service manual elecrical wiring diagrams
TRANSCRIPT
-
8/13/2019 service manual elecrical wiring diagrams
1/76
SERVICE MANUAL
ELECTRICAL WIRING DIAGRAMS
Supplement
http://cover.pdf/ -
8/13/2019 service manual elecrical wiring diagrams
2/76
LANCER
EVOLUTION VIII
MR
FOREWARD
This manual contains information about the mainchanges in the 2004 Lancer Evolution VIII MR.It only covers those points that are different from theprevious model. Therefore, when inspecting orrepairing electrical parts, this manual should be used inconjunction with the related documents listed on thefollowing pages, if necessary.This manual contains various different types of wiringdiagrams and circuit diagrams, but it should beremembered that these may not always coincide withthe exact specifications of each individual vehicle.This manual is based on the vehicle specifications as ofFebruary 2004.Please note that future vehicles may not match thecontents of this manual completely, due to changes inspecifications, or the like.The units shown in this manual are the standardinternational SI units. Conventional units are notincluded.
February 2004
MITSUBISHI MOTOR CORPORATION
General
Wiring Diagrams
Component Installation Positions
Circuit Diagrams
1
2
3
0
This manual is printed on recycled paper
Any opinions, requests, or questions concerning thismanual, should be written on the Servicing Comments
Form at the end, and sent to us by fax.
CONTENTS
-
8/13/2019 service manual elecrical wiring diagrams
3/76
Related documentation
Cautionary Note regarding servicing of vehicles fitted with SRS airbags and/or seatbelts withpre-tensioner systems.Warnings:1. Incorrect inspection or servicing of a component part of the SRS airbag system or seatbelt pre-tensioner system, or
a part relating to these systems, may cause accidental operation (deployment) of the SRS airbag or seatbelt pre-tensioners, or may cause these systems to be disabled, leading in either case the risk of serious injury.
2. If parts may be affected by heat during painting operations, then those parts must be removed in advance. Thisapplies to the SRS-ECU, airbag modules (drivers sear and front passengers seat), clock springs, front impactsensors, side impact sensors, and pre-tensioner seatbelts. 93C or above : SRS-ECU, airbag modules (drivers sear and front passengers seat), clock springs, front impact
sensors, side impact sensors 90C or above : Pre-tensioner seatbelts
3. The component parts of the SRS airbag system or seatbelt pre-tensioner system, and parts relating to thesesystems, must always be inspected and serviced by a Mitsubishi dealer.
4. Service personnel must read the relevant service manuals (particularly, Section 52B SRS Airbags) carefully andthoroughly, before inspecting or servicing the component parts of the SRS airbag system or seatbelt pre-tensionersystem, and parts relating to these systems.
Title of Document No. Date ofIssue
Title of Document No. Date ofIssue
Body Manuals (Service Manual) Mirage, Lancer (supplement) Lancer Cedia Lancer Cedia (supplement) Lancer Evolution VII(supplement) Lancer Cedia (supplement) Lancer (supplement) Lancer Evolution VIII MR(supplement)
1036F521036K501036K51
1036K521036K531036K54
1036K55
Aug 1996May 2000July 2000
May 2001Oct 2001Feb 2003
Feb 2004
Electrical Wiring DiagramsService Manual Lancer Evolution VIII 1036K77 Jan 2003
New Vehicle Manuals Mirage, Lancer Mirage, Lancer Mirage, Lancer Mirage, Lancer Mirage Mirage, Lancer Lancer Lancer Lancer Cedia Lancer Cedia Lancer Evolution VII Lancer Cedia Lancer Cedia Lancer Evolution VII Lancer Cedia Lancer Evolution VIII
Lancer Lancer Lancer Evolution VIII MR
1036F301036F311036F321036F331036F341036F351036F361036F371036K301036K311036K321036K331036K341036K351036K361036K37
1036K381036K391036K40
Oct 1995Jan 1996Aug 1996Jul 1997Jan 1998Oct 1998Jan 1999Dec 1999May 2000July 2000Jan 2001May 2001Oct 2001Jan 2002May 2002Jan 2003
Feb 2003Dec 2003Feb 2004
Engine Service Manual
4G6 Engine 4G6 Engine (supplement)
1039G461039G63
Jan 2001Jan 2003
Service Manuals Lancer Cedia Lancer Cedia (supplement) Lancer Evolution VII(supplement) Lancer Cedia (supplement) Lancer Cedia (supplement) Lancer Evolution VII(supplement)
Lancer Cedia (supplement) Lancer Evolution VIII(supplement) Lancer (supplement) Lancer (supplement) Lancer Evolution VIII MR(supplement)
1036K001036K011036K02
1036K031036K041036K05
1036K061036K07
1036K081036K091036K10
May 2000July 2000Jan 2001
May 2001Oct 2001Jan 2002
May 2002Jan 2003
Feb 2003Dec 2003Feb 2004
Transmission Service Manual W5M51 Manual Transmission W5M51 Manual Transmission(supplement) W6MAA Manual Transmission
1039M171039M22
1039M23
Jan 2001Jan 2003
Jan 2003
-
8/13/2019 service manual elecrical wiring diagrams
4/76
0-1
SECTION 0
GENERAL INFORMATIONCONTENTS
Vehicle Identification ..............................0-2
Implementation Code .............................0-2
Details of Changes .................................0-2Wiring Diagrams ................................................0-2Component Installation Positions ......................0-2Circuit Diagrams ................................................0-3
List of Circuit Diagrams.........................0-5
-
8/13/2019 service manual elecrical wiring diagrams
5/76
GENERAL INFORMATION - VEHICLE IDENTIFICATION0-2
Modelcode
Classcode
2004code
Grade Engine model Transmissionmodel
Fuelsupplysystem
GH-CT9A SNDFZ ! RS W5M51(4WD, 5M/T)
SJDFZ ! RSSJGFZ ! GSR
4G63 (2000DOHC 16-valve
intercooler turbo) W6MAA(4WD, 6M/T)
MPI
ConnectorCode
Name Page Details of Change
B Engine transmission p.1-2 Due to changes in the engine control system, thename of the wastegate solenoid valve (B-30) hasbeen changed to wastegate solenoid valve 1, andan additional wastegate solenoid valve 2 (B-32) hasbeen added. The 4WD-ECU (C-37, 38) has been moved fromthe instrument panel harness to the control harness. With the removal of the DVD-MMCS, the followingconnectors have been removed. Multi-centre display (C-11, 12) Navigation unit (C-47)The immobiliser ECU (C-54) has also been removed,due to changes in the engine immobiliser system.
