atr-74(7914)-1, vo-l. i equipment systems ... microfiche was producifii fillm documents received for...
TRANSCRIPT
; :
This microfiche was producifii fillm documents received for inclusion in the NCJRS data base. Since NCJRS cannot exercise
control over the ,physical condition of the documents submitted, the individual frame quality will vary. The resolution cha.rt on
this fume may be used to evaluate the document quality.
1.1 I .
111111.25 111111.4 \\\\\1.6
MICROCOPY RESOLUTlor~ TEST CHART NATIONAL BUREAU OF STANDARDS-1963-A
i
Microfilmini procedures used to create this fiche comply with
the standards set forth in 41CFR 101·11.504
Points of view or opinio~s. stated in this documint are
those of the author[s) and do not represent the official position or policies of the U.S.'Department of JusUce.
U.S. DEPARTMENT OF JUSTICE' LAW ENFORCEMENT ASSISTANCE ADMINISTRATION NATIONAL CRIMINAL JUSTICE REFERENCE, SERVICE WASHINGTON, D.C. 20531.
~-----=:(/, ,
~
Aerospace Report No. ATR-74(7914)-1, Vo-l. I
EQUIPMENT SYSTEMS IMPROVEMENT PROGRAM
METHODS FOR REDUCING POLICE CAR FUEL CONSUMPTION
Prepared by
Law Enforcement Development Group THE AEROSPACE CORPORATION
El Segundo, California
JANUARY 1974
Prepared for
NATIONAL INSTITUTE OF LAW ENFORCEMENT AND CRIMINAL JUSTICE
Law Enforcement Assistance Administration U. S. Department of Justice
Contract No. J -LEAA-025-73
This project was supported by Contract Number J -LEAA-025-73 awarded by the Law Enforcement As sistance Adm.inistration, U. S. Department of Justice, under the Omnibus Crime Control and Safe Streets Act of 1968, as amended. Points of view or opinions stated in this document are those of the authors and do not necessarily represent the official position or policies of the U. S. Department of Justice.
If you have issues viewing or accessing this file contact us at NCJRS.gov.
•
e·
E MENT PROGRAM EQUIPMENT SYSTEMS IMPROV
FOR REDUCING POLICE CAR FUEL CONSUMPTION
METHODS
Approved
iii
e-
- - - ---------
ABSTRACT
This report presents the results of a preliminary study on means for
reducing the consumption of petroleum products by police cars. Major
emphasis was placed on an exam.ination of the adaptability and utility of
smaller automobiles than are presently used by police agencies. Alternate
measures that involve operating procedures and driving habits were also
considered, and the potential benefits from applicable alternatives were
quantitatively assessed. Because it appears that both the intermediate
and compact-size cars have a far greater application than current usage
would suggest, strategies to overcome barriers to wider police use of such
smaller cars are presented. In Volume II, a proposed plan is presented
for implementation by the Law Enforcement Assistance Administration that
involves a comprehensive program for police fuel conservation.
v
e-
CONTENTS
ABSTRACT.
FOREWORD
I.
II.
INTRODUCTION
DISCUSSION ...
A. Police Energy Use Perspective
B. Trends in Automobile Characteristics
C. Police Automobile Usage.
D.
E.
1. Function s . . . . . . .
2. Present Automobile Use
3. Vehicle Procuremen;c ..
Possibilities for Reducing Petroleum Fuel Use
1. Car Size ................... .
2. Accessories and Optional Equipment
3.
4.
5.
6.
7.
Driving Cycle and Patrol Strategy.
Driver Technique ....
Effective Maintenance.
Fuel-Saving Devices and Adjustments
Estimate of Potential Benefits
Barriers to Srnall Car Use.
1.
2.
3.
User Attitude" .....
Limited Information Dissemination.
Procurement Process Bias .....
vii
v
xi
1
3
3
7
13
13
17
19
25
27
37
43
45
47
48
49
57
58
62
63
III.
CONTENTS (Continued)
4. Manufacturer-Imposed Bias ....
5. Means for Changing the Attitude
CONCLUSIONS.
A.
B.
C.
General.
Use of SmallE~r Cars
o'ther Fuel-Saving Procedures
1. Driving Techniques.
2. Patrol operations .
3, Improved Maintenance
4. Optional Equipment
IV. RECOMMENDA TIONS .
REFERENCES ..
BIBLIOGRAPHY
APPENDIXES
A.
B.
C.
D.
Contacts Established During Study
Police Vehicle Sample Brochure.
Small Car Safety .......... .
Calculation of Accumulated Benefits
viii
65
65
71
71
72
73
73
73
74
74
75
77
79
A-1
B-1
C-1
D-1
FIGURES
1. Distribution of U. S. Energy Consumption During 1972 . . 2. Distribution of Petroleum Consumption During 1972
3. Fuel Consumption by Mode of Transportation During 1971 •
4. Vehicle Weight-History Trend .. . . " " " " " . " . . " 5. Passenger Car Engine Displacement Trends . . . . . 6. Passenger Car Registrations by Market Class
7. NOx Emission Level Effect on Fuel Economy
8. Steady-Speed, Level-Road Fuel Consumption
9. Present Distribution and Possible Redistributions of the
PoLice Fleet Mix . . . . . .. . .
10. Effect of Idle Time on Mileage e 11. Effect of Improved Mileage on National Fuel Savings
12. Effect of Reduced Miles Driven on National Fuel Savings.
ix
4 1.
5 2.
6 3.
8 4.
9 5.
10 6.
12 7.
28 8.
9.
36
43 e 50
. . 53
TABLES
Comparison of Automobile Size Categories
Estimated Police Automobile Distribution
. . . Dimensions of 1974 Automobiles ..
Factors Influencing Fuel Economy
Interior Dimensions of 1974 Automobiles
PoLice Car Equipment Storage Requirements
Current Police Fleet Mix and Proposed Redistributions
Estimated Average Police Fleet Mileage ...
Police Community Image of the Smaller Car
x
7
19
20
26
31
32
38
51
60
• FOREWORD
In view of the short time during which this study was to be made,
cOl'l.:lulting aid from several sources was obtained. Each consultant was
requested to provide specific data and, in turn, establish contact with num-
erous law enforcement car-user agencies and other related information
sources. The three consulting sources contributing to this study and the
specific areas of focus for each are:
G. Ray Wynne (Director, Police Transportation, Los Angeles
Police Department): Metropolitan police vehicle
requirements, selection and procurement proce-
dures, vehicle test evaluation, operating and
maintenance experience.
Arthur D. Little, Inc. (Washington, D. C.): Adaptability and potential
utility of small and intermediate-size automobUes
as police vehicles.
Overly, Schell Associates (Washington, D. C.): Strategies for over-
coming barriers to the us e of small police vehicles.
As part of the A. D. Little, Inc., effort, a questionnaire was prepared
and submitted to a selected sample of police agencies. The purpose of this
survey was to establish typical auto use activities, the characteristics of the
automobiles involved, procurement and maintenance policies, and attitudes
xi
r
----------__ 1
toward u,s'ing smaller autos. D t b . a a'were 0 tamed from 37 police agencies
(see ArJpendix A).
Other contacts, both in person and by telephone, made during the
c~urse of this study by personnel of The Aerospace Corporation and the
assisting consultant are also listed in Appendix A. The total number of
contacts established during the course of this study are as follows:
46 city police agencies
12 county police agencies in 8 different states
17 state highway police agencies
8 law enforcement planning agencies
3 Federal agencies
8 associations
5 automobile manufacturers
4 research experts
The information obtained from these sources materially aided this study.
In addition, the results contained in a report on patrol cars (Reference 1)
and other reports from the National Bureau of Standards and the Mitre
Corporation were utilized..
xii
•
•
e-
CHAPT ER I. INT RODU eTlON
The occurrence of a national shortage of petroleum fuel has caused
rapid and varied reactions. Initial steps taken to meet this shortage involve
an examination of user practice and an assessment of means for lowering
the quantities of petroleum consurned. At the request of the National Institute
of Law Enforcement and Criminal Justice of the Law Enforcement Assistance
Administration, The Ae rospace Corporation undertook a brief study of the
feasibility of reducing the quantity of petroleum. fuel consumed by law enforce
ment vehicles. Major emphasis was to be placed on the utility of smaller cars
for law enforcement use; however, alternative fuel economy measures were
also to be considered. Appropriate recommendations for implementing fuel
economy measures among the law enforcement community were desired.
The study did not consider vehicles of foreign manufacture. Non-
pass enger car vehicles in the police fleet such as vans, motorcycles. etc. ,
are specialty vehicles with limited application and use and were also beyond
the scope of this study. Finally, any techniques proposed for reducing fuel
consumption were cons trained to curr ent knowledge and available technology.
The results of this study are reported in two volumes. This volume
presents a discussion of the pertinent issues and the conclusions reached.
Also included in Volume I are recomm.endations for action that could be
taken by the Law Enforcement Assistance Administration to encourage the
use of smaller police cars, as well as other means, to reduce the petro
leum fuel consumption by the law enforcement community.
1
Volume II is devoted to a detailed presentation of a suggested program
plan by the Law Enforcement Assistance Administration for attaining improved
fuel economy with police vehicles. The various phas es involved are described,
and estimated schedules and costs are provided. The steps proposed involve
near -term and subs equent action and can be treated individually, if des ired.
•
•
•
CHAPTER II. DISCUSSION
The discussion that follows is divided into the following five sections:
A. Police Energy Use Perspective
B. Trends in AutOlTIobile Characteristics
C. Police Automobile Use
D. Possibilities for Reducing Petroleum Fuel Use
E. Factors and Barriers that Influence Use of Smaller Cars
Section A examines the sourc:~s of energy used in the United States and
relates petroleum fuel us e by police agencies to total national consumption.
Section B traces the changes in automobile design trends and discusses
thei:r weight growth and resulting fuel consumption.
Section C focuses on the police use of automobiles, the functions per
formed, the types and size of automobiles currently utilized, and the selec
tion and procurement procedures employed.
. The major portion of this chapter is devoted to Section D. The numer-
ous possibilities for reducing police agency use of petroleum fuel are exam
ined and evaluated in this section.
Because the adoption of smaller cars raises unique problems, the fac
tors that influence its wider use by police agencies and barriers to its wide
adoption are discussed in the last section, Section E.
A. Police ]~nergy Use Perspective
Data on the current sources and the us e distribution of energy in the
United States are largely based on estimates. The most reliable data
3
f·1
1\ " \
\
presently available, Reference 2, are for calendar year 1972. As indicated
in Figure 1, petroleum provided 46% of the nation1s energy. An examination
of how this petroleum was distributed among its varied users, Figure 2,
reveals that over half of the amount (52.5%) was devoted to transportation.
It should also be noted that petroleum represents 96% of the total energy
used in transportation, the remainder being natural gas and coal. Although
the naUon's petroleum consumption has increased markedly during the last
decade, the actual percentage used for transportation and the portion of
total transportation energy that petroleum represents have remained rela-
tively unchanged.
PETROLEUM 46%
NATURAL GAS 32%
4% HYDROPOWER
--'~- NUCLEAR - 1 %
Figure 1. Distribution of U. S. Energy Consumption During 1972
4
e-
e-
TRANSPORTATION 52.5%
INDUSTRIAL 16. 9"10
ELECTRICAL GENERATION
9.8%
HOUSEHOLD AND COMMERCIAL
20.4%
~-~-- OTHER 0.4%
Figure 2. Distribution of Petroleum Consumption During 1972
Distribution among all users of petroleum devoted to transportation
is given in Figure 3 for 1971 (Reference 2). The pas senger car was by far
the greatest user (59.3%) of the 117 billion gallons of fuel devoted to trans
portation that year. All told, passengers cars consume about 14% of the
nation1s total energy supply.
The police fleet has been conservatively estimated at 160, 000 auto
mobiles (Reference 1) out of an estimated total of 100 million passenger
cars now on the road. The fuel cons1:lmption for police cars on a national
basis is estimated to be about one billion gallons of gas oline annually. Thus,
5
PASSENGER CAR
59.3%
RAILROADS - 3.3%
BUSES 0.8%
Figure 3. Fuel Consumption by Mode of Transportation During 1971
a realistic reduction in police petroleum use, 20 to 30% for example,
would provide a fuel savings of 2 to 3 hundred million gallons of gasoline
per year.
The nature of the energy shortage problem is such that no single mea
sure offers large economies. Instead, numerous steps, each contributing
a small saving, must be taken. A reduction in the police car use of petro ..
leum is one such step. Moreover, the procedures followed to achieve a
reduction will serve to demonstrate what other automobile operators could
do to also reduce their fuel consumption. The potential savings possible
through such amplification are truly significant.
6
e-
B. Trends in Automobile Characteristics
Police automobiles are generally selected from among con~mercial1y
available American models. A police car differs from a conventional car by
some specially selected, but off-the- shelf options; a suspension system that
provides significantly different handling characteristics; and a number of
heavy-duty components. In general, production cars can be grouped into four
size categories, namely, standard, intermediate, compact, and subcompact.
Luxury and specialty production cars are obviously also available, but, except
for special purchase needs, are rarely purchased by police agencies.
The characteristics of the four basic automobile size categories are
summarized in Table 1, and examples of current models that fall into these
Table 1. Comparison of Automobile Size Categories
(1974 Model Year)
Engine Size Category Wheelbase, in. Weight, lb Typical Models
Type CID
Standard 120 - 122 4,000 - 4,650 V-B 350 min Chevrolet Impala Ford Custom or
Galaxie Plymouth Fury AMC Ambassador Dodge Monaco Mercury Monterey
(124 in. wheelbase)
Intermediate 114 - 118 3,550 - 4,100 V-8 300 min Chevrolet Chevelle 6 cyl 225 min Ford Torino
Plymouth Satellite AMC Matador Dodge Coronet Mercury Montego
Compact 103 - 111 2, B50 - 3,300 V-B 300 =in Chevrolet Nova 6 cyl 225 min Ford Maverick
Plymouth Valiant Dodge Dart AMC Hornet Mercury Comet
Subcompact 94.2-97 2,450 - 2,750 V-B 304 Chevrolet Vega 6 cyl 232 Ford Pinto 4 cyl 122 to 140 AMC Gremlin
7
nl----------------------------------------------~ \ it U If;
'i lj il He :~
"
categories are also listed. Police cars generally fall in the standard or
intermediate- dze category.
