public transportation is amazing! · archer manufacturing inc. ops® is a federally registered...

ARCHER MANUFACTURING INC.ARCHER MANUFACTURING INC.OPSOPS®® is a FEDERALLY REGISTERED TRADEMARK OF ARCHER MANUFACTURING, INC. is a FEDERALLY REGISTERED TRADEMARK OF ARCHER MANUFACTURING, INC.

Email: [email protected] • Telephone: 800-796-5545Email: [email protected] • Telephone: 800-796-5545

PULL TISSUE

STRAIGHT DOWN

OPS® Soap Dispenser SKU: 1015-01G

OPS® Toilet Tissue DispenserSKU: 1220-01

OPS® High Capacity Paper TowelDispenser

SKU: 1100-01G

PATE

NTED

Your Restrooms Need OPS® Vandal Proof Dispensers

Public Transportation Is Amazing!

But Keeping Passengers Safe Is More Than Getting Them Home

NO MORE BROKEN DISPENSERS NO MORE DISPENSERS RIPPED OFF THE WALL

NO MORE DISPENSERS USED TO CLEAN HEROIN NEEDLES

BULK DISPENSERS ARE A BREEDING GROUND FOR BACTERIA.

https://youtu.be/SW2CpdCe_NY

https://youtu.be/Pl5k9bxs2FI



For Use in the OPS® Vandal Proof Dispenser

SIGNAL WORD: WARNING EYES: IRRITATION INGESTION: NAUSEA

Nonfood CompoundsProgram Listed (E-3)

(Registration #153367)

ARCHER Manufacturing, Inc. • Murrieta, CA [email protected] • 1-800-796-5545

1000ml-Net Made in USA Emergency Tel: 1-800-535-5053

Drug FactsActive Ingredients Purpose Benzalkonium Chloride 0.1% ................................................. Antimicrobial

Uses • For hand sanitizing to decrease bacteria on skin. • Recommended for repeated use.

Warnings For external use only.

When using this product avoid contact with eyes. In case of eye contact, flush eyes with water.

Stop use and ask a doctor if irritation or redness develops, or if condition persists for more than 72 hours.

Keep exposed cartridge out the reach of children. If swallowed, get medical help or contact a Poison Control Center right away.

Directions • Pump a small amount of foam into palm of hands. • Rub hands together briskly until dry.

Inactive Ingredients Water, dihydroxypropyl PEG-5, linoleammonium chloride, glycereth-2 cocoate, behentrimonium chloride, dihydroxyethyl cocamine oxide, fragrance.

Instant Hand SanitizerKills 99.99% of Germs

Alcohol Free, Non-Flammable



Nonfood CompoundsProgram Listed (E-2)

(Registration #153366)

ARCHER Manufacturing, Inc.Murrieta, CA 92562

[email protected] • 1-800-796-5545

Emergency Tel: 1-800-535-5053

1000ml-Net Made in USA

Drug FactsActive Ingredients Purpose Benzalkonium Chloride 0.13% .............................................. Antimicrobial

Uses • For hand washing to decrease bacteria on skin. • Recommended for repeated use.




Keep exposed cartridge out the reach of children. If swallowed, get medical help or contact a Poison Control Center right away.

Directions • Place a small amount of soap onto palm of wet hand or hands. • Rub hands together for 20 seconds. • Rinse with potable water.

Inactive Ingredients Water, coco-glucoside, laurtrimonium chloride, cocamidopropylamine oxide, citric acid.

ANTIBACTERIAL FOAMING SOAP



FOAMING HAND SOAP,BODYWASH & HAIR SHAMPOO

OPS® ECO is a non-toxic, biodegradable, fragrance free Foaming Hand Soap which is recognized by the US EPA's Safer Choice Program.

Emergency Tel: 1-800-535-50531000ml-Net Made in USA

Product FactsUses • This product is for use in a Facility where a "Safer Choice" Product is preferred.

Warnings For external use only. When using this product avoid contact with eyes. In case of eye contact, flush eyes with water. Stop use and ask a doctor if irritation or redness develops, or if condition persists for more than 72 hours. Keep exposed cartridge out the reach of children. If swallowed, get medical help or Contact Poison Control right away.

Directions • Apply foam to wet hands. • Lather and rinse.

Inactive Ingredients Water, Sodium Laureth Sulfate, Sorbitol, Citric Acid.

