colour television - electronica-pt.com · body when handle the lcd.in ... lcd controller u501...
TRANSCRIPT
SERVICE MANUAL
PRINTED IN UK. 2003 C
COLOUR TELEVISION
20VL44
TOSHIBA
CONTENTS
PAGES
Safety instructions 1
Technical specifications 2
Panel Specification 3
Chassis block diagram 4
Scaler block diagram 5
Block diagram of power supply 6
Chassis overwiev 7
Service mode items and explanations 12
Data sheet of important IC’s 17
Recommended Part List 29
Frequency list of channels
30
SAFETY PRECAUTIONS
GENERAL GUIDELINES 1. Always use the manufacturer’s replacement safety
components. The critical safety components marked
with on the schematics diagrams should not be by other substitutes. Other substitute may create the electrical shock , fire or other hazards. Take attention to replace the spacers with the originals. Furthermore where a short circuit has occurred , replace those components that indicate evidence of overheating.
2. After servicing , see that all the protective devices
such as insulation barriers, insulation papers, shields and isolation R-C combinations are correctly installed.
3. When the receiver is not being used for a long time
of period of time , unplug the power cord of the Adaptor from the AC outlet.
Color TFT LCD Module is very sensitive both electrically and physically.Users, therefore, are requested to follow the “Guidance of handling color TFT LCD Module”on the followings.
1 - Be careful not to make scratch on the polarizer.
Surface of polarizer is soft and can be physically damaged easily. Please do not touch, push or rub polarizer surface with materials over HB hardness.
2 - Keep clean the surface. Please wear rubber glove when touch the surface of LCD screen. Please use soft and anti-static material as cleaner.
3 - Keep out of water. Water on/in the LCD may cause electrical short or corrosion. Please wipe out dry or water carefully.
4 - Prevent swift Temperature & Humidity change.
Instantaneous temperature and/or humidity change can make dew or ice which cause nonconformance such as malfunction.
5 High temperature & high humidity reduce the life-time. LCD is not proper to be used at high temperature and high humidity. Please keep specified temperature and humidity condition.
6 - Keep out of Corrosive Gas.
Corrosive gas effect the polarizer and the circuit chemically and cause defects accordingly.
7 - Electrostatic discharge can make Damage
There are electro-static sensitive components such as CMOS in LCD Module. Please earth human body when handle the LCD.In addition, please do not touch the interface connector pin with bare. 8 - Do not operate for a long time under the same pattern
Operating LCD for a long time under the same pattern can cause image persistence and can damage it. Please follow following guidance. 1. Turn the power off when do not use. 2. Change the pattern periodically.
Receiving System PAL B/G+I+D/K SECAM L/L'
Comb Filter Adaptive 4H\2HScaling Upto SXGA at 75HzGamma Correction 8 to 10-bit LUTHistogram Equalization YESStereo Decoding (German A2, Nicam, BTSC) German A2, Nicam
Stereo L, R In 3Stereo L, R Out 3
Audio Output Power RMS in Max at 10% THD) 2x3W, 2x5W for 22"W
Level (1.5, 2.5, Teleweb) Teletext 1.5Type (Fast\Top\Simple) Simple, Fast, TopPage Memory 250p or 10p
WSS +VPS\PDC +
4:3 +16:9 +Panorama +Letterbox +Subtitle +
WSS (Wide Screen Signalling) +
ATS (Automatic Tuning System) Frequency SearchManual Search Channel Table SearchNumber of Program Storage 100No Ident Timer +Picture Freeze +Equalizer +Zapping +AVL (Automatic Volume Level) +Sound Status Memory +Picture Status Memory +Swap +Child Lock +Program Lock +Picture Format Switching Thru Pin 8 +Auto RGB Detect Thru Pin 16 +PC Plug & Play (DDC\CI) +
Off Timer (Sleep Timer) +On Timer +
Picture Smart (User, Soft, Natural, Rich) +Sound Smart (User, Music, Sports, Cinema, Speech) +
Scart 2S-video (DIN) 1AV In (3 RCA) 1AV Out (3 RCA) 1 (ONLY L, R)D-Sub 15 1Headphone 1CVBS In 3Y\C In 1RGB+FB -Video 1RGB+HS, VS In -Graphics 1CVBS Out 2
L5A TECHNICAL SPECIFICATION
Picture Formats(4:3, 16:9, 14:9, Panorama, LetterBox, Subtitle)
Timer
Teletext
14" 15" 17" 17W" 20" 22W" 23W"
Manufacturer AUO
Samsung Hannstar CMO AUO Sanyo
Samsung Samsung CMO AUO Samsung
Interface Single LVDS Double TTL\Single LVDS Dual LVDS Single LVDS Single TTL\Single
LVDS Single LVDS Single LVDS
Resolution VGA (640x480) XGA (1024x768) SXGA (1280x1024) WXGA (1280x768) SVGA (800x600)VGA (640x480) WXGA (1280x720) WXGA (1280x768)
Brightness (cd/m2)> 450 250 300 400 500 450 450
Contrast> 500 300 400 400 500 500 400
Response Time(Tr+Tf) msec < 25 35 25 25 16 25 25
Viewing Angle R\L\H\L > 85/85/85/85 60/60/40/50 70\70\60\60 70/70 50/60 80\80\60\60 85/85 85/85 85/85 85/85
Adaptor Input12V 12V 12V 12V 15V 15V 24V
Power consumptions48W 48W 60W 60W 75W 100W
St-By Power Consumption <3W <3W <3W <3W <3W <3W <3W
Input Range 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz
PANEL SPECIFICATION
YUV
HS/VS
R
LR
BLOCK DIAGRAM OF MAIN CHASSIS (L5A)
Tuner IF Video DecoderVPC 3230D
Teletext DecoderSDA 5550
K6T1008V2ESRAM
(Optional)
M29W040Flash
Memory
MSP3410GAUDIO DECODER
TDA1571Stereo
Amplifier
TDA1308Headphone
Amplifier
Scart 1 SVHS/FAV Scart 2
ScalerStage
VGA-IN EEPROM24LC02
CVBS-IF
SVHS-Y/C SC1-RGB
PANEL
YUV
HS/VS
HS/VS RGB FB CVBSRGB HS/VS
SIF/AM-mono
L
R
LR
EEPROM 24LC16
BLOCK DIAGRAM OF SCALER
Panel_En Standby Mute Reset
BR1_ADJ BLK_EN
HS/VS
RGB
VGA_RGB
VGA HS/VS
GM 5221 U500LCD
CONTROLLER
U501PARALEL
FLASHMEMORY
M29W040B(OPTIONAL)
S505PROGRAMING
CON
U503SERIAL FLASH
MEMORYM25P40
U502EEPROM
24C16
KEYBOARDCON. S509
DAUGHTERBOARD
FOR TTLINTERFACES
S506CONN.
