rites ltd · rites ltd open tender notice no: ... sor /n.f.rly-2010 3050 cum 24.09 73474.50 ......

Signature of the tenderer 1 under seal of the firm

RITES LTD

OPEN TENDER NOTICE NO: 03/OT/R/N.F. Rly-Coochbehar/MDTC/2012 Dated 11.04.2012.

TENDER DOCUMENT FOR CONSTRUCTION OF MULTI DISCIPLINARY TRAINING CENTRE AND HOSTEL BUILDINGS INCLUDING BOUNDARY WALL, INTERNAL ELECTRIFICATION AND OTHER ANCILLARY WORKS AT NEW COOCHBEHAR OF NORTHEAST FRONTIER RAILWAY

Part – 2 (FINANCIAL BID)

CONTENTS

SCHEDULE (BILL) OF QUANTITIES

(PERCENTAGE RATE CONTRACT)

Issued to (Name of Tenderer):________________________________________ Address of tenderer:_________________________________________________ Signature of officer issuing the documents___________________ Designation _______________________________ Date of Issue___________________

(A Govt. of India Enterprise) Regional Project Office, KOLKATA

56 C R Avenue, 2nd floor, Kolkata – 700 012 e.mail : [email protected]

Phone No: (033) 22367118/7146/7162/7143(Fax)


PART – 2

FINANCIAL BID

SCHEDULE (BILL) OF QUANTITIES


OPEN TENDER NOTICE NO: 03/OT/R/N.F.Rly-Coochbehar/MDTC/2012

Dated 11.04.2012

Name of work: Construction of Multi Disciplinary Training Centre & Hostel Building including boundary wall, internal electrification and other ancillary works at New Coochbehar of Northeast Frontier Railway

Completion Time: 18 (eighteen) months from the 15th day after the date of issue of Letter of Acceptance or from the first day of handing over of the site, whichever is later, in accordance with the phasing, if any, indicated in the tender Documents

RATE INDEX

(Percentage Rate Tender)

TENDERER SHOULD QUOTE THEIR RATES HERE UNDER ONLY

Schedule – A : CIVIL ENGINEERING WORKS:

Sl. No

Schedule No. Estimated Cost (In Rs.)

Quoted rates by bidders (Percentage above or below/At Par)

1 Schedule A-I 5,70,25,486.00

Rate quoted are _________________ % (in figures)

________________________(in words)

above /below/at par * on schedule in A-I

2 Schedule A-II 82,48,416.00

Rate quoted are ________________% (in figures)

________________________((in words)

above /below/at par * on schedule in A-II

3 Schedule A-III 3,00,000.00

Rate quoted are _____________ % (in figures)

________________________(in words)

above /below /at par* on schedule in A-III

6,55,73,902.00

* Strike out which are not applicable

Contd..


Schedule – B : ELECTRICAL WORKS:

Sl. No

Schedule No. Estimated Cost

( In Rs.)

Quoted rates by bidders (Percentage above or below/At Par)

4 Electrical Works 84,29,515.00

Rate quoted are _________________ % (in figures)

________________________%(in words)

above /below/at par * on schedule in Electrical estimate

* Strike out which are not applicable

Schedule – C : GENERAL REBATE IF ANY

ON SCHEDULE – A & B ABOVE ___________________________%(in figure)

__________________________% (in words)

i) Signature of Authorised signatory of Tenderer

ii) Name of the signatory iii) Name and Seal of Tenderer iv) Date v) Place

Note 1: TENDERERS ARE REQUESTED TO QUOTE THEIR RATE IN THIS PAGE ONLY AND

NOT IN SCHEDULES, BASIC RATES HAS BEEN SHOWN IN SCHEDULE FOR GUIDENCE

2. CONTRACTOR SHALL PAY WORKS CONTRACT TAX /VAT TO THE CONCERNED AUTHORITY AND SHALL SUBMIT CLEARANCE FROM VAT AUTHORITY REGARDING FURNISHING OF RETURN, COMPLETION OF ASSESSMENT AND HAVING NO DUES FOR VAT/WORKS CONTRACT TAX.

3. SERVICE TAX, IF LEVIABLE SHALL BE PAID BY THE CONTRACTOR AND TAX INVOICE THERE OF SHALL BE SUBMITTED.

4. WAY BILL AND “C”- FORM WILL NOT BE ISSUED. 5. UNIT RATE SHALL BE QUOTED INCLUSIVE OF INSPECTION CHARGES AND ALL

TAXES/VAT, DUTIES OF CENTRAL, STATE, LOCAL BODIES INCLUDING LOADING, TRANSPORTATION, LABOUR WELFARECESS, OCTROI TAX ,ENTRY TAX, UNLOADING AND STACKING AT SITE STORE, ROYALTIES ETC. THE QUOTED RATE SHALL REMAIN FIRM DURING THE CURRENCY OF THE CONTRACT


A. CIVIL ENGINEERING WORKS : SCHEDULE : A-I (Unified Standard Schedule of Rates/N.F. Rly – 2010 Items)

Sl. No.

Description of work Qty. Unit Rate (Rs.) Amount (Rs.)

FOUNDATION WORK:-

1 Earth work in excavation as per approved drawings & dumping at embankment site or spoil heap, within railway land, including 50 meter lead & 1.5 meter lift, the lead to be measaured from the center of gravity of excavation to center of gravity of spoil heap: the lead to be measured from natural ground level & paid for in layers of 1.5 meter each , including incidencial works, as per specification -In All kinds of soil Ref Ch:1,It-011010 & 011011 ,P-1, SOR /N.F.RLY-2010.

4680 Cum 104.72 490089.60

2 Extra over item no. 1 above for excavation in foundation for buildings & bridge to cover dressing to neat dimension & plumbing sides etc. Note : Dressing under this item is payble for the total quantity of excavation in foundation & not partly Ref Ch:1,It-011010 & 012010 ,P-1, SOR /N.F.RLY-2010.

4680 Cum 10.56 49420.80

3 Filling, watering and ramming earth in 15 cm layers in floors and foundations with surplus earth from foundations including 50m lead and 1.5m lift Ref Ch:1,It- 012040, P-2, SOR /N.F.RLY-2010

3050 Cum 24.09 73474.50

4 Extra for mechanical compaction of earth/blanketing material filled in proposed site of MDTC/New Coochbehar with contractor's rollers of suitable capacity, type and size to achieve specified density as per specification, testing as per IS codes incl. cost of water, T&P consumable material and all labour as a complete job. The work is to be executed as per Latest edition of "Guidelines for Earthwork in Railway Projects" issued by RDSO, Lucknow Ref Ch:1,It- 013130,P-3, SOR /N.F.RLY-2010.

48000 Cum 13.66 655680.00


Sl. No.


Demolishing plain cement concrete including disposal of material within 50m lead.

5

1:2:4 or richer mix with max 20 mm coarse aggregate Ref Ch:1,It-181020,& 181021,P-230, SOR /N.F.RLY-2010.

5 Cum 533.10 2665.50

6 Demolishing brick work including stacking of serviceable material and disposal of unserviceable material within 50m lead In cement mortar Ref Ch: 1,It-182010,182013 ,P-230, SOR /N.F.RLY-2010.

12 Cum 450.36 5404.32

Providing and laying non-pressure NP3 class (medium duty) R.C.C pipes including bends etc with collars jointed with stiff mixture of cement mortar in the proportion of 1:2 ( 1 cement : 2 fine sand ) including testing of joints etc. complete upto 800 mm dia

7

600 mm dia R.C.C pipe Ref Ch: 14,It-142030 & 142035 ,P-168, SOR /N.F.RLY-2010.

30 Metre 2916.90 87507.00

8 Providing & applying Pre-Construction Anti-Termite treatment to proposed structure, with application of Imidacloprid 30.5% SC @ 0.075% concentration mixed with water in ratio of 1:475, as per detailed specifications given in Indian Railways Standard Specifications, so as to create a chemical barrier below and around the structure by an approved agency. (Plinth Area/basement floor area shall be considered for Payment) Ref Ch:17,It-171690, P-227, SOR /N.F.RLY-2010.

1000 Sqm 82.19 82190.00

9 Post-construction anti-termite treatment to structures with application by trenching, drilling holes, injecting of Imidacloprid 30.5% SC @ 0.075% concentration mixed with water in ratio 1:475 alongwith spraying of woodwork with termiseal (oil based approved termiticide), as detailed in Indian Railways Standard Specifications, so as to create a chemical barrier below and around the structure by an approved professional agency. (Built-up area shall be considered for payment) Ref Ch:17,It-171700, P-227, SOR /N.F.RLY-2010.

250 Sqm 87.41 21852.50


Sl. No.


CEMENT CONCRETE WORK, BRICK WORK, FLOORING & PLASTERING WORK & PAINTING WORK:-

Providing and laying in position cement concrete of specified proportion excluding cost of cement, centering and shuttering - All works upto Plinth level:

10

1:3:6 ( 1 cement : 3 sand : 6 graded stone aggregate 20 mm nominal size ) Ref Ch: 3,It-031010 & 031011 ,P-15, SOR /N.F.RLY-2010.

