tv cars 14dn3wyd

M71(NTSC) SERVICE MANUAL

MODEL 14DN3WYD-BY LI CHANGZHENG

1、Caution ....................................... ................. 2、Specification ........................ ............................ 3、BOM list ............................ ........... ................. 4、Alignment Procedure ........................................... .. 5、Block Diagram .................................... .............. 6、Schematic Diagram ............................................... 7、PCB Layout .......................... ........... ................ 8、Explode View Diagram ......................................... ...

This manual is the latest at the time of printing, and does not include the modification which may be made after the printing, by the

constant improvement of product.

TTE Overseas Support Department

1. Cautions When working, the unit is with ultra high voltage about 21.8KV inside. So, to avoid the risk of electric shock, be careful to adjust the chassis! 1. Only qualified personnel should perform service procedures. 2. All specification must be met over line voltage ranger of 120V AC 60Hz. 3. Do not operate in WET/DAMP conditions. 4. Portions of the power supply board are hot ground. The remaining boards are cold ground. 5. Discharge of CRT anode should be done only to CRT ground strap. 6. When fuse blow, ensure to replace a fuse with the same type and specification. 7. Keep the wires away from the components with high temperature or high voltage. 8. When replacing the resister with high power, keep it over the PCB about 10mm. 9. The CRT anode high voltage has been adjusted and set in the factory. When repairing the chassis, do not make the high voltage exceed 24.0KV (The beam current is 0uA). Generally, the high voltage is set on 21.8KV±1.5KV (The beam current is 500uA). The values of parameters above are for information only.

10. Before return the fixed unit, do check all the covering of wires to ensure that not fold or not short with any metal components. Check the entire protection units, such as control knobs, rear cabinet & front panel, insulation resister & capacitor, mechanical insulators and so on. 11. There are some mechanical and electrical parts associating with safety (EMC) features (Generally related to high voltage or high temperature or electric shock), these features cannot be found out from the outside. When replace these components, perhaps the voltage and power suit the requirements, but efficient X-ray protection may not be provided. All these components are marked with in the schematic diagram. When replace these, you’d better look up the components listed in this manual. If the component you replaced not has the same safety (EMC) performance, harmful X-ray may be produced. 12. This DVD player is designed and manufactured to respond to the Region Management


Information. If the Region number of a DVD discdoes not correspond to the Region number of this DVD player, this DVD player cannot play the disc. Region 1 - USA, Canada Region 2 - Japan, Europe, South Africa, Middle East, Greenland 13. This device is protected by U.S. patent numbers 4,631,603 and 4,577,216 and 4,819,098 and other intellectual property rights. The use of Macrovision s copy protection technology in the device must be authorized by Macrovision and is intended for home and other limited pay-per-view uses only, unless otherwise authorized in writing by Macrovision. Reverse engineering or disassembly is prohibited.


2. Specification

Ⅰ.TV PART US CAR TV PFS Date:2006-01-19 ProductView… Report by............: Disney-CAR TV-DVD-PROJECT(M71) SPEC

MasterData

Customer Id

Version

Status

Locked

12NC

Brand

EAN

UPC

Reception

+Tuning - presets/channels 181 channels

+Tuning - technology PLL

+Tuning - Indication Full-Cable (OSD)

+Freq Bands VHF:2-13;UHF:14-69

Full CATV:2-13,A~W,W+1~W+84,A-5~A-1,5A

+Channels 181 channels

+IF Freq 45.75M

+TV Systems Off Air NTSC M

+Add Systems Ext In

+TV Systems Multi

+Sound Systems

Picture - Processing

+Scan

+Scan Modes 4:3

+Wide Screen Switching

+BLACK STRETCH,BLUE STRETCH

+SVM

+LTI;CTI

+Combfilter

+Picture Control (4 Picture Modes), Brightness, Color, Contrast, Tint, Sharpness Cont Var

+Pict Enhancement BLUE MUT


Picture - Display 60 HZ

+Display Type CRT

+Screen Format 4:3

+Size(Visual)" - size/vis. cm 13'

+Deflection System (CRT only)

+Tube Technology (CRT only)

+CRT Defl

+CRT Gun

+CRT Magn field

+Resolution >300 lines (TV test card)

+Coating (only for D.V. sets)

+White Point

Sound

+Leaflet Power

+RMS Power Intern 1Wx2

+RMS Power Extern

+DVSS(virtual Dolby Surround Sound)

+Surround Sound

+Sound Features MUTE, AV (stereo )

Sound - Speakers

+Speaker configuration 2

+Speakers used NORMAL RANGE

+Speaker Size

User Interface

+Interface Name

+Voice Control

+Menu control indication CURSOR CONTROL

+Menu Colours

+Menu Languages English, Spanish,french

+Special Features V-Chip / Child Lock / CCD

+Operational Features Alternate Channel/recall, AV/TV, Picture,sound , tuning,

+PP Features normal picture/sound

+Tuning/Install Features Auto Cable/Auto select.Auto channel Prog,Cable/Antenna select,Channel Edit(add/delete),Language Selection

+Clock/Timer Functions


+Local Controls Front Channel +-, TV/AV/DVD , Tact Switch( power), Vol +-, menu,play/pause,stop,open/close

+Local Controls Top

+Indicators - screen Yes with OSD

+Indicators - front YES, Red LED for standby

+Numb of Loc Cont (incl Mains) 10 pcs

+Number of Ind. (incl Mains)

+Local Controls (Old)

Remote Control

+Remote Control - scope TV-DVD

+Remote Control - type Standard

+Remote Control - typenr

+Remote Control - features

Connectors Rear

+Scart RGB+Y/C+CVBS

+Scart RGB+CVBS in/out(full)

+Scart CVBS+Y/C

+Component In (Y/U/V) Cinch

+In Y/C+Cinch(CVBS+St)

+In Y/C+Cinch(CVBS+Mo)

+In Y/C+Cinch(St)

+In BNC (CVBS)

+In Cinch(CVBS+St) 1x(Video,R,L)

+In Cinch(CVBS+Mo)

+Out Cinch(CVBS+St) 1x(Video,R,L)(AV stereo/TV mono)

+Out Cinch(CVBS+Mo)

+Out Cinch Audio Stereo

+Out Cinch Audio Mono

+Out Cinch Dolby Surround

+Dig Audio Out

+Loudspeakers

+Control Busses

+Feature Slot

+ITV Smart Port

+Terr. Antenna in 75 Ohms (F type)

Guide + IR Blaster Jack


Connectors Front

+In Cinch (CVBS + St) 1x(Video,R,L)

+In Cinch (CVBS+Mo)

+Headphone Out 3.5mm stereo jack

Connectors Side

+In Y/C + Cinch(CVBS+St)

+In Y/C + Cinch Stereo

+In Cinch (CVBS + St)

+IN Cinch (CVBS + Mo)

+Headphone Out

Connectors Top

Connectors Mechanical

Styling

+Cabinet Name

+Configuration

+Graphics/Logo's

+Cabinet Colour and Finish

+Mechanics

+Speaker Visibility

General

+Chassis

+Software Delivery Mode

+Software Version

+Mains Voltage 120V

+Mains Frequency 60Hz

+Type Mains Cord USA

Power Consumption (P)TV in On 65w

Power Consumption SB in Watts <3W

Power Consumption Semi SB in W

+Power in "ON" for

+Power in Standby for

+Power in "OFF" for

Weight (P)TV (incl. Packaging)

Weight (P)TV (excl. Package)

Weight AVUnit excl Packaging


+INDICATION on BACKCOVER FCC/Elect Shock caution label,Made-in family sheet,Serial Label,Warning Label on backover, UPC bar code etc

+Channel

Final Equipment

+Packaging - methods

+Documents and manuals

+Languages DFU

+Cables Supplied

+Antenna Supplied

+Stand Supplied

+Aux Equipm Supplied

Packaging - width cm

Packaging - height cm

Packaging - depth cm

Miscellaneous

+EAN Indication YES(to be confirmed the type of label)

+Approbation FCC/FDA/UL

+Tests For power code lead free EPA3050B

+Local Integration

Various Perf. Param.

+Service Call-Rate

PIP/POP

+Type

+Features

Digital Reception

+Transmission

Built-in Data System

+Text Standard CCD with V-chip

+(Tele)text Features CCD : off,c1,c2,t1,t2,v-chip

+Nbr bckgrnd page / Mem Size

+Text Technology

+Digital Data handling

+Program Guide

Built-in Clock/Timer

+Type

+Features


Built-in Radio

+Type

Built-in PC display

+PC Synch

+PC Control

Built-in DVD drive YES

+Type of Medium DVD

+Type of Deck DISK

Phased Out Items

+Tuner/Frontend

+Sensitivity

+CRT EHT

+Lightning Protection

+Account

+XX(Radio Antenna in)

+Non Volatile Memory

+In Y/C + Cinch(CVBS+Mo)

Ⅱ.DVD PART 2.1 Power Input (CN4)

