state of california · state of california air resources board ... code for the gm vehicles listed...

7
State of California AIR RESOURCES BOARD EXECUTIVE ORDER D-269-49 Relating to Exemptio ns Under Section 27156 of the California Vehicle Code K&N Engineering Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G-14-012; IT IS ORDERED AND RESOLVED: That the installation of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems, produced and marketed by K&N Engineering of 1455 Citrus Avenue, Riverside, California 92507, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the GM vehicles listed in the attached Exhibit A. The Fu el Injection Performance.Kits, 77 Series, Blackhawk, and Typhoon Intake Systems in clude the following main components: open-element reusable air filter, intake system tubing, assorted brackets, and hardware. This Executive Order is valid provided that the installation in structions for the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer. Changes made to the design or operating conditions of the Fuel Injection Performance Kit, 77 Series, Blackhawk, and Typhoon Intake Systems, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle's pollution control system shall invalidate this Executive Order. This Executive Order shall not apply to any Fuel Injection Performance Kit, 77 Series, Blackhawk, or Typhoon Intake System advertise d, offered for sale, sold with, or installed on a new motor vehicle prior to or co ncurrent with transfer to an ultimate purchaser. Marketing of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems using any identification other than that shown in this Executive Order or marketing of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems for an application other than those listed in this Executive Order shall be prohibited unless prior approval .is obtained from the Air Resources Board.

Upload: phamliem

Post on 13-Apr-2018

241 views

Category:

Documents


2 download

TRANSCRIPT

Page 1: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

State of California AIR RESOURCES BOARD

EXECUTIVE ORDER D-269-49

Relating to Exemptions Under Section 27156 of the California Vehicle Code

K&N Engineering Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems

Pursuant to the authority vested in the Air Resources Board by Section 27156 of the Vehicle Code; and

Pursuant to the authority vested in the undersigned by Section 39515 and Section 39516 of the Health and Safety Code and Executive Order G-14-012;

IT IS ORDERED AND RESOLVED: That the installation of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems, produced and marketed by K&N Engineering of 1455 Citrus Avenue, Riverside, California 92507, has been found not to reduce the effectiveness of the applicable vehicle pollution control systems and, therefore, is exempt from the prohibitions of Section 27156 of the Vehicle Code for the GM vehicles listed in the attached Exhibit A.

The Fuel Injection Performance. Kits, 77 Series, Blackhawk, and Typhoon Intake Systems include the following main components: open-element reusable air filter, intake system tubing , assorted brackets, and hardware.

This Executive Order is valid provided that the installation instructions for the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems will not recommend tuning the vehicle to specifications different from those of the vehicle manufacturer.

Changes made to the design or operating conditions of the Fuel Injection Performance Kit, 77 Series, Blackhawk, and Typhoon Intake Systems, as exempt by the Air Resources Board, which adversely affect the performance of the vehicle's pollution control system shall invalidate this Executive Order.

This Executive Order shall not apply to any Fuel Injection Performance Kit, 77 Series, Blackhawk, or Typhoon Intake System advertised, offered for sale, sold with, or installed on a new motor vehicle prior to or concurrent with transfer to an ultimate purchaser.

Marketing of the Fuel Injection Performance Kits , 77 Series, Blackhawk, and Typhoon Intake Systems using any identification other than that shown in this Executive Order or marketing of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems for an appl ication other than those listed in this Executive Order shall be prohibited unless prior approval .is obtained from the Air Resources Board.

Page 2: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

-2-

This Executive Order does not constitute any opinion as to the effect the use of the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems may have on any warranty either expressed or implied by the vehicle manufacturer.

This Executive Order is granted based on emission test results in the mod ified configuration using the Cold-Start CVS-75 Federal Test Procedure, Supplemental Federal Test Procedure (US06), and an examination of the On-Board Diagnostic II (OBD II ) systems. A 2014 Chevy Camara equipped with a 3.6 liter engine (EGMXJ03.6165, LEV-II LEV) was used for the evaluation of the Fuel Injection Performance Kits, 77 Series , Blackhawk, and Typhoon Intake Systems. Results from emissions testing conducted at Automotive Testing and Development Services, Inc., are shown below (in grams per mile):

US06 NMHC + NOx CO Emission Level 0.0415 0.238

STD 0.14 8.0 ·

The emission test results in the modified configuration were below the applicable certification standards. Examination of the OBD II system showed the Fuel Injection Performance Kits, 77 Series , Blackhawk, and Typhoon Intake Systems do not affect OBD II operation. Therefore, based on the test results , the staff concludes that the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems meet the criteria for exempting general criteria parts.

