sm-bdd-0013e-01 bdpt-1001 bpx-2001 bd drive service manual bpx-2001 bd drive service manual 1st...

SM-BDD-0013E-01

BDPT-1001BPX-2001BD DRIVE SERVICE MANUAL 1st edition

CS DepartmentPublished in Japan © 2007. 09

– 2 –

Reproduction ProhibitedSAFETY CHECK-OUT

After correcting the original service problem, perform the following safety checks before releasing the set to the customer:

1. Check the area of your repair for unsoldered or poorly soldered connections. Check the entire board surface for solder splashes and bridges.

2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors.

3. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement.

4. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement.

5. Check the power cable for cracks and abrasion. Recommend the replacement of any such power cable to the customer.

6.ChecktheB+voltagetoseeitisatthevaluesspecified.7. Check the metal trim, “metallized” knobs, screws, and all

other exposed metal parts for AC leakage. Check leakage as described below.

CAUTION:The use of optical instruments with this product will increase eye hazard.

CAUTIONUse of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

WARNING!!

WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 25 cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK.

LEAKAGE TESTThe AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers.).Leakage current can be measured by any one of three methods.1. A commercial leakage tester, such as the Simpson 229 or

RCA WT-540A. Follow the manufacturers’ instructions to use these instruments.

2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job.

3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK !! OR DOTTED LINE WITH MARK !! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉURITÉ!!

LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.

Fig. A. Using an AC voltmeter to check AC leakage.

CAUTIONEnsure that this product is disconnected from the power plug before the laser protective housing is removed.

CLASS 1M LASER RADIATION WHEN OPEN DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

This label is located on the BD/DVD/CD Drive laser protective housing inside the enclosure.

1.5 k0.15 FACvoltmeter(0.75 V)

To Exposed MetalParts on Set

Earth Ground

BD/DVD/CD driverear-side view

here

CAUTIONRisk of Explosion if Battery is replaced by an Incorrect Type. Dispose of Used Batteries According to the Instructions.

Lithium BatteriesIf an equipment is provided with a replaceable lithium battery, the following applies:

– if the battery is placed in an OPERATOR ACCESS AREA, there shall be a warning close to the battery or in both the operating and the service instructions:

– if the battery is placed elsewhere in the equipment, there shall be a warning close to the battery or in the service instructions.

SPECIAL COMPONENT NOTICE

The components identified by mark contain confidential information.Strictly follow the instructions whenever the components are repaired and/or replaced.

– 3 –

Reproduction Prohibited

1. CIRCUIT DIAGRAM1-1. BL1-001 Board ............................................. 1-21-2. BL2-001 Board ............................................. 1-21-3. BMD-001 Board (1/4) .................................. 1-31-4. BMD-001 Board (2/4) .................................. 1-41-5. BMD-001 Board (3/4) .................................. 1-51-6. BMD-001 Board (4/4) .................................. 1-61-7. BMD-002 Board (1/3) .................................. 1-71-8. BMD-002 Board (2/3) .................................. 1-81-9. BMD-002 Board (3/3) .................................. 1-9

2. PRINTED WIRING BOARDS2-1. BL1-001 Board ............................................. 2-12-2. BL2-001 Board ............................................. 2-12-3. BMD-001 Board (Side A) ............................ 2-22-4. BMD-001 Board (Side B) ............................ 2-32-5. BMD-002 Board (Side A) ............................ 2-42-6. BMD-002 Board (Side B) ............................ 2-5

3. EXPLODED VIEWS3-1. Loading Complete Assy Section .................. 3-13-2. Loading Block Assy Section ........................ 3-23-3. Base Frame Complete Assy Section ............. 3-33-4. Top Frame Complete Assy Section .............. 3-43-5. Front Arm Assy Section................................ 3-53-6. Optical Pick-up Section ................................ 3-6

4. ELECTRICAL PARTS LIST BL1-001 Board ............................................. 4-1 BL2-001 Board ............................................. 4-1 BMD-001 Board ........................................... 4-1 BMD-002 Board ........................................... 4-4

TABLE OF CONTENTS

1-1

Reproduction Prohibited SECTION 1CIRCUIT DIAGRAM

Note:Les composants identifiés par une marque !! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.

Note on Schematic Diagram:• All capacitors are in mF unless otherwise noted.

pF: mmF 50 WV or less are not indicated except for electrolytics and tantalums.

• All resistors are in W and 1/4 W or less unless otherwise specified.

• % : indicates tolerance.

Note:T h e c o m p o n e n t s identified by mark !! or dotted line with mark !!

are critical for safety.Replace only with part number specified.

1-2


1-1. BL1-001 BOARD

CN100

BL1-001 BOARD

CN101

JL100

R100

R101 R104

R102

SE101

SE100

R105

R106

C103R110

IC100

C105

C106

R112 R113

C107

R114S100

S101

S102

Q100

JL101

R109

Q101

R111C104

R107

R108

C100

R103

C101

C102

BL2-001 BOARD

CN200

R200

D200

JL200

JL201

1-2. BL2-001 BOARD

1-3


1-3. BMD-001 BOARD (1/4)

Les composants identifiés par unemarque !! sont critiques pourla sécurité.Ne les remplacer que par une piéce portant le numéro spécifié.

The components identified bymark !! or dotted line with mark

!! are critical for safety.Replace only with part numberspecified.

C266

C265

C264

C263

C262

C261

C260

C259

C270

R114

CL112

CL111

CL109

C111

C102

C110 C108R112

R110

R278

R277

CN103

CN102C269

Q104

C114

R103

Q507

C107

L100

C109

R113

Q508

L103

C238R126

R243

R244

R245

R246 C103

C255 C257

C256 C258CN101 C254

JL110

CL106

CL105

CL104

CL103

CL102C251

CL101

JL109

CN104

C237

Q107

Q105

C234

C252

C253Q106

R102

C244

C235

C236

C273

R101

CN100

CL117

CL116

CL115R281

R100

CL113

CL114C250

R121

R122 C113

R605

C115

C141

C140

C139

R163

R231

R258

D100

R214R204

D101

C243

C245

R260

C126

R199

R201

Q109

R259

Q102

Q103

L101R162

C136C274

C117

CL135

IC103

R600

R601

C156

CL138

CL140

CL137

CL136R232

C159

C154 R187

C157

R606

CL144

CL143

R607

C158 C155CL142

C161 C162R233

R602

R603R241

C198

CL153

CL152

CL186

R250

C242C241

R284

R285

CL187

CL146

C119C176

C195

R251

R249R242

C194

R209

R223

R210

R211

C175R224

IC108

CL145

R222CL184

CL185

C240C239

R282

R283R181

C144

R171

R180

C135

C134

C133

JL108

R711

R217

R268

R269

R270

R272

R273

R218

R219

R271

C106

C105

C104

CL100

R104

R119

R118

R124

R139

R111

C101 R129

CL110

C193

C192

C191

C190

C179

CL148

CL149

CL150

CL151

C178

R230

R229

R228

R227

R240

R226

R234

R235

R236

R237

R238

R239

C183

C184

C185

C186

C187

R202 R203

C197

C203

C207

C222

R215

R206R212

R625

R626

R627 CL

155

CL15

7

CL15

9

CL16

3

CL16

5JL

166

CL16

9CL

168

CL17

0

JL17

5

JL17

6

R109

R108

R107

R106

R105

CL16

0

CL16

1

CL16

2

CL17

7

CL17

8

JL17

9

C218

CL183

CL182

C233

C223

C225

FL104

C224

R127

R133

R288

R289

R290

R291

R292

R293

C231

C228

C227

FL103

C226 C232

C219

C196

C199

CL15

4

CL15

6

R265

R267 C2

15

R299

R298

R297

R296

R295

R294

R136

R135

JL15

8

JL16

2

JL16

4

C120 R134

C118

R141 R147JL133

C122C127

R150IC101

CL128

X101

R193

R140 R130C116

R125 R128R132

R131

C124

C121

R137

R138

C221

CL16

7

R213

C182

C189

C181

C188

C200 C209

C206 C213

C217

C180

IC110

BMD-001 BOARD (1/4)

IC103

IC108

IC110

1-4


1-4. BMD-001 BOARD (2/4)

IC304

IC300

IC300

IC309

IC303

IC310

BMD-001 BOARD(2/4)R441

R308

C306C324

C343

R333

R335

R346

C346C342

R341

C345

R344C337

C341C400

R309

R310

R311 CL

303

CL30

4

CL33

9CL

340

CL34

1

CL34

2

CL34

5

CL34

4

CL34

3

CL35

8

CL36

0

CL36

1

CL36

3

CL35

7

CL35

6

R307

R306

R305

R304

R303

R302

CL321

CL320

CL319

CL318

CL317

CL316

CL314

CL313

CL312

CL441

C457

CL311

CL310

CL315

CN300

C458

R301

C301

C300

CL32

2

CL32

3

CL32

4

CL32

5

CL43

4

CL32

6

CL43

5

CL33

5

CL30

2

C303

C304

R312

C308

C309

C310

R315

C311

C313

C312 C3

99

R326

C322

C323

C326

C321

C314

R384

R405

C334

C336

CL37

2

CL37

3CL

374 C4

01

C402

CL36

7 CL36

8

CL36

9

CL39

0

CL37

1

R432

R433

CL37

6CL

302

CL37

5CL

301

CL37

7

R408

R444

CL30

5

CL43

0

R360

CL38

4

CL38

6

CL38

2

R321

R322

R327

R328

R330

IC300

R378

R377

R376

R375

R374CL436

CL431

CL432CL392

CL450

CL400

CL399

CL398

C369CL397C368

CL396C367

CL395C366

CL402R372

R371

R370

R369

R368

R367

RB312

C352

CL370 C339

R349

R348 R350

R343

R363R358

R361

R354

C355

CL378CL359

C329C359

RB309

R352

C320

CL300

R440

R439

Q300

D301D300

R323 R325

CL354

CL353

CL352R397

CL351R411

CL350R336

CL349R399

CL348R409

CL347CL346

R324

C319

C318

C316

C317

C315

C307

RB308R351

C377

CL306

C305IC301 R472

C461

R313R355

CL38

9

R364 R362

R365

R332

R329 C325

R383

R382

R381

R380

R359

R357

R438

R437

R436

R435C3

51

C350

C349

C348

C344

C340

C358

C360

C361

C362

C363

C365

CL43

3CL

385

CL38

7CL

388

CL39

3

R340

R338

C357

C356

C354

C353

R391

R392

R389

R347

IC30

3

R345

R342

C335

C333

C332

C331

C330

C328

C327

CL37

9

CL38

0

CL38

3

R452

R366

R337

R339

CL36

5

CL36

2

CL36

4R300

R388

R373

R356

R387

R386

CL437CL438

CL439

CL440

C376

C375

C374

C373

C372

C371

C370

R406R434

S300

RB301

C382

RB300

FB301

RB303

C392

C391RB302

C381

C380

C390

R401

C389

R459 R460

R458

R417

R412CL442

CL443

CL444

CL445

R422

R421

R471R415

R418

RB305

RB306

RB307 R426

R427

R425

R424

R423

R463

R414

R320

R803

C404

C405

C406

C403

R446

R447

R448

R445

R398

R396

R449

C379R450

IC308

IC310

C383R453 R454R331

R379

R451

C364

C386

CL40

5R3

93

R390

C387

R400

R402

R403

R404

X301

C395

C396

R811

R443

C397IC314

R410

R416

CL413

IC300

CL414

CL415

CL416CL417

CL418

CL419

CL420

CL421

CL422

CL423

CL424

CL425

CL426

CL427

CL428

CL429

CL40

6CL

407

CL40

8CL

409

CL41

0CL

411

CL41

2

CL330

CL329

CL328

CL327

CN301

R430

R419

R431

R420R470

RB304

R461

C450

C451

C452

C453

C454

C456

C460

C455

R462

R429R442R464

R465 R413

IC309

IC300IC300

Les composants identifiés par unemarque !! sont critiques pourla sécurité.Ne les remplacer que par une piéce portant le numéro spécifié.


