switches and sensors catalogue - · pdf fileswitches and sensors catalogue oil pressure •...

Switches and Sensors Catalogue

Oil Pressure • Water Temperature • Coolant Temperature

Thermo Fan • Stop Light • Reverse Light

This section has been included to assist with the identifi cation of Tridon’s extensive range of engine oil pressure senders and sensors. Photographs and specifi cation tables are shown for each Tridon part number. Each specifi cation table contains spanner size, thread size, plug type, circuit diagram and pressure rating. The Tridon oil pressure senders and sensors range has been developed to operate within original equipment manufacturer’s specifi cations. As oil pressure values vary always refer to the vehicle application list to ensure correct part number selection.

Oil Pressure Senders And Sensors

Function

The engine oil pressure sender/sensor is used to measure the integrity of

the engine lubrication system. Normally located in the engine block, the

oil pressure sender responds to changes in engine oil pressure modifying

the signal from oil pressure instrumentation. This modifi ed signal is used to

determine the engine oil pressure via oil pressure light or gauge.

There are 3 main types of engine oil pressure senders and sensors;

spring controlled diaphragm, thermal transducer and piezo-resistor.

Spring Controlled Diaphragm Contains a spring loaded diaphragm designed to open a set of

contacts as pressure increases.

For operation of oil pressure lights (only ON or OFF switch position).

Thermal Transducer Contains a diaphragm designed to close a set of contacts attached to a

bimetal alloy leaf. The bimetal leaf defl ects with changes in oil pressure.

A corresponding bimetal leaf in the oil pressure gauge performs the

same operation, registering the appropriate pressure reading.

For operation of oil pressure gauges.

Piezo-Resistor Contains a semiconductor crystal, with special resistance

properties. Changes in these properties occur when pressure is

applied; the changes are then processed to operate an oil display.

For operation of electronic oil pressure gauges.

Testing and Replacement

The engine oil pressure sender/sensor is an integral component in a vehicle

engine warning system; a faulty engine oil pressure sender/sensor may

provide incorrect warning signals leading to potential engine damage.

Engine oil pressure senders/sensors should be inspected regularly, the

sender/sensor should be checked for any visible signs of contaminant.

Note the engine oil itself, particularly old oil or incorrect oil levels may cause

a sender/sensor to malfunction.

When an engine oil pressure sender/sensor malfunction or fault is

suspected, the engine oil pressure sender/sensor should be checked and

replaced by a trained professional.

Oil Pressure Sender/Sensor Testing Procedure

1. Check the oil pressure sender/sensor for visible faults or oil leaks.

2. Check correct oil pressure sender/sensor operation;

Oil Pressure Senders and Sensors

68

Spring Controlled Diaphragm (oil pressure lights)Measure continuity across the oil pressure sender/sensor contacts;

Using an Ohmmeter, remove the terminal or plug, connect the

Ohmmeter between the sender/sensor terminal and the vehicle

earth (ground).

With the engine OFF, the reading given should be zero (0) or show a

closed circuit.

Start the engine, as the oil pressure rises the reading given should

become infi nite or open circuit.

Thermal Transducer (oil pressure gauges)Test the operation of the oil pressure gauge circuit;

Remove the wiring plug or terminal, connect a potentiometer between

terminal and vehicle earth (ground).

With the ignition turned on, test the operation of the oil gauge starting

the potentiometer at a high resistance (around 500Ω) then slowly

reduce the resistance to 0Ω. The gauge should operate from low

pressure to high or a maximum pressure. (Resistance values

will vary between make and models, test procedure should be

used as a guide only).

Piezo-Resistor (electronic oil pressure displays)For testing procedures for a Piezo-resistor type sensor refer to

Thermal transducer type tests.

3. Replace the sender/sensor if readings are not as shown above.

4. Other oil pressure circuit tests include;

Gauge and light tests with a potentiometer.

Wiring tests, open and short circuits.

Available voltage (check fuses) - voltage stabilizer or voltage

regulator normally located in the instrument cluster.

The Tridon engine oil pressure sender/sensor range has been developed

to operate with OEM specifi cations. As sender/sensor pressures values

may vary, always refer to the Tridon Vehicle Application list to ensure

correct part number selection.

Engine Oil Pressure Sender Circuit

Engine Oil Pressure Sensor Circuit

69

* Test procedure values will vary between make and models and should be used a guide only.

Identifi cation Guide

14

1/8 GAS

6.3

14

1/8 GAS

6.3

14

1/8 GAS

6.3

14

1/8 GAS

6.3

14

1/8 GAS

6.3

24

1/8 GAS

6.3

Bar0.40

24

1/8 GAS

6.3

Bar0.30

24

1/8 GAS

6.3

Bar0.40

27

1/8 PT

Bar0.30

24

1/8 GAS

Bar0.20

24

1/4-18 NPT

8-32 UNC

Bar0.30

24

1/8 GAS

M4

Bar0.30


70 Note: To ensure correct product selection please check illustrations and specifi cations as values may differ.

TPS001

TPS004

TPS007

TPS011

TPS002

TPS005

TPS008

TPS012

TPS003

TPS006

TPS010

TPS013

24

1/8 GAS

ø 4

Bar0.30

24

1/8 GAS

ø 4

Bar0.40

27

1/8 GAS

ø 4

Bar0.30

24

1/8 GAS

Bar0.20

21

M14 x 1.5

6.3

Bar0.30

21

M14 x 1.5

6.3

Bar0.30

24

M10 x 1

6.3

Bar0.30

24

M10 x 1

6.3

Bar0.30

23

M18 x 1.5

6.3

Bar0.70

21

M16 x 1.5

6.3

Bar0.60

24

M14 x 1.5

6.3

Bar0.30

24

M12 x 1.5

6.3

Bar0.15

71

Oil

Pre

ssu

re S

end

ers

& S

enso

rs

Note: To ensure correct product selection please check illustrations and specifi cations as values may differ.

TPS014

TPS017

TPS020

TPS023

TPS015

TPS018

TPS021

Note: Replaces original brown part

TPS024

TPS016

TPS019

TPS022

TPS025

Note: Replaces original red part


24

M12 x 1.5

6.3

Bar0.35

24

1/8-27 NPT

8-32 UNC

Bar0.50

24

1/4-18 NPT

6.3

Bar0.40

24

M10 x 1

6.3

Bar1.80

24

M10 x 1

6.3

Bar1.40

24

1/8-27 NPT

6.3

Bar0.50

24

1/8-27 NPT

6.3

Bar0.30

24

M14 x 1.5

Bar0.50

24

M14 x 1.5

Bar0.50

24

M12 x 1.5

Bar0.30

24

M10 x 1

6.3

Bar0.30

24

1/8-27 NPT

Bar0.35



TPS026

Note: Replaces original brown and blue parts

TPS030

Note: Replaces original white part

TPS033

TPS039

TPS027

TPS031

Note: Replaces original black part

TPS034

TPS040

TPS029

TPS032

TPS038

TPS041

24

M10 x 1

6.3

Bar0.90

21

M14 x 1.5

Bar0.30

24

M12 x 1.5

M4

Bar0.40

24

M10 x 1

6.3

Bar0.30

24

M10 x 1

6.3

Bar2.50

21

M16 x 1.5

Bar0.50

24

M10 x 1

6.3

Bar0.50

24

1/8 GAS

Bar0.40

21

M16 x 1.5

Bar0.50

24

M10 x 1

Bar0.70

24

M10 x 1

Bar0.25

24

M10 x 1

Bar0.90

73

Oil

Pre

ssu

re S

end

ers

& S

enso

rs


TPS042

Note: Replaces original brown and grey parts

TPS045

Note: Replaces original light blue part

TPS048

TPS051


TPS043

TPS046

TPS049

TPS052

Note: Replaces original dark blue part

TPS044

TPS047

TPS050

TPS053

Note: Replaces original grey part


24

M10 x 1

Bar1.40

24

M10 x 1

Bar1.80

24

M10 x 1

Bar0.50

24

1/4-18 NPT

Bar0.40

24

3/8 NPT

Bar0.50

21

M14 x 1.5

Bar0.50

24

1/4-18 NPT

6.3

Bar0.40

14

1/8 GAS

27

1/4-18 NPT

27

1/4-18 NPT

ø 4.7

Bar0.40

27

1/4-18 NPT

14

1/8 GAS

Bar0.60



TPS054


TPS057

TPS061

TPS065

TPS055


TPS058

TPS063

TPS066

TPS056

Note: Replaces original green part

TPS059

TPS064

TPS067

Circuit TypeN/C = Normally Closed

N/O = Normally Open

7575

Part No. Spanner Thread Circuit Type Pressure Notes

TPS001 14 1/8 GAS

TPS002 14 1/8 GAS

TPS003 14 1/8 GAS

TPS004 14 1/8 GAS

TPS005 14 1/8 GAS

TPS006 24 1/8 GAS N/C 0.40

TPS007 24 1/8 GAS N/C 0.30

TPS008 24 1/8 GAS N/C 0.40

TPS010 27 1/8 PT N/C 0.20

TPS011 24 1/8 GAS N/C 0.30

TPS012 24 1/4 - 18 NPT N/C 0.30

TPS013 24 1/8 GAS N/C 0.30

TPS014 24 1/8 GAS N/C 0.30

TPS015 24 1/8 GAS N/C 0.40

TPS016 27 1/8 GAS N/C 0.30

TPS017 24 1/8 GAS N/C 0.20

TPS018 21 M14 x 1.5 N/C 0.30

TPS019 21 M14 x 1.5 N/C 0.30

TPS020 24 M10 x 1 N/C 0.30

TPS021 24 M10 x 1 N/C 0.30 Replaces original brown part

TPS022 23 M18 x 1.5 N/C 0.70

TPS023 21 M16 x 1.5 N/C 0.60

TPS024 24 M14 x 1.5 N/C 0.30

TPS025 24 M12 x 1.5 N/C 0.15 Replaces original red part

TPS026 24 M12 x 1.5 N/C 0.35 Replaces original brown and blue parts

TPS027 24 1/8 - 27 NPT N/C 0.50

TPS029 24 1/4 - 18 NPT N/C 0.40

TPS030 24 M10 x 1 N/O 1.80 Replaces original white part

TPS031 24 M10 x 1 N/O 1.40 Replaces original black part

TPS032 24 1/8 - 27NPT N/C 0.50

TPS033 24 1/8 - 27 NPT N/C 0.30

TPS034 24 M14 x 1.5 N/C 0.50

TPS038 24 M14 x 1.5 N/C 0.50

TPS039 24 M12 x 1.5 N/C 0.30

TPS040 24 M10 x 1 N/O 0.30

TPS041 24 1/8 - 27 NPT N/C 0.35

TPS042 24 M10 x 1 N/O 0.90 Replaces original brown and grey parts

TPS043 21 M14 x 1.5 N/C 0.30

TPS044 24 M12 x 1.5 N/C 0.40

TPS045 24 M10 x 1 N/C 0.30 Replaces original light blue part

TPS046 24 M10 x 1 N/O 2.50

TPS047 21 M16 x 1.5 N/C 0.50

TPS048 24 M10 x 1 N/C 0.50

TPS049 24 1/8 GAS N/C 0.40

TPS050 21 M16 x 1.5 N/C 0.50

TPS051 24 M10 x 1 N/O 0.70 Replaces original brown part

TPS052 24 M10 x 1 N/C 0.25 Replaces original dark blue part

TPS053 24 M10 x 1 N/O 0.90 Replaces original grey part

TPS054 24 M10 x 1 N/O 1.40 Replaces original black part

TPS055 24 M10 x 1 N/O 1.80 Replaces original white part

TPS056 24 M10 x 1 N/O 0.50 Replaces original green part

TPS057 24 1/4 - 18 NPT N/C 0.40

TPS058 24 3/8 NPT N/C 0.50

TPS059 21 M14 x 1.5 N/C 0.50

TPS061 24 1/4 - 18 NPT N/C 0.40

TPS063 14 1/8 GAS

TPS064 27 1/4 - 18 NPT

TPS065 27 1/4 - 18 NPT N/O 0.40

TPS066 27 1/4 - 18 NPT

TPS067 14 1/8 Gas 0.60

Quick Reference Guide

75

Oil

Pre

ssu

re S

end

ers

& S

enso

rs

This section has been included to assist with the identifi cation of Tridon’s extensive range of water temperature senders. Photographs and specifi cation tables are shown for each Tridon part number. Each specifi cation table contains spanner size, thread size, plug type and circuit diagram. The Tridon water temperature sender range has been developed to operate within original equipment manufacturer’s specifi cations. As Tridon water temperature sender circuits vary always refer to the Tridon vehicle application list to ensure correct part number selection.

Water Temperature Senders

Function

The water temperature sender is used to measure the integrity of the engine

cooling system. Located on the engine side of the thermostat in the cooling

system, the water temperature sender responds to changes in engine

coolant temperature modifying the signal from engine temperature

instrumentation. This modifi ed signal is used to determine the engine

coolant temperature via water temperature light or gauge.

The most common type of water temperature sender is a thermistor type

sender unit, containing semiconductor materials which respond to coolant

temperature changes. Most commonly used are thermistors with a negative

temperature coeffi cient (NTC), which respond with decreasing resistance

as the temperature increases. This decrease in resistance creates a higher

current fl ow through the bimetal leaf located inside the temperature gauge,

indicating the appropriate engine temperature reading.


The water temperature sender is an integral component in a vehicle

engine warning system; a faulty water temperature sender may provide

incorrect warning signals leading to possible engine overheating and

potential engine damage.

Water temperature senders should be inspected at regular service

intervals, the sender should be checked for any visible signs of

contaminant and conductivity. Note the coolant itself, particularly

old coolant, incorrect coolant levels or mixture may cause the sender

to malfunction.

When a water temperature sender malfunction or fault is suspected, the

sender should be checked and replaced by a trained professional.

77

Water Temperature Sender Testing Procedures

1. Remove the water temperature sender from the vehicle.

2. Check the water temperature sender for visible contaminant,

conductivity or leaks.

3. Check correct water temperature sender operation; Suspend the sender in a beaker fi lled with water so that the

bulb is covered. Using an Ohmmeter, measure the resistance across the

terminals (or terminal to the body of the sender). Heat the water until a simulated engine operating temperature is

achieved (80°C - 90°C). The sender is designed to respond to the

change in temperature (as the water temperature increases the

sender resistance will decrease or has a negative temperature

coeffi cient NTC). At low temperatures the resistance values may be several thousand

ohms (Ω) and reduce to as low as a few hundred ohms (Ω) at normal

engine operating temperatures.

4. Other water temperature circuit tests include; Gauge and light tests with a potentiometer. Wiring tests, open and short circuits. Available voltage (check fuses) - voltage stabilizer or voltage regulator,

normally located in the instrument cluster.

The Tridon engine water temperature sender range has been developed

to operate with OEM specifi cations. As sender values may vary, always

refer to the Tridon Vehicle Application list to ensure correct part number

selection.

Typical Temperature Gauge Circuit

78

Water Temperature Senders


12

1/8 GAS

6.3

17

M16 x 1.5

ø 4

12

1/8 GAS

ø 4

12

1/8 GAS

6.3

17

M16 x 1.5

6.3

17

M16 x 1.5

6.3

17

M16 x 1.5

12

1/8 GAS

17

3/8-18 NPT

10-32 UNF

12

3/8 GAS

ø 4

17

M16 x 1.5

6.3

12

M8 x 0.75

ø 4

79

Wat

er T

emp

erat

ure

Sen

der

s


TTS001 TTS002 TTS003


TTS007

Note: Replaces original black and grey parts

TTS008

Note: Replaces original black and grey parts

TTS010


17

M16x1.5

ø 4

17

M16x1.5

6.3 6.3

17

M16x1.5

6.3

13

M12 x 1.25

6.3

13

1/8-27 NPT

ø 4.7

13

1/8-27 NPT

6.3

19

M14x1.5

6.3

19

5/8-18UNF

6.3

17

M16x1.5

6.3

19

5/8-18UNF

6.3

13

M8 x 0.75

ø 4

17

M16 x 1.5

ø 4




TTS021 TTS023


TTS024



13

1/8-27 NPT

6.3

24

1/2 GAS

6.3

24

M16 x 1.5

ø 4

19

M14 x 1.5

13

M12 x 1.25

6.3

13

1/8-27 NPT

M5

—

—

19

M14x1.5

ø 4

19

5/8-18 UNF

19

M14 x 1.5

ø 4

19

1/8-27 NPT

13

M12 x 1.25

6.3

81

Wat

er T

emp

erat

ure

Sen

der

s


TTS032

Note: Replaces original yellow and violet parts

TTS033 TTS034

TTS035


TTS036 TTS037

TTS038


TTS039 TTS040


TTS043

Note: Replaces original light blue part

TTS044 TTS045

22

M16 x 1.5

13

1/8-27NPT

M5

13

1/8-27NPT

ø 4

19

M14 x 1.5

ø 4

13

M12 x 1.25

6.3

13

1/8-27 NPT

6.3

13

1/8-27NPT

6.3

21

1/8-27NPT

19

M14 x 1.25

19

5/8-18

—

—

ø 4.7

1/2”

1/8-27NPT

6.3


TTS046


TTS048 TTS049







1/2”

1/8-27NPT

1/2”

1/8-27NPT

6.3

1/2”

1/8-27NPT

6.3

1/2”

1/8-27NPT

6.3

22

M14 x1.5

ø 4

oC110

21

3/8 GAS

ø 4

oC60

—

—

oC120

—

—

oC60

19

M10 x 1

6.3

oC90

—

—

oC110

—

—

oC107 / 112

—

—

oC112 / 120

83

Wat

er T

emp

erat

ure

Sen

der

s



TTS064


TTS501 TTS503

TTS504


TTS505


TTS506

TTS507

TTS508 TTS509


—

—

oC102 / 115

20

M14 x 1.25

oC60

20

M14 x 1.25

oC120

19

M10 x 1

6.3

oC100

—

—

oC95

20

M14 x 1.25

oC115

22

M14 x 1.5

oC100

—

—

oC95

—

—

oC100

24

M12 x 1.5

oC120

22

M18 x 1.5

6.3 4.8

oC115


TTS510


TTS511

Note: Replaces original violet ring

TTS512

Note: Replaces original blue with yellow ring

TTS513 TTS514

Note: Replaces original blue with white ring

TTS515

Note: Replaces original part with grey ring

TTS516 TTS517

Note: Replaces original dark blue - white and yellow parts

TTS518

Note: Replaces original black part with dark blue ring

TTS519 TTS520


85

Part No. Spanner Thread Temp Ratings NotesTTS001 12 1/8 GASTTS002 17 M16 x 1.5TTS003 12 1/8 GASTTS004 12 1/8 GASTTS005 17 M16 x 1.5TTS006 17 M16 x 1.5TTS007 17 M16 x 1.5 Replaces original black and grey partsTTS008 13 1/8 GAS Replaces original black and grey partsTTS010 17 3/8 - 18 DRYSEAL THREADTTS013 12 1/8 GASTTS014 17 M16 x 1.25TTS015 12 M8 x 0.75TTS017 17 M16 x 1.5TTS018 17 M16 x 1.5TTS020 17 M16 x 1.5TTS021 13 M12 x 1.25TTS023 13 1/8 - 27 NPT Replaces original white partTTS024 13 1/8 - 27 NPTTTS025 19 M14 x 1.5TTS027 19 5/8 - 18 UNFTTS028 17 M16 x 1.5TTS029 19 5/8 - 18UNFTTS030 13 M 8 x 0.75TTS031 17 M16 x 1.5TTS032 13 1/8 - 27 NPT Replaces original yellow and violet partTTS033 24 1/2 GasTTS034 17 M16 x 1.5TTS035 19 M14 x 1.5 Replaces original brown partTTS036 13 M12 x 1.25TTS037 13 1/8 - 27NPTTTS038 - - Replaces original black partTTS039 19 M14 x 1.5TTS040 19 5/8 - 18UNF Replaces original black partTTS043 19 M14 x 1.5 Replaces original light blue partTTS044 19 1/8 - 27 NPTTTS045 13 M12 x 1.25TTS046 22 M16 x 1.5 Replaces original brown partTTS048 13 1/8 - 27 NPTTTS049 13 1/8 - 27 NPT Replaces original green partTTS050 19 M14 x 1.5TTS051 13 M12 x 1.25TTS052 13 1/8 - 27 NPT Replaces original white partTTS054 13 1/8 - 27 NPTTTS055 21 1/8 - 27 NPTTTS057 19 M14 x 1.25TTS058 19 3/8 - 18 DRYSEAL THREADTTS060 1/2” 1/8 - 27NPTTTS061 1/2” 1/8 - 27NPTTTS062 1/2” 1/8 - 27NPTTTS063 1/2” 1/8 - 27NPTTTS064 1/2” 1/8 - 27NPTTTS501 22 M14 x 1.5 110°CTTS503 21 3/8 Gas 60°CTTS504 - - 120°C Replaces original white partTTS505 - - 60°C Replaces original red partTTS506 19 M10 x 1 90°CTTS507 - - 110°CTTS508 - - 107°C / 112°CTTS509 - - 112°C / 120°C Replaces original brown partTTS510 - - 102°C / 115°C Replaces original grey partTTS511 20 M14 x 1.25 60°C Replaces original violet ringTTS512 20 M14 x 1.25 120°C Replaces original blue with yellow ringTTS513 19 M10 x 1 100°CTTS514 - - 95°C Replaces original blue with white ringTTS515 20 M14 x 1.25 115°C Replaces original part with grey ringTTS516 22 M14 x 1.5 100°CTTS517 - - 95°C Replaces original dark blue - white and yellow partsTTS518 - - 100°C Replaces original black part with dark blue ringTTS519 24 M12 x 1.5 120°CTTS520 22 M18 x 1.5 115°C


85

Wat

er T

emp

erat

ure

Sen

der

s

This section has been included to assist with the identifi cation of Tridon’s extensive range of engine coolant sensors. Photographs and specifi cation tables are shown for each Tridon part number. Each specifi cation table contains spanner size, thread size, plug type and circuit diagram. The Tridon coolant sensor range has been developed to operate within original equipment manufacturer’s specifi cations. As Tridon coolant sensor circuits vary always refer to the Tridon vehicle application list to ensure the correct part number selection.

Coolant Temperature Sensors

Function

The coolant temperature sensor is a device designed to respond to

changes in coolant temperature, this response causes a change in signal

voltage which is returned to the vehicle computer (ECU). The registered

change in voltage signal is then processed by the ECU to determine the

engine temperature. The coolant temperature sensor is crucial for the

control of temperature based functions performed ECU (e.g. ignition,

instrumentation, fuel metering and transmission shifting).

There are two types of coolant temperature sensors, the thermocouple

type and more commonly used thermistor type, normally located in the

water jacket of the engine cylinder head or intake manifold. The thermistor

type contains conductive materials which respond to coolant temperature

changes. Two types of conductive material are used; material with a

positive temperature coeffi cient (PTC), where the resistance increases as

the temperature increases. Alternatively and more commonly used is

material with a negative temperature coeffi cient (NTC), which responds

with decreasing resistance as the temperature increases.

The coolant temperature sensor is critical to many temperature based

functions performed by the ECU, these include;

Electronic fuel injection system.

- Changes to injector pulse width.

- Operation idle speed solenoid.

Ignition Timing systems.

- Changes to spark timing.

Variable valve timing.

Transmission control.

Electric cooling fan switching control (if separate

fan switch is not used).


The coolant temperature sensor is an integral component in a vehicle

engine management system; a faulty coolant temperature sensor can result

in poor engine performance including diffi cult starting, poor fuel economy,

possible overheating and potential engine damage.

Coolant temperature sensors should be inspected every 20,000 kilometres,

the sensor should be checked for any visible signs of contaminant and

conductivity. Note the coolant itself, particularly old coolant, incorrect

coolant levels or mixture may cause the sensor to malfunction.

When a coolant temperature sensor malfunction or fault is suspected

the coolant temperature sensor should be checked and replaced by a

trained professional.

87

Coolant Temperature Sensor Testing Procedures

1. Remove the coolant temperature sensor from the vehicle.

2. Check the coolant temperature sensor for visible contaminant,

conductivity or leaks.

3. Check correct coolant temperature sensor operation; Suspend the sensor in a beaker

fi lled with water so that the

bulb is covered.

Using an Ohmmeter, measure the resistance across the terminals,

(or terminal to the body of the sender). Heat the water until a simulated engine operating temperature is

achieved (80°C - 90°C). The sensor is designed to respond to the

change in temperature (as the water temperature increases the

sensor resistance will decrease or has a negative temperature

coeffi cient NTC). At low temperatures the resistance values may be several thousand

ohms (Ω) and reduce to as low as a few hundred ohms (Ω) at normal

engine operating temperatures.

The Tridon coolant temperature sensor range has been developed to

operate with OEM specifi cations. As coolant temperature sensor values

may vary, always refer to the Tridon Vehicle Application list to ensure

correct part number selection.

Typical Coolant Temperature Sensor Circuit

88

Coolant Temperature Sensors


25

3/8-18 Dry Seal

22

M16 x 1.5

17

M12 x 1.5

19

M12 x 1.5

19

M12 x 1.5

19

M12 x 1.5

17

3/8 GAS

6.3 6.3

19

3/8 GAS

19

M12 x 1.5

19

M12 x 1.5

19

3/8 GAS

19

M12 x 1.5

89

Co

ola

nt

Tem

per

atu

re S

enso

rs


TCS011 TCS020


TCS022


TCS024


TCS026


TCS029

Note: Replaces original white and black part

TCS030


TCS032

Note: Replaces original green and grey parts

TCS035


TCS040 TCS045 TCS050

Note: Replaces original dark blue part Note: Replaces original black part

19

3/8 GAS

19

M12 x 1.5

19

M12 x 1.5

19

3/8-18 NPT

19

M12 x 1.5

19

M12 x 1.5

19

3/8-18 NPT

19

M12 x 1.5

—

—

19

M14 x 1.5

19

M12 x 1.5

—

—


TCS055


TCS060


TCS065


TCS070


TCS075

Note: Replaces original red and dark blue parts

TCS080


TCS085 TCS090


TCS091


TCS093

Note: Replaces original white and black parts

TCS094


TCS095

Note: Replaces original black and yellow parts


19

M12 x 1.5

22

M10 x 1

19

M14 x 1.5

19

M12 x 1.5

19

M12 x 1.5

21

M12 x 1.5

17

M16 x 1.5

ø 4

19

M12 x 1.5

19

M12 x 1.5

—

M12 x 1.5

17

M12 x 1.5

19

1/8-27NPT

91

Co

ola

nt

Tem

per

atu

re S

enso

rs


TCS096


TCS098


TCS099


TCS102 TCS106


TCS115



19

M12 x 1.5

19

M12 x 1.5

19

3/8 GAS

19

M12 x 1.5

Part No. Spanner Thread Notes

TCS011 25 3/8 -18 Dry Seal

TCS020 22 M16 x 1.5 Replaces original black part


TCS024 19 M12 x 1.5 Replaces original green part

TCS026 19 M12 x 1.5 Replaces original white part

TCS029 19 M12 x 1.5 Replaces original white and black part

TCS030 17 3/8 Gas Replaces original black part

TCS032 19 M12 x 1.5 Replaces original green and grey parts

TCS035 19 3/8 Gas Replaces original green part

TCS040 19 M12 x 1.5 Replaces original dark blue part

TCS045 19 M12 x 1.5





TCS070 19 3/8 - 18 NPT Replaces original black part

TCS075 19 M12 x 1.5 Replaces original red and dark blue parts

TCS080 19 M12 x 1.5 Replaces original brown part

TCS085 19 3/8 - 18 NPT


TCS091 - - Replaces original dark blue part

TCS092 19 M10 x 1

TCS093 19 M14 x 1.5 Replaces original white and black parts


TCS095 - - Replaces original black and yellow parts

TCS096 19 M12 x 1.5 Replaces original green part


TCS098 19 M10 x 1 Replaces original white part



TCS101 - -

TCS102 19 M12 x 1.5

TCS103 - - Replaces original black part

TCS104 - - Replaces original green part

TCS105 - - Replaces original dark blue and green parts


TCS107 22 M12 x 1.5

TCS108 22 M12 x 1.5

TCS109 19 M12 x 1.5

TCS110 21 M12 x 1.5

TCS111 - -

TCS112 19 -

TCS113 21 M12 x 1.5

TCS114 - -

TCS115 21 M12 x 1.5

TCS116 17 M16 x 1.5

TCS117 19 M12 x 1.5

TCS118 19 M12 x 1.5

TCS119 - M12 x 1.5

TCS120 17 M12 x 1.5

TCS121 19 1/8 - 27 NPT Replaces original black and red parts

TCS124 19 M12 x 1.5 Replaces original grey part

TCS125 - M12 x 1.5

TCS126 19 3/8 Gas

TCS127 19 1/8 - 27 NPT

TCS128 19 M12 x 1.5Replaces original black, grey, red and dark blue parts



TCS124

TCS125

TCS127

Note: Replaces original black, grey, red and dark blue parts

TCS128


This section has been included to assist with the identifi cation of Tridon’s extensive range of thermo fan switches. Photographs and specifi cation tables are shown for each Tridon part number. Each specifi cation table contains spanner size, thread size, plug type, circuit diagram and temperature rating. The Tridon thermo fan switch range has been developed to operate within original equipment manufacturer’s specifi cations. As Tridon thermo fan switch circuits vary always refer to the Tridon vehicle application list to ensure correct part number selection.

Thermo Fan Switches

Function

The thermo fan switch is a mechanical switching device designed to

respond to changes in coolant temperature allowing the operation of the

electric radiator thermo fan(s).

Switching control is achieved through a bimetal alloy leaf, which defl ects

with changes in temperature opening or closing a set of contacts.

Each switch is calibrated to specifi c ON/OFF temperature ratings.

There are many different circuit functions of the thermo fan switch with

variations depending on vehicle manufacturer’s specifi cations.

Common triggering operations are as follows:

Single Speed Fan Normally closed between terminals.

Normally open between terminals.

Normally closed between earth and terminals.

Normally open between earth and terminals.

Dual Speed Fans Double circuit, normally open.

Double circuit - one normally closed, one normally open.

Independent circuits, normally open.


The thermo fan switch is an integral component in a vehicle cooling system;

a faulty fan switch can cause possible overheating and potential damage to

an engine.

Thermo fan switches should be inspected at regular service intervals.

The switch should be checked for any visible signs of contaminant and

conductivity. Note that the coolant itself, particularly old coolant, incorrect

coolant levels or mixture may cause the thermo fan switch to malfunction.

When a thermo fan switch malfunction or fault is suspected the thermo fan

switch should be checked and replaced by a trained professional.

94

Thermo FanSwitches

Thermo Fan Switch Testing Procedure

1. Remove the thermo fan switch from the vehicle.

2. Check the thermo fan switch for any visible signs of

contaminant, conductivity or leaks.

3. Check correct thermo fan switch operation;

Suspend the switch in a beaker fi lled with water so that the

bulb is covered.

Using an Ohmmeter, measure for continuity across the switch

terminals (or terminal to the body of the sender).

Heat the water until the simulated fan switch operating temperature

is achieved (ON/OFF temperature values located in fan switch

identifi cation guide).

When the correct ON switching temperature is achieved a change in

the Ohmmeter will be reading given; an indication switching between

the contacts (0Ω or infi nite depending to the type of switch).

Allow the water to cool, as the water temperature reaches the OFF

switching temperature the Ohmmeter will return to the original

reading (opposite of the previous step).

4. Replace the thermo fan switch if the readings are not as shown above.

Note: Thermo fan switch temperature ranges and switching types may vary.

Some vehicles have more than one thermo fan switch and more than

one thermo fan.

Please refer to vehicle applications and diagrams for correct thermo

fan switch application.

5. Other thermo fan circuit tests include;

Correct thermo fan motor operation.

Wiring tests, open and short circuits.

Relay operation.

Available voltage (check fuses).

The Tridon thermo fan switch range has been developed to operate with

OEM specifi cations. As thermo fan switch temperature values may vary,

always refer to the Tridon Vehicle Application list to ensure correct part

number selection.

