rajasthan co-operative dairy federation ltd., “saras ... · rajasthan co-operative dairy...
Embed Size (px)
TRANSCRIPT
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”, J.L.NEHRU MARG, JAIPUR –302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in & www.eproc.rajasthan.gov.in E-mail : [email protected]
No. RCDF/Proj. /C-4008-III/2015-16/ Dated 30.06.2015
NOTICE INVITING TENDER
e-tenders are invited for the civil works of “Construction of Wire fencing at CFP Pali, C.C. road at CFP Jodhpur and Expansion of FGS at CFP Bikaner, estimated cost Rs. 8.00, 30.00 and 36.00 lac respectively. Date & time of submission of tender is 04.08.2015, up to 5.00 PM. Details can be obtained from our web-site www.sarasmilkfed.rajasthan.gov.in.&: http://eproc.rajasthan.gov.in
Manager (Projects)
NIT IN DETAILS e-tenders are invited from experienced and registered civil contractors of state government/central government/government under taking as per their eligibility norms for the civil works of “Construction of Wire fencing at CFP Pali, C.C. road at CFP Jodhpur and Expansion of FGS at CFP Bikaner, estimated cost Rs. 8.00, 30.00 and 36.00 lac respectively. Date & time of submission of tender is 04.08.2015, up to 5.00 PM. Details can be obtained from our web-site www.sarasmilkfed.rajasthan.gov.in.&: http://eproc.rajasthan.gov.in
Name of work – No. 01 - e-Tender for P/F Barbed Wire fancing work at Cattle
Feed Plant, Hathlai, Pali 1 Estimated cost of construction work - Rs. 8.00 Lac. 2 Earnest money (By D.D. only in favour of RCDF Ltd; Jaipur) - Rs. 16,000/- 3 Tender Fees (By D.D. only in favour of RCDF Ltd; Jaipur) - Rs. 2,000/- 4 Tender Processing Fees (By D.D. only in favour of MD, RISL payable at Jaipur) - Rs. 1,000/- 5 Date & time of downloading of tender – 15.07.2015 9:30 AM to 04.08.2015 5.00 PM 6 Date & time of submission of tender - 15.07.2015 9:30 AM to 04.08.2015 5.00 PM 7 Date & Time of opening of bid – 07.08.2015 11:00 AM 8 Completion period of work - 02 Months 9 Validity of quoted rate in tender - 90 days Note : Tender fees and EMD alongwith processing fees should be deposited in physical form
from 04.08.2015, (5.30) PM to 07.08.2015 upto 10.30 AM in Project Section. For acceptance / rejection of any or all the bids, the decision of MD, RCDF shall be final and binding
CFP, Pali-2015
Important Information
Subject: e-Procurement/tendering system at RCDF
Government of Rajasthan has decided to implement e-procurement system for their departments and PSU to enhance efficiency & transparency in public procurement from April 2012, in which all purchases/ works/ services etc. will be processed electronically through State e-procurement portal i.e. www.eproc.rajasthan.gov.in.
Accordingly at RCDF, the existing process of manually submitting bids will be discontinued. Information regarding tenders will be posted on the above mentioned website & bids will also be accepted via the website. A registered user with a valid Digital Signature Certificate (DSC) will be able to access the website, view & download tender details, fill in tender bids & upload (send) to the website. At the scheduled time of tender opening, details of all bids can be viewed by the bidders.
Requirement for participating: Internet access (details available on the home page of website www.eproc.rajasthan.gov.in), DSC & registration on the website.
Bidders will need to get a class III digital certificate with encryption – decryption facility through controller of certifying authorities (CCA) approved certifying agencies. Information regarding DSC is available at the home page under ‘Information regarding DSC’. A bidder should enroll on the e-procurement website & register the DSC. Please arrange to fulfill the necessary requirements of e-procurement, since only the authorized bidders can participate in the tender.
Additional fee (1000/- per tender/bid) is payable to RajCOMP info services ltd.(RISL) for participating in e-procurement.
Help manual for bidder is available on the home page of the website under ‘Help for contractors’. You can also call on 0141-4022688 & 1800-233-7315 for any assistance regarding e-procurement during office hours.
Bidders training will be provided free of cost by RISL.
You may contact concerning department for further clarification(s).
GM (DPM&Proj.)
CFP, Pali-2015
Eligibility & Qualification Criteria for Civil Works
For the purpose of Civil contract work tenderers shall meet the following criteria as minimum :
1. a) Apart from the enlistment in appropriate class with the works department and undertakings of State/Central Government, the following eligibility criterion will be applicable.
b) The tenderer’s annual financial turnover in the same name and style during anyone of the last 5 years shall be equal to minimum 50% of the estimated value of contract as specified in the NIT. In support of which tenderer should submit the audited income tax return for respective year.
c) The tenderer, in the same name and style, should have completed at least one project of similar nature and value not less than 50% of the estimated value of the contract, for which this NIT is issue during the last 5 years, alongwith satisfactory completion report of that work.
d) The tenderer shall furnish a copy of Sales Tax clearance certificate in original or certified true copy.
Signature of Contractor GM(DPM&Proj.) RCDF, Jaipur
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
Annexure ‘A’
Name Name of work : Providing and Fixing of Barbed wire fencing over and above existing boundary wall at Cattle Feed Plant, Sirohi Road, Hathlai, Pali.
PART - I Schedule showing material to be supplied by department to the contractor. WATER The water for construction work during the construction shall be arranged by contractor at his own cost for which no recovery/no extra payment would be made ELECTRICITY Electricity for construction and fabrication work during the construction shall be supplied by CFP, Pali at the per unit rate according to the electricity bill (total bill amount divided by total units consumed) for the unit of electricity consumed, a separate sub-meter would be arranged by contractor necessary arrangement for electricity connection shall also be made by contractor from the place where electricity available. CEMENT Cement to be used for at construction work will be arranged by CFP, Pali for further release to contractor Cement bags will be lifted by the contractor at his own cost from the godown of the CFP, Pali. Recovery will be made at Rs. 190/- per bag plus 7.5% handling charges from contractor Bills. The empty bags will be the property of CFP, Pali. For storage of cement at site a temporary godown of suitable size with lockable arrangement shall be made by the contractor for which no payment shall be made. There will be two locks on gate one from Contractor side and other from department side. Daily cement consumption register will be maintained at site. After completion of work if actual cement consumed at site less than theoretical cement consumption statement then recovery of cement bag will be made equal to theoretical consumption. If the actual cement consumption is more than theoretical consumption than recovery will be made as per actual cement consumption and condition no. 10 B of contract agreement pertaining to cement regarding double recovery of issue rate will not be applicable. PART - II I/We hereby agree to abide by all the conditions of contract as laid down in appendix XI of the Public Works Department Finance & Accounts Rules of Rajasthan as amended to date in respect of works executed by the State P.W.D. in execution of this work and also undertake to follow the specifications of the P.W.D. / Federation as laid down for the Building, Road, Sanitary, Electrification, Joinery, Steel door, frames Park railing work etc., as may be applicable to similar contract in P.W.D. I/We also hereby agree to execute the above agreement within 10 days of issue of work order. I/We realize that my/our failure to execute the agreement within the aforesaid 10 days will make me/us liable for forfeiture of my/our earnest money, deposited for this tender, by the Federation without any further reference to me/us. The nomenclature and rates of items in schedule are based on PWD building BSR-2013 (for civil works), Distt. Pali. Any typographical and calculation error will not be entertained, the rates and nomenclature of items as in relevant BSR will be final and binding. Signature of Contractor General Manager (DPM&Proj.) RCDF, Jaipur.