Pin NO

Symbol definition Spec condition Remark

1 +5V (Digital) IN 600 mA -

2 +5V (Digital IN 600 mA

3 GND (Digital) GND

4 +5V (Analog) IN 800 mA - - -

5 GND (Analog GND

6 +12V IN 100mA

7 GND (Analog) GND


2.2 PDIF OUT(CN9) Pin NO


1 SIGNAL_OUT OUT

500mV +/- 20%P

P

-

100R100MHz

600R

100pF

DXX:Pin57

Conn:Pin2

2 GND GND -

3 +5V OUT +5V

2.3 Audio Out CN6)

Pin NO


1 Audio (R) OUT 2V RMS( 0dBFs

) 10K ohm MUTE

AGND

47PF

R

AGND

470

R126 470

AGND

10K

+

-

3

21 +

10UF

2 GND (R/L) OUT

3 Audio (L) OUT 2V RMS( 0dBFs

) 10K ohm MUTE

AGND

47PF

L

AGND

470

R126 470

AGND

10K

+

-

3

21 +

10UF

2.4 Video Out（CN5）

Pin NO


1 C OUT 0.3V (P-P)

75ohm

VGND

SP8202pin215

100

+5V

+

47UF

1.2K

10PF

150 1%

1UH

33 1/2W

100PF

2.4K

100PF

C

2 GND (Y/C) GND


3 Y OUT 1V (P-P)

75ohm

VGND

SP8202pin214

100

+5V

Y

+

47UF

1.2K

10PF

150 1%

1UH

33 1/2W

100PF

2.4K

100PF

4 GND (Y/C) GND

2.5 UART Communication Connect (CN8) Pin NO


1 Host RxD IN

2 Host TxD OUT

Start bit = 1bit

Data Bit = 8bit

Stop Bit = 1bit

Check Bit = None

Baudrate =

115200bps

3 GND GND

4 IR IN IRSP8202/81pin

4.7K

DVCC3

100

GND

100pF

5 DVD READY

IN


6 DVD_Reset IN

+ 10UF

1N4148

GND

0.1UF

DVCC3

10K

100

2N3904

RESET

10K

2.6 USB Connect(CN10) Pin NO


VBUS

2 USB_D+

3 USB_D-

22R

47pF

USB HC:Pins 50,51

Conn:Pins 2, 3

15k

47pF*

4 DGND Ground

2.7. 6 IN 1 card read Connect (CN11)Choose Assemble

Pin NO

Symbol definiti

on Spec condition

1 GND 2 CARD_D0 OUT 3 GND 4 CARD_D7 OUT 5 CARD_D1 OUT 6 CARD_D2 OUT 7 CARD_D3 OUT 8 CARD_D4 OUT 9 CARD_D5 OUT

10 CARD_D6 OUT 11 CARD_SENSE1 OUT 12 GND 13 GND 14 CARD_WP IN


15 CARD_RST IN 16 CARD_D8 OUT 17 CARD_D9 OUT 18 CF_A2 OUT 19 CARD_D10 OUT 20 CARD_D11 OUT 21 CARD_D12 OUT 22 GND 23 CARD_D13 OUT 24 CARD_D14 OUT 25 CARD_D15 OUT 26 CF_A0 OUT 27 GND 28 CF_WR IN 29 CF_A1 OUT 30 GND 31 CF_RD OUT 32 CF_IORDY IN 33 CF_CS1 IN 34 CF_RST IN 35 CF_CS2 IN 36 CARD_SENSE3 IN 37 CARD_SENSE2 IN 38 GND 39 GND 40 GND

2.8 Key Parts list Caption Symbol Item No spec

Power Supply Power Supply

46-33079W-05X

Pitch=2.5mm top entry Connector

DVD Digital Sound Output

SPDIF Out 46-33079W-03X


DVD Signal to TV AV Signals 46-33079W-13X


Communication Communic

ation 46-33079W-06X

Pitch=2.5mm top entry

Connector


USB USB 46-33079W-04X


6 in 1 Memory Card Reader

6-in-1 CR 40-39630W-40X

0.5mm 40P SMT Vertical

OPU OPU Refer to DV34-2 Specification


3. BOM List Item No. description qty BOM text Remark

T8-14DN3W-FC2 FRONT CABINET ASSEMBLY 1

02-GND014-XX0 ASS"Y - CRT GND WIRE&HOUSE 1

05-DMM06D-DVDS DVD MODULE DMM06D-S 1

36-DEG140-AX3A DEGAUSSING COIL XC-38 1

42-D7616C-XX0 SPEAKER 16 OHM 3W 1 FOR “R”

42-D7616C-XX0 SPEAKER 16 OHM 3W 1 FOR “L”

46-30627H-02X HS 2P24 360/7 F/W TJC3-2Y 1 TO P602

46-35102H-03X HS 2P 2468#22 200/5 TJC3-3Y 1 TO P601

54-205140-000 SPACER CRT MOUNTING T=2MM 4 MTG CRT

54-314740-0X0 CRT FIBRE SHEET

(22MMX22MMX0.8MM)

