presented to: purdue university extension 11 april 2013 presented by: fda cfsan produce safety staff...
TRANSCRIPT
Presented To:
Purdue University Extension
11 April 2013
Presented By:
FDA CFSAN Produce Safety Staff
FDA Office of Regulatory Affairs
FDA Coordinated Outbreak Response and Evaluation Network
FDA Overview of FSMA’s Proposed Produce Safety Rule and
Chamberlain Farms Environmental Assessment
Outline
• FSMA• Environmental Assessment (EA) – Background• EA – Epidemiology• EA – Assessment• Conclusions• Select Recommendations• Questions and Answers
US Food and Drug Administration
Part 1: Food Safety Modernization Act
Part 2: Environmental Assessment:Factors Potentially Contributing to the
Contamination of Fresh Whole Cantaloupe Implicated in a Multi-State
Outbreak of Salmonellosis
FSMA
• Produce Safety Standards - Published Jan. 2013
• Preventive Controls for Human Food - Published Jan. 2013
• Foreign Supplier Verification Program• Preventive Controls for Animal Food• Accredited Third Party Certification
Five Proposed Rules EstablishFood Safety Framework
FSMA
Produce Rule: Key Principles
• Flexible across the diversity of production• Considers risk posed by practices,
conditions, and commodities• Science- and Risk-based
– Identified routes of microbial contamination – Excludes “rarely consumed raw” and produce to be
commercially processed with a “kill-step”
FSMA
Qualitative Assessment of Risk Reflects Science Behind Produce
Rule• Draft qualitative assessment of risk helps to
inform proposed rule• Provides a scientific evaluation of potential
adverse health effects resulting from human exposure to hazards in produce
• Available for public comment as part of the proposed rule
FSMA
Standards for Produce SafetyFocus on 5 identified routes of microbial contamination:
1. Agricultural water2. Biological soil amendments of animal origin3. Worker health and hygiene4. Equipment, tools, buildings and sanitation5. Domesticated and wild animals
Additional requirements for:• Sprouts• Growing, harvesting, packing and holding
• Web site: http://www.fda.gov/fsma • Subscription feature available• Official site: http://www.regulations.gov
More Information Available
EA -
Background
Environmental Assessment conducted at Chamberlain Farms:
Background and Epidemiology
EA -
Background
• In August 2012, the Food and Drug Administration (FDA), the Centers for Disease Control and Prevention (CDC), and state and local health departments began to investigate a multi-state outbreak of salmonellosis.
Background
EA -
Background
Graphic Credit: http://www.ledc.org/where.html
• Cantaloupes from Chamberlain Farms, located in the southwest region of Indiana were implicated based upon:– Epidemiological evidence– Product traceback investigation evidence
Background
EA -
Background
* Epidemiology data (and map) as reported by CDC: http://www.cdc.gov/salmonella/typhimurium-cantaloupe-08-12/
• Final case count:– 261 reported cases from 24
states• Two outbreak strains were
identified:– Salmonella Typhimurium: 228
reported cases– Salmonella Newport: 33
reported cases• Illness onset dates:
– 07/06/2012 – 09/16/2012• 94 ill persons hospitalized• Three deaths reported from
Kentucky
Epidemiology*
EA -
Background
Photo Credit: Indiana Department of Health
• Multiple samples were collected, including:– Whole cantaloupe– Environmental (non-product)
from the Packinghouse
• Cantaloupe from the fields were positive for both outbreak strains
• Six of 70 sub-samples from the packinghouse were positive for one of the outbreak strains
• Several deficiencies were noted in the packinghouse including:– Equipment design– Packing and holding
Regulatory InspectionAugust 14-31, 2012
EA -
Background
Decision to Initiate a Second Regulatory Inspection with an Environmental
Assessment
• Decision based upon:– Isolation of one of the outbreak strains in the
packing environment– Isolation of both outbreak strains on whole
cantaloupe collected from production fields and storage
– A positive watermelon field sample
EA -
Assessment
Growing Environment
• Environmental samples– Cantaloupe and watermelon growing fields– Included:
• Soil from each parcel/field• Wild animal excreta• Well water• Pooling water on field perimeters• Drainage ditch water• Cantaloupe
Sample ResultsParcel A• Non-outbreak strains of Salmonella detected in soil and puddle water• Outbreak strain detected in soil
Parcel B• Non-outbreak strains of Salmonella detected in soil, plant root, and drip
tape
Parcel C• Non-outbreak strains of Salmonella detected in soil and animal excreta
Parcel D• Outbreak and Non-outbreak strains of Salmonella detected in soil
EA -
Assessment
Growing EnvironmentField Product
• Non-commercial cantaloupe collected from Parcel D
• One cantaloupe (of 10 collected) was positive for Salmonella.– Although still pathogenic, it was not one of
the two outbreak strains.
