romer labs allergen solutions - foodriskmanagement.com · romer labs supports you with: broad range...
TRANSCRIPT
Romer Labs Allergen Solutions
February 2015
Commercial analytical methodsdetecting Proteins ndash Peptides - DNA
Proteins
ELISA or LFDAgraQuantreg Allergen
AgraQuantreg + AllergenAgraStripreg Allergen
Antibodies recognizing Epitopes (3D structures)
allergens (antigen-antibodyinteraction)
Peptides
LCMSMS
Tryptic digestion into peptides whichare recognized by
LCMSMS
DNA
PCR or RT-PCR
Amplification of nucleic acid sequence
Romer Labsreg ndash Experts in food allergen testing
AgraStripreg lateral flow devices19 different allergens
AgraQuantreg ELISA 20 different allergens
AgraQuantreg Plus ELISA8 different allergens
ISO 17025 accredited service laboratory for allergen testing
RomerLabs solution for detecting allergens
bull ELISA Method
bull Quantitative Results
bull Lab equipment needed (Reader centrifuge water bath)
bull 48 (some 96) microwells
bull Lateral Flow Strip Method
bull Qualitative Results
bull On site testing
bull No Lab equipment needed (all components included)
bull 10 test strips amp swabs
AgraQuant Test kits AgraStrip Test kits
Allergen detection with the AgraStripreg
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Commercial analytical methodsdetecting Proteins ndash Peptides - DNA
Proteins
ELISA or LFDAgraQuantreg Allergen
AgraQuantreg + AllergenAgraStripreg Allergen
Antibodies recognizing Epitopes (3D structures)
allergens (antigen-antibodyinteraction)
Peptides
LCMSMS
Tryptic digestion into peptides whichare recognized by
LCMSMS
DNA
PCR or RT-PCR
Amplification of nucleic acid sequence
Romer Labsreg ndash Experts in food allergen testing
AgraStripreg lateral flow devices19 different allergens
AgraQuantreg ELISA 20 different allergens
AgraQuantreg Plus ELISA8 different allergens
ISO 17025 accredited service laboratory for allergen testing
RomerLabs solution for detecting allergens
bull ELISA Method
bull Quantitative Results
bull Lab equipment needed (Reader centrifuge water bath)
bull 48 (some 96) microwells
bull Lateral Flow Strip Method
bull Qualitative Results
bull On site testing
bull No Lab equipment needed (all components included)
bull 10 test strips amp swabs
AgraQuant Test kits AgraStrip Test kits
Allergen detection with the AgraStripreg
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Romer Labsreg ndash Experts in food allergen testing
AgraStripreg lateral flow devices19 different allergens
AgraQuantreg ELISA 20 different allergens
AgraQuantreg Plus ELISA8 different allergens
ISO 17025 accredited service laboratory for allergen testing
RomerLabs solution for detecting allergens
bull ELISA Method
bull Quantitative Results
bull Lab equipment needed (Reader centrifuge water bath)
bull 48 (some 96) microwells
bull Lateral Flow Strip Method
bull Qualitative Results
bull On site testing
bull No Lab equipment needed (all components included)
bull 10 test strips amp swabs
AgraQuant Test kits AgraStrip Test kits
Allergen detection with the AgraStripreg
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
RomerLabs solution for detecting allergens
bull ELISA Method
bull Quantitative Results
bull Lab equipment needed (Reader centrifuge water bath)
bull 48 (some 96) microwells
bull Lateral Flow Strip Method
bull Qualitative Results
bull On site testing
bull No Lab equipment needed (all components included)
bull 10 test strips amp swabs
AgraQuant Test kits AgraStrip Test kits
Allergen detection with the AgraStripreg
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Allergen detection with the AgraStripreg
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Why using a strip test for allergens
Real time testing ndash implement decisions quickly
Trouble shooting abilities
Simplicity of use ndash less training
Cost effective - single sample
No additional equipment for AgraStripreg Allergen Tests
On-site testing
Confidence through testing
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Why using AgraStripreg Allergen Kits
Testkit details
Everything included in kit
On-site method
Same procedure (ex G12 soy)
Sensitive - Low LOD
Certificate of Performance
Validation reports
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
AgraStripreg Allergen On-site Test Kit
Components in the kit
Store at Room Temperature Time-to-result 11min
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
On-site Testing for Trace Amounts of Allergens
3 extraction procedures
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Finished Products amp Rinse Water Testing -Extraction
