 361,788

brake pedal froze lube pedal 9/22/2014 363,312A-SERV. 9/26/2014 363,494tighten tail light barR&R rt front park lightR&R rt head light 10/7/2014 363,494replace 2 bulbs in lihgt under slprR&R bulb rt front t/sremove headache rack, move air lines. Put cat walk back onclean interiorwash and degrease eng 10/9/2014 363,516

heat will not shut offremoved seat, ck blend door. Ran truck and tested heat cntrl, working ok at this time 10/20/2014 365,421R&R map light left side (used M52) 10/21/2014 365,421repair shorted/broken wires in left door

straighten and secure loose wires arround enghas wrong air bag R&R air bag #3 axle rt side 11/7/2014 367,432

ck all fluids, top off ps res 11/10/2014 367,633replace missing power steer dip stick 11/12/2014 368,411

rattle under hood wrap center hood support with old strap 11/17/2014 368,411test coolant, add 8oz. Treatment

fuel leak left sideno fuel leak found, may have been something spilled in side box 11/19/2014 368,602R&R all 18 marker lights, changed to leddegreased eng, under cab and cleaned out side box

low oil press at idleck all piston cooling knosles, replace #1 piston cooling knosle 11/24/2014 368,794replace oil press sensorreplace p/s dip stick

need to recheck oil leaks, pan gasket leak R&R oil pan gasket 11/29/2014 369,208windshield cracked Replace windshield (American Eagle)

replace susp dump valve 12/10/2014 370,624B-SERV. 12/15/2014 370,821replace dip stick in power steer res

wheel seal leaking #3 axle rt side R&R wheel seal #3 axle rt side

brake shoes drum axle gasketadjust wiper arms up, 1/8/2015 373,965R&R wiper blades

p/s dip stick missing replace dip stick and clean liddead batteries, bateries are loose

jump start and test batteries. Put hold downs back in placeadjust clutch 1/26/2015 379,570R&R light on left door mirror 1/29/2015 380,388replace screws in pannels under doors

ran power wire from glove box to dash for CB

repaired ground for rt side lower marker lightstop off fluidsA-SERV. 1/31/2015 381,603 R&R air filteradjust clutch brake

air leakR&R broken air line between air tanks, 12' and 3 fittings 2/5/2015 383,311

bad oil leak, #1 and #2 cam boxes... and ??

reseal cam followers, oil cooler, acc drive gasket and seal, air comp, fuel pump, replaced turbo mounting gasket, ran overhead, adjusted valves and injectors, R&R a/c belt, replace antifreeze (Jones And Sons) 3/24/2015 384,113 Parts from Sternberg

park light out repair bad wire at bumper 3/30/2015 384,436annual dot insp 4/3/2015 385,369

B-SERV.adjust clutch

chirp noise, exh leak? R&R exhaust clamp at flex and mufflercrossmember under air tank is broken R&R crossmember

air tank hold down cable x 2R&R air bag #3 axle lft sideR&R brake chamber #3 axle rt side 12" brake hose

rt headlight is dim R&R head light rt sideR&R pigtail on left headlightR&R clamp at down pipe and flex pipe 4/7/2015 385,935

CAC leak at top rt corner R&R Charge Air Cooler (Rad Pro) 4/11/2015 386,923nail in tire #3 axle, left side, out side R&R tire (used steer) 4/14/2015 387,542

had original tire repaired and put back on (Georges) 4/24/2015 388,777

large chunk out of center tread, left steer tire

R&R tire #1 axle left side (good used tire, has more tread than original) 6/11/2015 394,474replace power steer dip stick

a/c in-op

recover 1.25# freon, recharge 3.3#, comp not kicking in. Troubleshoot…test switches, dash cntrl, ect…found and repaired bad connection at pony pak wireing behind glove box. Compressor kicks on as it should. found low press spiking out 350psi +, recovered freon to R&R expansion valve. AC working good lubed and got driver window working repair power wire to clearance lights 6/16/2015 394,669A-SERV. 6/21/2015 396,213remove axle vent, clean and replace hosetighten a/c belt

chirp noise….exhaust? May be leaking at exhaust manifold joints R&R exhaust manifold (Crossroads) 6/23/2015 396,213trans shifter is messed up, wont shift? R&R shift stick (used) reused original knob

straighten bumpercheck and adjust brakes 7/3/2015 397,763R&R exhaust stack pipe, rt side of cab 7/23/2015 399,625 4" seal clamp 4" u-bolt clamp

bad hood rattle tighten center hood support 8/20/2015 399,643mounted fire ext.