370 Cum 2993.93 1107754.10

Centering and shuttering for P.C.C work including strutting, propping etc. and removal of form work for:

11

Foundations, footings, bases of columns Ref Ch: 3,It-031060, 031061 & 031063 ,P-16, SOR /N.F.RLY-2010.

210 Sqm 170.74 35855.40

Providing and laying in position M25 grade concrete for reinforced concrete structural elements but excluding cost of centering, shuttering, reinforcement and Admixtures in recommended proportion (as per IS:9103) to accelerate, retard setting of concrete, improve workability without impairing strength and durability as per direction of Engineer in charge

i) All work upto plinth level, including raft foundation of washable aprons, HS tank, pile cap, footings of FOB, and Platform shelter etc.

683 Cum 3763.33 2570354.39

12

ii) All work in buildings above plinth level upto floor two level Ref Ch: 4,It-041010, 041011 & 041012, P-20, SOR /N.F.RLY-2010.

1245 Cum 4515.99 5622407.55

Centering and shuttering including strutting, propping etc. and removal of form for:

(i) Foundations, footings, bases of columns, raft foundation of washable aprons, Pile caps, Footings of FOB etc.

3250 Sqm 170.19 553117.50

(ii) Suspended floors, roofs, landings, balconies, FOB slabs, walkway slabs and access platform

5200 Sqm 261.87 1361724.00

(iii) Lintels. Beams, plinth beams, bed blocks, girders, bressumers and cantilevers

995 Sqm 224.11 222989.45

13

(iv) Columns, pillars, posts and struts 2950 Sqm 339.11 1000374.50


Sl. No.


(v) Stairs (excluding landings) except spiral staircases

150 Sqm 331.61 49741.50

(vi) Supplying and applying shuttering oil for mould releasing, having (Flash point 54 degree C and specific gravity 0.88±0.02) for concrete formwork to be applied either by brush or with spray machine to the satisfaction of Engineer In charge Ref Ch: 4,It-042010, 042011,042013, 042014, 042015, 042016 & 042040, P-20 & 21, SOR /N.F.RLY-2010.

12545 Sqm 8.74 109643.30

Cement concrete flooring 1:2:4 ( 1 cement : 2 coarse sand : 4 graded stone aggregate ) finished with a floating coat of neat cement including cement slurry, but excluding the cost of nosing of steps etc.

14

75mm thick with 20mm nominal size stone aggregate. Ref Ch: 9,It-092010 &092014 ,P-84, SOR /N.F.RLY-2010.

390 Sqm 289.05 112729.50

Supplying Reinforcement for R.C.C. work including straightening, cutting, bending, placing in position and binding all complete

15

Thermo-Mechanically Treated bars (TMT) Ref Ch: 4,It-045010 & 045016 ,P-22, SOR /N.F.RLY-2010.

183000 Kg 58.71 10743930.00

Providing and fixing 18mm thick mirror polished, machine cut for kitchen platforms of required size of approved shade, colour and texture laid over 20mm thick base cement mortar 1:4 (1 cement : 4 coarse sand) with joints treated with white cement, mixed with matching pigment, epoxy touchups, including rubbing, curing, etc. complete at all levels

16

Granite Black. Area of slab over 1.0 Sqm but upto 2.0 Sqm or larger Ref Ch: 9,It-099030 & 099035 ,P-92, SOR /N.F.RLY-2010.

20 Sqm 4047.39 80947.80

Providing and laying cement concrete 1:2:4 in damp-proof course ( 1 cement : 2 sand : 4 graded stone aggregate 12.5mm nominal size excluding the cost of cement and including providing, fixing and removal of forms.

17

40 mm thick Ref Ch: 3,It-032050 & 032052 ,P-17, SOR /N.F.RLY-2010.

150 Sqm 187.55 28132.50


Sl. No.


18 Extra for providing and mixing water proofing material of brand approved by railway, if not included in relevant item Ref Ch: 3,It-032060, P-17, SOR /N.F.RLY-2010.

1950 per 50 kg of

cement

110.44 215358.00

19 Applying a coat of residual petroleum bitumen of penetration 80/100 of approved quality using 1.7kg per square metre on damp proof course after cleaning the surface with brushes and finally with a piece of cloth lightly soaked in kerosene oil. Ref Ch: 3,It-032070, P-17, SOR /N.F.RLY-2010.

150 Sqm 151.11 22666.50

Brick work with non-modular (FPS) bricks of class designation 7.5 in foundation and plinth in:

20

Cement mortar 1:6 (1 cement : 6 fine sand) Ref Ch: 5,It-051010 & 051015 ,P-27, SOR /N.F.RLY-2010.

1610 Cum 3348.72 5391439.20

21 Extra over item no. 20 mentioned above for brick work in superstructure beyond plinth level upto floor two level Ref Ch: 5,It-051040, P-27, SOR /N.F.RLY-2010.

1400 Cum 177.51 248514.00

Half brick masonry with brick of class designation 7.5 in foundations and plinth in :

22

Cement mortar 1:4 (1 Cement : 4 coarse sand ) Ref Ch: 5,It-051180 & 051182 ,P-28, SOR /N.F.RLY-2010.

760 Sqm 397.87 302381.20

23 Extra for half brick masonry in superstructure above plinth level upto floor two level Ref Ch: 5,It-051190, P-28, SOR /N.F.RLY-2010.

760 Sqm 49.30 37468.00

24 Extra for providing and placing in position 2 nos. 6mm dia M.S. bars at every third course of half brick masonry (with non-modular (FPS) bricks) including cost of M.S. bars Ref Ch: 5,It-051210, P-28, SOR /N.F.RLY-2010.

760 Sqm 0.14 106.40

Providing hand packed dry flat brick flooring, class designation 7.5 (FPS bricks), excluding pointing with joints filled with sand over a bed of dry sand (ordinary) of average thickness 25 mm including ramming sub grade:

25

Flat brick Ref Ch:9,It-091030 & 091032 ,P-83, SOR /N.F.RLY-2010.

400 Sqm 270.17 108068.00


Sl. No.


20 mm cement plaster on the rough side of single or half brick wall of mix -

26

1:4 ( 1cement : 4 Coarse sand ). Ref Ch:11,It-111060 & 111061 ,P-128, SOR /N.F.RLY-2010.

3650 Sqm. 116.67 425845.50

15 mm cement plaster on mix - 27

1:6 ( 1cement : 6 Coarse sand ). Ref Ch:11,It-111050 & 111052 ,P-128, SOR /N.F.RLY-2010.

5870 Sqm. 98.30 577021.00

Cement plaster to ceilling of mix - 28

6mm thick 1:3 (1cement : 3 fine sand) Ref Ch:11,It-111150 & 111151 ,P-130, SOR /N.F.RLY-2010.

3070 Sqm. 70.71 217079.70

29 Supply and using cement at worksite : OPC 43 grade / PPC

Ref Ch:3,It-033060, 033061 & 033063 ,P-18, SOR /N.F.RLY-2010.

1190 Tonne 6900.44 8211523.60

30 Providing and applying plaster of Paris putty of 2 mm average thickness over plastered surface to prepare the surface even and smooth complete Ref Ch: 11, It- 112040, P- 129, SOR /N.F.RLY-2010.

9000 Sqm 89.77 807930.00

31 Applying priming coat with ready mixed red oxide zinc chromate primer of approved brand and manufacture on steel galvanized iron/steel works Ref Ch:12,It-121010 & 121013, P-137, SOR /N.F.RLY-2010.

600 Sqm 23.18 13908.00

32 Painting with synthetic enamel paint of approved brand and manufacture to give an even shade Two or more coats on new work (steel work) Ref Ch: 12, It- 121050, 121051, P- 137, SOR /N.F.RLY-2010.

600 Each 54.17 32502.00

33 Finishing walls with Acrylic smooth Interior paint with Silicon additives of required shade on new work (Two or more coats applied @ 1.67 ltr./10 sqm over and including base coat of water proofing paint applied @ 2.20 kg/10 sqm Ref Ch: 11, It- 115170, P- 133, SOR /N.F.RLY-2010.

8500 Sqm 112.13 953105.00


Sl. No.


34 Finishing walls with Acrylic smooth exterior paint of required shade on new work ( two or more coats applied @ 3.28 ltr / 10 sqm ) over and including base coat of water proofing cement paint applied @ 2.20 Kg/10sqm. Ref Ch:11,It-115160 , P-133, SOR /N.F.RLY-2010.

3650 Sqm 129.75 473587.50

35 Providing & laying water-proof treatment on roof slabs by applying after preparation, cement slurry mixed with Tapecrete acrylic based polymer water proofing compound ( having soil content 30 % + 2, pH > 7 ) in a ratio of 2:1 ( 2 cement : 1 water proofing compound ),followed by laying of fibre glass cloth; 2nd coat of cement slurry mixed with acrylic based polymer water proofing compound and a final coat of water proofing compound brush topping having water proofing compound, cement and c/sand @ 1:2:2 by weight. Complete job to be carried out as per specification Ref Ch:10,It-105010, P-105, SOR /N.F.RLY-2010.