8 MTG CRT

57-10654X-00F TWIST TIE NY66 4

59-439100-000 RUBBER PAD 2 STICK BOTTOM OF F.CAB

62-216340-0HAG HOLDER AC POWER CORD (2) 1

62-422710-0HAG POWER KNOB 1

62-435130-0HGG BRACKET_"L" 1

62-435380-0HGG BRACKET_"R" 1

63-B40150-AB3G S/T SCREW B 4 X 15 AB (BLACK) 4 MTG BUTTON BKT TO

F.CAB

63-W30100-AB4G S/T SCREW W 3 X 10 AB 2 MTG VENT BKT TO F.CAB

63-W30100-AB4G S/T SCREW W 3 X 10 AB 2 MTG LENS TO F.CAB

63-W30100-AB4G S/T SCREW W 3 X 10 AB 1 MTG SPRING SHEET TO

F.CAB

63-W30100-AB4G S/T SCREW W 3 X 10 AB 4 MTG SPEAKER BKT TO

F.CAB

63-W30140-AB4G S/T SCREW W 3 X 14 AB 4 MTG MB BKT TO F.CAB

63-Z50250-BF4G S/T SCREW 5 X 25BF 4 MTG CRT

64-B30060-304G TRIANGLE M/C SCREW B 3 X 6 2 MTG MB BKT & DVD

67-360040-0E2 SPRING PW KNOB 1 FOR POWER KNOB

67-M43663-0S0 SPRING 1

67-X12668-0E0 SPRING CRT 6MMX40MMX0.5MM 1

89-SN5055-JZ0 ADHESIVE TAPE OF DEGAUSSING COIL

& CRT

1

T8-14DN3W-FC2Z FRONT CABINET ART DESIGN

ASSEMBLY

1

55-EDN3FC-0UNG FRONT CABINET 1

56-434990-0HAG WENT-PIPE(R) 1


56-435000-0HAG WENT-PIPE(L) 1

56-435070-0HNG DVD DOOR 1

56-435110-0HNG KEY DOOR 1

56-EDN3PK-0HAG POWER KNOB 1

56-435090-0HCG LENS 1

56-EDN3FB-0HAG BRACKET 1

56-EDN3LE-0HCG LENS 1

58-EDN3FI-0UI INLAY FRONT CTL 1

58-EDN3SI-0UI INLAY SIDE AV 1

57-439110-000 LOGO 1

41-BF0300-0P2 WIRE 1007#24 2

T8-14DN3W-MA2SM MAIN BD SKD ASSEMBLY 1

T8-14DN3W-MA2HM MAIN BD ASSEMBLY 1

T8-14DN3W-AM2 AMP. BD ASSEMBLY 1

09-BAS316-ATX SMD.DIODE BAS316 115 1 D601


12-BC847B-0BX NPN SMD. TRANSISTOR BC847B 215 1 Q603


13-AN7522-NPS IC AN7522N PH 1 IC601

18-EG0228-JHX RES. FUS. 0.22 OHM 2W +/-5% 1 R620

19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 J601


19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 N601




19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 1 R612A

19-AB0102-JTX RES SMD 1K OHM 1/10W 0603 1 R613A

19-AB0103-JTX RES SMD 10K OHM 1/10W 0603 1 R611




19-AB0224-JTX SMD RES 220K OHM 1/10W 0603 1 R609

19-AB0274-JTX SMD. RES 270K OHM 1/10W +/-5% 0603 1 R604

19-AB0393-JTX SMD. RES 39K OHM 1/10W +/-5% 1 R601


19-AB0822-JTX SMD. RES 8.2K OHM 1/10W +/-5% 0603 1 R606

25-BCB100-M1X CAP. ELEC 10 UF 16V +/-20% 1 C603



25-BDA471-M1X CAP. ELEC 470 UF 25V +/-20% 1 C604

25-BDB220-M1X CAP. ELEC 22 UF 25V +/-20% 1 C617

27-MBC474-J0X CAP. M.P.E 0.47UF 63V +/-5% 1 C609


28-AB0101-JCX SMD. CAP 100 PF 50VDC +/-5% 1 C602




28-AB0104-KBX SMD. CAP 50VDC 0.1UF +/-10% 06 1 C610

28-AB0472-KBX CAP.SMD 4700PF 50V +/-10% 0603 1 C607


28-AB0821-JCX CAP.SMD 820PF 50V +/-5% 0603 1 C607A

28-AB0821-JCX CAP.SMD 820PF 50V +/-5% 0603 1 C608A

41-WJ0075-B00 WIRE BARE JUMPER 7.5MM 1 J608

41-WJ0100-B00 WIRE BARE JUMPER 10MM 1 J603




46-33079W-02X PIN BASE *2 TJC3-2A 1 P602

46-33079W-03X PIN BASE *3 TJC3-3A 1 P601

46-33079W-05X PIN BASE *5 TJC3-5A 1 P603

64-B30080-304G TRIANGLE M/C SCREW B 3 X 8 2 FOR IC602

67-H41048-0A0 HEAT SINK 1 FOR IC602


T8-14DN3W-AV2 REAR AV BD ASSEMBLY 1




12-C124ET-0BX SMD. TRANSISTOR PDTC124ET 1 Q903

12-C124ET-0BX SMD. TRANSISTOR PDTC124ET 1 Q904

13-000040-52P IC 4052 1 IC901

13-000040-52P IC 4052 1 IC902




19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 L935


























19-AB0221-JTX RES SMD 220 OHM 1/10W 0603 1 R947










19-AB0471-JTX SMD. RES 470 OHM 1/10W +/-5% 1 R914

19-AB0820-JTX SMD. RES 82 0HM 1/10W +/-5% 0603 1 R923





















28-AB0103-KBX SMD. CAP 0.01 UF 50V +/-10% 0603 1 C907






28-AB0221-JCX CAP.SMD 220PF 50V C 0603 +/-5% 1 C924


















33-KLN601-NTX CHIP BEAD 600 OHM +/-25% 1 L921

33-KLN601-NTX CHIP BEAD 600 OHM +/-25% 1 L924

34-A220K0-1IX COIL PL - 22UH +/-10% LGA0305-220K 1 L940


34-A560K0-1IX COIL CHOKE 56UH 1 L938


35-LB1005-0IX FERR BEAD H75 (3.5X1X5) 1 L937








41-WJ0100-B00 WIRE BARE JUMPER 10MM 1 L936















46-33079W-02X PIN BASE *2 TJC3-2A 1 P934

46-33079W-03X PIN BASE *3 TJC3-3A 1 P902

46-33079W-04X PIN BASE *4 TJC3-4A 1 P905

46-CC033T-04J 4P UL2468#26 330MM 1 MAIN PCB P905 TO DVD

PCB CN6

46-CC035T-03L HS 3P UL2547#24 350MM TJC3-3Y*2 1 MAIN PCB P902 TO DVD

PCB CN7

46-CC040T-02H01 2P UL2468#22 400MM 1 MAIN P934 TO DVD PCB

CN9

47-RCA124-XX1 RCA SOCKET AV-3.2-1WK38 1 S934

47-RCA182-XX0 AV SOCKET AV-3.2-6W56 1 P001




T8-14DN3W-HZ2 HORIZON. BD ASSEMBLY 1

09-38C2V4-DTX SMD.DIODE 2.4V 1 D307

09-38C3V9-DTX SMD.DIODE BZX384-C3V9 115 1 D304










10-0FR104-FBX DIODE FR104 (FAST RECTIFIER) 1 D401


10-1N4001-EBX DIODE 1N4001 (RECTIFIER) 1 D301



11-SC2235-YAX TRANSISTOR 2SC2235-Y(NPN) 1 Q401

11-SC5885-0AX TRANSISTOR 2SC5885 1 Q402

13-STV930-2BS IC STV9302B 1 IC301

18-CB0223-JNX RES. C.F. 22K OHM 1/6W +/-5% 1 R417

18-CB0822-JNX RES. C.F. 8.2K OHM 1/6W +/-5% 1 R303

18-CD0101-JAX RES.C.F 100OHM 1/4W +/-5% 1 R409

18-CD0102-JNX RES. C.F. 1K OHM 1/4W +/-5% 1 R405

18-CD0122-JNX RES. C.F. 1.2K OHM 1/4W +/-5% 1 R311

18-CD0223-JNX RES. C.F. 22K OHM 1/4W +/-5% 1 R406

18-CE0109-JNX RES. C.F. 1 OHM 1/2W +/-5% 1 R304

18-CE0152-JNX RES. C.F. 1.5K OHM 1/2W +/-5% 1 R315

18-CE0330-JAX RES.C.F 33 OHM 1/2W +/-5% 1 R412





18-DF0159-FAX1 RES. M.F.1W 1.5 OHM/+/-1% 1 R309

18-EE0109-JNX RES. FUS. 1 OHM 1/2W +/-5% 1 R404

18-EE0109-JS2 RES. FUS. 1 OHM 1/2W +/-5% 1 R418

18-EE0109-JS2 RES. FUS. 1 OHM 1/2W +/-5% 1 R415

18-EE0478-JS2 RES.FUSE 0.47 OHM 1/2W +/-5% 1 R410

18-FF0221-JAX RES. M.O. 220 OHM 1W +/-5% 1 R336

18-FG0109-JAX RES.C.C. 2W 1 OHM +/-5% 1 R301




19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 R305






19-AB0104-FTX 0603 RES. SMD 100K OHM 1/16W +/-1% 1 R306



19-AB0272-JTX RES SMD 2.7K OHM 1/10W 0603 1 R302

19-AB0473-JTX SMD. RES 47K OHM 1/10W 0603 1 R312

19-AB0683-FTX SMD.RES 68K OHM 1/10W +/-1% 1 R308

19-AB0821-JTX SMD. RES 820 OHM 1/10W +/-5% 0603 1 R307


25-BEA102-M1X CAP. ELEC 1000 UF 35V +/-20% 1 C308




25-BFB479-M1X CAP. ELEC 4.7 UF 50V +/-20% 1 C406




25-BLA100-M1X CAP. ELEC 10 UF 250V +/-20% 1 C409

25-GJA470-M1X CAP ELEC 47UF 160V +/-20% 105 1 C412

25-MFB109-K1X CAP.ELEC 1UF 50V +/-10% 1 C307

26-ABC102-KBX CAP. CER 1000 PF 50V +/-10% B 1 C401

26-ABC563-ZFX CAP. CER 56NF 50V +80/-20% 1 C408

26-AIC391-KBX CAP. CER 390 PF 500V +/-10% B 1 C413



27-PBC104-J0X CAP. P.E 0.1UF 63V +/-5% 1 C411

27-PBC222-J0X CAP. P.E 0.0022UF 63V +/-5% 1 C415

28-AB0330-JCX SMD CAP 33PF 50V +/-5% 1 C303

28-AD0222-JCX SMD.CAP 2.2NF 25V +/-5% 1 C306

34-A608K6-1BX COIL CHOKE 0.6 UH +/-10% 1 L401

36-HDR029-XX0 TRANSFORMER HOR. DRIVE

BCT-1012A

1 T401










41-WJ0125-B00 WIRE BARE JUMPER 12.5MM 1 D409




46-33624H-04X HS 3P 2468#24 270 TJC3-4Y/SCN-4Y 1 P402

64-B30080-304G TRIANGLE M/C SCREW B 3 X 8 1 FOR Q403

64-B30100-104G M/C SCREW B 3 X 10 1 FOR IC302

65-E30053-08EG SPRING WASHER 3 X 5.3 X 0.8 1 FOR IC302

65-Z30050-23MG NUT M 3 1 FOR IC302

67-384260-0E7 HEAT SINK 1 FOR Q402

67-H30752-DA0 HEAT SINK 1 FOR IC301

T8-14DN3W-MA2 MAIN BD ASSEMBLY 1

09-38C20V-DTX SMD.DIODE BZX384-C20V 115 1 D253

09-38C4V7-DTX BZX384-C4V7 115 1 D206












12-BC857B-0BX PNP SMD. TRANSISTOR BC857B 215 1 Q202



13-00M24C-08B IC EEPROM 8K M24C08 1 IC002

13-SDA555-XFP IC SDA555XFL (WRITE) 1 IC001

13-TB1238-ANP IC TB1238AN (P/SIF/VCD) CH/JP 1 IC201










19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 R262





19-AB0000-JTX RES SMD 0 OHM 1/10W +/-5% 0603 1 D262









19-AB0101-FTX RES SMD 100 OHM 1/10W +/-1% 0603 1 R255





















































19-AB0123-FTX SMD. RES 12K OHM 1/10W +/-1% 0603 1 R084


19-AB0123-JTX SMD. RES 12K OHM 1/10 J 0603 1 R226


19-AB0154-FTX SMD. RES 150K OHM 1/10W +/-1% 1 R202









19-AB0223-JTX SMD. RES 22K OHM 1/10W +/-5% 0603 1 R202A








19-AB0332-JTX SMD RES 3.3K OHM 1/10W 0603 1 R233



19-AB0391-FTX SMD. RES 390 OHM 1/10W +/-1% 0603 1 R254



19-AB0470-JTX RES SMD 47 OHM 1/10W +/-5%0603 1 R057














19-AB0751-JTX SMD. RES 750 OHM 1/10W 0603 1 R012























25-BFB100-M1X CAP. ELEC 10 UF 50V +/-20% 1 C219




25-MFB109-K1X CAP.ELEC 1UF 50V +/-10% 1 C220

25-MFB478-K1X CAP.ELEC 50V 0.47UF +/-10% 1 C230

25-MFB478-K1X CAP.ELEC 50V 0.47UF +/-10% 1 C208

27-MBC104-J0X CAP. M.P.E 0.1 UF 63V +/-5% 1 C238


27-PBC152-J0X CAP. P.E 0.0015UF 63V +/-5% 1 C201



28-AB0102-JCX SMD. CAP 1000PF 50V +/-5% 0603 1 C243

28-AB0102-KBX SMD. CAP 1000 PF 50V +/-10% B 1 C221



























28-AB0150-JCX CAP.SMD 15P 50V +/-5% 0603 1 C023

28-AB0150-JCX CAP.SMD 15P 50V +/-5% 0603 1 C020

28-AB0150-JCX CAP.SMD 15P 50V +/-5% 0603 1 C017

28-AB0150-JCX CAP.SMD 15P 50V +/-5% 0603 1 C024














28-AB0331-KBX SMD. CAP 330 PF 50VDC +/-10% 1 C042

28-AB0470-JCX CAP.SMD 47PF 50V +/-5% 0603 1 C019






28-AB0560-JCX SMD CAP. 56 PF 50V +/-5% 0603 1 C252

28-AB0560-JCX SMD CAP. 56 PF 50V +/-5% 0603 1 C251

28-AB0829-CCX SMD. CAP. 8.2 pF 50VDC +/-0.25% 0603 1 C010

33-KLL120-KTX SMD. COIL 12 UH +/-10% 0603 1 L203

33-KLL120-KTX SMD. COIL 12 UH +/-10% 0603 1 L202

33-KLN601-NTX CHIP BEAD 600 OHM +/-25% 1 R013

33-KLN601-NTX CHIP BEAD 600 OHM +/-25% 1 R014








34-A330K0-1IX COIL CHOKE 33UH +/-10% 1 L208




35-LB1005-0IX FERR BEAD H75 (3.5X1X5) 1 J043

35-LB1005-0IX FERR BEAD H75 (3.5X1X5) 1 J007

38-236083-00X COIL IFT FOR VCO 45.75MHZ 1 T201

40-14DN3W-MAF1X P.C.B MAIN BD 1



















































41-WJ0125-B00 WIRE BARE JUMPER 12.5MM 1 L207






































45-FIL4M5-0Y1 CERAMIC FILTER SFSH4.5MDB 1 X204

45-OSC4M4-3Y0 CRYSTAL 4.43MHZ (CL=16PF) 1 X201

45-OSC6M0-0Y0 CRYSTAL 6MHZ 1 X001

45-TRA4M5-0Y0 CER TRAP TPS 4.5MHZ 1 X209

46-30790H-06X HS UL #24 400 TJC3-6Y/SCN-6Y 1 MAIN PCB P003 TO DVD

PCB CN9

46-33079W-04X PIN BASE *4 TJC3-4A 1 P001

46-33079W-06X PIN BASE *6 TJC3-6A 1 P904

46-33079W-06X PIN BASE *6 TJC3-6A 1 P002

46-33079W-07X PIN BASE *7 TJC3-7A 1 P004

46-33630H-05X HS 5P24 280 F/W TJC3-5Y/SCN-5Y 1 P201 TO

P501

46-CC035T-07J HS 7P 2468#24 350MM TJC3-7Y*2 1 MAIN PCB P004 TO DVD

PCB CN5

62-227680-0UAG BRACKET ABS-KINGFA 606 (UO) 1

62-435060-0UNG MAIN BD BRACKET 1

63-B30100-AB4G S/T SCREW B 3 X 10 AB 4 MTG M.BD & M.BD BKT

62-227680-1UAG FBT BRACKET 1

28-AC0105-ZFX SMD. CAP 1 UF 16VDC +80%/-20% 1 C320

T8-14DN3W-PW2 POWER BD ASSEMBLY 1


09-38C18V-DTX SMD.DIODE 1 D821











10-0001H8-FBX DIODE 1H8 (FAST RECOVERY) 1 D809

10-0RL255-EBX DIODE RL255 OR RL206(POWER

RECTIFIER)

