nutritional composition of a semi-fermented fish product
TRANSCRIPT
J. Home Econ. Jpn. Vol. 50 No. 7 703•`712 (1999)
Nutritional Composition of a Semi-Fermented Fish Product
(Chapa Shutki) in Bangladesh
Mosammat Nazmanara KHANUM, Hitoshi TAKAMURA* and Teruyoshi MATOBA
Graduate School of Human Culture, Nara Women's University, Nara 630-8506, Japan * Faculty of Human Life and Environment , Nara Women's University, Nara 630-8506, Japan
The nutritional characteristics of a semi-fermented fish product, commonly known as chapa shutki in Bangladesh, were studied. Its crude protein, crude fat, and crude ash contents were 33.2, 17.0 and 12.2 %, respectively. The calcium, phosphorus, magnesium and iron contents of chapa shutki were higher than those of similar kinds of Japanese processed fish. The amino acid score of the protein was found to be 100, based on the provisional amino acid scoring pattern (FAO/WHO 1990). The percentage of available lysine was 97.6. Chemical changes in the amino acid residues scarcely occurred during
processing. Palmitic, palmitoleic, stearic, oleic, linoleic, and linolenic acids were the major fatty acids of chapa shutki. Highly unsaturated fatty acids with 20 or more carbons were relatively low. No significant losses of unsaturated fatty acids were observed during the semi-fermentation process. An investigation of the extent of lipid oxidation showed that the carbonyl value and thiobarbituric acid-reactive substances value were 27 meq/kg of oil and 38 mg/kg of oil, respectively. The level of peroxidation was the very minimum. These feature indicite that chapa shutki can be considered a high-quality protein food.
(Received August 27, 1998; Accepted in revised form March 25, 1999)
Keywords: chapa shutki, fish, marine processed food, semi-fermented fish, fermentation, food
constituents.
INTRODUCTION
Indigenous fermented foods are native to a country
or culture. They are important for a number of reasons: a) these foods and food processes have survived and persisted over the centuries in the
developing countries, b) they are important for the nutrition of the poor people, and c) they generally involve low-cost methods for processing. For these
reasons, fermented foods are very important for a developing country like Bangladesh, where a large number of people suffer from various types of chronic
malnutrition, and where most babies are born underweight, since their mothers are chronically
malnourished (Islam 1998). Protein malnutrition is one of the most serious problems in Bangladesh. At
present, 59% of the households suffer from protein deficiency and millions of people consume a deplor-ably low amount of protein in their diets (Hossain 1991). The content of animal protein in the Bang-ladeshi diet is particularly low.
According to a report of the Bangladesh Bureau of
Statistics (1997), the average intake of animal protein is only 4.5 g per head per day, and about 80 % of this intake comes from fish. Although fish is abundant in
Bangladesh, the supply of fresh fish is not uniform throughout the country due to the lack of suitable transportation. Moreover, fisheries are highly season-
al due to climatic conditions. The total catch of fish in Bangladesh is very high during the rainy season. At that time, the fishermen whose principal means of
livelihood is the sale of fish cannot sell all of their catch, so a sizable quantity is wasted due to the lack
of preservation and distribution facilities. Thus, the total production of fish is not sufficient to meet the total national demand.
Under such circumstances, it is obviously neces-sary to look at processed fish foods to meet this demand. Processed foods, especially protein-rich
processed foods, are very rare in the Bangladeshi diet. At present, only a few home-processed fish are eaten as processed protein foods. Among them, chapa shutki is the most common and popular fish food
prepared by the natural fermentation of the small fish,* *To whom all correspondence should be addressed .