1200 Sqm 387.23 464676.00

36 Making Drain mouth on roof waterproof by cleaning the surface of the structure at the location of drain mouth; lowering the drain mouth to the level of the concrete roof; chipping; thorough cleaning; mixing thoroughly an octadecanoic acid based cementitious waterproofing compound in the weight ratio of 50 cement (OPC or slag) and 3 waterproofing compound; placing the drain mouth in its final position, followed by filling of the annular space around the drain pipe with a paste of waterproofing compound-cement; sealing the edges of the drain mouth with acrylic-styrene based copolymer waterproofing compound Ref Ch:10,It-109070, P-119, SOR /N.F.RLY-2010.

65 Each 566.96 36852.40


Sl. No.


37 Treatment of expansion joints by cleaning the joint and surfaces abutting the expansion joint, applying two coats of primer on the cleaned surfaces at the opening of the joint, filling the joint, filling the joint (to a depth equalling half the width) with the paste of a two-component polysulphide based sealant (with base- curing agent weight ratio of 12.33:1 and a sp.gr. of 1.60, 0.10 gms/cc, permitting the sealant to cure in natural air for at least a day, providing the edges of the treatment with two coats of a paste of octadecanoic acid based cementitious waterproofing compound and acrylic-styrene based copolymer waterproofing material in the weight ratio of 1:3 Ref Ch:10,It-109090, P-120, SOR /N.F.RLY-2010.

100 Metre 1217.50 121750.00

Providing and fixing ceramic tiles conforming to IS : 15622 of manufacturers approved by railway/RITES in all colours, shades, design and abrasion resistance class as approved by the Engineer - in -Charge in floors and landing over 20mm thick bed of cement mortar 1:4 (1cement : 3 coarse sand ) including pointing in white cement mixed with pigment of matching shade complete.

38

Of Group B-I-a of IS : 15622 ( Vitrifled Tiles ) of size above 400x400mm upto 600x600mm Ref Ch:9,It-095020 & 095026 ,P-88, SOR /N.F.RLY-2010.

2750 Sqm 1070.84 2944810.00

Providing and fixing 1st quality ceramic tiles conforming to Group B-III (Ceramic wall Tiles) of IS : 15622 of manufacturers approved by railway/RITES in all colours, shades, and design as approved by the Engineer - in - Charge in skriting, risers of steps and dado over 12mm thick bed of cement mortar 1:3 ( 1 cement : 3 coarse sand ) including pointing in white cement mixed with pigment of matching shade complete.

39

200x300 mm Ref Ch:9,It-095010 & 095012 ,P-87, SOR /N.F.RLY-2010.

610 Sqm 597.27 364334.70


Sl. No.


Providing and fixing ceramic tiles conforming to IS : 15622 of manufacturers approved by RITES/Rly. in all colours, shades, design and abrasion resistance class as approved by the Engineer - in -Charge in floors and landing over 20mm thick bed of cement mortar 1:4 (1cement : 3 coarse sand ) including pointing in white cement mixed with pigment of matching shade complete.

40

Of Group B-II Clause 5.1 (for abrasion resistance) of IS:15622 (Ceramic Floor Tiles) of size 300x300mm Ref Ch:9,It-095020 & 095021 ,P-88, SOR /N.F.RLY-2010.

280 Sqm 527.41 160274.80

41 Kota Stone slab flooring of size up to 60 x 60cm over 20mm (average) thick bae of 1:4 cement mortar (1 cement:4 coarse sand) and jointed with grey cement slurry mixed with pigment to match the shade of the slab including rubbing and polishing complete 25mm thick Ref Ch:9,It-096070 & 096072, P-89, SOR /N.F.RLY-2010.

56 Sqm 1306.22 73148.32

42 Extra for kota stone flooring in steps and treads not exceeding 30cm in width Ref Ch:9,It-096110, P-89, SOR /N.F.RLY-2010.

124 Sqm 208.47 25850.28

43 Kota stone slabs 25mm thick in risers of steps, skirting, dado and pillars laid on 12mm (average) thick cement mortar 1:3 ( 1cement : 3coarse sand ) and jointed with grey cement slurry mixed with pigment to match the shade of the slab, including rubbing and polishing complete Ref Ch:9,It-096080, P-89, SOR /N.F.RLY-2010.

325 Sqm 1067.94 347080.50

Providing top layer of floor, 6mm thick with white, black, chocolate, grey, yellow or green marble chips of sizes from 1mm to 4mm nominal size laid in cement marble powder mix 3:1 (3cement: 1marble powder) by weight in proportion of 4:7 (4cement marble powder mix: 7marble chips) by volume including cement slurry etc. complete

44

With white cement with pigment Ref Ch:9,It-093010 & 093013, P-84, SOR /N.F.RLY-2010.

400 Sqm 654.56 261824.00


Sl. No.


Marble chips skirting (upto 30cm height) rubbed & polished to granolithic finish, top layer 6mm thick of marble chips - white/black/chocolate/grey/yellow/green of sizes - smallest to 4mm laid in cement marble powder mix 3:1 (3 cement : 1 marble powder) by weight in ratio of 4:7 (4 cement marble powder mix : 7 marble chips) by volume:

45

18mm thick with under layer 12mm thick cement plaster 1:3 (1 cement : 3coarse sand). With white cement and pigment Ref Ch:9,It-093030 & 093033, P-85, SOR /N.F.RLY-2010.

125 Sqm 864.31 108038.75

46 Providing and fixing glass strips in joints of terrazo/cement concrete floors 40mm deep and 4mm thick Ref Ch:9,It-098110 & 098111, P-92, SOR /N.F.RLY-2010.

300 Meter 35.22 10566.00

47 Making khurras 45 x 45 cm with average minimum thickness of 5cm cement concrete 1:2:4 ( 1 cement : 2 coarse sand : 4 graded stone aggregate 20mm nominal size ) over P.V.C. sheet 1m x1m x 400 micron, finished with 12 mm cement plaster 1:3 ( 1 cement : 3 coarse sand ) and a coat of neat cement rounding the edges and making and finishing the outlet complete. Ref Ch: 10, It- 104140, P-104, SOR /N.F.RLY-2010.

30 Each 155.00 4650.00

48 Providing and fixing of fibre glass reinforced plastic (FRP) door frames of three legged of cross-section 90mm x 45mm having single rebate of 32mm x 15mm to receive shutter of 30mm thickness. The laminate door frame moulded with fire retardant grade unsaturated polyester resin and chopped mat. Door frame laminate shall be 2mm thick and shall be filled with suitable wooden block in all the three legs from all sides. M.S. stay shall be provided at the bottom to ready the frame Ref Ch:7,It-078310, P-71, SOR /N.F.RLY-2010.

195 RM 666.91 130047.45


Sl. No.


49 Providing and fixing 30mm thick glass fibre reinforced (FRP) panelled door shutter of required colour and approved brand and manufacture, made with fire retardant grade unsaturated polyester resin, moulded to 3 mm thick FRP laminate for farming hollow rails and styles, with wooden frame and suitable blocks of seasoned wood inside at required places for fixing of fittings, cast monolithically with 5mm thick FRP laminate for panels and conforming to (IS:14856 2000) complete work Ref Ch:7,It-078320, P-72, SOR /N.F.RLY-2010.

65 Sqm. 3556.10 231146.50

50 Providing and fixing aluminium hanging floor door stopper ISI marked anodised (anodic coating not less than grade AC 10 as per IS: 1868) transparent or dyed to required colour and shade with necessary screws etc. complete Single rubber stopper Ref Ch: 7,It- 078070 & 078071, P-64, SOR /N.F.RLY-2010.

50 Each 33,54 1677.00

51 Providing & fixing bright finished brass 100 mm mortice latch and lock with 6 levers and a pair of lever handles with necessary screws etc. complete (best make of approved quality) Ref Ch:7,It- 077090, P-57, SOR /N.F.RLY-2010.

90 Each 736.27 66264.30

52 Providing and fixing IS:3564 marked aluminium die cast body tubular type universal hydraulic door closer, hardwyn make (Classic Queen) or equivalent with necessary accessories and screws etc. complete Ref Ch:7,It- 077180, P-58, SOR /N.F.RLY-2010.

40 Each 777.29 31091.60

53 Providing and fixing specified wood frame work for cup-board consisting of battens 50 x 25mm fixed with rawl plug and drilling necessary holes for rawl plugs etc. including priming coat complete

350 Cudm 87.72 30702.00

Hollock wood or locally available comparable species of country wood (to be listed by respective railway). - kiln seasoned & chemically treated Ref Ch:7,It-074070, & 074071, P-48, SOR /N.F.RLY-2010.


Sl. No.


54 Providing and fixing 25mm thick cup board shutters, with vineered paticle board conforming to IS: 3079- Grade-I of approved make including second class teak wood lipping 25 x 12mm thick with necessary screws and nickel plated bright finished MS piano hinges complete

120 Sqm 3223.54 386824.80

with teak vineering on one side and commercial vineering on other side Ref Ch:7,It-073040, & 073041, P-47, SOR /N.F.RLY-2010.

55 Vernishing with varnish of approved brand and manufacture on new work - two or more coats of glue sizing with copal vernish over an under coat of flatting varnish Ref Ch:12,It-124010, & 124011, P-141, SOR /N.F.RLY-2010.