With each succeeding model year, it has been a characteristic of
American-designed and produced cars to become larger and heavier and to
have larger engines. Only when a new model concept is introduced does this
trend change. These conclusions are readily confirmed by the weight-history
trend presented in Figure 4, and the engine displacement trend presented in
Figure 5. For a given size category, automobile curb weight increased con··
sistently with time. In the last decade, automobile weights in the compact,
intermediate, and standard categories have all increased 20 to 30%. In :fact,
4000
3500 .0
~
I-J: C> L&I :\t
~ III 0:: ::> u
2500 SUBCOMPACTS VEGA --
Figure 4. Vehicle Weight-History Trend
8
e-
e-
400
III 350 Gl
"§ .~ 300 ~ u
...: z 250 w ~ w U -< 200 ..J a. !!! c w 150 z l5 z w
100
"'" "'"
,..--"","'"
" "","'" "
'"
--INTERMEDIATE
-- ~ ....... ------COMPACT
SUBCOMPAC1'\
-------
50L-~--~--~~--~--~~--~------1962 1966 1970
Figure 5.
YEAR
Passenger Car Engine Displacement Trends
the average intermediate of 1973 is about as heavy as the average standard
" of 1963, and the average compact of 1973 is about as heavy as the average
1963 intermediate.
Consistent with this weight growth is the attendant growth in engine
size. Engine cubic inch displacernent, while not directly convertable to
horsepower, is a useful engine power trend indicator. In the last decade,
the average displacement in the standard, intermediate, and cornpact cate
gories have kept up with the weight growth. In fact, just as with weight, the
current interrnediate-category engine displacement is equivalent to that of
9
the standard category a decade ago (Figure 5). The engine displacement in
the current compact category even exceeds the displacement of the average
intermediate automobile of a decade ago.
Thus, although the registration (and sales) of standard-size autorno-
biles has been steadily declining in favor of smaller vehicles (Figure 6), the
fuel econorny of the average car on the road has not improved. Instead,
growing weight and larger engines have lowered miles achieved per gallon
of fuel. The situation is further aggravated by the public's desire for
90
80
70 I/)
z 0 i= 60 -< a:: .... I/) 50 l5 w a:: ..J 40 -< .... 0 .... 30 LL COMPACT INTERMEDIATE 0 ~ 20
10
YEAR
Figure 6. Passenger Car Registrations by Market Class
10
e-
numerous accessories and power-assisted equipment, which also reduce
fuel economy. The attitudes of both the consumer and the manufacturer
have dis couraged achievement of improved automobile fuel economy.
As later discussed in Section D, the fuel consumption of an average
automobile is basically a function of weight. Obviously, the driving cycle
and speed also have a significant impact on mileage, and cars involved
solely in urban driving will, for example. us e more fuel than is required
for steady, highway driving. Further, about 1967, the issue of emission
control was introduced, and subsequently Federal safety standards were
also imposed. The latter caused additional weight increases and the
former lowered engine operating efficiency, which lead to subsequent
increases in engine displacement and the accompanying increase in
engine weight.
Emission control requirements have been especially detrimental to
automobile mileage. The initial requirements have already lowered obtain-
able mileage almost 200/0, due to changes to the engine and its operation. If
these changE~s that are easily eliminated were to be discarded, about one
third of this decrement could be recovered, but at the expense of a large
increase in emissions. The more stringent NO emission requirements x
about to be imposed could well cause a further reduction of significant mag-
nituae. With existing knowledge and available technology, the decrements
indica1:ed in Figure 7 can be anticipated as the allowable NO emis sion is x
successively lowered. There is an obvious need for new technological
11
: ' \
3.0
~ 'E 2.0 I. III Q.
1/1
E tI I. til
OX 1.0 z
o
-- 1913-14 FEDERAL STANDARD
-- '1974-76 CALIFORNIA STANDARD. 1916 FEDERAL STANDARD
-- 1917 FEDERAL STANDARD
'10 20 30 40 50
% MIU£ PER GALLON DECREASE (from uncontrolled vehicle)
Figure 7. NO Emission Level Effect on Fuel Economy x
developments. However, by direction, the s cope of this study excluded
consideration of new technology that might redu.ce the emission control
penalty.
As reported by the Mitre Corporation (Reference 7), police car fuel
economy has dete:t:'iorated significantly and their maintenance increased
markedly since 1968. These changes are attributed primarily to the intro-
duction of emission controls and the higher engine operating temperatures
involved. This EJituation is expected to become even more severe with the
current model automobiles.
It is in thi.s environment that police cars are selected and procured.
Limitations obviously exist on the types of automobiles available to police
12
e-
agencies, as well as on the steps that might be taken to improve their fuel
economy. The next section (Section C) treats the extent and categories of
police auto usage, and this is followed by a discussion of possibilities for
reducing the fuel con:sumed by police agencies (Section D).
C. Police Automobile Usage
1. Functions. Police agencies are engaged in a variety of activities
in which an automobile is a key supporting element. The purpos e of the auto-
mobile is primarily to transport men and equipment during the commis sion
of the police function, namely, to protect life and property. The specific
police activities involved establish requirements for the automobiles used
and serve as the basis for defining the important police automobile
char acteris tics.
Police vehicle functions can be conveniently groupc.d into five
general categories. Thes e are
• Patrol
• Traffic
• Inves tigation
• Emergency Response
• Adminis tration
There are, of course, exceptions to these functions, as well as
varying degrees of specialization. The discussion that follows briefly exam
ines the vehicle needs associated with each of these functions.
13
a. Patrol. The patrol function serves several purposes,
including observation of crimes, deterrent to crimes being committed, mak
ing policemen readily available for citizen assistance, arresting and trans
porting suspects, and responding to a variety of emergencies. Patrol is the
most visible area of police work and, in the public view, is associated with
the protection of life and property. The requirements of an automobile to
support patrol work usually include the following factors:
•
•
Comfort - Head room; leg room; seat width;
eas e of entry and exit; s eat support;
driving effort; adequate ventilation,
heating, and cooling
Roominess - Personnel, equipment space,
trunk storage, adequate rear seat
• Safety - Crashworthiness, prisoner containment
• Performance - Handling, maneuverability, brak-
ing, acceleration and speed,
durability, dependability
• Special Characteristics - Visibility, equipment
mount feasibility
These five patrol requirements vary somewhat among different agencies.
In all cases, however, the patrol car is an essential element of the patrol
activity for 8 to 24 hours a day. As such, it must provide adequate and
dependable support to the patrolman, the other key element of the patrol
activity.
14
b. Traffic. The tra.ffic function can involve traffic patrol,
apprehension of traffic law violators, emergency response to accidents,
accident investigation, maintaining or restoring smooth traffic flow, or the
enforcement of parking laws. The traffic patrol activity. as a combination
of the two functions (patrol and traffic), requires a car much like the patrol
car. The other traffic activities are much less demanding of a vehicle.
They either require transportation to the scene of an accident or traffic
snarl, for examl.le, or they can be performed on foot (issuing parking
tickets). As a result, the requirements for these latter functions are sim
pler and more straightforward than for the traffic patrol function. They
are baSically no different than those for a family or for a light commercial
pass enger vehicle, namely, to safely and rapidly take one to four persons
on short, across-town trips.
c. Investigation. The investigative function is essentially
single purpos e, that is, to provir,e basic transportation to take one or two
men on short trips. It is similar to the nonpatrol traffic function in its
vehicle requirements. Where the investigative activity requires surveil
lance. a car not readily identifiable as a police car may often be needed
(for example, undercover vice or narcotics work). For some surveillance
and undercover work, the car may also be us ed as a pursuit car. In this
case, high-speed performance capability is also required.
d. Emergency response. Emergency response functions
include rescue service or ambulance calls, civil disorders, suicides; etc.
Some of these needs can be met by patrol cars (which have already been
15
discussed), others will require special vehicles, such as vans or
ambulances. It seems clear that such special purpose needs cun probably
not be met by smaller cars. The few cases where smaller cars might meet
these special purpose needs are expected to be minimal.
e. Administrative. In most police departments, cars may
be assigned to individuals, to organizational units, or to a pool for a vari
ety of administrative uses. This latter category can include the cars used
by the chief and other senior police officials, those used in community rela
tions work by juvenile workers and parole officers, and thos e used for mes
senger service and lor a variety of other n'liscellaneous needs. The require
ments for these vehicles are simple, perhaps even less demanding than for
the traffic functions. Only two pos sible exceptions may require that this car
have characteristics somewhat beyond simple transportation:
1. "Poolil cars may be used by so many different kinds
of drivers that durability and toughness are very
important.
2. Cars for senior police officials may have to be
appropriate to their status, and thus somewhat
more luxurious than mere transportation demands
would im ply.
£. Sumnlary. In summary, police functions related to auto-
mobile requirements can be grouped into two categories - patrol and non
patrol. The patrol car requires fairly high levels of comfort, performance,
16
• and durability, and has special safety, roominess, and equipment needs.
The car for nonpatrol use merely provides basic transportation as with
commercial or private passenger cars.
Furthel' discussion of police functions and their trans-
portation requirements is presented in References 3 and 4.
2. Present automobile use. A dete:i:.'mination of the number and
types of autOlnobiles presently in use is first necessary in order to estab-
lish a baseline for assessing the potential fut' reducing police car fuel con-
sumption. The size and type of police department obviously influences both
the number and kind of vehicles they use. Smaller departments have fewer
automobiles than larger departments, anq some vehicles must, therefore,
be us ed for multiple functions.
For purposes of this analysis, all police jurisdictions were con-
veniently divided into the following five categories:
• State police or state highway patrol
• County police or sheriff1s office
• Rural, townships, small city (population to 50,000)
with 1 to 49 man force
• SubUl:'ban, medium city (population 50,000 to 250,000)
with a force of 50 or more men
• Urban, metropolitan - 50 largest cities (population·
over 250,000)
17
a. Number of automobiles. A police equipment survey
performed by the National Bureau of Standards for the Law Enforcement
Assistance Administration estimated that in 1971 there were approximately
160,000 patrol cars (Reference 1).
The number of police automobiles other than patrol cars
was estimated by the use of factors derived from survey data and informa-
tion obtained as part of this study by Arthur D. Little, Inc. The survey sug-
ges~s that patrol c(),rs consti1;v,te 62.5% of the total police car fleet for urban
and suburban forces and about 77% of the police car fleet for all other juris-
dictions. On this basis, the total number of police automobiles, by jurisdic-
tion, is estimated to be as follows:
Patrol Car Other Total --States 29,100 8,730 37,830
Counties 70,900 21,270 92,170
Rural, small city 27,300 8,190 35,490
Suburban, medium city 15,900 9,540 25,440
Urban, metropolitan city 16, 100 9,660 25,760
159,300 57,390 216,960
b. Size of automobiles. An estimate of how the total number
of police automobiles are distributed by vehicle size is given in Table 2.
The estimate is based on the same sources of information as for the num-
ber of automobiles. For purposes of analysis, the patrol car and all other
18
•
e·
Table 2. Estimated Police Automobile Distribution
-., Application Standard ll)termediate Compact Total
-Patrol Cars
States 27.936 (96%) 1,164 ( 4%) 29,100 Counties 46,085 (65"10) 24,815 (35"10) 70,900 Rural/ small city 24,570 (90,,/0) 2,730 (10"10) 27,300 Suburban/medium city 12, no (80,,/.) 2,544 (16%) 636 WM 15,900 Urban/metropolitan city 11, 431 \71"10) 4 1 508 !28%) 161 p"lo) 16 , 100
Subtotal 122,747, (77%) 35,761 (22%) 797 (1"/0) 159,300
Administrative/Investigation/ Traffic
States 6,111 (70"/0) 2, 182 (25"10) 437 (5%) 8,730 Counties 10,635 (50"10) 8,508 (40%) 2,127 (10"/0) 21,270 Rural/ small city 6,552 (80"10) 819 (10"/0) 819 (10"10) 8,190 Suburban/medium city 4,i02 (43%) 4,388 (46"10) 1,050 (11,,/0) 9,540 Urban/metropolitan city 4 1 926 151%) 3,671138"10) 11 063 P 1"10) 9 1 660
Subtotal 321326 ~56"1o! 19 , 568 p4"1o! 5 , 496P°"lo1 57 13 90
Total 155.068 (71.5"10) 55,329 (25.5"/0) 6.293 (3"/0) 216,690
categories are listed separately. Three auto sizes are in use, namely,
standard, intermediate, and compact. The dimensional characteristics of
these size cars are summarized in Table 3.
Although standard cars are generally favored, both the
intermediate and compact sizes are used. It is especially clear that stan-
dard, full-size automobiles are not necessarily required for all patrol or
nonpatrol duty. Thus, greater use of cars smaller than standard size would
seem to be feasible and, more importantly, acceptable to some degree in
all police jurisdictions.
3. Vehicle procurement.
a. Present procedure. The comple(:e police vehicle procure
ment process, if competitive, can be represented by five discrete steps.
19
r i 1 i j
I
Table 3. Dimensions of 1974 Automobiles
Trunk Size Category Height, in. Length, in. Width, in_ Space,
cu ft
Standard . Ford, Chevrolet, 54.5 - 55.5 219.4 - Z22.7 77.2-79.5 18.2 - 20.4
Plymouth, Ambassador
Monaco
Intermediate
Chevelle, Coronet, 52.8 - 55.4 210.3 - 219.5 77.2-79.3 15.3 - 19.1
Torino, Montego,
Satellite, Matador
Comeact
Nova, Dart, 52.4 .. 54.3 187.0- 203.2 69.6 - 72.4 10.1 - 16.2
Maverick, Comet,
Valiant, Hornet '.
Whether or not all five steps are utilized depends upon the specific jurisdiction
involved, the fleet size, and the degree of vehicle function specialization.
(1 ) Specify police services provided and establish vehicle
requirements. Theoretically, police transportation needs are established
through detailed study and planning that take into consideration factors such
as the area covered, the nu~ber and types of calls received, emergency and
community services to be provided, investigative activity involved, etc.
Realistically, however, this step is informal and rarely explicit. If the
services involved are spec.ified, they are usually based on past experience,
and few changes in transportation needs are indicated. Superimposed on the
req't~ "'ements as stated by the police administration is the influence of
20
elected officials, police associations and unions, other agencies, and local
pressure groups. In addition, constraints to change frOlTI existing practices
provided by local charters and constitutions, as well as public comlTIitlTIent
and subtle agreelTIent between interested parties, are also involved. The
net result is a tendency to define a car lTIodel rather than transportation or
vehicle performance requirements.
