sony_cdx-4180r_sm_2

1

Model Name Using Similar Mechanism CDX-4170RCD Drive Mechanism Type MG-363X-121Optical Pick-up Name KSS-521A

SERVICE MANUAL AEP ModelUK Model

CDX-4180R

FM/MW/LW COMPACT DISC PLAYER

MICROFILM

CD player sectionSystem Compact disc digital audio

systemSignal-to-noise ratio 90 dBFrequency response 10 - 20,000 HzWow and flutter Below measurable limit

Tuner sectionFMTuning range 87.5 - 108.0 MHzAerial terminal External aerial connectorIntermediate frequency 10.7 MHzUsable sensitivity 8 dBfSelectivity 75 dB at 400 kHzSignal-to-noise ratio 65 dB (stereo),

68 dB (mono)Harmonic distortion at 1 kHz

0.5% (stereo),0.3% (mono)

Separation 35 dB at 1 kHzFrequency response 30 - 15,000 HzCapture ratio 2 dB

MW/LWTuning range MW: 531 - 1,602 kHz

LW: 153 - 281 kHzAerial terminal External aerial connectorIntermediate frequency 10.71 MHz/450 kHzSensitivity MW: 30 V

LW: 50 V

SPECIFICATIONS

Power amplifier sectionOutputs Speaker outputs

(sure seal connectors)Speaker impedance 4 - 8 ohmsMaximum power output 40 W 4 (at 4 ohms)

GeneralOutputs Line outputs (2)

Power aerial relay controlleadPower amplifier controlleadTelephone ATT controllead

Tone controls Bass 10 dB at 100 HzTreble 10 dB at 10 kHz

Power requirements 12 V DC car battery(negative ground)

Dimensions Approx. 178 50 185 mm(w/h/d)

Mounting dimensions Approx. 182 53 162 mm(w/h/d)

Mass Approx. 1.2 kgSupplied accessories Parts for installation and

connections (1 set)Front panel case (1)

Design and specifications are subject to change withoutnotice.

2

TABLE OF CONTENTS

1. GENERALLocation of Controls ................................................................ 3Getting Started ......................................................................... 3Setting the Clock ..................................................................... 4CD Player ................................................................................ 4Radio ....................................................................................... 5RDS ......................................................................................... 6Other Functions ....................................................................... 8Connections ........................................................................... 10

2. DISASSEMBLY2-1. Cover Assy ........................................................................ 122-2. Front Panel Assy ............................................................... 122-3. Sub Panel (1) Assy ............................................................ 132-4. CD Mechanism Block ....................................................... 132-5. Main Board ....................................................................... 142-6. Heat Sink ........................................................................... 142-7. Chassis (T) Sub Assy ........................................................ 152-8. Lever Assy ......................................................................... 152-9. Servo Board ....................................................................... 162-10. Roller Assy ........................................................................ 162-11. Chassis (OP) (O/S) Assy ................................................... 172-12. Optical Pick-up Block ....................................................... 17

3. ELECTRICAL ADJUSTMENTSTuner Section ......................................................................... 18CD Section ............................................................................ 21

4. DIAGRAMS4-1. IC Pin Description ............................................................. 224-2. Block Diagram CD Section ........................................... 254-3. Block Diagram Main Section ........................................ 274-4. Circuit Boards Location .................................................... 294-5. Schematic Diagram CD Mechanism Section ................ 314-6. Printed Wiring Boards CD Mechanism Section ............ 334-7. Printed Wiring Board Main Section .............................. 354-8. Schematic Diagram Main Section ................................. 394-9. Printed Wiring Board Display Section .......................... 434-10. Schematic Diagram Display Section ............................. 45

5. EXPLODED VIEWS5-1. Chassis Section ................................................................. 515-2. Front Panel Section ........................................................... 525-3. CD Mechanism Section (1) ............................................... 535-4. CD Mechanism Section (2) ............................................... 545-5. CD Mechanism Section (3) ............................................... 55

6. ELECTRICAL PARTS LIST ......................................... 56

SERVICE NOTE

CAUTIONUse of controls or adjustments or performance of proce-dures other than those specified herein may result in haz-ardous radiation exposure.

Notes on Chip Component Replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK ORBASE UNITThe laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic breakdown and also usethe procedure in the printed matter which is included in the repairparts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-upblock. Therefore, when checking the laser diode emission, observefrom more than 30 cm away from the objective lens.

NOTES ON PICK-UP FLEXIBLE BOARDThe pick-up flexible board in this set is secured to the optical pick-upwith an adhesive tape. Once the tape is removed, an adhering forcebecomes weak, and it cannot be reused.Therefore, if the optical pick-up is replaced, replace also the pick-upflexible board with a new one.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINEWITH MARK ! ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

3

SECTION 1GENERAL This section extracted

from instruction manual.

12

SECTION 2DISASSEMBLY

Note : Follow the disassembly procedure in the numerical order given.

2-1. COVER ASSY

2-2. FRONT PANEL ASSY

4 cover assy

1 claw

2 claw

3 claws

2 front panel assy

1 button (release)

13

2-3. SUB PANEL (1) ASSY

2-4. CD MECHANISM BLOCK

1 PTT 2.6x6

2 PTT 2.6x6

4 claw

3 claw

5 sub panel (1) assy

7 PTT 2.6x6

3 PTT 2.6x6

6 PTT 2.6x6

2 PTT 2.6x6

1 PTT 2.6x6

4 CNP700

8 bracket (M/D)

5 CD mechanism block

14

2-5. MAIN BOARD

2-6. HEAT SINK

2 ground point screw3 ground point screws

1 PTT 2.6x84 MAIN board

1 PTT 2.6x8

2 PTT 2.6x10

3 PTT 2.6x8

4 heat sink

15

2-7. CHASSIS (T) SUB ASSY

2-8. LEVER ASSY

4 chassis (T) sub assy

2 P 2x33 P 2x3

1 Unsolder the lead wires.

red

white

black

4 claws

2 DISC IN SW board

7 lever (L) assy

3 tension spring (LR)

6 lever (R) assy

5 guide (disc)

1 PS 2x4

16

2-9. SERVO BOARD

2-10. ROLLER ASSY

When installing, take note of the positions arm (roller) and washers. (Fig. 1)

5 PS 2x4

1 CN33 P 2x3

4 loading motor assy

7 SERVO board

2 CN2

6 PS 2x4

Fig. 1

4 PS 2x3

5 LOAD SW board

1 tension spring (RA)

2 arm (roller)

3 roller assy

washerarm armwasher washers

17

2-11. CHASSIS (OP) (O/S) ASSY

2-12. OPTICAL PICK-UP BLOCK

1 tension spring (angle)

8 compression spring (FL)

7 chassis (OP) (O/S) assy

9 compression spring (FL)

2 tension spring (KR1)

5 Fit lever (D) in the direction of the arrow.

3 damper (T)4 damper (T)

6 Turn loading ring in the direction of the arrow.

1 P 2x3

2 sled motor assy

3 optical pick-up block

18

SECTION 3ELECTRICAL ADJUSTMENTS

Carrier frequency : 98.00 MHzOutput level : 22 dB (12.6 V)Mode : monoModulation : 1 kHz, 22.5 kHz deviation (30%)

Procedure :1. Set to the test mode.2. Push the SOURCE button and set to FM.

Display

FM Auto Scan/Stop Level AdjustmentSetting :

D-BASS switch : OFFSOURCE button : FM

3. Push the preset 3 button.Display

TUNER SECTION

Cautions during repairWhen the tuner unit is defective, replace it by a new onebecause its internal block is difficult to repair.

TEST MODEThis set have the test mode function. In the test mode, FM AutoScan/Stop Level and MW Auto Scan/Stop Level adjustments canbe performed easier than it in ordinary procedure.

1. Set the OFF mode.2. Push the preset 4 button.3. Push the preset 5 button.4. Press the preset 1 button for more than two seconds.5. Then the display indicates all lights, the test mode is set.

1. Push the OFF button.

Note on AdjustmentThe adjustments of tuner section, should be performed accordingto the following sequence.1. FM Auto Scan/Stop Level Adjustment2. FM Stereo Separation Adjustment3. FM RDS S-Meter Adjustment4. MW Auto Scan/Stop Level Adjustment

0 dB = 1 V

REG

SHUF

4. Adjust with the volume RV2 on TU1 so that the FM indicationturns to FM0 indication on the display window.But, in case of already indicated FM0, turn the RV2 so thatput out light 0 indication and adjustment.

Display

REG

SHUF

REG

SHUF

FM RF signalgenerator

antennaterminal

set

0.01 F

Adjustment Location : See page 20.

19

FM Stereo Separation AdjustmentSetting :



Carrier frequency : 98.00 MHzOutput level : 70 dB (3.2 mV)Mode : stereoModulation : main : 1 kHz, 20 kHz deviation (26.5%)

sub : 1 kHz, 20 kHz deviation (26.5%)19 kHz pilot : 7.5 kHz deviation (10%)

antennaterminal

set

0.01 F10 k

level meter

LINE OUT REAR

FM stereoLevel meter Level meter

signal generatorconnection reading (dB)

output channelL-CH L-CH A

B

R-CH L-CH Adjust RV4 on TU1 forminimum reading.

R-CH R-CH C

D

L-CH R-CH Adjust RV4 on TU1 forminimum reading.

L-CH stereo separation : A BR-CH stereo separation : C DThe separations of both channels should be equal.

Specification : Separation more than 28 dB


Procedure :

Carrier frequency : 98.00 MHzOutput level : 35 dB (56.2 V)Mode : monoModulation : no modulation

Procedure :1. Set to the test mode. (See page 18.)2. Push the SOURCE button and set to FM.

Display

FM RDS S-Meter AdjustmentSetting :


3. Push the preset 10 button.4. Adjust RV801 so that the display indication is 16.0.

Display

REG

SHUF

Specification : Display indication : 15.8 to 16.2



antennaterminal

set

0.01 F

REG

SHUF

20

MW Auto Scan/Stop Level AdjustmentSetting :

D-BASS switch : OFFSOURCE n MODE button : MW

AM RF signalgenerator

Carrier frequency : 999 kHz30% amplitudemodulation by1 kHz signaloutput level : 33 dB (44.7 V)

AM dummyantenna (50 )

antennaterminal

set

15 pF30

65 pF

Procedure :1. Set to the test mode. (See page 18.)2. Push the SOURCE button.3. Push the MODE button and set to MW.