1 D803


RECTIFIER)

1 D804


RECTIFIER)

1 D802


RECTIFIER)

1 D801

10-0RU3AM-F0X DIODE RU3AM (FAST RECOVERY) 1 D833

10-0RU3YX-F0X DIODE RU3YX (FAST RECTIFIER) 1 D830

10-0RU3YX-F0X DIODE RU3YX (FAST RECTIFIER) 1 D841

10-0SR540-F0X DIODE SR540 1 D871

11-P5NK50-0AX TRANSISTOR STP5NK50ZFP 1 Q816

11-SA1015-YBX TRANSISTOR ST2SA1015Y (PNP) 1 Q801

11-SC1815-YBX TRANSISTOR 2SC1815-Y (NPN) 1 Q865

11-SD2012-0CX TRANSISTOR 2SD2012 1 Q843

12-BC847A-0BX SMD TRANSISTOR BC847A (NPN) 1 Q844







13-000TL4-31T IC TL431ACLP 1 IC803

13-0HPC92-2CP PHOTO COUPLER HPC922-C 1 IC802

13-0L7805-CVS +5V 1.5A IC L7805CV 1 IC402

13-78L33A-CZT IC L78L33ACZ 1 IC804

13-PQ05RD-21S IC PQ05RD21 TO-220 SHARP 1 IC871


13-TEA150-6TB IC TEA1506T/N1 118 1 IC801

18-CD0101-JNX RES. C.F. 100 OHM 1/4W +/-5% 1 R813







18-DE0823-FNX2 RES. M.F. 82K OHM 1/2W +/-1% 1 R839

18-EF0109-JGX RES. FUS. 1 OHM 1W +/-5% (LS) 1 R843

18-FF0334-JGX RES. M.O. 330K OHM 1W +/-5% 1 R804

18-FG0683-JHX RES. M.O. 68K OHM 2W +/-5% 1 R810

18-KF0825-JHX RES. GLASS GLAZE 8.2M OHM 1W 1 R829

18-RG0158-JHX RES. WIRE ROUND 0.15 OHM 2W +/-5% 1 R815



19-AB0100-JTX RES SMD 10 OHM 1/10W +/-5% 1 R814












19-AB0122-JTX SMD. RES 1.2K OHM 1/10 J 0603 1 R811




19-AB0332-JTX SMD RES 3.3K OHM 1/10W 0603 1 R812

19-AB0333-JTX RES. SMD 33K OHM 1/10W 0603 1 R837

19-AB0333-JTX RES. SMD 33K OHM 1/10W 0603 1 R818





19-AB0681-JTX SMD. RES. 680 OHM 1/10W 0603 1 R835



19-AB0753-FTX SMD.RES 75K OHM 1/10W +/-1% 1 R842

22-NTC479-XX0 NTC 4.7 OHM +/-18% NTC4.7D2-14 1 R803

22-PTC909-3A5 PTC 9 OHM 1 RT801

25-BCA102-M1X CAP. ELEC 1000 UF 16V +/-20% 1 C872


















25-BKJ221-M1X CAP. ELEC 220 UF 200V +/-20% 1 C806

25-DFB109-M1X CAP. ELEC 1 UF 50V +/-20% NP 1 C834

25-PJG101-M1X CAP.CELE 100UF/160V/+/-20% 1 C835

26-ABC103-ZFX CAP. CER 0.01 UF 50V +80-20% F 1 C842

26-ABC103-ZFX CAP. CER 0.01 UF 50V +80-20% F 1 C831




26-AIM103-KBX CAP. CER 0.01UF 500V +/-10% B 1 C805

26-AIM103-KBX CAP. CER 0.01UF 500V +/-10% B 1 C826

26-AKA221-KRX CAP. CER 220 PF 1KV +/-10% 1 C833

26-AKA221-KRX CAP. CER 220 PF 1KV +/-10% 1 C809

26-AKK103-MFX CAP. CER 10 NF 1KVDC +/-20% 1 C810

26-AMK152-KBX CAP. CER 1500 PF 2KV +/-10% B 1 C815

26-APK102-ME4 CAP. CER 1000PF 400VAC+/-20% E 1 C804



26-AQK472-ZFX CAP. CER 4700PF 250VAC +80%�-20% F 1 C808


26-AQK472-ZFX CAP. CER 4700PF 250VAC +80%�-20% F 1 C807

27-AQT224-MV3 CAP.M.PP 0.22UF 250VAV +/-20% 1 C801

27-MHM104-K0X CAP. M.P.E 0.1 UF 400V +/-10% 1 C802

28-AB0102-KBX SMD. CAP 1000 PF 50V +/-10% B 1 C839















28-AB0224-ZFX CAP.SMD 0.22UF 50V +80-20%0603 1 C818

28-AB0471-KBX SMD.CAP. 470PF 50V +/-10% 1 C813

28-AB0471-KBX SMD.CAP. 470PF 50V +/-10% 1 C812

28-AB0473-KBX SMD CAP 0.047UF 50V +/-10%0603 1 C811

34-R101K2-1BX COIL CHOKE 100 UH +/-10% 1 L834






35-392170-00X FERR.COIL BF-I35050C-683 1 L840

35-392170-00X FERR.COIL BF-I35050C-683 1 L885

35-392170-00X FERR.COIL BF-I35050C-683 1 L887

35-392170-00X FERR.COIL BF-I35050C-683 1 L884

35-392170-00X FERR.COIL BF-I35050C-683 1 L833

35-392170-00X FERR.COIL BF-I35050C-683 1 L830



36-LIF010-XX0 LINE FILTER LCL-2821A 1 T801

36-TRF198-AX1 TRANSFORMER CONV. BCK-3532A 1 T803










41-WJ0075-B00 WIRE BARE JUMPER 7.5MM 1 N802

41-WJ0075-B00 WIRE BARE JUMPER 7.5MM 1 N806




41-WJ0100-B00 WIRE BARE JUMPER 10MM 1 N805





43-TSS112-DMX RELAY POWER SMIT-SS-112DM 12V 1 K850

46-35063W-03X PIN BASE *3 VH-3A 1 P804

46-35063W-03X PIN BASE *3 VH-3A 1 P805

50-02000D-1GS1 FUSE 2.0AT 250VAC 5MMX20MM 1 F801

51-BC0190-0LN01 POWER CORD SP-120+NISPT-2

18AWG/2C

1 FOR P804

64-B30060-303G M/C SCREW 3 X 6 B 1 FOR Q816



64-B30080-304G TRIANGLE M/C SCREW B 3 X 8 1 FOR Q843

66-20517X-0B7 FUSE HOLDER 2 FOR F801

67-384260-0E7 HEAT SINK 1 FOR Q816

67-H10918-4M2 HEAT SINK 1 FOR Q843

67-H10918-4M2 HEAT SINK 1 FOR IC402

67-H27292-3A0 HEAT SINK 1 FOR IC871

90-209770-SR1U SILICONE GREASE G-746 1

18-KE0105-JN3 RES. H.VOLT. CC 1M OHM 1/2W +/-5% 1 R802

T8-14DN3W-TU1 TUNER BD ASSEMBLY 1

07-457FF5-NA8 TUNER FSNA05T-4 1 TU101

10-79C33V-DBX DIODE ZENER 33V 1/2W 5% 1 D101













34-A470K0-1IX COIL CHOKE 47 UH +/-10% 1 L101








45-SAWM19-71M SAW FILTER M1971M 1 Z101

T8-14DN3W-SW2 SWITCH BD ASSEMBLY 1

02-IRR001-XX1 IR RECEIVER MODULE HRM380017 1 IR001

14-LED05R-XX1 LED RED FB205 1 D080



18-CB0221-JNX RES. C.F. 220 OHM 1/6W +/-5% 1 R980












25-HCB100-M1X CAP. ELEC 10 UF 16V +/-20% 1 C981

25-HCB100-M1X CAP. ELEC 10 UF 16V +/-20% 1 C980

26-EBP103-KBS CAP.CER 10NF 50V +/-10% 1 C080

26-EBP471-JCS CAP. CER 470 PF 50V +/-5% 1 C988

26-EBP471-JCS CAP. CER 470 PF 50V +/-5% 1 C987

40-14DN3W-FBC1X P.C.B FROTN CTL BD 1


46-33630H-05X HS 5P24 280 F/W TJC3-5Y/SCN-5Y 1 P980 TO MAIN BOARD

P603

46-CD022T-06J HS 6P 2468#24 220MM TJC3-6Y/SCN-6Y1 P081 TO MAIN BOARD

P002

46-CD045T-06J HS 6P 2468#24 450MM TJC3-6Y 1 P982 TO MAIN BOARD

P904

47-EAR002-XX1 EARPHONE SOCKET CK3-3.5-9WK-D 1 P985

47-RCA009-XX3 AV SOCKET HORIZONTAL

RED/WHITE/YELLOW

1 P986

48-TAC001-XX0 TACT SWITCH 1 S009










62-226920-0HAG LED HOLDER ABS-LG H121 (HB) 1

T8-14DN3W-PA1 PACKING ASSEMBLY 1

T8-14DN3W-PA1Z PACKING ART DESIGN ASSEMBLY 1

76-437730-0AT CARTON BOX 1

74-020030-62C1A PLASTIC BAG 1

74-081081-80H POLYBAG (81CMX81CM) 1

77-400140-14C PLASTIC BAG 1 FOR REAR BKT

75-EDN3UL-CC0 POLYFOAM"UL" 1

75-EDN3UR-CC0 POLYFOAM"UR" 1

75-EDN3LL-CC0 POLYFOAM"LL" 1

75-EDN3LR-CC0 POLYFOAM"LR" 1

T8-14DN3W-RC2 ASS'S - REAR BD 1

63-B30100-AB4G S/T SCREW B 3 X 10 AB 6 MTG WHEEL

63-B30100-AB4G S/T SCREW B 3 X 10 AB 2 MTG SIDE COVER TO

R.CAB

63-B40150-AB3G S/T SCREW B 4 X 15 AB (BLACK) 6 MTG WHEEL TO R.CAB

63-B40200-AB4G S/T SCREW B 4 X 20 AB 4 MTG F.CAB & R.CAB

63-F30100-BT3G S/T SCREW F 3 X 10 BT 1 MTG RCA JACK TO R.CAB

63-W30100-AB4G S/T SCREW W 3 X 10 AB 2 MTG SUPPORT TO R.CAB

T8-14DN3W-RC1Z REAR CABINET ART DESIGN ASSEMBLY 1

55-EDN3RC-0UNG REAR CABINET 1


56-434970-0HNG PANEL_"R" 1

56-434980-0HNG PANEL_"L" 1

56-435010-0UNG REAR BKT 1

56-435020-0HNG OIL COVER 1 MTG RIGHT SIDE COVER

56-435030-0HNG TYRE_"R" 1

56-435040-0HNG TYRE_"L" 1

56-435390-0HNG TYRE 2

56-435050-0HNG SCREW CAP 10 MTG OUTSIDE WHEEL

58-EDN3RI-0UI INLAY REAR AV 1

T8-14OFLP-IR10ADA ASS'Y - METCH TUBE NOMINAL 1

T8-14DN3W-CR1 CRT BD ASSEMBLY 1


10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 D502

10-1N4148-ABX DIODE 1N4148 (SWITCHING) 1 D501

11-SA1015-YBX TRANSISTOR ST2SA1015Y (PNP) 1 Q510

11-SC2482-0BX TRANSISTOR 2SC2482 1 Q502








18-CB0472-JNX CARBON RES. C.F. 4.7K OHM 1/6W

+/-5%

1 R502


+/-5%

1 R505


+/-5%

1 R508








18-CD0105-JNX RES. C.F. 1M OHM 1/4W +/-5% 1 R528




18-FE0272-JNX RES. M.O. 2.7K OHM 1/2W +/-5% 1 R515