Typical Thermo Fan Switch Circuit

95


29

M22 x 1.5

6.3 6.3

oCon 90off 80

29

M22 x 1.5

6.3 6.3

oCon 85off 75

29

M22 x 1.5

6.3 6.3

oCon 95off 90

29

M22 x 1.5

oCon 95off 90

29

M22 x 1.5

oC

22

M14 x 1.5

4.8 4.8

oCon 102off 97

22

M14 x 1.5

6.3 6.3

oCon 95off 90

24

M14 x 1.5

oC

22

M14 x 1.5

6.3 6.3

oCon 100off 95

29

M22 x 1.5

6.3 6.3

oCon 90off 85

21

3/8 GAS

6.3

oCon 87off 82

21

3/8 GAS

6.3

oCon 95off 90

on 95-off 85on 102-off 87




TFS100 TFS101 TFS102





17

M16 x 1.5

oCon 97off 92

17

M16 x 1.5

oCon 90off 85

17

M16 x 1.5

6.3

oCon 97off 92

21

M16 x 1.5

oCon 90off 85

22

M16 x 1.5

oCon 92off 87

21

M16 x 1.5

oCon 90off 85

17

M16 x 1.5

oCon 90off 85

22

M16 x 1.5

oCon 92off 82

24

M16 x 1.5

oCon 92off 87

22

M16 x 1.5

oCon 92off 87

22

M16 x 1.5

oCon 105off 90

22

M16 x 1.5

oCon 92off 87

97

Th

erm

o F

an S

wit

ches






22

M16 x 1.5

oCon 92off 77

24

M18 x 1.5

oCon 112off 107

24

M18 x 1.5

oCon 95off 90

27

M16 x 1.5

ø 4

oCon 92off 87

21

M16 x 1.5

oCon 85off 80

21

M16 x 1.5

oCon 90off 85

21

M16 x 1.5

oCon 85off 80

29

M22 x 1.5

6.3 6.3

oCon 92off 87

17

M16 x 1.5

6.3

oCon 90off 85

17

M16 x 1.5

oCon 107off 102

17

M16 x 1.5

oCon 97off 92

17

M16 x 1.5

6.3

oCon 85off 80







21

M16 x 1.5

oCon 85off 80

22

M16 x 1.5

oCon 85off 80

22

M16 x 1.5

oCon 85off 80

27

M16 x 1.5

oCon 85off 80

22

M16 x 1.5

oCon 95off 85

29

M22 x 1.5

6.3 6.3

oCon 102off 97

29

M22 x 1.5

6.3 6.3

oCon 115off 110

—

—

6.3 6.3

oCon 115off 105

22

M16 x 1.5

6.3 6.3

oCon 95off 90

17

M16 x 1.5

oCon 90off 85

17

M16 x 1.5

oCon 95off 90

21

M16 x 1.5

oCon 90off 85

99

Th

erm

o F

an S

wit

ches






17

M16 x 1.5

oCon 85off 80

17

M16 x 1.5

oCon 105off 100

17

M16 x 1.5

oCon 50off 45

22

M16 x 1.5

oCon 87off 82

22

M16 x 1.5

oCon 100off 95

24

M18 x 1.5

oCon 100off 95

17

M16 x 1.5

oCon 50off 45

17

M16 x 1.5

oCon 110off 105

29

M22 x 1.5

oC

29

M22 x 1.5

oCon 100off 95

29

M22 x 1.5

oC

29

M22 x 1.5

oCon 95-off 90

on 105 -off 100on 95-off 90

on 120 -off 115

on 105-off 100on 120 -off 115





Note: Replaces original black part with violet ring



29

M22 x 1.5

oC

29

M22 x 1.5

oC

29

M22 x 1.5

oC

22

M16 x 1.5

oCon 90off 85

27

M16 x 1.5

ø 4

oCon 85off 80

29

M22 x 1.5

6.3 6.3

oCon 92off 87

29

M22 x 1.5

6.3 6.3

oCon 87off 77

29

M22 x 1.5

oCon 95off 90

21

M16 x 1.5

ø 4

oCon 92off 87

—

—

6.3 6.3

oCon 92off 87

22

M16 x 1.5

oCon 92off 82

29

M22 x 1.5

oCon 95off 90

on 105-off 100on 120-off 115

on 100-off 95on 105 -off 100

on 110-off 105on 120 -off 115

101

Th

erm

o F

an S

wit

ches





Note: Replaces original part with brown ring


21

3/8 GAS

ø 4

oCon 72off 67

29

M22 x 1.5

oCon 92off 82

27

M16 x 1.5

ø 4

oCon 95off 90

29

M22 x 1.5

oCon 92off 87

29

M22 x 1.5

oCon 97off 92

29

M22 x 1.5

oCon 100off 95

22

M14 x 1.5

6.3 6.3

oCon 95off 90

29

M16 x 1.5

oCon 112off 107

22

M14 x 1.5

ø 4

oCon 100off 95

29

M22 x 1.5

oCon 95off 90

17

M16 x 1.5

oCon 92off 87

21

M12 x 1.5

oCon 105off 100



Note: Replaces original part with yellow ring






17

M16 x 1.5

oCon 90off 85

21

M16 x 1.5

ø 4

oCon 97off 92

17

3/8 GAS

oCon 87off 82

21

M16 x 1.5

oCon 95off 90

29

M22 x 1.5

oCon 95off 90

21

M16 x 1.5

oCon 90off 85

24

3/8 GAS

6.3

oCon 92off 87

24

M14 x 1.5

oCon 110off 105

24

3/8 GAS

6.3

oCon 100off 95

17

3/8 GAS

oCon 95off 90

17

M16 x 1.5

6.3

oCon 90off 85

29

M22 x 1.5

oCon 87-off 77on 92-off 82

103

Th

erm

o F

an S

wit

ches






29

M22 x 1.5

oC

29

M22 x 1.5

oC

29

M22 x 1.5

oC

22

M14 x 1.5

oC

29

M22 x 1.5

oC

29

M22 x 1.5

oC

29

M22 x 1.5

oC

22

M22 x 1.5

oC

29

M22 x 1.5

oC

29

M22 x 1.5

oC

22

M14 x 1.5

oC

29

M22 x 1.5

oC

on 92-off 87on 105-off 100



on 100-off 95on 107-off 102






on 110-off 105on 120-off 115




Note: Replaces original part with red ring


Note: Replaces original red part Note: Replaces original dark blue part


Note: Replaces original grey part Note: Replaces original black part Note: Replaces original green part




—

—

oC

22

M16 x 1.5

oCon 95off 85

29

M22 x 1.5

oCon 87off 82

29

M22 x 1.5

oCon 102off 97

29

M22 x 1.5

oCon 100off 95

29

M22 x 1.5

oC

24

M18 x 1.5

oCon 95off 90

17

M16 x 1.5

oCon 100off 95

22

M16 x 1.5

oCon 95off 90


on 95-off 90on 105-off 100

105

Th

erm

o F

an S

wit

ches






Note: To ensure correct product selection please check illustrations and specifi cations as values may differ.106

Thermo Fan SwitchStyle Variations

This section has been

included to assist with Tridon

thermo fan switch selection.

Each thermo fan switch style

includes corresponding Tridon

part number with temperature

range, photograph and

specifi cation table.

29

M22 x 1.5

Style A

22

M14 x 1.5

Style B

21

3/8 GAS

6.3

Style C

17

M16 x 1.5

Style D

17

M16 x 1.5

6.3

Style E

21

M16x1.5

Style F

17

M16x1.5

Style G

22

M16x1.5

Style H

Part No. on off TFS100 90oC 80oC

TFS101 85oC 75oC

TFS102 95oC 90oC

TFS109 90oC 85oC

TFS135 92oC 87oC

TFS145 102oC 97oC

TFS170 92oC 87oC

TFS171 87oC 77oC


TFS108 100oC 95oC


TFS111 95oC 90oC


TFS114 90oC 85oC


TFS136 90oC 85oC


TFS197 95oC 90oC


TFS153 85oC 80oC


TFS126 105oC 90oC

TFS128 92oC 77oC

6.3 6.3 6.3 6.3

Note: To ensure correct product selection please check illustrations and specifi cations as values may differ. 107

Th

erm

o F

an S

wit

ches

27

M16 x 1.5

ø 4

Style I

17

M16 x 1.5

Style J

22

M16 x 1.5

Style K

24

3/8 GAS

6.3

Style L

29

M22x1.5

Style M

29

M22 x 1.5

Style N

29

M22 x 1.5

Style O

29

M22 x 1.5

Style P

24

M18 x 1.5

Style Q


TFS169 85oC 80oC

TFS183 95oC 90oC


TFS138 97oC 92oC

TFS154 105oC 100oC

TFS160 110oC 105oC


TFS220 95oC 85oC


TFS202 100oC 95oC


120oC 115oC

TFS165 105oC 100oC

120oC 115oC

TFS215 110oC 105oC

120oC 115oC


105oC 100oC

TFS166 100oC 95oC

105oC 100oC

TFS224 95oC 90oC

105oC 100oC


102oC 87oC

TFS205 87oC 77oC

92oC 82oC

TFS208 95oC 85oC

102oC 92oC


TFS221 87oC 82oC


TFS225 95oC 90oC

108


TridonPart No.

Style type,Common Thread, Plug and Circuit

Terminals Temp °C on-off

N/OTerm

N/CTerm

N/OGround

N/CGround

DualN/O-N/O

DualN/C-N/O

TFS100 A 2 90-80 X

TFS101 A 2 85-75 X

TFS102 A 2 95-90 X

TFS103 2 95-90 X

TFS104 O 3 95-85 and 102-87 X

TFS105 2 102-97 X

TFS106 B 2 95-90 X

TFS107 3 90-86 and 99-94 X

TFS108 B 2 100-95 X

TFS109 A 2 90-85 X

TFS110 C 1 87-82 X

TFS111 C 1 95-90 X

TFS113 D 1 97-92 X

TFS114 D 1 90-85 X

TFS115 E 1 97-92 X

TFS116 2 90-85 X

TFS117 2 92-87 X

TFS119 F 2 90-85 X

TFS120 G 1 90-85 X

TFS121 2 92-82 X

TFS123 2 92-87 X

TFS124 H 2 92-87 X

TFS126 H 2 105-90 X

TFS127 2 92-87 X

TFS128 H 2 92-77 X

TFS129 2 112-107 X

TFS130 2 95-90 X

TFS131 I 2 92-87 X

TFS132 2 85-80 X

TFS133 2 90-85 X

TFS134 2 85-80 X

TFS135 A 2 92-87 X

TFS136 E 1 90-85 X

TFS137 J 1 107-102 X

TFS138 J 1 97-92 X

TFS139 1 85-80 X

TFS140 2 85-80 X

TFS141 2 85-80 X

TFS142 2 85-80 X

TFS143 2 85-80 X

TFS144 2 95-85 X

TFS145 A 2 102-97 X

TFS146 2 115-110 X

TFS147 2 115-105 X

TFS148 2 95-90 X

109

TridonPart No.


Terminals Temp °C on-off

N/OTerm

N/CTerm

N/OGround

N/CGround

DualN/O-N/O

DualN/O-N/O

TFS150 1 90-85 X

TFS151 1 95-90 X

TFS152 2 90-85 X

TFS153 G 1 85-80 X

TFS154 J 1 105-100 X

TFS155 1 50-45 X

TFS156 2 87-82 X

TFS157 K 2 100-95 X

TFS158 Q 2 100-95 X

TFS159 1 50-45 X

TFS160 J 1 110-105 X

TFS161 3 105-100 and 120-115 X

TFS162 P 2 100-95 X

TFS163 N 3 95-90 and 105-100 X

TFS164 M 3 95-90 and 120-115 X

TFS165 M 3 105-100 and 120-115 X

TFS166 N 3 100-95 and 105-100 X

TFS167 3 110-105 and 120-115 X

TFS168 2 90-85 X

TFS169 I 2 85-80 X

TFS170 A 2 92-87 X

TFS171 A 2 87-77 X

TFS173 2 95-90 X

TFS174 1 92-87 X

TFS175 2 92-87 X

TFS176 2 92-82 X

TFS179 2 95-90 X

TFS181 2 72-67 X

TFS182 2 92-82 X

TFS183 I 2 95-90 X

TFS184 2 92-87 X

TFS185 2 97-82 X

TFS186 2 100-95 X

TFS187 2 95-90 X

TFS188 2 112-107 X

TFS189 2 100-95 X

TFS190 2 95-90 X

TFS191 1 92-87 X

TFS193 2 105-100 X

TFS194 1 90-85 X

TFS195 1 90-85 X

TFS196 1 97-92 X

TFS197 F 2 95-90 X

TFS198 2 95-90 X

TFS199 2 90-85 X

110

TridonPart No.


Terminals Temp °Con-off

N/OTerm

N/CTerm

N/OGround

N/CGround

DualN/O-N/O

DualN/C-N/O

TFS200 L 1 92-87 X

TFS201 2 110-105 X

TFS202 L 1 100-95 X

TFS203 1 95-90 X

TFS204 1 90-85 X

TFS205 O 3 87-77 and 92-82 X

TFS206 3 92-87 and 105-100 X

TFS207 3 97-87 and 100-95 X

TFS208 O 3 95-85 and 102-92 X

TFS209 3 100-95 and 107-102 X

TFS210 3 87-77 and 92-82 X

TFS211 3 90-80 and 97-87 X

TFS212 3 87-77 and 92-82 X

TFS213 3 95-90 and 102-97 X

TFS214 3 80-75 and 87-82 X

TFS215 M 3 110-105 and 120-115 X

TFS217 3 90-85 and 97-92 X

TFS218 3 97-87 and 102-97 X

TFS219 Note 1 4 95-90 and 102-97

TFS220 K 2 95-85 X

TFS221 P 2 87-82 X

TFS222 2 102-97 X

TFS223 2 100-95 X

TFS224 N 3 95-90 and 105-100 X

TFS225 Q 2 95-90 X

TFS226 1 105-100 X

TFS228 2 95-90 X

E,G – Normallyclosed betweenground and terminal

C,D,J,L – Normallyopen between groundand terminal

A,B,H,I,K,P,Q – Normally open between terminals

F – Normally closed between terminals

Note 1: TFS219 only – Two independant circuits normally open

M – Double circuit one normally closed theother open

N,O – Double circuit normally open

Temperature Conversion °F = ( °C x 1.8) + 32

Refer to page 106-107 for common switch combinations with temperature variations.

Single Circuit Double Circuit

This section has been included to assist with the identifi cation of Tridon’s extensive range of stop light switches. Photographs and specifi cation tables are shown for each Tridon Part number. Each specifi cation table contains spanner size, thread size, plug type and circuit diagram. The Tridon stop light switch range has been developed to operate within original equipment manufacturer’s specifi cations. As Tridon stop light switch circuits vary always refer to the Tridon Vehicle Application list to ensure correct part number selection.

Stop Light Switches

Function

The stop light switch is a mechanical device whose primary function is

to control circuit switching for the operation of the vehicles stop lights.

Normally located within the brake pedal assembly, the stop light switch is

activated by the application of the brake pedal, closing a set of contacts

allowing current to fl ow through the stop light circuit.

A secondary function for the stop light switch is used on vehicles with

cruise control. The stop light switch is used to interrupt the cruise

control circuit, disengaging the cruise control when the brake is applied.

This circuit uses a secondary set of contacts which open when the

brake pedal is applied.

Typical Stop Light Circuit

Stop Light Switches

112


When a stop light switch malfunction or fault is suspected, the stop light

switch should be checked and replaced by a trained professional.

Stop Light Switch Testing Procedure

1. Ensure correct plunger adjustment. The stop light switch plunger should be slightly compressed

when the brake pedal is in a resting position. When the brake pedal is applied the plunger should release.

2. Check correct stop light switch operation. Using an Ohmmeter, measure for continuity across the stop light

switch terminals. With the plunger depressed (the brake pedal in a resting position),

the reading should be infi nite or open circuit. As the plunger is slowly released (application of the brake pedal),

the reading should become zero (0Ω), or show a closed circuit between

the contacts.

3. Replace the stop light switch if the readings are not as shown above.

Note: For vehicles with cruise control, the stop light switch may

have more than two terminals and contain more than one circuit;

refer to vehicle applications and diagrams for correct stop light

switch application.

4. Other stop light circuit tests include; Faulty or blown stop light globes. Wiring tests, open and short circuits. Available voltage (check fuses).

The Tridon stop light switch range has been developed to operate

with OEM specifi cations. As switch circuits and operation may vary,

always refer to the Tridon Vehicle Application list to ensure correct

part number selection.

113


14

M10 x 1.25

14

M10 x 1.25

14

M10 x 1.25

14

M10 x 1.25

ø 4

14

M10 x 1.25

14

M10 x 1.25

14

M10 x 1.25

ø 4

14

M10 x 1.25

ø 4

14

M10 x 1.25

14

M10 x 1.25

14

M10 x 1.25

6.3 6.3

14

M10 x 1.25


TBS001

TBS002

TBS003

TBS004

TBS005

TBS006

TBS007

TBS008

TBS009

TBS010

TBS011

TBS012


14

M10 x 1.25

14

M10 x 1.25

14

M10 x 1.25

17

M12x 1

6.3 6.3

14

M10 x 1.25

14

M10 x 1.25

14

M12 x 1.5

6.3 6.3

14

M10 x 1.25

6.3 6.3

14

M10 x 1.25

14

M10 x 1.25

—

M12 x 1.75

6.3 6.3

—

1/2-20 UNF

6.3 6.3

115

Sto

p L

igh

t S

wit

ches


TBS014

TBS015

TBS016

TBS017

TBS018

TBS019

TBS020

TBS021

TBS022

TBS023

TBS024

TBS025

—

—

6.3 6.3

—

—

—

—

—

—

22

—

6.3 6.3

—

—

—

M16 x 1.5

22

M12 x 1.5

6.3 6.3

—

—

—

—

—

—

—

M12 x 1.5


TBS026

TBS027

TBS028

TBS029

TBS030

TBS031

TBS032

TBS034

TBS035

TBS036

TBS037

TBS038


—

—

14

M10 x 1.25

14

—

—

M10 x 1.25

—

—

—

—

—

—

—

M12 x 1.5

14

M10 x 1.25

22

1/8-27 NPT

6.3 6.3

—

—

6.3 6.3

—

—

117

Sto

p L

igh

t S

wit

ches


TBS039

TBS040

TBS041

TBS042

TBS043

TBS044

TBS045

TBS046

TBS047

TBS048

TBS049

TBS050

—

—

—

—

—

—

6.3 6.3

—

—

—

—

—

—

—

—

6.3 6.3

—

—

6.3 6.3

—

—

—

—

—

—

6.3 6.3

—

—

6.3 6.3


TBS051

TBS052

TBS053

TBS055

TBS056

TBS059

TBS060

TBS061

TBS064

TBS065

TBS068

TBS069


—

—

6.3 6.3

22

M10 x 1

6.3 6.3

119

TBS070

TBS071

Part No.

Spanner Thread Circuit Type

TBS001 14 M10 x 1.25 Dual N/O - N/C

TBS002 14 M10 x 1.25 N/C

TBS003 14 M10 x 1.25 N/C

TBS004 14 M10 x 1.25 N/C

TBS005 14 M10 x 1.25 N/C

TBS006 14 M10 x 1.25 N/C

TBS007 14 M10 x 1.25 N/C

TBS008 14 M10 x 1.25 N/C

TBS009 14 M10 x 1.25 N/C

TBS010 14 M10 x 1.25 N/C

TBS011 14 M10 x 1.25 N/C

TBS012 14 M10 x 1.25 N/C

TBS014 14 M10 x 1.25 N/C

TBS015 14 M10 x 1.25 N/C

TBS016 14 M10 x 1.25 Dual N/O - N/C

TBS017 14 M10 x 1.25 Dual N/O - N/C

TBS018 14 M10 x 1.25 Dual N/O - N/C

TBS019 14 M10 x 1.25 Dual N/C - N/C

TBS020 14 M10 x 1.25 Dual N/O - N/C

TBS021 14 M12 x 1.5 N/C

TBS022 - M12 x 1.75 N/C

TBS023 17 M12 x 1 N/C

TBS024 14 M10 x 1.25 N/C

TBS025 - 1/2 - 20 UNF N/C

TBS026 - - N/C

TBS027 22 - N/C

TBS028 - - N/C

TBS029 - - N/C

TBS030 - - Dual N/O - N/C

TBS031 - - N/C


TBS033 17 M12 x 1 Dual N/O - N/C

TBS034 - M16 x 1.5 N/C

Part No.

Spanner Thread Circuit Type

TBS035 - - Dual N/C - N/C


TBS037 22 M12 x 1.5 N/C

TBS038 - M12 x 1.5 N/C


TBS040 - - N/C

TBS041 14 M10 x 1.25 N/C

TBS042 14 M10 x 1.25 Dual N/O - N/C

TBS043 - - N/C

TBS044 22 1/8 - 27 NPT N/O

TBS045 14 - N/C

TBS046 - - N/C

TBS047 - - N/C

TBS048 - M10 x 1.5 Dual N/O - N/C

TBS049 - M12 x 1.5 Dual N/O - N/C

TBS050 - - N/C


TBS052 - - N/C




TBS056 - - N/C

TBS057 - - N/C



TBS060 - - N/O


TBS064 - - N/O


TBS068 - - N/O

TBS069 - - N/O

TBS070 - - N/O

TBS071 22 M10 x 1 N/O


Sto

p L

igh

t S

wit

ches


N/O = Normally Open

120

This section has been included to assist with the identifi cation of Tridon’s extensive range of reverse light switches. Photographs and specifi cation tables are shown for each Tridon part number. Each specifi cation table contains spanner size, thread size, plug type and circuit diagram. The Tridon reverse light switch range has been developed to operate within original equipment manufacturer’s specifi cations. As Tridon reverse light switch circuits vary always refer to the Tridon vehicle application list to ensure correct part number selection.

Reverse Light Switches

Function

The reverse light switch is a mechanical device whose primary function

is to control circuit switching for the operation of the vehicle reverse lights.

Normally located within the gearbox (manual transmission), the reverse light

switch is activated when reverse gear is selected. There are commonly two

different switch circuit types, which may vary depending on vehicle

manufacturer’s specifi cations.

Common Switch Circuits

Normally Open Contacts.

Normally Closed Contacts.


When a reverse light switch malfunction or fault is suspected, the reverse

light switch should be checked and replaced by a trained professional.

Reverse Light Switches Testing Procedure

1. Remove the reverse light switch from the vehicle.

2. Check the reverse light switch for visible faults or oil leaks.

3. Check correct reverse light switch operation, using an Ohmmeter,

measure for continuity across the reverse light switch terminals.

Normally CLOSED circuit type reverse light switch. With the plunger depressed, the reading should be infi nite

or open circuit. Slowly release the plunger to the resting position, the reading should

become zero (0Ω), or show a closed circuit between the contacts.

121

Testing Procedure (cont.)

Normally OPEN circuit type reverse light switch. With the plunger depressed, the reading should be zero (0Ω), or show a

closed circuit between the contacts. Slowly release the plunger to the resting position, the reading should be

infi nite or open circuit.

4. Replace the reverse light switch if the readings are not as shown above.

5. Other reverse light circuit tests include; Faulty or blown reverse light globes. Wiring tests, open and short circuits. Available voltage (check fuses).

The Tridon reverse light switch range has been developed to operate

with OEM specifi cations. As switch circuits and operation may vary,

always refer to the Tridon Vehicle Application list to ensure correct part

number selection.

Typical Reverse Light Circuit

Reverse Light Switches


122

21

M14 x 1.5

21

M14 x 1.5

21

M14 x 1.5

21

M16 x 1.5

19

M14 x 1.5

ø 4

25

M18 x 1.5

27

M18 x 1.5

19

M14 x 1.5

19

M14 x 1.5

24

M14 x 2

ø 4

24

M14 x 2

24

M14 x 2

Rev

erse

Lig

ht

Sw

itch

es


TRS001

TRS004

TRS007

TRS010

TRS002

TRS005

TRS008

TRS011

TRS003

TRS006

TRS009

TRS012

123

19

M12 x 1.25

ø 4

19

M12 x 1.25

ø 4

19

M12x 1.25

24

M14 x 1.5

19

M12 x 1.25

19

M14 x 1.5

ø 4

19

M14 x 1.5

ø 4

19

M14 x 1.5

22

M14 x 1.5

ø 4.6

19

M12 x 1.5

6.3 6.3

19

M12 x 1.5

6.3 6.3

22

M14 x 1.5

ø 3.5


TRS013

TRS016

TRS019

TRS022

TRS014

TRS017

TRS020

TRS023

TRS015

TRS018

TRS021

TRS024


19

3/8-16UNC

ø 4.5

19

M12 x 1.5

27

M16 x 1.5

6.3 6.3

19

M14 x 1.5

ø 4

22

M14 x 1.5

6.3 6.3

22

M14 x 1.5

27

M18 x 1.5

21

M12 x 1.5

22

M18 x 1.5

21

M12 x 1.5

24

M14 x 2

22

M16 x 1.5

125

Rev

erse

Lig

ht

Sw

itch

es


TRS025

TRS028

TRS031

TRS034

TRS026

TRS029

TRS032

TRS037

TRS027

TRS030

TRS033

TRS038

19

M14 x 1.5

24

M14 x 2

24

M14 x 2

19

M14 x 1.5

19

M14 x 1.5

—

—

27

M18 x 1.5

22

M16 x 1.5

22

M12 x 1.5

22

M16x 1.5

24

M14 x 2

24

M14 x 2


TRS040

TRS043

TRS046

TRS049

TRS041

TRS044

TRS047

TRS050

TRS042

TRS045

TRS048

TRS051


24

M14 x 2

24

M14 x 2

22

M16 x 1.5

6.3 6.3

22 22

M16 x 1.5

24

M14 x 2


N/O = Normally Open

127

Rev

erse

Lig

ht

Sw

itch

es


TRS052

TRS055

TRS053

TRS056

TRS054

TRS059

Part No. Spanner Thread Circuit TypeTRS001 21 M14 x 1.5 N/O

TRS002 21 M14 x 1.5 N/O

TRS003 21 M14 x 1.5 N/O

TRS004 21 M16 x 1.25 N/O

TRS005 19 M14 x 1.5 N/O

TRS006 25 M18 x 1.5 N/O

TRS007 27 M18 x 1.5 N/O

TRS008 19 M14 x 1.5 N/O

TRS009 19 M14 x 1.5 N/O

TRS010 24 M14 x 2.0 N/O

TRS011 24 M14 x 2.0 N/O

TRS012 24 M14 x 2.0 N/O

TRS013 19 M12 x 1.25 N/C

TRS014 19 M12 x 1.25 N/O

TRS015 19 M12 x 1.25 N/C

TRS016 24 M14 x 1.5 N/C

TRS017 19 M12 x 1.25 N/C

TRS018 19 M14 x 1.5 N/O

TRS019 19 M14 x 1.5 N/O

TRS020 19 M14 x 1.5 N/O

TRS021 22 M14 x 1.5 N/O

TRS022 19 M12 x 1.5 N/O

TRS023 19 M12 x 1.5 N/O

TRS024 22 M14 x 1.5 N/C

TRS025 19 3/8 - 16 UNC N/O

TRS026 19 M12 x 1.5 N/O

TRS027 27 M16 x 1.5 N/O

Part No. Spanner Thread Circuit TypeTRS028 19 M14 x 1.5 N/C

TRS029 22 M14 x 1.5 N/C

TRS030 22 M14 x 1.5 N/O

TRS031 27 M18 x 1.5 N/O

TRS032 21 M12 x 1.5 N/O

TRS033 22 M18 x 1.5 N/O

TRS034 21 M12 x 1.5 N/O

TRS037 24 M14 x 2 N/O

TRS038 22 M16 x 1.5 N/O

TRS039 21 M14 x 1.5 N/O

TRS040 19 M14 x 1.5 N/C

TRS041 24 M14 x 1.5 N/O

TRS042 24 M14 x 2 N/C

TRS043 19 M14 x 1.5 N/O

TRS044 19 M14 x 1.5 N/O

TRS045 - - N/O

TRS046 27 M18 x 1.5 N/O

TRS047 22 M16 x 1.5 N/O

TRS048 22 M12 x 1.5 N/O

TRS049 22 M16 x 1.5 N/O

TRS050 24 M14 x 2 N/O

TRS051 24 M14 x 2 N/O

TRS052 24 M14 x 2 N/O

TRS053 24 M14 x 2 N/O

TRS054 22 M16 x 1.5 N/O

TRS055 22 N/O


Alphabetical Index page

Coolant Temperature Sensors 86

Function - Coolant Temperature Sensors 87

Function - Oil Pressure Senders and Sensors 68

Function - Reverse Light Switches 121

Function - Stop Light Switches 112

Function - Thermo Fan Switches 94

Function - Water Temperature Senders 77

Guarantee 1

Identifi cation Guide - Coolant Temperature Sensors 89

Identifi cation Guide - Oil Pressure Senders and Sensors 70

Identifi cation Guide - Reverse Light Switches 123

Identifi cation Guide - Stop Light Switches 114

Identifi cation Guide - Thermo Fan Switches 96

Identifi cation Guide - Water Temperature Senders 79

Merchandising 4

Oil Pressure Senders and Sensors 67

Packaging 3

Product Range 2

Quick Reference Guide - Coolant Temperature Sensors 92

Quick Reference Guide - Oil Pressure Senders and Sensors 75

Quick Reference Guide - Reverse Light Switches 127

Quick Reference Guide - Stop Light Switches 119

Quick Reference Guide - Thermo Fan Switches 108

Quick Reference Guide - Water Temperature Senders 85

Replacement - Coolant Temperature Sensors 87

Replacement - Oil Pressure Senders and Sensors 68

Replacement - Reverse Light Switches 121

Replacement - Stop Light Switches 112

Replacement - Thermo Fan Switches 94

Replacement - Water Temperature Senders 77

Reverse Light Switches 120

Stop Light Switches 111

Style Variations - Thermo Fan Switches 106

Testing - Coolant Temperature Sensors 87

Testing - Oil Pressure Senders and Sensors 68

Testing - Reverse Light Switches 121

Testing - Stop Light Switches 112

Testing - Thermo Fan Switches 94

Testing - Water Temperature Senders 77

Thermo Fan Switches 93

Vehicle Application List 5

Water Temperature Senders 76

128128

Administrator

Rectangle

Administrator

Rectangle

Administrator

Rectangle

Administrator

Rectangle

Administrator

Rectangle

Administrator

Text Box

Vehicle Application Listing

Make and Model

Year Engine Part Number

NotesStart Finish Cyl Size ModelOilPressure

WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

6

33 Ti, Boxer 1985 1989 4 1.5L AR305 TPS019 TFS100

33 All 1988 1992 4 1.7L All TPS019 TCS040 TFS100 TBS021 Stop Light Switch on ’Sport’ models only

75 V6 1986 1992 V6 2.5L,3.0L AR019,AR61 TPS020 TTS520 TCS026 TFS101

75 Twin Spark 1988 1992 4 2.0L AR062.24 TPS020 TCS040 TFS101

90 Leaded Fuel 1985 1985 V6 2.5L AR016.46 TPS020 TCS026 TFS101

90 Unleaded Fuel 1985 1988 V6 2.5L AR019.11 TPS020 TFS101

147 All 08/2001 on 4, V6 ALL TPS043 TCS113 TBS054

156 Twin Spark 1999 10/2000 4 2.0L AR 32310 TPS043 TCS102TCS110

TBS045 2 x Coolant Sensors, check illustrations

156 2.0L 10/2000 on 4 2.0L TPS043 TCS113 TBS054

156 2.5L V6 1999 on V6 2.5L AR32405 TPS043 TCS113

156 3.0L V6 1999 on V6 3.0L TPS043

156 GTA 4D Sedan 2002 2004 V6 3.2L 932A000 TPS043 TCS113 TBS054

164 3.0L V6 1989 1991 V6 3.0L AR064.10 TPS040 TCS040 TFS101

164 3.0L V6 1989 1992 V6 3.0L AR643.01 TPS040 TCS040

166 4D Sedan 1999 2001 V6 3.0L AR343 TPS043 TCS110 TBS031TBS032

2 x Stop Light Switches, check illustrations

166 4D Sedan 2001 on V6 3.0L AR36101 TPS043 TCS113 TBS054

Alfasud All 1974 1988 4 ALL TPS019 TFS100 TBS021

Alfetta & Giulietta All 1974 1986 4 ALL TPS020 TFS101

GT 2D Coupe (incl JTS) 2004 on 4, V6 ALL TPS043 TCS113

GTV 2000 1977 1981 4 2.0L AR162 TFS101

GTV GTV 2.0L 1981 1986 4 2.0L AR016 TPS007 TFS101

GTV 6 1983 1988 V6 2.5L TPS020 TCS026 TFS101

GTV All 1998 on 4 2.0L AR16201 TPS043 TTS520 TCS096 TBS031

GTV V6 2D COUPE 05/1998 on V6 3.0L AR16102 TPS043 TCS110 TBS031 2 x Stop Light Switches, check illustrations

Spider Milennium 11/1999 03/2000 4 2.0L AR32301 TPS043 TTS520 TCS110

Spider Twin Spark with luxury pack

07/2000 09/2002 4 2.0L AR16201 TPS020 TTS520 TCS096 TFS101 TBS031

Spider Duetto & Veloce 12/2001 09/2003 4 2.0L AR32301 TPS020 TTS520 TBS031

Spider JTS Lusso 10/2003 01/2005 4 2.0L 937A1000 TPS043 TTS520 TCS113 TBS054

Spider V6 2D Convertible 06/2001 09/2003 V6 3.0L AR16102 TPS043 TTS520 TCS113 TBS031

Audi

80 CC 1986 1987 4 1.8L JN TPS030TPS031TPS045

TCS098 TBS038 3 x Oil Pressure Switches, check illustrations

80 1.8E Quattro 1988 1989 4 1.8L SD TPS021TPS030TPS031TPS042

TCS098 TFS103TFS104

TBS038 4 x Oil Pressure Switches & 2 x Thermo Fan Switches, check illustrations

Alfa Romeo

7

Vehicle Application List

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

80 2.0 & 2.0S 1989 1992 4 2.0L 3A,AAD,ABK

TPS030TPS031TPS042TPS045

TCS091TCS098

TFS103TFS104

TBS038 4 x Oil Pressure Switches, 2 x Coolant Sensor & 2 x Thermo Fan Switches, check illustrations

80 2.3 1992 1993 5 2.3L NG TPS021TPS030

TFS103TFS104

TBS038 2 x Oil Pressure Switches & 2 x Thermo Fan Switches, check Illustrations

80 2.3E 1992 1993 5 2.3L NG TPS030TPS045

TBS038 2 x Oil Pressure Switches, check illustrations

80 2.6E (incl Cab) 1992 1999 V6 2.6L ABC TPS045TPS046

TFS103TFS104


80 2.6E Quattro & 2.8E 1992 1999 V6 2.6L,2.8L AAK, ABC TPS045TPS046

TCS098 TFS103TFS104


90 Sport & Quattro 1989 1992 5 2.3L 7A, NG TPS030TPS045

TFS103TFS104


100 CD 1983 1991 5 2.1L KF, HX, NF TPS021TPS030TPS031TPS042

TFS103TFS104

TBS038 4 x Oil Pressure Switches & 2 x Thermo Fan Switches, check illustrations

100 CD 1990 1991 5 2.3L AAR TPS021TPS030

TFS208 TBS038 2 x Oil Pressure Switches, check illustrations

100 2.6E & 2.8E (incl Quattro)

1992 1994 V6 2.6L,2.8L ABC, AAH TPS021TPS042TPS046

TCS098 TFS208 TBS038 3 x Oil Pressure Switches, check illustrations

200 Turbo 1982 1984 5 2.1L KG, KJ TFS103TFS104

2 x Thermo Fan Switches, check illustrations

200 Turbo 1986 1991 5 2.2L MC TPS021 TPS030

TFS103TFS104


5+5 1981 1984 5 2.1L WE TPS020 TFS102TFS135

2 x Thermo Fan Switches, check illustrations and Temp ranges

5E 1978 1982 5 2.1L WB, WC TFS102TFS135


A3 4D Hatchback 1997 2004 4 1.6L AEH TPS031TPS054

TTS504 TCS104TCS105

TFS190TFS198

TBS028TBS051

TRS045TRS048

For correct application, check illustrations and spec tables

A3 Attraction Hatchback 2004 on 4 1.6L BGU TPS054 TRS048

A3 4D Hatchback 1997 2004 4 1.8L AGN TPS031TPS054

TCS104TCS105

TFS190TFS198

TBS028TBS051

TRS045TRS048


A3 Turbo 4D Hatchback 1998 2004 4 1.8L AGU TPS031TPS054

TTS504 TCS104TCS105

TFS190TFS198


A3 2.0 TDI 2004 on 4 2.0L BKD TPS051 TCS111 TRS048

A3 3.2 Quattro 2004 on V6 3.2L BDB TPS053 TCS111 TRS048

A4 1.8 4D Sedan 08/1995 06/2001 4 1.8L ADR TPS031TPS054

TCS091TCS101TCS104TCS105

TFS103TFS208

TBS038TBS049

TRS004 For correct application, check illustrations and spec tables

Alfa Romeo, Audi

Audi cont.