prop on left side box door is broke, cable is stiff

lube cables and latches on both side storage doors, replaced mount on door prop on left door

belt squeelstighten alternator and ac belt. Replace 2 missing bolts in ac mounttested CAC, OK

has a noise at high pull, boost leak ?? replaced 2 clamps on CAC boot

replace bulb in visor lightR&R oil return gasket on turboreplaced 6" x 1.75" hose on oil filler tube, titghten dip stick tubeR&R rear eng mount isolator bushings, both sides boltsn nuts and washersR&R front cab isolator bushngs, upper x 2 lower insulator x 2moved turbo pipe so that it will not hit cab, replace clamp at flex and turbo clamp lj clamp 4" lj clamp 5"

R&R isolator bushing on rad stabilizer bar x 2replace marker light under bunk

smokes on a big pull adjust overhead, valves and injectors 8/24/2015 399,650 jake brake gaskets x 3 rocker cover gaskets x 3R&R air filterR&R tail light barmount used headache rack mounting kit

overheated, rad hose leaking towed to TA (Malone's Wrecker Service) 9/14/2015replace bad hose (TA Baileyton,Tn)replaace gear in PD, (Virginia Truck Center) 9/30/2015 410,679A-SERV. (Petro Carlisle, Pa) 10/6/2015 411,242

front blower in-op R&R front blower mtr 10/16/2015 414,208 R&R cab air filterR&R all 3 battery (Lee Hi Freightliner, Lexington,Va) 11/3/2015

smoke, and valve noise in head…

troubleshoot, R&R #2 injector (reman from Interstate inj) 2/2/2016replace ps dip stickclean interior 2/3/2016 422,724B-SERV.R&R alternator (Leece Neville) and belts belt x 2

clean battery cables, replace 1 cableB-SERV. 3/21/2016 422,780tighten wheel bearing #1 axle lft sidereplace light on mirror left siderepair air leak at seat supply lineR&R brakes, seals, and drums #3 axle wheel seal x 2 drum x 2annual dot insp

mud flaps are gone replace flaps, hangers and reflective strips 3/29/2016 422,796 hanger x2 reflector x 2

a/c in-op

found and repaired leak at exp valve/line, replaced o-ring, recharged. found comp making allot of noise, replaced compressor, clutch pulley, and filter dryer 8/8/2016 422,911 compressor clutch pulley filter dryer

air not blowing out dash vents R&R blower wheel

replace blend door accuator (stepper motor)clean out side boxes 9/6/2016set road speed 65/70mphEnnis, lease to purchace begin, Will Wilson started driving 9/6/2016

stop eng light, low power

fault 111, troube shoot, ck connections etc...consult cummins, all cks come back to bad ECM (Adam and Dave 3hrs) 9/7/2016 424,750

stop eng lightR&R ECM (reman ECM, DSO Industrial) 500hp/1650torq 10/1/2016

eng fan runns constant, AC not kicking on

R&R high press switch, this tool care of fan issue. found and repaired bad connection behind fuse box 10/11/2016 424,751annual dot insp 3/1/2017 429,928

exhaust leak, hole in top of Y pipe covered hole with seal clamp

A-SERV. 3/1/2017 429,920 air filter dip stickR&R waterpump belt 4/7/2017 430,461

left front meadlight and marker light out replaced harness (used)

headlight marker lightreplace fog light, left side 5/9/2017 432,821

ac belt gone, comp locked upR&R AC compressor, recover and recharge as needed clutch pulley filter dryer ac beltremove headache rack, move air lines. air line and light chord assmbly

slow start, slow cranktest batteries and ck connections, test alt only puting out 12.3v. R&R alternator replace 2 drive tires (used) 7/7/2017 435,228B-SERV. 9/5/2017 437,700

coolant leakR&R Radiator (Jack's Truck & Trailer Gillette, Wy) 9/11/2017 439,613

driver seat lost air, troubleshoot and swap switch from pass seat(Ferguson Truck Center Houston,Tx.) 9/19/2017 442,806

batteries cought fire, road side

towed to shop. replace bateries, cables and some melted wires (Vernells Interstate Service Marion, Il) 9/23/2017

9/5/17, rt front hub was little low on grease

check battery hold downsfuel gauge jumps around

3/1/17, exhaust from turbo backe is in bad shape, will need reoplaced

500/1650 cpl#2592

lft str x/32 rt str x/32 part# cost: time:

15/32" 16/32"

$327.00 $116.24

16/32" 16/32"

13/32" 14/32"

$2,625.44 $750

$1,700

$325.00 $583.72

$2,302.86

$412.21

17/32" 17/32"

$350.32

0.5

0.75LFF3000 $14.39 0.25

used 1

0.5

TURBO 3804502RX $2,543.95 CAC 2005432c1

11

$136.49 30.51.5

$4.50 0.5

3134A $50.00 0.5K122E $360.00 4

1.5K5-190x $9.50 1

102910 $2 0.25$225.00

2587164c92 $139.55 0.750.5

$306.60 3515112c92 $220.49 3

0.50.5

$275.00 $300.00 10

$200.00 5cr35058 $28 skfbr3782 $19 skfbr3720 $9 skfhm212011 $15 skfhm212049 $26 2017594c3 $199.69 1

0.75

$225.00 1.5

14/32" 15/32" $140.00 3848-221 $123.11 1

0.75

0.5131400 1.25

31-22 $6.00 0.25$5.50 1

17405 $12.02 0.75

2504129c91 $232.25 1.535058 $30.25 0.5

0.75

65409 $205.72 1.50.75

17446 $11.29 0.5

0.5

14/32" 14/32" $150.00 2.521005R5 $4.36 0.2530/30 $38.34 1.25

0.25

0.51

4058941 $3 0.53965 $70 1.25

2503727c1 $13

$10 2.5JSK37FJST $734 3.25BSH150 $35 452187c2 $67 0.75

0.25

0.5

14/32" 14/32" $140 2.5$50 0.75

0.5

24702OMDB $45

35058 $28 skfbr3782 $20 skfhm212011 $16

skfhm212049 $27 skfbr3720 $10

1.517215-040 $51 1.251699956c1 $8 0.5

8

0.752032580c95 $30 1

1208925-82 $590 10797700c1 $30 FP6306RS2 $15

$45 3006737 $48 1

1S5-038 $33 1

$45 22

10/32" 12/32" $150 2.50.5

$17

$420 180920 $245 8

P-3076225 $15 3076226 $15 3800616 $32

3501266c1 $17 17405 $13

4060427 $19

1699953c1 $91 15256 $207 2

2509452c91 $631.36

3518703c93 $509.21

0.5$58 1

M100PHE $712 2

$35 1RY617 $813 2

4707 $176 3

$95 W01-358-9807 $420.55

17/32" 17/32" $150 2.50.75

fulk-3399 $14 0.5

$686 51.5

$219.44

16/32" 16/32" $150 20.50.5

$3 0.50.5

$275

315-7 $225 1

2.25

1699956c1 $10 0.251677433c1 $64 1P206607 $21 1

$10 0.51.250.75

3523689c1 $106 2.5x007785 $9

3965 $70 2.53157Y $6 12502583c1 $15 0.5L17446 $26 0.75

13/32" 15/32" $150 2.5

$275 BX107507X $470 4

200398 $65 3865312 $22 0.5

1681924c3 $33 0.25

1.5ge194 $4 40202R $4 0.25

0.5

13/32" 15/32" $150 2.5la1849 $36 0.5

0.54702Q $45.00 1AMO420SSC $724 1.5

$60 2x007785 $18

3020183 $52 4

8600310 $140 317446 $26

0.53606309c1 $133 31664729c7 $166

$15

0.753804303 $46 5

2275491 $12 1

3076496 $374 104058949 $18

3078307 $245 3020183 $52 3800616 $31

2036672c1 $25 17405 $13

H6054 $8 0.25

0.5033-04263 $20 0.75

47733 $19 1.5

$488.40

13/32" 15/32" $150 2.5

13/32" 14/32" $150 2.5

0.5

47692 $36 14707 $45

0.50.5

0.75

0.753518423c1 $206 0.75

4skfbr3720 $10 2skfhm212011 $18 skfhm212049 $28 br3782 $23

35058 $29 K-170X $8 1

0.54305294 $6 2

75 w90 synthetic $100 0.5

11

3518029c1 $261 0.5134a $5 1

20.75

1r12-538 $118 1

$1,347.42 101zL $857 1.5

0.5

17/32" 16/32" $150 2.59076 $4 0.25

0.517446 $13 0.5

1194 $4 0.5

1518512c4 $540 2