25-BLA479-M1X CAP. ELEC 4.7 UF 250V +/-20% 1 C510

26-AMK102-KRX CAP. CER 1000 PF 2KV +/-10% R 1 C505

26-EBP103-ZF1 CAP CER 50V 2.5MM 10KpF -20%+80% 1 C507

26-EBP103-ZF1 CAP CER 50V 2.5MM 10KpF -20%+80% 1 C515

26-EBP221-JCX CAP. CER 220PF 50V +/-5% CH 1 C502



34-R569K2-1BX COIL CHOKE 5.6 UH +/-10% 1 L501

35-139730-00X FERR. BEAD BF60 2 L505 FOR C516

40-14DN3W-CRA1X P.C.B CRT BD 1



46-10967W-01X PIN BASE *1 TJC1-1A 1 P531

46-33079W-05X PIN BASE *5 TJC3-5A 1 P501

46-35179W-04X PIN BASE TJC3-4A 1 P502

47-CRT009-CX0 SOCKET CRT 12P GZS12-4-2 1 S501

T8-14OFLP-FIR10ADA ASS'Y - METCH TUBE NOMINAL(F.CAB) 1

44-14OFLP-IR1A 14"CRT 37SX110Y22-DC15 1

46-20600H-04X HS 4P A/B 360/13 RBGW TJC1-4Y 1 TO P402

T8-14OFLP-MIR10ADA ASS'Y - METCH TUBE NOMINAL(MAIN

BD)

1

18-CE0103-JNX RES. C.F. 10K OHM 1/2W +/-5% 1 R413

18-EF0159-JGX RES. FUS. 1.5 OHM 1W +/-5% 1 R408

18-FG0122-JAX RES. M.O.F 1.2K OHM 2W +/-5% 1 R414

25-BJA100-M1X CAP. ELEC 10 UF 160V +/-20% 1 C417

27-AGQ394-JSX CAP. M.PP 0.39 UF 250VAC +/-5% 1 C416

27-ALR103-J0X CAP. M.PP 0.01 UF 1.6KV +/-5% 1 C424

36-LIN450-XX1 COIL LINEARITY 45 UH 1 L402

36-WID100-XX0 COIL WIDTH 10UH 1 L403

37-SC2502-07Q01 FBT BSC25-0207Q 1 T402

46-35184W-04X PIN BASE *4 TJC1-4A 1 P401


4、Alignment Procedure Ⅰ. SUMMARIZE 1.1 Common Information

M71 is NTSC only system model developed for NAFTA market specially. In trial run, burn the latest software to SDA5555 IC which has a 128KByte flash memory. At least after the first batch production, make the mask,please take care in production. And, please note: All the soldering points in white circles must be re-soldered before the Alignment Procedure.

To solve the probable problems in production, for the workers participate in alignment, please be familiar with the Alignment Procedure. 1.2 How to enter factory Mode

There are 2 operation modes：User mode and D-mode. You can use the Remote control or buttons on the panel to operate in user mode, but only Remote control works in The way to enter D-mode：Press “ OK” button on RC; use numeric buttons to select the pages of D-mode; use “▲ ” and “▼ ” to select the item you want to adjust, Press “ ” and “ ” to change the parameters. To quit factory mode， press “OK” button, the factory data changed will be memorized. 1.3 Some special modes： 1.3.1 Aging mode — used before alignment. The aging could start in D-mode. 1.3.2 Vertical stop mode — used to confirm the screen voltage. Press “CC”button in D-mode to enter Vertical stop mode. Then press “CC” button again to exit. 1.3.3 White balance alignment mode(BUS OFF) — used for white balance auto alignment. Press “CC” button in user mode to enter White balance alignment mode.

1.3.4 Factory out mode — To initialize the set, enter D-mode page 8 and select “INIT USER”, then press “ ” to start the initialization. When the initialization finish，the set will shut off D-mode automatically. Then D-mode can not be opened by pressing “OK” button. To enter D-mode again，use remote control to set the volume to “0” then press the following buttons orderly within 2 seconds: “OK—DISPLAY—OK—DISPLAY—OK—DISPLAY”. .


Ⅱ. Alignment contents：

2.1. Mains Supply check: Turn on TV and set volume, contrast, brightness and color to nominal, apply a RF signal modulated with a white pattern. Check the voltage across C835, it should match the below table or check the mains the mains supply building block. Model CRT Mains supply (V) 14DN3WYD/VS 44-140FLP-IR1A 108±3 2.2 AFT adjustment: 2.2.1 Cut off the RF signal and input a 45.75MHz color bar signal to the IF pin of tuner (pin11).

2.2.2 Adjust T201 until the voltage at pin 48 of IC201 is 4.62 +/- 0.2V and the color bar picture on screen keep stable.

2.2.3 Enter D-mode page 9 and select “SFVCO”, press “ ” to shift the data to “01”. Then Auto

AFT Adjustment start and the data will return to “00” when the adjustment is finished. 2.3 RF AGC adjustment 2.3.1 Via a 50 OHM coaxial cable terminated with a RC(50 OHM, 10 nF) network Illustrated as below, input 8-scale gray signal (100% video modulation, sound carrier off, 105dBuV/178mVrms) to the IF pin of tuner (pin11);

2.3.2 Detect the voltage Urf at the AGC pin of tuner (pin1); 2.3.3 Adjust RFAGC data in D-mode page 9, until Urf=3.3V+0.5V/-1.0V.

TTE Overseas Support Department 2.3.4 Test three units according to 1)，2)，3) steps, and record the values of AGC in three units. Take the average value as benchmark. Remarks: 1) Comparing test is necessary due to different probe of Oscilloscope and different Test Circuit. 2) AGC voltage value should be tested afresh, due to the type/supplier of Tuner or Saw filter changed, or other related components changed.

2.4 Screen & Focus voltage adjustment 2.4.1 Apply a NTSC crosshatch pattern signal in nominal status.

Enter Factory mode ， press “CC” button to stop vertical scan. (Note ： RCUT/GCUT/BCUT should be preset to 80，and GDRV/BDRV to 40) 2.4.2 Adjust the SCRREEN switch on the fly back transformer to make a horizontal shining line just visible on the screen. 2.4.3 Turn on the vertical output, adjust the “FOCUS” on the fly back transformer to obtain the optimum focus. 2.5 White balance adjustment 2.5.1 Apply a NTSC black and white pattern in nominal status; 2.5.2 Use a color analyzer to measure the black side of the screen. By changing the value of RCUT, GCUT and BCUT, set the reading of the color analyzer to x=284+8,

TTE Overseas Support Department y=299+8. 2.5.3 Use a color analyzer to measure the white side of the screen. By changing the value of GDRV and BDRV, set the reading of the color analyzer to x=284+8, y=299+8. Separately set the brightness and contrast from min. to max., repeat the step 2 and 3 until the reading of the color analyzer is correct. Note: Provided the production line is equipped with the auto-adjusting equipment for White balance adjustment, just use “CC” button under user mode to shut down the bus. 2.6 Sub-brightness Adjustment Apply a video NTSC grey scale and color bar signal in nominal status. Enter D-mode page 4, Select BRTC to adjust the sub-brightness, until that the 2nd dark bar of 8 level Grey scales just can be distinguished.

2.7 Geometry adjustment Apply the Philips standard testing pattern signal in nominal status.

Enter D-mode page 3, adjusting the following data to get the minimal distortion. VPOS60 (Vertical Center） HIGH60 (Vertical Amplitude) VLIN6 (Vertical Linearity） VSC60 (Vertical S-Correction) HPOS60 (Horizontal Center) 2.8 EHT/HEW ratio test（test with PC program）:


Instruments： EHT test meter，EHT test bar(1000:1)，adjustable power supply ， virtual DY( the same L value with CRT in production ).

