raleigh waste management centre landfill environmental ... · review and update the landfill...
TRANSCRIPT
Raleigh Waste Management Centre
Landfill Environmental Management Plan
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 2
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 3
Document Check Off and Disclaimer
DATE DRAFT AUTHOR CHECKED
20/12/2013 1 Thomas Freeman Greg Freeman
07/03/2014 2 Thomas Freeman Jeff Green
12/05/2014 FINAL Thomas Freeman Greg Freeman
The collection of information presented in this report was undertaken to the best level possible
within the agreed timeframe and should not be solely relied upon for commercial purposes. The
opinions, representations, statements or advice, expressed or implied in this report was done so in
good faith. While every effort has been made to ensure that the information contained within is
accurate, Impact Environmental Consulting makes no representation as to the suitability of this
information for any particular purpose. Impact Environmental Consulting disclaims all warranties
with regard to this information. No part of this report is to be reproduced without the written
consent of Impact Environmental Consulting Pty Limited.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 4
Table of Contents
PART 1 INTRODUCTION ............................................................................................................. 10
1.1 BACKGROUND ....................................................................................................................... 10
1.2 WHAT IS A LEMP? .................................................................................................................. 11
1.3 PURPOSE OF THE LEMP ...................................................................................................... 11
1.4 DOCUMENT CONTROL .......................................................................................................... 12
1.5 REVIEWS AND UPDATES ...................................................................................................... 12
PART 2 KEY DRIVERS OF THE LEMP ....................................................................................... 13
2.1 COMPLIANCE WITH EPA LICENSE ...................................................................................... 13
2.2 COMPLIANCE WITH LANDFILL GUIDELINES ...................................................................... 16
2.3 EPA LICENCE AND GUIDELINES IN THIS LEMP ................................................................. 17
PART 3 RELEVANT LEGISLATION, POLICIES AND GUIDELINES ......................................... 18
PART 4 SITE OVERVIEW ............................................................................................................ 19
4.1 LOCATION ............................................................................................................................... 19
4.2 LAND USE AND ZONING ....................................................................................................... 20
4.3 NEIGHBOURING LAND USES ............................................................................................... 22
4.4 OWNERSHIP ........................................................................................................................... 22
4.5 SITE HISTORY ........................................................................................................................ 22
PLANNING CONSENT ............................................................................................................ 22
4.6 LICENCING ............................................................................................................................. 22
PART 5 PHYSICAL ENVIRONMENT ........................................................................................... 23
5.1 CLIMATE AND METEROLOGICAL CHARACTERISTICS ..................................................... 23
5.2 FLORA AND FAUNA ............................................................................................................... 24
5.3 TOPOGRPAHY ........................................................................................................................ 24
5.4 GEOLOGY AND SITE SOILS .................................................................................................. 25
ACID SULPHATE SOILS ......................................................................................................... 25
5.5 SURFACE WATER HYDROLOGY .......................................................................................... 25
5.6 GROUNDWATER HYDROLOGY ............................................................................................ 26
GROUNDWATER USE ............................................................................................................ 27
5.7 FORESTRY ............................................................................................................................. 27
5.8 ACCOUSTIC ENVIRONMENT ................................................................................................ 28
5.9 VISUAL AMENITY ................................................................................................................... 28
5.10 CULTURAL AND HERITAGE VALUES ................................................................................... 28
PART 6 WASTE TYPES AND QUANTITIES ............................................................................... 29
6.1 GENERAL ................................................................................................................................ 29
6.2 WASTE TYPES AND QUANTITIES ........................................................................................ 29
6.3 WASTE GROWTH ................................................................................................................... 31
PART 7 FACILITY DESIGN .......................................................................................................... 32
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 5
7.1 ACCESS AND LAYOUT .......................................................................................................... 32
7.2 FACILITIES .............................................................................................................................. 32
SMALL VEHICLE TRANSFER STATION ................................................................................ 32
REUSE CENTRE ..................................................................................................................... 32
BULKY GARDEN WASTE PROCESSING AREA ................................................................... 32
SCRAP METAL STORAGE AREA .......................................................................................... 33
TYRES STOKCPILE AREA ..................................................................................................... 33
MATTRESS STORAGE SHED ................................................................................................ 33
WASTE OIL SHED .................................................................................................................. 33
E-WASTE CAGE ..................................................................................................................... 33
HAZARDOUS MATERIALS STORAGE SHED ....................................................................... 33
7.3 FINAL LANDFORM AND LIFE OF SITE ................................................................................. 33
7.4 STAGING OF LANDFILLING .................................................................................................. 34
STAGE 1 .................................................................................................................................. 34
STAGE 2 .................................................................................................................................. 34
7.5 FUTURE USE .......................................................................................................................... 34
7.6 STORMWATER DRAINAGE ................................................................................................... 35
7.7 LEACHATE MANAGEMENT SYSTEM ................................................................................... 35
PART 8 FACILITY OPERATION .................................................................................................. 37
8.1 OPENING HOURS .................................................................................................................. 37
8.2 MANAGEMENT, SUPERVISION AND STAFFING ................................................................. 38
8.3 TRAFFIC MANAGEMENT ....................................................................................................... 39
8.4 PUBLIC AND STAFF SAFETY ................................................................................................ 39
8.5 SITE SECURITY ...................................................................................................................... 40
8.6 WASTE ACCEPTANCE AND SCREENING ........................................................................... 40
ACCEPTED WASTES ............................................................................................................. 41
WASTE TYRES ....................................................................................................................... 42
WASTE SCREENING AND HANDLING ................................................................................. 42
UNACCEPTABLE WASTE PROCEDURE .............................................................................. 43
8.7 RECORDING OF WASTES RECIEVED ................................................................................. 43
8.8 WASTE COMPACTION ........................................................................................................... 44
8.9 FILLING PLAN ......................................................................................................................... 44
8.10 COVER MATERIAL ................................................................................................................. 45
DAILY COVER ......................................................................................................................... 45
ALTERNATE DAILY COVER................................................................................................... 46
INTERMEDIATE COVER ........................................................................................................ 46
8.11 FINAL CAPPING LAYER ......................................................................................................... 47
8.12 WET WEATHER OPERATIONS ............................................................................................. 47
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 6
8.13 FIRE PREVENTION AND CONTROL MEASURES ................................................................ 48
CONTROLLED BURNING ....................................................................................................... 49
8.14 EQUIPMENT ............................................................................................................................ 49
8.15 ASBESTOS HANDLING .......................................................................................................... 49
8.16 QUALITY ASSURANCE .......................................................................................................... 51
PART 9 RECYCLING AND RESOURCE RECOVERY ................................................................ 52
9.1 GENERAL ................................................................................................................................ 52
9.2 COMINGLED RECYCLABLES ................................................................................................ 52
9.3 GREENWASTE ....................................................................................................................... 52
9.4 SCRAP METAL & CAR BATTERIES ...................................................................................... 52
9.5 TYRES ..................................................................................................................................... 53
9.6 WASTE OIL ............................................................................................................................. 53
9.7 CONCRETE BRICKS AND TILES ........................................................................................... 53
9.8 CLEAN FILL ............................................................................................................................. 53
9.9 REUSE CENTRE ..................................................................................................................... 53
PART 10 ENVIRONMENTAL MANAGEMENT ISSUES ................................................................ 54
10.1 WATER .................................................................................................................................... 54
10.1.1 LEACHATE MANAGEMENT ........................................................................................ 54
i. LEACHATE BARRIER ................................................................................................. 54
ii. LEACHATE COLLECTION SYSTEM .......................................................................... 54
iii. LEACHATE DISPOSAL ............................................................................................... 55
iv. UPGRADES ................................................................................................................. 56
10.1.2 STORMWATER ............................................................................................................ 57
i. UPGRADES ................................................................................................................. 58
GROUNDWATER .................................................................................................................... 60
10.2 NOISE MANAGEMENT ........................................................................................................... 60
10.3 ODOUR CONTROL ................................................................................................................. 61
10.4 LITTER CONTROL .................................................................................................................. 62
10.5 DUST CONTROL ..................................................................................................................... 63
10.6 LANDFILL GAS MANAGEMENT ............................................................................................. 64
10.7 FERAL PESTS AND VERMIN CONTROL .............................................................................. 66
10.8 WEED MANAGMENT .............................................................................................................. 67
10.9 FINANCIAL ASSURANCE ....................................................................................................... 68
PART 11 ENVIRONMENTAL MONITORING ................................................................................. 70
11.1 RECORDS ............................................................................................................................... 70
11.2 GROUNDWATER .................................................................................................................... 70
LOCATION POINTS AND MONITORING ............................................................................... 70
GROUNDWATER POLLUTION DETECTION......................................................................... 71
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 7
11.3 LEACHATE .............................................................................................................................. 72
LOCATION POINTS AND MONITORING ............................................................................... 72
DISCHARGE OF LEACHATE TO SURFACE WATER ........................................................... 73
11.4 SURFACE WATER .................................................................................................................. 74
LOCATION POINTS AND MONITORING ............................................................................... 74
SURFACE WATER POLLUTION DETECTION ...................................................................... 75
11.5 RAINFALL MONITORING ....................................................................................................... 76
11.6 LANDFILL GAS ........................................................................................................................ 76
REMEDIATING LANDFILL GAS EMISIONS ........................................................................... 77
11.7 LANDFILL VOLUME ................................................................................................................ 77
11.8 COMPLAINTS HANDLING ...................................................................................................... 77
PART 12 SITE CLOSURE AND REHABILITATION ...................................................................... 78
12.1 CLOSURE PLAN ..................................................................................................................... 78
12.2 POST CLOSURE MANAGEMENT .......................................................................................... 79
ENVIRONMENTAL MANAGEMENT ....................................................................................... 79
ENVIRONMENTAL MONITORING ......................................................................................... 79
MAINTENANCE ....................................................................................................................... 79
PART 13 REPORTING ................................................................................................................... 80
13.1 MONTHLY SECTION 88 LEVY REPORTING ......................................................................... 80
13.2 ANNUAL REPORTING ............................................................................................................ 80
13.3 INCIDENT REPORTING .......................................................................................................... 81
EMERGENCY CONTACTS ..................................................................................................... 82
APENDICIES ................................................................................................................................... 85
APPENDIX 1: ENVIRONMENTAL PROTECTION LICENSE .......................................................... 86
APPENDIX 2: DRAWINGS .............................................................................................................. 87
APPENDIX 3: PLANS ...................................................................................................................... 88
APPENDIX 4: NON-COMPLIANCE RECORD ................................................................................ 92
APPENDIX 5: ANNUAL RETURN ................................................................................................... 96
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 8
Table of Figures
Figure 1 – ENLARGED BELLINGEN SHIRE LOCALITY BOUNDARIES, 2006 ............................. 10
Figure 2 –LOT86 D.P. 630914, BELLINGEN SHIRE COUNCIL RECORDS 2014 ......................... 19
Figure 3 – BELLINGEN LEP 2010: LAND ZONING MAP 6C &6E COMBINED ............................. 21
Figure 4 – GROUNDWATER BORE MAP ....................................................................................... 27
Table of Tables
Table 1 – ENVIRONMENTAL PROTECTION LICENSE ................................................................. 13
Table 2 - SOLID WASTE LANDFILL GUIDELINES ........................................................................ 16
Table 3 – CLIMATE DATA ............................................................................................................... 23
Table 4 – WASTE TYPES AND QUANTITIES ................................................................................ 30
Table 5 – KERBSIDE COLLECTION ............................................................................................... 30
Table 6 – BELLINGEN SHIRE POPULATION GROWTH ............................................................... 31
Table 7 – ACCEPTABLE WASTES ................................................................................................. 41
Table 8 – COVER MATERIAL REQUIRED ..................................................................................... 45
Table 9 – GROUNDWATER MONITORING POINTS ..................................................................... 70
Table 10 – GROUNDWATER MONITORING POLLUTANTS AND FREQUENCY ........................ 71
Table 11 – MONITORING POINT 18 TRIGGER VALUES .............................................................. 72
Table 12 – LEACHATE MONITORING POINTS ............................................................................. 72
Table 13 – LEACHATE POLLUTANTS AND FREQUENCY ........................................................... 73
Table 14 – SURFACE WATER MONITORING POINTS ................................................................. 74
Table 15 – SURFACE WATER POLLUTANTS AND FREQUENCY ............................................... 75
Table 16 – SURFACE WATER PERMITTED EXCEEDANCES ...................................................... 76
Table 17 – LANDFILL GAS MONITOING POINTS AND FREQUENCY ......................................... 76
Table 18 – BELLINGEN SHIRE COUNCIL CONTACTS ................................................................. 82
Table 19 – EMERGENCY ORGANISATION CONTACTS .............................................................. 83
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 9
Definitions
AHD Australian Height Datum
BSC Bellingen Shire Council
Council Bellingen Shire Council
DA Development Application
EIS Environmental Impact Statement
EPL 5896 Raleigh Waste Management Centre Environmental Protection Licence
EPA New South Wales Environmental Protection Authority
LCP Landfill Closure Plan
LEMP Landfill Environmental Management Plan
LEP Bellingen Local Environment Plan
Licence Environmental Protection Licence
OEH Office of Environment and Heritage
POEO Protection of the Environment Operations Act 1997
RWMC Raleigh Waste Management Centre
SEPP State Environmental Planning Policy
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 10
PART 1 INTRODUCTION
1.1 BACKGROUND
Impact Environmental Consulting have been contracted by Bellingen Shire Council (“Council”) to
review and update the Landfill Environmental Management Plan (“LEMP”) for its Raleigh Waste
Management Centre (“the RWMC”) which was produced in 1999 by Jelliffe Environmental.
Changes in landfill management have brought about the need to review the LEMP. Council is
committed to improving management operations generally at the Landfill through the adoption and
implementation of sound environmental management practices and required infrastructure.
Figure 1 below displays the locality of the Raleigh Waste Management Centre as shown by the red
circle.
Source: Bellingen Shire Council, 2014
Figure 1 – ENLARGED BELLINGEN SHIRE LOCALITY BOUNDARIES, 2006
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 11
This LEMP provides a general framework for Council to:
i. Undertake remediation of staged landfill areas;
ii. Make efficient use of available airspace
iii. Ascertain and continually improve existing environmental management practices at
the landfill in accordance with industry guidelines1;
iv. Assess the current impact by the landfill on the surrounding environment; and
v. To minimise any future impact on the natural environment caused by the landfill.
This LEMP is integral to the planning phase at the landfill ensuring that existing and future
activities at the landfill are sustainable, performed in an environmentally sound and appropriate
manner and in accordance with the conditions prescribed under Council’s Environmental
Protection Licence (EPL).
1.2 WHAT IS A LEMP?
A LEMP contains site specific strategic approaches that an organisation can implement to ensure
a facility is managed and operated in an environmentally responsible manner.
These approaches are based on industry best practice and on guidelines such as:
For landfills; the Environmental Guidelines - Solid Waste Landfills (Guidelines), NSW
Environmental Protection Authority 1996.
For resource recovery and transfer stations; the Handbook for the Design and Operation
of Rural and Regional Transfer Stations produced by the OEH, 2006.
The guidelines provide environmental goals and management benchmark techniques that provide
an illustration of the level of environmental protection that is recommended for each aspect of a
facility’s operation.
These guidelines adopt a performance based rather than prescriptive approach that are designed
to encourage operators to use their initiative to develop integrated, appropriate and relevant
solutions for their landfill and/or transfer station (using either benchmark techniques or
alternatives) to achieve environmentally beneficial outcomes in a cost effective manner.
1.3 PURPOSE OF THE LEMP
The LEMP has been prepared as a tool to assist Council in the management of the RWMC in an
environmentally responsible manner and in accordance with best practice and industry guidelines.
Council will ensure that operations undertaken at the Landfill are in accordance with regulatory
requirements including any conditions of consent for further expansion and development of the
landfill cell and associated infrastructure, and the conditions imposed under its EPL.
The objectives of the LEMP are to ensure that the existing site, environmental practices and
operations at the RWMC are improved, to minimise any off-site effects caused to the surrounding
environment and neighbouring communities. The LEMP also provides a guide to staff employed at
the landfill site regarding general operational procedures.
1 NSW EPA, Environmental Guidelines: Solid Waste Landfills, January 1996
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 12
The LEMP aims to address the following areas:
Legislative and Other Requirements;
Site overview including the physical environment;
Approvals and Licensing;
Landfill design and operations;
Waste management practices;
Environmental management issues and monitoring requirements;
Post closure and remediation of the landfill; and
Reporting requirements.
1.4 DOCUMENT CONTROL
A copy of BSC’s EPL for the site and this LEMP shall be kept on site at all times and shall be
made available for inspection to the EPA upon request.
BSC shall ensure that all staff and sub-contractors at the site are familiar with the relevant
requirements described in this LEMP.
1.5 REVIEWS AND UPDATES
Council will review and update the LEMP (as necessary) after every review of the site EPL or at
least every 3 years to ensure that it reflects the facilities and operations at the Raleigh Waste
Management Centre and any changes in regulatory requirements. This shall include undertaking
revisions and updates due to changes in the site’s EPL or due to changes in operations or
directives from BSC or the EPA.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 13
PART 2 KEY DRIVERS OF THE LEMP
2.1 COMPLIANCE WITH EPA LICENSE
This LEMP has been structured to address each and every EPL condition as shown below in
Table 1.
Table 1 – ENVIRONMENTAL PROTECTION LICENSE
Administrative Conditions Addressed in Section
of LEMP
A1 What the licence authorises and regulates 4.6
A2 Premises to which this licence applies 4.4
A3 Other activities N/A
A4 Information supplied to the EPA
Refer to License
Application
Discharges to Air and Water and Applications to
Land
Addressed in Section
of LEMP
P1
Location of monitoring/discharge points and
areas
11.2, 11.3, 11.4, 11.5,
1.6
Limit Conditions Addressed in Section
of LEMP
L1 Pollution of waters 11.2, 11.4
L2 Load limits N/A
L3 Concentration limits 11.4
L4 Volume and mass limits N/A
L5 Waste Table 6
L6 Noise Limits 10.1
L7 Hours of operation 8.1
L8 Odours 10.3
Operating Conditions Addressed in Section
of LEMP
O1
Activities must be carried out in a competent
manner 8.2
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 14
O2 Maintenance of plant and equipment 8.14
O3 Dust Control 10.5
O4 Closure plan 12.1
O5 Tyre Storage 9.5
O6 Leachate management 10.1.1
O7 Management of surface waters 10.1.2
O8 Fire risk reduction works 10.9
O9 Fire extinguishment 10.9
O10 Fire fighting capability 10.9
O11 Burning of green waste 10.9
O12 Quality assurance 8.18
O13 Screening of waste 8.6
O14 Filling plan 8.9
O15 Completion of landfill cells 8.11
O16 Unauthorised entry 8.5
O17 Degradation of local amenity 10.4
O18 Covering of waste 8.10
Monitoring and Recording Conditions Addressed in Section
of LEMP
M1 Monitoring records 11.1
M2
Requirement to monitor concentration of
pollutants discharged 11
M3 Testing methods - concentration limits 11
M4 Recording of pollution complaints 11.8
M5 Telephone complaints line 11.8
M6 Requirement to monitor volume or mass 11.3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 15
M7 Monitoring remaining landfill capacity 11.7
M8 Rainfall Monitoring 11.5
M9 Laboratory accreditation 11.1
Reporting Conditions Addressed in Section
of LEMP
R1 Annual return documents 13.2
R2 Notification of environmental harm 13.3
R3 Written report 13.3
R4 Recording of fires 13.3
R5 Leachate discharges to surface waters 13.3
R6 Landfill Gas Hazard Reporting 11.6
R7 Groundwater contamination reporting 13.3
R8 Surface water contamination reporting 13.3
General Conditions Addressed in Section
of LEMP
G1 Copy of licence kept at the premises 1.4
Source: Environment Protection Licence Number 5896
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 16
2.2 COMPLIANCE WITH LANDFILL GUIDELINES
This LEMP has been structured to address the relevant environmental goals stated in the
Environmental Guidelines: Solid Waste Landfills as shown below in Table 2.
Table 2 - SOLID WASTE LANDFILL GUIDELINES
Environmental Goals Addressed in Section of LEMP
Water Pollution
Preventing pollution of water by leachate 10.1.1
Detecting water pollution 11.2,11.3,11.4
Remediating water pollution 11.2,11.4
Air Pollution
Preventing landfill gas emissions 10.6
Detecting landfill gas emissions 11.6
Remediating landfill gas emissions 11.6
Land Management and Conservation
Assuring quality of design, construction and
operation 8.18
Assuring quality of incoming waste 8.6
Recording of wastes received 8.7
Minimising landfill space used 8.8
Maximisation of recycling 9
Remediating landfill after closure 12
Hazards and Loss of Amenity
Preventing unauthorised entry 8.5
Preventing degradation of local amenity 10.4
Preventing noise pollution 10.2
Adequate fire fighting capacity 8.13
Adequate staffing and training 8.2
Source: Environmental Guidelines: Solid Waste Landfills, 1996
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 17
2.3 EPA LICENCE AND GUIDELINES IN THIS LEMP
In addition to the tables above, the relevant licence conditions and benchmark techniques are
featured in the left column. An example is shown below:
O13.1 - The licensee must have in place and implement procedures to identify and prevent the
disposal of any waste not permitted by this licence to be disposed of at the premises in
accordance with the procedures in section 4.5.10 and 4.5.11 of the LEMP.
BM 21 - Screening of Waste Received: The landfill occupier should have in place waste
acceptance and screening procedures to ensure that the site does not accept wastes that are
prohibited from entry.
O13.1
BM 21
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 18
PART 3 RELEVANT LEGISLATION, POLICIES AND GUIDELINES
Activities carried out at the Bellingen Waste Management Centre must comply with the relevant
provisions of all legislation relating to the operation of the Facility. This includes but is not limited
to the following:
Protection of the Environment Operations Act 1997
Protection of the Environment Operations (Waste) Regulation 2005
Clean Energy Act 2011
Protection of the Environment Operations (General) Regulation 2009
Soil Conservation Act 1938
Dangerous Goods Act 1975
Environmental Restoration and Rehabilitation Act 1990
Environmentally Hazardous Chemicals Act 1985
Waste Minimisation and Management Act 1995
Ozone Protection Act 1989
Rivers and Foreshores Improvement Act 1948
Heritage Act 1977
Water Act 1912
Bushfire Act 1949
Native Vegetation Act 2003
Threatened Species Conservation Act 1995
Environmental Planning and Assessment Act 1979
Fisheries Management Act 1998
Waste Management Act 2000
Waste Avoidance and Resource Recovery Act 2001
The Environment Protection Authority’s “Environmental Guidelines; Solid Waste Landfills, 1996”
has significant importance and forms part of the regulatory framework for the operation and
management of the RWMC.