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017.
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
AMENDMENT NOTE/SPECIAL CONDITIONS OF CONTRACT AGREEMENT The conditions of contract as per Appendix XI of Public Works Financial and Accounts Rules of Government of Rajasthan is attached with the Agreement with the following amendments/conditions.
In place of the Governor of State of Rajasthan or “The Governor of Rajasthan” wherever occurs in the said form, should be treated as replaced by “The Managing Director, Rajasthan Co-operative Dairy Federation Ltd.”
In place of the Government of Rajasthan wherever it occurs, should be read as “The Rajasthan Co-operative Dairy Federation Ltd.” (RCDF Ltd.).
In place of the Chief Engineer wherever it occurs, should be read as “The Managing Director, Rajasthan Cooperative Dairy Federation Limited”.
The authorized Engineer or the Engineer Incharge wherever it occurs denotes the GM (DPM&Proj.)
Rajasthan Co-operative Dairy Federation Limited, Jaipur.
Specifications will mean the latest specifications approved by Public Works Department unless mentioned otherwise.
(i) Agreement Clause No. 1 is amended as under:- “The security deposit @ 10% of the gross amount of the running bill shall be deducted from each running bill and shall be refunded as per rules on completion of the contract as per terms and conditions. The EMD shall however be adjusted while deducting security deposit from the first running bill of the contractor. There will be no maximum limit of security deposit”.
“All compensations or other sums of money payable by the Contractor to the Government under the terms of his contract may be deducted from or paid by the sale of a sufficient part of his Security Deposit, or from interest arising therefrom, or from any sums, which may be due or may become due to the Contractor by the Government on any account whatsoever, and in the event of his security deposit being reduced by reason of any such deductions or sale as aforesaid, the contractor shall within ten days thereafter, make good in cash, any sum of sums which may have been, deducted from or raised by sale of his security deposit or any part thereof”.
(ii) Agreement Clause 43 stands amended as under:- “The R.C.D.F. Ltd., shall have right to exercise proper quality control measures. The contractor shall provide all equipment and assistance to conduct such tests.” Agreement Clause 43 A will remain as such.
(iii) Agreement Clause No. 45 & 45 A stands deleted. (i) In Agreement Clause No. 37(e) the Defect Liability Period (DLP) for civil works costing more than
Rs. 10.00 lacs. shall be three years as per the latest order of GoR. (ii) In Agreement Clause No. 37(e) the word “PWD” shall be replaced with “The R.C.D.F. Ltd.”. (iii) All contracts with RCDF Ltd; Jaipur shall require registration of workers under the Act, 1996 &
extension of benefit to such workers under the Act. One percent cess, on this account is deductable over work order value.
(vii) The tenderer should quote the rates in the prescribed ‘G’ schedule only, unless otherwise the tender would be treated as cancelled. (Signature of the Contractor) (Signature of Authority of
With seal & Date Rajasthan Co-operative Dairy Federation Limited, Jaipur)
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD.,
“SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017 Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : Providing and Fixing of Barbed wire fencing over and above existing boundary wall at Cattle Feed Plant, Sirohi Road, Hathlai, Pali.
GENERAL ABSTRACT
S. No
NAME OF PART Amount as per G-Schedule
(Rs.)
Expected T.P.
Total amount including T.P. (Rs.)
1 Part – A (Building Work - B.S.R. Items) 1,81,766/-
2 Part – B ( ITEM-RATE )
Say Rs. :
Signature of the Contractor. General Manager (DPM & PROJ.)
Quoting the above rates. R.C.D.F., Jaipur.
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD.,
“SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017 Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : Providing and Fixing of Barbed wire fencing over and above existing boundary wall at Cattle Feed Plant, Sirohi Road, Hathlai, Pali.
‘G’ Schedule
PART – ‘A’ (Building Work - B.S.R. Items)
(Based on P.W.D. B.S.R. 2013 circle Pali District)
S. No
Particulars of item Unit Qty. Rate /Unit (Rs.)
Amount (Rs.)
1. Dismantling stone rubble masonry including stacking of serviceable material and disposal of unserviceable material with in 50 meters lead.
In cement mortar.
Cum
18
557.00
10026.00
2. Providing and laying in position cement concrete including curing compaction etc. of specified grade excluding the cost of centring and shuttering all up to plinth level IS 456-2000
(a) 1:2:4(1cement:2coarse sand:4graded stone aggregate) 20 mm nominal size
(b) Add extra for laying concrete in superstructure up to floor three level in above item IS456-2000
Cum
Cum
35
35
3283.00
83.00
114905.00
2905.00
3. Centring and shuttering with plywood r steel sheets including strutting, propping, bracing, both ways with wooden members and removal of form work for super structure up to 4.5 mtr above plinth for.
Columns, pillars, posts and struts etc.
sqm
155
246.00
38130.00
CFP, Pali-2015
4. Plaster on new surface on walls in cement sand mortar 1:6 including racking of joint etc. complete fine finished.
25 mm thick
sqm
100
158.00
15800.00
__________________________ Total Rs. : 1,81,766.00
_______________________ I / We hereby quoted the T.P. ……… ……….. % above / below ‘G’ Schedule as above.
General Manager (DPM & PROJ.) R.C.D.F., JAIPUR Signature of Contractor.
CFP, Pali-2015
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD.,
“SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017 Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : Providing and Fixing of Barbed wire fencing over and above existing boundary wall at Cattle Feed Plant, Sirohi Road, Hathlai, Pali.
PART – ‘B’ (Item-rate)
S. No
Particulars of item Unit Qty. Rate /Unit (Rs.)
Amount (Rs.)
1. Providing and fixing including cutting and welding and making holes in angles in Ý’ shape of angle design for barbed wire fencing work at an interval of 3.00 mtrs including fixing in c.c. over and above existing wall, excluding cost of cc, shuttering and dismantling work
Kg.
4800
4. Supply and fixing GI barbed wire fencing, fitted and fixed with GI staples/wire over and above existing boundary wall
Rmt.
9240
__________________________ Total Rs. :
_______________________
General Manager (DPM & PROJ.) R.C.D.F., JAIPUR Signature of Contractor.