( 703 ) 39
J. Home Econ. Jpn, Vol. 50 No. 7 (1999)
A
B
Indian minor carp (Fig. 1). It is basically prepared by following a similar procedure to that employed for the
preparation of fish paste and sauce in other Southeast Asian countries (Ahmed 1979; Mansur et al. 1989); for example, "Bagoong" in Philippines, "Prahose" in
Cambodia, and "Pla-ra," "Pla-som," "Som-fuq," etc., in Thailand. These products are prepared under anaerobic conditions by traditional fermentation methods. Although there are differences in the detail
of preparation, the underlying principle is the same everywhere (Ahmed 1979; Mansur et al. 1989). Ex-
perimental results have indicated fish visceral en-zymes to be mainly responsible for the fermentation of these products (Uyenco and Lawas 1952; Vanveen 1965). In a few cases, however, the involvement of
bacterial activity has also been reported (Amano 1962). Although an enzymatic or bacteriological study
on the fermentation process for chapa shutki has
yet to be reported, it is assumed that both fish muscle
enzymes and bacterial enzymes are involved in the fermentation process. Traditional methods for produ-
cing fish paste and sauce involve 6-12 months of fermentation (Shimoda et al. 1996); however, in case
of chapa shutki, the fish are allowed to ferment for only 3-4 months. As a result, the final product is obtained as semi-solid in appearance and is therefore
termed a semi-fermented product (Mansur et al. 1989). Bhuiyan et al. (1989) have reported a new
semi-fermented powdered product from underutilized marine fish, and Mansur et al. (1989) described another type of ready-to-use powdered chapa shutki
from Puntius sp. Both products were prepared in the laboratory by using almost the same method as that
for chapa shutki involving an oven-drying process to make the powder. These products were found to be rich in protein and to have good acceptability by a
consumer test panel. However, such powdered
products are not commercially available. At present, people consume whole chapa shutki that is locally prepared from Indian minor carp by the fishermen. Chapa shutki forms an important part of the diet of many people in Bangladesh. This product is very
popular among Bangladeshis, because of its charac-teristic taste and flavor. However, information about
its nutritional and other health benefits is scant, except for a report by Ahmed (1979). Chapa shutki is
prepared by the traditional method of fermentation and it does not cost much nor require any technical knowledge. This product serves as a cheap source of
protein in Bangladesh. Scientific information regard-ing its nutritional value and protein quality is
necessary to make this food more popular among the
people, so that it can contribute much in improving the protein deficiency of the country.
This investigation has, therefore, been undertaken
primarily to clarify the nutritional quality and the acceptability of chapa shutki. We determined the
proximate composition, mineral content, amino acid and fatty acid spectra, and oil quality of commercially available chapa shutki. The commercial product was
prepared by a 90-day fermentation. A comparative investigation was also done in this study with samples fermented for 15, 30 and 60 days to observe the
biochemical changes occurring during the prepara-tion.
MATERIALS AND METHODS
Raw fish
Raw Indian minor carp (Burbus puntio) were
purchased fresh from a local market in Bangladesh
Fig. 1. Photographs of raw Indian minor carp (A) and chapa shutki (B)
40 ( 704 )
Nutritional Composition of a Semi-Fermented Fish Product (Chapa Shutki) in Bangladesh
and brought to Japan by air transport under properly
iced conditions. The specimens were stored at-30•Ž
until the investigation started, the time between the
purchase and-30•Ž storage being approximately 3
days.
Chapa shutki
Chapa shutki was prepared from raw fish by
following a traditional semi-fermentation method
commonly used in Bangladesh. Figure 2 shows a flow
chart for the preparation of chapa shutki. Raw fish was
purchased from a local market and gutted as quickly
as possible without any pre-washing. Fish oil was
separated from sunlight for 7 days. Meanwhile, four
sets of clay vats were soaked with previously collected
fish oil in such a way that no absorption of oil from
the fish body would occur during subsequent
ripening. After drying, the fish were sprayed with a
small amount of water and kept overnight. The
following day, they were divided into four batches and
poured into the vats ready for fermentation. The
mouth of each vat was then covered with a banana
leaf and plastered by a heavy layer of clay in order to
create anaerobic conditions inside the vat. The sealed
vats were then placed underground for periods of 15,
30, 60, and 90 days for fermentation. The product
prepared by 90-day fermentation is known as chapa
shutki. The fermented products were prepared in
Bangladesh and brought to Japan by air transport for
the investigation.
Sample preparation
Raw fish were gutted and scaled before the sample
was prepared for analysis. The semi-fermented fish
were scaled and cleaned properly. Then, both were
separately minced and finely homogenized with a
mortar and pestle. The resulting fish flesh was used
as samples for the subsequent analyses.
Proximate composition
The moisture, crude fat and ash contents of the raw
and semi-fermented fish samples were determined
according to the standard method of the Association
of Official Analytical Chemists (1970). The nitrogen
content was estimated by the micro-Kjeldhal method,
and the percentage of crude protein was calculated
by multiplying total nitrogen by a factor of 625.
Mineral content
To determine the mineral content, accurately
weighed samples (5 g) were taken in a porcelain
crucible, and ashed by heating with a gas burner and
then re-ashed in a muffle furnace for 16 h at 550•Ž.