(2) Establish technical specifications for cars and
~iplTIent. The usual practice is to start with the previous year's speci
fications and update thelTI, as feasible, with available new hardware. Fre
quently, the specifications intentionally lTIatch currently lTIanufactured cars
equipped with the optional "police package." In these cases, the specifica
tions reselTIble the manufacturer's brochure, and lTIelTIbers of the staff of
the individual police jurisdiction prepare the specifications. A few of the
larger urban and state police agencies provide specialists in automotive
engineering for this critical step, but, in the aggregate, they are a small
percentage of the total. In any case, manufacturer's bX9chures repres ent
the basic specifications input.
(3) Issue request for bids to qualified sources. Once
prepared, the specifications are sublTIitted for procurement action. Costs
are estimated and a bid package is prepared for executive approval. Once
approved, the bid package is norlTIally advertised and then sublTIitted to
qualified bidders. If a dealer is interested, he requests his manufacturer
to review the bid request to assess the ability to meet the specifications
and delivery date (for large orders), and to quote costs. Frequently, dealer
21
qualification is limited to the jurisdiction of the buyer. In rare cases,
large fleet buyers will request salTIple cars for test and evaluation prior to
bid or award. (The city of Los Angeles, for example, has followed this
procedure for a number of years.)
(4) Evaluate bids and select supplier. The procuring
office determines the legality of all submitted bids and also assesses the
bidder's ability to meet the cOlTIffiitment. The police agency involved evalu
ates any deviations of the bid from the specified vehicle characteristics and
recolTIlTIends the winning bidder. The selection will be influenced by fleet
lTIaintenance considerations, compatibility with other vehicles already in the
fleet, officer preference, and even by the opinions of elected officials.
(5) Vehicle delivery and cOlTImission. Vehicle delivery
and cOlTImission are based on the terrriS of the purchase contract. With a
slTIall procurement, all vehicles ordered are usually simultaneously deliv
ered by the manufacturer to the dealer. Larger orders usually follow a
delivery schedule specified in the contract and may extend over a period of
weeks or lTIonths. It is not unusual for the dealer to merely process the
paper work for large orders and for the cars to be delivered directly to the
procuring agency frolTI the factory.
ComlTIissioning a car for police duty involves the
installation of specialized equiplTIent such as lights, sirens, radio equip
lTIent, special purpose brackets, etc. SOlTIe of this equipment is installed
by the manufacturer or dealer and SOlTIe by the procuring agency. Equip
ment that has a longer life than the police vehicle is transferred frolTI the
22
e-
old vehicle to the new vehicle by the procuring agency. Other equipment,
specially procured for the new vehicle, can be installed at the factory if so
specified by the purchase agreement. Final acceptance of the delivered
vehicles involves establishing that the contract specifications have been met
and that all of the installed special equipment is in proper working order.
b. Jurisdictional differences. In those communities that
operate small fleets (2 to 15 cars), only two or three people might be
involved in the vehicle procurement process. The police chief or his dele
gate sets the specifications, a purchasing official prepares the bid package,
and a limited number of local dealers respond. Because the jurisdiction is
small, it is often not feasible to have a fleet of different types of cars for
different purposes. The standard-size vehicle with "police package" options
(see Appendix B) is often selected as the best all-purpose vehicle.
In larger jurisdictions, inputs from several sources aid
in establishing vehicle specifications. The chief's office, a research and
planning unit, and the police garage might all be involved. Further, other
public officials, such as the fleet administrator for all city-owned vehicles,
the city engineer, the mayor's budget representative, . and city procurement
officials, may also have s orne procurement responsibilities. Special inter
est groups will also make their views and desires known. The net result is
a long and timely procurement proces s that requires deliberate and effective·
advance planning.
23
c. Police car specifications. The following factors are
considered by a purchaser in establishing police car specifications:
Size Top speed Safety
Weight Braking Interior dimensions
Power Handling Comfort
Cost Durability Functional utility
Acceleration Maintainability
Each jurisdiction examines its perceived needs and then
prepares specifications. Not only are there specification differences between
jurisdictions, but the level of detail to which specifications are written varies
considerably as well. Moreover, even within the same general type of juris
diction, the requirements for a police automobile to be used for the same
function can differ. Topographical and climatic conditions influence speci
fications. Other influencing factors are of political or visceral origins. As
a result, autornobile manufacturers report that only two or three individual
requests out of the several thousand police bid requests they receive annu
ally are met by the same car.
As the requirements are generally vague, the criteria from
which vehicle specifications are derived are often highly subjective. More
over, although the factors considered can be identified, providing a mea
surable description is not always possible.
d. Summary. Selection and procurement of new police cars
is largely influenced by the vehicles currently in us e and ~s adjusted by new
24
vehicle and equipment availability. To a considerable degree, police car
specifications are set to match what automobile manufacturers produce.
They are not established from the basic police services and transportation
requirements becau.se of a lack of definitive data regarding functional re-
quirements and candidate vehicle performance. In addition, there is a re-
luctance on the part of the automobile manufacturers to design and produce
a special car for police use. Their attitude is based on the small volume
that the individual police agency fleets represent. It is estimated that a
market of at least 200,000 units is required to justify production of a spe-
cial police car.
D. Possibilities for Reducing Petroleum Fuel Use
Some of the factors that affect passenger car fuel economy have already
been identified in Section B. Vehicle configuration characteristics, such as
size, weight, horsepower, and acces sories, all influence auto fuel mileage.
There are, of course, additional factors that also influence the fuel economy.
The manner in which an automobile is operated and maintained can exert a
major effect on the fuel mileage obtained. In addition, good driver technique
and preventive maintenance are very effective in achieving higher fuel
mileage.
A summary of some of the factors that fall into the configuration,
operation, and maintenance categories and the magnitudes of typical impacts
are given in Table 4. The values shown are typical for passenger car use
and may not be directly applicable to police cars. However, their relative
effect is valid.
25
Table 4. Factors Influencing Fuel Economya
Item
Co nti gur ation
Added weight
Engine size
Compression ratio
Air conditioning
Heavy duty alternator
Power steering
Radial tires
Automatic transmission
Operation
Fast starts
Varying cruise spe("~1 5 mph
120/0 idle time (pa.rked)
Maintenance
5° ignition retard
One spark plug misfiring 50%
Tires under inflated
0.25 in. toe-in misalignment
a Reference 5
Impact, mpg
Standard: -0.1 mpg for each additional 100 lb Intermediate: -0.2 mpg for each additional 100 lb Subcompact: - 0.4 mpg for each additional 100 lb
-0.2 mpg for 10% increase in displacement (urban driving)
+0.3 mpg for 100/0 increase (equivalent to -5% acceleration gaL)
-2.0 mpg (urban driving)
-0.9 mpg (urban driving)
-0.7 mpg (urban driving)
+0.5 mpg
-1.6 mpg (urban driving)
-2 mpg or more in urban driving
-1 mpg in highway driving
-2 mpg in urban driving
-1 mpg
-1 mpg
-1 mpg
-0.3 mpg
26
It is clear that there are numerous possibilities for improving police
vehicle fuel economy. For purposes of discussion, they have been grouped
into the following categories:
• Car size
• Accessories and optional equipment
Driving cycle and patrol strategy
• Personal driving habits
• Effective maintenance
• Fuel-saving devices
1. Car size. Car size and its effect on total weight are directly
related to fuel economy. The larger and heavier the car, the lower the fuel
lTIileage. It is the purpose of this section to exalTIine the extent to which the e-proportion of slTIaller police vehicles can be increased and a fuel sa.vings
obtained.
As already discussed earlier, the use of slTIaller than standard-
size cars by the police appears feasible. Smaller cars are already accep-
table to a limited degree, and a wider adoption should be expected to reduce
police gasoline needs. However, to quantify this conclusion, three funda-
mental issues must be addressed. They are:
• How much will smaller cars actually improve police
fuel mileage?
27
f l I
1
•
•
To what extent can police substitu te smaller cars
for the standard-size cars now in use?
Do currently available smaller cars meet police
needs?
Each of these questions is t 1 d separa e y a dressed in the next
three sections.
Smaller car lTIileage. The steady-speed, level-road, fuel
consumption for three different car sizes over a range of cruise speeds is
a.
shown in Figure 8. The 1 1 curves c ear y illustrate that for any specified
cruis e speed, the mileage improves as the car SI' ze (and weight) decreases.
40
z 0 30 ...J ...J « C> 0:: 20 w a. Il)
w ...J 10 5E
0
SUBCOMPACT 4-CYL ENGINE MANUAL TRANSMISSION
.----- _________ INTERMEDIATE ~ ___ -------~ ________ v-a ENGINE
AUTOMATIC TRANSMISSION
LUXURY SEDAN v-a ENGINE AUTOMATIC TRANSMISSION
MILES PER HOUR
Figure 8. Steady-Speed, Level-Road Fuel Consumption
28
e-
Urban driving mileage, for which an average speed of 20 to 25 mph is typical,
falls below these curves because of the frequent stops, periods of engine idling,
and acceleration and deceleration. An additional mileage penalty is suffered
by urban patrol cars because their operating procedures accentuate all of
these factors to a greater extent. Nevertheless, the effect of mileage differ
ences between lighter and heavier police cars still prevails.
A National Bureau of Standards report in preparation
(Reference 6) indicates the difference in the average fuel consumption
between standard and intermediate-size patrol cars is nearly 1 mpg (7.9
vs 8.7). A similar mileage difference was found to exist with a standard
size patrol car in congested driving vs open (suburban type) driving (7.65 vs
8.78 mpg).
The survey information obtained by Arthur D. Little, Inc.,
in support of this study showed a wide variance in gasoline mileage experi
ence of police agencies. The mileage ranged from a low of 4 to 6 mpg
for a full-size car to a high of 17 to 18 mpg for a compact car. While the
general trend of higher mileage with smaller cars existed, the data was
inconclusive as different size cars are usually used for different purpos es
under different driving conditions.
A similar trend was apparent from information obtained
from the New York City Taxi and Limousine Corporation. The gasoline
mileage for compacts was 10 to 11 mpg; for intermediate, 9 to 10 mpgi. a~ld
for full-size cars, 7 to 7.6 mpg. The full-size cars had V -8 engines, while
29
the others had 6-cylinder engines. All cars were exposed to the same kind
of duty and similar driving style.
It can, therefore. be cons e:.rvatively concluded that the
adoption of a sl11.aller police car (an intermediate where a standard-size
car is now used, or a compact to replace currently deployed intermediates)
would result in a 10% fuel saving per car.
b. Smaller car use. As discussed earlier, the manner in
which current police car specifications are prepared is not necessarily
based on an objective assessment of agency needs. Instead, a highly sub
jective approach, which often assumes that only the standard-size car can
adequately meet police needs, prevails. To test this assumption, a com
parative analysis was undertaken of the capabilities of intermediate and
compact-size cars and the standard··size car. The characteristics con
sidered included interior dimensions, handling characteristics, perform
ance, safety, braking, etc.
With respect to general roominess and comfort, for
example, the summary of appropriate body dimensions, Table 5, shows
that there is little difference between the intermediate and standard-car
size. Moreover, rear seat leg room (approximately 3-in. reduction) and
shoulder room (approximately 7 -in. reduction) are the only significant
dimensional differences between the compact and standard-size car. Fre
quent transportation of two people in the rear seat of a 4-door compact auto
mobile rnay prove to be unacceptable. In-service testing is probably the
30
Table 5. Interior Dimensions of 1974 Automobiles
Size Head Room, in. Leg Room, in ~ Shoulder Room, In.
Category Front Rear Front Rear Front Rear
Standard
Ford, Chevrol~t, 37.4-39.6 36.5-38.4 41.6-42.5 35.4-38.8 60 - 64.3 60 - 63.5
Plymouth, Monaco
Ambassador
Intermediate
Chevelle, Goronet, 36.3-39.6 36.3-37.5 41.8 - 42.. 5 33-38.6 58.6 - 60 58.4-60
Torino, Montego,
Satellite, Matador
Compact
Nova, Dart, 37.1-39.5 35.9-37.3 40.7 - 42. 1 31.8 - 36. 2 54.9-56.6 53.3 - 56.2
Maverick, Comet,
Valiant, Hornet -
only feasible approach for assessing the roominess acceptability of the
compact 4-door police cal'.
The space requirements for equipment installed or carried
in police cars may vary considerably depending on the type of jurisdiction and
degree of specialization. A summary of typical equipment involved, their
sizes, and where they may be located is given in Table 6. The car radio
and switch console, flashing lights, and siren are considered to be installed
items of equipment (nonmovable). The remaining items of equipment are
those that are carried in at le~st 50% of patrol cars, as reported in Refer
ence. 1. The approximate dimensional size of each item of equipment is
given rather than volume to indicate the shapes involved. The total volume
31
Table 6. Police Car Equipment Storage Requirements
Equipm(lnt Item
Approximate Size, in. Remarks
Typical Mounting or
Sto rage Location 1-.-.. -----+------ -+--~-- _____ ·_._.~o_. ---t---~-.------
Car radio 4 X II X 2.2. Trunk More than One unit may be required for mulLidistrict frequency coverage
Radio mike/ 8 X J 0 panel switch can sale
Flashing lights (5) 8X8X8
Siren (electronic) 6 X 6 X 8
Shotgun 40 (length)
Batons J 2 - 18 (length)
Fire extinguisher 8 diam X 24
First aid kit bXBXI5
Extra ammo .5X5X4 5.X 3 X 2.
Clipboard 12 X 10
Flares 12X 12X 18
Blankets 8X!2X!8
Brief case 9XI6XI8
Under dash/between front seats
Roof, behind grille
Roof bar, behind grille
Front compartment, trunk
Door panel
Trunk
Trunk
Glove box/trunk
Front seat
Trunk
Trunk
Rear floor/trunk
Other: ''lhts (rear deck)
Mech nical siren larger
Shotgun and 0.38 caliber
LA?D has writing desk secured to dash
Varies with numb"r of blankets
t'ront seat in one-man patrol
of trunk-located equipment is about 5.6 cu ft. It is estimated that about
twice this volume nlay be required to provide ready access to most items
and to acconlmodate the shapes involved. Because a11 items ar.e not neces-
sarily carried in every car and some cars may carry additional items, it
would appear that the trunk space available for all car sizes (see Table 3)
is adequate. The front interior dimensions are not significantly different
for all car sizes (see Table 5), and front compartment space also appears
adequate. There understandably may be a compatibility problem using
equipment designed for a standard-size car with a compact car (roof rack,
for example). This is not considered to be a serious problem, however, as
year-to-year changes in dimensions of the same model car present the same
type of problenl.