Input signal pattern： Black pattern Required Data: EHT and HEW voltage when Ib=0; (HEW voltage value is the DC

voltage across C431). Expected Result: EHT/HEW should match the requirements below： Model CRT FBT EHT(0uA)(KV) HEW(0Ua)(V) RATIO

14DN3WYD 44-140FLP-IR1A

37-SC2502-07Q01

22.5±1.5 21.0±1.5 1071±3%

2.9 X-rays over protecting circuit test: Turn on the TV and apply more than 26V DC voltage across C431，the set should enter protecting mode，or check X rays protecting circuit. 2.10 Mains cord polarity test: Connect follow the graphic below：

Plug the PS line onto the PS socket M, then touch any pin of F801 with the probe, the LED DX will shine at the moment, with sound reminder, or it is disqualification. 2.11 Power consumption test (Random test): Instruments： Power meter. Press TV/AV/DVD button ,select the DVD mode ,press play button. Test Method： Set the Brightness, Contrast to max, adjust the volume to get 0.5W output.

Connect the power meter to test the input power consumption. Switch the set to standby, and test the power consumption again, which should meet the


requirements below： Model Power on Standby

14DN3WYD Less than 60W Less than 3W

2.12 EHT Range test (random test) Instruments： High voltage meter， Ib meter. Input signal pattern： White pattern Input signal intensity： 60dBuv (1 Mv rms) Test Method： Connect High voltage meter and Ib meter. Test EHT-voltage at

respective Ib separately, It should meet the requirements below：

EHT(KV) Diff. in EHT at Respective Ib (KV)Model

Ib=50uA Ib = 50uA and 700uA 14DN3WYD 22.5± 1.5 < 2

2.13 Heater voltage test (random test) Instruments： RMS voltage meter Input signal： White pattern Input signal intensity： 1mVrms（60dBuV）to 50mVrms Connect the RMS voltage meter across CRT filament, set contrast, brightness to max, test the heater voltage and it should meet：6.3±0.3Vrms 2.14 CCD and V-CHIP function test (random test) Test V-CHIP and CCD function according to the related standard file. 2.15 Initialization

To initialize the set, enter D-mode page 8 and select “INIT USER”, thenpress “ ” to start

the initialization. When the initialization finish，the set will shut off D-mode automatically. EEPROM DATA： Note：Only the items with “*” can be adjusted according to respective status; please set the other items to the same data as below.

Data

Model

PAGE 0

14DN3NYD

BACK

COLOR 00

OSD HL

CA

OSD HH

00

OSD VL

15

OSD VH

00

OSD CLKL

48

OSD CLKH

01

TXCX

30

RGCN

1D


PAGE 8 Data Model SWITCH* THEME TUNER POWER INIT USER

14DN3NYD 01 01 00 01

Data Model

PAGE 9

DVD14DN3NYD AFCGN 00

PIFVCO*40

RFAGC*18

SFADJ00

SFVCO00

SCNT 0A

IF 01 01

Ⅲ. CDRH Document: 3.1 Testing for EHT and HEW

Model CRT FBT

EHT(Ib=0uA) (KV)

RATIO

14DN3WYD/VS 44-14OFLP-IR1A

22.5±1.5

21.0±1.5

1071±3%

3.2 The Value of Sample Register in X-ray protection circuit

Model BOM CRT Designator value 14DN3WYD/VS 03-EDN3ADA-US30 44-14OFLP-IR1A R254/R255 390Ω/120Ω 3.3 Test of X-ray protection circuit ( X-ray protection circuit will not work with nominal voltage, or it does work with over-load voltage) Model

BOM

CRT Designator

Nominal Voltage

over-load voltage

14DN3WYD/VS 03-EDN3ADA-US30 44-14OFLP-IR1A

C431

21.5±1.5

>26V

Ⅳ. RE-SOLDER POINT LIST: All the soldering points in white circles must be re-soldered: T402 (pin1, pin8, pin10) Q402(C) C424 C416 P401 L402 L403 D833

TTE Overseas Support Department C835 T803 (pin1, pin3, pin6, pin7, pin12) Q816 (D) C806 P804 T801 C801 P805 RT801 C402 Ⅴ. TESTING PROCEDURE FOR DVD SECTION : 5.1 Check the functional key and disc reading devices。 Press the OPEN/CLOSE button to open the disc tray. Play a DVD disc, and at the same time, check whether other functional keys, such as PLAY/PAUSE, STOP can also take effect. The tray should move smoothly when taking in a disc, no noise or pause. 5.2 Check the playability 5.2.1 CD: open the disc tray and put in a CD disc, the disc will be played automatically,music comes out and without any noise and in-continuous. 5.2.2 DVD: open the disc tray and play a DVD disc, the picture on the screen should be continuous, no in-continuous or mosaic. 5.3 Check the sound and picture Before checking, make sure the TV video parameters such as brightness, color, contrast and sharpness are set to normal values. The TV set should be in good status when co-working with DVD player. When playing DVD disc, Snow, horizontal/vertical stripes, mosaic, darkness and sharp brightness are unacceptable. Check the picture’s clearness, saturation and stability. Disturbance, distortion and cross disturbance are unacceptable. 5.4 Check the output signals of DVD 5.4.1 Analog signal Connect the set to a TV monitor which has a SCART input terminal using SCART cable, or connect to another 14DC1EJ0 set, from terminal SCART 1 to SCART 2, Play a DVD disc to check the sound and picture, any disturbance, distortion, cross disturbance noise are unacceptable.

TTE Overseas Support Department 5.4.2 Digital signal Connect the set to a power amplifier which has coaxial input terminal using a coaxial cable, when playing a DVD disc, check the digital sound. Noise and distortion are unacceptable. 5.5 Check the DVD menu and DVD regional code settings 5.5.1 Check the DVD menu (include OSD LANGUAGE; AUDIO settings) 5.5.2 Check the DVD regional code setting and destination country.


5、Block Diagram

5

5

4

4

3

3

2

2

1

1

D D

C C

B B

A A

VERTICAL CONTACT

3(C) 1(E)

2(B)