The resulting ash was dissolved in 10 ml of 30%
HNO3 and diluted 200-fold with ultra-pure water. The
solution was then subjected to an ICP analysis with an
ICP-575 II instrument (Nippon Jarrell-Ash) according
to the method of Haraguchi et al. (1988).
Amino acid analysis
The fats were extracted from the sample by using a
chloroform/methanol mixture (2 : 1, v/v). The resul-
ting de-fatted sample was ground with a mortar and
pestle in the presence of acetone, and this de-fatted
fish powder was used as a sample for the amino acid
analysis. The sample was hydrolyzed with re-distilled 6
N HCl at 110•Ž for 24 h in an evacuated Pyrex tube. y -
Amino butyric acid was used as the internal standard.
To determine the sulfur amino acids, performic acid
oxidation and subsequent acid hydrolysis was carried
out according to Moore (1963). Alkaline hydrolysis
with 3.75 N NaOH for 16 h at 110•Ž was followed by an
amino acid analysis to determine tryptophan and
methionine sulfoxide according to the method of
Neumann (1967). Available lysine was determined
according to the procedure of Matoba et al. (1984),
which is a modification of the method Roach et al.
(1967). The quantitative amino acid determination
was carried out with an amino acid analyzer (Hitachi
L-8500), the contents of the different amino acids
recovered being expressed as g per 100 g of protein
Collection of fish
Gutting the fish and separating the oil from the gut
Drying the fish for at least 7 days
Sprinkling water on the dry fish and keeping overnight
Soaking clay vats with fish oil up to full saturation
Placing dry fish in the oil-soaked vats
Sealing the vats with banana leaves and a heavy layer of clay
Placing the vats underground for a period of 3 months for
fermentation
Fig. 2. Flow chart for the preparation of chapa shutki
( 705 ) 41
J. Home Econ. Jpn. Vol. 50 No. 7 (1999)
and compared with the FAO/WHO (1990) reference
pattern.
Fatty acid composition
Total lipids were extracted from the fish flesh by
following the method of Folch et al. (1966), using a
chloroform/methanol mixture (2:1, v/v). The extra-
cted lipids were subjected to methylation according to
the method of Christie (1973), and the converted
sample was analyzed with a Shimadzu GC-14 gas
chromatograph, using a flame ionization detector and
an HR-SS-10 capillary column (0.25 mm •~25 m). The
column temperature gradient was 3•Ž /min from 150-
220t. Peaks were identified by comparing with
authentic standards, and quantitative fatty acid data
were calculated directly as the percentage area.
Oil quality
Peroxide value (POV), carbonyl value (COV) and
thiobarbituric acid reactive substances (TBARS) were
determined as indices of the oil quality. POV was
determined iodometrically according to the standard
method of the Japan Oil Chemists' Society (1986)
(2.4.12-86) and spectrophotometrically by the method
of Asakawa and Matsushita (1980). COV was de-
termined according to the standard method of the
Japan Oil Chemists' Society (1986) (2.4.22-73), the
value being expressed as meq/kg of oil. TBARS was
determined according to the method of Ito et al.
(1988). Two milliliters of TBA reagent and 0.1 ml of
SDS (5 mg/ml in H2O) were added to 0.1-0.3 g of fish
oil and mixed well, an ethanol solution (0.1 ml) of
BHT (0.22 %) being added to the mixture to prevent
oxidation during the TBA reaction. The mixture was
then heated in boiling water for 15 min. After cooling,
acetic acid (1 ml) and chloroform (2 ml) were added
and the mixture shaken thoroughly. The absorbance
of the upper layer was recorded at 535 nm after
centrifugation. TBARS is expressed as mg of ma-
londialdehyde per kg of oil.
RESULTS AND DISCUSSION
The raw fish used in this experiment were Indian minor carp, commonly called puti in Bangladesh (Fig.