LVDSCONNECTOR
(20 OR 30 PINS)(S503,S502)
BAC LIGHT UNIT S508 (LVDS) S500(TTL)
PANEL
L5A POWER SUPPLY BLOCK DIAGRAM
3.3V-STBY V-INV
DC Jack +15V-STBYF600 15V,12V
1.8V-STBYFuse5A
+8V2.5V
+5V 3.3VINPUT: 12V FOR 14,15,17 INCH 5V-STBY
15V FOR 20, 22 INCH + 12V24V FOR 23 INCH Panel
+12V Power ONLY FOR 23 "
ONLY FOR 20, 22, 23 " +8V
V-INVF601
PNL-EN Power STBY
S602
S600
LM2576U600
LM2576U607
78L08U606
78L12U608
LM1117 1.8VU605
LM1117 3.3V
U602SDI9933ADY
LM117-3.3VU604
78L08U606
V-INV
+5V-STBY
L5-A Low-to-Mid End LCD-TV BOARD OVERVIEW L5-A Low-to-Mid End LCD TV board incorporates the LCD Controller gm2221, to create a high quality, stand-alone LCD-based TV system for consumer applications. Figure 1 illustrates the Block diagram of the board. This board supposed to have two versions:
1. Low-End (to drive 14''-15’’ 4:3 panels) 2. Mid-End (to drive 17’’-20’’ 4:3 and 17’’-22’’-23'' 16:9 panels)
Figure 1 System Block Diagram
L5-A board supports 5 types of video and graphics inputs. These inputs are: Analog terrestrial tuner input for multisystem PAL/SECAM transmission, SCART input (x2), S-VHS input, RCA input and analog PC video input. The analog RGB signals coming from the PC input (via D-Sub15 connector P401) are directly connected to the gm2221 analog input port. One EDID IC (U400) is provided on board to support VESA standard plug-and play compatibility.
LOW TO MID END LCD TV WITH GM2221
Multimedia Tuner
Chroma Decoder
VPC 3230D
CVBS
EXT. CVBS, S-video
Scart RGB, FB
Teletext Decoder +MCU
SDA5550
ITU 656
8-bit
GM2221
ADC+PLL ITU 656
De-interlace Scaling
MCU X86 OSD(4bit\pixel)
2 LVDS Tx
1p, 2p\clk LVDS
15", 17",20''4:3
17''22''16:9TFTLCD
24-bit TTL HS, VS, DE
Upto SXGA at 75Hz
Graphics Upto SXGA at 75Hz
UXGA at 60Hz
RGB, HS, VS
EDID VGA
SDA,SCL
FLASH
NVRAM QSS
Audio Decoder
MSP 3410G
QSS
Ext L/R
HPTDA1308T
HP L/R
AudioAmp TDA1517P
Main L/R
L R
Step Down & Lineer Regulators
12V
5V 3.3V 2.5V
8V
FLASH
SDRAM
Teletext R
GB
, FB
Selected Video
1.8V
On the board, one high quality video decoder (U100) is provided (VPC3230D of Micronas) to process video inputs coming from the video sources. The video processor can process 3 composite video inputs and 1 S-Cideo input from the NTSC/PAL video sources. The CVBS output recovered from the tuner module is made available to one of the video inputs of the video decoder. The digitized video output (in ITU-656 format) from U100 is fed to the dedicated video Port of gm2221 for decoding and processing. Gm2221 makes it possible to perform scaling and de-interlacing for the video input. A 4Mbit serial flash ROM (U503) is used for storing system firmware. Also the footprint for a parallel flash ROM, which can be upto 2Mbits, is available on the board. This option can be used either for development or for production purposes. The gm2221 provides direct connect via the integrated LVDS transmitters to LCD panels with integrated LVDS receivers. Both single LVDS (via S503) and double LVDS(via S502) panels can be supported directly from the L5-A main-board. For single LVDS panels, only S503 connector is soldered on the main-board, which is a 20 pin connector. For Double LVDS panels, only S502 connector is soldered on the main-board, which is a 30 pin connector. For supporting different LVDS panels, different LVDS cables (either single or double LVDS) can be made used. For supporting different single or double TTL panels, a daughter board interface is used via 40 pin S506 connector. On this connector, the signals are 3x8bit RGB with TTL control signals (i.e. HSync, VSync, CLK, O/E etc.) to support a wide variety of LCD panels. Depending on the panel used, different daughter boards will be used to support that particular panel. For single TTL panels, the daughter board will just be a routing the RGB and control signals to the particular connector interface for that particular panel. For double TTL panels, there will be two LVDS receiver IC’s on the daughter board (double TTL is not directly from GM2221 but double LVDS is supporter due to IC packaging problems) to demodulate double LVDS signal into double TTL signal. The LCD panel resolution supported can be up to SXGA at 75 Hz or UXGA at 60 Hz. It is important to note that at any point in time gm2221 could drive only one type of Panel. When LVDS Panel is connected (to connector S503 or S502) ensure that the panel backlight is connected to S508. The integrated PWM output from gm2221 is used to control the LCD panel backlight intensity for dimming functions. The on screen display is implemented using OSD capability of gm2221. Infra Remote (IR) controller connector (S507) is provided as a primary control interface for connecting IR detector to the GPIO of gm2221. An IR remote controller unit and detector provide remote OSD menu access at user convenience.