!! are critical for safety.Replace only with part numberspecified.

1-5


1-5. BMD-001 BOARD (3/4)

BMD-001 BOARD (3/4)

R907

IC509

R555

C506

Q506

JL500

JL501

JL502

JL503

JL504

JL505

JL506

JL507

JL508

JL509

JL510

R508

C505R511

R529

R554

IC501

C509

R505IC502

C513

R507

R548

R513

R504

C535

IC300

C534

C533

C532

C527

C528

C529

C530

C531

C515IC505

R552

CL521

R516IC500

R546 R512

CL519

C510

S500

CL520

C512

R498

CL518

FL500

D502

IC507

C508

R553

D50

0

C537

C539

C541

C543

C570

C536

C538

C540

C542

C544

C546

C548

C550

C549

C552

C556

C554

C558

C562

C560

C564

C568

C566

C572

C574

C576

C578

C580

JL51

4

JL51

8

JL52

1

JL52

4

JL52

7

JL52

9

JL53

1

JL53

3

JL53

5

JL53

7

JL51

3

JL51

7

JL52

0

JL52

3

JL52

6

JL52

8

JL53

0

JL53

2

JL53

4

JL53

6

JL51

2

JL51

6

JL51

1

JL51

5

JL51

9

JL52

2

JL52

5

C545

C547

C551

C553

C555

C557

C559

C561

C563

C565

C567

C569

C571

C573

C575

C577

C579

C581

C609C616

R522

R521C652

R520

L505

R556

L504

FB557

C649

C619 C618

C648

R524 L507

C610

JL54

0JL

541

L506

L511

L510

L509

L508C611

C612

C613

JL542

JL543

C651

FB528

FB527C650

CN502

JL538

JL539

L514

ET501

ET502

ET503

ET504

ET505

ET506

ET507

IC506

C500 C501

R906 C523

R510

Q501

R518 R509

C606 C607 C608

IC508R523

Q502L503

C614 C615

C605

R502

R503

IC503

Q500

C507

L500

D50

1

R500

C514FB499C516C504C503R514R509

R515

FL501

FL502

FL503

C603

C602

C601

C600

C599

C598

C597

C596

C595

C594

C593

C592

C591

C590

C589

C604

IC300

C588

C587

C586

C585

C584

C583

R547

IC509

IC507

IC500

IC501

IC300 IC300

IC506

IC503

IC508

1-6


1-6. BMD-001 BOARD (4/4)

R517 R519

C638

R540

R539R538

R537

R536

R535R534

R533

R532

C637

C636

R531

R530C635

CL533

CL534

CL535

CL532

R543CL537

CL538

CL536

R545

C642

C646

C645C627

C626

IC504

R542

R541C629

C628

R544

C647

C617

C620

C639

C621

C640

C641

C622

C623

C624

C625

R551

R550

R549

CL52

2

CL52

3

CL52

4

CL52

5

C634

C633 CL

526

CL52

7

CL52

8

CL52

9

CL53

0CL

531

C644

C643

C632

C631

C630

BMD-001 BOARD (4/4)

IC504

1-7


1-7. BMD-002 BOARD (1/3)

BMD-002 BOARD (1/3)

IC110

IC108

IC103

IC110

C266

C265

C264

C263

C262

C261

C260

C259

C270R114

C101R129

C111

R111

C102

C110 C108 R112

R119

R118

R110

CN103R120

CN102

IC111

C255 C257

C256 C258

R272

C251

C237

R101

CL117

CL116

CL115R281

R121

R122 C113

C141

R163

C115

C136CL135

C135

C134

C133

C140

C139

R144

R171

C234

C252

C253

R231

R201

R204

C126

R214

D100

R258

R199

Q109

R162 L101C117

R158

R157C274

R100

C250

CL190

CL113

CL114

R102

C235

C236

C273

C244

CN104

CN100

R273

R218

R219

CN101

CL191

CL192CL106

CL105

CL104

CL103

CL102

CL101 R150

Q107

Q105 Q106

R271

R217

C269

R243 C106

R244 C105

R245 C104

R246 C103

R268

R269

R270

JL109

JL108

R104

R156 Q104

R125 R153

R126

Q111 R152

L103

C238

R103

Q110

C107

R113 R151

L100

C109

CL140

CL138

CL137

CL136

CL144

CL143

CL142

IC103

R140

R141

C156

C159

R187C154

C157

R145

R146

C158 C155

C162

C119

C175R224

R211CL188

R210

R209

R223

IC108

C194

C195

R251

R249

CL189

R206R212

R147

R148

R149 CL

155

CL16

0

CL16

1

CL16

2

R215 R213

C197

R202 R203

C187

C186

C185

C184

R239

R238

R237

R236

R235

R230

R229

R228

R227

C183

C182

C189

C181

R240

C178

C180CL151

CL150

CL149

CL148

C179

C193

C200 C209

C206 C213

C217

FL103

R292

R290

R288

R289

R127

C224

FL104

C231

C232

C233

CL183

C222

C218JL

179

JL17

6

JL17

5CL

170

CL16

9CL

168

CL16

6CL

165

CL16

3

CL15

9

CL15

7

CL16

7

C203

C207

CL17

8

CL17

7

R105

R106

R107

R108

R109

CL182

C223

C226

C225

R133

R291

R293

C227

C228

C192

C191

C190

C188

C196

C199

R265

R267 C2

15

R299

R298

R297

R296

R295

R294

R136

R135

C219

C221

CL15

4

JL15

8

JL16

2

JL16

4

CL15

6

R234R226

R242

C198

R250 CL153

C242C241

R284

R285

R241 R143

CL152

CL186

CL187

C176

CL146

CL145

CL184CL185

R142

R282

R283

C239 C240

R222R233

C161

R181 R180

C144

R232

Q103

R259

R260

D101

C243

C245

Q102

R124

R154

R155

Q112

R139

R278

R277

CL100

CL112

CL111

CL110

CL109

Les composants identifiés par une marque !! sont critiques pourla sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.


!! are critical for safety.Replace only with part number specified.

1-8


1-8. BMD-002 BOARD (2/3)

IC300IC300

IC304

IC300IC300

IC310

IC300IC300

IC309

IC303

R441

R308

CL314

R307

R306

R305

R304

R303R302

CL321

CL320

CL319

CL318

CL317

CL316

CL313

CL441

CL322

CL315

CL310

CL311R301

C457

C458

CN300

CL323

CL324

CL43

4

CL32

6

CL43

5

CL33

5C3

02

C303

C304

R312 R4

72

C306

C308

C309

C310

R473

R315

R384

CL36

2

CL36

4

CL36

5

CL36

7 CL36

8CL

369

R432

CL30

1

CL30

2

CL37

5

CL37

6

C401

C402

CL30

5R4

33

R444

R408

CL43

0

CL37

7

CL37

9CL

380

CL38

3

CL38

4

CL38

6

R360

R321

R322

R327

R328

R330

R478

R489CL

382

R337

R339

CL39

0CL

371

CL37

2

CL37

3

CL37

4

C334

C336

R452

R366

R476

R378

R377

R376

R375

R374

R372

R371

R370

R406 R434

S300

R369

R368

R367

R383

R382

R381

R380

R359

R357

R438

R437

R338

R340

R436

R435

R475C3

35

R347

R342

R389

C340

C344

C347

C348

C349

C350

C351

C327

C328

C330

C331

C332

C333

C353

C354

C356

C357

R391

R392

C358

C360

C361

C362

C363

C365

CL46

3CL

433

CL38

5CL

387

CL38

8CL

393

C313

C312

C314

R326

C321 C3

22

C323

C465

C399

C326

C311

CL325

CL312

D300

R323 R325

D301R324

R439

R440

R397

R411

R336

R399

R409

CL300

CL453

CL454

CL455

CL456

CL354

CL353

CL352

CL351

CL350

CL349

CL348CL347

CL346

R331 R453 R485

IC310

R451

C383

R449

R396

X301C395

R416CN301

R463

R423

R424

R425

R426

R427

R430

R419

R431

R420

R421

R471

CL445

CL444

CL443

CL442R412

R417

R458

R461

R462

C450

C451

C452

C453

C454

C456

C460

C455

R470

R415

R418

R422

C396 R443

R398

C386

CL40

5R3

93

R400

R402

R403

R404

CL45

8

CL45

9

CL40

6

CL40

7

CL40

8

CL40

9

CL41

0

CL41

1

CL41

2

CL429

CL428

CL427

CL426

CL425

CL424

CL423

CL422

CL421

CL420

CL419

CL418

CL417CL416

CL415

CL414

CL413

CL437 R487

R486

R488

CL438

CL439

CL440

R300

C375

C374

C372

C371

C370

R388

R387

R386

C382

C392

FB301

R401

R479

R480

R481

R482

R483

R484

RB304

RB307

RB306

RB305

RB303

C391

C390

C389

RB300

RB301

RB315 RB316RB314RB313

IC309

C381

RB302

C380

R465

R464

R459 R460

R442

CL436

CL431

CL432CL392

CL450

CL400

CL399

CL398

RB312

CL37

0

IC30

3

C339

C352

RB309RB308

C307R352

R351

R349R343

R348R350

R363

R361R354

C355CL378

R358

CL397C368

CL396C367

CL395C366

C369

CL402

R332

R329 C325

C359 C329 CL359

R379

IC304

C337 R344

R346

R333

C343

RB317R474

CL36

3

CL36

1

CL36

0

CL35

8

C466

C305

C315

C316

C467CL

343

CL34

2

CL34

1

CL46

2

CL46

1

CL46

0CL

304

CL30

3

R309

R310

R311

R335

C342C346

C464

C341C463

C400

C462

R373

R356

C364

Q300

BMD-002 BOARD (2/3)

Les composants identifiés par une marque !! sont critiques pourla sécurité. Ne les remplacer que par une piéce portant le numéro spécifié.


!! are critical for safety.Replace only with part number specified.

1-9


1-9. BMD-002 BOARD (3/3)

BMD-002 BOARD (3/3)

IC509

IC507

IC500

IC510

IC501

IC300 IC300

IC508

IC503

IC509

C506

R508

R511

C511

R532

IC507R530

R504

R552 D502

C508

IC500

IC501

R516

CL521

CL518

CL520

D500

R512

CL519R546

C510

S500

C512

R505

R537

IC503

C507

R503

R502

Q500

L500 R500

C514FB500C516C502C504C503R506D50

1

R514

R515

R531IC506

C500 C501

R510

R518 R509

Q503

C523

R536 C605 C606 C607 C608

IC508Q502

R523 L503

C609

C616

C652

R522

R521

R520

L505

R556

L504

FB557

C649 C648

JL546

JL547

JL548

JL549

L514

L508

C613

C612

C611

C610

C650FB527

L507R524

L506

FB528

C651

CN502

C618C619

C614 C615

JL538

JL54

0

JL54

1

JL539

JL542

L511

L510

L509

JL543

FL500

FL501

FL502

FL503

IC300

C584

C583

JL51

3

JL51

7

JL52

0

JL52

3

JL52

6

JL52

8

JL53

0

JL53

2

JL53

4

JL53

6

JL51

4

JL51

8

JL52

1

JL52

4

JL52

7

JL52

9

JL53

1

JL53

3

JL53

5

JL53

7

JL51

2

JL51

6

JL51

9

JL52

2

JL52

5

JL51

1

JL51

5

R513

R553

IC510

IC511

R547

C509

R535

R534

R538R533

C653

C535

C534

C533

C532

C531

C530

C529

C528

C527

C537

C539

C541

C543

C545

C547

C551

C553

C555

C557

C559

C53

6

C53

8

C54

0

C54

2

C54

4

C54

6

C54

8

C54

9

C55

0

C55

2

C55

4

C55

6

C55

8

C56

0

C56

2

C56

4

C56

6

C56

8

C57

0

C57

2

C57

4

C57

6

C57

8

C58

0

IC300

R557R558

C655

R539

C505

R529

R554

JL500

JL501

JL502

JL503

JL504

JL505

JL506

JL507

JL508

JL509

JL510

2-1

Reproduction Prohibited SECTION 2PRINTED WIRING BOARDS

Note on Printed Wiring Boards:• :Patternfromthesidewhichenablesseeing. (Theotherlayer’spatternsarenotindicated.)

