sony cdx-ca580x_cdx-l580x

1

Ver 1.0 2002. 11

Model Name Using Similar Mechanism CDX-L380X

CD Drive Mechanism Type MG-393XA-121//Q

Optical Pick-up Name KSS-720A

SERVICE MANUAL AEP ModelUK Model

CDX-CA680X/L580X

FM/MW/LW COMPACT DISC PLAYER

CD player sectionSignal-to-noise ratio 90 dBFrequency response 10 – 20,000 HzWow and flutter Below measurable limit

Tuner sectionFMTuning range 87.5 – 108.0 MHzAerial terminal External aerial connectorIntermediate frequency 10.7 MHz/450 kHzUsable sensitivity 9 dBfSelectivity 75 dB at 400 kHzSignal-to-noise ratio 67 dB (stereo),

69 dB (mono)Harmonic distortion at 1 kHz

0.5% (stereo),0.3% (mono)

Separation 35 dB at 1 kHzFrequency response 30 – 15,000 Hz

MW/LWTuning range MW: 531 – 1,602 kHz

LW: 153 – 279 kHzAerial terminal External aerial connectorIntermediate frequency 10.7 MHz/450 kHzSensitivity MW: 30 µV

LW: 40 µV

Power amplifier sectionOutputs Speaker outputs

(sure seal connectors)Speaker impedance 4 – 8 ohmsMaximum power output 50 W × 4 (at 4 ohms)

SPECIFICATIONS

GeneralOutputs Audio outputs (front)

(CDX-CA680X only)Audio outputs (rear)Power aerial relay controlterminalPower amplifier controlterminal

Inputs Telephone ATT controlterminalRemote controller inputterminalBUS control input terminal(CDX-CA680X only)BUS audio input terminal(CDX-CA680X only)

Tone controls Low ±10 dB at 60 Hz(XPLOD)Mid ±10 dB at 1 kHz(XPLOD)High ±10 dB at 10 kHz(XPLOD)

Power requirements 12 V DC car battery(negative ground)

Dimensions Approx. 178 × 50 × 180 mm(w/h/d)

Mounting dimension Approx. 182 × 53 × 161 mm(w/h/d)

Mass Approx. 1.2 kgSupplied accessories Parts for installation and

connectionsFront panel case (1)

Design and specifications are subject to change withoutnotice.

• The tuner and CD sections have no adjustments.

Sony Corporatione Vehicle Company

Published by Sony Engineering Corporation

9-874-248-012002K0400-1

© 2002. 11

Photo: CDX-CA680X

2

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNITThe laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic breakdown and also usethe procedure in the printed matter which is included in the repairparts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, ob-serve from more than 30 cm away from the objective lens.

Notes on Chip Component Replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

SERVICE NOTES

This label is located on the bottom of the chassis.

This label is located on the drive unit’s internal chassis.

When replacing the chassis (T.U) of mechanism deck which havethe “CAUTION LABEL” attached, please be sure to put a newLABEL (OP CAUTION) (3-223-913-01) to the chassis (T.U).

CDX-CA680X/L580X

TEST DISCSThis set can playback CD-R and CD-ROM discs. The followingtest discs should be used to check the capability:

CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)CD-RW test disc TCD-W082L (Part No. J-2502-063-2)

Notes on CD-R/CD-RW discs• You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs)

designed for audio use on this unit.Look for these marks to distinguish CD-Rs/CD-RWs for audiouse.

These marks denote that a disc is not for audio use.

• Some CD-Rs/CD-RWs (depending on the equipment used forits recording or the condition of the disc) may not play on thisunit.

• You cannot play a CD-R/a CD-RW that is not finalized*.

* A process necessary for a recorded CD-R/CD-RW disc to beplayed on the audio CD player.

3

z UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size.)

: LEAD FREE MARKUnleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40°C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350°C.Caution: The printed pattern (copper foil) may peel away if theheated tip is applied for too long, so be careful!

• Strong viscosityUnleaded solder is more viscous (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

EXTENSION CABLE AND SERVICE POSITIONWhen repairing or servicing this set, connect the jig (extension cable)as shown below.

• Connect the MAIN board (CNP301) and the SERVO board (CN1)with the extension cable (Part No. J-2502-011-1).

CDX-CA680X/L580X

MAIN BOARDCNP301

J-2502-011-1

SERVO BOARDCN1

4

TABLE OF CONTENTS

1. GENERALLocation of controls ................................................................. 5Connections ............................................................................. 6

2. DISASSEMBLY2-1. Sub Panel Assy .................................................................... 72-2. CD Mechanism Block ......................................................... 82-3. Main Board ......................................................................... 82-4. Heat Sink ............................................................................. 92-5. Chassis (T.U) Assy .............................................................. 92-6. Disc in Board .................................................................... 102-7. Servo Board ....................................................................... 102-8. Shaft Roller Assy .............................................................. 112-9. Floating Block Assy .......................................................... 112-10. Optical Pick-up Block ....................................................... 12

3. DIAGRAMS3-1. IC Pin Description ............................................................. 133-2. Block Diagram –CD Section– ........................................... 143-3. Block Diagram –Tuner Section– ....................................... 153-4. Block Diagram –Display Section– .................................... 163-5. Circuit Boards Location .................................................... 173-6. Printed Wiring Boards –CD Mechanism Section– ............ 183-7. Schematic Diagram –CD Mechanism Section– ................ 203-8. Printed Wiring Board –Main Section– .............................. 213-9. Schematic Diagram –Main Section (1/2)– ........................ 223-10. Schematic Diagram –Main Section (2/2)– ........................ 233-11. Printed Wiring Board –Relay Section– ............................. 243-12. Printed Wiring Board –Key Section– ................................ 253-13. Schematic Diagram –Key Section– ................................... 263-14. IC Block Diagrams ............................................................ 27

4. EXPLODED VIEWS4-1. Chassis Section ................................................................. 294-2. Main Board Section .......................................................... 304-3. Front Panel Section ........................................................... 314-4. CD Mechanism Section (1) ............................................... 324-5. CD Mechanism Section (2) ............................................... 334-6. CD Mechanism Section (3) ............................................... 34

5. ELECTRICAL PARTS LIST ........................................ 35

CDX-CA680X/L580X

5

CDX-CA680X/L580XSECTION 1GENERAL This section is extracted

from instruction manual.

6

CDX-CA680X/L580X

Connections

7

CDX-CA680X/L580XSECTION 2

DISASSEMBLY

Note : This set can be disassemble according to the following sequence.

Note : Follow the disassembly procedure in the numerical order given.

2-1. SUB PANEL ASSY

2-1. SUB PANEL ASSY()

2-2. CD MECHANISM BLOCK(Page 8)

2-5. CHASSIS (T.U) ASSY(Page 9)

2-6. DISC IN BOARD(Page 10)

2-8. SHAFT ROLLER ASSY(Page 11)

2-9. FLOATING BLOCK ASSY(Page 11)

2-10. OPTICAL PICK-UP BLOCK(Page 12)

SET

2-7. SERVO BOARD(Page 10)

2-3. MAIN BOARD(Page 8)

2-4. HEAT SINK(Page 9)

4 CN702

5 sub panel assy

3 claws

2 claws

1 PTT 2.6x6

8

CDX-CA680X/L580X

2-2. CD MECHANISM BLOCK

2-3. MAIN BOARD

1 PTT 2.6x6

6 PTT 2.6x4

7 bracket (CD)

2 PTT 2.6x6

5 CD mechanism block

4 CNP301

3

1 PTT 2.6x6

3 PTT 2.6x6 (ground point)

4 PTT 2.6x6 (ground point)

5 MAIN board

2 PTT 2.6x6

9

CDX-CA680X/L580X

2-4. HEAT SINK

2-5. CHASSIS (T.U) ASSY

3 PTT 2.6x8

5 PTT 2.6x8

7 heat sink

6

4 PTT 2.6x12

1 PTT 2.6x82 cord (RCA)

4 chassis (T.U) assy

3 P 2x32 P 2x3

1 Unsolder the lead wires.

blackredwhite

10

CDX-CA680X/L580X

2-6. DISC IN BOARD

2-7. SERVO BOARD

3 claws

2 DISC IN board

4 guide (disc)

1 PS 2x3

1 CN3

2 Removal the solders.

3 P 2x3

6 PS 2x45 PS 2x4

4 loading motor assy

7 SERVO board

optical pick-up block

8 PICK-UP FLEXIBLE board

11

CDX-CA680X/L580X

2-9. FLOATING BLOCK ASSY

Fig. 1

1 tension spring (RA3)

2 arm (roller T)

3 retaining ring (roller)

4 bearing (roller)

5 shaft roller assy

retaining ring (roller)arm

armwasher (RA) washer (RA)

bearing (roller) bearing (roller)

1 tension spring (KF1)

2 tension spring (KR1)

8 compression spring (FL)

7 floating block assy

9 compression spring (FL)

5 Fit lever (D) in the direction of the arrow.

3 damper (T)4 damper (T)

6 Turn loading ring in the direction of the arrow.

2-8. SHAFT ROLLER ASSY• When installing, take note of the positions arm (roller) and washers. (Fig. 1)

12

CDX-CA680X/L580X

2-10. OPTICAL PICK-UP BLOCK

1 P 2x3 4 P 2x3

5 leaf spring (feed)

6 shaft (feed) assy

2 sled motor assy

3 optical pick-up block

13

CDX-CA680X/L580XSECTION 3DIAGRAMS

3-1. IC PIN DESCRIPTION• IC501 MN101C49KSE (SYSTEM CONTROL)

Pin No. Pin Name I/O Pin Description

1 VREF– — A/D converter power supply (–) pin

2 VSM I S-meter voltage detection input

3 QUALITY I Noise detection input

4, 5 KEYIN1, 0 I Key input 1, 0

6 RCIN0 I Rotary commander key input

7 – 9 NIL I Not used. (Fixed at L in this set)