used 131-22 $6

1used 0.5

0.25

$80.24 0.75

1681924c3 $36 0.2540202r $5 0.25

0.250.25

2.5T-203 $37 1515212c1 $34 1

3025589 $63 $5 0.75

3069678 214210 $17 0.5

19420-1 $14

1mmbledfl $265 1.5

0.750.5

2035006c2 $24 0.75$20 0.5

sc30 $33 20.5

16/32" 16/32" $150 2.5laf1849 $38 0.251111-48 $7 0.2531-22 $6 0.25

0.5

TY-517 $1,600 2

0.7514/32" 16/32" $150 2.5

laf1849 $31 0.253529900c96 $25 0.25r134-a $15 2.531s-7 $258 0.7531-22 $3 0.252607881c1 $89 1

$225 $695

K122E $153 4101zL $840

3411767 $1,300 43871704 $291 24025352 $40

3505161c92 $144 19908501 $329 2

1s5-038 $33 1.50.5

1.250.50.5

17/32" 16/32" $175 2.50.5

3157na 0.25H6054 $8 0.25

1895 $1 0.253157na $2 0.25

1.50.5

1

1.50.5

0.75

0.51r12-538 $119 1

0.51681924c3 $36

0.5$4 0.25

0.5G4603 $119 2

1

4058947 $9 14921487 $179 1

1681924c3 $38 0.5

3804303 $44 6.5$275.00

280758 $15 10.75

1681924c3 $39

47692 $40 1.544707 $45

$75 3566160c1 $6

0.531-22 $10 0.251681924c3 $39 0.25

10.5

47733 $20 0.250.5

0.5

0.50.25

15/32" 16/32" $175 2.5LAF1849 $31

0.5

$15 1.3

inv#3830 $1,867.73 inv#907107 $228.76

0.5 Nick0.5 Dave

0.5 Dave0.5 Dave

5" clamp $10 0.5

used 1 Dave455538c1 $36 1R12-538 $118 0.7 Davezaj1431901 $74 1 Dave

6054 $9 0.5 Dave84-1006 $8 0.5 Davex007785 $11 1 Davezg-dc-018 $581 2.5 Dave

$150 0.5 Dave

$10 0.5 Ben

$100 0.5 Ben1681924c3 $39 Dave

6 Dave

2501794c93 $103 Dave1 Dave

0.7 Ben17/32" 17/32"

0.5 Adam0.3 Adam

181006 $547 2.5 Dave

Adam0.5 Adam0.8 Ben

1518512c4 $599 2 Benx007784 $10 j000230 $10

0.5 Adam0.5 Adam

506112c2 $40 1 Adam

1 Adam0.5 Adam

hts-406 $11 194 0.2 Adam

3202117 $3 0.8 Adam

0.7 Adam

1664729c7 $364 6 Adam$35

3515345c2 $146 1664730c7 $72

fltxc50vbs $15 1 Adamx007784 $10 x007785 $10

1675868c1 $34 0.5grote, 9196 $16 0.2 Adam

2 Dave4920093 $43 3066311 $58

LAF1849 $31 0.3 Adam50820 $162 0.5 Adam

2 AdamRR68200100 $62

$708.75 $422.43 TA

inv#306104 $1,491.26 336 148290 $297.04 1699949c1 $122 1 Josh1699956c1 $11

inv#1253070018 $355.58

3411767R $250 2 Dave1681924c3 $35

2 Josh0.7 Josh

110-555JHO $137.50 2 Josh9447HD $20

$10 0.5 Josh0.5 Adam

1 Adam47733 $20 1 Adam

0.5 Adam4707 $90 2.5 Adam

47691 $86 1601b $130

0.5 Adam2430pbs $10 1 Josh034-00426 $18 033-04259 $24

6 Adam5256 $201 5031 $86 7230 $20

fltbm1699947 $19

2503207c1 $56

6 Adam Dave

sale#7944 $1,195 5 Dave

3521729c1 $53 1.5 Dave0.5 Dave

J000216 $9 1 Dave15/32" 13/32" $175 2.5 Dave

LAF1849 $31 1681924c3 $38 K060425HD $29 1.5 Adam

1.5H6054 $9

31573815291c91 $29 0.5 Higgins

Z502459c91 $312 2.5501064578 $86

PTAC7230 $27 9405hd $18

217215-040 $51

110-555JHO $138 1$150 1 Dave

job#1 05-36 $2,583.40

inv#94016 $386.26

inv#118558 $1,334.11