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

8

A4 1.8 Quattro 1995 1997 4 1.8L AGB TFS103TFS208


A4 1.8T (incl Quattro) 12/1995 1999 4 1.8L AEB TPS031 TCS101TCS105

TFS103TFS208

TBS038 2 x Coolant Sensors & 2 x Thermo Fan Swit-ches, check illustrations

A4 1.8T 1999 on 4 1.8L AJL TPS031TPS054

TCS104TCS105

TFS103TFS208

TBS038TBS049


A4 1.8T 4D Sedan 02/2002 on 4 1.8L AVJ TPS054 TCS104TCS111

2 x Coolant Sensors, check illustrations

A4 1.8T Cabriolet 2003 on 4 1.8L AVJ TCS104TCS111


A4 2.0 B6 07/2001 on 4 2.0L ALT TPS054 TCS104TCS111


A4 2.4 V6 (AGA) 1998 on V6 2.4L AGA TPS031 TCS105 TFS103TFS208

TBS038 2 x Thermo Fan Switches, check illustrations

A4 2.4 V6 (AFM) 02/1998 06/2001 V6 2.4L AFM TPS030TPS031

TFS103TFS208

TBS038 2 x Oil Pressure Switches & 2 Coolant Sensors, check illustrations

A4 2.6 V6 (ABC) 1995 1999 V6 2.6L ABC TPS030 TCS101TCS105

TFS103TFS208

TBS038TBS050


A4 2.6 Quattro 1995 1999 V6 2.6L ABC TPS030TPS031

TCS101TCS105

TFS103TFS208

TBS038TBS050


A4 2.8 Quattro 1995 1999 V6 2.8L ACK TPS030TPS031

TCS105 TFS103TFS208

TBS038 2 x Oil Pressure Switches & 2 Coolant Sensors, check illustrations

A4 3.0 V6 (incl Cab) 10/2001 on V6 3.0L ASN TPS054 TCS104TCS111

TRS030 2 x Coolant Sensors, Rev Light sw 5sp man only, check illustrations

A6 2.4 V6 (AGA) 1997 2004 V6 2.4L AGA TPS031TPS054

TCS104TCS105

TFS219 TBS038TBS049


A6 2.4 Quattro 1997 1999 V6 2.4L AGA TPS031TPS054

TCS104TCS105

TFS208 TBS038TBS049


A6 2.6 V6 (ABC) 1994 1997 V6 2.6L ABC TPS030TPS031TPS045TPS046

TCS098 TFS208 TBS038TBS049

4 x Oil Pressure Switches & 2 x Stop Light Switches, check illustrations

A6 2.6 Quattro 1994 1997 V6 2.6L ABC TPS030TPS031TPS045

TCS098 TFS208 TBS049 3 x Oil Pressure Switches, check illustrations

A6 2.7T Quattro 02/2002 on V6 2.7L AJK TPS031TPS054

TCS104TCS105

TFS219 TBS038TBS049


A6 2.8 V6 (ACK) 1997 1999 V6 2.8L ACK TPS030TPS031TPS045

TCS098 TFS103TFS208

TBS038TBS049


A6 2.8 Quattro 1997 2004 V6 2.8L ACK TPS031TPS054

TCS098 TFS103TFS208

TBS038TBS049


A6 3.0 Quattro 02/2002 10/2004 V6 3.0L BBJ TCS104 TFS219

A6 3.0 Quattro 11/2004 on V6 3.0L BBJ TPS054 TCS104

Audi cont.

9


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

A6 Tdi FWD 2004 on V6 3.0L BMK TPS053 TCS111

A6 4.2 Quattro 04/2000 2004 V8 4.2L ABZ TFS219

A6 4.2 Quattro 2004 on V8 4.2L BAT TPS054 TCS111

A8 2.8 V6 05/1995 12/1996 V6 2.8L AAH TPS045TPS046

TCS105 TFS103TFS208

TBS038TBS049


A8 2.8 Quattro 01/1997 on V6 2.8L ACK TPS045TPS046

TCS105 TFS208 TBS049 TRS030 2 x Oil Pressure Switches, check illustrations

A8 3.7 V8 (AEW) 10/1996 1999 V8 3.7L AEW TPS030 TCS093 TFS205 TBS038TBS049


A8 4.2 Quattro 1995 2000 V8 4.2L ABZ TPS030TPS045

TCS093 TFS205 TBS049 TRS030 2 x Oil Pressure Switches, check illustrations

Allroad Quattro Tdi 4D Wagon 05/2002 on V6 2.5L AKE TPS053 TCS104 TFS219 TBS049 TRS030

Allroad Quattro 2.7 (incl Twin Turbo) 02/2001 on V6 2.7L AJK TPS031TPS054

TBS038 TBS049


Allroad Quattro 4.2 V8 4D Wagon 12/2003 on V8 4.2L BAS TPS054 TCS104 TBS049

S2 Turbo 1993 1996 5 2.2L AAN TFS103TFS208


S3 1.8T 1999 on 4 1.8L APY TPS054 TCS104TCS105

TFS190TFS198

TBS028TBS051

TRS045TRS048


S4 2.7 Twin Turbo 1999 2003 V6 2.7L ABG / AZB TCS104TCS105

TFS103TFS208


S6 4.2 V8 02/2001 on V8 4.2L AQJ TPS054 TBS038TBS049


S8 4.2 V8 1998 on V8 4.2L AHC, AHK TFS208

TT 1.8 (incl Turbo & Quat-tro)

1999 on 4 1.8L AJL,AJQ,APX

TPS054 TTS504 TCS104TCS105

TFS213 TBS051 TRS045TRS048


TT 3.2 Quattro 2004 on V6 3.2L BHE TPS054 TCS104 TFS218 TBS051 TRS048

V8 3.6 Quattro 1990 1992 V8 3.6L PTK TPS021 TCS093 TFS104 TBS038 TRS030 Reverse Light Switch for 6sp model only

BMW

316i E36 1995 1999 4 1.6L M43 B16 TPS039 TCS108 TFS107 TBS029TBS035

TRS034 2 x Stop Light Switches, check illustrations

316i E46 1999 2001 4 1.9L M43 B18 TPS039 TCS107 TFS107 TRS034

316ti E46 2001 on 4 1.8L N42 B18 TPS039 TCS107 TRS034

318i E21 (M10) 1980 1983 4 1.8L M10 TFS107

318i E30 1983 1987 4 1.8L M10 TTS035 TCS026 TFS107 TBS023TBS029


318i & 318iS E30 1988 1991 4 1.8L M40,M42 TPS039 TTS035 TCS040 TFS107 TBS029 TRS023 2 x Coolant Sensors, check illustrations

318i E36 1991 1994 4 1.8L M40 TPS039 TCS040TCS099

TFS107 TBS029TBS035

TRS023TRS034


318i E36 1994 1998 4 1.8L M43 TPS039 TCS040TCS099TCS108

TFS107 TBS029TBS035


Audi, BMW

Audi cont.

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

10

318i E46 1998 on 4 1.9L M44 TCS108 TFS107

318iS E36 (Sedan M43) 1992 1998 4 1.8L M43 TFS201TFS217


318iS E36 (Coupe M42) 1993 1996 4 1.8L M42 B18 TPS039 TCS040TCS099

TFS107 TBS029 TRS034 2 x Coolant Sensors, check illustrations

318iS & 318Ti E36 (M44) 1996 on 4 1.9L M44 B19 TPS039 TCS108 TFS107 TBS029 TRS034

320 & 320i E21 (M10) 1976 1980 4 2.0L M10 TFS105TFS106


320i E30 (M20) 1988 1990 6 2.0L M20 TPS039 TTS035 TFS105TFS106

TBS029 TRS023 2 x Thermo Fan Switches, check illustrations

320i E36 (M50) 1991 1995 6 2.0L M50 TPS039 TTS035 TCS040TCS099

TFS107 TBS029TBS035

TRS023TRS034


320i E46 (M47) 06/2002 on 6 2.2L M47 TCS107

323i E30 (M20) 1982 1985 6 2.3L M20 B23 TPS026 TTS025TTS035

TBS023 TRS023 2 x Water Temp Senders, check illustrations

323i E36 (M52) 1996 1998 6 2.5L M52 TCS108 TFS217

323i & 323Ci E46 (M52) 1998 on 6 2.5L M52 B25 TPS039 TCS107 TFS217 TRS034

325i E30 (M20) 1988 1990 6 2.5L M20 B25 TPS039 TTS035 TCS040 TFS107 TBS023TBS029


325i E36 (M50) 1991 1995 6 2.5L M50 B25 TPS039 TTS035 TCS040TCS099



325e E30 (M20) 1986 1987 6 2.7L M20 B27 TPS039 TTS035 TCS026 TFS105TFS106

TBS023TBS029

TRS023 2 x Stop Light Switches & 2 x Thermo Fan Switches, check illustrations and Temp ranges

325iS E30 (M20) 1988 1990 6 2.5L M20 TPS039 TTS035 TCS040 TFS105TFS106


325Ti E46 (M54) 05/2002 on 6 2.5L M54 TPS039 TRS034

325Ci E46 (M54) 2004 on 6 2.5L M54 TPS039 TCS107 TRS034

328i E36 (M52) 1995 2000 6 2.8L M52 B28 TPS039 TBS035 TRS034

328i E46 (M52) 1998 2000 6 2.8L M52 B28 TPS039 TCS107 TBS035 TRS034

328Ci E46 (M52) 1999 on 6 2.8L M52 B28 TPS039 TRS034

330i & 330Ci E36 (M54) 09/2000 on 6 3.0L M54 TPS039 TCS107 TRS034

520 E12 (M10) 1973 1978 4 2.0L M10 TFS107

520i E28 (M20) 1983 1985 6 2.0L M20 TPS026TPS039

TTS025TTS035

TCS026 TFS105TFS106

TBS023TBS029


520i E34 (M50) 1990 1996 6 2.0L M50 TPS039 TTS035 TCS040 TFS107 TRS023TRS034

2 x Coolant Sensors, & 2 x Reverse Light Switches check illustrations

523i E39 (M52) 1996 2000 6 2.5L M52 B25 TPS039 TCS108 TFS201TFS217

TRS034 2 x Thermo Fan Switches, check illustrations

525 i E34 (M20) 1988 1990 6 2.5L M20 B25 TPS039 TFS107 TBS035

525 i E34 (M50) 1990 1996 6 2.5L M50 TCS040TCS099

TFS107 TRS023 2 x Coolant Sensors, check illustrations

BMW cont.

11


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

525i E60 (M54) 2003 on 6 2.5L M54256S5 TCS107

525e E28 (M20) 1986 1988 6 2.7L M20 B27 TTS035 TCS040 TFS105TFS106

TBS023TBS029


528 E12 (M30) 1975 1982 6 2.8L M30 TFS106

528i E28 (M30) 1982 1985 6 2.8L M30 B28 TPS026 TTS025 TCS026 TFS106 TBS023TBS029


528i E39 (M52) 1996 09/2000 6 2.8L M52 B28 TPS039 TCS108 TFS201TFS217


530i E34 (M60) 1993 1996 V8 3.0L M60 B30 TPS039 TCS093TCS099


530i E60 (M54) 2003 on 6 3.0L M5430S3 TPS039 TCS107 TRS034

535i E28 (M30) 1986 1988 6 3.4L M30 B35 TPS026 TCS040 TFS107 TBS023TBS029


535i & 535iS E34 (M30) 1988 09/1991 6 3.4L M30 B35 TPS039 TCS040 TFS107 TBS035 TRS023

535i E34 (M30) 09/1991 1993 6 3.4L M30 B35 TPS039 TCS040 TFS107 TBS035 TRS034

535i E39 (M62) 10/1996 on V8 3.5L M62 TPS039 TCS108 TRS034

540i E34 (M60) 1994 1996 V8 4.0L M60 B40 TPS039 TCS093TCS099


540i E39 (M62) 10/1996 2003 V8 4.0L M62 B44 TPS039 TCS108 TFS107 TRS034

545i E60 (M62) 2003 on V8 4.4L N62 B44 TPS039 TCS107

633 Csi E24 (M30) 1977 1980 6 3.2L M30 B32 TPS025 TBS023 TRS023

635 Csi E24 (M30) 1986 1989 6 3.4L M30 B35 TPS025 TBS023 TRS023

730i & 730iL E32 (M30) 1990 1994 6 3.0L M30 B30 TPS039 TCS040TCS093TCS099

TFS107 TBS023TBS029TBS035

TRS023TRS034


730iL E38 (M60) 1995 1996 V8 3.0L M60 B30 TCS093TCS099

TFS107 TRS034 2 x Stop Light Switches, check illustrations

733i E23 (M30) 1978 1984 6 3.2L M30 B32 TPS026 TCS026 TFS105TFS106


735i E23 (M30) 1985 1987 6 3.4L M30 B35 TPS026 TFS107 TBS023 TRS023

735i & 735iL E32 (M30) 1985 1992 6 3.4L M30 B35 TPS039 TCS040TCS093TCS099


TRS023TRS034


735i & 735iL E38 (M62) 1996 on V8 3.5L M62 TPS039 TCS108 TRS034

735Li E66 LWB (N62) 07/2002 on V8 3.6L N62 B36 TPS039 TCS107 TFS107

740iL E32 (M60) 1992 1994 V8 4.0L M60 B40 TPS039 TCS093TCS099

TFS107 TBS035 2 x Coolant Sensors, check illustrations

740iL E38 (M60) 1994 1996 V8 4.0L M60 B40 TCS093TCS099

TRS034 2 x Coolant Sensors, check illustrations

740iL E38 (M62) 1996 on V8 4.4L M62 B44 TPS039 TCS108 TRS034

745Li E66 LWB (N62) 07/2002 on V8 4.4L N62 B44 TPS039 TCS107

BMW cont.

BMW

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

12

750iL E32 (M70) 1988 1994 V12 5.0L M70 B50 TCS093TCS099



750iL E38 (M73) 1995 on V12 5.4L M73 B54 TPS039 TCS108

760Li E66 (N73) 2003 on V12 6.0L N73 B60 TPS039 TCS107

840i E31 (M60) 1993 1996 V8 4.0L M60 B40 TCS093TCS099

TFS107 TRS034 2 x Coolant Sensors, check illustrations

840Ci E31 (M62) 1996 2000 V8 4.4L M62 B44 TPS039 TCS108 TRS034

850i & 850Ci E31 (M70) 1990 1994 V12 5.0L M70 TCS093TCS099


M3 E36 (S50) 1994 1996 6 3.0L S50-B30 TPS039 TCS040TCS099

TFS107TFS217

TBS035 TRS034 For correct application, check illustrations and spec tables

M3 E36 (S50) 1996 on 6 3.2L S50-B32 TPS039 TCS108 TFS217 TBS035 TRS034

M3R E36 1995 1995 6 3.0L M3R TFS107

M3 E46 (S54) 2001 on 6 3.2L S54 TPS039 TCS107 TRS034

M535i E28 (M30) 1986 1988 6 3.4L M30 B35 TPS026 TCS026 TFS107 TBS023TBS029


M5 E34 (S38) 1990 1993 6 3.5L S38 B36 TPS039 TCS040TCS099



X3 E83 3.0i 2004 on 6 3.0L M54306S3 TPS039 TCS107

X5 E53 3.0i 03/2001 on 6 3.0L M54B30 TPS039 TCS107 TRS034

X5 E53 3.0d 2003 01/2004 6 3.0L M57 TPS039 TCS108 TRS034

X5 E53 3.0d 01/2004 on 6 3.0L M57D30TU TPS039 TCS108

X5 E53 4.4i 11/2000 01/2004 V8 4.4L N62B44 TPS039 TCS108

X5 E53 4.4i 01/2004 on V8 4.4L N62B44 TPS039 TCS107

X5 E53 2002 2004 V8 4.6L TPS039 TCS108

Z3 E36 (M44) 1997 2003 4 1.9L M44 B19 TPS039 TCS108 TBS035 TRS034

Z3 E36 (M52) 1999 2003 6 2.0L M52 B TPS039 TCS107 TFS217 TBS035 TRS034

Z3 E36 (M52) 1999 2003 6 2.8L M52 B28 TPS039 TCS107TCS108


Z4 2D Convertible 2003 on 6 2.5L,3.0L M542,M543 TPS039 TCS107 TRS034

Mini Cooper incl Cabriolet 03/2002 on 4 1.6L M54 TRS030

Mini Cooper S (incl Cabriolet) 03/2002 on 4 1.6L TRS026

Chrysler

Centura KB 1975 1977 4 2.0L TPS007 TTS017

Centura KB & KC 1975 1978 6 3.5L,4.0L HEMI TPS033

Galant All 1971 1977 4 ALL TPS007 TTS017

Lancer LA, LB & LC 1974 1981 4 1.4L,1.6L 4G33, 4G32 TPS007 TTS017 TFS139 TRS014

Valiant All 1962 1981 6, V8 ALL TPS033 TTS024

BMW cont.

13


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

AX 1.4 GT 1991 1993 4 1.4L TU3/KDZ TPS023 TFS102TFS185

TRS030 2 x Rev Light Switches & 2 x Thermo Fan Switches, check illustrations

Berlingo 2D Van 07/1999 05/2003 4 1.4L TU3J TPS023TPS050

TTS512TTS515

TFS185 TBS040 TRS030 For correct application, check illustrations and spec tables

Berlingo 2D Van 05/2003 on 4 1.4L TU3J TPS023TPS050

TTS512TTS515


BX19 TRi, TRZ, 16 Valve 1988 1994 4 1.9L XU9J4 TPS023

C3 All 2002 on 4 1.4L,1.6L TU3J,TU5J TPS050 TTS512 TBS040

C5 2.0L Hdi 06/2001 on 4 2.0L DW10ATED TPS050 TBS040

C5 2.0L & 3.0L V6 06/2001 on 4, V6 2.0L,3.0L EW10J,ES9J TPS050 TCS109 TBS040

CX2200 & CX2400 1976 1983 4 2.2L,2.3L 073, 079 TFS102

CX25 & CX25iE 1984 1985 4 2.5L 080, 081 TFS102

Xantia Turbo Diesel 1996 2001 4 1.9L Td XUD9T TPS047TPS050

TTS057TTS515


Xantia 2.0 (8V) 1994 2001 4 2.0L XU10J2 TPS047 TTS057TTS515

TFS185 2 x Water Temp Senders, check illustrations

Xantia 2.0 (16V) 1994 2001 4 2.0L XU10J4D TPS047 TTS057TTS515

2 x Water Temp Senders, check illustrations

Xantia X2 Turbo (XU10J2TE) 1998 1999 4 2.0L XU10J2TE TPS047TPS050


Xantia 3.0L V6 (ES9J4) 1998 on V6 3.0L XFZ(ES9J4) TPS047TPS050

TFS185 TRS030 For correct application, check illustrations and spec tables

XM 3.0L V6 1991 1994 V6 3.0L SFZ TPS047 TTS057TTS515

TRS030 2 x Water Temp Senders & 2 x Rev Light Switches, check illustrations

XM 3.0L V6 1994 1997 V6 3.0L SFZ TPS047 TRS030 2 x Rev Light Switches, check illustrations

XM 3.0L V6 1997 on V6 3.0L XFZ(ES9J4) TPS047TPS050

TFS185 2 x Oil Pressure Switches, check illustrations

Xsara 1.6i 2000 on 4 1.6L TU5JP4 TPS050 TTS512 TFS185 TBS040

Xsara 1.8i 1998 on 4 1.8L XU7J TPS047TPS050

TTS057 TFS185 For correct application, check illustrations and spec tables

Xsara 2.0i (XU10J4) 1998 09/2000 4 2.0L XU10J4 TPS047TPS050

TTS057 TFS185 For correct application, check illustrations and spec tables

Xsara 2.0i (EW10J4) 10/2000 on 4 2.0L EW10J4 TCS109

Daewoo

1.5 1994 1995 4 1.5L G15MF TCS090 TFS109 TBS027TBS030


Cielo GL 1995 1998 4 1.5L (8V) G15MF TTS024 TCS090 TFS109 TBS027TBS030


Cielo GLX 1995 1998 4 1.5L (16V) A15MF TTS024 TCS090 TFS109 TBS027 TRS026

Espero CD 1995 1997 4 2.0L C20LE TTS052 TCS070 TFS109 TBS027 TRS026

Lanos All 1997 2003 4 1.5L,1.6L A15S,A16D TPS038 TTS024 TCS090 TBS043 TRS026

Citroen

BMW, Chrysler, Citroen, Daewoo

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

14

Leganza 2.0L 07/1997 04/1999 4 2.0L C20SED TPS038 TTS024 TCS090 TBS030TBS043


Leganza 2.2L 04/1999 12/2004 4 2.2L T22SED TPS038 TTS024 TCS090 TBS030TBS032


Matiz KL 10/1999 12/2004 3 796cc F8CV TPS007 TBS027TBS030


Musso 2.9 Turbo 09/1998 2002 5 2.9L OM602 TPS044

Musso 3.2L 09/1998 2002 6 3.2L M162-99 TPS044 TTS039 TBS016

Nubira 1.6L 06/1997 10/1999 4 1.6L A16DMS TCS090

Nubira 2.0L 05/1998 08/2003 4 2.0L X20SED TTS024

Tacuma Wagon 11/2000 12/2004 4 2.0L X20SED TCS090

Daihatsu

Applause A101 1989 1992 4 1.6L HDE TPS006 TTS013 TCS035 TFS110 TBS003 TRS004

Applause A101 1992 1999 4 1.6L HDE TPS006 TTS004 TCS035TCS055


Charade G10 1980 1983 3 993cc CB20 TPS008 TTS002 TFS111

Charade G11 1983 01/1985 3 993cc CB20 TPS006 TTS013 TFS111 TRS004

Charade G11 01/1985 1987 3 993cc CB20 TPS006 TTS013 TFS111 TBS004 TRS004

Charade G11 Turbo 1983 01/1985 3 993cc CB50/60 TPS006 TTS013 TRS004

Charade G11 Turbo 01/1985 1987 3 993cc CB50/60 TPS006 TTS013 TBS004 TRS004

Charade G100 1987 1993 3 993cc CB23 TPS006 TTS013 TCS035 TFS111 TBS003 TRS004

Charade G100 Turbo 1987 1988 3 993cc CB61T TPS006 TTS013 TFS111 TBS003 TRS004

Charade G102 1988 1993 4 1.3L HCE TPS006 TTS013 TCS035 TFS110 TBS003

Charade G200, G202 & G202B 10/1993 1998 3 993cc CB24 TFS111

Charade G200 & G200B 10/1993 1998 4 1.3L HCE TPS006 TTS001 TCS055 TFS196 TRS004

Charade G203 & G203B 1994 1998 4 1.5L HEE TPS006 TTS001 TCS055 TFS196 TRS004

Charade G203C 1998 on 4 1.5L HEE TCS055 TFS203

Charade L500 Centro 1995 1999 3 659cc EFEL, EFGL TCS126 TFS200

Cuore L700 2000 2003 3 1.0L EJDE TPS006 TTS013 TBS009 TRS049

Delta (5R - Petrol) DV23 1971 1977 4 2.0L 5R TPS007 TTS002 TBS011

Delta (5R - Petrol) V30,V31,V32,V34,V35 1979 1984 4 2.0L 5R TPS008 TTS006 TRS004

Delta (3Y - Petrol) V67,V68,V69 1984 1988 4 2.0L 3Y TPS008 TTS006 TRS004

Delta (4Y - Petrol) V107,V108,V109 1987 1993 4 2.2L 4Y TPS008 TTS006 TRS004

Delta (DG - Diesel) D23,DV26 1973 1977 4 2.5L DG TPS006 TTS002 TBS011

Delta (DG - Diesel) V20,V22,V24,V25 1979 1983 4 2.5L DG TPS006 TTS002 TBS003 TRS004

Delta (DL - Diesel) V50,V54 1983 1984 4 2.8L DL TPS006 TTS002 TCS024 TRS004

Delta (DL - Diesel) V55 1987 1993 4 2.8L DL TPS006 TTS002 TCS024 TRS004

Delta (DL - Diesel) V57,V58 1984 06/1992 4 2.8L DL TPS006 TTS002 TCS024 TRS004

Delta (DL - Diesel) V57,V58 06/1992 05/1993 4 2.8L DL TPS006 TTS013 TCS024 TRS004

Delta (DL - Diesel) V57,V58 05/1993 on 4 2.8L DL TPS006 TTS004 TCS032 TRS004

Daewoo cont.

15


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Delta (B - Diesel) V10,V11,V12,DV28 1974 1984 4 3.0L B TPS006 TTS005 TBS011

Delta (B - Diesel) V90,V92 1981 1984 4 3.0L B TPS006 TTS006 TBS002 TRS005

Delta (B - Diesel) V98,V99 1984 1996 4 3.0L B TPS008 TTS006

Delta (13B - Diesel) V47,V48 1982 1984 4 3.4L 13B

Delta (13B - Diesel) V76,V78,V79 1984 1990 4 3.4L 13B TPS008 TTS006

Delta (14B - Diesel) V116,V118,V119 1989 01/1992 4 3.7L 14B TPS008 TTS006 TCS032 TRS004

Delta (14B - Diesel) V116,V118,V119 02/1992 on 4 3.7L 14B TPS008 TTS006 TCS032

F20, F25 1.6L Petrol 1978 1984 4 1.6L 12R TPS006 TTS005

F50, F55 2.5L Diesel 1978 1982 4 2.5L DG TPS006 TTS002 TBS011

F60, F65 2.8L Diesel 1983 1984 4 2.8L DL TPS006 TTS002 TBS002

Feroza F300 1988 09/1993 4 1.6L HDE TPS006 TTS013 TCS035 TFS110 TBS002 TRS004

Feroza F300 09/1993 1998 4 1.6L HDE TPS006 TTS013 TCS055 TFS110 TBS002 TRS004

Feroza F310 09/1993 1998 4 1.6L HDE TPS006 TTS004 TCS055 TFS110 TBS002 TRS004

Handi Van L55,L60 1981 1985 2 ALL TPS006 TTS002

Handi Van L80 1986 1990 3 846cc ED10 TPS006 TTS013 TRS004 2 x Rev Light Switches, check illustrations

Handi Van L500,L600 1995 1999 3 659cc EFEL TPS006 TTS013 TCS055

Handi Van L701 1999 2002 3 1.0L EJ TPS006

Hi Jet S70,S75,S76 1982 1986 3 ALL TPS006 TTS001

Hi Jet S85 1987 1990 3 993cc CB TPS010 TTS002 TRS004

Mira L201,V 1990 1992 3 847cc ED-10 TPS006 TTS004 TCS035 TRS004

Mira L200 1992 1995 3 660cc EFEL TPS006 TTS004 TCS035 TFS200 TRS004

Move L601 1997 1999 3 847cc ED-20 TCS035 TFS202

Pyzar G303 02/1997 09/1998 4 1.5L HEEG TPS006 TTS001 TCS055 TFS203 TRS004

Pyzar G301 10/1998 2000 4 1.6L HDEP TPS007 TTS001 TRS004

Rocky F80,F85,F87 - Carb 1984 1989 4 2.0L 3Y-C TPS008 TTS006 TBS002 TRS004

Rocky F80,F85 - EFI 1987 1989 4 2.0L 3Y-E TPS008 TTS006 TCS024 TBS002 TRS004

Rocky - Diesel F70 (incl Turbo),F75 & F77 (non Turbo)

1984 06/1992 4 2.8L DL, DL-T TPS006 TTS002 TBS002 TRS004

Rocky - Diesel Turbo F75 1985 06/1992 4 2.8L DL-T TPS006 TTS002 TCS055 TBS002 TRS004

Rocky - Diesel F70,F75 06/1992 07/1993 4 2.8L DL TPS006 TTS013 TBS002 TRS004

Rocky - Diesel F73 1993 1998 4 2.8L DL TPS006 TTS002 TBS002 TRS004

Rocky - Diesel Turbo F78 1993 1999 4 2.8L DL-T TTS013 TCS032 TBS002 TRS004

Sirion 1.0L (M100) 1998 02/2005 3 1.0L EJDE TPS006 TTS001 TFS200 TBS009 TRS049

Sirion 1.3L (M103) 2000 on 4 1.3L K3-VE2 TCS119

Terios 1997 on 4 1.3L HC-EJ TPS006 TBS009

YRV 4D Wagon 2001 on 4 1.3L K3-VE TFS200

Fiat

124, 128, 131, 132 All 1967 1982 4 ALL TPS018 TFS135

125 1967 1973 4 1.6L TFS100

Daihatsu cont.

Daewoo, Daihatsu, Fiat

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

16

500 All 1958 1971 2 ALL TBS044

Ducato All 2002 on 4 2.8L TPS043 TBS054 Stop Light Switch models without cruise control

Regata 85S 1985 1987 4 1.5L 149A TPS018

X1/9 All 1974 1983 4 ALL TPS018 TFS135

Ford

Bronco 1981 1985 6 4.1L TPS061 TTS037

Bronco 1981 1985 V8 5.8L TPS029 TTS023 TBS070

Bronco 1985 1987 V8 4.9L TPS061 TTS023 TCS011

Capri 1969 1974 4, V6 1.6L, 3.0L All TPS012 TTS023 TBS022 TRS021

Capri SA - Series I 10/1989 10/1990 4 1.6L B6 (8V) TTS001 TCS024 TFS115TFS136

TBS009 TRS011 3 x Thermo Fan Switches, TFS115 located in radiator, TFS136 located in Cyl head, NO Tridon application for 3rd Switch also located in radiator

Capri SA - Series I (Turbo) 10/1989 10/1990 4 1.6L B6 (16V) TTS003 TCS024 TFS115TFS136

TBS009 3 x Thermo Fan Switches, TFS115 located in radiator, TFS136 located in Cyl head, NO Tridon application for 3rd Switch also located in radiator

Capri SA - Series I, 3 spd Auto

10/1989 10/1990 4 1.6L B6E TTS015 TCS024 TFS181 TBS009 TRS011

Capri SA - Man & Series II Auto

10/1989 10/1990 4 1.6L B6E TTS015 TCS024 TFS115TFS136

TBS009 TRS011 3 x Thermo Fan Switches, TFS115 located in radiator, TFS136 located in Cyl head, NO Tridon application for 3rd Switch also located in radiator

Capri SA (Series II) - SBincl Turbo

11/1990 1992 4 1.6L B6 TTS003 TCS024 TFS136 TBS009

Capri SC - incl Turbo 1992 1993 4 1.6L B6 TTS003 TCS024 TFS136 TBS009

Capri SE 1993 1994 4 1.6L B6 TTS003 TCS024 TFS136 TBS009

Capri SE Turbo 1993 1994 4 1.6L B6 (16V) TTS003 TCS024 TFS136 TBS009 TRS042

Corsair UA 1989 1992 4 2.0L, 2.4L CA20EKA24E

TPS014TPS017

TCS127 TBS007 2 x Oil Pressure Switches, check illustrations

Cortina Mk 1 1963 1968 4 1.2L,1.5L All TTS023

Cortina Mk 2 1968 1971 4 1.3L,1.6L TPS027 TTS023 TBS044 TRS021

Cortina TC 1971 1974 4 1.6L TTS023

Cortina TC,TD,TE,TF 1971 1981 4 2.0L TTS023 TBS022 TRS021

Cortina TC,TD,TE,TF 1972 1981 6 3.3L TPS061 TTS037 TBS022

Cortina TC,TD,TE,TF 1972 1981 6 4.1L TPS061 TTS037 TBS022

Cougar SW 1999 2001 V6 2.5L LCBC TCS085TCS112


Courier SGC(D) 1978 1985 4 1.8L, 2.0L VC, MA TPS013 TTS002 TBS009 TRS010 2 x Reverse Light Switches, check illustrations

Courier PC - RWD 1985 1990 4 2.0L FE TPS006 TTS015 TBS009 TRS010

Fiat cont.

17


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Courier PC - RWD 1990 1996 4 2.2L F2 TPS007 TTS003 TBS009 TRS010

Courier PC - 4WD 05/1987 08/1990 4 2.6L 4G54 TPS006 TTS003 TBS009

Courier PC - 4WD 09/1990 04/1996 4 2.6L G6 TPS006 TTS003 TCS045 TBS009

Courier PD 05/1996 03/1998 4 2.6L G6 TPS006 TTS001 TCS045 TBS014

Courier PD 04/1998 12/1998 4 2.6L G6 TPS006 TTS001 TCS045 TBS014 TRS050

Courier PE,PG,PH 01/1999 on 4 2.6L G6 TPS006 TTS001 TCS045 TBS014 TRS050

Courier PH 02/2005 on V6 4.0L TPS006TPS066

TTS001 TBS014 2 x Oil Pressure Switches, check illustrations

Courier - Diesel SGHW 1981 1985 4 2.2L S2 TPS013 TTS002 TBS009 TRS010

Courier - Diesel PC - RWD 06/1985 01/1990 4 2.2L R2 TPS013 TTS015 TBS009 TRS010

Courier - Diesel PC - RWD 01/1990 04/1996 4 2.2L R2 TPS013 TTS003 TBS009 TRS010

Courier - Diesel PD 1996 1998 4 2.5L WL TPS007 TCS032 TBS014

Courier - Diesel Turbo

PE,PG,PH 01/1999 on 4 2.5L WL-AT TPS007 TTS001 TCS032 TBS014

Econovan 1.4L 05/1984 12/1985 4 1.4L D4 TPS013 TTS015 TBS009 TRS010

Econovan 1.6L 06/1979 04/1984 4 1.6L NA TPS013 TTS002 TBS009 TRS010

Econovan 1.8L 04/1984 01/1990 4 1.8L F8 TPS013 TTS015 TBS009 TRS010

Econovan 1.8L 02/1990 05/1997 4 1.8L F8 TPS013 TTS003 TBS009 TRS010

Econovan 1.8L 03/2003 on 4 1.8L JH TPS007 TTS001 TCS045 TBS014

Econovan 2.0L 04/1984 01/1990 4 2.0L FE TPS013 TTS015 TBS009 TRS010

Econovan 2.0L 01/1990 06/1997 4 2.0L FE TPS013 TTS003 TBS009 TRS010

Econovan 2.0L, JG - Carb. 07/1997 07/1999 4 2.0L FE TPS007TPS013

TTS001 TBS014 TRS010 2 x Oil Pressure Switches, check illustrations

Econovan 2.0L, JG,JH - Carb. 07/1999 02/2003 4 2.0L FE TPS007TPS013


Econovan 2.0L, JH 2003 on 4 2.0L TPS007 TTS001 TCS045 TBS014

Econovan - Diesel 2.2L 07/1981 04/1984 4 2.2L S2 TPS013 TTS002 TBS009 TRS010

Econovan - Diesel 2.2L 04/1984 01/1990 4 2.2L R2 TPS013 TTS015 TBS009 TRS010

Econovan - Diesel 2.2L 01/1990 1997 4 2.2L R2 TPS013 TTS003 TBS009 TRS010

Escape 4D Wagon 4x4 03/2001 on V6 3.0L V6 TPS058

Escort Mk 1 1968 1975 4 ALL TPS012 TTS023 TBS022

Escort Mk 2 1976 1982 4 1.6L TPS012

Escort Mk 2 1976 1982 4 2.0L TPS012 TTS023

Explorer UN,UP (OHV) 10/1996 08/1997 V6 4.0L OHV TPS065 TCS085 TBS068 TRS055

Explorer UN,UP (OHV) 09/1997 05/1999 V6 4.0L OHV TPS065 TCS085 TBS067 TRS055

Explorer UQ,US (OHV) 06/1999 09/2001 V6 4.0L OHV TPS066 TCS085 TBS067 TRS055

Explorer UT (OHV) 10/2001 08/2004 V6 4.0L OHV TPS066 TCS112

Explorer UT (OHV) 08/2004 on V6 4.0L OHV TPS066 TCS112 TBS064

Explorer UN,UP (SOHC) 10/1996 08/1997 V6 4.0L SOHC TPS065 TCS124 TBS068 TRS055

Explorer UN,UP (SOHC) 09/1997 05/1999 V6 4.0L SOHC TPS065 TCS124 TBS067 TRS055

Ford cont.