10 VREF+ — A/D converter power supply (+) pin (+5 V)

11 VDD — Power supply pin (+5 V)

12 OSCOUT O Main clock output (18.432 MHz)

13 OSCIN I Main clock input (18.432 MHz)

14 VSS — Ground

15 XIN I Sub clock input (32.768 kHz)

16 XOUT O Sub clock output (32.768 kHz)

17 MMOD I Not used. (Fixed at L in this set)

18 LCDSO O Serial data output for LCD driver IC.

19 LCDCE O Chip enable output for LCD driver IC.

20 LCDCKO O Serial clock output for LCD driver IC.

21 CD_TSO O Serial data output for CD servo IC.

22 CD_TSI I Serial data input from CD servo IC.

23 CD_TCKO O Serial clock output for CD servo IC.

24 SYSRST O System reset output (Used for CDX-CA680X only)

25 BUSON O BUS ON output (Used for CDX-CA680X only)

26 KEYACK I Key acknowledge detection input

27 DAVN I RDS data block synchronization detection input

28 BUIN I Backup power supply input

29 SIRCS I SIRCS input

30 TU_ATTIN I Tuner attenuator control input

31 CD_PACK I CD text pack synchronization signal input from CD servo IC.

32 NC (VCC) — Power supply pin (+5 V)

33 RESET I Microcomputer reset input

34 NOSE-SW I Front panel attachment detection input

35 BEEP O Beep output

36 NC O Not used. (Open)

37 TESTIN I Test mode detection input

38 ACCIN I Accessory power supply detection input


40 TELATT I Telephone attenuator detection input

41 NC (VCC) I Not used. (Fixed at H in this set)

42 UNISO O SONY-BUS data output (Used for CDX-CA680X only)

43 UNISI I SONY-BUS data input (Used for CDX-CA680X only)

44 UNICKO O SONY-BUS clock output (Used for CDX-CA680X only)

45 I2C_SIO I/O I2C BUS serial data input/output


47 I2C_CKO O I2C BUS serial clock output

48, 49 NC O Not used. (Open)

50 CD_SELFSW I CD mechanism deck Self switch detection input

51 TSTB O CD text parameter strobe output for CD servo IC.

52 RFOK I RFOK signal input from CD servo IC.

53 CD_RST O Reset signal output for CD servo IC.

54 A0 O Command/parameter discrimination signal output for CD servo IC.

55 STB O Data strobe signal output for CD servo IC.

14

CDX-CA680X/L580X

Pin No. Pin Name I/O Pin Description

56 X_EN O Not used. (Open)

57 LIMIT I CD mechanism deck Limit switch detection input

58 NCO O Not used. (Open)

59 D_SW I CD mechanism deck Down switch detection input

60 INSW I CD mechanism deck Disc in switch detection input


62 CD_LM_LO O CD mechanism deck loading motor control output (Loading direction)

63 CD_LM_EJ O CD mechanism deck loading motor control output (Eject direction)

64 – 66 NC O Not used. (Open)

67 ATT O System attenuator control output

68 DIAG I Mode input from power amp IC.

69 STB O Standby control output for power amp IC.

70 VOLATT O Electronic volume attenuator control output


75 DOOR-IND O Sub panel power supply control output


85 NS_MASK O Noise mask output

86 E2P_CKO O EEPROM serial clock output

87 E2P_SIO I/O EEPROM serial data input/output

88 TU-ATT O Tuner attenuator control output


91 AD_ON O Key power supply control output


94 PANEL_SW I Not used. (Fixed at L in this set)

95 DAVSS — D/A converter power supply (–) pin

96 COLSW I Key illumination 1 color/2 color select initial setting input (Fixed at L in this set)

97 FLASH_W I Flash microcomputer write detection input

98 RCIN1 I Rotary commander SHIFT key input


100 DAVDD — D/A converter power supply (+) pin (+5 V)

15 15

CDX-CA680X/L580X

84

85

82

83

1612

D/ACONV

TRACKINGERROR

FORCUSERROR

1

OSC

EFMDEMOD

SERVOCTL

RFEQ

5256

DSUB CODEPROCESS

8

7

6

5

4

3

2

60

50

57

59

3151

21

22

23

55

54

53

52

I/F

87

86

97

98LD

DRIVEQ1

FOCUSCOIL

DRIVE

TRACKINGCOIL

DRIVE

SLEDMOTORDRIVE

SPINDLEMOTORDRIVE

LOADINGMOTORDRIVE

6

5

23

2

16

15

17

18

13

14

11

12

9

10

26

62 63 64 65

63

62

33

M902(SLED)

M901(SPINDLE)

M903(LOADING)

SW3(LIMIT)

SW2(SELF)

SW5(DOWN)

SW1(DISC IN)

X116.9344MHz

OPTICAL PICK-UP(KSS-720A)

I-VCONV.

CDLCDR

CD PACKTSTB

STB

AO

CD_TSO

CD_TSI

CD_TCKO

CD_RST

RFOK

INSW

LIMIT

CD_SELFSW

D_SW

CD_L_ LO

CD_LM_EJ

TUNERSECTION

A

23 24

M

M

M

IC602

B.UP+B

LOUTROUT

PACKTSTB

SI

RFOK

SO

SCK

STB

AO

RST

RESET

A

C

B

D

E

F

PD

LD

A

C

B

D

E

F

PD

LD

LD AMP

FOCUSCOIL

TRACKINGCOIL

FDFSC+

FSC-

TRK+

TRK-

SL-

SL+

SP-

SP+

LD-

LD+

TD

SD

MD

LOAD

EJECT

SYSTEM CONTROLIC501 (1/3)

RF AMP,DIGITAL SERVO,DIGITAL SIGNAL PROCESSOR

IC1

FOCUS/TRACKING COIL DRIVE,SLED/SPINDLE/LOADING MOTOR DRIVE

IC2

FD TD SD MD

Signal path

: CD

A5V

AU5V

D5V

DR6V

SERVO 5V

MECH6V

+ -

+ -

+ -

1

S702RESET

RESET 3

3-2. BLOCK DIAGRAM — CD SECTION —

(Page 16)

1616

CDX-CA680X/L580X

J1(ANTENNA) 1 ANT

CDL

CDR R-CH

3R-CH

9RDS 16 910

8

MPX

VDD

RDS DEMODULATORIC51

SDASCL

DAVN4 OSCO

5 OSCI

AUDIO 8.3V

TUNER UNITTU1

6S-METER14TU-SDA


67

ACCIN 38

TELATT 40

STB 69BEEP 35

AUDIO OUT FRONT

CDSECTION

A

3

-1

11

CN601

19

FL+FL-

210

RL+RL-

412

13

7

FR+FR-

15

RR+RR-

TEST

ACC

ATT

16 +B(BATT)

8 GND

R-CH

F90110A

TU-ATTIN

QUALITY

NS-MASKBATT

BATT

17

19

18BATT

L

CA680X

R-2

R-CH

BUS INTERFACEIC580

1312891113

3

E2P_CKO86

VSM

13TU-SCLATT

BATT

68

TESTIN

DIAG

372

VOLATT70

SOUND CONTROLELECTRONIC VOLUME

IC401

VCC 22BUS-LCH

5

CD-LCH9

TV-LCH7

SDASCL

MUTE

CONT.

EVR

25

I2C_SIOI2C_CKO

4547

17E2P-SDA16E2P-SCL

5QUALITY

8MUTE-CONDITION7TU-MUTE

11TU-VDD

10VCC(8.3V)

27

87 E2P_SIO

DAVN

85

30TU-ATT88

6DATA I/O4CLK

2CLK

3CLK

CN580BUS

CONTROL IN

R-CH

1

25

29

BUSON 654

3

8

7

21

BUS AUDIO IN-3

J330

L

R-4

R-CH

AUDIO OUT REAR-1L

R-2

R-CH

BUSON

DATA OUTCLK INB/U-C

DATA IN

B/U-C

5 ANP-R

27

35

3734333130

6 ANT-R

BEEPSTB

4 SCL2 SDA

CONT.

97

620

POWER AMPIC750 (1/2)

MULTIPLE VOLTAGEREGULATORIC750 (2/2)

AUDIO 8.3V

VP2VP1

• Signal path

: FM

: CD

• R-ch is omitted due to same as L-ch.

12

SYSRST 24BUSON 25

UNISI 43UNICKO 44

UNISO 42BU IN 28

4L-CH

OUT-FL

19

OUT-RL

18

+5V REG.Q1

BACK-UP CHECK/LOW VOLTAGE

CHECKQ581,582

OVER VOLTAGEDET.

Q580,D580,581

LINE MUTECONTROLQ478,479

TELATT

Q651

I2CBUS

ACCDETECT

Q631

MUTEQ441

MUTEQ461

11

MUT

E

TONE

INPU

T SE

LECT

OR

EFFECT

Q22

X514.332MHz

53

DIAG

AMP-REM

ANT-REM

B.UP+BPANEL+BMECH 6V

SERVO 5VAUDIO 8.3V

B.UP+BPANEL+BMECH 6VSERVO 5VAUDIO 8.3V

VP

D759

D760

CA680X

CA680X

L580X

MUT

E

1622I2C

BUS2726

3-3. BLOCK DIAGRAM — TUNER SECTION —

(Page 15)

17 17

CDX-CA680X/L580X

3-4. BLOCK DIAGRAM — DISPLAY SECTION — 3-5. CIRCUIT BOARDS LOCATION

MAIN board

SERVO board

LIMIT board

SUB (CD) board

tuner unit(TU1)

SUB board

DISC IN board

KEY board

IC1 uj (RFO)

• Waveforms— Servo Board —(MODE: CD PLAY)

1

2

3

IC1 ts (PACK)

0V

1.8Vp-p

16.9344MHz

IC1 wd (XTAL)

0V

4

Approx. 620mVp-p

IC1 oa (FEO)

5

Approx. 200mVp-p

IC1 od (TEO)

2.4Vp-p

4.8Vp-p

3.4msec

32.768kHz

IC501 qh (XOUT)

— Main Board —

1

2

3

18.432MHz

IC501 qs (OSCOUT)

5Vp-p

4.332MHz

IC51 4 (OSCO)

4.5Vp-p

2.3Vp-p

LSW901,904-910,912-922

S902,903,911

KEYACTIVEQ664

LEDDRIVER

Q701

REMOTERECEIVE

J561(REMOTE IN)

IC971

X50232.768kHz

15

16

12

13

5 1820194

26

91

986

29


LCD DRIVERIC901

KEYIN0 DATACLKCE

LCDSOLCDCKO

LCDCEKEYIN1

KEY ACK

AD_ON

RCIN1RCIN0

SIRCS

75 DOOR-IND

34 NOSE-SW

XIN

XOUT

OSCOUT

OSCIN

X50118.432MHz

7778

76

COM1

COM4

LCDLCD901

PANEL+B

PANEL+BLSW901,904-910,912-922LED903,911,933,934,951-954

LED933,934(LCD BACK LIGHT)

D502

S801

D501

65|

68|

SEG1

SEG64

1|

64|

DICLCE

KEYILLUMINATION( )

Z

S501(NOSE DET)

LED801(DOOR INDICATOR)

LED802

Z

KEY MATRIX

2

1818

CDX-CA680X/L580X

1

A

B

C

D

E

F

G

H

I

234567891011121314

SW5

CN2

3-6. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 17 for Circuit Boards Location. : Uses unleaded solder.