120 Sqm 73.55 8826.00

56 French spirit polishing Two or more coats on new work including a coat of wood filler Ref Ch:12,It-124010, & 124011, P-141, SOR /N.F.RLY-2010.

112 Sqm 135.26 15149.12

57 Providing and fixing in position collapsible steel shutters with vertical channels 20 x 10 x 2mm and braced with flat iron diagonals 20 x 5 mm size with top and bottom rail of T-iron 40 x 40 x 6mm with 40 mm dia, steel pulleys complete with bolts, nuts, locking arrangement, stoppers, handles and hold fasts including applying a priming coat of approved steel primer. Ref Ch: 8, It- 081180, P- 75, SOR /N.F.RLY-2010.

20 Sqm 3311.87 66237.40

58 Providing and fixing 16mm MS Fan clamp of standard shape and size in existing R.C.C. slab including cutting chase and making good with 1:2 C:S mortar and painting ( Two coats) exposed portion of the clamps complete. Ref Ch: 17, It- 171100, P- 217, SOR /N.F.RLY-2010.

100 Each 162.35 16235.00

59 Supplying, fitting & fixing in position reinforced cement polymer concrete ( R.C.P.C. ) manhole cover and frame to match with IS : 12592 with cement conc. 1:2:4 for embedding the manhole cover frame.

10 Each 945.47 9454.70


Sl. No.


a) 3 MT load bearing capacity manhole cover provided with 2 nos. lifter lock fitted with matching frame ( size of cover : 440 mm dia. X 50 mm thick and size of frame : 530 mm dia x 100 mm thick ) Ref Ch: 14, It- 143150, 143151, P- 173, SOR /N.F.RLY-2010.

60 Structural steel work in single section including cutting, bending, straightening, drilling, rivetting, bolting, hoisting, fixing in position, including applying a priming coat of approved steel primer, complete - upto 6m height above GL.

In RSJ, tees, angles and channels 1800 Kg 64.32 115776.00

In flats, plates, round or square bars Ref Ch: 8, It- 081010,081011& 081012, P- 74, SOR /N.F.RLY-2010.

4500 Kg 64.63 290835.00

WATER SUPPLY & SANITARY WORKS:- 61 Providing and fixing medium grade G.I pipes

complete with G.I fittings and clamps, including cutting and making good the wall etc. Concealed pipe including painting with anti corrosive bitumastic paint, cutting chase and making good the wall

15 mm dia nominal bore 150 metre 208.62 31293.00 20 mm dia nominal bore 100 Metre 236.84 23684.00

25 mm dia nominal bore Ref Ch:13,It-131140,131141,131142,131143,P-146, SOR /N.F.RLY-2010

150 metre 293.28 43992.00

62 Providing and fixing medium grade G.I pipes complete with G.I fittings including trenching and refilling etc. External work

40 mm dia nominal bore 75 Metre 326.40 24480.00

50 mm dia nominal bore Ref Ch:13,It-131150,131155,131156, P-146, SOR /N.F.RLY-2010.

75 Metre 396.94 29770.50

63 Providing and laying S&S centrifugally cast ( spun ) iron pipes ( class LA ) conforming to IS-1536: upto 300 mm dia.

150mm dia. Pipe 100 metre 2234.38 223438.00

200mm dia. Pipe Ref Ch:13,It-133050,133054,133055, P-150, SOR /N.F.RLY-2010.

150 metre 3276.64 491496.00


Sl. No.


64 Providing and fixing plain bend of required degree

10 Each 351.78 3517.80

100mm dia. Sand cast iron S&S as per IS-1729 Ref Ch:15,It-153050,153051, P - 184, SOR /N.F.RLY-2010.

65 Providing and fixing single equal plain junction of required degree with access door, insertion rubber wash 3mm thick, bolts and nuts complete

100x100x100x100mm sand cast iron S&S as per IS-1729 Ref Ch:15,It-153090,153091, P - 185, SOR /N.F.RLY-2010.

10 Each 1053.64 10536.40

66 Providing and fixing collar

100mm sand cast iron S&S as per IS- 1729 Ref Ch:15,It-153240,153241, P - 188, SOR /N.F.RLY-2010.

10 Each 186.14 1861.40

67 Supplying, fitting and fixing cowls to vent pipes :

Wire cowls for pipes of size 100/150 mm dia. Ref Ch:15,It-153230,153232, P - 187, SOR /N.F.RLY-2010.

10 Each 192.02 1920.20

68 Providing and fixing trap of self cleaning design with screwed down or hinged grating with or without vent arm complete including cost of cutting and making good the walls and floors

100mm inlet and 100mm outlet sand cast iron S&S as per IS:1729

10 Each 719.27 7192.70

100mm inlet and 75mm outlet sand cast iron S&S as per IS:1729 Ref Ch:15,It-153270,153272,153274, P - 188, SOR /N.F.RLY-2010.

15 Each 657.93 9868.95

69 Providing and fixing 110 mm dia PVC soil, waste and vent pipes including jointing and cost of spun yarn and sand etc. complete Ref Ch:15,It-154010, P-191, SOR /N.F.RLY-2010.

100 metre 228.70 22870.00

70 Providing and fixing white, vitreous china water closet squatting pan ( Indian Type ) Long pattern W.C.pan of size 580mm Ref Ch:15,It-151120, & 151121, P-180, SOR /N.F.RLY-2010.

14 Each 952.41 13333.74


Sl. No.


71 Providing and fixing white. Vitreous china pedestal European type water closet pan Ref Ch:15,It-151140, P-181, SOR /N.F.RLY-2010.

8 Each 1307.65 10461.20

72 Providing and fixing P.V.C low level flushing cistern with manually controlled device (handle lever) conforming to IS:7231, with all fittings and fixtures complete 10 litre capacity - white Ref Ch:15,It-151180 & 151181, P-181, SOR /N.F.RLY-2010.

12 Pair 1052.01 12624.12

73 Providing and fixing a pair of approved colour, vitreous china foot rests of standard pattern, for squatting pan water closet or in urinals 250x130x30mm Ref Ch:15,It-151160 & 151161, P-181, SOR /N.F.RLY-2010.

15 Pair 239.77 3596.55

74 Providing and fixing solid plastic seat with lid for pedestal type W.C pan complete White, solid plastic seat with lid Ref Ch:15,It-151220 & 151221, P-181, SOR /N.F.RLY-2010.

8 Each 617.81 4942.48

75 Providing and fixing Soap dish (C.P Brass) having approx. wt. 220gm Ref Ch:15,It-153570, P-191, SOR /N.F.RLY-2010.

13 Each 1220.55 15867.15

76 White, vitreous china wash basin of size 550x400mm with a pair of 15mm C.P brass pillar taps Ref Ch:15,It-151073, & , P-179, SOR /N.F.RLY-2010.

20 Each 2395.78 47915.60

77 Providing and fixing Stainless Steel AISI- 304(18/8) kitchen sink with drain board as per IS:13983 with C.I brackets and stainless steel plug 40mm including painting of fittings and brackets, cutting and making good the walls wherever required

3 Each 3235.38 9706.14

510 x 1040 mm bowl depth 250mm Ref Ch:15,It-152020, & 152021, P-182, SOR /N.F.RLY-2010.

78 Providing and fixing P.V.C. waste pipe for sink or wash basin including P.V.C. waste fittings complete

30 Each 80.98 2429.40

Flexible pipe 32mm dia. Ref Ch:15,It-152080, & 152082, P-183, SOR /N.F.RLY-2010.


Sl. No.


79 Providing and fixing 600 x 450mm bevelled edge mirror, 5.5 mm thick of float glass (of approved quality) complete with 6mm thick hard board ground fixed to wooden cleats with C.P. brass screws and washers complete Ref Ch:15,It-152110, P-183, SOR /N.F.RLY-2010.

14 Each 628.15 8794.10

80 Providing and fixing Toilet paper holder (C.P.Brass) having approx. wt. 250 gm. Ref Ch:15,It-153550, P-191, SOR /N.F.RLY-2010.

25 Each 207.75 5193.75

81 Providing and fixing liquid soap container ( C.P. brass ) having approx wt.240gms. Ref Ch:15,It-153540, P-191, SOR /N.F.RLY-2010.

25 Each 242.12 6053.00

82 Providing and fixing PTMT shower rose of approved quality with 15mm or 20mm inlet. 150 mm dia. Ref Ch:15,It-153370, P-189, SOR /N.F.RLY-2010.

15 Each 224.58 3368.70

83 Providing and fixing white, vitreous china flat back half stall urinal of 580 x 380x 350mm with white P.V.C automatic flushing cistern, with fittings, standard size C.P brass flush pipe, spreaders with unions and clamps (all in C.P. brass) with waste fitting as per IS: 2556, C.I trap with outlet grating and other coupling in C.P brass including painting of fittings and cutting and making good the walls and floors wherever required

16 Each 5521.26 88340.16

Single half stall urinal with 5litre P.V.C automatic flushing cistern Ref Ch:15,It-151050 & 151051 , P-179, SOR /N.F.RLY-2010.