1-A). There are various types of minor carp of different sizes (2-10 cm), the smaller fish (2-6 cm) usually being used to prepare chapa shutki (Fig. 1-B). This fish is somewhat similar in appearance to the
Japanese freshwater fish, Crucian carp (funa). We, therefore, compared our results for raw fish with the
published values in the Standard Table of Food Composition in Japan (Resource Council of Science and Technology Agency 1982, 1989, 1991) for raw
Crucian carp (the edible part), and three other commonly consumed Japanese raw fish, horse mackerel (aji, the edible part), Japanese pilchard
(maiwashi, the edible part), and pond smelt (wakasagi, the whole fish). The results for commercially available chapa shutki were compared with those of the
published values for two semi-dried Japanese prod-ucts, mildly salted, semi-dried whole Japanese pil-chard (iwashi no nama boshi) and salted, semi-dried
split horse mackerel (aji no hiraki boshi). Proximate composition
To evaluate the nutritional quality of chapa shutki,
the proximate compositions of the raw fish and of the semi-fermented fish were determined. Table 1 shows the proximate composition of raw Indian minor carp
and its commercially available semi-fermented prod-uct, chapa shutki. Compared with Japanese fish
(Standard Table of Food Composition in Japan), the protein content of raw Indian minor carp (18.3 g) was almost the same as that of both horse mackerel (18.7
g) and Crucian carp (18.2 g), slightly lower than that of Japanese pilchard (19.2 g), and slightly higher than that of pond smelt (17.1 g) on a wet-weight basis. Its crude fat content was 1.4 and 1.2 times higher than
that of Crucian carp and pond smelt, respectively, but was 1.9 and 3.8 times lower than that of horse
Table 1. Proximate composition of raw Indian minor
carp and chapa shutki
Data are expressed as means + SD (n=3). Values in
parentheses are percentages to dry weight.
42 ( 706 )
Nutritional Composition of a Semi-Fermented Fish Product (Chapa Shutki) in Bangladesh
mackerel and Japanese pilchard, respectively. The ash content of raw Indian minor carp was almost the same
as that of pond smelt and approximately twice that of the three other Japanese fishes. Compared with mildly salted, semi-dried Japanese pilchard and with salted,
semi-dried split horse mackerel, chapa shutki con- tained 1.5 and 1.6 times more protein, respectively,
per 100 g of the edible part. The fat and ash contents (17.0 and 12.2 g, respectively) were also higher in chapa shutki than the amounts in salted, semi-dried horse mackerel (6.8 g) and mildly salted, semi-dried
Japanese pilchard (15.6 g) per 100 g of the edible
portion. Compared to the Japanese raw fishes, Indian minor carp contained a comparable amount of
protein, a higher amount of ash, and a lower amount of fat. Chapa shutki prepared from raw Indian minor
carp also showed comparatively higher amounts of
protein, fat, and ash on a wet-weight basis than those of the Japanese raw and processed products. Mineral composition
Table 2 shows the mineral contents of raw Indian minor carp and of commercially available chapa shutki. Sodium, potassium, calcium, phosphorus and magne-
sium were the predominant mineral elements in both these samples. The mineral composition of raw Indian
minor carp was then compared with that of horse mackerel, Japanese pilchard and Crucian carp
(Standard Table of Food Composition in Japan). The calcium content of raw Indian minor carp (302 mg) was considerably higher than that of horse mackerel
(65 mg), Japanese pilchard (70 mg) and Crucian carp (100 mg), but was less than that of pond smelt (750 mg). The phosphorus content (130 mg) was much lower than that of pond smelt (680 mg) and slightly
lower than that of the other three Japanese fishes
(160-190 mg). Raw Indian minor carp contained 8.8 and 21 times less sodium and 3.9 and 4.4 times less
potassium than those of horse mackerel and Japanese
pilchard, respectively. The iron content of minor carp was comparable with that of Japanese pilchard and Crucian carp, but the amount was about 30 % of that
of pond smelt (5.0 mg). The other minerals were either comparable or higher in content than those of
the Japanese fishes. As shown in Table 2, chapa shutki contained
approximately 2.0 and 3.4 times more calcium and
phosphorus, respectively, than those in the raw fish. The sodium, potassium, magnesium and iron contents
of chapa shutki were also considerably higher those in the raw fish. Chapa shutki was found to contain larger amounts of zinc and copper than those in raw fish.