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note isprinted in each block.)

for schematic diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwisespecified.

• % : indicates tolerance.• f : internal component.• C : panel designation.

• A : B+ Line.• Power voltage is dc 14.4V and fed with regulated dc power

supply from ACC and BATT cords.• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

F : FMf : MWJ : CD

for printed wiring boards:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• a : Through hole.• : Pattern from the side which enables seeing.

(The other layer’s patterns are not indicated.)

Note: The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified.

Caution:Pattern face side: Parts on the pattern face side seen from the(Side B) pattern face are indicated.Parts face side: Parts on the parts face side seen from the(Side A) parts face are indicated.

19 19

CDX-CA680X/L580X

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13 14

TP8

C4

C26

TP1

TP2

TP3

TP4

TP5TP87

TP86M903

TP57

TP77

TP11

TP79

TP83

TP70

TP10

TP9

TP27

TP12

TP78

TP31

TP81

TP84

TP54

TP25

TP24

TP37

TP39

TP36

TP38

TP40

TP45

TP22

TP88

TP41

TP46

TP30 TP21

M902 M901

CN1

TP17

TP20

TP42

C44

TP19

TP28

TP90

C41

TP29

TP15

TP33

TP73

TP14

TP18

TP48

TP71

TP51

TP49

TP52

TP55

TP75

TP53

TP56

TP43

TP58

TP61

TP74

TP60

TP68

TP80

TP7TP62

TP91

TP63

TP66

TP64

TP69

TP72

TP50

TP26

TP32

TP59

TP76

BP4

BP3BP1

BP2

R8R9

R5

R7

R12

R14

R15

R10

R17R18

R19

R20

R22

TP92FB5

C3

C5

C6

C8

C9 C10

C11 C1

3C1

4

C16

C18C19

C24C25

C29

C34

C36

C38

C35

C22

C30

TP6

C23

C1

C27

R21

TP47

C15 C20

TP35

TP23

R6

C17

TP82

TP44

Q1

R26

TP34

TP89

R3

TP16

TP85

R31

CN1

IC1

IC2

C43

R30

R29

CN3

X1

C70

C71

SW1SW3

SW2

(Page 21)

: Uses unleaded solder.

2020

CDX-CA680X/L580X

IC B/D

IC B/D

TP77TP78

R29R30

C43

TP79TP80

TP81TP82TP83TP84

CN2

CN3

SW3

M902

M901

TP1TP4

SW2

SW1

TP5TP2

TP3

M903

TP87

TP86

TP9 TP8

R3 R26

C4

TP10

C13

R5

C11

C10

C8

TP7

TP92

R6

TP15

TP14

TP17TP20TP16TP19

TP21

TP18

BP4

BP3

R7

C17

TP11

TP12 C9

C14

TP89

C19

C20 C23

R9

R8 TP

22TP

23TP

24TP

25

TP88

C26

TP31BP1

BP2TP33

TP32R14R15

TP30

R12

R10

TP91

TP90

TP29

TP28TP26

TP27

R21

R22

R31

C44

TP6

TP34TP35

TP36

TP46

TP37TP38TP39TP40

TP41TP42TP43TP44TP45

CN1

R18

R19

R20

R17

TP66

TP62TP47TP63TP48

TP49TP64TP50

TP51

TP52TP68TP53TP69TP54TP70TP55TP71TP56TP72TP57TP73TP58TP74TP59TP75TP60TP76TP61

IC1

X1

C1 C5 C3C6

TP85

C15

C16C70

C24

C35

C38

C36

FB5

C25

C34

C71

C29

C27

C41

C22

C30

C18

Q1

SW5

IC2

CN1

3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION — • Refer to page 17 for Waveforms and page 18 for Common Note on Schematic Diagram.

• Refer to page 27 for IC Block Diagrams.

Note:• Voltage is dc with respect to

ground under no-signal conditions.no mark : CD PLAY

(Page 23)

21 21

CDX-CA680X/L580X

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

Q43

1

Q44

1

Q47

8

Q47

9

C582

Q651

Q58

2

R519

R50

8

R509C506

C505

R51

3

R51

4

D501

C621

C504

C508

C507

R510

R511 R512

Q664

R517

R51

8R523

R524R52

5

R52

6

R527

R528

R530

JC701

JC532

JC40

1

JC21

JC40

9

JC407

R404

R403

C411

C413

R40

5

R406R407R409

R408R401

R402

D1

C6

C409

JC1

R2

R3

C2C1

Q22

R29

JC59

R60C58

C59

C62

IC51

C54

R54

R56

C55

C56

R57

R62

R61C64

R501

R533

C501

R50

3

D502

R582

D580

Q58

1

D583

D761

D762

R65

1

R653

R654

D651

R60

9

D609

R632

R634

R633

Q63

1

R636

JC584

D582

Q58

0

JC582

JC63

1

JC60

9

JC65

1

R521

R522

C580

R581

R580

JC581

R585

R584

D581

R583R

532

JC75

4JC88

Q70

1

R531

R701R702R703

R704

D715

D70

4

D711

JC533

R44

1

R43

1R

461

R45

1

JC444

JC44

1

JC43

1

R333

R33

1R332

R330C3

30

C331

C751

JC75

3

R432

R44

2

C57

R502

R515

R516

C343

L304

L305

D752

JC53

JC58

0

R674 R67

1R

672

C602

JC53

0

R53

4

JC755

IC401

R75

6

C755

R75

2

C7

R47

9R

480

C480 D480

D479

JC479

IC58

0JC406

D755

D756

R43

3

R44

3

R1

C764C765

R53

6

R53

5

C334

C335

C402C403C404C405

C617

C618

C61

C452

C462

C432

C442

C756

Q1

IC501

R538

R453Q

451

R452

C333C332

R462

Q46

1

R463

JC29

IC602

JC756

D712

C420

C421

C406

C407

C509

R720

JC30

3

R50

4

R50

5

R673

L303

L307

L302L306

L1

L502

R999

R540R541

C11

JW1

JW2JW3

F901

JW4

JW5

JW7JW

8

JW10

JW11

JW12

JW13

JW14

JW15

JW16

JW17

JW18

JW19

JW20JW

21

JW22

JW23

JW24 JW

25

JW26

JW27

JW29

JW30JW31

JW32

JW33

JW34

JW35

JW36

JW37

JW38

JW39

JW40

JW41

JW42

JW44

JW45

JW46

JW47

JW48JW

49

JW50

JW51

JW52

JW53

JW54

JW55

JW56

JW57

JW58

JW59

JW60

JW61

JW62

JW63

JW64

JW65

JW69

JW70JW

71

JW73

JW74JW

75

JW76

JW77

JW78 JW79

JW80

JW81JW82

JW83

JW84

JW85

JW86

JW87

JW88

JW89

JW90

JW91

JW96

JW100

JW101

R631L301

L501

JW103

JW10

4

JW10

5

J561

CN580

CN601

J330

C431

C461C451

JW10

2

C3

C401

C4

JW93

D71

9

D71

6

D71

7

D71

8

D72

0

D71

0

CN702

X501 C503

JW67

JW66

S702

CNP3

01

C301

C305

C302

R65

2

TH580

C601

L601

J1

TU1

C51

X51

C5

C412

C479

C761

C757

C303

X502

C758

C441

C622

C623

R52

0

C581

D75

7

D759

D760

D601

C631

JW9

D75

8

D75

1

D75

3

JW68

S501

C760

C759

IC750

JW92

JW28

JW106

JW107

JW108

C753

C754

C410

D75

4

JW10

9

JW110

C408

JW99

JW98

R53

9

CN33

0

JW95

JW97

3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 17 for Circuit Boards Location and page 18 for Common Note on Printed Wiring Boards. : Uses unleaded solder.

(Page 24)

(Page 19)

D758 D-8D759 D-8D760 D-8D761 D-9D762 D-9

IC51 G-3IC401 E-4IC501 H-6(IC580) F-9IC602 J-8IC750 B-6

Q1 F-3Q22 E-2Q431 C-3Q441 C-4Q451 C-4Q461 C-3Q478 E-5Q479 E-5Q580 E-10<Q581> E-10<Q582> F-10Q631 F-8Q651 D-8Q664 H-8Q701 H-4

Ref. No. LocationD1 F-3D479 E-5D480 E-6D501 I-7D502 I-6D580 E-10D581 E-9(D582) E-9(D583) F-9D601 D-9D609 D-9D651 D-8D704 I-4D710 I-2D711 J-3D712 I-2D715 J-4D716 I-3D717 I-3D718 I-3D719 I-3D720 I-2D751 D-7D752 B-7D753 D-7D754 D-7D755 C-5D756 D-5D757 D-6

• Semiconductor LocationRef. No. Location

( ) : CDX-CA680X only< > : CDX-L580X only

2222

CDX-CA680X/L580X

3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 17 for Waveforms and page 18 for Common Note on Schematic Diagram.

• Refer to page 27 for IC Block Diagrams.