CCRoad at CFP, Jodhpur
Name of work – No. 02 - e-Tender for Construction of C.C. Road at Cattle Feed
Plant, Jodhpur.
1 Estimated cost of construction work - Rs. 30.00 Lac. 2 Earnest money (By D.D. only in favour of RCDF Ltd; Jaipur) - Rs. 60,000/- 3 Tender Fees (By D.D. only in favour of RCDF Ltd; Jaipur) - Rs. 2,000/- 4 Tender Processing Fees (By D.D. only in favour of MD, RISL payable at Jaipur)
- Rs. 1,000/- 5 Date & time of downloading of tender – 15.07.2015 9:30 AM to 04.08.2015 5.00 PM 6 Date & time of submission of tender - 15.07.2015 9:30 AM to 04.08.2015 5.00 PM 7 Date & Time of opening of bid – 07.08.2015 11:00 AM 8 Completion period of work - 02 Months 9 Validity of quoted rate in tender - 90 days Note : Tender fees and EMD alongwith processing fees should be deposited in physical form
from 04.08.2015, (5.30) PM to 07.08.2015 upto 10.30 AM in Project Section. For acceptance / rejection of any or all the bids, the decision of MD, RCDF shall be final and binding
CCRoad at CFP, Jodhpur
Important Information
Subject: e-Procurement/tendering system at RCDF
Government of Rajasthan has decided to implement e-procurement system for their departments and
PSU to enhance efficiency & transparency in public procurement from April 2012, in which all
purchases/ works/ services etc. will be processed electronically through State e-procurement portal i.e.
www.eproc.rajasthan.gov.in.
Accordingly at RCDF, the existing process of manually submitting bids will be discontinued.
Information regarding tenders will be posted on the above mentioned website & bids will also be
accepted via the website. A registered user with a valid Digital Signature Certificate (DSC) will be
able to access the website, view & download tender details, fill in tender bids & upload (send) to the
website. At the scheduled time of tender opening, details of all bids can be viewed by the bidders.
Requirement for participating: Internet access (details available on the home page of website
www.eproc.rajasthan.gov.in), DSC & registration on the website.
Bidders will need to get a class III digital certificate with encryption – decryption facility through
controller of certifying authorities (CCA) approved certifying agencies. Information regarding DSC
is available at the home page under ‘Information regarding DSC’. A bidder should enroll on the
e-procurement website & register the DSC. Please arrange to fulfill the necessary requirements of e-
procurement, since only the authorized bidders can participate in the tender.
Additional fee (1000/- per tender/bid) is payable to RajCOMP info services ltd.(RISL) for
participating in e-procurement.
Help manual for bidder is available on the home page of the website under ‘Help for contractors’.
You can also call on 0141-4022688 & 1800-233-7315 for any assistance regarding e-procurement
during office hours.
Bidders training will be provided free of cost by RISL.
You may contact concerning department for further clarification(s).
GM (DPM&Proj.)
CCRoad at CFP, Jodhpur
Eligibility & Qualification Criteria for Civil Works
For the purpose of Civil contract work tenderers shall meet the following
criteria as minimum :
1. a) Apart from the enlistment in appropriate class with the works department
and undertakings of State/Central Government, the following eligibility
criterion will be applicable.
b) The tenderer’s annual financial turnover in the same name and style
during anyone of the last 5 years shall be equal to minimum 50% of the
estimated value of contract as specified in the NIT. In support of which
tenderer should submit the audited income tax return for respective year.
c) The tenderer, in the same name and style, should have completed at
least one project of similar nature and value not less than 50% of the
estimated value of the contract, for which this NIT is issue during
the last 5 years, alongwith satisfactory completion report of that
work.
d) The tenderer shall furnish a copy of Sales Tax clearance certificate
in original or certified true copy.
Signature of Contractor GM(DPM&Proj.)
RCDF, Jaipur
CCRoad at CFP, Jodhpur
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : construction of C.C. Road at Cattle Feed Plant, Basni, Jodhpur.
PART - I Schedule showing material to be supplied by department to the contractor. WATER The water for construction work during the construction shall be supplied departmentally by CFP, Jodhpur and 1% of value work done shall be deducted from the contractor’s running / final bill. Necessary arrangements to tap the water shall be made by the contractor from the place where water is available. ELECTRICITY Electricity for construction and fabrication work during the construction shall be supplied by CFP, Jodhpur at the per unit rate according to the electricity bill (total bill amount divided by total units consumed) for the unit of electricity consumed, a separate sub-meter would be arranged by contractor necessary arrangement for electricity connection shall also be made by contractor from the place where electricity available. CEMENT (i)Cement to be used for the construction work will be arranged by CFP, Jodhpur for further release to contractor Cement bags will be lifted by the contractor at his own cost from the godown of the CFP, Jodhpur. Recovery will be made at Rs. 190/- per bag plus 7.5% handling charges from contractor Bills. The empty bags will be the property of CFP, Jodhpur. (ii) For storage of cement at site a temporary godown of suitable size with lockable arrangement shall be made by the contractor for which no payment shall be made. There will be two locks on gate one from Contractor side and other from department side. Daily cement consumption register will be maintained at site. (iii) After completion of work if actual cement consumed at site less than theoretical cement consumption statement then recovery of cement bag will be made equal to theoretical consumption. If the actual cement consumption is more than theoretical consumption than recovery will be made as per actual cement consumption and condition no. 10 B of contract agreement pertaining to cement regarding double recovery of issue rate will not be applicable.
PART - II (i)I/We hereby agree to abide by all the conditions of contract as laid down in appendix XI of the Public Works Department Finance & Accounts Rules of Rajasthan as amended to date in respect of works executed by the State P.W.D. in execution of this work and also undertake to follow the specifications of the P.W.D. / Federation as laid down for the Building, Road, Sanitary, Electrification, Joinery, Steel door, frames Park railing work etc., as may be applicable to similar contract in P.W.D. I/We also hereby agree to execute the above agreement within 10 days of issue of work order. I/We realize that my/our failure to execute the agreement within the aforesaid 10 days will make me/us liable for forfeiture of my/our earnest money, deposited for this tender, by the Federation without any further reference to me/us. (ii) The nomenclature and rates of items in schedule are based on PWD Road BSR-2013 (for civil works), Distt. Jodhpur. Any typographical and calculation error will not be entertained, the rates and nomenclature of items as in relevant BSR will be final and binding. Signature of Contractor GM (DPM&Proj.) RCDF, Jaipur.
CCRoad at CFP, Jodhpur
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017.
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
AMENDMENT NOTE/SPECIAL CONDITIONS OF CONTRACT AGREEMENT The conditions of contract as per Appendix XI of Public Works Financial and Accounts Rules of
Government of Rajasthan is attached with the Agreement with the following amendments/conditions.
In place of the Governor of State of Rajasthan or “The Governor of Rajasthan” wherever occurs in the
said form, should be treated as replaced by “The Managing Director, Rajasthan Co-operative Dairy
Federation Ltd.”