In comparison with mildly salted, semi-dried Japa-
nese pilchard, and salted, semi-dried split horse
mackerel, chapa shutki showed higher values for all the minerals determined, except for sodium and potas-sium. Although chapa shutki contained a higher
amount of sodium than the two freshwater raw fishes
(Indian minor carp, 17 mg; Crucian carp, 30 mg), the amount was 1.5 times less than that in raw Japanese
pilchard, a salt-water fish (360 mg). In addition, the sodium content of chapa shutki (247 mg) was far below that of mildly salted, semi-dried Japanese pilchard
(750 mg) and salted, semi-dried split horse mackerel (1,200 mg) per 100 g of fish. Among the other minerals, the greatest variation appeared in the
amount of calcium, which was 7.8 times higher in chapa shutki than in Japanese processed fishes. The
potassium content of chapa shutki was about half that in these two semi-dried Japanese products. Protein quality 1. Amino acid composition
The results of the amino acid analysis of raw Indian minor carp and its semi-fermented products at various stages are shown in Table 3. Raw minor carp
contained higher levels of aspartic acid, threonine, serine, glutamic acid, glycine, alanine, valine, and leucine per 100 g of crude protein than horse
mackerel, Japanese pilchard, Crucian carp, and pond smelt. In addition, cysteine and methionine in raw minor carp were comparable with those in the four
Japanese raw fishes. The results in Table 3 indicate that the amino acid
contents of raw puti fish and chapa shutki were not
significantly different and that there was hardly any change in the amino acid composition before and after fermentation. The results also suggest that any
Table 2. Mineral content of raw Indian
minor carp and chapa shutki
Data are expressed as means +SD (n=3).
( 707 ) 43
J. Home Econ. Jpn. Vol. 50 No. 7 (1999)
chemical changes in the amino acid residues were very rare during processing. Decreases in the availability of lysine and sulfur-containing amino acids
during processing have been reported (Miller et al. 1965; Matoba et al. 1984). The amount of lysine and
its availability are meaningful criteria for evaluating the protein nutritional quality of a food, because its availability is lost with the modification of the E-amino
group of the lysine residue. Available lysine in the proteins of raw minor carp and chapa shutki was 98.9 and 97.6%, respectively. Particular attention has also
been paid to the sulfur amino acids, because their levels in fish protein are not particularly high (Miller 1956; Chalupa and Fisher 1963). The result of the
present investigation reveals that available lysine in the protein of chapa shutki was comparable with that in the raw fish. Damage to the sulfur-containing amino
acids also insignificant, because a very low amount of methionine sulfoxide was found in the fermented and
non-fermented samples (Table 3). 2. Amino acid score
The essential amino acid composition of the
proteins in raw Indian minor carp and in commercial-ly available chapa shutki are presented in Table 3,
together with the FAO/WHO (1990) recommended
pattern. Of the 10 essential amino acids, the contents of 6 (threonine, methionine, valine, leucine, isoleucine
and phenylalanine) were relatively higher in minor carp and chapa shutki than in the Japanese fishes. The amounts of all the essential amino acids in the raw
fish and chapa shutki were also higher than the recommended pattern. Proteins in both the raw fish and commercial chapa shutki have amino acid scores
of 100, are Crucian carp, and are comparable with egg, meat and milk in protein nutritional quality. Oil quality
1. Fatty acid composition Table 4 shows the fatty acid compositions of the
Table 3. Amino acid composition of raw Indian minor carp, semi-processed fish,
and chapa shutki
Data are expressed as means •}SD (n=3). * FAO/WHO reference pattern 1990.
* * Methionine sulfoxide.
44 ( 708 )
Nutritional Composition of a Semi-Fermented Fish Product (Chapa Shutki) in Bangladesh
raw and semi-fermented products at various stages.
The relative percentages of eighteen fatty acids were identified in the total fatty acids, and traces of some unidentified fatty acids were also found. In raw minor
carp, the major fatty acids were palmitic (16 : 0),
palmitoleic (16: 1), stearic (18 : 0), oleic (18: 1), linoleic (18 : 2), and linolenic (18 : 3) acids. Compared
to those in Japanese fishes, the percentages of both the 18 : 2 and 18 : 3 fatty acids in minor carp were 13.4
times higher than those in horse mackerel and 6.7 and 4.7 times higher than those in .Japanese pilchard respectively (Standard Table of Food Composition in Japan). The percentage of icosapentaenoic acid (20 :
5) in Indian minor carp (0.6%) was much lower than that in horse mackerel (7.9%), Japanese pilchard
(13.0%), Crucian carp (6.5%) and pond smelt (11.3%).
The percentage of docosahexaenoic acid (22 : 6) was also lower in the raw fish (0.7%), in contrast with
horse mackerel (14.5%), Japanese pilchard (10.7%), Crucian carp (7.2%), and pond smelt (21.0%). As
shown in Table 4, the major fatty acids 16 : 0, 16 : 1, 18 : 0, 18 : 1, 18 : 2 and 18 : 3 in raw minor carp were also commonly found in commercial chapa shutki and in the semi-fermented product at different stages.