Note:• Voltage is dc with respect to ground under no-signal

(detuned) condition.no mark : FM( ) : MW< > : CD PLAY

∗ : Impossible to measure

(Page 23)

IC B/D

IC B/D

IC B/D

C51

C412

C479

C631

C758

D752

D755

D756

D757

D759

D760

R60

R406

R407

R408

R409

R431 R433

R441 R443

R451 R453

R461 R463

R479

R480

R752R61 R62

D761

D762

R452

R442

R462

R54

R1

R634

R633 R654

R653 R651

D651

D751

D758

D753

D754

JC29

C3

C64

C59

C62

C61

C58

C56

C54

C421

C404

C405

JC406

JC407

JW95

JW97

C420

C413

JC441

JC431 C432

C452

C442

C462

JC755

C480

R631

JC754

JC753

C751

C765 C764

C617

C602

C618

C6

R652

D480

Q479

Q478

JC479

JC444

Q461

Q441

JC59C5

D1

C4 C1JC1

C57

Q451

R432Q431

Q631

Q651

JC756

D609

D601

C401

C406

C407

C756

R756

L1

X51R57

R56

R636

R3

R2J1

TU1

R29

Q22

R402 R401

C409

JC409C408

C411

R403

C410 R404

C402

C403

D479

F901

J330

CN330

C335

C330C331

C332C333

R330R331R333

R332

C334

C7

C753R609

L601

R632

C759

C760

C761

C757

C754

C11

Q1

IC401

C755

CN601

IC750

JC651

JC631

JC609

C2

C451

C431

C441

C461

C55

C601

R405

IC51

23 23

CDX-CA680X/L580X

IC B/D

D71

0D

711

D71

6

D71

7D

718

D72

0

R502R503

R508R509

R515

R516

R523

R524R525

R526

R527

R671

JC533

R672

R518

R517

R674

R583

R501

R531

R512

R511R510

L501

X501

D71

2

D70

4

JC532

JC21

C501

C505

C506

C507

C509

C508

D580

TH580

R582

J561

R53

9JC530R530

R528

R534

R520

D502

C621

CN580

CN702

L502

R52

2

C504

C503

JC53

JC401

L303

C305

C301

C343

R720

R504R505

R513 R514

CNP301

C303

JC701

R701

R702

R703

R704

JC580 JC581 JC582

D71

9D

715

R999

JC88

R538

R532 R533

D501

X502

R540 R541

S501R519

R52

1

R53

6

R53

5

IC602

IC580

JC584

R580R581

R584

Q664

R585

C580

C581

D583D582

R673

D581Q581

Q580

Q582

L301 L304

L305

JC303

L306

IC501

Q701

S702

C622

C623

C582

L307

L302C302

3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 18 for Common Note on Schematic Diagram and page 27 for IC Block Diagrams.

(Page 20)

(Page 26)

(Page 22)


(detuned) condition.no mark : FM( ) : MW< > : CD PLAY

∗ : Impossible to measure

2424

CDX-CA680X/L580X

3-11. PRINTED WIRING BOARD — RELAY SECTION — • Refer to page 17 for Circuit Boards Location and page 18 for Common Note on Printed Wiring Boards. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11

CN801

CN802

LED801

LED802

S801

FMA3

(Page 25)

(Page 21)

25 25

CDX-CA680X/L580X

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13 14

S903

LSW904

LSW905

LSW906

LSW907

LSW908

LSW909 LSW910

S911

LSW912

LSW915LSW916LSW917LSW918LSW919LSW920

LCD901

LSW921LSW922

LSW901

R91

1

R90

4

R91

2

R91

3

LSW913

LED

953

LED

903

LSW914

LED

911

LED

951

LED952

IC971

LED954

LED933LED934

R95

0R

951

R966

R96

7

R93

6R

935

S902

R98

6

R98

8

C982

C984R98

7C9

83C981

C985

C986

R98

1

R982

R98

3

R98

5

R989

R99

0

D901

R975

R97

6

R97

7

R97

9

R97

8

R98

0

R971

R97

2

R901

R90

2

R90

3 R90

5 R90

6R

907

R90

8

R90

9

R91

0

R914R915R916

R917

R918

R91

9

R920

R92

1

D98

1

R94

1

R94

2 R946

R94

7

D98

3

D90

2

C971

R970

FMB5

FMB6

CN901R927

R92

8

R929

R960

R961

R962

R934

R93

1

R93

0

IC901

3-12. PRINTED WIRING BOARD — KEY SECTION — • Refer to page 17 for Circuit Boards Location and page 18 for Common Note on Printed Wiring Boards. : Uses unleaded solder.

(Page 24)

LED911 C-14LED933 C-11LED934 C-4LED951 C-14LED952 C-12LED953 C-1LED954 A-2

Ref. No. LocationD901 H-10D902 G-11D981 G-6D983 H-6

IC901 G-8IC971 C-13

LED903 C-2

• Semiconductor LocationRef. No. Location

2626

CDX-CA680X/L580X

3-13. SCHEMATIC DIAGRAM — KEY SECTION — • Refer to page 18 for Common Note on Schematic Diagram.


(detuned) condition.no mark : FM

(Page 23)

R901 R902 R903

R911 R912 R913

D901

R972

R975

R976R977

R978

R979

R980

R990

D98

3

R909 R910R907 R908

R917 R918 R920R919R916R915R914

R904 R905 R906

R986

R988R987R989

R981 R982 R983

R921

IC901

LED903

LED953

LED952

LED951

LED911

LED954

LED933

LED934

R927

R928

R935

R936

LSW912(2/2)LSW913(2/2)

LSW913(1/2)

LSW914(2/2)

LSW914(1/2)

LSW901(2/2)

LSW901(1/2)

LSW915(2/2)

LSW915(1/2)

LSW916(2/2)

LSW916(1/2)

LSW917(2/2)

LSW917(1/2)

LSW918(2/2)

LSW918(1/2)

R941

R942

LSW919(2/2)

LSW919(1/2)

LSW920(2/2)

LSW920(1/2)

LSW921(2/2)

LSW921(1/2)

LSW922(2/2)

LSW922(1/2)

R946

R947

LSW905(2/2)

LSW905(1/2)

R950

R951

LSW906(2/2)

LSW906(1/2)

LSW909(2/2)

LSW909(1/2)

LSW910(2/2)

LSW910(1/2)

R960

R961

LSW908(2/2)

LSW908(1/2)

LSW904(2/2)

LSW904(1/2)

R966

LSW907(2/2)

LSW907(1/2)

C981

C986

C985C982

R929

C971

R985

C983 C984

R971

S911 LSW912(1/2)

S902 S903

LED802

LED801

CN802 CN901

S801

IC971

LCD901

CN801

D981

R970

D902

R930

R931

R934

R962 R967

27 27

CDX-CA680X/L580X

76

75

AGCI

AGCO

74

RFI

73

C3T

72

ASY

71

EFM

70

AVDD

69

7E D

AC3

68

7D D

AC2

67

7C D

AC1

66

7F D

AC0

65

MD

64

SD

63

TD

62

FD

60

ATES

T

59

TEST

1

58

TEST

0

57

DGND

56

TSTB

55

TSCK

54

TSI

53

TSO

52

PACK

51

DVDD

61

AGND

1

DGND

2

RFOK

3

RST

4

A0

5

STB

6

SCK

7

SO

8

SI

9

XTAL

EN

10

DVDD

11

DAVD

D

12

ROUT

13

DAGN

D

REGC

16

LOUT

17

DAVD

D

18

R+

19

R–

20

L+

21

L–

22

XVDD

23

XTAL

24

XTAL

25XG

ND1514

DAGN

D

77RFO

78EQ2

79EQ1

80RF-

81AGND

82A

83C

84B

85D

86F

87E

88AVDD

89REFOUT

90FE-

91FEO

92TE-

93TEO

94TE2

95

AGND

TEC

96

PD 97

98LD

PN 99

100AVDD

50 C2D3

49 C2D2

48 C2D1

47 C1D2

46 C1D1

45 DGND

44 PLCK

43 MIRR/WFCK

42 RFCK

41 LOCK

40 DVDD

39 TSOI

38 C16M

37 DGND

36 TX

35 HOLD/WDCK

34 LRCK

33 LRCKIN

32 SCKO

31 SCKIN

30 DOUT

29

28

DIN

FLAG

27 EMPH

26 DVDD

EFM

COMPARATOR

EFM

EFM

DEFECT

FOK

A3T

MIRR

FEO

TEO

TEOFS

FEOFS

RFAMP BLOCK

SWITCH

MICROCOMPUTER INTERFACE SCF OSC

FOCUS REGISTER

TRACKINGREGISTER

OCTUPLEDOVERSAMPLING DIGITAL FILTER

NOISE SHAVER

OUTPUT BUFFER

NOISE SHAVER

OUTPUT BUFFER

DE-EMPHASIS CIRCUIT

D/AINTERFACE

CIRCUIT

OUTP

UT P

ROCE

SSOR

DIGITALAUDIO

INTERFACE

DIGITAL PLL

TIMING GENERATOR

EFM DEMODULATOR

ERRO

RCO

RREC

TION

PROC

ESSO

R

MICROCOMPUTER INTERFACE

CD-TEXT DECODER

SUB-CODE PROCESSOR16K

SRAM

D/A

AUTO GAIN CONTROLLER

FD/TD/SD/MDCONTROLLER

ADDER

SVDRAM

MULTIPLIER SVCRAM

SVROM ROMDECODER

CLVPROCESSOR

DEFECTCOMPARATOR

RFENV

MIRENV

A/D

CONV

ERTE

RMEMORY

PROCESSOR

COMPARATOR

IC51 SAA6588T/V2-518

IC1 µPD63711GC-8EU

3-14. IC BLOCK DIAGRAMS

SCOU

T

MRO

MPT

H

TCON

OSCO

OSCI

VSSD

VDDD

DAVN SD

A

VREF

MPX

VSSA

VDDA

AFIN

MAD

PSW

N

SCL

21 6

15 111316 14 12

INTERFACEREGISTER

SIGNAL QUALITYDECODER

CLOCKEDCOMPARATOR

POWER SUPPLY& RESET

TESTCONTROL

OSCILLATOR& CLOCK

PAUSEDETECTORMULTI

PATHDETECTOR

57kHz8th ORDER

BAND-PASS FILTER

RDS/RDBSDECODER

RDS/RDBSDEMODULATOR

IIC BUS SLAVETRANSCEIVER

1718

CIN

19

LVIN

20

87

DATA

CLOCK

DATA

CLOCK

44

5

9 103 4 5

IC580 MM1175XFF (CDX-CA680X only)