I2C ADDR = 0XA0

SDRAM POWER +3.3V34ma~58ma170MA, 570MA待机开机

Flash POWER +3.3V

Servo MOTOR+5V power

8202 kernel +1.8V Video PLL +1.8V

260mA

Video buffer +5V

SYSTEM

Servo

Audio PLL

Video DAC

3 mA

RF Power

PLL power

APC Power

close to 8202

Power OnMute

PowerOffMute

R29

0

R36 R32

NC

0

R31

NC

1 22K

C54

NC0

1

NCAM5668

Motor Driver Parameter

NC

NC

C51

NC0

330pNC

NC0

R350

R41 R3822K

R341 1AT5660 330p

R39

NC

R40

1000P

C47

20K

Motor Driver AT5660

4.7

Motor Driver AM5668

20K0

R26

39K

100

5.1

R49

1000P

R24

100

1000P

R23

2.2K

R50 C46

0

R24

1000P1500PSony

C46

68K33K 1000P

10K

5.1

R54

Sanyo

39K4.7

Pickup head parameter

R52 C47 R23

CTC01-SCH-D8202-001 1.0

DMM06C

D

2 7Tuesday, May 10, 2005

A&D TECHNOLOGY CENTER

Title

Size Document Number Rev

Date: Sheet of

DVDLDOCDLDO

RAD+

DVD_VR#CDLD

CD_VRCDVR

C

FBA

DVD_VR

E

DVDLD

MD

11

MD

0

MA2

RA4

MD

2

D

RFCT

PUHRF

RA8

V_B

IAS

V_R

EF

DQM0

XOPVIP1

DMEA

LGIN

MD

4

US

B_D

P

RA6

RA14

M_B

A0

M_C

S0

MD

3

MA6

TV_D

AC

3

Vref0

RA0

M_C

AS

MD

5

RE

SE

T_B

V_C

OM

P

MA8

DQM2

XOPVIN1

RFI

RA5

RA

15

SDRAM_CLKTRAY-

RA11

RA12

RA

16R

A18

MW

E

MA7

RFR

P

RFIP

MD

10

MD9

MA1

DFCT

RA7

MD

12

MD

6

MA9

UA

RT1

_RX

XOPOP1

CDMDIDVDMDI

MA4

RFO

VREF2

RA3

RA17

RA10

MD

7

DQM3

RA1

RA13

RA

19

M_BA1

DVDLDO

RA2

MD

14M

D15

MA10

TRAYIN

DPDC

VREF1

DPDA

RD7

MD

13

M_R

AS

MA0

MA3

PD

US

B_D

M

IR#

MA11

M_CKE

C

E

FD

CDMDI

RA9

MD

1

MD8

DQM1

TRAY+

VREF2

CDLDO

F

DVDLDCDLD

SPDCO

LDSW

LDSW

HOME

D

TRAYOUT

SP+SP-

SLED-

LOAD-LOAD+

TRAYIN

TRAY+TRAY-

SLED+

DMEA

VOSP-VOSP+

XOPVIP1 VREF2

XOPVIN1XOPOP1

TCO

SCO

TCO

FCO

FCO

SPDCO

MD3

M_BA0

M_CS0

D9D8

M_CAS

D0

MA2

M_CKE

MD4MA3

MD6

MA9

MA7

MWE

MA9

MA0

MA4

MD7

M_RAS

M_CKE

D10

D5

D1

MA5

MD13

MWE

MD5

DQM2

MD2MA2

D4

MA8

SDRAM_CLK

M_CS0

D6MA6

MD1

MD9

DQM3

D15

D3

MA1

RAM_CLKMD14

D2

M_RAS

MA4MA3

MA0

M_BA0

MA5

DQM1

MA7

MD12

M_CAS

RAM_CLKD14

MD10

DQM0

MD15

MA8

MA1

D12

MD0

MA6

MA10

D13

D11MA10

MD8

MD11

D7

RA18RA19

RA12

RWE

RA4

RD1

RA6

RA8

RA11

RD0

RA17

RA9

RD6

RA2

ROE

RA10

RESET_B

RA7RD5

RA3

RD7

RA16

RA13RA14RA15

RA5RD3RD4

R_CS1

RD2

RA1

RA0

SCO

DAC-LAU_XCK

AU_D0+5AVAA

AU

_D0

AU_BCKAU_LRCK

DAC-R

VGND

R

LAGND

GND+A5V

+12V

+D5V

TRAYOUT

AUDIO_MUTE

SPDIF_OUT

V_F

SA

DJ

SCL

VGNDAGND

C/G

Y/CVBS

IR#

UR_SDA

COAXAGND

+D5V

D14

D6D7

D15

D2D3

D5D4

D13D12D11

D1

D9

D0

D8

D10

A20

RA20A20DQM0

D0

D12

D9

D6

MWE

MA4

M_BA0

M_CS0

MA1

RAM_CLK

MA9D8

MA6

M_CKE

MA8

D3

D7

MA5

D13

M_RAS

D5

D10

D4

D15

MA10D11

D1

M_CAS

MA7

MA2

DQM1

D14

MA11

MA3

MA0

D2

UA

RT1

_TX

UA

RT0

_RX

UA

RT0

_TX

FOC+

DVDMDI

RAD-

VREF1

A

FOC-

PUHRF

UART0_RX UR_SDA

UART0_TX UR_SCL

GND

UART1_RXUART1_TX

P+5V

DVD_READY

UR_SCLGNDIR

P+5V

M_BA1

RESET_B

PSWUSB_DM

DGND

USB_D+USB_DP USB_D-

VBUS

HOME

RESET_B

V_BIAS

GND

DVCC3UART0_RXUART0_TX

FLASH_POWER

B

FGIN

CLK

OU

TC

LKIN

DGND

RD4RD3

RD2

RD6RD5

RD1

RWE

ROE

RD0

MA5

TV_D

AC

4

SD

AS

CL

TV_D

AC

5

AU

_XC

KA

U_B

CK

AU

_LR

CK

SP

DIF

_OU

T

AU

DIO

_MU

TE

DA

_LD

A_R

SDA

R_C

S1

PS

W

DV

D_R

EA

DY

TV_D

AC

0

RA13

ROM_PIN1RA18

RA6

RD2

RA0

FLASH_POWER

RA9

RD0

RA3 RD3

RA10RA11

RA16RA15

RWE

RD6

RA4

RA14

RA5

RA1

RD7

RA12

RA7RA8

ROE

RD5

RA2RD1

R_CS1

RD4

RA17

GND

VCC1.8

DVCC3

GND

RFGND

APC3.3V

RFGND

RFGND

RFGND

RFGND

A+5V

RFGND

RFGND

RFGND

RFGNDRFGND

RF3

.3V

VGND

GND

VG

ND

US

B_P

LL3.

3

GN

D

RFGND

GND

GN

D

RF3

.3V

GN

D

GN

D

VCC1.8

DVCC3

RFGND

RF3.3V

PLL

3.3V

DVCC3

VV

CC

3

VG

ND

RFGND

AP

LLV

CC

3

RFGND

APC3.3V

RFGND

DV

CC

3

AD_VCC3

RFGND

DVCC3

VC

C1.

8

VP

LLV

CC

1.8

A+5V

RFGND

VV

CC

3

DV

CC

3

VV

CC

3

VC

C1.

8

RFGND

VG

ND

VCC1.8

GND

RFGND

RFGND

RF3.3V

RFG

ND

GND

RFGND

RF3.3V

RFGND

MGND

MGND

MGNDM+5VMGND

RF3.3V

GNDGND

SD_VCC3SD_VCC3

GNDGND GND

ROM_VCC3

AGND

AGNDAGND

AGND

A12V

AGND

AGNDAGND AGNDAGND

AGND

AGND

AGND AGND AGND

AGND

AGND

M+5V

SD_VCC3

DVCC3

ROM_VCC3

GND

GND

GND GND

VCC1.8

GND

VPLLVCC1.8

GND

V+5V

GNDGND

+5AVAA

VGND

P+5V GND

A+5V

APLLVCC3

AD_VCC3

VVCC3

USB_PLL3.3VGND

APC3.3V

RF3.3V

PLL3.3V

RFGNDRFGND

GND

DVCC3

A12V

AGND

+5AVAA

VGND

DVCC3

GND GND

GND

GND AGND

AGND

AGND

AGND

AGND

AGND

AGND

AGND

A12V

DVCC

DVCC

SD_VCC3

SD_VCC3

RFGND

RFGND

RFGND

RFGND

DVCC3

P+5V

DVCC3

V+5V

SD_VCC3

MGND

P+5VGND

GND

RF3

.3V

VV

CC

3

MGND

RFGND

RFGND

GN

D

GND

GN

D

GND

GND

GND

GND

GND

GND

VG

ND

PLL

3.3V

VV

CC

3

GND

RF3

.3V

GND

D8 1N4148

C105100PF

C58

0.1UF

R2470

R218 0

R158 100

R19 150K

C78

0.1UF

U2 AZ1117D-ADJ-TO252

1

3 2

AD

J

IN OUT

C85

0.1UF

R117 100

C930.1UF

R114 1K

R1331K

+ EC10

47UF16V

C27 0.01uF

R123 3.3K

R101100K

+

-U11BNJM4558

5

67

84

C1

0.1UF

Q139012.

EC7

220UF16V

R5 10

R118 470

C77

0.1UF

R2084.7K

R14 150K

+ EC5

220UF16V

C45330PF

C71

10PF

Q12SK3018

2

31

+

EC2610UF16V

R130

22

CN13

1 2

+

-U11ANJM4558

3

21

84

C730.1UF

TP30PIN7

R131

R1322K2

+EC20

3.3u16V

R52

5.1

C47

1000PF

L24 500

R8 33

C103

10PF

R105 1K

C1070.1uF

R47470

TP3FGINCN8

CON7-2.54mm

1234567

C560.1UF

D5

1N4148

C260.01UF

L16

1UH

C117330PF

TP4RFCT

RN2 33(8 Pin, 4R)4321 8

765

U5

SDRAM 16M-6(512Kx16x2)

1

23

4

56

7

89

10

1112

1314

15161718

1920

21222324

25

26

272829303132

33

3435

36

37

38

3940

41

4243

44

4546

47

4849

50

VCC

DQ0DQ1

VSSQ

DQ2DQ3

VCCQ

DQ4DQ5

VSSQ

DQ6DQ7

VCCQDQML

WECASRASCS

BA/A11A10

A0A1A2A3

VCC

VSS

A4A5A6A7A8A9

NC

CKECLK

DQMH

NC

VCCQ

DQ8DQ9

VSSQ

DQ10DQ11

VCCQ

DQ12DQ13

VSSQ

DQ14DQ15

VSS

R46 100K

R115 1.8K

C82

0.1UF

C113

47PF

R36 1

R137 100

C84

0.1UF

U13

AM27C040/Flash MX29F040(PLCC)

12111098765

272623254

282932

3031

1

1314151718192021

3216

2224

A0A1A2A3A4A5A6A7A8A9A10A11A12A13A14A15A16A17A18

A19

D0D1D2D3D4D5D6D7

VCCGND

CEOE

U4 AM5668S1

910

12

32

15

7

1413

21

1920

24

27

6

45

28

8

111718

16

2322

2526

2930

VINFC

PVCC1PGND

VOSL+

CF2CF1

VOTK+

VNFFC

VOFC+VOFC-

PVCC2

PGNDVNFTK

CTK2

BIAS

VOSL

VINSL+VINSL-

STBY

VCC

VOSL-VOLD+VOLD-

VOTK-

VINLDPREGND

CTK1VINTK

GNDGND

C900.1UF

C112 390PF

R51 390

C76

0.1UF

R154 33/NC

RN4 33(8 Pin, 4R)4321 8

765

R11022K

R67

1K

C920.1UF

R25 2.2K

EC6

470UF16V

R37150K

L10FB

R121 100

R103 4.7K

R64

4.7K

R219 0

R54

5.1

R48 100K

R21 33K (1%)

C104100PF

L19500

+EC31 100UF16V

Q16C9014

C102100PF

C124 0.1U/NC

CN10

CON4-2.54mm

1234

Q5

2SB1132(type R)

R33 470K

R94100

C15

0.1UF

R113 22K

+EC12

10UF16V

Q22SK3018

2

31

R31 1

R6333

R68

1K

+ EC32

100UF16V

C53 4700

R9333 1/2W

R104 22K

R32 1

F1FUSE(0603,500mA)1 2

C109220PF

R28 4.7K

R58

10K

TP1LDSW

C11

0.1UF

R138 33/0805

R4470

U12RT9701/NC

4

5123 EN

VOUTVOUTGNDVIN

R76

4.7K

R23 68K

R70

NC

Q159012.

+

EC23

10UF16V

C32NC(120PF)

RN5 33(8 Pin, 4R)4321 8

765

R56 100

R53 0

C12

0.1UF

TP6RFRP

R153 33/NC

R50 0

C44 1000PF

+EC15

100UF16V

C83

0.1UF

L20500

C69

0.1UF

R11610K

Q149012.

R57

10K

R49 0

R17 1.5K

R1312K2

R223 0

D4

1N4148

CN12

CON4-2.0mm

1234

TP20

RFGND

L18500

C100

10PF

C118

47PF

R136100

C128

0.1U/NC

+

EC2220UF16V

+ EC9

100UF16V

C640.1UF

L15

1UH

R39 0

C6633PF

Q102N3904

R159 4.7K

+

EC2710UF16V

C13

0.1UF

CN4PITCH=2.5mm*7

1234567

C59

0.1UFR45

470

R15 5.1K

R40 NC

C6533PF

C8

0.1UF

C38 0.22UF

+EC25100UF16V

D3

1N4148(SMT)

R41 0

R7710K

C120 104

CN7

CON4-2.0mm

1234

R59 4.7KQ4

2SB1132(type R)

C750.1UF

C51 330

TP8

Reset

R120

10K

R24 33K

C43820PF

R126 470

R62

R160 4.7K

R35 1

R55 0

R38 NC

XT1 27MHz

R29 22K

R107 470R80

150

1%

Q6

2N3904

C37

0.1UF

C410.047UF

R109100K

R27 4.7K

C119104

C115 390PF

R75

150

1%

+EC2110uF16V

R61

C101100PF

C19

0.1UF

C240.068UF

R921.2K

R88100

C114 104

EC16

220UF16V

RN3 33(8 Pin, 4R)4321 8

765

R72 NC

C720.1UF

C3

0.1UF

+ EC14

100UF16V

R8733 1/2W

C16

0.1UF

L5

FB DIP

R106 1.8K

R10

2.2-0805

R102

22K

R912.4K

R71 NC

R11 0

CN9

CON2-2.54mm

12

C5

0.1UF

TP5DFCT

L21500

C123

NC

EC1

470UF16V

D7 1N4148

C291UF

C68

0.1UF

C10

0.1UF

+

EC19

47UF16V

R20

1.2K

(1%

)