C Instrument panel p.1-4
With the removal of the DVD-MMCS, the followingconnectors have been removed. Audio unit (C-102) Hazard switch (C-105)
F Boot interior p.1-6 Spare connector (F-28) added.
Changed part Page Details of changeECU p.2-2 With changes in the engine immobiliser system, the
installation position of the immobiliser ECU has beenchanged.
Solenoid valve p.2-2 With the addition of the wastegate solenoid valve 2, anew installation point has been provided.
VEHICLE IDENTIFICATIONM3000000100845
Note: denotes a continued model
IMPLEMENTATION CODEM3000001000584
GH-CT9A ; CT9A-0300001 ~
DETAILS OF CHANGESWiring diagrams
M3000003000159
Component installation positionsM3000004000141
-
8/13/2019 service manual elecrical wiring diagrams
6/76
GENERAL INFORMATION - DETAILS OF CHANGES 0-3
Main circuit Name of circuit Page Details of changeJ/C - p.3-2 Partial changes to circuit and
destination system names in J/C(1) (6)
- With the introduction of manual air conditioning, the circuit used by the
fusible link No.2 has been changed. Wastegate solenoid valve 2 added to
load of special fuse No.3. Rating of special fuse No.10 changed
from 15A to 20A.Power supply - p.3-10 Partial changes to destination system
names. Earth No.13 added. Rating of special fuse No.10 changed
from 15A to 20A. Partial changes to circuit details, due
to removal of sunroof.Engine control - p.3-16 Rating of special fuse No.10 changed
from 15A to 20A. Earth No.13 added. Some changes to circuit, due to
addition of wastegate solenoid valve2 (B-32).
Partial changes, due to removal of DVD-MMCS
Lighting Interior lights, boot interior light, ignition key cylinder illumination light, door notclosed indicator light
- Change to terminal number in J/C(2)(C-119) on line linking ETACS anddiagnosis connector. (No.1 " No.5)
Reversing lights - Change to terminal number in J/C(2)(C-119) on line linking reversing lightand rear combination light (LH).
(No.18 " No.19)
Signal
Stop lights p.3-24 Spare connector (F-28) added, andcircuit partially changed.
Meters / Gauges -MetersRemaining fuel warninglight, oil pressure warninglight, brake warning light,seatbelt warning light
- Change to terminal number in J/C(1)
(C-07) on line inking J/B (general fuseNo.18) and combination meter. (No.4" No.8)
Change to terminal number in J/C(4)(C-110) on line linking combinationmeter and fuel gauge unit (sub).(No.20 " No.21)
Door openingcontrol
Electric windows - Change to terminal number in J/C(2)(C-119) on line linking power windowmain switch and diagnosis connector.(No.12 " No.14)
Fully automatic air conditioning
- Change to terminal number in J/C(1)(C-07) on line linking J/B (generalfuse No. 18) and A/C-ECU. (No.6 "No.4)
Change to terminal number in J/C(5)(C-06) on line linking A/C-ECU anddiagnosis connector. (No.8 " No.9)
Air conditioning
Manual air conditioning p.3-26 With the adoption of manual air conditioning, a new circuit has beeninstalled.
