Weekly Checks

• Monday – VSP Room

•Tuesday – Pilothouse System Controls

• Wednesday – Starboard / Engine Room

•Thursday – Foam Room

• Friday – Port / Engine Room

Monday – VSP Roomweekly checks

Visually Check:• Hvac system for leaks & valve settings• Fresh water system for leaks & valve

settings• VSP linkage • Autopilot connections• Ventilation fan switch and breaker• Fuel Valves at the fwd tank for leaks &

settings• Fuel valves at the transfer pipe for leaks &

settings

Monday – VSP RoomWeekly Checks

•Cycle all valves in the VSP room•Check oil level in the VSP units•Check oil level in the VSP header tanks•Check bilge for water and pump or suction as needed•Check fresh water system for leaks•Check hot water heater for heat•Fill day tanks and check and record fuel level in the fwd fuel storage tank• Pump out grey water tank as needed•Check hydraulic oil storage tank level – fill as needed•Check and replace lights•Check ventilation fan plenum for water – drain as needed•Check general alarm bell & light•Check phone & intercom # 107•Clean / wipe / wash / service all areas as needed

Monday - VSP Room

Pump out grey water tank

Cycle the overboard valve located on the starboard side

Pump switch

50 gal. tank

Overboard valve

Monday – VSP Room

• Fill day tanks• Stick and measure

main storage tank• Measure sight

gauge for the fwd storage tank

• Record fuel onboard

Between each colored mark is 1000 gallons

Monday – VSP Roomweekly checks

• Cycle VSP cooling overboard valves P&S

• Cycle HVAC overboard valve starboard side

• Cycle grey water overboard valve starboard side

Port Side

VSP cooling

Monday – VSP Roomweekly checks

HVAC overboard

Grey water overboard

VSP cooling

Starboard Side

Monday – VSP Roomweekly checks

Check VSP unit oil level P & S

Dipstick location

Replace gently to avoid cross threading

Operating range

Look for signs of water (foam/milk)

Monday – VSP Roomweekly checks

Tank Fill

Sight gauge

Refill at this Level

Discharge – Oil out

Monday – VSP Roomweekly checks

• Remove / Lift floor plate and check for water

• NEVER PUMP OILY NEVER PUMP OILY WATER OVERBOARDWATER OVERBOARD

• Start pump and listen Start pump and listen for prime – NEVER run for prime – NEVER run dry – use prime valves dry – use prime valves if necessaryif necessary

• Close all valves when Close all valves when finishedfinished

Check under this floor plate

On / Off

VSP Room Valve

Prime valves

Bilge suction under floor plate

Tuesday – pilothouseweekly checks

• Cycle all valves forward & aft

• Operate all Monitors forward & aft

• Check all indicator lights

• Cycle below deck cameras

• If needed, reset camera angles below deck

• Operate remote monitor controls from main deck

Tuesday – pilothouseweekly checks

Monitor controlsValve & pump controls

Engine and throttle controls

Tuesday – pilothouseweekly checks

Camera control boxesCamera Monitor

Tuesday – pilothouseweekly checks

Remote aft deck / boat deck monitor controls

• Boat Deck• Aft Deck

Wednesday – starboard side engine roomweekly checks

•Cycle all valves on the starboard side of the engine room•Check all systems, connections, valves, & bilges for leaks•Wipe / wash / vacuum / polish / service all areas as needed•Check and replace lights as needed•Check phone / intercom & # 106•Check general alarm (bell & Light)•Check oil level in the fire pump hydraulic clutches – Main Engine & Pump Engine

Wednesday – starboard side engine room

weekly checks

• Fresh water flush valve

• Raw water seachest valve

• Raw water isolation valves

Wednesday – starboard side engine room

weekly checks

Raw water inlet valve – Pump Engine

Fire pump sea chest inlet valve

Sea chest valve “wheel”

Wednesday – starboard engine roomweekly checks

Main engine raw water overboard

Generator raw water overboard

Wednesday – starboard engine roomweekly checks

Pump Engine Raw Water Overboard

Wednesday – starboard engine roomweekly checks

Firemain by-pass valve (pump 3)

Firemain by-pass valve (pump1)

Hydraulic Clutch (pump #3)

Wednesday – starboard engine roomweekly checks

Hydraulic clutch (pump #3) Hydraulic clutch (pump #1)Remove guard for service

Oil level dipstick – check while NOTNOT engaged

Wednesday – starboard engine roomweekly checks

Sea chest Valve Pump #5

Fuel Fill Valve

Wednesday – starboard engine roomweekly checks

Sea chest vent / blow down valve

Foam delivery valve

Wednesday – starboard side

weekly checks

Fire main by-pass valves

Pump #5Pump #6

Thursday – foam roomweekly checks

• Cycle overboard valves•Visually check all hydraulic HPU connections for leaks•Check bilge for water – Pump as needed•Check lights and replace as needed•Wipe, clean, paint, vacuum, service area as needed

Thursday – foam roomweekly checks

Firemain “Overboard” valve

Foam storage & foam pump inlet valves

Thursday – foam roomweekly checks

Hydraulic Power Units “HPU’s”

Under wharf Monitors

Aft Capstan

Thursday – foam roomweekly checks

Hydraulic Power Unit for the Deck Crane

Friday – port side engine roomweekly checks

• Cycle all valves on the port side of the engine room• Check all systems, connections, valves, & bilges for leaks• Wipe, wash, vacuum, polish, service all areas as needed• Check and replace lights as needed• Check oil level in the fire pump hydraulic clutches – main

engine & pump engine

Friday – port side engine roomweekly checks

Bilge pump overboard valve

Main engine raw water overboard valve

Friday – port side engine roomweekly checks

Raw water sea chest valve

Cooling system fresh water flush valve

Friday – port side engine roomweekly checks

Hydraulic clutch – pump #2

Remove guard for service

Hydraulic clutch – pump #4

Hydraulic oil level dipstick

Friday – port side engine roomweekly checks

Generator raw water overboard

Pump engine raw water overboard

Friday – port side engine roomweekly checks

Air Dryers Compressor oil level dipstick

Friday – port side engine roomweekly checks

Sea chest valve pump #6

Sea chest valve for pump #2Raw water inlet valve

Friday – port side engine roomweekly checks

Firemain by-pass valves

Pump #2Pump #4

Friday – port side engine roomweekly checks

Bilge Pump System Manifold

Fire pump & firemain drains