The RWMC is also licensed and regulated under an Environmental Protection Licence pursuant to
the Protection of the Environment Operation Act 1997 (POEO Act).
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 19
PART 4 SITE OVERVIEW
4.1 LOCATION
The Raleigh Waste Management Centre is located on Lot 86 D.P. 630914 which is approximately
9km east of the township of Bellingen. The entrance is off Short Cut Road as shown below in
Figure 2 which connects to Waterfall Way and the Pacific Highway. The total area of the landfill
site is 6.3 hectares.
Source: Bellingen Shire Council, 2014
Figure 2 –LOT86 D.P. 630914, BELLINGEN SHIRE COUNCIL RECORDS 2014
The landfill is located within a small valley bounded to the north by a ridge of appoximatly 23 m
Australian Heigh Datum (AHD) elevation. The ridge forms the northern boundary of the landfill site
catchment. The existing surface of the landfill has been raised to an elevation of around 15m AHD.
N
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 20
The services provided by the Centre include:
Raleigh Reuse Shop which is a waste collection and sorting building
Small Vehicle Transfer Station:
34m3 domestic putrescible waste skip
34m3 comingled recyclables skip
34m3 greenwaste skip
Hazardous chemical storage shed
Mattress storage shed
Waste oil storage shed
Temporary battery storage shed
Collapsable E-waste skip bin
Bulky greenwaste stockpile
4.2 LAND USE AND ZONING
Land surrounding the landfill site is zoned General Industrial (IN 1). This zone extends at least
500m beyond the existing landfill area which can be seen below in Figure 3.
Zone IN1 General Industrial: Objectives of zone
To provide a wide range of industrial and warehouse land uses.
To encourage employment opportunities.
To minimise any adverse effect of industry on other land uses.
To support and protect industrial land for industrial uses.
To minimise any adverse effect of industry on the surrounding environment, with
particular regard to the on site disposal of effluent and the generation of stormwater.
To ensure that industrial development is adequately screened from the view of
classified roads
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 21
Source: Bellingen Shire Council, 2014
Figure 3 – BELLINGEN LEP 2010: LAND ZONING MAP 6C &6E COMBINED
Part of the industrial zone near the landfill site has been classified Zone E3 Environmental
Management which provides a ‘buffer zone.’ This encircles the northern, eastern, western and
south eastern boundaries of the industrial zone. Only land to the south west does not fall under
this zoning. There is no land use conflict for this area and the landfill.
N
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 22
4.3 NEIGHBOURING LAND USES
Generally land to the west of the site is predominantly rural. Land to the north is forested and an
industrial area bounds the site to the south. The closest residence is located approximately 250m
from the Raleigh Reuse Shop.
Land use zones adjacent to the General Industrial (IN 1) Zone include:
E3 Environmental Management: north, east, west and south east
R5 Large Lot Residential: west and north.
Land use zones in the broarder viscinity of the General Industrial (IN 1) Zone include:
RU4 Primary Production Small Lots: south west
SP2 Special Infrastructure (Classified Road): east
4.4 OWNERSHIP
Bellingen Shire Council owns the land on Lot 86 D.P. 630914 where the landfill site is situated.
4.5 SITE HISTORY
It is understood that the site has been used for solid waste disposal since 1978.2
PLANNING CONSENT
There is no evidence of the original Development Application on Councils Property Planning
Consent System. The earliest documented application on Lot 86 D.P. 630914 is regarding the
construction of a caretaker residence in 1985.
Approval for DA-00376 was granted in 1999 regarding the landfill extension.
4.6 LICENCING
The Raleigh Waste Management Centre is currently licensed under the Protection of the
Environment Operations Act 1997 (POEO Act) (Licence No, 5896)
Scheduled Activity: Waste disposal (application to land)
Fee Based Activity Scale; Waste disposal (application to land) Scale 0 – All.
A copy of the current licence is annexed in Appendix 1.
2 Jelliffe Environmental - Raleigh Waste Management Facility EIS 2/9/97
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 23
PART 5 PHYSICAL ENVIRONMENT
5.1 CLIMATE AND METEROLOGICAL CHARACTERISTICS
The site is located in a humid sub-tropical climate with warm to hot, humid summers and mild, dry
winters with the occurrence of high intensity rainstorms. Rainfall predominantly occurs in the
summer months. The average annual rainfall is 1701.5mm3 as measured at the Coffs Harbour
Meteorological Observation (MO) station.
The mean daily pan evaporation rate for Coffs Harbour MO is 4.4mm/day. Wind conditions are
variable throughout the year. As a general pattern winds are predominantly from the south west in
the morning and from the north east in the afternoon.
Table 3 below displays detailed climate data obtained from the Bureau of Meteorology.
Table 3 – CLIMATE DATA
Ja
nua
ry
Fe
bru
ary
Ma
rch
Ap
ril
Ma
y
Ju
ne
Ju
ly
Au
gu
st
Se
pte
mb
er
Octo
be
r
Nove
mb
er
Dece
mb
er
An
nu
al
Temperature
Mean maximum
temperature (°C) 26.9 26.8 26 24 21 19 19 20 22 24 25 26 23.3
Mean minimum
temperature (°C) 19.4 19.5 18 15 12 9 7.6 8 11 14 16 18 14
Rainfall
Mean rainfall
(mm) 189 222 234 179 160 123 74 77 60 98 143 145
1701.
5
Decile 5 (median)
rainfall (mm) 151 179 201 135 117 90 58 41 36 75 125 114
1623.
5
Mean number of
days of rain >= 1
mm 9.4 9.5 11 8.5 7.6 6.2 4.5 5 4.5 6.8 8.1 8.4 88.8
Mean number of
days of rain >= 10
mm 3.8 3.9 4.7 3.6 3 2.6 1.6 1 1.2 2.2 3.3 3.3 34.6
Mean number of
days of rain >= 25
mm 1.7 1.8 2.2 1.7 1.3 1.3 0.7 1 0.3 0.8 1.3 1.2 14.9
Other Daily
Elements
Mean number of
clear days 7 5.9 8.3 9.8 10 11 14 15 14 10 8.1 7.9 122.1
3 Mean average rainfall as measured at Bellingen Post Office is 1520.4mm. Measurements ceased in 2002.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 24
Mean number of
cloudy days 12.8 12.8 12 11 11 9.7 8 7 6.5 9.8 11 12 123.2
Evaporation
Mean daily
evaporation (mm) 6.2 5.6 4.8 3.9 2.8 2.3 2.5 3 4.5 5.2 5.7 6.2 4.4
9am
Conditions
Mean 9am
temperature (°C) 23.9 23.4 23 21 17 15 14 15 19 21 22 23 19.7
Mean 9am
relative humidity
(%) 72 75 74 71 71 71 67 60 56 61 65 68 68
Mean 9am wind
speed (km/h) 14.5 13.4 13 12 11 11 10 12 14 16 16 15 13.1
3pm
Conditions
Mean 3pm
temperature (°C) 25.3 25.3 25 23 20 18 18 19 20 22 23 24 21.8
Mean 3pm
relative humidity
(%) 69 71 69 65 62 59 54 53 57 63 65 68 63
Mean 3pm wind
speed (km/h) 22.4 20.9 19 17 15 15 16 18 22 23 24 23 19.5
Source: Bureau of Meteorology Coffs Harbour MO Station, 2013
5.2 FLORA AND FAUNA
Much of the site has been disturbed as a result of more than 25 years of landfill operations. During
the Environmental Impact Statement (EIS) process a flora and fauna survey was undertaken in
1996. It found that there were:
“No endangered or vulnerable species listed in Schedules 1 and 2 of the Threatened Species
Conservation Act 1995 or ROTAP plants were identified on the site. It is concluded that the
proposed extension will no effect any areas of significant, endangered or vulnerable flora.”
“No reptile, bird or mammal species listed in Schedules 1 and 2 of the Threatened Species
Conservation Act 1995 or ROTAP plants were identified on the site.”
5.3 TOPOGRPAHY
The site is located on the southern side of a small ridge with the landfill area situated in the valley.
A detailed survey of the site was undertaken in 2013 by Hopkins Consultants on behalf of Impact
Environmental. Drawing 6835-0002-01 in Appendix 2 displays the existing topography.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 25
Site topography is characterised by a small ridge running steeply down to the south. The elevation
of the site varies from maximum heights of approximately 23m AHD along the ridge line to a low
point of approximately 4m AHD at the toe of the landfill. The existing landfill surface is generally
flat with gradients less than 2%. Batters around the edge of the landfill are constructed to a
gradient of 33%.
5.4 GEOLOGY AND SITE SOILS
Boreholes drilled at the site as part of the EIS for the expansion of the facility in 1997 indicated that
the sub-surface strata on the ridge is of weathered phyllite origin, being multicoloured, silty clay
with residual rock structure. Soil at the toe of the landfill area comprises a grey to black, silty
topsoil over silt, clayey silt and silty clay. The silty clays are grey or yellow brown with some red-
brown mottling. The site is underlain by highly weathered grey-yellow-brown phyllite clay to a
depth of 4 meters4.
The underlying geology is part of the Nambucca Beds consisting of slate, phyllite, schistose
sandstone and schistose conglomerate. Quaternary sediments are located in the drainage line
along the southern boundary and in the low lying eastern section of the site.
ACID SULPHATE SOILS
During the EIS process CaLM ASS Risk Maps (Bellingen/Raleigh) identified potential acid
sulphate soils on the eastern edge of the landfill. Testing of this area in November 1997 during the
construction of sediment control ponds found Acid Sulphate Potential to be below the level of
concern established by the EPA.
5.5 SURFACE WATER HYDROLOGY
The Raleigh landfill site is located within the Boggy Creek and Yellow Rock Creek catchments.
Runoff from the Raleigh landfill flows into Boggy Creek which flows east into Yellow Rock Creek.
This then joins the Kalang and Bellinger Rivers. The total drainage path is approximately 3km from
the landfill to the Kalang River5.
Waters of the Kalang and Bellinger River are traditionally used for cultivating oysters and for
recreational uses. Currently all oyster farming in the Kalang River is on hold due to issues
involving septic tanks and farm runoff in the area. The creek immediately below the Melaleuca
forest is used by cattle. It is therefore necessary to ensure that the landfill does not cause levels of
pollution which may adversely affect those beneficial uses.
The surface water catchment of the Raleigh landfill area is 6.3 ha. This is formed by the ridge on
the northern and western boundaries. A channel running along the southern boundary of the
landfill area to the Melaleuca forest diverts runoff from the upper catchment west of the landfill site
(20.6ha) and part of the industrial estate (5.3ha) but does not collect water from the landfill site.
4 Jelliffe Environmental - Raleigh Waste Management Facility EIS 2/9/97 5 Jelliffe Environmental - Raleigh Waste Management Facility EIS 2/9/97
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 26
5.6 GROUNDWATER HYDROLOGY
Low lying areas below the site are characterised by silty clays overlaying phyllite bedrock. The
water table in this area fluctuates at times becoming saturated near the surface6. Groundwater
depth monitoring has been undertaken in a series of seven bore holes (BH) around the perimeter
of the facility. Their location is annexed in Appendix 3: Plan E.
Subsurface investigations during the original EIS stated:
Occasional bands of quartz gravel were located at 5.0 to 5.2 m below ground level7 within the
Melaleuca forest which are a potential source of water inflow. On the eastern edge of the
Melaleuca forest a water inflow zone is located 1.5 m below ground level, with another level
located at a depth of 5.4 m below ground level.
The original EIS in 1997 stated:
Nearby water bores were over 3 km from the landfill site to the NNE. It is considered extremely
unlikely that water originating in the landfill would flow in the direction of these bores or be
affected by the landfill.
Since 1997 there have been a number of new groundwater bores drilled in the vicinity of the
landfill as shown below in Figure 4. Some of these the bores are located in the direction of the
north east groundwater flow as annexed in Appendix 3: Ground Water Flow diagram.
6 Jelliffe Environmental - Raleigh Waste Management Facility EIS 2/9/97 7 Jelliffe Environmental - Raleigh Waste Management Facility EIS 2/9/97
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 27
Source: NSW Office of Water, 2013
Figure 4 – GROUNDWATER BORE MAP
Recent rounds of groundwater monitoring on 05/12/12 and 04/06/13 at Bore Hole 7 (Monitoring
Point 18 in EPA Licence) indicate that the downstream water is well within the licence conditions.
GROUNDWATER USE
Groundwater is extracted for various purposes from sites down gradient from the landfill such as
agricultural purposes.
5.7 FORESTRY
The NSW Resource Atlas indicates that Newry and Tarkeeth State Forests are the closest forests
to the RWMC. Newry State Forest is located approximately 2km SW of the Raleigh Resource Hub.
Tarkeeth is situated 6 to 8 km further west of the facility.
N
Raleigh Waste Management
Centre
Locality
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 28
5.8 ACCOUSTIC ENVIRONMENT
The existing acoustic environment is characterised by:
rural activities
industrial activities in the neighbouring industrial area
traffic generated by the landfill
plant operations within the landfill
the re-use centre
traffic along Short Cut Road
Noise measurements were recorded during the EIS process for the landfill expansion.
Background noise measurements were taken at the closest residence which was approximately
200m west of the site. The daytime lowest repeatable LA90-15min background noise level was
found to be 40 dB.
5.9 VISUAL AMENITY
The RWMC is located within a well wooded valley and is largely hidden from view from Short Cut
Road or Waterfall Way. The landfill only becomes visible upon turning off Shortcut Road and
approaching the gate. The recycling area is visible to the closest residence to the West. The visual
character of the landfill itself is dominated by exposed earth, plant, waste piles and dust
surrounded by open eucalypt forest and scarred hill slopes. As expected the landfill has a low
visual aesthetic value and hence low visual amenity.
The area of the landfill has a moderately low aesthetic value due mainly to inaccessibility and the
fact that it does not from part of any wider view. As the landfill approaches 22 m AHD it has the
potential to become more visually accessible from the Short Cut Road and the industrial park the
south. The visual impact will be minimised through revegetation.
5.10 CULTURAL AND HERITAGE VALUES
During the EIS a cultural and heritage survey was undertaken in 1996 finding that the area held no
special significance to the local Aboriginal people. This is possibly as a result of extensive clearing
and landfill operations.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 29
PART 6 WASTE TYPES AND QUANTITIES
6.1 GENERAL
Bellingen Shire has a population of approximately 12,819. The waste catchment for the landfill
comprises the following areas:
Township of Bellingen
Mylestom/Repton
Township of Urunga
Rural Valley and seaboard
6.2 WASTE TYPES AND QUANTITIES
The RWMC accepts a range of wastes from the Bellingen local government area and from the
region. The predominant source of waste in the catchment is municipal solid waste to a lack of
heavy industries. There is some commercial and light industry waste.
The range of materials accepted at the RWMC includes:
Municipal solid waste (putrascible and non-putresciable)
Commingled recylables
Construction and demolition material
Greenwaste
Metals for recycling
Tyres
Waste Oil
E-waste
The amount of waste deposited to landfill is calculated using NSW EPA’s weight conversion
factors. Table 4 below contains the waste tonnage data for the RWMC.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 30
Table 4 – WASTE TYPES AND QUANTITIES
Units
Jun 2012 - May
2013
Jun 2013 -
Dec 2013
Accepted Waste - RWMC
Municipal Solid Waste tonnes 569.6 257.23
Commercial and Industrial Waste tonnes 0 0
Construction and Demolition Waste tonnes 733.52 402.76
Transferred Waste tonnes 1065.96 609.58
Asbestos Waste tonnes 49 30
Contaminated Soil tonnes 0 0
VENM tonnes 78.67 0
Total tonnes 2,496.75 1,299.57
Resource Recovery - RWMC
Garden Waste tonnes 463.36 281.22
Scrap Metal (ferrous) tonnes 161.4 100
Scrap metal (non-ferrous) tonnes 11.35 12.28
Bricks and Concrete tonnes 0 0
Waste Oil litres 4950 1600
Mattresses (number) number 58 74
Co-mingled recycling tonnes 242.16 137.16
E-waste tonnes 13.96 15.27
Total Resource Recovery tonnes
Source: Bellingen Shire Council, 2013
Waste collected by the kerbside collection is taken to Coffs Harbour for processing; as such it
does not enter the RWMC. Before 2007 this waste was disposed at the RWMC. Table 5 below
provides an indication of the kerbside collection tonnages.
Table 5 – KERBSIDE COLLECTION
MATERIAL 2012 2011 2010 2009 2008 2007 2006
Recycling 1,101.68 1,224.80 1,180.68 1,209.74 1,239.84 1,228.21 1,345.89
Organic 1,513.08 1,597.20 1,433.62 1,351.28 1,398.82 938.88 -
MSW 1,325.20 1,150.68 1,193.96 1,433.48 1,243.14 1,153.53 1,766.91
Source: Bellingen Shire Council, 2013
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 31
6.3 WASTE GROWTH
With no heavy industry and limited light industry in Bellingen Shire waste growth is dependent on
domestic waste. The historic growth in population is shown below in Table 6.
Table 6 – BELLINGEN SHIRE POPULATION GROWTH
YEAR ENDING JUNE 30 NUMBER % CHANGE
2001 12,634 --
2002 12,673 +0.31
2003 12,705 +0.25
2004 12,672 -0.26
2005 12,682 +0.08
2006 12,716 +0.27
2007 12,773 +0.45
2008 12,787 +0.11
2009 12,837 +0.39
2010 12,891 +0.42
2011 12,923 +0.25
2012 12,819 -0.80
Source: Australian Bureau of Statistics, Regional Population Growth, Australia 2012
The population of Bellingen Shire has remained relatively steady in the years 2001-2012; the
amount of waste disposed at the RWMC however has dropped significantly during this period. In
1998 there were 8,166 tonnes per year of waste landfilled at the RWMC; by 2013 this has dropped
to 1,389 tonnes per year. The large decrease can be attributed to the introduction of a three bin
collection system as part of the Coffs Coast Waste Services (CCWS) partnership between
Handybin Waste Services, Coffs Harbour City Council, Bellingen and Nambucca Shire Council.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 32
PART 7 FACILITY DESIGN
7.1 ACCESS AND LAYOUT
The Raleigh Waste Management Centre is located approximately 9km east of Bellingen off
Shortcut Road. Drawing 6835-0002-01 in Appendix 2 displays the general layout.
The main features of the RWMC include the following:
Small vehicle transfer station;
Reuse centre;
Hazardous chemical shed;
Mens club shed;
Stockpile areas for garden waste, scrap metal, tyres, mattresses;
Animal carcass trench;
Landfilling area for general solid waste;
Stormwater ponds;
Leachate storage tanks; and
Leachate interception trench
7.2 FACILITIES
SMALL VEHICLE TRANSFER STATION
The small vehicle transfer station is located a short distance from the entrance of the facility. It
comprises a covered rectangular pad including two large 34m3 hook lift bins. One bin is provided
for domestic putrescible municipal solid waste, the other is for commingled recyclables.
Greenwaste is deposited in a 34m3 skip that is adjacent to this shed.
All material collected is transported by Handybin Waste Services to the Coffs Coast Resource
Recovery Facility on Englands Road, Coffs Harbour under the Coffs Coast Waste Services
(CCWS) regional contract.
REUSE CENTRE
The reuse centre is located adjacent to the load inspection point. BSC staff collect and sort
incoming waste, diverting reusable items such as furniture into the reuse centre.
BULKY GARDEN WASTE PROCESSING AREA
Bulky greenwaste such as tree stumps and trunks is not accepted under the Coffs Coast Waste
Services (CCWS) regional contract. At present it is temporarily stockpiled an old quarry towards
the east of the site where it is shredded and used on site.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 33
SCRAP METAL STORAGE AREA
Scrap metal is stockpiled along the ridge to the north of the existing landfill area. It is separated
into ferrous and non-ferrous materials. Once the stockpile reaches sufficient size it is collected by
Matthews Metal Management.
TYRES STOKCPILE AREA
Tyres are stockpiled adjacent to the scrap metal pile on the northern ridge of the landfill. Once the
stockpile reaches sufficient size it is collected by Tyre Cycle.
MATTRESS STORAGE SHED
Mattresses are stored in an old shed located on the northern ridge of the landfill. RWMC staff strip
the mattresses, recovering the ferrous metal which is stockpiled in the scrap metal storage area.
WASTE OIL SHED
The waste oil is stored in a lockable shed adjacent to the small vehicle transfer station. It is
collected by Australian Waste Oil.
E-WASTE CAGE
E-waste items are stored in collapsible cages next to the waste oil. They are collected by
Matthews Metal Management.
HAZARDOUS MATERIALS STORAGE SHED
Hazardous materials such as chemicals, chemical containers and used gas cylinders are stored in
a purpose built lockable shed on a bunded base located near to the entry to the centre. They are
collected by Transpacific Industries.
7.3 FINAL LANDFORM AND LIFE OF SITE
The final landform will consist of a domed landform with a minimum 5% (1V:20H) grade to shed
water. It is proposed to rehabilitate the landfill batters as they are completed by shaping to a
maximum grade of 33% (1V:3H) and covering with suitable clay material and topsoil. According to
Council this has been completed through stages 1 to 4 which has raised the landfill to its present
surface of around 15m AHD.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 34
Stages 1 to 4 as stated in the 1996 LEMP are as follows:
Stage 1: 10m AHD
Stage 2: 12m AHD
Stage 3: 13.5m AHD
Stage 4: 15m AHD
The proposed final landform is annexed in Appendix 2: Drawing 6835-0002-02. The estimated
landfilling capacity from the existing landform to the proposed final landform is approximately
87,572 m3. This will result in approximately 52,224 m3 of airspace available for waste fill.
At the current filling rate and assuming the targeted waste compaction rate is achieved the landfill
has a predicted life of up to 20 years8.