In place of the Government of Rajasthan wherever it occurs, should be read as “The Rajasthan Co-
operative Dairy Federation Ltd.” (RCDF Ltd.).
In place of the Chief Engineer wherever it occurs, should be read as “The Managing Director,
Rajasthan Cooperative Dairy Federation Limited”.
The authorized Engineer or the Engineer Incharge wherever it occurs denotes the GM (DPM&Proj.)
Rajasthan Co-operative Dairy Federation Limited, Jaipur.
Specifications will mean the latest specifications approved by Public Works Department unless
mentioned otherwise.
(i) Agreement Clause No. 1 is amended as under:-
“The security deposit @ 10% of the gross amount of the running bill shall be deducted from each
running bill and shall be refunded as per rules on completion of the contract as per terms and
conditions. The EMD shall however be adjusted while deducting security deposit from the first
running bill of the contractor. There will be no maximum limit of security deposit”.
“All compensations or other sums of money payable by the Contractor to the Government under the
terms of his contract may be deducted from or paid by the sale of a sufficient part of his Security
Deposit, or from interest arising therefrom, or from any sums, which may be due or may become due
to the Contractor by the Government on any account whatsoever, and in the event of his security
deposit being reduced by reason of any such deductions or sale as aforesaid, the contractor shall within
ten days thereafter, make good in cash, any sum of sums which may have been, deducted from or
raised by sale of his security deposit or any part thereof”.
(ii) Agreement Clause 43 stands amended as under:-
“The R.C.D.F. Ltd., shall have right to exercise proper quality control measures. The contractor shall
provide all equipment and assistance to conduct such tests.”
Agreement Clause 43 A will remain as such.
(iii) Agreement Clause No. 45 & 45 A stands deleted.
(i) In Agreement Clause No. 37(e) the Defect Liability Period (DLP) for civil works costing more than
Rs. 10.00 lacs. shall be three years as per the latest order of GoR.
(ii) In Agreement Clause No. 37(e) the word “PWD” shall be replaced with “The R.C.D.F. Ltd.”.
(iii) All contracts with RCDF Ltd; Jaipur shall require registration of workers under the Act, 1996 &
extension of benefit to such workers under the Act. One percent cess, on this account is deductable
over work order value.
(vii) The tenderer should quote the rates in the prescribed ‘G’ schedule only, unless otherwise the tender
would be treated as cancelled.
(Signature of the Contractor) (Signature of Authority of Rajasthan Co-operative Dairy
Federation Limited, Jaipur) With seal & Date
CCRoad at CFP, Jodhpur
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : construction of C.C. Road at Cattle Feed Plant, Basni, Jodhpur.
GENERAL ABSTRACT
S. No NAME OF PART Amount as per G-
Schedule
(Rs.)
Rate / T.P.
quoted by
contractor
Total amount
including T.P.
(Rs.)
1 Part – A ( B.S.R. Items ) 9,41,842/-
2 Part – B (ITEM-RATE )
TOTAL RS. :
Signature of the Contractor. General Manager (DPM & PROJ.) Quoting the above rates. R.C.D.F., Jaipur.
CCRoad at CFP, Jodhpur
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : construction of C.C. Road at Cattle Feed Plant, Basni, Jodhpur.
‘G’ Schedule
PART – ‘A’ (Building Work - B.S.R. Items)
(Based on P.W.D. B.S.R. 2013 Road works circle Jodhpur )
S.
No
Particulars of item Unit Qty. Rate /Unit
(Rs.) Amount
(Rs.)
1. Dismantling of flexible payments Dismantling of flexible payments and disposal of dismantled materials with all leads (all useful materials obtained by dismantling shall be property of the contractor ) as per technical specification clause202 Bituminous courses
Sqm.
1700.00
31.00
52700.00
2. Dismantling of cement concrete pavements as per technical specification clause 202 by mechanical means using pneumatic tools breaking to pieces not exceeding 0.02 cum in volume and stock piling at designated locations and disposal of dismantled materials with all leads, stacking serviceable and unserviceable materials separately.
Cum
32.00
992.00
31744.00
3. Construction of granular sub-base by providing well graded material brought from all leads, spreading in uniform layers with motor grader on prepared surface, mixing by mix in place method with rotavator at omc, and compacting with smooth wheel roller to achieve the desired density , complete as per technical specification clause 401 For grading III material
Cum
225.00
250.00
56250.00
CCRoad at CFP, Jodhpur
4. Providing laying spreading and compacting stone aggregates of specific sizes brought from all leads to water bound macadam specification including spreading in uniform thickness, hand packing, rolling with three wheel 80-100 kN static roller in stages to proper grade and camber, applying and brooming, crushable screening t fill-up the interstices of coarse aggregate, watering and compacting to the required density grading 2 as per technical specification clause 405 By manual Means. Crusher broken
Cum
128.00
1006.00
128768.00
5. Providing concrete for plain/reinforced concrete in open foundations complete as per drawings and technical specifications clause 802, 803, 1202 & 1203 P.C.C. grade M10 Nominal mix 1:3:6
Cum
170.00
3674.00
624580.00
6. Providing and laying reinforced cement concrete pipe NP3 for culverts on first class bedding of granular material including fixing collar with cement mortar 1:2 but excluding excavation, protection work, backfilling, concrete and masonry works in head walls and parapets clause 1106 300 mm dia
Mtr.
40.00
1195.00
47800.00
________________________
Total Rs. : 9,41,842.00 ______________________
Signature of the Contractor . General Manager (DPM & PROJ.) R.C.D.F., Jaipur.
CCRoad at CFP, Jodhpur
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : construction of C.C. Road at Cattle Feed Plant, Basni, Jodhpur.
PART – ‘B’ ( Item-rate)
S.
No
Particulars of item Unit Qty. Rate /Unit
(Rs.) Amount
(Rs.)
1. Construction of un-reinforced, dowel jointed at expansion and construction joint only, plain cement concrete pavement, thickness as per designover a prepared sub base, with 43 grade cement or any other type as per Clause 1501.2.2 1:1.5:3 Grade), coarse and fine aggregates conforming to IS:383, maximum size of coarse aggregate not exceeding 25mm, mixed in a concrete mixer of not less than 0.2 cum capacity and appropriate weigh batcher using approved mix design, laid in approved fixed side formwork (steel channel, laying and fixing of 125 micron thick polythene film, wedges, steel plates including leveling the formwork as per drawing), spreading the concrete with shovels, rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including provision of contraction and expansion, construction joints, applying debonding strips, primer, sealant, dowel bars, near approaches to bridge / culvert and construction joints, admixtures as approved, curing of concrete slabs using curing compound (where specified) and water finishing to lines and grade as per drawing and Technical Specification Clause 1501.
Cum
340.00
__________________________
Total Rs. : ______________________
Signature of the Contractor . General Manager (DPM & PROJ.) R.C.D.F., Jaipur.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
Name of work – No. 03 - e-Tender for Expansion of finished goods store (FGS) at Cattle
Feed Plant, Lalgarh, Bikaner.
