on-site hydrogen production from high-pressure liquids nha hydrogen conference and expo ben oster...
TRANSCRIPT
![Page 1: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/1.jpg)
On-Site Hydrogen Production From High-Pressure Liquids
NHA Hydrogen Conference and Expo
Ben Oster
May 5, 2010
![Page 2: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/2.jpg)
Outline
• Introduction
• Objectives
• Hydrogen Production Flow Diagram and Results
• Future Work
• Conclusions
![Page 3: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/3.jpg)
Introduction
• High pressure reactor system– Distributed hydrogen production– Converts liquid reactants directly to high pressure
hydrogen• Pump liquid reactants into reactor operating at 6000 to
12,000psi• Purify hydrogen at system pressure (6000 to 12,000 psi)
NOT REQUIR
ED
REDUCED
![Page 4: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/4.jpg)
Compression Energy SavingsPercent of Hydrogen LHV
Storage →
Source ↓ 3626
psia
5076
psia
7252
psia
10,153
psia
15 psia 13.2% 14.3% 15.5% 16.7%
102 psia 7.8% 8.8% 9.8% 10.9%
290 psia 5.6% 6.5% 7.4% 8.4%
1958 psia 1.7% 2.5% 3.3% 4.2%
Source: Air Products and Chemicals, Inc.
![Page 5: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/5.jpg)
Mass of Hydrogen Per DeliveryBasis: 7500 gal Transport Tank
01000200030004000500060007000
highpressurehydrogen(3200psi)
liquidhydrogen
methanol glycerol ethanol
Hy
dro
ge
n (
kg
)
![Page 6: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/6.jpg)
Hydrogen Pipeline Challenges
• Least expensive way to transport large amounts of hydrogen [1]
• Existing hydrogen pipeline is 0.33% of natural gas pipeline in length with only 200 delivery points [2]
• $1.2 million/mile (transmission) and $0.3 million/mile (distribution) [3]
• Advancements could decrease costs >50% [4]
• Distributed hydrogen generation provides a near term solution
![Page 7: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/7.jpg)
Objectives of On-Site Hydrogen Production from Liquids
• Circumvent hydrogen pipeline to allow near-term H2 fueling stations.
• Transport liquid feedstocks to take advantage of existing fuel infrastructure while gaseous/liquid H2 infrastructure develops.
• Avoid or reduce compression requirements with pressurized production.
![Page 8: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/8.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 9: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/9.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 10: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/10.jpg)
Lab Scale Hydrogen Production System
• Continuous reactor system utilizes supercritical water• Rated to 1,200ºF and 12,000psig; typically 0.2 kg
hydrogen per hour
![Page 11: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/11.jpg)
Ethanol
• On-site hydrogen generation from ethanol– Ethanol is an available and renewable feedstock– Crude ethanol/water mixture could be a less
expensive feedstock• Long term data needed to study catalyst activity
over time• Potentially cheaper due to less processing at the
ethanol production facility• Water is a non-issue as it is a required reactant• Other contaminants need to be examined more
closely with respect to potential plugging & coking issues
![Page 12: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/12.jpg)
Results – Refined Ethanol
Ethanol Mole % of dry product gas
T, ºC P, psi H2 CO2 CO CH4 CxHy Conversion
467 5363 51 23 0.6 19 5 95%
Desired reaction: C2H5OH + 3H2O 6H2 + 2CO2
Hydrogen max = 75mole%
Competing reactions lead to methane formation
![Page 13: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/13.jpg)
Glycerol
• On-site hydrogen generation from glycerol– Glycerol is a biodiesel byproduct accounting for 10%
of total product at a biodiesel facility– Refining bottleneck = stable price for refined glycerol– Crude glycerol could be a cheap, abundant,
renewable feedstock for hydrogen production• Long-term data needed• Study contaminants’ affect on catalyst activity over
time• Contaminants include water, salt, organic matter
![Page 14: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/14.jpg)
Results – Refined Glycerol
Glycerol Mole % of dry product gas
T, ºC P, psi H2 CO2 CO CH4 CxHy Conversion
541 4838 60 31 1.1 5.8 0.7 93%
Desired reaction: C3H5(OH)3 + 3H2O 7H2 + 3CO2
Hydrogen max = 70mole%Competing reactions
![Page 15: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/15.jpg)
Methanol
• Methanol is currently synthesized from natural gas
• Methanol can be synthesized from renewable biomass
• Methanol is a simple molecule and reforms completely at high pressures and relatively low temperatures
![Page 16: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/16.jpg)
Results - Methanol
Methanol Mole % of dry product gas
T, ºC P, psi H2 CO2 CO CH4 CxHy Conversion
384 4885 73 25 0.5 0.9 0.01 100%
Desired Reaction: CH3OH + H2O 3H2 + CO2
Hydrogen max = 75mole%
![Page 17: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/17.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 18: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/18.jpg)
Water Removal
• Water is fed in excess of stoichiometric.– Avoid coking of catalyst– Provide process heat
• Need to remove water.• Critical temperature (Tc) of water = 374°C.• Cooling below Tc causes phase change to liquid.