7.4 STAGING OF LANDFILLING
Currently, landfilling operations are occurring towards the north east of the landfill area. A staging
and filling plan is annexed in Appendix 2: Drawing 6835-0002-04 with cross sections detailed in
Drawing 6835-0002-05. Filling of the landfill, detailed in 8.9, will be in successive lifts of no greater
than 1.5 metres deep. In general it is proposed to fill towards a central ridge which will run east
west. To minimise infiltration, the landfill surface at each stage will have a minimum gradient of 1%
towards the batters of the landfill.
A general overview of the works required to support ongoing landfilling activities is as follows:
Regrading of the landfill surface during future lifts to promote water sheding;
Upgrade of the perimter drainage system;
Installation of additional spurs in the leachate interceptor trench;
Upgrade of the leachate irrigation system.
STAGE 1
Stage 1 will involve raising the surface of the landfill from 15m AHD to around 17m.
STAGE 2
Stage 2 will involve raising the surface of the landfill to a maximum of 19.795m along the east west ridge. This will be the final level of the waste before the capping layer is applied.
7.5 FUTURE USE
The final land use options for the completed landfill are considered limited due to:
The crossfall on the finished surface and the steep batters
The potential for ongoing surface settlement and displacement due to the nature of the
waste being landfilled
The limited width of the finished surface.
8 Assuming a minimum compaction of 650 kg per cubic metre is achieved
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 35
The concepts for the future use of the landfill site have therefore been identified as:
Passive recreation including walking tracks and viewing platforms
Informal active recreation areas.
7.6 STORMWATER DRAINAGE
Stormwater drainage comprises a concrete lined drain running around the perimeter of the landfill,
temporary bunded stormwater channels and culverts on the surface of the landfill and a sediment
pond at the south east of the site as detailed in Appendix 2: Drawing 6835-0002-01.
Recent works include:
Sealing a 450mm stormwater drainage pipe that was found to be carrying leachate
Increasing bund heights across the active cell
Realigining and stabilising onsite drains
Bunding leachate irrigation areas to prevent runoff
Placing topsoil scross poorley grassed areas of the site to improve vegetation
In addition to the recent works the site stormwater management system will be upgraded,
encompassing the following:
Construction of temporary bunds and drainage on each landfill lift as required to divert
stormwater from active waste disposal areas
Excavating strips from the existing sediment pont for the purpose of sedimant retention
7.7 LEACHATE MANAGEMENT SYSTEM
A leachate model was developed for the site during the 1997 Environmental Impact Statement
process. It predicted a maximum daily production of 29,000L of leachate. The model
recommended 40,000L of storage to handle the maximum daily generation with 33% reserve
capacity remaining.
The leachate management system is divided into three components: capture, storage and
treatment:
1. Capture:
A 370m leachate interceptor trench (LIT) is excavated into the underlying phyllite around the lower
perimeter of the landfill. Refer to annexed Plan 2 and 3 in Appendix 3. It is lined with a 2mm
HD.P.E liner on the outer edge with a continuous membrane. A 150mm perforated agricultural
pipe drains the leachate to a low point. Here a 1,500L leachate sump is located with dual
submersible pumps (3 l/s) which are activated by the depth of leachate in the sump. The sump is
covered and locked to prevent unauthorised access.
A high level alarm will be activated if the leachate sump storage level exceeds 75%.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 36
2. Storage:
Leachate is pumped into two 25,000L concrete tanks located south of the landfill area as annexed
Plan 2 in Appendix 3.
A high level alarm will be activated if the tank storage level exceeds 75% and the leachate sump
pumps shall be set to cut out when the level reaches 95%. The tanks are accessible by a pump
truck to allow for periodic silting and emergency emptying.
3. Treatment:
Dual submersible pumps (3 L/s) pump leachate from the tanks into a recirculation network. This
irrigates the leachate across bunded areas of the landfill which have been intermediately capped,
relying on evaporation and evapotranspiration to reduce the volume before infiltration back into the
landfill. Time switches connected to the pump determine the application of the leachate to the
irrigation area. Irrigation is not practiced on high wind days or during times of significant rainfall.
The original design in the 1999 LEMP relied upon recirculation of leachate through trenches
excavated in the landfill (185 m x 1 m wide x 0.5 m deep) that allowed leachate to be pumped into
re-injection wells located within the landfill mass. The leachate would be absorbed into the waste
material or percolate through to the leachate interceptor trench. This practice will be reserved for
periods of heightened leachate generation.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 37
PART 8 FACILITY OPERATION
The Raleigh Waste Management Centre shall be operated by BSC in accordance with the site’s
EPL, this LEMP, and other relevant regulatory requirements.
The primary activities carried out in the Facility shall include:
Receival of waste other than hazardous waste;
Retrieval of recyclable resources and their redistribution;
The separation, storage and transfer of received waste;
Monitoring of waste movement and maintenance of records of that movement;
The control of the aspects of the Facility and its operations that may affect the
environment;
Management of the Facility to ensure the safety of the public, the operators and the
environment.
8.1 OPENING HOURS
The RWMC shall be open to the public as advertised by Council. It will be closed on nominated
public holidays and as advertised by Council.
The current summer operating hours are Sunday to Saturday 08:00 am till 5:00pm. The winter
operating hours are between 08.00 am to 4:00 pm. The waste disposal facility is closed:
New Years Day
Australia Day
Good Friday
Easter Sunday
Easter Monday
Anzac Day
Queen's Birthday
Labour Day
Christmas Day
Boxing Day
The site will remain in operation until no later than 6:00 pm so that staff may undertake required
earthmoving activities such as compaction of deposited waste, separation of waste materials and
application of daily cover material. This ensures that landfill activity disturbance impacts such as
noise, dust and odour will be minimised during times where the majority of staff and residents are
onsite.
L7.1
L7.2
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 38
8.2 MANAGEMENT, SUPERVISION AND STAFFING
The RWMC is to be supervised by suitably trained staff at all times during operating hours. Council
will provide as a minimum two (2) staff members on site any given time to ensure that the overall
management, supervision, operation and maintenance of the site and operations at the landfill are
achieved such as:
Directing the public to designated stockpile areas and tip face and ensuring public safety
and access;
Supervision of any active disposal of waste to designated waste disposal and stockpile
areas;
Design, maintenance and construction of roads, firebreaks, leachate and stormwater
ponds and associated drainage works as required;
Leachate pump and irrigation system monitoring and maintenance;
Waste screening and recording;
Ensuring that incoming collected waste is appropriately spread, separated, compacted
and covered using earthmoving equipment as required;
Recording of waste data such as tonnages, waste types including hazardous materials
and asbestos;
Ensuring that monitoring bores are maintained and accessible;
Weed, vermin, fire and litter management practices are undertaken by staff appropriately
and in accordance with this LEMP; and
Security of the site preventing unauthorised entry and illegal dumping.
The RWMC management structure is as follows:
Manager Environment and Sustainability
Waste Management Coordinator
Waste Site Supervisor
RWMC Plant Operator and Field Staff
All RWMC staff will be appropriately qualified and trained to conduct tasks allocated by the
Manager Environment and Sustainability and the Waste Management Coordinator in a safe and
proper manner.
O1.1
BM 39
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 39
At a minimum, staff training is to ensure that:
1. All operators of compaction or earthworks plant are skilled at undertaking al tasks
required of them
2. All those who operate gas testing, water sampling or testing apparatus are familiar with
required testing and sample preservation procedures, to a standard approved by the
EPA
3. Al those who inspect or direct the placement of incoming wastes are capable or accurate
data recording and skilled at identifying wastes that are unacceptable.
Staff training procedures will be documented and recorded in Councils corporate records keeping
system.
8.3 TRAFFIC MANAGEMENT
The Waste Site Supervisor and Field Staff are empowered to direct the movement of vehicular and
pedestrian traffic to ensure a safe work environment is maintained. This shall be noted as a
condition of entry on the gate signage. Traffic control signage shall be erected as directed by the
Manager Environment and Sustainability or the Waste Management Coordinator. The signage
shall include:
Conditions of entry
Hours of operation
Acceptable and prohibited wastes signage
Speed restriction signage (10 km/h max)
Directional signage
Material drop off points signage
Notification that it is the vehicle operator’s responsibility to ensure that the remnants of
their load or the material stuck to the underside of the vehicle or the wheels does not litter
public roads
There is no vehicle wash bay in operation at the RWMC.
8.4 PUBLIC AND STAFF SAFETY
Council will ensure that all staff and contractors are provided with training in workplace, health and
safety issues as it relates to the duties performed at the RWMC. Council will ensure that all staffs
are made aware of the potential hazards and risks present at the landfill and the provisions of the
Work Health and Safety Act 2011 (WHS Act) and regulations.
Council will also ensure that staffs working at the RWMC are provided with personal protective
equipment as required to perform their duties in a safe and responsible manner, in particular when
handling hazardous waste materials such as asbestos or operating machinery.
BM 32
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 40
Signage relating to safety on site will be clearly displayed for the public, staff and contractors
visiting the site ensuring that safety precautions are adhered to. The types of signage include but
not limited to:
The types of wastes not accepted on site, e.g combustible materials, unauthorised
chemical drums;
Location of first aid and fire extinguishers; and
Excluded or barricaded areas e.g. around active tipping areas and ponds.
Operational plant and equipment will be operated in such a way as to minimise risk to persons
delivering waste for disposal or transfer.
8.5 SITE SECURITY
Council will maintain adequate security on the RWMC during its life. This will include:
Access gates being locked at all times outside opening hours
Maintenance of boundary fences
Maintenance of lockable gates
The site is currently gated with a 1.5m man-proof chain link fence extending to either side. A five
strand wire cattle fence runs along the western and northern boundary of the site. The creek to the
south and Melaleuca wetland to the south east form a natural boundary. No fencing has been
installed along this boundary.
Council is aware that the fence has not been maintained to an adequate standard in certain areas
and as a result requires work to secure the facility.
Staff and contractors are provided with keys to the main gate and site buildings as deemed
necessary for after hour access.
8.6 WASTE ACCEPTANCE AND SCREENING
All wastes entering the RWMC are inspected before disposal to ensure they are not hazardous,
and their entry is to be recorded. If the load is suitable for the disposal, the drivers are
subsequently advised as to which section of the Waste Management Centre each component of
their load should be taken.
O16.1
O16.2
O16.3
BM 30
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 41
ACCEPTED WASTES
The total quantity of waste disposed of at the premises in accordance with Council’s EPL must not
exceed 8000 tonnes per year. The Raleigh Waste Management Centre is licensed to accept the
following wastes as detailed in Table 7 below.
Table 7 – ACCEPTABLE WASTES
CODE WASTE DESCRIPTION ACTIVITY OTHER
LIMITS
NA General Solid Waste
(Putrescible)
Waste
disposal
(application
to land)
Total tonnage
of waste
disposed of at
the premises
must not
exceed 8,000
tonnes per
year
NA General Solid Waste
(Non-putrescible)
As describes in Schedule 1 of the
POEO Act, in force from time to
time
Asbestos
Waste Tyres
NA General Solid Waste
Wastes assessed as General Solid
Waste which are also subject to
general or specific immobilisation
approvals which have a restriction
that they may only be disposed of
at waste disposal facilities which
have currently operating leachate
collection systems.
NA
Any waste received on site that is
below licensing thresholds in
Schedule 1 of the POEO Act, as in
force from time to time
NA
Source: NSW EPA EPL 5896, 2013
Bellingen Shire Council will not permit or allow any waste to be received at the premises except for
those expressly referred to in the EPL.
The material listed below will not be accepted for burial at the RWMC. Council staff will be
responsible for preventing their acceptance.
1. Liquid wastes
2. Radioactive wastes
3. Medical Waste
4. Any explosive, flammable material including material derived from grease, oil, tar,
petroleum or oil
5. Any sludge or refuse material (unless it can be shown to be harmless) from any:
i. Tanning or leather processing plant
ii. Petroleum or petrochemical plant
iii. Chemical plant
iv. Paint manufacturing plant
v. Metal treatment plant
vi. Vegetable oil or mineral oil plant
vii. Pharmaceutical or drug manufacturing plant
L5.1
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 42
6. Any material containing:
i. Arsenic
ii. Cadmium
iii. Cyanide
iv. Lead (including batteries)
v. Mercury
vi. Selenium
vii. Sulphide
7. Any toxic inorganic material, including any soluble salt or the following:
i. Barium
ii. Boron
iii. Chromium
iv. Copper
v. Manganese
vi. Silver
vii. Zinc
8. Fertilisers in quantities greater than 1 kg
9. Any toxic organic material, including any pesticide or weedicide, in particular containing:
i. Chlorinated hydrocarbons
ii. Fluorinated hydrocarbons
iii. Organophosphates
iv. Carbamates or thiocarbamates
v. Phenols
10. Any soluble acid or alkali or acidic or basic compound, unless it can be shown that it may
be beneficial to the operation of the depot.
WASTE TYRES
Tyres from the Sydney Metropolitan Area must not be received at the premises unless:
a) they have been shredded into pieces measuring no more than 250mm in any direction; or
b) they have had their walls removed; or
c) the facility has the capacity, at the time of receiving the tyres, to recycle or reprocess the
d) tyres into a saleable product (including retreading the tyres); or
e) the facility has the capacity, at the time of receiving the tyres, to shred the tyres or remove
the walls from the tyres; or
f) the tyres are from a domestic load containing no more than 5 tyres having a diameter of
less than 1.2 metres.
WASTE SCREENING AND HANDLING
Residents are encouraged by staff at the RWMC entrance to sort waste materials into designated
stockpiles or transfer bins at the point of access. Material suitable for sale in the Raleigh Ruse
Centre is to be identified and placed aside for processing.
All staff members that monitor the site entrance shall be trained in the identification and
classification of waste. New staff will undergo at least one week of supervised training in the
identification of materials not accepted at the RWMC. Vehicles with unacceptable loads of waste
will be refused entry to the site. Waste handling will be undertaken in accordance with relevant
L5.2
O13.1
BM 21
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 43
industry guidelines and standards.
The following activities are carried out for waste screening purposes:
1. The RWMC staff will inspect all waste loads for materials not accepted at the landfill.
2. Supervision of waste deposited at the tip face should be conducted to screen for
unacceptable waste material.
3. Signs should clearly be in place showing types of waste accepted and those not
accepted at the landfill.
4. The regional EPA office must be notified if any unauthorised hazardous wastes have
been discovered on-site. The identity of the person/s found dumping the waste must be
reported to the EPA if known.
5. Where there is any uncertainty regarding whether soil is contaminated the Waste
Management Coordinator can require NATA accredited lab testing before accepting the
material on site. This process will enable Council to screen out any single amount of
hazardous waste greater than 200 mL/tonne or 200 g/tonne. Soil which has acid
sulphate potential must be pH stabilised before it is accepted.
6. Records of all inspections are to be maintained for at least 4 years.
7. Hazardous waste should be handled by appropriately trained staff. It is the Waste
Management Coordinators responsibility to ensure that staff is appropriately trained and
that a record of the training is maintained.
UNACCEPTABLE WASTE PROCEDURE
Vehicles that are deemed by BSC staff to be carrying unacceptable waste will be refused entry, re-
directed, and details of the incident recorded. Details to be recorded include:
Date and time
Waste type
Source of waste
Approporite waste management facility and results of contact
EPA cpntact if required
RWMC personnel will advise the driver of the vehicle of appropriate waste management facilities,
or contact the EPA for advice on appropriate management of the unacceptable waste.
8.7 RECORDING OF WASTES RECIEVED
All waste loads that come into the RWMC will be inspected by Council staff at the gate. As there is
no weighbridge Council will use the EPA approved standard weights to calculate waste tonnages.
The following information will be recorded directly into Councils computer database by Council
field staff:
Vehicle type (classified using the NSW EPA Weigh Conversion Factors)
Registration number
Type of waste
Volume of waste
Source of waste (MSW, C&I or C&D)
BM 21
BM 22
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 44
All RWMC staff responsible for monitoring the site entrance shall be trained in vehicle identification
and classification of waste. New staff will undergo at least one week of supervised training in the
classification of waste accepted at the RWMC. At the end of each month the Waste Management
Coordinator will apply the EPA standard weights to each vehicle that deposited waste at the facility
in order to calculate tonnages for the monthly EPA reporting. If data if found to be missing then the
Waste Management Coordinator will be responsible for informing the EPA and estimating vehicle
movements using past months as reference.
Council will undertake a yearly volumetric survey performed by a registered surveyor as required
for the annual EPA report.
All vehicles entering the RWMC will have a receipt completed and issued by the field staff. The
receipt shall include the vehicle registration and waste classification, and amount of money paid, if
applicable.
8.8 WASTE COMPACTION
Waste deposited will be spread evenly in layers within the lift and compacted by the landfill plant
which is currently owned and operated by Council and contractors. Compaction will ideally occur
before the application of daily cover. Generally, the plant will make 3 to 5 passes over the waste
and will not operate on slopes exceeding 1:3 (vertical to horizontal) due to reduced compaction
and operational safety considerations. Heavy vehicles may also be directed over appropriately
capped areas to aid in compaction of the waste.
Council will seek to achieve the desired waste density (>650 kg/m3) required for landfills receiving
less than 50,000 tonnes per year. Council is seeking to improve its compaction capabilities
through additional plant such as a tracked loader.
8.9 FILLING PLAN
Conceptual filling plans have been developed for the site by Impact Environmental and are
annexed in Appendix 2: Drawing 6835-0002-04 and 6835-0002-05.
A staged lift approach will be used to raise the landfill profile to a maximum height of 22m AHD.
This is slightly higher than the original 20m AHD height stated in the 1999 LEMP due to the need
to achieve minimum 5% water shedding grades. Settlement of up to 20% can be expected over a
period of 20-30 years after closure which will further reduce the final profile.
Progression towards the final landform will be assessed by the Manager of Environment and
Sustainability and the Waste Management Coordinator during the annual volumetric survey with
the location of any special burials such as asbestos or decontaminated soil being updated.
BM 24
O14.1
BM 27
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 45
8.10 COVER MATERIAL
The RWMC EPA EPL 5896 states the following with regard to covering of waste:
O18.1 Cover material must be virgin excavated natural material (VENM) or an alternative
cover material approved in writing by the EPA.
(a) Daily cover: Cover material must be applied to a minimum depth of 15
centimetres over all exposed landfilled waste prior to ceasing operations at the
end of each day.
(b) Intermediate cover: Cover material must be applied to a depth of 30
centimetres over surfaces of the landfilled waste at the premises which are to
be exposed for more than 90 days.
(c) Cover material stockpile At least two weeks cover material must be available
at the premises under all weather conditions. This material may be won on site,
or alternatively a cover stockpile must be maintained adjacent to the tip face.
DAILY COVER
At the end of each day a layer of compacted soil or other EPA approved material wll be aplied to
active surfaces to a minimum depth of 150 mm.
The principle source of daily cover is an old quarry on site. However, clean fill delivered to site by
residents and small commerical operators is the prefered source of cover material. Soil excaveted
from the old quarry is of weathered phyllie orign, making it difficult to processs when wet. Council
will ensure that a stockpile of clean fill is to be kept in sufficient quantities and stockpiled in a
readily accessible location for the daily application cover to the active landfill cell. Shredded
woodwaste will be mixed with soil and used as cover for the internal batters of each lift i.e. not the
exterior batters of the landfill which will be clay capped.
The filling plans annexed in Appendix 2 indicate that there is potentially 52,224 m3 of airspace
remaining at the RWMC landfill. Putrescible landfills tend to require 20 to 25 precent of the
available airspace as daily cover. This percentage can increase substantially at smaller landfills
where there are low tonnages and an absence of specialised landfill plant. Table 8 below provides
estimates of the daily cover required at the RWMC.
Table 8 – COVER MATERIAL REQUIRED
COVER MATERIAL DAILY COVER
REQUIRED (M3)
20 % 10,444
30 % 15,667
40 % 20,889
O18.1
BM 33
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 46
These estimates will require continued revision to reflect the landfill volume consumption rates
experienced and the amount of cover used. In order to reduce the need for cover material Council
will examine the following measures where practicable:
Alternative daily cover to be used on non-traficable areas
Areas of the landfil that will be accessed by vehicles such as the tip face will be covered to
a maximum thickness of 150mm; to be thickened to 300mm if it will not be landfilled for 90
days
Weathered phyllite soil excavated from the quary is to be used for batters while clean fill
delivered to site is to be conserved for traficable areas and intermediate cover.
ALTERNATE DAILY COVER
Variability in the amount of clean fill delivered to site requires the use of the phyllite soil for daily
cover. This is not ideal due to its high water retention in wet weather, making vehicular access
difficult. The use of alternate daily cover (ADC) would enable BSC to minimise cover material
requirements and conserve clean fill.
Landfill occupiers are free to specify any alternative cover material (foams, mulch, etc.) provided
they can demonstrate compliance with the performance goals specified in benchmark Technique
33 of the Environmental Guidelines: Solid Waste Landfills 1996:
limiting run-on and infiltration of water
controlling and minimising risk of fire
minimising emission of landfill gas
suppressing site odour
reducing fly propagation and rodent attraction
decreasing litter generation
A number of ADC options exist, and one or more of the following could be used at the Raleigh
Landfill subject to EPA approval:
Tarpaulin style covers and lid style covers for non trafficable areas;
Fibre mulch applied by spray (potentially including a seed mix) for non trafficable areas;
Other spray on cover products for non trafficable areas;
Composts & mulches blended with 10% VENM for non trafficable areas; and
Crushed brick /concrete/ asphalt for trafficable and non trafficable areas.
INTERMEDIATE COVER
Intermediate cover is used to close off a cell that will not receive additional lifts of refuse or final
cover for some time. Areas of the landfill that remain inactive for a period of greater than 90 days
will be covered by 300 mm of compacted soil or other suitable material approved by the EPA.
Upon resuming waste deposition the cover material will be stripped back to a thickness of 100-
150mm and stockpiled for reuse as daily cover in subsequent lifts.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 47
8.11 FINAL CAPPING LAYER
Council will ensure that completed landfill cells are capped progressively at times when the level of
waste reaches final heights. Council will supply, construct and install a landfill capping system at
the premises in accordance with Australian Standard HB90.3 (2000) as detailed in 8.16.