84 Providing and fixing one piece construction white vitreous china squatting plate with an integral longitudinal flushing pipe, white, PVC automatic flushing cistern with fittings, standard size G.I flush pipe for back and front flush with standard spreader pipes with fittings, GI clamps and CP brass coupling complete including painting of fittings and cutting and making good the walls and floors etc. wherever required

5 Each 4598.24 22991.20

Single squatting plate of 600 x 350 mm size with 5 litre P.V.C automatic flushing cistern Ref Ch:15,It-151060 & 151061, P-179, SOR /N.F.RLY-2010.


Sl. No.


85 Providing and fixing PTMT towel rail complete with brackets fixed to wooden cleats with C.P brass screws with concealed fitting arrangement of approved quality colour and make

15 Each 416.76 6251.40

450 mm long towel rail with total length of 495 mm, 78 mm wide and effective height of 88 mm, weighing not less than 190 gms Ref Ch:15,It-153320 & 153321, P-189, SOR /N.F.RLY-2010.

86 Providing and fixing 600 x 120 x 5 mm glass shelf with edges round or supported on anodised aluminium angle frame with C.P brass brackets and guard rail complete fixed with 40 mm long screws, rawl plugs etc. complete Ref Ch:15,It-152130, P-184, SOR /N.F.RLY-2010.

16 Each 633.50 10136.00

87 Providing and fixing C.P. brass stop cock,15 mm nominal bore, (concealed) of standard design and of approved make conforming to I.S.:8931 Ref Ch:13,It-132210, P-149, SOR /N.F.RLY-2010.

20 Each 443.65 8873.00

88 Providing and fixing C.P. brass bib cock, 15mm nominal bore, of approved quality conforming to IS :8931 Ref Ch:13,It-132180, P-149, SOR /N.F.RLY-2010.

20 Each 372.91 7458.20

89 Providing and fixing gun metal gate valve with C.I wheel of approved quality (screwed end)

(a) 25 mm nominal bore 10 Each 566.26 5662.60

(b) 40 mm nominal bore 10 Each 1008.07 10080.70 (c) 50 mm nominal bore

Ref Ch:13,It-132030, 132031, 132033 & 132034, P-147, SOR /N.F.RLY-2010.

10 Each 1069.04 10690.40

90 Supplying and fixing half round white glazed earthen ware drains 150 mm dia with cement sand mortar 1:3 mix and joints grouted with neat cement slurry of the matching colour: Ref Ch:15,It-153590, P-191, SOR /N.F.RLY-2010.

45 metre 127.30 5728.50

91 Providing, laying and jointing glazed stoneware pipes grade 'A' as per IS:651 including bends etc. with stiff mixture of cement mortar in the proportion of 1:1 (1cement : 1fine sand) including testing of joints etc. complete

230mm diameter 150 Meter 545.00 81750.00

150mm diameter Ref Ch:14,It-141010, 141014 & 141012, P-167, SOR /N.F.RLY-2010.

60 Meter 309.23 18553.80


Sl. No.


92 Making soak pit 2.5m diameter 3.0m deep with 45 x 45cm dry brick honey comb shaft with bricks of class designation 7.5 and S.W. drain pipes 100mm diameter, 1.8m long complete as per standard design, including excavation complete With F.P.S bricks Ref Ch: 14, It- 143270 & 143271, P- 176, SOR /N.F.RLY-2010.

2 Each 16166.20 32332.40

ROAD WORK:-

93 Preparation of subgrade by excavating earth upto required depth, dressing to camber and consolidating with power road roller of 8 to 12 tonne capacity including making good the undulations etc. and disposal of surplus earth with all lead . Ref Ch: 23, It- 231010, P- 266, SOR /N.F.RLY-2010.

5300 Sqm 48.56 257368.00

94 Consolidation of subgrade with power road roller of 8 to 12 tonne capacity including making good the undulations etc. with earth or quarry spoils etc. and re-rolling the subgrade. Ref Ch: 23, It- 231020, P- 266, SOR /N.F.RLY-2010.

5300 Sqm 1.38 7314.00

95 Providing and laying each layer of flat brick soling hand packed and joints filled with ordinary sand With Jhama bricks Ref Ch: 23, It- 231030 & 231032, P- 266, SOR /N.F.RLY-2010.

5300 Sqm 167.96 890188.00

96 Providing and laying water bound macadam sub-base with brick aggregate and binding material, earth / moorum etc. including screening, sorting and spreading to template and consolidation with light power road roller etc. complete

Over burnt (Jhama) brick aggreagte 120mm to 40mm

790 Cum 1318.51 1041622.90

Over burnt (Jhama) brick aggreagte 90mm to 45mm Ref Ch: 23, It- 231050, 231051,21052 P- 266, SOR /N.F.RLY-2010.

790 Cum 1318.51 1041622.90


Sl. No.


97 Providing and laying bitumen penetration macadam with hard stone aggregate, with bitumen of suitable penetration grade including required key aggregate as specified, spreading coarse aggregate with the help of self propelled / tipper tail mounted aggregate spreader and applying bitumen by a pressure distributor and then spreading key aggregate with the helpe of aggregate spreader complete including consolidation with road roller of minimum 8 to 10 tonne capacity. water bound macadam with specified stone aggregate, stone screening, and binding material including sorting, sorting, spreading to template and consolidation with power road roller of 8 to 10 tonne capacity etc, complete.

5300 Sqm 190.46 1009438.00

For 50mm compacted thickness using 6cum coarse aggregate of size 50 -20mm graded, 1.5cum key aggregate of size 12.5mm graded, and 500kg paving asphalt 80/100 per 100 Sqm. Ref Ch: 23, It- 231060 & 231061, P- 267 SOR /N.F.RLY-2010.

98 Providing and applying tack coat using bitumen emulsion ( rapid setting ) complying with IS:8887-1995, spraying the bitumin emulsion with mechanically operated spray unit clening and preparing the existing road surface as per specification

5300 Sqm 20.26 107378.00

On bituminus surface @ 0.25 kg / sqm, Ref Ch: 23, It- 233012, P- 268 SOR /N.F.RLY-2010.

99 Providing and laying 2cm premix carpet with 1.8 cum and 0.90cum of stone chippings of 13.2mm size and 11.2mm size respectively and 144kg of hot bitumin per 100 sqm over a tack coat including consolidation with road roller of 6 to 8 tonne capacity etc. complete ( Tack coat to be paid separately )

5300 Sqm 108.21 573513.00

with paving asphalt 80/100 heated and then mixed with solvent at the rate of 70 grams per kg. of asphalt. Ref Ch: 23, It- 233020,233021, P- 268 ,SOR /N.F.RLY-2010.


Sl. No.


100 Providing and laying seal coat of premixed fine aggregate ( passing 2.36mm and retained on 180micron sieve ) with bitumen using 128 kg of bitumen of grade 80/100 bitumen and 0.6 cum of fine aggregate per 100sqm of road surface including rolling and finishing with road roller all complete. Note - This should not be operated along with Hot mix carpeting Ref Ch: 23, It- 235010, P- 269 ,SOR /N.F.RLY-2010.

5300 Sqm 73.52 389656.00

101 Providing and laying in position cement concrete of specified proportion excluding cost of cement, centering and shuttering - All works upto Plinth level:

1:5:10 (1 cement : 5coarse sand : 10graded stone aggregate 40mm nominal size) Ref Ch: 3, It- 031010 & 031014, P- 15 ,SOR /N.F.RLY-2010.

20 Cum 2532.57 50651.40

102 Precast R.C.C. standard posts (for barbed wire fencing) 1.8m long Ref Ch: 24, It- 241011, P- 276 ,SOR /N.F.RLY-2010.

200 Each 627.91 125582.00

103 Providing 1.2m high fencing with 1.8m RCC post placed every 3m apart, embedded in cement concrete blocks, every 15th post (or nearer if there is abrupt change of ground slope), last but one end post and corner post shall be strutted on both sides and end post one side only, and strutts embedded in cement concrete blocks, provided with five horizontal lines and two diagonals of G.I barbed wire 9.38 kg per 100 metres (min.) between the two post fitted and fixed with G.I staples on turn buckles or G.I binding wire tied to 6mm bar nibs fixed while casting the post (cost of posts, struts and concrete to be paid for separately) Ref Ch: 24, It- 242010, P- 276 ,SOR /N.F.RLY-2010.

580 Metre 56.51 32775.80

104 Supply and fixing of barbed wire weighing 9/38 kg per 100 m (minimum) on previously erected with wire nails , hooks stitching bolts, binding wire etc. straight and/or cross pattern. (Rate includes drilling of holes in the post whereever required) Note: This item can also be operated as extra over Items 242010 to 242060 for fixing additional wires to those stipulated in the respective items. Ref Ch: 24, It- 242080, P- 278 ,SOR /N.F.RLY-2010.

5500 per metre of barbed

wire

13.88 76340.00


Sl. No.


105 Extra for supplying and fixing turn tuckles and straining bolts for barbed wire fencing Ref Ch: 24, It- 242070, P- 278 ,SOR /N.F.RLY-2010.