Fiat, Ford

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

18

Explorer UQ,US (SOHC) 06/1999 09/2001 V6 4.0L SOHC TPS066 TPS124 TBS067 TRS055

Explorer UT (SOHC) 10/2001 08/2004 V8 4.6L SOHC TPS066 TRS055

Explorer UT (SOHC) 08/2004 on V8 4.6L SOHC TPS066 TBS064 TRS055

F100, F250, F350 All 6 Cyl 1970 1985 6 4.1L All TPS061 TTS023 TBS070

F100, F250, F350 All 5.8L - Carb. 1973 1985 V8 5.8L C TPS061 TTS023 TBS070

F100 All 4.9L - EFI 1985 1987 V8 4.9L W TPS061 TTS023 TCS011 TBS070

F150, F250 All 4.9L - EFI 05/1987 01/1990 V8 4.9L W TPS061 TTS023 TCS011 TBS070

F150, F250 All 4.9L - EFI 01/1990 06/1990 V8 4.9L W TPS061 TTS059 TCS011 TBS070

F150, F250, F350 All 5.8L - EFI 1991 1993 V8 5.8L W TPS065 TTS059 TCS011 TBS070

F250 4.2L Turbo Diesel 08/2001 on 6 4.2L TBS068

F250, F350 5.4L 08/2001 on V8 5.4L TTS058 TBS068 TRS055

F250, F350 7.3L Turbo Diesel 08/2001 on V8 7.3L TTS058 TCS085 TBS068 TRS055

Fairlane - 6 Cyl ZA - ZG 1967 1976 6 ALL TPS029 TTS037

Fairlane - 6 Cyl ZJ,ZK - Carb. 10/1979 03/1983 6 4.1L TPS061 TTS010

Fairlane - 6 Cyl ZJ,ZK - EFI 03/1983 09/1984 6 4.1L TPS061 TTS010

Fairlane - 6 Cyl ZL 10/1984 05/1988 6 4.1L TPS061 TTS037

Fairlane - 6 Cyl NA,NC,NF,NL 06/1988 02/1999 6 3.9L, 4.0L TPS061 TTS032 TCS011

Fairlane - 6 Cyl NU - NU II 03/1999 12/2002 6 4.0L TPS061 TBS060

Fairlane - 6 Cyl BA 06/2003 on 6 4.0L Barra-182 TPS066 TBS046

Fairlane - 8 Cyl FB,FC,FD 1959 1965 V8 ALL W TPS029

Fairlane - 8 Cyl ZA - ZG 1967 1976 V8 ALL TPS029

Fairlane - 8 Cyl ZH 05/1976 04/1979 V8 4.9L C TPS029 TTS024

Fairlane - 8 Cyl ZH 05/1976 04/1979 V8 5.8L C TPS029

Fairlane - 8 Cyl ZJ,ZK - Carb. 05/1979 03/1983 V8 4.9L, 5.8L C TPS029 TTS010

Fairlane - 8 Cyl NC 07/1991 03/1995 V8 5.0L W TPS061 TCS011

Fairlane - 8 Cyl NF,NL 03/1995 02/1999 V8 5.0L W TPS061 TCS085

Fairlane - 8 Cyl NU - NU II 03/1999 12/2002 V8 5.0L W TPS061 TCS085 TBS060

Fairlane - 8 Cyl BA 06/2003 on V8 5.4L Barra-220 TPS066 TBS046

Falcon - 6 Cyl XK,XL,XM,XP,XR,XT,XW,XY

01/1960 03/1972 6 ALL TPS029 TTS023

Falcon - 6 Cyl XA,XB,XC 03/1972 02/1979 6 ALL TPS029 TTS037

Falcon - 6 Cyl XD,XE 03/1979 09/1984 6 3.3L, 4.1L TPS061 TTS010

Falcon - 6 Cyl XF - Carb. 10/1984 02/1988 6 4.1L TPS061 TTS037 TCS040

Falcon - 6 Cyl XF - EFI 10/1984 02/1988 6 4.1L TPS061 TTS037 TCS011

Falcon - 6 Cyl EA 03/1988 09/1989 6 3.2L, 3.9L SPFI, MPFI TPS061 TTS037 TCS011

Falcon - 6 Cyl EA Series II,EB,ED 10/1989 08/1994 6 3.9L, 4.0L SPFI, MPFI TPS061 TTS032 TCS011

Falcon - 6 Cyl EF,EL 08/1994 08/1998 6 4.0L MPFI TPS061 TTS032 TCS011 TBS060TBS069

2 x Stop Light Switches, check illustrations (TBS069 models with disabled kit only)

Falcon - 6 Cyl AU (incl XR6) 08/1998 08/2002 6 4.0L All TPS061 TBS060

Ford cont.

19


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Falcon - 6 Cyl BA (incl Turbo) 09/2002 on 6 4.0L B-182,240T TPS066 TBS046

Falcon - 8 Cyl XR,XT,XW,XY,XA,XB,XC

09/1966 02/1979 V8 ALL TPS029

Falcon - 8 Cyl XD,XE 03/1979 02/1982 V8 4.9L, 5.8L C TPS029 TTS010

Falcon - 8 Cyl XE 03/1982 10/1983 V8 4.9L W TPS061 TTS010

Falcon - 8 Cyl EB Ser.II, ED 04/1992 08/1993 V8 5.0L W TPS061 TCS085

Falcon - 8 Cyl EF,EL 08/1994 08/1998 V8 5.0L W TPS061 TCS085 TBS060

Falcon - 8 Cyl AU (incl XR8) 08/1998 08/2002 V8 5.0L All TPS061 TCS085 TBS060

Falcon - 8 Cyl BA (incl XR8 ,GT,GT-P) 09/2002 on V8 5.4L All TPS066 TBS046

Falcon - Ute, 6 Cyl XF - Carb. 02/1988 02/1990 6 4.1L TPS061 TTS037 TCS040

Falcon - Ute, 6 Cyl XF - Carb. 02/1990 12/1990 6 4.1L TPS061 TTS032 TCS040

Falcon - Ute/Van, 6 Cyl

XF - Carb & EFI 01/1991 03/1993 6 4.1L TPS061 TTS032 TCS011


XG 03/1993 03/1996 6 4.0L TPS061 TTS032 TCS085


XH 03/1996 12/1998 6 4.0L TPS061 TCS011 TBS060

Falcon - Ute, 6 Cyl AU (incl XR6) 06/1999 08/2002 6 4.0L TPS061 TBS060

Falcon - Ute, 6 Cyl BA Tornado 12/2004 on 6 4.0L F6 270T TBS046

Falcon - Ute, 6 Cyl BA RTV 09/2003 on 6 4.0L Barra 182 TPS066 TBS046

Falcon - Ute, 8 Cyl XH 10/1997 05/1999 V8 5.0L TPS061 TCS085 TBS060

Falcon - Ute, 8 Cyl AU (incl XR8) 06/1999 08/2002 V8 5.0L TPS061 TCS085 TBS060

Falcon - Ute, 8 Cyl BA Pursuit & RTV 09/2003 on V8 5.4L Barra-220,Boss-290

TPS066 TBS046

Festiva WA 10/1991 01/1993 4 1.3L B3 TPS006 TFS136 TBS009

Festiva WA 02/1993 03/1994 4 1.3L B3 TPS006 TFS204 TBS009

Festiva WB,WD - EFI (Kia) 04/1994 12/1997 4 1.3L B3 TPS008 TTS001 TCS032 TBS014 2 x Oil Pressure Switches, check illustrations

Festiva WB,WD - EFI (Mazda) 04/1994 12/1997 4 1.3L B3 TPS008 TCS032 TBS014 TRS051 2 x Oil Pressure Switches & 2 x Rev Light Switches, check illustrations

Festiva WF - EFI (Kia) 04/1994 12/2002 4 1.3L B3 TPS008 TTS001 TCS024TCS032

TBS014 2 x Oil Pressure Switches & 2 x Coolant Sensors, check illustrations

Festiva WF - EFI (Mazda) 01/1998 12/2002 4 1.3L B3 TPS008 TCS024TCS032


Festiva WD,WF - 1.5L (Kia) 02/1997 12/2002 4 1.5L B5 TPS008 TCS024TCS124

TBS014 For correct application, check illustrations and spec tables

Festiva WD,WF - 1.5L (Mazda) 02/1997 12/2002 4 1.5L B5 TPS008 TCS024TCS124


Fiesta LX, Zetc, Ghia 02/2004 on 4 1.6L, 2.0L TPS012 TBS046 TRS047 2 x Stop Light Switches, check illustrations

Focus LR 09/2002 01/2005 4 1.8L TPS057 TCS121 TFS222 TBS046 TRS047

Focus LR (inc ST170) 09/2002 01/2005 4 2.0L TPS057 TCS112TCS121


Ford cont.

Ford

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

20

KA 11/1999 03/2004 4 1.3L XJ TPS012 TCS085 TBS047 TRS047

Laser KA,KB (incl Turbo) 03/1981 09/1985 4 1.3L, 1.5L E3,E5 TPS013 TTS015 TFS115 TBS009 TFS115 (In Therm Housing )

Laser KC, 1.3L - Carb. 10/1985 09/1987 4 1.3L E3 TPS013 TTS015 TFS136 TBS009 TRS012 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing and Radiator only)

Laser KC, 1.6L - Carb. 10/1985 02/1990 4 1.6L B6 TPS006 TTS015 TFS136 TBS009 TRS011 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

Laser KC, 1.6L - EFI 10/1985 12/1985 4 1.6L B6 TPS013 TTS015 TCS024 TFS136 TBS009 TRS012 TFS136 (Located in Therm Housing)

Laser KC, 1.6L - EFI 12/1985 09/1987 4 1.6L B6 TPS013 TTS015 TCS024 TFS136 TBS009 TRS011 TFS136 (Located in Therm Housing)

Laser KC, 1.6L - Turbo 10/1985 09/1987 4 1.6L B6T DOHC TPS013 TTS015 TFS136 TBS009 TRS042 TFS136 (Located in Therm Housing)

Laser KE, 1.3L - Carb. 10/1987 02/1990 4 1.3L B3,E3 TPS013 TTS015 TFS136 TBS009 TRS012 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing and Radiator only)

Laser KE, 1.6L - Carb. 10/1987 04/1989 4 1.6L B6 TPS006 TTS015 TFS136 TBS009 TRS011 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

Laser KE, 1.6L - Carb. 04/1989 02/1990 4 1.6L B6 TPS006 TTS003 TFS136 TBS009 TRS011 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

Laser KE, 1.6L - EFI 10/1987 04/1989 4 1.6L B6 TPS006 TTS015 TCS024 TFS136TFS181

TBS009 TRS011 Many Thermo Fan Switches applications, (TFS136 in Therm Housing only all models and TFS181 in manifold on A/T models)

Laser KE, 1.6L - EFI 04/1989 04/1990 4 1.6L B6 TPS006 TTS003 TCS024 TFS136TFS181


Laser KE, 1.6L - EFI Turbo 10/1987 09/1988 4 1.6L B6 TPS013 TTS015 TCS024 TFS136 TBS009 TRS042 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

Laser KE, 1.6L - EFI Turbo 09/1988 04/1990 4 1.6L B6 TPS013 TTS003 TCS024 TFS136 TBS009 TRS042 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

Laser KE, TX3 Efi 16V (4x4 Turbo)

10/1987 09/1988 4 1.6L B6 TPS013 TTS015 TCS024 TFS136TFS192

TBS009 Many Thermo Fan Switches applications, (TFS136 in Therm Housing, TFS192 in Radiator)

Laser KE, TX3 Efi 16V (4x4 Turbo)

09/1988 04/1990 4 1.6L B6 TPS013 TTS003 TCS024 TFS136TFS192


Laser KF, 1.6L - Carb. 03/1990 09/1991 4 1.6L B6 TPS007 TTS001 TFS114 TBS009 TRS037 TFS114 (Located in Therm Housing)

Laser KF, 1.8L - EFI 03/1990 09/1991 4 1.8L BP TPS007 TTS001 TCS024 TFS114TFS193


Laser KF, 1.8L - EFI (16V) 03/1990 09/1991 4 1.8L BPE TPS007 TTS001 TCS024 TFS114TFS113TFS193

TBS009 TRS012TRS037

Many Thermo Fan Switches applications, (TFS113 or TFS114 in Therm Housing, TFS193 in Radiator)2 x Rev Light Switches, check illustrations

Laser KF, 1.8L - EFI Turbo 03/1990 09/1991 4 1.8L BPD TPS007TPS008

TTS001 TCS024 TBS009 TRS037TRS052

2 x Oil Pressure Switches & 2 x Rev Light Switches, check illustrations

Laser KH, 1.6L - EFI 10/1991 10/1994 4 1.6L B6 TPS007 TTS001 TFS114 TBS009 TRS037 TFS114 located in Therm housing

Ford cont.

21


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Laser KH, 1.8L - EFI 10/1991 10/1994 4 1.8L BP TPS007 TTS001 TCS024 TFS114TFS193

TBS009 TRS037 Many Thermo Fan Switches applications, ( TFS114 in Therm Housing, TFS193 in Radiator )

Laser KH, 1.8L - EFI (16V) 10/1991 10/1994 4 1.8L BPE TPS007 TTS001 TCS024 TFS114TFS193

TBS009 TRS012TRS037

Many Thermo Fan Switches applications, ( TFS114 in Therm Housing, TFS193 in Radiator )2 x Rev Light Switches, check illustrations

Laser KH, 1.8L - EFI Turbo 10/1991 07/1993 4 1.8L BPD TPS006TPS008

TTS001 TCS024 TFS113TFS193

TBS009 TRS037TRS052

Many Thermo Fan Switches applications, (TFS113 in Therm Housing, TFS193 in Radiator)2 x Rev Light Switches, check illustrations

Laser KJ, 1.6L - EFI 10/1994 12/1996 4 1.6L B6 D-tech TPS007 TTS001 TCS032 TBS057 TRS037 TCS032 located in cylinder head

Laser KJ, 1.6L - EFI 12/1996 11/1998 4 1.6L B6 D-tech TPS007 TCS125 TBS009 TRS012TRS037

TCS125 located in Therm Housing2 x Rev Light Switches, check illustrations

Laser KJ, 1.8L EFI 10/1994 12/1996 4 1.8L BP TPS007 TTS001 TCS032 TBS057 TRS037 TCS032 located in cylinder head

Laser KJ, 1.8L EFI 12/1996 11/1998 4 1.8L BP, BPE TPS007 TCS125 TBS009 TRS012TRS037

TCS125 located in Therm Housing2 x Rev Light Switches, check illustrations

Laser KN 11/1998 06/1999 4 1.6L, 1.8L ZM,FZP TPS007 TCS125 TBS014 TRS059

Laser KN 07/1999 03/2001 4 1.6L, 1.8L ZM,FZP TPS007 TCS032 TBS014 TRS059

Laser KQ 04/2001 09/2002 4 1.6L, 1.8L ZM, FP TPS007 TCS032 TBS014 TRS059

Laser KQ 04/2001 09/2002 4 2.0L FP TPS007 TCS032 TBS014

LTD - 6 Cyl FC,FD 10/1979 09/1984 6 4.1L TPS061 TTS010

LTD - 6 Cyl FE 10/1984 05/1988 6 4.1L TPS061 TTS037 TCS040

LTD - 6 Cyl DA 06/1988 06/1991 6 3.9L TCS011

LTD - 6 Cyl DC,DF 07/1991 06/1999 6 3.9L, 4.0L TTS032 TCS011

LTD - 6 Cyl DL 07/1991 06/1999 6 3.9L, 4.0L TCS011

LTD - 6 Cyl AU 06/1999 06/2003 6 4.0L TPS061 TBS060

LTD - 8 Cyl FC,FD 10/1979 03/1983 V8 4.9L,5.8L C TPS029 TTS010

LTD - 8 Cyl DC,DF,DL 07/1991 06/1999 V8 5.0L W TCS011

LTD - 8 Cyl AU 06/1999 06/2003 V8 5.0L W TPS061 TCS085 TBS060

LTD - 8 Cyl BA 07/2003 on V8 5.4L Barra 220 TPS066

Maverick Petrol 02/1988 09/1993 6 4.2L TB42E TPS017 TTS036 TCS127 TFS188 TBS007 TRS039

Maverick Diesel 02/1988 09/1993 6 4.2L TD42 TPS017 TFS188

Meteor GA,GB, 1.5L - Carb. 04/1982 09/1985 4 1.5L E5 TPS013 TTS015 TFS115 TBS009

Meteor GC, 1.6L - Carb. 10/1985 09/1987 4 1.6L B6 TPS006 TTS015 TFS136 TBS009 TRS011 2 x Thermo Fan Switches, TFS136 located in cylinder head

Meteor GC, 1.6L - EFI 10/1985 09/1987 4 1.6L B6 TPS013 TTS015 TCS024 TFS136 TBS009 TRS012TRS011

2 x Thermo Fan Switches, TFS136 located in cylinder head2 x Rev Light Switches, check illustrations

Mondeo HA,HB 07/1995 1996 4 2.0L SD/ZH20 TPS012 TCS011TCS085


Mondeo HC 10/1996 1998 4 2.0L SD/ZH20 TPS012 TCS085 TBS046

Ford cont.

Ford

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

22

Mondeo HD 10/1998 2000 4 2.0L SD/ZH20 TPS057 TCS124 TBS046

Mondeo HE 02/2000 12/2000 4 2.0L SD/ZH20 TPS057 TCS112 TBS046

Mondeo HE ST24 02/2000 12/2000 V6 2.5L KL TPS057 TBS046

Mustang Coupe & Convert 02/2001 on V8 4.6L TCS085 TBS060

Probe ST,SU,SV 07/1994 01/1998 V6 2.5L KL TPS007 TTS001 TCS032 TBS058 2 x Stop Light Switches, check illustrations

Raider UV 08/1991 1996 4 2.6L G6 TPS007 TTS017 TCS045 TBS010

Spectron 05/1984 12/1986 4 1.8L F8 TPS012 TTS017 TBS010

Spectron 1986 1990 4 2.0L FE TPS012 TTS015 TBS010

Taurus DN,DP 03/1996 09/1998 V6 3.0L TA TPS012 TTS059 TCS085 TBS058

Telstar AR 05/1983 08/1985 4 2.0L FE TPS013 TTS015 TFS115 TBS009 TRS011 Many Thermo Fan Switch applications TFS115 located in Therm Housing

Telstar AS 09/1985 11/1987 4 2.0L FE TPS013 TTS015 TFS115 TBS009 TRS011TRS050

Many Thermo Fan Switch applications TFS115 located in Therm Housing2 x Rev Light Switches, check illustrations

Telstar AS, EFI - Turbo 01/1986 09/1987 4 2.0L FE TPS013 TTS015 TCS024 TFS136 TBS009 Many Thermo Fan Switch applications TFS136 located in Therm Housing

Telstar AT 10/1987 10/1988 4 2.0L FE TPS013 TTS015 TFS136 TBS009 TRS011 Many Thermo Fan Switch applications TFS136 located in Therm Housing

Telstar AT 10/1988 12/1989 4 2.0L FE TPS013 TTS003 TFS136 TBS009 TRS011 Many Thermo Fan Switch applications TFS136 located in Therm Housing

Telstar AT Auto 10/1987 12/1989 4 2.2L F2 TPS013 TTS003TTS015

TFS181 TBS009 TRS011 2 x Water Temp Senders, check illustrations

Telstar AT, 2.2L - EFI 10/1987 12/1989 4 2.2L F2 TPS013 TTS003TTS015

TCS024 TFS115 TBS009 TRS011 Many Thermo Fan Switch applications TFS115 located in Therm Housing

Telstar AT, EFI - Turbo 10/1987 10/1988 4 2.2L F2 TPS013 TTS015 TCS024 TFS115 TBS009 Many Thermo Fan Switch applications TFS115 located in Therm Housing

Telstar AT, EFI - Turbo 10/1988 12/1989 4 2.2L F2 TPS013 TTS003 TCS024 TFS115 TBS009 Many Thermo Fan Switch applications TFS115 located in Therm Housing

Telstar AT, EFI - Turbo (Auto) 10/1987 10/1988 4 2.2L F2 TPS013 TTS015 TFS137TFS181


Telstar AT, EFI - Turbo (Auto) 10/1988 12/1989 4 2.2L F2 TPS013 TTS003 TFS137TFS181


Telstar AV 12/1989 01/1992 4 2.2L F2 TPS007 TTS001 TFS113 TBS014 TRS011 Many Thermo Fan Switch applications TFS113 located in Therm Housing

Telstar AV Auto 12/1989 01/1992 4 2.2L F2 TPS007 TTS001 TFS181 TBS014 TRS011

Telstar AV, EFI 01/1990 01/1992 4 2.2L F2 TPS007 TTS001 TCS024 TBS014 TRS011

Telstar AV, EFI - Turbo 12/1989 01/1992 4 2.2L F2 TPS007 TTS001 TCS024 TFS115 TBS014 Many Thermo Fan Switch applications TFS115 located in Therm Housing

Telstar AV, EFI - Turbo (Auto) 12/1989 01/1992 4 2.2L F2 TPS007 TTS001 TCS024 TFS137TFS181


Ford cont.

23


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Telstar AX,AY 01/1992 11/1996 4 2.0L FS TPS007 TTS015 TCS032 TBS014

Telstar AX,AY 01/1992 11/1996 V6 2.5L KL TPS007 TTS001 TCS032 TBS014 TRS011

Territory TX,Ghia (4x2, 4x4) 04/2004 on 6 4.0L Barra 182 TPS066 TBS046

Trader 0409, 0509 1979 1984 4 2.0L,3.0L Petrol TPS013 TTS002 TBS008

Trader 0409, 0509 1984 1989 4 3.5L SL TPS006TPS013


Trader 0409, 0509 1989 1995 4 3.5L SL TPS006TPS013


Trader 0509 - (Diesel) 1995 1998 4 4.0L TF TPS006 TTS001 TBS009

Trader 0711, 0811 - (Diesel) 1981 1995 4 4.1L ZB TPS013 TTS002 TBS009

Trader 0811 - (Diesel) 1989 1998 4 4.0L TF TPS006TPS013


Trader 0812 - (Turbo Diesel) 1987 1989 4 3.5L SL-T TPS013 TTS015 TBS009

Trader 0812 - (Turbo Diesel) 1989 1992 4 3.5L SL-T TPS013 TTS001 TBS009

Transit 1973 1981 6 4.1L TPS029 TTS037

Transit VE - (Diesel) 06/1994 05/1996 4 2.5L 4DA TPS027 TTS044 TCS011 TBS026 TRS038

Transit VF,VG 01/1996 01/2001 4 2.0L NSJ TPS012 TCS011TCS085

TBS026 TRS038 2 x Coolant Sensors, check illustrations

Transit VF,VG- (Turbo Diesel) 01/1996 01/2001 4 2.5L TPS027 TTS044 TCS011TCS085


Transit VH 01/2001 on 4 2.3L TPS012 TCS085 TBS026

Holden

Apollo JK - Carb. 08/1989 06/1991 4 2.0L 3S-FC TPS008 TTS001 TFS120 TBS014 TRS007

Apollo JK,JL 05/1991 02/1993 4 2.0L 3S-FE TPS008 TTS001 TCS032 TFS120 TBS014 TRS007

Apollo JM 03/1993 08/1995 4 2.2L 5S-FE TPS011 TTS007 TCS032 TFS120 TBS005 TRS007

Apollo JM 03/1993 08/1995 V6 3.0L 3VZ-FE TPS011 TTS001 TCS032 TFS119 TBS005

Apollo JP 09/1995 05/1997 4 2.2L 5S-FE TPS011 TTS007 TCS032 TFS119 TBS005TBS018

TRS007 2 x Stop Light Switches TBS005 (without cruise control), TBS018 (with cruise control) check illustrations

Apollo JP 09/1995 05/1997 V6 3.0L 3VZ-FE TPS011 TTS001 TCS032 TFS119 TBS005TBS018

2 x Stop Light Switches TBS005 (without cruise control), TBS018 (with cruise control) check illustrations

Astra LB,LC 08/1984 07/1987 4 1.5L,1.6L E15, E16 TPS014 TFS121 TBS007

Astra LD 07/1987 07/1989 4 1.6L,1.8L 16LF,18LE TTS052 TCS040 TBS007 TRS020

Astra TR 09/1996 09/1998 4 1.6L C16SE TPS038 TTS052 TCS040 TFS164TFS165TFS223

TBS027 TRS026 3 x Thermo Fan Switches, check illustrations and Temp ranges

Astra TR 09/1996 09/1998 4 1.8L, 2.0L C18SELX20XEV

TPS038 TTS052 TCS094 TFS162TFS186TFS221TFS224


Ford cont.

Ford, Holden

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

24

Astra TS 09/1998 07/2004 4 1.8L X18XE TPS038 TCS106 TBS027TBS052TBS053


Astra TS02 10/2001 07/2004 4 2.2L Z22SE TCS090 TBS027TBS052TBS053


Astra TS02 (Turbo) 05/2003 07/2004 4 2.0L Z20LET TCS102 TBS027TBS052TBS053


Astra AH 11/2004 on 4 1.8L Z18XE TPS038 TCS106

Barina MB,ML 02/1985 1988 4 1.3L G13A TPS013 TTS004 TFS116 TBS012

Barina MF 01/1989 09/1991 4 1.3L G13B TPS013 TTS004 TFS220 TBS012 TRS003

Barina MH 10/1991 05/1994 4 1.3L G13B TPS013 TTS001 TFS220TFS225


Barina SB 04/1994 07/1997 4 1.2L C12NZ TPS038 TTS022 TCS040 TFS161TFS162


Barina SB - (incl Combo) 04/1994 11/2000 4 1.4L C14NZC14SE

TPS038 TTS022 TCS040 TFS161TFS162


Barina SB - Gsi 04/1994 09/1998 4 1.6L X16XEC16XE



Barina XC - (incl Combo) 04/2001 on 4 1.4L Z14XE (P) TPS038 TCS102 TBS055 TRS026

Barina XC - Combo 04/2001 on 4 1.6L Z16SE TPS038 TBS055 TRS026

Barina XC - Sri 04/2001 on 4 1.8L X18XE TPS038 TCS106 TBS055 TRS026

Barina XC - Combo 04/2001 on 4 1.8L Z18XE TPS038 TBS055 TRS026

Calibra YE 10/1991 07/1995 4 2.0L C20NEC20XE

TPS038 TTS047 TCS040 TFS164TFS186TFS221

TBS027TBS036TBS043

TRS026 3 x Stop Light Switches & 3 x Thermo Fan Switches, check illustrations

Calibra YE - Turbo 06/1994 07/1995 4 2.0L C20LET TPS038 TTS047 TCS040 TFS186TFS215TFS221

TBS027TBS036TBS043

TRS026 3 x Stop Light Switches & 3 x Thermo Fan Switches, check illustrations

Calibra YE95 - Turbo 08/1995 07/1998 4 2.0L C20LET TPS038 TTS047 TCS040 TFS186 TBS027TBS036


Calibra YE95 - Ecotec 08/1995 07/1998 4 2.0L X20XEV TPS038 TTS047 TCS040 TFS186 TBS027TBS036TBS043


Calibra YE95 08/1995 07/1998 V6 2.5L C25XE TTS022 TCS040 TFS215 TBS027TBS036TBS043


Camira JB,JD,JE 08/1982 08/1989 4 1.6L,1.8L2.0L

TPS024 TCS040 TFS108 TRS022

Commodore - 4 Cyl VC,VH 1980 1981 4 1.9L VN TPS029 TTS063 TBS037 TRS022 Rev Light Switch models with MC6 4sp torquemaster g/box only

Commodore - 6 Cyl VB 1978 1980 6 2.8L, 3.3L VD, VL TPS029 TTS063 TBS037TBS061

TRS022 2 x Stop Light Switches, check illustrationsRev Light Switch models with MC6 4sp torquemaster g/box only

Holden cont.

25


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Commodore - 6 Cyl VC 1980 1981 6 2.8L, 3.3L VD, VL TPS029 TTS060 TBS037TBS061


Commodore - 6 Cyl VH 1981 1984 6 2.8L, 3.3L VD, VL TPS029 TTS062 TBS037TBS061


Commodore - 6 Cyl VK - EFI, EST 03/1984 02/1986 6 3.3L TPS029 TTS062 TCS040 TBS037TBS061


Commodore - 6 Cyl VL - (incl Turbo) 03/1986 08/1988 6 3.0L RB30E(T) TPS017TPS064

TTS021 TCS127 TBS037TBS061


Commodore - 6 Cyl VN,VP,VR 08/1988 04/1995 V6 3.8L LG2 VH TPS064 TTS062 TCS040 TBS037TBS061


Commodore - 6 Cyl VS 04/1995 08/1997 V6 3.8L LG2 VH TPS064 TTS064 TCS070 TBS037TBS061


Commodore - 6 Cyl VS - Supercharged 04/1995 08/1997 V6 3.8L L67 TPS064 TTS062 TCS070 TBS037TBS061


Commodore - 6 Cyl VT 09/1997 10/2000 V6 3.8L LG2 VH TPS064 TTS062 TCS070 TBS037TBS061


Commodore - 6 Cyl VT - Supercharged 09/1997 10/2000 V6 3.8L L67 TPS064 TTS062 TCS070 TBS037TBS061


Commodore - 6 Cyl VX,VY - (incl Super-charged)

10/2000 07/2004 V6 3.8L LN3 VH,L67 TPS064 TCS070 TBS037TBS061


Commodore - 6 Cyl VZ 08/2004 on V6 3.6L LE0,LY7 TBS065

Commodore - 8 Cyl VB 1978 1980 V8 4.2L, 5.0L VR, VT TPS029 TTS062 TBS037TBS061


Commodore - 8 Cyl VC,VH 1980 1984 V8 4.2L, 5.0L TPS029 TTS062 TBS037TBS061


Commodore - 8 Cyl VK 03/1984 02/1986 V8 5.0L TPS029 TTS062 TBS037TBS061


Commodore - 8 Cyl VL 10/1986 08/1988 V8 5.0L VJ TPS029 TTS062 TCS040 TBS037TBS061


Commodore - 8 Cyl VL - SS Group A 03/1988 03/1989 V8 5.0L VP TPS064 TTS062 TBS037TBS061


Commodore - 8 Cyl VN,VP,VR,VS 03/1989 08/1997 V8 5.0L LB9 VU TPS064 TTS062 TCS040 TBS037TBS061


Commodore - 8 Cyl VR,VS,VT 09/1994 2000 V8 5.7L L98 TPS064 TTS062 TCS040 TBS037TBS061


Commodore - 8 Cyl VT 09/1997 06/1999 V8 5.0L LB9 VM TPS064 TTS062 TCS040 TBS037TBS061


Commodore - 8 Cyl VT GTS 06/1999 07/2004 V8 5.7L L98 TTS062 TCS040 TBS037TBS061


Holden cont.

Holden

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

26

Commodore - 8 Cyl VT,VX,VY 06/1999 07/2004 V8 5.7L LS1 GenIII TCS090 TBS037TBS061

TRS056 2 x Stop Light Switches, check illustrations, TBS037 without cruise control, TBS061 with cruise control

Commodore - 8 Cyl VZ 08/2004 on V8 5.7L LS1 GenIII TCS090 TBS065 TRS056

Commodore - 8 Cyl VZ 08/2004 on V8 6.0L LS2 Gen IV TCS090 TBS065

Commodore Ute VG 08/1988 04/1995 V6, V8

3.8L, 5.0L LG2, LB9 TPS064 TTS062 TCS040 TBS037TBS061


Commodore Ute VS 04/1995 01/2000 V6 3.8L LG2 VH TPS064 TTS064 TCS070 TBS037TBS061


Commodore Ute VS 04/1995 01/2000 V8 5.0L LB9 VU TPS064 TTS062 TCS040 TBS037TBS061


Commodore Ute VU,VY 01/2001 07/2004 V6 3.8L LN3 VH TPS064 TCS070 TBS037TBS061


Commodore Ute VU,VY 01/2001 07/2004 V8 5.7L LS1 GenIII TCS090 TBS037TBS061


Commodore Ute VZ 08/2004 on V6 3.6L LE0 175 TBS065

Commodore Ute VZ 08/2004 on V8 5.7L LS1 GenIII TCS090 TBS065 TRS056

Crewman VY 08/2003 07/2004 V6 3.8L LN3 VH TPS064 TCS070 TBS037TBS061


Crewman VY SS & Cross8 08/2003 07/2004 V8 5.7L LS1 GenIII TCS090 TBS037TBS061


Crewman VZ 08/2004 on V6 3.6L LE0 175 TBS065

Crewman VZ SS & Cross8 08/2004 on V8 5.7L LS1 GenIII TCS090 TBS065 TRS056

Drover QB 03/1985 12/1987 4 1.3L G13A TPS007 TTS004 TBS010 TRS001

FJ to EJ 1953 1963 6 ALL Grey TPS029 TTS033

EH to WB 1963 1985 6 ALL Red TPS029 TTS033

HK to WB 1968 1985 V8 ALL ALL TPS029 TTS033

Frontera UED55 (UT) 10/1995 03/1999 4 2.0L X20SE TCS040 TFS163 TBS027 TRS028

Frontera UES30 02/1998 01/2004 4 2.2L X22SE TPS038 TTS052 TCS090 TBS016 TRS028

Frontera UES25 02/1998 01/2004 V6 3.2L 6VD1 TPS014 TTS004 TCS070 TBS016 TRS028

Gemini TX,TC,TE,TF,TG (incl Diesel)

03/1977 05/1985 4 1.6L,1.8L-D

G161Z,4FB1 TPS006 TBS010

Gemini RB 05/1984 06/1987 4 1.5L 4XC1 TPS014 TBS007

Jackaroo - Petrol UBS81 11/1981 07/1985 4 2.0L G200Z TRS028

Jackaroo - Petrol UBS16 08/1985 12/1988 4 2.3L 4ZD1 TPS006 TTS004 TCS070 TBS007TBS016

TRS028 2 x Stop Light Switches TBS007 without cruise control, TBS016 with cruise control.

