27 memory controllers

Memory Controllers 1

Memory Controllers

Memory Controllers 2

Motivation• Many memory controllers have as features:

– Multiple ports– Single port memory devices– SRAM, DRAM, or SDRAM or technology

• Have seen failures in multiple flight systems– Circuit design errors– Risky, complex architectural decisions

Memory Controllers 3

SRAM Technology Overview

Background

Memory Controllers 4

Some SDRAM Features

• Synchronous Timing– Signal generation much simpler than DRAM

• Complex devices with state machines, pipelines, refresh modes, power states, etc.

• Like DRAM, startup sequence required

Memory Controllers 5

Block DiagramMicron, 64 Mbit

4 Banks

Control SignalsSampled

Synchronously

ModeRegister

Memory Controllers 6

Block DiagramMicron, 64 MbitControl Signals

SampledSynchronously

ModeRegister

CKECLK

CS*WE*CAS*RAS*

Memory Controllers 7

Control Signal Interpretation

Function CS* RAS* CAS* WE*

COMMAND INHIBIT H X X XNOP H X X X

LOAD MODE REGISTER L L L LAUTO/SELF REFRESH L L L HPRECHARGE L L H LACTIVE (SEL BANK/ROW) L L H HWRITE L H L LREAD L H L HBURST TERMINATE L H H L

Memory Controllers 8

Example Read w/ Auto PrechargeCAS Latency=2; Burst Length=4

Memory Controllers 9

Load Mode Register CommandAddress Used As Operation Code

A2:A0 Burst Length

A3 Burst Type {Sequential, Interleaved}

A6:A4 CAS Latency

A8:A7 Operation Mode

A9 Write Burst Mode

A11:A10 Reserved

Memory Controllers 10

Load Mode Register CommandExamination of Some Fields - Burst Length

BURST LENGTHA2 A1 A0 M3=0 M3=1 0 0 0 1 1 0 0 1 2 2 0 1 0 4 4 0 1 1 8 8 1 0 0 RESERVED RESERVED 1 0 1 RESERVED RESERVED 1 1 0 RESERVED RESERVED 1 1 1 FULL PAGE RESERVED

Memory Controllers 11

Load Mode Register CommandExamination of Some Fields - CAS Latency

A6 A5 A4 CAS LATENCY 0 0 0 RESERVED 0 0 1 RESERVED 0 1 0 2 0 1 1 3 1 0 0 RESERVED 1 0 1 RESERVED 1 1 0 RESERVED 1 1 1 RESERVED

Memory Controllers 12

Load Mode Register CommandExamination of Some Fields - Op Mode

A8 A7 Operation Mode

0 0 Standard Operation 0 1 RESERVED 1 0 RESERVED 1 1 RESERVED

Memory Controllers 13

State Diagram, Simplified [3]Hitachi 256M SDRAM

PowerOn

Pre-charge

LoadModeReg

Idle

SelfRefresh

AutoRefresh

IdlePowerDownRead/

Write

Lockup states?

Memory Controllers 14

Mode Register and Device StateSpecial Considerations

• Mode Register likely SEU Soft– Test data supports this

• RESERVED states in Mode Register– May be able to load invalid state– May require power cycle– May result in damage to device

• Toggling N/C Pins– May require power cycle to recover– May result in damage to device

• Poor Signal Integrity or Power/Ground Noise– May upset Mode Register: put into a RESERVED state

Memory Controllers 15

What Happens with Heavy Ions?

Memory Controllers 16

Heavy Ion SEUs, 128 Mbit Samsung [2]

KM44S32030B

LET (MeV-cm2/mg)

Cro

ss-s

ectio

n (c

m2 /d

evic

e)

SEE Event SEL

Memory Controllers 17

Heavy Ion SEUs, 256 Mbit [2]

• Samsung– Multiple bit upsets seen– LETTH is around 1 MeV-cm2/mg

• Hitachi– Multiple bit upsets seen– LETTH is around 1 MeV-cm2/mg

Memory Controllers 18

Heavy Ion: Stuck Bits• Reference [1] reports 30 stuck bits on one

128 Mb device, after exposure to a large fluence. Fewer stuck bits observed after being annealed at room temperature, unbiased for one week.

• Reference [2] reports stuck bits for the 256M Samsung devices. The small number of stuck bits annealed within a few weeks in an unbiased condition.

Memory Controllers 19

Loss of Functionalityand other

Unusual Events

RadiationSignal Integrity

Memory Controllers 20

“Large Event” - Samsung [1]

Most or all bits “wrong” were seen a few times for the 128 Mbit Samsung device; it was not seen for the 64 Mbit Samsung SDRAM.

Memory Controllers 21

Loss of Functionality - Early Data• 256M Samsung [2]

– “Often, ‘reset’ (power cycle) is needed to recover from SEFI conditions.” [2]

– Large multiple bit errors (> 100 bits) making an oval patch in the memory

– Multiple-bit errors over many consecutive address locations– Events above may have an increase of about 10 mA in

supply current.• 256 Hitachi [2]

– Also seen. – Anomalous Currents– Ranged from 0.5 to 145 mA [3]

Memory Controllers 22

Loss of Functionality [3]Hyundai 256M (Auto Refresh Operation)

LET (MeV-cm2/mg)

Cro

ss-s

ectio

n (c

m2 /d

evic

e)

10-3

10-4

10-5

10-6

10-7

Memory Controllers 23

Loss of FunctionalityAdditional Issues

• Refreshing MODE Register– Will restore functionality in some cases– But not all!

• Different ways of operating SDRAM can result in different affects from radiation. See Reference [3] for details.

Memory Controllers 24

Loss of Functionality - A SampleSee Ref. 3 for Detailed Data

Self-Refresh Operation: Power Cycle Required

LET HIT256M HYND256M SAM128M SAM256M

4.1 - N/A - N/A12 X N/A X X28 X X X X

- No problemN/A Data Not AvailableX Power Cycle Required

Memory Controllers 25

Design FSM Controllers

Memory Controllers 26

Data Flow

SDRAM

ProducerProcess

ConsumerProcess

Memory Controllers 27

One Flight Hardware ApproachControl Signals Shown

SDRAM

ProducerFSM

ConsumerFSM

Arbitration

OR Gate

FPGA

Arbitration between the FSMs complex, a small error was made, resulting in putting the SDRAM in an illegal state, potentially damaging it, and locking up the entire system.

Memory Controllers 28

Another Flight Hardware DesignControl Signals Shown

SRAM

ProducerFSM

ConsumerFSM

Arbitration

Tri-State Mux

Arbitration between the FSMs complex, a small error was made, resulting in putting glitches into the SRAM, destroying the contents, and locking up the entire system.

Memory Controllers 29

A Reliable Flight Hardware TopologyControl Signals Shown

xRAM

Producer Consumer

Arbiter

ControllerFSM

Timer to refresh

xRAM state

Memory Controllers 30

Some Recommendations for Memory Data Path

• Stuck Bits– These are common place and can weaken EDAC

• Stronger EDAC• Map pages

– May anneal over times• Multiple Bit Errors

– Use EDAC as appropriate

Memory Controllers 31

Some Recommendations for Memory Controllers

• Control Register– Illegal configuration can lockup SDRAM

• May be cleared by reloading; provide either automatic or commandable reload.

• May require power cycling. Support power cycling at either the subsystem or circuit level

– Illegal configuration can damage SDRAM– SDRAM control registers can not be read

• Bummer.

Memory Controllers 32

Some Recommendations for Memory Controllers (cont'd)

• Design a robust, correct arbiter• Design a robust, correct, memory controller• Do not mix the above two logic blocks