1 Estimated cost of construction work - Rs. 36.00 Lacs.
2 Earnest money (By D.D. only in favour of RCDF Ltd; Jaipur)
- Rs. 72,000/- 3 Tender Fees
(By D.D. only in favour of RCDF Ltd; Jaipur)
- Rs. 5,000/- 4 Tender Processing Fees
(By D.D. only in favour of MD, RISL payable at Jaipur) - Rs. 1,000/-
5 Date & time of downloading of tender – 15.07.2015 9:30 AM to
04.08.2015 5.00 PM 6 Date & time of submission of tender - 15.07.2015 9:30 AM to
04.08.2015 5.00 PM 7 Date & Time of opening of bid – 07.08.2015 11:00 AM
8 Completion period of work - 06 Months 9 Validity of quoted rate in tender - 90 days
Note : Tender fees and EMD alongwith processing fees should be deposited in physical form from 04.08.2015, (5.30) PM to 07.08.2015 upto 10.30 AM in Project Section. For acceptance /
rejection of any or all the bids, the decision of MD, RCDF shall be final and binding.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
Important Information
Subject: e-Procurement/tendering system at RCDF
Government of Rajasthan has decided to implement e-procurement system for their
departments and PSU to enhance efficiency & transparency in public procurement from April
2012, in which all purchases/ works/ services etc. will be processed electronically through
State e-procurement portal i.e. www.eproc.rajasthan.gov.in.
Accordingly at RCDF, the existing process of manually submitting bids will be discontinued.
Information regarding tenders will be posted on the above mentioned website & bids will also
be accepted via the website. A registered user with a valid Digital Signature Certificate (DSC)
will be able to access the website, view & download tender details, fill in tender bids & upload
(send) to the website. At the scheduled time of tender opening, details of all bids can be viewed
by the bidders.
Requirement for participating: Internet access (details available on the home page of website
www.eproc.rajasthan.gov.in), DSC & registration on the website.
Bidders will need to get a class III digital certificate with encryption – decryption facility
through controller of certifying authorities (CCA) approved certifying agencies. Information
regarding DSC is available at the home page under ‘Information regarding DSC’. A
bidder should enroll on the e-procurement website & register the DSC. Please arrange to fulfill
the necessary requirements of e-procurement, since only the authorized bidders can participate
in the tender.
Additional fee (1000/- per tender/bid) is payable to RajCOMP info services ltd.(RISL) for
participating in e-procurement.
Help manual for bidder is available on the home page of the website under ‘Help for
contractors’. You can also call on 0141-4022688 & 1800-233-7315 for any assistance
regarding e-procurement during office hours.
Bidders training will be provided free of cost by RISL.
You may contact concerning department for further clarification(s).
GM (DPM&Proj.)
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
Eligibility & Qualification Criteria for Civil Works
For the purpose of Civil contract work tenderers shall meet the following
criteria as minimum :
1. a) Apart from the enlistment in appropriate class with the works department
and undertakings of State/Central Government, the following eligibility
criterion will be applicable.
b) The tenderer’s annual financial turnover in the same name and style during
anyone of the last 5 years shall be equal to minimum 50% of the estimated
value of contract as specified in the NIT. In support of which tenderer
should submit the audited income tax return for respective year.
c) The tenderer, in the same name and style, should have completed at
least one project of similar nature and value not less than 50% of the
estimated value of the contract, for which this NIT is issue during
the last 5 years, alongwith satisfactory completion report of that work.
d) The tenderer shall furnish a copy of Sales Tax clearance certificate in
original or certified true copy.
Signature of Contractor GM(DPM&Proj.)
RCDF, Jaipur
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Annexure ‘A’
Name of work : Expansion of FGS at Cattle Feed Plant, Lalgarh, Bikaner PART-I
Schedule showing material to be supplied by department to the contractor. WATER The water for construction work during the construction shall be supplied departmentally by CFP, Lalgarh, Bikaner and 1% of value work done shall be deducted from the contractor’s running / final bill. Necessary arrangements to tap the water shall be made by the contractor from the place where water is available. ELECTRICITY Electricity for construction and fabrication work during the construction shall be supplied by CFP, Lalgarh, Bikaner at the per unit rate according to the electricity bill (total bill amount divided by total units consumed) for the unit of electricity consumed, a separate sub-meter would be arranged by contractor necessary arrangement for electricity connection shall also be made by contractor from the place where electricity available. CEMENT Cement to be used for at construction work will be arranged by CFP, Lalgarh, Bikaner for further release to contractor Cement bags will be lifted by the contractor at his own cost from the godown of the Milk Union. Recovery will be made at Rs. 200/- per bag plus 7.5% handling charges from contractor Bills. The empty bags will be the property of CFP, Lalgarh, Bikaner. For storage of cement at site a temporary godown of suitable size with lockable arrangement shall be made by the contractor for which no payment shall be made. There will be two locks on gate one from Contractor side and other from department side. Daily cement consumption register will be maintained at site. After completion of work if actual cement consumed at site less than theoretical cement consumption statement then recovery of cement bag will be made equal to theoretical consumption. If the actual cement consumption is more than theoretical consumption than recovery will be made as per actual cement consumption and condition no. 10 B of contract agreement pertaining to cement regarding double recovery of issue rate will not be applicable.
PART - II I/We hereby agree to abide by all the conditions of contract as laid down in appendix XI of the Public Works Department Finance & Accounts Rules of Rajasthan as amended to date in respect of works executed by the State P.W.D. in execution of this work and also undertake to follow the specifications of the P.W.D. / Federation as laid down for the Building, Road, Sanitary, Electrification, Joinery, Steel door, frames Park railing work etc., as may be applicable to similar contract in P.W.D. I/We also hereby agree to execute the above agreement within 10 days of issue of work order. I/We realize that my/our failure to execute the agreement within the aforesaid 10 days will make me/us liable for forfeiture of my/our earnest money, deposited for this tender, by the Federation without any further reference to me/us. The nomenclature and rates of items in schedule are based on PWD building BSR-2013 (for civil works), Distt. Bikaner & Electrical BSR-2012. Any typographical and calculation error will not be entertained, the rates and nomenclature of items as in relevant BSR will be final and binding. Signature of Contractor GM (DPM&Proj.) RCDF, Jaipur.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017.
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
AMENDMENT NOTE/SPECIAL CONDITIONS OF CONTRACT AGREEMENT The conditions of contract as per Appendix XI of Public Works Financial and Accounts Rules of
Government of Rajasthan is attached with the Agreement with the following amendments/conditions.
In place of the Governor of State of Rajasthan or “The Governor of Rajasthan” wherever occurs in the
said form, should be treated as replaced by “The Managing Director, Rajasthan Co-operative Dairy
Federation Ltd.”