At the conclusion of landfilling the landfilled areas will be levelled, graded and capped. The final
capping layer proposed draws from Benchmark 28 in the Solid Waste Landfills guidelines. A
typical capping cross section is annexed in Appendix 2: Drawing 6835-0002-05. It will comprise:
A seal bearing layer;
A 500mm clay sealing layer with permeability less than K=10-8ms-1;
A 300mm drainage layer with permeability not less than K=10-4ms-1;
A revegetation layer of depth of not less than 1000mm sown with a mixture of native and
introduced shallow rooted grasses. Fertiliser and mulch will be applied to assist
establishment.
The gas drainage layer has been omitted due to the following assumptions:
i. Waste tonnages delivered to the RWMC will remain low (less than 2,000 tonnes per
year), prolonging the remaining life.
ii. Bellingen Shire Council will continue to divert all putrescible waste and organics from
landfill;
iii. With 20 years of life remaining the vast majority methane will have been emitted from
putrescible material landfilled prior to 2007.
The site contours and drainage pattern shall be in accordance with Drawing 6835-0002-02
annexed in Appendix 2. Runoff from the top of the landfill will be collected by the perimeter drain
which will continue into the sedimentation pond.
At the current filling rate the landfill has a predicted life of up to 20 years9. During this time new
capping techniques such as Phytocapping may become preferable or Government Policy may
change. Designs for the final proposed capping system will be submitted to the EPA three months
prior to the last load of waste being landfilled.
8.12 WET WEATHER OPERATIONS
The stormwater management and collection systems on site will be maintained in such a way that
minimises the risk of flood events and spills. Access into the landfill will be maintained during all
weather conditions without compromising the environmental management of the site. The access
roads will be levelled, graded and where practicable sealed to ensure traffic is maintained in a safe
manner and damage to the environment and property are minimised.
9 Assuming a minimum compaction of 650 kg per cubic metre is achieved
O15.1
O15.2
O18.1
BM 28
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 48
8.13 FIRE PREVENTION AND CONTROL MEASURES
Council personnel at the landfill will be trained in fire safety practices and are made aware of the
location of fire safety equipment on site such as fire extinguishers. Council will work in
collaboration with NSW Rural Fire Service who are to be contacted immediately in the event of a
fire outbreak. Any fire incidents are to be recorded in detail and reported immediately to the EPA.
The incidence of accidental fires occurring at the site will be minimised by the implementation of
the following measures:
1. Signage on display advertising to the public that flammable liquids are not permitted on
site;
2. Regular fire break maintenance around the perimeter of the site;
3. Internal fire breaks around combustible stockpiles;
4. Combustible materials such as fuels and other flammables are separated into small
secure storage areas away from the active tipping areas;
5. Greenwaste materials are stored separately in small windrows to minimise combustion;
6. Council staff to man the site during operating hours preventing residents from deliberately
lighting fires;
7. The regular compaction and covering of the landfill cell to prevent the escape of methane
gas;
8. All staff insitu are trained in fire management procedures;
9. A fire log book to record any fire incidents and relevant contact numbers for fire fighting
authorities and the EPA will be in a central location readily accessible for staff;
10. All machinery will contain fire extinguishers and staff will be appropriately trained in the
use of fire fighting equipment.
In the event of a fire Council will notify the EPA as soon as practical by telephoning the
Environment Line service on 131 555 and providing written details of the notification to the EPA
within 7 days of the date on which the fire occurred. Under the site’s EPL, Council as licensee will
record the following data in relation to fires occurring at the premises:
Time and date when the fire started;
Whether the fire was authorised by the licensee, and, if not, the circumstances which
ignited the fire.
The time and date that the fire burnt out or was extinguished;
The location of fire (e.g clean timber stockpile, putrescibles garbage cell, etc..);
Prevailing weather conditions at the time of the fire;
Observations made in regard to smoke direction and dispersion;
The amount of waste that was combusted by the fire;
Action taken to extinguish the fire;
Action taken to prevent a reoccurrence.
O5.4
O8.1
O9.1
O10.1
O11.1
R4.1
R4.2
BM12
BM13
BM 38
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 49
CONTROLLED BURNING
After flood events the RWMC can receive heightened amounts of oversized greenwaste. This
material is often mulched and offered to residents or used as daily cover. Oversized greenwaste
unsuitable for mulching or composting will be stockpiled and burnt in a controlled environment.
Material suited for controlled burning includes vegetation, timber, paper and cardboard.
The following conditions shall be met before the commencement of controlled burning:
RWMC field staff have inspected the stockpile, removing any material other than
greenwaste;
An authorised person from the RFS must be present at all times during the controlled
burning and is solely responsible for lighting and controlling the fires;
Waste for burning must be placed in windrows, trenches or pits. The controlled fire must
be at lest 50 metres from any site perimeter or working face of the landfill;
The fire shall not be located over any areas previously used for landfill unless it is proven
to the EPA that landfill gas is not present in the area;
The fire shall not be located so that it is offensive or potentially harmful to any person at or
beyond the landfill boundary.
8.14 EQUIPMENT
Council will maintain, hire or purchase required machinery, plant and equipment sufficient to
undertake the following:
Separating and maintaining stockpiles of metals, tyres, timber, concrete and demolition
wastes;
Compaction of landfill lifts;
Application of daily cover material to exposed waste;
Landforming and shaping of existing landfill area;
Spreading of waste;
Levelling, grading, tidying of landfill areas;
Closure of landfill cell including capping and revegetation.
All plant and equipment will be maintained in a proper and efficient manner and in accordance with
relevant Australian Standards. Maintenance and monitoring of equipment will be undertaken by
on-site staff daily. Servicing of equipment and machinery will be undertaken regularly by a suitably
qualified third party mechanic as required.
8.15 ASBESTOS HANDLING
All asbestos material accepted at the RWMC will be handled in accordance with Clause 42 of the
Protection of the Environment Operations (Waste) Regulation 2005 shown below.
O2.1
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 50
Protection of the Environment Operations (Waste) Regulation 2005
(1) This clause applies to any activity that involves the transportation, disposal, re-use or
recycling of any type of asbestos waste, regardless of whether the activity is required to be
licensed.
(2) A person who carries on an activity to which this clause applies must comply with the
requirements specified in this clause in relation to the activity concerned.
Maximum penalty: 400 penalty units in the case of a corporation, 200 penalty units in the case
of an individual.
(3) The requirements relating to the transportation of asbestos waste are as follows:
(a) bonded asbestos material must be securely packaged at all times,
(b) friable asbestos material must be kept in a sealed container,
(c) asbestos-contaminated soils must be wetted down,
(d) all asbestos waste must be transported in a covered, leak-proof vehicle.
(4) The requirements relating to the offsite disposal of asbestos waste are as follows:
(a) asbestos waste in any form must be disposed of only at a landfill site that
may lawfully receive the waste,
(b) when asbestos waste is delivered to a landfill site, the occupier of the landfill
site must be informed by the person delivering the waste that
the waste contains asbestos,
(c) when unloading and disposing of asbestos waste at a landfill site,
the waste must be unloaded and disposed of in such a manner as to prevent
the generation of dust or the stirring up of dust,
(d) asbestos waste disposed of at a landfill site must be covered with virgin
excavated natural material or other material as approved in the facility’s
environment protection licence:
(i) initially (at the time of disposal), to a depth of at least 0.15 metre, and
(ii) at the end of each day’s operation, to a depth of at least 0.5 metre, and
(iii) finally, to a depth of at least 1 metre (in the case of bonded
asbestos waste or asbestos-contaminated soils) or 3 metres (in the case
of friable asbestos material) beneath the final land surface of the landfill site.
(5) A person must not cause or permit asbestos waste in any form to be re-used or recycled.
(6) In this clause:
"bonded asbestos material" means any material (other than friable asbestos material) that
contains asbestos.
"friable asbestos material" means any material that contains asbestos and is in the form of a
powder or can be crumbled, pulverised or reduced to powder by hand pressure when dry.
Asbestos will only be accepted at the RWMC after Council staff has received at least 24 hours
prior notice, with Council scheduling a time for disposal. The burial of asbestos waste will be
carried out immediately with the pit already having been excavated and the cover material nearby.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 51
Council staff will record the amount and the GPS coordinates of the burial pit.
The asbestos waste will not be compacted before it is covered and will not come into direct contact
with earthmoving equipment tracks at any time. Resident access to the tip face will be restricted
until the pit has been covered in 0.5m of soil.
8.16 QUALITY ASSURANCE
Key construction work at the site includes the landfill capping layer which will meet Australian
Standard HB90.3(2000) HB90.3 provides guidance in the application of the ISO 9001:2000
standards for the construction industry. Quality assurance of the construction of these key works
and other significant works shall be conducted during their construction. Alternative construction
quality assurance programs will be approved in writing by the EPA.
O12.1
BM 20
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 52
PART 9 RECYCLING AND RESOURCE RECOVERY
9.1 GENERAL
Bellingen Shire Council will continue to assess methods to maximise materials recovery and
minimise the amount of waste going to landfill. Council will continue its involvement in community
campaigns to educate the public about separation of waste at the kerb and on site.
9.2 COMINGLED RECYCLABLES
After inspecting the load, RWMC Field Staff will direct customers to deposit any commingled
recyclables into a 34m3 skip bin near the entrance to the facility. The skip bin is serviced by
Handybin with the materials processed at the Coffs Coast Waste Services Materials Recovery
Facility.
9.3 GREENWASTE
After inspecting the load, RWMC Field Staff will direct customers to deposit any small to medium
size greenwaste (mainly bushes, branches and tree waste) into a 34m3 skip bin near the entrance
to the facility. The skip bin is serviced by Handybin with the materials processed at the Coffs Coast
Waste Services Biomass Facility.
Customers with bulky green waste such as large tree stumps will be directed to the bulky
greenwaste stockpile which is currently located in the old quarry. The bulky greenwaste stockpiles
shall not exceed a height of two metres. All works required to keep the stockpiles within these size
constraints shall be conducted by BSC.
When the bulky greenwaste stockpile reaches a sufficient size, a waste shredding contractor will
be engaged to shred the stockpile. The shredded material will be primarily used on site for
landscaping and cover purposes. Its use as cover will be limited to the internal batters of each lift
i.e. not the exterior batters of the landfill which will be clay capped. Any material that is taken
offsite will comply with the relevant 51/51A exemption clause of the POEO.
9.4 SCRAP METAL & CAR BATTERIES
Customers will be directed to separate their scrap metal into ferrous metal, non-ferrous metals and
batteries upon entering the RWMC.
Ferrous metals are stockpiled on the northern ridge of the site. Non-ferrous metals (mainly
aluminium and copper) are stored in lockable cages adjacent to the Reuse Centre. Batteries are
stored in a bunded lockable cage near the landfill entrance.
Scrap metal stockpiles will be kept tidy and located in an accessible location for recyclers. All
works required to keep the stockpile within these size constraints shall be conducted by RWMC
Field Staff. RWMC Field Staff will be responsible for preventing the public from scavenging directly
from the scrap metal stockpile.
All arrangements for the removal of scrap metal and batteries, including all income, reside with
BSC.
BM 25
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 53
9.5 TYRES
Customers will be directed to place their waste tyres in the waste tyre stockpile area opposite the
ferrous scrap metal stockpile. The total quantity of used, rejected or unwanted tyres (including
shredded tyres and tyre pieces) stockpiled at the premises will not exceed 50 tonnes.
9.6 WASTE OIL
Customers will be directed to place their waste oil containers adjacent to the bunded waste oil
shed which is located opposite the Reuse Centre. RWMC Field Staff will be responsible for
decanting containers into the waste oil collection tank provided. Customers are not permitted to
have access to the oil collection tank for any reason.
9.7 CONCRETE BRICKS AND TILES
Concrete, bricks and tiles are not specifically separated for recovery due to low volumes and high
crushing costs. They are used for engineered fill on site or mixed in with soil for daily cover.
9.8 CLEAN FILL
Residents or contractors delivering clean fill will be directed to the daily cover stockpile area.
9.9 REUSE CENTRE
Items of value that may be sold back to the public and avoid going to landfill include:
Bulky items such as couches and furniture of a reasonable condition;
Childrens toys;
Bikes;
Electrical and white goods (as determined by staff);
Drainage pipes of a reasonable condition;
Carpet of a reasonable condition (as determined by staff);
Kitchen crockery; and
Star pickets and tomato stakes.
O5.1
O5.2
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 54
PART 10 ENVIRONMENTAL MANAGEMENT ISSUES
10.1 WATER
10.1.1 LEACHATE MANAGEMENT
The basic requirement of the leachate collection and storage system is to ensure that the leachate
cannot leak out into the surrounding soil. Leachate on site consists of stormwater run-off from the
active landfill area/greenwaste stockpiles and water that has percolated though the landfill surface
into the LIT. Leachate generated on site shall be minimised, collected and disposed. The strategy
for managing leachate at the RWMC is to minimise leachate generation by undertaking the
following:
Directing stormwater run-on away from the active landfill area;
Regular compaction and covering of the landfilled waste;
Keeping any leachate generated within the active tipping area separate from stormwater
run-off;
Grading the active landfill and directing clean stormwater runoff to a collection point;
Only operating one active landfill face;
Intermediate covering of landfilled areas that will be inactive for a period of 90 days or
more;
Progressively constructing the final capping across the site as the final landform is
reached;
Collection and irigation of leachate from the leachate interceptor trench
Continuing to operate and maintain the leachate management system as required post-
restoration.
Minimising the amount of water used to clean the transfer station and storage areas
generally
If required, excess leachate could also be tankered off site for disposal at the nearest
sewage treatment plant.
i. LEACHATE BARRIER
Permeability testing during the EIS indicated that the phyllite bedrock underlying the landfill site
met the benchmark conductivity of 10-9 ms-1. Therefore, no leachate barrier was deemed
necessary between the landfill and the underlying substrata. A leachate interceptor trench was
constructed down gradient of the landfill in September 2000.
ii. LEACHATE COLLECTION SYSTEM
The leachate collection system consists of a 370m leachate interceptor trench (LIT) excavated into
the underlying phyllite around the lower perimeter of the landfill as annexed in Plans 2 and 3 in
Appendix 3. It is lined with a 2mm HD.P.E liner on the outer edge with a continuous membrane. A
150mm perforated agricultural pipe drains the leachate to a low point. Here a 1500L leachate
sump is located with dual submersible pumps (3 L/s) which are activated by the depth of leachate
in the sump. The sump is covered and locked to prevent unauthorised access. All leachate
collected is pumped to the leachate storage tanks.
L1.2
L1.3
O6.1
O6.2
O6.3
O6.4
O6.5
O6.6
O6.7
O6.8
U2.1
U2.2
U2.3
U2.4
U2.5
U2.6
U2.7
U2.8
U2.9
BM 1
BM 2
BM 3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 55
Leachate is only permitted to overflow from either the leachate sump or the active cell as a direct
result of a rainfall event of equal to or greater than 300mm in total falling over any consecutive five
day period. In the event of an overflow the leachate will enter into the surface water collection
system where it will be diluted upon entering the sedimanetation pond and Melaleuca wetland.
RWMC field staff will be responsible for monitoring the level of leachate within the leachate sump
and the leachate storage tanks on the days the facility is open to the public. If the leachate level
approaches the invert of the leachate pipes where they enter the leachate sump the Waste Site
Supervisor will inform the Waste Management Coordinator who will:
i. Review the rainfall records to see whether 300mm or greater has fallen over the
previous five day period;
ii. Commence leachate recirculation as detailed in 7.7;
iii. If recirculation is infeasable arrange for disposal at sewerage treatment plant.
In the event of an unexpected drop in the leachate level in the sump the Waste Management
Coordinator will arrange to have a pipe camera inserted into the drainage line to determine the
issue. Similarly, should there be an unforseen drop in the leachate level in the storage tanks the
Waste Management Coordinator will arrange to have the tanks drained, cleaned and inspected for
leaks.
iii. LEACHATE DISPOSAL
Council will take all practical measures to minimise the amount of leachate in the leachate
collection and storage system and maximise the disposal of leachate. Leachate disposal on site
comprises irrigation and when necessary reinjection.
IRRIGATION
Irrigation on site consists of static and mobile irrigation. A 32mm Trolley with Sime K1 sprinkler will
be used to irrigate an area of approximately 1134m2. This will be moved around the site in order to
irrigate areas that are not currently covered by the static irrigation system. A valve manifold at the
top of the will enable Council staff to switch between the static sprinklers and a 2” rural poly line to
the mobile unit.
Mobile irrigation will only take place within areas of the landfill that have been bunded to prevent
contact with storm water runoff. Council staff will be responsible for moving the irrigator regularly to
maximise evaporation and prevent circulation of leachate due to saturation. Irrigation rates shall be
limited to 50% of evaporation rates. This is approximately 3 mm during the hotter months, 2 mm
during autumn and spring and 1.5 mm during winter (Jelliffe, 1999).
Before commencing irrigation the Waste Site Supervisor will access the Bureau of Meteorology
database and check the wind forecasts. Irrigation will not occur if the winds exceed 10 knots
(around 19 km/hour) in any direction. Irrigation of leachate will not occur within 50m of areas with
public access. Sprays will be larger droplets to prevent drift across the bunds that surround the
leachate irrigation area.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 56
RECIRCULAION
The recirculation scheme involves infiltrating leachate back into the landfill. Leachate will be
pumped from the leachate tank to trenches constructed on the surface of the landfill. Jellifee
(1999) predicted the average daily flow to be 4,100 L/d with a peak flow of 29,100 L/d and a 90
percentie flow of 16,200 L/d in a leachate model developed for the 1997 landfill expansion.
If the trench is designed to dispose of the 90 pecentile flow (16,200L) a trench of approximatly 185
m long x 1 m wide x 0.5 m deep is required assuming 0.25 m leachate depth, effective porosity of
0.35 and a width of 1.0 m (Jelliffe, 1997).
The trenches will be gravel filled with a 150 mm slotted pipe laid along the base. In addition to the
trench 50 mm bore hole should be bored into the landfill, piercing the intermediate cover to a depth
of 2 m where possible.A bore hole seperation of 25 m will be adequate (Jelliffe 1997).
iv. UPGRADES
The leachate management system will be upgraded, encompassing the following:
Regrading the landfill surface during future lifts to promote water shedding and reduce
ponding and percolation;
Bunding of the greenwaste stockpile area in the old quarry to divert run-on of stormwater
and limit leachate generation;
Upgrade of leachate irrigation system to allow for mobile irrigation (currently underway);
Installation of two new dual submersible leachate pumps in the leachate sump
(completed);
Mounting the leachate pumps on rails in the leachate collection sump to facilitate faster
maintenance (completed);
Installtation of new sumbersible pump in lechate storage tanks (currently underway);
Excavation and inspection of leachate seepage points and if necessary, installation of
additional spur lines which is detailed below.
A visual inspection of the batters revealed that leachate is currently seeping from two areas
Western batter: Council staff belive that the seepage of leachate is due to a perched water
table which is preventing leachate from entering the leachate interception trench, instead
forcing it to migrate laterally. Council staff will excavate into the batter and attempt to
penetrate the impermeable barrier, lining the hole with gravel to minimise future lateral
migration. The disturbed area of the batter will be recapped and revegetated. Works will
only be undertaken during dry periods to prevent leachate mixing with stormwater.
Southern toe: If the works undertaken on the western batter prove sucessful then a similar
method will be followed at the seepage point on the southern batter.
If neither of these options are successful at preventing leachate seepage Council will consider
constructing additional spur lines to conduct leachate from the landfill into the interceptor trench as
detailed in Plan 3 annexed in Appendix 3. Additional spur lines will follow the same design as
those which were installed during the installation of the LIT. It will comprise a 150-160mm
perforated pipe with a minimum gradient of 1% installed at least 2m into the landfill.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 57
LEACHATE RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Applying daily cover to the active landfill face
Daily monitoring of the level of leachate within the leachate control structures on the
days the RWMC is open to the public
Advising the Waste Management Coordinator of the need to reduce the leachate level
in the containment structures when it reaches the agreed level
Waste Management Coordinator is responsible for:
Informing earthmoving contractors of the location of the leachate structures
Regular monitoring of the leachate structures and the level of leachate within the
containment structures
Arranging for the removal of leachate from the leachate containment structures and its
disposal at an approved facility when required
Regular monitoring of the leachate management structures to ensure the agreed
capacity is maintained
Arranging for the cleaning/desilting of leachate management structures to ensure the
agreed capacity is maintained
Coordinating the repair of leachate management structures, plant and equipment
Regular monitoring of day to day operations to ensure compliance with the EMP
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the LEMP
Overall management of the site and the activities carried out in the RWMC
10.1.2 STORMWATER
Stormwater gathered on the site is managed to ensure it is not contaminated with leachate and is
free of sediment prior to discharge. The stormwater on site consists of:
Clean stormwater from roofs, undisturbed and revegetated areas:
Leachate contaminated stormwater run-off from the active landfill area and greenwaste
stockpiles;
Sediment laden stormwater from disturbed areas; and
Stormwater runoff from the transfer station.
Contamination of surface water is generally managed by Council by:
Constructing and maintaining a series of temporary stormwater drains during landfilling
operations to prevent stormwater run-off from entering the active waste disposal area or
recycling area.
Constructing and maintaining a series of temporary stormwater bunds to keep
L1.4
O7.1
O7.2
O7.3
O7.4
BM 3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 58
contaminated stormwater run-off inside the active landfill area
Revegetating disturbed areas as soon as practicable;
Minimising disturbance of areas on site;
Ensuring stormwater channels, ponds are cleaned/desilted and functional; and
Ensuring leachate management system is functional to prevent leachate contaminated
surface water runoff.
Controling vehicle movements
All surface water that comes into contact with waste will be treated as leachate. Leachate will be
kept separate from stormwater via the measures described in 10.1.1. Surface water will be
directed from the landfill surface by maintaining a minimum 1% grade towards all drainage
structures. A system of temporary bunds and drains will direct the runoff into a permanent
perimeter drainage system which will drain into a sediment control pond. The catchment of the
sediment pond is approximately 3.8 ha. All temporary drains will be earthen drains constructed at
grades no steeper than 3% to minimise scouring. Where drain slopes exceed 3% the drains shall
be suitably lined with crushed rock, grassed or otherwise stabilised to prevent erosion.