Windscreen wipers andwashers
-Safety andvisibility
Electric retractable remotecontrol door mirrors -
Change to terminal number in J/C(2)(C-119) on line linking ETACS and
diagnosis connector. (No.1 " No.5)
Circuit diagramsM3000004500157
-
8/13/2019 service manual elecrical wiring diagrams
7/76
GENERAL INFORMATION - DETAILS OF CHANGES0-4
Main circuit Name of circuit Page Details of changeSpare Audio connectors - Change to terminal number in J/C(1)
(C-07) on line inking J/B (general fuseNo.18) and spare audio connector.(No.3 " No.7)
Accessories
Clock - Change to terminal number in J/C(1)(C-07) on line inking J/B (general fuseNo.18) and clock. (No.2 " No.6)
SpecialEquipment
ABS p.3-32
ACD (Vehicles not fitted with AYC)
p.3-40
Circuit changed due to change inbranching point of connector for 4WD-ECU (C-37) (C-38) (frominstrument panel harness to controlharness).
J/C(6) (C-23) added between ABS-ECU and 7 th terminal of junctionconnector (C-20) between instrumentpanel harness and control harness.
J/C(6) (C-23) added between ABS-ECU and 22 nd terminal of junctionconnector (C-22) between instrument
panel harness and control harness. ACD, AYC p.3-48 Circuit changed due to change inbranching point of connector for 4WD-ECU (C-37) (C-38) (frominstrument panel harness to controlharness).
Earth No.13 added J/C(6) (C-23) added between 4WD-
ECU and 7 th terminal of junctionconnector (C-20) between instrumentpanel harness and control harness.
J/C(6) (C-23) added between 4WD-ECU and 22 nd terminal of junctionconnector (C-22) between instrumentpanel harness and control harness.
Intercooler water spray - Change to terminal number in J/C(1)(C-07). (No.12 " No.21).
Engine immobiliser system p.3-58 Partial changes due to removal of DVD-MMCS.
Partial changes to circuit, due tochange in installation point of immobiliser ECU.
Spare general connectors - Change to terminal numbers in J/C(1)(C-07) on line linking J/B (generalfuse No.18) / special fuse No.15, and
general spare connectors. (No.7 "No.5), (No.21 " No.12).
-
8/13/2019 service manual elecrical wiring diagrams
8/76
GENERAL INFORMATION - LIST OF CIRCUIT DIAGRAMS 0-5
Main circuit Name of Circuit Circuit DiagramJ/B - !J/C - #Central junction - #Power supply - #Start up - !Ignition - !Charging - !Engine control - #Coolant - !
Headlights (excluding discharge type ) !Headlight ( discharge type) !Tail lights, side lights, licence plate lights, lighting monitor warning buzzer
!
Cabin lights, boot interior light, ignition key cylinder illumination light, door not closed indicator light *2
!
Fog lights !
Lighting
Headlight levelling system !Indicator lights, hazard warning lights !Reversing lights *2 !Stop lights #
Signalling
Horn !Meters / Gauges *2 !MetersRemaining fuel warning light, oil pressure warning light,brake warning light, seatbelt warning light *2
!
Electric windows *2 !Central door locking (vehicle not fitted with keyless entry) !
Door opening control
Central door locking (vehicle fitted with keyless entry) !Heater !Fully automatic air conditioning !
Air conditioning
Manual air conditioning #
List of Circuit DiagramsM3000006000169
Notes:1. This list of circuit diagrams indicates whether each circuit has been modified or added.2. The symbol indicates a circuit that has been modified or added. Diagrams for these circuits are included inthis supplement.3. The symbol indicates a circuit that is unchanged. Details of these circuits can be found in the existingElectrical Wiring Diagram manual (03-1 No.1036K77).4. The X symbol indicates a circuit that is unrelated to the vehicle referred to in this manual.5. The *1 symbol marks circuits whose names have been changed the previous names.6. The *2 symbol marks circuits whose J/C terminal numbers have changed. For more information, please referto the Details of Changes table above.
-
8/13/2019 service manual elecrical wiring diagrams
9/76
-
8/13/2019 service manual elecrical wiring diagrams
10/76
1-1
SECTION 1
WIRING DIAGRAMSCONTENTS
Engine transmission ..............................1-2 Instrument panel.....................................1-4
Boot interior ............................................1-6
-
8/13/2019 service manual elecrical wiring diagrams
11/76
WIRING DIAGRAMS - ENGINE TRANSMISSION1-2
ENGINE TRANSMISSIONM3010000400494
B-01 (1-black) Engine oil pressure switchB-02 (1) AlternatorB-03 (4-grey) AlternatorB-04 (1) StarterB-05 (1-black) StarterB-06 (4-black) Throttle position sensor
B-07 (2-black) Purge control solenoid valveB-08 (7-black) Airflow sensorB-12 (5-grey) Windscreen wiper motorB-13X (1) Engine speed detection connectorB-14X (5) Starter relayB-17X (4) Ignition coil relay
Connectorsymbol -
B -01 -32
AC311230AB
Control harness
Battery harness
-
8/13/2019 service manual elecrical wiring diagrams
12/76
WIRING DIAGRAMS - ENGINE TRANSMISSION 1-3
B-19X (4) Engine control relayB-20X (4) A/C compressor relayB-21 (10-black) Junction between control harness and
battery harnessB-25 (4-black) O 2 sensorB-26 (2-black) Indicator 4B-27 (2-black) Indicator 3B-28 (2-black) Indicator 2B-29 (2-black) Indicator 1
(2-grey) Wastegate solenoid valve 1B-31 (6-black) Junction between control harness andtransmission harness
(2-grey) Wastegate solenoid valve 2
Note : Boxed connector numbers indicateconnectors with changed names, or new,additional connectors.