ARCHER Manufacturing, Inc.Murrieta, CA 92562

[email protected] • 1-800-796-5545



ARCHER Manufacturing, Inc. • Murrieta, CA [email protected] • 1-800-796-5545

HAND, HAIR & BODY WASHWITH HAIR CONDITIONER

EXCELLENT AS A SHAVING FOAM

Product FactsUses • A high foaming cleanser for the entire body.




Keep exposed cartridge out the reach of children. If swallowed, get medical help or Contact Poison Control right away.

Directions • Apply foam to wet hands, skin, or hair. • Lather and rinse.

Inactive Ingredients Water, Sodium Laureth Sulfate, Sodium Lauryl Sulfate, Polyquaternium-7, Sodium Cocoyl Sarcosinate, Sodium C12-15 Alkoxypropyl Iminodipropionate, PEG 75 Lanolin, DMDM Hydantoin, Fragrance, Citric Acid, Green 5, Green 8, Yellow 8.

Emergency Tel: 1-800-535-50531000ml-Net Made in USA

PATE

NTED

LABOR COST SAVINGSCost to replace 1 “free” broken soap dispenser = $100

CASE STUDY – Long Beach School DistrictJohnathan Mendoza – Plant Maintenance Supervisor

“I could tell you that we have just over 7000 soap dispensers and around 25% get vandalized every year. The cost of replacing our broken dispensers is about $100 per dispenser. We have to drive to the school, find the right bathroom, clear it of

children, put up the necessary signage, mop up the spilled soap, take down the old dispenser, throw it away, put up the new dispenser, and document the repair.”

SKU:1015-01G++

Anti-bacterial hand soap.Effective against MRSA

SKU: 1405-02G

Instant Hand SanitizerEffective against MRSA

SKU: 1405-03G

Body wash, shampoo, shave cream, & conditioner

SKU: 1405-04G

Environmentally Friendly Hand Soap

SKU: 1405-05G

oror oror oror

OPS® Vandal PrOOf SOaP diSPenSer



VANDAL PROOF PAPER TOWEL DISPENSERS

OPS® Vandal ProofHigh Capacity Paper

Towel DispenserSKU: 1100-01G

ä Indestructible. äSuicide Resistant.äSecurely Locked. äSecurely Mounted.

OPS® TOWELSä The OPS® paper is a toilet flushable hand towel!

ä Install at any restroom sink!

ä Guests flushing your hand towels down the drain?

Use OPS® Paper Towels! Prevent clogged toilets!

ä 8000 sheets per case!OPS® Towel should be used at sinks only. For a Vandal

Proof toilet paper system, please refer to next page.

Use the OPS® Paper Towel Dispensers both at the sink to dry your hands and at the door so restroom guests do not have to touch the door handle when leaving.

OPS® Paper TowelsSKU: 1260-01G

Can Use Same Key as OPS® Vandal Proof Soap Dispenser

High capacity paper towel dispenser dimensions are 17” (H) 9.2” (W) 4” (D),

holds 1500 sheets



PULL TISSUE

STRAIGHT DOWN

SKU: 1225-01

For use in the OPS® VANDAL PROOF TOILET TISSUE DISPENSERä400 individual sheets per pack ä40 packs per case

ä16,000 SHEETS PER CASE!

OPS® 2-PLY INTERLOCKING TOILET SHEETS

OPS® VANDAL PROOF TOILET TISSUE DISPENSERTHE ONLY VANDAL PROOF TOILET

TISSUE DISPENSER IN THE WORLD!UNBREAKABLE! ANTI-LIGATURE!

NO WEAPON STOCK! NO VANDALISM!

Use for toilet tissue in a bathroom stall.

Use near bathroom door exit so guests can use tissue to open the door.

800 tissue sheet capacity.

Can only dispense 1 sheet at a time (guests cannot rip out 30 sheets to throw on floor or to flood toilet).

Place 2 dispensers side by side to double tissue capacity in high volume area.

OPS® Tissue is safe for septic systems. No cardboard Core to throw out or to be thrown in the toilet.

Unlike roll tissue, only 1 sheet is dispensed at a time: äDramatically slows usage äNo more clogged toilets

äBudget Savings! Less sheets used per use

Dispenser Dimensions: 9.5” Width x 8.9” Tall x 3.1” Deep

(These dispensers work best if installed higher on the partition or wall than normal low security dispensers. So the bottom is about eyelevel when seated.)

SKU: 1220-01



To avoid potential violations of Health and Safety Policy, please estimate how long an area is without soap while each soap dispenser is broken. (The labor cost table below will help calculate your answer.)