The sedimentation pond was designed during the 1997 EIS for the landfill extension using the EPA
Managing Urban Stormwater: Soils and Construction (1998). It is capable of settling particles of
0.05mm diameter (fine sand) for a 1 in 10 year average recurrence interval, 1 hour storm event
and 0.02 mm diameter (fine silt) 0.25 x 0.25 x QTc 1 year ARI. Overflow is spread out across the
Melaeuca forest through a grassed spillway where the remaining sediments settle out. The
sediment pond is designed to drain dry during no-flow periods to minimise the retention of poor
quality water which then overflows during rainfall events.
The pond will be maintained at an average depth of 1.5m which is 250% of the required settling
depth of 0.6m. At present there is no sedimentation depth marker installed. Once Council has
installed a depth marker the upper level of the storage zone will be monitored by the RWMC field
staff. Once the pond has reached capacity the Waste Management Coordinator will be responsible
for organising de-silting.
i. UPGRADES
The stormwater management infrastructure will be upgraded, encompassing the following:
Installation of a sedimentation basin marker that identifies the upper level of the sediment
storage zone;
Excavation of macrophyte area of sediment pond to remove captured sediments and
increse the storgare volume of the pond;
Ensuring a minimum 1% slope is maintanined towards drainage structures during each
sucessive landfill lift;
Staged upgrade of perimteter drainage system to the design specified in Drawing 6835-
0002-02 annexed in Appendix 2.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 59
STORMWATER RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Regular monitoring for damage to the surface water management structures on the
days the RWMC is open to the public
Removal of litter from the surface water drainage structures on a weekly basis
Reporting damage to surface water management structures to the Waste Coordinator.
Advising the Waste Coordinator of the need to reduce the water level in the containment
structures when it reaches the agreed level
On receipt of a complaint documenting and advising the Waste Management
Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Advising the Waste Environment & Operations Manager of any surface water
management complaint received
Complying with the procedures and practices outlined in the LEMP
The Waste Management Coordinator is responsible for:
Co-ordinating the repair of surface water management structures
Arranging for the cleaning/desilting of surface water management structures to ensure
the agreed capacity is maintained
Investigating any surface water management complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the surface water management complaints on Councils
corporate records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the LEMP
Overall management of the site and the activities carried out in the RWMC
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 60
GROUNDWATER
Council will take all reasonable measures to prevent the migration of leachate into the
groundwater table. The existing landfill will be closed capped and revegetated as soon as
practicable to prevent further generation of leachate. Other measures to be adopted by Council
include:
Minimising exposed areas of the active landfill areas by ensuring that material is
compacted and covered daily. Council will ensure that cover material is available on site
for this purpose.
Grading areas to divert surface water run-off away from active landfill areas into
stormwater channels and holding ponds;
Ensuring leachate pump is operational and pumping is carried out regularly; and
Complying with this LEMP and EPL 5896 in terms of leachate collection, monitoring and
storage
10.2 NOISE MANAGEMENT
Council will seek to ensure that the noise generated from the site is minimised by implementing
the following measures:
Plant and equipment is to be used within specified working hours that will have the least
impact on surrounding residents, i.e sometime between the standard working hours of
9.00am – 5.00pm;
All landfill machinery, plant and equipment is to be maintained regularly in a proper and
workmanlike manner;
Traffic to be controlled by Council officers ensuring that residents accessing the site use
designated roads away from the active tipping face and work areas which are susceptible
to higher than background levels of noise;
Buffer zones around the landfill are to be maintained and not cleared.
The landfill site is not in close proximity to neighbouring residents and there have been no
recorded complaints received by Council regarding noise pollution. Generally there are small
movements of vehicles at any one given time and the traffic into and out of the site is relatively
minor. Plant and equipment on site is generally run infrequently.
Noise measurements will only be taken should valid complaints be received. Should Council need
to undertake noise monitoring it will comply with Licence Condition L6.1 and L6.2 which can be
found in Appendix 1.
L 6.1
L6.2
BM 37
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 61
NOISE MANAGEMENT RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Regular monitoring of the noise levels on the days the RWMC is open to the public and
informing the Waste Management Coordinator if it is believed that the license conditions
are being exceeded
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of noise levels on the days the RWMC is open to the public
Taking steps to limit noise levles if it is believed that the license conditions are being
exceeded
Investigating any noise complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the noise complaints on Councils corporate records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.3 ODOUR CONTROL
The landfill is not in close proximity to neighbouring residents and there have been no recorded
complaints regarding odour arising from the landfill that can be found on Councils records.
Operations at the landfill are undertaken in such a manner so as to minimise the generation of
odour and impacts on surrounding landholders.
All practicable measures will be implemented to minimise future offensive odours escaping the
site. These include:
Covering all animal carcasses and putrescibles deposited in the animal burial pit with daily
cover material;
Maintenance of surface water control structures to ensure that stormwater does not enter
the active landfill face;
Investigating and implement either the use of alternate dialy cover such as landfill lids to
cover all exposed waste in the existing active landfill face to contain odours;
L8.1
BM 36
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 62
If any odorous sources are identified, these are to be covered immediately with cover
material.
ODOUR CONTROL RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Regular monitoring of odours levels on the days the RWMC is open to the public
Cleaning of the waste receival bin bays and the transfer station generally
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of odour levels on the days the RWMC is open to the public
If necessary, taking steps to limit odour levles
Investigating any noise complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the noise complaints on Councils corporate records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.4 LITTER CONTROL
Council will take all practical measures to prevent the incidence of wind-blown litter at the RWMC.
Litter will be minimised by:
Maintenance of perimeter litter fences;
Conducting litter patrols on a daily basis;
Requiring vehicles entering the RWMC to be covered to prevent escaped litter;
Application of daily cover to exposed waste of each day and as often as required as
detailed in 8.10.
O17.1
BM 31
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 63
LITTER CONTROL RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Applying daily cover to the active landfill face
Conducting litter patrols on the days the RWMC is open to the public
Notifying residents of the requirement to cover loads when entering the RWMC
Inspecting perimeter fencing for areas where litter has migrated offsite
Cleaning of the waste receival bin bays and the transfer station generally
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Taking steps to limit litter generation if it is believed that the license conditions are being
exceeded
Investigating any litter complaints
Documenting the results of the investigation and the actions taken
Maintaining records of that dust complaints on Councils corporate records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.5 DUST CONTROL
The primary access road to the RWMC is bitumen sealed which reduces potential dust generation.
The waste transfer station reduces the total number of vehicle movements on the internal
unsealed roads.
Council will ensure that dust generation at the site is minimised where practicable by adhering to
the following practices:
Use of water cart as required on dusty roads, and loads as required;
Maintenance and enforcement of careful speed limits within the site to avoid disturbance
of roads and dust generation;
Landfill machinery and equipment to be washed frequently;
To delay or suspend earthmoving activities when excessive dust is being generated that
O3.1
BM 34
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 64
may affect neighbouring residents; and
To rehabilitate and revegetate landfill areas as soon as practicable after works have been
completed.
DUST CONTROL RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Regular monitoring of dust generation on the days the RWMC is open to the public
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of dust generation on the days the RWMC is open to the public
Taking steps to limit dust generation if it is believed that the license conditions are being
exceeded
Investigating any dust complaints
Documenting the results of the investigation and the actions taken
Maintaining records of that dust complaints on Councils corporate records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.6 LANDFILL GAS MANAGEMENT
At present there is no landfill gas infrastructure in place at the RWMC as the low waste tonnages
do not warrant dedicated landfill gas infrastructure. Council has been proactive in removing
organics from the municipal waste stream. This has resulted in a significant drop in the amount of
organic material being landfilled. The landfill is a fairly permeable structure with ample opportunity
for methane to escape to the atmosphere along the lower edges. Any methane that is emitted can
be expected to move east through the Melaleuca forest. No hazards are identified along this path.
R6.1
BM 19
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 65
The landfill will be operated to minimise the generation and effect of gaseous odours arising from
the waste management operations. Council will ensure that landfill gas generation at the site is
minimised by adhering to the following practices:
Regular compaction of exposed waste at the active landfill as discussed in section 8.8;
Application of daily cover to exposed waste of each day and as often as required as
detailed in 8.10; and
Animal waste (offal) will to be deposited into the designated animal pit and covered
immediately with soil.
There has been a rapid decline in the amount of putrescible material landfilled since the beginning
of the Coffs Coast Waste Services collection contract in 2007. The contract saw the addition of a
third bin allowing for the source separation of household organics which are sent to the Biomass
facility in Coffs Harbour for composting. Kerbside putrescible MSW is also directed to the same
facility where the organic fraction is recovered. This lack of putrescible material limits the
availability of nutrients for methane-generating bacteria.
Landfill gas monitoring is required at the RWMC as required in EPL 5896 and discussed in 11.6. In
the event of a gas monitoring triggering the EPA threshold of 1.25% (v/v) the Waste Management
Coordinator will be responsible for installing a passive venting system. This would involve sinking
of perforated shafts or the layering of perforated collection pipes under the final cover soil within
the refuse layer.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 66
LANDFILL GAS MANAGEMENT RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Ensuring daily cover is applied to waste
Maintnenance of stormwater diversion structures as detailed in 10.1.1 Stormwater.
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of landfill gas as detailed in 10.6 Landfill Gas Management
Arranging for the design and installation of landfill gas management systems
Investigating any landfill gas complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the feral pests or vermin complaints on Councils corporate
records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.7 FERAL PESTS AND VERMIN CONTROL
The compaction and covering of waste will minimise the incidence of feral pests such as cats, rats
and foxes. Council will manage pest and vermin numbers through the use of baits, traps and bird
scares where required. Should the use of chemicals be deemed necessary, care will be exercised
to ensure that chemicals are not subject to stormwater or leachate runoff or not susceptible to
becoming air borne and posing an environmental pollution hazard.
Areas of the RWMC that will require particular attention will be the:
tippng face;
scrap metal, tyre and greenwaste stockpiles
O5.3
BM 35
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 67
FERAL PESTS AND VERMIN CONTROL RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Ensuring daily cover is applied to waste
Regular monitoring of feral pests and vermin on the days the RWMC is open to the
public
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of feral pests and vermin on the days the RWMC is open to the public
Ensuring RWMC staff are trained in the identification of relevant pests and vermin of
concern in order to effectively manage landfill site
Arranging for baiting and trapping and bird scares when required
Investigating any feral pests or vermin complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the feral pests or vermin complaints on Councils corporate
records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.8 WEED MANAGMENT
Weed management is required to be undertaken as frequently as deemed necessary to sufficiently
control numbers. Council will undertake regular patrols and spray weeds as deemed necessary.
To minimise the incidence of weed growth, disturbed landfill areas will be revegetated as soon as
practicable. Green waste material will be stockpiled appropriately in windrows to ensure organic
matter and seed banks are kept at optimum temperatures for organic breakdown. Residents will
be directed to cover all incoming and outgoing loads containing waste material, including green
waste, to prevent dispersal of seed.
Particular attention will be given to locations where weeds are most prevalent such as sumps,
leachate drains and pillar box drains as well as around the green waste deposit areas.
BM 35
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 68
WEED MANAGEMENT RESPONSIBILITIES
Waste Site Supervisor/Field Staff are responsible for:
Ensuring daily cover is applied to waste
Regular monitoring of weeds on the days the RWMC is open to the public
On receipt of a complaint documenting and advising the Waste Coordinator of:
i. The nature of the complaint
ii. The date and time of the complaint
iii. The name and address of the complainant
Complying with the procedures and practices outlined in the EMP
The Waste Management Coordinator is responsible for:
Monitoring of weeds on the days the RWMC is open to the public
Ensuring RWMC staff are trained in the identification of weeds of concern in order to
effectively manage landfill site.
Arranging for sprays of pesticides to target weeds
Investigating any weed complaints
Documenting the results of the investigation and the actions taken
Maintaining the records of the feral pests or vermin complaints on Councils corporate
records system
Implementing this procedure
Manager Environment and Sustainability is responsible for:
Auditing the RWMC on a regular basis to ensure compliance with the EMP
Overall management of the site and the activities carried out in the Facility
10.9 FINANCIAL ASSURANCE
Council must ensure that it has the financial assurance to appropriately manage and undertake
required developments at the RWMC. It is a means of ensuring that landfill operators adequately
plan for emergency closure, site remediation and post closure care, by providing a specific
mechanism to accumulate requisite funding during the life of the landfill. The estimated costs of
closing the landfill are set out below.
The proposed cap will have a volume of around 35,348 m3. The Victorian EPA’s Determination of
Financial Assurance for Landfills (2001) was used to provide an estimate of the cost of closure and
remediation costs. Prices for raw materials and construction were increased from 2001 prices to
bring them in line with inflation.
The capital cost of closure and final rehabilitation is estimated to be around $1,000,000. This figure
does not take into ongoing post maintenance and monitoring costs. This amount is a preliminary
calculation that will require refinement in line with future regulatory changes. Council will ensure
that the funds in the landfill reserve are capable of covering closure, site remediation and post
BM 26
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 69
closure care of the RWMC.
FINANCIAL ASSURANCE RESPONSIBILITIES
RWMC Waste Attendant/Field Staff are responsible for:
Collecting waste disposal fees from residents accessing the facility
Balancing the cash register after the RWMC has closed each day
Depositing collected cash in the bank account specified by the Waste Management
Coordinator
The Waste Management Coordinator is responsible for:
Auditing the RWMC cash flow on a regular basis
Manager Environment and Sustainability is responsible for:
Ensuring that revenue is collected from the Domestic Waste Management Charge and
waste disposal fees
Ensuring funds in the landfill reserve are capable of covering closure, site remediation
and post closure care of the RWMC
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 70
PART 11 ENVIRONMENTAL MONITORING
11.1 RECORDS
Bellingen Shire Council shall ensure that environmental monitoring of groundwater, surface water
and landfill gas are carried out in accordance with EPA Environmental Guidelines: Solid Waste
Landfills and the EPA publication Methods for Sampling and Analysis of Water Pollutants in NSW.
Monitoring will be undertaken as required under the EPL 5896 and this LEMP to ensure legislative
and regulatory requirements are met. The sampling will be undertaken by suitably qualified
environmental scientists as nominated by Council. All samples collected will be sent to a NATA
registered laboratory for final analysis and reporting.
For each of the required monitoring points records will be kept of any samples collected for the
purposes of this licence:
the date(s) on which the sample was taken;
the time(s) at which the sample was collected;
the point at which the sample was taken; and
the name of the person who collected the sample.
All records required to be kept by BSC will be:
in a legible form, or in a form that can readily be reduced to a legible form;
kept for at least 4 years after the monitoring or event to which they relate took place; and
produced in a legible form to any authorised officer of the EPA who asks to see them.
11.2 GROUNDWATER
LOCATION POINTS AND MONITORING
The monitoring locations specified in the EPL 5896 are identified below in Table 9 and are
annexed in Appendix 3: Plan E.
Table 9 – GROUNDWATER MONITORING POINTS
EPA IDENTIFICATION
NUMBER
TYPE OF MONITORING
POINT
DESCRIPTION OF
LOCATION
3 Groundwater quality
monitoring.
BH1, as marked on works-as-
executed Plan E forwarded to
the EPA with the licensee's
correspondence dated 22
November 2004.
18 Groundwater quality
monitoring.
BH7, as marked on Plan E of
LEMP.
Source: NSW EPA EPL 5896, 2013
M2.1
R7.1
BM 4
BM 5
BM 6
M1.2
M1.3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 71
There are 7 groundwater monitoring bores named BH1 to BH7 as shown Plan E annexed in
Appendix 3: Plan E. The bores have been installed downstream of the leachate interception trench
in order to detect any potential leaks. In accordance with the site’s EPL 5896 BH1 and BH7 (EPA
Identification Number 3 and 13 respectively) are sampled for groundwater quality.
Collection of samples is the responsibility of the Waste Management Coordinator. The pollutants,
units of measure, frequency and sampling methods are indicated under EPL 5896 and shown
below in Table 10.
Table 10 – GROUNDWATER MONITORING POLLUTANTS AND FREQUENCY
POLLUTANT UNITS OF
MEASURE FREQUENCY
SAMPLING
METHOD
Alkalinity (as calcium
carbonate) milligrams per litre Every 6 months Grab sample
Ammonia milligrams per litre Every 6 months Grab sample
BOD milligrams per litre Every 6 months Grab sample
Calcium milligrams per litre Every 6 months Grab sample
Nitrate milligrams per litre Every 6 months Grab sample
Potassium milligrams per litre Every 6 months Grab sample
pH pH Every 6 months Probe
Source: NSW EPA EPL 5896, 2013
If a borehole is not sampled because it is dry or damaged, or for any other reason, then the person
responsible for sampling shall record the reasons for not sampling and report the reason in writing
to BSC. BSC will then include this information in the annual monitoring report.
GROUNDWATER POLLUTION DETECTION
The results of groundwater testing will be reported annually to the EPA. Should monitoring at point
18 (BH7 as shown Plan E annexed in Appendix 3) exceed the trigger values shown below in Table
11 for any two or more parameters; the affected monitoring boreholes will be re-sampled as soon
as possible.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 72
Table 11 – MONITORING POINT 18 TRIGGER VALUES
UNITS OF MEASURE TRIGGER VALUE
Potassium mg/l 16.5
Ammonia mg/l 3.1
Calcium mg/l 49.5
Alkalinity mg/l 63.9
Source: NSW EPA EPL 5896, 2013
If the results for any two consecutive monitoring rounds exceed the rigger values Council will
prepare a report to the EPA within 14 days proposing a Groundwater Assessment Program
identifying a strategy for assessing the nature and extent of groundwater contamination at the
premises. In addition to the EPL 5896 trigger values groundwater data will be compared to
background conditions, leachate water quality and previously recorded trends.
11.3 LEACHATE
LOCATION POINTS AND MONITORING
The monitoring locations specified in the EPL 5896 are identified below in Table 12 and are
annexed in Appendix 3: Plan E.
Table 12 – LEACHATE MONITORING POINTS
EPA IDENTIFICATION
NUMBER
TYPE OF
MONITORING POINT
TYPE OF
DISCHARGE
POINT
DESCRIPTION OF
LOCATION
1 Leachate quality and
leachate level.
Leachate quality
and leachate
level.
Leachate sump,
marked MH on Plan E
of LEMP
13 Leachate volume
monitoring
Leachate tank as
marked on Plan E of
LEMP
Source: NSW EPA EPL 5896, 2013
Collection of samples is the responsibility of the Waste Management Coordinator. The pollutants,
units of measure, frequency and sampling methods are indicated under EPL 5896 and shown
below in Table 13.
M2.1
R5.1
R5.2
R5.3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 73
Table 13 – LEACHATE POLLUTANTS AND FREQUENCY
POLLUTANT UNITS OF
MEASURE FREQUENCY
SAMPLING
METHOD
Alkalinity (as calcium
carbonate) milligrams per litre Every 6 months Grab sample
Ammonia milligrams per litre Every 6 months Grab sample
Arsenic milligrams per litre Yearly Grab sample
BOD milligrams per litre Every 6 months Grab sample
Calcium milligrams per litre Every 6 months Grab sample
Nitrate milligrams per litre Every 6 months Grab sample
Organochlorine
pesticides milligrams per litre Yearly Grab sample
Organophosphate
pesticides milligrams per litre Yearly Grab sample
Phenols milligrams per litre Yearly
Potassium milligrams per litre Every 6 months Grab sample
pH pH Every 6 months Probe
Source: NSW EPA EPL 5896, 2013
DISCHARGE OF LEACHATE TO SURFACE WATER
Council will inform the EPA in the event of leachate discharging from the premises and/or when
the level of leachate in the leachate sump (Point 1) exceeds the invert of the leachate pipes in the
leachate interception trench where they enter the leachate sump.
In the event of a leachate discharge Council will prepare a report for the EPA detailing the
following:
1. the volume of the leachate discharged and over what time period the discharge
occurred;
2. the date and time of the commencement of the overflow;
3. the weather conditions at the time of the discharge, specifying the amount of rainfall on a
daily basis that had fallen:
on the day(s) of the discharge; and
for the one week period prior to the discharge.
4. the most recent monitoring results of the chemical composition of the leachate;
5. an explanation as to why the discharge occurred;
6. the location(s) of the discharge;
7. a plan of action to prevent a similar discharge in the future; and
8. was the discharge permitted by this licence.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 74
11.4 SURFACE WATER
LOCATION POINTS AND MONITORING
The monitoring locations specified in the EPL 5896 are identified below in Table 14 and are
annexed in Appendix 3: Drawings – Plan C and Plan E.
Table 14 – SURFACE WATER MONITORING POINTS
EPA IDENTIFICATION
NUMBER
TYPE OF
MONITORING POINT
TYPE OF
DISCHARGE
POINT
DESCRIPTION OF
LOCATION
2 Surface water quality
monitoring.
Surface water
quality
monitoring.
Outlet pipe of surface
water treatment
wetland, marked SWB
on Plan E of LEMP (as
modified by
correspondence from
the licensee dated 8
November 2004).
8 Surface water quality
monitoring.
In creek immediately
upstream of landfill,
marked as SWA on
Plan C of LEMP.
9 Surface water quality
monitoring.
Outlet of pipe located in
bund of eastern edge of
wetland, marked as
SWC on Plan C of
LEMP.
Source: NSW EPA EPL 5896, 2013
Collection of samples is the responsibility of the Waste Management Coordinator. Samples will be
taken from a point 100mm below the surface. The pollutants, units of measure, frequency and
sampling methods are indicated under EPL 5896 and shown below in Table 15.
M2.1
R8.1
BM 7
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 75
Table 15 – SURFACE WATER POLLUTANTS AND FREQUENCY
POLLUTANT UNITS OF
MEASURE FREQUENCY
SAMPLING
METHOD
Alkalinity (as calcium
carbonate) milligrams per litre Special Frequency 2 Grab sample
Ammonia milligrams per litre Special Frequency 2 Grab sample
BOD milligrams per litre Special Frequency 2 Grab sample
Calcium milligrams per litre Special Frequency 2 Grab sample
Nitrate milligrams per litre Special Frequency 2 Grab sample
Potassium milligrams per litre Special Frequency 2 Grab sample
TKN-N milligrams per litre Special Frequency 2 Grab sample
TN milligrams per litre Special Frequency 2 Grab sample
TSS milligrams per litre
Special Frequency 1
(MP2)
Special Frequency 2
(MP8,MP9)
Grab sample
pH pH
Special Frequency 1
(MP2)
Special Frequency 2
(MP8,MP9)
Probe
Source: NSW EPA EPL 5896, 2013
For the purposes of the above table(s) Special Frequency 1 means the collection of one sample as
soon as practicable after each of five rainfall events each year exceeding 40mm in any 48 hour
period, including three samples from the outlet of the discharge pipe of Point 2.