32
- ----_.,-------_._------
Considerable reluctance toward the use of smaller police
cars is based on the issue of their safety and handling during high-speed pur-
suit and their crashworthiness and occupant protection. A discussion of this
issue is presented in Appendix C. Statistics sh")w that smaller cars are
more frequently involved in accidents, and that, if involved in an accident,
there is a greater risk of occupant injury in a smaller car than in a standard-
size car. Safety experts s1.!ggest that the higher accident frequency m.ay be
due to the younger average age of drivers of smaller cars. They further
suggest that there will be an improvement in safety for small car us ers as
the proportion of the smaller car population increases, speed lin1.its are
lowered, manufacturers introduce structural improvements, and Federal
safety standards are adopted.
Driver fatigue, especially during the long driving periods
at high speed involved in patrolling highways, is another barrier to small-
car use. The Alabama State Highway Patrol found, for example, that a
compact-size car (AMC Javelin) had adequate acceleration and speed for
highway patrol duty but caused greater driver fatigue than was caused by
standard-size patrol cars. Intermediate-size cars are less susceptable to
such criticism, becaus e they are significantly larger and heavier than the
compact car (see Table 1), In fact, as discussed in Section B, the inter-
mediate of today is as large as the standard car of just a few years ago.
33
The following conclusions are offered regarding the use
of smaller police cars:
c.
(1 )
(2)
(3)
(4)
Intermediate-size cars are adequate for all
urban uses and most patrol applications.
Highway patrolling will continue to require
some standard-size cars
No significant constraint exists to the wide
adoption of compact-size cars for nonpatrol
duties.
For any patrol use, heavy-duty modifications
to the compact car are needed.
Availability of smaller cars. The standard and intermediate-
size models listed in Table 1 are known to be available in police configura
tions. In some cases, the conventional passenger car may be acceptable,
but in most cases, the . . d car 1S equ1ppe with selected optional equipment in
order to increase its durability and change its handling characteristics to
meet police needs. A sa 1 l' b mp e po lCe rochure published by one of the manu':'
facturers (Appendix B) illustrates the extent of proviSions available in the
"police package." The . te t f 1 ms mos requently procured include a high-
performance engine, heavy-duty brakes, a heavy-duty suspension system,
and a heavy-duty electrical sys tern.
34
At present, there is no compact-size car available with a
"police package." One manufacturer has a 4-door compact model available
with a taxi heavy-duty package. All manufacturers state that a visible
market must exist before a firm development commitment for a compact
police car would be made. Should development be undertaken, the lead time
for design, test, and evaluation of a police version compact-size car would
take from 2 to 3 years before it was offered on the market.
The subcompact-size automobile is available in 2 -door
models only and appears to have limited police applicability. The car width
and rear seat dimensions are significantly smaller than that of a compact
car. Also, this class of vehicle is not available with heavy duty equipment,
and its use would be limited to ordinary street and highway driving. Sub-
compacts are practical as a runabout for messenger and administrative
functions and are already so deployed for nonpolice use in Detroit and
Los Angeles.
Approximately 2 years ago, Volkswagons were employed
as patrol vehicles in test programs in the cities of Mamoronek and White
Plains, New York. The objective of the programs was to see if Volkswagons
could perform the work of foot patrolmen in policing neighborhoods, thus
reducing the number of patrolmen needed for this duty. The cars were
purchased from local Volkswagon dealers and were not modified for police
35
duty. Fuel saving was not a consideration at the time. Although success
ful, the tests were not followed by a large-scale procurement of Volks-
wagons equipped for police duty because of political pressures.
of the current energy crisis, interest is again being renewed.
As a result
d. Possible changes in the police car mix. The present dis-
tribution of standard, intermediate, and compact-size cars in the police
fleet is given in Figure 9. Also included in Figure 9 are two alternate re
distributions, both of which are based on a judgemental interpretation of
the study survey results. Alternative No. 1 involves increasing the number
-I <C ..... 0 ..... IL. 0 ill!
100
75 71. 5
50
25.5 25
55
38
c:::J STANDARD
~ INTERMEDIATE
~COMPACT
37 35
a '-...Io_ ....... ~~ ~-liiii;;;;;;;;;;;;j.., ...... _ ..........
Figure 9.
PRESENT AL TERNATIVE No.1 AL TERNATIVE No.2
Present Distribution and Possible Redistributions of the Police Fleet Mix
36
~-----~~~~~~~~~~-
of smaller cars in nonpatrol use and shifting to a significant number of Table 7. Current Police Fleet Mix and Proposed Redistributions
intermediate cars for urban patrol. Some substitution of intermediate cars
for small town and suburban patrol and minimal substitution for state and Patrol Other ~
county patrol are also involved. Jurisdiction Std, Inter, Compact, Std, Inter, . Compact,
% % % % % % Alternative No. 2 is based 011. a maximum substitution of
Current smaller cars, given present automobile technology and no significant change
State 96 4 - 70 25 5 in police procedures. It is assumed that the heavy-duty components avail- County 65 35 - 50 40 10
able in the larger car police package are also available for compact cars, Rural, small 90 10 - 80 10 10
thus permitting an even greater shift to compact cars for patrol and non-Suburb, med 80 16 4 43 46 11
Urban, metro 71 28 1 51 38 11 patrol use than ifl Alternative No. 1. A greatly increased use of intermediate- Overall 77 22 1 56 34 10
size cars for st.ate patrol use was also assumed. Because of the compact- Alternative No. 1
car design changes involved and the effect of the procurement process on a State 90 10 - 60 30 10
e- major vehicle mix redistribution, it could take from 3 to 5 years to imple-
ment Alternative No.2, as compared to 1 to 3 years for Alternative No.1.
County 60 40 - 40 40 20
Rural, small 70 30 - 20 60 20
Suburb, med 50 45 5 20 60 20 At best, it appears that the proportion of standard-size Urban, metro 30 65 5 10 40 50
cars in the police fleet could be reduced to about half the current number Overall 63 36 1 32 45 23
of 155,000. The detailed breakdown by jurisdictional category from which Alternative No. 2
this conclusion was reached is given in Table 7. Obviously, the alternatives State 50 50 - 20 50 30
shown in Figure 9 and Table 7 are estimates only and are intended to pro-County 50 40 10 20 50 30
Rural, small 50 40 10 10 40 50 vide an initial perspective. Further examination and assessment is Suburb, med 30 50 20 - 20 80
appropriate. Urban, metro 30 70 - 20 80
2. Accessories and optional equipment. A gallon of gasoline con-Overall 43 42 15 12 24 64
tains a fixed amount of energy. Through the combustion process in the auto-
mobile motor this energy is transformed, and a portion of it becomes
37 38
available as mechanical work to drive the wheels and electrical power
generating equipment. The overall efficiency of this energy transforma
tion is no more than about 30% and depends upon the vehicle operating mode
and speed. Accessories generally consume power and reduce the portion
of energy in each gallon of gasoline available to the wheels. The result is
a reduction in miles driven per gallon of gasoline consumed. Optional equip
ment can also be a source of reduced mileage, but certain options available
can actually do the revers e and improve the mileage. Radial tires, for
example, fall into this latter category. The impact of accessories and
optional equipment on vehicle mileage is shown in Table 4. A discussion
of each is presented in the paragraphs that follow.
a. Heavy-duty alternator. A heavy-duty alternator is required
on a police car due to the extraordinary electrical load involved. The radios,
lights, siren, and other special electrical devices impose a greater electri
cal requirement than can be met by the alternator ordinarily supplied. Little
can be done to avoid this mileage reducing source.
b. Air conditioning and power steering. The need for air
conditioning or power steering equipment is established by departmental
policy toward personnel comfort and fatigue and vehicle-handling character
istics. Some air-conditioning systems operate the compressor continuously
and mix warm air with the cooled air to achieve temperature control. Others
control the compressor by thermostat, thus providing for intermittent oper
ation and somewhat reduced fuel energy consumption.
39
Continuous air-conditioner operation introduces a fuel
consumption mileage decrement of 2 mpg in urban driving. When turned off,
the impact on fuel consumption is negligible. Disconnecting the compressor
drive belt during the winter months is not recommended.
Power steering imposes a 0 ~ 7 -mpg decrement in fuel con
sumption under urban driving conditions. If the car is equipped with power
steering, its use cannot be avoided.
c. Radial tires. As indi.cated in Table 4, radial tires repre-
sent a means of raising fuel mileage. An improvement of 0.5 mpg can be
anticipated. Unfortunately, due to their susceptability to sidewall break
age, their use on police vehicles is limited. Radial tires c,ertified for high
speed use might be placed on highway patrol cars. However, due to a need
for all-around toughness, a capability to withstand repeated curb bumping,
and frequent off-road operation, general police use is not feasible.
d. Engine size. Engine size is one of the major options con-
sidered in specifying the "police package,!! and the average police car is
equipped with a larger engine than the same vehicle would have in ordinary
private use.
Theoretically. engine size and maximum horsepower capa
bility do not control fuel economy. The engine merely meets the demand for
power imposed on it. However, to develop more power takes more gasoline;
with more power available, the acceleration rate is greater and the maximum
speed higher. A larger engine does consume more fuel at idle, at low vehi
cle speeds, and to overcome internal friction, but these effects are small.
40
e-
An additional factor that a larger engine introduces is
vehicle weight growth. Not only does the engine weigh more, but its weight
growth causes a concommittant growth in other vehicle components as well.
The vehicle structure must be "beefed-up" to accept the added weight and a
sturdier drive train (see the next section) may be required. The net result
of this added weight is lower mileage per gallon of gasoline.
Federal emission standards also influence engine size and
weight. As a result of meeting these standards, the horsepower capability
of a given displacement engine is lower. Thus, to maintain the same deliv
ered horsepower for a given size automobile, a larger displacement engine
is required. The net result has been a heavier engin~ to which must also
be added the weight of emission control accessory equipment. It should be
noted that the accommodation of these emission standards has generally
reduced the number of engine choices available for a specific size car. In
fact, compression ratio options have been completely eliminated.
Short of reducing vehicle size and weight in order to re
duce the required vehicle horsepower, little can be done to reduce fuel
consumption.
e. Drive train. The drive train includes components involved
in transferring the power delivered by the engine to the vehicle wheels. The
transmission, rear axle differential gearing, and tire si.ze are considered
part of the drive train. These ele.ments and the engine are matched to meet
desired accelel:"ation and speed characteristics. If performance require
ments are not controlling, then changes that decrease engine rotational speed
41
.-~ .. --~ --- .-- -~.- ~-~~-
for a given vehicle speed will, in general, improve mileage but :reduce
acceleration capability.
Use of an aut()matic transmission instead of a properly
operated manual transmission lowers mileage 0.5 to 1. 8 mpg, depending
on the rear axle ratio and the type of driving (for example, 1.6 mpg in urban
driving). However, consideration of driver fatigue and vehicle handling does
favor the automatic transmission. Also, experience in the Los Angeles
Police Department indicates that the manual transmission requires more
maintenance.
A properly matched drive train that provides a balance
between acceleration response and fuel consumption over a ,speed range is
necessary, irrespective of transmission type. The optimum combination
depends upon the type of driving involved, and is best determined by in
service testing.
£. Dual-exhaust system. With large V -8 automobile engines,
some improvement in engine efficiency is possible by the us e of a dual
exhaust system instead of the cheaper single-exhaust. The lowering of back
pressure on the piston exhaust stroke achieved with the dual-exhaust system
results in an increase in the net work output of the engine.
A dual-exhaust system is particularly advantageous fOT
cars involved in extensive moderate-speed cruising. Under this condition,
the potential benefit is estimated to be as much as a 10% improvement in
mileage.
42
e·
3. Driving cycle and patrol strategy. The duty to which police cars
are assigned, the manner in which a car is deployed, and the operating pro
cedures involved all influence fuel consumption. The duration of engine
idling, intermittent stopping, cruising speed, trip le:ngth, and terrain all
affect vehicle fuel consumption. These factors can be grouped under the
general heading of either driving cycle or patrol strategy.
a. Driving cycle. Police patrol cars often spend an appreci-
able portion of their duty cycle parked but with ,the engine idling. As illus
trated in Figure 10, the impact of idle tbne on mileage is quite significant.
The data presented are for a 4450 lb, 1973 Chevrolet Impala. Also indi
cated is the portion of idle time (17.8%) involved in the urban driving cycle
z o
15
j 10 « C)
Q! l1.I 0. II)
l1.I ....l 5 ~
o
I I I I
URBAN DRIViNG I CYCLE (17.8%) I
I I I I I
1973 IMPALA (-4450Ib)
20 30 40 % tOLE TIME
Figure 10. Effect of Idle Time on Mileage
43
50
used in Environmental Protection Agency mileage tests. Because patrol
car idle times as high as 30% are not unusual, a total mileage reduction
penalty of about 30% (relative to steady-state cruise) is imposed. City driv
ing obviously requires some amount of engine idling at stop signs and in
heavy traffic. However, if heater or air conditioner operation is not essen
tial during parked observation or investigation, an improvement in fuel
economy can be achieved by turning the engine of£. (According to tests by
the Los Angeles Police Department, a 401-cu in. engine conSlsmes 1. 25
gallons of fuel per hour at idle.)
During engine-off observation, power to operate needed
equipment, such as radios, can be provided by the battery. However, bat
tery drain should never be allowed to exceed one-third of its stored capa
city, or difficulty might be encountered in starting the engine. A 60-ampere
hour battery could, for exam.ple, be allowed to support a 20-ampere load for
about one hour. Use of a calibrated ammeter could aid in preventing excessive
battery discharge.
The effect of steady-state cruise speed on fuel economy
was presented in Figure 8 for typical luxury, intermediate, and subcompact:
vehicles, which represent the extreme range of passenger vehicle size. Peak
m.ileage results at speeds between 35 to 40 mph. A mileage reduction in
excess of 10% results for either the standard or intermediate size car if
the speed is lowered to 25 mph or raised to 55 mph. From. a fuel economy
viewpoint, automobiles should be operated at conditions that give maxim.um
efficiency, if at all possible.
44
Hilly, uneven terrain, trip length, and the extent of long,
straight stretches of road all translate into an ability to maintain a constant
cruise speed. Any deviation that requires frequent acceleration and decel
eration causes increased fuel consumption and lower mileage. Little can be
done to avoid this decrement.
b. Patrol strategy. There are a number of ways that patrol
strategy could perhap~' be altered to reduce the number of miles driven. ,
They vary from simply p::l.rking in high visibilit~ areas instead of continuous
cruising to devising sophisticated simulation models for identifying optimum
patrol strategy. This latter approach is intended to lead to a need for fewer
patrol cars and reduced patrol mileage without sacrificing patrol
effectiveness.