EA -
Background
Agricultural Water Wells
• Five wells provided water for irrigation and packinghouse
• One well served a greenhouse used to grow melon seedlings
• The aquifer that serves these wells is approximately 36 feet below the surface
EA -
Assessment
Agricultural Water Wells
• None of the wells tested positive for Salmonella
• Each of the five wells tested positive for enteric bacteria/fecal indicator:– E. coli– Total Coliforms
EA -
Assessment
Scott Ditch
• The ditch is a narrow, shallow, flowing, man-made waterway located in a gulley ~15 feet deep
• Discharges into the Wabash River several miles northwest
• Located ~100 feet from one of the agricultural water wells
• The ditch tested positive for:– Salmonella
• Non-outbreak strain
– Enteric bacteria/fecal indicator:• E. coli• Total Coliform
EA -
Assessment
Packing and Holding
• Factors that may have contributed to the introduction, growth, or spread of Salmonella:– Packinghouse Design– Equipment Design– Packing or Holding Practices
• Note: some of these issues were from the August regulatory inspection and were not observed during the EA
EA -
Assessment
Packinghouse Design
• Packinghouse design allowed for the pooling of water on the packinghouse floor adjacent to equipment
• The packinghouse floor was constructed in a manner that was not amenable to cleaning
EA -
Background
Packinghouse Design
• Harborages existed in the packinghouse structures
• The drip-line of the packinghouse roof extends over the conveyor belt and brush washer
EA -
Assessment
Equipment Design
• Packing equipment not easily cleaned and sanitized– Used porous materials– Likely to have retained microorganisms and
moisture– Brush rollers
• Design flaws similar to equipment previously associated with cantaloupe-related foodborne illness outbreaks
EA -
Assessment
*Cantaloupe line, during August regulatory inspection only. During EA, only positive from watermelon line – separate and not in operation at the time
• Visible product and filth buildup
• Visible signs of corrosion
• Environmental positive for Salmonella*
Equipment Design
EA -
Assessment
Packing and Holding Practices
• No pre-cooling before storing and shipping
• Cantaloupes packed while still moist from washing
EA -
Assessment
• Un-emptied garbage receptacles (pest harborage)
• Inadequate cleaning and sanitizing procedures– Equipment– Wash water disinfectant– Maintained no records of any sanitary procedures
Packing and Holding Practices
EA -
Assessment
Discussion of Findings
• Salmonella on even a few incoming cantaloupe may introduce bacteria – lack of sanitary control measures allow persistence and cross contamination
EA -
Assessment
Discussion of Findings
• Agricultural water sources were negative for Salmonella– Agricultural water used for irrigation, crop protection sprays,
and in the packinghouse were not a likely route for introducing Salmonella.
• Agricultural water may not have been of adequate quality– Cannot be eliminated as a potential contributor in the spread
of Salmonella
EA -
Assessment
Possible Sources and Routes of Contamination
• Biological soil amendments– May have been the source of the pathogen– However, the firm reported no use
• Adjacent or previous land use may have played a role in this (unknown)
• Significant poultry (turkey) production is located in the local region
EA -
Assessment
Possible Sources and Routes of Contamination
• Wells tested negative for Salmonella, but positive for generic E. coli and total coliform– It is unusual to note indicators of fecal
contamination to be recovered from ground water sources
– Possible that Scott Ditch is influencing the aquifer– Some of the wells were poorly constructed – may
have been subject to contamination by run-off, or through subsurface influences
Conclusions
Based on the positive test results from the environmental samples collected from the Chamberlain Farms production fields and packinghouse during two
separate FDA inspections, it is likely that the initial contamination of the melons occurred in the production
fields and was spread by operations and practices within the packinghouse.
It is also likely that the contamination proliferated during storage and transport to market.
Select Recommendations
• Follow good agricultural practices for handling animal manure to reduce the introduction of microbial hazards to produce, such as using properly composted manures
• Assess produce packinghouse and equipment design to ensure adequately cleanable surfaces and eliminate opportunities for introduction, growth, and spread of Salmonella and other pathogens
Select Recommendations
• Assess and minimize opportunities for introduction of Salmonella and other pathogens in packing facilities
• Implement and verify regular cleaning and sanitizing procedures
• Periodically evaluate the processes and equipment used to assure they do not contribute to contamination
Select Recommendations
• Ensure that water is of adequate microbial quality for its intended use.
