lI. POWER SUPPLY

www.knau

sowne

rs.co

m

POWER SUPPLY

I I. POWER SUPPTY

ATTENTION:The electricol system must be checked by o quolified service centre otleost once o yeorl

I I.t 230 Volt power supply (moins voltoge)

You con connect your mobile home to on externol power supply of 230 Volt (moins voltoge). The 230-Volt powersupply must be protected with o residuol current circuit breoker (RCCB) rqted ot 30 mA.

ll.2 Moking elecfricol connection between mobile home ond power point

ATTENTION:When using on extension reel without o thermol sofety cut-out the electric coblemust be fully unwound from the drum.

The mobile home must be connected to the 230 Volt moinswith rubber insuloted flexible coble ,,HO7 RN-F 3G 2.5 mm2"or equivolent fitted with connectors complying wiih ,,DIN EN60309-2" (Europe). The electric coble should not be morethon 25 m long in totol!

Power point Plug

I l.l Moking mains conneclion

:.a::;.:::): t?

!,ffi|VanYl

A

Mobile home

GB"A3 2A(.)r' o i,N 2aA8

www.knau

sowne

rs.co

m

r------- ---'l

I itI lJ-rlilltv I

POWER SUPPLY

Moke the electricol connection between the mobile home ond power poinf os follows:

I. When running the coble to the power point, stort from the mobile home ond connect to the power point lost.

2. When disconnecting the electricol coble, remove the plug from the power point end first ond then reel the coblein.

When the mobile home is connected to the 23O-Volt power supply, both the bockup bottery (bottery ll) ond the storterbottery (bottery l) ore outomoticolly re-chorged vio the chorger.

All l2-Volt opplionces ore supplied from the bockup bottery.

r r.3 Boord control

Theboordcontrol conbeusedtoswitchiheelectricql l2-Voltopplionceswoterpump (item7, figure 11.2) ondtheowning light (item B, figure 1 1.2] on ond off either seporotely using their respective switches or together using themoin switch (item 6, figurel 1.2).

These electricol opplionces ore eoch proiected with fuses. The fuses ore locoied in the distribution box in thewordrobe.

The fuse for the refrigerotor in I 2 Volt operotion is locoted in the distributor box.

The power circuit for the woter pump hos o I0 A fuse in the distributor box.

The power circuits for the opplionces on the left ond right-hond side ore eoch equipped with o l5 A fuse locoted inthe distributor box.

Additionolly, the boord control con be used io check both the chorge stote of the storter bottery (bottery l) (item 1,figure I I.2) ond o[ the bockup bottery (botiery ll) (item I, figurel 1.2) os well os the level in the fresh woter tonk(iteml I, figurell.2) ond of the wostewoter tonk (item 11, figure 11.2) using the relevont buttons when the moinswitch is switched on.

The voltoge level of the storter bottery (bottery l) (item 10, figure I 1 .2) ond of the bockup bottery (bottery ll) (item 4,figure 1 L2) con olso be checked using buttons. The volioge stotus is then shown in the disploy field by meons of o5-position, multicoloured LED orroy (item I, figure 1 1.2):

LED red ,, @*:.,. Bottery must be chorged

LED yellow u Jt*r" Botlery is olmo$ flut

LED griln , , ', Bottery is chorged ru#iciently

The LED (item 3, figure 1 1 .2) obove the chorger symbol lights up when the bockup bottery is chorged connected tothe moins.

.::::r1L::i;:l;fr ,;:;a

,.i,i;,ti i.i,j,::.ta:a.:,;li:rt"ri!./ialil;i

GBC3 2AC)7 . A1r'.1C05 VanTl

www.knau

sowne

rs.co

m

t5. AIR CONDITIONING

www.knau

sowne

rs.co

m

AIR CONDITIONING

l.'llr t!?

ll tllwia:lttllf I

I5.

t5.t

l5.l .l

You will find

WARNING:r= Do not put fingers or other objects in the slots on the ventilotion opening!r= Do not ollow ony woter inside the oir conditioning unit!r= Remove oll eosily inflommoble moteriols from the iicinity of the oir conditioning!

ATTENTION:r=To prevent domoge to the compressor, woit of leost 3 minutes ofter switching

oir conditioning off before switching it bock on ogoin!r= No obiects ore ollowed in the oir intoke ond the vent openingsl

the

AIR CONDITIONING

Operoting the oir conditioning blizzord

Conkols

the following controls on the oir conditioning control ponel.

Moin swikhSwitch offSwitch on

Position ., 0 l-1'

Position ,, l ' r- "

Air conciilioning switched o#

A co"d"ioning :witched on

function switchWorm qirCooling

Pos:r o- # fl Wo.rr oir

Posilion ,, #' r--r ",Cooling

Thermostol,Air temperoture-oppr. I8 - 40qC

Air lemr:eroture increosed when rolofed ilockwlse 1mox.

^ te-pe'o1:, e 'educeo *I en ro-o'ed crri cloclwise (down torpp'o^ 1 B 'CJ

Blower rwitchAirspeed

fos 1ror,

f osrllon

xLa7\

f ], rt___r : I5l soeeo 5e11lno

-_,-I I lno soeecj selflnr}

l5.l Conhols air conditioning Blizzord

VanYl Gts43 2007 . A,il'2008

A

www.knau

sowne

rs.co

m

IP-")*'.

AIR CONDITIONING

I5.1.2 Adiusting the direction of oir flow

Adiust the deflectors so thot the oir flows in the desired direction:

f,, lttt,litii,?i.t,,,,,1

.,fiffi'niii':a./

:r=:,;::2 -t)/ (r,lall: tl:1t t: ri ,I

,t;11 t4 il v. fr w !!,/Lbr rG?

* .-*

I 5.2 Air-flow direction adiustment

.::.::::= a:::a::::aa, ttt t1'

$;t:iii,;;i;;.1^,rl:il,itii

NOTE:You willfind further informotion in the seporote monuol supplied by the monufocturer.

GBC3 2AC/ . Ni'/ 2aOE VanTl

@

www.knau

sowne

rs.co

m

16. TOILET

www.knau

sowne

rs.co

m

',T;iv,rua;. i. I tr'/4 &t I

;i il'i;,1 it::k H)l

TOILET

l.: iJ ir

',!1w,,,$1r:

r6.

r6.r

TOILET

Thetford unit

ATTENTION:The Thetford unit should only be droined on sites with suitoble sewogesystems or speciolly designoted disposol focilities!

Before using the toilet, push down the flush button briefly to ollow o smoll omount of woter into the bowl. Repeotos necessory. The flow of woter stops when the button is releosed.

After use, push down the flush button ond turn onticlockwise ot the some time. This turning motion opens the volvein the WC. The toilet bowl is flushed thoroughly but is economicol with woter.

After flushing, turn the flush button clockwise to close the volve ogoin. The toilet con olso be used with the volveopen.

AITENTION:t=The Thetford unit should be droined completely if there is o risk of frost ond the

mobile home is not heoted.r= ln winter the toilet flush should not be used until the toilet cubicle hos thoroughly

wormed up otherwise the woter pump in the Thetford flush moy be domoged.r=An environmentolly friendly ond fully bio-degrodoble chemicol WC odditire

should be used for the WC.n= lf environmentol concerns exist, the WC con olso be used without chemicol odditi-

ves but the Thetford unit will require more frequent droining os o result.

NOTE:You will find further informotion in the seporote monuol supplied by the monufocturer.

I.

2.

3.

VanTl CBO3 2407 o l',,':'t'2aAB

r\

A

A

@ www.knau

sowne

rs.co

m

17. WINIER CAMPING

www.knau

sowne

rs.co

m

|//INTER CAIIIPING

17.

17.1

WINTER CAMPING

Generol notes on winter comping

lf you plon to enjoy lhe freedom of comping life in winter os much os in summer, then here are sorne hinfs which youshould follow:

r-- After driving on roods thot hove been sproyed with solt, wosh the underneoth of the bosic vehicle with woter.

r-: Find out os much os you con obout ihe weother ond driving cond;tions before you set out ond during your iourney.

i; Your mobile home hos oll-round insulotion ond double glozing ond is perfectly ,winter-worthy' if used correctly.The woter supply is inside the vehicle on oll models.

i-,'' Proper ventilotion is just os importont in winter os in summer. Ski boots ond other wet items will increose the levelof humidity ond condensotion inside the mobile home.

r = Heoting is of course porticulorly importont in winter. For this reoson heoting is porticulorly importont for wintercomping - the heoters instolled os stondord ore normolly odequote. Quick removol of the woter vopour producedby cooking, wet clothing ond breothing is porticulorly importont for comping in winter. ln oddition to goodventilotion, the heoted oir will ropidly eliminote the woter vopour os worm oir con obsorb much more moisturethon cold oir. With moisture in the oir, the lower the room temperoture, the quicker condensotion will form i[ thereis o slight difference between the temperoture of the room oir ond the temperoture on the inside woll.

i:.- The windows, window fromes ond the corners of storoge lockers ore porticulorly prone to condensotion dependingon use. the number of persons, the site ond the level of humidity both inside ond outside the mobile home.Adequote heoiing of the mobile home with the hot oir blower switched on will improve this situotion.

17.2 Additionol notes on winter comping

Secure the mobile home ogoinst rolling owoy ond then releose the porking broke to prevent it from freezing.

Ploce oll cushions upright in the mobile home to ensure thot they ore oired ond dried.

:-- Use only i00% propone in winter os butone will not gosify below freezing point. Moke sure you hove onodequote supply of gos bottles.

: - Avoid the use of electricol opplionces thot consume o lot of current. Compsites do not hove unlimited omounts ofelectriciiy.

r,= ln cold weother the woter pipes in the mobile home moy freeze if the vehicle is left for long periods with theheoting switched off.

To prevent freezing, droin the wostewoter tonk with the heoting off, pleose refer to Section 10.3.2 ,,Emptying thewostewoter tonk".

The bockup bottery (bottery ll) should be kept fully chorged ot oll times.

VanTl G'ts03 2007 . ,t',1\IXr.t:.!.|:, ta::.:,

www.knau

sowne

rs.co

m

|//INTTR CAIIIPING y' ;=.+:):.::.+.4::..

r r While heoting up the vehicle, open oll cupboords, flops ond storoge lockers to prevent condensotion forming.

r= Avoid storing contoiners (bottles, cons etc.) with woter, iuice or other liquids in the unheoted mobile home os theymoy freeze.

r-' All snow ond ice should be corefully removed from the roof of the vehicle ond from the owning; it is porticulorlyimportont to ensure thot the flue on the side woll is kept free qt oll times.

i-' Alwoys keep the forced oir vents open, ond open the roof light slightly if required.

r Never run power cobles on the ground - they moy freeze to the soil or be domoged by snow-cleoring vehicles.

r-- KeeP metol tops open in on unheoted mobile home ot low temperotures, even if the woter system hos beendroined. Alwoys remember to open the mixer lever in both the ,,cold woter O" ond then in the ,,hot woter @"position ond to leove it in one of these opened positions.

17.3 Recommended occessories for winter comping

To be prepored for ony eventuolity when winfer comping, we recommend the following occessories;

7.,,rllw)iil"tiiri{i;

t;.11/..n7.t11Y./,tLili.%t

,ltff trtl:-/..t ll'l;:i

i:;ititrXlltk!:i:l':;!!

nrclki

ft Wint"r cover for refrigerotor {opiionol exko}

ft Exhoust flue extension {optionol exho)

S Snow shorel

ft 8,-,,h

S Plostlc ice scroper

rYr ^tF< t eicer sproy

S Tol.u, powder or Voseline

*p Cooking so t or environmentolly friendly onti-* fr""r" fir the wostewoter tonk

Dde: ] *t*I -F. :now sttp mots

ff Sno* choins for tow vehicle

rtrYXr JUmp storllng cobles

g A bog of sond is olwoys useful should you gei^ stuck in snow.

ff Sno* covers for roof lights (Douercomper)

}K

*

*trtl"

}K

OK: tr

OK: tr

OK: D

OK: fOK: D

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: tr

OK: f

a-,:Bo3 2C4,7 . t,1( )COg VanTl

www.knau

sowne

rs.co

m

18. LAYING UP

www.knau

sowne

rs.co

m

UYING UP

'ttgg

LAYING.UPr8.

WARNING:r= You should completely droin the woter system even if you ore loying up the

mobile home just for o short period. Bocterio will grow in fresh woter ofier iust ofew-doys, moking the woter.undrinkoble f-11th9 f1e.sh woier tonkwe recommendo disinfectqnt thot is qvoiloble frorn your KNAUS deoler.

,r=After on extended loy-up, the entire brqke system should be checked by onouthorised service centre!

I8.I Tempororily loying up the mobile home

The mobile home wiil not suffer from being left outdoors oll yeor round provided o number of precoutions ore token.

lf the mobile home is fo be tempororily loid up, you should follow these steps:

trtrDtrtrtrtrtrntrItrfntrtl

urEgltd(tro=

Forced oir in the roof lights, mushroom vents ond in the eniry ore to be kept open. OK:

ffn"lUUr[::::of corrosion ond repoir minor domoge to pornrwork. Producis suiloble for repoiring pointwork ore ovoiloble from

OK:

I*f"Wl,f;";3J?i{rfr"}J:"[Te ond opplv o point core product Products suitoble lor the core of your mobile home ore

OK:Greose oll moving poris of the legs. OK:Jock up mobile home by winding down the legs so thot the welght is token olf the wheels. OK:lf the mobile home is nol iocked up, move the vehicle once o month to prevent domoge to the tyres ond beorings. Secure mobile OK:home using chocks. ---".r-'

Fill up mobile home. In this woy you con prevent corrosion domoge to the fuel system. OK:Releose hondbroke on mobile home, OK:

I#"!'"in3;:J::,f';*5 il'L,: i1ffi:J[i"";l'J'i,[:if;[:ili:'k[i:'ffi#"'rhe 'oor {e s bv procins risht wooden bottens oK:Also ensure thot there is odequote oir circulotion under the floor. OK:Thoroughly oir the mobile home euery 3 weeks. OK:Fit cover - if ovoiloble - to f ue. OK:

OK:E

OK:5i oK:' oK:

VanTl GBA3 2Aa7 o r\,i!'20C8

www.knau

sowne

rs.co

m

UYING UP ..: , ;: 1t tl;1.

I i; ::a:'::= l::b1:b .:.:l:.'':a;:7.!;;::l

.ffi:.:a:t rrt""q: :

;1:= '//'!'

::, : Ll r: .r." j. L','.

Close gos boile stop volve.

Close oll gos tops.

Alwoys remove gos bohles - incl. empty gos bottles -from the gos locker ond store ot home in on oppropriote ploce.

6oc]oo

OK:OK:OK:OK:OK:OK:

trntrtrtrU

,jitittiiiil tti;

tl;iffE=l'

Completely droin the entire woter system. OK:

['t'llT&i:l]|id:|fifl:i""nil;i,|h:ih:::tJJl,l*;:* Moke obsoruterv sure rhe mixer lever is opened to boih positions {e oK:e oK:P: OK:oi oK:o

OK:

tltrftrtrtr

OK:OK:OK:OK:OK:OK:OK:OK:OK:OK:

Leove oll cupboord doors, service flops ond storoge lockers open.

Cleon oll cupboords.

Ploce oll cushions.uprighi or keep oi home.

Cleon refrigerotor.

Leove refrigerotor door ond freezer comportment slightly oior.

Check thot tfie forced oir vents ore not obsiructed.

ntrtrtrtltrtrutrtr

oocc;o?

o

Pleose.refer hc the.seporote operoting inskuclions.from. the relevonl monufodurers for inlormotion on tempororily loying up th" opplion."i rr"d, tomoKe me tclsk eosEr/ me tndtvtcluot srcps con be ltsled here.

trUDtrnn

OK:OK:OK:OK:OK:OK:

CBA3 2A();' . l"'tY )aa? VanT{

www.knau

sowne

rs.co

m

UYING UP

riiffall

18.2 loying up the mobile home over the winter

lf the mobile home is loid up over the winler, the following sfeps ore to be token in oddition to section I 8.1

::,i5:

=o3cEtoffi

Cleor heovy snow off tire roof.

Heotthe mobile home once o month ond ventilote thoroughly.

Cleon ond lubricote oll door ond service flop hinges.

Oil oll locks.

Smeor oll rubber seols with tolcum powder or Voseline.

Treot oll lock cylinders with grophite powder.

lnsioll winter cover for refrigerotor ventilotion grille (if {itted}

OK:

OK:

OK:OK:OK:OK:OK:

OK:OK:

OK:OK:

trtrtrnntrtrtrtrtrtr

oocc3o

o

o

Etiuii!,i::>!.v} :

-J-<:,:,IE i

iEta i

lJt:rrll

Remove slorter ond bockup boitery, chorge with o suitoble chorger ond store in o frostfree ploce ot home. OK:

OK:OK:

OK:OK:

flDo

occ

o)o

oL

Utrtr

,'.tfi}iL'IL

:tY'('z,E

,:. ]

Remove oll upholstery from the mobile home ond store ot home in o dry ploce. OK:

OK:OK:

OK:

OK:

[ltri

goCc)o=o

otrf

inl&rrJzGLIL,r .lr,

Pleose refer lo he.seporote operoting inskuclions from. the relevonl monufocturers for informolion on tempororily loying up the opplionces used. Tomoke the tosk eosier. the individuol sieps con be listed here.