IC2 BA5810FP-E2

1FWD

+–

+–

+

–

2REV LOADING PREFWD REV

3LDCONT

6IN2

7PREVCC

8POWVCC

VOL–

VOL+

IN1

4PS

+–

LEVEL SHIFT+

–

+

–

LEVEL SHIFT

LEVEL SHIFT+

–

POWERSAVE

CH1-4MUTE

X3

9

10

11VO2–

12VO2+

13VO1–

14VO1+

5

BIAS

OPIN4+OPIN4–

OPIN3–

OPOUT3

MUTE

POWVCC

GND

OPIN3+

OPOUT4

VO3–

VO3+

VO4–

VO4+

7.5k

7.5k

16k

16k

7.5k

7.5k

16k

16k

10k10k

10k

10k

10k

10k

10k

10k

10k

10k

10k

10k

+ –

+–

+ –

LEVEL SHIFT +

–

+–

+

–

10k

10k

10k

10k

+–

28

2726

23

22

21

25

20

19

18

17

16

15

24

POWVCC34(CH3,CH4)

PREVCC(PRE.LOADING)

POWVCC12(CH1.CH2)

VCC

RESETIN

BUS ONIN

CLKIN

BATTCHECK

DATAIN

DATAOUT

BUS ONOUT

RESETOUT

BATT

CLKOUT

VREF

DATAIN / OUT

GND

1

2

3

4

5

6

7 8

9

10

11

12

13

14

RESETSWITCH

BATTSWITCH

2828

CDX-CA680X/L580X

IC401 BD3802F-FE2 IC750 TDA8588J/N1

28 27 26 25 24 23 22 21 20 19 18 17

I2C BUSLOGIC

16 15

VCO

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

EFFECT (OFF,6dB,10dB,14dB)

EFFECT (OFF,6dB,10dB,14dB)

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

INPUT GAIN(0~15dB,1dB STEP)

INPUT SELECTOR(4 STEREO INCLUDE 1 ISOLATION INPUT)

INPUT GAIN(0~15dB,1dB STEP)

MUTE MUTE

6 7 8 9 10 11 123 4 521

D-GND

A-GND FIL BUS-RCH

AN BUS-LCH

TU-RCH

TU-LCH

CD-RCH

CD-LCH

D1 D2 DS1113

DS2114

DS31

SDA SCL MUTE SEL ADJ VCCOUT-RL

OUT-RR

OUT-FL

OUT-FR DS32 DS22 DS12

VCC

VCC/2

ON OFF ON OFF

TONEPASS

TONEPASS

MUT

EM

UTE

ENABLELOGIC

STANDBY/MUTE

BATTERYDETECTION

CHIP DETECT/DIAGNOSTIC

PROTECTION/DIAGNOSTIC

SWITCH

REGU

LATO

R

SWITCH

REFERENCEVOLTAGE

LOADDUMPPROTECTION

TEMPERATUREPROTECTION

BACK-UPSWITCHREGULATOR

1

3

5

7

9

11

13

15

17

19

21

23

25

27

29

31

33

35

37

2

4

6

8

10

12

14

16

18

20

22

24

26

28

30

32

34

36

TAB

OUT-FL-

OUT-FL+

OUT-RL-

OUT-RL+

IN-RL

S-GND

IN-RR

OUT-RR+

OUT-RR-

OUT-FR+

OUT-FR-

DIAG

ANT-REM

AMP-REM

SERVO5V

MECH6V

VP

B.UP+B

SDA

SCL

VP2

PGND3

SVR

IN-FL

IN-FR

BEEP

PGND2

VP1

STB

PGND1

RST

CRES

AUDIO8.3V

GND

PANEL+B

CBU

FL

RL

RR

VP

FR

I2C BUS

29


EXPLODED VIEWS

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color• Accessories are given in the last of this parts list.

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

Ref. No. Part No. Description Remark

4-1. CHASSIS SECTION

R

Ref. No. Part No. Description Remark

R

11

12

10

10

14

13

#1

#1

MG-393XA-121//Q

#2#1

3

1

4

7 89

52

2

2

2#1

#1

#1

not supplied

not supplied

not supplied

not supplied

6

1 3-243-177-01 CUSHION (SUB PANEL)2 3-042-244-01 SCREW (T)3 X-3382-700-1 PANEL ASSY, SUB4 1-686-703-11 SUB BOARD5 1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE)

6 X-3376-699-6 GEAR ASSY7 3-030-909-03 DAMPER, OIL8 3-713-786-51 SCREW +P 2X3

9 X-3381-381-3 LOCK ASSY10 3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT11 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)12 3-246-450-01 BRACKET (CD)13 3-246-441-01 BUTTON (EJECT)

14 3-246-481-01 PLATE (TU), GROUND#1 7-685-792-09 SCREW +PTT 2.6X6 (S)#2 7-685-790-01 SCREW +PTT 2.6X4 (S)

30

CDX-CA680X/L580X

4-2. MAIN BOARD SECTION

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

F901

TU1

51

52

#4

not supplied

not supplied

#3#3

#3

#3

#5

#3

#3

51 A-3274-581-A MAIN BOARD, COMPLETE (L580X)51 A-3274-585-A MAIN BOARD, COMPLETE (CA680X)52 1-790-355-71 CORD (WITH CONNECTOR) (RCA)

(AUDIO OUT FRONT) (CA680X)F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

TU1 A-3220-887-A TUNER UNIT (TUX-030)#3 7-685-793-09 SCREW +PTT 2.6X8 (S)#4 7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT#5 7-685-795-09 SCREW +PTT 2.6X12 (S)

31

CDX-CA680X/L580X

4-3. FRONT PANEL SECTION

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

#6

#6

not supplied(KEY board)

LCD901

not supplied

not supplied

not supplied

not supplied

not supplied

not suppliednot supplied

not supplied

101

102107

103

104

105

106

101 A-3315-881-A PANEL COMPLETE ASSY, FRONT (L580X)101 A-3315-894-A PANEL COMPLETE ASSY, FRONT (CA680X)102 X-3382-703-1 PANEL ASSY, FRONT (L580X)102 X-3382-744-1 PANEL ASSY, FRONT (CA680X)103 X-3383-105-1 BUTTON ASSY (S)

104 1-694-976-11 CONDUCTIVE BOARD, CONNECTION

105 X-3382-702-1 PANEL ASSY, FRONT BACK106 X-3383-264-1 CASE (PANEL) ASSY (for FRONT PANEL)107 3-246-778-01 SPRING (OPEN)LCD901 1-805-076-11 DISPLAY PANEL, LIQUID CRYSTAL#6 7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT

32

CDX-CA680X/L580X

4-4. CD MECHANISM SECTION (1)(MG-393XA-121//Q)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

151

152153

154

155

161

159

156160

158

157

#7

#7

#9

#9 #7

#8

M903

C

C

not supplied

not supplied

not supplied

not supplied

not supplied

151 A-3315-247-B CHASSIS (T.U) ASSY152 3-931-909-01 SPRING (LR), TENSION153 1-683-664-11 DISC IN BOARD154 3-338-737-01 SCREW (2X3), +PS155 A-3315-040-A ROLLER ASSY, ARM

156 A-3283-270-A SERVO BOARD, COMPLETE157 1-683-666-11 PICK-UP FLEXIBLE BOARD

* 158 3-039-629-02 BRACKET (MOTOR)

159 3-225-784-01 SPRING (RA3), TENSION160 3-933-152-03 ROLLER (S)161 3-931-913-11 RING (ROLLER), RETAININGM903 A-3315-039-A MOTOR SUB ASSY, LD (LOADING)#7 7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3

#8 7-627-553-17 SCREW, PRECISION +P 2X2 TYPE3#9 7-628-253-00 SCREW +PS 2X4

33

CDX-CA680X/L580X



204201

206

207

208

210

212

211

209

202

202

202

203

213

207

215

D

D

214

205

216

216

not supplied

201 X-3378-956-8 ARM ASSY, CHUCKING202 3-931-897-61 DAMPER (T)203 3-039-627-01 LEVER (D)204 3-040-165-02 RETAINER (DISC)205 3-014-727-01 WHEEL (LW), WORM

206 3-931-895-01 SPRING (CH), TENSION207 3-931-898-01 SPRING (FL), COMPRESSION208 3-032-483-02 SPRING (KF1), TENSION

209 A-3315-243-D CHASSIS (M) ASSY210 3-220-180-01 SPRING (TR2), TENSION211 3-931-881-03 LEVER (LOCK)212 3-931-882-02 GEAR (MDL)213 3-007-537-11 WHEEL (U), WORM

214 3-007-536-05 LEVER (TR)215 3-032-484-01 SPRING (KR1), TENSION216 3-018-272-01 WASHER

34

CDX-CA680X/L580X




M902

M901

not supplied(SUB (CD) board)

not supplied(LIMIT board)

#7

#7

256

260

258259

255

254261

253

252

257

251

251 X-3378-598-3 CHASSIS (OP) ASSY (including M901)252 3-043-494-01 SPRING (SL), TORSION253 3-040-170-01 BASE (DRIVING)254 3-040-419-01 GEAR (MIDWAY)255 A-3291-669-A SHAFT (FEED) ASSY

256 3-025-743-01 SPRING (FEED), LEAF257 1-683-665-11 MOTOR FLEXIBLE BOARD

258 3-909-607-01 SCREW0259 8-820-103-11 OPTICAL PICK-UP KSS-720A/C-RP

260 3-338-737-01 SCREW (2X3), +PS261 3-241-673-01 SCREW (SM), SPECIALM902 A-3291-674-A MOTOR ASSY, SLED (SLED)

#7 7-627-553-37 SCREW, PRECISION +P 2X3 TYPE3

35


ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH



When indicating parts by referencenumber, please include the board.