Each sample contained higher levels of 16 : 0 and 18 : 1 fatty acids. Highly unsaturated fatty acids with more than 20 carbons were considerably lower in both the
fermented and non-fermented samples. The fatty acid composition reveals that raw Indian
minor carp and its semi-fermented product of
different stages, including commercial chapa shutki, almost resembled each other. Although the raw fish
Table 4. Fatty acid composition, COV, and TBARS of raw Indian minor carp,
semi-processed fish, and chapa shutki
Data are expressed as means •}SD (n=3). * ND, not determined, **MDA, malondialdehyde.
( 709 ) 45
J. Home Econ. Jpn. Vol. 50 No. 7 (1999)
and chapa shutki showed characteristic features of
freshwater fish in their fatty acid composition (Table 4), the pattern was somewhat different from that of
the Japanese freshwater fishes. Compared to the Japanese freshwater fishes, the percentages of total unsaturated fatty acids in the total fatty acids were
relatively lower in both the raw minor carp and its semi-fermented products. Moreover, Indian minor
carp and its semi-fermented product both showed higher levels of 18 : 2 and 18 : 3 fatty acids and lower levels of 20 : 5 and 22 : 6 fatty acids than those in
Japanese freshwater fishes. These results might indicate an environmental variation in their habitats,
because the fatty acid composition of fish lipids is influenced by the geographical location, season of catch, temperature, maturity, and diet, etc. (Toyomizu
et al. 1975). Little loss of unsaturated fatty acid in the semi-fermented products was apparent, which sug-
gests a lower level of oxidation in the fermented products. 2. POV, COV and TBARS
The peroxide values (POV) of the oils of the raw
fish and chapa shutki were found to be 0 by both iodometric and spectrophotometric methods. COV and TBARS values for the raw fish and commercial
chapa shutki are presented in Table 4. In the present study, we were unable to successful-
ly determine POV, which may have been due to an
insufficient amount of oil being used for the determination. Furthermore, the presence of phos-
pholipids in the oil sample, which formed an emulsion when shaken, also hindered end point observation
(Lezerovich 1985). We were also unsuccessful in determining POV by the spectrophotometric method. The presence of phospholipids in the sample gave erroneous results in peroxide value when determined
by the highly sensitive spectrophotometric method
(Asakawa 1998, personal communication). However, the COV and TBARS values for raw Indian minor carp
and chapa shutki were not high enough to show any extensive oxidation of the semi-fermented products.
In general, hydroperoxides formed by lipid oxida-tion react with amino acid residues to reduce their
nutritional availability (Gardner 1979; Matoba et al. 1982). Damage to methionine occurs most extensive- ly, followed by tryptophan, histidine and lysine
(Motaba et al. 1984). In particular, methionine is oxidized mainly to methionine sulfoxide (Tannen-baum et al. 1969; Matoba et al. 1984). Cuq et al.
(1973) have reported that the formation of methion- ine sulfoxide in an intact protein leads directly to the
loss of methionine availability. However, in the
present study, no significant increase in methionine sulfoxide was apparent in the semi-fermented prod-
ucts during processing (Table 3). This suggests that the level of oxidation during fermentation was not
extensive. It should be noted that raw fish collected by fishermen in Bangladesh are usually left without
preservation. The time that elapsed between collect-ing the raw fish and preparing the semi-fermented
product is considered to be the reason for the slightly higher oxidative damage in the semi-fermented
products since the raw fish had already been oxidized
(Table 4). From the preceding discussion, it appears that raw
Indian minor carp and its commercial semi-fermented
product, chapa shutki are both rich in protein and ash content. The mineral composition reveals them to be
good sources of calcium, phosphorus and most of the trace minerals. There was no significant loss of chemical constituents resulting from fermentation. Both the raw fish and semi-fermented chapa shutki were found to contain sufficient amounts of essential
amino acids and in proper balance to serve as a high-quality food. Moreover, the fatty acid profile,
COV and TBARS values reveal the products to be acceptable in quality in terms of their low degree of lipid peroxidation. Therefore, chapa shutki can be
considered a high-quality protein source to improve the nutritional value of the cereal-based Bangladeshi diet.