A keypad connector (S507) is provided which utilizes the integrated low bandwidth ADC in gm2221 for scanning 5-6 keys (menu,V+,V-,P+,P- keys standard- source key optional) on the keypad. The keypad allows access to the OSD without using the remote IR controller. The L5-A board also has In System Programming (ISP) capability for the external flash ROM using DDC2Bi. This can be done using the D-Sub 15 (PC) connector on the board. ISP can also be performed using G-probe through the RS232 interface. One channel of the dual channel FET power switch (U602) is used to control the power sequencing to the LCD panel. Depending on the type of the panel, the input voltage to this FET device can be chosen as shown below: For +3.3V panels J601 is soldered on the main-board For +5V panels J600 is soldered on the main-board For +12V panels J603 is soldered on the main-board An LM2576, a step-down regulator IC (U600), is used to generate the main +5V_STBY voltage on the board. This IC can deliver up-to 3 Ampers of 5Volts. There is no stand-by control for this regulator, which means this IC is always on, as soon as power is supplied to the board. U603(+3.3V_STBY) and U605 (+1.8V_STBY) linear regulators are used to supply the voltage necessary for the GM2221 IC and some peripherals. These voltages are also available in stand-by mode to power the microprocessor inside gm2221, LED, IR receiver IC and EEPROM. These devices are necessary to wake up the board from stand-by state. Second channel of the dual channel FET power switch (U602) is used to control cut some voltages in stand-by mode. These voltages are +5V, +3.3V and +2.5V. These voltages are used by the video processor (VPC 3230D), audio processor (MSP 34x0G), teletext processor (SDA5550), tuner and some peripheral IC’s and circuitry. In order to limit the stand-by power consumption, these voltages are not available in stand-by mode. Also the audio amplifier (TDA1517) is also in its stand-by mode using its dedicated stand-by pin. The board employs MSP3410G, a multi-system audio processor solution from Micronas. The system supports 4 audio input ports, one of which is not used on the L5-A board. Audio output is provided with speaker and headphone jacks (S409, S401) provided on the board. The sound IF signal from the tuner is connected to the audio processor directly.
4. GM2221 LCD TV CONTROLLER The gm2221 IC is a highly integrated single channel scaler that can be used for both LCD monitors up to SXGA/UXGA resolutions and rear projection systems with DLP and HTPS LCD engines up to 1280x720 (720P). Some of the key features include:
• Single processing channel. • RGB and YUV signal processing with RGB to YUV and YUV to RGB color space
converters. • Video signal processing/de-interlacing using spatial, VT (vertical-temporal) diagonal
interpolation. • The on-chip turbo x86 micro-controller is used as the system CPU. • The on-chip OSD controller is available for creating bitmapped OSD menus • The keypad buttons utilize the input of the on-chip low bandwidth ADC. • Software IR decoders is used with an external remote controller. • One of the on-chip PWM outputs is used for controlling back-light intensity • Integrated LVDS transmitters to LCD panels with integrated LVDS receivers.
The LCD panel resolution supported can be up to SXGA resolutions.
6. LCD PANEL INTERFACE The L5-A board can drive panels both with LVDS and TTL interfaces. The footprints for single LVDS and double LVDS connectors are available on the board (S503 and S502, respectively). Either of these connectors can be used without any changes on the board. The TTL interface is supported by a daughter board (S506 is the connector for the daughter board). For the TTL case, connecting the daughter board to the connector will be sufficient.
A Hirose 30-pin connector (S502) is used for double LVDS link from the board to various LVDS panels. This connector can also be used for single LVDS, but another connector footprint (S503) is available for single LVDS purposes. Using only S503 for single LVDS panels decreases the cost. The LVDS traces are routed differentially from the gm2221 IC to the connector. These are 100-Ohm differential traces.
L5A SERVICE MENU
Service Menu is entered by pressing 9, 3, 0, 1 keys on the remote controller when the Picture icon is highlighted in the Main Menu.