Display

4. Push the preset 3 button.Display

5. Adjust with the volume RV1 on TU1 so that the MWindication turns to MW0 indication on the display window.But, in case of already indicated MW0, turn the RV1 so thatput out light 0 indication and adjustment.

Display

Adjustment Location : tuner unit (TU1)

Adjustment Location : tuner unit (TU1)

set upper view

REGTP

SHUF

REGTP

SHUF

REGTP

SHUF

TU1RV1

MW AUTO SCAN/STOP LEVEL ADJ

RV2FM AUTO SCAN/

STOP LEVEL ADJRV801

FM RDSS-METER ADJ

RV4FM STEREO

SEPARATION ADJ

21

CD SECTION

Note:1. CD Block basically constructed to operate without adjustment.

Therefore, check each item in order given.2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.3. Use the oscilloscope with more than 10 M impedance.4. Clean an objective lens by an applicator with neutral detergent

when the signal level is low than specified value with the followingchecks.

Focus Bias AdjustmentSetting: This adjustment is performed with the set placed

horizontally.

Focus Gain Adjustment (Coarse adjustment)This adjustment is not required unless the following parts are replaced: Optical pick-up RV4

Procedure:1. Set RV4 to the standard position. (mechanical center)2. Check whether operation noise (while noise type) caused by

the 2-axis device (lens section of the optical pick-up) isabnormally loud.If the operation noise is too loud, turn RV4 slightly counter-clockwise.

If the gain is too low:Focus does not function and no music is selected.

If the gain is too high:Noise caused by scratches and dust is heard and the operationbecomes unstable.

Adjustment Location: servo board

Adjustment Location: servo board (component side)Procedure:1. Connect an oscilloscope between TP (RF) and TP (RF. GND)

on the SERVO board.2. Connect the power supply.3. Push the RESET button (S900) on the MAIN board.4. Insert the disc (YEDS-18) and playback.5. Adjust RV1 so that the oscilloscope waveform is clear and check

RF signal level is correct or not.Note: Clear RF signal waveform means that the sharp can be

clearly distinguished at the center of the waveform.

When observing the eye pattern, set the oscilloscope to AC rangeand raise the vertical sensitivity so that it may be easily seen.

Adjustment Location: servo board

SERVO boardoscilloscope

TP (RF)TP (RF. GND)

RF signal waveformVOLT/DIV: 200 mVTIME/DIV: 500 nS

level: 1.0 1.5 Vp-p

CN2

RV1FOCUS BIAS ADJ

TP(RF. GND)

FOCUS GAIN ADJRV4

TP(RF)

IC1

IC3

IC2CN1

CN3

22

4-1. IC PIN DESCRIPTION IC801 MB90574FPV-G-110 (SYSTEM CONTROL)

Pin No. Pin Name I/O Pin Description1 LD ON O Laser power ON/OFF control pin2 FOK I Focus signal detection input3 XLAT25 O CD signal process latch output4 DATA25 O CD signal process serial data output5 XRSRO O CD signal process IC reset output6 GFS I GFS signal detection input7 NIL Not used. (Contact to GND.)8 VCC Power supply (+5 V)9 PLL SI I PLL data input

10 PLL SO O PLL data output11 PLL CKO O PLL CLK output12 NOSE I Front panel connect detection input13 LCD SO O LCD serial data output14 LCD CKO O LCD serial clock output15 BEEP O Buzzer control output16 DBMOD2 O D-BASS mode set signal output17 SQSI I SUBQ data input18 NIL Not used. (Contact to GND.)19 SQCKO O SUBQ read clock output20 UNI SI I BUS system serial interface input21 UNI SO O BUS system serial interface output22 UNI CKI/O I/O BUS system serial interface input/output23 C OUT I CD track jump number count input24 SIRCS I Remote commander input25 SRDT I CD-TEXT data input26 NIL Not used. (Contact to GND.)27 SCLK O CD TEXT data read clock output (Not used.)28 CLOCK25 O CD signal process serial clock output29 SYSRST O System reset control output30 DEEM O Emphasis control output31 DBMOD1 O D-BASS mode set signal output32 MD ON O Machanism deck section power supply control output33 VSS GND34 C Capacitor terminal for power supply35 CD ON O CD power supply control output36 BUS ON O BUS ON control output (Not used.)37 AD ON O Power control output for A/D conversion38 DVCC Power supply for D/A convertor39 DVSS GND for D/A convertor40 TEST I Test mode direct setting input41 VOL CE O Electric volume serial chip enable output42 AVCC Power supply for analog circuit43 AVRH Power supply for A/D convertor44 AVRL Power supply for A/D convertor45 AVSS GND for analog circuit46 KEY IN0 I Key input47 KEY IN1 I Key input48 KEY IN2 I Key input for D-BASS rotary switch49 RC IN0 I Rotary commander input

50, 51 NIL Not used. (Contact to GND.)52 MPDH I Tuner multi-path input

SECTION 4DIAGRAMS

23

Pin No. Pin Name I/O Pin Description53 S-METER I S-meter voltage detection input54 VCC Power supply55 AMP MUTE O Power amplifier mute control output56 AMP ON O Power amplifier power control output57 XMODE O Reset signal output for CD-TEXT decoder (Not used.)58 VOL SO O Electric volume serial data output59 VOL CKO O Electric volume serial clock output60 AU MUTE O Audio mute signal output61 AF MUTE O RDS mute signal output (Not used.)62 TU MUTE O Tuner mute signal output63 VSS GND64 ACC IN I Accessory power voltage detection input65 AFSEEK O RDS operation control output66 M SIO I/O EEPROM serial data input/output (Not used.)67 DAVN I RDS data input detection input68 M CK O EEPROM serial clock output (Not used.)69 M CE O EEPROM chip enable output (Not used.)70 RDS SI O RDS serial data input71 RDS CKI O RDS serial clock input72 RC IN1 I Remote commander shift key input73 X1A Low frequency oscillator input74 X0A Low frequency oscillator input75 SCOR I SCOR signal detection input76 BU IN I Back-up power supply detection input77 DQSY I CD-TEXT data set complete signal detection input (Not used.)78 CD SENCE I CD SENS signal detection input79 KEY ACK I Key input acknowledge80 TEL MUTE I Telephone mute detection input81 ST IN/MONO I Tuner stereo signal detection input82 SEEKOUT O SEEK OUT output83 SD IN I Signal detection input84 NC Not used. (Contact to GND.)85 PLL CE O PLL CE output86 H I Hardware standby input87 VSS GND

88, 89 VCC Power supply90 RESET I Reset input91 VSS GND92 X0 High frequency oscillator input93 X1 High frequency oscillator input94 VCC Power supply95 PW SEL I Power select initial setting input96 NIL Not used. (Contact to GND.)97 AREA1 I Fixed to L.98 AREA2 I Fixed to L.99 AREA3 I US, Canadian model : Fixed to L. E model : Fixed to H.

100 BAND (9K 10K) I AM/FM frequency select (E model)101 NIL Not used. (Contact to GND.)102 PH3 I Disc insert detection photo sensor input (Not used.)103 PH2 I Disc insert detection photo sensor input (Not used.)104 LCD CE O LCD chip enable output105 NIL Not used. (Contact to GND.)106 RE0 I Rotary encoder input

24

Pin No. Pin Name I/O Pin Description107 RE1 I Rotary encoder input108 LAMP ON O Illumination power control output109 PW ON O System power control output110 REGMOD1 O FM power control output111 REGMOD2 O System power control output112 CTL1 O Laser power ON/OFF control output (Not used)113 CTL2 O Laser power ON/OFF control output114 FWD O Loading motor control output (Loading)115 REV O Loading motor control output (Eject)116 L SW I SLED limit switch detection input117 IN SW I Disc insert detection input118 D SW I DOWN switch detection input119 VSS GND120 SELF SW I SELF switch detection input

4-2. BLOCK DIAGRAM CD SECTION

25 26

CDX-4180R

43

1415

16

14 RF59 CLKO57 XLTO56 DATO

21PCMD20LRCK22BCK34XTAI

50 XRST

DIGITAL SIGNALPROCESSOR

IC1

55 CNIN54 SEIN1 FOK3 MDP

27GFS46SQSO47SQCK49SENS51DATA52XLAT53CLOK

SCOR

SERVO 5V

35 PD1

36 PD2

39 E

38 F

31RFO19CLK20XLT21DATA

RF AMP, SERVO CONTROLIC2

OPTICAL PICK-UPKSS-520A

37 FE BIAS

SERVO 5V

PD

LD

RV1FOCUS BIAS

RV4FOCUS GAIN

LD DRIVEQ2

1 FEO

2 FEI

16SLO

22XRST23C. OUT24SENS25FOK

6FEO13TAO

34 PD

33 LD

Q1

16 CH2+

15 CH2-

18 CH1+

17 CH1-

19CH1 IN22CH2 IN24CH3 IN

TRACKING

FOCUS 3CH4 IN

FOCUS/TRACKING COIL DRIVE,MOTOR DRIVE

IC3

13 CH3+

14 CH3-

M902(SLED)

M901(SPINDLE)

M903(LOADING)

12 CH4+

11 COM

6FWD7REW

4CTL15CTL2

10 CH5+

3 DI1 LRCI2 BCKI4 CLK

9DOUT10BCKO11LRCO

6 RSTN

D-BASSCONTROL

IC701

MOD1MOD2

DB/DS

6 DI5 BCKI8 LRCI3 CLKO

12LO14RO R-CH

18 XTI

19 XTO

D/A CONVERTERIC702

X70016.9344MHz

2DEEM

22RSTN30 DEEM

6 GFS17 SQSI

31 DBMOD116 DBMOD2

19 SQCKO78 CD SENCE

SYSTEM CONTROLIC801(1/2)

SERVO 5V

M

M

M

I-VCONV.