REFERENCES
Ahmed, S. (1979) Biochemical Evaluation of the Effects of Semi Drying on the Composition and Quality of Puti
(Burbus puntio), M. Sc. Thesis, Bangladesh Agricultural University, Mymensingh, Bangladesh, 1-52
Amano, K. (1962) The Influence of Fermentation on the Nutritive Value of Fish with Special Reference to Fermented Fish Products of South East Asia, in Fish in Nutrition (ed. by Heen, E., and Kreuzer, R.), Fishing News (Books) Ltd., London, 180-197
Asakawa, T., and Matsushita, S. (1980) A Colorimetric Micro Determination of Peroxide Values Utilizing Aluminum Chloride as the Catalyst, Lipids, 15, 965-967
Association of Official Analytical Chemists (ed.) (1970) Official Methods of Analysis, 11th ed., Association of Official Analytical Chemists, Washington, D.C.
Bangladesh Bureau of Statistics (ed.) (1997) Statistical Year Book of Bangladesh, Dhaka, Bangladesh
Bhuiyan, A. K. M. A., Gheyasuddin, S., and Mansur, M. A.
(1989) Guro Sheedal Shutki-A New Semi-Fermented Product from Underutilized Marine Fishes, Bangladesh J.
46 ( 710 )
Nutritional Composition of a Semi-Fermented Fish Product (Chapa Shutki) in Bangladesh
Fish, 12, 21-26 Chalupa, W., and Fisher, H. (1963) Comparative Protein
Evaluation Studies by Carcass Retention and Nitrogen Balance Methods, J. Nutr., 81, 139-146
Christie, W. W. (1973) Lipid Analysis, Pergamon Press, Oxford, 89-90
Cuq, J. L., Provansal, M., Guilliux, F., and Cheftel, C. (1973) Oxidation of Methionine Residues of Casein by Hydro-
gen Peroxides. Effects on In Vitro Digestibility, J. Food Sci., 38, 11-13
FAO/WHO (1990) Protein Quality Evaluation, in Report of a Joint FAO/WHO Expert Consultation, Food and Agriculture Organization of the United Nations, Rome, 23
Folch, J., Lees, M., and Stanley, G. H. S. (1966) A Simple Method for Isolation and Purification of Total Lipids from Animal Tissues, J. Biol. Chem., 222, 583-593
Gardner, H. W. (1979) Lipid Hydroperoxide Reactively with Protein and Amino Acids: A Review, J. Agric. Food Chem., 27, 220-229
Haraguchi, H., Kubota, M., Morita, M., Miyazaki, A., Fuwa, K., and Furuta, N. (1988) ICP-Atomic Emission Spect-rometry (in Japanese), Japan Society of Analytical Chemists' Sankyo Press, Tokyo, 180-237
Hossain, M. (1991) Future of Khesari Cultivation in Bangladesh, in Proceedings of the Second National Workshop on Pulses, 6-8 Jan 1989, Joydebpur, Ban-
gladesh, 183-187 Islam, T. (1998) Health—Bangladesh: Valuable Lessons in
Tackling Malnutrition, Inter Press Service, Bogra, Ban-
gladesh Ito, H., Ishinaga, M., Otsuru, M., Kugimiya, M., Sakane, Y.,
and Sonda, T. (1988) Experimental Food Science (in Japanese), Asakura Shoten, Tokyo, 111-112
Japan Oil Chemists' Society (1986) Standard Methods for the Analysis of Oils, Fats and Derivatives, 2.4.12-86,2.4.22- 73
Lezerovich, A. (1985) Determination of Peroxide Value by Conventional Difference and Difference Derivative Spectrophotometry, J. Am. Oil Chem. Soc., 62, 1495-1500
Mansur, M. A., Gheyasuddin, S., and Aminullah, A. K. M.
(1989) Preparation of a New Ready-to-Use Dried Semi-Fermented Fish Product of Increased Shelf Life from Puntius sp., Bangladesh J. Fish, 12, 27-32
Matoba, T., Yoshida, H., and Yonezawa, D. (1982) Chemical Changes in Casein and Egg Albumin Due to Reactions
with Oxidizing Methyl Linoleate in Dehydrated Systems, Agric. Biol. Chem., 46, 979-986
Matoba, T., Yonezawa, D., Nair, B. M., and Kito, M. (1984) Damage of Amino Acid Residues of Proteins after Reaction with Oxidizing Lipids: Estimation by Proteolytic Enzymes, J. Food Sci., 49, 1082-1084
Miller, D. S. (1956) The Nutritive Value of Fish Proteins, J. Sci. Food Agric., 7, 337-343
Miller, E. L., Carpenter, K. J., and Milner, C. K. (1965) Availability of Sulphur Amino Acids in Protein Foods, H. Assessment of Available Methionine by Chick and Microbiological Assay, Br. J. Nutr., 19, 249-267
Moore, S. (1963) On the Determination of Cystine as Cysteic Acid, J. Biol. Chem., 238, 235-237
Neumann, N. P. (1967) Analysis for Methionine Sulfoxide, Methods Enzymol., 11, 487-490
Resource Council of Science and Technology Agency (ed.)