For the purposes of the above table(s) ‘Special Frequency 2’ means the collection of one sample
as soon as practicable after each of two rainfall events each year exceeding 40mm in any 48 hour
period.
SURFACE WATER POLLUTION DETECTION
Surface water data will be compared to background conditions, leachate water quality and
previously recorded trends and ANZECC (2000) water quality trigger levels for freshwater
ecosystems (95% protection). It is likely that the existing water quality will not meet the ANZECC
(2000) criteria in full. Analysis of the results should therefore seek to identify parameters which
significantly exceed the parameters or show a significant trend upwards.
Exceedances of the concentration limits shown below in Table 16 are permitted at Point 2 (SWB
as shown Plan E annexed in Appendix 3), whenever a wet weather overflow is occurring due to a
stormwater event greater than or equal to 74mm of rain in total falling over any consecutive five
day period.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 76
Table 16 – SURFACE WATER PERMITTED EXCEEDANCES
POLLUTANT UNITS OF
MEASURE
100 PERCENTILE
CONCENTRATION LIMIT
pH pH 6.5 -8.5
Total Suspended
Solids milligrams per litre 50
Source: NSW EPA EPL 5896, 2013
If the parameters measured during testing exceed the established limits than the affected
monitoring point will be re-sampled as soon as possible. If the contamination is confirmed by the
re-sampling, the EPA will be notified by Council, in writing, within 14 days. Within 28 days of
notifying the EPA Council will prepare a detailed surface water assessment plan which will
determine the extent of remediation required. Upon completion of the surface water assessment
program a remediation plan will be prepared, if required by the EPA, detailing the corrective
actions proposed.
11.5 RAINFALL MONITORING
Council field staff will undertake daily rainfall monitoring. The Waste Management Coordinator will
be responsible for ensuring that the data is entered into Councils corporate records system.
11.6 LANDFILL GAS
The monitoring locations and frequency specified in the EPL 5896 are identified below in Table 17.
Table 17 – LANDFILL GAS MONITOING POINTS AND FREQUENCY
EPA
IDENTIFIACTION
NUMBER
TYPE OF
MONITORING
POINT
TYPE OF
DISCHARGE
POINT
DESCRIPTION OF
LOCATION FREQUENCY
14 Air quality
monitoring. -
All enclosed buildings
at the premises Monthly
15 Air quality
monitoring. -
All enclosed buildings
within 250 metres of
waste filled areas of
the premises.
Quarterly
16
Landfill gas
generation
monitoring
-
The surface of waste
filled surfaces which
have been subject to
final capping.
Yearly
Source: NSW EPA EPL 5896, 2013
M8.1
R6.1
BM 17
BM 18
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 77
Gas monitoring will be the responsibility of the Waste Management Coordinator who will hire
appropriately qualified consultants. Monitoring will be conducted on calm days with wind speeds
less than 10 km/hour and will include. The handheld equipment will sample (50) millimetres above
the ground surface. The Waste Management Coordinator will start at a point five (5) metres away
from the waste perimeter and walk across the landfill surface parallel to the boundary until
reaching the opposite site. This procedure will be repeated every 25 metres from the perimeter
across the site to the opposite of the capped area.
REMEDIATING LANDFILL GAS EMISIONS
If the gas surface emissions and accumulation monitoring program detects methane levels
exceeding 1.25% methane (v/v) then sub surface gas monitoring and possibly surface remediation
will be required. The preparation of an assessment program and if required, a plan for sub surface
gas monitoring and site remediation will be triggered if methane gas levels at any part of the site or
in buildings exceed the EPA threshold of 1.25% (v/v). The assessment program shall be the
responsibility of the Waste Management Coordinator and shall be prepared and initiated within
one week of the elevated gas measurement. A remediation plan, if necessary, shall be prepared
on completion of the assessment program and in consultation with the EPA.
11.7 LANDFILL VOLUME
Council will engage a registered surveyor to produce plans detailing the remaining disposal
capacity of the RWMC landfill. Copies of the plans will be provided to the EPA as part of the
annual reporting.
11.8 COMPLAINTS HANDLING
Complaints received from an outside party will be reported, investigated and appropriate action
taken/implemented as required. Complaints are received through the Council office or through the
Waste Management Coordinator after hours as listed in 13.3 Incident Reporting.
Any complaint received will be investigated including:
The cause of the complaint
The climatic conditions at the time of the incident which is the cause of the complaint
If known, the date and time the incident took place
The occurrence of similar complaints in the past
Actions taken in the past to overcome similar complaints
Details of the complaint received, investigations and actions taken are to be recorded on Councils
corporate records system and kept for at least four years. The records will be available in either
electronic or physical form to any authorised officer of the EPA who asks to see them.
M4.1
M4.2
M4.3
M4.4
M5.1
M5.2
M7.1
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 78
PART 12 SITE CLOSURE AND REHABILITATION
The landfill has predicted life of up to 20 years by which time it is likely this LEMP will have been
reviewed in line with changes in Government policy and technology.
Upon completion, the maximum slope angles on the landfill batters shall not exceed 1 (vertical) to
3 (horizontal) (33%) and level parts of the landfill will be domed or graded to a minimum 5% to
minimise infiltration and consequent leachate generation. Rehabilitation of the batter slopes shall
be undertaken at the end of each lift with the final rehabilitation of the landfill surface occurring at
the end of the final sage.
A water irrigation system shall be located on the top of the rehabilitated landfill. The irrigation
scheme shall irrigate water from the sediment pond or use town water. Water from the leachate
system will not be irrigated. Water from the sediment pond will not be irrigated within 20m of areas
accessed by the public. Wind conditions will be monitored by Council staff to ensure that spray
drift of sediment pond water does not cross into area used by the public.
12.1 CLOSURE PLAN
BSC will prepare and submit a written closure plan to the NSW EPA within 3 months prior to the
last load of waste being landfilled a closure plan in accordance with section 76 of the Protection of
the Environment Operations Act 1997. The plan will detail as a minimum:
The schedule and means proposed for closure and rehabilitation and for any remediation
required;
Maintenance, monitoring and reporting required until such time as the landfill does not
pose a threat to the environment;
Complaint recording and corrective action procedures;
Measures proposed to safeguard against waste materials being deposited following
closure of the landfill. Waste materials that are intended for use in site remediation will be
reported and documented.
BSC may apply to complete all obligations with the landfill site and retrieve any financial assurance
lodged with the NSW EPA by submitting a Certified Statement of Completion. The statement of
completion specifies that the landfill site had been remediated and further environmental
management of the premises is not required. The certified statement of completion must provide
evidence of the following:
Gas concentrations measure on the surface of the landfill are below the lower explosive
limit (LEL) of 5% for methane.
Waste stabilisation is complete. This would be shown by the leachate containing a low
level of contamination and posing no environmental threat;
Groundwater monitoring indicates that the interceptor trench is operating correctly;
Over several years of assessment, the landfill capping is found to be stable with
acceptable water drainage;
Written documentation and confirmation that the closure plan submitted has been
completed;
Notify the NSW EPA that the site is now classed as contaminated land under the
Contaminated Land Management Act 1997.
O4.1
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 79
12.2 POST CLOSURE MANAGEMENT
Post closure management of the RWMC will encompass ongoing environmental management,
environmental monitoring, and maintenance of the landfill.
ENVIRONMENTAL MANAGEMENT
Environmental management will consist of:
Maintenance of stromwater structures;
Maintenance of leachate interceptor trench, leachate storage tanks and pumps;
Management of surface water runoff from the the waste transfer station, reuse shop and
remaining scrap metal stockpiles.
ENVIRONMENTAL MONITORING
BSC will maintain the same monitoring program and reporting practices for leachate, groundwater,
stormwater and landfill gas as used throughout the operation of the site.
MAINTENANCE
Post-closure landfill maintenance will consist of:
Identifying any cracks that may occur in the final cover layer;
Inspecting the landfill surface for depressions that will hinder surface water runoff and
promote infiltration;
Repairing erosion damage to the capping layer;
Maintenance of vegetation to limit erosion;
Ensuring monitoring borehole and surface water points are maintained and accessible.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 80
PART 13 REPORTING
13.1 MONTHLY SECTION 88 LEVY REPORTING
Monthly reports will to be provided to the EPA within 56 days of the end of each month, and will
include information for that month on:
1. the quantity, source (MSW, C&I, C&D) and type of waste received at the facility
2. the quantity and type of waste transported from the facility
3. any other information specified by DECCW
The quantity of waste will be determined using the EPA’s weight conversion factors.
BSC will keep records for at least 3 years of:
the movement of waste into the RWMC
the movement of waste within the RMWC
the movement of waste material or recycled, recovered or processed material out of the
RWMC
exempted waste that is received at the RWMC
At all times BSC will comply with the Waste and Environment Levy: Operational Guidance Notes
(2009) published by the EPA.
13.2 ANNUAL REPORTING
An Annual Return is prepared by Bellingen Council and submitted to the EPA for the required
reporting period i.e. twelve (12) months ending 29 June. Under the terms of the EPL 5896 , the
Annual Return must be submitted by Council to the EPA no later than sixty (60) days after the
expiry of the reporting period in the approved form comprising a signed Statement of Compliance
and Monitoring and Complaints Summary.
The Monitoring and Complaints Summary will generally include information such as:
a summary report on total wastes received;
a qualified surveyors report of volume of landfill space and estimate of compaction
density;
detected changes in groundwater;
surface water results;
summary report of fires that occurred on site;
a copy of odour litter and other complaints received by the landfill in the past twelve
months and
a summary of any incident reports during the 12 month reporting period
A copy of the Annual Return for the period 30 June 2012 to 29 June 2013 is annexed in Appendix
5.
R1.1
R1.2
R1.3
R1.4
R1.5
R1.7
R.18
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 81
13.3 INCIDENT REPORTING
The Protection of the Environment Operations Act (POEO) 1997 requires that if a licensee
becomes aware of a pollution incident, they are required to report pollution incidents immediately.
Section 147 of the Protection of the Environment Operations Act:
Harm to the environment is material if:
it involves actual or potential harm to the health or safety of human beings or to
ecosystems that is not trivial, or
it results in actual or potential loss or property damage of an amount, or amounts in
aggregate, exceeding $10,000 (or such other amount as is prescribed by the
regulations), and
loss includes the reasonable costs and expenses that would be incurred in taking all
reasonable and practicable measures to prevent, mitigate or make good harm to the
environment’.
Bellingen Council has implemented a Pollution Incident Response Management Plan (PIRMP) for
the RWMC to report pollution incidents as they happen. Should a pollution incident occur Councils
primary duty will be to enact the relevant procedure in the PIRMP. A copy will be kept on site and
referred to in the case of an incident. After the PIRMP has been enacted notifications will be made
by telephoning the EPA’s Pollution Line service on 131555. Under the terms of the EPL, a written
report must be submitted within seven (7) days of the date on which the incident occurred.
Examples of incidents under the EPL that require reporting include but are not limited to:
Leachate level in sump exceedes invert level of the leachate pipes
Leachate storage tanks overflow
Discharge of untreated leachate into the environment from landfill operations
Leachate pump line rupture or failure
Leachate sump overflow
Surface water contamination from leachate irrigation activities
Ground water contamination
Leachate spring eruption
Fire at tip face
Fire in transfer bin
Fire in incoming load
Fire in tyre stockpile
Fire in green waste stockpile
Chemical spill
Oil/fuel spills
Failure of hazardous material containment tanks/bund
Windblown litter
R2.1
R2.2
R3.1
R3.2
R3.3
R3.4
R5.1
R5.2
R5.3
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 82
Odour
Dust
Explosion (gas cylinders, methane)
Escape of refrigerant gases
The occurrence of any incident will be recorded in the site’s daily logbook and Councils corporate
records system as appropriate. The EPA shall be notified of any incident that represents a material
threat to the environment and which may lead to a breach of the license conditions immediately.
A written incident report will be provided to the EPA if requested by the authorised officer of the
EPA. The report will include, but not be limited to, the following details.
i. The cause, time and duration of the event;
ii. The type, volume and concentration of every pollutant discharged as a result of the
event;
iii. The name, address and business hours telephone number of employees of CMSC or
other witnesses;
iv. Actions taken by the BSC in relation to the event; and
v. Details of any measure taken to proposed to be taken to prevent or mitigate against a
recurrence of such an event;
vi. Any other relevant matters
EMERGENCY CONTACTS
Below is a list of incident response individuals and organizations that may be needed during a
pollution incident. Table 18 contains Council staff contact details and Table 19 contains
emergency organisations.
Table 18 – BELLINGEN SHIRE COUNCIL CONTACTS
NAME POSITION CONACT
Council Office - (02) 6655 7300
Glen Rumble Waste Site Supervisor 0417 239 447
Sam Tate Waste Management
Coordinator 0427 715 343
Daan Schiebaan Manager Sustainability and
Natural Resources 0407 662 963
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 83
Table 19 – EMERGENCY ORGANISATION CONTACTS
ORGANISATION CONTACT NAME CONTACT DETAILS
Fire and Rescue NSW
Duty Officer
1300729579
Police Force NSW
Duty Officer
66551444 (Bellingen)
000
Ambulance Service of NSW
Duty Officer
1312 333
000
Bellingen River District
Hospital
Reception
6659 5800
000
Department of Environment
and Conservation (EPA)
EPA Environment Line
131 555
Coffs Harbour Regional Office
6651 5946
Department of Environment
and Conservation (NP&WS)
NSW Parks and Wildlife
Service
6657 2309
Workcover Authority
Duty Officer
131 050
Department of Primary
Industries (NSW Fisheries)
Reception
1300 550 474
Forests NSW
Coffs Harbour Regional Office
6652 0111
Poisons Information Duty Officer
131 126
000
NSW Ministry of Health Reception 9391 9000
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 84
Department of Families and
Community Services
Reception 9248 0900
State Emergency Service
Duty Officer
132 500
000
Roads and Traffic Authority
Reception
132 213
Bureau of Meteorology
Land weather and flood
warnings
1300 659 218
Rural Fire Service Reception 000
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 85
APENDICIES
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 86
APPENDIX 1: ENVIRONMENTAL PROTECTION LICENSE
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 1 of 29 Archive date: 01-Apr-2011
Licence Details Number: 5896 Anniversary Date: 01-July Licensee BELLINGEN SHIRE COUNCIL PO BOX 117 BELLINGEN NSW 2454 Licence Type Premises Premises RALEIGH WASTE MANAGEMENT CENTRE LOT 86, DP 630914, SHORTCUT ROAD URUNGA NSW 2455 Scheduled Activity Waste disposal (application to land)
Fee Based Activity Scale Waste disposal (application to land) 0 - All Region Waste Operations (Coffs Harbour) 59-61 Goulburn Street SYDNEY NSW 2000 Phone: 02 9995 5000 Fax: 02 9995 5999 PO BOX A290 SYDNEY SOUTH NSW 1232
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 2 of 29 Archive date: 01-Apr-2011
INFORMATION ABOUT THIS LICENCE................................................................................................................... 4
Dictionary..................................................................................................................................................... 4
Responsibilities of licensee.......................................................................................................................... 4
Variation of licence conditions ..................................................................................................................... 4
Duration of licence ....................................................................................................................................... 4
Licence review ............................................................................................................................................. 4
Fees and annual return to be sent to the EPA............................................................................................. 4
Transfer of licence ....................................................................................................................................... 5
Public register and access to monitoring data ............................................................................................. 5
1 ADMINISTRATIVE CONDITIONS ................................................................................................................. 5 A1 What the licence authorises and regulates ......................................................................................... 5
A2 Premises to which this licence applies................................................................................................ 7
A3 Other activities .................................................................................................................................... 7
A4 Information supplied to the EPA.......................................................................................................... 7
2 DISCHARGES TO AIR AND WATER AND APPLICATIONS TO LAND................................................................. 8
P1 Location of monitoring/discharge points and areas............................................................................. 8
3 LIMIT CONDITIONS................................................................................................................................... 9
L1 Pollution of waters............................................................................................................................... 9
L2 Load limits ......................................................................................................................................... 10
L3 Concentration limits........................................................................................................................... 10
L4 Volume and mass limits .................................................................................................................... 10
L5 Waste ................................................................................................................................................ 11
L6 Noise Limits....................................................................................................................................... 11
L7 Hours of operation............................................................................................................................. 12
L8 Odours .............................................................................................................................................. 12
4 OPERATING CONDITIONS....................................................................................................................... 12 O1 Activities must be carried out in a competent manner................................................................... 12
O2 Maintenance of plant and equipment ............................................................................................ 12
O3 Dust Control .................................................................................................................................. 13
O4 Closure plan .................................................................................................................................. 13
O5 Tyre Storage.................................................................................................................................. 13
O6 Leachate management.................................................................................................................. 13
O7 Management of surface waters ..................................................................................................... 14
O8 Fire risk reduction works ............................................................................................................... 14
O9 Fire extinguishment ....................................................................................................................... 14
O10 Fire fighting capability.................................................................................................................... 14
O11 Burning of green waste ................................................................................................................. 14
O12 Quality assurance.......................................................................................................................... 15
O13 Screening of waste........................................................................................................................ 15
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 3 of 29 Archive date: 01-Apr-2011
O14 Filling plan ..................................................................................................................................... 15
O15 Completion of landfill cells............................................................................................................. 15
O16 Unauthorised entry ........................................................................................................................ 15
O17 Degradation of local amenity......................................................................................................... 15
O18 Covering of waste.......................................................................................................................... 15
5 MONITORING AND RECORDING CONDITIONS ........................................................................................... 16 M1 Monitoring records......................................................................................................................... 16
M2 Requirement to monitor concentration of pollutants discharged ................................................... 16
M3 Testing methods - concentration limits.......................................................................................... 18
M4 Recording of pollution complaints ................................................................................................. 18
M5 Telephone complaints line............................................................................................................. 19
M6 Requirement to monitor volume or mass ...................................................................................... 19
M7 Monitoring remaining landfill capacity ........................................................................................... 20
M8 Rainfall Monitoring......................................................................................................................... 20
M9 Laboratory accreditation................................................................................................................ 20
6 REPORTING CONDITIONS....................................................................................................................... 20 R1 Annual return documents .................................................................................................................. 20
R2 Notification of environmental harm.................................................................................................... 21
R3 Written report .................................................................................................................................... 22
R4 Recording of fires .............................................................................................................................. 22
R5 Leachate discharges to surface waters............................................................................................ 23
R6 Landfill Gas Hazard Reporting .......................................................................................................... 23
R7 Groundwater contamination reporting............................................................................................... 23
R8 Surface water contamination reporting ............................................................................................. 24
GENERAL CONDITIONS.................................................................................................................................... 24 G1 Copy of licence kept at the premises ............................................................................................ 24
POLLUTION STUDIES AND REDUCTION PROGRAMS ........................................................................................... 24 U1 The licensee must complete by 30 June 2005 the upgrading of its existing sediment basin to a ..... 24
U2 Leachate Management ..................................................................................................................... 24
SPECIAL CONDITIONS...................................................................................................................................... 25
Not applicable ............................................................................................................................................ 25
DICTIONARY ................................................................................................................................................... 25
General Dictionary ..................................................................................................................................... 25
Special Dictionary.................................................................................................................................... 27
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 4 of 29 Archive date: 01-Apr-2011
Information about this licence
Dictionary
A definition of terms used in the licence can be found in the dictionary at the end of this licence.
Responsibilities of licensee
Separate to the requirements of this licence, general obligations of licensees are set out in the Protection of the Environment Operations Act 1997 ("the Act") and the Regulations made under the Act. These include obligations to: ensure persons associated with you comply with this licence, as set out in section 64 of the Act; control the pollution of waters and the pollution of air (see for example sections 120 - 132 of the Act);
and report incidents causing or threatening material environmental harm to the environment, as set out in
Part 5.7 of the Act.
Variation of licence conditions
The licence holder can apply to vary the conditions of this licence. An application form for this purpose is available from the EPA. The EPA may also vary the conditions of the licence at any time by written notice without an application being made. Where a licence has been granted in relation to development which was assessed under the Environmental Planning and Assessment Act 1979 in accordance with the procedures applying to integrated development, the EPA may not impose conditions which are inconsistent with the development consent conditions until the licence is first reviewed under Part 3.6 of the Act.
Duration of licence
This licence will remain in force until the licence is surrendered by the licence holder or until it is suspended or revoked by the EPA or the Minister. A licence may only be surrendered with the written approval of the EPA.
Licence review
The Act requires that the EPA review your licence at least every 5 years after the issue of the licence, as set out in Part 3.6 and Schedule 5 of the Act. You will receive advance notice of the licence review.
Fees and annual return to be sent to the EPA
For each licence fee period you must pay: an administrative fee; and a load-based fee (if applicable). The EPA publication "A Guide to Licensing" contains information about how to calculate your licence fees.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 5 of 29 Archive date: 01-Apr-2011
The licence requires that an Annual Return, comprising a Statement of Compliance and a summary of any monitoring required by the licence (including the recording of complaints), be submitted to the EPA. The Annual Return must be submitted within 60 days after the end of each reporting period. See condition R1 regarding the Annual Return reporting requirements. Usually the licence fee period is the same as the reporting period.
Transfer of licence
The licence holder can apply to transfer the licence to another person. An application form for this purpose is available from the EPA.
Public register and access to monitoring data
Part 9.5 of the Act requires the EPA to keep a public register of details and decisions of the EPA in relation to, for example: licence applications; licence conditions and variations; statements of compliance; load based licensing information; and load reduction agreements. Under s320 of the Act application can be made to the EPA for access to monitoring data which has been submitted to the EPA by licensees.