KEYDISC IN

1-683-664-11 DISC IN BOARD*************

*************************************************************

KEY BOARD**********

1-694-976-11 CONDUCTIVE BOARD, CONNECTION

< CAPACITOR >

C971 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC981 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC982 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC983 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC984 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C985 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC986 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

< CONNECTOR >

CN901 1-817-158-21 PLUG, CONNECTOR 14P

< DIODE >

D901 8-719-085-72 DIODE UMZ6.8ENTRD902 8-719-083-66 DIODE UDZS-TE-17-18BD981 8-719-069-54 DIODE UDZS-TE-17-5.1BD983 8-719-404-50 DIODE MA111-TX

< IC >

IC901 8-759-826-21 IC LC75874WIC971 6-600-163-01 IC RS-770

< LIQUID CRYSTAL DISPLAY >

LCD901 1-805-076-11 DISPLAY PANEL, LIQUID CRYSTAL

< DIODE >

LED903 6-500-450-01 LED CL-195SR-CD-T (DSO)LED911 6-500-450-01 LED CL-195SR-CD-T (EQ3)LED933 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)LED934 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT)LED951 6-500-450-01 LED CL-195SR-CD-T (EQ3)

LED952 6-500-450-01 LED CL-195SR-CD-T (SEEK)LED953 6-500-450-01 LED CL-195SR-CD-T (DSO)LED954 6-500-450-01 LED CL-195SR-CD-T (SOURCE)

< SWITCH >

LSW901 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (OFF)LSW904 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (SEL)LSW905 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (+ (VOLUME))LSW906 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (– (VOLUME))LSW907 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (ATT)

LSW908 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (MODE)LSW909 1-771-883-11 SWITCH, TACTILE (WITH LED) (AF)LSW910 1-771-883-11 SWITCH, TACTILE (WITH LED) (SENS/BTM)LSW912 1-771-476-11 SWITCH, KEYBOARD (WITH LED) (DSPL)LSW913 1-771-476-11 SWITCH, KEYBOARD (WITH LED)

(+ > M SEEK)

LSW914 1-771-476-11 SWITCH, KEYBOARD (WITH LED)(SEEK m . –)

LSW915 1-771-883-11 SWITCH, TACTILE (WITH LED) (TA)LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (PTY/LIST)

(CA680X)LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (PTY) (L580X)LSW917 1-771-883-11 SWITCH, TACTILE (WITH LED) (6/ALBUM +)

(CA680X)

LSW917 1-771-883-11 SWITCH, TACTILE (WITH LED) (6) (L580X)LSW918 1-771-883-11 SWITCH, TACTILE (WITH LED) (5/ALBUM –)

(CA680X)LSW918 1-771-883-11 SWITCH, TACTILE (WITH LED) (5) (L580X)LSW919 1-771-883-11 SWITCH, TACTILE (WITH LED) (4/SHUF)LSW920 1-771-883-11 SWITCH, TACTILE (WITH LED) (3/REP)

LSW921 1-771-883-11 SWITCH, TACTILE (WITH LED) (2/DISC +)(CA680X)

LSW921 1-771-883-11 SWITCH, TACTILE (WITH LED) (2) (L580X)LSW922 1-771-883-11 SWITCH, TACTILE (WITH LED) (1/DISC –)

(CA680X)LSW922 1-771-883-11 SWITCH, TACTILE (WITH LED) (1) (L580X)

< RESISTOR >

R901 1-216-819-11 METAL CHIP 680 5% 1/10WR902 1-216-819-11 METAL CHIP 680 5% 1/10WR903 1-216-819-11 METAL CHIP 680 5% 1/10WR904 1-216-821-11 METAL CHIP 1K 5% 1/10WR905 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R906 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR907 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR908 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR909 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR910 1-218-867-11 METAL CHIP 6.8K 5% 1/10W

R911 1-216-819-11 METAL CHIP 680 5% 1/10W

36

CDX-CA680X/L580X


KEY MAIN

R912 1-216-819-11 METAL CHIP 680 5% 1/10WR913 1-216-819-11 METAL CHIP 680 5% 1/10WR914 1-216-821-11 METAL CHIP 1K 5% 1/10WR915 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR916 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R917 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR918 1-216-827-11 METAL CHIP 3.3K 5% 1/10WR919 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR920 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR921 1-216-833-11 METAL CHIP 10K 5% 1/10W

R927 1-216-025-11 RES-CHIP 100 5% 1/10WR928 1-216-021-00 METAL CHIP 68 5% 1/10WR929 1-216-017-11 RES-CHIP 47 5% 1/10WR930 1-216-017-11 RES-CHIP 47 5% 1/10WR931 1-216-041-11 RES-CHIP 470 5% 1/10W

R934 1-216-017-11 RES-CHIP 47 5% 1/10WR935 1-216-025-11 RES-CHIP 100 5% 1/10WR936 1-216-021-00 METAL CHIP 68 5% 1/10WR941 1-216-025-11 RES-CHIP 100 5% 1/10WR942 1-216-021-00 METAL CHIP 68 5% 1/10W

R946 1-216-025-11 RES-CHIP 100 5% 1/10WR947 1-216-021-00 METAL CHIP 68 5% 1/10WR950 1-216-025-11 RES-CHIP 100 5% 1/10WR951 1-216-021-00 METAL CHIP 68 5% 1/10WR960 1-216-025-11 RES-CHIP 100 5% 1/10W

R961 1-216-025-11 RES-CHIP 100 5% 1/10WR962 1-216-029-00 RES-CHIP 150 5% 1/10WR966 1-216-025-11 RES-CHIP 100 5% 1/10WR967 1-216-037-00 RES-CHIP 330 5% 1/10WR970 1-216-864-11 METAL CHIP 0 5% 1/10W

R971 1-216-821-11 METAL CHIP 1K 5% 1/10WR972 1-216-809-11 METAL CHIP 100 5% 1/10WR975 1-216-817-11 METAL CHIP 470 5% 1/10WR976 1-216-817-11 METAL CHIP 470 5% 1/10WR977 1-216-817-11 METAL CHIP 470 5% 1/10W

R978 1-216-817-11 METAL CHIP 470 5% 1/10WR979 1-216-817-11 METAL CHIP 470 5% 1/10WR980 1-216-817-11 METAL CHIP 470 5% 1/10WR981 1-216-811-11 METAL CHIP 150 5% 1/10WR982 1-216-811-11 METAL CHIP 150 5% 1/10W

R983 1-216-811-11 METAL CHIP 150 5% 1/10WR985 1-216-864-11 METAL CHIP 0 5% 1/10WR986 1-216-821-11 METAL CHIP 1K 5% 1/10WR987 1-216-821-11 METAL CHIP 1K 5% 1/10WR988 1-216-821-11 METAL CHIP 1K 5% 1/10W

R989 1-216-840-11 METAL CHIP 39K 5% 1/10WR990 1-216-857-11 METAL CHIP 1M 5% 1/10W

< SWITCH >

S902 1-771-884-11 SWITCH, TACTILE (WITH LED) (SOURCE)S903 1-771-884-11 SWITCH, TACTILE (WITH LED) (DSO)S911 1-771-884-11 SWITCH, TACTILE (WITH LED) (EQ3)

*************************************************************

A-3274-581-A MAIN BOARD, COMPLETE (L580X)A-3274-585-A MAIN BOARD, COMPLETE (CA680X)

*********************

7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT7-685-793-09 SCREW +PTT 2.6X8 (S)7-685-795-09 SCREW +PTT 2.6X12 (S)

< CAPACITOR >

C1 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC2 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC3 1-126-163-11 ELECT 4.7uF 20% 25VC4 1-124-589-11 ELECT 47uF 20% 16VC5 1-124-589-11 ELECT 47uF 20% 16V

C6 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC7 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC11 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC51 1-124-589-11 ELECT 47uF 20% 16VC54 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50V

C55 1-162-919-11 CERAMIC CHIP 22PF 5% 50VC56 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC57 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC58 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC59 1-162-959-11 CERAMIC CHIP 330PF 5% 50V

C61 1-164-505-11 CERAMIC CHIP 2.2uF 16VC62 1-164-739-11 CERAMIC CHIP 560PF 5% 50VC64 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC301 1-126-153-11 ELECT 22uF 20% 6.3VC302 1-126-153-11 ELECT 22uF 20% 6.3V

C303 1-126-153-11 ELECT 22uF 20% 6.3VC305 1-124-584-00 ELECT 100uF 20% 10VC330 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

(CA680X)C331 1-163-251-11 CERAMIC CHIP 100PF 5% 50V


C333 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC334 1-163-251-11 CERAMIC CHIP 100PF 5% 50V


(CA680X)C343 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC401 1-124-233-11 ELECT 10uF 20% 16V

C402 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V(CA680X)

C403 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V(CA680X)

C404 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC405 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC406 1-216-864-11 METAL CHIP 0 5% 1/10W

C407 1-216-864-11 METAL CHIP 0 5% 1/10WC408 1-136-154-00 FILM 0.012uF 5% 50VC409 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50VC410 1-136-154-00 FILM 0.012uF 5% 50VC411 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V

C412 1-124-589-11 ELECT 47uF 20% 16VC413 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC420 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC421 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC431 1-124-233-11 ELECT 10uF 20% 16V

37

CDX-CA680X/L580X


MAIN

C432 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC441 1-124-233-11 ELECT 10uF 20% 16VC442 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC451 1-124-233-11 ELECT 10uF 20% 16VC452 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V

C461 1-124-233-11 ELECT 10uF 20% 16VC462 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC479 1-124-589-11 ELECT 47uF 20% 16VC480 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC501 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V

C503 1-124-584-00 ELECT 100uF 20% 10VC504 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC505 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC506 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC507 1-162-919-11 CERAMIC CHIP 22PF 5% 50V

C508 1-162-918-11 CERAMIC CHIP 18PF 5% 50VC509 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50VC580 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

(CA680X)C581 1-126-935-11 ELECT 470uF 20% 16V

(CA680X)C582 1-165-319-11 CERAMIC CHIP 0.1uF 50V

(CA680X)

C601 1-135-473-21 ELECT 3300uF 20% 16VC602 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC617 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC618 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC621 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C622 1-125-710-11 DOUBLE LAYERS 0.1F 5.5VC623 1-124-584-00 ELECT 100uF 20% 10VC631 1-124-257-00 ELECT 2.2uF 20% 50VC751 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC753 1-124-589-11 ELECT 47uF 20% 16V