Service Menu has 3 sub-menus. These are:
• Options
• Adjustments
• Selections.
Navigation through these menus can be done by pressing OK button. Every adjustment made in this menu is saved automatically.
OPTIONS Options are adjustments that the user can select On or Off.
• BG
• DK
• I
• LL’
• SCART 2
• FAV
• SVHS
• HOTEL MODE
• STAND BY
• MSP CARRIER MUTE
• WSS SCART
• FIRST ATS
BG / DK / I / L Enabling or disabling these options will remove / add these standards to Manual Install menu, SYSTEM item.
SCART 2 / FAV / SVHS If a source is disabled in the Service Menu, it will be skipped during source switches. If SCART2 is enabled, SW assumes that the FAV source share the same path as the SVHS source on the HW. If it is disabled, it is assumed that FAV and SVHS share separate paths. TUNER and SCART1 are enabled by default.
HOTEL MODE Enabling Hotel Mode has two effects. First, SETUP menu is no longer accessible by the user. Second, maximum adjustable volume value is limited to HOTEL VOLUME value. This value can be adjusted in the ADJUSTMENTS sub-menu of the Service Menu.
STAND BY If this Option is OFF, the TV will stay in Stand By mode after a Power On. If this Option is ON, the TV will recall its last stand by status before the Power Off, and switch on from Stand By automatically, if the last state was ‘Stand by On’.
MSP CARRIER MUTE If this option is ON, sound processor’s carrier mute functionality will be enabled. The MSP will mute the sound automatically if the signal quality is bad. Setting this option Off will disable this functionality.
WSS RF / WSS SCART Automatic picture format switching for WSS and Pin8 can be enabled or disabled through this option.
If WSS SCART is set to OFF, AUTO picture format mode will be disabled for SCART1 and SCART2 modes. Pin8 source switching will still be operational, but no picture format changes from Pin8 voltage level will be ignored.
ATS If this option is set to ON, TV will display Country Selection menu in the next start. After some country is selected, the user will be prompted for the start of AutoProgramming process.
ADJUSTMENTS This sub-menu contains numeric adjustments. These items are:
• WHITE R
• WHITE G
• WHITE B
• PRESCALE FM
• PRESCALE NICAM
• PRESCALE SCART
• HOTEL VOLUME
WHITE R / WHITE G / WHITE B These are used for color bias adjustment. Unlike other items in the service menu, changes will take effect immediately.
PRESCALE FM / PRESCALE NICAM / PRESCALE SCART These are prescale values that will be used for the initialization of the sound processor (MSP), at the next switch on.
HOTEL VOLUME This value is used as the volume limit, when the Hotel Mode is on.
SELECTIONS This sub-menu contains selections.
• TUNER TYPE SAMSUNG / PHILIPS
• TELETEXT NO TEXT / FAST / FAST&TOP
• MSP CLIP REDUCE VOL / REDUCE TONE / COMPROMISE / DYNAMIC
TUNER TYPE One of two supported tuner can be selected from this item. System must be restarted for this change to take effect.
TELETEXT NO TEXT: Teletext is totally disabled. TXT/MIX button will not be functional. AUTO picture format mode will be disabled in RF, F-AV and SHVS modes. Naming and sorting functionality during Autoprogramming will be disabled.
FAST: TOPtext functionality will be disabled.
FAST&TOP: TOPtext functionality is enabled.
TIMER MODE If OFF TIMER is selected, the user will be able to enter time of the day info for the TV to switch off. If SLEEP TIMER is selected, the user can specify some time period, after which the TV will go to stand by automatically.
MSP CLIP This selection identifies which method will be used by the sound processor to prevent clipping effects on volume. Details can be found in data sheet msp34x0g_4pd.pdf, page 30.
AUTOPROGRAMMING When the user selects the Autoprogram item in Setup menu, Country Selection menu is opened. The user must select a country before the Autoprogramming starts. Broadcast system will be selected according to the country selected.
Broadcast systems according to countries:
BELGIUM BG + L
CROATIA BG
CZECH REP. DK
DENMARK BG
FINLAND BG
FRANCE L + BG
GERMANY BG
GREECE BG
HUNGARY DK
IRELAND I
ITALY BG
NETHERLANDS BG
NORWAY BG
POLAND DK
PORTUGAL BG
SPAIN BG
SWEDEN BG
SWITZERLAND BG + L
TURKEY BG
UNITED KINGDOM I
For countries France, Belgium and Switzerland, autoprogramming is done twice. For Belgium and Switzerland, first BG channels will be searched, after the search in BG is done, searching will restart for L standard. If the selected country is France, the sequence of standards is reversed, thus, first L then BG.
TELETEXT LANGUAGES L5A SW decides which teletext language group will be used for teletext decoding, according to the country selected for autoprogramming.Teletext languages according to countries:
EAST EUROPE:CROATIA ,CZECH_REP, POLAND
WEST EUROPE: BELGIUM ,DENMARK, FINLAND, UK, FRANCE, GERMANY, IRELAND ,ITALY ,NETHERLANDS, NORWAY, PORTUGAL,SPAIN, SWEDEN, SWITZERLAND, HUNGARY
TURKISH-GREEK:GREECE TURKEY
PC MODE PC mode can be entered by pressing PC button on the remote controller. User can return back to TV mode by pressing the PC or TV buttons.
After the switching to PC mode, VGA input will be displayed on screen, as soon as the mode (input resolution and frequency) is determined.