Jackaroo - Petrol UBS17 - EFI 07/1988 03/1992 4 2.6L 4ZE1 TPS006TPS016


TRS028 2 x Oil Pressure Switches, check illustrations2 x Stop Light Switches TBS007 without cruise control, TBS016 with cruise control.

Holden cont.

27


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Jackaroo - Petrol UBS17 - Carb. 01/1990 1991 4 2.6L 4ZE1 TPS006TPS016

TTS004 TBS007TBS016

TRS028 2 x Oil Pressure Switches, check illustrations2 x Stop Light Switches TBS007 without cruise control, TBS016 with cruise control.

Jackaroo - Petrol UBS25 L2 - EFI 04/1992 02/1998 V6 3.2L 6VD1 TPS014 TTS004 TCS070 TBS007TBS016


Jackaroo - Petrol UBS26 L8 - EFI 02/1998 09/2004 V6 3.5L 6VE1 TPS014 TTS004 TCS070 TBS007 2 x Stop Light Switches TBS007 without cruise control

Jackaroo - Diesel UBS81 11/1981 07/1985 4 2.2L C223 TPS006 TRS028

Jackaroo - Turbo Diesel

UBS521 01/1984 12/1988 4 2.2L C223T TPS006 TBS007TBS016



UBS55 07/1988 03/1992 4 2.8L 4JB1T TPS006 TTS014 TBS007TBS016



UBS69 L2 04/1992 02/1998 4 3.1L 4JG2 TPS006 TTS014 TBS007 TRS028


UBS73 L8 03/1998 09/2004 4 3.0L 4JX1 TPS006 TTS014 TBS007 2 x Stop Light Switches TBS007 without cruise control

Monaro VX,VY - CV6 Supercharged

12/2001 08/2004 V6 3.8L L67 VH TPS064 TCS070 TBS037TBS061

2 x Stop Light Switches, TBS037 without cruise control, TBS061 with cruise control

Monaro VX,VY - CV8 & GTO 12/2001 08/2004 V8 5.7L LS1 GenIII TCS090 TBS037TBS061


Monaro VX,VY - GTS 12/2001 08/2004 V8 5.7L C4B TCS090 TBS037TBS061

2 x Stop Light Switches, check illustrations, TBS037 without cruise control, TBS061 with cruise control

Monaro VZ 09/2004 on V8 5.7L LS1 ,C4B TCS090 TBS065 TRS056

Nova LE 08/1989 08/1991 4 1.4L, 1.6L 6AFC,4AFC TPS006 TTS001 TFS120 TBS009 TRS007

Nova LF 09/1991 10/1994 4 1.4L, 1.6L 6AFC,4AFC TPS006 TTS008 TFS150 TBS009 TRS007

Nova LF - EFI 09/1991 10/1994 4 1.6L 4A-FE TPS006 TTS008 TCS032 TFS150 TBS009 TRS007

Nova LF - EFI 09/1991 10/1994 4 1.8L 7A-FE TPS011 TTS008 TCS032 TFS150 TBS009 TRS007

Nova LG - EFI 10/1994 04/1997 4 1.6L, 1.8L 4AFE,7AFE TPS011 TTS008 TCS032 TFS191 TBS005 TRS007

Piazza YB - Turbo 1986 11/1987 4 2.0L 4ZC1 TCS040 TFS117 TBS016 TRS028

Rodeo - Petrol RWD,4WD - KB25,26,40,41

01/1978 12/1982 4 1.6L G161Z TPS006 TTS022 TRS028

Rodeo - Petrol RWD,4WD - KB27,42 01/1983 12/1983 4 1.8L 4ZB1 TPS006 TTS017 TBS007 TRS028

Rodeo - Petrol 4WD - KB47,48 01/1983 12/1984 4 1.8L G180Z TPS006 TTS001

Rodeo - Petrol RWD,4WD - KB28,43

01/1983 03/1987 4 1.9L G200Z TPS006 TTS017 TBS007 TRS028

Rodeo - Petrol RWD,4WD - KB28,29,43,49

1985 06/1988 4 2.3L 4ZD1 TPS006 TBS007 TRS028

Rodeo - Petrol 4WD - KB43,49 1985 06/1988 4 2.3L HZA1 TPS006 TTS004 TBS007 TRS028

Rodeo - Petrol RWD,4WD - TFR54,TFS54

06/1988 01/1993 4 2.5L 4JA1 TPS006 TTS014 TBS007 TRS028

Holden cont.

Holden

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

28

Rodeo - Petrol RWD,4WD - TFR17,TFS17 (EFI)

07/1988 1997 4 2.6L 4ZE1 TPS016 TTS004 TCS040 TBS007 TRS028

Rodeo - Petrol RWD - TFR25 03/1998 06/1998 4 2.3L 4ZD1 TPS006 TTS004 TBS007 TRS028


03/1998 06/1998 4 2.6L 4ZE1 TTS004 TCS040 TBS007 TRS028

Rodeo - Petrol RWD - TFR26 07/1998 2003 4 2.2L C22NE TPS038 TTS061 TCS070 TBS007 TRS028


06/1998 2003 V6 3.2L 6VD1 TPS014 TTS004 TCS070 TBS007 TRS028

Rodeo - Petrol RA03 - DX 02/2003 on 4 2.4L C24SE TPS038 TTS061 TCS070 TRS028

Rodeo - Petrol RA03 - DX, LX & LT 02/2003 on V6 3.5L 6VE1 TPS014 TTS004 TCS070 TRS028

Rodeo - Diesel ALL - 2.0L Diesel 01/1979 12/1982 4 2.0L C190 TPS006 TTS022 TBS007 TRS028

Rodeo - Diesel KBD27,28 01/1983 06/1988 4 2.2L C223 TPS006 TTS033

Rodeo - Diesel KBD42,43,47 01/1983 06/1988 4 2.2L C223 TPS006 TTS001

Rodeo - Diesel ALL - 2.8L Turbo Diesel 01/1991 12/2001 4 2.8L 4JB1T TPS006 TTS014 TBS007 TRS028

Rodeo - Diesel TFR6-R9 2001 01/2003 4 3.0L 4JH1T TTS014 TBS016 TRS028

Rodeo - Diesel RA03 02/2003 on 4 3.0L 4JH1TC TPS006 TTS014 TRS028

Scurry NB 07/1985 12/1987 4 970cc F10A TPS007 TTS004 TBS010 TRS001

Shuttle WFR - incl Diesel 03/1982 11/1988 4 1.8L, 2.0L 4ZB,C, 4FC TTS014 TBS007 TRS028

Shuttle WFR 12/1988 1990 4 2.0L 4ZC1 TTS014 TRS028

Statesman HQ,HJ,HX,HZ 1971 1980 6, V8 ALL TPS029 TTS033

Statesman WB 1980 1985 V8 WT 5.0L TPS033 TTS033

Statesman - 6 Cyl VQ Series.II 11/1991 02/1994 V6 3.8L LG2 VH TPS064 TTS052 TCS040 TBS061

Statesman - 6 Cyl VR 03/1994 04/1995 V6 3.8L LG2 VH TPS064 TTS062 TCS040 TBS037TBS061


Statesman - 6 Cyl VS 04/1995 06/1999 V6 3.8L LG2 VH TPS064 TTS064 TCS070 TBS037TBS061


Statesman - 6 Cyl VS Series.II - Supercharged

10/1996 06/1999 V6 3.8L L67 VH TPS064 TTS062 TCS070 TBS037TBS061


Statesman - 6 Cyl WH,WK - incl Supercharged

06/1999 07/2004 V6 3.8L LN3,L67 VH TPS064 TCS070 TBS037TBS061


Statesman - 6 Cyl WL 08/2004 on V6 3.6L LY7 190 TBS065

Statesman - 8 Cyl VQ 03/1990 02/1994 V8 5.0L LB9 VU TPS064 TTS052 TCS040 TBS061

Statesman - 8 Cyl VR,VS 03/1994 06/1999 V8 5.0L LB9 VU TPS064 TTS062 TCS040 TBS037TBS061


Statesman - 8 Cyl VR,VS - HSV 09/1994 09/1996 V8 5.7L L98 VU TPS064 TTS062 TCS040 TBS037TBS061


Holden cont.

29


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Statesman - 8 Cyl WH,WK 06/1999 07/2004 V8 5.7L LS1 GenIII TCS090 TBS037TBS061


Statesman - 8 Cyl WL 08/2004 on V8 5.7L LS1 GenIII TCS090 TBS065

Statesman - 8 Cyl WL 08/2004 on V8 6.0L LS2 Gen IV TCS090 TBS065

Suburban K8 1500,2500 4D Wagon 02/1998 07/2002 V8 5.7L, 6.5L L31,L65 TCS070

Sunbird LX,UC 1976 1980 4 1.9L Opel,Sfi re TPS029 TTS022

Torana LH,LX 1974 1976 4 1.9L 19S OPEL TPS024 TTS025

Torana LC,LH,LJ,LX,UC 1969 1979 6 ALL TPS029 TTS033

Torana LH,LX 1974 1978 V8 ALL TPS029 TTS033

Vectra JR 06/1997 1998 4 2.0L C20SEL TPS038 TTS052 TCS094 TFS166 TBS027 TRS026

Vectra JR 06/1997 08/1999 V6 2.5L X25XE TPS038 TTS022 TCS040TCS102


Vectra JS 08/1998 12/2002 4 2.0L,2.2L C20SELC22SEL

TPS038 TTS052 TBS027TBS052TBS059


Vectra JS 08/1999 12/2002 V6 2.5L X25XE TPS038 TTS022 TCS102 TBS027TBS052TBS059


Vectra JS 11/2000 12/2001 V6 2.6L Y26SE TPS038 TTS022 TCS102 TBS027TBS052TBS059


Vectra ZC 03/2003 on 4 2.2L Z22SE TCS090

Vectra ZC 03/2003 on V6 3.2L Z32SE TPS038 TCS102

Zafi ra TT 06/2001 on 4 2.2L Z22SE TCS090 TBS053 TRS026

Honda

Accord SJD, SJF 03/1977 12/1978 4 1.6L EG,EL TPS014 TTS013 TFS131 TBS015 TRS008

Accord SJ,SM,SY,SZ 01/1979 1983 4 1.6L EL1 TPS014 TTS013 TFS123 TBS015 TRS008

Accord AD - Carb. 01/1984 12/1985 4 1.8L ET TPS014 TTS013 TFS123 TBS015 TRS008

Accord AD - Carb. 01/1986 10/1986 4 2.0L A20A2 TPS014 TTS013 TFS123 TBS015 TRS008

Accord AD - EFI 01/1986 10/1986 4 2.0L A20A4 TPS014

Accord EX, LX CA5 - Carb. 01/1986 03/1988 4 2.0L A20A2 TPS014TPS015

TTS013 TFS124 TBS015 TRS008 2 x Oil Pressure Switches, check illustrations

Accord Si CA4 - EFI 01/1987 12/1989 4 2.0L A20B4 TCS022 TFS124

Accord EXi CB7 -EFI (incl 4WS) 11/1989 10/1993 4 2.2L F22A5/6/9 TPS014 TTS013 TCS029 TFS129 TBS016 TRS004 2 x Stop Light Switches, check illustrations, TBS016 with cruise control

Accord Aerodeck CB8, 9 05/1992 1994 4 2.2L F22A6/9 TCS029 TFS127TFS129

2 x Thermo Fan Switches, check illustrations and spec tables

Accord - Vti,Vti-S & Wagon

CC5,CD5,CE1 10/1993 1997 4 2.2L F22B1 TTS013 TCS029 TFS129

Accord Vti CK2,CG5 12/1997 06/2003 4 2.3L F23A1 TFS127TFS129

2 x Thermo Fan Switches,check illustrations and spec tables

Holden cont.

Holden, Honda

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

30

Accord V6, V6-L CK1,CG1 12/1997 1998 V6 3.0L J30A1 TTS013 TCS029 TFS130 TBS016 TRS004

Accord V6, V6-L CK1,CG1 01/1999 06/2003 V6 3.0L J30A1 TCS029 TFS130 TBS016 TRS004

City VF 01/1984 06/1986 4 1.2L ER TPS013 TTS003 TFS131

Civic SB,SF 03/1973 1979 4 1.2L EB1/2/3 TPS013 TTS002 TFS131 TBS015

Civic 10/1974 1978 4 1.5L EC,ED TPS013 TTS002 TFS131 TBS015

Civic SL,WC 11/1979 12/1983 4 1.3L EN1 TPS013 TTS002 TFS131 TBS015

Civic AK,AH,AN 01/1984 1987 4 1.5L EW2 TPS013 TTS013 TCS020 TFS131 TBS015 TRS009

Civic ED,EE - Twin Carb. 11/1987 09/1991 4 1.5L D15B4 TPS014TPS015

TTS013 TCS029 TFS131 TBS015 TRS008 2 x Oil Pressure Switches, check illustrations

Civic EG - Breeze 10/1991 10/1993 4 1.3L D13B2 TPS014 TTS013 TFS130 TBS015 TRS009

Civic EG - Breeze 10/1993 09/1995 4 1.5L D15Z2 TCS029 TFS130

Civic EG - Twin Carb. 10/1991 10/1993 4 1.5L D15B4 TPS014 TTS013 TCS029 TFS131 TRS009

Civic EG - VEI VTE-C eng 06/1993 09/1995 4 1.5L D15Z1 TPS014 TTS013 TCS029 TFS131 TRS009

Civic EG - GLI 10/1993 09/1995 4 1.5L D15B7 TCS029 TFS131

Civic EH - EFI 10/1991 10/1993 4 1.6L D16A8 TPS014 TTS013 TFS130 TRS009

Civic EH - EFI 10/1993 09/1995 4 1.6L D16Y1 TFS131

Civic EK4 - VTi-R 10/1995 09/2000 4 1.6L B16A2 TPS014 TTS013 TCS029 TFS131 TBS041 TRS009

Concerto MA EX-I 11/1988 1993 4 1.6L D16Z2 TPS014TPS015


CR-V 09/1997 12/2001 4 2.0L B20B3 TPS014 TTS013 TCS029 TFS130

CR-X ED9 11/1987 05/1992 4 1.6L D16A8 TPS014TPS015


TBS015 TRS008 2 x Oil Pressure Switches, check illustrations2 x Thermo Fan Switches, check illustrations and Temp ranges

CR-X EG2 - V-TEC EFI 09/1992 09/1998 4 1.6L B16A2 TPS014 TTS013 TCS029 TFS130 TBS015 TRS009

HRV All 01/1999 2001 4 1.6L D161W1 TPS014 TTS013 TCS029 TFS130

Insight 05/2001 06/2004 4 1.0L TCS029

Integra DA3,DA4 05/1986 05/1989 4 1.6L D16A3 TPS014 TTS013 TFS131 TBS015 TRS008

Integra DA9 06/1989 1992 4 1.8L B18A1 TPS014 TTS013 TCS029 TFS131 TBS015 TRS008

Integra DC2, VTi-R V-TEC 07/1993 1999 4 1.8L B18C2 TPS014 TTS013 TCS029 TFS130 TBS016 TRS004

Integra DC4, Gsi 07/1993 1999 4 1.8L B18B2 TTS013 TCS029 TFS131

Integra DC2, Type R 10/1999 08/2001 4 1.8L B18C7 TFS131

Legend KA4 05/1986 12/1987 V6 2.5L C25A1 TPS008TPS013

TTS013 TCS022 TFS126 TBS016 2 x Oil Pressure Switches, check illustrations

Legend KA4 11/1987 03/1991 V6 2.7L C27A1 TPS008TPS013


Legend KA7 04/1991 03/1996 V6 3.2L C32A3 TPS014 TTS013 TCS029 TFS128

Legend KA8 04/1991 03/1996 V6 3.2L C32A3 TPS014 TTS013 TCS029 TFS128 TBS016

Legend KA9 05/1996 01/2005 V6 3.5L C35A3 TPS014 TTS046 TCS029 TBS016

NSX NA,NB 04/1995 01/2005 V6 3.0L,3.2L All TPS013 TTS046 TCS029 TBS016

Odyssey RA1 06/1995 12/1997 4 2.2L F22B3/6 TPS014 TTS013 TFS130 TBS016 TRS004

Honda cont.

31


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Odyssey RA3 - V-TEC 01/1998 04/2000 4 2.3L F23A1/7 TPS013 TTS013 TFS130 TBS016 TRS004

Odyssey RA6 - V-TEC 04/2000 05/2004 4 2.3L F23Z4 TFS130

Odyssey RA9 04/2000 05/2004 V6 3.0L J30A3 TFS130

Prelude SNF 05/1979 01/1982 4 1.6L EL TPS013 TTS003 TFS131 TBS024 TRS008

Prelude AB7 01/1983 12/1985 4 1.8L ES TPS013 TTS003 TFS123 TBS024 TRS008

Prelude BA3 - Si 01/1986 09/1987 4 2.0L A20A4 TPS013 TTS003 TCS029 TFS124 TBS024 TRS008

Prelude BA4,BA5 - Si 4WS 10/1987 1991 4 2.0L B20A6 TPS014TPS015


Prelude BA8,BB2 12/1991 12/1996 4 2.2L.2.3L F22A1H23A1


TBS016 TRS004 2 x Thermo Fan Switches, TFS127(92no-87nc), TFS129(112no-107nc)

Prelude BB1 - Vti-R 02/1994 12/1996 4 2.2L H22A1 TPS013 TTS013 TFS127 TBS015TBS016


Prelude 01/1997 07/2002 4 2.2L F22Z6 TFS127

Prelude BB1 - Vti-R 01/1997 07/2002 4 2.2L H22A4 TCS029 TFS127

S2000 AP11 V-Tec 08/1999 on 4 2.0L F20C1 TCS029

Hyundai

Accent 06/2000 on 4 1.5L,1.6L All TPS007 TTS001 TBS012 TRS016

Coupe FX,SX,SFX 07/1996 04/2002 4 1.8L,2.0L G4GFT,MT TPS007 TTS001 TCS040 TRS016

Elantra GL,GLS,Lavita & Elite 10/2000 06/2004 4 1.8L,2.0L G4GB,G4GC

TPS007 TCS040

Excel X1 02/1986 12/1989 4 1.5L G4AJ TPS007 TTS017 TFS132 TBS006 TRS016

Excel X2 - EFI 01/1990 11/1994 4 1.5L G4DJ TPS007 TTS017 TCS030 TFS132 TBS006 TRS016

Excel X3 - EFI (SOHC) 09/1994 04/1998 4 1.5L G4EKR TPS007 TTS001 TCS040 TFS132 TBS012 TRS016

Excel X3 - EFI (DOHC) 01/1998 04/2000 4 1.5L G4FKR TPS007 TTS001 TCS040 TFS132

Getz XL 03/2003 on 4 1.3L TPS007 TTS001

Getz GL & FX 09/2002 on 4 1.5L G4EC TPS007

Lantra KF 05/1991 10/1992 4 1.6L G4CR TPS008 TTS004 TCS030 TFS134 TBS006 TRS016

Lantra KF J2 11/1992 08/1995 4 1.8L G4CNM TPS008 TTS004 TCS030TCS050

TFS132TFS227

TBS006TBS020


Lantra KF, KW J1 08/1995 02/1999 4 1.8L G4GMR TPS008 TTS004 TCS040 TFS133 TBS006 TRS016

Lantra KF, KW J3, SE & GLS 03/1999 10/2000 4 1.8L G4GMR TPS007 TTS001 TCS040

S Coupe UE3 01/1993 03/1996 4 1.5L G4EKM TPS008 TTS004 TCS040 TFS134 TBS006TBS020


S Coupe UE3,UE34 - Turbo 01/1993 04/1995 4 1.5L G4EKT(2) TTS004 TCS040 TBS006TBS020


Sonata AF2, 3 03/1989 1992 4 2.4L G4CSK TPS007 TTS001 TCS030 TFS133 TBS006 TRS016TRS029

2 x Rev Light Switches, check illustrations

Sonata AF2, 3 04/1990 1993 V6 3.0L G6AT TPS010 TTS004 TCS030 TFS132 TBS020 TRS016

Honda cont.

Honda, Hyundai

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

32

Sonata DF2, 4 10/1993 08/1998 4 2.0L G4CPP TPS008 TTS004 TCS030 TFS132 TBS020 TRS016

Sonata DF3, 4 10/1993 08/1998 V6 3.0L G6ATP/S TPS049 TTS004 TCS030 TFS132 TBS020 TRS016

Sonata EM3 - SIRIUS 11 08/1998 10/2001 4 2.0L G4JPV TPS008 TTS001 TCS030 TBS006TBS020


Sonata EN1, 4 - DELTA 08/1998 10/2001 V6 2.5L G6BVV TPS007 TTS001 TRS016

Jaguar

XJ6 Series 1 1969 1974 6 2.8L,4.2L TFS179

XJ6 Series 2 & 3 1974 03/1987 6 4.2L TTS029 TFS179

XJ6 EFI 10/1994 10/1997 6 3.2L,4.0L TCS128

XJ,XJS,XJSC & Sovereign

04/1974 09/1993 V12 5.3L 7P TTS029

XJ,XJS,XJSC & Sovereign

11/1992 1996 V12 6.0L All TTS029

Jeep

Cherokee & Grand Cherokee

10/1996 on 6 4.0L TTS048 TRS031

Wrangler 10/1996 on 6 4.0L MX TTS048

Kia

Carnival 09/1999 on V6 2.5L KV6 TPS008 TTS001 TBS009 TRS053

Credos GC 05/1998 05/2001 4 2.0L FED TPS008 TTS001 TBS009 TRS053

Pregio Van 07/2002 on 4 2.7L J2 TPS007 TTS001 TCS116 TBS009

Rio BC 06/2000 on 4 1.5L A5D TPS008 TBS009

Shuma FB 12/1999 04/2001 4 1.8L TE TPS008 TTS001 TBS009

Sorento Sorento AWD 02/2003 on V6 3.5L TBS016

Spectra 5D Hatch 05/2001 03/2004 4 1.8L TPS008 TTS001 TBS009TBS016


Sportage 12/1996 03/2004 4 2.0L FED TPS008 TTS001 TBS009

Lada

Niva All 1.6L 07/1983 12/1995 4 1.6L TPS018 TFS135

Samara 07/1988 05/1991 4 1.3L TPS018 TFS135

Landrover

Series 3 1972 1980 6 2.6L TTS029

3.5L V8 1972 1985 V8 3.5L TTS029

110 3.5 , Country 3.5 11/1984 1988 V8 3.5L 17G TTS029 TFS145TFS146

2 x Thermo Fan Switches, TFS145 - red, TFS146 - green.

Defender 110 - Turbo Diesel 09/1992 03/1999 4 2.5L 11L TPS048 TFS146

Defender 90,110,130 - Td5 02/1999 on 5 2.5L 10P TPS041 TFS146

Discovery ML, BL - 3.5L 04/1991 10/1993 V8 3.5L 17G TTS029 TFS145 TBS025

Discovery ML, BL - 3.9L 11/1993 02/1997 V8 3.9L 22D TFS145

Hyundai cont.

33


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Discovery ML - 3.9L 02/1997 03/1999 V8 3.9L 37D, 38D TFS145

Discovery Tdi BF, MF 03/1993 1997 4 2.5L 12L TPS048 TFS146 TBS025

Discovery Tdi MF 03/1997 1999 4 2.5L 18L TFS146

Freelander 1.8L 02/1998 07/2003 4 1.8L 18K4FJ TPS039TPS041

TBS027 2 x Oil Pressure Switches, check illustrations

Freelander 2.0 Di 02/1998 11/2000 4 2.0L 20T2N TPS041 TTS054 TBS027

Freelander 2.5L V6 11/2000 03/2004 V6 2.5L TPS039 TBS027

Freelander 2.0 TD4 03/2004 on 4 2.0L M47 TPS039

Range Rover 3.5L V8 02/1986 12/1989 V8 3.5L 22D/23D TTS029 TFS145

Range Rover 2.4 TD4 12/1989 1990 4 2.4L VM TPS048 TTS029 TFS146 TBS025

Range Rover 3.9L V8 12/1989 1991 V8 3.9L 37D/38D TTS029 TFS145 TBS025TBS035


Range Rover 3.9L V8 1991 04/1995 V8 3.9L 37D/38D TTS049 TFS145 TBS025TBS035


Range Rover SE,HSE - TD6 08/2002 on 6 2.9L TPS039

Range Rover HSE & Vogue 08/2002 on V8 4.4L TPS039

Lexus

ES300 VCV10R 06/1992 10/1996 V6 3.0L 3VZ-FE TPS011 TTS001 TBS018

ES300 LXS, S MCV20R 10/1996 on V6 3.0L 1MZ-FE TPS011 TTS008 TBS018

GS300 JZS160R 11/1997 on 6 3.0L 2JZGE TPS011 TBS018

IS200 GXE10R 03/1999 on 6 2.0L 1GFE TPS011 TBS005TBS018


LS400 UCF10R, UCF20R 05/1990 2000 V8 4.0L 1UZ-FE TPS011 TCS032 TFS119 TBS018

LS430 12/2000 on V8 4.3L 3UZ-FE TPS011 TBS018

LX470 UZJ100R 05/1998 on V8 4.7L 2UZFE TTS008 TBS018

RX330 MCU38R 04/2003 on V6 3.3L 3MZ-FE TPS011 TCS032

Mazda

121 CD2 03/1976 03/1979 4 1.8L VC TPS006 TTS002

121 DA 03/1987 11/1990 4 1.3L B3 TPS008 TTS003 TCS024 TFS114TFS136


121 DB1031 12/1990 08/1997 4 1.3L B3 TPS008 TTS001 TCS032 TFS114 TBS009 TRS041

121 DB1052 01/1994 1998 4 1.5L B5 TTS001 TCS032 TFS114

121 Metro - DW1031 10/1996 2000 4 1.3L B3 TCS085 TFS113

323 FA 03/1977 12/1981 4 1.3L,1.4L TPS006 TTS015TTS503

TFS136 TBS009 2 x Water Temp Senders, check illustrations

323 BD 10/1980 10/1985 4 1.3L,1.5L E3,E5 TPS006 TTS015TTS503


323 BF - incl 4WD & Turbo 10/1985 10/1989 4 1.5L,1.6L B6 TPS006 TTS001 TCS024 TFS136 TBS009 TRS042 3 x Thermo Fan Switches applications, (TFS136 in Therm Housing only)

323 BW 06/1986 09/1987 4 1.5L B5,B6 TPS006 TTS001 TFS136 TBS009 TRS042

Landrover cont.

Hyundai, Jaguar, Jeep, Kia, Lada, Landrover, Lexus, Mazda

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

34

323 BG 10/1989 08/1994 4 1.6L,1.8L B6,BP TPS008 TTS001 TCS024 TFS114 TBS009 TRS037

323 BG Astina 10/1989 08/1994 4 1.6L,1.8L B6,BP TPS008 TTS001 TCS024TCS032


323 BG Shades 10/1994 05/1996 4 1.6L B6 TPS007 TTS001 TFS114 TBS009 TRS037 TFS114 located in Therm housing

323 BA - Astina & Protégé 07/1994 09/1998 4,V6 1.6L,1.8L2.0L

All TPS008 TTS001 TCS032 TBS009TBS057


323 BJ - Astina & Protégé 09/1998 01/2004 4 1.6L,1.8L ZMD,FPD TPS008 TTS001 TCS032TCS125


626 CB2 12/1978 02/1983 4 2.0L MA TPS006 TTS015 TFS115

626 GC10E 02/1983 10/1987 4 2.0L FE TPS013 TTS015 TFS136 TBS009 TRS010 Many Thermo Fan Switch applications TFS136 located in Therm Housing

626 GC - Turbo 01/1986 10/1987 4 2.0L FE TPS013 TTS015 TCS024 TFS136 TBS009 TRS010 Many Thermo Fan Switch applications TFS136 located in Therm Housing

626 GC - Diesel 1984 1987 4 2.0L RF TPS006 TTS001 TFS136 TBS009 TRS011 Many Thermo Fan Switch applications TFS136 located in Therm Housing

626 GD 10/1987 12/1991 4 2.2L F2 TPS006 TTS015 TCS024 TFS113TFS115TFS137TFS181

TBS009 TRS011 Many Thermo Fan Switch applications TFS113 & TFS115 located in Therm HousingTFS137 Nippondenso typeTFS181 located in manifold

626 GD - Turbo 10/1987 12/1991 4 2.2L F2 TPS006 TTS015 TCS024 TFS137 TBS009 TRS011

626 GV10 - Wagon 06/1988 1997 4 2.2L F2 TPS008 TTS001 TCS024 TFS137 TBS009TBS014


626 GE 01/1992 06/1997 4 2.0L FS TPS008 TTS001 TCS032 TBS009TBS014


626 GE 01/1992 06/1997 V6 2.5L KL TPS008 TTS001 TCS032 TFS137 TBS009TBS014


626 GF 07/1997 06/2002 4 2.0L FSD TPS008 TTS001 TCS032 TBS009TBS014


626 GW10 - Wagon 01/1998 06/2002 4 2.0L FSD TPS007TPS008

TTS001 TCS032 TBS009 2 x Oil Pressure Switches, check illustrations

808 1972 1978 4 1.3L,1.6L TPS006 TTS034 TBS010

929 HBSHE 03/1982 06/1987 4 2.0L MA TPS006 TTS015 TFS115 TBS009 TRS010

929 HBES - incl Turbo 02/1984 06/1987 4 2.0L FE TPS013 TTS015 TFS136

929 HC10E1 07/1987 1989 V6 3.0L JE TPS006 TTS015 TCS024 TBS009

929 HC10E2 07/1989 08/1991 V6 3.0L JE42 TPS006 TTS015 TCS024 TBS009

929 HC10E2 - 4WS 01/1990 05/1991 V6 3.0L JE41 TPS008 TTS001 TBS009TBS014


929 HD10E1 - 4WS 07/1991 03/1996 V6 3.0L JE55 TPS008 TTS001 TCS032 TBS009TBS014


929 HE10E1 - 4WS 04/1996 11/1997 V6 3.0L JE-ZE TCS032

1200,1300,1500,1800

11/1968 02/1977 4 1.2L - 1.8L TPS006 TTS034 TBS010

Mazda cont.

35


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

B1500,B1600,B1800

Petrol 01/1970 11/1982 4 1.5L,1.6L1.8L

UB,NA,VC TPS006 TTS034 TBS010

B2000 Petrol 12/1982 07/1988 4 2.0L MA,FE TPS006 TTS015 TBS009 TRS010

B2200 Diesel 01/1981 05/1985 4 2.2L S2 TPS013 TTS034 TBS009 TRS010

B2200- incl Bravo Diesel 06/1985 1996 4 2.2L R2 TPS008TPS013

TTS003TTS015

TBS009 TRS010 2 x Oil Pressure Switches, check illustrations2 x Water Temp Senders, check illustrations

B2200- incl Bravo Petrol 03/1988 02/1993 4 2.2L F2 TPS008 TTS003TTS015


B2500 - RWD, 4WD Diesel 04/1996 1999 4 2.5L WL TPS008 TTS001 TBS009TBS014


B2500 - RWD, 4WD Turbo Diesel 02/1999 on 4 2.5L WL-AT TPS008 TBS009TBS014


B2600 4WD 03/1987 10/1991 4 2.6L 4G54 TPS008 TTS020 TBS009 TRS012

B2600 - EFI incl Bravo & 4WD 12/1990 03/1996 4 2.6L G6 TPS006 TTS003 TBS009 TRS012

B2600 - EFI Bravo & 4WD 04/1996 10/2002 4 2.6L G6 TPS006 TTS001 TBS009TBS014


Capella 10/1970 12/1978 4 1.6L NA TPS006 TTS034

E1300, E1400 05/1978 07/1986 4 1.3L - 1.5L TPS006 TTS034 TBS010

E1600 05/1978 1986 4 1.6L NA TPS006 TTS002 TBS010

E1800 02/1984 01/1988 4 1.8L F8 TPS013 TTS003TTS015


E2000 02/1984 12/1990 4 2.0L FE TPS013 TTS003TTS015


E2000 1998 on 4 2.0L FE TPS008 TTS001 TBS009TBS014


E2200 Diesel 02/1984 08/1997 4 2.2L R2 TPS013 TTS003TTS015


E2500 08/1997 on 4 2.5L WL TPS008 TTS001 TBS009TBS014


E3000 Diesel 1977 1981 4 3.0L HA TPS013 TTS002 TBS010

Millenia 4D Sedan 10/2000 05/2002 V6 2.3L TPS008 TCS032 TBS058

MPV LV 10/1993 03/1996 V6 3.0L JE TPS006 TTS001 TCS032 TFS137 TBS009TBS014


MPV LV Series II 04/1996 08/1999 V6 3.0L JE TPS006 TTS001 TCS032 TBS009TBS014


MPV LW 08/1999 06/2002 V6 2.5L GY TPS058 TBS009TBS014


MPV 4D Wagon 06/2002 on V6 3.0L MZI TBS009TBS014


MX5 NA 10/1989 11/1993 4 1.6L B6 TPS062 TTS001 TCS024 TFS114 TBS009 TRS010

MX5 NA 11/1993 1998 4 1.8L B8-ZE TPS062 TTS001 TCS125 TBS009 TRS010

Mazda cont.