This licence is issued to:
BELLINGEN SHIRE COUNCIL PO BOX 117 BELLINGEN NSW 2454
subject to the conditions which follow.
1 Administrative conditions
A1 What the licence authorises and regulates
A1.1 Not applicable.
A1.2 This licence authorises the carrying out of the scheduled activities listed below at the premises specified in A2. The activities are listed according to their scheduled activity classification, fee-based activity classification and the scale of the operation.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 6 of 29 Archive date: 01-Apr-2011
Unless otherwise further restricted by a condition of this licence, the scale at which the activity is carried out must not exceed the maximum scale specified in this condition.
Scheduled Activity
Waste disposal (application to land)
Fee Based Activity Scale
Waste disposal (application to land) 0 - All
A1.3 Not applicable.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 7 of 29 Archive date: 01-Apr-2011
A2 Premises to which this licence applies
A2.1 The licence applies to the following premises:
Premises Details
RALEIGH WASTE MANAGEMENT CENTRE
LOT 86, DP 630914, SHORTCUT ROAD
URUNGA
NSW
2455
86/630914
86/630914
A3 Other activities A3.1 Not applicable.
A4 Information supplied to the EPA A4.1 Works and activities must be carried out in accordance with the proposal contained in the licence
application, except as expressly provided by a condition of this licence. In this condition the reference to "the licence application" includes a reference to:
(a) the applications for any licences (including former pollution control approvals) which this licence replaces under the Protection of the Environment Operations (Savings and Transitional) Regulation 1998; and
(b) the licence information form provided by the licensee to the EPA to assist the EPA in connection with the issuing of this licence.
A4.2 The following report submitted to the EPA:
Environmental Management Plan for the Raleigh Waste Management Facility Short Cut Road, Raleigh, Jellife Environmental Pty Ltd, 10 June 1999 amended 14 September 1999. as amended subsequently by;
(a) replacement pages 40, 41, 49 and Plan B faxed by Jelliffe Environmental Pty Ltd dated 14
September 1999; and (b) the letter and attachments from Bellingen Shire Council dated 18 February 2000; and (c) revised LEMP dated 20 April 2001.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 8 of 29 Archive date: 01-Apr-2011
is not to be taken as part of the documentation in A4.1, other than those parts specifically referenced in this licence.
Note: For the purposes of this licence the abbreviation ‘LEMP’ is defined as the report described in
this condition.
2 Discharges to air and water and applications to land
P1 Location of monitoring/discharge points and areas
P1.1 The following points referred to in the table below are identified in this licence for the purposes of monitoring and/or the setting of limits for the emission of pollutants to the air from the point.
Air
EPA Identi-
fication no.
Type of Monitoring Point Type of Discharge Point Description of Location
14 Air quality monitoring. All enclosed buildings at the premises.
15 Air quality monitoring. All enclosed buildings within 250 metres of
waste filled areas of the premises.
16 Landfill gas generation
monitoring
The surface of waste filled surfaces which
have been subject to final capping.
P1.2 The following points referred to in the table are identified in this licence for the purposes of the
monitoring and/or the setting of limits for discharges of pollutants to water from the point. P1.3 The following utilisation areas referred to in the table below are identified in this licence for the
purposes of the monitoring and/or the setting of limits for any application of solids or liquids to the utilisation area.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 9 of 29 Archive date: 01-Apr-2011
Water and land
EPA identi-
fication no.
Type of monitoring point Type of discharge point Description of location
1 Leachate quality and
leachate level.
Leachate quality and
leachate level.
Leachate sump, marked MH on Plan E of
LEMP
2 Surface water quality
monitoring.
Surface water quality
monitoring.
Outlet pipe of surface water treatment
wetland, marked SWB on Plan E of LEMP (as
modified by correspondence from the licensee
dated 8 November 2004).
3 Groundwater quality
monitoring.
BH1, as marked on works-as-executed Plan
E forwarded to the EPA with the licensee's
correspondence dated 22 November 2004.
8 Surface water quality
monitoring.
In creek immediately upstream of landfill,
marked as SWA on Plan C of LEMP.
9 Surface water quality
monitoring.
Outlet of pipe located in bund of eastern edge
of wetland, marked as SWC on Plan C of
LEMP.
13 Leachate volume
monitoring
Leachate tank as marked on Plan E of LEMP.
18 Groundwater quality
monitoring.
BH7, as marked on Plan E of LEMP.
3 Limit conditions
L1 Pollution of waters L1.1 Except as may be expressly provided in any other condition of this licence, the licensee must
comply with section 120 of the Protection of the Environment Operations Act 1997. L1.2 The level of leachate in the leachate sump (Point 1) must not exceed the level of the invert of the
leachate pipes where they enter the leachate sump, except as direct result of a rainfall event of greater than or equal to 300mm in total falling over any consecutive five day period.
L1.3 Leachate is permitted to overflow from the leachate management system only as a direct result of
a rainfall event of equal to or greater than 300mm in total falling over any consecutive five day period and only from the following points: Point 1 and the active cell.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 10 of 29 Archive date: 01-Apr-2011
L1.4 The level of liquid and other material in each sedimentation basin must not exceed the level indicated by the sedimentation basin marker, except:
(a) when the basin is receiving stormwater caused by rainfall on the premises; or (b) within five days of the cessation of any rain.
L2 Load limits L2.1 Not applicable. L2.2 Not applicable.
L3 Concentration limits
L3.1 For each monitoring/discharge point or utilisation area specified in the table\s below (by a point number), the concentration of a pollutant discharged at that point, or applied to that area, must not exceed the concentration limits specified for that pollutant in the table.
L3.2 Where a pH quality limit is specified in the table, the specified percentage of samples must be
within the specified ranges.
L3.3 To avoid any doubt, this condition does not authorise the pollution of waters by any pollutant other than those specified in the table\s.
Water and Land POINT 2
Pollutant Units of Measure 50 percentile concentration limit
90 percentile concentration limit
3DGM concentration limit
100 percentile Concentration Limit
pH pH 6.5 - 8.5 Total suspended solids
milligrams per litre 50
L3.4 Exceedances of the concentration limits for total suspended solids in condition L3.3 are permitted
at the following points for the duration of the overflow: Point 2, whenever a wet weather overflow is occurring due to a stormwater event greater than or
equal to 74mm of rain in total falling over any consecutive five day period.
L4 Volume and mass limits
L4.1 Not applicable.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 11 of 29 Archive date: 01-Apr-2011
L5 Waste L5.1 The licensee must not cause, permit or allow any waste to be received at the premises, except the
wastes expressly referred to in the column titled “Waste” and meeting the definition, if any, in the column titled “Description” in the table below. Any waste received at the premises must only be used for the activities referred to in relation to that waste in the column titled “Activity” in the table below. Any waste received at the premises is subject to those limits or conditions, if any, referred to in relation to that waste contained in the column titled “Other Limits” in the table below. Condition L5.1 does not limit any other conditions in this licence.
Code Waste Description Activity Other Limits
NA General Solid Waste (putrescible)
NA General Solid Waste (non-putrescible)
Asbestos Waste
Waste Tyres
As defined in Schedule 1 of the POEO Act, in force from time to time
NA General Solid Waste Wastes assessed as General Solid Waste which are also subject to general or specific immobilisation approvals which have a restriction that they may only be disposed of at waste disposal facilities which have currently operating leachate collection systems.
Waste disposal (application to land)
Total tonnage of waste disposed of at the premises must not exceed 8000 tonnes per year.
NA Any waste received on site that is below licensing thresholds in Schedule 1 of the POEO Act, as in force from time to time
NA
L5.2 Tyres from the Sydney Metropolitan Area must not be received at the premises unless:
(a) they have been shredded into pieces measuring no more than 250mm in any direction; or (b) they have had their walls removed; or (c) the facility has the capacity, at the time of receiving the tyres, to recycle or reprocess the
tyres into a saleable product (including retreading the tyres); or (d) the facility has the capacity, at the time of receiving the tyres, to shred the tyres or remove
the walls from the tyres; or (e) the tyres are from a domestic load containing no more than 5 tyres having a diameter of less
than 1.2 metres.
L6 Noise Limits L6.1 Noise from the premises must not exceed:
(a) an LAeq (15 minute) noise emission criterion of 45 dB(A) (7am to 6pm ) Monday to Friday and 8am to 5pm Saturday ; and
(b) an LAeq (15 minute) noise emission criterion of 40 dB(A) during the evening (6pm to 10pm) Monday to Friday; and
(c) at all other times, an LAeq (15 minutes) noise emission criterion of 35 dB(A), except as expressly provided by this licence.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 12 of 29 Archive date: 01-Apr-2011
L6.2 Noise from the premises is to be measured at the most affected point on or within the affected property boundary or, if this is more than 30 metres from a residence located within the boundaries of the affected property, at the most affected point within 30 metres of the residence.
L7 Hours of operation L7.1 All work at the premises must be conducted between the following hours: 7am to 6pm Mondays to Fridays, 8am to 5pm Saturdays, Sundays and Public Holidays. L7.2 The hours of operation permitted by this licence may be varied where there is no significant impact
on the ambient levels outside the premises or at any noise sensitive location. The licensee must provide evidence that no significant impact occurs prior to a variation being granted for the hours of operation.
L8 Odours L8.1 No condition of this licence identifies a potentially offensive odour for the purposes of section 129
of the Protection of the Environment Operations Act 1997. Note: Section 129 of the Protection of the Environment Operations Act 1997, provides that the licensee
must not cause or permit the emission of any offensive odour from the premises but provides a defence if the emission is identified in the relevant environment protection licence as a potentially offensive odour and the odour was emitted in accordance with the conditions of a licence directed at minimising odour.
4 Operating conditions
O1 Activities must be carried out in a competent manner
O1.1 Licensed activities must be carried out in a competent manner.
This includes: (a) the processing, handling, movement and storage of materials and substances used to carry
out the activity; and (b) the treatment, storage, processing, reprocessing, transport and disposal of waste generated
by the activity.
O2 Maintenance of plant and equipment O2.1 All plant and equipment installed at the premises or used in connection with the licensed activity:
(a) must be maintained in a proper and efficient condition; and (b) must be operated in a proper and efficient manner.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 13 of 29 Archive date: 01-Apr-2011
O3 Dust Control O3.1 All operations and activities occurring at the premises must be carried out in a manner that will
minimise the emission of dust from the premises.
O4 Closure plan O4.1 The last licensee must prepare and submit to the EPA within three months prior to the last load of
waste being landfilled a closure plan in accordance with section 76 of the Protection of the Environment Operations Act 1997.
O5 Tyre Storage O5.1 The total quantity of used, rejected or unwanted tyres (including shredded tyres and tyre pieces)
stockpiled at the premises must not exceed 50 tonnes. O5.2 The licensee must ensure that stockpiles of used, rejected or unwanted tyres (including shredded
tyres and tyre pieces) are located in a clearly defined area. O5.3 The licensee must ensure that stockpiles of used, rejected or unwanted tyres (including shredded
tyres and tyre pieces) are managed so as not to cause or to be likely to cause the spread of disease by vermin.
O5.4 The licensee must ensure that measures are taken to prevent stockpiles of used, rejected or
unwanted tyres (including shredded tyres and tyre pieces) from catching on fire.
O6 Leachate management O6.1 The leachate management system must be operated and maintained to ensure that the level of
leachate in the leachate interception trench will not exceed the level of the upper surface of the bedrock, except as a direct result of rainfall events greater than or equal to 300mm in total falling over any consecutive five day period.
O6.2 The leachate interception trench and drainage pipes must be maintained to ensure that their
capacity to capture and drain leachate to the leachate sump is not reduced. O6.3 The licensee must take all practical measures to minimise the amount of leachate in the leachate
collection and storage system and maximise the disposal of leachate to enable compliance with conditions L1.1 to L1.3 of this licence.
O6.4 Leachate collected at the premises may be irrigated onto waste filled areas of the premises,
reinjected into waste filled areas of the premises or transported off the premises to a facility lawfully able to receive and treat or process the leachate.
O6.5 Irrigation of leachate at the premises must not occur in a manner which causes surface runoff. O6.6 The volume of leachate directed to the reinjection trenches must not exceed the capacity of the
trenches to assimilate the leachate.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 14 of 29 Archive date: 01-Apr-2011
O6.7 Spray from leachate irrigation must not drift beyond the boundary of the premises. O6.8 The active cell must be bunded to prevent surface water flowing onto the active cell and to prevent
leachate overflowing from the active cell except as permitted by condition L1.3 of this licence. O6.9 The surface area of the active cell must be minimised at all times.
O7 Management of surface waters O7.1 The perimeter of the areas where waste has been landfilled must be contoured to prevent
stormwater running onto these surfaces from all storm events less than or equal to a 1 in 10 year 24 hour duration storm event .
O7.2 Each sedimentation basin must have a marker (the “sedimentation basin marker”) that identifies
the upper level of the sediment storage zone. O7.3 Whenever the level of liquid and other material in any sedimentation basin exceeds the level
indicated by the sedimentation basin marker, the licensee must take all practical measures as soon as possible to reduce the level of liquid and other material in the sedimentation basin.
O7.4 Surface water must not pond on the landfill surface, excepting ponding within the active cell which
arises from rain water falling directly onto the active cell.
O8 Fire risk reduction works O8.1 The licensee must have in place and implement section 4.4.2.3 of LEMP to minimise the risk of fire
at the premises.
O9 Fire extinguishment O9.1 The licensee must extinguish fires at the premises as soon as possible.
O10 Fire fighting capability O10.1 The licensee must have adequate fire prevention measures in place, and ensure that facility
personnel are able to access fire-fighting equipment and manage fire outbreaks at any part of the premises in accordance with section 4.6.6 in the LEMP.
O11 Burning of green waste O11.1 There must be no incineration or burning of any waste at the premises, except in accordance with
section 4.6.6.1 of the LEMP.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 15 of 29 Archive date: 01-Apr-2011
O12 Quality assurance O12.1 The licensee must supply, construct and install landfill capping system at the premises in
accordance with Australian Standard HB90.3(2000) or an alternative construction quality assurance program approved in writing by the EPA in advance.
O13 Screening of waste O13.1 The licensee must have in place and implement procedures to identify and prevent the disposal of
any waste not permitted by this licence to be disposed of at the premises in accordance with the procedures in section 4.5.10 and 4.5.11 of the LEMP.
O14 Filling plan O14.1 The licensee must manage the disposal of waste at the premises in accordance with the
progressive filling plan in section 4.5.2 of the LEMP.
O15 Completion of landfill cells O15.1 The licensee must ensure that the completed landfill cells are capped progressively at times when
the level of waste reaches final heights as detailed in section 4.5.2 of the LEMP. O15.2 Final capping of completed cells must comprise four layers in the order of installation: a seal
bearing surface, a sealing layer, an infiltration layer and a revegetation layer, which must be installed in accordance with section 4.5.20.1 of the LEMP.
O16 Unauthorised entry O16.1 The licensee must take all practicable steps to control entry to the premises. O16.2 The licensee must install and maintain lockable security gates at all access and departure
locations. O16.3 The licensee must ensure that all gates are locked whenever the landfill is unattended.
O17 Degradation of local amenity O17.1 The licensee must implement the litter management program specified in section 4.6.4.4 of the
LEMP.
O18 Covering of waste O18.1 Cover material must be virgin excavated natural material (VENM) or an alternative cover material
approved in writing by the EPA.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 16 of 29 Archive date: 01-Apr-2011
(a) Daily cover Cover material must be applied to a minimum depth of 15 centimetres over all exposed
landfilled waste prior to ceasing operations at the end of each day. (b) Intermediate cover Cover material must be applied to a depth of 30 centimetres over surfaces of the landfilled
waste at the premises which are to be exposed for more than 90 days. (c) Cover material stockpile At least two weeks cover material must be available at the premises under all weather
conditions. This material may be won on site, or alternatively a cover stockpile must be maintained adjacent to the tip face.
5 Monitoring and recording conditions
M1 Monitoring records
M1.1 The results of any monitoring required to be conducted by this licence or a load calculation protocol must be recorded and retained as set out in this condition.
M1.2 All records required to be kept by this licence must be:
(a) in a legible form, or in a form that can readily be reduced to a legible form; (b) kept for at least 4 years after the monitoring or event to which they relate took place; and (c) produced in a legible form to any authorised officer of the EPA who asks to see them.
M1.3 The following records must be kept in respect of any samples required to be collected for the purposes of this licence: (a) the date(s) on which the sample was taken; (b) the time(s) at which the sample was collected; (c) the point at which the sample was taken; and (d) the name of the person who collected the sample.
M2 Requirement to monitor concentration of pollutants discharged M2.1 For each monitoring/discharge point or utilisation area specified below (by a point number), the
licensee must monitor (by sampling and obtaining results by analysis) the concentration of each pollutant specified in Column 1. The licensee must use the sampling method, units of measure, and sample at the frequency, specified opposite in the other columns:
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 17 of 29 Archive date: 01-Apr-2011
POINT 1 Pollutant Units of measure Frequency Sampling Method Alkalinity (as calcium carbonate)
milligrams per litre Every 6 months Grab sample
Ammonia milligrams per litre Every 6 months Grab sample Arsenic milligrams per litre Yearly Grab sample BOD milligrams per litre Every 6 months Grab sample Calcium milligrams per litre Every 6 months Grab sample Nitrate milligrams per litre Every 6 months Grab sample Organochlorine pesticides milligrams per litre Yearly Grab sample Organophosphate pesticides milligrams per litre Yearly Grab sample Phenols milligrams per litre Yearly Grab sample Potassium milligrams per litre Every 6 months Grab sample pH pH Every 6 months Probe
POINT 2 Pollutant Units of measure Frequency Sampling Method Alkalinity (as calcium carbonate)
milligrams per litre Special Frequency 2 Grab sample
Ammonia milligrams per litre Special Frequency 2 Grab sample BOD milligrams per litre Special Frequency 2 Grab sample Calcium milligrams per litre Special Frequency 2 Grab sample Nitrate milligrams per litre Special Frequency 2 Grab sample Potassium milligrams per litre Special Frequency 2 Grab sample TKN-N milligrams per litre Special Frequency 2 Grab sample TN milligrams per litre Special Frequency 2 Grab sample TSS milligrams per litre Special Frequency 1 Grab sample pH pH Special Frequency 1 Probe
POINTS 3,18 Pollutant Units of measure Frequency Sampling Method Alkalinity (as calcium carbonate)
milligrams per litre Every 6 months Grab sample
Ammonia milligrams per litre Every 6 months Grab sample BOD milligrams per litre Every 6 months Grab sample Calcium milligrams per litre Every 6 months Grab sample Nitrate milligrams per litre Every 6 months Grab sample Potassium milligrams per litre Every 6 months Grab sample pH pH Every 6 months Probe
POINTS 8,9 Pollutant Units of measure Frequency Sampling Method Alkalinity (as calcium carbonate)
milligrams per litre Special Frequency 2 Grab sample
Ammonia milligrams per litre Special Frequency 2 Grab sample BOD milligrams per litre Special Frequency 2 Grab sample Calcium milligrams per litre Special Frequency 2 Grab sample Nitrate milligrams per litre Special Frequency 2 Grab sample Potassium milligrams per litre Special Frequency 2 Grab sample TKN-N milligrams per litre Special Frequency 2 Grab sample TN milligrams per litre Special Frequency 2 Grab sample TSS milligrams per litre Special Frequency 2 Grab sample pH pH Special Frequency 2 Probe
POINT 14 Pollutant Units of measure Frequency Sampling Method Methane percent by volume Quarterly Probe
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 18 of 29 Archive date: 01-Apr-2011
POINT 15 Pollutant Units of measure Frequency Sampling Method Methane percent by volume Quarterly Probe
POINT 16 Pollutant Units of measure Frequency Sampling Method Methane percent by volume Quarterly Probe
For the purposes of the above table(s) Special Frequency 1 means the collection of one sample as
soon as practicable after each of five rainfall events each year exceeding 40mm in any 48 hour period, including three samples from the outlet of the discharge pipe of Point 2.
For the purposes of the above table(s) ‘Special Frequency 2’ means the collection of one sample as soon as practicable after each of two rainfall events each year exceeding 40mm in any 48 hour period.
M3 Testing methods - concentration limits
M3.1 Monitoring for the concentration of a pollutant emitted to the air required to be conducted by this licence must be done in accordance with:
(a) any methodology which is required by or under the Act to be used for the testing of the concentration of the pollutant; or
(b) if no such requirement is imposed by or under the Act, any methodology which a condition of this licence requires to be used for that testing; or
(c) if no such requirement is imposed by or under the Act or by a condition of this licence, any methodology approved in writing by the EPA for the purposes of that testing prior to the testing taking place.
Note: The Protection of the Environment Operations (Clean Air) Regulation 2002 requires testing for certain purposes to be conducted in accordance with test methods contained in the publication "Approved Methods for the Sampling and Analysis of Air Pollutants in NSW".
M3.2 Subject to any express provision to the contrary in this licence, monitoring for the concentration of a pollutant discharged to waters or applied to a utilisation area must be done in accordance with the Approved Methods Publication unless another method has been approved by the EPA in writing before any tests are conducted.
M4 Recording of pollution complaints
M4.1 The licensee must keep a legible record of all complaints made to the licensee or any employee or agent of the licensee in relation to pollution arising from any activity to which this licence applies.
M4.2 The record must include details of the following:
(a) the date and time of the complaint;
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 19 of 29 Archive date: 01-Apr-2011
(b) the method by which the complaint was made; (c) any personal details of the complainant which were provided by the complainant or, if no
such details were provided, a note to that effect; (d) the nature of the complaint; (e) the action taken by the licensee in relation to the complaint, including any follow-up contact
with the complainant; and (f) if no action was taken by the licensee, the reasons why no action was taken.
M4.3 The record of a complaint must be kept for at least 4 years after the complaint was made.
M4.4 The record must be produced to any authorised officer of the EPA who asks to see them.
M5 Telephone complaints line
M5.1 The licensee must operate during its operating hours a telephone complaints line for the purpose of receiving any complaints from members of the public in relation to activities conducted at the premises or by the vehicle or mobile plant, unless otherwise specified in the licence.
M5.2 The licensee must notify the public of the complaints line telephone number and the fact that it is a
complaints line so that the impacted community knows how to make a complaint.