OK: DOK: flOK: DOK: trOK: fl

VanTl GBO3 2CC:/ . t,'r'i 20CB

www.knau

sowne

rs.co

m

UYING

:--e* Iidsr:Pitffit ITTI

UP

18.3 Re-using the mobile home ofter loying up tempororily or over the winter

lf the mobile home is to be tempororily loid up, you should follow these sfeps:

trEtrtrtrUntrtr

;ir& =;1r;S1i:::t

,1rr{}r111:

:::::.ll;l:: -.::t:::::ia{: a:r:,:::$itli l;.i

...:.1S..1r it::;i$, 1;

=iiftr

Check legs for function.

Check function of oll quorter vents, forced oir vents, roof windows ond liftond-tilt roof.

Check function o[ oll locks on service flops ond enlry door.

Remove cover from the flue (if fitted).

Remove winler cover for refrigerotor ventiloiion grille {;f fiited).

Check tyre pressure of spore wheel {if fitted).

-6P

;oo

OK:OK:OK:OK:OK:OK:OK:OK:OK:

ntrtrntrtr

pocc3o

o

Flush through woter pipes ond fresh woler lonk with fresh woter. Tops must be open during fiis process

Close oll droin volves ond tops.

Check tops, droin volves ond woier fittings for leoks.

OK:OK:OK:OK:OK:OK:

,,!E',,.!.{tJ-l

a,tr}+,t

-.Ata,:a.:r :1Ll=

=

Ploce gos bottles in the gos locker, fosten ond connect. OK:OK:OK:OK:

::!l),:E, :ttr(r!

l,:.:F.a,:,,.!",..':::::i'l::l.::::{.:,,:-L9;

q)occ)o,o

trfnf

Pleose refer t9 ft.e sgporote inslructions from fie relevont mon#octurer lor informotion on putiing opplionces bock into service. To moke the loskeosier, fie individuol iteps con be listeJ here.

OK:OK:

S=Ei TC.

bq.:5 i.':g.: l

OK: trtrtr

Pleose refer to the .gporole inskuctions from the relevonl mon#octurer for informotion on putiing opplionces bock into service. To moke *re hskeosier, lhe individuol iteps con be listed here.

OK: tr

OK: trOK: tr

.OIt*(Jzs

.J(tTL

'I

GBC3 2CA: . AiY 2CO6 VanTf

www.knau

sowne

rs.co

m

I.9. CLEANING AND CARE

mmffi

www.knau

sowne

rs.co

m

"'!ltt'ii,,11

tl,

i;1tt l:*1

CLEANING AND CARE

r9.

r 9.l

CLEANING AND CARE

Cleoning ond core of the exterior of the mobile home

The outer skin of the mobile home is mode from oluminium sheeting. The surfoce of this oluminium sheet is stove-enomelled with on ocrylic point. This process - known os polyester coil cooting - is o modern, environmentolly friendlymethod of surfoce finishing, which cieotes high colour brillionce ond is extrJmely duroble.

To maintoin the high quol;ty of the finish you should cqre for the poinfwork os described below:

) Solt {neor the coost), soot, bird droppings ond other oggressive substonces should olwoys be removed from ihepointwork of the mobile home immediotely before it is morked.

) Wosh your mobile home with woter regulorly if you ore neor the coost.

You should cleon the mobile home os you would o cor:

WARNING:Toke extro coution when wolking over the roof of the vehicle whenwet or icy. There is on increosed donger of slipping or folling offl

ATTENTION:a= Avoid locolised loods (e.g. kneeling) os for os possible if you need to go onto the

roof of the mobile home! Wolk only in the horizontol oreos of the mobile homeroof ond weor soft-soled shoes (e.g. troiners or pumps)l

n=Avoid wolking on the mobile home roof with texture-soled footweor os ony stonesembedded in the soles will dent the outer skin of the mobile home!

) Wosh your mobile home with o pH neutrol product (pH: 6 B). Don't forget the roof!

) Now thoroughly rinse off the vehicle with woier ond dry.

) Use only sponges, soft cloths or soft brushes - hqrd tools moy domoge the pointwork.

) The mobile home should be wqxed from time to time to protect ond enhonce its sheen. Apply the coot of wox qsdirected by the monufocturer of the produci.

> GFK ports con ocquire o yellowish hue over time. This is noi o quollty defect however. To improve the look of theseports there ore speciol cleoning ond polishing products. These products con be obtoined through outhoriseddeolerships.

VanTi GBA-2 2407 o ,\,iI'2008

www.knau

sowne

rs.co

m

ffiLl *ly,

CLEANING AND CAR:[ ry"r'u'

,+;i

.-;r $ .ar. #

) To freshen up old point, the mobile home cqn be treoted with o suitoble polish. Here ogoin, you should follow themonufocturer's directions. Polishing con qttock the point finish of your mobile home (obrosion) so do not opplypolish unless obsolutely necessory.

Plostlc ports must not be treoted with oggressive cleoning ogents {benzene, methyloted spirits, thinners, etc.) - seesection l9 I . i ,,Cleoning plostic ports on the exterior of the mobile home".

Tor stoins_or other orgonic stoins on the point finish ore best removed with benzene. We strongly odvise ogoinstthe use of other solventsllnsects should be softened with woter ond then removed with o spongewropped in o nylon stocking.

Domoge to the finish of your mobile home should be repoired immediotely with refinish point to prevent corrosion.

Check the condition of the underbody protection once o yeor. Pleose contoct your KNAUS deoler if the underbodyprotection is domoged.

After driving on roods thot hove been sproyed with solt, wosh the underbody of the bose vehicle with woter.

r 9.t.l Cleoning plostic ports on the exlrerior of the mobile home

) Ploslic or GFK products con be corefully cleoned using worm woter, with the oddition of o sllghtly ocidic, neutrolor slightly olkoline cleoner.

) You con use low concentrotions 1.2%l of mild household cleoners dissolved in woter.

) Abrosive ogents like scouring powder ore not recommended os they will scrotch plostic surfoces.

) Very.greosy or oily surfoces con be woshed down with petroleum substonces free from oromotic compounds suchos ethonol. The use of orgonic solvents con domoge the moteriol.

) Plostic mouldings cqn be domoged by stress crocks coused by o voriety of products. Other chemicols con cousethe plostic to swell ond soften. These mouldings should therefore only be exposed to brief contoct with the solventslisted obove {2 minutes moximum} ot room temperoture.

GBO?, 2OO/ r {'i1/!ff),a VanTl: ::!:.

i I ::::

::,1;:Y.,1%rrrf

=r, ,i,i,

www.knau

sowne

rs.co

m

CLEANING AND CARE

19.2 Core ond cleoning of the inside of the mobile home

ATTENTION:r= Use only stondord household core ond cleoning products!r=Coustic ond obrosive products should not be used!r= Avoid using onything thot might scrotch or score surfocesl

The furniture should only be cleoned with o commerciolly ovoiloble furniture polish. Powerful cleoning productsshould not be used.

Cleqn tqble tops ond kitchen worktops using only woter with woshing-up liquid or o mild household cleoner.odded

The kitchen sink is mode from stoinless steel ond con be cleoned with products thot ore commerciolly ovoiloble.

Dry-cleon upholstery covers, curtoins ond the diolene blinds.

AITENTION:r;The toilet cubicle should only be cleoned with o little woter with o mild cleoner

ond o domp cloth!r= Do not use ony products contoining ocetone for cleoning the corpet since these

products will couse discolourotion.

NOTE:Sunshine con couse plostic ports in the interior of the toilet cubicle to turn yellowover time. This is not o quolihy defect however.

ATTENTION:Never loy the corpet onto wet PVC floor covering os the corpet moy stick to the PVC

ond pull the covering with it when the corpet is next token up!

The PVC floor covering is hordweoring ond eosy to cqre [or. To cleon it, iust wet-mop ond rub dry; use no wox.

Never use obrosives or oggressive cleoners.

VanTl GB-03 2CC)7 o tt','l 2AaB 'lPre

A

@

A www.knau

sowne

rs.co

m

?ry

19.2.1 Cleoning plostic ports inside the mobile home

) Plostic products con be corefully cleoned using worm woter with the oddition of o slightly ocidic, neutrol or sllghtlyolkoline cleoner.

) You con use low concentrotions (< 2%l of mild household cleoners dissolved in woter.

) Abrosive ogents like scouring powder ore nol recommended os they will scrotch plostic surfoces.

) Very greosy or oily surfoces con be woshed down with peiroleum substonces free from oromotic compounds suchos petroleum ether, ethonol or perchloroethylene. The use of orgonic solvents con domoge the moteriol.

) Plostic mouldings con be domoged by stress crocks coused by o voriety of products. Other chemicols con cousethe plostic to swell ond soften. These mouldings should therefore only be exposed to brief contoct with the solventslisted obove (5 minutes moximum) ot room temperoture.

CLEANINO AND CARE

WARNING:Working with concentroted ocids is dongerous ond should be ovoidedlTo remove c_olcium build-up, use commerciolly ovqiloble ocids only(e.g. ocid of vinegor).

AITENTION:l-r= Never use o cor wosh to cleon the mobile home os the ocrylic gloss windows con

be scrotched by the rototing brusheslr=The ocrylic aloss windows must not be cleoned using chemicol cleoners, gloss

cleoners or products thot contoin olcohol spirit. Cleoning products must not contoinplosticiser os this would couse the ocrylic gloss windows to become brittle ondcrock!

r=Avoid twisting ond distorting the windows when opening ond closing.

While cleoning, keep mechonicol stress on mouldings, e.g. squeezing, to o minimum to prevent distortion.

Woter used for cleoning should be softened to prevent scoling. Colcium build-up con be removed with commerciollyovoiloble ocids (e.g. ocid of vinegor).

r 9.3 Cleoning ocrylic aloss windows, body ond top oirscoop

' :: :: : :::::a::at. .va'

ij ::=' :,.:;:jt:ji,ibt ii-;:..;

lNl ir.a;::= .:|,/.tr

ll:$Q4litrilE: ::+dil,t

a:B03 2007 . ,,1'i\'2008 VanT{

AA

A www.knau

sowne

rs.co

m

CLEANING AND CART

The ocrylic gloss windows should be cleoned using plenty of woter with o cleon sponge ond o soft cloth.

The only liquid whlch you should ollow io come into contoct with the ocrylic gloss is woter wiih the oddition of ol0% solution of mild woshing-up liquid to keep the windows cleor ond free from stotic.

To remove stubborn stoins use o speciol ocrylic gloss cleoner thot is ovoiloble from your KNAUS deoler.

Regulorly lubricote oll hinges, flops ond windows with ocid-free bottery terminol greose or gun oil (e.g. Bollistol)to ensure thot moving ports continue to move freely ond do not seize up.

NOTE:Becouse of the physicol properties of ocrylic gloss, the colder of the two gloss pones,usuolly the outer one, will mist up on the inside. This condensotion will disoppeorwhen the oir oround the window is very dry, but this process of diffusion moy still bequite slow.

19.4 Cleoning ond mointenonce of the Midi-Heki

ATTENTION:r-= Foilure to follow the instructions for the core ond cleoning of the roof window will

void the monufocturer's worronty!n=When woshing the mobile home it is to be ensured thot the woter jet is not

pointed ot the roof window. There is on oir gop oround the gloss dome ond thefrome (forced ventilotion) through which the woter could enter the mobile home.

) Never use oggressive cleoners (solvents/scouring ogents).

) Only cleon ocrylic gloss (gloss dome) ond frome elements with o domp cloth ond mild soop solution; if necessoryuse o speciol cleoner (ot your own risk). This speciol cleoner is ovoiloble from your KNAUSdeoler. Ensure thotthere is no woter on the mechonicol ports.

) Treot oll rubber seols with tolcum powder.

) The 4 ventilotion grilles ond light covers con be removed for cleoning.

) Cleon cover ond mosquito blind with o soft brush, iI necessory with o domp cloth.

VanTf G&03 2A0,7 . AlY 2|08

@

www.knau

sowne

rs.co

m

CLEANING ANl- CARE

r 9.5 Cleoning ond core of the sun owning

) The tent fobric should be regulorly cleoned with o sponge ond cleon woter or PVC cleoner os dirt porticles conotherwise quickly creote o medium for the growth of mould ond bocterio.

I9.5.1 Deoling with mould on the owning

It does not toke long for mould to oppeor on the fobric of the owning i[ it is not cleoned ond oired regulorly (e.g. ifit is folded up ond stowed owoy when wet). Avoid the use of strong solvenis in this cosel

@@ffi

WARNING:l= When opplying fungicides, you must use probctive equipment such

os goggles, mosk ond sofety gloves, ond ensure thot ihe oreo iswell ventiloted!

r="The directions for use in the leoflet enclosed with the fungicidemust be strictly followed,

) Cleon the offected oreo with o 3% coustic sodo solution (ovoiloble from ony phormocist)

) Allow the coustic sodo solution to oct, then thoroughly rinse the fobric ond dry.

) Repeot this treotment ot regulor iniervqls.

19.5.2 Treotment of stiff zip fostreners

The zip fosteners on the owning con sometimes be stiff when new.

) This con be cured by rubbing condle wox into the zips or sproying them with o silicone sproy

.,i:' :.: 'l:"tl;iill

;.aa::44 {ffi

#tf,;,#ffi,(.:BC3 2CtC;7 o A,lj/200c9 VanYI

/./:tl.i!/r:i:1'."' lt ':,, r*:

i;i' ; aa: + a:a :, .1*.

www.knau

sowne

rs.co

m

POWTR SUPPLY

The LED (item 2, figure 1 1.2) obove the bottery symbol lights up when botteries I ond ll ore switched in porollel.

The current fill levels for the fresh woter tonk (item 9, figure 1 I.2) ond wostewoter tonk (item 5, figure 1 1.2) con bechecked using buttons. The fill level is shown in the disploy field by meons of o 5-position LED orroy (item 1 I, figuret 1 .21

:

LED I {l/Il ,.,J"i,,,i1 1o6[ t/r full :

LED 2 I' 1on[ r/r full" :,:tai:;

tED 3 nJ.:: .lr r: :11.-..-,:+.:--..,..::,,:=11

'': :::i:::::::::j::::::=

tat..,,,J:i

Tonk l/r full ',,, q

1on[ rl+ fullLED 4

tED 5 tOl ,, J,'r:.,i li Tonkolmortemfu':

NOTE:You will find further informotion obout the boord control in the seporote operotinginstructions from the monufocturer.

liii|!tuli1i1;;,.,;

willVanTl GBA3 2AA/ o A.t)'2aC)t

www.knau

sowne

rs.co

m

PAWTR

intlltliltt!

SUPPLY

I

2

3

4

5

6

7

8

9

ro

II

Voltoge indicotor chorge stote bottery |

Voltoge indicotor chorge stote bottery ll

lndicotor porollel switching bottery I + ll

lndicotor chorging bottery ll vio moins

Button voltoge bockup bottery (bottery (ll)

Button wostewoter tonk fill level

Moin switch

Switch woter pump

Switch owning light

Button fresh woter tonk fill level

Button voltoge storter bottery (bottery (l)

Fill level indicotor level fresh woter tonkFill level indicotor level wosiewoter tonk

ll.2 Bord-Control

W.jiiry,:,:;";

.ttri.i::.:a,a-:.:!;:...a:

ii.tr:4.42.a: | :;L:a;i.;i;??.:a|; ) i

G&C_1 .)a)A7 o Lt), 2CAE VanTl

\

bKNAUS

,z?tI..JP

@W@W

[]

r

\

www.knau

sowne

rs.co

m

n.,W

,.,8!

,..Ibiil.l:l:t l.;a

tt.4 I2 Volt power supply in the living oreo

When the 23O-Volt power supply is not connected or is switched off, the living oreo of the mobile home is suppliedwith l2 V (DC) power from the bockup bottery (bottery ll) whether the vehicle engine is running or not.When the engine is running, the bockup bottery (bottery ll) ond the storter bottery (bottery l) ore both chorged by thevehicle's olternotor.The l2-Volt power supply con be switched on ond off with the l2-V system moin switch (item 6, figure | 1 .2) on theboord control.

ATTENTION:Excessive operotion of the electricol opplionces (especiolly the refrigerotor, the hot oirblower ond with optimum equipment of the mobile home with the wostewoter tonkheoter) from the bockup bottery without o 230 Volt supply ond with the vehicle engineswitched off will significontly impoir the copocity of the bockup bofferyl

The hot oir blower runs continuously when the heoting is on. This will considerobly reduce the copocity of the bockupbottery when the 230 Volt supply is not swiiched or not connected.

r t.5 Prolection of the electricol circuits inthe mobile home

When the mobile home is connected to on externol 230 Vsupply, ii is protected by o I 3 A outomotic circuit breoker.

