working casts and dies

62
Working casts and dies Working casts and dies Presented by Presented by Dr. Mohamed Abdel Dr. Mohamed Abdel Aziz Aziz Lecturer of fixed Lecturer of fixed prosthodontics prosthodontics

Upload: agsdds54

Post on 22-Nov-2014

805 views

Category:

Documents


1 download

TRANSCRIPT

Page 1: Working Casts and Dies

Working casts and diesWorking casts and dies

Presented byPresented byDr. Mohamed AbdelDr. Mohamed Abdel

AzizAzizLecturer of fixedLecturer of fixedprosthodonticsprosthodontics

Page 2: Working Casts and Dies

���� ����� � �� � ��� ����� �� ��� �� ��� ���� ��������� ���� �� �� � ��� ����� � ��� �� ��� ��� � ����

���� �� � ��� ������ ���������� �� ��� ���� ���������

���� ���� �� �� � �� � �� � ����� ������������� � ���� �� �� ��� �������

Page 3: Working Casts and Dies

����� �� ����� ���������� ��� ���� � ���

• �� ���� ���� �� ������ ����� ����� ��� ��� ������ ��� �� ��� ���� ��� ������

• �� ��� ������ �� ��� � �� ���� �� ������� �����

• �� ��� � ��� ���� �� ������ �� ���� ����� ���� ��� � � ���� � ����

Page 4: Working Casts and Dies

�� ���� ������� �� ��� � �� ����� � �� � �� �������• !� ����� � �� ��� "�� � �� ��– "��� � �� ��� ��� � � ��� ��� � �������– "��� �� ��� � ���� � � ���"��� �� ��� � ���� � � ���

• !!� ����� � �� ��� ����� ��� ���– #�� �� �� �� � �� $���� �� �� ���%– &� �� ���� ��� ��� � � ��� ���� ������� �� ���

Page 5: Working Casts and Dies

'� ( ��� ��

• �� !������� ����

• �� �� �� � ��

• �� ������ �� )�� � ����

• *� #��� ����� �� $+�� �� ��%

• ,� )�������� ��� '� $"���� �� +����� �� ��%

• -� .�� ��� '�

Page 6: Working Casts and Dies

�/ ���� ��• �'� �� ����� ������ �������� �� , �����

• "��� �� ��� � ���������� � ��� �� ��� ���� !0 � ���� 0������ ���������

• ��� ����� � ��������� �� ����� ����� �� ������� ���� ����� ����� � ���� � �� ���� ��� ��� ������ � ��� � ����� �� ��� ��������� ���� � �

• !������� ��������� �� �� ���� � � ��� �� ������� ��������� �� �� ��� �� ��� � ���� ����� �� ��� ��� $���/���������� ������% 1 � �� ��� ���� ������ � � ������������ ��� ������� ������� �� ������ � ��2

• ��� ���� ���� ��� �� � ��� � ������ � �� ���� ����� ������ � � � ��� � � ��� ��������� � ���� �� � �����

Page 7: Working Casts and Dies

3/ �� �� � ��

• 4��� ��� ��� ������ � � ������� ��� ������ ������������ /�� ��� ��� ������ � �� ��� �� ��� �� ��� �������� �� ���� ��� � �� � ��� �� ����� � ������ �� � �� � ����� ��

• ��� � ��� �� � �� � �� � �� � � � ���� � ��

• '� �� � �� � � ����� ����� ���� ��� ��� ����� � � ��� �� ��� �� ���� ��� ������� ������� � ��� �

Page 8: Working Casts and Dies

+/ ������ �� )�� � ��� ��

• 4��� ��� ������� �������� ���� � ��� ��������� ���������� ������� � ��� ��

• ��� ��� �� � � ��� �� �� ����� �� � ��� ����������������� �� ���� ���

• #�� ��� �� ���������� ��� ��� � ��� �� �� �� ��� ��• #�� ��� �� ���������� ��� ��� � ��� �� �� �� ��� �������� ���

• ��� � �� �� �� �� ����� ��� � �������5 �� ���� �� ���� ��� �� � ���� ���� ������ ��� ��� �� ��� ������� �����5�� ��

• 6���� ������ ��� � ��������� � ���� ����� ��� ������� ����5�� �������5 �� ���� ���

Page 9: Working Casts and Dies

'/ #��� ����� ��

• "��� � ���� �� ��� �� � ��� � ������� � ������ � ���� �

• ���� �� � �� �������� � ������ ��� �������

• ����� ����� � � ������� ���� ��� ������� � ���� ���� ������� ��� ��

• ��� �� ���� ��� ��������� �� ������ ������ ��� ������ ������ �� �� ��� ��� � ���

Page 10: Working Casts and Dies

)/ )�������� ��� ��• !� ������ � ����������� ���� �� � ������� ����� �

� ���� ��� ��� ������� �������

• ��� ������� � ��� � ���� �� ��� ��� �� ������ ��������� ��������� �� �� ��� ��� ���

• � �� � �� ����� � �������� � ����������� ������ �������� ���� � � � �������� � �� ���� ���� ��� ���� ������� ���� � �� ����������� �� ������ �� � �� �� ���� ��� ������� �� ��� ������� ���������� � ���

• 7��������� ��� �� � ��� �� ���� � ��� ���� ����� ��� ����� � ���� �� �� ��� ��������

• � �� � �� ���� ������ � �� �������� � ���� ������ � ������������ ��������

Page 11: Working Casts and Dies

• ��� ������� � � ���� � ����

• ��� �� � �� �� �� ��� �� ������ ��� �� ���� �� �������� ����� ��� �� ���� ������ ���������

• !������� � �� ��� ��� ��������� �� � �� ������� �� ���+ ������ � � �� ���� ������ �� ����� � ������� �� ��� ���

• � � ������ ��� ����� �� �� � $����� � ��� ���� �� ������ ���� � ��� �� � ������� � ���%��� ���� � ��� �� � ������� � ���%

• � � ������ ��� ������ �� �� � $����� ��� ��� ���� ��� �������� � ���%

• 7� �� ��� � ��� ������ 8/�� ���

• 9 �� � ��� ��� �������� ��� ��� �� ��� ������� ��� �� ������ ��� �� ������� ��� �� ��� � ���

Page 12: Working Casts and Dies

• ��� � ���• '���� ��� �� ���

• "����

• + �� � ��� ��� � � �� ��

• '� �� � ���'� �� � ���• : ���� �� ������� ��� � �� � � �� ��������� ������

• ��� �� �� �� $8/�� ���% ���� ����� � �� ��� ����������� � ����� ��� � ����������

• 7���� ������ �� ��� �� ��� ��� � � ������ �� ����� �� ���

• ��� ������� ������� ������ � ��� �� �� � �� ��������� ����� � ���� ��

Page 13: Working Casts and Dies

./ .�� ��� ��

• ���� �� ��� � �� �� ��/���� ���� �� ��������� �������� ��� ��

• ���� �� �� ��� ��� ����� �������� ��� � �� �� � �� �� ����

• ��� �� � �� �� ����� ��� ���� ���� ��� �����; ���� � ��• ��� �� � �� �� ����� ��� ���� ���� ��� �����; ���� � �������� � �� �� ����� � �� ������ ��

• + �� ������ �� � ������� �� ������ ���� ���� �������� ��� � ��� ��� �� � ��� � �� ������ ���� ���������� ������ �� ��� ��

Page 14: Working Casts and Dies

#��������� �� '� ( ��� �

• �� <�� ���� � � ������� ��������� �� ����� �� ��� ������ ��� �� ������ �� ����������

• �� <�� ���� �� � ����� �� ����� ��� ���� � �� ������ ��� � � ���� � ��� � ��� ����

• � +��� ���� ��� ��� ������� � ��� �• �� +��� ���� ��� ��� ������� � ��� ��• *� =��� ����� ���� �� ��� ��� ����� � ��� �� �� �� � ���

���� � �� � ��� � �� � ��� ���������• ,� +��� ���� ��� ��� ��� � �� ����� �����• -� ) ��� ���� ��� ��� ��� � ����• >� <�� �� ���� � � ������ ����� � ���� ���

Page 15: Working Casts and Dies

�� ����� �� � ���� � �������� ���

• ��� ����� � �� ��� ��� � �� �� � ��� ��������� � �� � ��� �� ����� � �� � ��

• ��� ��������� ������ � �� ����� � � �� � • ��� ��������� ������ � �� ����� � � �� � ����/ ��� � ���

Page 16: Working Casts and Dies

��� � ������ � ���

•• �� ) �� �� � ��� ����� ) �� �� � ��� ���

•• �� ����� ��� ��� ����� ������ ������� � ���� ����� ��� ��� ����� ������ ������� � ��� ��� �� � ���� ���� � ���� ����

•• �� ��� ��� � ����� � ����� � �� ��� �� � ���� ��� ��� � ����� � ����� � �� ��� �� � ��

Page 17: Working Casts and Dies

'� �� � ���• ����� � � ���� ���� �� �� ������� ���� �� � �� ��

����� $���� ��� ��� � �� �� �� ��� ����� � ��%� ��������� �� ��� � � ���� � � �������

• �� ��� ����� � �� � ��� ����� � � �� ��� ��� �� � �� ��� �� ���� ��� � �� �������� �� �� ����� �� ������� ����/ ��� ������� ����� !� ������ ���� ����5��� ��� ���� � �� � ���� ��� � ��� �� �� ��� ������ �������� ������ ����� � �� ���� ��� ����� ������� ��������� ��� ����������� � ��� ��������� ��� ���� �� �� ���� ��� ���� �� ����������

Page 18: Working Casts and Dies
Page 19: Working Casts and Dies

!������� 7����;• � < �� ������� ���� $���� !0 �� 0% ������ �� ���� ��� � ��� �� ��� ��

� ��� � �� �� ������ ���� �� �� �� ��� � � ���� � � ��� ����

• � 9 �� ��� ������� ���� ���� ��� � � � ��� �� ������ ������ �� �� ���� � � ����� ��� �������� ������� � ��� � ���� ��� ������ �� ��� ������� � ��� � �����

• � .����� ��� � �� ������?� �������� ��� ��� ������� � ���@������ � ������� � � ����� � � �� ��� ��������� �� ��� ��� ����� ����� ��������� �������� ����� � � �� � ���� �� ��������

• � ( � ��� � ���� �� � � ��� �� ��� ��� ��� ������ � ������������� ��� ��� � �����

• � #����� ������� ������ �� ���������� ���� ��� ���� �� ������ �� ���� ������� � ��� ��� � ������ ���� ���� � ��� ���� �� ��� �� ����� � � � ������� ����� � ���� ������� � � ������ ��� ���� ��� ���� �� ��

Page 20: Working Casts and Dies

• � 4�� �� �� ������� �� � ��� ���� �� ��� ������� �� ������� ��� ������ �� �� �� �� ���� �� ���� � ��� ��� �� ���������� ���� ��� ���� � �� � ��� �� ��� ���� �� ���� ��������� � ���� �� �� ��� ���� � ���

• � ��� ��� ������� �� �� � ��� ���� ����� ������ ����� ��� �������� ��� ���� � ��� �� ���� �� �� �������� !� � ��� ���� ������ � �������� � ��� �� �� ����� � ���� ��� ������ ��� � ���

• � 3��� ��� ���� �� �� ����� ���� � ���� �� �� ���� ������� � �� �� ���� ���� ��� ���� �� � ��� �� ��� ������ � �� �� ���� ���� ��� ���� �� � ��� �� ��� ���

• � �� ���� ���� ��� �������� �� �� ��� �� � � ��� ��� ��� $�� ������ � � ��� ������� � ��� ��%�

• � ��� �� �� ������� �� ���� �� ��� ��� � ���� �� �� �� ��� ����� �������� ������ � �� ��� ��� � �� �� ��� �������� �� �� ����� ��� ���� ��� ��� ����� ���� ����� �� ����� � ���� � ���� ���� ���� ��� �������

Page 21: Working Casts and Dies

• � ��� ���� � ��� �� ��� �� ��� ����� ��� ��� �� ������

• � !� ���� � � �� ���� �� ���� � � ��� ��� � � ��� � ���������� ���� ��� ������ ������� �� ��� ��� ��� � �� ��� � ������ ��� ������� � �� �� ��� � �� �� ������ ��� �* ����� ��� ��� �����������

Page 22: Working Casts and Dies
Page 23: Working Casts and Dies

Die Preparation

�The cast from which the die is made, is trimmed on a modeltrimmer to remove all excess stone around the prepared tooth.

� The cast is held by the base while cutting it down to form thehandle of the die, the handle of the die should be slightly largei th di t th th ti It id h ld bin the diameter than the preparation. Its sides should beparallel or slightly tapered toward the base, and should beparallel to the long axis of the tooth, because if not parallel itwill be more difficult to adapt the wax pattern margins. Thehandle is approximately one inch long

�Trim the die gingival to the finish line of the preparation, thisarea should be smooth and free from irregularities.

Page 24: Working Casts and Dies

�The contour of the die gingival to the finish line shouldapproximate that of the root to facilitate good axial contours inthe finished restoration.

�. After the die has been trimmed, the finish line should behighlighted with a sharp color bright red pencil, this facilitatecarving the margins of the wax pattern.