M5.3 Conditions M5.1 and M5.2 do not apply until 3 months after:
(a) the date of the issue of this licence or (b) if this licence is a replacement licence within the meaning of the Protection of the Environment
Operations (Savings and Transitional) Regulation 1998, the date on which a copy of the licence was served on the licensee under clause 10 of that regulation.
M6 Requirement to monitor volume or mass
M6.1 Not applicable.
M6.2 For each Point specified below the licensee must monitor:
(a) the volume of leachate discharged from the Point for reinjection into waste filled areas; (b) the volume of leachate discharged from the Point for irrigation onto waste filled areas; and (c) the volume of leachate discharged from the Point for transport off-site, at the frequency and using the method and units of measure specified below.
POINT 13 Frequency Unit of Measure Sampling Method Weekly
kL
No method specified
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 20 of 29 Archive date: 01-Apr-2011
M7 Monitoring remaining landfill capacity M7.1 The licensee must monitor the remaining disposal capacity (in cubic metres) of the landfill.
M8 Rainfall Monitoring M8.1 The licensee must monitor and record rainfall occurring at the premises on a daily basis.
M9 Laboratory accreditation M9.1 Samples taken pursuant to a requirement in this licence to monitor the volume, mass or
concentration of pollutants, must be analysed and reported in accordance with the laboratory accreditation requirements set out in section 2.1.3 of the Load Calculation Protocol.
The Load Calculation Protocol is the Protocol referred to in clause 18 of the Protection of the
Environment Operations (General) Regulation 1998. A copy of the Protocol was published in the Government Gazette on 25 June 1999 and can be purchased from the EPA or viewed at http://www.epa.nsw.gov.au.
6 Reporting conditions
R1 Annual return documents What documents must an Annual Return contain? R1.1 The licensee must complete and supply to the EPA an Annual Return in the approved form
comprising: (a) a Statement of Compliance; and (b) a Monitoring and Complaints Summary. A copy of the form in which the Annual Return must be supplied to the EPA accompanies this licence. Before the end of each reporting period, the EPA will provide to the licensee a copy of the form that must be completed and returned to the EPA.
Period covered by Annual Return
R1.2 An Annual Return must be prepared in respect of each reporting period, except as provided below.
Note: The term "reporting period" is defined in the dictionary at the end of this licence. Do not complete the Annual Return until after the end of the reporting period.
R1.3 Where this licence is transferred from the licensee to a new licensee:
(a) the transferring licensee must prepare an Annual Return for the period commencing on the first day of the reporting period and ending on the date the application for the transfer of the licence to the new licensee is granted; and
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 21 of 29 Archive date: 01-Apr-2011
(b) the new licensee must prepare an Annual Return for the period commencing on the date the application for the transfer of the licence is granted and ending on the last day of the reporting period.
Note: An application to transfer a licence must be made in the approved form for this purpose. R1.4 Where this licence is surrendered by the licensee or revoked by the EPA or Minister, the licensee
must prepare an Annual Return in respect of the period commencing on the first day of the reporting period and ending on: (a) in relation to the surrender of a licence - the date when notice in writing of approval of the
surrender is given; or (b) in relation to the revocation of the licence - the date from which notice revoking the licence
operates.
Deadline for Annual Return
R1.5 The Annual Return for the reporting period must be supplied to the EPA by registered post not later than 60 days after the end of each reporting period or in the case of a transferring licence not later than 60 days after the date the transfer was granted (the 'due date').
Notification where actual load can not be calculated R1.6 Not applicable.
Licensee must retain copy of Annual Return
R1.7 The licensee must retain a copy of the Annual Return supplied to the EPA for a period of at least 4 years after the Annual Return was due to be supplied to the EPA.
Certifying of Statement of Compliance and signing of Monitoring and Complaints Summary R1.8 Within the Annual Return, the Statement of Compliance must be certified and the Monitoring and
Complaints Summary must be signed by: (a) the licence holder; or (b) by a person approved in writing by the EPA to sign on behalf of the licence holder.
R1.9 A person who has been given written approval to certify a certificate of compliance under a licence issued under the Pollution Control Act 1970 is taken to be approved for the purpose of this condition until the date of first review of this licence.
R2 Notification of environmental harm
Note: The licensee or its employees must notify the EPA of incidents causing or threatening material harm to the environment as soon as practicable after the person becomes aware of the incident in accordance with the requirements of Part 5.7 of the Act.
R2.1 Notifications must be made by telephoning the Environment Line service on 131 555.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 22 of 29 Archive date: 01-Apr-2011
R2.2 The licensee must provide written details of the notification to the EPA within 7 days of the date on which the incident occurred.
R3 Written report R3.1 Where an authorised officer of the EPA suspects on reasonable grounds that:
(a) where this licence applies to premises, an event has occurred at the premises; or (b) where this licence applies to vehicles or mobile plant, an event has occurred in connection
with the carrying out of the activities authorised by this licence, and the event has caused, is causing or is likely to cause material harm to the environment (whether the harm occurs on or off premises to which the licence applies), the authorised officer may request a written report of the event.
R3.2 The licensee must make all reasonable inquiries in relation to the event and supply the report to the EPA within such time as may be specified in the request.
R3.3 The request may require a report which includes any or all of the following information:
(a) the cause, time and duration of the event; (b) the type, volume and concentration of every pollutant discharged as a result of the event; (c) the name, address and business hours telephone number of employees or agents of the
licensee, or a specified class of them, who witnessed the event; (d) the name, address and business hours telephone number of every other person (of whom
the licensee is aware) who witnessed the event, unless the licensee has been unable to obtain that information after making reasonable effort;
(e) action taken by the licensee in relation to the event, including any follow-up contact with any complainants;
(f) details of any measure taken or proposed to be taken to prevent or mitigate against a recurrence of such an event; and
(g) any other relevant matters.
R3.4 The EPA may make a written request for further details in relation to any of the above matters if it is not satisfied with the report provided by the licensee. The licensee must provide such further details to the EPA within the time specified in the request.
R4 Recording of fires R4.1 The licensee must maintain a daily log and record the following data of fires at the site: (a) Time and date when the fire was deliberately started or reported.
(b) Whether the fire was authorised by the licensee, and, if not, the circumstances which ignited the fire.
(c) The time and date that the fire ceased and whether it burnt out or was extinguished. (d) The location of fire (eg. clean timber stockpile, putrescible garbage cell, etc).
(e) Prevailing weather conditions. (f) Observations made in regard to smoke direction and dispersion. (g) The amount of waste that was combusted by the fire. (h) Action taken to extinguish the fire.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 23 of 29 Archive date: 01-Apr-2011
R4.2 The licensee or its employees or agents must notify the EPA in accordance with conditions R2.1 and R2.2 of all fires at the premises as soon as practical after becoming aware of the incident.
R5 Leachate discharges to surface waters R5.1 The licensee must notify the EPA in accordance with condition R5.2.when leachate discharges
from the premises and/or when the level of leachate in the leachate sump (Point 1) exceeds the invert of the leachate pipes in the leachate interception trench where they enter the leachate sump.
R5.2 The licensee must provide written details of any leachate discharge(s) to the EPA within 7 days of
the date on which the incident occurred in accordance with condition R5.3. R5.3 The written details referred to in the above condition must be provided as a report. The report
must include the following information: (a) the volume of the leachate discharged and over what time period the discharge occurred; (b) the date and time of the commencement of the overflow; (c) the weather conditions at the time of the discharge, specifying the amount of rainfall on a
daily basis that had fallen: - on the day(s) of the discharge; and - for the one week period prior to the discharge.
(d) the most recent monitoring results of the chemical composition of the leachate; (e) an explanation as to why the discharge occurred; (f) the location(s) of the discharge; (g) a plan of action to prevent a similar discharge in the future; and (h) was the discharge permitted by this licence.
R6 Landfill Gas Hazard Reporting R6.1 The licensee must notify the EPA within 24 hours in accordance with condition R2.1 if landfill gas
monitoring detects methane at Point 14 and/or 15 above 1.25% (v/v), and increase the frequency of monitoring to daily, until the EPA determines otherwise.
R7 Groundwater contamination reporting R7.1 Whenever the results for any two consecutive monitoring rounds required by condition M2 of this
licence for the following Point exceeds the following trigger values for any two or more parameters the licensee must submit a report to the EPA within 14 days proposing a Groundwater Assessment Program identifying a strategy for assessing the nature and extent of groundwater contamination at the premises:
Point 18
Parameter Units of Measure Trigger Value Potassium mg/l 16.5 Ammonia mg/l 3.1 Calcium mg/l 49.5 Alkalinity mg/l 63.9
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 24 of 29 Archive date: 01-Apr-2011
R8 Surface water contamination reporting R8.1 Within three months after the completion of each 24 months of sampling in accordance with
condition M2 of this licence for the following Points the licensee must submit a report to the EPA incorporating all monitoring results in graphical and tabular form together with an assessment of the nature and extent of any impacts of the landfill activity on water quality: Points 2, 8, 9
General conditions
G1 Copy of licence kept at the premises
G1.1 A copy of this licence must be kept at the premises to which the licence applies.
G1.2 The licence must be produced to any authorised officer of the EPA who asks to see it.
G1.3 The licence must be available for inspection by any employee or agent of the licensee working at the premises.
Pollution studies and reduction programs U1 The licensee must complete by 30 June 2005 the upgrading of its existing sediment basin to a
surface water treatment wetland in accordance with the plan provided to the EPA dated 8 November 2004.
U2 Leachate Management U2.1 By 9 July 2010 the licensee must have in place a system to contain any leachate seeping from the batters of
the landfill. U2.2 By 9 July 2010 the licensee must have in place a system to contain any leachate from the greenwaste
storage area at the north of the current cell. U2.3 The licensee must prevent any collected leachate from entering the stormwater drainage system. U2.4 The licensee must direct all collected leachate to the leachate storage tanks.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 25 of 29 Archive date: 01-Apr-2011
U2.5 By 9 July 2010 the licensee must remove at least 15,000 litres of leachate out of the leachate collection and storage system and dispose of that leachate at a facility that is lawfully able to accept that waste.
U2.6 By 23 July 2010 the licensee must provide documentation that at least 15,000 litres of leachate has been
removed and disposed of at a facility that is lawfully able to accept that waste. U2.7 By 6 August 2010 the licensee must remove at least a further 15,000 litres of leachate out of the leachate
collection and storage system and dispose of that leachate at a facility that is lawfully able to accept that waste.
U2.8 By 20 August 2010 the licensee must provide documentation that at least a further 15,000 litres of leachate
has been removed and disposed of at a facility that is lawfully able to accept that waste. U2.9 No leachate shall be injected back into the landfill until at least 30 October 2010.
Special conditions Not applicable
Dictionary
General Dictionary
In this licence, unless the contrary is indicated, the terms below have the following meanings:
3DGM [in relation to a concentration limit]
Means the three day geometric mean, which is calculated by multiplying the results of the analysis of three samples collected on consecutive days and then taking the cubed root of that amount. Where one or more of the samples is zero or below the detection limit for the analysis, then 1 or the detection limit respectively should be used in place of those samples
Act Means the Protection of the Environment Operations Act 1997
activity Means a scheduled or non-scheduled activity within the meaning of the Protection of the Environment Operations Act 1997
actual load Has the same meaning as in the Protection of the Environment Operations (General) Regulation 1998
AM Together with a number, means an ambient air monitoring method of that number prescribed by the Approved Methods for the Sampling and Analysis of Air Pollutants in New South Wales.
AMG Australian Map Grid
anniversary date The anniversary date is the anniversary each year of the date of issue of the licence. In the case of a licence continued in force by the Protection of the Environment Operations Act 1997, the date of issue of the licence is the first anniversary of the date of issue or last renewal of the licence following the commencement of the Act.
annual return Is defined in R1.1
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 26 of 29 Archive date: 01-Apr-2011
Approved Methods Publication
Has the same meaning as in the Protection of the Environment Operations (General) Regulation 1998
assessable pollutants
Has the same meaning as in the Protection of the Environment Operations (General) Regulation 1998
BOD Means biochemical oxygen demand
CEM Together with a number, means a continuous emission monitoring method of that number prescribed by the Approved Methods for the Sampling and Analysis of Air Pollutants in New South Wales.
COD Means chemical oxygen demand
composite sample Unless otherwise specifically approved in writing by the EPA, a sample consisting of 24 individual samples collected at hourly intervals and each having an equivalent volume.
cond. Means conductivity
environment Has the same meaning as in the Protection of the Environment Operations Act 1997
environment protection legislation
Has the same meaning as in the Protection of the Environment Administration Act 1991
EPA Means Environment Protection Authority of New South Wales.
fee-based activity classification
Means the numbered short descriptions in Schedule 1 of the Protection of the Environment Operations (General) Regulation 1998.
flow weighted composite sample
Means a sample whose composites are sized in proportion to the flow at each composites time of collection.
general solid waste (non-putrescible)
Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
general solid waste (putrescible)
Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
grab sample Means a single sample taken at a point at a single time
hazardous waste Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
licensee Means the licence holder described at the front of this licence
load calculation protocol
Has the same meaning as in the Protection of the Environment Operations (General) Regulation 1998
local authority Has the same meaning as in the Protection of the Environment Operations Act 1997
material harm Has the same meaning as in section 147 Protection of the Environment Operations Act 1997
MBAS Means methylene blue active substances
Minister Means the Minister administering the Protection of the Environment Operations Act 1997
mobile plant Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
motor vehicle Has the same meaning as in the Protection of the Environment Operations Act 1997
O&G Means oil and grease
percentile [in Means that percentage [eg.50%] of the number of samples taken that must meet the concentration limit
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 27 of 29 Archive date: 01-Apr-2011
relation to a concentration limit of a sample]
specified in the licence for that pollutant over a specified period of time. In this licence, the specified period of time is the Reporting Period unless otherwise stated in this licence.
plant Includes all plant within the meaning of the Protection of the Environment Operations Act 1997 as well as motor vehicles.
pollution of waters [or water pollution]
Has the same meaning as in the Protection of the Environment Operations Act 1997
premises Means the premises described in condition A2.1
public authority Has the same meaning as in the Protection of the Environment Operations Act 1997
regional office Means the relevant EPA office referred to in the Contacting the EPA document accompanying this licence
reporting period For the purposes of this licence, the reporting period means the period of 12 months after the issue of the licence, and each subsequent period of 12 months. In the case of a licence continued in force by the Protection of the Environment Operations Act 1997, the date of issue of the licence is the first anniversary of the date of issue or last renewal of the licence following the commencement of the Act.
restricted solid waste
Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
scheduled activity Means an activity listed in Schedule 1 of the Protection of the Environment Operations Act 1997
special waste Has the same meaning as in Part 3 of Schedule 1 of the Protection of the Environment Operations Act 1997
TM Together with a number, means a test method of that number prescribed by the Approved Methods for the Sampling and Analysis of Air Pollutants in New South Wales.
TSP Means total suspended particles
TSS Means total suspended solids
Type 1 substance Means the elements antimony, arsenic, cadmium, lead or mercury or any compound containing one or more of those elements
Type 2 substance Means the elements beryllium, chromium, cobalt, manganese, nickel, selenium, tin or vanadium or any compound containing one or more of those elements
utilisation area Means any area shown as a utilisation area on a map submitted with the application for this licence
waste Has the same meaning as in the Protection of the Environment Operations Act 1997
waste type Means liquid, restricted solid waste, general solid waste (putrescible), general solid waste (non-putrescible), special waste or hazardous waste
Special Dictionary
Bedrock Means naturally occurring sub-surface strata of consistent particle size, texture and density which exhibits a permeability of less than or equal to 10 –9 metes per second.
dry weather Means any day at the premises which receives less than 10mm of rain and which is preceded by a 10 day period during which rainfall of not more than 10mm of rain is received at the premises on any one of those 10 days.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 28 of 29 Archive date: 01-Apr-2011
Leachate means liquid released by, or water that has percolated through, waste and which contains
dissolved and/or suspended liquids and/or solids and/or gases. Active cell means that part of the landfill where waste is being disposed of at the time.
Mr Graeme Budd Environment Protection Authority (By Delegation) Date of this edition - 17-Aug-2010
End Notes
1 Licence varied by notice 1005932, issued on 11-Apr-2001, which came into effect on 06-May-2001.
2 Licence varied by notice 1008507, issued on 17-Jul-2001, which came into effect on 11-Aug-2001.
3 Licence varied by notice 1012661, issued on 06-Nov-2001, which came into effect on 01-Dec-2001.
4 Licence varied by notice 1016356, issued on 10-Apr-2002, which came into effect on 05-May-2002.
5 Licence varied by notice 1022323, issued on 30-Apr-2003, which came into effect on 25-May-2003.
6 Licence varied by notice 1039983, issued on 24-Sep-2004, which came into effect on 19-Oct-2004.
7 Licence varied by notice 1044776, issued on 22-Feb-2005, which came into effect on 19-Mar-2005.
8 Licence varied by notice 1056840, issued on 02-Mar-2006, which came into effect on 27-Mar-2006.
9 Condition A1.3 Not applicable varied by notice issued on <issue date> which came into effect on <effective date>
10 Licence varied by notice 1097463, issued on 20-Mar-2009, which came into effect on 20-Mar-2009.
11 Licence varied by notice 1114446, issued on 18-Jun-2010, which came into effect on 18-Jun-2010.
12 Licence varied by change to DECCW region, issued on 17-Aug-2010, which came into effect on 17-Aug-2010.
Section 55 Protection of the Environment Operations Act 1997
Environment Protection Licence
Licence - 5896
Environment Protection Authority - NSW Page 29 of 29 Archive date: 01-Apr-2011
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 87
APPENDIX 2: DRAWINGS
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 88
APPENDIX 3: PLANS
Plan C
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 89
Plan E
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 90
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 91
GROUNDWATER FLOW
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 92
APPENDIX 4: NON-COMPLIANCE RECORD C
ON
DIT
ION
TYPE OF NON-COMPLIANCE
CO
ND
ITIO
N
TYPE OF NON-COMPLIANCE
CO
ND
ITIO
N
TYPE OF NON-
COMPLIANCE
CO
ND
ITIO
N
TYPE OF NON-COMPLIANCE
2012 2011 2008 2007
L 3.3
Limits exceeded for alkalinity and
pH at the downstream
groundwater borehole BH7, EPA
point 18.
L 3.3
Exceedance of alkalinity at downstream
groundwater borehole BH7 most likely
due to natural variations; three
exceedances of TSS and one
exceedance of ammonia at surface water
treatment wetland associated with
significant rainfall.
M 2.1
Only one sample
at the BH 1 was
taken
M2
Some parameters not tested
during a number of monitoring rounds
[alkalinity, BOD, TKN, ammonia, nitrate,
total nitrogen, calcium and potassium] at
the surface water treatment wetland (i.e.
EPA Sampling Point 2).
L 3.3
Concentration limits for Ammonia
exeeded in surface waters at the
outlet of wetland / EPA Point 2
O
11.1
Council carried out burning of a
greenwaste stockpile at RWMC during
January 2011. Fire not supervised and no
action taken to extinguish fire. Fire
brigade called. DECCW issued Council
with a penalty notice for breach of licence
conditions for site.
M 2.1
Nil samples for
arsenic in the
leachate -
sampling point 1
were taken
Two (2) exceedances of TSS at the
surface water treatment wetland (i.e. EPA
Sampling Point 2)
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 93
2012 2011 2008 2007
L 3.3
ANZECC concentration limits for
total nitrogen, nitrate and
potassium were exceeded in
surface waters at outlet of wetland
/ EPA Point 2
M 2.1
Only 3 of the
4required
monitoring rounds
for methane were
taken - due to wet
weather
One (1) exceedance of pH at the
surface water treatment wetland (i.e.
EPA Sampling Point 2)
L 3.3
ANZECC concentration limits for
total nitrogen and potassium were
exceeded in downstream surface
waters at EPA point 9.
L 3.3
There were 4
exceedances of
TSS - see return
for further detail
One (1) exceedance of potassium at
BH 7 (i.e. EPA Sampling Point 18)
L 3.3
Sampling and monitoring of
groundwater was not conducted
on a six monthly basis
M2
1
exceedance of pH
at the surface
water treatment
wetland
M 2.1 Concentration limit for total
suspended solids M 2.1
Two exceedances
for ammonia at
the surface water
treatment wetland
- see return for
further detail
M 2.1 (TSS) was exceeded in surface
waters at EPA Point 2
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 94
2006 2003 2002 2001 2000
M 2.1
EPA Sampling
Point 3 - No
samples were
taken from BH
1(old) instead of
the required 2
monitoring
samples.
M2
Failed to monitor
one water quality
parameter (DO)
and failed to
monitor some
ground and
surface water
locations.
M2
Not all sampling
or records
provided due to
death of
consultant.
M2
Not all
parameters
monitored and
number of
monitoring events
not complied with.
M2
No pollutant
concentration
monitoring re
leachate or
stormwater or
gas
undertaken.
M 2.1
Only 1 sample
was taken for
calcium in the
leachate (EPA
Sampling Point
1), instead of the
required 2
monitoring
samples.
L3
Sediment basin
discharge quality
limit (suspended
solids) not
achieved.
M6
No monitoring
of discharge
volumes from
leachate
storage tank
were provided.
M 2.1
No samples were
taken for the
upstream and
downstream
monitoring
locations (EPA
Sampling Points 8
and 9), instead of
the required 2
samples.
L1
Discharge of
leachate over 4
week period.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 95
M 2.1
Only 1 sample
was taken at the
surface water
treatment wetland
(EPA Sampling
Point 2) instead of
the required 5
monitoring
samples.
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 96
APPENDIX 5: ANNUAL RETURN
Bellingen Shire Council - Raleigh Landfill Environmental Management Plan 97
References
Australian Bureau of Statistics, 2011 Census
NSW EPA, Environmental Guidelines: Solid Waste Landfills
Environmental Management Plan for the Raleigh Waste Management Facility, Jelliffe
Environmental Pty Ltd, 2000
Raleigh Waste Management Centre Polution Incident Response Management Plan,
Robert Bailery Consulting, 2013
Environmental Impact Statement for the Proposed Expansion of the Bellingen Sire
Landfill, Jelliffe Environmental Pty Ltd, 1997
Bellingen Shire Council
Raleigh Landfill Environmental Management Plan
12 May 2014