100 Each 123.68 12368.00

106 Any other unforseen item if required to be executed during the course of execution shall be operated from Unified Standard Schedule of Rates/N.F.Rly-2010 (all chapters). Basic cost. Rs. 6,00,000.00/- (Rupees six lakh)

LS LS At par 600000.00

TOTAL COST OF SCHEDULE -A-I 57025485.17

Say 57025486.00

Total cost of Schedule - A-I is Rs. 5,70,25,486.00 (Rupees five crore seventy lakh twenty five thousand four hundred eighty six) only


SCHEDULE -A-II (NON Schedule Item - Other than SOR & LAR of N.F.Rly)

Sl. No.


1 Earthwork in filling in layers (mechanical compaction) in plinth etc with contractor's own earth in all classes nature and condition of soil excluding mechanical compaction, with all lead, lift, descent and crossing of track and any other obstructions including dressing etc. with all carriage charges, royalty charges etc. including making and maintaining service road where necessary with contractor's own labour, tools and equipments complete in all respect as per specification and as directed by the engineer at site.

48000 Cum 155.29 7453920.00

2 Supplying, fitting, fixing Godrej make multi purpose lock to be provided in drawer / cupboard including screws, consumable complete in all respect

80 Each 105.64 8451.20

3 Supplying, providing & fixing PVC hand rail toping (3 to 4 mm thick) of approved shade 40 to 50 mm wide including cost of material tool and tackless complete in all respect

85 Rm 92.28 7843.80

4 Supplying, fitting and fixing 100mm PVC Rain Water pipe

120 Mtr. 249.34 29920.80

5 Supplying, hoisting, fitting and fixing PVC water storage tank (Sintex or similar brand), conforming to IS-10146-1982, including provision of inlet, outlet and overflow pipe connection with cover and locking arrangements including connecting to service pipe line

12000 Ltr 5.84 70080.00

6 Supplying and filling sand in plinth and under floors including watering, ramming, consolidating and dressing complete

1650 Cum 411.03 678199.50

Cost of Schedule "A-II" 824815.30

Say 8248416.00

Total cost of Schedule "A-II" is Rs. 82,48,416.00 (Rupees eighty two lakh forty eight thousand four hundred sixteen) only


SCHEDULE -A-III -HORTICULTURE WORKS - Unified Standard Schedule of Rates/N.F Rly-2010

1 Overall percentage increase/decrease over rates under Chapter 15 - Horticulture Items of N.F Railway Engineering Department Schedule of Labour & Material Rates, 2010

Quantity Unit Rate

Basic cost Rs.3,00,000 (Three lakh only ) LS-3,00,000.00

LS LS- 300000.00

TOTAL COST OF SCHEDULE "A-III" 300000.00

Total cost of Schedule "A-III" - Rs. 3,00,000.00( Rupees three lakh) only


B. ELECTRICAL WORKS:

Sr. No

Description

Unit Qty Rate Unit Supply

Unit Erection

Total Supply Total Erection

1 Point Wiring including supply of all materials by PVC recessed conduit : -- Internal wiring for light, fan , plug points and night lamp points by 1.5 sq.mm Cu. cable, 660 Volt grade, make - Mescab/Fenolex/KDK/Havell's through PVC conduit pipe of (20 mm dia and 1.5 mm thickness) make-Kalinga/Presto plus/Precission and piano type switches, batton holder, ceiling rose, sockets to be provided as and where required as per direction of consignee on phenolic covered switch board of suitable size with continuous earthing by 14 SWG tinned Cu. wire / by 1 Sq.mm PVC Cu wire (Provision of fan regulator should be kept on switch board) *Each switch board should contain flash type fuse of 5A capacity. *All switches, batton holder, ceiling rose, 5A socket etc. will be make of Anchor/Cona/Preeti.( Two 5-ampere socket point treated as one point)

Pts 1200 319.77 0.00 319.77 0.00 383724.00

As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.


Sr. No

Description


Unit Erection


2 Circuit/Sub-circuit wiring including supply of all materials by PVC recessed conduit wiring by 2.5 sq.mm Cu.cable, 660 Volt grade make- Mescab/Fenolex/KDK/Havell's through PVC conduit (20 mm dia and 1.5 mm thickness) make-Kalinga/Presto plus/Precission and continuous earthing by 14 SWG tinned Cu. wire/1 Sq. mm PVC Cu. wire to be provided as and where required as per direction of consignee as per GEN- 3-B. *Quantity per meter means-one meter conduit with 2 (two) meters Cu. cable & 1mtr of 14 SWG tinned Cu. wire. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Mtrs 1800 55.37 0.00 55.37 0.00 99666.00

3 Circuit/Sub-circuit wiring including supply of all materials by PVC recessed conduit wiring by 4 sq.mm Cu.cable, 660 Volt grade make-Mescab/Fenolex/KDK/Havell's through PVC conduit (20 mm dia and 1.5 mm thickness) make-Kalinga/Presto plus/Precission and continuous earthing by 14 SWG tinned Cu. wire/2.5 Sq. mm PVC Cu. wire to be provided as and where required as per direction of consignee as per GEN- 3-B. *Quantity per meter means-one meter conduit with 2 (two) meters Cu. cable & 1mtr of 14 SWG tinned Cu. wire. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part- A)/469, Dt : 24/07/09.

Mtrs 1125 58.13 0.00 58.13 0.00 65396.25


Sr. No

Description


Unit Erection


4 Circuit/Sub-circuit wiring including supply of all materials by PVC recessed conduit wiring by 6 sq.mm Cu.cable, 660 Volt grade make-Fenolex/KDK/Havell's through PVC conduit (20 mm dia and 1.5 mm thickness) make-Kalinga/Presto plus/Precission and continuous earthing by 14 SWG tinned Cu. wire/2.5 Sq. mm PVC Cu. wire to be provided as and where required as per direction of consignee as per GEN- 3-B. *Quantity per meter means-one meter conduit with 2 (two) meters Cu. cable & 1mtr of 14 SWG tinned Cu. wire. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Mtrs 675 104.58 0.00 104.58 0.00 70591.50

5 Supply, fixing and commissioning of ISI marked Energy Efficient type, BEE labled 5 Star rated Ceiling fan, capacitor type, 1400 mm down rod etc., suitable for 230V, 50Hz, AC supply confirming to Class:I of IS: 374/latest. Fixing of the fan shall be done with suitable clamp, hook, nut/bolts etc. and connection with flexible twin twisted multistrand Copper wire of 0.75 Sq.mm and removing of the existing old fan (if any) and handing over of the same to Railway Store with clear acknowledgement, as per site requirement. As per P.O.No.42/09/5008/1/62549 Dt: 08.06.09. + 12.5% VAT.

Nos 425 1696.59 1542.35 154.24 655498.75 65552.00

6 Supply, Fixing and Commissioning of heavy duty Electronic fan regulator stepped type, 400 / 550 W, suitable operation in 230 V, 50 Hz, AC supply as per ISS:11037/ Latest. Regulator Rs. 135/- as per COS/ GRC's PO No. 42.09.5016.1.62699, Dt : 19.11.09

Nos 425 158.46 142.61 15.85 60609.25 6736.25


Sr. No

Description


Unit Erection


7 Supply, fixing and commissioning of Single phase propeller type Exhaust Fan ISI marked, 4-pole, 300 mm sweep, suitable for 230V, 50Hz, AC supply, capacitor run, confirming to IS:2312/ latest complete with mounting frame and louver shutter etc.. As per R/C no: EX.Fans/ME-2/RC-B3050000/0910/02/02073/3944 dt:09/10/09 valid upto 30/09/10. + 12.5% VAT.

Nos 40 1492.15 1356.51 135.64 54260.40 5425.60

8 Supply, fixing and commissioning of Single phase propeller type Exhaust Fan ISI marked, 4-pole, 450 mm sweep, suitable for 230V, 50Hz, AC supply, capacitor run, confirming to IS:2312/ latest complete with mounting frame and louver shutter etc.. As per R/C no: EX.Fans/ME-2/RC-B3050000/0910/02/02073/3944 dt:09/10/09 valid upto 30/09/10. + 12.5% VAT.

Nos 15 2464.60 2240.64 223.96 33609.60 3359.40

9 Supply, fixing and commissioning of wall / ceiling mounted, box type Energy Efficient FL fitting complete with electronic ballast suitable for 1 X 28 W, T5 fluorescent lamp duly wired for use on 230 v, 50 Hz, single phase AC supply, complete with energy efficient type T5, 28 W FL tube as per RDSO Specification no. RDSO/PE/SPEC/AC/0100 (REV. 'O') - 2008. similar to Philips's model/ type - VECTOR 28W TCH 207/ 1XTL5, 28 W for fitting and TL5, 28 W HE for lamp . Fixing of the fitting with lamp on ceiling/ wall and necessary connection thereof shall be done as per field requirement. As per Philips price list w.e.f 05.04.10 - 10%.