The electricol opplionces in the living oreo connected to thel2 Volt power supply ore protected by seporote fuses in thedistribution box in the wordrobe.

The oir conditioning system (occessory) is protected by the.l 3 A qutomotic circuit breoker.

The box contoining the outomotic circuit breokers is instolledin the wordrobe.

POWER SUPPLY

.:=

I I,-5;

I1.3 Automolic circuit breoker

VanTl GB03 2OA/ . /',ttf 2OaB

A

www.knau

sowne

rs.co

m

POWER SUPPLY

r r.6 Electrico! supply

The electricol supply to the opplionces in the mobile home is as follows:

I2 Volt power supply from bockup bottery ond chorger

Bockup bottery

WARNING::= No mointenonce work is to be performed on the mointenonce-free

gel bottery! The botfery would 'be

irreporobly domoged, ond thereis the risk of the bottery exploding.

;; The gel bottery should only be reploced by onother gel botteryl

ffi , :, ,ifl!0ilfg1if,: i sin*l@lffiryt:,r lst$l#ai*

=,, n3$YA€., :l

=={olhrfonnx*on}'..:,t:.,ftlim dturger-,,, i

Refrigerotor

230 Volt sockets

@ .**wffi"@

Electric cortridge hot woter syfem !T1umo)

Electric cortridge hot woier heoting {Alde)

Circuloting pump hot woter heqting (Alde)

rry

Air<onditioning {optionol extro) W'12 Volt power supply to living oreo

Lights -*We...WWoter pump wHeoter -M-WI2 Volt sockets MW

I 1.4 Electricol supply

11.7

11.7.1

AThebockup bottery (bottery ll) is locoted in the reor goroge in o bottery box. The ossocioted chorger plus moinbottery switch con be found in the wordrobe. This meons thot the mobile home hos its own l2 Volt power supply.The chorge stote of the slorter boftery (botiery l) ond the bockup bottery (bottery ll) con be checked by pressing theoppropriote button (item :0 or 4, figure I 1.2) on the LED orroy (item 1, figure I L2) on ihe boord control.

.,r,,,i|!tl&ii,.t:!,!I

it il: :iti.t.t' i ii. : ::.:i:=itltll;.8= GtsA3 204/ . til,,\,)OOg VanTl

www.knau

sowne

rs.co

m

POWER SUPPLY

It is odvisoble to chorge up the bockup bottery with the chorger for ot leqst I8 hours before use. Here the moin switch(item 6, figure I 1 .2) hos to be switched on.

Switch off oll electricol opplionces while chorging to ochieve o ropld ond optimum chorge. Chorging should be

checked. This is possible using the button (item 4, figure 1 1.2)ond the LED disploy (item 1, figure I I.2)on the boordcontrol.

Before connecting to the 230 V moins, check the chorge stote of the bockup bottery by pressing the relevont buttonon the LED disploy. On connection to the 230 Volt supply, press the button ogoin ond observe the LED disploy. The

green section of the LED disploy should now light up towords ,,l3V".lf it does so, this indicotes thot the chorger is

working correctly. lf the LED disploy does not chonge, this indicotes thot the chorger is not chorging. You should tryond identify the couse, i.e. check lhe 2 A,30 A ond 50 A fuses with the bottery box. lf you ore unoble to find the

couse, contqct on oppointed deoler.

A fully dischorged bottery thot connol be re-chorged must be reploced os it is irreporobly domoged.

NOTE:The bockup bottery is still under o lood of opproximotely 20 to 65 mA from electricolopplionces (heoting, chorger, on-boord control, etc.) even ofter switching the

opplionces off. The chorge stotus of the bockup bottery should therefore be checkedregulorly to prevent ony domoge to it!

AITENTION:r= lf the bockup bottery hos not been used for o while, chorge it up fully first ond

then turn it off with the moin bottery switch.t=The fully chorged bottery should be disconnected ond removed from the vehicle

in winter. A complete dischorge con domoge the bottery beyond repoir.r=The bockup bottery moy only be chorged with o suitoble chorger when removed

from the vehicle.

The entire l2 Volt sysiem con be switched on ond offwith the moin switch (item 6, figure 1 L2) on the boord control.lf the rocker switch is in position ,, C " , the I2 Volt system is switched of[. However the eleciricol supply to the

refrigerotor (WAECO) when in 12 V operotion, the ceiling light ond the heoter remoins on.

,iiNrl iiYtfl!*

TilillXWVanTl GBA3 2AC7 o ltt,r,2(:09

A

www.knau

sowne

rs.co

m

POWER SUPPLY

11.7.2 Chorger

The use of high-quolity electronics meons thot the chorger operotes virtuolly without loss of power. The outomoticchorging process chorges the botteries gently ond without hormful overlooding, thereby considerobly enhoncing botterylife. The chorger hos outputs for the siorter bottery (bottery l) ond the bockup bottery (bottery ll). The chorger storts tooperote os soon os it is connected to the 230 V supply.

NOTE:You will find further informotion obout the bottery chorger in the seporote operotinginstructions from the monufocturer.

11.7.3 Exomple showing how to colculote elechicity consumption (using 80 Ah bofiery)

WARNING:Due to o risk of fire with recessed spotlights, only use mox. 10 W bulbsl

? ;::. .,4..: 1:. :.:)/

These volues ore ,,opproximote figures" ond depend on the relevont model.

Ap$f idt|i!'i ir,".,.,. .,,,, iriii P,,uwero; &*s*i Hri/daitop. houisi

.f**irneiifu,

tlii/dsvtep. homs) ,

:P,,r ir:JDei,ffiii

Seoting moduie spotlightl

20llv r t./A 20 40 w 3.4 Ah 4.0 B0 l,vI

2.A 40 W

6.8 Ah

34Ahl(itchen light 20!1l I 7A ro iow r /Ah

Ceiling light 40!11 33Alr.0 r 40w 33Ah

l20 BOW 6.6 Ah

Light, toilet cubicle 20!v t./ A r0 20\/V I t./ Ah 1.5 30w 2.55 Ah

Woter pump 40 W 3.3 A

Heoter/hol woter boiler 72W O.O Ii

ru 40w 33A

0.5

2.0

20

20\,1l

144 \/1/

BOW

1.7 Ah

I rz o ltT

66Ah

0.5 20 w t,/ Ah

16.0 r,r52W 960Ah

4.0 l60w t36Ah..=: :,1.1.;:r.:,,11,

t1:'al:t ..:.': :.:a:

lP,owr$irumplion !i;;'";l:|,,, : : :

iliui:ltsd> 3Hilf, gU:4 *h

=kr}-

.::.1; I ,:::

iliw---------------,1f.r30.e5 Ah

I1.5 Exomple showing how to colculate electricity consumplion (using 80 Ah bottery)

r:i)lll: : "t,|rr.,r,*,

': :'.::.!:, :1?ih

#ffi GBC3.2a07 o l,tt\' 2aCS VanTl

www.knau

sowne

rs.co

m

POWER SUPPLY

I r.8 Externol power supply 230 Volt vio emergency power unit

ATTENTION:r=To prevent domoge to the electronics, olwoys ovoid voltoge deviotions when

operoting the emergency power unitlr= Poy ottention to the monufocturer's specificotions when using on emergency po-

wer unitl

AITENTION:When using on emergency power unit, on overvoltoge protector should be fittedbefore the chorger in the 230 Volt circuit. You con obtoin further informotion fromyour locol KNAUS service centre.

I I.8.1 Using the emergency power unit

I. Stort the emergency power unit ond bring up to operoting temperoture by ollowing to run for opprox. 5 to IOminutes (depending on the outside temperoture) until o uniform voltoge is ottoined (see voltoge indicotor onemergency power unit).Couses of voltoge deviotion moy be e.g. suddenly switching the emergency power unit on or off or the emergencypower unit shutting down outomoticolly when the fuel runs out.

2. Moke the connection befween the emergency power unit ond the mobile home occording io section 11.2.

I 1.8.2 Shutting down the emergency power unit

l. Disconnect the emergency power unit from the mobile home

2. Switch the emergency power unit off.

NOTE:You will find further informotion obout the emergency power unit in the seporoteoperoting instructions from the monufocturer.

allll: "1,,:a:":.:=

==ll::L' .

/i; iill,

VanY{ CB-O3 2aA7 . l,1l'2008

A

@

www.knau

sowne

rs.co

m

12. HEATING AND HOT WATER

www.knau

sowne

rs.co

m

,:iffir1=

a4' ,r: ,

HTATING AND HOT WATTR

12. HEATING AND HOT WATER

l2.l Generol informotion

Your mobile home is fitted with o Trumotic LPG oir-heoting system ond integrol hot woter boiler os stondord. Thewoter boiler hos o copocity of 12.5 litres ond supplies hoi woter within o ronge o[ 40 to 60"C.

12.2 Commissioning the Trumotic

AITENTION:Work on the electronic control unit for the Trumotic moy only be corried out by oquolified ond troined service engineer.

I.

2.

3.

NOTE:The seporote monuol from the monufocturer is to be reod prior to using the Trumotic!

Remove flue cover.

Connect o gos bottle. Open the gos bottle stop volve ond gos top for the heoter ,, @ ". The opplionce shut-offvolve is locoted neor the heoter ond is occessible vio on opening in the goroge:

Proceed os follows to prepore ihe hot woter supply:

o. Fill the fresh woter tonk.

b. Check thot the droin volve in the fresh woter tonk is closed.

c. Check thot the octuotion button for the sofety droin volve is set to position ,,CLOSED".

d. Switch on moin switch (item 6, poge 11-4) ond thewoter pump using the switch (item7, poge 1l-4) on theboord control.

e. Now open the hot woter top in the @ ,,hot" mixer position until the hot woter boiler hos filled, i.e. oir hos beenforced out of the hot woter boiler ond the woter pipes, ond woter is flowing.

wi;ffiVanTl GBO3 2A0r' o r',,fi 2AOE

www.knau

sowne

rs.co

m

HEATING AND HOT WATER

ffi-I ['rl.H

I2.3 Setting the modes heoting/hot woter preporotion

'i:11:::,iii#:;:a,;ffi,1i,t, ,,:' ,,

ii|ll.ti|tt*i:ii7.fiLt

iilllff GBa3 2oa: ' t'it\'2cal

ATTENTION:n=The woter pump must not be operoted unless o supply of woter is ensured!r= Switch the moin switch on (item 6, figure 'l

I -4) with lengthy periods of obsence.

4. To set the respective operoting mode for heoting/hot woter preporotion, see section 12.3

I2.3.1 Setting the modes

I. Set the desired operoting mode os follows using the turn-knob (2) on the Trumotic control ponel:

Summer operotion in setting (4) ondWinter operotion in setting (5) or (6).

2. Once one of the two modes is switched on, o greenindicotor lomp behind the turn-knob (3) lights up.

3. lf the green indicotor lomp does not l;ght up, reploce the[use in the electronic control unit or the fuse for the botterymonitor.

4. A continuously lit red indicotor lomp (9) indicotes o closedgos bottle shut-off volve ond/or opplionce shut-off volve,interrupted oirJlow, oir in the gos line or o foulty fuse.The foult is reset by iurning the opplionce off ond thenbock on ogoin.

12.3.2 Summer mode

12.3.2.1 Hot woter only

I. Set the turn-knob (2) to the desired woter iemperoture 40 'C or 60 "C (4) Once the desired temperoture hos beenreoched, the burner shuts off ond the yellow indicotor ,,Boiler worm-up phose" (8) goes out. This function is onlyovoiloble in Summer mode. The burner operotes ot the lowest burner sefting.

I

8

I3

I Knob for r00m temperottlre, continuously odiu$oble I 9(illuminoled by green ,,0peroling" LED)

2 0peroting mode turn-knob

3 0reen ,,0peroling' lomp

4 Summer mode ,,0n" (woter lemperolure 40 'C or 60 "[)5 Winter mode ,,0n" (heoler wifiout hot woter commond)

6 Winter mode ,,0n" (heoter with hol woler commond)

7 Turn-knob posilion,0ff"

8 Yellow indicotor lomp ,,Boiler worm-up phose"(goes out when ihe preset woter temperoture is reoched)

9 Red,,Foult" indicotor lcmp

l2.l Trumotic C control ponel

VanTl

www.knau

sowne

rs.co

m

HEANNG AND HOT WATER

I2.3.3 Winter mode

I2.3.3.1 Heoting with controlled woter iemperoture

l. Set turn-knob (item 2, poge I2-21to position (item 6, poge l2-21.

2. Rotote the turn-knob (item 1, poge 12-2lto the desired thermostot setting l-9 for the room temperoture. The greenindicotor lomp ,,Operoting" (item 3, poge 12-2) lights up ond shows the setting of the room temperoture selected.After ochieving the room temperoture selected, the burner switches bock to the lowest level ogoin, ond the woterin the boiler is heoted to o temperoture of 60 'C.The yellow indicotor lomp ,,Boiler worm-up phose" (item B, poge 12-2) shows the heoting phose ond goes outwhen the woter temperoture hos been ochieved.

12.3.3.2 Heoting without conholled woter temperoture

I. Set turn-knob (item 2, poge 12-21to position (item 5, poge 12-21.

2. Rotote the turn-knob (item 1 , poge 12-2) to the desired thermosiot setting l-9 for the room temperoture. The greenindicotor lomp ,,Operoting" (item 3, poge 12 2) lights up ond shows the setting of the room temperoture selected.After ochieving the room temperoture selected, the heoting switches off. When the boiler is filled, the woter isheoted outomoticolly os well.ln this operoting mode the yellow indicotor lomp ,,Boiler worm-up phose" (item 8, poge 1 2-21 is only illuminotedof woter temperotures under 5 'C.

NOTE:Heoting operotion is bosicolly unrestricted with or without woter.

12.3.3.3 Heoting with on empty woter system

I. Set turn-knob (item 2, poge l2-21to position (item 5, poge I2-2).

2. Rotote the turn'knob {item 1, poge 12-2lto the desired thermostot setting l-9 for the room temperoture. The greenindicqlor lomp ,,Operoting" (item 3, poge 1 2 2) lights up ond shows the setting of the room temperoture selected.After ochieving the room temperoture selected, the heoting switches off.ln this operoting mode the yellow indicotor lomp ,,Boiler worm-up phose" (item 8, poge I 2-21is only illuminoiedqt woter temperotures under 5 oC.

, .a::=

l'2;,&.,VanTf GB03.2AO7 c 1,,1Y 20Ct8

www.knau

sowne

rs.co

m

=u.Wr*.,r.,rh,.1 ,,.,'' .,;i:'t'" Sn

'"t:L:' " '#"-..-...= ,,/.

ii{f !t; :. .a ii li {|..!:.: tr ! ,/// 4

3.

4.

l. Switch ihe woter pump off with the switch (item 9, pogeI 1-4) or the moin switch (iiem 6, poge I 1-4) on the boordcontrol.

2. Open oll the hot woter tops in the kitchen ond bothroom.

3. Push the operoting button (l) to the ,,DRAIN" posirion.This oction droins the contents of the hot woter boilerdirectly to the exterior vio the sofeiy/droin volve.Dr.rring droining check thot the entire conients of the hotwoter boiler (opprox. 12.5 litres) empties completely.

;: ii?i!r:::l '' :,:lt'.;:it1tial..: .::i:ji

'//iilril&&.ttt?i.:a:a:;:=

i)ii,, ffi

HEATING AND HOT WATER

WLB

12.4 Switching off the heoter/hot worer boiler

I. Set turn-knob (item 2, poge 1 2-21 to position litem 7 , poge I 2-2] ,, C " .

2. Close the opplionce shut-off volve for the heoting ,, @ " ond the gos bottle stop volve i[ it will not be used for sometime.

Fit flue cover.

Switch. the woter pump off with the switch (item 9, poge 1 1-4) or the moin switch (item 6, poge 1 1-4) on the boordcontrol.

12.5 Emptying the hot \ /oter boiler

AITENTION:The droin plug on the electric sofety/droin volve must be kept free from obstructions(slush, ice, leoves etc.) ot oll timesl

12.2 Sofety/drain volve, hot woter boiler

VanTfGBa3 2aAl . t't,/ )COE

www.knau

sowne

rs.co

m

HEANNG AND HOT WATER

ATTENTION:When the heoting is off, the sofety/droin volve con only be closed ogoin ottemperotures obove 8 "C.

NOTE:When temperotures ot the sofety/droin volve ore belo* opprox. l0 "C ond theopplionce is not in operotion or hos o foult, the woter con droin off by itself!

As oll other opplionces in the woter circuit (woter pump, tops etc.) ore not protected by the frost protection volve ondthe outomqtic droin could be obstructed by dirt or ice, ihe woter must be droined ofter ihe boiler is turned off if thereis o risk of frost.