The ARB reserves the right in the future to review this Executive Order and the exemption provided herein to assure that the exempted add-on or modified part continues to meet the standards and procedures of Title 13, California Code of Regulations, Section 2222, et seq. Further, if test results or other evidence provides the ARB with reason to suspect that the Fuel Injection Performance Kits, 77 Series, Blackhawk, and Typhoon Intake Systems will affect the durability of emission control systems, K&N Engineering shall be required to submit durability data to show that the durability of vehicle emission control systems are not, in fact, affected and/or that the add-on or modified part demonstrates adequate durability.

THIS EXECUTIVE ORDER DOES NOT CONSTITUTE A CERTIFICATION, ACCREDITATION , APPROVAL, OR ANY OTHER TYPE OF ENDORSEMENT BY THE AIR RESOURCES BOARD OF ANY CLAIMS OF THE APPLICANT CONCERNING ANTI-POLLUTION BENEFITS OR ANY ALLEGED BENEFITS OF THE K&N ENGINEERING FUEL INJECTION PERFORMANCE KITS, 77 SERIES, BLACKHAWK, AND TYPHOON INTAKE SYSTEMS.

No claim of any kind, such as "Approved by the Air Resources Board", may be made with respect to the action taken herein in any advertising or other oral or written communication.

Vio lation of any of the above conditions shall be grounds for revocation of this order. The order may be revoked only after a ten-day written notice of intention to revoke the

K&N Engineering - Fuel Injection Performance Ki ts , 77 Series, Blackhawk, and Typhoon Intake Systems - D-269-49

Page 3: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

-3-

order, in which period the holder of the order may request in writing a hearing to contest the proposed revocation. If a hearing is requested, it shall be held within ten days of receipt of the request and the order may not be revoked until a determination is made after the hearing that grounds for revocation exist.

Executed at El Monte, California , this / 3 day of July 201 5.

Annette Hebert, Chief Emissions Compliance, Automotive Regulations and Science Division

K&N Engineering- Fuel Injection Performance Kits , 77 Series, Blackhawk, and Typhoon Intake Systems - D-269-49

Page 4: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

1st P/N

57-3078

57-3070

57-3070

57-3070

57-3070 - ~- -57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3070

57-3077

57-3077

57-3077

57-3077

57-3082

2nd P/N

69-4523TP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3070KP

77-3077KP

77-3077K~ r 77-3077KP

77-3077KP

77-3082KP

3rd P/N

N/A 71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

71-3070

Model-Year

2012-2014

2009-2014

2009-2014

2009-2013 ---- ·-2009-2013

Make

Chevrolet

Cadillac

Cadillac

Cadillac

Chevrolet

2012-2013_ ,. _Chevrolet 2012-2013 Chevrolet

20122009

2009-2014

2009

2009-2014

2009-2013

2009-2013

Chevrolet

Chevrolet

Chevrolet

Chevrolet

Chevrolet

Chevrolet

Chevrolet

GMC ,

GMC 1

GMC

Exhibit A

Model

Camaro

Escalade

Escalade ESV - - -· -

Escalade EXT

Silverado

Silverado

Silverado

Tahoe

Tahoe

Tahoe

Suburban

Suburban

Avalanche

Avalanche

Sierra

Sierra

Sierra

2009

2009-2013

2012-2013

2012-2013

2009-2013

2009-2011

GMC [_=~- Sierra Denali GMC Yukon

--1-- -

;

71-3070 12ao9-2014 GMC

GMC

GMC

Yukon

Yukon

Yukon XL

Engine

V6-3.6L

V8-6.2L

V8-6.2L

V8-6.2L

V8-4.8L

V8-5.3L

V8-6.2L

V8-4.8L

V8-5.3L

V8-6.2L

V8-5.3L

V8-6.0L

V8-5.3L

V8-6.0L

V8-4.8L

V8-5.3L

V8-6.2L

V8-6.2L

V8-4.8L

V8-5.3L

V8-6.2L 71-3070

71-3070

71-3070

71-3070

71-3070

N/A

N/A

N/A

N/A 71-3082

2011

2009-2014

2013-2014

2009-2014

2009-2014

2011-2014

2011-2014

2011-2014

2011-2014

2014

GMC Yukon XL I V8-5.3L

V8-6.2L GMC Yukon-D~ali ~ ·1 V8-6.2L

GMC Yukon XL De~ail ., V8-6.2L

~h~vrolet Silverado 2500!:'.~ t V8-6.6L Turbo Diesel Chevrolet Silverado 3500HD V8-6.6L Turbo Diesel