Nos 450 643.35 612.71 30.64 275719.50 13788.00


Sr. No

Description


Unit Erection


10 Supply, fixing and commissioning of industrial grade, ceiling suspension type Energy Efficient, box type FL fitting complete with electronic ballast suitable for 2 X 28 W, T5 fluorescent lamp, duly wired for use on 230 V, 50 Hz single phase AC supply, complete with energy efficient type 2 x T5, 28 W FL tubes as per RDSO's Specification No. RDSO/PE/SPEC/AC/0100 (REV.'O') - 2008. Similar to Philips model/ type -TMS 122 M 2 X TL5 28W EBE for fitting and TL 5, 28 W HE for lamp. Fixing of the fitting with lamp on ceiling/ wall and necessary connection thereof shall be done as per field requirement. As per Philips price list w.e.f 05.04.10 - 10%.

Nos 40 1696.59 1616.30 80.29 64652.00 3211.60

11 Supply, fixing and commissioning of industrial grade, ceiling suspension type Energy Efficient, Decorative recessed mirror optics fitting complete with electronic ballast suitable for 2 X 28 W, T5 fluorescent lamp, duly wired for use on 230 V, 50 Hz single phase AC supply, complete with energy efficient type 2 x T5, 28 W FL tubes as per RDSO's Specification No. RDSO/PE/SPEC/AC/0100 (REV.'O') - 2008. Similar to Philips model/ type - TBS 520 2XTL528W EBE MI for fitting and 2XTL 5, 28 W HE for lamp. Fixing of the fitting with lamp on ceiling/ wall and necessary connection thereof shall be done as per field requirement. As per Philips price list w.e.f 05.04.10 - 10%.

Nos 20 2894.55 2757.22 137.33 55144.40 2746.60


Sr. No

Description


Unit Erection


12 Supply, Fixing and Commissioning of Energy Efficient type, recessed mounting, mirror optic based luminaire, suitable for 4 X 14 W FTL T5 lamps, designed for false ceiling, ( 600 X 600 mm ) with pre anodised Aluminium louver, duly wired suitable for use in 230 V, 50 Hz AC supply complete with electronic ballast, 4 X T5, 14 W FL tube with G5 cap etc. as per RDSO's Specification No. RDSO/PE/SPEC/AC/0100 (REV.'O') - 2008. Similar to Philips model/ type - TBS 440 4 X TL5 14W SP EBP for fitting and 4 X TL5 14 W HE for lamp. Fixing of the fitting with lamp in the false ceiling shall be done with necessary connections etc. as per site requirement. As per Philips price list w.e.f 05.04.10 - 10%.

Nos 20 4911.65 4677.76 233.89 93555.20 4677.80

13 Supply, Errection & Commissioning of 9 mtr length SST pole of weight 108 KG having four nos short arm bracket of length 1.5 mtr, top cap etc. 1/6 of the pole to be burried in ground , concreting the foundation of size 1mx1mx1.5m in the ratio 1:3:6 and construction of muffing of size 1.5 ftx 1.5 ftx 1.5 ft. ( the rate shall be inclusive of all materials ) & painting of pole. As per LOA No: 114-Elect/OT/KGP/461/Shalimar Station. Dt: 20/05/09.

Nos 6 12890.74 10585.40 2305.34 63512.40 13832.04


Sr. No

Description


Unit Erection


14 Supply, fixing and commissioning of Cable loop box ( of fibre body) for 3-Phase incoming and out going connection consists of 3-Phase terminal and 15 Amps K-fuse as per relevant ISS, with suitable bridge arrangement of size : 240mm X 140mm x 100 mm.,as per relevant specification/drawing. Fixing shall be made with necessary arrangements as per site requirement. As per LOA No: 114-Elect/OT/KGP/Digha Station/462. Dt: 02/06/09.

Nos 6 795.04 722.77 72.27 4336.62 433.62

15 Supply, fixing and commissioning of Energy efficient Street Light fitting, Housing shall be fabricated out from sheet Al.Stove Enemalled white etc. Suitable for 2 x 28 W,Energy efficient T-5 lamp, complete with electronic ballast,lamp holders duly wired suitable for use on 230 V,50H AC supply complete with 2 nos.T-5 28 W FTL Lamps and all other accessories, as per RDSO's specification No. RDSO/PE/SPEC/AC/0100(Rev.'0')-2008.Similar to Philips model/type : HGS 120 2XTL528W EBE for fitting and 2x TL-5, 28 W HE for lamp. The fitting shall be supplied complete with necessary fixing arm bracket to fix the fitting on the pole suitable for the fitting and complete with fixing arrangement, necessary connection etc. As per Philips price list w.e.f 05.04.10 - 10%.

Nos 40 2457.73 2234.30 223.43 89372.00 8937.20

16 Supply, fixing and commissioning of switch socket board ( Power), shutter type 15/5 Amps 5-pin socket /15 Amps switch on a MS board/TW board with phenolic cover. (Wiring will be covered under Schedule item No.3) As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Nos 40 127.83 106.91 20.92 4276.40 836.80


Sr. No

Description


Unit Erection


17 Supply, fixing and commissioning of PC Board consisting with 03 nos switch socket unit 06 Amps capacity with fuse indicator lamp and internal wiring. As per LOA No: 114-Elect/OT/KGP/Various School/443. Dt: 13/02/09

Nos 20 125.40 114.00 11.40 2280.00 228.00

18 Supply of L.T. Aluminium Armoured PVC/XLPE cable of size 3 1/2 x 240 Sqmm 1100 Volts Grade.

Mtrs 400 614.64 614.64 0.00 245856.00 0.00


Mtrs 500 325.97 325.97 0.00 162985.00 0.00


Mtrs 800 213.89 213.89 0.00 171112.00 0.00


Mtrs 350 165.83 165.83 0.00 58040.50 0.00

22 Supply of L.T. Aluminium Armoured PVC/XLPE cable of size 3 1/2 x 25 Sqmm 1100 Volts Grade for new connection and removal of exiting infringement .

Mtrs 2500 107.58 107.58 0.00 268950.00

0.00

23 Supply of XLPE Al armoured LT cable, 4 X 16 sq.mm 1100 volt grade.

Mtrs 1500 87.07 87.07 0.00 130605.00 0.00

24 Supply of XLPE Al armoured LT cable, 2 X 10 sq.mm 1100 volt grade. As per R/Cno.XLPE-LT/ES-4/RC-B1040000/0110/34/02397/1230, Dt.20/03/09 Valid upto 31/03/10 + ED 8.24% + 4%VAT

Mtrs 500 57.12 57.12 0.00 28560.00 0.00

25 Laying of cable / cables in under ground along the road through cable trench etc . as per standard drawing (cable will be supplied by Railway) including necessary termination , connection and testing. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Mtrs 4200 84.80 0.00 84.80 0.00 356160.00


Sr. No

Description


Unit Erection


26 Laying of cable / cables across the road, track, drain etc through RCC pipe of size 100mm x 150mm (or any suitable size as per field requirement based on the actual size of the cable) as per relevant specification and as per standard drawing with necessary termination, connections and testing ( cable will be supplied by Railway). As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Mtrs 200 315.87 0.00 315.87 0.00 63174.00

27 Laying of cable/ cables on wall/ Structure ( cable will be supplied by Railway) with suitable clamp / saddale/ fixtures etc with necessary termination, connection and testing as per standard drawing. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Mtrs 1000 33.00 0.00 33.00 0.00 33000.00

28 Supply, erection, testing and commissioning of indoor type Transformer 250 KVA, 11 KV/416 volt with a TAP at 6.6KV complete with oil and other accessories as per CEE, S. E. Rly specification No. CEE/ Transformer / 11-98/REV As per COS/GRC PO.No.47.09.5056.1.70041, dated: 16.06.10.

No 2 269541.74 256706.42 12835.32 513412.84 25670.64

29 Supply, fixing and commissioning of Drop Out Fuse suitable for 11 KV/6.6KV ( Each set - 3 Nos ) . As per LOA No. 114-Elect/OT/KGP/Substn R-Yard NMP/B Maha/428, Dated: 10/11/2008.

Set 2 9422.88 8566.26 856.62 17132.52 1713.24

30 Supply, fixing and commissioning of Lighting arrester suitable for 11 KV/6.6KV system. As per LOA No. 114-Elect/OT/KGP/Substn R-Yard NMP/B Maha/428, Dated: 10/11/2008.

Set 2 4810.87 4373.52 437.35 8747.04 874.70


Sr. No

Description


Unit Erection


31 Supply, fixing and commissioning of Airbreak Switch 200 Amps 11 KV/6.6KV grade ( Each set - 3 Nos). As per LOA No. 114-Elect/OT/KGP/Substn R-Yard NMP/B Maha/428, Dated: 10/11/2008.

Set 2 7548.83 6692.21 856.62 13384.42 1713.24

32 Supply, Fixing and Commissioning of HT Heat shrinkable type End Termination Outdoor type suitable for 3 X 50 Sq.mm XLPE cable 11KV/E As per 3M Electrical Energy Products Price list 2008.

No 4 12423.33 11831.74 591.59 47326.96 2366.36

33 Supply of HT XLPE cable 3 x 50 Sq mm, 11 KV (earthed) confirming to IS- 7098/II/85 with latest amendements. Havell's price list w.e.f 01/01/08 + 16.48% ED + 4% VAT - 20%.