B-32
B-32
Earth cable
Transmission harness
AC311231AB
-
8/13/2019 service manual elecrical wiring diagrams
13/76
WIRING DIAGRAMS - INSTRUMENT PANEL1-4
INSTRUMENT PANEL
C-01 (4) Register (vehicle not fitted with full autoA/C)
C-02 (2-red) Front pass. seat airbag module (squib)C-03 (7) Internal / external air changeover damper
motorC-04 (7) Junction between instrument panel
harness and A/C harness (vehicle notfitted with full auto A/C)(13) Junction between instrument panel
harness and A/C harness (vehicle fittedwith full auto A/C)
C-05 (2) Air thermo sensor (vehicle fitted with fullauto A/C)
C-06 (13) J/C (5)C-07 (22-grey) J/C (1)C-08 (6) Air mix door motor and potentiometer
(vehicle with full auto A/C)C-09 (2) Heater water temperature sensor (vehicle
with full auto A/C)C-10 (5) Blower outlet changeover damper motor
& potentiometer (vehicle with full autoA/C)
C-13 (4) ClockC-14 (4) Hazard switchC-15 (6) Blower switch
(vehicle not fitted with full auto A/C)C-16 (12-black) Heater control unit
(vehicle with heater) or A/C-ECU
(vehicle with manual A/C)C-17 (20-black) A/C-ECU (vehicle with full auto A/C)C-18 (16-black) A/C-ECU (vehicle with full auto A/C)C-20 (22-blue) Junction between instrument panel
harness and control harnessC-21 (10-grey) Junction between instrument panel
harness and control harnessC-22 (25) Junction between instrument panel
harness and control harness
Connectorsymbol
Front passengers side
Instrument panel harness
Tweeter sub-harness
Frontharness (LH)
Front doorharness (LH)
Floor
harness (LH)
A/C harness
Controlharness
-
8/13/2019 service manual elecrical wiring diagrams
14/76
WIRING DIAGRAMS - INSTRUMENT PANEL 1-5
C-23 (33) J/C (6)C-28 (2) Blower motor
(Vehicle not fitted with full auto A/C)(6) Blower pulse controller
(Vehicle fitted with full auto A/C)C-29 (13) Junction between instrument panel
harness & floor harness (LH)C-30 (11-grey*) Junction between instrument panelharness & floor harness (LH)
C-31 (25) Junction between instrument panelharness & front harness (LH)
C-32 (3) Junction between instrument panelharness & front harness (LH)
C-33 (16) Junction between instrument panelharness & front door harness (LH)
C-34 (16) Junction between control harness & frontharness (LH)
(22) 4WD-ECU
(26) 4WD-ECUC-43 (1-grey) Junction between control harness and
floor harness (LH)C-44 (2) Junction between instrument panel
harness and tweeter sub-harnessC-45 (2) Tweeter (LH)
C-49 (35-grey) Engine ECUC-50 (28-grey) Engine ECUC-51 (30-grey) Engine ECUC-55 (2) Spare connector
Note : A connector colour marked * indicates the male connector.
The female connector is black. Boxed connector numbers indicate connectors in harness
routes that have been changed.
C-38
C-37
-
8/13/2019 service manual elecrical wiring diagrams
15/76
WIRING DIAGRAMS - BOOT INTERIOR1-6
BOOT INTERIOR
F-01 (2) Boot interior lightF-02 (2-grey) High-mount stop lightF-05 (4) Rear wiper motorF-06 (2) Rear speaker (RH)F-07 (1) Demister (+)F-10 (6-black) Rear combination light (RH)F-11 (1) Book interior light switchF-12 (2-grey) Licence plate light (RH)F-13 (2-grey) Licence plate light (LH)F-14 (2-grey) Junction between floor harness (LH) &
bumper harnessF-15 (6-black) Rear combination light (LH)F-16 (2) Rear speaker (LH)
F-18 (1-black) Demister (-)F-19 (2) Windscreen washer motor
F-20 (2-green) Rear washer motorF-21 (2-black) Electrical pumpF-22 (8-grey) Junction between floor harness (LH) and
4WD harness (vehicle with AYC)F-23 (2-black) Directional valve (left) (vehicle with AYC)F-24 (2-black) Directional valve (right) (vehicle with AYC)F-25 (3-black) Proportional valve (for ACD)F-26 (3-black) Proportional valve (for AYC) (vehicle with
AYC)F-27 (3-black) Pressure sensor
(2) Spare connector
Boxed connector numbers indicate newly added connectors.
F-28
Demister earth
Floorharness (LH)
4WDharness
Bumperharness
Floor harness(RH)
Connectorsymbol
-
8/13/2019 service manual elecrical wiring diagrams
16/76
-
8/13/2019 service manual elecrical wiring diagrams
17/76
-
8/13/2019 service manual elecrical wiring diagrams
18/76
-
8/13/2019 service manual elecrical wiring diagrams
19/76
COMPONENT INSTALLATION POSITIONS - J/C3-2
J/C
Note :In an actual vehicle, any of the terminals connected in the J/Cmay be used. Therefore, the terminal numbers given in thecircuit diagrams may not coincide with the terminal arrangementin the actual vehicle.