:t t ;'11""'';/j

;ffih.4: ",

VanTl GBO3 2AO7 o !',\Y 2a08

A

@

www.knau

sowne

rs.co

m

t:*,2".444tl4t.7L:.a.ttlfrun

HEATING AND HOT WATTR

ffitI I{83-1Itll| &*{lLI

r2.6 Heoting ond hot woter supply with Alde Compoct centrol heoting

The Alde Compoct centrol heoting system with integroted hot woter heoting is locoted under the reor bed ond is

controlled using the relevont control ponel (see figure 12.3).

The heoters (rodiotors) supplied by o circuloting pump with glycol fluid ore positioned in the mobile home to ensureon even temperoture throughout the interior of the vehicle.Thonks to this efficient centrol heoting system you do not hove to do without the occustomed comfort of o pleosontindoor temperoture in the mobile home - os in your living room.

12.6.1 Functions on conhol ponel of centrol heoting

l. To switch on the centrol heoting in gos mode, open the gos botile stop volve ond opplionce shut-off volve for the

heoting ,, @ " o, the volve block under the kitchen ronge.

2. The centrol heoting is controlled with o slider switch on the control ponel, with the desired room temperoture olsobeing selected ond moniiored vio the control ponel.

AITENTION:Work on the electronic control unit for the Alde Compoct centrol heoting system

should only be corried out by o quolified ond iroined service engineer.

The Alde Compoct centrol heoting system is equipped wiih ionising flome control, i.e. if the flome goes out, theelectronic control unit otiempts to light ii ogoin.

lf the flome does not ignite within l0 seconds ogoin, the solenoid shuts the gos feed off ond blocks the electroniccontrol unit.This process is indicoted bythe red LED lighting up (item G, figure 12.3).When the room thermostot storts up the centrol heoting, i.e. if the temperoture in the mobile home is under the settemperoture, the circuloting pump is storted.This mokes the fluid in the heoting system circuloie, ond cold fluid enters the heoting circuit.The operoting thermostot for the heoting regislers the fluid temperoture, ond the heoting system heots the fluid thotcirculoies through the sysiem.

lf the set temperoture is ochieved, the circuloting pump is switched off.The operoting thermostot registers thot the fluid hos ochieved the set temperoture, ond the heoting unit is switched off.

As soon os the temperoture of the fluid hos dropped o few degrees, the heoting unit is switched on ogoin.This ensures ihot heqied fluid is olwoys running through the heoting circuit if the thermostot is operoting the heoting.

GBC3.2CA7 . A1\'2006 VanTl

A

www.knau

sowne

rs.co

m

HEATING AND HOT WATTR

& ffikF,

D

c

B

A

ffi

J>l>H>

A Heoting (electric operolion) ,,OFF"

B Heoting (eleckic operotion) ,,ON" ot 1,050 W power

C Heoting (electric operotion) ,,ON" ot 2,100 W power

D Heoting (elechic operotion) ,,ON" ot 3,,l 50 W power

E Heoting (gos operotion) ,,OFF"

F Heoting (gos operotion) ,,ON"

G LED ,,Gos operotion foult indicotor"Heoting does not ignite or flome goes out ogoin becouse of onother foult.

H Circuloting pump ,,OFF Summer mode"Heoting is controlled by the thermostot integroted in the device in gos ond/or electric operotion.Operoting mode for worm woter only.

I Circuloting pump ,,ON Winter mode"Heoting is conkolled by the ihermostot integroted in the device in gos ond/or electric operoiion.Operoting mode for heoiing ond worm woter. This is siondord operotion.

J Circuloting pump ,,ON Winlrer mode"The heoting is controlled by the room thermostot in the controller in gos ondf or electric operotion.Operoting mode for heoting (produces the mosi even room temperoture in the mobile home).

K Knob for room lemperoture

L Morking for on overoge room temperoture of opprox. 22 'C

12.3 Hot water centrol heoting control panel

t:i:tlA|| lll:iHintl

.,:li 1, i!iLl!.1:: ::

W;ltltli,WllVanTf GBO3 2A07 . N'r"r'2()OB

www.knau

sowne

rs.co

m

ffi]ffil

r2.6.3

A

HilfiNO AND HOT WATER ,,,'.'ffi'

ii,tti&iit tli,.!lt:l

12.6.2 Optimum heoting comfort

ln order to best utilise the principle o[ woter-bosed heot, it is importont thot the heoted oir con circulote under the bedboxes ond behind the bock cushions freely.

It is iust os importont thot the cushions ond covers do not hinder the oir circulotion behind the bock cushions.

Circuloting pump

ATTENTION:Pleose note thot with continuous operotion of the l2 Volt circuloting pump, theservice life of the motor will be significontly reduced!

The exponsion tonk contoins q I 2 V circuloiing pump thot distributes the heoted glycol fluid in the heoting system.Afterwords, the circuloting pump is switched on ond off by the room thermostot depending on the heoting requirements.

12.6.4 Exponsion tonk

The exponsion tonk is instolled in the wordrobe. The level of the glycol fluid con be reod off ot the exponsion tonk.This should be opprox. I cm over the,,MlN" mork when the heoting unit is cold (see figure 12.4].

Theheotingcircuitshouldbefilledwitho 40%glycolmixtureosusedinoutomobileengines. lf theheotingsystemissubiected to temperotures under -25 'C, the glycol mixture is to be increosed, but never lo.obove50%. Before filling with new fluid, check the octuol glycol content so thot the glycol concentrotion in the fluid mixtureis not increosed too much.

The glycol mixture should be chonged every 2 yeors since importont chorocteristics such os e.g. corrosion protectioncon deieriorote over time.

AITENTION:The heoting system should never be operoted without glycol fluid.

lf the fluid level in the exponsion tonk drops lower thon with normol condensotion, the entire heoting system must bechecked for leoks.

lf the glycol mixture is leoking out, the offected spot should be rinsed thoroughly with woier ond then dried off.

a,:B'C3 2OO/ . ,\'1)'2COS VanY{7r,i;!; rffi1."11;.1l,

iiffiffi,i"

A www.knau

sowne

rs.co

m

(\ipya

"* fl{t "i ',

HEAIING AND HOT WATTR

,,tlt tili!1.ffi

.::::::::::::=

#tfi

I.

2.

12.6.5 Top up glycol mixture

WARNING:Toke core when fillingthis fluid is toxic!

the exponsion tsnk with the glycol mixture.

Unscrew the cop nut Ion the exponsion tonk ond lift thecirculoting pump.

Slowly pour the glycol mixture into the exponsion tonkuntil it reoches o level opproximotely 1 cm obove theMIN mork.

NOTE:The heoting system should olwoysbe bled ofter filling before stortingup!

Air pockets mqy occur when filling the heoting system depending on the system of pipes instolled. You will notice thot,when there is oir in the heoting system, the heot only reoches obout I metre down the pipes olthough the circuloiingpump is running.

lf the heoting system hos iust been filled, smoll oir bubbles moy form in the exponsion tonk. lf the circuloting pump isshut off for o few seconds, the oir bubbles will disoppeor under normol circumstqnces.

To bleed the oir from lhe heoting system, proceed os follows:

I. Switch on heoting unit.

2. Check thot the circuloting pump is switched off.

3. Open the bleed screws for oll rodiotors one ofter the other ond leove open until fluid escopes.

12.6.6 Ventiloting the heoting system

12.4 Hotwoter cenlrol haling: Expnsion tonk

VanTl GB03 2C)07 . A.1Y2OOs

A

www.knau

sowne

rs.co

m

HEATING ANl- HOT WATER

4. Now switch on the circuloting pump ond ollow to run for o few minutes. Check thot the pipes ond rodiotors ollround the mobile home ore heoting up.

NOTE:lf these meosures do not hove the desired effect, you moy hove to top up with glycolmixture ogoin.

Otherwise continue os follows:

5. Pork the mobile home on o slope or lift with o suitoble jock so thot it is leoning forwords. Moke sure the mobilehome is secured from rolling owoy with wheel chocks!

6. Woit severol minutes with the mobile home in this position so thot the oir in the heoting system con rise to the top.

7. Unscrew the bleed screw ot the highest point (check beforehond!) ond leove open until glycol mixture escopes.

8. Pork the mobile home on o slope or lift with o suitoble jock so thot it is leoning bockwords. Moke sure the mobilehome is secured from rolling owoy with wheel chocks!

9. Woit severol minutes with the mobile home in this position so thqt the oir in the heoting system con rise to the top.

10. Unscrew the bleed screw qt the highest point (check beforehondl) ond leove open until glycol mixture escopes.

I I. Set the mobile home up so thot it is level ogoin.

12. Nowswitchonihecirculotingpumpondollowtorunforofewminutes.Checkthotthepipesondrodiotorsoreoll worm throughout the mobile home.

NOTE:lf these meosures still do not hove the desired effect, consult o quolified engineer.

NOTE:You will find further informotion in the seporote monuol supplied by the monufocturer.

GBO3 )CO; o t1\' 2CCE VanTl

@

@

@www.kn

auso

wners.

com

lr,i?*;. ,:iitl

,' ,. t$l .1 i:':

&; ;l*: ,f:-.::,.: i'. -/l)l-""= ,/'

t: .*4 "^"

HEATING AND HOI WAIER

I .8 bor builds

pressure of 1.8

The hot woter is supplied vio o hot woter boiler in the ALDE heoting unit. The hot wqter boiler con be operoted withliquid gos, with 2i0 V (electric cortridge) or with both simulton"o,irly.

The 8.5-litre hot woter boiler supplies hot woter in o temperoture ronge of 40 to 70 "C. With moximum usogeopproximotely 17 litres of hot woter ot o temperoture of 40 'C con be provided.

The hot woter boiler tokes opprox. 30 minutes to heot I2 litres of woter from I0 "C to 40 'C when working withliquid .gos. lf the hot woter boiler is operoted ot 230 V, the copocity will be slightly lower. lf the electric cortrilge isnot.sufficient for your hot woter requirements, the hot woter boiler con olso be operoted using 230 V ond liquid gosot the sqme time.

AITENTION:The woter pump moy only be operoted dry for o very short period!

12.6.7 Hot wolrer supply with Alde Compoct

\#ARNING:Hot wqter should not be used os drinking wqter or to cook wifi!

The woter pump is ociivoted vio the tops. When o top is turned on, on operoting pressure of opprox.up in the woter pump. This ensures thot pressure is ovoiloble when woter is required.Should the pressure foll below o certoin level while woter is being drown (pressure drop) the nominolbor is outomoticolly restored by the woter pump.

Proceed os follows to prepore the hof woter supply:

l. When storting up for the first time or when the hot woter boiler is empty, the boiler must be filled with woier; thisrequires filling the fresh woter tonk, see section 10.3 ,,Filhng the fresh woter tonk".

2. Ensure thot the droin volve on the fresh woter tonk is closed.

3. Now open the hot woter top in the W ,,hot" mixer position until the hot woter boiler hos filled, i.e. oir hos beenforced out of the hot woter boiler ond ihe woter pipes, ond woter is flowing.

'"'rzAilVanTl C803 2a07 o M/20C8

A

www.knau

sowne

rs.co

m

HEATING ANl- HOT WATER

k4;.'i,t -.l .,:,I q

2.

3.

4.

12.6.7.1 Hot woler heoting with gos

I. Open gos bottle stop volve ond opplionce shut-off volvefor the heoting ,, @ " under the kitchen ronge.

Switch on the heoting with the slider switch, position F ,,6"

The slider switch for the circuloting pump remoins in theposition H,,0".

The slider switch for the electric cortridge remoins in thepositionA,0".

12.6.7.2 Hot woter heoting with 230 Volt

l. Check thot the 230 V power supply is connected.

2. Set the electric cortridge slider switch to the desired heotsetting:

o Setting B / .l,050 W ,, 1"

r Setting C / 2,100W ,,11". Setting D / 3,150W ,,111"

3. The slider switch for the heoting remoins in the positionE ,,4 ".

12.6.7.3 Hot woter heoting wi*r gos ond 230 Volt

l. Open gos bottle stop volve ond opplionce shut-off volve for the heoting ,, @ " under the kitchen ronge

2. Check thot the 230 V power supply is connected.

3. Switch on the heoting with the slider switch, position F ,, 6 " .

4. The slider switch for the circuloting pump remoins in the position H ,, O " .

5. Set the electric cortridge slider switch to the desired heot setting:

o SettingB/1,050W,,1". Setting C / 2,100W ,,11"o Setting D / l,l50W ,,lyt"

ffi 1i:j::a:aaa=tlztlf)t

?l{:ia::::::;:tii!i'{n?t

'=Y,,,

G

ffi

@ ^{#/kb

.l{ie= = ,,..'

1@{W:- |ryl"l:i:,:,:Wl\:,#ii*jffi!*,\ffiW: ::.::::

r., @ ',]tIIF> ltil I'rt

lH'2?7= li.rZ| 1 :!-

AL%*,

@

12.5 Hot woter heoting with gos

@ffiw

D

cB

ffi

&

t*tu*r4r=.

/:7kM{:""'|,,ffi\..:/W\::::::/W\lW

-Yry

12.6 Hot waler heoting wilh 230 Volt

a_,:'tsC)3 2C07 . l,'t\'2CCE VanTf

www.knau

sowne

rs.co

m

fliTATING AND HOT WATER

12.6.7.4 Emptying the hot woter boiler

l. Ensure thot the woter droins to the outside ond thot it is notoffected by dirt, snow, slush, etc.

Switch the fresh woter pump off.

Open oll tops.

Open the droin volve (lon the woter supply.

The contents of the hot woter boiler ore emptied directlyoutside vio the droin volve.

During droining check thqt the entire contents of the hotwoter boiler (opprox. Z-10 litres) ore dischorged.

Leove the droin volve ond oll woter tops open until the next

12.7 Alde Compocf. Emptying hotwoter boiler

USE.

2.

3.

4.

5.

6.

7.

NOTE:Check thot the outomotic non-return volve opens, odmits oir to the woter heoter ondroinoge ond thqt the hose is not blocked.

NOTE:You will find further informotion in the seporote monuol supplied by the monufocturer.

(;ii1:;i1i 'ii;,.

lull:L;I#VanTl G8C3.2007 . A,1I2C0E

@

www.knau

sowne

rs.co

m

13. COOKING AND BAKING

www.knau

sowne

rs.co

m

COOKINO AND BAKING

r3.

r3.r

COOKING AND BAKING

WARNING:u= To ensure o continuous flow of oir in the mobile home, the forced oir

vents in l|re roof, mushroom vents ond in the floor plote in the reormust never be couered

n=When using ihe cooker, you must open o window or roof light toensure on odequote supply of oxygen to the interior of your mobi-Ie home.

u=The gos cooker should never be used os o heoterlas Explosion hozord - Never sllow gos to escope unburnedlasThe user must be oble to tegp the gos llghting process in fullview

- this must not be conceoled'by po'is etcimThe flome sofety cover must be lifted whenever the cooker is in

use!

Using the gos cooker

I. Open gos botile stop volve ond ,, @ " gos shuloffvolve on the volve block under the kitchen ronge.

2. Lift up the cover on the hob.

AA

3. To light the burner, turn the required control knob qnticlockwise in the recess in the hob to low or high flome, pushdown ond hold.

4. Light the escoping gos with suitoble lighter ond keep the control knob held down for onother 5 to Z seconds. Theflome moy go out if the control knob is releosed too soon. Repeot the operotion if this hoppens.

5. To switch off, turn the control knob clockwise to the,, O " position.

l[ the thermocouple is bent or foulty, the burner will not operote correctly, ond the flome will keep going out evenwhen the control knob is held down. lf this hoppens, o new thermocouple must be fitted by o quolified engineer.

NOTE:A flome with on indistinct pottern is o sign of poor combustion, ond we ihereforerecommend onnuol servicing by o quolified engineer.

You willfind further informotion in the monufocfurer's seporote operoting inslructions.

iiitlll)lt:6 tiF,*,"

t{1ffi:::VonTl GBCt3.2047 r r,1)'2008

A

www.knau

sowne

rs.co

m

[HlLll

COOKING AND BAKIN?

13.2

t 3.2.1

I.

2.

3.

4.

5.

6.

NOTE:Before using the oven/grill for the first time, it should be switched on empty (withoutfood) qt the moximum temperoture for obout holf on hour.

Open gos bottle stop volve ond opplionce shut-off volve ,, @ " on the volve block under the kitchen ronge.

To lightthe oven monuolly, push in the rotory knob (item 1, figure 13.1) slightly, hold ond move to the ignitionposition.

Light the burner using o gos lighter ond keep the rotory knob pushed in for between 5 to I O seconds.

Releose the rotory knob ond move to the required position.

Gos oven with/without grill

Using lhe gos oven

NOTE:To light the oven outomoticolly, the oven door must be opened fully or the outomoticignition process connot toke ploce.