• Using dump tank water with sufficient disinfectant present and monitor the levels to reduce the potential risk of cross-contamination
Note: The primary purpose of the water disinfectant is not to sanitize melons, but rather to prevent the water from becoming contaminated and acting as a source of contamination for incoming melons
Select Recommendations
• Implement melon handling operations that minimize the incidence of melon surface moisture to reduce potential plant and human pathogen growth
• Cooling and cold storing melons as soon as possible after harvest (if cooled)
Select Recommendations
Growers should further consider the recommendations put forth in FDA’s documents:• Guidance for Industry: Guide to Minimize
Microbial Food Safety Hazards for Fresh Produce and Vegetables; and
• Draft Guidance for Industry: Guide to Minimizing Microbial Food Safety Hazards of Melons
Question: Are the Regional Industry Guidance Documents a suggested source of information beyond FDA’s guidance documents?
Answer: Yes, these documents may contain additional information.
Question: Was there any rodent control observed during the environmental assessment?Answer: No. Monitoring and control of pests is urged.
Question: How were the cantaloupes contaminated in the field?
Answer: There are many possible routes of contamination; no one single route was identified. Pathogen, however, was found in the soil and puddles and on equipment.
Questions and Answers
Question: How often was the dunk tank changed? Use of water temperature and disinfection in reducing risk for water to melon cross-contamination?
Answer: The dunk tank was changed daily at the farm.
Evaluating and monitoring water disinfectant levels is important to ensure that disinfectant is present at levels sufficient to reduce the potential risk of cross-contamination when melon cooling water is re-circulated. If melons are fully submerged in water as a means of cooling, they are more likely to have cooling water infiltrate into the melons and consideration should be given to cooling water quality variables such as pH, soil (including organic) load, turbidity, and product through-put capacity, to ensure that the wash water disinfectant of choice is effective in reducing the potential for water-to-melon cross-contamination.
Questions and Answers
Question: How do I obtain a copy of the Environmental Assessment?
Answer: The environmental assessment is available to the public and is available on the FDA website. (See Slide 47 of this presentation for the link.)
Question: Did the Environmental Assessment include other farms?
Answer: No, the Environmental Assessment was limited to the Chamberlain Farms.
Question: What are the considerations for the water wash of cantaloupes?
Answer: Those considerations are the depth and length of time the fruit is in the wash. Also, soaps should be avoided as surfactants in the soap can lead to uptake of water (and potentially pathogens).
Questions and Answers
Question: Is there any information that can be shared about upcoming nationwide FDA inspection of cantaloupe firms?
Answer: There was a letter from FDA released February 25, 2013 which may be found at:
http://www.fda.gov/AboutFDA/CentersOffices/OfficeofFoods/CFSAN/CFSANFOIAElectronicReadingRoom/ucm341029.htm
In short, the inspections are limited to cantaloupe. They are focused on packing houses and not fields. The FDA will be assessing current practices and identifying insanitary conditions that may affect the safety of cantaloupe to consumers. Finally, outreach to states by FDA will occur regarding timing of inspections.
Questions and Answers
List of Resources
• FDA Guidance Documents for Melons and Fruits/Vegetables:
http://www.fda.gov/Food/GuidanceRegulation/GuidanceDocumentsRegulatoryInformation/ProducePlantProducts/ucm174171.htm• Draft Guidance for Industry: Guide to Minimize Microbial Food Safety Hazards for Fresh Produce and
Vegetables:
http://www.fda.gov/Food/GuidanceRegulation/GuidanceDocumentsRegulatoryInformation/ProducePlantProducts/ucm064574.htm• Form FDA 483-General Observations:
http://www.fda.gov/AboutFDA/CentersOffices/OfficeofFoods/CFSAN/CFSANFOIAElectronicReadingRoom/ucm341029.htm• FDA Environmental Assessment: Factors Potentially Contributing to the Contamination of Fresh Whole
Cantaloupe Implicated in a Multi-State Outbreak of Salmonellosis
http://www.fda.gov/Food/FoodSafety/FoodborneIllness/ucm341476.htm• The letter to industry may be found at:
http://www.fda.gov/AboutFDA/CentersOffices/OfficeofFoods/CFSAN/CFSANFOIAElectronicReadingRoom/ucm341029.htm• FSMA
http://www.fda.gov/fsma• Outbreak Information
http://www.fda.gov/Food/RecallsOutbreaksEmergencies/Outbreaks/ucm272347.htm
http://www.fda.gov/AboutFDA/CentersOffices/OfficeofFoods/CFSAN/WhatWeDo/ucm211758.htm