Homogenize the sample(ie blend crush grind)
Weigh 02g of sample (with Balance or estimate by filling up one of the extraction tubecaps) and add to an extraction tube or just add 02 mL rinse water
Fill Extraction Tube withExtraction Buffer tolevel shown below (bluearrow)
Close tube with tube cap andshake vigorously by hand for 1minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to an incubation vial
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Swabbing - ExtractionFill extraction tube withExtraction Buffer take aswab and wet the end bydipping into the buffer
Wipe an area of 5cmx5cm using side toside movements rotating the swab tip asyou go (we recommend the ldquocross-hatchrdquoswabbing technique indicated below)
Place the swab into theextraction tube Carefully breakoff the end at the pre-scoredpoint
Close the tube with a cap and shake vigorously for 1 minute
Remove cap from the Extraction Tube and replace with dropper tip And transfer 12 drops (400ml) to a new tube (incubation Vial)
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Running the Assay for all sample types
Shake Incubation Vial vigorously by hand for 15 seconds(ensuring liquid comes in contact with the lid of the vial) thenleave to stand at room temperature for 5 minutes
Open the container of AgraStripsreg remove the necessarynumber of strips and close the tube Open the IncubationVial and dip the bottom end of test strip into the vial
Remove the test strip from the Incubation Vial after 5 minutes and read off the result immediately
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Reading Results
One single purple line in the central part of the test = negative result
Two purple lines in the result zone = positive result
No control line appears = invalid result
bull After 5 min strip development cut off filter pad for proper read out
Filter pad
Cut here
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Video AgraStripreg Allergen Procedure
httpwwwyoutubecomwatchv=AWmB3jk8Q1I
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
AgraStripreg Allergens (19)
AgraStripreg Peanut(COKAL0110AS)
AgraStripreg Egg(COKAL1810AS)
AgraStripreg Walnut(COKAL0910AS)
AgraStripreg Sesame(COKAL1910AS)
AgraStripreg Soy(COKAL0410AS)
AgraStripreg
CashewPistachio(COKAL1310AS)
AgraStripreg Hazelnut(COKAL0310AS)
AgraStripreg Gluten G12(COKAL0200AS)
AgraStripreg Lupin(COKAL1510AS)
AgraStripreg Macadamia(COKAL1610AS)
AgraStripreg Milk (COKAL2610AS)
AgraStripreg BLG(COKAL1010AS)
AgraStripreg Crustacea(COKAL1010AS)
AgraStripreg Almond(COKAL0710AS)
AgraStripreg Casein(COKAL1210AS)
AgraStripreg Mustard(COKAL2110AS)
AgraStripreg Brazil Nut(COKAL1710AS)
AgraStripreg Coconut(COKAL2610AS)
AgraStripreg Gluten(COKAL0210AS)
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Allergen detection with the AgraQuantreg
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
AgraQuantreg Peanut(COKAL0148)
AgraQuantreg Egg white(COKAL0848)
AgraQuantreg Walnut(COKAL0948)
AgraQuantreg Sesame(COKAL1948)
AgraQuantreg Soy(COKAL0448)
AgraQuantreg Cashew(COKAL3148)
AgraQuantreg Ovalbumin(COKAL2948)
AgraQuantreg Hazelnut(COKAL0348)
AgraQuantreg Gluten G12(COKAL0200)
AgraQuantreg Lupin(COKAL1548)
AgraQuantreg Pistachio(COKAL2748)
AgraQuantreg Milk (COKAL2448)
AgraQuantreg BLG(COKAL1048)
AgraQuantreg Gluten (COKAL0248)
AgraQuantreg Almond(COKAL0748)
AgraQuantreg Casein(COKAL1200)
AgraQuantreg Mustard(COKAL2148)
AgraQuantreg Crustacea(COKAL2248)
AgraQuantreg Fish(COKAL2548)
AgraQuantreg Lysozyme(COKAL2848)
AgraQuantreg Allergens (20)
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
ELISA assays
bull Microplates coated with specific antibody
bull Antibody-enzyme conjugates
bull Substrate changing colorin presence of enzyme
Abs
Conc
Microwell
bdquoCapture
Antibodyldquo
Conjugate
bdquoDetection Antibodyldquo
Sample
(Antigen)
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Why AgraQuant Kits
Ready to use reagents
Extraction solution included
Same procedure all kits
Sensitive - Low LODLOQ
Certificate of Performance
Spreadsheet provided
Validation service
Full product pipeline
Customer support
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Kit components
Antibody coated wells
5 vials of standards
1 vial conjugate
1 vial substrate
1 vial stop solution
1 bottle extraction solution (10x)
1 bottle wash buffer (10x)
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Sample Preparation - Example
Sample size 1 g
Extractionsolution
20 mL extraction buffer (provided)
Extractiontime
15 min at 60degC water bath shake vigorously every 2 minutes
