1986 mercedes benz 560sl (107.048) v8-5.6l …...1986 mercedes benz 560sl (107.048) v8-5.6l...
TRANSCRIPT
1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967)
Vehicle » Powertrain Management » Computers and Control Systems » Testing and Inspection » Component
Tests and General Diagnostics » Component Tests » Ignition System Test
Test Data
Voltages
Resistances (test data valid from 0C to 100C)
Dwell Angle
• at cranking rpm -- 1-40% or 1-18°
• at 3,500 rpm -- 60-90% or 27-40°
Ignition Timing (firing point)
Spark Plugs
Page 1 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Equipment
• Multimeter -- SUN DMM-5
• Engine tester -- SUN EMT-1019, Master 3, MCM 2110
• Tachometer -- All-Test 3610-MB
Wiring Diagram For Electronic Ignition System
B11/2 Coolant temperature sensor
Page 2 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
L5 Position sensor (via flexplate segments)
N1/2 Ignition control module
R16/1 Reference input resistor (EZL)
S5/3 High voltage distributor
S29/2 Throttle valve switch
T1 Ignition coil
W3 Ground, front left wheel housing (ignition coil)
W11 Ground, engine (wire connection)
X11 Diagnostic socket/terminal TO
a To CIS-E control unit, socket 5
b To engine idle speed control unit, socket 4
c To CIS-E control unit, socket 21
e To plug connection X 26 on engine, socket 3 (circuit 30)
f To plug connection X 26 on engine, socket 1 (circuit 15)
g Not used - ends in wiring harness
NOTE: The ignition system test procedure is divided into two sections:
1. Engine Not Running
The voltage supply, the position indicator, the ignition coil and several functions of ignition control module are
tested.
2. Engine Running
The basic functions of the ignition system are in order, but a fault in ignition adjustment is suspected. The
faults may be caused by the coolant temperature sensor or by the ignition control module itself. They cannot
be evaluated using driving performance since this type of ignition control influences only the emission
characteristics and the fuel consumption data.
1. Engine Not Running
Test Page 1
Page 3 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 1
Page 4 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Test Page 2
Page 5 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Page 6 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 2
Fig. 3
Page 7 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Test Page 3
Fig. 4
2. Engine Running
Test Page 1
Page 8 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 5
Page 9 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Ignition ...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 6
S29/2 Throttle valve switch (idle/full load contact)
X56 Throttle valve switch plug connection
1 Idle contact
2 Common
3 Full load contact
Test Page 2
Page 10 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Igniti...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 7
Page 11 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Igniti...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 8
Fig. 9
Page 12 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Igniti...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Test Page 3
Page 13 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Igniti...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...
Fig. 10
Page 14 of 15ALLDATA Repair - 1986 Mercedes Benz 560SL (107.048) V8-5.6L (117.967) - Igniti...
11/5/2017http://www.alldatapro.com/alldata/PRO~V497460842~C46827~R0~OD~N/0/34870059/5...