7.

8.

Open oven door fully.

Push in the rotory knob (item l, figure 13.1) slightly ond hold, move to the ignition position ond keep pushed infor between 5 to l0 seconds.

Releose the rotory knob ond move to the required position.

To light the oven with the thermostot, proceed os for monuol ond outomotic ignition, with or without electronicignition.

To use the oven, turn the rotory knob to on ignition position between I ond 6, ond to use the grill, to position,,sra".

9.

10. For ovens with o thermostot the different positionsof the rotory knob correspond to the temperoturesshown opposite.

Position rotcry,fug!., I 2 3 4 5 6

'I@cJ t30 t60 t80 200 220 240

t : ::a:a.aa,;xi1:l ::1"/:a:i::.:t:,'"' a::;;?l.lll.,rt::.!::11:.:r:.

;;;11]:,:=,"!1V11ri.11;t;:li

=:y.,#rt#

VanTf

@

@t

a.:tsc3 2oc7 I i;11/.rflfg

www.knau

sowne

rs.co

m

.,,0,,,',1ht!,:ltU

': .:' tillt:

,r,.i, .r

;:::':. .:;''aUil

COOKING AND BAKING

NOTE:r= lf ignition foils, repeot the entire ignition process. lf necessory check thot the gos

ond power supply ore on.r= lf the ignition process still foils, consult on outhorised deoler to hove the foult

repoired.

I I. To use the grill, first remove the heotprotection plote ond then light the grillburner.

Leove the oven door obout holfopen.

To use the spit, insert the greose troy withthe spit fitted.

To stort the spit, press the pushbutton (2).

13.2.2 Spit with grill

I. Remove ihe heot protection plote ond then light the grill burner.

2. Leove the oven door obout holf-open.

13.2.3 Spit with oven

l. Light the oven burner ond move the rotory knob to the required temperoture setting.

2. Close oven door.

12.

t3.

14.

NOTE:You will find further informotion in the monufocturer's seporote operoting instructions.

s'1r7:1i1Y1i,

'W;|,,ffa\.

l3.l Gos oven wirh grill: Controls

VanTl GtsOJ 2OC7 o t:if 2aC8

@

www.knau

sowne

rs.co

m

14. REFRIGERATOR

www.knau

sowne

rs.co

m

,,::::ft'-' -"

;,,i:;,;.iiii't,.

i::,1;;, ittil ll,iiii

REFRIr,ERATl,R

14. REFRIGERATOR

AITENTION:The electricol ignition hos no function if the mobile homeVolt or 12 Volt supply!

is not connected to the 230

I4.I Refrigerotor RM 7401

r The refrigeroior con be operoted with 230 Volt, l2 Volt or LPG. These operoting modes ore selected with theenergy source selector.

r The refrigerotor hos on outomotic flome detector, which outomoticolly shuts the gos feed off if the flome goes out.

I See the roting plote inside the refrigerotor for its copocity.

l4.l.l Conhols

[0 l]smetiu

I ,,Energy source" selector

2 Operoting disploy {3 LEDs}

3,,Goslelectricol thermostot" rotory knob

l4.l Refrigerotor RM 7401: ControlPonel

NOTE:You will find further informotion in the seporote monuol supplied by the monufocturer.

:a=:::aaa=

wt-tVanTl GBO3 2AC7 c t,i'r'2aAB

www.knau

sowne

rs.co

m

20. MAINTENANCE AND INSPECTION

www.knau

sowne

rs.co

m

ilAI/ilTTNAN CE AND INSPTCIIr,N

20. MAINTENANCE AND INSPECTION

2A.l Servicing

For the soke of rood sofety your mobile home must be regulorly ond properly serviced, iust like o cor.

ATTENTION:r=Corrying out mointenonce work on your mobile home requires speciolist skills

ond knowledge. This is why you should hove your mobile home serviced only byon outhorised service centre.

r= The service centre will stomp your Customer Service Record Book to confirm thotthe leok tests on oll tonks ond pipes, hoses etc. hove been corried out.

r-= lf ony ports need replocing, ensure thot only the monufocturer's originol sporeports ore used.

NOTE:For mobile homes thot ore not used very often, servicing should be corried out onceo yeor ond in plenty of time before the stort of o iourriey.

20.2 lntervols for stotutory testing ond exhoust gos test

Under Section 29 SIYZO, mobile homes under 3.5 t registered in Germony musi be tested every 2 yeors (by TUV,DEKRA); mobile homes over 3.5 t must be tested onnuolly.

ln Germony oll vehicles must olso undergo on exhoust gostest ot the intervols shown in the toble opposite. The teststicker on the front number ploie will tell you when the nexttest is due (see olso section 23.'l ,,Stotutory tests Germony").

NOTE:The relevont regulotions whichopply in other countries must beobserved!

trlginr-

;ft',r'*

lmpedionintervul::

Turbo diesel Yes

Turbo diesel Yes

Petrol engine Yes

0ver 3.5 tonnes

Up to 3.5 tonnes

Annuolly

[very 2 yeors

[very 2 yeors

20.1 lntervols for Exhausl Gos Test (AIJ)

i"rri lril: trtLliliru

:::::::::::::.:::=:i,r

'=ffiVanTl GBO3 2aO7 . A,i'{ 2aC8

@

www.knau

sowne

rs.co

m

IIIAI NT EN AN CE AN D I NSP ECT I O N

tkl!ul-l

Theon-boordgossystemmustbetestedbyogosengineerevery2yeors(seeolsosection23.l Stotutoryiests).

The engineer must issue o gos test certificote certifying thot the gos system hos been tested. The gos test siicker conbe found neor the reor number plote.

20.3 Mointenonce plon for body

Like ony other mochine, your mobile home needs to be properly serviced from iime to time. The scope ond frequencyof this work will depend first ond foremost on the conditions under which the vehicle is used ond operoted.

All servicing work requires speciolist skills ond knowledge. lt is therefore essentiol for this work to be corried out bytroined speciolists.

The following toble only lists the mointenonce ond inspection work thot is corried out on the body of the mobile home.Pleose refer to the seporote FIAT mqnuol for mointenonce ond inspection of the FIAT bose vehicle.

Perform hondover inspection (see worronty booklet| On doy of the hondover

L Check for leoks After I 2 - 14 months- -:*- -"

2. Check for leoks After 24- 26 months

3. Check for leoks After 36 - 38 months

o*:11_il*'iT_* .,_

TUV check ::: ' 'r': -::_ .,:,: , *:f*rn"3-]i -

Gos test ,. " ,t Every 2 yeors ,, ,.'.-''

-

Lubricote support legs Every 6 monlhs

20.2 Superslructure maintenonce plan

'4ili|!.:i : a.ai=. .

ia,a.a=

*..:i:,r:=aa,:.= ..!j2

1,i::t::a:.aa:a::;.:,:::a:;

ti VanTl

' :L::':l:;'1 ''

*"

- '..t: .:,/;.!aaa-: /:i

:= ..:/ ,:.:, ::.;.ai::'4

(,:tsi)-"' 2CC); . l"'i\'2CC.9

www.knau

sowne

rs.co

m

2I , TROUBLESHOOTING ANDFAULT RECTffrcATNN

ffiffiffirW

S)@==f}Y,+\-S

www.knau

sowne

rs.co

m

TROUBLESHOOT ING AND fAU LT RECTIF ICATNN

21. TROUBLESHOOTING AND FAULT RECTIFICATION

) Troubleshooting should be corried out with reference to the following troubleshooting toble.

) lf you ore unoble to deol with molfunctions yourself, you should contoct the Customer Service deportment ot yourlocol KNAUS service centre or ot the opplionce monufocturer (heoter = Trumo, refrigerotor : Dometic, toilet =Thetford etc).

[wltwlls!:*all::i

WARNING:For the soke o[ your own sofety you ore qdvised to hsve repoirs io the bose uehiclecqrried,out by on outhorised service cenhe, especiolly repoirs ond odiustments tothe broke system!

G $'jfEf,tEl|.r'; .:.]:

Foult

Smell of gos, high gos consumpiion.

Couse

Leqk in gos system.

Action

A lmmediotely shut off gossystem, close gos bottlestop volve ond opplionce

No gos. I Top for opplionce is closed.

tops, open doors ond windows ondventilqte. Seek speciolist odvice ond

hqve the gos system checked.Do not operote electricol swilches(e.9. igniiion).Open flomes ond smoking ore strictlyforbiddenl

Open top for oRelionce,

Open gos bottle stop volve.

Woit for outside lemperoture to rise.

Consult quolified eng ineer.

Stop volve on gos bottle is .f"r"j

Outdoor temperoture ""

f"*Propone: -32'CButone: 0 "C

Foulty opplionce.

i, irinr.i;'i1l.i1 lili#

l1!T:@rt+VanTl GBA3 2C)07 . t':)'2AaB

A

www.knau

sowne

rs.co

m

T RAUBLESHAONNG AND TAU LT l(,|CT IF ICAT IO N

%p&

iln* ii **Foult

Heoting will not stort

Action

Connect full gos bottle.

ii".lir,"t n", o"n[ ri"p uotu" onaopplionce top o1e open

lf the heoting hos been ,*,,.n"a offor o long time or the gos bottlehos iust been reconnected, it willtoke o bit longer until ihe gos circu-loies.

Check oll electricol connectionson heoting unll ond securelf necessor/-

Check whether voltoge is ovoiloble(> 1 1 Volt).

Check l3 A {230 V} or i5 A (12 V),

reploce if necessory.

lf ihe overheoting protection hos beentriggered, the heoting con only beswitched on ogoin once it hos cooleddown to I0-20 "C. Before switchingon ogoin, check thot heoting is

properly ventiloted.

Switch off heoiing, woit opprox.30 seconds ond switch heoting bockon ogoin.lf oll previously specified meosuresdo not solve t(e problem, contoct oquolified engineer.

Ensure 230 Volt operotingvoltoge.

I

No gos.

Electricol connections loose.

No voltoge.

O"f".tiu" frr".

Overheoting protection triggered.

Red LED ,,Electronic conholunit blocked" lights up.

Eleckic cortridge does not function. No 230 Volt operoting voltoge.

No 12 Voli operoting voltoge.

Foulty reloy in heoier.

Fuse in distributor box defective,reploce {use.

Check whether the reloys in the heoterswitch (gentle click is heord). lf noclick con be heord, contoct oquolified engineer.

?i::,::?:..::::.=

rii|.tfl cB.c_2 2aa: . ,,,1\,200,q VanTf

www.knau

sowne

rs.co

m

TROU BLESHOANNG AND TAU LT RECIITICAT Il,N

CENTRAT HEATING ALDE CO'IIPACT "::li

Foult Couse

Overheoting protection triggered.

Action

P,;r;;i" ,"r", brton on the top rif hton the front of the heoting unit.lf the overheoting protection hos beentriggered, the heoting con only beswiiched on ogoin once ii hos cooleddown to I O20 "C. Before switchingon ogoin, check thot heoiing is

properly ventiloted.lf oll previously specified meosures donot solve the problem, contoct oquolified engineer.

Cop nut on the exponsion tonkshould be opened slightly, turn thecirculoting pump slightly ond cop nuttightened up ogoin.

Check whether the rubber couplingis seoted properly ond does noiwobble.

Loosen the cop nut, pull the circulotingpump out of the exponsion tonk ondremove foreign body. Reinstoll circulot-ing pump.lf oll previously specified meosures donot solve the problem, contoct oquolified engineer.

Switch on slider switch , position ,,1111"switch setting I or J.

This is not o circuloting pump foult.lf the temperoture in the mobile homedrops below the temperoture sei onihe temperoture controller, the circulot-ing pump switches on.

Check oll electricol connections on ihecirculoting pump ond secure if neces-sory.

Check whether l2 V voltoge is

ovoiloble.lf oll previously specified meosures donot solve the problem, contoci oquolified engineer.

Vibrotions in the circuloting pump. 9irculoting pump is not properlytostened.

The rubber coupling between the motorond the shoft is not properly seoled.

Suciion of the circulotino pump is

blocked by foreign bod!.

Circuloting pump will not stort. Slider switch on Alde control ponelswitched off, position H ,, O " .

Temperoture controller is set lower thonihe octuol room temperoiure.

Elechicol conneciions loose.

No voltoge.

:_

l%l,AiiVanTl GBA3 2AA7 . Att\'24(,\8

www.knau

sowne

rs.co

m

T ROU BLESHAOTNG AND TAU LI r(ECT IT I CATION 'l{tltt, 'tu ft'r.,' /t :',. -

:"'" 'wk .'*":#

' ; "-- " ;. t- 44#.-

HEATING/TRUMATrc €

Foult

Red ,,Fouh" indicotor on Trumoticcontrol ponel lights up.

Red ,,Foult" indicotor on Trumoticconirol ponel floshes.

Green light behind rototing knob is

not lit up on Trumotic control ponel.

Hot woter boiler droins (woter runsout - frost protection volve hosopened).

Antifreeze volve does not closewhen the system is switched on.

Couse

Air in gos line.

Cor lo*.

Foulty fuse.

Operoting volioge too low.

Operotyng voltoge too high,

Fuse in the electronic control unit hostripped.

l5 A fuse in distribution box foulty.

Foulty bockup bottery.

i5 A fuse in distribuiion box foulty.

Voltoge opprox. I I V when moinswitch is in On position ,, 1".

l5 A fuse in distribution box {oulty.

Voltoge opprox. I I V when moinswitch is in On position ,,1".

Bockup bottery foulty or flot.

Moin bottery switch is of[.

ail off opplion." ond s*irch onogoin. After Mo foiled ofiemptsto ignite, wqil l0 minutes beforeswitching on ogoin.

Check thot gos bottle stop volve ondopplionce iop ore open.Connect full gos bottle.

Consu]t Auollfied eng ineer.

Chorge bockup bottery with chorgeror hove chorged.Instoll new bockup bottery.

Consuli quolified engineer.

Fit new fuse.

=*si

Chorge bockup bofl'ery with chorgeror hove chorged. lf necessory fit newbockup bottery.

Fit new fuse.

Chorge bockup boitery.

Fit new fuse.

Chorge bockup bottery.

Check bockup boitery ond chorge,fit new bockup bottery if necessory.

Turn on moin bottery swiich.

7:Lti(,i1ffi:i: :

:i:ii/.dl,rl1l1|,|ffiW GB03 2()C7 . itlY 2OCt VanTl

www.knau

sowne

rs.co

m

T RAUBLTSHOOIIN G AND TAU LT fl(:rt,TIT ICAI NN

ActionFoult

lgnition detectors foil to respond

lflome soes out on

1e]eosins .""jloll

Flome goes out on ,,Low flome".

Couse

Foulty ign ition detector.

lgnition dut".tor ,"nror not correctly.

Consult quolified engineer.

Oairri'nr,t,". detection sensor

odlusted. (do not bend!).The tip of the sensor should proiectobove the burner by 5 mm.The sensor neck should be no morethon 3 mm owoy from the burner ring.Consult o quoli{led engineer if neces-sory.

F ii;' I

ii;,i. i:ai, ...

i,2t1#IVanTl GB'03 2C07 . A,iY 2008

www.knau

sowne

rs.co

m

TRAUBLESHAON NG AND FAULT r(ECT IT I CANON

l2 Volt operoiion of refrigerotor notpossible during lourney.

.i:: ,.

Couse

Automotic circuit breoker-'. *"ra.U"is switched off.

50 A, 30 A or 2 A fuses for bockupboiiery defectlve

Fuses or reloy in chorger defective.

Bockup bottery is flot, bottery voltoge> 2Y.

Bockup botiery is flot, bottery volioge<2Y.

Plug contocts ond connectionsdefective.

Moin bottery switch is off.

30 A fuse under lining of B.pillor onpossenger side defeci ve

2 A fuse under lining "f

g;f f;;";possenger syde defective,

Fuses or relly in chorger defective.

Plug contocis ond connectionsdefective.

Moin bottery switch is off.

30 A fuse under lining of B-pillor onpossenger side defeciive.

50 A fuses (bockup bottery) or 2 Afuse (meosurement line) for bockupbottery defectlve

Foulty reloy in chorger,

llrtn'xl;.;:u+;;;;;';;

.:.r. l/3

tt

Reset outomotic circuii ir""l"r.

Reploce blown fuse.

i""rrrt lr"r,i'J ungin"",.

Chorge bockup bofl'ery withchorger

Sto* the engine ond run for obout30 seconds. Voltoge of bockupbottery increoses to obove 2 V ondchorging storts.

ldeniily foult ond correct.

Turn on moin botery switch.

Reploce blown fuse.

Reploce blown fuse.

i".rrf t quolified engineer.

ldentify foult ond correct.

Turn on moin bottery switch.

Reploce blown fuse.

Reploce blown fuse.

*"0i"." .r","*".

Move l2 V toggle ,*it.i i O.setting ,, I ".

Bockup bottery does not chorgeduring the iourney. Chorging shownby green indicotor lomp on boordconhol (item 2, figure 1 I .2).