Mazda

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

36

MX5 NB 05/1998 on 4 1.8L B8-ZE TPS008 TCS032TCS125

TBS009TBS014

TRS012 2 x Stop Light Switches, check illustrations2 x Coolant Sensors, check illustrations

MX6 GC - Turbo 11/1986 1987 4 2.0L FE TPS013 TTS001 TBS009 TRS036

MX6 GD - Turbo 2WS 10/1987 09/1991 4 2.2L F2 TPS008 TTS001 TCS024 TBS009 TRS036

MX6 GD - Turbo 4WS 05/1989 1991 4 2.2L F2 TPS008 TTS001 TCS024 TFS113TFS137

TBS009TBS014

TRS036 2 x Stop Light Switches, check illustrations2 x Thermo Fan Switches, check illustrations

MX6 GE10 - 4WS 11/1991 09/1997 V6 2.5L KL TPS008 TTS001 TCS032 TFS137 TBS009TBS014


MX6 GE20 - 2WS 09/1994 09/1997 V6 2.5L KL TPS008 TTS001 TCS032 TFS137 TBS009

PREMACY 4D Wagon 02/2001 03/2002 4 1.8L FP TPS008 TCS032 TBS009TBS014


R100 06/1969 12/1971 Rot. 982cc 10A TPS006 TBS010

RX2,RX3,RX4,RX5 1970 06/1979 Rot. 1.1L,1.3L 12A,13B TPS006 TTS030 TBS010 TRS010

RX7 SA22 Series I, II & III 03/1979 12/1985 Rot. 1.1L 12A TPS006 TTS030 TFS115 TBS010 TRS010

RX7 FC10 Series IV incl Turbo

01/1986 02/1989 Rot. 1.3L 13B TTS003 TCS024 TFS115

RX7 FC10 Series V incl Turbo

03/1989 1992 Rot. 1.3L 13B TTS001 TCS024 TFS138 TBS009TBS014


RX7 FD10 Series VI Twin Turbo

03/1992 07/1993 Rot. 1.3L 13B TPS005 TTS001 TCS024 TFS138 TBS009TBS014


RX7 FD10 Series VII Twin Turbo

08/1993 06/1994 Rot. 1.3L 13B TPS005 TTS001 TCS024 TFS137 TBS009TBS014


RX7 FD10 Series VIII Twin Turbo

07/1994 1999 Rot. 1.3L 13B TPS005 TTS001 TCS024 TFS137 TBS009TBS014


T2000 05/1981 1982 4 2.0L VA/GE TPS007 TTS003 TBS010 TRS010

T2600 04/1985 12/1988 4 2.6L 4G54 TPS013

T3000 Diesel 01/1984 10/1984 4 3.0L HA TPS013 TTS003 TBS010 TRS010

T3500 Diesel - incl Turbo 05/1984 04/1997 4 3.5L SL(T) TPS006 TTS001 TBS009

T4000 Diesel 11/1989 07/2000 4 4.0L TF TPS006 TTS001 TBS009

T4100 Diesel 01/1984 12/1991 4,6 4.0L,4.1L ZB TPS007 TTS003 TBS009

T4600 Diesel 06/1992 on 4 4.6L 4HG1,TM TPS006 TTS001 TBS009

Traveller 06/1984 1986 4 1.6L NA TPS013 TTS034

Traveller 08/1986 1988 4 1.8L F8 TPS007 TTS002

Traveller 08/1986 03/1988 4 2.0L FE TPS013 TTS015

Mazda Eunos

30X EC 1992 06/1996 V6 1.8L K8-ZE TCS032

30X EC 06/1996 10/1997 V6 1.8L K8-ZE TPS007TPS008

TTS001 TCS032 TBS009 2 x Oil Pressure Switches, check illustrations

500 CA 1992 06/1996 V6 2.0L KF-ZE TCS032

500 CA 06/1996 1999 V6 2.0L KF-ZE TPS008 TTS001 TCS032 TBS014

Mazda cont.

37


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

800 TA5 06/1996 10/1998 V6 2.5L KL TPS008 TTS001 TBS058 TRS036

800M TA3 06/1996 03/1999 V6 2.3L KJ(Miller) TPS008 TTS001 TBS058 TRS036

800M TB3 03/1999 10/2000 V6 2.3L KJ(Miller) TPS008 TTS001 TBS058

Mercedes

190 E 1.8 1990 1992 4 1.8L M102 TTS039TTS050TTS501TTS516

TFS189TFS209

TBS039 4 x Water Temp application,2 x Thermo Fan Switches, check illustrations


TFS189TFS209



TFS189TFS209


190 E 2.6 1987 1991 6 2.6L M103 TFS189TFS209


Class A - 140,160,190

W168 10/1998 on 4 1.5L,1.6L1.8L

M166 TCS114

Class C - C180 W202 03/1994 01/1997 4 1.8L M111 TTS039TTS043

TCS100 TBS039 2 x Water Temp Senders, check illustrations

Class C - C180 W202 02/1997 2000 4 1.8L M111 TTS039TTS043


Class C - C180, C200 Kompressor

S203,W203 11/2002 on 4 1.8L M271 TCS114

Class C - C200,C200T

S203,W203 11/1996 2000 4 2.0L M111 TTS039TTS043


Class C - C220 W202 03/1994 11/1996 4 2.2L M111 TTS039TTS043


Class C - C240T S202 08/1997 2000 V6 2.3L M112 TCS114 TBS039

Class C - C250D W202 10/1994 11/1996 5 2.5L OM605 TTS043 TCS100 TBS039 3 x Water Temp Senders, check illustrations

Class C - C250TD W202 10/1994 2000 5 2.5L OM605 TBS039

Class C - C280 W202 1994 07/1997 6 2.8L M104 TTS039TTS043


Class C - C280 W202 08/1997 2000 6 2.8L M112 TCS114 TBS039

Class C - 300CE 24V

W124 1988 1993 6 3.0L M104 TTS039TTS043

TBS039 2 x Water Temp Senders, check illustrations

Class C - C36 AMG W202 10/1995 1997 6 3.6L M104 TTS039TTS043

TCS100 TFS115 TBS039 2 x Water Temp Senders, check illustrations

Class C - C43 AMG 04/1998 2000 V8 4.3L M113 TCS114 TBS039

CLK 200 W211 10/1997 07/2004 4 2.0L M111 TBS039

Mazda Eunos cont.

Mazda, Mazda Eunos, Mercedes

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

38

CLK 230 W211 Kompressor 10/1997 on 4 2.3L M111 TBS039

CLK 320 W211 10/1997 2002 V6 3.2L M112 TCS114 TBS039

CLK 430 W211 11/1999 on V8 4.3L M113 TCS114 TBS039

Class E - E220 C, CA

W124 1993 1996 4 2.2L M111 TTS039TTS043


Class E - 230E,GE,TE

All 07/1981 1993 4 2.3L M102 TFS189TFS209


Class E - E230 T W210 02/1996 1998 4 2.3L M111 TBS039

Class E - E240 T W210 02/1998 08/2002 V6 2.3L M112 TCS114 TBS039

Class E - E270Cdi W211 01/2000 on 5 2.7L TCS114 TBS039

Class E - E280, E280T

S124,W124 09/1993 02/1996 6 2.8L M104 TTS039TTS043


Class E - E280 W210 09/1998 on 6 2.8L M112 TCS114 TBS039

Class E - E300D W124 (Diesel) 1993 1994 6 3.0L OM606 TTS043TTS050


Class E - E320 CA,CE

W124 1993 1997 6 3.2L M104 TTS039TTS043


Class E - E320,E320T

W210 08/1997 03/2002 V6 3.2L M112 TCS114 TBS039

Class E - E430 W210 02/1998 08/2002 V8 4.3L M113 TCS114 TBS039

Class E - E36 AMG C124 1996 1997 6 3.6L M104 TTS039TTS043


Class E - E55 AMG W210 03/1998 09/2002 V8 5.4L M113 TCS114 TBS039

Class S -260SE,300SE,300SEL

W124,W126 04/1986 1992 6 2.6L,3.0L M103 TTS039TTS043TTS501


Class S - 380SE,SL,SEL,SEC

C126,W126 02/1981 1986 V8 3.8L M116 TTS039 TBS033

Class S - 420SEL,560S,SEC

C126,W126 04/1986 1992 V8 4.2L,5.5L M116,M117 TTS039TTS043


Class S - S280 W140 10/1995 1999 6 2.8L M104 TTS039TTS043


Class S - S400SE, SEL

W140 1992 1993 V8 4.2L M119 TTS039TTS043


Class S - S420SE W126 07/1990 1992 V8 4.2L M116 TTS039TTS043


Class S - S420,S420L

W140 1993 1999 V8 4.2L M119 TTS039TTS043


Class S - S500C, SEC,SE,SEL,SL

All 1992 1999 V8 5.0L M119 TTS039TTS043


Class S - S600SEL,SL,L

W129,W140 1992 1999 V12 6.0L M120 TTS039TTS043


Mercedes cont.

39


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

SL280 2D Convertible 11/1995 1997 6 2.8L M104 TTS039TTS043


SL320 2D Convertible 03/1999 10/2001 V6 3.2L M112 TCS114 TBS039

SL500 2D Convertible 09/1993 1996 V8 5.0L M119 TTS039TTS043


SL600 2D Convertible 09/1993 1996 V12 6.0L M120 TTS039 TCS097 TBS039

SLK200, SLK230 Kompressor 02/1997 11/2002 4 2.0L,2.3L M111 TBS039

SLK320 R170 03/2000 11/2002 V6 3.2L M112 TCS114 TBS039

SLK32 AMG AMG Kompressor 09/2001 01/2004 V6 3.2L M112 TCS114 TBS039

Sprinter All 2001 on 4,5 2.1L,2.2L2.7L

TCS114

Vito 02/1998 2004 4 2.0L M111 TPS026 TTS039 TBS026

Vito Diesel 02/1998 1999 4 2.3L OM601 TPS026 TBS026

Vito Turbo Diesel 08/1999 2004 4 2.2L OM611A TCS114

MG

MGB GT 1975 1976 V8 3.5L TTS029

MGF TF 03/1997 on 4 1.8L 18K4F TPS039TPS041

TBS027TBS041


ZS 11/2004 on V6 2.5L KV6 TBS041TBS057TBS058


Mitsubishi

3000GT JF - 4WD Turbo (without cruise control)

1992 1996 V6 3.0L 6G72 TPS005TPS008

TTS004 TCS030TCS050

TFS141 TBS002 TRS016 2 x Oil Pressure Switches & 2 x Coolant Sensors, TPS005(gauge), TPS008(Light), check illustrations

3000GT JF - 4WD Turbo (with cruise control)

1992 1996 V6 3.0L 6G72 TPS005TPS008

TTS004 TCS030TCS050

TFS141 TBS016 TRS016 2 x Oil Pressure Switches & 2 x Coolant Sensors, TPS005(gauge), TPS008(Light), check illustrations

Canter FC212,FC432 1981 1992 4 2.6L 4G54 TPS007 TTS001 TBS009 TRS013

Challenger PA 03/1998 on V6 3.0L 6G72-S4 TPS007 TTS001 TBS009TBS016

2 x Stop Light Switches,TBS009 (without cruise control),TBS016 (with cruise control), check illustrations

Colt RA,RB 11/1980 1984 4 1.4L,1.6L 4G12,32,33 TPS007 TTS017 TFS139

Colt RC,RD,RE 1984 1990 4 1.4L,1.6L 4G32,4G33 TPS008 TTS017 TFS139 TBS010 TRS015

Cordia AA,AB,AC - Carb. 04/1983 11/1985 4 1.6L,1.8L 4G32,4G37 TPS005 TTS017 TFS139 TBS002TBS014


Cordia AA,AB - EFI Turbo. 03/1984 11/1985 4 1.8L 4G62 TPS005 TTS017 TFS139 TBS002TBS014


Cordia AC - EFI Turbo. 12/1985 07/1989 4 1.8L 4G62 TPS005 TTS017 TCS030 TFS139 TBS002 TRS015

Galant HG,HH,HJ - incl GSR, VR4

05/1989 10/1996 4 2.0L 4G63 TPS008 TTS004 TCS030 TFS140 TBS002TBS016

TRS016 2 x Stop Light Switches, TBS002 (without cruise control), TBS016 (with cruise control), check illustrations

Mercedes cont.

Mercedes, MG, Mitsubishi

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

40

Galant HJ 04/1993 10/1996 V6 2.0L 6A12 TPS008 TTS004 TCS055 TBS002TBS016


L200 MA,MB -incl 4WD 05/1979 09/1982 4 1.6L,2.0L All TPS007 TTS017 TBS002 TRS013

L200 MC 01/1984 08/1984 4 1.6L 4G32 TPS008 TTS017 TBS014 TRS014

L200 MD 09/1984 10/1986 4 1.6L 4G32 TPS007 TTS017 TBS002 TRS013

L200 MC,MD - incl 4WD 10/1982 10/1986 4 2.0L 4G63 TPS008 TTS017 TBS014 TRS013

L200 MC,MD - incl 4WD 10/1982 10/1986 4 2.3L 4D55 TPS008 TTS018 TBS014 TRS013

L300 Express SA,SB 04/1980 04/1983 4 1.6L,1.8L 4G32,4G62 TPS008 TTS017 TRS014

L300 Express SC,SD,SE 05/1983 10/1986 4 1.6L,1.8L2.0L

All TPS008 TTS017 TBS010 TRS014

L300 Express SC,SD,SE - 4WD 10/1983 10/1986 4 1.8L,2.0L 4G62,4G63 TPS008 TTS017 TBS010

Express - Starwagon

SF,SG,SH 10/1986 09/1994 4 2.0L,2.4L 4G63,4G64 TPS008 TTS004 TFS141 TBS010 TRS014

Express - Starwagon

SF - incl 4WD 10/1986 08/1990 4 2.4L 4G64 TPS008 TTS004 TCS030 TFS141 TBS010

Express - Starwagon

SG,SH - incl 4WD (EFI) 09/1990 10/1994 4 2.4L 4G64 TPS008 TTS004 TCS030 TBS010

Express - Starwagon

SJ - incl 4WD 10/1994 09/2000 4 2.4L 4G64 TPS008 TTS004 TCS030 TBS010 TRS014

Express - Starwagon

SJ - incl 4WD 01/1998 04/2004 4 2.0L 4G63 TPS008 TTS004 TBS010 TRS014

Express - Starwagon

SF,SG,SH,SJ - Diesel 09/1989 10/2003 4 2.5L 4D56 TPS008 TTS018 TBS010 TRS014

Express - Starwagon

WA - EFI 09/1994 04/2004 4 2.0L 4G63 TPS008 TTS004 TBS002

Express - Starwagon

WA - EFI 09/1994 1998 4,V6 2.4L,3.0L 4G64,6G72 TPS008 TTS004 TCS030 TBS002

Lancer CA,CB,CC - Carb. 09/1988 07/1996 4 1.5L 4G15 TPS008 TTS004 TFS141 TBS002 TRS016

Lancer CA - EFI 04/1989 08/1990 4 1.5L 4G15 TPS008 TTS004 TCS030 TFS141 TBS014 TRS016

Lancer CB - EFI 09/1990 09/1992 4 1.5L 4G15 TPS008 TTS004 TCS050 TFS141 TBS002TBS014


Lancer CB - GSR 09/1990 09/1992 4 1.6L 4G61 TPS008 TTS004 TCS030 TFS141 TBS002TBS014


Lancer CC - 1.6L EFI 09/1992 07/1996 4 1.6L 4G92 TPS008 TTS004 TCS055 TFS141 TBS002TBS014


Lancer CC - 1.8L EFI 09/1992 07/1996 4 1.8L 4G93 TPS008 TTS001 TCS055 TFS141 TBS002TBS014


Lancer CC - GSR 09/1990 07/1996 4 1.8L 4G93 TPS008 TTS001 TCS055 TFS142 TBS002TBS014


Lancer CE 1.5L 07/1996 07/2004 4 1.5L 4G15 TPS008 TTS001 TCS055 TFS141 TBS009 TRS016

Lancer CE 1.8L 07/1996 09/1998 4 1.8L 4G93 TPS008 TTS001 TCS055 TFS141 TBS009 TRS016

Lancer CE 1.8L - Series II 10/1998 07/2004 4 1.8L 4G93 TTS001 TCS055 TFS141

Mitsubishi cont.

41


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Lancer CG 07/2002 08/2003 4 2.0L 4G94 TTS001

Magna TM 05/1985 05/1987 4 2.6L 4G54 TPS005TPS006

TTS001 TFS139 TRS015 2 x Oil Pressure Switches TPS005(gauge), TPS006(Light), check illustrations

Magna TN - Carb. 05/1987 05/1989 4 2.6L 4G54 TPS006 TTS001 TFS139 TRS029

Magna TN - EFI 04/1987 05/1989 4 2.6L 4G54 TPS005 TTS001 TCS040 TFS139 TRS016TRS029

2 x Rev Light Switches, check illustrations

Magna TP - Carb. 06/1989 02/1990 4 2.6L 4G54 TPS006 TTS001 TFS139 TBS016

Magna TP - EFI 06/1989 04/1992 4 2.6L 4G54 TPS006 TTS001 TCS040 TFS139 TBS016

Magna TR - Carb. 10/1991 03/1994 4 2.6L 4G54 TPS006 TTS001TTS004

TFS140 TBS002TBS016

TRS016 2 x Stop Light Switches, TBS002 (without cruise control), TBS016 (with cruise control),2 x Water Temp Senders, check illustrations

Magna TR - EFI 04/1991 03/1994 4 2.6L 4G54 TPS006 TTS001TTS004


TRS016 2 x Stop Light Switches, TBS002 (without cruise control), TBS016 (with cruise control),2 x Water Temp Senders, check illustrations

Magna TR - EFI (V6) 04/1993 03/1994 V6 3.0L 6G72 TPS008 TTS004 TCS050 TFS141 TBS002TBS016


Magna TS - Carb. 03/1994 03/1996 4 2.6L 4G54 TPS006 TTS004 TFS141 TBS009TBS016

TRS016 2 x Stop Light Switches,TBS009 (without cruise control),TBS016 (with cruise control), check illustrations

Magna TS - EFI 03/1994 02/1997 4 2.6L 4G54 TPS006 TTS004 TCS040 TFS141 TBS009TBS016


Magna TS - EFI (V6) 03/1994 02/1997 V6 3.0L 6G72 TPS008 TTS004 TCS050 TFS141 TBS009TBS016


Magna TE - EFI 04/1996 05/1997 4 2.4L 4G64-S4 TPS007 TTS001 TCS030 TFS139 TBS009 TRS013

Magna TE - EFI (V6) 04/1996 05/1997 V6 3.0L 6G72-S4 TPS007 TTS001 TCS055 TFS139 TBS016 TRS016

Magna TF - EFI 06/1997 03/1999 4 2.4L 4G64-S4 TPS007 TTS001 TCS030 TFS139 TBS009 TRS027

Magna TF - EFI (V6) 06/1997 03/1999 V6 3.0L 6G72-S4 TPS007 TTS001 TCS055 TFS139 TBS016 TRS016

Magna TH,TJ - 3.0L (V6) 03/1999 08/2002 V6 3.0L 6G72-S4 TPS007 TTS001 TCS055

Magna TH,TJ - 3.5L (V6) 03/1999 05/2003 V6 3.5L 6G74-S4 TPS007 TTS001 TBS009 TRS016

Magna TL,TW - 3.5L (V6) 06/2003 10/2004 V6 3.5L 6G74 TPS007 TTS001

Mirage CE 07/1996 08/2004 4 1.5L 4G15 TPS007 TTS001 TCS055 TFS141 TBS009 TRS016

Nimbus UA,UB 05/1984 08/1987 4 1.8L 4G37 TPS008 TTS017 TFS139 TBS002TBS014


Nimbus UC 09/1987 1988 4 2.0L 4G63 TPS007TPS008


Nimbus UC 1988 01/1992 4 2.0L 4G63 TPS007TPS008


Nimbus UF 02/1992 11/1998 4 2.4L 4G64 TPS008 TTS004 TCS030 TFS141 TBS002TBS009


Nimbus UG 11/1998 04/2004 4 2.4L 4G64 TPS007 TTS001 TFS141 TRS016

Mitsubishi cont.

Mitsubishi

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

42

Outlander ZE (LS & XLS) 01/2003 07/2004 4 2.4L 4G63 TPS007 TTS001

Pajero NA,NB,NC 1983 09/1987 4 2.6L 4G54 TPS005TPS008

TTS017 TCS030 TBS014 TRS013 2 x Oil Pressure Switches TPS005(gauge), TPS008(Light), check illustrations

Pajero ND 10/1986 09/1987 4 2.6L 4G54 TPS005TPS008


Pajero ND - Auto 10/1986 09/1987 4 2.6L 4G54 TPS005TPS008


Pajero NE,NF,NG 10/1987 05/1991 4 2.6L 4G54 TPS005TPS008


Pajero NF - with cruise control 08/1988 05/1991 4 2.6L 4G54 TPS005TPS008


Pajero NF 05/1988 08/1989 V6 3.0L 6G72 TPS005 TTS004 TCS030 TBS014 TRS040

Pajero NG 09/1989 05/1991 V6 3.0L 6G72 TPS005 TTS004 TCS030 TBS014TBS016

TRS040 2 x Stop Light Switches, TBS014(without cruise control), TBS016(with cruise control), check illustrations

Pajero NH 05/1991 10/1993 4 2.6L 4G54 TPS005TPS008

TTS004 TBS014 TRS017 2 x Oil Pressure Switches TPS005(gauge), TPS008(Light), check illustrations

Pajero NH 05/1991 10/1993 V6 3.0L 6G72 TPS005 TTS004 TCS050 TBS014TBS016

2 x Stop Light Switches, TBS014(without cruise control), TBS016(with cruise control), check illustrations

Pajero NJ 11/1993 10/1996 V6 3.0L 6G72 TPS005 TTS004TTS018

TCS050 TBS014TBS016

2 x Stop Light Switches, TBS014(without cruise control), TBS016(with cruise control),2 x Water Temp Senders, check illustrations

Pajero NJ 11/1993 10/1996 V6 3.5L 6G74 TPS005 TTS004 TCS050 TBS016 TRS017

Pajero NK 10/1996 07/1997 V6 3.0L 6G72 TPS007 TTS001

Pajero NK 10/1996 07/1997 V6 3.5L 6G74 TPS007 TTS001 TBS009 TRS013

Pajero NL 08/1997 2000 V6 3.5L 6G74 TPS007 TTS001 TBS009 TRS013

Pajero Diesel Turbo

NA,NB,NC 05/1984 10/1986 4 2.3L 4D55 TPS005TPS008


Pajero Diesel Turbo

ND,NE,NF 10/1986 08/1989 4 2.5L 4D56 TPS005TPS008


Pajero Diesel Turbo

NG 09/1989 05/1991 4 2.5L 4D56 TPS005TPS008


Pajero Diesel Turbo

NH - Intercooler 05/1991 10/1993 4 2.5L 4D56T TPS008 TTS018 TBS014 TRS017

Pajero - Diesel NJ 11/1993 10/1996 4 2.8L 4M40 TPS005TPS008

TTS018 TBS014TBS016

TRS017 2 x Oil Pressure Switches TPS005(gauge), TPS008(Light). 2 x Stop Light Switches, TBS014(without cruise control), TBS016(with cruise control), check illustrations

Pajero iO QA 03/1999 07/2003 4 1.8L 4G93 TPS008 TTS001

Scorpion GE 03/1978 06/1979 4 2.0L 4G52 TPS007 TTS017 TBS014 TRS029

Scorpion GH 07/1979 10/1980 4 2.6L 4G54 TPS005 TTS017 TBS002 TRS013

Scorpion GJ,GK,GL 11/1980 09/1985 4 2.6L 4G54 TPS007 TTS017 TBS014 TRS029

Mitsubishi cont.

43


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Sigma GE,GH,GJ,GK 10/1977 09/1985 4 1.6L 4G32 TPS008 TTS017

Sigma GE,GH 10/1977 02/1982 4 2.0L 4G52 TPS008 TTS017 TRS013

Sigma GJ 03/1982 02/1984 4 2.0L 4G52 TPS005 TTS017 TRS013

Sigma GK,GN 03/1984 12/1985 4 2.0L 4G52 TPS008 TTS017 TRS014

Sigma GE,GH 05/1980 04/1982 4 2.6L 4G54 TPS008 TTS017 TRS013

Sigma GJ 05/1982 02/1984 4 2.6L 4G54 TPS005 TTS017 TRS013

Sigma GK,GN 03/1984 12/1987 4 2.6L 4G54 TPS008 TTS017 TRS014

Starion JA,JB - Turbo 05/1982 11/1985 4 2.0L 4G63T TPS005 TTS017 TFS139 TBS002TBS014


Starion JD - Turbo 12/1985 08/1987 4 2.0L 4G63T TPS005 TTS017 TCS030 TFS139 TBS002

Triton ME,MF,MG,MH,MJ - 2.6L Petrol

10/1986 04/1994 4 2.6L 4G54 TPS005TPS008


Triton ME,MF,MG,MH,MJ - Diesel (incl turbo)

10/1986 10/1996 4 2.5L 4D56(T) TPS008 TTS018 TBS014 TRS013

Triton MH,MJ - 4WD 09/1990 10/1996 V6 3.0L 6G72 TPS005TPS008


Triton MK - 4WD 10/1996 on V6 3.0L 6G72 TPS007 TTS001 TCS050TCS055

TBS009TBS016

2 x Stop Light Switches,TBS009 (without cruise control),TBS016 (with cruise control), check illustrations

Verada KR 07/1991 03/1994 V6 3.0L 6G72 TPS008 TTS001TTS004

TCS050 TFS140 TBS016 2 x Water Temp Senders, check illustrations

Verada KS 03/1994 02/1997 V6 3.0L 6G72 TPS008 TTS004 TCS050TCS055

TFS141 TBS009TBS016


Verada KE,KF 10/1996 03/1999 V6 3.5L 6G74 TPS007 TTS001 TCS030 TFS141

Verada KH,KJ,KL 03/1999 08/2002 V6 3.5L 6G74 TPS007 TTS001

Nissan

120Y B210 03/1974 03/1979 4 1.2L A12 TPS014 TTS031 TFS169 TBS011

180B 610 09/1972 10/1977 4 1.8L L18 TPS014 TTS031 TFS169 TBS011

200B 810 10/1977 05/1981 4 2.0L L20B TPS014 TTS031 TFS169 TBS011 TRS018

200SX S14 - Turbo 10/1994 10/2000 4 2.0L SR20DET TPS017 TTS051 TCS127 TBS007

200SX S15 - Turbo 10/2000 12/2003 4 2.0L SR20DET TPS017 TTS051 TCS075 TBS056

240,260,280 C,K,Z,ZX 10/1970 05/1984 6 2.4L,2.6L2.8L

L24,26,28 TPS014 TTS031 TFS176 TBS011 TRS018

300C incl - Brougham 05/1984 1988 V6 3.0L VG30E TPS017 TTS036 TCS127 TBS007

300ZX Z31 - incl Turbo 05/1984 12/1989 V6 3.0L VG30E TPS014 TTS036 TBS011 TRS018

300ZX Z32 12/1989 03/1997 V6 3.0L VG30DE TTS036 TCS127 TBS007 TRS020

350Z 02/2003 on V6 3.5L VQ35DE TCS075 TBS056

520,620 1971 1979 4 1.5L J15 TPS014 TTS031 TBS011

720 RWD,4WD 01/1980 12/1985 4 1.8L L18 TPS014 TTS028TTS031

TRS018 2 x Water Temp Senders, check illustrations

Mitsubishi cont.

Mitsubishi, Nissan

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

44

720 Petrol - incl 4WD 06/1983 12/1985 4 2.2L Z22 TPS014 TTS028 TRS018

720 Diesel - incl 4WD 01/1980 09/1984 4 2.2L SD22 TPS014 TTS028TTS031


720 Diesel - incl 4WD 06/1983 12/1985 4 2.3L,2.5L SD23,SD25 TPS014TPS017

TTS028 TRS018 2 x Oil Pressure Switches, check illustrations

Bluebird Series I & II 1981 01/1985 4 2.0L L20B TPS007 TTS031 TFS143 TBS011 TRS018

Bluebird Series III 02/1985 12/1986 4 2.0L CA20S TPS017 TTS036 TCS127 TFS143 TBS007 TRS020

Bluebird U13 10/1993 12/1997 4 2.4L KA24DE TPS017 TTS036TTS051

TCS127 TBS007 TRS020 2 x Water Temp Senders, check illustrations

Caball C240,C340 01/1970 1981 4 2.0L H20 TPS014 TTS031 TBS011

Cabstar F22 1982 1987 4 2.0L Z20 TTS028TTS031TTS036

TBS011 TRS018 3 x Water Temp Senders check illustration

Cabstar F22 1985 1987 4 2.5L SD25 TPS014 TTS028TTS036


Cabstar F22 05/1987 1992 4 2.7L TD27 TPS014 TTS036 TBS007 TRS020

Cabstar H40 05/1987 1992 4 2.7L TD27 TPS017 TTS045 TBS007 TRS020

Cabstar H40,H42 05/1982 1987 4 3.3L ED,FD(T)33 TPS014 TTS031

Cabstar H40 05/1987 1993 4 3.5L FD35(T) TTS031

Civilian Bus W40 05/1984 1991 4 3.3L ED33,FD33 TPS014 TTS028 TBS011

Civilian Bus W40 07/1999 on 6 4.2L TD42 TPS017 TTS036

EXA Coupe 02/1987 1988 4 1.6L CA16DE TPS017 TTS028TTS036

TCS127 TFS144 TBS007 TRS020 2 x Water Temp Senders, check illustrations

EXA Coupe 01/1988 10/1991 4 1.8L CA18DE TPS017 TTS036 TCS127 TFS144 TBS007

Gazelle S12 01/1984 10/1986 4 2.0L CA20E TPS014 TTS028 TCS026 TBS007

Gazelle S12 10/1986 11/1988 4 2.0L CA20E TPS014 TTS028 TCS127 TBS007

Homer F20,T20 1969 1981 4 1.6L,2.0L J16,H20 TPS014 TTS031 TBS011

Infi niti All 1993 1997 V8 4.5L VH45DE TPS017 TTS036 TCS075 TBS007

Maxima HJ30 05/1990 02/1995 V6 3.0L VG30E TPS017 TTS036 TCS127 TBS007

Maxima UA32 02/1995 11/1999 V6 3.0L VQ30DE TPS017 TTS051 TCS075 TBS007

Maxima UA33 11/1999 11/2003 V6 3.0L VQ30DE TPS017 TTS051 TCS075 TBS056

Maxima J31 11/2003 on V6 3.5L VQ35DE TCS075

Micra AK11E 05/1995 12/1997 4 1.3L CG13DE TPS017 TCS075 TRS020

Navara FGD21 01/1986 10/1995 4 2.0L Z20 TPS017 TTS036 TBS007 TRS020

Navara D21 - incl 4WD 01/1986 1996 4 2.4L Z24 TPS017 TTS036 TBS007 TRS020

Navara D21 - incl 4WD 06/1992 10/1995 4 2.4L KA24E TPS017 TTS036 TCS127 TBS007 TRS020

Navara D21 - incl 4WD 10/1995 1997 4 2.4L KA24E TPS017 TTS036 TCS075 TBS007 TRS020

Navara D21 - incl 4WD 06/1992 02/1997 V6 3.0L VG30E TTS036 TCS127 TBS007 TRS020

Navara D21 - Diesel, incl 4WD 01/1986 12/1988 4 2.5L SD25 TPS014TPS017


Navara D21 - Diesel, incl 4WD 01/1988 05/1992 4 2.5L TD25 TPS017 TTS036 TBS007 TRS020

Nissan cont.

45


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Navara D21 - Diesel, incl 4WD 02/1988 02/1997 4 2.7L TD27 TPS017 TTS036 TBS007 TRS020

Navara D22 03/1997 on 4 2.4L KA24D(E) TPS017 TTS051 TCS075 TBS007 TRS020

Navara D22 06/2000 on V6 3.0L,3.3L VG30E,33E TTS051 TCS075 TBS007 TRS020

Navara D22 - Diesel 03/1997 12/2001 4 2.7L,3.2L TD27,QD32 TPS017 TTS051 TCS075 TBS007 TRS020

Navara D22 - Diesel 12/2001 on 4 3.0L Z30 TTS051 TCS075 TBS007 TRS020

NX,NX-R AB13 10/1991 01/1996 4 2.0L SR20DE TPS017 TTS036 TCS127 TBS007 TRS020

Pathfi nder D21 - 4WD 1986 11/1995 4 2.4L Z24 TPS017TPS067

TTS028TTS036

TBS007 TRS020 2 x Water Temp Switches, 2 x Oil Pressure Switches, check illustrations

Pathfi nder D21 - 4WD 1986 11/1995 V6 3.0L VG30E TPS067 TTS036 TCS127 TBS007 TRS020

Pathfi nder R50 - 4WD 1995 on V6 3.3L VG33E TPS017TPS067

TTS051 TCS075 TBS007 TRS020

Patrol G60,MQ 1965 1987 6 2.8L,4.0L L28,P40 TPS014 TTS031 TBS007 TRS020

Patrol GQ 02/1992 1997 6 3.0L RB30S TPS017 TBS007 TRS020

Patrol GQ 02/1988 1999 6 4.2L TB42E,S TPS017 TFS188

Patrol GQ,Y60 02/1992 12/1997 6 4.2L TB42E,S TPS017TPS067


Patrol GU 12/1997 10/2001 6 4.5L TB45E TPS017 TCS075 TFS188

Patrol GU 10/2001 on 6 4.8L TB48DE TCS075

Patrol - Diesel GQ - Turbo 02/1995 12/1997 6 2.8L RD28T TPS017TPS067

TTS036TTS051

TCS075 TBS007 TRS020 2 x Water Temp Switches, 2 x Oil Pressure Switches, check illustrations

Patrol - Diesel GU - Turbo 01/1998 04/2000 6 2.8L RD28ET TPS017TPS067


Patrol - Diesel GU - Turbo 04/2000 on 4 3.0L ZD30T TCS075

Patrol - Diesel MQ - incl Turbo 1980 1987 6 3.3L SD33(T) TPS014 TTS036 TBS007 TRS020

Patrol - Diesel GQ 02/1988 05/1998 6 4.2L TD42 TFS188 TBS007 TRS020

Patrol - Diesel GQ 05/1998 04/2000 6 4.2L TD42 TCS075 TFS188 TBS007 TRS020

Patrol - Diesel GU - Turbo 05/1999 10/2001 6 4.2L TD42T TCS075 TFS188

Patrol - Diesel GU - Turbo 10/2001 on 6 4.2L TD42T TCS075

Pintara U12,R13,R31 06/1986 10/1992 4 2.0L,2.4L CA20E,KA24

TPS017 TTS036 TCS127 TBS007 TRS020

Prairie M10 12/1982 08/1986 4 1.5L E15 TPS006 TTS036 TFS168 TBS007 TRS020

Pulsar N10 10/1981 12/1982 4 1.3L E13 TPS017 TTS028 TFS169 TBS007 TRS020

Pulsar N10 10/1980 1981 4 1.4L A14 TPS014 TTS028 TCS127 TRS018

Pulsar N10 10/1981 1982 4 1.5L E15 TPS017 TTS028 TFS169 TBS007 TRS020

Pulsar N12 11/1982 07/1987 4 1.3L,1.5L E13,E15 TPS008 TFS121TFS168


Pulsar N12 04/1986 07/1987 4 1.6L E16 TPS008 TFS121TFS168


Pulsar N12 - EXA & ET 10/1983 07/1987 4 1.5L E15ET TPS008 TTS031 TCS026 TFS121TFS168


Pulsar N13 06/1987 09/1991 4 1.6L,1.8L 16LF,18LF TPS017 TTS036 TCS040 TFS144 TBS007 TRS020

Nissan cont.