CentrifugationFiltration
10 min at 2000g at room temperature or filter
Dilution Supernatant is ready for testing
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Sandwich ELISA
Pre-coated Ab
Ab-Conjugate
Analyte(Allergen)
321
54 6
87
1 Add samplestandards2 Incubation3 Washing4 Add conjugate5 Incubation6 Washing
7 Add substrate8 Add stopp solution9 Read
9
Ab coated well
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Procedure- AgraStrip Allergen
Add samples amp StandardsIncubate 20 minutesWash
Add ConjugateIncubate 20 minutesWash
Add SubstrateIncubate 20 minutesAdd Stop amp Read results
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Spreadsheet
Sandwich ELISA
direct signal to
concentration curve
more analyte
higher OD value
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
AgraQuant reg Swabbing Kit
bull 20 swabbs
bull 20 temper proof vials
bull Swabbing buffer
Validations for
bull Plastic stainless steel teflon
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Allergen detection with the AgraQuantreg PLUS
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
AgraQuantreg Plus Allergens
AgraQuantreg Plus Egg(COKAL1848F)
AgraQuantreg Plus Peanut(COKAL0148F)
AgraQuantreg Plus Hazelnut(COKAL0348F)
AgraQuantreg Plus Cashew(COKAL3148F)
AgraQuantreg Plus Almond(COKAL0748F)
AgraQuantreg Plus Macadamia nut(COKAL1648F)
AgraQuantreg Plus Casein(COKAL1248F)
AgraQuant Plus Mustard(COKAL2148F)
hellipmore to come soon(BLG Pistachio Lupin Sesame Soy)
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Fastest Allergen ELISA on the market bull Extraction 1minbull ELISA Assay 30minbull Time-To-Result 31min
Accuratebull low cross-reactivitybull good recovery from challenging matricesbull good inter- and intra-assay precision
Sensitivebull low LODs
Technologybull time saving extraction technologybull capsules used for extraction
AgraQuantreg PLUS Allergens
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Conjugate
Stop solution
Substrate
Extraction additive 1 amp2
5 standards
Washbuffer
Antibody coated wellsTransfer wells
Kit components
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Extraction Procedures
1Food
2Environmental samples (swab and sponge)
3Rinse water
1Food
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Extraction procedure
2 Bring destilled water
to 80-100degC and Add 20mLhot but not boiling water tothe tube
1 Accurately weigh 1g (mL) of
sample into a 50mL centrifuge tubeand add one capsule each ofextraction addititve 1 amp 2
3 Shake tube vigorously for 15
seconds (until sample and capsules aredissolved)
4 Transfer an aliquot to a 15 or 2 mL
reaction vial and centrifuge OR alternatively filtrate through a pleated filter and use the filtrate in the test
8000g 5min
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
ELISA Assay
Running the assay 30 min
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
The big advantages
bull fast extraction of up to 24 samples at the same time
bull no need for preparing extraction buffer
bull one extract can be used to measure several allergens (exception egg)
10 vs 70 samples
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Online Video Instructions on YouTube
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
but also the extracts of the normal AQ kitscan be used in different assayshellip
taken from the AQ Allergen Quick Guide
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
The next generation Gluten Antibody
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Gluten G12
AgraQuantreg Gluten G12 AgraStripreg Gluten G12
AOAC Official Method 201403
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Romer offers solutions for the whole process
Ingredients
Analytical Service
FinishedProducts
In-Process
CleaningValidation
Certification
Coveringall
Stages
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Analytical Service
ISO 170252005 accredited through the American Association for Laboratory Accreditation
bull for allergensbull for mycotoxins
For customized validation For confirmation of positives
ROMER LABS INC 1301 Stylemaster Drive Union MO 63084 Laboratory Director Christy Brewe
Phone 636-583-8600
ISO 170252005ISO 90012008 170252005
ISO170252005
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Romer Labs supports you with
Broad Range of Allergen Solutions
Custom based validations
Confirmation of positives
Customer service
Technical servicesupport
Trainings and Certification
Check Sample Surveys
Thanks for your attention
Questions
Thanks for your attention
Questions