Mtrs 600 882.10 882.10 0.00 529260.00 0.00

34 Laying of HT XLPE cable 3 x 50 Sq mm, 11 KV in ground or as required. CPWD SOR -Electrical, Part-2, External - 2007 with 5% per yr. escl.

Mtrs 600 145.78 0.00 145.78 0.00 87468.00

35 Supply and delivery of HT panel 6.6 KV TAP/ 11KV 400A VCB ( one panel ) by providing all requisite materials components and complete in all respect as per direction of Engineering charge. Rate Ref : Maa-er Ghat Project 2010

no. 1 1478967.00 1478967.00 0.00 1478967.00 0.00

36 Supplying and making outdoor end termination with cast resin compound including aluminium lux and other joining materials for the following size of PVC insulates and PVC sheathed / XLPE aluminium conductor cable of 1.1KV grade as required. CPWD/SOR Elect Part-II with 5% /year ESCL.

i) 3.5 x 240Sq mm Item no 4.2.26 p-13 Each 4 890.54 774.34 116.20 3097.36 464.80


Sr. No

Description


Unit Erection


ii) 3.5x 120Sq mm Item no 4.2.22 p-13 Each 4 566.23 492.28 73.95 1969.12 295.80

iii) 3.5 x 70 Sq mm Item no 4.2.20 p-12 Each 4 532.43 462.71 69.72 1850.84 278.88 iv) 3.5 x 50Sq mm Item no 4.2.19 p-12 Each 4 496.51 431.01 65.50 1724.04 262.00 v) 3.5 X 25Sq mm Item no 4.2.17 p-12 Each 4 357.06 310.58 46.48 1242.32 185.92

vi) 4 X 16 Sq mm Item no 4.2.29 p-13 Each 4 406.72 353.90 52.82 1415.60 211.28

vii) 2X 10 Sq mm Item no 4.1.2 p-10 Each 4 92.97 80.29 12.68 321.16 50.72

37 Supplying and making straight through joint with cast resin compound including ferrles and other joining materials for the following size of PVC insulates and PVC sheathed / XLPE aluminium conductor cable of 1.1KV grade as required. CPWD/SOR Elect Part-II with 5% /year ESCL.

i) 3.5 x 240Sq mm Item no 4.3.26 p-14 Each 2 2053.65 1785.32 268.33 3570.64 536.66 ii) 3.5x 120Sq mm Item no 4.3.22 p-14 Each 2 1482.13 1288.81 193.32 2577.62 386.64

iii) 3.5 x 70 Sq mm Item no 4.3.20 p-14 Each 2 1020.49 887.38 133.11 1774.76 266.22

iv) 3.5 x 50Sq mm Item no 4.3.19 p-14 Each 2 939.14 816.60 122.54 1633.20 245.08 v) 3.5 X 25Sq mm Item no 4.3.17 p-14 Each 2 742.65 645.46 97.19 1290.92 194.38 vi) 4 X 16 Sq mm Item no 4.3.29 p-14 Each 2 725.75 630.67 95.08 1261.34 190.16


Sr. No

Description


Unit Erection


38 Supply, Fixing and Commissioning of LT panel consisting with 800 Amps, FP ACB ( with Microprocessor release IPR 1 manual Drawout type ) - 2 Nos as incoming and 800 Amps, FP ACB ( with Microprocessor release IPR 1 manual Drawout type ) as Bus coupler and FP 200 Amps MCCB (35 kA breaking capacity) - 2 Nos and FP 100 Amps MCCB (35 kA breaking capacity) - 4 Nos and FP 63 Amps MCB - 4 Nos as outgoing with Cu.bus-bar, ammeter, Voltmeter, selector switch, indicator lamp etc with measuring Protective circuit suitable for Copper Bus- Bar and Enclosure. As per Havells Price list w.e.f 01/01/10 - 10%.

Sets 2 420525.25 382296.07 38229.18 764592.14 76458.36

39 Supply, Fixing and Commisioning of 20 Amps DP MCB with Sheet Steel Enclosure. As per standard Electricals price list w.e.f 05/02/10 - 10%.

Sets 120 732.09 665.54 66.55 79864.80 7986.00

40 Supply, Fixing and Commissioning of TP&N 4-way DB (Single Door) consisting with 63A FP MCB as incoming and 16 Amps DP MCB - 6 nos as outgoing with Cu.bus-bar, ammeter, Voltmeter, selector switch, indicator lamp etc., As per standard Electricals price list w.e.f 05/02/10 - 10%.

Sets 3 6264.48 5695.08 569.40 17085.24 1708.20

41 Supply, Fixing and Commissioning of TP&N 4-way DB (Single Door) consisting with 63A FP MCB as incoming and 20 Amps DP MCB - 6 nos as outgoing with Cu.bus-bar, ammeter, Voltmeter, selector switch, indicator lamp etc., As per standard Electricals price list w.e.f 05/02/10 - 10%.

Sets 15 6264.48 5695.08 569.40 85426.20 8541.00


Sr. No

Description


Unit Erection


40 Supply, Fixing and Commissioning of Power Line Vertival DB Board 8-way (Double Door) consisting with 100A FP MCCB (25 kA breaking capacity) - 1 No as incoming and 32 Amps DP MCB - 6 nos as outgoing with Cu.bus-bar, ammeter, Voltmeter, selector switch, indicator lamp etc., As per standard Electricals price list w.e.f 05/02/10 - 10%.

Sets 2 15044.26 13676.22 1368.04 27352.44 2736.08

42 Supply, Fixing and Commissioning of DB Board consisting with 200A FP MCCB (35 kA breaking capacity) as incoming and 100 Amps FP MCCB (25 kA breaking capacity) - 4 nos as outgoing with Cu.bus-bar, ammeter, Voltmeter, selector switch, indicator lamp etc., As per standard Electricals price list w.e.f 05/02/10 - 10%.

Sets 4 42356.56 38505.96 3850.60 154023.60 15402.40

43 Installation , testing and commissioning of self contained drinking water cooler, storage type, cooling capacity 150 Ltrs/Hr, Storage Capacity :150 Ltrs. suitable for operation in 230 V, 50 Hz AC supply , complete with hermetically sealed compressor energy efficient unit with overload protection, as per IS:10617(Pt.1)/Latest, (to be supplied by Railway) complete with all accessories conforming to IS : 1475 (Pt.1)/Latest. Installation and commissioning the water cooler shall be made with all necessary arrangement as per site requirement As per R/C No: DC/ME-3/RC- 12010000/0610/03/N0321/1478, Dt: 30.06.09' Valid upto 30.06.10 + 12.5 % CST.

No 4 40163.27 38251.18 1912.09 153004.72 7648.36


Sr. No

Description


Unit Erection


44 Supply, fixing and commissioning of North West Starter 7.5 HP(16A-20A) capacity with 25 Amps socket. As per LOA No: 114-Elect/OT/KGP/417/Sr.DFM office/SRE dated: 09/09/2008.

Nos 6 765.36 680.32 85.04 4081.92 510.24

45 Supply, Erection and commissioning of 2 Ton Split type AC Model.No: LG/LSA7V W3CIG , with Rotary Compressor, energy efficient, Nominal cooling capacity: 6000 Kcal/hr, Min. Room discharge Airflow: 800 Cub.m/hr, Guaranteed Cooling capacity (Min) Kcal/hr : 5700, Star Rating: 3 star and above. As per R/C no. SAC-WM/ME-3/RC - 11050000/ 0111/03/00790/1493 dt: 14.05.10 Valid upto 30.04.11 + 10.3% E.D +13.5% VAT.

Nos 4 38076.00 34579.30 3496.70 138317.20 13986.80

46 Supply and erection of Earthing arrangement with supply and commissioning of earth cone and all other requisite materials as per CEE/GRC's Drg. No.CEE/G/A3/P-150 including sump box with salt and charcoal, metalic cover etc. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Pts 30 1745.18 1396.14 349.04 41884.20 10471.20

47 Supply and erection of and commissioning of Gyser 5Lit capacity. As per 114 Elect/OT/KGP/North Settlement, Kharagpur(Part-A)/469, Dt : 24/07/09.

Nos 6 9085.08 8451.24 633.84 50707.44 3803.04

48 Supplying lowering fixing of 3 phase 10HP 50mt. Head submursible pump motor set including panel with all materials, testing and commissioning complete in all respect. CON/EP/DGR/534/Elect/TV/2008 dt.30.06.2008 depth of 100mt in each case consider.

Each 2 73948.35 0.00 73948.35 0.00 147896.70


Sr. No

Description


Unit Erection


49 Co-ordination/liasoning and chasing with state Utility Company foe availing new electrical connection/augmentation of sanctioned load at buildings including applying for load, collection of estimates of loads arranging payment from RITES, depositing payment to State Utility Company arranging release of load & other related works. Payment to be made to WBSEDCL for new connection ,load augmentation, shall be made by RITES.

Each Locatio

n

1 52820.25 0.00 52820.25 0.00 52820.25

Total 6671234.86 1674820.01

Sub-Total (Supply+Erection) 8346054.87 Contingencies @ 1% on sub-total 83460.55 Grand Total 8429515.42 Say 8429515.00