Caution: Patternfaceside:Partsonthepatternfacesideseen (SideB) fromthepatternfaceareindicated. Partsfaceside: Partsonthepartsfacesideseen (SideA) fromthepartsfaceareindicated.

2-1. BL1-001 BOARD 2-2. BL2-001 BOARD

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7

BL1-001 BOARD (SIDE B)

BL1-001 BOARD (SIDE A)

1-871-576-

1-871-576-

Q10

1

Q100

R111

C10

4

R109

R107

R112

C10

1

C10

7

C10

5

R104

R100

C10

0

C106

R101

SE101

S101

S100

SE10

0

R102

S102

CN101

CN

100

R103

R113

IC10

0

R114

R110 C103

R105

R108 R106

C102

1323

1323

1

A

B

2 3 4 5

CN200

R200

D200

BL2-001 BOARD (SIDE A)

BL2-001 BOARD (SIDE B)

1-871-577- 1-871-577-1323

1323

2-2


2-3. BMD-001 BOARD (SIDE A)

1

A

B

C

D

E

F

G

2345678910111213

R323

R409

R439

R401

RB303

R453

IC310 IC308

R454

RB302

R450

C379R449C383

R404

R402

C397

IC314R406

R434

S300

R398

X301

IC304

C405

R448

C403

R447

R445

R393

C395 R396 C396

C404

R320

RB300 RB301

IC300

R325D301

D300

C455 CN102

R376

R345 C325

R392

R361

R112

C196

C199

R363R358R348

CN103

C102 C108 C110

R391

R135R136R294

R295

R296R297

R298

R299

R309R310

R311

R302

R303

R306

R307

C621

C620

C617

C638 C636

IC504 R906L505

FB557

L504

D100

R510

R556

L503C614

C616 IC508C500

C126

R259 R603

C241

C195Q102

C198

R250

R209

R222

R602R211R210

R249R251

D502

R513

R512

R498

C512

IC501

C510

IC500 R268 C236R218

R273

R272

R217R271

R269C235

C234

R518

R509

C615

Q106

C627

R214R544

R106

R105R107

R181

C158

C157

IC103

C274C141

C140C139R605

R101

C186

R100R281

C250

C187

R626

R627

R102

CN100

C136

R162

C305 R313

C461

IC505 C513R507

R505

C253R270

C244

L101

C161

C162

R109

R108

R212R213R215R206

C155

C240

R180

R545

R308

R541

R542

R543

C222

IC110

C209

C213

D10

1

R223

Q10

3

R233

C144

R121

R122

C113

R907C1

97

ET50

5

C203

C207

R118

R119

R111 R1

04

R277

R278

R110

R227

C339

R343

R349

R114

R350

R354

C355

R228

R229

R230

R235

R236

R237

R238

R239

R226

ET50

4

R260

C633

ET50

2

R199 Q

109

R201

R284

R552

R283

R601

R600

R171

C133

IC30

1

IC50

2

L514

C252

CN10

1

C251

C254

ET50

6

R711

Q10

5

R219

C273

R548

C515

R504

C134

D50

0

C154

R187

S500

R547

C509

R546R2

58

C644

C632

C630

IC50

6C501 C6

49 C619

C508

IC50

7

R553R2

04

R522

R521 C5

23

R520

C608

C607 C6

06

C605

Q50

1

C648 C6

18

C652

C609

R523

Q50

2

R531

R530

ET50

3

C457

C458

R540

R538

R536

R534

R532

C623

C641

C310

C322

C321C314

C312 C313

RB309

R364

R365

R362

R389

C303R347

R375

R327

CN301

ET507

R423

R360

R422

R412

R374

C304R3

12C3

57C3

56C3

62

R332

R329

C329

C359

C377

R355

R321

R322

R368

R367

R380

R381

R437

R438

C349

C350

C344

R326

C215

C331

C332

C335

C311

C309

R315

C337

C341

R344

C200

C190

C191

C192

C193

R625

IC30

3

C361

R417R4

21

R420

R419

R431

R430

R424

R425

R426

R427

R442

R458

R460

R462

R459

C402

C401

R408

R432

R433

R444

C389

C380

C391

C392

C381

C382

R451

R331

R403R4

00

R811

R410

R300

R803 R4

46

R390

C387

C406

ET50

1

RB30

6RB

307

IC30

9

Q30

0

FB30

1

C390

R461

1-871-575- 142434

BMD-001 BOARD (SIDE A)

2-3


2-4. BMD-001 BOARD (SIDE B)

1

A

B

C

D

E

F

G

2 3 4 5 6 7 8 9 10 11 12 13

R524

FB527

C610

L507 L506

R472

C650

CN50

2

C651

FB52

8

C613

L511

L509

Q107

C611

L510

C239

R232C159

C156

C135

R163

R554

C185C184

C189

R234

R139 R124

C101

C269

C178 C180

Q507

C107Q508

R103C238

C114R126

R113R265

R267

C179

C183R240

C505C506

IC509

R508

R282

C612

IC108

R147 C122

R141C118 C124

R137

C629C628

C226

C223

C233 C232 C231

L103

L100 FL103

C109

C228 C227 R293

R292

C642

C645

C626

C635 C637

C647

CN300

R441

R379

R386

C538

R388C374 C556

R305

C548

R301

C373

C560

C601C602

C603

C533

FL502

C534

C535C537

C306C342

R333

R335

C346

C541

C578C577C539C532C551C559

C555

C553

C348

C557

C351C371C542

C317C343

C323

C307R352C340

R202

RB312

C300

R378R377R328R330

R366

R452R405

R336

R397

R399C315

C573

C550

C399C372

R324

C576

C561

C575

C590

C565

C591

FL500

C570

C567

C536

C302R342

R351

RB308

C588

C589

C569

C571

C572

C549

C319 C544

C568

R443C386

C554

R138

C121R193

R140

R131R132

IC101

R128

X101

R241

R285

R515

C507

R503

Q50

0

R502

IC50

3D

501

R506

R514

C503

R516

C242

R606

C115

R511

C182

C181

C188 R1

29C1

11

C260

C259

C261

C262

C263

C264

C265

C266 C2

70

C255

C256

C257

C258

R555 Q

506

Q10

4

C218

C104

C103

C175

R224

C194

R242

R243

R245

R246

R529

R231 C1

17

R607

R244

C105

C119

C176

C106

C504 C5

16

C243

C245

R150

C127

R134

C120

C116

R125

R130

R533

R535

R537

R539

R519

R517

C640

C622

C624

C540

R387 C5

58C625

C639

C634

C643

C631

R551

R550

R549

C646

R127

R133

R288

R289

R290

R291

C224

C219

C217

C221

R346

C308

R304

FL50

3

C564

C301

C552

C324

C370

C352

C604

C326

C328

R341

C206

C375

C345

C400

C333

C327

C330

R203 C3

54

R435

C360

C358

C365

C363

R359

R357

R383

C595

C547

C531

C527

C545

C528

C530

C543

FL50

1 C594

C529

C593

C592

C574

C316

R411

R382

R372

R370

C353 R3

40

R338

C369

C368

C367

C366

C454

C460

C456

C452

C450

C451

C453

R464

R429

R413

R465

C334

R339

R337

R440

C376

R384

C562

RB30

5RB

304

C566

C336

R470

R471

R415

R463

R414

R416

R418

R369

R371

R436

C546

C600

C599

C598

C597

C596

C587

C586

C585

C584

C583

C581

C580

C563

C579 C3

18

C364

R373

R356

C320

C225

FL10

4

L500

R500

FB49

9

C514

L508

C237CN

104

BMD-001 BOARD (SIDE B)

1-871-575- 142434

2-4


2-5. BMD-002 BOARD (SIDE A)

1

A

B

C

D

E

F

G

2345678910111213

1-874-277- 132333

BMD-002 BOARD (SIDE A)

R400

R401

R402

R403

R210

R404

R211

R212

R406

R213

R408

R214

R215

R409

R217

R218

R219

C273

R412

R222

R223

R417R419

R226

R227

R228

R229

R420

R421

R422

R423

R230

R424

R425

R426

R427

R233

R235

R236

R237

R238

R239

C200

R430

R431

R432

R433 C2

03

R434

C207

R437

R438

R439

C209

C401

R249

C402

R442

C213

R443

R444

R250

C215

R251

R449

R258

C605

R259

C606

C607

C608

C609

R451

C222

R453

R260

R458

R459

R268

C614

R269

C615

C616

R460

C618

C619

R461

R462

R270

C234

R271C235

R272

C236

R273

R277

R278

C240

C241

R472

R473

C244

R474

R281

R475

R283

R284

C250

C251

C252

C253

R483

R485

R486

R487

R294

R488

R295

R296

Q102

R297

Q10

3

R298

Q10

5

R299

Q106

C648

Q10

9

C455

C649

C457

Q30

0

C458

C652

Q112

L101

RB300 RB301

Q50

2

RB302

Q50

3

RB303

C274

RB30

6RB

307

RB309

RB31

6

RB31

7

L503

L504

L505

L514

FB30

1

R100R101

R102

R104

R105

R106

R107

R108R109

R300

R302

R303

R110

R111

R306

R112

R307

R308

R114

R309

R118

R119

R310

CN100

R504

CN10

1

R311

R505

R312

CN102CN103

R120

R315

R509

R121

R122

R510

CN301

R512

R513

R321

R322

R323

R518

R325

R326

R327

R135

R329

R136

R520

R521

R522

R523

R331

R332

C102

R333

R140

R335

R141

R142

R143

C108

R144

R147

R530

R148

R531

R149

R532

C303

C304

C110

R536

R343

C113

R537

R150

C309

R346

R347

R348

C500

R154

R349

C501

R155

R156R157

C310

R158

X301

C311

C312C313

C314

R350

C508C509

R546

FB557

R547

R354 R162

C126

R358

C510

C512

C321

C322

R552

C323

R553

R360

S300

R361C325

R556

R363

C133

C134

C329

R171

C136

R367

R368

C139

C523

S500

C140

C335

C141

R374

C144

R180

R375

C339

R181

R376

R187

C342

C344

R380

R381

C346

C154

C155

C157

C158

R389

R199

C351

D100

R391

D101

C355

C161

R392C3

56

C162

C357

R393

C359

R396 R398

D300 C361

D301

C362

D50

0

JL54

6

D502

JL54

7

JL54

8

JL549

IC103

C186

C187

IC300

C380

C381

C382

IC30

3

C383

C190

IC304

IC11

0

C191

IC111

C192

C193

IC30

9

C389

C195

C196

C197

IC500

C198

C199

IC501

C390

IC310

C391

C392

IC50

6

IC50

7

IC508

C395 C396

R201

R204

R206

R209

2-5


2-6. BMD-002 BOARD (SIDE B)

