safety data sheet - new pig - absorbents, spill .safety data sheet this safety data sheet complies

Download Safety Data Sheet - New Pig - Absorbents, Spill .Safety Data Sheet This safety data sheet complies

Post on 26-Aug-2018




0 download

Embed Size (px)


  • Safety Data Sheet

    This safety data sheet complies with the requirements of: 2012 OSHA Hazard Communication Standard ( 29CFR 1910.1200)

    Product name Spill-X-A Acid Neutralizer

    1. Identification

    Product name Spill-X-A Acid Neutralizer

    Product code 073344Synonyms NoneChemical Family No information available

    Recommended use Spill Control ProductsUses advised against Consumer use

    Contact point Product Stewardship at 1-715-735-7411E-mail address

    Emergency telephone CHEMTREC 800-424-9300 or 703-527-3887

    2. Hazards Identification

    OSHA Regulatory StatusThis product is not considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR 1910.1200)

    Precautionary Statements

    Not Applicable.

    Unknown Acute Toxicity

  • _____________________________________________________________________________________________

    Product code 073344 / Product name Spill-X-A AcidNeutralizer

    / PAGE 2 / 7

    3. Composition/information on Ingredients

    The following component(s) in this product are considered hazardous under applicable OSHA(USA)

    Chemical name CAS No. weight-%Magnesium Oxide 1309-48-4 60 - 100

    Attapulgite 12174-11-7 7 - 13Sodium carbonate 497-19-8 5 - 10

    4. First aid measures

    Eye Contact Rinse thoroughly with plenty of water for at least 15 minutes, lifting lower and upper eyelids.Consult a physician.

    Skin contact Wash skin with soap and water. Get medical attention if irritation develops and persists.

    Inhalation Remove to fresh air. If breathing is difficult, give oxygen. (Get medical attention immediatelyif symptoms occur.).

    Ingestion Rinse mouth. Do not induce vomiting without medical advice. Aspiration hazard ifswallowed - can enter lungs and cause damage. If swallowed, call a poison control centeror physician immediately.

    Symptoms None known.

    Note to physicians Effects of exposure (inhalation, ingestion or skin contact) to substance may be delayed.

    5. Fire-fighting measures

    Hazardous CombustionProducts

    Carbon oxides

    Sensitivity to Mechanical Impact None.Sensitivity to Static Discharge None.

    3.1. Mixture

    4.1. Description of first aid measures

    4.2. Most Important Symptoms and Effects, Both Acute and Delayed

    4.3. Indication of Any Immediate Medical Attention and Special Treatment Needed

    5.1. Suitable Extinguishing MediaUse extinguishing measures that are appropriate to local circumstances and the surrounding environment.

    5.2. Unsuitable Extinguishing MediaNone.

    5.3. Specific Hazards Arising from the ChemicalNone known.

    5.4. Explosion Data


    Revision date 10-Jan-2017 Version 27

    5.5. Protective Equipment and Precautions for FirefightersAs in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and fullprotective gear.

    MSD-V007 NewPig

  • _____________________________________________________________________________________________

    Product code 073344 / Product name Spill-X-A AcidNeutralizer

    / PAGE 3 / 7

    6. Accidental release measures

    Personal Precautions Do not breathe dust.

    For emergency responders Use personal protection recommended in Section 8.

    Environmental Precautions Prevent further leakage or spillage if safe to do so. Prevent entry into waterways, sewers,basements or confined areas. See Section 12 for additional Ecological Information.

    Methods for Containment If sweeping of a contaminated area is necessary use a dust suppressing agent which doesnot react with product. Prevent further leakage or spillage if safe to do so.

    Methods for Cleaning Up Sweep up and shovel into suitable containers for disposal. Clean up material with vacuumequipped with HEPA filter. Following product recovery, flush area with water.

    7. Handling and Storage

    Advice on safe handling Avoid generation of dust. Do not breathe dust. Do not enter storage areas or confinedspaces unless adequately ventilated. Handle in accordance with good industrial hygieneand safety practice.

    Storage Conditions Keep containers tightly closed in a cool, well-ventilated place. Guard against dustaccumulation of material. Use care in handling/storage.

    Incompatible Materials None known.

    8. Exposure Controls/Personal Protection

    Exposure guidelinesChemical name ACGIH TLV OSHA PEL NIOSH IDLH

    Magnesium Oxide 1309-48-4

    TWA: 10 mg/m3 inhalableparticulate matter

    - IDLH: 750 mg/m3 fume

    Attapulgite 12174-11-7

    TWA: 1 mg/m3 respirableparticulate matter

    - -

    ACGIH (American Conference of Governmental Industrial Hygienists). OSHA (Occupational Safety and Health Administration ofthe US Department of Labor). NIOSH IDLH: Immediately Dangerous to Life or Health.