Although there have been efforts to improve patrol strat-
egy in several cities, the results to date appear inconclusive. At present,
there is no clearly definable approach for modifying patrol strategy that
could assure no reduction in police effectiveness and simultaneously reduce
fuel consumption. Pilot programs should be conducted to determine the
practicality of suggested patrol strategy revisions and the fuel savings
achieved would be proportional to the reduction in miles driven.
4. Driver technique. The driving habits of the individual driver
can significantly effect aut01TIobile fuel consumption. The importance of
reasonable accele;~ation and a steady gas pedal pressure have alre".:iy been
indicated in. Table 4.
Experience of the Los Angeles Police Department is especially
revealing. In 1972, the average mileageifor a marked patrol car was 7.4 mpg
45
r ' I,
The mileage for an unmarked model of exactly the same car used by
plain clothesmen was 10. 7 mpg. Although there were some differences in
the functions performed, the Los Angeles Police Department concluded that
this large mileage difference may be attributed primarily to driver technique
and the psychology of being in uniform and driving a marked car.
The effect of driver technique was further confirmed by an infor-
mal experiment conducted by the Los Angeles Police Department with an
intermediate-size patrol car equipped with a 40 1-cu in. engine and driven
over a 100-mile city test segment. The car was equipped with an intake
manifold vacuum control device to maintain fixed acceleration levels. The
acceleration level was constrained to three different conditions and the fo1-
lowing results were obtained:
Vacuum Level, in.
10
5
",0
Acceleration Level
Mild
Normal traffic flow
Maximum
Fuel Consumption, mpg
14.7
12.5
8.5
The penalty for "flooringll the gas pedal to accelerate was a 30%
:uileage reduction. ' Except for emergency situations, this procedure should
obviously be avoided.
A simple intake manifold vacuum gage is the first step in alert
ing drivers to this wasteful procedure. Somewhat more complex devices to
provide gas pedal resistance to pulling high intake manifold vacuum levels
or alerting the driver by a flashing light or buzzer to wasteful acceleration
46
levels are already on the market. The Chrysler Corporation has, in fact,
announced such a device as an available option for its late 1974 ITlodels.
A displayed vaCUUITl gage is also useful in ITlaintaining constant
pedal pr es sure and attaining good fuel econoITlY at cruis e conditions. The
effect of a varying cruise speed over a 5-ITlph range can, as shown in
Table 4, reduce ITlileage by as ITluch as 100/0. Clearly, cruise speed should
be ITlaintained constant for good fuel ITlileage, but, in addition, the speed
should also be close to the optimuITl value (see ~igure 8).
"Coasting" in anticipation of a stop instead of ITlaintaining speed
and then br::l..king hard can also help fuel economy. This and all the other
techniques described can perhaps be best proITlulgated by SOITle forITl of
driver training prograITl as well as a driver efficiency recognition award.
S. Effective ITlaintenance. The frequency and effectiveness of
periodic ITlaintenance, including engine tuneups, have a significant iITlpact
on fuel econoITlY (see Table 4). As a ITliniITluITl, the tuneup should include
the replacement of spark plugs, conventional breaker systeITl points and
condenser, and the adjustITlent of ignition tiITling, dwell, and idle speed.
Additional HeITls can include a check or replacement of the carburetor: air
filter, spark plug wiring, and a che·:k and adjustment, if necessary, of the
autoITlatic choke operation and carburetor float level. Such periodic ITlain
tenance is generally perforITled at a frequency specified by the ITlanufacturer
or as shown by experience to be necessary for maintaining good vehicle
performance.
Tire underin£lation and front-wheel misalignment can each reduce
fuel econOITlY and should be checked periodically.
47
~,
1 \
Police cars are generally ITlaintained at near optiITlUITl levels.
Whether or not a ITlore intensive ITlaintenance prograITl could significantly
iITlprove fuel econoITlY is uncertain and would have to be determined by ini
tiating a pilot program.
6. Fuel-saving devices and adjustITlents. There are a number of
cOITlITlercially available devices that reportedly increase autoITlobile fuel
ITlileage. They include techniques to iITlprove air and fuel mixing or ITlix
ture ratio, regulate fuel pressure, increase spark vo~tage, or to display
intake ITlanifold vaCUUITl level ("ITlileage ITleter"). They can all be placed
into either of two categories: (1) devices to improve the efficiency of the
engine in converting available cheITlical energy to useful ITlechanical work,
or (2) devices for aiding the driver to operate the vehicle in a ITlore eco-
nOITlical ITlanner.
It is generally not obvious whether a device will offer improved
fuel ITlileage, and a road test is usually necessary to assess any potential
benefit. An out-of- service road test can be very misleading. In- service
assessment is most reliable and is recoITlITlended. Of particular concern
are the devices or adjustITlents that can effect vehicle eITlissions; especially
the nitrogen oxides. For example, as pointed out in Section B, a reduction
in the nitrogen oxide eITlissions of conventional internal cOITlbustion engines
reduces their fuel econoITlY. This is due to the approach currently being
taken to control nitrogen oxide formation, naITlely, reducing combustion
teITlperature, which, in turn, reduces the engine efficiency. Any devices
or adjustITlents to increase combustion teITlperature as a ITleans of iITlproving
48
fuel mileage would be unacceptable should there be a concomitant increase
in nitrogen oxide emissions. It is essential that any evaluation of fuel-saving
devices or adjustments include not only mileage but emission-level consid-
erations as well.
One additional is sue regarding evaluation of fuel-saving devices
should be rais ed. As indicated in Section D4, driver technique can signifi-
cantly influence fuel economy. Any evaluation and tes t of a propos ed fuel
saving device must, therefore, be designed to eliminate driver bias.
Installation of an intake manifold vacuum gage appears to be a
simple, inexpensive and effective approach to improved fuel economy. Its
adoption is recommended. If other devices also prove to be significantly
effective, their adoption should also be considered.
7. Estimate of potential benefits. The preceding discussions have
identified numerous potentially effective measures for improving police fleet
fuel economy. Some can be quickly achieved with the fleet as currently con
figured, whereas others are longer term and require some changes in the
present fleet composition or vehicle configuration.
a. Feasible economies with current fleet. Means for quickly
reducing fuel consumption of the existing police fleet fall into two general
categories, operation and maintenance. Individual items in each category
are listed below:
Operational Techniques Maintenance Factors
Engine idle time • Engine tune up
• Patrol strategy • Front-end alignment
• Driving habits • Proper tire inflation
49
In general, a maximum potential benefit has been identified for each factor.
However, to collectively add these maximum benefits is unrealistic and mis
leading. Similarly, to offer a quantitative estimate of possible national fuel
saving is difficult, because the different jurisdictions involve dissimilar
vehicle operating modes. Numerical examples for possible savings are
as follows:
100
7S
0 1.1.1 > ..J 0 > z 50 ... LIJ 1.1.1 ..J II..
II.. 0 ~ 2S
1. Gasoline Savings - A parametric estimate for
the possible national fuel savings may be
obtained from Figure 11. Based on the
as sumed mileage indicated in Table 8 and
1 MILE PER GALLON IMPROVEMENT
2 MILES PER GALLON IMPROVEMENT
~ 100 ANNUAL FUEL SAVING, MILLIONS OF GALLONS
Figure 11. Effect of Improved Mileage on National Fuel Savings
50
e-
Table 8. Es timated Average Police Fleet Mileage
Miles Driven Miles per Gallon Application per Year Full Size Intermediate Compact
State
Patrol 60,000 10 11 12
Nonpatrol 40,000 10 11 12
County
Patrol 60,000 10 11 12
Nonpatrol 40,000 10 11 12
Rural/Small Town
Patrol 50,000 10 II 12
Nonpatrol 30,000 10 II 12
Suburb/ Medium
Patrol 50,000 10 II 12
Nonpatrol 30,000 10 11 12
U rban/ Metro
Patrol 50,000 8 9 10
Nonpatrol 30,000 8 9 10
Note: The values in this table are intended for use as a basis for estimating potential gasoline
savings (see Figs. 11 and 12) and do not nec:essarily represent actual mileage data.
the vehicle distribution presented in Table 2,
parametric curves were calculated for both
a 1- and 2 -mpg mileage improvement as a
function of the percent of the fleet involved.
Results are presented for patrol vehicles only
as well as for the entire police fleet.
This approach may be applied in esti-
mating the incremental savings from a single
factor as well as estimating the total savings
51
2.
from collective factors. For example, if
reducing the idle time offers .a 2-mpg improve-
ment in fuel mileage and the approach applies
to 50% of the total national police fleet, the
resulting fuel savings would be approximately
90 million gallons per year.
A second parametric trend in terms of
the fuel savings pos sible by reducing police
fleet annual mileage is shown in Figure 12.
In this latter cas e, if the total annual mileage
driven by the entire police fleet is reduced by
10%, then a savings in excess of 100 million
gallons per year would result. This savings
would provide enough fuel to drive 100, 000
private cars in exces s of 10, 000 miles per
year.
Motor Oil Savings - Reducing the total number
of miles driven by the police fleet lowers
motor oil consumption during operation and
requires fewer oil changes as well. At an
average police car mileage of 40, 000 miles
per year and an oil consumption rate of 7
52
5% FEWER MILES 10% FEWER MILES 100
75 0 LLI > ..J 0 > ~ .... 50 LLI LLI ..J I.&..
I.&.. 0 ~
25
o~----------------~----------------~--------o 50 100 __ ANNUAL FUEL SAVING, MILLIONS OF GALLONS
Figure 12. Effect of Reduced Miles Driven on National Fuel Savings
quarts every 4000 miles (primarily oil change),
the total annual police fleet oil consumption is
estimated as 3.8 million gallons. A 10%
reduction in annual mileage could thus produce
a 10% drop in oil consumption, or an estimated
380,000 gallons of oil per year.
S3
b. Economies from fleet distribution changes. Fuel economies
achieved by changing the fleet distribution result from reducing car size and
weight as well as providing a more judicious selection of options and acces
sories. In general, this approach to fuel economy is, in itself, less effec-
tive than the several collective steps that could be taken with the existing
fleet. Moreover, a complete police fleet changeover, including the time
required for developing, testing, and delivering an acceptable compact-size
car is estimated to take from 3 to 5 years.
1. Gasoline Savings - Two fleet mix alternatives
were considered (see Figure 9 and Table 7).
The annual fuel savings estimated for each
(based upon the mileage values of Table 8)
is as follows:
Alternative Savings, gal/yr
No.1 19. 6 million
No.2 57 million
Until revision of the fleet mix is entirely com-
pleted, these savings are obviously not achieved.
(A linear distribution might be assumed during
the change-over period.)
2. Motor Oil Savings - Assuming no change in
either the total number of cars in the police
54
• fleet or the total number of miles driven, any
oil savings that might occur would result from
either the reduced oil capacity of smaller car
engines or their reduced consumption during
operation. A smallel' engine with fewer cylin
ders does contain and burn less oil. It is un
likely, however, that a significant number of
4 to 6 cylinder engines will find use in either
Alternative No.1 or No.2. No major reduc
tion in annual oil consumption can therefore
be anticipated by merely changing the police
fleet mix distribution. A concomitant reduc
tion in the mileage driven would be required.
3. Materials Savings - The weight difference
between a full-size and intermediate-size car
is about 500 lb. Between a full-size and
compact-size car, the weight difference is
about 1000 lb. The material savings, par
ticularly petroleum-based plastics as well as
metal, and the energy saved in production of
the material is expected to be significant if
smaller size police cars are adopted. At an
55
annual procurement of 65,000 police cars, the
total annual weight savings for fleet mix Alter-
natives No. 1 and No. 2 (see Figure 9) is esti-
mated below:
Alternative
No.1
No.2
Weight Savings per Year, million lb
4.7
20
An estimate of the savings in production energy
is not available.
c. Vehicle option economies. Prudent selection of vehicle
options and accessories, including fuel-saving devices, can lead to appreci-·
able fuel economies. Each individual item generally offers a small improve-
ment and must be assessed separately.
The savings resulting from fuel economy measures varies
with the extent to which they are applied. The incremental, as well as col-
lective, benefit from these measures can be projected to the national level
by use of Figure 11, as was done for operational and maintehance factors.
d. Summary. Th<:: maximum feasible reduction in police car
fuel consumption is estimated as 40%. This reduction is an accuITmlation of
benefits from several sources that are categorized into five contributing
factors.
56
e-
•
Contributing Factor
Driving techniques
Patrol operations
Optional equipment
Smaller cars (Alternative No.2)
Improved maintenance
Total
Reduction in Fuel Consurn.ption, 0/0
11
10
9
5
5
400/0
These estimates are based on the calculations presented in Appendix D. It
should be noted that although this maximum savings is less than 0.40/0 of the
car fuel consumption, the potential national benefit is very total passenger
h tt for means of reducing great, especially if the police become t e pacese er
the fuel consumed by large automotive fleets.
E. Barriers to Small Car Use
f 11 cars for meeting police needs is far The potential utility 0 sma er
ld "d" t However, conversion greater than present police practice wou In lca e.
fl t t smaller cars will undoubtedly of a significant portion of the police ee 0
be resisted in spite of its feasibility.
of r esistance to the adoption of smaller There are four general sources
d inadequate dissemination of pertinent and police cars, namely, user attitu e,
available information, bias in the police vehicle. procurement process, and the
d hi 1 s Each of these manufacturer~imposed limits on available candi ate ve c e .
issues is addressed in this section. Also treated in this section are strate-
gies for improving the current attitude toward smaller cars .
57
1. User attitude. The survey conducted as part of this study
confirmed that smaller-than-standard cars have already received limited
user acceptance (see Table 7). Intermediate-size cars are now in use as
patrol or traffic cars in nine of the cities sampled and as investigative or
administrative vehicles in six additional cities. Moreover, police depart-
ments in six of the cities surveyed now use compact cars for some functions.
"C
None of the state police forces surveyed (except Alabama") pres-
ently use smaller-than-standard patrol cars. However, two states, Georgia
and Washington, expressed a willingness to try smaller patrol cars. Three
other states already use intermediate or compact-size cars for either traf-
fic, investigative, or administrative functions.
The les s recent but broader survey performed by the National
Bureau of Standards (Reference 1) also examined police agency use of smaller
cars. Bas ed upon the data pres ented in Reference 1, it was estimated that
25.50/0 of the police fleet is compos ed of intermediate -size cars and 30/0 of
compact-size cars (see Table 2).