GBC3 2()Ai . lli'2003 VanTl

Foult

Bockup bottery does not chorgeduring connection to 230 V moins.Chorging from 230 V moins shownby green indicotor lomp on boordcontrol {item 3, figure 1 1 .2}.

,a:.,!trlliillltl:;:.= ::.:n1 t,i:.,. .::::::;;;,;1:1t1i!iii:::= ;:,ti1;;l: :i.:;:, :,=

r/{1ffi1i1,1il!1 ,

tiW.=4:ii. I liii;;j=,, :.'. ; ,*

www.knau

sowne

rs.co

m

.. fl$'i.:"

TRo UBLESHOONN G AND TAU LT ffr,TIT ICATION

Foult

Co"n light,,Porollel switching botteryI ond boflery ll" on boord controldoes not go out (iiem 2, figure 1 I .2).

ldentify foult ond correct.

Fit new fuse.

Woit for chorge to build up.

Woit for chorge to build up.Green light,,Porqllel swiiching botteryI ond bottery ll" on boord controldoes not light up (item 2, figure 1 1,2).

lndicotor only lights up with chorginghom the 230 Voh moins when bottery ll

volioge hos reoched I4.0 V ond ifbottery lond llore immediotelyswitched to porollel operotion duringthe journey,

Flot bockup boftery.No power from bockup bottery. Chorge the bockup bottery.After dischorging completely severoliimes the bockup bottery be domogedirreporobly.The bottery con olso be dischorgedby opplionces thot ore not switchedon, e.g. SAT system on stondby, TV onstondby, boord conirol, chorger etc.

Colculotion exomple:Dischorge current of 40 mA is flowing:in 24 hrs = 0.96 Ahin 31 doys = 29.76 Ah

A bottery with o copocity o{ 80 Ahhos o residuol copocity of opprox.50o/o ofter 31 doys.The prerequisite is thot bottery wosfully chorged.At low temperotures boflery copocitydecreoses further.

Turn on moin botiery switch.

ldentify foult ond .orr".t.

Moin bottery switch is off.

Foulty coble connections.

VanTl GBAJ 2a)07 o A.iY2008

= ,;.,.,;. ,i!1Ji,i",, ,:,,:

!;(.!/;;:;:::,:,,:.:i%,

i{ivi.#!r, ;ii.tul

Couse Action

Foulty evoporotor (refrigerotor). Consult quollfied engineer.

:::

www.knau

sowne

rs.co

m

T RO U B LESH O OT I N G AN D TAU LT RECT I T I CAN A N

[Wrt&ll<#ill* "-I

:.::::j?,.11

a;1:/,titl

p R EUP.p

Foult

l2 Volt opplionces connot be switchedon with the i 2 V moin switch onboord control (item 6, figure 1 1.2).

I2 Volt opplionces connot be switchedon with the I2 V moin swiich onboord conlrol (item 6, figure 1 1.2).

, ';.. '

Couse

'12 V moin swiich on boord control

is switched o[f, Off seiting ,, C "(item 6, figure I 1.2]l.

Foulry reloy in chorger.

Foulty konsistor in chorger.

50 A, 30 A or 2 A {uses for bockupbottery defective.

Action

Switch on moin swiich,on ,, 1".

Reploce chorger.

Reploce chorger.

position

Level disploy fresh woter tonk orwostewoter tonk does not work(item 5, 9, 11, figure I I.2).

Relox o1 honsisfol 1n 1!1roe1 {efectiye

Plug contocts ond connectionsbetween boord control ond chorgerdefective.

Moin botiery switch is off.

Connection beiween boord conirol ondmeosuring sensor(s) defective

Plug contocts ond connections betweenboord conirol ond chorger defective

Foulty boord control.

Moin bottery switch is off.

Reploce blown fuse.

Reploce chorger.

ldentify foult ond correct.

Turn on moin bottery switch.

ldentify foult ond .orr".t.

ldentify foult ond correct.

*;;r":; ;;;; .;;;;,iTurn on moin botiery switch.

r:t-#,(ffi1%,1)

,1;;::;:1;!i/,:t1t4a.:lllll,fr

;#,ffi[i VanTfL)Ea3 2C0,= o rt,1'( 2a(').q

www.knau

sowne

rs.co

m

TROU BLESHOONNG AND TAU LT RECTITICATNN

:4,!,,f.;l,ililli,

::,,..= a,?titt.tE

','i,tffiffiw:

lnstoll woter hose without k,;i;;;reploce.

Foulty distributor box or boord control. I Consult quohfied engineer.

Foulty woter pump. Hove woter pump reploced by yourCusiomer Service deportmenl of yourlocol KNAUS Service Cenire.

Locote leok, r+clomp supply hoses.Woter leoking in mobile home. I Leok in woier system.

VonTl GB03 2AA7 . A,i|'20C8

Fresh woter tonk empty.

Fuse for the woter pump in thedistributor box is burned oui.

www.knau

sowne

rs.co

m

T ROU BLTSHOOilNG AND TAULT P(ECTII ICATION ffi,,,,r,/4'":);;:'' !1 /i'' 'illr

,//,#/

. ."dl'i$ d 1 .. de;::ll l! i- . | )/r a;n

[%p Iiellk:lv' -i

i

Refrigeroto, a"", ,"i ,*n.f, ".

*ifl230 Volt operoifon

I2 Volt operoiion of refrigerotornot possible dyilO iournef-

Refrigerotor does not switch on in gosmode.

Couse

230 V outomotic circuit breoker inwordrobe hos tripped.

l2 V rocker switch on refrigerotor is

sei to Off setting ,, O ".

Gos bottle stop volve or opplionceshut-off volve closed.

Gos borle empiy.

-;"; ;;;;tic circuit u.."oi",..

Move I2 V toggle switch to Onsetting,, I ".

Open the oppropriote top.

Connect full gos bottle.

GB,A_1 2C0.7 o t.1/20CS WnTt

www.knau

sowne

rs.co

m

22. sPECtFtCATtoilS

www.knau

sowne

rs.co

m

SPECITICATIONSi:'' ::,.='

;tii . ,l:.r':

22. SPECIFICATIONS

22.1 Floor plons

22.1.1 Key to symbols

All obbreviotions possibly occurring in the floor plons of the mobile home ore exploined below.

22.1 Key to symbols

NOTE:Mosses ond weights con vory within t 5 % due to the use of noturql moteriqlsl

iii.l Wi'i ',,1):i

':;':t"":a:1i),,"1 1

Wostewoter tonk, on rollers

Boiler

Roof light

ER

FT

Spore wheel

Fresh woier tcnk

Gos locker flcp

HE

HEB

HTKI Lift ond tih roof

Air conditioning

M-HEKI .;iir Midi-Heki, Mini-Heki

Pt Mushroom vent

REMI REM|roof window

Service flop

ST )ervrce ooor

Thetford flop

Trumo heoter

wZH

LCD television

Centrol heoiing Alde Cornpqel;'

VanTl

@

CBC 2A07 o t:it'2008

www.knau

sowne

rs.co

m

SPECIFICATIl,NS

22.1.2 Specificotions ond floor plons

lEmptyweight=weightofemplyvehicle{inci.toolkitondsporewheel) +diesel tonk(90%full) +driver{Z5kg) +bosicequipment

:....',. t':j';:',r...:a...::-:-'. a.'::::=,:ait:iti ;;r,:li lii|,fililYon-fl 550 MD - 2.2 , l o

:

Von-Tl 550 MDChossis

Engine [kw/hp]

Mox. totolweight [kg]Empty weight [kS] 'Poylood opprox. [kg]

Totol length [mm]Totol width outside [mm]Totol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

Mox. number of persons in vehicle while trovelling

:1: . ;;;,;:;;;:. ;ii ttii].:,i

2.2Liter,100 MuhiietFIAT Ducoto

2.2 Liter 174/lOAl

3,5002,933

667

5,9902,194

2,700/1,9603,454

Sleeping

Reor bed [mm]

Figures not bindingl

2

2,040x1,360/1,260

DL HEB KA DL TK

22.2 Von-Tl550lvlD - 2.2

tilii:ltlliiliti,l.

,ii,ltti.::=

n*2., GBO3 2C)47 . t,'i:'2aCE VanTl

ST BA LG AT M.HEKI KS

lmci_re nc', nct motcir descr pircrl

www.knau

sowne

rs.co

m

I Empty weight = weight of empty vehicle (incl. toolkit ond spore wheel) + diesel tonk (90% full) + driver {75 kg) + bosic equipment

SPTCITICATIONS

ti! il - :..=. .

i|r.a, i '.::::.:..:=

"liitfr2;*:;1

Von-T|550 MDChossis

Ensine [kw/hp]

Mox. totolweight [kg]Empty weight [ks] 'Poylood opprox. [kg]

Totol length [mm]Totol width outside [mm]Toiol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

il;'=','= iii,rii'lF', L "

... i,:.r:li iiiiii

2.3 Liter, I30MultiietFIAT Ducoto

2.3 Liter {95l I 30)

3,5002,833

667

5,9902,190

2,700/1,9603,450

550

Sleeping

Reor bed [mm]

Figures not bindingl

2

2,040x1,360/1,260

Mox. number of persons in vehicle while trovelling

DL HEB KA DL

\

5T BA tG iT M.HEKI KS

n,r.te mo'y' not rotch de:criplicn!

22.3 Van-Tl 550 MD - 2.3

VanTf GB-43 2Ct07 . A1r' 2Ca8

FTTvi0i llcr

www.knau

sowne

rs.co

m

SPECIFICATIl,NS

y";:1i5jg.*p$6;-ii,':;)i1li;-1;,-, :"',;;;;lE-j=,:'l

Von-TI550 MDChossis

Ensine [kw/hp]

Mox. totolweight [kg]Empty weight [kg] 'Poylood opprox. [kg]

Totol length [mm]Totol width outside [mm]Totol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

iiiiEf#==

3.0 Liter,

lli :

Mox. number of persons in vehicle while trovelling 4

Sleeping 2

Reor bed [mm] 2,O40 x 1,360/1,260

550 Figures not binding!

160 MuhiietFIAT Ducoto

3.0 Liter 11l5/157)

3,5002,933

567

5,9902,190

2,7OO/1,9603,450

22-4 ;'1 .,#'

rEmptyweight=weighlofemptyvehicle{incl.toolkitondsporewheel) +diesel tonk(90%full) +driver(75kg) +bosicequipment

lnooe rno\, nol r. ol.h d,.scripl ,:r l

22.4 Van-Tl 550 MD - 3.0

CB03 2C)C7 r /l)':'ll08 VanTl

FTlrr0 !hr

TV

\

www.knau

sowne

rs.co

m

SPECITICATIONS

Von-Tl 600 ME 2.2 Liter, I00 MultiietChossis FIAT DucotoEngine [kw/hp] 2.2Liter 174/100|

Mox. number of persons in vehicle while trovelling -

Sleeping

Mox. totolweight {kglEmpty weight [kg]

,

Poylood opprox. [kg]

Totol length [mm]Totol width outside [mm]Totol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

3,500 Reor bed [mm]

Figures not bindingl

I Empty weight = weight of empty vehicle {incl. toolkit ond spore wheel) + diesel tonk (909," full) + driver (75 kg) + bosic equipmenr

Dt BKADL TK FTlC0 |ller

\

M.HEKI KS

lmoq-. r,ov nr,r. motah descr ptroni

22.5 Von-T|600 ME - 2.2

'|:ijitli ii::::,r ?-;f#f'VonTf GB 0,? 200r,/ . 1,,,r, 2Oa8

tG

www.knau

sowne

rs.co

m

SPECIIICATIl,NS

t ;';)',ilt tllr1 ll,!1i;!.t,

..:::::i-?41 : l!.i

iffi,

.,., :

Van-TI6W ME - 2,3i:

;, :,

Von-Tl 600 ME

Chossis

Ensine [kw/hp]

Mox. totolweight [kg]Empty weight [kg] 'Poylood opprox. [kg]

Totol length [mm]Totol width outside [mm]Totol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

130 MultiietFIAT Ducoto

2.3 Liter (95l130)

3,500

Sleeping

Reor bed [mm]

Figures not bindingl

I Empty weight = weight of empty vehicle (incl. toolkit ond spore wheel) + diesel tonk (90% full) + driver {25 kg) + bosic equipment

inrog-- mo1, ,rct nolcn descr cr r:,r

22.6 Von-T1600 ME - 2.3

Gb C3.2CC7 . 4,'i)' 2(,r0ri VanTl

Dt HEB KA Dt TK FT Tv'11ttr

l5 he

AT M.HEK! KS

www.knau

sowne

rs.co

m

.=' 1/'

SPECIIICANONS

.il;"f,;; ti1tL t,,,::

:i:;.;^fr'q3l-l

; ,;it;:;:=.

Von-Tl 600 ME

Chossis

Ensine lkW/hp]

Mox. totolweight [kg]Empty weight [kg] 'Poylood opprox. [kg]

Totollength [mm]Totol width outside [mm]Totol height outside/inside [mm]Wheelbose [mm]

Mox. towing lood [kg]

FIAT Ducqto3.0 Liter 11l5/157l

3,500

Sleeping

Reor bed [mm]

- Figures not binding!

lEmpt"yweight=weightof emptyvehicle{incl.toolkitondsporewheel) +diesel tonk(907.fu11) +driver(75kg) +bosicequipment

HEB KA Dt

!5 ltyLG AT

TK

\

rrroee moy not rnolar descr pilonl

M.HEKI KSST tG

22.7 Von-f|600 ME - 3.0

VanTl GBO3 2007 o Atrt"2008

'aa:=.

Mox. number of persons in vehicle while trovelling

www.knau

sowne

rs.co

m

SPTCITICANONS

22.2

22.2.r

Poylood

Explonotions on the poylood colculotion

WARNING:r=The permitted totol weight of the mobile home specified in the vehicle

documentotion must not be exceeded!a=,An overlooded mobile home moy go out of controlwhile drivinglrs Looding the mobile home is to be performed occording to section 4.3 ,,Poylood"!rc"Once yoq hove looded up your mobile home, hove it weighed on o public

weighbridge before you set out on your iourney.t= lf the totol weight determined of your mobile home hos exceeded the permitted

totol weighl, oll gucrontee cloims ogoinst the monufocturer ore voided os well osinsuronce cloims!

The poylood is the difference between the permitted totol weight ond the empty weight The respective volue is to betoken from the vehicle documentotion.

EC Directive 92/21/EEC governs the poylood of mobile homes ot Europeon level. The regulotions specified thereinlorgely correspond to stondord DIN EN 1646-2.

22.2.1.1 Empty weight

The empty weight corresponds to the weight of the empfy vehicle (including lubriconts, toolkit, spore wheel, fuel tonk90% full), with foctory-fitted stondord equipment plus the weight of the driver (25 kg) ond the bosic equipment (seesection 22.2.1.2|1.

22.2.1.2 Bosicequipment

The bosic equipment comprises oll items of equipment ond fluids thot ore necessory for the sofe ond proper use of themobile home.

h includes the weights of:

Gos: Liquid gos bottles

Woler: Fresh woter heoterFresh woter iqnk

(up to 90% full)

(100% full)(e0% full)

lllilltilli!1,i1!:i=

llLlllt ttt:-.-::;"''

l,ilff,. =

(,:BC3 2AOl o A,l),20CE VanT{

www.knau

sowne

rs.co

m

SPECIIICATIONS

22.2.1.3 Moximum totolweight

This weight ollows for specific operoting conditions including foctors such os moteriol strength, lood copocity of tyresetc. This weight musi nof be exceeded under ony circumstonces!

NOTE:You will find theond the poylood

moximum technicolly permissible loden moss, the empty weightin the specificotions on poges 22-2 to 22-7.

.,t i,E

'" ";,ffi1,rr],,:" :,j- ')i.t'tili-""=

.'r; ri,,,,1"i,!, ]!!i1.

22.2.2.1 Weights of the occessories

This includes oll items thot ore ovoiloble in oddition to the stondord equipment. The individuol weights of the occessoriescon be found in the weight definitions on poges 22-llto 22-14.

22.2.2.2 Weights of the personol equipment

Personol equipment comprises the weights of oll orticles corried on the vehicle in oddition to the optionol extros, suchcls:

. All persons cqrried (except driver)o Pets

. Clothing ond shoes

o Sonitory orticles, ioilet orticleso Kitchen orticles, crockery, cutlery, etc.. Food ond drinko Sports ond leisure orticles. TV, rqdio, VCR etc.

. Toys

The individuol weights for the personol equipment corried must be occurotely determined ond recorded in full in thelist on poges 22-15 to 22-17 ond odded up.