In place of the Government of Rajasthan wherever it occurs, should be read as “The Rajasthan Co-
operative Dairy Federation Ltd.” (RCDF Ltd.).
In place of the Chief Engineer wherever it occurs, should be read as “The Managing Director, Rajasthan
Cooperative Dairy Federation Limited”.
The authorized Engineer or the Engineer Incharge wherever it occurs denotes the GM (DPM&Proj.) Rajasthan Co-operative Dairy Federation Limited, Jaipur.
Specifications will mean the latest specifications approved by Public Works Department unless
mentioned otherwise.
(i) Agreement Clause No. 1 is amended as under:-
“The security deposit @ 10% of the gross amount of the running bill shall be deducted from each
running bill and shall be refunded as per rules on completion of the contract as per terms and conditions.
The EMD shall however be adjusted while deducting security deposit from the first running bill of the
contractor. There will be no maximum limit of security deposit”.
“All compensations or other sums of money payable by the Contractor to the Government under the
terms of his contract may be deducted from or paid by the sale of a sufficient part of his Security
Deposit, or from interest arising therefrom, or from any sums, which may be due or may become due to
the Contractor by the Government on any account whatsoever, and in the event of his security deposit
being reduced by reason of any such deductions or sale as aforesaid, the contractor shall within ten days
thereafter, make good in cash, any sum of sums which may have been, deducted from or raised by sale
of his security deposit or any part thereof”.
(ii) Agreement Clause 43 stands amended as under:-
“The R.C.D.F. Ltd., shall have right to exercise proper quality control measures. The contractor shall
provide all equipment and assistance to conduct such tests.”
Agreement Clause 43 A will remain as such.
(iii) Agreement Clause No. 45 & 45 A stands deleted.
(i) In Agreement Clause No. 37(e) the Defect Liability Period (DLP) for civil works costing more than
Rs. 10.00 lacs. shall be three years as per the latest order of GoR.
(ii) In Agreement Clause No. 37(e) the word “PWD” shall be replaced with “The R.C.D.F. Ltd.”.
(iii) All contracts with RCDF Ltd; Jaipur shall require registration of workers under the Act, 1996 &
extension of benefit to such workers under the Act. One percent cess, on this account is deductable over
work order value.
(vii) The tenderer should quote the rates in the prescribed ‘G’ schedule only, unless otherwise the tender
would be treated as cancelled.
(Signature of the Contractor) (Signature of Authority of
With seal & Date Rajasthan Co-operative Dairy
Federation Limited, Jaipur)
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
Name of work : Expansion of FGS at Cattle Feed Plant, Lalgarh, Bikaner
GENERAL ABSTRACT
S.
No
NAME OF PART Amount as per
G-Schedule
(Rs.)
Expected
T.P.
Total amount
including T.P.
(Rs.)
1 Part – A (Building Work - B.S.R. Items) 23,47,058/-
2 Part – B ( ITEM-RATE )
3 Part – C ( Electric Work BSR – Item) 1,21,378/-
Say Rs. :
Signature of the Contractor. General Manager (DPM & PROJ.)
Quoting the above rates. R.C.D.F., Jaipur.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD.,
“SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017 Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : Expansion of FGS at Cattle Feed Plant, Lalgarh, Bikaner
‘G’ Schedule
PART – ‘A’ (Building Work - B.S.R. Items)
(Based on P.W.D. B.S.R. 2013 circle Bikaner)
S.
No
Particulars of item Unit Qty. Rate /Unit
(Rs.) Amount
(Rs.)
1. Earth work in excavation by mechanical
means (hydraulic excavator)/manual
means in foundation trenches or drains,
(not exceeding 1.5 mtr in width of 10 sqm
on plan) including dressing of sides and
ramming of bottoms, lift upto 1.5 Meter
including taking out the excavated soil
and depositing and refilling of jhiri with
watering and ramming and disposal of
surplus excavated soil as directed within a
lead of 50 Mtr. All kinds of soil.
Cum
100
153.00
15300.00
2.
Providing and laying in position cement
concrete including curing, compaction
etc. complete in specified grade excluding
the cost of centering and shuttering – All
work up to plinth level. 1 : 4 : 8 ( 1:
Cement : 4 Coarse Sand : 8 graded stone
aggregate 40mm nominal size).
Cum
35
2761.00
96635.00
3.
P & L in position specified grade of
cement concrete for all RCC structural
work elements up to plinth level including
curing, compaction, finishing with
rendring in cement sand mortar 1:3
(1cement : 3 coarse sand) and making
good the joints excluding the cost of
centering shuttering and reinforcement.
M – 20 grade nominal mix 1:1½:3 (1
cement :1 ½ coarse sand : 3 graded stone
aggregate 20mm nominal size) foundation
and plinth.
Cum
45
4053.00
182385.00
4.
Centering and shuttering with plywood or
steel sheets including strutting, propping,
bracing both ways and removal of form
work for foundations in basement rafts,
footings, straps, beams bases of columns
etc. up to plinth level.
Sqm.
70
125.00
8750.00
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
5. Brick work F.P.S. bricks of class
designation 75 in foundation and plinth in
Cement Mortar 1:6 (1 cement : 6 coarse
sand).
Cum
55
3486.00
191730.00
6.
Providing and laying in position specified
grade of cement concrete for RCC
structural elements upto floor Five level
including curing, compaction, finishing
with rendering in cement sand mortar 1:3
(1-Cement:3-Coarse sand) and making
good the joints and cost of plasticizer (if
required) excluding the cost of centering,
shuttering and reinforcement for:
(a) Walls (any thickness) including
attached pilasters, buttresses, plinth
and string courses, fillets, columns,
pillars, piers, abutments, posts and
struts etc. M-20nominal grade.)
(b) Beams, suspended floors, roofs,
girders having slopes up to 15º,
landings, balconies, shelves, chajjas,
lintels, bands, plain windows sills,
staircases and spiral staircases.
M – 20 grade nominal mix.
Cum
Cum
11
35
4168.00
4523.00
45848.00
158305.00
7.
Centering and shuttering with playwood
or steel sheets including strutting,
propping, bracing both ways with steel
props and removal of form work for upto
floor five level for :
a) Columns, pillars, posts and struts etc.
b) Suspended floors, roofs lendings,
staircase, balconies, girders,
cantilevers, bands, copings, bed
plates, anchor blocks, sills, chhajjas,
lintel, beam, plinth beam etc.
Sqm
Sqm
120
300
285.00
269.00
34200.00
80700.00
8. Providing and fabricating reinforcement
for RCC work including straightening,
cutting, bending, placing in position and
binding (including cost of binding wire)
all complete up to floor five level.
Thermo-mechanically Treated bars
(conforming of relevant IS code)
Kg.
7300
65.00
474500.00
9.
Cement plaster in skirting (up to 30 cm
height) with cement mortar 1:3 (1-cement
: 3-coarse sand) finished with a floating
coat of neat cement 18mm thick.