4 DATA253 XLAT2528 CLOK2575 SCOR

5 XRSRO2 FOK23 C OUT1 LD ON

57 XMODE27 SCLK25 SRDT77 DQSY

115 REV114 FWD113 CTL2

CD 5VREGQ909

MD 8VREGQ912

MD 8VSWITCH

Q910, 911

CD POWERSWITCH

Q907,908

SERVO 5VREGQ913

120 SELF SW

117 IN SW

116 L SW

118 D SW

CD ON

32

35

MD ON

SW2(SELF)

CD 5V BACK UP

MD 8V

SERVO 5V

MAINSECTION1

Signal path : CD

SW3(LIMIT)

SW1(DISC IN)

SW4(DOWN)

04

4-3. BLOCK DIAGRAM MAIN SECTION

CDX-4180R

27 28

-3L

2 1

626364

2

1

1

2

12

18

16

41121

20

2219

83

81

53

8

9

10

6

9

131516

5

CNJ600(ANT)

AM ANTFM L-CH

FM R-CH

LO/DXAM-IFCFM-IFC

VCO

SD

ST-IND

23FM-DET

S-METER

FM+B

TU+B

AM+B

VT

AM DET

FM ANT

TUNER UNITTU1 TUNER LINE SWITCH

IC404(1/2)

IC404(2/2)

R-CH

R-CH

Signal path : FM : MW : CD

CDSECTION

3536

3738

TONE21

20

ELECTRONIC VOLUMEIC401

181716

L4

L1

L3

L2

CL DI CE

FLOUT

RLOUT

SYSTEM CONTROLIC801(2/2)

595841

1041413

90

4972

37

64

109

4748

12

15

61

60

FM8V

RV801S-METER

AM8V

D602D601 TU 5V REG

Q601

B+ SWITCHQ604, 605

SWITCHQ901,902

COM+B REGQ903

D-BASSSWITCH

S801

ROTARYENCODER

RE801

TU5V

TU5V

FM8V

546

10119

181

20

PLLIC601

LO/DX

IFINAMOSC

DINCLK

DOUT

X OUT

X IN

FMOSCPD

VTCONTROL

Q611

VTSWITCHIC603

S-METERBUFFER

Q801

X6017.2MHz

76

46

4379

106107

BATTCHECKQ906

ACC DETSWITCH

Q917, 918

BACK UP LINE

BACK UP LINE D807

D910

LCD DRIVEIC801

CECLKDATA

MUTEQ111

MUTEQ110

MUTESWITCH

Q401

U COM 5V

TU 5V

COM+BBACK UP LINE

RESETIC902

S900RESET

CNP802(REMOTE IN)

KEY MATRIXLSW801-819, S802

(DISPLAY BOARD)

KEY ACTIVEQ914,915

PL801PL802 LAMP REG

Q802, 805

COM +8V

LSW801-819LED801-805

TEL MUTESWITCH

Q916

4

591011

68

23

7

POWER SUPPLYIC901

STBY

BU5VCOM8VAM8VFM8V

PULL UP 5VU COM 5V

COM+8VAM8VFM8V

MODE2MODE1

VCC

AMP+BANT+B

BACK UP LINE

BACK UP LINE

ACCCHECKQ905

D906

F901

11

3

12

4

10

2

9

1

13ATT

16BATT

7ACC

5AMP REM

6ANT REM

15TEST

X1A

X0A

PLL SO

62 TU MUTE

PLL CKOPLLSI

2016

14

1098

10119

4

2 4

5

RDS DEMODULATORIC602

SMETERFM-DET

AVDD

CLKDATADAVN

XI

XO

MPDH

PLL SOPLL CKOPLLSI

SD IN13 82SEEK SEEK OUT

65 AF SEEK

ST IN/MONO

S-METER

KEY IN0

BU IN

AD ON

AVRHKEY ACK

RE0RE1

ACC IN

TEL MUTE

KEY IN1KEY IN2

RC IN0RC IN1

RESET

MPDH

108 LAMP ON

LCD CKOLCD SO

P2/S2

LCD CE

REGMOD1REGMOD2

PW SEL

AMP MUTE

BEEP

D801Q402AF MUTE

AU MUTE

VOL CEVOL SO

VOL CKO

PW ON

TEST

NOSE

12

11

5

3

9

7

POWER AMPIC200

22 4

FL

RL

MUT

EST

BY

-6 REARR

-5L

-4 FRONTR

R-CH

R-CH PJ400

R-CH

CNP501

FL+

FL-

RL+

RL-

FR+

FR-

RR+

RR-55

AMP ON 56

110111

80

95

40

SW801(POWER SELECT)

OFF

ON

04

BACK UP

D918 D919

LINE OUT

+

92

93

X8004.19MHz

X6024.332MHz

X0

X1

73

74

X80132.768kHz

AM 8V

Q610

8

6

9

1

13

2MUTEQ607

MUTESWITCH

Q701

1

7

3

HPF

2

6 5

HPF

LCD801

29

4-4. CIRCUIT BOARDS LOCATION

tuner unit(TU1)

DISC IN SW board

DISPLAY board

LOAD SW board SERVO board

MAIN board

LIMIT SW board

SUB board

30

Note on Schematic Diagram: All capacitors are in F unless otherwise noted. pF: F

50 WV or less are not indicated except for electrolyticsand tantalums.

All resistors are in and 1/4

W or less unless otherwisespecified.

Note: The components identified by mark ! or dotted linewith mark ! are critical for safety.Replace only with part number specified.

U : B+ Line. H : adjustment for repair. Power voltage is dc 14.4V and fed with regulated dc power

supply from ACC and BATT cords. Voltage and waveforms are dc with respect to ground

under no-signal conditions.no mark : CD PLAY

: Impossible to measure Voltages are taken with a VOM (Input impedance 10 M).

Voltage variations may be noted due to normal productiontolerances.

Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal productiontolerances.

Circled numbers refer to waveforms. Signal path.J : CD

Waveforms (MODE:PLAY)1

2

3

4

5

6

7

Approx. 620mVp-pIC2 1 (FEO)

0V

IC2 #` (RFO)

1.2Vp-p

Approx. 200mVp-pIC2 $ (TEO)

0V

IC1 3 (MDP)

2.6Vp-p

7.6sec

IC1 @ (LRCK)

5.8Vp-p

22.7sec

IC1 @ (BCK)

5.7Vp-p

474nsec

16.89MHzIC1 # (XTAI)