22.2.2 Weights of the poylood

:i:::::::::, ::r.t:::i!l

,,lt'VanTl GBA3 2A07 o t.\Y 2AaB

www.knau

sowne

rs.co

m

SPECIFICATIl,NS

22.2.3 Formulo for the poylood colculotion

The poylood is colculoted using the following formulo:

::,:.:a:a::=:::il./;/.:$Y:.:::;;=i.r..hjl_!):.:

:.,''',a.::1:Zli/tLill*

=ffi

NOTE:The poylood, i.e. ,,occessories +personol equipment" must notexceed o weight of 617.00 kgoccording to this exomple with theVon-Tl 550 MD!

NOTE:r=The porticulors given in the vehicle registrotion document ore binding for the

specificotions.r=You will find further informotion on the bose vehicle in the seporote operoting

instructions from the monufocturer.t= Other specificotions ore not port of this monuol. These figures ore enclosed with

the mobile home os o seporote monuol.

22.8 Formula for colculating poyload

GBC3 2CA/ . A,1 ,!i 2irCri VanTf

@

@

[olculotion exomple:

www.knau

sowne

rs.co

m

SPTCITICATIONS

22.2.4 Weight definitions of optionol exlros for pockoges qnd occessories

Weigt for KNAUS optionol extros (pockoges) ond occessories ore listed below. lf used, tick the oppropriote items( OK: E ) ond enter the totol in the field provided for this purpose ,,Totol weighr of KNAUS occessories" ot the end of thisweight list where occessories ore not olreody included in the weight given for the mobile home. All weights given ore,,opproximote".

Pockoges

Vqn-Tl Plus pockoge

Silverline pockoge

Electro-Comfort poc koge

Multimedio pockoge.

Multimedio lll pockoge

Sofety pockoge

AAir conditioning for driving cob . .

Air Lift, extro reqr oxle springing . . . .

Air Lift, extro spring Pneumo Lift (1 sei)

Alcove heoter

AL-KO HYF5BA troiler hitch

AL-KO moiorcycle corrier incl. electricol sei . .

Alloy wheel 6 | /2 x l6 .

Awning 3,000 x 2,500 mm

B

Cob occess step. .

Corpeting in cob

Corpeting in living oreo

Coil springs

Cycle corrier for 2 bicycles (reor mounting) . . . .

Cycle corrier for 3 bicycles (reor mounting) . . . .

Cycle corrier in mobile home gorog e for 2 bicycles

Cycle corrier in mobile home goroge for 3 bicycles

5.0 ks OK: E2.5 kg OK: E3.0 kg OK: E3.0 ks OK: E3.0 kg OK: E2.0 kg OK: f

30.0 kg OK: E7.9 kg OK: [17.9 kg OK: [J1.0 kg OK: E

3l .4 kg OK: E45.0 kg OK: E

7.9 ks OK: E23.5 ks OK: E

6.0 kg OK: E6.9 kg OK: E8.3 ks OK: E4.6 ks OK: [l6.0 kg OK: []6.5 kg OK: [l

31 .O kg OK: E33.0 ks OK: [l

D

Disposol hose storoge box for wostewoter. 2.0 kg OK: [l

Pg ',1,:

IWVanTl GB'A3 2AA7 . i\/j'i 2a)C)8

www.knau

sowne

rs.co

m

SPECIIICATNNS ,,,,ffi,ffii,fr;.' ./i: :: .;.;;': s:.! lllll

,*: ' .,.:,il:(' #'-: :-'"#:

;: : ,J:JbF

E

Electric externol reor view mirror 1.0 kg OK: fElectrolux BLIZZARD I 900 oir conditioning . . . 31 .0 kg OK: EElectrolux BLIZZARD 2200 on conditioning . . . 00.0 kg OK: EEngine heot exchonger for hot woter heoter 4.0 kg OK: fl

F

Flot-screen television 3.5 kg OK: t3.0 ks OK: fl1.0 kg OK: E

Folding blind insteod of curtoin

Front mud flops

DuoComfort L with remote indicotor

DuoComfort L

G

Gos cooker

Gloss top

I

lnner spring mottress for fixed beds - exponded foom mottress .

L

Loserline olqrm

Loshing rqilwith 2 ringbolts {models with goroge)

Lottoflex for fixed beds

2.0 ks OK: E1.4 kg OK: [l

14.7 kg OK: f5.0 ks OK: [l

9.5 kg OK: [l

1.5 kg OK: E2.0 kg OK: E3.5 kg OK: U

MMFK 169 coupling heod. . . . . Z5.7kg OK: [iMicrowove (depending on model) . . . . 15.0 kg OK: LlMidi-Heki 5.0 ks OK: EMolto (250488) mororcycle upgrode kit . . . . . 19.5 kg OK: IlMolto motorcycle mounting (for models with goroge) . . i 8.5 kg oK: []Mosquito net door 3.0 kg OK: IlMotorcycle corrier in mobile home goroge . . . . 30.0 kg OK: fMotorcycle corrier, reor mounting, incl. romp . 53.0 kg OK: E

'"::::a:= ta:El;tl1

t:.,,-?.:,,.ffi11 CBC3 2CC)7 r Al),,I'L)CS VanTl

www.knau

sowne

rs.co

m

SPECIIICATIONS

,"..r tttl.tli.lj))

4.. a-::::::aa i l:*t

tn-rai t itit,l

MPK toilet fon, l2 V 2.5 kg OK: f

N

Novigotion system 2.0 kg OK: f

oOmnivent i2 V roof fon . . 5.0 kg OK: EOn-boord bottery chorger, outomotic 250 W 1.8 kg OK: flOnboord gel bottery 80 Ah, odditionol 20.0 k9 OK: fOutside storoge flop 1,000 x 500 mm {reor) 5.5 kg OK: EOutside storoge {lop725 x 1,075 mm 6.7 kg OK: [lOven gos, depending on model . 16.5 kg OK: [lOysierDx65oeriol pockoge... ....25.0kg OK:EOysterDxSsoeriol pockoge... ....27.6kg OK:E

P

Pilot seots (2 pcs.) 72.4kg OK: fPower owning drive . 2.5 kg OK: fl

oQuick clomp support legs, front (2 x kg)

Quick clomp support legs, front, Linnepe, left . .

Quick clomp support legs, front, Linnepe, right .

Quick clomp support legs, reor {2 x 4 kg)

Quick<lomp folding support legs, front, incl. stiffener plote .

Quickclomp folding support legs, reor, incl. stiffener plote .

R

Rodiocobling ....Rodio coss. tuner .

Rodio CD iuner .

Roof hood with l2 V fon .

5

Sofori Room K500 for mounted ownings

8.0 kg OK: E4.0 ks OK: [l4.0 kg OK: E8.0 ks OK: f

20.0 kg OK: f20.0 ks OK: [l

2.0 kg OK: E1.0 ks OK: l-l1.0 ks OK: fI4.5 kg OK: E

20.0 kg OK: E

VanYl GBa3 2C)07 o l,l\'2008

i,r|, il r .:r --::'r' ,

www.knau

sowne

rs.co

m

SPTCIIICAIIONS,ta.= a; :':: I

i -: ,..1

SAMY-Sotoeriol pockoge... ..20.0kgSAT (Astro) oeriol pockoge, monuol 9.0 kg

SAWIKO troiler hitch . . . 35.0 kg

SMV 150 kg copocity motorcycle corrier incl. mountings . . . 77.0kgSolor power system,

.l20 !V . . I5.O kg

Solid foom mottress for fixed beds - exponded foom mottress 2.4kgSupport leg set reor for frome extension AL-KO 8.4 kg

Surfboord ond boot holder KNAUS Swifty 1.9 kg

Surfboord corrier in conjunction with roof bors . 3.2 kg

T

OK: EOK: EOK: []OK: EOK: EOK: [lOK:3OK: fOK: []

50.0 ks OK: []35.0 kg OK: 327.Okg OK: E35.0 kg OK: f

8.6 ks OK: []3.0 ks OK: [l2.0 kg OK: J

2.0 ks OK: E

1.5 k9 OK: t

Top Box S Closs S Combi 550 litre 1225 x 90 x 36 cm) . .

Top Box S Closs Ski 350 litre (225 x 54 x 36) . . .

Top Box S Closs Tovr 370 litrc ,142 x 90 x 36 cm)

Top-Box 142 x 92 x 36 cm TOUR or 225 x 54 x 36 cm SKI

Trock widener (l set)

TV cobling

TV suppori extension

vVideo reversing system

wWheel covers

Totol weight of fNIUS occessories nn!,Eu'

W..tLirt \..=vl:i:.i,ti:: '::'

iw.:

NOTE:On the following poges you con note down the weights of the personol equipmentond odd them up.

CBA3 2CCt= o ,\,\f 2OOS VanT{

@\.,. t ::-l

www.knau

sowne

rs.co

m

tltltt.l.k#;itti:i.t/ll;2

lllt*ttl,l'.

jti

I {it-r,,.=:i.iiinvrir,

SPECIFICANONS

ara,, i a,a,ttr ri,,

;ii**:;r:|;::-

'10,tr:l!;i?:?i :Tim:;l15.

III,IonfII,f o'

If I,IonIII,IonfII,IonII[,IonIf I,IonIII,IonlnI,Io'III,IonfII,IonIII,Io'III,Io'III,IonIII,f o'

fEI,IonIII,IonIIT,IO,lf I,[onInI,Io'lII,IonIlI,f o'

lII,[onII[,IonIII,Ion

22.2.5 Weights of personol equipment

VanTl Gtsa3 2OCa . /\,,1\'2CtAB

www.knau

sowne

rs.co

m

SPECITICATIr,NS

lii:)i=a::a:

i.4;:?.:::= ::,....=.:: :':

?{;:l:f;}-6'

III,IonIII,Io'IlI,IonTII,TO,III,I,.nIII,Io'III,Io'TTT TO,

IIT,IO,III,IonTTT,TO,III,I,.nnII,IonIII,Io'III,IonlI[,Io'nII,Io'In[,IonrIn,ro,If I,IonIII,IonIIf,IonIII,IonIII,Io'NIT,TO,lf I,Ion

GE-'i3 2007 . A'1\'2CO8 VanTI

www.knau

sowne

rs.co

m

',rt ,i*,;,;'"

:.;{.!t. . ,:,

@mffiw

,t,.

SPECIIICANr,NS

+ri tffifl l#.i

tlltrfr ,ti:

22.2.6

ATotol for the KNAUS occessories ond personol equipment

WARNING:Once you hove noted ond odded ,p oll weights os well os those of theKNAUSoccessories ond personol equipment, this totol must be compored with thepossible pcylood of the mobile home. ih" totol must not exceed the figure specifiedfor the possible poylood under ony circumstonces!

My mobile home:

Possible poylood:

TTT TT

nln*'

Totol weight o[ KNAUS-occes- f-- lt-l, --lsories corried: L-J L-"JL-] kg

Totol weight of personol equip- -f-1flmentcorried: [-lL"JL,J kg

Finoltotol: nnn*'

III,IonIlI,f on

III,I*'III,I*'lII,IonII[,[onIlI,EonIIf,IonIII,I*'TTT,T,.,

Totol weight of personol equipment corried . . . . . m[,n on

VanTl CBA3 2O0r' o t\iiv'2008

www.knau

sowne

rs.co

m

SPECIIICATNNS

i! ,4l:: " !, I,r :: lll:lll: ::: ::: ii ;: 1:: : : "d.

22.3 Tyre pressure ond wheel bolt tightening torque toble

22.9 Tyre pressure lable

, ryr*r* , i

t ;.

,ii;ij::;ilti [1l :::i::=.=r: ::: =

if ,. u*

Steel wheel

2ts/70 Rl5Steel wheel

6J x 154.5 I

I

4.5 4.5

Alum. wheel "2ts/70 R15

Alum. wheel *

6l/2x15 5.0 5.5 5.0

Snow choins should not be fitted to tyres morked , * ". Pleose contoct your FIAT deolership.

All tyre pressures opply to tyres when cold ond for o fully loden mobile home.

ffi*iP. ::::: '.-:::a:.a:1: .:,1 tl:.-=',$@rifi j

.,,

ti$Irrcnirg tdfgue

6Jx 15 90 Nm t I0 Nm

6)x16 90 Nm t '10 Nm

90Nmtl0NmMB6Jx I6

61/zJx15 l20Nmtl0Nm

ATSZJx l5 'l20Nm+l0Nm

22.10 Tightening torque toble for rims

GBC3 2C)07 o ,t,'tY 2OAB VanTf;-'-);

';1./.1.1,ii|i::i!.{./.:/.ffi .

,fi,

www.knau

sowne

rs.co

m

23. INIORMATION AND TIPS

e*{*lII

LL

www.knau

sowne

rs.co

m

23. INFORMATION AND TIPS

INTC,RIILANI,N AND TIPS

i::.tlW:': illi,iLllllllll

:: i.l

?;,,fiffi

NOTE:r=All informotion on this poge relotes only to regulotions opplicoble in Germony.t= For iourneys obrood the regulotions in the specific country ore to be observed!

23.r Stotutory tests (Germony)

23.1 Stotutory tests (Germony)

23.2 Accessories to be corried on the vehicle in cqse of emergency (Germony)

Accessories lo be corried inmobile home in cose ofemergency

A Firskid kit

A Hozord worning hiongle

A Fintoid kit

A Hozord worning kiongle

A First{idkit

A Hozord worning hiongle

A Hozord worning lomps

23.2 Accessories to be corried in cose of emergency (Germony)

VanTl Gts"03.2407 . A.tt)' 20aS

Inspection of IPG system by o gosengineer

2yeors | 2yeors

@

www.knau

sowne

rs.co

m

INF0RIIIATNN AND TIPS,/.:a,aa::.. 7;u

/,21,:'i-;,.,:ri:

. l.:.. !;f

23.3 Emergency telephone numbers

aJI

I

. ,irrii'rillil ={E+ltif. ,='1....ry5

i'i'',:!liitffil ,Erst8*

.f,.,&.

:: ::::::::::::: :I I I :UUUt::t:::

ADA( or pwrmr de eaerditrxrmb*&d&wra*jrtore '+, :'

I ,*i*hdl ll'trlt

=i, iir

ffiffi'.i

Belgirm

(0?i/4t9il 00 32r00

t0rlCB Bnrseh, (02) 2 33 22 1 I

074344/ll0,5 9,oo n0ne

Bulgorio

(02) 9t Bi B0

0enmork

35 45 99 00

1'*t

00359IJU

t60

r t2

il2

MAtr!1unirh,0049 {89) 22 2222

(w9lt46

A0At Veile, 79 42 42 85

t9 42 42 854 / /9 42 42 425',

A0At rllunich, ffi 49 (89) 22 22 22

22 22 22Ekialaiilll;,?z

00 45

00 49

-l

00358

0,5 9i,o

0,5 ebo

0,5 ei,o

Bridges Gr. Beit / 0resund

I 12

n0 n0ne

ffi_ffi

Finlond

(oil 158580

112I 11

SAt t1unich,00 49 (89) 22 22 22

(oil // 47 64 N, 02 00 80 B0 t) n0ne

lrurce

(00 53 Bi 45 0000 33

t5

t/A0AC Lyon, (M) 72171222

Al,A( lyon, (0$ /2 1/ 12220,5 qi,

Iolls on motorwoys

Greete

21 0/ 2B 5t lt 00 30r 66./r sr

*t00

ADA(Altren, 21 09 60 l2 66

ta 0,5 em iolls on motorwoys

'&wif.3ffW,1|;l;Kiffiy*t}/r*\

U(

(01 ) 53 83 45 0000 44

999 /112999/n2

Mlontun, (087 05)44 8866

0 BA 0A U 9A I B, 0B 0A 82 82 B2; ltobtre: A ft 22) / 6 23 420,8 9* fl0rie

lrchnd

0t)2 69 30 il999 /11199A /1 t1

M0ublin, (01)61/ 99 99

Dlkn, lB 00 66 // BB0,8 sbo n0ne

lhliir

(06) 49 2t 31

Imofo

(01) 6 t5 Bt 05

irBn2

94

92

ADAI lvloilond, (02) 66 15 9l

BA3t t6,800il 6800

AOAI ZoEeb, (01) 3 44 06 66

I BI: lltoble:0 19 Bl

0,5 9i,o Iolk on motorwoys

Tolh on motorwoys0,5 1i,

'.,.rrM

€frmffiffiL=*!il:.itr,... . rr,J;:a:---;e

,iiha':l:t,'i.:1:t)/:/1:JW

Luxernlruq

fi0352) 4 53 44 5t00352

il2I t3

94

92

I t2

-i!1 t3

I t2

144

IJJ

999

99/

AClluemburg (003 52) 4 50 04 5l

4500451

A0At Belglode,0 03 81 (1 1) 34?21 0l(42) I 8/

A\'li B Den foog, (05 92) 39 05 60

aB 00 0B BB iltobile. 05 92) i9 05 Ai

AlAt litunrh, 00 49 189) 22 22 22

Bt 0a a5 a5

ADII[e.no, 0l 251 2060

I 20 lhr fixed ond natih plwne networir)