If there is no input from the VGA input, NO SIGNAL dialog will be displayed for 15 seconds. At the end of this period if there is no signal from VGA input, the TV will go to Sleep State. While in the sleep state, the TV will keep monitoring the VGA input. If VGA signal is detected, the TV will wake from Sleep State, to PC mode. Alternatively, the user may select to switch the TV on from Sleep State, just like switching on from Stand-by. In this case, the set will switch on from TV mode.
ITEM NAME OPTIONS/ VALUES
DEFAULT VALUES OR
SETUPOPTIONS
BG ON/OFF ON
DK ON/OFF ON
I ON/OFF ON
LL' ON/OFF ON
SCART 2 ON/OFF OFF
FAV ON/OFF ON
SVHS ON/OFF ON
HOTEL MODE ON/OFF OFF
STBY ON/OFF OFF
MSP CARRİER MUTE ON/OFF OFF
WSS SCART ON/OFF ON
FIRST ATS ON/OFF OFF
BACKLIGHT POL ON/OFF OFF
FACTORY MODE ON/OFF OFF
ADJUSTMENTS
WHITE R 0-255 128
WHITE G 0-255 128
WHITE B 0-255 128
PRESCALE FM 0-127 37
PRESCALE NICAM 0-127 63
PRESCALE SCART 0-127 27
HOTEL VOLUME 0-63 16
AGC 0-31 23
SELECTIONS
TUNER TYPE PHILIPS SAMSUNG PHILIPS
TELETEXTFAST&TOP NO TEXT
FAST FAST&TOP
MSP CLIPREDUCE TONE COMPROMISE
DYNAMIC DYNAMIC
GENESIS GM5221 LCD TV CONTROLLERThe gm5221 is an LCD TV controller supporting resolutions up to SXGA (1280x1024). The gm5221 leverages Genesis patented advanced image-processing technology as well as a proven integrated ADC/PLL and an Ultra-Reliable DVI™ compliant digital receiver to provide excellent image quality. gm5221 also integrates a microcontroller, an OSD controller, advanced color management and dual LVDS transmitters.
1.1 gm5221 System Design Example
Figure 1 below shows a typical dual interface LCD TV system based on the gm5221. Designs based on the gm5221 have reduced system cost, simplified hardware and firmware design and increased reliability because only a minimal number of components are required in the system.
TUNERPACK
VIDEODECODER
AUDIOPROCESSOR
gm5221
LCD
DISPLAY
AUDIOAMPL
V CHIP
VGA
DVI
YPbPr
MUX
IR KEY BOARD
EEPROM
SVIDEO
CVBS
Figure 1. gm5221 System Design Example
1.2 gm5221 Family Features
• Intelligent Image Processing™ • Fully programmable zoom ratios • High-quality shrink capability from UXGA resolution • Programmable coefficients for variable sharpness control • RealRecovery™ provides full color recovery image for
refresh rates higher than those supported by the LCD panel
• Analog RGB Input Port • Supports SDTV RGB inputs in interlaced mode • Supports EDTV (480p) up to 1080i HDTV inputs • Supports mid level clamp for YPbPr inputs • Macro vision decoding • Supports up to 162 MHz (SXGA 75Hz / UXGA 60Hz) • On-chip high-performance PLLs (single reference crystal
required) • Composite-sync, Sync-on-Green (SOG) and Sync-on-Y
(SoY) support • Input format detection • Phase and image positioning
• Ultra-Reliable DVI-Compliant Input Port • Operating up to 165 MHz (up to UXGA 60Hz) • Direct connect to all DVI 1.0-compliant transmitters • High-bandwidth Digital Content Protection (HDCP)
Note: HDCP function is available H version only.
• CCIR-656 8-bit Video Input Port • Supporting NTSC / PAL interlaced and progressive • Direct connect to commercially available video decoders • Spatial de-interlacing
• Advanced Color Management • Programmable gamma correction (CLUT) • TV color controls including hue and saturation controls • Full color matrix allows end-users to experience the same
colors as viewed on CRTs and other displays (e.g. sRGB compliance)
• Advanced Active Color Management ™ (ACM-II) provide flesh-tone compensation and image enhancement for video preset modes like sport, nature .
• Adaptive Contrast and Color™ (ACC) ensures full dynamic range is used in video content
• On-chip Versatile OSD Controller • On-chip RAM for high-quality programmable menus • 1, 2 and 4-bit per pixel character cells • Horizontal and vertical stretch of OSD menus • Blinking, transparency and blending • Supports two independent OSD menu rectangles • Proportional fonts
• Embedded X86 On-chip Microcontroller • High-performance X86 MCU with on-chip RAM and ROM • External parallel ROM or serial SPI ROM interface • Unified memory architecture simplifies chip programming • 23 general-purpose inputs/outputs (GPIOs) available • 2-wire serial bus master to control NVRAM, video decoder • Two DDC2Bi ports with DMA buffer to internal RAM • Four PWM outputs for analog backlight control, audio, etc. • General-purpose ADC’s for keypad and temperature sensing • Integrated reset circuit • Slow clock mode for 50mW sleep mode power consumption • JTAG debug / ICE support for firmware debugging
• Built-in Test Pattern Generator • Simplifies manufacturing / test
• Energy Spectrum Management (ESM™) • Digital clock spectrum management • Eliminates EMI suppression components and shielding
• Built-in LVDS Transmitters • Four channel 6/8-bit LVDS transmitter • Support for 8 or 6-bit panels with high-quality dithering • Single / double wide up to SXGA 75Hz output • Pin swap, odd / even swap and red / blue group swap of RGB
outputs for flexibility in board layout
• Highly integrated System-on-a-Chip • All system clocks synthesized from a single external crystal • 50mW power saving mode • 5-Volt tolerant inputs • Two Layer PCB support • On-chip reset feature to eliminate external reset component • Integrated Schmitt trigger for HSYNC and VSYNC
PACKAGE • 208-pin PQFP • 3.3V IO and 1.8V core power supplies
2 gm5221 Pinout The gm5221 devices are packaged in a 208-pin Plastic Quad Flat Pack (PQFP).