3.2Vp-p

47

IC Block Diagrams

IC1 CXD2507AQ

IC3 BA6796FP-T1

XLON

SPOD

SPOC

SPOB

SPOA

CLKO

VDD

CNIN

SEIN

CLOK

XLAT

XLTO

DATO

52535455565758596061626364

51SERVO AUTOSEQUENCER

33

3435363738

39

40414243

454647484950

44

DATAXRSTSENSMUTESQCKSQSOEXCKSBSOSCORVSSWFCKEMPH

DOUT

C4MFSTTXTSLXTAOXTAI

MNTO

20 21 22 23 24 25 26 27 29 30 31 3228

LRCK

PCM

DBC

LKGT

OPXU

GFXP

CKVD

DGF

SRF

CKC2

POXR

OFM

NT3

MNT

1

1

23456

789

101112

161718

19

13

1415

FOK

MONMDPMDS

LOCKTEST

FILOFILIPCOVSS

AVSSCLTVAVDD

RFBIASASYI

ASYOASYE

WDCK

5

14CPU

INTERFACESUB CODE

PROCESSOR

DIGITALCLV

EFMDEMODULATOR

DIGITALPLL

ASYMMETRYCORRECTOR

5 D/AINTERFACE

ERRORCORRECTOR

3

6

3

16KRAM

DIGITALOUT

CLOC

KGE

NERA

TOR

4

1 2 3 4 5 6 7 8 9 10 11 12 13 14

OPOU

T

CH4-

IN

CH4

CTL1

CTL2

FWD

REV

TRAY

GND

CH3

CH5

COM

CH4

+

CH3

+

CH3-

IN

CH3

VREF

CH2

CH2-

IN

VCC

VCC

CH1

CH2

CH1-

IN

OP IN

CH1

CH1

+

OP IN

+

CH2

+

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

DRIVEBUFFER

LEVELSHIFT

LEVELSHIFT

LEVELSHIFT

LEVELSHIFT

THERMALSHUTDOWN

1516171819202122232425262728

LOGIC

CTL1 CTL2 FWD REV

V/I

48

IC2 CXA1782BQ

36 35 34 33 32 31 30 29 28 27 26 25

24

23

22

21

20

19

18

17

16

15

14

13

121110987654321

37

38

39

40

41

42

43

44

45

46

47

48

PHD

2

PHD

1

PHD

LD RF

O

RF I

CP CB CC1

CC2

FOK

SENS

C.OUT

XRST

DATA

XLT

CLK

VCC

ISET

SL O

SL M

SL P

TA O

TA M

FSET

TG2

TGU

SRCH

FE OFLB

FGD

FDFC

T

FE MFE

I

FEO

FE BIAS

F

E

EI

VEE

TED

LPFI

TEI

ATSC

TZC

TDFCT

VC

APC LEVEL SFO

K

MIRR

RF IV AMP1

RF IV AMP2

FE A

MP

TTL

IIL

FZC COMP

DFCT

IIL

TTL

IIL DATA REGISTER INPUT SHIFT REGISTER

ADDRESS DECODER

OUTPUT DECODER

TTL

IIL

TOG1-3BAL1-3

FS1-4 TG1-2 TM1-7 PS1-4F IV AMP

E IV AMP

BAL1

BAL2

BAL

3

TE AMP

TZC COMP

DFCT

TM1

DFCT

FS4

ATSC

WINDOW COMP

TOG1

TOG2

TOG3

FCS PHASECOMPENSATION

FS1

F SE

TTG2

TM7

TM3

TM4

TM5

TM6

ISETTRACKINGPHASECOMPENSATION

HPF COMP LPF COMP

TG1

FS2

TM2

RF M

49

IC401 LC75374E

IC601 BU2624FV

+

+

+

+

+

+

+

+

+

+

+

+

+

+

DECODER LATCH SHIFTREGISTER

CONTROL

+

+

1 2 3 4 5 6 7 8 9 10

20

19

18171615

14

13

12

11

21

22

2324252627282930313233

3435363738

39

4041424344

LSELOL4L3L2L1

VDD

R1R2R3R4

RSELO

RVRI

N

RCOM RT

1RT

2

RT3

RTOU

TRS

IN NC NCRS

B1

RSB2

RFIN

RFOUT

RROUTVSS

CLDICE

VREF

LROUT

LFOUT

LFIN

LSB2

LSB1

NCNCLSIN

LTOU

T

LT3

LT2

LT1

LCOM

LVRI

N

PHASEDET

PRESCALERMAINCOUNT

IF COUNTCTL

20BIT COUNT

SHIFT REGISTER LATCH

REFERENCEDIVIDER

I/OCTL

1

2

4

5

6

7

9

10

20

18

17

16

15

14

13

1211

19

XIN

CE

CKDA

CD

P0

P1

P3

XOUT

VSS

PD

VDD

FMIN

AMIN

P2

IFIN

SDP4

50

IC701 SM5852FS-E2

IC901 BA3918-V3

123

4

5

6

7

8

910

16151413

12

11

DIGITALSIGNAL

PROCESSOR

OUTPUTINTERFACE

SYSTEMCLOCK

INPUTINTERFACE

SEQUENTIALCONTROL

MUTECONTROL

MODECONTROL

LRCIBCKI

DI

CLK

VSS

RSTN

TESTN

MUTEN

DB/DSMOD2MOD1OPT

VDD

LRCOBCKODOUT

ATTENUATION COUNTER

FILTER & ATTENUATIONOPERATION BLOCK

NOISE SHAPEROPERATION BLOCK

INPUT INTERFACECLOCK

GENERATOR

TIMINGCONTROL

1

2

3456

78

910

11

121314

15

1617

18

19

20

2122

2324

MUTE

DEEN

CKODVSSBCKI

DI

DVDDLRCI

TSTNTO1

AVDDL

LOAVSSRO

AVDDR

MUTEXVDD

XTI

XTO

XVSS

DSRSTN

MODEATCK

LL RR

11 LEVELDEM DAC

LPF

AMP

11 LEVELDEM DAC

11 LEVELDEM DAC

LPF

AMP

11 LEVELDEM DAC

+

+

+

+

OVER VOLTAGEPROTECT

REGULATOR

1 2 3 4 5 6 7 8 9 10 1211

NC

MOD

E2M

ODE1 STB

VDD

AMP

VCC

ANT

COM AM FM GND

IC702 SM5878AM-E2IC602 SAA6588T

1112

13

109

87654

3

12

20

18

17161514

19

PAUSEDETECTOR

INTERFACEREGISTER

RDS/RDBSDECODER

OSCILLATORAND CLOCK

TESTCONTROL

MULTI-PATHDETECTOR

RDS/RDBSDEMODULATOR

CLOCKEDCOMPARATOR

POWER SUPPLYAND RESET

57kHz8th ORDERBAND-PASS

SIGNALQUALITY

DETECTOR

IIC-BUSSLAVE

TRANSCEIVER

SCLSDA

DAVN VDDD VSSD OSCI OSC0

TCON

MPTH MRO LVIN

CIN SCOUT

VREF MPX

VSSA VDDA

AFIN

MAD PSWN

5

4

4

51

SECTION 5EXPLODED VIEWS

NOTE: The mechanical parts with no reference

number in the exploded views are not supplied. Items marked * are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

-XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

AbbreviationG : German model

Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinets Color Accessories and packing materials and

hardware (# mark) list are given inthe last of this parts list.

The components identified bymark ! or dotted line with mark.! are critical for safety.Replace only with part numberspecified.

Ref. No. Part No. Description Remark

5-1. CHASSIS SECTION

N N

Ref. No. Part No. Description Remark

1

11

3

512

8

9

6

72

10

4 #1

#1

#2

#2 #2

#10

#11#11

#2

#2 #2

#1

#1

#1

#3#3

MG-363X-121

TU1

F901

A

A

B

B

1 X-3374-926-1 COVER ASSY2 X-3374-808-1 PANEL (1) ASSY, SUB3 X-3368-104-2 LOCK ASSY

* 4 3-019-564-01 BRACKET (M/D)5 3-915-923-01 SCREW, GROUND POINT

* 6 A-3294-367-A MAIN BOARD COMPLETE (G)* 6 A-3294-369-A MAIN BOARD COMPLETE (AEP,UK)* 7 3-020-107-11 HEAT SINK

* 8 3-019-565-01 BRACKET (IC)* 9 3-019-533-01 BRACKET (REG)* 10 3-020-104-01 CHASSIS (MAIN)

11 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)12 3-937-650-01 PLATE (C), GROUND

F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10ATU1 A-3282-029-A TUNER UNIT (TUX-006/2 (E))

52

5-2. FRONT PANEL SECTION

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

57

58

59

62

64

61 60

65

54

66 53

67

51

52

56

#4

#4

#4

LCD801

D

C

D

C

55

not supplied(DISPLAY board)

63

51 3-019-549-01 BUTTON (RELEASE)52 3-019-544-31 KNOB (SEEK/AMS)53 3-375-373-01 SPRING (RELEASE)54 3-019-550-01 BUTTON (MODE/SOUND)55 3-019-528-01 BUTTON (1-10)

56 3-019-551-21 BUTTON (EJECT)57 3-019-545-01 BUTTON (SOURCE)58 3-019-547-01 KNOB (VOL)59 3-019-548-01 RING

60 3-019-543-01 KNOB (D-BASS)* 61 X-3374-890-1 HOLDER (LCD) ASSY* 62 3-020-102-01 PLATE (I) (LCD), GROUND

63 3-021-407-01 SHEET (D), LCD* 64 3-019-531-01 SHEET (LCD), COLOR

65 3-019-521-01 PANEL, FRONT BACK66 X-3374-886-1 FRONT PANEL ASSY67 3-019-527-01 BUTTON (DSPL)LCD801 1-803-028-11 DISPLAY PANEL, LIQUID CRYSTAL

53

5-3. CD MECHANISM SECTION (1)(MG-363X-121)


102

104111

112103

109101

107

111112

105106

108

114115

110

113

116

#8#8

#7

#7

#7

#8

#9

M903

E

E

* 101 1-659-836-11 DISC IN SW BOARD* 102 A-3291-816-B CHASSIS (T) SUB ASSY

103 3-931-909-01 SPRING (LR), TENSION104 X-3371-501-1 LEVER (L) ASSY105 3-338-737-01 SCREW (2X3), +PS

* 106 1-659-837-11 LOAD SW BOARD107 X-3371-502-1 LEVER (R) ASSY108 A-3301-203-A ROLLER ASSY109 3-931-908-01 GUIDE (DISC)

110 3-931-902-03 ARM (ROLLER)111 3-936-756-01 ROLLER (D)112 3-321-393-01 WASHER, STOPPER

* 113 3-939-139-01 SPACER114 3-931-916-01 SPRING (RA), TENSION

* 115 A-3309-227-A SERVO BOARD, COMPLETE* 116 3-007-530-01 BRACKET (MOTOR)

M903 A-3291-676-A MOTOR SUB ASSY, LOADING

54

5-4. CD MECHANISM SECTION (2) (MG-363X-121)


155

154151

156

157

158

160

162

161

164

159

152

152

152

153

163

157

not supplied

#9

F

F

151 3-931-893-01 ARM, CHUCKING152 3-931-897-01 DAMPER (T)153 3-931-879-02 LEVER (D)

* 154 3-913-404-11 RETAINER (DISC)155 3-931-894-01 BRACKET (CP)

156 3-931-895-01 SPRING (CH), TENSION157 3-931-898-01 SPRING (FL), COMPRESSION

158 3-019-805-01 SPRING (KF1), TENSION* 159 A-3291-677-G CHASSIS (M) ASSY

160 3-931-883-01 SPRING (TR), TENSION161 3-931-881-01 LEVER (LOCK)162 3-931-882-02 GEAR (MDL)

163 3-007-537-01 WHEEL (U), WORM164 3-019-806-01 SPRING (KR1), TENSION

55

5-5. CD MECHANISM SECTION (3)(MG-363X-121)



#6

M901

#9

#8

#8

#5

M902

212211

209210

213

208205

206

204

203

202

207

201

* 201 X-3374-022-1 CHASSIS (OP) (O/S) ASSY202 3-931-829-01 SPRING (SL), PLATE203 X-3371-504-1 BASE (DRIVING) ASSY204 3-931-832-01 GEAR (SL MIDWAY)

* 205 1-659-835-12 LIMIT SW BOARD

206 3-338-737-01 SCREW (2X3), +PS207 1-659-880-11 MOTOR FLEXIBLE BOARD

* 208 1-659-834-11 SUB BOARD

209 3-909-607-01 SCREW!210 8-820-010-06 PICK-UP, OPTICAL KSS-521A/K1RP

211 3-931-834-01 SPRING (FEED), PLATE212 1-659-881-11 PICK-UP FLEXIBLE BOARD213 A-3291-669-A SHAFT (FEED) ASSY

M901 X-3371-664-2 MOTOR ASSY (SPINDLE)M902 A-3291-674-A MOTOR ASSY, SLED

56

SECTION 6ELECTRICAL PARTS LIST

NOTE: Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

-XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

AbbreviationG : German model

Items marked * are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

SEMICONDUCTORSIn each case, u : , for example:uA.. : A.. uPA.. : PA..uPB.. : PB.. uPC.. : PC.. uPD.. : PD..

CAPACITORSuF : F

COILSuH : H



When indicating parts by referencenumber, please include the board.

DISPLAYDISC IN SW

* 1-659-836-11 DISC IN SW BOARD****************

< SWITCH >

SW1 1-572-288-11 SWITCH, PUSH (DISC IN)SW2 1-572-288-11 SWITCH, PUSH (SELF)

*************************************************************

DISPLAY BOARD**************

* X-3374-890-1 HOLDER (LCD) ASSY* 3-019-531-01 SHEET (LCD), COLOR* 3-020-102-01 PLATE (I) (LCD), GROUND

3-021-407-01 SHEET (D), LCD

< CAPACITOR >

C802 1-164-222-11 CERAMIC CHIP 0.22uF 25VC803 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC804 1-164-005-11 CERAMIC CHIP 0.47uF 25VC805 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V

< CONNECTOR >

CNP802 1-764-423-11 PIN, CONNECTOR 12P

< DIODE >

D801 8-719-422-43 DIODE MA8051-HD802 8-719-420-90 DIODE MA8051-MD803 8-719-914-43 DIODE DAN202KD806 8-719-977-12 DIODE DTZ6.8BD807 8-719-977-12 DIODE DTZ6.8B

D808 8-719-977-12 DIODE DTZ6.8BD809 8-719-977-12 DIODE DTZ6.8BD810 8-719-977-12 DIODE DTZ6.8BD811 8-719-977-12 DIODE DTZ6.8B

< IC >

IC801 8-759-365-90 IC LC75824W

< JUMPER RESISTOR >

JR850 1-216-295-00 SHORT 0JR855 1-216-295-00 SHORT 0JR859 1-216-295-00 SHORT 0

< LIQUID CRYSTAL DISPLAY >

LCD801 1-803-028-11 DISPLAY PANEL, LIQUID CRYSTAL

< DIODE >

LED801 8-719-033-14 LED CL-170PG-CD-T (GREEN)LED801 8-719-033-13 LED CL-170Y-CD-T (AMBER)LED802 8-719-033-14 LED CL-170PG-CD-T (GREEN)LED802 8-719-033-13 LED CL-170Y-CD-T (AMBER)LED803 8-719-033-14 LED CL-170PG-CD-T (GREEN)