~(
The Alabama State Highway Patrol is now phasing out AMC Javelins (a
short wheel-base specialty car). These cars were found to have adequate
acceleration and speed but are judged too small to satisfactorily transport
prisoners. Also, driver fatigue is greater than with standard-size cars.
58
User attitude toward smaller cars is <:thlo discuss ed i '.1 Reference 1
and the results presented are summarized below:
b.:g~ncy_"~ Favorable, 0/0 Unfavorable, 0/0 No Comment, 0/0
Sta.te 13 85 2
Metropolitan 28 72
Suburban 35 64 1
Rural 25 74 1
The greatest number of unfavorable responses carne from state highway
patrol agencies. This is not unexpected, for their high-speed patrol and
pursuit requirement favors the larger, standard-size car. Nonhighway
patrol duty in which state police agencies engage does include investigative
and administrative functions, and it is primarily for use in these latter
activities that a favorable attitude was expressed. The other agency types
place less emphasis on the high-speed patrol and pursuit function and are,
therefore, more amenable to use of smaller-than-standard size cars.
The police community's general attitude toward smaller cars
has been consistently negative. The most frequent criticisms given have
been summarized in Table 9. It is instructive to compare the validity of
these observa.tions with the findings of this study.
Comfort - A comparison of the interior space dimensions
between standard, intermediate, and compact cars (see
Tables 3 and 5) indicates that a significant portion of the
59
Table 9. Police Community Image of the Smaller Car
Factor Critique
Comfort Inadequate leg, head, shoulder room. Entrance / eg re s s difficult. Bumpier ride and vibration, especially in pursuit. Excessive fatigue for a 8-hr shift.
Convenience/ efficiency Inadequate space for storage of equipment. Clearance of rear door inadequate for placement of prisoners. No space for installing panel between seats.
Dependability /maintenance Inferior quality, cannot withstand police use. More down thne, would impair response.
Economy
Compatibility with auxiliary gear
Performance
Safety
Savings in' purchase and fuel costs offset by: increas ed maintenance and repair, shorter life, more down time, requires more units, incompatibility with auxiliary equipment, reduced trade-in value.
Insufficient size and power for transfer of gear. Inadequate electrical power. Impossible to instail.
Poor acceleration, top speed too low. Inadequate braking.
Intractable at high speed. Inadequate braking for panic stops. Less safe for pursuit. Not competitive with the car population.
critique could well'be psychological and not based on fact.
Except for shoulder room and rear s eat leg room, the
difference between standard, intermediate, and cornpact-
size cars is very small. For even two occupants, the
front seat roominess is not significantly reduced .. As
indicated by Alabama State Highway Patrol experience,
fatigue may be a problem with compact cars for extended
high-speed patrol duty (a use not recommended by this
study) .
60
•
Convenience and Efficiency - The storage space in
. f police equipment is believed to be smaller cars or
adequate. Some redesign of the rear door may be appro-
l'mprove the entry of recalcitrant prisoners. priate to
or screen between s eats can crowd the Ins erting a panel
rear seat area.
N I'd statistics have Dependability and Maintenance - 0 va 1
been found to support this critique. Existing comparisons
were made between standard-size cars modified for heavy
duty police use and smaller cars without such modifica
tion. Appropriately modified and equipped, there is no
reason to expect properly selected smaller cars to be
less durable or less reliable.
Economy - In-service use of appropriately modified and
equipped intermediate-size cars does not support the con
tention of an increased maintenance requirement, greater
down time, and shorter life. There may be some
'I' ui incompatibility of compact cars and the aUXl lary eq p-
ment currently in inventory. In the pres ent environment,
the depreciation of smaller cars (especially compact-size
cars) is anticipated to be less than that of standard-size
cars.
61
Compatibility with auxiliary gear - Intermediate-size cars,
properly equipped with auxiliary gear are already in use.
With compact-size cars, some repackaging may be re-
quired, but installation in some of the compact designs is
believed feasible.
Performance - When equipped with heavy-duty brakes and
an appropriately selected optional engine, the performance
of intermediate-size cars can meet police use requirements,
as well as the standard-size car, Similarly equipped
compact-size cars are adequate for urban patrol.
Safety - Insurance statistics for private passenger cars
indicate that smaller cars are more frequently involved
in accidents than larger cars. Moreover, the chance of
an injury to an occupant is greater than for a standard-
size car. However, the smaller car population trend is
rapidly increasing and experts anticipate improving safety
for small-car users as they become a larger part of the
total car mix and as manufacturers introduce new struc-
tural changes.
2. Limited information, dissemination. The lack of adequate
information flow between the police car user and the manufacturing Source
not only reduces the effectiveness of the procurement process (see C3)
62
but also severely limits the favorable consideration of smaller cars.
Unless the potential user is provided with a clear understanding of the
features and capability of available smaller cars, it is reasonable for him
to continue acquiring the type of equipm.ent with which he is familiar and
experienced.
Catalogs and brochures on the "police package" and other options
are available to prospective police purchasers. Unfortunately, purchaser
and even the dealer I s knowledge is generally lim.ited to such published mate
rial. Other features available through the factory may not be widely pub
licized' thus restricting the acquisition of desired and available features.
Such technical information exists at the factory and is provided upon direct
request. But even though development of such special-purpose equipment is
completed and the option is available, there is no incentive to widely dis
seminate knowledge of its existence.
It is unreasonable to conclude that this situation is intended by
the t::lanufacturer, as information dissemination is generally limited for
standard-size cars as well. Moreover, the customer often does not meet
his responsibility of realistically defining for the manufacturer those modi
fications to conventional production cars desired for improving their police
utility.
3. Procurement process bias. The current police vehicle procure-
ment process tends to discourage consideration of smaller cars. Instead of
specifying needs and functional requirements that might allow competition
63
between standard and smaller cars, there is a tendency to deal III
vehicle - specific terms. Moreover, the attitude of the participants in the
procurement proces s, particularly their subjective view toward smaller
cars, is especially significant in establishing the acceptability of smaller
cars.
The patrol officer who uses the car has considerable influence
on its s election, and his opinion cannot be ignored. However, he generally
lacks technical knowledge of the relative merits of cars. Further, he has
insufficient incentive to distinguish between a vehicle he wants and one that
is jus t sufficient for his needs. He is frequently concerned about his public
image and the lack of respect a small car might engender. The most ardent
opponents of smaller cars are officers who feel that the capability for high
speed pursuit is of overriding importance. Others feel that larger cars are
a deserved benefit of rank.
The administrative head of a police agency respects the opinions
of his car-using officers and his fleet operating and maintenance personnel.
His background is usually nonte~hnical, but his own knowledge and experience
obviously affect his attitude. If budget is not a problem, the administrator
has little incentive for considering smaller police cars.
Elected officials, such as the Mayor, have in principle the ulti
mate decision authority. However, the recommendation of the agency ad:r:nin
istrator is usually accepted. E'lected officials generally avoid the political
vulnerability that a public debate with the police administration would
engender.
64
•
4. Manufacturer -imposed bias. Automobile manufacturers and
their dealers impose a barrier to police use of smaller cars. Dealers pre
fer to sell full-s'ize cars to police for the same reason they prefer to sell
them to the general public - they are more profitable. Consequently, avail
able alternatives to standard-size cars are not greatly emphasized. On the
other hand, unless the manufacturer provides a durable smaller car with a
"police package " and appropriate other options, police agencies are re
stricted to using larger cars. Until recently, automobile manufacturers
offered a "police package ll primarily on standard-size vehicles. One result
of this product-restricting practice is that police-car users have largely
accepted the currently manufactured standard-size vehicle as the basic
police car.
From the manufacturer's point of view, it is clear that there is
no large incentive to bear the risk of developing spC)cialized police car fea
tures for smaller-size vehicles. Unless an aggregated police car market
is developed, a major development expenditure cannot be justified.
As a group, automobile suppliers have not voluntarily discussed
the utility of smaller cars with the police. Moreover, they have in the past
discouraged the use of smaller cars through longer delivery schedules and
frequently no cost savings.
5. Means for changing the attitude. There is, as a result of the
existing energy crisis, a national trend toward smaller cars. This trend
will undoubtedly also occur within the police community. A normal police
65
transition to smaller vehicles can be accepted, or if desired, this transitioil
can be accelerated by providing encouragement at both the user and supplier
levels. The steps involved to provide this encouragement can be identified,
a.nd how rapidly the smaller car adoption process is accelerated depends
upon how many of these steps are implemented. A central focal point to
identify and coordinate any accelerating activities would be required.
One of the more important steps involved in accelerating police
agency use of smaller cars would be an activity to change existing small car
bias. Any strategy on this issue should include as its objectives the follow
ing four items:
• Upgrading user knowledge
• • •
Influencing the procurement process
Increasing the market size
Assuring compatibility with auxiliary equipment
a. Upgrading user knowledge. The process of upgrading user
knowledge involves both improving the dissemination of available info:;:omation,
as well as providing technical assistance to those agencies who desire it.
Specific action to achieve these objectives include the following:
1. Improving information dissemination
a. Obtain complete information on available
smaller cars.
b. Conduct seminars and conferences on
suitability of smaller cars for police use .
66
..
c. Document currently available experience
with intermediate and compact cars by
police agencies and recommend how to
improve utility.
d. Prepare, disseminate, and maintain
vehicle procurement specifications proven
to be suitable for police operations.
2. Technical assistance
a. Conduct a study of the vehicle needs of
rural, suburban, urban, and state police
agencies.
b. Conduct tests in two phases of available
• candidates for use as smaller police
cars. The first phase should involve
assessment of performance and handling,
and the second phase should involve field
tests with representative user agencies.
c. Provide on-site technical support to
agencies seeking assistance in defining
their vehicle needs and preparing their
vehicle procurement specifications.
d. Promote development of a strong tech-
nical capability on vehicle use and opera-
tion within the larger police jurisdictions.
67
,~
\
\ '
e. Financially encourage the knowledgable
larger agencies to provide technical
assistance to their smaller neighboring
police agencies.
b. Influencing the procurement process. Important steps can
be taken to eliminate the bias in the procurement proces s and to encourage
a more effective approach to the fragmented procurement by the smaller
police jurisdictions:
1. Provide an effective public relations program
for stressing smaller car suitability to both
elected officials and the general public .
2. Encourage multi-jurisdictional purchasing
procedures through a combined purchase order
for similar (or identical) equipment.
c. Increasing the market size. Unless vehicle equipment
that meets us er requirements is available, little can be done to foster a
broader adoption of smaller cars. The manufacturers have already pro
vided some intermediate-size cars that meet police agency needs. How-
ever, little has been done to date to provide a compact car that can replace
a significant number of either the standard or intermediate-size cars now in
use. Clearly, the availability of candi<;late compact cars that satisfy police
requirements must be improved. To achieve this end, manufacturers must
68
•
be induced to recognize both the need and the market potential that smaller
police cars represent. Action to achieve these objectives includes:
1. Identify deficiencies of currently available
smaller vehicles and recommend changes and
improvements to the manufacturers in order
to broaden their acceptability and utility.
2. Provide incentives for the manufacturer (sub-
sidies, tax, etc.) to improve the suitability of
smaller cars for police agency use.
3. Aggregate the police car market to increase
the size of individual purchase orders. The
deSign and production of a special car for
police agency use might be considered but
would undoubtedly require a manufacturing
subsidy similar to that involved in the pro
curement of military hardware.
d. Compatibility with auxiliary equipment. Auxiliary equip-
ment installed in many police cars, such as radios, lights, sirens and public
address speaker, as well as accident and other kits carried for emergency
use, can outlast the life of the vehicle. In certain cases, it is economically
necessary to transfer such equipment from the car being retired to the new
car with which it is being replaced. It is obviously prudent to facilitate the
69
transfer of such auxiliary equipment to smaller cars if favorable
consideration of smaller cars is desired. Appropriate steps include:
1.
2.
Technical assist;ance to individual jurisdic
tions for the adaptation of the exis ting aUXiliary
equipment inventory.
Subsidizing equipment replacement or modifi
cation where an incompatibility with smaller
cars exists.
3. Sponsor development of modular small-car
4.
equipment packages.
Require that all equipment purchased or being
developed with federal funds include smaller
car compatibility considerations.
70
•
•
•
e-
•
CHAPTER III. CONCLUSIONS
In general, the dissemination among police agencies of information on
police vehicle performance, test evaluation, operating experience, and mainte
nance technique is very limited. Thus, a necessary prerequisite to any police
agency fuel savings program such as might be derived from the findings of this
study are an effective information exchange and a source for expert technical
data.
Numerous specific conclusions were reached on. the feasibility of and
techniques for reducing police fuel consumption. They have been combined
into three separate categories and are presented in the paragraphs that follow.
A. General
1. The total fuel consumption of the entire police agency fleet is
about 10/0 of the nation's passenger car fuel consumption. Thus,
any anticipated benefit by reducing police fuel consumption will
be a very small part of the needed total reduction in petroleum
energy consumption.
2. A fallout benefit, which could well exceed the direct police fuel
saving, is the large saving that could result if other automobile
operators were to a.dopt any steps demonstrated by police
agencies as effective fuel-saving measures.
3. Short of reducing the total number of miles driven, there is
no single step that can be readily taken to provide a significant
saving in police vehicle petroleum consumption .
71
B.
4. Several separate steps, each of which is feasible and
contributes a small fuel saving, can be combined to provide
a reduction in fuel consumption of up to 400/0.
Use of Smaller Cars
1.
2.
3.
4.
The intermediate-size car is currently available with the
durability and special provisions needed for police patrol use.
It is estimated that intermediate - size car s have a potential
application of nearly 400/0 of the national police fleet compared
with the 250/0 that they currently represent.
Compact-size cars equipped with the necessary provisions for
police patrol use are not currently available. Such cars have
some nonpatrol use anel C:"Li-.!"~ntly represent 3% of the national
police fleet. Properly mo..iified and equipped, the compact- size
car has a total potential application of nearly 30% of the national
police fleet.
Although technically feasible, the full benefit from greater use
of smaller police cars would not occur ir~'1r.n~diately. It could
take 3 to 5 years for a turnover of the entire police fleet to smaller
cars, assuming the availability of a compact- size car for police
patrol \.se in 2 to 3 years.
The adoption of a smaller police car (an intermediate where a
standard-size car is nOW used, or a compact to replace
72
•
e-
C.
5.
-----------------~ .. ,.-
currently deployed intermediates) would result in a 10% fuel
savi'ng per car.