1

A

B

C

D

E

F

G

2 3 4 5 6 7 8 9 10 11 12 13

BMD-002 BOARD (SIDE B)

1-874-277- 132333

R411

R415

R416

R224

R418

R231

R232

R234 R240

R435

R241

R436

R242

C206

R243

R244

R245

R246

C400

R440

R441

C217

C218

C219

C221

R452

C223 C224

C225

C226

C227C228

C610

R265

C611

C612

R267

C613

C231C232

R463

C233

R464 R465

C237

C238

C239

R470

R471

C242

C243

C245

R282

R476

R478

R285

R479R288

R289

R480

R481

R482

R290

R484

R291

C255

R292

C256

R293

C257

C258

C259

R489

Q10

4

C450

C451

C452

Q107

C453

C260

C454

C261

C262

C456C2

63C2

64C2

65C2

66

C650

Q110

C651

C269

Q111

C653

L100

C460

C655

C462

C463

L103

C464Q50

0

C270

C465

C466

C467

RB30

4RB

305

RB308

RB312

RB31

3

FL103

RB31

4

L500

FL104

RB31

5

L506L507

L508

L509

L510

L511

FL500

FL50

1

FL502

FL50

3

R103

FB50

0

R301

R304

R305

R113

R500

R502

R503

R506

CN104

R508

R124

R125

R126

R127

CN300

R129

R511

R514

R515

R516

FB527

FB52

8

R324

R133

R328

CN50

2

R139

R524

R330

C101

C103

C104

C105

R529

C106

R336

C107

R337

R338

R339

C109

R145

R146

C302

R533

R340

R534

C111

R535

C305

C306

R342

C307

C308

R344

R538

C115

R151

R539

R152

C117

R153

C119

C502

C503

C504

C505C506

C507

R351

C315

R352

C316

R356

R357

R163

R359

C511

C514

C516

R554

C326

R557

C327

R558

C328

C135

R366

R369

C330

C331

C332

C333

C527

R370

C528

C334

R371

C529

C336

R372

C337

R373

R377

R378

C530

R379

C531

C532

C533

C340

C534

C341

C535

C536

C343

C537

C538

C539

R382

C347

R383

C348

R384

C349

C156

R386

R387

C540

R388

C159

C541

C542

C543

C350

C544

C545

C352

C546

C353

C547

C548

C354

C549

C358

R397

C550

C551

R399

C552

C553

C360

C554

C555

C556

C363

C557

C364

C558

C365

C559

C366

C367

C368

C369

C175

C176

C178

C560

D50

1

C179

C562

C370

C564

C371

C566

C372

C180

C374 C5

68

C181

C375

C182

C183

C184

C185

C188

IC108

C570

C189

C572

C574

C576

C578

C386

C194

C580

IC50

3

C583

C584

IC509

C399

IC510

IC51

1

R202

R203

3-1

Reproduction Prohibited SECTION 3EXPLODED VIEWS

3-1. LOADING COMPLETE ASSY SECTION

NOTE:• Themechanicalpartswithnoreference numberintheexplodedviewsarenotsupplied.• Accessoriesaregiveninthelastofthis partslist.

Thecomponentsidentifiedbymark !! ordottedlinewithmark

!! arecriticalforsafety.Replaceonlywithpartnumberspecified.

Lescomposantsidentifiésparunemarque !! sontcritiquespourlasécurité.Nelesremplacerqueparunepiéceportantlenumérospécifié.

NOTE:•SCClassification:S:SuppliedpartsU:Unsuppliedparts

CAUTIONUseofcontrolsoradjustmentsorperformanceofproceduresotherthanthosespecifiedhereinmayresultinhazardousrediationexposure.

SC Ref. No. Part No. Description Remark

S !! 1 9-910-001-47 LOADING COMPLETE ASSYU 2 A-1203-908-A LOADING BLOCK ASSYS 3 2-894-364-02 SPRING (MD), LEAFS 4 3-948-339-12 SCREW, TAPPINGU 5 3-074-552-02 0 PLATE 2 MAIN 2X5 S TITE

S 6 1-834-594-11 CABLE, FLEXIBLE FLAT (FFC-60)S 7 2-698-708-02 CUSHION (PWB)S 8 A-1267-249-A BMD-001 COMPL (SERVICE)S 9 X-2177-119-1 SHIELD ASSY (MD)

• LOADING COMPLETE ASSY (1.5G)

S !! 1 A-1433-712-A LOADING COMPLETE ASSY (1.5G)U 2 A-1203-908-A LOADING BLOCK ASSYS 3 2-894-364-02 SPRING (MD), LEAFS 4 3-948-339-12 SCREW, TAPPINGU 5 3-074-552-02 0 PLATE 2 MAIN 2X5 S TITE

S 6 1-834-594-11 CABLE, FLEXIBLE FLAT (FFC-60)S 7 2-698-708-02 CUSHION (PWB)S 8 A-1433-743-A BMD-002 COMPL (SERVICE)S 9 X-2177-119-1 SHIELD ASSY (MD)


Thecomponents identifiedbymark containconfidentialinformation.Strictly followthe instructionswhenever thecomponentsarerepairedand/orreplaced.

12

3

4

4

5

5

6

8

7

9

• LOADING COMPLETE ASSY


3-2


3-2. LOADING BLOCK ASSY SECTIONSC Ref. No. Part No. Description Remark

S 51 9-910-001-52 COVER ASSY, TOPU 52 2-698-683-01 YOKE (CHUCK PULLEY)U 53 1-471-407-11 MAGNETU 54 2-698-682-02 PULLEY, CHUCKS 55 3-948-339-12 SCREW, TAPPING

S 56 A-1204-033-A FRAME COMPLETE ASSY, TOPS 57 2-647-360-61 SCREW (B2), TAPPINGS 58 A-1204-035-C ARM ASSY, FRONTU 59 A-1203-909-A FRAME COMPLETE ASSY, BASES 60 2-888-817-01 LABEL, LASER CAUTION

S 61 3-069-212-01 TAPE, HARNESS STOPPERS 62 A-1204-038-B PULLEY ASSY, CHUCK

5152

53

54

55

55

55

62

56

61

57

59

60

58

3-3


3-3. BASE FRAME COMPLETE ASSY SECTIONSC Ref. No. Part No. Description Remark

U 101 X-2149-112-1 ARM SUB ASSY, SWINGU 102 2-698-620-01 GEAR (SWING ARM)U 103 2-698-633-01 WASHER (GEAR)S 104 2-059-635-11 SCREWU 105 2-698-466-01 GEAR (A)

U 106 2-698-467-01 GEAR (CAM DRIVING)U 107 2-698-652-01 SPRING (SLIDE CAM), COMPRESSIONS 108 2-698-624-02 CAM (L), SLIDES 109 2-698-629-01 BRACKET, MOTORS 110 X-2149-103-1 MOTOR ASSY, LOADING

U 111 2-698-465-01 WHEEL, WORMU 112 2-647-360-61 SCREW (B2), TAPPINGU 113 2-698-630-01 SPRING (BU HOLDER), LEAFS 114 A-1267-250-A BL1-001 COMPL (SERVICE)S 115 1-833-249-11 CABLE, FLEXIBLE FLAT (FFC-014)

U 116 2-698-653-01 SPRING (BU HOLDER), EXTENSIONS 117 2-890-570-01 LABEL, SERIAL NUMBERS 118 2-698-625-02 CAM (R), SLIDEU 119 2-698-626-02 FRAME, BASEU 120 2-698-664-01 SPRING (SHUTTER ARM), TORSION

U 121 2-698-623-01 ARM, SHUTTERS 122 2-698-628-01 ARM, LINKS 123 A-1203-919-D BASE FRAME ASSYS 124 3-069-212-01 TAPE, HARNESS STOPPERU 125 2-698-631-02 SHEET (BASE FRAME)

U 126 2-698-617-01 GEAR (SHAFT R)U 127 2-698-621-01 SLIDER (SHUTTER), LOCKU 128 2-698-622-01 LEVER (SHUTTER), LOCKU 129 2-698-654-02 SPRING (LOCK SLIDER), EXTENSIONU 130 2-698-618-01 GEAR (BELT)

S 131 2-698-651-01 BELT (FRONT ARM)S 132 2-698-650-01 GEAR (SHAFT L)U 133 2-698-619-01 GEAR (IDLER)S 134 2-698-666-01 COVER, BOTTOMS 135 A-1203-920-A ARM ASSY, SWING

U 136 A-1204-032-B FRAME SUB ASSY, BASES #1 7-627-554-38 SCREW, PRECISION +P 2X1.8 TYPE1

117

101

102

135

103

104

104

#1

104

104

104

105

106

107

107

136

108

109

110

111

112

113

112

119

123

114

115

116118

OPTICAL PICK-UP SECTION

120

121

122

124

124

125

134

126

127

128

129

130131

132

133

3-4


3-4. TOP FRAME COMPLETE ASSY SECTIONSC Ref. No. Part No. Description Remark

S 151 2-059-635-11 SCREWU 152 2-698-660-02 ARM (REAR GUIDE), LOCKU 153 2-698-686-01 SPRING (LOCK ARM), TORSIONU 154 2-698-656-02 ARM (L), CHUCKS 155 1-964-978-11 HARNESS, 2PIN CONNECTOR (LED)

U 156 A-1205-601-A BL2-001 COMPLU 157 2-698-655-03 FRAME, TOPU 158 2-699-485-01 SPRING (REAR GUIDE ARM), TORSIONU 159 2-698-661-02 ARM, REAR GUIDEU 160 2-889-123-03 ARM (A), DETECTION

U 161 2-698-687-01 SPRING (CHUCK ARM), EXTENSIONU 162 2-698-657-04 ARM (R), CHUCKU 163 2-698-685-01 SPRING (SUPPORT ARM), TORSIONU 164 2-698-658-01 ARM, SUPPORTU 165 2-698-663-01 SHUTTER

U 166 2-889-118-01 HOOK (SHUTTER)U 167 2-698-665-01 SPRING (SHUTTER), TORSIONU 168 2-889-128-02 SHEET, FRAME TOPS 169 3-069-212-01 TAPE, HARNESS STOPPERU 170 A-1204-034-H FRAME ASSY, TOP

U 171 2-698-662-01 ROLLER (REAR GUIDE)

151

151

151

151

151

154

155156

157

158

159

160

171161

162

163

164

165

166

167

168

169

170

152

153

3-5


3-5. FRONT ARM ASSY SECTIONSC Ref. No. Part No. Description Remark

U 201 2-698-697-02 LOCK (FRONT ARM L)U 202 2-698-699-03 SPRING (LOCK FA), TORSIONU 203 2-698-688-04 BRACKET (FRONT ARM)U 204 2-698-698-02 LOCK (FRONT ARM R)U 205 2-698-694-01 ARM (FB), LINK

U 206 2-698-633-01 WASHER (GEAR)U 207 2-698-710-01 SPRING (FRONT ARM), TORSIONU 208 2-698-693-01 ARM (FA), LINKU 209 2-698-691-02 GEAR (FRONT ARM)U 210 2-698-692-02 GEAR (ROLLER)

U 211 2-698-690-02 ARM (R), FRONTU 212 2-698-689-02 ARM (L), FRONTU 213 2-698-695-02 ROLLER, RUBBER

201 204

205

206

206

208

207

209

211

210

213

210

213

212

209

209

209

202

202203

3-6


3-6. OPTICAL PICK-UP SECTIONSC Ref. No. Part No. Description Remark

S !! 251 8-820-372-03 DEVICE, OPTICAL KEM400AAA/J1NP1S 252 2-698-669-01 SCREW, STEPS 253 2-698-668-01 INSULATORS 254 2-698-627-01 HOLDER, BUS 255 1-833-247-11 CABLE, FLEXIBLE FLAT (FFC-019)

S 256 1-833-248-13 CABLE, FLEXIBLE FLAT (FFC-045)

Lescomposantsidentifiésparunemarque0sontcritiquespourlasécurité.Nelesremplacerqueparunepiéceportantlenumérospécifié.