LED803 8-719-033-13 LED CL-170Y-CD-T (AMBER)LED804 8-719-033-14 LED CL-170PG-CD-T (GREEN)LED804 8-719-033-13 LED CL-170Y-CD-T (AMBER)LED805 8-719-033-14 LED CL-170PG-CD-T (GREEN)LED805 8-719-033-13 LED CL-170Y-CD-T (AMBER)

< SWITCH >

LSW801 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (6) (AMBER)LSW801 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (6) (GREEN)LSW802 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (DSPL)

(AMBER)LSW802 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (DSPL)

(GREEN)LSW803 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (SOUND)

(AMBER)

LSW803 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (SOUND) (GREEN)

LSW804 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (5) (AMBER)LSW804 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (5) (GREEN)LSW805 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (6) (AMBER)LSW805 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (6) (GREEN)

LSW806 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (7) (AMBER)LSW806 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (7) (GREEN)LSW807 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (8) (AMBER)LSW807 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (8) (GREEN)LSW808 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (9) (AMBER)

LSW808 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (9) (GREEN)LSW809 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (10) (AMBER)LSW809 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (10) (GREEN)LSW810 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (1) (AMBER)LSW810 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (1) (GREEN)

LSW811 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (2) (AMBER)LSW811 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (2) (GREEN)LSW812 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (3) (AMBER)LSW812 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (3) (GREEN)LSW813 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (4) (AMBER)

57


LIMIT SW LOAD SWDISPLAY

LSW813 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (4) (GREEN)LSW814 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (PTY)

(AMBER)LSW814 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (PTY)

(GREEN)LSW815 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (AF/TA)

(AMBER)LSW815 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (AF/TA)

(GREEN)

LSW816 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (OFF) (AMBER)

LSW816 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (OFF) (GREEN)

LSW817 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (SOURCE) (AMBER)

LSW817 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (SOURCE) (GREEN)

LSW818 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (SHIFT) (AMBER)

LSW818 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (SHIFT) (GREEN)

LSW819 1-762-141-12 SWITCH, KEYBOARD (WITH LED) (MODE) (AMBER)

LSW819 1-762-142-12 SWITCH, KEYBOARD (WITH LED) (MODE) (GREEN)

< PILOT LAMP >

PL801 1-517-665-11 LAMP, PILOTPL802 1-517-665-11 LAMP, PILOT

< TRANSISTOR >

Q802 8-729-903-46 TRANSISTOR 2SB1132-PQ805 8-729-620-06 TRANSISTOR 2SC3052-EF

< RESISTOR >

R801 1-216-647-11 METAL CHIP 680 0.5% 1/10WR802 1-216-647-11 METAL CHIP 680 0.5% 1/10WR803 1-216-647-11 METAL CHIP 680 0.5% 1/10WR804 1-208-437-41 RES,CHIP 1K 2% 1/10WR805 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10W

R806 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10WR807 1-208-445-41 RES,CHIP 2.2K 2% 1/10WR808 1-208-449-41 RES,CHIP 3.3K 2% 1/10WR809 1-208-453-41 RES,CHIP 4.7K 2% 1/10WR810 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10W

R811 1-216-647-11 METAL CHIP 680 0.5% 1/10WR812 1-216-647-11 METAL CHIP 680 0.5% 1/10WR813 1-216-647-11 METAL CHIP 680 0.5% 1/10WR814 1-208-437-41 RES,CHIP 1K 2% 1/10WR815 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10W

R816 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10WR817 1-208-445-41 RES,CHIP 2.2K 2% 1/10WR818 1-208-449-41 RES,CHIP 3.3K 2% 1/10WR819 1-208-453-41 RES,CHIP 4.7K 2% 1/10WR820 1-216-655-11 METAL CHIP 1.5K 0.5% 1/10W

R821 1-208-449-41 RES,CHIP 3.3K 2% 1/10WR822 1-216-671-11 METAL CHIP 6.8K 0.5% 1/10WR823 1-208-518-41 RES,CHIP 22K 2% 1/10WR832 1-216-029-00 METAL CHIP 150 5% 1/10WR834 1-216-029-00 METAL CHIP 150 5% 1/10W

R836 1-216-029-00 METAL CHIP 150 5% 1/10WR838 1-216-037-00 METAL CHIP 330 5% 1/10WR840 1-216-029-00 METAL CHIP 150 5% 1/10WR842 1-216-029-00 METAL CHIP 150 5% 1/10WR843 1-216-059-00 METAL CHIP 2.7K 5% 1/10W

R844 1-216-053-00 METAL CHIP 1.5K 5% 1/10WR845 1-216-059-00 METAL CHIP 2.7K 5% 1/10WR848 1-216-049-11 RES,CHIP 1K 5% 1/10WR849 1-216-049-11 RES,CHIP 1K 5% 1/10WR850 1-216-049-11 RES,CHIP 1K 5% 1/10W

R851 1-216-107-00 METAL CHIP 270K 5% 1/10WR852 1-216-121-00 RES,CHIP 1M 5% 1/10WR853 1-216-049-11 RES,CHIP 1K 5% 1/10WR854 1-216-049-11 RES,CHIP 1K 5% 1/10WR855 1-216-049-11 RES,CHIP 1K 5% 1/10W

R856 1-216-049-11 RES,CHIP 1K 5% 1/10WR858 1-216-033-00 METAL CHIP 220 5% 1/10W

< ROTARY ENCODER >

RE801 1-475-014-11 ENCODER, ROTARY

< SWITCH >

S801 1-762-937-11 SWITCH, ROTARY (D-BASS)S802 1-771-290-11 SWITCH, SLIDE (SEEK/AMS)

*************************************************************

* 1-659-835-12 LIMIT SW BOARD**************

< SWITCH >

SW3 1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT)*************************************************************

* 1-659-837-11 LOAD SW BOARD**************

< SWITCH >

SW4 1-572-288-11 SWITCH, PUSH (DOWN)*************************************************************

58


MAIN

* A-3294-367-A MAIN BOARD, COMPLETE (G)* A-3294-369-A MAIN BOARD, COMPLETE (AEP,UK)

*********************

* 3-019-533-01 BRACKET (REG)* 3-019-565-01 BRACKET (IC)

3-020-107-11 HEAT SINK7-685-547-14 SCREW +BTP 3X10 TYPE 2 N-S7-685-793-09 SCREW +PTT 2.6X8 (S)

7-685-794-09 SCREW +PTT 2.6X10 (S)

< CAPACITOR >

C101 1-163-010-11 CERAMIC CHIP 0.0012uF 10% 50VC104 1-164-346-11 CERAMIC CHIP 1uF 16VC105 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC106 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC107 1-126-160-11 ELECT 1uF 20% 50V

C108 1-126-160-11 ELECT 1uF 20% 50VC109 1-164-182-11 CERAMIC CHIP 0.0033uF 10% 50VC110 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC111 1-126-157-11 ELECT 10uF 20% 16VC112 1-164-492-11 CERAMIC CHIP 0.15uF 10% 16V

C113 1-164-492-11 CERAMIC CHIP 0.15uF 10% 16VC114 1-126-157-11 ELECT 10uF 20% 16VC120 1-126-157-11 ELECT 10uF 20% 16VC121 1-126-157-11 ELECT 10uF 20% 16VC122 1-164-005-11 CERAMIC CHIP 0.47uF 25V

C123 1-164-005-11 CERAMIC CHIP 0.47uF 25VC124 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50VC125 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100VC126 1-109-982-11 CERAMIC CHIP 1uF 10% 10VC129 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C131 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC201 1-163-010-11 CERAMIC CHIP 0.0012uF 10% 50VC204 1-164-346-11 CERAMIC CHIP 1uF 16VC205 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC206 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C207 1-126-160-11 ELECT 1uF 20% 50VC208 1-126-160-11 ELECT 1uF 20% 50VC209 1-164-182-11 CERAMIC CHIP 0.0033uF 10% 50VC210 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC211 1-126-157-11 ELECT 10uF 20% 16V

C212 1-164-492-11 CERAMIC CHIP 0.15uF 10% 16VC213 1-164-492-11 CERAMIC CHIP 0.15uF 10% 16VC214 1-126-157-11 ELECT 10uF 20% 16VC220 1-126-157-11 ELECT 10uF 20% 16VC221 1-126-157-11 ELECT 10uF 20% 16V

C222 1-164-005-11 CERAMIC CHIP 0.47uF 25VC223 1-164-005-11 CERAMIC CHIP 0.47uF 25VC224 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50VC225 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100VC226 1-109-982-11 CERAMIC CHIP 1uF 10% 10V

C228 1-124-584-00 ELECT 100uF 20% 10V

C229 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC231 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC232 1-164-232-11 CERAMIC CHIP 0.01uF 50VC401 1-124-234-00 ELECT 22uF 20% 16VC402 1-164-346-11 CERAMIC CHIP 1uF 16V

C403 1-124-257-00 ELECT 2.2uF 20% 50VC404 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC406 1-126-160-11 ELECT 1uF 20% 50VC407 1-164-346-11 CERAMIC CHIP 1uF 16VC408 1-164-346-11 CERAMIC CHIP 1uF 16V

C409 1-126-936-11 ELECT 3300uF 20% 16VC410 1-124-242-00 ELECT 33uF 20% 25VC411 1-126-967-11 ELECT 47uF 20% 16VC412 1-124-465-00 ELECT 0.47uF 20% 50VC413 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C501 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC601 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC602 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50VC603 1-164-232-11 CERAMIC CHIP 0.01uF 50VC606 1-126-933-11 ELECT 100uF 20% 10V

C607 1-164-232-11 CERAMIC CHIP 0.01uF 50VC608 1-126-933-11 ELECT 100uF 20% 10VC609 1-164-232-11 CERAMIC CHIP 0.01uF 50VC610 1-126-933-11 ELECT 100uF 20% 10VC611 1-164-232-11 CERAMIC CHIP 0.01uF 50V

C612 1-164-346-11 CERAMIC CHIP 1uF 16VC613 1-126-967-11 ELECT 47uF 20% 16VC615 1-163-019-00 CERAMIC CHIP 0.0068uF 10% 50VC618 1-163-029-11 CERAMIC CHIP 0.0047uF 50VC619 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C620 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC621 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC622 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC623 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC624 1-163-017-00 CERAMIC CHIP 0.0047uF 5% 50V

C625 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC626 1-164-232-11 CERAMIC CHIP 0.01uF 50VC627 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC628 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100VC629 1-126-967-11 ELECT 47uF 20% 16V