Barriers to wider police l.lSe of smaller cars are introduced by
the police vehicle procurement process itself as well as by the
negative image of smaller vehicles held by participants in that
process.
Other Fuel-Saving Procedure~
1. Driving techniques. There are specific driving techniques that
offer a direct means of lowering fuel consumption that are applicable to any
size of car. Eliminating fast starts and m.aintaining :.i steady gas -pedal
pressure can combine to improve fuel mileage as nlUch as 20% in individual
cases. By apportioning these techniques to those agencies and types of patrol
to which each is applicable, it is estimated that a national police fuel savings
of up to 11 % is pos sible.
2. Patrol operations. Changing the driving cycle and the patrol
strategy also off~l's a direct Beans of reducing fuel consumption. Imposing
a 120/0 idle period during urban patrol reduces mileage up to 2 mpg, while
lowering highway patrol cruise speed !by 5 mph irnproves mileage by 1 mpg.
Judicious planning of patrol deployment aTjd 'strategy offers a means for
reducing the total miles driven without necessarily compromising police
services. Collectively, it is estimated these techniques could save up to
10% of the pres ent fuel consumed.
73
3. Improved maintenance. Effective automobile maintenance that
emphasizes the goal of fuel economy, as well as performance and service, is
still another approach. A revision of some procedures and their frequency
can yield an additional savings of up to 5%.
4. Optional equipment. The judicious select.ion of options available
and restriction of unnecessary power-consuming accessories can lead to some
fuel savings. These options and a minor reduction in use of power -consuming
accessories are estimated to provide a potential fuel savings of up to 9% •
. '
,I
74
•
•
e' CHAPTER IV. RECOMMENDATIONS t::..
There are munerous individual steps that will contribute to an effective
police fuel conservation program. In all cases, these steps must be taken at
the local operating level. It is, however, appropriate that the Law Enforce-
ment Assistance Administration not only identify the means for reducing
petroleum fuel consumption, but also disseminate the information and promul-
gate recommendations for implementation as well. A detailed plan, suggested
for sponsorship by the Law Enforcement Assistance Administration and includ-
ing schedules and estimated costs, is presented separately in Volume 11.
In summary, it is recommended that the Law Enforcement Assistance
3.
4.
5.
Admifistration undertake steps necessary to:
i. Provide at the local police agency level an awareness of fuel-
economy measures that can be immediately implemented with
6.
the existing vehicle fleet.
2. Foster an awarenes s of the utility and encourage the availability
and adoption of the smaller police vehicles.
3. Provide technical assistance to evaluate local police vehicle
requirements and to identify available automobi.le models that
satisfy these needs.
The procedures for implementing these steps should include:
1. A driver training program that emphasizes fuel economy, as
well as the capability of smaller cars .
• 75
A national test and evaluation center to assess the performance ,
ro cars and safety. and handllng characteristics of candidate pat 1
to identify for manufacturer action required vehicl ' . . e lmprovement.
Studies to establish police vehicle . requirements, to define appro
priate vehicle specifications. and to identify desired design changes
in existing vehicles and equipment.
Establishment of a police vehicle informatl' on clearing house and
dissemination center for dealing with technical inqul'rl'es concern-
ing vehicle selection and for widely dist 'b t' , rl U lUg pertlnent operating
and maintenance information as it becomes available through user
experience ~
Guidelines and training for maintenance
fuel economy.
personnel that emphasize
A public relations program to ensure an awareness of available
au 0 ue consumption both among methods for readily reducing t f 1
munl y as well as among drivers of passenger the police com 't
cars.
76
REFERENCES
1. E. D. Bunten and P. A. Klaus, LEAA Police Equipment Survey,
National Bureau of Standards Report 73216, Draft dated 9 July 1973.
2. Energy Statistics, Department of Transportation Report No.
DOT-TSC-OST-73-34, September 1973.
3. G. R. Wynne, Police Transportation Management, Coda Publications,
1965.
4. Report on Police, National Advisory Commission on Criminal Justice
Standards and Goals, 23 January 1973.
5. Automobile Fuel Economy, Motor Vehicle Manufacturers Association,
21 September 1973.
6. R. T. Ruegg, Police Vehicle Life Cycle Costing of Police Patrol
Cars - Efficiency in Vehicle Acquisition, Operation, and Disposition,
National Bur eau of Standards, Draft dated October 1973.
7. S. Halpern, Patrol Vehicle Emission Control, The Mitre Corporation
Problem Identification Report 2/053/2006/13/01/6/76, 16 July 1973.
8. Initial Results for 1973 Models Com.pared to 1972 Models, Highway
Loss Data Institute, Septem.ber 1973.
9. OIDay, Colom.b, and Cooley, A Statistical Description of Large and
Sm.all Car Involvem.ent in Accidents, HIT Lab.Report, Vols.3 and 9,
Univ. of Michigan, Highway Safety Re search Institute, May 1973.
-- 77
BIBLIOGRAPHY
. E Environm.ental Protection Agency, !! Report on Autom.obil~ Fuel conomy,
Washington, D.C., October 1973.
Autin, T. C., and K. H. Hellman, Passenger Car Fuel Economy - Trends
Factors, P aper No. 730790, Society of Automotive ~a~n~d~I~n~f~lu~e~n~c~in~g __ ~ __ __
Engineers, Milwaukee, Wisconsin, 10-13 September 1973.
J d D J Gasser Energy and the Automobile - General Huebner, G. 0, an . ~ , -
Factors Affecting Vehicle Fuel Consumption, Paper No. 730518,
Society of Automotive Engineers~ Inc., SP-383, July 1973.
L d J E Ullman Are We Running Out of Gas?, Department Liston, L. ., an ., ,
of Transportation Publication, 1973.
d· H G Study of the Police Patrol Vehicle, Wayne State University,
Lu Wlg, ." _
197 o.
G., The Ownership of Police Vehicles, The Mitre Corporation, Ludwig, H. -
V · .' Draft dated 16 November 1973. McClean, lrglnla,
S International Association of Morton, Jan P., -Police Automotive Fuel urvey,
Chiefs of Police, July 1973.
The Aerospace Corporation, El Segundo, Weight Trends of Passenger Vehicles,
California, to be published.
79
•
•
e-APPENDIX A. CONTACTS ESTABLISHED DURING STUDY
1. A. D. Little, Inc., Survey
a. State Police Agencies
Alabama
Florida
Georgia
Illinois
Massachusetts
Missouri
Pennsylvania
Texas
Virginia
Washington
b. County Police Agencies
Charles County, Maryland
c.
Los Angeles County, California
St. Louis County, Missouri
Large City Police Departments
Atlanta, Georgia El Paso, Texas
Baltimore, Maryland
Boston, Mas sachusetts
Cincinnati, Ohio
Cohunbus, Ohio
Dallas, Texas
Memphis, Tennessee
Oklahoma City, Oklahoma
Seattle, Wasington
Tucson, Arizona
Washington, D. C.
d. Medium City Police Departments
Des Moines, Iowa
Durham, North Carolina
Orlando, Florida
A-1
Richmond, Virginia
Salt Lake City, Utah
2.
e. Srn.all City Police Departrn.ents
Anniston, Alabarn.a
Bradford, Pennsylvania
Jacksonville, North Carolina
Joplin, Missouri
Lararn.ie t Wyorn.ing
Paris, Texas
Winter Park, Florida
Other Contacts
a.
b.
c.
State Police Agencies
Arizona
Arkansas
California
Colorado
County Police Agencies
Orange County, Florida
Cook County, Illinois
Connecticut
Michigan
New Mexico
New York
Prince Georges County, Maryland
Charles County, Maryland
Arlington County, Virginia
l;::~ependence County, Mis souri
Jackson County, Missouri
King County, Washington
Wayne County, Michigan
City Police Departrn.ents
Austin, Texas
Arkadelphia, Arkansas
Bed!ord, Ohio
Charleston, South Carolina
A-2
Chicago, Illinois
Denver, Colorado
Detroit, Michigan
Fredericksburg, Virginia
e-
d.
e-- e.
f.
,
Harrisburg, Pennsylvania
Hartford, Connecticut
Houston, Texas
Little Rock, Arkansas
Los Angeles, California
New Orleans, Louisiana
New York, New York
Philadelphia, Pennsylvania
Pocatello, Idaho
Portland, Oregon
Provo, Utah
San Francisco, California
St. Louis, Missouri
Wenatchee, Washington
Law Enforcern.ent Planning ~gencies.
Maryland
Seattle
Michigan
Washington, D. C.
Federal Agencies
Connecticut
Arkansas
Little Rock
Texas
National Institute of Law Enforcern.ent and Crirn.inal Justice
National Bureau of Standards
National Highway Traffic Safety Adrn.inistration
Associations
University City Science Center
Pennsylvania Science and Engineering Foundation
National As sodation of Fleet Adrn.inistrator s
National Conference of State Planning Agencies
National Institute of Governrn.ental Purchasing
National Sheriffs' Association
International Association of Chiefs of Police
Insurance Institute for Highway Safety
A-3
g. Automobile Manufacturers
American Motors
Chrysler Corporation
Volkswagen
h. Research Experts
Mitre Corporation
Ford Motor Company
General Motors Corporation
Herbert G. Ludwig, Associate Professor, Wayne State University
M. Radnor, Professor, Northwestern University
R. Iv1ichaels, Associate Professor, Northwestern University
A-4
I
APPENDIX B. POLICE VEHICLE SAMPLE BROCHURE
•
B-1
1974 MONTEGO POLICE PACKAGE
(Package Content Subject To Change)
Model Availability: Montego and Montego MX Two Door Hardtop and Four Door Sedan N/A on Station Wagons
Wheelbase: Four Door Sedan - 118 inch Two Door Hardtop - 114 inch
Engines: Oispl,cement (CI D) (3) Horsepower (SAE Ne., (3) Torque (lbo·lt) (SAE Nod Comprosllon Ratio Fuel Exhaust
Automatic trufl$mlulon H.D. Low Ge.r Lock OUt (A.T: only) Rear Axle Rado •• Lock & Non·Locklng Powor Steering
(5) Power Steering 011 Cooler (7) Power Disc Brake. 11 Inch (H.D. orQIJnlcl (B) Power DI.c Brekes H.O. 11 Inch
(Collf. Pack) Saml Motallle Maximum Handling Paekap"
H.D. Front Sprlnl/l. H.D. Reo,Sprlngl Extra Control Shock Absorbers Front Stabilizer BlI!r H.D. Frame No.4 Body Mount Rssr Stabilizer Bar
Maximum Cooling Package Radiator Fen· Shroud
Coolant Recovery System Parking Brake Warning Light Alternator:
70 Amp 90 Amp Transistorized Voltage Rltgulator
Battery. 77 Amp H.D. S.at:
Front Rear
Intarlor trim· Standard Passenger Car (Cloth or Vinyl)
High Serl .. Sound Package Speed 0 Meter (0 to 140 MPH· 2 MPH Inc.) External Crankcase 011 Cool or Interior Hood Latch R.I ...... Battery Compartment Shield Solid State Ignhlon WhOBI.,
15x6.5 Inch with 5 Inch Bolt Clrcl. Tires:
G78)(15 BSWB.ltod (Non Police' G7Bx15 BSW 4 Ply Nylon Pollee H7Bx15 BSW Belted' (Non Pollc.) H78x15 BSW" Ply Nylon Pollc. HR70l<15 BSW& WSW Radial (Non St.eU
(1) N/A In Callfornl. (2) Electric Fuel Pump In Gal Tank. • Std. (3) Preliminary Ratln!/< (41 3.00 to 1 Rear Axle Mand.tOrl' In California
(1) 250·1 V
B.O:l Regulnr Singlo Man Opt RPO 3.00 OPt N/A Std.
N/A
Std. Std. Std. Std. Std. Std. Std.
Std. N/A Std.
Std. N/A Std. Std.
Std. OPt
Std. Std. Std. N/A Std. N/A N/A
Std.
Std. LPO N/A N/A N/A
(5) power St •• rlng Man OPt with AIC (Cooler Std with all P.S.) (6) Ayailabl. at a delete option I" "au of Semi Metallic (7) H.D. Organic Lining with LaqIG Air Scoo,," & Pollee Boost.r
AVAILABILITY
(1) 302·2V 351·2V (1) 351-4V CJ 400·2V
B.O:l a.O:l B.O:l B.O:l . Regular Regular ROQuJar Regular
Single Single DUol Single RPO Man OPt Man OPt . Man OPt RPO RPO RPO RPO 3.00 (4) 3.25 3.25 (4) 3.25 (5) OPt Man OPt Man Opt Man OPt Std. Std. Std. Std. Std. Sid. (6) LPO Std.
N/A N/A Std, LPO
Std. Sid. Std, Sid. Sid. Std. Std, ·Std. Std •. Std. Std, Std. Std. Std. Std. Sid. Std. Std. Std. SId. Std. Std. Std. Std. Std. Std. Std. Std.
Std. Sid. Std. Std. Std. Std. Std. Std. Std. Std. Std. Std.
SId. Std. Std. Std. OPt OPt OPt Opt Std. Std. Std. SId. Std. Std. Std. Std.
Std. Std. Std. Sid. OPt OPt Opt Opt
SId. Std. Std. Std. Std. Stc'. Std. Std. Std. Std. St(.~. Std. N/A Std. Std. Std. Std. N/A DSO (9) Std. . DSO N/A (101 NIA NIA Std.
Std. Std. Std. Std.
Std, N/A N/A N/A LPO N/A N/A N/A N/A SId. N/A N/A N/A LPO Std. Std. N/A LPO LPO LPO
(B) H.D. Semi Matsilic Lining with Large Air Scoop, & Pollee BOQuer nec .... ry to pasl LOl Angel •• Police Te .. (9) Battery H."t ShIeld Std. on Illl 46()4V • Std. on 351-4\1 CJ with A/C Only (Otherwise DSO) (10) Stand.rd Callfor~l. only
NOTE: Air Conditioning N/A with 250 Engine H.D. Rubber I'loor Mall optlonellt Extra COlt Carpe .. Std. on Montego .nd Montego MX
RPO Man Opt Std.
B-2
- Regular Production Option - Requlrad Mandatory Option - Standard' I neluded In Package
460·4V III (2) 4604V P.1.
B.O,1 8.S'1 Regular Regular Ou.1 Dual Man OPt Man OPt RPO RPO (413.25 3.00 Man OPt Man Opt Std. Std. (6) LPO (61 LPO
Sid. Sid.