Thecomponentsidentifiedbymark0ordottedlinewithmark0arecriticalforsafety.Replaceonlywithpartnumberspecified.

254

255

256

252

252

251

253

253

4-1

Reproduction Prohibited SECTION 4ELECTRICAL PARTS LIST

NOTE:• Duetostandardization,replacementsin thepartslistmaybedefferentfromthe partsspecifiedinthediagramsorthe componentsusedontheset.• RESISTORS METAL:Metal-filmresistor. F:nonflammable• SEMICONDUCTORS Ineachcase,u:m,forexample: uA..:mA..uPA..:mPA.. uPB..:mPB..uPC..:mPC..uPD..:mPD..• CAPACITORS uF:mF• COILS uH:mH



S A-1267-250-A BL1-001 COMPL (SERVICE) *************

< CONNECTOR >

U CN100 CONNECTOR, FFC/FPC (ZIF) 14PU CN101 CONNECTOR 2P

< TRANSISTOR >

U Q100 TRANSISTOR 2SC4081T106QU Q101 PHOTO SENSOR CPT-184S-C-TU-BCD

< RESISTOR >

U R107 METAL CHIP 100K 0.5% 1/16WU R109 METAL CHIP 1K 0.5% 1/16WU R111 METAL CHIP 10K 0.5% 1/16W

< SWITCH >

U S100 SWITCH, PUSH (1 KEY)U S101 SWITCH, PUSH (1 KEY)U S102 SWITCH, PUSH (1 KEY)*****************************************************************

U BL2-001 COMPL *************

< CONNECTOR >

U CN200 PIN, CONNECTOR 2P

< DIODE >

U D200 LED CL-200IR-X-TU

< RESISTOR >

U R200 METAL CHIP 220 0.5% 1/16W*****************************************************************

S A-1267-249-A BMD-001 COMPL (SERVICE) **************

< CAPACITOR >

U C101 CERAMIC CHIP 0.1uF 10% 10VU C102 CERAMIC CHIP 0.1uF 10% 10VU C103 CERAMIC CHIP 0.001uF 10% 50VU C104 CERAMIC CHIP 0.001uF 10% 50VU C105 CERAMIC CHIP 0.001uF 10% 50V



U C106 CERAMIC CHIP 0.001uF 10% 50VU C107 CERAMIC CHIP 47uF 20% 6.3VU C108 CERAMIC CHIP 0.1uF 10% 10VU C109 CERAMIC CHIP 0.1uF 10% 10VU C110 CERAMIC CHIP 0.1uF 20% 16V

U C113 CERAMIC CHIP 0.1uF 10% 10VU C114 SHORT CHIP 0U C115 CERAMIC CHIP 0.1uF 20% 16VU C117 CERAMIC CHIP 0.1uF 20% 16VU C119 CERAMIC CHIP 0.1uF 20% 16V

U C126 CERAMIC CHIP 2.2uF 20% 16VU C133 CERAMIC CHIP 22uF 20% 16VU C135 CERAMIC CHIP 0.1uF 20% 16VU C136 CERAMIC CHIP 470PF 10% 50VU C139 CERAMIC CHIP 0.01uF 10% 25V


U C156 CERAMIC CHIP 0.1uF 20% 16VU C157 CERAMIC CHIP 0.1uF 10% 10VU C158 CERAMIC CHIP 0.1uF 20% 16VU C161 CERAMIC CHIP 0.1uF 20% 16VU C162 CERAMIC CHIP 10uF 10% 16V



U C186 CERAMIC CHIP 0.1uF 10% 10VU C187 CERAMIC CHIP 0.1uF 10% 10VU C188 CERAMIC CHIP 0.001uF 10% 50VU C189 CERAMIC CHIP 0.1uF 10% 10VU C190 CERAMIC CHIP 47PF 5% 50V

U C191 CERAMIC CHIP 47PF 5% 50VU C192 CERAMIC CHIP 100PF 5% 50VU C193 CERAMIC CHIP 100PF 5% 50VU C194 CERAMIC CHIP 0.01uF 10% 25VU C195 CERAMIC CHIP 0.1uF 10% 10V

U C196 CERAMIC CHIP 100PF 5% 50VU C197 CERAMIC CHIP 0.1uF 10% 10VU C198 CERAMIC CHIP 10uF 10% 16VU C199 CERAMIC CHIP 100PF 5% 50VU C200 CERAMIC CHIP 0.1uF 10% 10V



U C222 CERAMIC CHIP 0.1uF 10% 10VU C223 CERAMIC CHIP 0.22uF 10% 6.3VU C224 CERAMIC CHIP 0.1uF 10% 10VU C225 CERAMIC CHIP 100PF 5% 50VU C226 CERAMIC CHIP 0.1uF 10% 10V


U C235 CERAMIC CHIP 0.1uF 10% 10VU C236 CERAMIC CHIP 0.1uF 10% 10VU C237 CERAMIC CHIP 100PF 5% 50VU C238 CERAMIC CHIP 22uF 20% 16VU C239 CERAMIC CHIP 0.1uF 10% 10V

U C240 CERAMIC CHIP 0.1uF 10% 10VU C241 CERAMIC CHIP 0.1uF 10% 10VU C242 CERAMIC CHIP 0.1uF 10% 10VU C243 ELECT CHIP 220uF 20% 16VU C244 CERAMIC CHIP 0.001uF 10% 50V



U C307 CERAMIC CHIP 470PF 10% 50VU C308 CERAMIC CHIP 0.1uF 10% 10VU C310 CERAMIC CHIP 0.0068uF 10% 16VU C311 CERAMIC CHIP 0.1uF 10% 10VU C312 CERAMIC CHIP 0.001uF 10% 50V


U C318 CERAMIC CHIP 0.1uF 10% 10VU C319 CERAMIC CHIP 0.1uF 10% 10VU C320 CERAMIC CHIP 0.1uF 10% 10V

U C321 CERAMIC CHIP 1uF 20% 6.3VU C322 CERAMIC CHIP 0.22uF 10% 6.3VU C323 CERAMIC CHIP 0.1uF 10% 10VU C324 CERAMIC CHIP 0.1uF 10% 10VU C325 CERAMIC CHIP 10uF 20% 16V

U C326 CERAMIC CHIP 0.1uF 10% 10VU C327 CERAMIC CHIP 22PF 5% 50VU C328 CERAMIC CHIP 22PF 5% 50VU C329 CERAMIC CHIP 0.1uF 10% 10VU C330 CERAMIC CHIP 22PF 5% 50V

U C331 CERAMIC CHIP 220PF 10% 50VU C332 CERAMIC CHIP 220PF 10% 50VU C333 CERAMIC CHIP 0.022uF 10% 16VU C334 CERAMIC CHIP 0.1uF 10% 10VU C335 CERAMIC CHIP 0.0047uF 10% 50V

U C336 CERAMIC CHIP 0.1uF 10% 10VU C340 CERAMIC CHIP 220PF 10% 50VU C341 CERAMIC CHIP 0.0015uF 10% 50VU C342 CERAMIC CHIP 0.0033uF 10% 16VU C343 CERAMIC CHIP 0.1uF 10% 10V









Whenindicatingpartsbyreference number,pleaseincludetheboard.

NOTE: •SCClassification:S:SuppliedpartsU:Unsuppliedparts


Thecomponents identifiedbymark containconfidentialinformation.Strictly followthe instructionswhenever thecomponentsarerepairedand/orreplaced.

Thecomponentsidentifiedbymark !! ordottedlinewithmark

!! arecriticalforsafety.Replaceonlywithpartnumberspecified.

Lescomposantsidentifiésparunemarque !! sontcritiquespourlasécurité.Nelesremplacerqueparunepiéceportantlenumérospécifié.

4-2


SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark

U C395 CERAMIC CHIP 15PF 5% 50VU C396 CERAMIC CHIP 15PF 5% 50VU C399 CERAMIC CHIP 0.1uF 10% 10VU C400 CERAMIC CHIP 0.1uF 10% 10VU C401 CERAMIC CHIP 0.0068uF 10% 16V

U C402 CERAMIC CHIP 0.0068uF 10% 16VU C450 CERAMIC CHIP 100PF 5% 50VU C451 CERAMIC CHIP 100PF 5% 50VU C452 CERAMIC CHIP 100PF 5% 50VU C453 CERAMIC CHIP 100PF 5% 50V

U C454 CERAMIC CHIP 100PF 5% 50VU C455 CERAMIC CHIP 0.1uF 10% 10VU C456 CERAMIC CHIP 100PF 5% 50VU C457 CERAMIC CHIP 0.1uF 10% 10VU C458 CERAMIC CHIP 0.1uF 10% 10V

U C460 CERAMIC CHIP 100PF 5% 50VU C500 CERAMIC CHIP 1uF 10% 6.3VU C501 CERAMIC CHIP 0.47uF 10% 6.3VU C503 CERAMIC CHIP 100PF 5% 50VU C504 CERAMIC CHIP 100uF 20% 6.3V

U C505 CERAMIC CHIP 1uF 10% 16VU C506 CERAMIC CHIP 10uF 20% 16VU C507 CERAMIC CHIP 22uF 20% 16VU C508 CERAMIC CHIP 0.1uF 10% 10VU C509 CERAMIC CHIP 0.1uF 10% 10V

U C510 CERAMIC CHIP 0.1uF 10% 10VU C512 CERAMIC CHIP 0.22uF 10% 6.3VU C523 CERAMIC CHIP 1uF 20% 6.3VU C527 CERAMIC CHIP 0.1uF 10% 10VU C528 CERAMIC CHIP 0.1uF 10% 10V
















U C603 CERAMIC CHIP 0.1uF 10% 10VU C604 CERAMIC CHIP 0.1uF 10% 10VU C605 CERAMIC CHIP 0.1uF 10% 10VU C606 CERAMIC CHIP 1uF 10% 10VU C607 CERAMIC CHIP 22uF 20% 10V

U C608 CERAMIC CHIP 22uF 20% 10VU C609 TANTAL. CHIP 47uF 20% 6.3VU C610 ELECT CHIP 100uF 20% 16VU C611 ELECT CHIP 100uF 20% 6.3VU C612 ELECT CHIP 100uF 20% 6.3V

U C613 ELECT CHIP 100uF 20% 6.3VU C614 CERAMIC CHIP 1uF 10% 10VU C615 CERAMIC CHIP 0.1uF 10% 10V







U C648 CERAMIC CHIP 1uF 10% 6.3VU C649 CERAMIC CHIP 1uF 10% 6.3VU C650 CERAMIC CHIP 0.1uF 10% 16VU C651 CERAMIC CHIP 0.1uF 10% 16VU C652 CERAMIC CHIP 0.1uF 10% 10V

