maclaughlin management and design - burlington, vermont
TRANSCRIPT
RIN
K RE
FRIG
ERA
TIO
NPL
AN
MacL
au
gh
lin
M
an
ag
em
en
t
an
d D
esig
n
RIN
K RE
FRIG
ERA
TIO
NPI
PIN
G &
INST
RUM
ENTA
TIO
ND
IAGR
AM
MacL
au
gh
lin
M
an
ag
em
en
t
an
d D
esig
n
CLOSE COUPLED BASE MOUNT PUMP DETAIL
P-1 COLD FLOOR PUMP BELL & GOSSETT - E-1532 5EB CLOSE COUPLED - END SUCTION 1125 90 1800 40 460/3/60
TAG NO.
SERVICE
BASIS OF SELECTION TYPE
GPM
FT.
HEAD
RPM HP
V/PH/HZFLUID
P-2
P-4 220 37 1800 3 460/3/60
P-5 125 45 1800 3 22% CALCIUM CHLORIDE BRINE 460/3/60
COLD FLOOR BACKUP PUMP
WATER
CLOSE COUPLED - END SUCTION
CLOSE COUPLED - END SUCTION
CLOSE COUPLED - END SUCTION
MOTOR SHALL BE PREMIUM EFFICIENCY VFD COMPATIBLE
REMARKS
PROVIDE W/ SHAFT GROUNDING RING & FLEXIBLE PIPING CONNECTORS
MIN MAX
SYS. TEMP. (°F)
10
NO.
TAG
ET-1
LOCATION SERVICE
TANK
125
(PSI)
RATING
PRESSURE
502070
MIN MAX
120
(GAL.)
VOLUME
TANK
B&G - 116036
BASIS OF SELECTION
B&G - 116031
1125 90 1800 40 460/3/60
PCS-1 130.4 8°F 90°F 2AMMONIA
65ET-2
WARM FLOOR
1255020105 30
LOOP
REFRIGERATION RM.
COLD FLOOR
LOOP
P-3 CLOSE COUPLED - END SUCTION 220 37 1800 3 WATER 460/3/60CONDENSER SPRAY PUMP
BELL & GOSSETT - E-1532 5EB
BELL & GOSSETT - E-1532 2.5AC
BELL & GOSSETT - E-1532 2.5AC
BELL & GOSSETT - E-1532 2AD
MOTOR SHALL BE PREMIUM EFFICIENCY VFD COMPATIBLE
PROVIDE W/ FLEXIBLE PIPING CONNECTORS
REFRIGERATION RM.
1
PIPE SUPPORT AND HANGER DETAIL
94.9 100HP 94.5% 111.0 3550
OPEN DRIVE
SCREW
BITZER AMMONIA SCREW COMPRESSOR PACK
DIRECT COUPLED
REMARKS
BITZER ACP CONTROLER, NEMA 3R STARTER PANEL
PROVIDE W/ (1) REFRIGERANT ECONOMIZER, (1) THERMOIPHON OIL COOLER,
(2) SOFT STARTERS, (1) OIL SEPARATOR, OIL MANAGEMENT SYSTEM,
CONDENSER BACKUP SPRAY PUMP
WARM FLOOR PUMP
22% CALCIUM CHLORIDE BRINE
22% CALCIUM CHLORIDE BRINE
MOTOR SHALL BE PREMIUM EFFICIENCY VFD COMPATIBLE
PROVIDE W/ FLEXIBLE PIPING CONNECTORS
MOTOR SHALL BE PREMIUM EFFICIENCY VFD COMPATIBLE
PROVIDE W/ FLEXIBLE PIPING CONNECTORS
MOTOR SHALL BE PREMIUM EFFICIENCY VFD COMPATIBLE
PROVIDE W/ SHAFT GROUNDING RING & FLEXIBLE PIPING CONNECTORS
PROVIDE W/ TANK DRAINER FITTING, LEVEL GAUGE VALVES
REMARKS
& 5/8" CLEAR RIGID PLASTIC LEVEL GAUGE TUBING - ASME RATED
HX-1 200175°F 90°F AMMONIA
REMARKS
(1) HANSEN HT-100 FLOAT DRAINER
PROVIDE W/ (1) DUAL RELIEF MANIFOLD
(2) 300 PSIG RELIEF VALVES
22% C.C.
BRINE
12573°F70°F
BASIS OF SELECTION
TAG NO.
EF-1
SERVICE
TYPE
DRIVE
F A N D A T A
(Wg)
TSPCFM RPM HP
M O T O R D A T A
AMPSVOLTS PHASE
R E M A R K S
HZ
DELHI - MODEL 212E DUCT BLOWER 2800 0.5" 786 3/4 BELT 120 1 60 10.4
INTERLOCK W/ AMMONIA DETECTION SYSTEM
VENTILATION
EF-2 CENTRAL-AIRE - MODEL K12 SIDEWALL 450 0.375" 1550 1/20 DIRECT 120 1 60 1.4
EMERGENCY
REF. ROOM
PROVIDE W/ 16x16 B.D.D.
VENTILATION
OCCUPANCY
REF. ROOM
INTERLOCK W/ ROOM LIGHTS
PROVIDE W/ GRAVITY WALL SHUTTER
CH-1 1,5648.0°F
REMARKS
- INTEGRATED OIL ASSEMBLY
PROVIDE WITH THE FOLLOWING:
- REMOVABLE INSULATION PACKAGE FOR PLATE AND FRAME CHILLER
22% C.C.
BRINE
1,12514°F17.2°F8.0°F 8.0°F 3724 LB/H 0.405
AMMONIA
R-717
ALFA LAVAL
MK15-BWFD
- "U-Turn" LIQUID SEPARATOR
VESSEL MUST BE ASME RATED
ALFA LAVAL
AMC SERIES
PROVIDE W/ TANK DRAINER FITTING, LEVEL GAUGE VALVES
& 5/8" CLEAR RIGID PLASTIC LEVEL GAUGE TUBING - ASME RATED
W/ OPEN DRIVE OSKA COMPRESSORS
BASIS OF SELECTIONTAG NO.
AGLM-1
SERVICE
TYPE
ELECTRICAL DATA
VOLTS PHASE
R E M A R K S
HZ
BACHARACH - AGM-SZ INFRARED SENSING 120 1 60
INTERLOCK ALARM RELAY W/ EF-1 EMERGENCY EXHAUST FAN
DETECTION SYSTEM
AMMONIA LEAK
REFRIGERATION ROOM
PROVIDE W/ INLET TERMINATION FILTER, 100' OF SAMPLING TUBE
SENSITIVITY
25 PPM
PROVIDE AN ADD ALTERNATE #1 FOR VFDs IN LIEU OF SOFT STARTERS
RIN
K RE
FRIG
ERA
TIO
NSC
HED
ULE
S &
DET
AIL
SM
acL
au
gh
lin
M
an
ag
em
en
t
an
d D
esig
n