– Cooling water used for heat exchange• Removed via level control and a valve at the bottom of
the condensate vessel.• Works very well.
![Page 19: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/19.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 20: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/20.jpg)
CO2 Removal
• CO2 is continuously removed via selective absorption.
• The resulting product gas composition approaches 96 mole% hydrogen with the balance being methane and carbon monoxide.
• A final, high pressure gas purification step is required to purify the gas to PEM fuel cell quality.
![Page 21: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/21.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 22: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/22.jpg)
Electrical Swing Adsorption (ESA)
• Objective is to purify the hydrogen rich gas stream to PEM fuel cell quality at 6,000-12,000psig.
• Tailoring an ESA process, developed by Oak Ridge National Lab, for high pressure.
• Involves gas separation in an electrically conductive monolith.
• Non-hydrogen gases adsorb on the monolith, whereas hydrogen passes through; results in hydrogen separation.
• Similar to pressure swing adsorption but does not require a drop in pressure to release contaminants.
• Release contaminants by applying an electric current.
![Page 23: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/23.jpg)
ESA Test System
![Page 24: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/24.jpg)
Electrochemical H2 Purification
H+
H2
H2
H2, CO, H2O, CO2
CO2
2H+ + 2e- H2
H2 2H+ + 2e-
CO + H2O CO2 + 2H+ + 2e-
Cathode Chamber
Anode Chamber
Cathode
Electrolyte
Anode
PrincipleAnode reactions:CO + H2O CO2 + 2H+ + 2e- Eo = -0.106 V; H2 2H+ + 2e- Eo = 0 V
Cathode reaction:2H+ + 2e- H2 Eo = 0 V
Total Reactions:CO + H2O CO2 + H2
Eo = 0.106 VH2 H2
Eo = 0 V
• High-purity H2 can be obtained at the cathode side with low energy consumption.
![Page 25: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/25.jpg)
Fully Automatic Controlled High-Pressure Electrochemical H2 Purification Unit
![Page 26: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/26.jpg)
Hydrogen Production Flow Diagram
High Pressure Reformer
Water Condensate
Pot
CO2
RemovalTechnology
Water andOrganic Feedstock
(ex. methanol, ethanol)
H2, H2O, CO2, CO, CH4,
CxHy
H2O
H2, CO2, CO, CH4,
CxHy
CO2
H2, CO,CH4, CxHy
H2 to fuel cell vehicle
Gas SeparationTechnology
HydrogenDispensor
CO,CH4, CxHy
H2
![Page 27: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/27.jpg)
Scaled-up, Integrated System:Projected H2 delivery rate of 0.6 kg/hr
PREHEATERFEED STORAGETANKS
REFORMER REACTORDISPENSING
CO2 REMOVAL
H2
HYDROGENPURIFICATION
STORAGE
![Page 28: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/28.jpg)
Future Work
• Finalize construction and shakedown of scaled-up, integrated hydrogen production unit.
• Demonstrate hydrogen production with scaled-up unit.
• Continue to study other reformer feedstocks.
• Continue to develop high pressure gas purification technologies.
![Page 29: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/29.jpg)
Conclusions
• High pressure liquid reforming offers a distributed hydrogen platform that has unique advantages.
• Renewable liquids have been converted to 6000psi hydrogen in the lab.
• A scaled up unit is being fabricated to demonstrate integrated high pressure hydrogen production, purification, and dispensing.
![Page 30: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/30.jpg)
Acknowledgements
• U.S. Army Corps of Engineers, Engineer Research Development Center, Construction Engineering Research Laboratory (ERDC-CERL)
• National Center for Hydrogen Technology (NCHT) sponsored by the U.S. Department of Energy (DOE)
National Energy Technology Laboratory (NETL)
![Page 31: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/31.jpg)
Thank You
![Page 32: On-Site Hydrogen Production From High-Pressure Liquids NHA Hydrogen Conference and Expo Ben Oster May 5, 2010](https://reader036.vdocuments.net/reader036/viewer/2022062804/56649f285503460f94c41465/html5/thumbnails/32.jpg)
Cited Sources• [1] DOE Hydrogen Program. Hydrogen distribution and delivery infrastructure. Fact
Sheet. http://www.hydrogen.energy.gov/pdfs/doe_h2_delivery.pdf • [2] The Impact of Increased Use of Hydrogen on Petroleum Consumption and carbon
Dioxide Emissions. August 2008. Energy Information Administration. Office of Integrated Analysis and Forecasting, Office of Coal, Nuclear, Electric and Alternative Fuels. US Department of Energy. Washington, DC 20585.
• [3] See U.S. Department of Energy, Energy Efficiency and Renewable Energy, Hydrogen, Fuel Cells & Infrastructure Technologies Program: Multi-Year Research, Development and Demonstration Plan, Table 3.2.2 (Washington, DC, October 2007), www1.eere.energy.gov/hydrogenandfuelcells/mypp.
• [4] B. Smith, B. Frame, L. Anovitz, and T. Armstrong, “Composite Technology for Hydrogen Pipelines,” in U.S. Department of Energy, Hydrogen Program, 2008 Annual Merit Review Proceedings, www.hydrogen.energy.gov/annual_review08_proceedings.html