Indicate Number Of Minutes Per Activity Listed Below

Labor Cost of Dispenser Replacement - How much time does it take your Maintenance Professional to:

‑Receive a radio call asking him/her to fix the dispenser

‑Complete the necessary work order forms for repair

‑Drive to warehouse and pick up a replacement soap dispenser and cartridge of soap

‑Drive to and park at location with broken soap dispenser

‑Walk to bathroom with broken soap dispenser

‑Clear area of guests around the soap dispenser and wait for them to finish using restroom

‑Remove the broken soap dispenser

‑Put up necessary slip hazard signage

‑Clean up the soap spilling out from the broken soap dispenser and mop up the floor

‑Install the new soap dispenser

‑Throw out the broken soap dispenser

‑Take out the trash

‑Report that the issue has been resolved

‑Total Minutes

‑Total Hours to Replace One Dispenser (DIVIDE TOTAL MINUTES ABOVE BY 60 TO CALCULATE HOURS USED FOR DISPENSER REPLACEMENT.)

OPS® Dispenser Labor Cost Savings

Total Labor Cost of Replacing Just One Soap Dispenser -Multiply the number of hours to replace the broken dispenser by the hourly rate of your maintenance professional.

_____________________ X $ _______________________ = $ _________________________ Hours To Replace Dispenser Maintenance Staff Hourly Pay Rate Labor Cost To Replace One Dispenser

Total Labor Cost of Replacing All Soap Dispensers Each Year -Multiply the labor cost to replace one broken dispenser by the number dispenser per year.

_____________________ X $ _______________________ = $ _________________________ Labor Cost To Replace One Dispenser Number Of Broken Dispensers Per Year Annual Labor Cost For

The Cost to Replace a Vandalized Soap Cartridge is $ ______________

The Cost of a Replacement Soap Dispenser is $ ______________

Consider - Are there areas you do not use soap dispensers due to vandalism issues?Consider - What are the labor costs of broken hand towel and toilet tissue dispensers?

The Average Price of the OPS® Vandal Proof Soap Dispenser is ___________$80.00



$100 labor cost to fix Contaminated soapspreads sickness

It just takes one kick25% of all liquid soap dispensers look like this inside

WE CAN DO BETTER!

- Why our customers chose Vandal Proof -The following are not word for word quotes, but accurate representations of

conversations we’ve had with real customers:

Dear Vandalproof, I represent a large public transportation system in Northern California. Our homeless population is breaking our soap dispensers and using them to form crack pipes. They then steal the soap and wash their clothes. We need something that won’t break. I loved your online video where you hit the dispenser with a stainless steel pipe. Wow that thing is tough! I’m sold.

Dear Vandalproof, I represent 50 parks in Missouri. We use bulk-filled stainless steel soap dispensers. There is a lock on these dispensers, but now I know how flimsy it is. Thank you for visiting our park restrooms and showing me how the lock can be broken with a simple house key. Also, I appreciate you showing me what the inside of our soap dispensers look like. Obviously, finding used toilet paper with fecal matter in one and a nearly a dozen dead crickets in another was not what I was expecting! I appreciate that the OPS® vandal proof soap dispenser is unbreakable, securely locked, and uses a disposable soap cartridge. I’m going to make sure that this never happens again.

Dear Vandalproof, many of our parks are at the beach along California’s coastline. We use plastic soap dispensers that cannot be locked. Heroin addicts are opening the soap dispensers and injecting their needles into our soap cartridges in order to clean them. They are injecting from the top of the cartridge so that the soap does not spill out. Our kids are washing their hands with the remainder. Please, we need something vandal proof and securely locked.

Dear Vandalproof, I represent a large school district and 40% of our soap dispensers are vandalized each year. Our kids light our plastic soap dispensers on fire. Of those that are not broken, when I look inside the dispensers I find gum, pencils, erasers, spit, and urine floating in the soap. I’m glad that the vandal proof soap dispenser is fire proof and securely locked!

Dear Vandalproof, I recently bought a stainless steel soap dispenser for $50, but it came with only 1 mounting hole. Our guests ripped it off the wall within a day. What a waste of $50. I noticed that your vandal proof soap dispenser has 10 mounting holes. No way that’s coming off the wall! Thank you for the help.

https://youtu.be/SW2CpdCe_NY

public transportation is amazing! · archer manufacturing inc. ops® is a federally registered...

Documents