C754 1-124-257-00 ELECT 2.2uF 20% 50VC755 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC756 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC757 1-124-233-11 ELECT 10uF 20% 16VC758 1-124-233-11 ELECT 10uF 20% 16V

C759 1-124-233-11 ELECT 10uF 20% 16VC760 1-124-584-00 ELECT 100uF 20% 10VC761 1-124-233-11 ELECT 10uF 20% 16VC764 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC765 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

JW95 1-126-160-11 ELECT 1uF 20% 50VJW97 1-126-160-11 ELECT 1uF 20% 50V

< CONNECTOR >

* CN330 1-564-506-11 PLUG, CONNECTOR 3P (CA680X)CN580 1-580-907-31 PLUG, CONNECTOR (BUS CONTROL IN)

(CA680X)CN601 1-774-701-11 PIN, CONNECTOR 16PCN702 1-784-456-11 CONNECTOR, FFC/FPC 14PCNP301 1-764-617-12 PIN, CONNECTOR (PC BOARD) 30P

< DIODE >

D1 8-719-158-15 DIODE RD5.6S-BD479 8-719-404-50 DIODE MA111-TXD480 8-719-158-15 DIODE RD5.6S-BD501 8-719-404-50 DIODE MA111-TX

D502 8-719-404-50 DIODE MA111-TXD580 8-719-056-82 DIODE UDZ-TE-17-6.2B (CA680X)D580 8-719-056-84 DIODE UDZ-TE-17-7.5B (L580X)D581 8-719-056-93 DIODE UDZ-TE-17-18BD582 8-719-056-93 DIODE UDZ-TE-17-18B (CA680X)

D583 8-719-072-70 DIODE MA2ZD14001SO (CA680X)D601 8-719-049-38 DIODE 1N5404TUD609 8-719-056-83 DIODE UDZ-TE-17-6.8BD651 8-719-056-93 DIODE UDZ-TE-17-18BD704 8-719-056-93 DIODE UDZ-TE-17-18B

D710 8-719-109-97 DIODE RD6.8ES-B2D711 8-719-056-83 DIODE UDZ-TE-17-6.8BD712 8-719-056-83 DIODE UDZ-TE-17-6.8BD715 8-719-056-83 DIODE UDZ-TE-17-6.8BD716 8-719-109-97 DIODE RD6.8ES-B2

D717 8-719-109-97 DIODE RD6.8ES-B2D718 8-719-109-97 DIODE RD6.8ES-B2D719 8-719-034-94 DIODE MA4180-M(QZ)D720 8-719-109-97 DIODE RD6.8ES-B2D751 8-719-970-02 DIODE 1SR139-400

D752 8-719-053-18 DIODE 1SR154-400TE-25D753 8-719-970-02 DIODE 1SR139-400D754 8-719-970-02 DIODE 1SR139-400D755 8-719-053-18 DIODE 1SR154-400TE-25D756 8-719-053-18 DIODE 1SR154-400TE-25

D757 8-719-970-02 DIODE 1SR139-400D758 8-719-970-02 DIODE 1SR139-400D759 8-719-970-02 DIODE 1SR139-400D760 8-719-970-02 DIODE 1SR139-400D761 8-719-053-18 DIODE 1SR154-400TE-25

D762 8-719-053-18 DIODE 1SR154-400TE-25

< IC >

IC51 6-703-809-01 IC SAA6588T/V2-518IC401 6-703-304-01 IC BD3802F-FE2IC501 6-802-512-01 IC MN101C49KSEIC580 8-759-096-16 IC MM1175XFF (CA680X)IC602 8-759-682-69 IC XC61CN4302MR

IC750 6-703-375-01 IC TDA8588J/N1

< JACK >

J1 1-815-185-12 JACK (ANTENNA)J330 1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR) (L580X)J330 1-774-699-12 JACK, PIN 4P (AUDIO OUT REAR,

BUS AUDIO IN) (CA680X)J561 1-566-822-41 JACK (REMOTE IN)

< JUMPER RESISTOR >

JC1 1-216-296-11 SHORT CHIP 0JC21 1-216-296-11 SHORT CHIP 0JC29 1-216-864-11 METAL CHIP 0 5% 1/10WJC53 1-216-296-11 SHORT CHIP 0JC59 1-216-296-11 SHORT CHIP 0

JC88 1-216-821-11 METAL CHIP 1K 5% 1/10WJC303 1-216-864-11 METAL CHIP 0 5% 1/10WJC401 1-216-864-11 METAL CHIP 0 5% 1/10WJC406 1-216-296-11 SHORT CHIP 0JC407 1-216-296-11 SHORT CHIP 0

38

CDX-CA680X/L580X


MAIN

JC409 1-216-296-11 SHORT CHIP 0JC431 1-216-296-11 SHORT CHIP 0JC441 1-216-296-11 SHORT CHIP 0JC444 1-216-296-11 SHORT CHIP 0JC479 1-216-864-11 METAL CHIP 0 5% 1/10W

JC530 1-216-296-11 SHORT CHIP 0JC532 1-216-296-11 SHORT CHIP 0JC533 1-216-864-11 METAL CHIP 0 5% 1/10WJC580 1-216-296-11 SHORT CHIP 0JC581 1-216-296-11 SHORT CHIP 0

JC582 1-216-296-11 SHORT CHIP 0JC584 1-216-296-11 SHORT CHIP 0 (CA680X)JC609 1-216-296-11 SHORT CHIP 0JC631 1-216-296-11 SHORT CHIP 0JC651 1-216-296-11 SHORT CHIP 0

JC701 1-216-296-11 SHORT CHIP 0JC753 1-216-296-11 SHORT CHIP 0JC754 1-216-296-11 SHORT CHIP 0JC755 1-216-296-11 SHORT CHIP 0JC756 1-216-864-11 METAL CHIP 0 5% 1/10W

< COIL >

L1 1-469-844-11 INDUCTOR 2.2uHL301 1-410-501-11 INDUCTOR 2.2uHL302 1-469-876-11 INDUCTOR, FERRITE BEADL303 1-469-876-11 INDUCTOR, FERRITE BEADL304 1-500-245-11 INDUCTOR, FERRITE BEAD

L305 1-500-245-11 INDUCTOR, FERRITE BEADL306 1-500-245-11 INDUCTOR, FERRITE BEADL307 1-469-876-11 INDUCTOR, FERRITE BEADL501 1-410-501-11 INDUCTOR 2.2uHL502 1-469-844-11 INDUCTOR 2.2uH

L601 1-456-227-11 COIL, CHOKE 250uH

< TRANSISTOR >

Q1 8-729-106-68 TRANSISTOR 2SD1615A-GPQ22 8-729-900-53 TRANSISTOR DTC114EKQ431 8-729-920-21 TRANSISTOR DTC314TK-T-146Q441 8-729-920-21 TRANSISTOR DTC314TK-T-146Q451 8-729-920-21 TRANSISTOR DTC314TK-T-146

Q461 8-729-920-21 TRANSISTOR DTC314TK-T-146Q478 8-729-900-53 TRANSISTOR DTC114EKQ479 8-729-027-23 TRANSISTOR DTA114EKA-T146Q580 8-729-900-53 TRANSISTOR DTC114EKQ581 8-729-900-53 TRANSISTOR DTC114EK (L580X)

Q582 8-729-120-28 TRANSISTOR 2SC1623-L5L6 (L580X)Q631 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q651 8-729-120-28 TRANSISTOR 2SC1623-L5L6Q664 8-729-027-23 TRANSISTOR DTA114EKA-T146Q701 8-729-047-76 TRANSISTOR FMC2A-T148

< RESISTOR >

R1 1-216-821-11 METAL CHIP 1K 5% 1/10WR2 1-216-809-11 METAL CHIP 100 5% 1/10WR3 1-216-809-11 METAL CHIP 100 5% 1/10WR29 1-216-809-11 METAL CHIP 100 5% 1/10WR54 1-216-837-11 METAL CHIP 22K 5% 1/10W

R56 1-216-797-11 METAL CHIP 10 5% 1/10W

R57 1-216-817-11 METAL CHIP 470 5% 1/10WR60 1-216-797-11 METAL CHIP 10 5% 1/10WR61 1-216-864-11 METAL CHIP 0 5% 1/10WR62 1-216-864-11 METAL CHIP 0 5% 1/10WR330 1-216-821-11 METAL CHIP 1K 5% 1/10W

(CA680X)

R331 1-216-821-11 METAL CHIP 1K 5% 1/10W(CA680X)



R401 1-216-833-11 METAL CHIP 10K 5% 1/10WR402 1-216-833-11 METAL CHIP 10K 5% 1/10W

R403 1-216-833-11 METAL CHIP 10K 5% 1/10WR404 1-216-833-11 METAL CHIP 10K 5% 1/10WR405 1-218-882-11 METAL CHIP 30K 0.5% 1/10WR406 1-216-809-11 METAL CHIP 100 5% 1/10WR407 1-216-809-11 METAL CHIP 100 5% 1/10W

R408 1-216-809-11 METAL CHIP 100 5% 1/10WR409 1-216-809-11 METAL CHIP 100 5% 1/10WR431 1-216-809-11 METAL CHIP 100 5% 1/10WR432 1-216-841-11 METAL CHIP 47K 5% 1/10WR433 1-216-864-11 METAL CHIP 0 5% 1/10W

R441 1-216-809-11 METAL CHIP 100 5% 1/10WR442 1-216-841-11 METAL CHIP 47K 5% 1/10WR443 1-216-864-11 METAL CHIP 0 5% 1/10WR451 1-216-809-11 METAL CHIP 100 5% 1/10WR452 1-216-841-11 METAL CHIP 47K 5% 1/10W

R453 1-216-864-11 METAL CHIP 0 5% 1/10WR461 1-216-809-11 METAL CHIP 100 5% 1/10WR462 1-216-841-11 METAL CHIP 47K 5% 1/10WR463 1-216-864-11 METAL CHIP 0 5% 1/10WR479 1-216-805-11 METAL CHIP 47 5% 1/10W