N/C
N/C
DC
LKJT
AG_R
ESET
RES
ERVE
DR
ESER
VED
RES
ERVE
DR
ESER
VED
RES
ERVE
DR
ESER
VED
RES
ERVE
DJT
AG_T
DO
RES
ERVE
DJT
AG_T
DI
PPW
RPB
IAS
GPI
O15
RES
ERVE
DH
OST
_SC
L/U
ART_
DI
HO
ST_S
DA/
UAR
T_D
OR
VDD
_3.3
CR
VSS
CVD
D_1
.8C
RVS
SD
DC
_SC
L_VG
AD
DC
_SD
A_VG
AD
DC
_SC
L_D
VID
DC
_SD
A_D
VIG
PIO
0G
PIO
1G
PIO
2G
PIO
3G
PIO
4C
VDD
_1.8
CR
VSS
GPI
O5
GPI
O6
GPI
O7/
IRQ
inG
PIO
8/IR
Qou
tG
PIO
9/SC
LG
PIO
10/S
DA
CR
VSS
RVD
D_3
.3C
VDD
_1.8
CR
VSS
GPI
O11
/PW
M0
GPI
O12
/PW
M1
GPI
O13
/PW
M2
GPI
O14
/PW
M3
GPI
O16
/VD
ATA7
GPI
O17
/VD
ATA6 N/C
ROM_DATA3ROM_DATA2ROM_DATA1ROM_DATA0
ROM_OEnROM_WEnROM_CSn
CRVSSCVDD_1.8
RESERVEDAVDD_LV_E_3.3
AVSS_LV_ECH3P_LV_E/ER0CH3N_LV_E/ER1CLKP_LV_E/ER2CLKN_LV_E/ER3CH2P_LV_E/ER4CH2N_LV_E/ER5CH1P_LV_E/ER6CH1N_LV_E/ER7CH0P_LV_E/EG0CH0N_LV_E/EG1
AVSS_LV_EAVDD_LV_E_3..3
AVSS_LVAVDD_LV_3.3
AVDD_LV_O_3.3AVSS_LV_O
CH3P_LV_O/EG2CH3N_LV_O/EG3CLKP_LV_O/EG4CLKN_LV_O/EG5CH2P_LV_O/EG6CH2N_LV_O/EG7CH1P_LV_O/EB0CH1N_LV_O/EB1CH0P_LV_O/EB2CH0N_LV_O/EB3
AVSS_LV_OAVDD_LV_O_3..3
CVDD_1..8CVSS
EB4EB5EB6EB7DENDHSDVS
RVDD_3.3CRVSS
N/C
53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
101
102
103
104
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152
156155154153152151150149148147146145144143142141140139138137136135134133132131130129128127126125124123122121120119118117116115114113112111110109108107106105
AGND_ADCRESERVEDAVDD_ADC_3.3AGND_REDRED-RED+AVDD_RED_3.3AGND_GREENGREEN-GREEN+SOG_MCSSAVDD_GREEN_3.3AGND_BLUEBLUE-BLUE+AVDD_BLUE_3.3CRVSSCVDD_1.8RESERVEDVDD_RXPLL_1.8GND_RXPLLRESERVEDAVDD_RXC_3.3RXC-RXC+AGND_RXCAVDD_RX0_3.3RX0-RX0+AGND_RX0VDD_RX0_1.8AVDD_RX1_3.3RX1-RX1+AGND_RX1VDD_RX1_1.8AVDD_RX2_3.3RX2-RX2+AGND_RX2VDD_RX2_1.8AGND_IMBREXTAVDD_IMB_3.3VCLKGPIO23/VDATA0GPIO22/VDATA1GPIO21/VDATA2GPIO20/VDATA3GPIO19/VDATA4GPIO18/VDATA5N/C
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
RO
M_D
ATA4
RO
M_D
ATA5
CR
VSS
RVD
D_3
.3R
OM
_DAT
A6R
OM
_DAT
A7R
OM
_AD
DR
0R
OM
_AD
DR
1R
OM
_AD
DR
2R
OM
_AD
DR
3R
OM
_AD
DR
4R
OM
_AD
DR
5R
OM
_AD
DR
6R
OM
_AD
DR
7R
OM
_AD
DR
8R
OM
_AD
DR
9R
OM
_AD
DR
10C
RVS
SR
VDD
_3.3
RO
M_A
DD
R11
RO
M_A
DD
R12
RO
M_A
DD
R13
RO
M_A
DD
R14
RO
M_A
DD
R15
RO
M_A
DD
R16
RO
M_A
DD
R17
VSYN
CH
SYN
C/C
SYN
CC
RVS
SC
VDD
_1.8
RES
ETn
LBAD
C_G
ND
LBAD
C_R
ETU
RN
LBAD
C_I
N3
LBAD
C_I
N2
LBAD
C_I
N1
LBAD
C_V
DD
_3.3
AVD
D_R
PLL_
3.3
TCLK
XTAL
AGN
D_R
PLL
RES
ERVE
DVD
D_R
PLL_
1.8
GN
D_R
PLL
VDD
_AD
C_1
.8G
ND
_AD
CN
/CN
/CN
/CN
/CN
/CN
/C
Figure 2. gm5221 Pin Out Diagram
VPC3230D
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
65666768697071727374757677787980
40393837363534333231302928272625
B1/
CB
1IN
G1/
Y1I
NR
1/C
R1I
NB
2/C
B2I
NG
2/Y
2IN
R2/
CR
2IN
AS
GF
NC
VS
UP
CA
PV
SU
PD
GN
DD
GN
DC
AP
SC
LS
DA
RE
SQ
TE
ST
VG
AV
YC
OE
QF
FIE
FFW
EF
FR
STW
FF
RE
FF
OE
CLK
20
GNDFVRT
I2CSELISGNDVSUPF
VOUTCIN
VIN1VIN2VIN3VIN4
VSUPAIGNDAIVREFFB1IN
AISGND
Y0Y1Y2Y3VSUPYGNDYY4Y5Y6Y7GNDLLCVSUPLLCLLC1LLC2VSUPPAGNDPA
AS
GF
XT
AL2
XT
AL1
NC
CLK
5
VS
TB
Y
FP
DA
T
VS
MS