Windscreen wiper& washer
Indicator lights,
hazard warninglights Tail lights, side
lights, licenceplate lights,lightning monitorwarning buzzer
Fog lights Headlights Headlight levelling
system Rear wiper /washer
Full autoA/C
Generalspare
connector
Clock
Spare audioconnector
Warninglights
Meter
gauge
ACD Engine
control
J/B
General fuse( )18
Generalspare
connector
Fog light
Spare audioconnector
Demister (Vehiclew/out full auto A/C)
Demister, doormirror heatingelement (vehiclewith full auto A/C)
Heater Full auto A/C
Manual A/C
Cigar lighterAshtray
illuminationlight
Clock
ACD
Headlightlevellingsystem
Indicator lightHazard
warning lights
Intercoolerwater spray
General fuse 15
Meter gauge Tail lights, side
lights, licenceplate lights,lighting monitorwarning buzzer
-
8/13/2019 service manual elecrical wiring diagrams
20/76
-
8/13/2019 service manual elecrical wiring diagrams
21/76
-
8/13/2019 service manual elecrical wiring diagrams
22/76
CIRCUIT DIAGRAMS - J/C 3-5
Electric retractableremote control door
mirrors
J/BGeneral
fuse( )11
J/BGeneral
fuse( )13
General spareconnector
Spareaudio
connector
Clock
Fog lights Spareconnectorfor fog lights
Foglights
Fog lights Spareconnectorfor fog lights
SRS airbags,seatbelt pre-
tensioners
ABS ACD
Engineimmobiliser
systemEnginecontrol
Diagnosisconnector
Cabin lights,boot interiorlight, ignitionkey cylinderillumination
light, door notproperly closedindicator light
Central doorlocking(vehicle withkeyless entry)
Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, door not
properlyclosedindicator light
Warning lights Meter gauge
-
8/13/2019 service manual elecrical wiring diagrams
23/76
CIRCUIT DIAGRAMS - J/C3-6
J/C (contd)
Diagnosisconnector
Security
alarm Security alarm Horn
Full auto A/C ABS ACD
Horn
Ignition keyreminderbuzzer
Windscreenwiper &washer
Security alarm Central door
locking
Turn signallights, hazardwarning lights
Tail lights,position lights,licence platelights, lightingmonitorwarningbuzzer
Electricstowableremote controldoor mirrors
Powerwindows
Fog lamps Headlights Rear wiper /
washer
Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, door notproperlyclosedindicator light
Enginecontrol
Enginecontrol
Ignition
Meter gauge Engine control Meter gauge Ignition
Engine immobilisersystem
Engine control Full auto A/C Cooling
Enginecontrol
Engineimmobilisersystem
Enginecontrol
Full auto A/C Cooling
Engineimmobilisersystem
-
8/13/2019 service manual elecrical wiring diagrams
24/76
CIRCUIT DIAGRAMS 3-7
(Notes)
-
8/13/2019 service manual elecrical wiring diagrams
25/76
CIRCUIT DIAGRAMS - CENTRAL JUNCTION3-8
Central JunctionM3030000300552
Fusible link (Relay box inside engine space)
No. Circuit Type Housing colour Rated current (A)
2 Full auto air conditioning;
manual air conditioning;cooling
Connector type Red 50
Forwarddirection ofvehicle
-
8/13/2019 service manual elecrical wiring diagrams
26/76
CIRCUIT DIAGRAMS - CENTRAL JUNCTION 3-9
Fusible link (Relay box inside engine space)
Power supply circuit Fuse No. Ratedcurrent (A)
IDcolour
Applied loads
Battery / Alternator (fusiblelink No. 6)
3 20 Yellow O2
sensor, secondary arecontrol solenoid valve, idlespeed control servo, ignitioncoil 1, ignition coil 2, wastegate solenoid valve 1, wastegate solenoid valve 2, airflow sensor, engine ECU,engine control relay, camposition sensor, crank anglesensor, purge controlsolenoid valve, fuel pressuresolenoid valve, radiator fancontrol relay, register (forinjector)
10 20 Yellow Fuel pump relay 3, fuel pumpregister, fuel pump & fuelgauge unit (main)
Forwarddirection ofvehicle
-
8/13/2019 service manual elecrical wiring diagrams
27/76
CIRCUIT DIAGRAMS - POWER SUPPLY3-10
Power Supply
Battery
Fusible link
Special fuse
Starter
Charging Full auto A/C Manual A/C Cooling
Full auto A/C Manual A/C Cooling
Enginecontrol
Security alarm Central door
locking(vehicles withkeyless entry)
Turn signallights, hazardwarning lights
Charging Full autoA/C
ManualA/C
Cooling
ABS ACD Stop
lights
Heater Full auto
A/C Manual
A/C
-
8/13/2019 service manual elecrical wiring diagrams
28/76
-
8/13/2019 service manual elecrical wiring diagrams
29/76
CIRCUIT DIAGRAMS - POWER SUPPLY3-12
Power supply (contd)
Fusible link 4
Ignitionswitch
Specialfuse
Intercoolerwater spray
Engine control Starter
ABS ACD SRS airbags, seat
pre-tensioners Ignition key reminder
buzzer Intercooler water
spray Windscreen wiper /