< CONNECTOR >

U !! CN100 CONNECTOR, FFC/FPC (ZIF) 19PU !! CN101 CONNECTOR, FFC/FPC (ZIF) 14PU !! CN102 CONNECTOR, FFC/FPC (ZIF) 8PU !! CN103 CONNECTOR, FFC/FPC (ZIF) 45PU CN104 PIN, CONNECTOR 2P

U !! CN301 CONNECTOR, FFC/FPC (ZIF) 60PU CN502 PIN, CONNECTOR (PC BOARD) 4P

< DIODE >

U D100 DIODE RR264M-400U D101 DIODE RR264M-400U D500 DIODE DAP202K-T-146U D501 DIODE RB051LA-40TRU D502 DIODE DAP202K-T-146

< FERRITE BEAD >

U FB301 FERRITE, EMI (SMD) (1608)U FB499 FERRITE, EMI (SMD) (2012)U FB527 FERRITE, EMI (SMD)U FB528 FERRITE, EMI (SMD)U FB557 FERRITE, EMI (SMD) (2012)


< FILTER >

U FL103 FILTER, EMI REMOVAL (SMD)U FL104 FILTER, EMI REMOVAL (SMD)U FL500 FILTER, EMI REMOVAL (SMD)U FL501 FILTER, EMI REMOVAL (SMD)U FL502 FILTER, EMI REMOVAL (SMD)

U FL503 FILTER, EMI REMOVAL (SMD)

< IC >

U IC103 IC BD7956FS-E2U IC108 IC BA5888FP-E2U IC110 IC CXA2720R-TLU IC300 IC CXD5063GG-1U IC303 IC NJM13403V(TE2)

U IC304 U IC309 IC K4S641632K-UC75TU IC310 IC MX25L1005MC-12GU IC500 IC PST3629ULU IC501 IC PST3814UL

U IC503 IC TPS64201DBVRG4U IC504 IC CXD5064R-T6U IC506 IC MM3292FNREU IC507 IC TC7WH74FK(TE85R)U IC508 IC TPS64203DBVRG4

U IC509 IC BD7800FP-E2

< COIL >

U L100 COIL, CHOKE 150uHU L101 COIL, CHOKE 10uHU L103 COIL, CHOKE 4.7uHU L500 COIL, CHOKE 10uHU L503 COIL, CHOKE 10uH

U L506 COIL, CHOKE 1uHU L507 COIL, CHOKE 4.7uHU L508 COIL, CHOKE 4.7uHU L509 COIL, CHOKE 4.7uHU L510 INDUCTOR (EMI FERRITE) (2012)

U L511 INDUCTOR (EMI FERRITE) (2012)U L514 INDUCTOR (EMI FERRITE) (2012)

< TRANSISTOR >

U Q102 FET RTR025N03TLU Q103 FET RTR025N03TLU Q104 TRANSISTOR UMH4NTNU Q105 TRANSISTOR DTC144EE-TLU Q106 TRANSISTOR UMH11NTN

U Q107 TRANSISTOR DTA143EE-TLU Q109 TRANSISTOR UMH11NTNU Q500 FET RSQ035P03TRU Q501 TRANSISTOR DTC144EE-TLU Q502 FET IRF7422D2TRPBF

U Q506 TRANSISTOR DTC115EETLU Q507 FET RTQ035P02TRU Q508 FET RTQ035P02TR

4-3


SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark

< RESISTOR >

U R101 RES-CHIP 68 5% 1/16WU R102 RES-CHIP 180 5% 1/16WU R104 SHORT CHIP 0U R105 RES-CHIP 10K 5% 1/16WU R106 RES-CHIP 10K 5% 1/16W

U R107 RES-CHIP 47K 5% 1/16WU R108 RES-CHIP 47K 5% 1/16WU R109 RES-CHIP 47K 5% 1/16WU R110 RES-CHIP 10K 5% 1/16WU R111 SHORT CHIP 0

U R112 SHORT CHIP 0U R114 SHORT CHIP 0U R118 SHORT CHIP 0U R119 SHORT CHIP 0U R121 RES-CHIP 10K 5% 1/16W

U R122 RES-CHIP 100 5% 1/16WU R124 METAL CHIP 12K 0.5% 1/16WU R126 RES-CHIP 1K 5% 1/16WU R127 SHORT CHIP 0U R129 SHORT CHIP 0

U R133 SHORT CHIP 0U R135 SHORT CHIP 0U R136 SHORT CHIP 0U R139 METAL CHIP 3.3K 0.5% 1/16WU R163 METAL CHIP 0.33 1% 1/2W

U R171 SHORT CHIP 0U R180 METAL CHIP 0.56 5% 1/3WU R181 METAL CHIP 0.56 5% 1/3WU R187 METAL CHIP 10K 0.5% 1/16WU R199 SHORT CHIP 0

U R201 SHORT CHIP 0U R202 METAL CHIP 12K 0.5% 1/16WU R203 METAL CHIP 24K 0.5% 1/16WU R204 RES-CHIP 10K 5% 1/16WU R206 SHORT CHIP 0

U R212 METAL CHIP 1.8K 0.5% 1/16WU R214 RES-CHIP 15K 5% 1/16WU R217 RES-CHIP 10K 5% 1/16WU R218 RES-CHIP 100 5% 1/16WU R219 RES-CHIP 100 5% 1/16W

U R222 METAL CHIP 1 5% 1/3WU R224 SHORT CHIP 0U R226 SHORT CHIP 0U R227 SHORT CHIP 0U R228 SHORT CHIP 0

U R229 SHORT CHIP 0U R230 SHORT CHIP 0U R231 SHORT CHIP 0U R232 SHORT CHIP 0U R233 SHORT CHIP 0


U R240 SHORT CHIP 0

U R241 METAL CHIP 1 5% 1/3WU R242 SHORT CHIP 0U R243 METAL CHIP 22 5% 1/10WU R244 METAL CHIP 22 5% 1/10WU R245 METAL CHIP 22 5% 1/10W

U R246 METAL CHIP 22 5% 1/10WU R258 RES-CHIP 680K 5% 1/16WU R259 METAL CHIP 5.6 5% 1/3WU R260 METAL CHIP 100 5% 1WU R265 METAL CHIP 22K 0.5% 1/16W

U R267 METAL CHIP 22K 0.5% 1/16WU R268 RES-CHIP 10K 5% 1/16WU R269 RES-CHIP 10K 5% 1/16WU R270 RES-CHIP 2.2K 5% 1/16WU R271 RES-CHIP 100 5% 1/16W

U R272 RES-CHIP 100 5% 1/16WU R273 RES-CHIP 100 5% 1/16WU R277 RES-CHIP 47K 5% 1/16WU R278 RES-CHIP 47K 5% 1/16WU R282 RES-CHIP 10 5% 1/16W

U R283 RES-CHIP 10 5% 1/16WU R284 RES-CHIP 10 5% 1/16WU R285 RES-CHIP 10 5% 1/16WU R288 SHORT CHIP 0U R289 SHORT CHIP 0



U R300 METAL CHIP 2.2K 0.5% 1/16WU R301 RES-CHIP 47K 5% 1/16WU R302 RES-CHIP 47K 5% 1/16WU R303 RES-CHIP 47K 5% 1/16WU R304 RES-CHIP 47K 5% 1/16W

U R305 RES-CHIP 47K 5% 1/16WU R307 RES-CHIP 47K 5% 1/16WU R309 RES-CHIP 33 5% 1/16WU R310 RES-CHIP 33 5% 1/16WU R311 RES-CHIP 33 5% 1/16W

U R312 METAL CHIP 3.3K 0.5% 1/16WU R315 METAL CHIP 12K 0.5% 1/16WU R320 RES-CHIP 10K 5% 1/16WU R324 RES-CHIP 10K 5% 1/16WU R326 METAL CHIP 100K 0.5% 1/16W

U R329 METAL CHIP 47K 0.5% 1/16WU R331 SHORT CHIP 0U R332 METAL CHIP 47K 0.5% 1/16WU R333 SHORT CHIP 0U R336 RES-CHIP 47K 5% 1/16W

U R337 RES-CHIP 10K 5% 1/16WU R339 RES-CHIP 4.7K 5% 1/16WU R341 SHORT CHIP 0

U R342 METAL CHIP 4.7K 0.5% 1/16WU R343 METAL CHIP 4.7K 0.5% 1/16WU R344 RES-CHIP 470 5% 1/16WU R346 RES-CHIP 1.5K 5% 1/16WU R348 METAL CHIP 4.7K 0.5% 1/16W

U R349 METAL CHIP 22K 0.5% 1/16WU R350 METAL CHIP 22K 0.5% 1/16WU R351 METAL CHIP 4.7K 0.5% 1/16WU R352 METAL CHIP 10K 0.5% 1/16WU R354 METAL CHIP 4.7K 0.5% 1/16W

U R355 SHORT CHIP 0U R357 RES-CHIP 4.7K 5% 1/16WU R358 METAL CHIP 4.7K 0.5% 1/16WU R359 RES-CHIP 1K 5% 1/16WU R360 RES-CHIP 100 5% 1/16W

U R361 METAL CHIP 22K 0.5% 1/16WU R363 METAL CHIP 22K 0.5% 1/16WU R365 SHORT CHIP 0U R366 METAL CHIP 47K 0.5% 1/16WU R367 RES-CHIP 100 5% 1/16W

U R368 RES-CHIP 100 5% 1/16WU R369 RES-CHIP 100 5% 1/16WU R370 RES-CHIP 100 5% 1/16WU R371 RES-CHIP 100 5% 1/16WU R372 RES-CHIP 100 5% 1/16W

U R374 RES-CHIP 47K 5% 1/16WU R375 RES-CHIP 47K 5% 1/16WU R376 RES-CHIP 47K 5% 1/16WU R377 RES-CHIP 47K 5% 1/16WU R378 RES-CHIP 47K 5% 1/16W

U R379 SHORT CHIP 0U R380 RES-CHIP 4.7K 5% 1/16WU R381 RES-CHIP 4.7K 5% 1/16WU R382 RES-CHIP 4.7K 5% 1/16WU R383 RES-CHIP 4.7K 5% 1/16W

U R384 RES-CHIP 47K 5% 1/16WU R386 RES-CHIP 47K 5% 1/16WU R387 RES-CHIP 47K 5% 1/16WU R388 RES-CHIP 47K 5% 1/16WU R389 METAL CHIP 10K 0.5% 1/16W

U R391 METAL CHIP 10K 0.5% 1/16WU R392 METAL CHIP 10K 0.5% 1/16WU R393 RES-CHIP 33 5% 1/16WU R396 RES-CHIP 1K 5% 1/16WU R397 RES-CHIP 47K 5% 1/16W

U R398 RES-CHIP 1M 5% 1/16WU R399 RES-CHIP 47K 5% 1/16WU R400 RES-CHIP 33 5% 1/16WU R401 RES-CHIP 33 5% 1/16WU R402 RES-CHIP 33 5% 1/16W

U R403 RES-CHIP 33 5% 1/16WU R404 RES-CHIP 33 5% 1/16WU R405 RES-CHIP 47K 5% 1/16WU R408 METAL CHIP 47K 0.5% 1/16WU R409 RES-CHIP 47K 5% 1/16W

U R411 RES-CHIP 47K 5% 1/16WU R415 RES-CHIP 10K 5% 1/16WU R416 RES-CHIP 82 5% 1/16W

U R418 RES-CHIP 1K 5% 1/16WU R419 RES-CHIP 82 5% 1/16WU R420 RES-CHIP 82 5% 1/16WU R421 RES-CHIP 82 5% 1/16WU R422 RES-CHIP 22 5% 1/16W