�The die is then painted with a die strengthening material toclose the stone micro porosities , and harden it and decreasescratching

�. The preparation area of the die should be painted with a dierelief material to provide space for cement, a relief of 25 micronsis desired, the tooth preparation on the die is painted within 0.5mm of the finish line.

Page 25: Working Casts and Dies

��� ����� �� � ���� ��������� ���

) �����

• ��9���� � �� ��� ����� ��

�• �� 7�� ������

• �� ����� � �� ��� '/:�� �� �

Page 26: Working Casts and Dies

#��������� �� #���� ��� '��

• �� ��� ��� ���� ����� �� ���� � �� ��� ��������

• �� ��� ��� ���� ��� �� ���� ��� ��� �������

� �� � � �• �� ��� � �� ��� � ��� ��� ���� �� � �� ������ � ����� ����

Page 27: Working Casts and Dies

������� �� � ���� ����� ��

Page 28: Working Casts and Dies

• � ����� � � ������� ���� � �� ���� ��� ����� ����������� � ��� ����� �� �� ������� ���� ��������� � � ���� � ��� � ���� �� �� ��� ��� �������� � ���� ��� � ��� ������� ���� ��� � ���

• � ����� �� ���� � �� ���� ��� ������ ��� �������A ������� ������� � ��� ���� � ����� ��� ������ � �� ��� ������ ��� ��� �� ��� ����� ��� �������� � � ������� �����/��� ��� ����� ���������� �� �� � ��� ����� � ��� �� ������ ����������� ��� ���� � ���

Page 29: Working Casts and Dies

• 7��� ��� ��� � ������ ��� ��� �� ����� � � ����� ������� � ��� � � ���� ��� ���� � � ��� � ��� �� ����� �� � �� ����� � �� ��� ���� �� "� ��5� �������� ��� ����� � � ��� ����� � ����� � �� ������ ��� � ��� ����� � �

• '� ���� � ��� ������ �� ��� �������� ���� ���������� �� ��� ����� � ������ ��� ������ ��1��������2 �� ��� ����� ��

Page 30: Working Casts and Dies

• 7 ��� ���� �� ��� �� ��� ���� ������ � ����� �� ������������ ��� ��� � �� ���� ��� �� �� ��� � ���� ����� ���������� �� �� ��� �� � ��� �� ��� ����� �� � �� �� �� ������� ��� ���� ��� ��������� � ���

• #����� ��� ��� ��� � � ����� � ���� ��� ������� ���� �������� ����� �� ��� ���� ���� �������� ����� �� ��� �����

• 7� �� � �� �� ���� � � ��� �� �� � �� ������ 0/�� ��������/��� � ���� �� ������ � ��� � � �� �� �� � ���� �� ��� �� ���������� ���� ���� ���� ����

Page 31: Working Casts and Dies

• ��� ���� ���� � �� ����� � ����� ��� ��� �� �� ��� ������ ��� �� ����� � ��� ��� � �� �� ��� �� ������� ����� � ��� ��� ���� ���� �� ��� �������� � �������� �������� ����� �� ��� ����� ������ ��� � �� ������� ������� � ��� ��� ��� � ���� � ����� �������

• 4�� �� �� ��� �� ������ ��� ������� �� ����� � �

• 9�� ��� ���� � � �� � ���� ��� � � �� �� �� ���������� ��� � ��� �� �� ����� ��� ��� � ��� ��� � � ����� ��� ���� ������ � ��� ��� �� � �� ����� ������� ���������� � �� ��� ��

Page 32: Working Casts and Dies

• :���� ��� �� ����� ��� ������� � ����

• 7� �� � ���� ��� ��� �� ��� ������ �� ������� �������� ��� �� ���� ��� � ���

• "� � ��� � �� ��� � ��� � ���� � � ��� ����� ������� ����� �� ����� ����� � ���� �� ��� �� ���������� ��� ��� � ������ ��� ��� �� ��� �������

Page 33: Working Casts and Dies

• ��� � � � � ���� ���� ��� � �� ��� ��� ��� � ����� ��� �� ��� ��� ��� �����

• #��� � ��� ��������� ��� � �� �� � ��� � ���

• #��� � ��� ��� �� � �� ���� �� � ���� ��� �� ����������� � ��� �� �� ����

Page 34: Working Casts and Dies
Page 35: Working Casts and Dies
Page 36: Working Casts and Dies
Page 37: Working Casts and Dies