washer Warning lights Engine control Meter gauge Charging Security alarm
Central door locking
Turn signal lights,hazard warning lights
Tail lights, positionlights, licence platelights, lighting monitorwarning buzzer
Electric stowableremote control doormirrors
Power windows General spare
connectors Fog lamps Headlights Rear wiper / washer
Cabin lights, bootinterior light, ignitionkey cylinderillumination light, doornot properly closedindicator lamp
SRS airbags, seatbeltpre-tensioners
Reversing lights Rear wiper / washer
Engine controlIgnition
-
8/13/2019 service manual elecrical wiring diagrams
30/76
CIRCUIT DIAGRAMS - POWER SUPPLY 3-13
ABS ACD Intercooler water spray Windscreen wiper /
washer Turn signal lights,
hazard warning lights Tail lights, position
lights, licence platelights, lighting monitorwarning buzzer
Heater Fog lamps Full auto A/C Headlights Headlight levelling
system Manual A/C Cooling
ABS ACD
Windscreenwiper / washer
Cigar lighter,ashtrayillumination lamp
Electricstowableremotecontrol doormirrors
Spare audioconnector
Clock General spare
connector Cabin lights,
boot interiorlight, ignitionkey cylinderilluminationlight, door notproperly closedindicator lamp
Rear wiper/ washer
Cabin lights,boot interiorlight, ignitionkey cylinderilluminationlight, doornot properlyclosedindicatorlamp
-
8/13/2019 service manual elecrical wiring diagrams
31/76
CIRCUIT DIAGRAMS - POWER SUPPLY3-14
Power Supply (contd)
Fusiblelink 1
Fusiblelink 5
ABS ACD SRS airbags, seat pre-
tensioners Ignition key reminder
buzzer Windscreen wiper /
washer Engine immobiliser
system Engine control Security alarm Central door locking Turn signal lights,
hazard warning lights Tail lights, position
lights, licence platelights, lighting monitorwarning buzzer
Electric stowable remotecontrol door mirrors
Power windows Fog lamps Full auto A/C Headlights Rear wiper / washer Cabin lights, boot interior
light, ignition key cylinderillumination light, doornot properly closedindicator lamp
ACD Ignition key reminder
buzzer Windscreen wiper /
washer Warning lights Engine control Spare audio connector Clock Meter gauge Security alarm Central door locking Turn signal lights,
hazard warning lights Tail lights, position lights,
licence plate lights,lighting monitor warningbuzzer
Electric stowable remotecontrol door mirrors
Power windows General spare connector Fog lamps Full auto A/C Headlights Headlight levelling
system Rear wiper / washer
Cabin lights, bootinterior light, ignition keycylinder illuminationlight, door not properlyclosed indicator lamp
Heater Full auto
A/C Manual A/C
Powerwindows
J/BGeneral fuse( )5
Demister relay
Demister, door mirrorthermal element (vehiclewith full auto A/C)
Demister (vehiclew/out full auto A/C)
Demister, door mirrorthermal element
(vehicle with full autoA/C)
Demister (vehicle
w/out full autoA/C) Demister, door
mirror thermalelement (vehiclewith full autoA/C)
-
8/13/2019 service manual elecrical wiring diagrams
32/76
CIRCUIT DIAGRAMS - POWER SUPPLY 3-15
(Notes)
-
8/13/2019 service manual elecrical wiring diagrams
33/76
CIRCUIT DIAGRAMS - ENGINE CONTROL3-16
ENGINE CONTROLM3030000801516
Battery
Special fuse
Enginecontrolrelay
EngineECU
-
8/13/2019 service manual elecrical wiring diagrams
34/76
CIRCUIT DIAGRAMS - ENGINE CONTROL 3-17
Ignition switch
Fuelpumprelay
Fuelpumprelay
Combinationmeter
Windscreenwasher/wiper
Turn signal lights / hazard warninglights
Tail lights, positionlights, licenceplate lights,lighting monitorwarning buzzer
Fog lights Headlights Rear
washer/wiper
-
8/13/2019 service manual elecrical wiring diagrams
35/76
-
8/13/2019 service manual elecrical wiring diagrams
36/76
-
8/13/2019 service manual elecrical wiring diagrams
37/76
CIRCUIT DIAGRAMS - ENGINE CONTROL3-20
Engine Control (contd.)
Ignition
switch (ST) Engine control relay
Starterrelay
Idle speedcontrolservo Fuel
pressuresolenoidvalve
Wastegatesolenoidvalve
Engine ECU
Engine speeddetectionconnector
Power steering fluidpressure switch
-
8/13/2019 service manual elecrical wiring diagrams
38/76
CIRCUIT DIAGRAMS - ENGINE CONTROL 3-21
Engine control relay
Waste gatesolenoidvalve 2
Purge controlsolenoidvalve
Secondaryair controlsolenoidvalve
Intercooler water spray
Full auto A/C Manual A/C Cooler
Heater Full auto A/C Manual A/C
-
8/13/2019 service manual elecrical wiring diagrams
39/76
CIRCUIT DIAGRAMS - ENGINE CONTROL3-22
Engine Control (contd.)