Sqm
15
241.00
3615.00
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
10. Providing and laying cement concrete
including curing, compaction etc,
complete in retaining walls, return walls,
walls (any thickness) including attached
pilasters, columns, piers, abutments,
pillars, posts, struts, buttresses, string or
lacing courses, parapets, coping, bed
blocks, anchor blocks , plain window
sills, fillets, leveling course etc up to floor
five level excluding the cost of centering
and shuttering.
M 15 grade nominal mix
1:2:4(1cement:2coarse sand:4graded
stone aggregate 20 mm nominal size)
Cum
2.5
3688.00
9220.00
11. Structural steel work in single section
fixed with or without connecting plate
including cutting hoisting (height up to
10mtr) fixing in position and applying a
priming coat f approved steel primer all
complete.
Kg.
310
74.00
22940.00
12.
Steel work in built up tubular trusses
including cutting, hosting(height up to 10
mtr) fixing in position and applying a
priming coat of approved steel primer all
complete.
Hot finished seamless type tubes.
Kg.
4420
94.00
415480.00
13
Providing batta (gola) 75 mm x 75 mm in
cement concrete ( 1 : 2 : 4 ) including
finishing with cement mortar 1 : 3 as per
standard design.
Mtr.
60
27.00
1620.00
14 Plaster on new surface on walls in cement
sand mortar 1:3 including racking of
joints etc. complete fine finish.
(On canopy roof grading )
Sqm
25
125.00
3125.00
15
Plaster on new surface on walls in cement
sand mortar 1:4 including racking of
joints etc. complete fine finish.
a) 20mm thick
b) 12mm thick
Sqm
Sqm
230
470
164.00
116.00
37720.00
54520.00
16.
Making groves as per design in plaster 10
mm to 20 mm wide
Mtr.
250
4.00
1000.00
17
White washing with lime to give an even
shade including all scaffolding on New
work (three or more coats)
Sqm.
325
11.00
3575.00
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
18
Finishing wall with water proofing
cement paint of approved brand and
manufacture and or required shade to give
an even shade including all scaffolding
on New work (two or more coats applied
@ 3.84 kg. /10sqm).
Sqm
380
39.00
14820.00
19
Painting with synthetic enamel paint of
approved brand and manufacturer to
given an even shade two or more coat on
new work.
Sqm
85
49.00
4165.00
20
P&F rigid PVC Pipe (IS:4985) class II
(4Kg./Cm.) approved quality / make
including joining the pipe with solvent
cement rubber ring and lubricant.
(a) 110mm dia.
Rmt
30
179.00
5370.00
21
P&F rigid PVC Pipe fittings (IS:4985
mark) of approved quality / make
including joining the pipe with solvent
cement rubber ring and lubricant. 110mm
dia.
(a) Bend 87.5º
(b) Pipe Clips
(c) coupler
Each
Each
Each
4
8
4
150.00
32.00
87.00
600.00
256.00
348.00
22
Brick work with F.P.S bricks of class
designation 75 in superstructure above
plinth level up to floor V level in all
shapes and sizes in
Cement mortar 1:4(1cement:4 coarse
sand)
Cum
60
4230.00
253800.00
23
Supplying & fixing rolling shutters of
approved make made of 80 x 1.25mm
M.S. laths interlocked together through
their entire length and jointed together at
the end by end locks mounted on
specially designed pipe shaft with
brackets, side guides and arrangements
for inside and outside locking with push
and pull operation complete including
cost of spring hooks, providing and fixing
necessary 25.3 cm. Long wire spring
grade No. 2 and M.S. top cover 1.25mm
thick for rolling shutters as per design
(clear openable area to be measured for
payment)
Sqm.
30
1775.00
53250.00
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
24
Extra for providing grilled rolling shutters
manufactured out of 8 mm dia ms bar
instead of laths as per design approved by
engineer in charge (area of grill to be
measured)
Sqm.
4
360.00
1440.00
25
Providing and fixing steel glazed doors
windows and ventilator shutters of
standard rolled steel section joints
mitered and welded with steel lugs 13 x 3
mm, 10 cm Long embedded in cement
concrete block 15 x 10 x 10 cm of 1 : 3 :
6 (1 cement : 3 corase sand : 6 graded
stone aggregate 20mm nominal size) or
with wooden plugs and screws or rawl
plugs and screws with fixing clips or with
bolts and nuts as required including
providing and fixing of plain glass panes
4 mm thick with copper glazing clips and
special metal sash putty of approved
make or metal beading with screws
complete including priming coat of
approved steel primer, excluding the cost
of metal beading and other fitting except
necessary hinges of pivots steel handles
peg stay etc. as required.
(a) Window Fixed without glass panes
Sqm
11
1720.00
18920.00
26
Providing and fixing square bars or other
flat welded to window ventilators etc.
Kg.
70
76.00
5320.00
27
Providing and fixing welded
mesh/expanded metal mesh in frame
work, flat iron beading 20x3mm
including top cross laps inside and out
sides welding, iron bolts, screws, clips etc
complete (excluding frame work ) of size
Welded mesh 25x25mmx16gauge
Sqm.
11
631.00
6941.00
28
Random rubble dry stone Kharanja under
floor
Cum
40
646.00
25480.00
29
Providing PVC strips in joints of
terrazzo/cement concrete floor PVC strips
40mm wide and 2 to 3mm thick
Mtr.
300
13.00
3900.00
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
30
62 mm thick cement concrete flooring
with concrete hardener topping under
layer 50mm thick cement concrete
1:2:4(1cement:2coarse sand:4 graded
stone aggregate 20mm nominal size) and
top layer 12 mm thick cement hardener
consisting of mix 1:2(1 cement hardener
mix :2 graded stone aggregate 6mm
nominal size) by volume. Hardening
compound is mixed @ of 2 litre per
50Kg. of cement or as per manufactures
specifications. This includes cost of
cement slurry, but excluding the cost of
nosing of steps etc complete.
Sqm
260
428.00
111280.00
__________________________
Total Rs. :23,47,058.00
______________________
I/We hereby quoted the rates T.P. ………………% above / below the ‘G’ schedule.
Signature of the Contractor . General Manager (DPM & PROJ.)
Quoting the above rates. R.C.D.F., Jaipur.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD., “SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017
Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in E-mail : [email protected]
Name of work : Civil work for Expansion of FGS at Cattle Feed Plant, Lalgarh, Bikaner.
PART – ‘B’ (Item-Rate)
S.
No
Particulars of item Unit Qty. Rate /Unit
(Rs.) Amount
(Rs.)
1 Filling in plinth with locally available
excavated earth under floors in layers (each
layer should not be more than 20cm thick)
including watering up to OMC and
ramming with heavy iron rammer
consolidation, dressing compaction etc
complete
Cum
210
2 Supply of earth from cattle feed plant
premises including excavation,
transportation, loading and unloading at
construction site.