Std. Std. Std. Std. Std. Std. Std. Std. Std. Std. Sid. Std. Std. Std.
Std. Std. Std. SId. Std. Std •
Std. N/A OPt SId. Std. Std. Sid. Std.
Std. Std. OPt OPt
f-td. Std. Std. Std. Std. Std.
Std. Std. Std. Std. Std • Std. Std.
Std. Std.
N/A N/A N/A N/A N/A N/A Std. Std. LPO LPO
OPt LPO DSO N/A
Option - Limited Production Option - Spec'.' Ordsr - Not Available
!'i:.:f. ilF
'f
e-
1974 MERCURY POLICE PACKAGE
(Package Content Subject To Change)
Model Availability: Monterey, Monterey Custom, Marquis Two Door Hardtop and Four Door Sedan and Monterey, Marquis Station Wagon
AVAILABILITY
Englno" IH 400·2V 460·4V Dlsplacem.nt (CIO) (3) Horsepower @I RPM (SAE N.t) (3) Torque (IIn·ft) (\0 RPM (SAE N.t) B.O:l B.O:l Compresston Ratio Rogular RBgu~er
Fuol Single Singi' E)(hau'l Std. Std. Automotlc n.nsmllSloo (H.D. 460· P.I. only)
(4) 3.25 (4) 3.25 R.ar A~I. Rotlos (Locking & Non Locking)
Std. Std. Alteroolor 90 Amp W/WO A.C. Std. Std. Transistorized Volt.ge Rogulotor & Solid St.to Ignition
Std. Std. Bott.rv BO Amp
arakel: Std. IS) LPO Power Disc (H.D. OrganIc) OSO Std. Power Olsc • H.D. C.lif. Packag. (semi M.talllc)
Moxlrr',m Handling Pock ago Std. Std. Extra 1-i.D. Fron\ Spdngs Std. Std. Extra H.D. Reor spring. Std. Std. H.D. Front & Aoar Shock Ablorbers
Std. Std. H.D. Front & Roo' Stoblllze, ear Std. Std. H.D. R.ar tr.ck Ber & Uppor Arm Bushings
Std. Std. H.D. Front Strut Bushln\;S Std. Std. H.D. Front Upp.r Susp.nslon Arm Bushings
Std. Std. H.D. !'ront Spindle< Std. Std. H.O. Frame Std. Sid.
Automatic Parking Brok. R.I ..... Std. Std. Speed 0 Metor 0 to 140 MPH (2 MPH Inc,.ments) Maximum Cootlng Packaoe: Std. Std.
(7 Bledo Flax Fen· Extre Cep. R.dl.tor • Shroud) Std. Std.
(61 Front S •• t H.D. Std. Std. Interior Hood Latch RelealCl Std. Std. f\emoto EI.etrle Dock Lid R.I ..... Std. Std. Powe, St •• rlng With 011 Cool.r (7) Std. Std. (71 B.nory Comportment Shlold Std. Std. Cloled COdlant Recovery SYltsm Std. Std. Single Kev Locking SVIt.m Engln. Cr.nke_ Oil cooler (Extorn.1) LPO LPO Low G •• r Lock Out (AutO tr.nl) Std. Std. H.P. FI .. har Unit std. Std. Wheel. (H.D. 15x6.5 Inch)
Tlr"' Std. Std. J7Bx16 BSW 4 Ply Pollee Nylon (BIOI PlY)
I.PO LPO JR7Bx16 BSW Pollc. R.dl.1 (Non Sto.1)
LPO LPO JR70x15 BSW & WSW police Redl.1 (Non Sto.n
Std. Std. LR7Bx15 BSW· e P .... St.tlon W.gon
Std. Std. J7B.15 BSW· 6 P .... St.tlon Wegon
(II N/A 00 Marquis N I C IIfornl. (2) Electric Fu.1 Pump In tonk. 460 P.1. N/A on Marquis and st.tlon Wagon.' /A n •
(3) Prellmln.ry Ratlngo (4) 3.00 to 1 R.or Axl. M.nd.tory In Callfornl. (5) Av.llable a. a delate option In lieu ot Semi Metallic Lining (6) H.D. S •• t N/A on M.rqul. (7) Batterv He.t Shield Std. on 460 .nd 460 P.I. W/WO A.C .• Std. on 400 with A.C.
Wheelb ...
NOTE~
Soden, 124 Inch Wegon. 121 Inch
Montorov CUltom Sound PlckegO Standord on aU Monteroy. H .. VV DutY Rubbor Floor Moll Optlon.1 ot Extra Coot
B-3
std. N/A LPO DSO
Included In Pocklge Not AVIU.blt Limited Production Option Sp.clol Ord.r
(2) 460-4V P.I.
a.B:l Regul.r Dual Std. 3.00 Std. std. Std.
(5) LPO Std.
Std. Std. Std. Std. Std. Std. Std. Std. Std. Std. Std.
Std. Std. Std. Std. Std. Std. Std. Std. Std. LPO Std. Std.
Std. LPO LPO N/A N/A
-
SPECIAL EQUIPMENT OPTIONS
Outlined below is a list of some of the equipment that may be available on a special order basis. Because of engineering and prOCIHement lead time, firm delivery dates cannot be quoted without prior approval of the Special Order Section of the General Sales Office.
Spotlights Single Key Locking System Radio Shielding Load Levelers Special Paint Hand Throttle Control Engine Block Heater Ammeter Oil Pressure Gauge Water Temperature Gauge Roof lights Additional Dome Light Roof Wiring Roof Reinforcement Radio Antenna Cable
TIRE AVAILABIL!TY
Radio Wiring Conduit Radio Speaker Electric Deck Lid Opener Manual Deck Lid Opener Tinted Windshield Siren Mounting Platform Siren & Roof Light Wiring and Switches Vascar Split Cable Pull Cord for Routing Radio Antenna Sirens Zippered Headliner Magnetic Drain Plugs H.D. Rear Seat H.D. Floor Mats
Because of the many makes, sizes and types of tires available in the tire industry it is not possible for the LincolnMercury Division to list every tire approved or not approved for Law Enforcement use. Customers frequently request specific tires by size, make and type. Dealers should not commit to availability and prices on these requests until the local District Sales Office has confirmed by wire or telephone firm prices ,,,,d availability dates. Information should be secured by forwarding an inquiry by wire to the Special Order Section, Lincoln·Mercury Division, Dearborn. Prices and availability on specific tires should not be quoted without prior approval of the Special Order Section or Leasing and Fleet Sales Department.
The above are some of the items which afe frequently requested. Other items may be available. To determine availability and pricing, a special inquiry on each item desired must be forwarded through the District Sales Office, Special Order Section. Dealers and District Sales Offices cannot quote prices and delivery dates on Special Order items without confirmation of the Special Order Section.
All vehicles are designed and engineered to meet the Federal Motor Vehicle Safety Standards. Therefore requests for modifications which involve the basic vehicle, safety systems and lighting cannot be accomplished by the manufacturer or dealer.
Lincoln·Mercury Division leasing Gnd Fleet Sales Department
3000 Schaefer Road Dearborn, Michigan 4B121
Telephone: 313/322·6182
The Informallon and sp.ellleatlons Ineludod In this cot. log were In eff.et at the tim. the material was approved for publicatlQn, and are subject to change without notice or liability th~refor .. The Ford Marke.ttng. Corporation, whose polley Is ono of continuous lmprov6m.nt, reserves the right to ct'lange or discontinue models ,at any time without Incurring any obligation whatsoever.
B-4
·-e APPENDIX C. SMALL CAR SAFETY
The issue of occupant safety with small cars necessarily involves the
use that such cars are given as well as their design and human factors
considerations. Although smaller -than- standard size cars can be equipped
with sufficient power to permit operation at the same acceleration and top
speed levels as standard cars, the absolute level of performance desired is . a matter of departmental policy. Police strategies that do not expose the
driver to the dangers of very high speed chase may be utilized, or alterna
tively, the functions for which cars are used may be established by their
size.
Among the elements involved in assessing vehicle safety are such
items as crash deceleration levels, occupant compartment size, occupant
restraint systems, side rail and roof supports, maneuverability, and stopping
distance. Some of these considerations favor the large standard-size car,
whereas others favor a small car. Operational experience is probably the
best way of quantitatively assessing their influence on and difference with
car size.
A summary of accident data obtained from several police agencies is
given in Table C -1. The lowest accident rate was reported by a metropolitan
police agency using inte rmediate-size car s (Los Angeles). It should be noted
that car size is not the sole factor that involves fleet miles driven per accident.
Operating conditions such as traffic density, number of inter sections per mile
C-1
Table C-1. Exam.ples of Police Agency Accident Experience
Department Number Total
Accidents Miles per of Cars Miles Accident
State
New York 1620 28 M 209 134,000 California 2313 118M 689 172,000 New Jersey 1025 195 M 216 90,000
Metropolitan
Philadelphia 1366 29 M 1199 24,000 Kansas City 355 11 M 480 23,000 Los Angeles a 1960 29 M 727 39,000
aIntermediate-size cars, all other full-size.
travelled, defensive driving habits, and extent of driver training are also
contributing factors. A more complete analysis of the data is recommended
before any conclusion concerning the relation between police car size and
accident frequency is reached.
Accident information onnonpolice passenger vehicles, Table C-2, shows
an opposite trend. There is a distinct increase in accident claims per
100 automobiles between standard-size cars and intermediate and compact-
size cars. There is another significant increase with subcompact-size cars.
Some experts explain the increase in accident rate as car size is reduced by
the young average age of the driver of such cars and the use that such cars
are given. Additional analysis of such nonpolice accident data is also
reco:rn:rnended.
C-2
Table C-2. Passenger Car Accident Data U
Subcompact Rate b Compact Rate b
Pinto station wagon 10.9 Dart 7.8 Volkswagen 11.2 Valiant 10.7 Pinto 12.3 Nova 8.9 Gremlin 12.6 Hornet 10.7 Vega 12.6 Maverick 2 dr 12.2 -- --
Average 11.9 Average 10. 1
Intermediate Full Size
Century 8.4 Catalina 7.7 Monte Carlo 10.7 Caprice 7.4 Chevelle 9.5 Impala 8.4 Torino 11.8 Delta 88 7.4 Cutlass ~ Ford LTD 2.:..!
Average 10.0 Average 8. 1
a From. Reference 8.
bRate is expressed in claims per 100 insured vehicle years.
An evaluation of the risk of injury to occupants of small cars is reported in
Reference 9. It was concluded that injuries are more likely with small car s.
Once involved in an accident, the chance of injury to the occupants of the car
increased about 2.5% for each decrease of 100 lb in car weight. In head-on
collisions, for example, injury occurred to small car occupants about 44% of
the time in small-to- small or small-to-large car accidents. On the other
C-3
hand, injury in similar collisions occurred to large car occupants only about
35% of the tirne for large-to-large or large-to- small car accidents. Infor
mation on the degree of injury was not available. These data include few
~ost-197 0 small American cars and define a small car as weighing 3100 lb
or les s. An analysis of more recent injury data is also recommended.
C-4
APPENDIX D. CALCULATION OF ACCUMULATED BENEFITS
The following methods and assUInptions were used in calculating the
estimated maximum fuel savings that could be achieved by means of each of
the methods identified in Chapter II, Section D7.
1. Driving Techniques
The conditions under which improved driving techniques can
be employed are related to the type of agency patrol. It was
rationalized that the avoidance of fast starts was applicable to
all urban agencies, that the maintenance of a steady cruis e speed
was applicable to all state agencies, and that although both are
applicable to rural/ county agencies, the latter is the major
source of a potential fuel saving. The benefits obtained from
each technique have been discussed in Chapter II, Section D7 (see
Table 4). By using an average of 10 mpg and the information
from Table 4, a percentage improvement in fuel economy was
derived. In order to estimate the national savings, this value
m.ust be weighted by the percentage of the national fleet to which
it applies. These weighting factors were derived from the infor
mation given in Table 2. The total national savings determined in
this manner are given in Table D-1.
D-1
2.
Table D-1. Gas Savings from Driving Techniques
Improved Total
Technique Type of Fuel Fleet, Savings,
Agency EconOlny, % 0/0
%
Slow start Urban 20 10 2
Steady cruise State 10 20 2
Both Rural/ county 10 70 7 -Total 11 %
~-
Patrol Operation s
A large part of many patrols are spent in "joy riding" to
maintain police visibility. It is also not uncommon to spend con-
siderable time, approximately 12% (about 1 hour per 8-hour sbft)
at engine idle. It is believed that both practices can be changed
significantly without affecting the goals or s ervic,es of patrol.
Perhaps of most importance is the lack of any guidelines being
provided to patrol officers for improving the efficiency of their
beat coverage. An accurate estimate of the degree of improve
ment that can be achieved can only be provided by further study
and simulation of patrol strategies and operations. as has been
recommended in this report. However, based on agencies con-
tacted in the survey conducted for this study and on availabli'!
literature on patrol administration, it is estimated that savings
D-2
3.
of from 10 to 30% could be obtained. For example, if idle time
were reduced by half for 40% of the fleet, i. e., urban and sub-
urban, a national fuel savings of 4% would result. Combihing
this value with a conservatively estimated reduction in patrol
mileage of 6% yields a total fuel saving of 10%.
Optional Equipment
The estimate for savings in this cat.c!gory used the same
rationale developed above for that of driver techniques. The
benefits from the allocation of dual exhausts to the national fleet
are shown in Table D-2. This technique is not useful for urban,
slower speed driving. Thus, it is assumed that this equipment
is installed on 50% of the state, rural, and county agency cars.
The resultant national fuel saving is 4.5%. It is estimated that
the same amount could result from the use of a cooling system
clutch-fan (or similar device). Such a device reduces the power
used for fan operation when maximum cooling is not required.
Further, minor adjustments in the use of power-consuming
acces sories such as air conditioning would yield additional small
savings. The collective savings for optional equipment are esti-
mated to be 9%.
Table D-2. Savings from the Use of Dual Exhausts
Type of Improved Fuel Total Modified, % Savings,
Agency EcononlY, % Fleet, % %
State 10 20 50 1
County 10 70 50 3.5
Total 4.5%
D-3
4. Improved Maintenance
It is difficult to estimate the benefit that could be obtained
by this means because the quality of the present agency mainte-
nance procedures on a national scale is unknown. It is reason-
able to assume that not all are excellent, and that there is room
for improvement. Further, the prime goal of present procedures
is performance rather than economy. For purposes of this study,
it is estimated that a fuel savings of up to 5% could be achieved.
D-4
--.------.
- '."