J/BCommonfuse( )2
Fusible link 1Engine ECU
Vehiclespeedsensor
Engineimmobilizer
system
Diagnosticsconnector
Diagnosticsconnector
Front view Front view
-
8/13/2019 service manual elecrical wiring diagrams
40/76
CIRCUIT DIAGRAMS - ENGINE CONTROL 3-23
Remarks* : Windscreen washer / wiper Meter gauges Electric retractable door mirrors Generic spare connectors Cabin lights, boot interior light,
ignition key cylinderillumination light, door notproperly closed reminder light
J/B(Fuel pump relay 2)
Fuel pumprelay 3
Fuel
pumpregister
Fuel pump& fuel gaugeunit (main)
Back-uppower supply
Engine ECU
-
8/13/2019 service manual elecrical wiring diagrams
41/76
CIRCUIT DIAGRAMS - SIGNALLING3-24
Signalling
Stop lights
Battery
Generalfuse
Stop lightswitch
Rearcombinationlight (stop : LH)
Rearcombinationlight (stop : RH)
High-mountstop light
Spareconnector
-
8/13/2019 service manual elecrical wiring diagrams
42/76
-
8/13/2019 service manual elecrical wiring diagrams
43/76
CIRCUIT DIAGRAMS - AIR CONDITIONING3-26
Air Conditioning
Manual Air Conditioning
Fusible
link 1
Ignition
switch (IG2)
Blowerrelay
Blowerswitch
Register
Blowermotor
Intercoolerwater spray
-
8/13/2019 service manual elecrical wiring diagrams
44/76
CIRCUIT DIAGRAMS - AIR CONDITIONING 3-27
J/B
(general fuse) 5
J/B (general
fuse) 5
Front ECU
(tail light relay)Register
Air thermo sensor
Internal / external
changeoverdamper motor
Special fuse
Tail lights, side lights,licence plate lights,lighting monitorwarning buzzer
Meter gauge Tail lights, side
lights, licence platelights, lightingmonitor warningbuzzer
A/C switch, internal/external changeover damper motor, ILL
Demister
-
8/13/2019 service manual elecrical wiring diagrams
45/76
CIRCUIT DIAGRAMS - AIR CONDITIONING3-28
Manual Air Conditioning (contd)
Fusible link 2 Engine control relay
Radiator fan
control relay
Radiator fan controller
Input signalprocessor
Temperaturedetection
Drive circuit
Currentdetection
Equalizingcircuit
Field effecttransistor circuit
Radiator fanmotor
-
8/13/2019 service manual elecrical wiring diagrams
46/76
-
8/13/2019 service manual elecrical wiring diagrams
47/76
CIRCUIT DIAGRAMS - AIR CONDITIONING3-30
Manual Air Conditioning (contd)
Battery J/C(2)(General fuse) 5 Radiator fancontroller
A/Ccompressor
relay
General fuse
A/Ccompressor
Coolingtemperatureswitch
Magneticswitch
Dualpressureswitch
Low pressure sideON OFF: 196kPaOFF ON: 221kPaHigh pressure sideON OFF: 3138kPaOFF ON: 2550kPa
Engine ECU
-
8/13/2019 service manual elecrical wiring diagrams
48/76
CIRCUIT DIAGRAMS 3-31
(Notes)
-
8/13/2019 service manual elecrical wiring diagrams
49/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-32
Special Equipment
ABS
Fusible link 3Ignition switch
(IG2)
Ignition switch
(IG1)Battery
Generalfuse
Combinationmeter
Stop light switch
Stop lights
Solenoid valvepower supply
Motor powersupply
Powersupply
-
8/13/2019 service manual elecrical wiring diagrams
50/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-33
Note:* : Windscreen wiper / washer Engine control Meter gauge Indicator lights, hazard warning
lights Tail lights, side lights, licence
plate lights, lighting monitorwarning buzzer
Electric retractable remotecontrol door mirror
General spare connector Fog lights Headlights Rear wiper / washer Cabin lights, boot interior light,
ignition key cylinder illuminationlight, door not properly closedindicator light
Motor powersupply
Motor
Hydraulic unit
Solenoid valve
-
8/13/2019 service manual elecrical wiring diagrams
51/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-34
ABS (contd)
Ignition switch (IG2)
Front / rearG sensor
Lateral Gsensor
-
8/13/2019 service manual elecrical wiring diagrams
52/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-35
Brakewarning
light
Parking brakeswitch
-
8/13/2019 service manual elecrical wiring diagrams
53/76
-
8/13/2019 service manual elecrical wiring diagrams
54/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-37
Front : LH Front : RH Rear : LH Rear : RH
ABS sensors
-
8/13/2019 service manual elecrical wiring diagrams
55/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-38
ABS (contd)
Fusible link 1
Diagnosisconnector
Front view
-
8/13/2019 service manual elecrical wiring diagrams
56/76
CIRCUIT DIAGRAMS 3-39
(Notes)
-
8/13/2019 service manual elecrical wiring diagrams
57/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-40
ACD (Vehicle not fitted with AYC)
Fusible link 1Ignition switch
(IG2) Battery
General fuse
Stop lightswitch
Stop light
Back-uppower supply
Enginecontrol
Powersupply
-
8/13/2019 service manual elecrical wiring diagrams
58/76
-