U6

SDRAM 16M-6(512Kx16x2)

1

23

4

56

7

89

10

1112

1314

15161718

1920

21222324

25

26

272829303132

33

3435

36

37

38

3940

41

4243

44

4546

47

4849

50

VCC

DQ0DQ1

VSSQ

DQ2DQ3

VCCQ

DQ4DQ5

VSSQ

DQ6DQ7

VCCQDQML

WECASRASCS

BA/A11A10

A0A1A2A3

VCC

VSS

A4A5A6A7A8A9

NC

CKECLK

DQMH

NC

VCCQ

DQ8DQ9

VSSQ

DQ10DQ11

VCCQ

DQ12DQ13

VSSQ

DQ14DQ15

VSS

+ EC8

100UF16V

L8 FB(DIP)

C461000PF

L6FB

CN2

JCON5-2.0mm

54321

C60

0.1UF

R90150 1%

L11 10UH

TP25

A+5V

C281UF

C1270.1U/NC

Q112N3904

R34 22K

L12 10UH

R119

100K

R10810K

C810.1UF

C18

0.1UF

+ EC13

100UF16V

R135220

+EC29

470U/16V

+ EC4

100UF16V

R12 0

C1080.1uF

R214150 1%

R3 220

U19

ESMT M12L64164A-?SDRAM64M

1

24

12

57

9

810

46

1113

15

16171819

3522

23242526

14

41

293031323334

36

3738

39

40

43

4244

52

4547

49

48505153

54

2021

3

6

27

28

VCC

DQ0DQ1

VSSQ

DQ2DQ3

VCCQ

DQ4DQ5

VSSQ

DQ6DQ7

DQML

WECASRASCS

A11A10/AP

A0A1A2A3

VCC

VSS

A4A5A6A7A8A9

NC

CKECLK

DQMH

NC

VCCQ

DQ8DQ9

VSSQ

DQ10DQ11

VCCQ

DQ12DQ13DQ14DQ15

VSS

BA0/A13BA1/A12

VCCQ

VSSQ

VCC

VSS

C400.01UF

L9 FB

D1

1N4148(SMT)

C500.1UF

U10

CS4344

12345 6

78910SDIN

DEM_/SCLKLRCKMCLKVQ FILT

AOUTLGND

VAAOUTR

R7 33

R134220

CN3

CON6-2.0mm654321

CN1

2625

1716151413121110987654321

18192021222324

2728

R1624.7K

C390.01UF

R22 470K

Q92N3904

CN5

CON4-2.54mm

1234

L3

FB

R100 100

R217 0

D2

1N4148(SMT)

C6

330PF

R1614.7K

C311UF

R155 33/NC

R6033

+ EC3

100UF16V

R9 10

L22 500

R216 0

L1 FB(DIP)

U8

24C01/CAT24C021

1234 5

678A0

A1A2GND SDA

SCLWP

VCC

R6 2.2/0805

R168 0

R215150 1%

C36680PF

L26 FB 0805

U1 AZ1117D-ADJ-TO252

1

3 2

AD

J

IN OUT

C125

0.1U/NC

C7

0.1UF

+

EC24

10UF16V

C80

0.1UF

C221UF

C1060.1uF

L4

FB

U7

MX29LV800T/B,SST39VF088

TSOP-48

29253124332335223821402042194418308327346365394413432451

4817

2628

12

47

16

37

2746

11

15

9 101314

DQ0A0DQ1A1DQ2A2DQ3A3DQ4A4DQ5A5DQ6A6DQ7A7DQ8A8DQ9A9

DQ10A10DQ11A11DQ12A12DQ13A13DQ14A14

DQ15/A-1A15A16A17

CEOE

RST

BYTE

A18

VCC

GNDGND

WE

RY/BY

A20 NCNCNC

C121 104

C34680PF

C131

0.1UF

C48

0.1UF

C23 47PF

C116220PF

C570.1UF

R15215K

C9

0.1UF

TP17 VREF1

C20

0.1UF

R861.2K

C14 680PF

C2

0.1UF

C17

0.1UF

L2FB(DIP)

C35680PF

CN6

CON3-2.54mm

123

R26 2.2K

R124 10K

C25100PF

C30

0.1U

F

R42 470K

R74

820

R852.4K

R1 220

C55 4700

C61

0.1UF

+

EC18

47UF16V

Q122N3904

R122 3.3k

C4

0.1UF

C79

0.1UFC74

0.1UF

C42300PFR30 1

Q32N3904

C54 330

+ EC28

100U/16V

C33680PF

C70

0.1UF

C86NC

R1564.7K

R89150 1%

RN1 33(8 Pin, 4R)4321 8

765

R73

NC

R18 20K

C21 47PF

L23 500

C110330PF

R43 4.7K

R15115K

U9

SPHE8202S/D

23456789

10111213141516171819202122

24252627282930313233343536373839404142434445464748495051525354

55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100

101

102

103

104

105

106

107

108

162161160159158157156155154153152151150149148147146145144143142141140139138137136135134133132131130129128127126125124123122121120119118117116115114113112111110109

1

216

215

214

212

211

210

209

208

207

206

205

204

203

202

201

200

199

198

197

196

195

194

193

192

191

190

189

188

187

186

185

184

183

182

181

180

179

178

177

176

175

174

173

172

171

170

169

168

167

164

166

165

163

23

213

AGCOPRFIPRFISRFSUMDPDADPDBDPDCDPDDDVDDDVDCDVDBDVDACDBCDACDFCDERF_AVSSAPC_AVSSDVDLDOCDLDODVDMDI

APC_SRV_AVDDV21R33KV165SVOTSTRFRPPHRFRPBHRFRPMEANSBADPHSBADFEOTEOTEOLPOPVIPOPVINOPVOPSRV_AD_AVSS_VRGDAD_DA_AVDDDATEODAFEODA_AVSSTRAY_IS_INTRAY_IS_OUTSPDC_OUT/GPIOSC_OUT/GPIOSC1_OUT/GPIOTRAY_OUT/GPIODMEA/GPIOFGIN/GPIOHOMESW/GPIOLDSW/GPIO

DFC

T/G

PIO

VD

D_K

1G

PIO

/SD

_CK

/MS

_CK

GP

IO/S

D_C

MD

/MS

_BS

GP

IO/tt

io0_

4/S

D_D

0/M

S_D

0V

SS

_O1/

VS

S_K

1G

PIO

/ttio

1_5/

SD

_D1/

MS

_D1

GP

IO/tt

io2_

6/S

D_D

2/M

S_D

2G

PIO

/ttio

3_7/

SD

_D3/

MS

_D3

VD

D_O

1G

PIO

R_C

S4_

B/G

PIO

R_C

S3_

B/G

PIO

R_C

S2_

B/G

PIO

R_C

S1_

B/G

PIO

RS

T_B

IR_I

N/G

PIO

VFD

_CLK

/GP

IOV

FD_S

TB/G

PIO

VFD

_DA

TA/G

PIO

R_2

0/E

_MX

10R

_A19

CLK

INC

LKO

UT

US

B_G

ND

US

B_V

DD

US

B_D

PU

SB

_DM

VS

S_P

LLA

VD

D_P

LLA

VS

S_P

LLV

VD

D_P

LLV

M_D

7M

_D6

M_D

5M

_D4

M_D

3V

DD

_O2

M_D

2M

_D1

M_D

0M

_WE

_BM

_CA

S_B

M_R

AS

_BV

SS

_O2/

VS

S_K

2M

_CS

0_B

/GP

IOM

_BA

0M

_D15

M_D

14M

_D13

VD

D_K

2M

_D12

M_D

11M

_D10

R_A12R_A7R_A6R_A5R_A4R_A3R_A2R_A1R_A0R_D0R_D1R_D2

VSS_O5/VSS_K5R_D3R_D4R_D5R_D6R_D7

R_OE_BVDD_K4

M_DQM2/GPIOM_DQM3/GPIO

R_A10R_A11R_A9R_A8

VDD_O4R_A13R_A14R_A17

R_WE_BM_A3M_A2M_A1

VSS_O4/VSS_K4M_A0

M_A10M_BA1/GPIO

M_DQM0/GPIOM_DQM1/GPIO

M_A4VDD_K3

M_A5M_A6M_A7M_A8M_A9

M_CKE/GPIOVSS_O3/VVV_K3

M_CLKOVDD_O3

M_A11/GPIOM_D8M_D9

AGCON

FLTI

NFL

TIP

RFO

AG

CC

AP

GM

RE

SR

F_A

VD

DD

S_A

VD

DS

LVL

CN

IN RFI

PLL

_DS

_AV

SS

LGIN

LPFN

INFD

FLT

PD

FLT

VR

EFO

LPFN

LPFO

PLL

_AV

DD

VS

S_T

VA

2TV

_DA

C5

VD

D_T

VA

2TV

_DA

C4

TV_D

AC

3V

SS

_TV

A1

VD

D_T

VA

1V

SS

_TV

A0

VD

D_T

VA

0TV

_DA

C0

V_R

EFO

UT

V_F

SA

DJ

V_B

IAS

V_C

OM

PU

A0_

TX/G

PIO

UA

0_R

X/G

PIO

A_X

CK

/GP

IOA

_BC

K/G

PIO

VS

S_K

6/V

SS

_O6

A_L

RC

K/G

PIO

A_D

ATA

3/G

PIO

A_D

ATA

2/G

PIO

A_D

ATA

1/G

PIO

VD

D_O

5A

_DA

TA0/

GP

IOA

_IE

C_T

X/G

PIO

R_A

18R

_A16

AD

_VS

SA

D_V

DD

AD

_L

AD

_RE

FA

D_R

R_A

15

CDMDI

RFR

P

C130100

R16 5.1K

R112 4.7K

L7FB

EC3047uF/16V

R157 100

+ EC11

47UF16V

D6 1N4148

C49

0.1UF

R44 4.7K

DVD Diagram