U R423 RES-CHIP 82 5% 1/16WU R424 SHORT CHIP 0U R425 RES-CHIP 82 5% 1/16WU R426 RES-CHIP 82 5% 1/16WU R427 RES-CHIP 22 5% 1/16W

U R430 RES-CHIP 82 5% 1/16WU R431 RES-CHIP 82 5% 1/16WU R432 METAL CHIP 4.7K 0.5% 1/16WU R433 METAL CHIP 4.7K 0.5% 1/16WU R434 RES-CHIP 47K 5% 1/16W


U R443 RES-CHIP 10K 5% 1/16WU R444 METAL CHIP 47K 0.5% 1/16WU R449 RES-CHIP 47K 5% 1/16WU R452 RES-CHIP 47K 5% 1/16WU R453 RES-CHIP 47K 5% 1/16W

U R454 RES-CHIP 47K 5% 1/16WU R458 SHORT CHIP 0U R459 RES-CHIP 10K 5% 1/16WU R460 RES-CHIP 10K 5% 1/16WU R461 RES-CHIP 100 5% 1/16W

U R462 RES-CHIP 100 5% 1/16WU R463 RES-CHIP 100K 5% 1/16WU R464 RES-CHIP 10K 5% 1/16WU R465 RES-CHIP 10K 5% 1/16WU R470 SHORT CHIP 0

U R471 SHORT CHIP 0U R498 SHORT CHIP 0U R502 RES-CHIP 10 5% 1/16WU R503 METAL CHIP 0.047 1% 1/4WU R504 RES-CHIP 47K 5% 1/16W

U R506 METAL CHIP 560K 0.5% 1/16WU R508 METAL CHIP 330K 0.5% 1/16WU R509 RES-CHIP 10K 5% 1/16WU R510 SHORT CHIP 0U R511 METAL CHIP 27K 0.5% 1/16W

U R512 SHORT CHIP 0U R514 METAL CHIP 180K 0.5% 1/16WU R515 METAL CHIP 560K 0.5% 1/16WU R516 RES-CHIP 10K 5% 1/16WU R517 RES-CHIP 22K 5% 1/16W

U R518 RES-CHIP 10K 5% 1/16WU R519 RES-CHIP 22K 5% 1/16WU R520 METAL CHIP 2K 0.5% 1/16WU R521 METAL CHIP 3.3K 0.5% 1/16WU R522 METAL CHIP 150 0.5% 1/16W

U R523 METAL CHIP 0.047 1% 1/4WU R524 SHORT CHIP 0U R529 SHORT CHIP 0

4-4





U R540 RES-CHIP 10K 5% 1/16WU R541 SHORT CHIP 0U R542 SHORT CHIP 0U R543 SHORT CHIP 0U R544 RES-CHIP 100 5% 1/16W

U R545 RES-CHIP 100 5% 1/16WU R546 SHORT CHIP 0U R547 SHORT CHIP 0U R549 RES-CHIP 47K 5% 1/16WU R550 RES-CHIP 47K 5% 1/16W

U R551 RES-CHIP 47K 5% 1/16WU R552 SHORT CHIP 0U R553 RES-CHIP 10K 5% 1/16WU R555 RES-CHIP 10K 5% 1/16WU R556 SHORT CHIP 0

< NETWORK RESISTOR >

U RB300 RES, NETWORK 33X4 (1005)U RB301 RES, NETWORK 33X4 (1005)U RB302 RES, NETWORK 33X4 (1005)U RB303 RES, NETWORK 33X4 (1005)U RB304 CONDUCTOR, NETWORK 0X4 (1005)

U RB305 CONDUCTOR, NETWORK 0X4 (1005)U RB306 CONDUCTOR, NETWORK 0X4 (1005)U RB307 CONDUCTOR, NETWORK 0X4 (1005)U RB308 RES, NETWORK 4.7KX4 (1005)U RB309 RES, NETWORK 4.7KX4 (1005)

U RB312 RES, NETWORK 4.7KX4 (1005)

< VIBRATOR >

U X301 VIBRATOR, CRYSTAL (33.8688MHz)*****************************************************************

S A-1433-743-A BMD-002 COMPL (SERVICE) *************

< CAPACITOR >


U C106 CERAMIC CHIP 0.001uF 10% 50VU C107 CERAMIC CHIP 47uF 20% 6.3VU C108 CERAMIC CHIP 0.1uF 10% 10VU C109 CERAMIC CHIP 0.1uF 10% 10VU C110 CERAMIC CHIP 0.1uF 20% 16V

U C113 CERAMIC CHIP 0.1uF 10% 10V

U C115 CERAMIC CHIP 0.1uF 20% 16VU C117 CERAMIC CHIP 0.1uF 20% 16VU C119 CERAMIC CHIP 0.1uF 20% 16VU C126 CERAMIC CHIP 2.2uF 20% 16VU C133 CERAMIC CHIP 22uF 20% 16V

U C135 CERAMIC CHIP 0.1uF 20% 16VU C136 CERAMIC CHIP 470PF 10% 50VU C139 CERAMIC CHIP 0.01uF 10% 25VU C140 CERAMIC CHIP 0.01uF 10% 25VU C141 CERAMIC CHIP 0.01uF 10% 25V


U C158 CERAMIC CHIP 0.1uF 20% 16VU C161 CERAMIC CHIP 0.1uF 20% 16VU C162 CERAMIC CHIP 10uF 20% 16VU C175 CERAMIC CHIP 0.01uF 10% 25VU C176 CERAMIC CHIP 0.1uF 10% 10V



U C188 CERAMIC CHIP 0.001uF 10% 50VU C189 CERAMIC CHIP 0.1uF 10% 10VU C190 CERAMIC CHIP 47PF 5% 50VU C191 CERAMIC CHIP 47PF 5% 50VU C192 CERAMIC CHIP 100PF 5% 50V

U C193 CERAMIC CHIP 100PF 5% 50VU C194 CERAMIC CHIP 0.01uF 10% 25VU C195 CERAMIC CHIP 0.1uF 10% 10VU C196 CERAMIC CHIP 100PF 5% 50VU C197 CERAMIC CHIP 0.1uF 10% 10V

U C198 CERAMIC CHIP 10uF 20% 16VU C199 CERAMIC CHIP 100PF 5% 50VU C200 CERAMIC CHIP 0.1uF 10% 10VU C203 CERAMIC CHIP 0.1uF 10% 10VU C206 CERAMIC CHIP 0.1uF 10% 10V


U C218 CERAMIC CHIP 0.1uF 10% 10VU C219 CERAMIC CHIP 0.1uF 10% 10VU C221 CERAMIC CHIP 0.1uF 10% 10VU C222 CERAMIC CHIP 0.1uF 10% 10VU C223 CERAMIC CHIP 0.22uF 10% 6.3V

U C224 CERAMIC CHIP 0.1uF 10% 10VU C225 CERAMIC CHIP 100PF 5% 50VU C226 CERAMIC CHIP 0.1uF 10% 10V


U C236 CERAMIC CHIP 0.1uF 10% 10VU C237 CERAMIC CHIP 100PF 5% 50VU C238 CERAMIC CHIP 22uF 20% 10VU C239 CERAMIC CHIP 0.1uF 10% 10VU C240 CERAMIC CHIP 0.1uF 10% 10V

U C241 CERAMIC CHIP 0.1uF 10% 10VU C242 CERAMIC CHIP 0.1uF 10% 10VU C243 ELECT CHIP 220uF 20% 16VU C244 CERAMIC CHIP 0.001uF 10% 50VU C251 CERAMIC CHIP 0.1uF 10% 10V



U C313 CERAMIC CHIP 0.001uF 10% 50VU C314 CERAMIC CHIP 0.47uF 10% 6.3VU C315 CERAMIC CHIP 100PF 10% 50VU C316 CERAMIC CHIP 0.1uF 10% 10VU C321 CERAMIC CHIP 0.1uF 10% 10V

U C322 CERAMIC CHIP 1uF 10% 6.3VU C323 CERAMIC CHIP 0.1uF 10% 10VU C325 CERAMIC CHIP 10uF 20% 16VU C326 CERAMIC CHIP 0.1uF 10% 10VU C327 CERAMIC CHIP 22PF 5% 50V

U C328 CERAMIC CHIP 22PF 5% 50VU C329 CERAMIC CHIP 0.1uF 10% 10VU C330 CERAMIC CHIP 22PF 5% 50VU C331 CERAMIC CHIP 220PF 10% 50VU C332 CERAMIC CHIP 220PF 10% 50V

U C333 CERAMIC CHIP 0.022uF 10% 16VU C335 CERAMIC CHIP 0.0047uF 10% 50VU C340 CERAMIC CHIP 220PF 10% 50VU C341 CERAMIC CHIP 0.0015uF 10% 50VU C342 CERAMIC CHIP 0.0033uF 10% 16V











U C466 CERAMIC CHIP 0.1uF 10% 10VU C467 CERAMIC CHIP 0.1uF 10% 10VU C502 CERAMIC CHIP 47uF 20% 6.3VU C504 CERAMIC CHIP 47uF 20% 6.3VU C505 CERAMIC CHIP 1uF 10% 16V

U C506 CERAMIC CHIP 10uF 20% 16VU C507 CERAMIC CHIP 22uF 20% 10VU C508 CERAMIC CHIP 0.1uF 10% 10VU C509 CERAMIC CHIP 0.1uF 10% 10VU C510 CERAMIC CHIP 0.1uF 10% 10V

U C511 CERAMIC CHIP 0.022uF 10% 16VU C512 CERAMIC CHIP 0.22uF 10% 6.3VU C523 CERAMIC CHIP 1uF 20% 6.3VU C527 CERAMIC CHIP 0.1uF 10% 10VU C528 CERAMIC CHIP 0.1uF 10% 10V




4-5


SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark SC Ref. No. Part No. Description Remark








U C584 CERAMIC CHIP 0.1uF 10% 10VU C605 CERAMIC CHIP 0.1uF 10% 10VU C606 CERAMIC CHIP 1uF 10% 10VU C607 CERAMIC CHIP 22uF 20% 10VU C608 CERAMIC CHIP 22uF 20% 10V

U C609 TANTAL. CHIP 47uF 20% 6.3VU C610 ELECT CHIP 100uF 20% 16VU C611 ELECT CHIP 100uF 20% 6.3VU C612 ELECT CHIP 100uF 20% 6.3VU C613 ELECT CHIP 100uF 20% 6.3V

U C614 CERAMIC CHIP 1uF 10% 10VU C615 CERAMIC CHIP 0.1uF 10% 10VU C616 CERAMIC CHIP 100PF 5% 50VU C648 CERAMIC CHIP 1uF 10% 6.3VU C649 CERAMIC CHIP 1uF 10% 6.3V

U C650 CERAMIC CHIP 0.1uF 10% 16VU C651 CERAMIC CHIP 0.1uF 10% 16VU C652 CERAMIC CHIP 0.1uF 10% 10VU C653 CERAMIC CHIP 1uF 10% 10V

< CONNECTOR >

U !! CN100 CONNECTOR, FFC/FPC (ZIF) 19PU !! CN101 CONNECTOR, FFC/FPC (ZIF) 14P

U !! CN102 CONNECTOR, FFC/FPC (ZIF) 8PU !! CN103 CONNECTOR, FFC/FPC (ZIF) 45PU CN104 PIN, CONNECTOR 2PU !! CN301 CONNECTOR, FFC/FPC (ZIF) 60PU CN502 PIN, CONNECTOR (PC BOARD) 4P