Cum
210
3 Providing and fixing of Aluminium Zink
coated 0.5mm thick pre-painted steel sheet
with 18 to 20 micron painting on top and 5
to 7 micron painting at bottom glossy
finish / mat finish confirming to IS:277
sheet to be fixed over existing truss with
self drilling screw complete in all respect
as per manufacture specification and
instruction of Engineer-Incharge.
Sqm
320
4 Providing and fixing ridge made out of
Aluminium zink coated steel sheet the
width of ridge not less then 588mm with
painted top profile. Other specifications as
mentioned in item No. 3 above.
Mtr.
14
__________________________
Total Rs. :
______________________
I/We hereby quoted the rates T.P. ………………% above / below the ‘G’ schedule.
Signature of the Contractor . General Manager (DPM & PROJ.)
Quoting the above rates. R.C.D.F., Jaipur.
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
RAJASTHAN CO-OPERATIVE DAIRY FEDERATION LTD.,
“SARAS SANKUL”,J.L.N. MARG, JAIPUR–302017 Phone No. 0141-2702501-508 : Telefax 0141-2702135 : Website : sarasmilkfed.rajasthan.gov.in
E-mail : [email protected]
Name of work : Expansion of FGS at Cattle Feed Plant, Lalgarh, Bikaner.
‘G’ Schedule
PART – ‘C’ (Electric Work - B.S.R. Items)
(Based on P.W.D. B.S.R. Electrical 2012)
S.
No
Particulars of item Unit Qty. Rate
(Rs. )
Amount
(Rs.)
1. Wiring of light point / fan point / exhaust
fan point / call bell point with 1.5 Sq.mm.
nominal size FR PVC insulated
unsheathed flexible copper conductor
1.1KV grade and 1.5 Sq.mm nominal size
FR PVC insulated unsheathed flexible
copper earth conductor 1.1KV grade
(IS:694) of approved make in surface /
recessed ISI marked medium duty PVC
conduit & it’s accessories, round tiles, 18
SWG M.S. box with earth terminal, screw
less cage connectors for neutral looping in
a switch board and false ceiling point, 6A
switch, 3.0 mm thick phenolic laminated
sheet, zinc plated / brass screws, cup
washers making connections, testing etc.
as required. Group – 1.
(i) Long point (upto 10 mtr.)
(ii) On board
Each
Each
40
02
390.00
75.00
15600.00
150.00
2.
S&F following sizes (dia) of ISI marked
medium duty PVC conduit along with
accessories in surface / recessed using
saddles, clamps, fastener as required
including cutting the wall and making
good the same as required. Group - I
(a) 20mm dia.
Mtr.
150
27.00
4050.00
3. Supplying and drawing FR PVC insulated
and unsheathed flexible copper conductor
ISI marked (IS : 694) of 1.1 kV grade and
approved make in existing surface or
recessed conduit / casing capping
including making connections etc. as
required. Group – I.
(i) 2 x 1.5 Sq.mm.
(ii) 2 x 2.5 Sq.mm.
Mtr.
Mtr.
175
150
21.60
33.10
3780.00
4965.00
4.
P & F box type fluoresent tube fitting
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
fabricated from CRCA sheet and finished
with powder coating stove enameled paint
complete with accessories like (OCCB,
starter, starter seat)/ EB, Condenser, rotor
holder, terminal block duly pre-wired with
copper conductor including making
connection, testing etc as required
(without tube).
(a) 2 x 36 Watt. Group-1 with OCCB.
Each
38
1840.00
69920.00
5.
P & F fluorscent tube rod in existing
fixtures as required fluorescent powder
coated
Group-I, 36 / 40 Watt.
Each
76
56.00
4256.00
6.
P&F Recessed / Surface mounting heavy
duty horizontal type sheet steel
distribution board phosphate / powder
painted complete with copper bus bar,
shorting link, neutral link, earth link and
din bar, conforming to IS 13032 and IS
8623 including making internal DB
terminations with copper lugs. Testing etc.
as required. Group – I.
(a) Single door (Single phase) 8 Way.
Each
1
897.00
897.00
7.
P&F 240/415V isolator conforming to
IS:13947-III IEC 60947-3 on existing
board / sheet including making
connections with lugs, testing etc. as
required. Group–1.
30/40 Amp. rating Double pole Group-I
Each
1
367.00
367.00
8. P&F 240 / 415V AC MCB with positive
isolation of breaking capacity not less
than 10 KA (B/C/D tripping
characteristic) ISI marked IS 8828 (1996)
/ conforming to IEC 60898 in existing
board / sheets including making
connections with lugs, testing etc. as
required. Group - 1.
(a) Single pole MCB 6 A to 32 A rating.
Each
3
151.00
453.00
9.
P/Laying PVC/XLPE insulated &PVC
sheated cable of 1.1 KV grade with
aluminium conductor of IS:1554 P-
I/IS:7098 P-I of group-I of approve make
in ground as per IS:1255 including
excavation of 30cmx75cm size trench,
25cm thick under layer of sand, IInd class
bricks covering, refilling earth,
compaction of earth, making necessary
connection, testing etc, as required size
C:\Users\g\Desktop\FGS, CFP, Bikaner.doc
3x10Sqm.mm. Mtr. 30 134.00 4020.00
10.
P & F IS:371 marked 6 Amp surface type
ceiling rose including making connection
testing etc. As required.
Group – I.
Each
40
18.00
720.00
11.
P & F IP –65 protected integral flood light
luminaire suitable for HPSV/Metal halide
lamp, comprising of powder coated Dia
cast aluminium housing, electrochmically
brightened and anodized stippled
aluminium reflector, covered with suitably
gasketed, heat resistant and toughened
glass porcelain holder, integral control
ear box having, copper ballast, capacitor,
electronic ignitor, prewired with PVC
insulated copper conductor up to terminal
block including making connection testing
etc. as required, (without lamp)
Light 1 x 150 Group – I.
Each
2
5250.00
10500.00
12.
P & F high pressure sodium vapour /High
pressure mercury vapour/metal
halide/Halogen Lamp as required.
HPSV tubler lamp 150 Watt. Group-I
Each
2
465.00
930.00
13.
Providing and laying M.S. (medium duty
‘B’class) pipe IS:1239 marker including
all accessories such as screwed/welded
flanges, tees, reducers etc. conforming to
IS: 1239 complete including painting,
welding, jointing and compressed as
bestos gaskets, nuts, bolts etc. as required.
The pipe shall be painted with one coat of
primer ant two coats of post office red
primer paint fixed in ceiling, walls,
columns fr all heights with
hangers/supports and fasteners including
chasing of walls/column/ceiling etc, and
making good the same complete as
required. 32 mm dia pipe
Each
2
385.00
770.00 __________________________
Total Rs. : 1,21,378.00 _______________________
I / We hereby quoted the T.P. ……… ……….. % above / below
‘G’ Schedule as above.
General Manager (DPM & PROJ.)
R.C.D.F., JAIPUR Signature of Contractor.