Y/H
S
FS
Y/H
C
AV
O
INT
LC
VS
UP
SY
GN
DS
Y
C0
C1
C2
C3
GN
DC
VS
UP
C
C4
C5
C6
C7
Video Processing - VPC3230D
Video Processing - VPC3230D
1. Features
Video Decoding
- 4 Composite inputs, 1 S-VHS input- Composite video & sync output- integrated high-quality A/D converters- Adaptive 2H comb filter Y/C separator- 1H NTSC comb filter- Multi-standard color decoder(1 Crystal)- Multi-standard sync decoder- Black line detector
Video Decoding
- Horizontal scaling(0.25 to 4)- Panorama vision- Black level expander- Dynamic peaking- Soft limiter(gamma correction)- Color transient improvement
RGB Processing
- Programmable RGB matrix- Digital color bus interface- Additional analog RGB/Fast blank input- Half contrast switch- Picture frame generator
Deflection
- Scan velocity modulation output- High performance H/V deflection- Separate ADC for tube measurements- EHT compensation
Miscellaneous
- One 20.25MHz crystal, few external components- Embedded RISC controller(80 MIPS)- I2C Bus interface- Single 5V power supply- Submicrom COMS technology- 64 pin PSDIP package
I2C BUSProcessing
MatrixContrast
SaturationBrightness
Tint
SYNC+
ClockGeneration
AnalogFront End
ANALOGComponentFront-End
4 x ADC
AdaptiveCombFilter
ColorDecoder
NTSC,PAL,
SECAL
SaturationTint
MIXER 2D Scaler
PIPPanorama
Mode
ContrastBrightnessPeaking
OutputFormatter
ITU-R 656ITU-R 601
MemoryControl
AGC,2*ADC
CIN1
VIN1
VIN2
VIN3
VIN4
VOUT
Y OUT
CrCb OUT
YCOE
FIFOCNTL
20.25MHz
Y
Cr
CbNTSCPAL
ClockGen.
Y
Cr
Cb
FB
Y/G
U/B
V/R
FB
RGB/YCbCr
FB
RGB/YCbCr
LL Clock
H Sync
Vsync
CNTLAVI0
Block Diagram
Video Processing - VPC3230D
PinNo. Pin Name Type Short Description
1 B1/CB1IN IN Blue1/Cb1 Analog Component Input
2 G1/Y1IN IN Green1/Y1 Analog Component Input
3 R1/CR1IN IN Red1/Cr1 Analog Component Input
4 B2/CB2IN IN Blue2/Cb2 Analog Component Input
5 G2/Y2IN IN Green2/Y2 Analog Component Input
6 R2/CR2IN IN Red2/Cr2 Analog Component Input
7 ASGF Analog Shield GND F
9 V SUPCAPSUPPLYD Supply Voltage, Digital DecouplingCircuitry
10 V SUPD SUPPLYD Supply Voltage, Digital Circuitry
11 GND D SUPPLYD Ground, Digital Circuitry
12 GND CAPSUPPLYD Ground, Digital Decoupling Circuitry
13 SCL IN/OUT I 2 C Bus Clock
14 SDA IN/OUT I 2 C Bus Data
8 NC - No connected
15 RESQ IN Reset Input, Active Low
16 TEST IN Test Pin, connect to GND D
17 VGAV IN VGAV Input
18 YCOEQ IN Y/C Output Enable Input, Active Low
19 FFIE OUT FIFO Input Enable
20 FFWE OUT FIFO Write Enable
21 FFRSTW OUT FIFO Reset Write/Read
22 FFRE OUT FIFO Read Enable
23 FFOE OUT FIFO Output Enable
24 CLK20 IN/OUT Main Clock Output 20.25 MHz
25 GND PA SUPPLYD Ground, Pad Decoupling Circuitry
PinNo. Pin Name Type Short Description
26 V SUPPA SUPPLYD Supply Voltage, Pad Decoupling Circuitry
27 LLC2 OUT Double Clock Output
28 LLC1 IN/OUT Clock Output
29 V SUPLLCSUPPLYD Supply Voltage, LLC Circuitry
30 GND LLC SUPPLYD Ground, LLC Circuitry
31 Y7 OUT Picture Bus Luma (MSB)
32 Y6 OUT Picture Bus Luma
34 Y4 OUT Picture Bus Luma