< DIODE >

U D100 DIODE RR264M-400U D101 DIODE RR264M-400U D501 DIODE RB051LA-40TRU D502 DIODE DAP202K-T-146

< FERRITE BEAD >

U FB301 FERRITE, EMI (SMD) (1608)U FB527 FERRITE, EMI (SMD)U FB528 FERRITE, EMI (SMD)U FB557 FERRITE, EMI (SMD) (2012)

< FILTER >

U FL103 FILTER, EMI REMOVAL (SMD)U FL104 FILTER, EMI REMOVAL (SMD)U FL500 FILTER, EMI REMOVAL (SMD)U FL503 FILTER, EMI REMOVAL (SMD)

< IC >

U IC103 IC BD7956FS-E2U IC108 IC BA5888FP-E2U IC110 IC CXA2720R-TLU IC300 IC CXD5065GB-1U IC303 IC NJM13403V(TE2)

U IC304 U IC309 IC K4S641632K-UC75TU IC310 IC MX25L1005MC-12GU IC500 IC PST3629ULU IC501 IC PST3810UL

U IC503 IC TPS64201DBVRG4U IC507 IC TC7WH74FK(TE85R)U IC508 IC TPS64203DBVRG4U IC509 IC BD7800FP-E2U IC510 IC PST3443UL

< COIL >

U L100 COIL, CHOKE 150uHU L101 COIL, CHOKE 10uHU L103 COIL, CHOKE 4.7uHU L500 COIL, CHOKE 10uHU L503 COIL, CHOKE 10uH

U L506 COIL, CHOKE 1uHU L507 COIL, CHOKE 4.7uHU L508 COIL, CHOKE 4.7uHU L509 COIL, CHOKE 4.7uHU L510 INDUCTOR (EMI FERRITE) (2012)

U L511 INDUCTOR (EMI FERRITE) (2012)U L514 INDUCTOR (EMI FERRITE) (2012)

< TRANSISTOR >

U Q102 FET RTR025N03TLU Q103 FET RTR025N03TLU Q104 TRANSISTOR UMH2NTN

U Q105 TRANSISTOR DTC144EE-TLU Q106 TRANSISTOR UMH2NTNU Q107 TRANSISTOR DTA143EE-TLU Q109 TRANSISTOR DTC144EE-TLU Q111 FET RTQ035P02TR

U Q112 TRANSISTOR UMH2NTNU Q500 FET RSQ035P03TRU Q502 FET IRF7422D2TRPBFU Q503 TRANSISTOR 2SC5658T2L

< RESISTOR >

U R101 RES-CHIP 68 5% 1/16WU R102 RES-CHIP 180 5% 1/16WU R105 RES-CHIP 10K 5% 1/16WU R106 RES-CHIP 10K 5% 1/16WU R107 RES-CHIP 47K 5% 1/16W

U R108 RES-CHIP 47K 5% 1/16WU R109 RES-CHIP 47K 5% 1/16WU R110 RES-CHIP 10K 5% 1/16WU R121 RES-CHIP 10K 5% 1/16WU R122 RES-CHIP 100 5% 1/16W

U R124 METAL CHIP 12K 0.5% 1/16WU R126 RES-CHIP 1K 5% 1/16WU R139 METAL CHIP 3.3K 0.5% 1/16WU R153 RES-CHIP 10K 5% 1/16WU R154 RES-CHIP 10K 5% 1/16W

U R155 RES-CHIP 10K 5% 1/16WU R157 METAL CHIP 47K 0.5% 1/16WU R158 METAL CHIP 47K 0.5% 1/16WU R163 METAL CHIP 0.33 1% 1/2WU R180 METAL CHIP 0.56 5% 1/3W

U R181 METAL CHIP 0.56 5% 1/3WU R187 METAL CHIP 10K 0.5% 1/16WU R202 METAL CHIP 12K 0.5% 1/16WU R203 METAL CHIP 24K 0.5% 1/16WU R204 RES-CHIP 10K 5% 1/16W

U R212 METAL CHIP 1.8K 0.5% 1/16WU R214 RES-CHIP 15K 5% 1/16WU R217 RES-CHIP 10K 5% 1/16WU R218 RES-CHIP 100 5% 1/16WU R219 RES-CHIP 100 5% 1/16W

U R222 METAL CHIP 1 5% 1/3WU R241 METAL CHIP 1 5% 1/3WU R243 METAL CHIP 22 5% 1/10WU R244 METAL CHIP 22 5% 1/10WU R245 METAL CHIP 22 5% 1/10W

U R246 METAL CHIP 22 5% 1/10WU R258 RES-CHIP 680K 5% 1/16WU R259 METAL CHIP 5.6 5% 1/3WU R260 METAL CHIP 100 5% 1WU R265 METAL CHIP 22K 0.5% 1/16W

U R267 METAL CHIP 22K 0.5% 1/16WU R268 RES-CHIP 10K 5% 1/16WU R269 RES-CHIP 10K 5% 1/16WU R270 RES-CHIP 2.2K 5% 1/16WU R272 RES-CHIP 100 5% 1/16W

U R273 RES-CHIP 100 5% 1/16WU R277 RES-CHIP 47K 5% 1/16W

U R278 RES-CHIP 470K 5% 1/16WU R282 RES-CHIP 10 5% 1/16WU R283 RES-CHIP 10 5% 1/16WU R284 RES-CHIP 10 5% 1/16WU R285 RES-CHIP 10 5% 1/16W


U R307 RES-CHIP 47K 5% 1/16WU R309 RES-CHIP 33 5% 1/16WU R310 RES-CHIP 33 5% 1/16WU R311 RES-CHIP 33 5% 1/16WU R315 METAL CHIP 12K 0.5% 1/16W

U R324 RES-CHIP 10K 5% 1/16WU R326 METAL CHIP 10K 0.5% 1/16WU R329 METAL CHIP 47K 0.5% 1/16WU R332 METAL CHIP 47K 0.5% 1/16WU R335 METAL CHIP 3K 0.5% 1/16W

U R336 RES-CHIP 47K 5% 1/16WU R342 METAL CHIP 4.7K 0.5% 1/16WU R343 METAL CHIP 4.7K 0.5% 1/16WU R344 RES-CHIP 470 5% 1/16WU R346 RES-CHIP 1.5K 5% 1/16W

U R348 METAL CHIP 4.7K 0.5% 1/16WU R349 METAL CHIP 22K 0.5% 1/16WU R350 METAL CHIP 22K 0.5% 1/16WU R351 METAL CHIP 4.7K 0.5% 1/16WU R354 METAL CHIP 4.7K 0.5% 1/16W

U R357 RES-CHIP 1K 5% 1/16WU R358 METAL CHIP 4.7K 0.5% 1/16WU R359 RES-CHIP 1K 5% 1/16WU R360 RES-CHIP 100 5% 1/16WU R361 METAL CHIP 22K 0.5% 1/16W

U R363 METAL CHIP 22K 0.5% 1/16WU R366 METAL CHIP 47K 0.5% 1/16WU R367 RES-CHIP 100 5% 1/16WU R368 RES-CHIP 100 5% 1/16WU R369 RES-CHIP 100 5% 1/16W

U R370 RES-CHIP 100 5% 1/16WU R374 RES-CHIP 47K 5% 1/16WU R375 RES-CHIP 47K 5% 1/16WU R376 RES-CHIP 47K 5% 1/16WU R377 RES-CHIP 47K 5% 1/16W

U R378 RES-CHIP 47K 5% 1/16WU R379 SHORT CHIP 0U R380 RES-CHIP 4.7K 5% 1/16WU R381 RES-CHIP 4.7K 5% 1/16WU R382 METAL CHIP 4.7K 0.5% 1/16W

U R383 METAL CHIP 4.7K 0.5% 1/16WU R384 RES-CHIP 47K 5% 1/16WU R386 RES-CHIP 47K 5% 1/16WU R387 RES-CHIP 47K 5% 1/16WU R388 RES-CHIP 47K 5% 1/16W

U R389 METAL CHIP 10K 0.5% 1/16WU R391 METAL CHIP 10K 0.5% 1/16WU R392 METAL CHIP 10K 0.5% 1/16W

4-6



U R397 RES-CHIP 47K 5% 1/16WU R399 RES-CHIP 47K 5% 1/16WU R400 RES-CHIP 33 5% 1/16WU R401 RES-CHIP 33 5% 1/16WU R402 RES-CHIP 33 5% 1/16W

U R403 RES-CHIP 33 5% 1/16WU R404 RES-CHIP 33 5% 1/16WU R408 METAL CHIP 47K 0.5% 1/16WU R409 RES-CHIP 47K 5% 1/16WU R411 RES-CHIP 47K 5% 1/16W



U R430 RES-CHIP 82 5% 1/16WU R431 RES-CHIP 82 5% 1/16WU R432 METAL CHIP 4.7K 0.5% 1/16WU R433 METAL CHIP 4.7K 0.5% 1/16WU R434 RES-CHIP 47K 5% 1/16W


U R443 RES-CHIP 47K 5% 1/16WU R444 METAL CHIP 47K 0.5% 1/16WU R449 RES-CHIP 47K 5% 1/16WU R452 RES-CHIP 47K 5% 1/16WU R453 RES-CHIP 47K 5% 1/16W


U R472 METAL CHIP 3K 0.5% 1/16WU R473 METAL CHIP 3K 0.5% 1/16WU R474 METAL CHIP 75 0.5% 1/16WU R475 METAL CHIP 18K 0.5% 1/16WU R476 RES-CHIP 47K 5% 1/16W

U R485 RES-CHIP 47K 5% 1/16WU R486 RES-CHIP 47K 5% 1/16WU R487 RES-CHIP 47K 5% 1/16WU R488 RES-CHIP 47K 5% 1/16WU R502 RES-CHIP 10 5% 1/16W

U R503 METAL CHIP 0.047 1% 1/4WU R504 RES-CHIP 10K 5% 1/16WU R506 METAL CHIP 560K 0.5% 1/16WU R508 METAL CHIP 270K 0.5% 1/16WU R509 RES-CHIP 10K 5% 1/16W

U R511 METAL CHIP 27K 0.5% 1/16WU R516 RES-CHIP 10K 5% 1/16WU R520 METAL CHIP 2K 0.5% 1/16W

U R521 METAL CHIP 3.3K 0.5% 1/16WU R522 METAL CHIP 150 0.5% 1/16WU R523 METAL CHIP 0.047 1% 1/4WU R533 RES-CHIP 20K 5% 1/16WU R534 RES-CHIP 36K 5% 1/16W

U R536 RES-CHIP 100K 5% 1/16WU R537 RES-CHIP 4.7K 5% 1/16WU R538 RES-CHIP 6.8K 5% 1/16WU R539 METAL CHIP 1K 0.5% 1/16WU R553 RES-CHIP 10K 5% 1/16W

< NETWORK RESISTOR >

U RB300 RES, NETWORK 33X4 (1005)U RB301 RES, NETWORK 33X4 (1005)U RB302 RES, NETWORK 33X4 (1005)U RB303 RES, NETWORK 33X4 (1005)U RB304 RES, NETWORK 33X4 (1005)

U RB305 RES, NETWORK 33X4 (1005)U RB306 RES, NETWORK 33X4 (1005)U RB307 RES, NETWORK 33X4 (1005)U RB308 RES, NETWORK 4.7KX4 (1005)U RB309 RES, NETWORK 4.7KX4 (1005)

U RB312 RES, NETWORK 4.7KX4 (1005)

< VIBRATOR >

U X301 VIBRATOR, CERAMIC (33.868MHz)

sm-bdd-0013e-01 bdpt-1001 bpx-2001 bd drive service manual bpx-2001 bd drive service manual 1st...

Documents