C631 1-164-489-11 CERAMIC CHIP 0.22uF 10% 16VC633 1-163-234-11 CERAMIC CHIP 20PF 5% 50VC634 1-163-243-11 CERAMIC CHIP 47PF 5% 50VC635 1-164-232-11 CERAMIC CHIP 0.01uF 50VC636 1-164-161-11 CERAMIC CHIP 0.0022uF 10% 100V

C637 1-163-038-00 CERAMIC CHIP 0.1uF 25VC640 1-163-135-00 CERAMIC CHIP 560PF 5% 50VC641 1-163-237-11 CERAMIC CHIP 27PF 5% 50VC642 1-163-237-11 CERAMIC CHIP 27PF 5% 50VC643 1-163-275-11 CERAMIC CHIP 0.001uF 5% 50V

C644 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC645 1-126-157-11 ELECT 10uF 20% 16VC646 1-124-257-00 ELECT 2.2uF 20% 50V

59


MAIN

C647 1-164-232-11 CERAMIC CHIP 0.01uF 50VC652 1-164-232-11 CERAMIC CHIP 0.01uF 50VC657 1-163-003-11 CERAMIC CHIP 330PF 10% 50VC658 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC701 1-163-001-11 CERAMIC CHIP 220PF 10% 50V

C702 1-164-232-11 CERAMIC CHIP 0.01uF 50VC703 1-164-232-11 CERAMIC CHIP 0.01uF 50VC704 1-164-232-11 CERAMIC CHIP 0.01uF 50VC705 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC706 1-164-232-11 CERAMIC CHIP 0.01uF 50V

C707 1-164-232-11 CERAMIC CHIP 0.01uF 50VC708 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC709 1-164-232-11 CERAMIC CHIP 0.01uF 50VC710 1-128-057-11 ELECT 330uF 20% 6.3VC711 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

C712 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC713 1-164-232-11 CERAMIC CHIP 0.01uF 50VC716 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC717 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC718 1-163-239-11 CERAMIC CHIP 33PF 5% 50V

C801 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC802 1-164-346-11 CERAMIC CHIP 1uF 16VC806 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC809 1-163-001-11 CERAMIC CHIP 220PF 10% 50VC811 1-163-235-11 CERAMIC CHIP 22PF 5% 50V

C812 1-163-235-11 CERAMIC CHIP 22PF 5% 50VC813 1-163-038-00 CERAMIC CHIP 0.1uF 25VC814 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC816 1-109-982-11 CERAMIC CHIP 1uF 10% 10VC817 1-109-982-11 CERAMIC CHIP 1uF 10% 10V

C819 1-124-584-00 ELECT 100uF 20% 10VC903 1-163-117-00 CERAMIC CHIP 100PF 5% 50VC904 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC905 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC906 1-126-157-11 ELECT 10uF 20% 16V

C907 1-126-157-11 ELECT 10uF 20% 16VC908 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25VC909 1-126-157-11 ELECT 10uF 20% 16VC910 1-164-232-11 CERAMIC CHIP 0.01uF 50VC911 1-126-157-11 ELECT 10uF 20% 16V

C912 1-164-222-11 CERAMIC CHIP 0.22uF 25VC913 1-126-160-11 ELECT 1uF 20% 50VC914 1-125-701-11 DOUBLE LAYER 0.047F 0 5.5VC915 1-124-584-00 ELECT 100uF 20% 10VC916 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C917 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC918 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC919 1-124-465-00 ELECT 0.47uF 20% 50VC920 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC921 1-124-465-00 ELECT 0.47uF 20% 50V

C922 1-163-038-00 CERAMIC CHIP 0.1uF 25VC923 1-124-234-00 ELECT 22uF 20% 16VC924 1-126-163-11 ELECT 4.7uF 20% 50V

C925 1-124-257-00 ELECT 2.2uF 20% 50VC926 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V

< JACK >

CNJ600 1-764-808-21 JACK (ANT)

< CONNECTOR >

CNP501 1-774-701-11 PIN, CONNECTOR 16PCNP700 1-764-617-12 PIN, CONNECTOR (PC BOARD) 30PCNP800 1-764-422-11 PLUG, CONNECTOR 12PCNP802 1-566-822-41 JACK (REMOTE IN)

< DISCHARGE GAP >

CP601 1-519-504-11 GAP, DISCHARGE

< DIODE >

D402 8-719-109-71 DIODE RD3.9ES-B1D403 8-719-914-43 DIODE DAN202KD404 8-719-200-82 DIODE 11ES2D405 8-719-200-82 DIODE 11ES2D406 8-719-200-82 DIODE 11ES2

D407 8-719-200-82 DIODE 11ES2D408 8-719-200-82 DIODE 11ES2D409 8-719-200-82 DIODE 11ES2D410 8-719-200-82 DIODE 11ES2D411 8-719-200-82 DIODE 11ES2

D601 8-719-986-73 DIODE RB441QD602 8-719-986-73 DIODE RB441QD603 8-719-977-03 DIODE DTZ5.6BD605 8-719-422-16 DIODE MA8039-L-TXD801 8-719-914-43 DIODE DAN202K

D807 8-719-017-62 DIODE MA8068-L-TXD812 8-719-109-97 DIODE RD6.8ES-B2D813 8-719-109-97 DIODE RD6.8ES-B2D814 8-719-109-97 DIODE RD6.8ES-B2D815 8-719-109-97 DIODE RD6.8ES-B2

D816 8-719-109-97 DIODE RD6.8ES-B2D817 8-719-109-97 DIODE RD6.8ES-B2D818 8-719-109-97 DIODE RD6.8ES-B2D819 8-719-109-97 DIODE RD6.8ES-B2D820 8-719-109-97 DIODE RD6.8ES-B2

D821 8-719-109-97 DIODE RD6.8ES-B2D822 8-719-109-97 DIODE RD6.8ES-B2D823 8-719-977-12 DIODE DTZ6.8BD824 8-719-977-12 DIODE DTZ6.8BD901 8-719-200-82 DIODE 11ES2

D902 8-719-200-82 DIODE 11ES2D903 8-719-049-38 DIODE 1N5404TUD904 8-719-914-44 DIODE DAP202KD907 8-719-914-43 DIODE DAN202KD909 8-719-422-76 DIODE MA8075-M

D910 8-719-017-91 DIODE MA8160

60


MAIN

D911 8-719-977-03 DIODE DTZ5.6BD912 8-719-923-60 DIODE MTZJ-T-77-9.1AD913 8-719-109-89 DIODE RD5.6ESB2D914 8-719-977-12 DIODE DTZ6.8BD916 8-719-921-80 DIODE MTZJ-11B

D917 8-719-914-44 DIODE DAP202KD918 8-719-914-43 DIODE DAN202KD919 8-719-914-43 DIODE DAN202K

< FUSE >

F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

< IC >

IC200 8-759-490-74 IC TDA7384IC401 8-759-487-82 IC LC75374EIC404 8-759-391-88 IC BU4066BCFV-E2IC601 8-759-448-85 IC BU2624FV-E2IC602 8-759-492-59 IC SAA6588T-118

IC603 8-759-242-66 IC TC4W66FIC701 8-759-473-70 IC SM5852FS-E2IC702 8-759-498-36 IC SM5878AM-E2IC801 8-759-499-11 IC MB90574PFV-G-110IC901 8-759-347-50 IC BA3918-V3

IC902 8-749-010-99 IC KIA7039P-AT

< JUMPER RESISTOR >

JR1 1-216-295-00 SHORT 0JR2 1-216-295-00 SHORT 0JR124 1-216-295-00 SHORT 0JR125 1-216-295-00 SHORT 0JR224 1-216-295-00 SHORT 0



JR804 1-216-295-00 SHORT 0JR856 1-216-295-00 SHORT 0JR857 1-216-295-00 SHORT 0

< COIL >

L201 1-414-137-31 INDUCTOR 0.22uHL601 1-410-513-11 INDUCTOR 22uHL603 1-410-509-11 INDUCTOR 10uHL703 1-410-513-11 INDUCTOR 22uHL801 1-410-501-11 INDUCTOR 2.2uH

L901 1-416-539-11 COIL, CHOKE

< JACK >

PJ400 1-764-697-11 JACK, PIN 4P (LINE OUT FRONT/REAR)

< TRANSISTOR >

Q110 8-729-920-21 TRANSISTOR DTC314TKH04Q111 8-729-920-21 TRANSISTOR DTC314TKH04Q210 8-729-920-21 TRANSISTOR DTC314TKH04Q211 8-729-920-21 TRANSISTOR DTC314TKH04Q401 8-729-901-05 TRANSISTOR DTA124EK

Q402 8-729-027-52 TRANSISTOR DTC124EKA-T146Q601 8-729-620-06 TRANSISTOR 2SC3052-EFQ604 8-729-901-05 TRANSISTOR DTA124EKQ605 8-729-027-52 TRANSISTOR DTC124EKA-T146Q606 8-729-920-21 TRANSISTOR DTC314TKH04

Q607 8-729-920-21 TRANSISTOR DTC314TKH04Q610 8-729-027-52 TRANSISTOR DTC124EKA-T146Q611 8-729-021-94 TRANSISTOR 2SK1657-T1BQ701 8-729-620-06 TRANSISTOR 2SC3052-EFQ801 8-729-620-06 TRANSISTOR 2SC3052-EF

Q901 8-729-901-05 TRANSISTOR DTA124EKQ902 8-729-027-52 TRANSISTOR DTC124EKA-T146Q903 8-729-019-00 TRANSISTOR 2SD2394-GQ905 8-729-422-27 TRANSISTOR 2SD601A-QQ906 8-729-027-52 TRANSISTOR DTC124EKA-T146

Q907 8-729-901-05 TRANSISTOR DTA124EKQ908 8-729-027-52 TRANSISTOR DTC124EKA-T146Q909 8-729-920-85 TRANSISTOR 2SD1664-QRQ910 8-729-901-05 TRANSISTOR DTA124EKQ911 8-729-027-52 TRANSISTOR DTC124EKA-T146

Q912 8-729-019-00 TRANSISTOR 2SD2394-GQ913 8-729-015-11 TRANSISTOR 2SD1802FAST-TLQ914 8-729-901-05 TRANSISTOR DTA124EKQ915 8-729-901-05 TRANSISTOR DTA124EKQ916 8-729-620-06 TRANSISTOR 2SC3052-EF