Nissan

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

46

Pulsar N14 10/1991 09/1995 4 1.6L,2.0L GA16,SR20 TPS017 TTS051 TCS127 TBS007 TRS020

Pulsar N15 10/1995 09/2000 4 1.6L,2.0L GA16,SR20 TPS017 TTS051 TCS075 TBS007 TRS020

Pulsar N16 07/2000 on 4 1.6L,1.8L QG16,QG18 TPS017 TTS051 TCS075 TBS056

Serena AC23 10/1992 11/1995 4 2.0L SR20DE TPS017 TTS036 TCS127 TBS007 TRS020

Silvia - Imported S12 - turbo 12/1984 05/1988 4 1.8L CA18ET TPS007 TTS028 TBS007

Silvia - Imported S12 - incl turbo 03/1983 02/1986 4 2.0L FJ20(T) TPS014 TTS031

Silvia - Imported S14 - incl Turbo 10/1993 01/1999 4 2.0L SR20DE(T) TPS017 TTS036 TCS127 TBS007 TRS020

Skyline C210 03/1978 03/1981 6 2.4L L24 TPS014TPS067


Skyline R30 - EFI 03/1981 06/1986 6 2.4L L24E TPS014TPS067


Skyline R31 - EFI 07/1986 12/1990 6 3.0L RB30E TPS017TPS064

TCS127 2 x Oil Pressure Switches, check illustrations

Skyline GT-R, Twin Turbo 06/1991 02/1993 6 2.6L RB26DETT TPS017TPS064

TTS036 2 x Oil Pressure Switches, check illustrations

Skyline - Imported R31,R32,R33,R34 - incl turbo

08/1985 2000 6 2.0L RB20E,T,TD TPS017TPS064


Skyline - Imported R32,R33,R34 - incl turbo

08/1991 2000 6 2.5L RB25DE,DET

TPS017TPS064


Skyline - Imported R32,R33,R34 - incl turbo

08/1989 2000 6 2.6L RB26D(E)TT TPS017TPS064


ST - Ute XFN 07/1988 09/1992 6 4.1L Falcon TPS061 TCS040

Stanza A10 10/1978 09/1983 4 1.6L L16 TPS014 TTS028

Sunny B310 1979 1983 4 ALL TPS017 TTS036 TBS007 TRS020

Terrano II R20 - incl Turbo Diesel 03/1997 03/2000 4 2.4L,2.7L KA24,TD27T TPS017 TTS045 TCS075 TBS007 TRS020

Urvan E20,E23 01/1974 1982 4 1.6L,2.0L All TPS014 TTS031 TBS011

Urvan E23 09/1982 1986 4 2.0L Z20S TPS017 TTS028 TBS007 TRS020

Urvan E24 03/1987 09/1993 4 2.4L Z24 TPS014 TTS028TTS036


Urvan E23 - Diesel 11/1980 1986 4 2.2L,2.3L SD22,SD23 TPS017 TTS028 TBS011 TRS018

Urvan E24 - Diesel 05/1987 12/1992 4 2.7L TD27 TPS014 TTS036 TBS007 TRS018

Vanette C22 12/1986 03/1988 4 2.0L Z20 TPS017 TTS028TTS036


Vanette C22 04/1988 1993 4 2.0L Z20 TPS017 TTS036 TBS007 TRS020

X-Trail T30 - 4D Wagon 10/2001 on 4 2.5L QR25 TTS051 TCS075 TBS056

Peugeot

205 Si 1991 1994 4 1.6L XU5M3 TPS023 TRS030 For correct application, check illustrations

205 GTi 1987 1994 4 1.9L XU9JA(Z) TPS023 TFS171 TRS030 For correct application, check illustrations

206 XR Manual 03/2002 on 4 1.4L TP3UJP TPS023TPS050

TBS040 TRS030 For correct application, check illustrations

206 XR Auto 03/2002 on 4 1.4L TP3UJP TPS023TPS050

TRS030 For correct application, check illustrations

206 CC Auto 10/2001 on 4 1.6L TU5JP4 TPS050 TTS512

Nissan cont.

47


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

206 CC Manual 10/2001 on 4 2.0L EW10J4 TTS512 TCS109 TBS040

206 GTI 2D Hatchback 2003 on 4 2.0L EW10J4 TPS050 TCS109 TBS040

306 N3,N5 04/1994 2001 4 1.8L XU7JP TPS047TPS050

TTS057TTS515

TFS185TFS207


306 N3,N5 - Manual 11/1995 06/1997 4 2.0L XU10J2 TPS047 TTS057 TFS185 TBS040 TRS030 2 x Water Temp Senders, check illustrations

306 N3,N5 - Auto 11/1995 06/1997 4 2.0L XU10J2 TPS047 TTS057 TFS207 TBS040 2 x Water Temp Senders, check illustrations

306 N3 07/1994 06/1997 4 2.0L XU10J4 TPS047TPS050

TTS057TTS515


306 N5 - Auto 07/1997 2001 4 2.0L XU10J4 TPS047TPS050

TTS057TTS515

TFS207 TBS040 For correct application, check illustrations and spec tables

306 N5 - Manual 07/1997 2001 4 2.0L XU10J4 TPS047TPS050

TTS057TTS515


306 N5 - Turbo Diesel 04/1996 12/2001 4 1.9L XUD9TE/L3 TPS047TPS050

TTS057TTS511TTS515


307 1.6L 12/2001 on 4 1.6L TU5JP4 TPS050 TTS512 TBS040

307 2.0L 12/2001 on 4 2.0L EW10J4 TPS050 TCS109 TBS040

307 HDI 12/2001 on 4 2.0L DW10 (Hdi) TPS050 TBS040

307 CC 11/2003 on 4 2.0L EW10J4 TPS050 TCS109 TBS040

405 Mi16 02/1989 04/1993 4 1.9L D6C,XU9J4 TPS023 TRS030 For correct application, check illustrations and spec tables

405 SRi, STi 05/1993 05/1996 4 2.0L XU10J2 TPS047 TTS057TTS515


405 SRDT Turbo Diesel 1993 1996 4 1.8L XU9TE TPS023 TFS207 TRS030 For correct application, check illustrations and spec tables

406 ST 4D Sedan 09/1996 08/2004 4 2.0L XU10J4R TPS050 TTS057TTS515

TFS185TFS207


406 3.0L V6 10/1997 08/2004 V6 3.0L ES9J4 TPS047TPS050


406 HDi Turbo Diesel 08/1999 08/2004 4 2.0L DW10ATED TPS050 TBS040 TRS030 For correct application, check illustrations and spec tables

406 STDT Turbo Diesel 10/1997 1999 4 2.1L XUD11BTE TPS047 TTS057 TBS040 TRS030 For correct application, check illustrations and spec tables

605 SV 03/1994 08/1996 V6 3.0L ZPJ TPS047 TTS039TTS515


607 4D Sedan 10/2001 on V6 3.0L ES9 J4S/L4 TPS050 TBS040

Porsche

924 incl Turbo 1979 1982 4 2.0L TPS020 TFS104

924,924S,944 incl Turbo 1982 1989 4 2.5L TPS020 TFS104

944 1988 1989 4 2.7L TPS020 TFS104

928 1977 1982 V8 4.5L TPS020 TCS026 TFS104

928,928S 1979 1985 V8 4.7L M28 TFS104

Peugeot cont.

Nissan, Peugeot, Porsche

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

48

M21 10/1997 1999 4 1.8L 4G93 TCS055 TFS141

Persona Gli 11/1996 1999 4 1.5L S3/4G15 TTS001 TCS055 TFS141

Persona Xli 11/1996 10/2004 4 1.6L S4/4G92 TCS055 TFS141

Satria GL, Gli 02/1997 1999 4 1.5L S3/4G15 TCS050 TFS141

Satria Xli 02/1997 on 4 1.6L S4/4G92 TCS055 TFS141

Wira 05/1995 11/1996 4 1.5L 4G15 TTS001 TCS050 TFS141

Wira 05/1995 11/1996 4 1.6L 4G92 TTS001 TCS055 TFS141

Renault

Fuego 08/1984 1988 4 2.0L J6R TFS171

Kangoo Van 09/2004 on 4 1.6L K4M TPS059

Laguna 1995 1996 4,V6 2.0L,3.0L F3R,Z7X TFS182TFS210


Master 2.5 dCi 09/2004 on 4 2.5L G9U TPS059

Megane ll All 2003 on 4 1.6L,2.0L K4M,F4R(T) TPS059

R10,R12,R15,R16,R18

1966 1983 4 ALL TFS171

R21,R25 1985 1991 4,V6 ALL J7T,Z7W TFS182

Rover

75 03/2001 on 4,V6 2.0L,2.5L TPS039

825,827 Sterling,Vitesse 1987 1992 V6 2.5L,2.7L C25,C27 TPS013 TFS147

3500 1968 1987 V8 3.5L TPS061 TTS029 TBS025 TRS025

Quintet 1983 1986 4 1.6L EL TPS013 TFS131

Saab

99 1971 1973 4 1.9L TPS020 TTS024

99 1976 1979 4 2.0L TTS024

900 EFI 03/1979 1984 4 2.0L B120 TPS020 TTS024 TFS135

900 EFI 04/1983 1988 4 2.0L B201 TPS020 TTS024 TFS170

900 EFI 03/1988 1991 4 2.0L B202 TTS024 TFS170

900 Turbo 06/1985 1993 4 2.0L B202L TTS024 TFS170

9000 incl Turbo 01/1987 02/1991 4 2.0L B202 TFS170

9000 incl Turbo 05/1990 1998 4 2.3L B234(L,ET,T)

TFS146TFS184TFS206

3 x Thermo Fan Switches check illustrations

Seat

Cordoba GLX 01/1995 1997 4 1.8L ABS/ABY TPS030TPS045

TTS504TTS507


TRS032TRS033


Cordoba SXE 09/1998 10/1999 4 1.6L AFT TPS045 TTS504TTS505

TFS173 TBS028TBS050

TRS032TRS033


Cordoba SXE 09/1998 10/1999 4 1.8L ADZ TPS045 TTS504TTS505TTS509

TFS173 TBS028TBS050

TRS032TRS033


Proton

49


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Ibiza CLX 01/1995 01/1997 4 1.4L ABD TPS045 TTS504TTS505

TCS091 TFS173TFS208TFS211

TBS028TBS050

TRS032TRS033


Ibiza GTi 01/1995 01/1997 4 2.0L 2E TPS030TPS045

TTS504TTS505TTS507

TCS091 TFS173TFS208TFS211

TBS028TBS050

TRS032TRS033


Ibiza Cupra Sport 09/1998 10/1999 4 2.0L ABF TPS030TPS045

TTS507 TFS213 TBS050 TRS032TRS045


Toledo GLX 01/1995 01/1997 4 2.0L 2E TPS021TPS030

TTS038TTS507

TCS091 TFS208TFS211

TRS032TRS033


Toledo 2.0 16V 10/1995 01/1997 4 2.0L ABF TPS021TPS030TPS045

TCS091 TFS208TFS211


Smart

City,Pulse,Roadster

05/2003 on 3 698cc M160 TPS026

Ssangyong

Korando 02/1998 07/1998 4 2.3L M161-97 TPS044 TTS039

Korando 03/2004 on 5 2.9L 662LA TPS044 TTS039 TBS016

Subaru

Brumby 1978 03/1994 4 1.6L,1.8L EA71,EA81 TPS008 TTS005 TFS195 TBS002

DL,GL,Leone incl 4WD 1976 11/1984 4 1.6L,1.8L EA71,EA81 TPS008 TTS005 TFS195 TBS002

DL,GL,Leone 2WD - Carb. 12/1984 01/1995 4 1.8L EA82 TPS008 TTS005 TFS148TFS228


DL,GL - Sportswagon

4WD - Carb. 01/1985 01/1995 4 1.8L EA82 TPS008 TTS005 TFS148TFS228


DL,GL 4WD - EFI 09/1988 09/1990 4 1.8L EA82 TPS008 TTS005 TCS026 TFS148TFS228


Fiori 11/1989 12/1992 4 758cc EN08 TFS195

Forester 08/1997 06/2002 4 2.0L EJ20E TPS008 TTS001 TCS080 TFS195 TBS007TBS042


Forester GT - Turbo 09/1998 06/2002 4 2.0L EJ20J TPS008 TFS195 TBS007TBS042


Impreza LX 04/1993 09/1998 4 1.6L EJ16 TTS001 TCS080 TBS007

Impreza GX 04/1993 11/1996 4 1.8L EJ18S TPS008 TTS001 TCS080 TBS007TBS042


Impreza GX - AWD 04/1993 11/1996 4 1.8L EJ18S TPS008 TTS001 TCS080 TBS007TBS042


Seat cont.

Proton, Renault, Rover, Saab, Seat, Smart, Ssangyong, Subaru

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

50

Impreza GX,LX,RX 11/1996 10/2000 4 2.0L EJ20E TPS008 TTS001 TCS080 TFS195 TBS007TBS042


Impreza GX,RV,RX 10/2000 on 4 2.0L EJ20,EJ201 TPS008 TTS001 TCS080 TBS042 TRS044

Impreza WRX - Turbo 02/1994 on 4 2.0L EJ20 TPS008 TTS001 TCS080 TBS042 TRS044

Liberty GX - AWD 10/1998 08/2003 4 2.0L EJ20E TPS008 TFS148TFS195

TBS007TBS042

2 x Stop Light Switches TBS007 (without cruise control), TBS042 (with cruise control) check illustrations2 x Thermo Fan Switches check Illustrations

Liberty 4WD Turbo 10/1991 06/1994 4 2.0L EJ20 TPS008 TTS001 TCS080 TBS007TBS042


Liberty B4 03/1999 2003 4 2.0L H4-2.0 TPS008 TBS007TBS042


Liberty GX ,LX - FWD,AWD 10/1989 03/1999 4 2.2L EJ22 TPS008 TTS001 TCS080 TFS148 TBS007TBS042


Liberty RX 11/1996 03/1999 4 2.5L EJ25D TPS008 TTS001 TCS080 TBS007TBS042


Liberty RX 03/1999 2003 4 2.5L EJ25D TPS008 TFS195 TBS007TBS042


Outback 09/1996 2000 4 2.5L EJ25 TPS008 TTS001 TFS195 TBS007TBS042


RX 4WD - Turbo RX 4WD - Turbo 11/1985 08/1987 4 1.8L EA82 TPS008 TTS005 TCS026 TFS148TFS228


RX 4WD - Turbo RX 4WD - Turbo 08/1987 03/1988 4 1.8L EA82 TPS008 TTS005 TFS148TFS228


SVX CX 03/1992 04/1997 6 3.3L EG33 TPS008 TTS001 TCS080 TFS148 TBS042

Vortex XT 4WD Turbo 09/1985 09/1989 4 1.8L EA82 TPS008 TTS005 TCS026 TFS174 TBS002

Suzuki

Alto 05/1985 02/1989 3 ALL TPS007 TTS004 TFS131TFS156


Alto 03/1996 04/1998 4 993cc G10B TFS158

Baleno SH410 04/1995 01/1999 4 1.6L G16B TPS007 TBS012 TRS003

Baleno SB308 03/1996 01/1999 4 1.8L J18A TPS007 TBS012 TRS003

Carry ST80,ST90 06/1978 07/1985 4 797cc F8A TPS007 TTS002 TBS010 TRS001

Hatch SS40V,SS80V 02/1980 1985 3 ALL TPS013 TTS004 TFS131 TBS010

Ignis GA,GL 10/2000 02/2005 4 1.3L M13A TPS013

Subaru cont.

51


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Jimny JX,JLX - 4x4 10/1998 on 4 1.3L G13BB TPS013 TTS001 TBS019 TRS002

LJ80,LJ81 11/1977 12/1981 4 797cc F8A TTS002 TFS156 TBS010

Mighty Boy SS40T 07/1985 10/1988 3 543cc F5A TPS013 TTS004 TFS156 TBS010

Sierra SJ410 07/1981 07/1988 4 1.0L F10A TPS007 TTS002 TBS010 TRS001

Sierra MJ410 - Stockman 03/1990 1996 4 1.0L F10A TPS013 TTS001 TBS010 TRS001

Sierra SJ413 10/1984 12/1990 4 1.3L G13A TPS007 TTS004 TFS116 TBS010 TRS001

Sierra SJ413 03/1990 1998 4 1.3L G13BA TPS007 TTS004 TBS010 TRS001

Super Carry SK410 07/1985 12/1990 4 970cc F10A TPS007 TTS004 TBS010 TRS001

Swift SOHC - Carb. 03/1984 12/1988 3 993cc G10A TPS007 TTS004 TFS116 TBS012

Swift SOHC - Carb. 01/1989 1996 3 993cc G10A TPS007 TTS004 TFS157 TBS010 TRS003

Swift SOHC - Carb. 01/1985 03/1987 4 1.3L G13A TPS007 TTS004 TCS032 TFS116 TBS010

Swift SOHC - Carb. 12/1990 09/1995 4 1.3L G13A TPS007 TTS001TTS004


Swift GTi - DOHC, EFI 10/1986 12/1988 4 1.3L G13B TPS007 TTS004 TCS065 TFS116 TBS010

Swift GTi - DOHC, EFI 01/1989 2000 4 1.3L G13B TPS007 TTS001TTS004


Cino DOHC 05/1994 2000 4 1.3L G13B TFS158TFS225


Swift DOHC - EFI, incl 4WD 10/1989 05/1995 4 1.6L G16B TPS007 TTS001TTS004


Vitara SOHC - Carb. 07/1988 11/1994 4 1.6L G16A TPS007 TTS001TTS004


Vitara EFI - Manual 10/1994 12/1998 4 1.6L G16B TPS007 TTS001TTS004


Vitara EFI - Auto 10/1994 12/1998 4 1.6L G16B TPS007 TTS001TTS004


Vitara SE420 05/1997 04/2000 4 2.0L J20A TPS013 TBS019TBS048


Vitara SV620 - LWB 04/1995 09/1999 V6 2.0L H20A TPS013 TBS019TBS048


Grand Vitara SQ420 04/1998 07/2001 4 2.0L J20A TPS013 TBS019TBS048


Grand Vitara SQ625 04/1998 07/2001 V6 2.5L H25A TPS013 TBS019TBS048


Wagon SR410 10/1997 1999 4 1.0L K10A TPS013 TRS003

X90 4 x 4 04/1996 05/1998 4 1.6L G16B TPS007 TTS001 TCS032 TBS012TBS019


Toyota

4 Runner YN60,YN63 07/1984 12/1988 4 2.0L,2.2L 3Y-C,4Y-C TPS007 TTS006 TFS159 TRS006

4 Runner YN130 10/1989 12/1990 4 2.2L 4Y-E TPS007 TTS006 TCS032 TFS160 TRS006

Suzuki cont.

Subaru, Suzuki, Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

52

4 Runner YN63 10/1988 09/1989 4 2.2L 4Y-EC TPS007 TTS006 TCS024 TFS159 TRS006

4 Runner YN63 05/1989 09/1989 4 2.4L 22R TPS008 TTS006 TBS005TBS018


4 Runner RN130R 10/1989 08/1990 4 2.4L 22R TPS008TPS011


4 Runner RN130R 08/1990 06/1996 4 2.4L 22R TPS008TPS011

TTS006TTS007

TFS159 TBS005 TRS007 2 x Oil Pressure Switches & 2 x Water Temp Senders check illustrations

4 Runner VZN130 10/1990 08/1992 V6 3.0L 3VZ-E TPS002TPS004

TTS006 TFS154 TBS005TBS018

TRS007 2 x Oil Pressure Switches2 x Stop Light Switches TBS005 (without cruise control), TBS018 (with cruise control) check illustrations

4 Runner VZN130 08/1992 06/1996 V6 3.0L 3VZ-E TPS002TPS004


TRS007 2 x Oil Pressure Switches2 x Stop Light Switches TBS005 (without cruise control), TBS018 (with cruise control) check illustrations

4 Runner - Diesel LN60,LN61 07/1984 1989 4 2.4L 2L TPS006 TTS006 TFS160 TBS006 TRS007

4 Runner - Diesel LN61 05/1989 09/1989 4 2.8L 3L TPS006 TTS006 TFS160 TBS006 TRS007

4 Runner - Diesel LN130R 10/1989 08/1992 4 2.8L 3L TPS002TPS006

TTS006 TFS160 TBS005 TRS007 2 x Oil Pressure Switches TPS002(gauge), TPS006(Light), check illustrations

4 Runner - Diesel LN130R 08/1992 06/1996 4 2.8L 3L TPS002TPS006

TTS007 TFS160 TBS005 TRS007 2 x Oil Pressure Switches TPS002(gauge), TPS006(Light), check illustrations

Avalon MCX10R 07/2000 on V6 3.0L 1MZ-FE TPS011 TTS008 TCS032 TFS194 TBS005TBS018


Blizzard LD10 - Diesel 03/1982 12/1983 4 2.2L L TPS006 TTS006 TBS009 TRS007

Bundera RJ70 11/1984 12/1991 4 2.4L 22R TPS007 TTS006 TBS009 TRS007

Bundera LJ70 - Turbo Diesel 01/1986 12/1991 4 2.4L 2L-T TPS006 TTS006 TBS009 TRS007

Camry - 4 Cyl SV11 04/1983 06/1984 4 2.0L 2SEC TPS008 TTS006 TCS024 TFS120 TBS009

Camry - 4 Cyl SV11 06/1984 04/1987 4 2.0L 2SEC TPS008 TTS006 TCS024 TFS120 TBS009 TRS006

Camry - 4 Cyl SV20 05/1987 08/1989 4 1.8L 1SE TPS008 TTS006 TCS024 TFS120 TBS009 TRS006

Camry - 4 Cyl SV21 05/1987 06/1989 4 2.0L 3S-FE TPS008 TTS001 TCS024 TFS120 TBS017 TRS006

Camry - 4 Cyl SV21 06/1989 02/1993 4 2.0L 3S-FE TPS008 TTS001 TCS024 TFS120 TBS014 TRS007

Camry - 4 Cyl SV22 09/1989 06/1991 4 2.0L 3S-FC TPS008 TTS001 TCS032 TFS120 TBS017 TRS007

Camry - 4 Cyl SDV10 02/1993 04/1995 4 2.2L 5S-FE TPS011 TTS007 TCS032 TFS119 TBS005TBS018


Camry - 4 Cyl SXV10 04/1995 03/1998 4 2.2L 5S-FE TPS011 TTS007 TCS032 TFS119 TBS005 TRS007

Camry - 4 Cyl SXV20R 08/1997 08/2002 4 2.2L 5S-FE TPS011 TTS008 TCS032 TFS119 TBS005TBS018


Toyota cont.

53


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Camry - 4 Cyl ACV36R 09/2002 on 4 2.4L 2AZ-FE TPS011 TCS120 TBS005TBS018


Camry - 6 Cyl VZV20 06/1988 08/1988 V6 2.5L 2VZ-FE TPS008 TTS006 TCS024 TFS120 TBS014TBS017


Camry - 6 Cyl VZV20,VZV21 08/1988 02/1993 V6 2.5L 2VZ-FE TPS008 TTS006 TCS032 TFS120 TBS014TBS017


Camry - 6 Cyl VDV10 02/1993 08/1995 V6 3.0L 3VZ-FE TPS011 TTS001 TFS119 TBS005TBS018


Camry - 6 Cyl VCV10 08/1995 09/1997 V6 3.0L 3VZ-FE TPS011 TTS001 TCS032 TFS119 TBS005 TRS007

Camry - 6 Cyl MCV20R 08/1997 08/2002 V6 3.0L 1MZ-FE TPS011 TTS008 TFS197 TBS005TBS018


Camry - 6 Cyl MCV36R 09/2002 on V6 3.0L 1MZ-FE TPS011 TTS008 TCS117 TBS005TBS018


Camry Avensis ACM20R 05/2001 10/2003 4 2.0L 1AZ-FE TPS011 TCS032

Camry Avensis ACM21R 10/2003 on 4 2.4L 2AZ-FE TPS011 TCS120

Camry Vienta VZV20, VZV21 08/1988 02/1993 V6 2.5L 2VZ-FE TPS008 TTS006 TCS032 TFS120 TBS009TBS017


Camry Vienta VDV10R 02/1993 08/1997 V6 3.0L 3VZ-FE TPS011 TTS001 TCS032 TFS119 TBS005TBS018


Camry Vienta MCV20R 08/1997 10/2000 V6 3.0L 1MZ-FE TPS011 TTS008 TFS197 TBS005TBS018


Celica RA23,RA28,TA22,TA23 11/1971 10/1977 4 1.6L,2.0L 18R,2T TPS007 TTS005 TFS150 TBS006 TRS006

Celica RA40R 11/1977 10/1981 4 2.0L 18R-C TPS005 TTS006 TFS150 TBS006 TRS005

Celica RA60R 11/1981 09/1983 4 2.0L 21R-C TPS007 TTS006 TFS150 TBS006

Celica SA63 10/1983 09/1984 4 2.0L 2S-C TPS007 TTS006 TFS150TFS152


Celica RA65R 10/1984 12/1985 4 2.4L 22R-EC TPS008 TTS006 TFS150 TBS006

Celica ST162R 10/1985 03/1989 4 2.0L 3S-FE TPS005 TTS001 TCS024 TFS152 TBS009 TRS006

Celica ST162R 10/1985 03/1989 4 2.0L 3S-GE TPS005 TTS006 TCS024 TFS152 TBS009TBS017


Celica ST184R 09/1989 03/1994 4 2.2L 5S-FE TPS008 TTS007 TCS032 TFS119 TBS005TBS018


Toyota cont.

Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

54

Celica - Imported ST185 09/1989 03/1993 4 2.0L 3S-GTE TPS008 TTS006 TBS005 TRS007

Celica ST185R 03/1990 12/1992 4 2.0L 3S-GTE TPS008 TTS006 TCS032 TFS152 TBS005 TRS007

Celica ST204R - SX,ZR 03/1994 11/1999 4 2.2L 5S-FE TPS011 TTS008 TCS032 TFS119 TBS005TBS018


Celica ST205R - GT-Four 05/1994 12/1994 4 2.0L 3S-GTE TPS011 TTS007 TFS119 TBS005 TRS007

Celica ZZT231 - SX,ZR 11/1999 on 4 1.8L 2ZZGE TRS046

Coaster All Petrol 1968 09/1992 4 2.0L,2.2L2.4L

5R,20R,22R TPS007 TTS005 TBS009

Coaster - Diesel BU,BB 1974 1984 4 3.0L,3.2L B,2B TPS007 TTS005 TBS009

Coaster - Diesel BB20,BB21 01/1984 06/1992 4 3.4L 3B TPS007 TTS005 TBS009

Coaster - Diesel HB30 01/1987 12/1990 6 4.0L 2H TPS006 TTS006 TBS009 TRS006

Coaster - Diesel BB40 01/1993 07/1999 4 3.4L 3B TPS011 TTS007 TRS007

Coaster - Diesel HB30,HZB30 01/1993 08/2004 6 4.2L 1HZ TPS008 TTS007 TRS007

Coaster - Diesel HZB50 01/1993 08/2004 6 4.2L 1HZ TPS007TPS008

TTS007 TRS007 2 x Oil Pressure Switches, check illustrations

Corolla KE10 1966 1970 4 1.1L K TPS007 TTS005 TBS008

Corolla KE20 1970 1974 4 1.2L 3K-C TPS008 TTS005 TFS151 TBS008 Stop Light Switch on models without brake warning

Corolla KE30,KE35,KE36,KE50 11/1974 11/1978 4 1.2L 3K-C TPS008 TTS005 TFS151 TBS006 Stop Light Switch on models without brake warning

Corolla KE38,KE55 11/1978 08/1979 4 1.3L 4K-C TPS008 TTS005 TFS151

Corolla KE38,KE55 08/1979 11/1981 4 1.3L 4K-C TPS008 TTS006 TFS151

Corolla KE70R 10/1981 04/1985 4 1.3L 4K-C TPS008 TFS151 TBS006

Corolla AE71 10/1983 04/1985 4 1.6L 4A-C TPS008 TTS001 TFS150 TBS009 TRS007

Corolla AE80,AE82 04/1985 05/1989 4 1.3L,1.6L 2A-C,4A-LC TPS008 TTS005 TFS150 TBS006 TRS006 2 x Water Temp Senders, check illustrations

Corolla AE82 - DOHC 06/1986 05/1989 4 1.6L 4A-GE TPS008 TTS005 TCS024 TFS150 TBS006 TRS006 2 x Water Temp Senders, check illustrations

Corolla AE86 - Sprinter 07/1983 11/1987 4 1.6L 4A-C TTS006 TFS150 TBS009

Corolla AE90 07/1989 11/1992 4 1.4L 6A-FC TPS007 TTS001 TFS120

Corolla AE92 - Carb. 06/1989 04/1994 4 1.6L 4A-FC TPS006 TTS001 TCS032 TFS191 TBS009 TRS007

Corolla AE92,AE92R - EFI, incl 4WD

07/1989 09/1994 4 1.6L 4A-FE,GE TPS006 TTS001 TCS032 TFS150 TBS009 TRS007

Corolla AE93 11/1992 09/1994 4 1.8L 7A-FE TPS011 TTS008 TCS032 TFS191 TBS009 TRS007

Corolla AE95R 04/1988 07/1995 4 1.6L 4A-FE TPS006 TTS001 TCS032 TBS009 TRS007

Corolla AE95R - 4WD 04/1988 07/1995 4 1.6L 4A-GE TPS006 TTS001 TFS191 TBS009 TRS007

Corolla AE101R 07/1994 04/1998 4 1.6L 4A-FE TPS011 TTS008 TCS032 TFS191 TBS005TBS018


Corolla AE102R,AE102X 09/1994 09/1998 4 1.8L 7A-FE TPS011 TTS008 TCS032 TFS191 TBS005 TRS007

Corolla AE112 04/1997 12/2001 4 1.8L 7A-FE TPS011 TTS008 TCS032 TFS191 TBS005 TRS007

Toyota cont.

55


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Corolla ZZE122R 12/2001 on 4 1.8L 1ZZ-FE TPS011 TCS032 TBS005 TRS007

Corolla ZZE123 - Sportivo 05/2003 on 4 1.8L 2ZZ-GE TPS011 TCS032 TBS005 TRS007

Corona RT40,RT80,RT81 1964 1974 4 1.5L,1.6L 2R.12R TPS006 TTS005 TBS008 TRS005

Corona RT72 1969 1972 4 1.9L 8R TPS006 TTS005 TBS006 TRS005

Corona MX10,MX13,MX22,MX23

07/1972 12/1977 6 2.0L,2.3L2.6L

M,2M,4M TPS006 TTS005 TBS005TBS006


Corona RT104 03/1974 09/1979 4 2.0L 18R-C TPS002TPS006


Corona RT118 08/1977 09/1979 4 2.0L 18R-C TPS006 TTS005 TBS006 TRS005

Corona XT130 10/1979 07/1983 4 1.9L Starfi re TPS006 TTS005 TBS006 TRS005

Corona RT132 10/1979 1982 4 2.0L 18R-C TPS007 TTS006 TBS006 TRS006

Corona RT133 01/1982 1983 4 2.0L 21R-C TPS008 TTS006 TBS006 TRS005

Corona incl Avante

RT142 - without cruise control

11/1984 04/1987 4 2.4L 22R-E TPS002TPS004TPS008

TTS006 TCS024 TFS143TFS150TFS152

TBS006 3 x Oil Pressure Switches TPS002(gauge), TPS004(gauge), TPS008(Light)3 x Thermo Fan Switches check illustrations

Corona incl Avante

RT142 - with cruise control

11/1984 04/1987 4 2.4L 22R-E TPS002TPS004TPS008

TTS006 TCS024 TFS143TFS150TFS152

TBS063 3 x Oil Pressure Switches TPS002(gauge), TPS004(gauge), TPS008(Light)3 x Thermo Fan Switches check illustrations

Corona incl Avante

ST141 - without cruise contol

08/1983 04/1987 4 2.0L 2S-C TPS002TPS005TPS008

TTS006 TFS150TFS152

TBS006 TRS005 3 x Oil Pressure Switches TPS002(gauge), TPS005(gauge), TPS006(Light)

Corona incl Avante

ST141 - with cruise contol

08/1983 04/1987 4 2.0L 2S-C TPS002TPS005TPS008

TTS006 TFS150TFS152

TBS063 TRS005 3 x Oil Pressure Switches TPS002(gauge), TPS005(gauge), TPS006(Light)2 x Thermo Fan Switches check illustrations

Cressida MX32,MX36 03/1977 1981 6 2.6L 4M TPS007 TTS006 TRS006

Cressida MX62R 02/1981 04/1985 6 2.8L 5M-E TPS002TPS004


Cressida MX73R 11/1984 10/1985 6 2.8L 5M-E TPS006 TTS006 TCS024 TBS009TBS017


Cressida MX73R - DOHC 11/1985 12/1988 6 2.8L 5M-GE TPS008 TTS006 TCS024 TBS009TBS017


Cressida MX83R 08/1988 08/1990 6 3.0L 7M-GE TPS006 TTS006 TCS032 TBS009TBS017


Cressida MX83R 08/1990 02/1993 6 3.0L 7M-GE TPS006 TTS006 TCS032 TBS018 TRS006

Crown RS56 1968 1971 4 2.0L 5R TPS007 TTS005 TBS008

Crown MS65,MS83,MS85,MS111

1971 1980 6 2.6L 4M TPS007 TTS005 TBS006 TRS006

Crown MS112 10/1980 09/1983 6 2.8L 5M-E TPS006 TTS006 TBS006 TRS006

Toyota cont.

Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

56

Crown MS123 10/1983 11/1985 6 2.8L 5M-E TPS006 TTS006 TCS024 TBS009TBS017


Crown MS125 12/1985 05/1988 6 2.8L 5M-GE TPS006 TTS006 TCS024 TBS006 TRS006

Dyna All 2.0L Petrol 1969 1984 4 2.0L 5R TPS006 TTS005

Dyna 100 YH81R 11/1985 2001 4 1.8L 2Y-C TPS008 TTS006 TFS155 TBS006 TRS006

Dyna 200 YU60,YU62 11/1984 12/1991 4 2.0L,2.2L 3Y-C,4Y-C TPS007 TTS006 TFS155 TBS006 TRS006

Dyna 200 BU300 2003 on 4 4.1L 15B-FTE TTS007 TBS018

Dyna - Diesel HU15,HU30,HU40 1969 1984 6 3.6L,4.0L H,2H TPS006 TTS006 TBS009 TRS006

Dyna - Diesel BU20,BU32,BU36 08/1977 1984 4 3.0L,3.4L B,3B TPS008 TTS005

Dyna - Diesel, 150 LY60 11/1985 09/1988 4 2.4L 2L TPS006 TTS006 TBS006 TRS006

Dyna - Diesel, 100,150

LH80,LY61 11/1985 06/1995 4 2.4L 2L TPS007 TTS007 TBS006 TRS007

Dyna - Diesel, 150 LY61,LY211 10/1988 09/2001 4 2.8L 3L TPS006 TTS007 TBS006 TRS007

Dyna - Diesel, 200 BU60,BU61,BU63,BU65,BU66

11/1984 06/1995 4 3.0L B,11B,14B TPS007 TTS005 TBS006 TRS006

Dyna - Diesel, 200 BU100R,BU110 07/1995 05/2003 4 3.4L 13B TPS011 TTS007 TRS046

Dyna - Diesel, 200 BU142 07/1995 05/2003 4 4.1L 15B TPS011 TTS007 TBS018 TRS046

Dyna - Diesel, 200 BU212 11/1997 05/2003 4 4.1L 15B TPS011 TTS007 TRS046

Dyna - Diesel, 300 BU85,BU88 11/1984 06/1995 4 3.4L,3.7L 13B,14B TPS007 TTS005 TBS006 TRS006

Dyna - Diesel, 300 BU212 11/1997 05/2003 4 4.1L 15B-F TTS007 TBS018

Dyna - Diesel, 400 WU90,BU91 11/1984 06/1995 4 4.0L 1W TPS007 TTS006 TBS006 TRS006

Dyna - Diesel, 400 BU212 07/1995 05/2003 4 4.1L 15B-F TTS007 TBS018

Echo NCP10R,NCP12R Sedan & Hatch

10/1999 on 4 1.3L,1.5L 1NZFE2NZFE

TPS011 TCS119 TFS199 TBS005 TRS007

Echo NCP13R - Sportivo 03/2001 on 4 1.5L 1NZ-FE TPS011 TCS119 TBS005 TRS007

Estima - Imported TCR10W,TCR20W 02/1993 01/1998 4 2.4L 2TZ-FE TPS011 TTS007 TBS009 TRS007

Estima - Imported TCR11W,TCR21W 05/1990 12/1999 4 2.4L 2TZ-FE TPS008TPS011

TTS006TTS007

TBS009 TRS007 2 x Oil Pressure Switches & 2 x Water Temp Senders check illustrations

Hi-Ace RH10,RH15 1967 1977 4 1.5L 2R TPS007 TTS005 TBS006 TRS006

Hi-Ace RH11,RH16,RH20,RH30 01/1972 12/1985 4 1.6L 12R TPS007 TTS005 TFS143 TBS006 TRS006

Hi-Ace RH32 05/1977 12/1982 4 2.0L 18R-C TPS007 TTS005 TFS143 TBS006

Hi-Ace YH50,YH51,YH60,YH61,YH71

01/1983 09/1986 4 1.8L,2.0L 2Y-C,3Y-C TPS007 TTS006 TBS006 TRS006

Hi-Ace YH53,YH63,YH73 10/1986 09/1989 4 2.2L 4Y-C TPS007 TTS006 TFS119TFS155


Hi-Ace RZH103,RZH113 10/1989 09/1998 4 2.4L 2RZ TPS008TPS011

TTS007 TCS032 TBS005 TRS007 2 x Oil Pressure Switches, check illustrations

Hi-Ace RZH103R,RXH113R - EFI

09/1998 02/2005 4 2.4L 2RZE TPS011 TTS007 TCS032 TBS005 TRS007

Toyota cont.

57


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Hi-Ace RZH125 10/1989 09/1998 4 2.4L 2RZE TPS011 TTS006TTS007

TCS032 TBS002TBS005

TRS007 2 x Water Temp Senders & 2 x Stop Light Switches check illustrations

Hi-Ace RZH125R - EFI 09/1998 02/2005 4 2.4L 2RZE TPS011 TTS006TTS007


Hi-Ace - SBV RCH12R 10/1995 02/2005 4 2.4L 2RZE TTS007 TCS032 TBS005 TRS007

Hi-Ace - Diesel LH20,LH30,LH50,LH60,LH70

1981 02/1984 4 2.2L L TPS007 TTS006

Hi-Ace - Diesel LH51,LH61,LH71 03/1984 08/1989 4 2.4L 2L TPS007 TTS006 TBS009 TRS006

Hi-Ace - Diesel LH103,LH113,LH125 10/1989 09/2000 4 2.8L 3L TPS006 TTS007 TBS005 TRS007

Hi-Ace - Diesel LHR172R 07/1999 02/2005 4 3.0L 5L TPS006 TTS007 TRS007

Hi-Ace - Diesel LH184R 10/2000 02/2005 4 3.0L 5L TPS006 TTS007 TBS005 TRS007

Hi-Lux All 1.6L Petrol 06/1971 10/1983 4 1.6L 12R TPS006TPS008


Hi-Lux YN55 11/1983 09/1987 4 1.6L 1Y-C TPS007 TTS006 TFS143 TBS009 TRS007

Hi-Lux YN56 10/1987 09/1988 4 1.8L 2Y-C TPS007 TTS006 TFS143 TBS009 TRS007

Hi-Lux YN85R 10/1988 11/1997 4 1.8L 2Y-C TPS011 TTS006TTS007


Hi-Lux All 2.0L Petrol 01/1978 10/1983 4 2.0L 18R TPS006TPS008


Hi-Lux YN57,YN65 11/1983 09/1987 4 2.0L 3Y-C TPS007 TTS006 TFS143 TBS009 TRS007

Hi-Lux YN58,YN67 10/1987 09/1988 4 2.2L 4Y-C TPS007 TTS006 TFS143 TBS009 TRS007

Hi-Lux RN85R 01/1990 08/1992 4 2.4L 22R TPS008TPS011


Hi-Lux RN85R 08/1993 11/1997 4 2.4L 22R TPS008TPS011


Hi-Lux RN90R 10/1988 11/1997 4 2.4L 22R TPS002TPS004TPS011

TTS006 TFS159 TBS005 TRS007 3 x Oil Pressure Switches TPS002(gauge), TPS004(gauge), TPS011(Light) check illustrations

Hi-Lux RN105R 10/1988 08/1992 4 2.4L 22R TPS002TPS004TPS008TPS011



Hi-Lux RN105R 08/1992 11/1997 4 2.4L 22R TPS002TPS004TPS008TPS011



Hi-Lux RN106R 01/1992 11/1997 4 2.4L 22R TPS011 TTS007 TFS159 TBS005 TRS007

Hi-Lux RN110 10/1988 11/1997 4 2.4L 22R TPS008TPS011

TTS006TTS007

TFS159 TBS002TBS005


Hi-Lux RZN147R - EFI 08/1997 08/2002 4 2.0L 1RZ-E TPS011 TTS007 TCS032 TBS005 TRS007

Hi-Lux All 2.7L Petrol 01/1997 04/2005 4 2.7L 3RZ-FE TPS011 TTS008 TCS032 TBS005 TRS007

Hi-Lux VZN167R 08/2001 02/2005 V6 3.4L 5VZ-FE TPS011 TTS001 TCS032 TBS005 TRS007

Toyota cont.

Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

58

Hi-Lux VZN172R 09/2002 02/2005 V6 3.4L 5VZ-FE TPS011 TTS001 TCS032

Hi-Lux, Diesel All - 2.2L 10/1978 08/1984 4 2.2L L TPS007 TTS006 TBS006 TRS005

Hi-Lux, Diesel All - 2.4L 11/1983 08/1991 4 2.4L 2L TPS006 TTS006TTS007

TBS005TBS009

TRS007 2 x Water Temp Senders & 2 x Stop Light Switches check illustrations

Hi-Lux, Diesel LN86R 09/1991 11/1997 4 2.8L 3L TPS006 TTS007 TBS005 TRS007



Hi-Lux, Diesel LN107R 01/1992 11/1997 4 2.8L 3L TPS002TPS004TPS006

TTS007 TBS005 TRS007 3 x Oil Pressure Switches TPS002(gauge), TPS004(gauge), TPS006(Light) check illustrations


Hi-Lux, Diesel LN147R 11/1997 04/2005 4 3.0L 5L TPS006 TTS007

Hi-Lux, Diesel LN167R,LN172R 11/1997 04/2005 4 3.0L 5L TPS006 TTS007 TBS005 TRS007

Hi-Lux, Turbo Diesel

KZN165R 12/1999 04/2005 4 3.0L 1KZ-TE TPS011 TTS007 TBS005 TRS007

Kluger MCU28R 10/2003 on V6 3.3L 3MZ-FE TPS011 TCS032 TBS018

Landcruiser FJ40,FJ45,FJ55 03/1969 01/1975 6 3.9L F TPS007 TTS005 TFS155

Landcruiser FJ40,FJ45,FJ55,FJ60 01/1975 11/1984 6 4.2L 2F TPS007 TTS005 TFS155 TBS006

Landcruiser FJ62 11/1984 1990 6 4.0L 3F TPS003 TTS006 TFS154 TBS006 TRS006

Landcruiser FJ70 11/1984 09/1992 6 4.0L 3F TPS006TPS011


TRS006TRS007






TRS046 2 x Oil Pressure Switches & 2 x Stop Light Switches check illustrations

Landcruiser FJ80 - with cruise control

08/1991 10/1992 6 4.0L 3F TPS003TPS006

TTS006 TCS032 TBS018 TRS046 2 x Oil Pressure Switches TPS003(gauge), TPS006(Light) check illustrations

Landcruiser FJ80 - without cruise control

08/1991 10/1992 6 4.0L 3F TPS003TPS006


Landcruiser FJ80 - EFI 03/1990 10/1992 6 4.0L 3F-E TCS032 TFS226

Landcruiser FZJ80R - without cruise contol

11/1992 02/1998 6 4.5L 1FZ-FE TPS001TPS063

TTS007 TCS032 TBS005 TRS046 2 x Oil Pressure Switches ,check illustrations

Landcruiser FZJ80R - with cruise contol

11/1992 02/1998 6 4.5L 1FZ-FE TPS001TPS063

TTS007 TCS032 TBS018 TRS046 2 x Oil Pressure Switches ,check illustrations

Landcruiser FZJ105R 03/1998 09/2002 6 4.5L 1FZ-FE TTS007 TCS032 TBS005TBS018


Landcruiser UZJ100R - without cruise control

08/2000 on V8 4.7L 2UZ-FE TPS011 TTS008 TCS118 TBS005 TRS046

Landcruiser UZJ100R - with cruise control

08/2000 on V8 4.7L 2UZ-FE TPS011 TTS008 TCS118 TBS018 TRS046

Toyota cont.

59


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Landcruiser Diesel

BJ42,BJ70,BJ73 10/1980 03/1990 4 3.4L 3B TPS008 TTS005

Landcruiser Diesel Turbo

BJ74 03/1986 12/1989 4 3.4L 13B-T TPS008 TTS006

LandcruiserDiesel

HJ45 09/1977 07/1980 6 3.6L H TPS007 TTS005 TBS006

Landcruiser Diesel

HJ60,HJ75 11/1980 04/1990 6 4.0L 2H TPS007 TTS006 TBS006 TRS006


HDJ80R 05/1990 08/1991 6 4.2L 1HD-T TPS063 TTS006 TCS032 TBS009TBS017



HDJ80R - without cruise control

08/1991 02/1998 6 4.2L 1HD-FT TPS063 TTS006TTS007

TCS032 TBS005 TRS046 2 x Water Temp Switches check illustrations


HDJ80R - with cruise control

08/1991 02/1998 6 4.2L 1HD-FT TPS063 TTS006TTS007



HDJ100R 10/2000 09/2002 6 4.2L 1HD-FTE TTS007 TCS032 TBS005TBS018


LandcruiserDiesel

HZJ70 03/1991 09/1992 6 4.2L 1HZ TPS006TPS063


LandcruiserDiesel

HZJ73 01/1990 12/1991 6 4.2L 1HZ TPS006TPS063


Landcruiser Diesel

HZJ80R 01/1990 08/1991 6 4.2L 1HZ TPS006 TTS006 TCS032 TBS009 TRS046

Landcruiser Diesel

HZJ80R 08/1991 02/1998 6 4.2L 1HZ TPS006 TTS006TTS007


Landcruiser Diesel

HZJ105R 03/1998 on 6 4.2L 1HZ TTS007 TCS032 TRS007

Landcruiser Diesel

PZJ70,PZJ73 03/1990 02/1991 5 3.5L 1PZ TPS006 TTS006 TBS009 TRS007

Landcruiser Prado RZJ95R 07/1996 02/2003 4 2.7L 3RZ-FE TPS011 TTS008 TCS032 TRS007

Landcruiser Prado RZJ120R 02/2003 08/2004 4 2.7L 3RZ-FE TPS011 TTS008 TCS032 TRS007

Landcruiser Prado VZJ95R 06/1999 09/2002 V6 3.4L 5VZ-FE TPS011 TTS001 TCS032 TBS005TBS018


Landcruiser Prado GRJ120R 02/2003 08/2004 V6 4.0L 1GR-FE TPS011 TCS120 TRS007

Landcruiser Prado Diesel Turbo

KZJ95R,KZJ120R 03/2000 on 4 3.0L 1KZ-TE TPS011 TTS007 TCS032 TBS005TBS018


Landcruiser C/Chas

FZJ79 10/1999 10/2001 6 4.5L 1FZ-FE TTS007 TCS032 TBS005TBS018


Toyota cont.

Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

60

Landcruiser C/Chas

FZJ79 10/2001 on 6 4.5L 1FZ-FE TPS011 TTS007 TCS032 TRS046

Landcruiser C/Chas

HDJ79R - Diesel 10/1999 10/2001 6 4.2L 1HZ TPS006 TTS006 TCS032 TBS005 TRS006

Landcruiser C/Chas

HDJ79R - Diesel 11/2001 on 6 4.2L 1HZ TPS006 TTS007 TCS032 TRS007

Landcruiser C/Chas

HDJ79R - Diesel Turbo 11/2001 on 6 4.2L 1HD-FTE TPS004TPS006

TTS007 TCS032 TRS046 2 x Oil Pressure Switches TPS004(guage), TPS006(Light) check illustrations

Landcruiser Troopcarrier

FJ75 11/1984 10/1992 6 4.0L 3F TPS006TPS011

TTS006 TBS005TBS009



FZJ75 11/1992 11/1999 6 4.5L 1FZ-FE TPS006TPS063



FZJ75 11/1999 10/2001 6 4.5L 1FZ-FE TPS006TPS063


TRS046 2 x Oil Pressure Switches TPS063(gauge), TPS006(Light) &2 x Stop Light Switches TBS005 (without cruise control), TBS018 (with cruise control) check illustrations


HZJ75RP - Diesel 03/1990 08/1991 6 4.2L 1HZ TPS006TPS063



HZJ75RP - Diesel 08/1991 11/1999 6 4.2L 1HZ TPS006TPS063

TTS006TTS007

TCS032 TBS005 TRS006 2 x Oil Pressure Switches & 2 x Stop Light Switches check illustrations


HZJ78R - Diesel 10/1999 10/2001 6 4.2L 1HZ TPS006 TTS006 TCS032 TBS005 TRS006


HZJ78R - Diesel 10/2001 on 6 4.2L 1HZ TPS004TPS006

TTS007 TCS032 TRS007 2 x Oil Pressure Switches TPS004(gauge), TPS006(Light) check illustrations


HDJ78R - Diesel Turbo 11/2001 on 6 4.2L 1HD-FTE TPS004TPS006

TTS007 TCS032 TRS046 2 x Oil Pressure Switches TPS004(gauge), TPS006(Light) check illustrations

Lexcen VN,VP,VR 09/1989 04/1995 V6 3.8L LG2 VH TPS064 TTS062 TCS040 TBS037TBS061


Lexcen VS 05/1995 04/1997 V6 3.8L LG2 VH TPS064 TTS062 TCS070 TBS037TBS061


Lite-Ace KM20 02/1980 12/1985 4 1.3L 4K-C TPS008 TTS006 TBS006 TRS007

Lite-Ace KM36 01/1986 03/1992 4 1.5L 5K-C TPS008 TTS006 TBS006 TRS007

Lite-Ace YM21,YM30 01/1984 12/1992 4 1.8L 2Y-C TPS007 TTS006 TFS152 TBS006 TRS007

Lite-Ace YM35RV 01/1986 03/1992 4 1.8L 2Y-C TPS008 TTS006 TFS152 TRS007

Lite-Ace YM40,YM41 03/1986 09/1988 4 2.0L 3Y-C TPS007 TTS006 TFS152 TBS006 TRS007

Lite-Ace All 1.8L - Diesel 01/1983 03/1992 4 1.8L 1C TPS006 TTS006 TBS006 TRS006

MR2 AW11R 10/1987 02/1990 4 1.6L 4A-GE TPS004 TTS006 TCS024TCS032

TFS152 TBS006TBS063

TRS007 2 x Coolant Sensors & 2 x Stop Light Switches, TBS037 without cruise control, TBS061 with cruise control, check illustra-tions

Toyota cont.

61


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

MR2 SW20R 01/1990 03/1994 4 2.0L 3S-GE TPS008 TTS006 TCS032 TFS152 TBS009TBS017


MR2 SW20R 03/1994 08/1999 4 2.0L 3S-GE TPS011 TTS007 TCS032 TFS119 TBS005TBS018


MR2 ZZW30R 10/2000 on 4 2.0L 1ZZ-FE TPS011 TCS032 TRS007

Paseo EL44R,EL54R 07/1991 08/1995 4 1.5L 5E-FE TPS011 TTS001 TCS032 TFS191 TBS005 TRS007

Paseo EL44R,EL54R 08/1995 07/1999 4 1.5L 5E-FE TPS011 TTS008 TCS032 TFS191 TBS005 TRS007

Prius NHW11R 10/2001 08/2003 4 1.5L 1NZ-FXE TPS011 TCS032

Prius NHW20R 08/2003 on 4 1.5L 1NZ-FXE TPS011 TCS120

RAV4 SXA10R,SXA11R 05/1994 09/1997 4 2.0L 3S-FE TPS011 TTS007 TCS032 TFS119 TBS005 TRS007

RAV4 SXA10R,SXA11R 09/1997 09/2000 4 2.0L 3S-FE TPS011 TTS008 TCS032 TFS119 TBS005 TRS007

RAV4 ACA20R,ACA21R 07/2000 03/2003 4 2.0L 1AZ-FE TPS011 TCS032 TFS199 TRS007

RAV4 ACA22R,ACA23R 10/2003 on 4 2.4L 2AZ-FE TPS011 TCS120 TBS018 TRS007

Soarer - Imported JZZ30 05/1991 12/2000 6 2.5L 1JZ-GTE TPS011 TTS007

Soarer - Imported JZZ31 05/1991 12/2000 V6 3.0L 2JZ-GE TPS011 TTS007 TBS018

Soarer - Imported UZZ30,UZZ31,UZZ32 05/1991 12/2000 V8 4.0L 1UZ-FE TPS011 TTS008 TBS018

Spacia YR22R 10/1993 01/1998 4 2.2L 4Y-EC TPS011 TTS007 TFS143 TRS007

Spacia SR40R 01/1998 12/2001 4 2.0L 3S-FE TPS011 TCS119 TFS120 TBS005 TRS007

Starlet EP91R 01/1996 12/1997 4 1.3L 4E-FE TPS011 TTS001 TCS032 TFS194 TBS005 TRS007

Starlet EP91R 12/1997 07/1999 4 1.3L 4E-FE TPS011 TTS001 TCS119 TFS194 TBS005 TRS007

Stout All 2.0L 1970 1983 4 2.0L 5R TPS007 TTS005 TBS009

Supra MA61 10/1983 03/1986 6 2.8L 5M-E TPS007 TTS006 TBS006 TRS006

Supra MA70 1986 08/1988 6 3.0L 7M-GE TTS005 TCS024

Supra - Imported MA70 02/1986 05/1993 6 3.0L 7M-GTEU TTS006 TBS017

Supra MA71 08/1988 04/1993 6 3.0L 7M-GTE TTS006 TCS032 TBS017

Supra - Imported JZA80 05/1993 12/1997 V6 3.0L 2JZ-GE(TE) TPS011 TTS007 TBS018 TRS046

T18 TE72 10/1979 07/1983 4 1.8L 3TC TPS007 TTS006

Tarago YR20 02/1983 02/1984 4 1.8L 2Y-C TPS007 TTS006 TFS155 TBS006 TRS007

Tarago YR21R 03/1984 08/1988 4 2.0L 3Y-C TPS004TPS008

TTS006 TFS155 TBS006 TRS006 2 x Oil Pressure Switches TPS004(gauge), TPS008(Light) check illustrations

Tarago YR22R 10/1988 10/1990 4 2.2L 4Y-EC TTS006 TCS024 TFS155 TBS006 TRS006

Tarago YR31 03/1986 10/1990 4 2.2L 4Y-EC TTS006 TCS024TCS032

TFS155 2 x Coolant Sensors check Illustrations

Tarago TCR10R 09/1990 08/2000 4 2.4L 2TZ-FE TPS011 TTS007 TCS032 TBS009 TRS007

Tarago TCR11R 09/1990 08/2000 4 2.4L 2TZ-FE TPS011 TTS007 TCS032 TBS009TBS017


Toyota cont.

Toyota

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

62

Tarago TCR20R,TCR21R - 4WD 09/1990 10/1993 4 2.4L 2TZ-FE TPS008 TTS006 TCS032 TBS009 TRS007

Tarago ACR30R 06/2000 04/2003 4 2.4L 2AZ-FE TPS011 TTS007 TCS032 TFS199 TBS005TBS018


Tarago ACR30R 04/2003 on 4 2.4L 2AZ-FE TPS011 TTS007 TCS120 TFS199 TRS007

Tarago CR21 - Diesel 1983 1988 4 2.0L 2C TPS006 TTS006 TBS006 TRS007

Tercel AL25 10/1983 04/1988 4 1.5L 3A-C TPS011 TTS001 TFS152 TBS005 TRS007

Townace YR39R 04/1992 09/1993 4 2.0L 3Y-C TPS008TPS011

TTS006 TFS155 TRS007 2 x Oil Pressure Switches, check illustrations

Townace YR39R 09/1993 01/1997 4 2.0L 3Y-C TPS008TPS011

TTS007 TFS155 TRS007 2 x Oil Pressure Switches, check illustrations

Townace SBV KR42R 02/1997 12/1998 4 1.8L 7K-C TPS011 TTS007 TBS005 TRS007

Townace SBV KR42R - EFI 12/1998 on 4 1.8L 7K-E TPS011 TCS032 TBS005 TRS007

Toyo-Ace LY30,LY31 - Diesel 03/1982 1985 4 2.2L,2.4L L,2L TPS007 TTS006

Volkswagen

1600 Type III 05/1966 1973 4 1.6L TPS020

Beetle All 1953 1976 4 ALL TPS020

Beetle - New 1.6 01/2002 11/2003 4 1.6L AYD TPS054TPS056



Beetle - New 1.8 Turbo 09/2001 on 4 1.8L AGU TPS054TPS056

TTS504 TBS028TBS051

TRS032TRS045TRS048


Beetle - New 2.0 01/2000 on 4 2.0L AQY TPS054TPS056

TTS504 TCS104TCS105

TFS213 TBS028TBS051

TRS045TRS048


Bora 2.0 11/1999 on 4 2.0L APK TPS054 TTS504 TCS104 TFS190TFS198TFS213TFS218

TBS028TBS051


Bora 2.3 V5 09/2001 on V5 2.3L AGZ TPS053TPS054

TTS504 TCS104TCS105

TBS028TBS051


Bora V6 4 MOTION - 4WD 06/2001 02/2005 V6 2.8L AUE TPS052TPS054

TCS104TCS105

TBS028TBS051


Caravelle T4 - Carb. 01/1993 12/1996 5 2.5L AAF TPS030TPS031TPS045

TTS505TTS517

TCS091 TFS205TFS212


Caravelle T4 - EFI 01/1993 12/1996 5 2.5L ACU TPS030TPS031TPS045

TTS038TTS505TTS517

TCS091 TFS205TFS212


Caravelle T4 - EFI 10/1997 07/2000 5 2.5L AET TPS030TPS045TPS051

TTS038TTS508TTS514TTS517

TCS095TCS091TCS104


Toyota cont.

63


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Caravelle V6 03/2003 on V6 2.8L AMV TPS031TPS045TPS054

TTS038TTS508TTS514

TCS095TCS104


Golf I LS, GLS 03/1976 12/1980 4 1.6L FP/FN TPS020 TTS027 TFS135

Golf II 1.8 Cabriolet 09/1990 12/1993 4 1.8L RV TPS030TPS031TPS042TPS045


TCS091 TFS173TFS208


Golf II 1.8 GTI 09/1990 12/1993 4 1.8L RV TPS030TPS031TPS042TPS045


TCS091 TFS173TFS208


Golf III CL 10/1995 09/1998 4 1.8L ADZ/JH TPS030TPS045


TBS028 TRS032 2 x Oil Pressure Switches & 2 x Thermo Fan Switches check illustrations

Golf III GL Tdi 10/1995 1998 4 1.9L 1Y/AFN TPS042TPS045


TBS028 TRS045 2 x Oil Pressure Switches & 2 x Thermo Fan Switches check illustrations

Golf III 2.0 GL 07/1994 1998 4 2.0L ADY/2E TPS030TPS045

TTS513 TFS190TFS213


Golf III Cabriolet 03/1995 03/2003 4 2.0L 2E TPS030TPS045


Golf III VR6 03/1994 10/1998 V6 2.8L AAA TPS031TPS045

TTS507TTS509TTS518

TCS091 TFS190TFS213


Golf IV 1.6 09/1998 2002 4 1.6L AEH/AKL TPS031TPS054

TTS504 TCS104TCS105

TBS028TBS051

TRS045TRS048


Golf IV 1.6S,1.6SE 03/2002 07/2004 4 1.6L AKL TPS031TPS054

TTS504 TCS104TCS105

TBS028TBS051

TRS045TRS048


Golf IV GLE 10/1998 1999 4 1.8L AGN TPS031TPS054


TRS045TRS048


Golf IV GLE 07/1999 2002 4 2.0L AGG TPS045TPS052TPS055

TTS504TTS507

TCS095 TFS190TFS213

TBS028TBS051

TRS032TRS045TRS048


Golf IV R32 11/2003 07/2004 V6 3.2L BFH TPS054 TCS104 TBS051 TRS048

Kharmann Ghia 1959 1970 4 ALL TPS020

Kombi 1965 1973 4 ALL TPS020

Kombi EFI - incl Syncro 05/1989 02/1992 4 2.1L TFS102

Passat LS, GLS 11/1975 1981 4 1.6L FP/FS TPS020 TFS135

Passat 1.8 03/1998 07/2004 4 1.8L ADR TPS031TPS054

TCS103TCS105

TFS103TFS208TFS219

TBS038TBS049


Passat 1.8 Turbo 03/1998 07/2004 4 1.8L AEB TPS031TPS054

TCS103TCS105

TFS103TFS208TFS219

TBS038TBS049


Volkswagen cont.

Toyota, Volkswagen

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

64

Passat GL 08/1995 02/1997 4 2.0L ADY TPS030TPS045

TTS038TTS506TTS513

TCS095 TFS190 TRS045 For correct application, check illustrations and spec tables

Passat GL 08/1995 02/1997 4 2.0L 2E TPS021TPS030TPS031TPS042TPS045

TTS038TTS506TTS513

TCS091TCS095

TFS190 TRS045 For correct application, check illustrations and spec tables

Passat V5 11/2002 on V5 2.3L AZX TPS031TPS053TPS054

TCS111 TBS038TBS049


Passat GL VR6 08/1995 02/1997 V6 2.8L AAA TPS031TPS045

TTS038TTS509TTS518

TCS091 TFS190 TRS045 For correct application, check illustrations and spec tables

Passat VR6 03/1998 07/2004 V6 2.8L ACK TPS031TPS054

TCS103TCS105

TFS103TFS208TFS219

TBS038TBS049


Passat VR6 Syncro 02/1999 07/2004 V6 2.8L AEG TPS031TPS054

TCS103TCS105

TFS190 TBS038TBS049


Passat V6 - incl 4 Motion 05/2001 07/2004 V6 2.8L ACK TPS031TPS054

TBS038TBS049


Passat W8 4D Sedan 04/2003 07/2004 W8 4.0L DBN TPS054 TCS111 TRS030

Polo 1.4 16V 09/2000 07/2002 4 1.4L AHW TPS056 TCS104 TFS190TFS213

TBS028TBS051


Polo 1.4 2D & 4D Hatchback 07/2002 on 4 1.4L BBY TPS056 TCS111 TFS198TFS218


Polo 1.6i 10/1996 10/2000 4 1.6L AEE/AEX TPS045 TTS504TTS505TTS513

TCS091TCS095

TFS190TFS213


Polo 1.6 2D & 4D Hatchback 03/2004 on 4 1.6L BAH TPS056 TCS111 TFS198TFS218


Touareg V6 09/2003 on V6 3.2L AZZ TPS054 TCS111 TBS051

Touareg V8 09/2003 on V8 4.2L AXQ TPS054 TCS111 TFS218 TBS051

Touareg V10 HDI 09/2003 on V10 4.9L AYH TPS056 TCS111 TBS051

Transporter 11/1986 1992 4 2.1L TFS102

Transporter IV T4 11/1992 2004 4 2.0L AAC TPS030TPS031TPS045TPS052TPS054TPS055

TTS508TTS509TTS518

TCS091TCS095TCS104

TFS205TFS212


Transporter IV Diesel - incl Syncro 05/1995 1999 5 2.4L AAB TPS031TPS042TPS045

TTS038TTS505TTS508TTS510TTS517

TFS205TFS212TFS214


Volkswagen cont.

65


Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

Transporter IV T4 01/1994 2004 5 2.5L AAF TPS030TPS031TPS045

TTS505TTS508TTS517

TCS091 TFS205TFS212


Transporter IV Syncro & FWD 05/1995 2004 5 2.5L ACU TPS030TPS031TPS045

TTS038TTS505TTS508TTS510TTS517

TCS091 TFS205TFS212


Transporter IV FWD 10/1997 2004 5 2.5L AET TPS030TPS045TPS051


TCS091TCS095TCS104


Transporter V T5 1.9 Tdi 07/2004 on 4 1.9L AXB TPS051 TCS111 TBS051 TRS048

Transporter V T5 2.5Tdi 07/2004 on 5 2.5L AXA TPS053 TBS051 TRS048

Vento GL 06/1995 02/1997 4 2.0L ADY/2E TPS030TPS045

TCS095 TFS190 TBS028 TRS032TRS033


Volvo

240,244,245 1975 1982 4 2.1L B21A,B21E TTS027 TFS187

240,242,244,245 1981 1993 4 2.3L B230E,F TPS034 TTS027 TFS187 TBS023 TRS024

260,264,265 1981 1986 V6 2.8L B28E TPS022 TBS023 TRS024

360 03/1984 12/1987 4 2.0L B200E(A) TPS034 TTS027 TCS026 TFS187

440 10/1993 09/1996 4 2.0L B20F TBS026

740 01/1986 12/1991 4 2.3L B230F TPS034 TTS027TTS040


740 GLE 16v 05/1989 12/1990 4 2.3L B234FA TPS034 TTS027TTS040


740 Turbo 03/1986 12/1990 4 2.3L B230FT TPS034 TTS027TTS040


760 02/1983 02/1985 V6 2.8L B28E TPS022 TFS175 TBS023 TRS024

760 02/1986 12/1988 V6 2.8L B28F TPS022 TFS175 TBS023

760 12/1988 12/1990 V6 2.8L B280F TPS022 TCS060 TFS175 TBS023

760 Turbo 01/1984 02/1985 4 2.3L B23ET TPS032 TTS027 TCS040 TFS175 TBS023

760 Turbo 03/1985 03/1986 4 2.3L B230ET TPS034 TTS027 TCS060 TFS175 TBS023

850 incl Turbo 10/1992 01/1997 4,5 2.3L,2.5L TPS034 TCS092 TBS023 TRS024

940 incl Turbo 11/1990 01/1997 4 2.3L B230F,B,T TPS034 TTS040 TCS060 TFS175 TBS023 TRS024

960 11/1990 10/1991 V6 2.8L B280F TCS060 TFS175 TBS023

960 11/1991 01/1997 6 2.9L B6304F TPS034 TTS040 TCS092 TFS175 TBS023

C70 Coupe & Convertible 09/1999 09/2004 5 2.3L B5234T TPS034 TCS092 TRS024

C70 Coupe & Convertible 09/1999 04/2001 5 2.5L B5244T TPS034 TRS024

S40,V40 1.8 07/1999 02/2004 4 1.8L B4184S TPS011 TTS055 TCS055 TBS034 TRS016

S40,V40 2.0 - incl Turbo 02/1997 02/2004 4 2.0L B4204S,T TPS034TPS059

TTS519 TCS115 TBS034 TRS024 2 x Oil Pressure Switches, check illustrations

Volkswagen cont.

Volkswagen, Volvo

Make and Model



WaterTemp

CoolantSensor

Fan Switch

Stop Light

Reverse Light

66

S60 AWD T5 06/2002 10/2003 5 2.4L B5254T2 TPS034 TCS032 TRS024

S60R S60R Turbo 10/2003 03/2004 5 2.3L B5234T3 TPS034 TCS032

S70,V70 2.3 incl Turbo 02/1997 08/2000 5 2.3L B5234(T) TPS034 TCS092 TRS024

S70,V70 2.4 incl Turbo 02/1997 02/2003 5 2.4L B524,B525 TPS034 TCS092 TRS024

S70R S70R Turbo 10/2003 03/2004 5 2.3L B5234T3 TPS034 TCS092 TRS024

S80 TS95,TS97 05/1998 06/2003 6 2.9L B6304F TPS034 TRS024

S90, V90 02/1997 08/1998 6 2.9L B6304F TPS034 TCS092

XC70 Cross Country 09/2000 03/2003 5 2.5L B5244T TPS034

XC90 2.5T 06/2003 on 5 2.5L B5254T2 TPS034 TCS032

XC90 T6 06/2003 on 6 2.9L TPS034

Volvo cont.

switches and sensors catalogue - · pdf fileswitches and sensors catalogue oil pressure •...

Documents