R480 1-216-864-11 METAL CHIP 0 5% 1/10WR501 1-216-837-11 METAL CHIP 22K 5% 1/10WR502 1-216-809-11 METAL CHIP 100 5% 1/10WR503 1-216-809-11 METAL CHIP 100 5% 1/10WR504 1-218-871-11 METAL CHIP 10K 0.5% 1/10W

R505 1-218-871-11 METAL CHIP 10K 0.5% 1/10WR508 1-216-813-11 METAL CHIP 220 5% 1/10WR509 1-216-813-11 METAL CHIP 220 5% 1/10WR510 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR511 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R512 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR513 1-216-845-11 METAL CHIP 100K 5% 1/10WR514 1-216-845-11 METAL CHIP 100K 5% 1/10WR515 1-216-809-11 METAL CHIP 100 5% 1/10WR516 1-216-809-11 METAL CHIP 100 5% 1/10W

R517 1-216-841-11 METAL CHIP 47K 5% 1/10WR518 1-216-821-11 METAL CHIP 1K 5% 1/10WR519 1-216-845-11 METAL CHIP 100K 5% 1/10WR520 1-249-441-11 CARBON 100K 5% 1/4WR521 1-216-833-11 METAL CHIP 10K 5% 1/10W

R522 1-216-833-11 METAL CHIP 10K 5% 1/10WR523 1-216-809-11 METAL CHIP 100 5% 1/10WR524 1-216-809-11 METAL CHIP 100 5% 1/10WR525 1-216-809-11 METAL CHIP 100 5% 1/10WR526 1-216-809-11 METAL CHIP 100 5% 1/10W

39

CDX-CA680X/L580X


SERVOMAIN

R527 1-216-809-11 METAL CHIP 100 5% 1/10WR528 1-216-845-11 METAL CHIP 100K 5% 1/10WR530 1-216-845-11 METAL CHIP 100K 5% 1/10WR531 1-216-845-11 METAL CHIP 100K 5% 1/10WR532 1-216-845-11 METAL CHIP 100K 5% 1/10W

R533 1-216-845-11 METAL CHIP 100K 5% 1/10WR534 1-216-833-11 METAL CHIP 10K 5% 1/10WR535 1-216-845-11 METAL CHIP 100K 5% 1/10W

(L580X)R536 1-216-845-11 METAL CHIP 100K 5% 1/10W

(L580X)R538 1-216-845-11 METAL CHIP 100K 5% 1/10W

R539 1-249-417-11 CARBON 1K 5% 1/4WR540 1-216-845-11 METAL CHIP 100K 5% 1/10W

(L580X)R541 1-216-845-11 METAL CHIP 100K 5% 1/10W

(L580X)R580 1-216-809-11 METAL CHIP 100 5% 1/10W

(CA680X)R581 1-216-809-11 METAL CHIP 100 5% 1/10W

(CA680X)

R582 1-216-821-11 METAL CHIP 1K 5% 1/10W(L580X)



(L580X)R585 1-216-849-11 METAL CHIP 220K 5% 1/10W

(L580X)

R609 1-216-821-11 METAL CHIP 1K 5% 1/10WR631 1-249-425-11 CARBON 4.7K 5% 1/4WR632 1-216-841-11 METAL CHIP 47K 5% 1/10WR633 1-216-841-11 METAL CHIP 47K 5% 1/10WR634 1-216-829-11 METAL CHIP 4.7K 5% 1/10W

R636 1-216-845-11 METAL CHIP 100K 5% 1/10WR651 1-216-821-11 METAL CHIP 1K 5% 1/10WR652 1-249-437-11 CARBON 47K 5% 1/4WR653 1-216-833-11 METAL CHIP 10K 5% 1/10WR654 1-216-833-11 METAL CHIP 10K 5% 1/10W

R671 1-216-809-11 METAL CHIP 100 5% 1/10WR672 1-216-809-11 METAL CHIP 100 5% 1/10WR673 1-208-806-11 RES-CHIP 10K 0.5% 1/10WR674 1-216-845-11 METAL CHIP 100K 5% 1/10WR701 1-216-029-00 METAL CHIP 150 5% 1/10W

R702 1-216-029-00 METAL CHIP 150 5% 1/10WR703 1-216-029-00 METAL CHIP 150 5% 1/10WR704 1-216-029-00 METAL CHIP 150 5% 1/10WR720 1-216-864-11 METAL CHIP 0 5% 1/10WR752 1-216-809-11 METAL CHIP 100 5% 1/10W


< SWITCH >

S501 1-786-458-11 SWITCH, PUSH (1 KEY) (NOSE DET)S702 1-692-431-21 SWITCH, TACTILE (RESET)

< THERMISTOR (POSITIVE) >

TH580 1-803-350-21 THERMISTOR, POSITIVE (CA680X)

< TUNER >

TU1 A-3220-887-A TUNER UNIT (TUX-030)

< VIBRATOR >

X51 1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz)X501 1-781-294-21 VIBRATOR, CRYSTAL (18.432MHz)X502 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)

*************************************************************

A-3283-270-A SERVO BOARD, COMPLETE**********************

1-683-666-11 PICK-UP FLEXIBLE BOARD

< CAPACITOR >

C1 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC3 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC4 1-104-609-11 ELECT CHIP 100uF 20% 4VC5 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC6 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C8 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC9 1-162-924-11 CERAMIC CHIP 56PF 5% 50VC10 1-162-924-11 CERAMIC CHIP 56PF 5% 50VC11 1-162-909-11 CERAMIC CHIP 4PF 0.25PF 50VC13 1-162-916-11 CERAMIC CHIP 12PF 5% 50V

C14 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC15 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC16 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC17 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC18 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V


C25 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC26 1-126-391-11 ELECT CHIP 47uF 20% 6.3VC27 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC29 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC30 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V


C43 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50VC44 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC70 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC71 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

< CONNECTOR >

CN1 1-764-616-41 HOUSING, CONNECTOR (PC BOARD) 30PCN3 1-770-347-21 CONNECTOR, FPC 6P

< RESISTOR >

FB5 1-216-298-11 RES-CHIP 2.2 5% 1/10W

40

CDX-CA680X/L580X


SERVO SUB

< IC >

IC1 8-759-699-98 IC uPD63711GC-8EUIC2 8-759-658-87 IC BA5810FP-E2

< TRANSISTOR >

Q1 8-729-904-87 TRANSISTOR 2SB1197K-R

< RESISTOR >

R3 1-216-797-11 METAL CHIP 10 5% 1/10WR5 1-218-344-11 METAL CHIP 7.5K 5% 1/10WR6 1-216-837-11 METAL CHIP 22K 5% 1/10WR7 1-216-839-11 METAL CHIP 33K 5% 1/10WR8 1-216-833-11 METAL CHIP 10K 5% 1/10W

R9 1-216-840-11 METAL CHIP 39K 5% 1/10WR10 1-216-835-11 METAL CHIP 15K 5% 1/10WR12 1-216-837-11 METAL CHIP 22K 5% 1/10WR14 1-216-841-11 METAL CHIP 47K 5% 1/10WR15 1-216-841-11 METAL CHIP 47K 5% 1/10W

R17 1-216-809-11 METAL CHIP 100 5% 1/10WR18 1-216-809-11 METAL CHIP 100 5% 1/10WR19 1-216-809-11 METAL CHIP 100 5% 1/10WR20 1-216-809-11 METAL CHIP 100 5% 1/10WR21 1-216-821-11 METAL CHIP 1K 5% 1/10W

R22 1-216-821-11 METAL CHIP 1K 5% 1/10WR26 1-216-797-11 METAL CHIP 10 5% 1/10WR29 1-216-833-11 METAL CHIP 10K 5% 1/10WR30 1-216-833-11 METAL CHIP 10K 5% 1/10WR31 1-216-789-11 METAL CHIP 2.2 5% 1/10W

< SWITCH >

SW5 1-762-944-12 SWITCH, DETECTION (SMALL TYPE) (DOWN)

< VIBRATOR >

X1 1-795-520-11 VIBRATOR, CERAMIC (16.9344MHz)*************************************************************

1-686-703-11 SUB BOARD**********

1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE) (CN801)

< CONNECTOR >

CN802 1-817-159-11 SOCKET, CONNECTOR 14P

< DIODE >

LED801 8-719-082-38 LED CL-270SR-C-TS (DOOR INDICATOR)LED802 6-500-450-01 LED CL-195SR-CD-T (Z)

< SWITCH >

S801 1-771-884-11 SWITCH, TACTILE (WITH LED) (Z)*************************************************************

MISCELLANEOUS***************

11 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)52 1-790-355-71 CORD (WITH CONNECTOR) (RCA)

(AUDIO OUT FRONT) (CA680X)251 X-3378-598-3 CHASSIS (OP) ASSY (including M901)257 1-683-665-11 MOTOR FLEXIBLE BOARD

0259 8-820-103-11 OPTICAL PICK-UP KSS-720A/C-RP

F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10AM902 A-3291-674-A MOTOR ASSY, SLED (SLED)M903 A-3315-039-A MOTOR SUB ASSY, LD (LOADING)

*************************************************************

ACCESSORIES************

3-247-306-11 MANUAL, INSTRUCTION (ENGLISH,GERMAN,FRENCH,ITALIAN,DUTCH)

3-247-307-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,GERMAN,FRENCH,ITALIAN,DUTCH)

X-3383-264-1 CASE (PANEL) ASSY (for FRONT PANEL)*************************************************************

PARTS FOR INSTALLATION AND CONNECTIONS***************************************

301 X-3382-647-1 FRAME ASSY, FITTING302 X-3382-926-1 SCREW ASSY (BS), FITTING303 3-349-410-11 BUSHING304 3-246-443-01 COLLAR305 1-465-459-21 ADAPTOR, ANTENNA

306 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)307 3-246-471-01 KEY (FRAME)

301 302303

304 305 306

307


41

CDX-CA680X/L580X

MEMO

42

CDX-CA680X/L580X

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper right on the revised page allows you to jump to the next revisedpage.

Ver. Date Description of Revision1.0 2002. 11 New

sony cdx-ca580x_cdx-l580x

Documents

use of unleaded solder

audio use

solder joint

audio cd player

unleaded solder melts

cd sections

khz lw

lead free markunleaded