ADAI Pmen,10 6l) B 31 98 88

%3/, (022)8259/ 34

0,8 9io n0ne

l,,loredonio

(0t) 6 t5 Bt 05

Nethrlon6

(0 /0) 3 42 06 00

00389

00 3r 0,5 1*

0.2 9io

n0ne

|,iorwoy

23U540A00 47

00 43

00 48

00 35 16

lor some bridges/tunnels

Molorwoy vigneile from 7-60 eurosfunn(01) / r1 54

Pohnd

(a22) 6tl 3011

0,5 e*

0,2 9, Ior (ofiolvitz"(rokow motorwoy

PoilL{ol

0t) B 8t 02 t0

I t2n2

AilAt Bonelom,00 34 (93) 5 08 28 28

Alpue:2 19 42 9l 03t , Aker: 2 28 34 A0 0i 3' 0,5 960 Autobohnen moutpflichtig

Romonio

(ar) 2 30 25 B000 40

961

955

03

a2

A0A( Buhorsi, \21) 223 4525

Bwhorx,2234690or92/l

MAt l'l1unich,00 49 (89) 22 22 22Russio

(0 95) I 3/ 95 0000/

Sweden

(aB)6lAt5N 00 46112

I t2A0A( lt1unich, 00 49 (89) 22 22 22

02091 2? t2,08/ 6/ ?0rl00,2 qr,o

0resund tunnel/bridge

.j1!:4.1r r,ti+)r.i:,;:aa,.-;t8,1X::#GF]O3 2AA7 o N'tY 2AaE VanTl

L,I

VA

00353

00 39

00385

www.knau

sowne

rs.co

m

INTORIilANAN AND IIPS

futryl=r.gsflrffi f}it

(ru!,t.:,,t ,..,

!-.n*.1stc.

rcADI( or po*nor 116 anerpty nunstr&addo*,rm*tmla

Legd tHil1

,lollhlt l

:.' l::i

Swrtzellond

(0 3l) 3 59 4t tl 00 4l144

t 1/

ADAI filunrth, 00 49 (89) ?2 22 22

I 40; t/dlh:03 18 50 53ll0,5!o l,4otonqr vignefie Sfr 40

Serbirl/lonhnegro

(0 tr) i 6t 42 55003 8r

0042r

94

92

ADAI Belgmde, (0 I 1 ) 42 2/ 0/

98/;ltlilk:01 19Bl

00e'0, Mohrumy vigntte from (r 100:re Slovok Republic

(02)5920U00r55

t5B

AM( Pruguq0042 (02) 6l 1043 5l

18124

&Slovenio

232/540000386

lt2n3

ADAI 7oEeb,0 03 85 (1) 3 44 06 50

19 8/n(0v,J m Iolb on motorwoyr

uui4llt lliJIinIR\::il

Spil(0t)/il 54

00345061

u2ADAt Borceloru, 9 35 0B 28 28

I t5 93 33 330,5

j*

0,0 e,b0

Iolb on motorwoys

MtzedRryilk

25/ il 3u1004 20

r55

t5B

I l2

t55

104

t0/

ADA(Plupe,261 104351

fi? 1230/!1otonwy vigntte from k 1 00

-Iuftry

(43'Z'4555100

Hrn$ry

(01)4BBi5N

00 90ADA( lstmh{ (02 12) 2 88 71 90

io AJA1htonbul, (U 12) 2 BB /1 900,5 !m Iolh on nrotorwoys

ihtorwoy ugrcrc from Foi 1,Offi00 36ADACBud@sl, CI61)345 l/ l/I 88; tilohk: (0 6l) 3 45 ll 44

0,0 q*

USA001

911

9 tl

1191112

t t|l 12

ADA( emergency coll centre Florido: l3B&2221 3 73

1'* 003t 00301%01266

tl

2l=3) =4)=

only in citiesoutside lorge citiesFri. i 8.00 to Sun. 22.OOLisbonPorto8.30- 18.00 Uhr8.30- r 8.00

From oll countries without ADAC emergency coll centres, lhe 24-hour service in the ADAC heodquorters in Munichcon be contocied:Telephone: 0O 49 (0) 89 22 22 22 or 00 49 (0) 89 76 76 76.

Stotus: 10/2003lnformotion not guoronteed

VanTl GtsA3 2007 e A,i)'2008

www.knau

sowne

rs.co

m

24. CHECKLIST

www.knau

sowne

rs.co

m

CHECKUST

t-__-lll,{ltryl

24. CHECKLIST

ti jlllltitii,r,tililltVtt!

\::itL:411 t1l t:

tiffifrr

wffiii,:j

I : $""1:iHi:[i:tn',",r:n:;,t :l,i: :?. t"cT::i ;:lX ; :i,l"ti**1i;,"]l Uxnsers hove their trover documents {0"" oK: f

2: 3,.",H'.!:J:J[]"iff;[?*o::xtT:t[i"Jti:ffff,3::iJ;ri?:".i,i:,1,'f,:H,ilt;"*5il:)i:r,:ili."[,fffi:11? rnrormotion oK: E

J; fr tt't" gos tesi certificote still volid {see gos lest sticker}? Check volidity in good time! OK: EOK: E4: Ooyou hove o complete set of spore keys (store seporotely!) for the mobile home ond ony olorm?

$; Hou. oll the necessory servicing work ond inspections been performed on the mobile home ot the correct intervols? OK: E

/' Wosiooding the mobile home performed occording to the specificotions (see section 4.3 ,,Poylood")?

$; ar" oll doors, flops, gos locker, windows, roof lights ond HEKI correctly closed - except forced ventiloiion?

Q; Hou" oll honging lights been removed ond sfored properly?

l0' Or" oll tobles in sleeping position {see section B ,,Sleeping"}?

I ' Are you sure thoi oll contoiners with liquids - including those in the refrigerotor * connot tip over? OK: E

I 3: ,r the poylood securely fostened ogoinst sliding? OK: Effi:ffiffi ffiffi@]ft+ }trffitrmffi *,W

I 5' Oo the first-oid kit (check for completeness!) ond hozord worning triongle stowed where ihey ore eosy to reoch?

t6: hf;'"[t:.".:::T:'i'.ij5#.irfl;:h;",];the co,espondins tools ond o suirobte vehicle iock r""h";;;'; p"''is'rbl"

17: Oroll lights work on the mobile home {testl)?

OK: EOK: flOK: E

VanTl GB03 2CO7 . A,]Y2008

OK: E

l)7 A," the gos bottles securely fostened with fostening skops in the gos locker, ore the gos bottle stop volve ond oll gos tops .lor"d? Ql(; f

www.knau

sowne

rs.co

m

CHECKUSTi-.--**-----ltI r-----dlI I dgl i

I I.rrfl I I

ll{ 11

24.1 Checklist for personol entries

5:

6:

7:

I6:

17:

a:::;4,:ttlYtttt iatii?.::::::::

,' :. :. I ti titittull | )1!.4

,"ffi,iiEL;BC3 2047 ' ,r,1Y200E VanTl

OK: E

www.knau

sowne

rs.co

m

25. INDEX

www.knau

sowne

rs.co

m

1,2,3l2 Volt power supply from bockup

bottery ond chorger

Bockup bottery

Chorger

Exomple showing how to colculote elechicity

consumption (using 80 Ah boffery)

l2 Volt power supply in the living oreo ...................230 Volt power supply (moins voltoge)

AAccessories to be corried on the vehicle

in cose of emergency (Germony)

Additlonol notes on winter comping ......................Adiusting the vehicle seots

Bose vehicle seots

,,Aguti MllAN" vehicle seor

Forword-bock odiustment

Rotory unii

Bockrest odiustment

Armrest odiustment.

AFTER THE IOURNEY

AtR CONDtTtONtNG .........

Airmix.........

Recirculoting oir operotion vio gos heoting

Ouiside oir from below..........Combined setting ..........

Awning

Extending ihe owning

INDEX

Chossis

Checking the mobile home

before storting the journey 4-B

Checklist for personolentries.......... 24-2CHECKTIST 24.1

CLEANING AND CARE

Cleoning ocrylic gloss windows,

body ond top oirscoop 19.4

Cleoning ond core of the

exterior of the mobile home . .. . . .. .. .. l 9- l

Cleoning plostic ports on the

exterior of the mobile home........... . ig"2

i .."i ,. ii:a'+.|

.iliili

I r-6

il-61 t-B

I t-8

r 1.5

il-l

3-t

l9-t

23117-1

4.5

4-5

4-6

4.6

4-6

4-6

4-6

6-t

r 5.1

9-9

Cleoning ond core of the sun owning

Deoling with mould on the owning

Treotment of sliff zip fosteners

Cleoning ond mointenonce of the Midi-Heki

Commissioning the Trumotic .

COOKING AND BAKING ..

DDESCRIPTION AND EQUIPMENT

Driver ond possenger door bqse vehicle

Driving your mobile home

DuoComfort L (outomotic volve

for o tw+boftle gos system)

Utilisotion of DuoComfort

Connecting the DuoComfort L to the gos bottles .....lmportont notes on use of lhe DuoComfort t ..........Chonging the gos bottle on the DuoComfort 1........

DuoComfort L remote stotus indicolor ...................Using in summer

Using in winter

DURING THE ]OURNEY

E

Electricol supply

Emergency telephone numbers

Emptying the hot woter boiler

Empiying the woter system

Emptying the fresh wqter tonk

Empiying the wostewoter tonk

Environmentol notes

Extending the reor lodder

196t9-6

t9-6

t9-5

12.1

r3-t

3-1

5l

9.69-9

9-9

9.9

6.2

6-3

3.2

4-1

7-14

7.13

11-2

4.3

r9-3

19.4(')

95

9-6

9-6

9-7

9-8

9-B

9-BB

Beds

BEFORE THE.JOURNEY.

Blockout blind side window

Blockout blind windscreen

Boord conlrol

Brokes

cCore ond cleoning of the inside of the mobile home ...

Cleoning plostic ports inside the mobile home .......Chonging o wheel

Chonging the gos bottle

9-B

5-t

il-623-2

12-4

10.2

10-2

10-2

2117.17

i: :i:a=I ll:::.::::a.4

a,;t.t ::.=

25-t:::::

VanTl GB-O3 2AA7 . t\tt"r'2Oa8

www.knau

sowne

rs.co

m

INDEXl-ti

ffitrw tl

Extending voriqble seoiing module

Moving out the toble top ..............Exlernol power supply 230 Volt

vio emergency power unil

Using the emergency power unit

Shutting down the emergency power unii....

F

Fire sofeiy

Prevention of fire ho2ords..................

Fire fighting

ln cose o[ fire ..........

Flot-screen television

Moving out ond odlusting the television

Adiusting the resistonce of the television pull-oui.....

Floor plons

Key to symbols .................

Specificotions ond floor plons ...........

FOREWORD

Fresh woter ond wostewoier................

Fresh woter supp|y..........

Furn iture

GGos locker

Gos oven with/withoul grill

Using the gos oven

Spit wilh grill .............

Spit with oven ...........

Gos shutoff volves ..........

Gos shuroff volves for cooker ond refrigerotor .....,.

Gos shutoff volve for heoting/hot woter boiler ......

GAS SUPPLY

Generol informotion on gos consumption

Generol informotion

Generol notes on the gos supply .

Generol notes on winter comping

Generol sofety instructions .............

Sofety inskuctions for fitting reor corrier systems .....

HHeoter.........

Heoting ond hot woter supply with

ALDE Compoct centrol heoting 12-6

Functions on control ponel of centrol heoling ......... 12-6

Optimum heoting comfoil......... l2-8

Circuloting pump ...........

7-15

7.15

I t-9

I t-9

I t-9

2-10

2-10

2 r02-\07-10

7"10

7-11

22-1aa 1LL- I

222HJ-t

I 0-t

3-t

11u-l

13.2

13.2

IJ-J11')

o?

9.2

t2-1

9-t

17-l

24)R,

Exponsion tonk..... . . .

Top up glycol mixture

Ventiloting the heoting syslem

Hot woter supply with ALDE Compoct .................. 12-l I

Hot woter heoting with gos 12-12

Hot woter heoting with 230 Vo|t.............. 12-12

Hoi woier heoting with gos ond 230 Volt ............. 12-12

Empiying the hot woter boiler . . . .. . . .. . 12 13

HEATING AND HOT WATER 12-1

I

lmporiont notes for the sonitory oreo 2-11

23.1

20-1

3-2

r8-3

r B"t

2-1

t-t7.1

92

20-r

20-2

il-l7_A

7a

/-d

7-9

INFORMATION AND TIPS

Kilchen ronge

mobile home ond power point............

Opening the gloss dome

Locking lhe gloss dome

Closing the blockout blind

Opening the blockout blind

12.8

12-B

t2-9

12-9

9-3

9-3

9-t

lntervols for stotulory testing ond exhoust gos test ....

K

tLoying up the mobile home over ihe winter

Loying-up

List ond explonotion for utilised sofety morkings........

List ond explonoiion for utilised sofet'y symbols .........

LIVING

IPG......

MMAINTENANCE AND INSPECTION

Mointenonce plon ............

Moking elechrcol connection between

Midi-Heki

GBil3 2t)(r,- . t,'1\'2ACB VanTl

www.knau

sowne

rs.co

m

INDTX

oObtoining o replocement key ............

Opening ond closing the side door from the inside ...

Opening ond closing the side door from the outside ...

Opening/closing the folding blind

for the ocrylic gloss top oirscoop

Opening/closing the quorter venl ...........

Opening/closing the roof light

Opening/closing the sliding window

Operoling the oir conditioning blizzord

Conhols

Adiusting the direction of oir flow

Outside gos connector

Connecting opplionces to

the outside gos connector

PPorking broke

Poylood

Explonoiions on the poylood colculolion

Empty weight

Bosic equipment ................Moximum totolweight

Weights of the

Weights of the

poylood

occessories

Weights of ihe personol equipment

Formulo for the poylood colculotion

Weight definitions of optionol extros

for pockoges ond occessories ................Weights of the personol equipment

Tolol for the KNAUS occessories

ond personol equipment

Poylood

Looding the mobile home ..,........

Plocing gos bottles in the gos locker ..........POWER SUPPLY

Protection of the electricol

circuits in the mobile home

RRecommended occessories for winter comping ........

Refrigerolor RM Z40lConhols

4-7

727-2

REFRIGERATOR

Refuelling the mobile home

Registering the mobile home

Reusing the mobile home ofter loying

up tempororily or over the winter

sSofety devices

Solety instructions for electricol system .........

Storter bottery ond bockup bottery

Emergency power unil

Sofety instructions for gos system

SAFETY INSTRUCTIONS

Sofety regulotions for porticipotion in rood troffic .....

Seoting |oyou|...........

Servicing

Setting the modes heoting/hot woter preporotion .....

Setting the modes .........

Summer mode ...........

Hot woter only ............

Winter mode...........

Heoiing with controlled woter temperoture ............Heoting without controlled woter temperoiure ........

Heoting with on empty woter system..........

Sefiing up the mobile home with

support legs (occessories) ..............

Extending lhe support legs

Retrocting the support legs

TOILET

Towing ond being towed .

Towing ond being towed .

Towing the mobile home

14.1

5.2

4-l

tB.4

2-3

2-9

2.9

2-9

2-6

2"1

2-3

3-3

12.2

t2-2

12.3

\2.3

12-3

12.3

6-t

6-l

6"1

r 8.1

t6-lt6-t

t-65-4

5-4

7-12

7.4

7.4

7.5

r5-l

t5-t

15.2

9-4

9-4

6-t

22822"8

22-B

22-B

22-9

22.9

22.9

22-9

22-t0

22-11

22-15

22-17

4-2

4-2

9.2

il-t

I l-5

17-2

14-1

14.1

20.1

12-2

12-2

Setting up the mobile home........... 6-l

STEEPING B.]

SPECIFICATIONS... 22.1

Stotutory tests (Germony) .... 231Supershucture 3-l

Supplementory notes 2-11

Switching off the heoter/hol woter boiler ................ 12-4

TTempororily loying up the mobile home

l6iil iffi

', i,wtVanTl GB03 2AC7 . Att)' 2Oa8

www.knau

sowne

rs.co

m

INDEX

TROUBLESHOOTING AND FAULT RECTIFICATION ... 21-1

Tyre pressure ond wheel boh tightening iorque toble... 22.18

Tyres ........... 4-4

Sofety informotion concerning the tyres 4-4

UUsing the gos cooker t3 t

4-1Using the mobile home for the first iime

vVehicle lights on mobile home

Veniiloting the mobile home ..

wWqstewqter disposol

WATER SUPPLY

WINTER CAMPING

ffiij4/t t'l,,,

.,,|l,i,i,,

E:tt tri,li,tli,tr

',.j::j:ffi)lil,ffi,Jt

":l:.fW{ffilii;ffiH,is

4-7

7-1

t0-lt 0.t

17.1

GE,O3 2AA/ o Al)'2C0,3 VanTl

www.knau

sowne

rs.co

m

www.knau

sowne

rs.co

m