(1982) Standard Table of Food Composition in Japan, 4th revised ed., Ministry of Finance Printing Bureau, Tokyo
Resource Council of Science and Technology Agency (ed.)
(1989) Standard Table of Food Composition in Japan, Follow-Up H, Ministry of Finance Printing Bureau, Tokyo
Resource Council of Science and Technology Agency (ed.)
(1991) Standard Table of Food Composition in Japan, Follow-Up N, Ministry of Finance Printing Bureau, Tokyo
Roach, A. G., Sanderson, P., and William, D. R. (1967) Comparison of Methods for the Determination of Available Lysine Value in Animal and Vegetable Protein Sources, J. Sci. Food Agric., 18, 274-279
Shimoda, M., Peralta, R. R., and Osajima, Y. (1996) Headspace Gas Analysis of Fish Sauce, J. Agric. Food Chem., 44, 3601-3605
Tannenbaum, S. R., Barth, H., and Le roux, J. P. (1969) Loss of Methionine in Casein during Storage with Autoxidiz-ing Methyl Linoleate, J. Food Sci., 17, 1353-1354
Toyomizu, M., Nakamura, T., and Shono, T. (1975) Fatty Acid Composition of Lipid from Horse Mackerel Muscle-Discussion of Fatty Acid Composition of Fish Lipid,
Bull, Japan. Soc. Sci. Fish., 42, 101-108 Uyenco, V., and Lawas, I. (1952) Mechanics of Bagoong
and Patis Processing, Philippines J. Fish., 2, 85-91 Vanveen, A.G. (1965) Fermented and Dried Seafood
Products in South East Asia, in Fish as Food, Vol. III (ed. by Borgstrom, G.), Academic Press, New York, 227-247
( 711 ) 47
J. Home Econ. Jpn. Vol. 50 No. 7 (1999)
バングラデシュの半発酵魚製品(チ ャパ ・シュ トキ)の 栄養成分組成
モサマットナズマナラ カノム,高 村仁知*,的 場輝佳
(奈良女子大学大学院人間文化研究科,*奈 良女子大学生活環境学部)
原稿受付平成10年8月27日;原 稿受理平成11年3月25日
バ ング ラデ シュの半 発酵 魚 製品 チ ャパ ・シ ュ トキ の栄養 特性 につ い て研 究 を行 っ た.粗 タン
パ ク質,粗 脂 肪,お よび粗 灰 分 含量 はそ れ ぞれ33.2,17.0,12.2%で あ った.カ ル シ ウム,
リン,マ グネ シウム,お よび鉄 含量 は相 当す る 日本 の魚加 工 品 よ りも高 か った.暫 定 ア ミノ酸
ス コ アパ ター ン(FAO/WHO1990)に 基 づ くア ミノ酸 ス コ アは100で あ った.ま た,有 効 性
リジ ンは97.6%で あ っ た.加 工 中 の ア ミ ノ酸 残基 の化 学変 化 は ほ とん ど起 こ らなか った.パ
ル ミチ ン酸,パ ル ミ トレイ ン酸,ス テ ア リ ン酸,オ レイ ン酸,リ ノー ル酸,お よび リノ レ ン酸
が主 要脂 肪酸 であ っ た.炭 素数20以 上 の 高度 不飽 和 脂肪 酸 は比 較 的少 なか った.半 発 酵 中の
不 飽和 脂肪 酸 の有 意 な減少 は見 られ なかっ た.脂 質酸化 につ いて調べ た ところ,カ ル ボニ ル価
とチ オバ ル ビツール酸 反応 性物 質値 は27meq/kg油 脂 お よび38mg/kg油 脂 と低 か った.こ の
ように,脂 質 酸化 の おそ れ は少 な く,チ ャパ ・シュ トキ は良質 な タ ンパ ク性食 品 と考 え られる.
キ ーワー ド:チ ャパ ・シュ トキ,魚 介,水 産加工 品,半 発 酵魚,発 酵,食 品成分.
48 ( 712 )