������� � ���

• ��� 7�� ������ $+�����@9� ������ ( �� ��6B% � ������� ���� ����� � ���� �� ��� �� � ����� �� ��� ��� �� � � �� ������� � ���� ������� ����� ��� ��� � ���������� ����� ��� ��� � ������

• ��� ������� � ������ ������ ������ � �� ��� ����� ��� ��� � ��� ���� ���� ������ � ���� ����� ���� ��� ������� �� ������ � ���

Page 38: Working Casts and Dies
Page 39: Working Casts and Dies
Page 40: Working Casts and Dies
Page 41: Working Casts and Dies

!�� ��� + ��

• �� =��� �� ��� � � ���� �� �����– :�� � ��� �� � � �– "���� � ��� �� ��� �– =��� ����� �� ���� $������ �����%

� 7� � $ � ��� � %• �� 7� �� ������� � �� $�� ���� �� ��%• �� 3� � �� � � ��• *� ����� ��� � �� ������• ,� 7��� ����� � �� ��� ������ ����

Page 42: Working Casts and Dies
Page 43: Working Casts and Dies
Page 44: Working Casts and Dies
Page 45: Working Casts and Dies

"���� C ��� '��

• �� ( �� �� �� � � ���� ��� ����• �� +�� �� ����� ��� ������� ��� � �

– 7 � ���� � � ����– ) �� ������ ���� ��� ����� ���

• �� 4�� ���������� ������ ����� ���� ����� ��� ����� D> � � � ���� ��� ��� ��� � �����

• *� .�� ����� ��� �� ���� �� �����/����� �������������

Page 46: Working Casts and Dies
Page 47: Working Casts and Dies

'� �����

• �� #����� ���� �� � ���� ���� ��� D> � � � ������� ��� ��������� ����� �

• �� .� ����� ��� �� ���� �� �����/����� � ����• � ( �� ������ �� �� �� � ����� ��� ������� ( �� ������ �� �� �� � ����� ��� ��������� � ������ �� �� �������

• *� 4��� ����� ����� ��� �� ������ ��� � �� �� ������ ������ ������� �

Page 48: Working Casts and Dies
Page 49: Working Casts and Dies
Page 50: Working Casts and Dies

'� 7��� � ��

• �� ����� �� � �����– +���� �� ����� ��� ���– ����� �� ��� ��� , �����

• �� ����� �� �� ����� ����� �� �� ���– �, ���� ������� ����� �� �� ��� �����– "� ��� � �� ���� ��� ��

Page 51: Working Casts and Dies
Page 52: Working Casts and Dies

3-Di-Lok Tray

�A snap-apart plastic tray with internalorienting grooves and notches also can beorienting grooves and notches also can beused to reassemble the working cast and die

Page 53: Working Casts and Dies

•Pour the full arch impression with die stone, restrictedto u-shaped i.e., with no stone in the center, building upto one inch.

•After setting, separate it from the impression. The u-shaped cast, with an open lingual area must be trimmedth t it ill fit i t Di L k tso that it will fit into Di-Lok tray.

•Trim the buccal side of the cast-on a model trimmer,tapering toward the base, trim the lingual, then tray thecast into Di-Lok tray to make sure that it will fit.

Page 54: Working Casts and Dies

• One or two horizontal grooves are placed in the inner andthe outer aspects of the cast to provides undercuts forholding the cast in stone in the tray, soak the base of thecast in water for about 5 minutes. Mix yellow stone andvibrate it into the tray until the tray is approximately three-quarter full. Seat the cast into the tray. The cervical line ofthe tooth should be about 4 mm above the edge of the tray

dwhen the cast has been seated. Remove excess stone.

• Remove the cast from the tray after complete hardeningDisassemble the tray, after the cast has been slightlydisplaced, side it forward and remove it from the tray base.

Page 55: Working Casts and Dies

• With the saw from the blade cut between the preparedtooth and the adjacent tooth, starting from theinterdental papilla extend downward on a very slighttaper and approximately three-quarter of the waythrough the stone base. Using finger pressure break thedie and attached teeth from the cast. Repeat the processfor every prepared tooth on the cast. Remove the excessstone cervical to the finish line. And remove any stoneparticles from the tray by brushing and dry it withcompressed air. Reassemble the dies and other parts ofthe cast in the tray. Attach the tray to the articulatorusing mounting plaster.

Page 56: Working Casts and Dies
Page 57: Working Casts and Dies
Page 58: Working Casts and Dies
Page 59: Working Casts and Dies
Page 60: Working Casts and Dies
Page 61: Working Casts and Dies
Page 62: Working Casts and Dies

THANK YOU