GMC ~- Sierra 2500HD -- V8-6.6L Turbo Diesel - --- . -

GMC Sierra 3500HD V8-6.6L Turbo Diesel Chevro~ - C15 Silverado XFE 2WD ,--- V8-5 .3L

Page 1 of 4

.I

E.O. D-269-49

Remarks

Revised 10/13/15

Page 5: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

Exhibit A E.O. 0-269-49

1st P/N 2nd P/N I 3rd P/N 1 M()de i-Ye~ Makel_ Model .I Engine I Remarks - -----

57-3082 77-3082KP 71-3082 2014 Chevrolet C15 Silverado 2WD l. V8-5.3L - - - --- - .. ~ - ----

57-3082 77-3082KP 71-3082 2014 GMC l -·· C15 Sierra XFE 2WD V8-5.3L - ·- --~- -- ·· ' ·- - -

57-3082 77-3082KP 71-3082 2014 GMC j C15 Sierra 2WD V8-5.3L - - ~ - - -----

57-3082 77-3082KP 71-3082 2014 Chevrolet C15 Silverado 2WD V8-5.3L - - -- ---·----

57-3082 77-3082KP 71-3082 2014 GMC i KlS Sierra 4WD V8-5.3L

57-3082 77-3082KP 71-3082 2014 . Chevr()l ~! . K15 Silverado 4WD V8-5.3L -

57-3082 77-3082KP 71-3082 2014 Chevrolet K15 Silverado 4WD V8-5.3L - - -- -----

57-3082 77-3082KP 71-3082 2014 GMC KlS Sie rra 4WD ~ V8-5.3L

57-3082 77-3082KP 71-3082 2014 GMC-- 1 - C15 Sierra 2WD . V8-5.3L

· • -57-3082 77-3082KP 71-3082 2014 Chevrolet C15 Si lverado 2WD V8-6.2L

-- - - . - - -- +

57-3082 77-3082KP 71-3082 2014 Chevrolet K15 Silverado 4WD V8-6.2L - --- -- -- t

57-3082 77-3082KP 71-3082 2014 GMC C15 Sierra 2WD V8-6.2L .

I ·- -

57-3082 77-3082KP 71-3082 2014 GMC K15 Sierra 4WD V8-6.2L ... - - --57-3082 77-3082KP 71-3082 2015 GMC Tahoe V8-5.3L

- -- -· 57-3082 77-3082KP 71-3082 2015 GMC Yukon V8-5.3L

. - · 57-3082 77-3082KP 71-3082 2015 GMC Yukon V8-6.2L

57-3082 77-3082KP 1

71-3082 2015 1 - ··- -

GMC Yukon XL V8-5.3L . + - - --

57-3082 77-3082KP 71-3082 2015 GMC Yukon XL V8-6.2L -- - ~- --- -- ·-

57-3082 77-3082KP 71-3082 2015 Chevrolet Surburban V8-5.3L - - - -

57-3082 77-3082KP 71-3082 2015 Cad illac Esca lade V8-6.2L . -

57-3082 77-3082KP 71-3082 2015 Cad illac Esca lade ESV V8-6.2L

[ --------- --

71-3058 N/A N/A 2007-2008 Cadillac Esca lade V8-6.2L --- ------

71-3058 N/A N/A 2007-2008 Cad illac Esca lade EXT V8-6.2 L - - ---- -

71-3058 N/A N/A 2007-2008 Cad illac Esca lade ESV V8-6.2L . - - --

71-3058 N/A N/A 2007-2008 Chevro let Ava lanche V8-5.3L -- --

71-3058 N/A N/A 2007-2008 Chevro let Ava lanche V8-6.0L

2007-2008-l~he':~o l et --- ~

71-3058 N/A N/A Silverado 1500 V8-4.8L ---

71-3058 N/A N/A 2007-2008 Chevro let Silverado 1500 V8-5.3L .,.. ---· -·

71-3058 N/A

I N/A 2007-2008 j Chev~ let Silverado 1500 V8-6.0L

r -·

71-3058 N/A N/A 2007-2008 Chevrolet Suburban 1500 V8-5.3L

Page 2 of 4 Revised 10/13/15

Page 6: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

Exhibit A E.O. D-269-49

1st P/N 2nd P/N 3rd P/N I ~odei-Year Make l Model_~-- L Engine j Rerr1_arks_

71-3058 N/A N/A 2007-2008 Chevrolet Suburban 1500 I V8-6.0L

7i~ios8 N/A __ ---- ~fA 200l _:-200~ Chevrolet_ -~-- Ta~oe --=:_- V8-4.8L -~ _l __ 71-3058 N/A N/A 2007-2008 Chevrolet Tahoe V8-5.3L I