8/13/2019 service manual elecrical wiring diagrams
59/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-42
ACD (Vehicle not fitted with AYC) (contd)
Front ECU(tail light relay)
Specialfuse
Tail lights, sidelights, licenceplate lights,lighting monitoringwarning buzzer
Meter gauges Tail lights, side
lights, licence platelights, lightingmonitoring warningbuzzer
ACDmodeswitch
Ignition switch(IG1) Windscreen wiper /
washer Engine control Meter gauge Indicator light, hazard
lights Tail lights, side lights,
licence plate lights,lighting monitoringwarning buzzer
Electric retractableremote control doormirrors
General spareconnectors
Fog lights Headlights Rear wiper / washer Cabin lights, boot
interior light, ignitionkey cylinder illuminationlight, door not properlyclosed indicator light
Combinationmeter
-
8/13/2019 service manual elecrical wiring diagrams
60/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-43
Engine ECU
Throttle positionsensor
-
8/13/2019 service manual elecrical wiring diagrams
61/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-44
ACD (Vehicle not fitted with AYC) (contd)
Fusible link 7
Electricpump
Electric pumprelay
Pressuresensor
Proportionalvalve (forACD)
-
8/13/2019 service manual elecrical wiring diagrams
62/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-45
Front : LH Front : RH Rear : LH Rear : RH
ABS sensors
-
8/13/2019 service manual elecrical wiring diagrams
63/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-46
ACD (Vehicle not fitted with AYC) (contd)
Ignition switch(IG2)
Intercooler waterspray
Heater Full auto A/C Manual A/C
Steering sensor
Front view
-
8/13/2019 service manual elecrical wiring diagrams
64/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-47
Fusible link 1
Diagnosisconnector
-
8/13/2019 service manual elecrical wiring diagrams
65/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-48
ACD, AYC
Fusible link 1Ignition switch(IG2) Battery
Enginecontrol
Back-uppower supply
Powersupply
Specialfuse
Stop lightswitch
Stop lights
-
8/13/2019 service manual elecrical wiring diagrams
66/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-49
Ignition switch(IG2)
Front /Rear Gsensor Lateral G sensor
-
8/13/2019 service manual elecrical wiring diagrams
67/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-50
ACD, AYC (contd)
Front ECU (taillight relay)
Specialfuse
Tail lights, sidelights, licence platelights, lightingmonitor warningbuzzer
Meter gauge Tail lights,
side lights,licence platelights, lightingmonitorwarningbuzzer
ACD modeswitch
Ignition switch(IG1) Windscreen wiper &
washer Engine control Meter gauge Indicator lights, hazard
warning lights Tail lights, side lights,
licence plate lights,lighting monitorwarning buzzer
Electric retractableremote control doormirrors
General spareconnectors
Fog lights Headlights Rear wiper / washer Cabin lights, boot
interior lights, ignitionkey cylinderillumination light,door not properlyclosed indicator light
Combinationmeter
Drive circuit
-
8/13/2019 service manual elecrical wiring diagrams
68/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-51
Engine ECU
Throttle position sensor
-
8/13/2019 service manual elecrical wiring diagrams
69/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-52
ACD, AYC (contd)
Brake warninglight
Parking brakeswitch
-
8/13/2019 service manual elecrical wiring diagrams
70/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-53
(Front : LH) (Front : RH) (Rear : LH) (Rear : RH)
ABS sensors
-
8/13/2019 service manual elecrical wiring diagrams
71/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-54
ACD, AYC (contd)
Fusible link 7
Electricpump
Electric pumprelay
Pressure sensor
-
8/13/2019 service manual elecrical wiring diagrams
72/76
-
8/13/2019 service manual elecrical wiring diagrams
73/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-56
ACD, AYC (contd)
Ignition switch(IG2)
Intercooler waterspray
Heater Full auto A/C Manual A/C
Steering sensor
Front view
-
8/13/2019 service manual elecrical wiring diagrams
74/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-57
Fusible link 1
Diagnosisconnector
-
8/13/2019 service manual elecrical wiring diagrams
75/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT3-58
Engine Immobiliser System
Front view
Battery
Specialfuse
Enginecontrolrelay
Engine control
Powersupply
Powersupply
EngineECU
-
8/13/2019 service manual elecrical wiring diagrams
76/76
CIRCUIT DIAGRAMS - SPECIAL EQUIPMENT 3-59
Fusible link 1Engine ECU
Immobiliser ECU
Ignition key ringantenna
ID
card
Transponder
Diagnosisconnector
Diagnosisconnector
High-frequency circuit