Q917 8-729-620-06 TRANSISTOR 2SC3052-EFQ918 8-729-620-06 TRANSISTOR 2SC3052-EF

< RESISTOR >

R101 1-216-073-00 METAL CHIP 10K 5% 1/10WR102 1-216-073-00 METAL CHIP 10K 5% 1/10WR104 1-216-059-00 METAL CHIP 2.7K 5% 1/10WR105 1-216-081-00 METAL CHIP 22K 5% 1/10WR106 1-216-081-00 METAL CHIP 22K 5% 1/10W

R111 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR112 1-216-041-00 METAL CHIP 470 5% 1/10WR113 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR114 1-216-041-00 METAL CHIP 470 5% 1/10WR115 1-216-075-00 METAL CHIP 12K 5% 1/10W

R116 1-216-075-00 METAL CHIP 12K 5% 1/10WR117 1-216-129-00 METAL CHIP 2.2M 5% 1/10WR118 1-216-129-00 METAL CHIP 2.2M 5% 1/10WR122 1-216-053-00 METAL CHIP 1.5K 5% 1/10W

(G)

61


MAIN

R122 1-216-077-00 METAL CHIP 15K 5% 1/10W(AEP,UK)

R123 1-216-077-00 METAL CHIP 15K 5% 1/10WR127 1-216-077-00 METAL CHIP 15K 5% 1/10WR128 1-216-082-00 RES,CHIP 24K 5% 1/10WR129 1-216-082-00 RES,CHIP 24K 5% 1/10W

R201 1-216-073-00 METAL CHIP 10K 5% 1/10WR202 1-216-073-00 METAL CHIP 10K 5% 1/10WR204 1-216-059-00 METAL CHIP 2.7K 5% 1/10WR205 1-216-081-00 METAL CHIP 22K 5% 1/10WR206 1-216-081-00 METAL CHIP 22K 5% 1/10W

R211 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR212 1-216-041-00 METAL CHIP 470 5% 1/10WR213 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR214 1-216-041-00 METAL CHIP 470 5% 1/10WR215 1-216-075-00 METAL CHIP 12K 5% 1/10W

R216 1-216-075-00 METAL CHIP 12K 5% 1/10WR217 1-216-129-00 METAL CHIP 2.2M 5% 1/10WR218 1-216-129-00 METAL CHIP 2.2M 5% 1/10WR222 1-216-053-00 METAL CHIP 1.5K 5% 1/10W

(G)R222 1-216-077-00 METAL CHIP 15K 5% 1/10W

(AEP,UK)

R223 1-216-077-00 METAL CHIP 15K 5% 1/10WR227 1-216-077-00 METAL CHIP 15K 5% 1/10WR228 1-216-082-00 RES,CHIP 24K 5% 1/10WR229 1-216-082-00 RES,CHIP 24K 5% 1/10WR401 1-216-049-11 RES,CHIP 1K 5% 1/10W

R402 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR403 1-216-073-00 METAL CHIP 10K 5% 1/10WR408 1-216-073-00 METAL CHIP 10K 5% 1/10WR410 1-216-097-00 RES,CHIP 100K 5% 1/10WR411 1-216-097-00 RES,CHIP 100K 5% 1/10W

R601 1-216-049-11 RES,CHIP 1K 5% 1/10WR602 1-216-025-00 RES,CHIP 100 5% 1/10WR603 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR604 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR605 1-216-077-00 METAL CHIP 15K 5% 1/10W

R609 1-216-061-00 METAL CHIP 3.3K 5% 1/10WR610 1-216-049-11 RES,CHIP 1K 5% 1/10WR611 1-216-025-00 RES,CHIP 100 5% 1/10WR612 1-216-073-00 METAL CHIP 10K 5% 1/10WR613 1-216-061-00 METAL CHIP 3.3K 5% 1/10W

R614 1-216-061-00 METAL CHIP 3.3K 5% 1/10WR615 1-216-077-00 METAL CHIP 15K 5% 1/10WR616 1-216-073-00 METAL CHIP 10K 5% 1/10WR617 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR619 1-216-073-00 METAL CHIP 10K 5% 1/10W

R620 1-216-129-00 METAL CHIP 2.2M 5% 1/10WR621 1-216-053-00 METAL CHIP 1.5K 5% 1/10WR622 1-216-089-00 RES,CHIP 47K 5% 1/10WR623 1-216-035-00 METAL CHIP 270 5% 1/10WR624 1-216-035-00 METAL CHIP 270 5% 1/10W

R625 1-216-041-00 METAL CHIP 470 5% 1/10W

R626 1-216-049-11 RES,CHIP 1K 5% 1/10WR627 1-216-113-00 METAL CHIP 470K 5% 1/10WR642 1-216-077-00 METAL CHIP 15K 5% 1/10WR644 1-216-061-00 METAL CHIP 3.3K 5% 1/10WR645 1-216-065-00 RES,CHIP 4.7K 5% 1/10W

R647 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR648 1-216-001-00 METAL CHIP 10 5% 1/10WR701 1-216-025-00 RES,CHIP 100 5% 1/10WR702 1-216-025-00 RES,CHIP 100 5% 1/10WR703 1-216-025-00 RES,CHIP 100 5% 1/10W

R705 1-216-033-00 METAL CHIP 220 5% 1/10WR706 1-216-121-00 RES,CHIP 1M 5% 1/10WR707 1-216-113-00 METAL CHIP 470K 5% 1/10WR708 1-216-037-00 METAL CHIP 330 5% 1/10WR710 1-216-027-00 METAL CHIP 120 5% 1/10W

R802 1-216-073-00 METAL CHIP 10K 5% 1/10WR804 1-216-049-11 RES,CHIP 1K 5% 1/10WR805 1-216-049-11 RES,CHIP 1K 5% 1/10WR806 1-216-049-11 RES,CHIP 1K 5% 1/10WR807 1-216-049-11 RES,CHIP 1K 5% 1/10W

R809 1-216-025-00 RES,CHIP 100 5% 1/10WR810 1-216-025-00 RES,CHIP 100 5% 1/10WR820 1-216-085-00 METAL CHIP 33K 5% 1/10WR821 1-216-089-00 RES,CHIP 47K 5% 1/10WR822 1-216-057-00 METAL CHIP 2.2K 5% 1/10W

R823 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR824 1-216-089-00 RES,CHIP 47K 5% 1/10WR825 1-216-097-00 RES,CHIP 100K 5% 1/10WR826 1-216-097-00 RES,CHIP 100K 5% 1/10WR827 1-216-097-00 RES,CHIP 100K 5% 1/10W

R828 1-216-097-00 RES,CHIP 100K 5% 1/10WR829 1-216-073-00 METAL CHIP 10K 5% 1/10WR830 1-216-073-00 METAL CHIP 10K 5% 1/10WR831 1-216-073-00 METAL CHIP 10K 5% 1/10WR839 1-216-073-00 METAL CHIP 10K 5% 1/10W

R842 1-216-073-00 METAL CHIP 10K 5% 1/10WR843 1-216-073-00 METAL CHIP 10K 5% 1/10WR844 1-216-025-00 RES,CHIP 100 5% 1/10WR845 1-216-025-00 RES,CHIP 100 5% 1/10WR846 1-216-097-00 RES,CHIP 100K 5% 1/10W

R847 1-216-097-00 RES,CHIP 100K 5% 1/10WR848 1-216-097-00 RES,CHIP 100K 5% 1/10WR850 1-216-097-00 RES,CHIP 100K 5% 1/10WR853 1-216-097-00 RES,CHIP 100K 5% 1/10WR854 1-216-089-00 RES,CHIP 47K 5% 1/10W

R855 1-216-097-00 RES,CHIP 100K 5% 1/10WR856 1-216-025-00 RES,CHIP 100 5% 1/10WR857 1-216-097-00 RES,CHIP 100K 5% 1/10WR858 1-216-097-00 RES,CHIP 100K 5% 1/10WR863 1-216-049-11 RES,CHIP 1K 5% 1/10W

R864 1-216-049-11 RES,CHIP 1K 5% 1/10WR865 1-216-049-11 RES,CHIP 1K 5% 1/10WR866 1-216-049-11 RES,CHIP 1K 5% 1/10WR868 1-216-049-11 RES,CHIP 1K 5% 1/10W

62


SERVOMAIN

R869 1-216-049-11 RES,CHIP 1K 5% 1/10WR870 1-216-049-11 RES,CHIP 1K 5% 1/10WR881 1-216-049-11 RES,CHIP 1K 5% 1/10WR902 1-216-097-00 RES,CHIP 100K 5% 1/10WR903 1-216-041-00 METAL CHIP 470 5% 1/10W

R904 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR905 1-216-073-00 METAL CHIP 10K 5% 1/10WR906 1-216-097-00 RES,CHIP 100K 5% 1/10WR907 1-216-057-00 METAL CHIP 2.2K 5% 1/10WR908 1-216-205-11 RES,CHIP 2K 5% 1/8W

R909 1-216-049-11 RES,CHIP 1K 5% 1/10WR910 1-216-049-11 RES,CHIP 1K 5% 1/10WR911 1-216-033-00 METAL CHIP 220 5% 1/10WR913 1-216-089-00 RES,CHIP 47K 5% 1/10WR914 1-216-089-00 RES,CHIP 47K 5% 1/10W

R915 1-216-085-00 METAL CHIP 33K 5% 1/10WR916 1-216-205-11 RES,CHIP 2K 5% 1/8WR917 1-216-085-00 METAL CHIP 33K 5% 1/10WR918 1-216-073-00 METAL CHIP 10K 5% 1/10WR919 1-216-073-00 METAL CHIP 10K 5% 1/10W

R920 1-216-097-00 RES,CHIP 100K 5% 1/10WR921 1-216-079-00 METAL CHIP 18K 5% 1/10WR922 1-216-064-00 METAL CHIP 4.3K 5% 1/10WR923 1-216-105-00 RES,CHIP 220K 5% 1/10WR924 1-216-089-00 RES,CHIP 47K 5% 1/10W

R925 1-216-097-00 RES,CHIP 100K 5% 1/10W

< VARIABLE RESISTOR >

RV801 1-238-552-11 RES, ADJ, CARBON 470K

< SWITCH >

S900 1-762-638-11 SWITCH, TACTILE (RESET)SW801 1-571-478-11 SWITCH, SLIDE (POWER SELECT)

< TUNER >

TU1 A-3282-029-A TUNER UNIT (TUX-006/2 (E))

< VIBRATOR >

X601 1-760-749-11 VIBRATOR, CRYSTAL (7.2MHz)X602 1-579-242-41 VIBRATOR, CRYSTAL (4.322MHz)X700 1-767-453-11 VIBRATOR, CRYSTAL (16.9344MHz)X800 1-767-833-21 VIBRATOR, CERAMIC (4.19MHz)X801 1-567-098-41 VIBRATOR, CRYSTAL (32.768KHz)