-~--- --71-3058 N/A N/A 2007-2008 GMC Sierra 1500 V8-4.8L

-·-- - --- ~--~·- . -71-3058 N/A N/A 2007-2008 GMC Sierra 1500 V8-5.3L ·- --- - ----------- -?~=3058 N/A 1 N/A , 2007-2008 GMC _ Sierra 1500 . _ ~'J~~?-OL

__ 7~-3058 N/A I N/A GMC _ _ _ Sierra Denali -·-~ ~~-=-?-2L 71-3058 N/A N/A GMC Yukon V8-4.8L l l-3058 N/A 1 N/A GMC . - - Yukon -· . V8-S.3L

- ----~--- -71-3058 N/A N/A 2007-2008 GMC Yukon Denali V8-6.2L

- t- - ~- -- -- -

71-3058 N/A N/A 2007-2008 GMC Yukon XL 1500 V8-5.3L 71-3058 N/A - .. N/A 2007-2008 GMC - . Yukon XL 1500 I V8-6.0L

71-3058 N/A •- N/A 2007-2008 GMC - Yuk~-n XL 1500 Denali 1

V8-6.2L I ---· .

71-3066 N/A N/A 2007-2010 Chevrolet Silve r-_a~?_2500HD f V8-6.6L Turbo Diesel 71-3066 N/A N/A 2007-2010 Chevrolet Silverado 3500HD V8-6.6L Turbo Diesel

-- - -------71-3066 N/A N/A 2007-2010 GMC Sierra 2500HD V8-6.6L Turbo Diesel

71-306 6 N/A N/A 2007:_-i OlO GMC Sierra 3500HD- -~- V8-6.6L Turbo Diesel

77-3071KS N/A N/A 2010-2011 --~_!l~_':'rolet Equinox _ _ -· L4-2.4L 77-3071KS N/A N/A 2010-2011 GMC Terrain L4-2.4L

-- . - - · -- ! • --

K&N retains OEM air box

2010-2014 l I I that incorporates the 57-3074 N/A j N/A j Chevy __ Camara SS V~?~? L factory HC trap

K&N retains OEM air box

2010-2014 I that incorporates the

57-3075 j N/A j N/A I Chevy __ Camara V6-~.6_L factory HC trap

77-3076KTK N/A 1 N/A 2011-2013 Chevrolet 2500HD V8-6.0L

77-3076KTK N/A ' N/A h 2011-2013 Chevrolet - ~ 3500HD j V8-6.0L -- +

77-3076KTK N/A N/A 2011-2013 GMC 2500HD V8-6.0L --- ---- -- -~·

77-3076KTK N/A N/A 2012-2013 GMC 3500HD V8-6.0L

77-3078KTK N/A N/A 2010-2012 I Chevrolet Equinox V6-3.0L

Page 3 of 4 Revised 10/13/15

Page 7: State of California · State of California AIR RESOURCES BOARD ... Code for the GM vehicles listed in the attached Exhibit A. ... V8-6.2L V8-6.2L V8-6.2L V8-4.8L V8-5.3L

Exhibit A E.O. D-269-49

1st P/ N 2nd P/N l 3rd P/N Model-Year Make Model Engine I Remarks ----- ~ ----

77-3078KTK N/A N/A 2010-2012 GMC Terrain V6-3.0L --- T -

57-3079 N/A N/A 2014 Chevrolet Camara ZL1 V8-6.2L ----

69-4522TS N/A N/A 2011-2012 Chevrolet Cruze L4-1.8L -----·-

69-4527TS N/A N/A 2012 Cadillac CTS V6-3.0L

Cadill ac I - ---- ~

69-4527TS N/A N/A 2012 CTS V6-3.6L - -

69-8432TS N/A N/A 2006-2009 Pontiac Solstice L4-2.4L - -

69-8432TS N/A N/A 2007-2009 Saturn Sky L4-2.4L -

57-3069 N/A N/A 2008-2010 Chevrolet HHR L4-2 .0L +-- --

69-4517TIK N/A N/A 2006-2008 Chevrolet Cobalt SS L4-2 .4L I ---

69-4518TIK N/A N/A 2008-2010 Chevrolet Coiba It SS L4-2.0L Turbo

69-4521TS N/A N/A 2011-2014 Chevrolet I -- Cruze L4-1.4L

Page 4 of 4 Revised 10/13/15