    Engineering controls Ensure adequate ventilation, especially in confined areas.

    Eye/Face Protection Avoid contact with eyes. Tight sealing safety goggles.

    Skin and Body Protection Wear protective gloves and protective clothing.

    6.1. Personal precautions, protective equipment and emergency procedures

    6.2. Environmental Precautions

    6.3. Methods and material for containment and cleaning up

    7.1. Precautions for Safe Handling

    7.2. Conditions for safe storage, including any incompatibilities

    8.1. Control Parameters

    8.2. Appropriate Engineering Controls

    8.3. Individual protection measures, such as personal protective equipment


    Revision date 10-Jan-2017 Version 27MSD-V007 NewPig

  • _____________________________________________________________________________________________

    Product code 073344 / Product name Spill-X-A AcidNeutralizer

    / PAGE 4 / 7

    Respiratory Protection In case of inadequate ventilation wear respiratory protection.

    Ventilation Use local exhaust or general dilution ventilation to control exposure with applicable limits

    9. Physical and Chemical Properties

    Physical State powder

    10. Stability and Reactivity

    Stable under normal conditions.

    None under normal processing.

    hazardous polymerization Hazardous polymerization does not occur.

    None known.

    8.4. General hygiene considerationsDo not eat, drink or smoke when using this product. Avoid contact with skin, eyes or clothing. Keep away from food, drink andanimal feeding stuffs. Handle in accordance with good industrial hygiene and safety practice.

    9.1. Information on basic physical and chemical properties

    Odor None Color Redodor threshold No data available

    Property VALUES Remarks Method pH No data availableMelting point/freezing point No data availableBoiling point / boiling range No data availableFlash Point No data availableEvaporation Rate No data availableflammability (solid, gas) No data availableFlammability limit in air

    Upper flammability limit: No data availableLower flammability limit: No data available

    Vapor Pressure No data availableVapor Density No data availableSpecific gravity No data availableWater Solubility No data availableSolubility in Other Solvents No data availablePartition coefficient No data availableAutoignition Temperature No data availableDecomposition Temperature No data availableKinematic viscosity No data available

    10.1. Chemical Stability

    10.2. Reactivity None known

    10.3. Possibility of hazardous reactions


    Revision date 10-Jan-2017 Version 27

    10.4. Conditions to Avoid

    MSD-V007 NewPig

  • _____________________________________________________________________________________________

    Product code 073344 / Product name Spill-X-A AcidNeutralizer

    / PAGE 5 / 7

    None known.

    Carbon oxides.

    11. Toxicological Information

    Product information

    INHALATION May cause irritation of respiratory tract.

    Eye Contact May cause irritation.

    Skin contact May cause irritation.

    INGESTION Ingestion may cause irritation to mucous membranes.

    Acute Toxicity

    Chemical name Oral LD50 dermal LD50 Inhalation LC50Sodium carbonate 497-19-8

    = 4090 mg/kg ( Rat ) - = 2300 mg/m3 ( Rat ) 2 h

    Symptoms No information available.

    sensitization No information available.Germ Cell Mutagenicity No information availablecarcinogenicity Attapulgite (palygorskite fibers) is a hydrated magnesium aluminum silicate. Long

    palygorskite (attapulgite) fibers (>5 micrometers) are possibly carcinogenic to humans(Group 2B). Short palygorskite (attapulgite) fibers (

  • _____________________________________________________________________________________________

    Product code 073344 / Product name Spill-X-A AcidNeutralizer

    / PAGE 6 / 7

    7.19% of the mixture consists of components(s) of unknown hazards to the aquatic environmentChemical name Algae/aquatic plants Fish Crustacea

    Sodium carbonate 497-19-8

    EC50 120 h = 242 mg/L Nitzschia 310 - 1220: LC50 96 h 310 - 1220mg/L Pimephales promelas static

    300: LC50 96 h = 300 mg/LLepomis macrochirus static

    EC50 48 h = 265 mg/L Daphniamagna

    No information available.

    No information available.

    No information available

    13. Disposal Considerations

    Disposal of wastes Disposal should be in accordance with applicable regional, national and local laws andregulations.

    Contaminated Packaging Do not reuse container.

    14. Transport Information



View more >