*************************************************************

* A-3309-227-A SERVO BOARD, COMPLETE**********************

< CAPACITOR >

C1 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC2 1-164-232-11 CERAMIC CHIP 0.01uF 50VC3 1-135-145-11 TANTALUM CHIP 0.47uF 10% 35V

C4 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC5 1-164-182-11 CERAMIC CHIP 0.0033uF 10% 50VC6 1-163-011-11 CERAMIC CHIP 0.0015uF 10% 50VC7 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC9 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C10 1-126-206-11 ELECT CHIP 100uF 20% 6.3VC11 1-135-259-11 TANTAL. CHIP 10uF 20% 6.3VC12 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC13 1-164-232-11 CERAMIC CHIP 0.01uF 50VC14 1-163-989-11 CERAMIC CHIP 0.033uF 10% 25V

C15 1-164-232-11 CERAMIC CHIP 0.01uF 50VC16 1-163-989-11 CERAMIC CHIP 0.033uF 10% 25VC17 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC18 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC19 1-163-037-11 CERAMIC CHIP 0.022uF 10% 25V

C20 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC21 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25VC22 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC23 1-135-259-11 TANTAL. CHIP 10uF 20% 6.3VC24 1-163-259-00 CERAMIC CHIP 220PF 5% 50V

C25 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16VC26 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC27 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC28 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50VC29 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C30 1-126-603-11 ELECT CHIP 4.7uF 20% 35VC31 1-164-232-11 CERAMIC CHIP 0.01uF 50VC32 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50VC33 1-124-779-00 ELECT CHIP 10uF 20% 16VC34 1-109-982-11 CERAMIC CHIP 1uF 10% 10V

C35 1-164-232-11 CERAMIC CHIP 0.01uF 50VC36 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC37 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC38 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25VC39 1-126-204-11 ELECT CHIP 47uF 20% 16V

C40 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

< CONNECTOR >

CN1 1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30PCN2 1-565-728-11 CONNECTOR, FPC 17PCN3 1-770-347-21 CONNECTOR, FPC 6P

< IC >

IC1 8-752-372-94 IC CXD2507AQIC2 8-752-074-34 IC CXA1782BQIC3 8-759-354-16 IC BA6796FP-T1

< JUMPER RESISTOR >

JR1 1-216-296-00 SHORT 0JR2 1-216-296-00 SHORT 0JR3 1-216-296-00 SHORT 0JR4 1-216-296-00 SHORT 0

63


SERVO









JR45 1-216-296-00 SHORT 0JR46 1-216-296-00 SHORT 0

< COIL >

L1 1-412-058-11 INDUCTOR CHIP 10uHL2 1-412-058-11 INDUCTOR CHIP 10uHL3 1-412-058-11 INDUCTOR CHIP 10uH

< TRANSISTOR >

Q1 8-729-904-60 TRANSISTOR DTB113ZKQ2 8-729-904-86 TRANSISTOR 2SB1197K-Q

< RESISTOR >

R1 1-216-073-00 METAL CHIP 10K 5% 1/10WR2 1-216-097-00 RES,CHIP 100K 5% 1/10WR3 1-216-121-00 RES,CHIP 1M 5% 1/10WR4 1-216-061-00 METAL CHIP 3.3K 5% 1/10WR5 1-216-061-00 METAL CHIP 3.3K 5% 1/10W

R6 1-216-073-00 METAL CHIP 10K 5% 1/10WR7 1-216-009-00 METAL CHIP 22 5% 1/10WR8 1-216-119-00 METAL CHIP 820K 5% 1/10WR9 1-216-119-00 METAL CHIP 820K 5% 1/10WR10 1-216-073-00 METAL CHIP 10K 5% 1/10W

R11 1-216-073-00 METAL CHIP 10K 5% 1/10WR14 1-216-085-00 METAL CHIP 33K 5% 1/10WR15 1-216-085-00 METAL CHIP 33K 5% 1/10WR16 1-216-077-00 METAL CHIP 15K 5% 1/10WR17 1-216-081-00 METAL CHIP 22K 5% 1/10W

R19 1-216-079-00 METAL CHIP 18K 5% 1/10WR20 1-216-105-00 RES,CHIP 220K 5% 1/10WR21 1-216-105-00 RES,CHIP 220K 5% 1/10WR22 1-216-085-00 METAL CHIP 33K 5% 1/10WR23 1-216-121-00 RES,CHIP 1M 5% 1/10W

R24 1-216-073-00 METAL CHIP 10K 5% 1/10WR27 1-216-295-00 SHORT 0R28 1-216-101-00 METAL CHIP 150K 5% 1/10WR29 1-216-097-00 RES,CHIP 100K 5% 1/10WR30 1-216-097-00 RES,CHIP 100K 5% 1/10W

R31 1-216-081-00 METAL CHIP 22K 5% 1/10WR32 1-216-109-00 METAL CHIP 330K 5% 1/10WR33 1-216-105-00 RES,CHIP 220K 5% 1/10WR34 1-216-009-00 METAL CHIP 22 5% 1/10WR35 1-216-065-00 RES,CHIP 4.7K 5% 1/10W

R36 1-216-097-00 RES,CHIP 100K 5% 1/10WR37 1-216-117-00 METAL CHIP 680K 5% 1/10WR38 1-216-109-00 METAL CHIP 330K 5% 1/10WR39 1-216-101-00 METAL CHIP 150K 5% 1/10WR40 1-216-114-00 RES,CHIP 510K 5% 1/10W

R41 1-216-093-00 METAL CHIP 68K 5% 1/10WR42 1-216-103-00 METAL CHIP 180K 5% 1/10WR43 1-216-097-00 RES,CHIP 100K 5% 1/10WR44 1-216-085-00 METAL CHIP 33K 5% 1/10WR45 1-216-081-00 METAL CHIP 22K 5% 1/10W

R46 1-216-097-00 RES,CHIP 100K 5% 1/10WR47 1-216-105-00 RES,CHIP 220K 5% 1/10WR48 1-216-073-00 METAL CHIP 10K 5% 1/10WR49 1-216-065-00 RES,CHIP 4.7K 5% 1/10WR50 1-216-065-00 RES,CHIP 4.7K 5% 1/10W

R51 1-216-295-00 SHORT 0

< VARIABLE RESISTOR >

RV1 1-238-091-11 RES, ADJ, CERMET 22KRV4 1-238-091-11 RES, ADJ, CERMET 22K

*************************************************************

64

SUB



* 1-659-834-11 SUB BOARD**********

< CONNECTOR >

CN1 1-770-347-21 CONNECTOR, FPC 6P*************************************************************

MISCELLANEOUS***************

11 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)207 1-659-880-11 MOTOR FLEXIBLE BOARD!210 8-820-010-06 PICK-UP, OPTICAL KSS-521A/K1RP

212 1-659-881-11 PICK-UP FLEXIBLE BOARDF901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A

M901 X-3371-664-2 MOTOR ASSY (SPINDLE)M902 A-3291-674-A MOTOR ASSY, SLEDM903 A-3291-676-A MOTOR SUB ASSY, LOADING

*************************************************************

ACCESSORIES & PACKING MATERIALS********************************

3-861-912-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH, PORTUGUESE,SWEDISH) (AEP,UK)

3-861-912-21 MANUAL, INSTRUCTION (FRENCH,GERMAN, DUTCH,ITALIAN) (AEP)

3-861-912-31 MANUAL, INSTRUCTION (GERMAN) (G)3-861-913-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

SPANISH,PORTUGUESE,SWEDISH) (AEP,UK)3-861-913-21 MANUAL, INSTRUCTION, INSTALL (FRENCH,

GERMAN,DUTCH,ITALIAN) (AEP,G)

X-3374-927-1 CASE ASSY*************************************************************

**************

HARDWARE LIST**************

#1 7-685-792-09 SCREW +PTT 2.6X6 (S)#2 7-685-793-09 SCREW +PTT 2.6X8 (S)#3 7-621-772-10 SCREW +B 2X4#4 7-685-106-19 SCREW +P 2X10 TYPE 2 NON-SLIT#5 7-627-850-28 SCREW, PRECISION +P 1.4X3

#6 7-627-000-00 SCREW, PRECISION +P 1.7X2.2 TYPE 3#7 7-628-253-00 SCREW +PS 2X4#8 7-627-553-37 PRECISION SCREW +P 2X3 TYPE 3#9 7-627-553-17 PRECISION SCREW +P 2X2 TYPE 3#10 7-685-794-09 SCREW +PTT 2.6X10 (S)

#11 7-685-547-14 SCREW +BTP 3X10 TYPE 2 N-S*************************************************************

PARTS FOR INSTALLATION AND CONNECTIONS***************************************

251 3-916-161-31 FRAME252 X-3374-928-1 COLLAR ASSY253 3-386-828-01 SCREW, FITTING254 3-349-410-01 BUSHING255 3-388-078-01 KEY

256 X-3370-077-1 SCREW ASSY (AE.KEY), FITTING257 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)258 1-465-459-21 ADAPTOR, ANTENNA

Sony CorporationPersonal & Mobile Communication Company9-925-781-11

CDX-4180R

98C047545-1Printed in Hungary C1998. 3

Published by Quality Assurance Dept.

DISASSEMBLY ( Tree )

CDX-4180R

Main body Power cordFront panel

assyBracket(M/D)

Main board

Tuner unit

CD mechablock Chassis

Cover assy

Heat sink B

Heat sink A

(connector)

(claw)

(2.6*64) (2.6*62)

(2.6*64)(CNP)

(CNP)

(3*63, 2.6*83)

(solder26)

(2.6*83, 2.6*101)

Sub panelassy

clawclaw

claw5

sub panel

Button(release)

DC power cord

[Fig.1] Main body [Fig.2] Cover assy

[Fig.3] Front panel[Fig.4] Sub panel

Button(release)

to next page

CDX-4180R

Cover assy

Screw4

[Fig.5] CD macha brock[Fig.6] Main board

Tuner unitChassis

Heat sink

Main board

from front page

CDX-4180R

Screw3

Connector

COVERGENERALDISASSEMBLYDISASSEMBLY ( Tree)ELECTRICAL ADJUSTMENTSDIAGRAMSEXPLODED VIEWSELECTRICAL PARTS LIST

sony_cdx-4180r_sm_2

Documents

panel assy

db stereo

cover assy

lever assy

roller assy

chassis t sub assy

chassis op os assy

db monoharmonic distortion