35 GND Y SUPPLYD Ground, Luma Output Circuitry
36 V SUPY SUPPLYD Supply Voltage, Luma Output Circuitry
37 Y3 OUT Y Picture Bus Luma
33 Y5 OUT Picture Bus Luma
38 Y2 OUT Y Picture Bus Luma
39 Y1 OUT Y Picture Bus Luma
40 Y0 OUT Y Picture Bus Luma(LSB)
41 C7 OUT Picture Bus Chroma (MSB)
42 C6 OUT Picture Bus Chroma
44 C4 OUT Picture Bus Chroma
45 V SUPC SUPPLYD Supply Voltage, Chroma Output Circuitry
46 GND C SUPPLYD Ground, Chroma Output Circuitry
43 C5 OUT Picture Bus Chroma
47 C3 OUT Picture Bus Chroma
48 C2 OUT Picture Bus Chroma
Video Processing - VPC3230D
PinNo. Pin Name Type Short Description
51 GND SY SUPPLYD Ground, Sync Pad Circuitry
52 V SUPSY SUPPLYD Supply Voltage, Sync Pad Circuitry
53 INTLC OUT Interlace Output
54 AVO OUT Active Video Output
55 FSY/HC OUT Front Sync/ Horizontal Clamp Pulse
56 MSY/HS IN/OUT Main Sync/Horizontal Sync Pulse
57 VS OUT Vertical Sync Pulse
59 V STBY SUPPLYA Standby Supply Voltage
60 CLK5 OUT CCU 5 MHz Clock Output
61 NC - No connected
62 XTAL1 IN Analog Crystal Input
63 XTAL2 OUT Analog Crystal Output
64 ASGF Analog Shield GND F
58 FPDAT IN/OUT Front-End/ Back-End Data
65 GND F SUPPLYA Ground, Analog Front-End
66 VRT OUT Reference Voltage Top, Analog
67 I2CSEL IN I 2 C Bus Address Select
68 ISGND SUPPLYA Signal Ground for Analog Input, connect to GND F
69 V SUPF SUPPLYA Supply Voltage, Analog Front-End
70 VOUT OUT Analog Video Output
71 CIN IN Chroma / Analog Video 5 Input
72 VIN1 IN Video 1 Analog Input
73 VIN2 IN Video 2 Analog Input
74 VIN3 IN Video 3 Analog Input
75 VIN4 IN Video 4 Analog Input
PinNo. Pin Name Type Short Description
76 V SUPAI SUPPLYA Supply Voltage, Analog Component Inputs Front-End
77 GND AI SUPPLYA Ground, Analog Component Inputs Front-End
78 VREF OUT Reference Voltage Top, Analog Component Inputs Front-End
79 FB1IN IN Fast Blank Input
80 AISGND SUPPLYA Signal Ground for Analog ComponentInputs, connect to GND AI
50 C0 OUT Picture Bus Chroma(LSB)
49 C1 OUT Picture Bus Chroma
MSP3410D
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41
65666768697071727374757677787980
40393837363534333231302928272625
NC
I2C
_CL
I2C
_DA
I2S
_CL
I2S
_WS
I2S
_DA
_OU
T
I2S
_DA
_IN
1
AD
R_D
A
AD
R_W
S
AD
R_C
L
DV
SU
P
DV
SU
P
DV
SU
P
DV
SS
DV
SS
DV
SS
I2S
_DA
_IN
2
NC
NC
NC
RE
SE
TQ
NC
NC
DA
CA
_R
AVSUPAVSUP
ANA_IN1+ANA_IN-
ANA_IN2+TESTENXTAL_IN
XTAL_OUTTP
AUD_CL_OUTNCNC
D_CTR_I/O_1D_CTR_I/O_0
ADR_SELSTANDBYQ
CAPL_MAHVSUPCAPL_ASC1_OUT_LSC1_OUT_RVREF1SC2_OUT_LSC2_OUT_RASG3NCDACM_SUBNCDACM_LDACM_RVREF2DACA_L
NC
NC
AV
SS
AV
SS
MO
NO
_IN
NC
VR
EF
TO
P
SC
1_IN
_R
SC
1_IN
_L
AS
G1
SC
2_IN
_R
SC
2_IN
_L
AS
G2
SC
3_IN
_R
SC
3_IN
_L
AS
G4
SC
4_IN
_R
SC
4_IN
_L
NC
AG
ND
C
AH
VS
S
AH
VS
S
NC
NC
Audio Processing - MSP3440G
PinNo. Pin Name Type Short Description
1 NC Not connected
2 I2C_CL IN/OUT I2Cclock
3 I2C_DA IN/OUT I2C data
4 I2S_CL IN/OUT I2S clock
5 I2S_WS IN/OUT I2S word strobe
6 I2S_DA_OUTOUT I2S data output
7 I2S_DA_IN1 IN I2S1 data input
9 ADR_WS OUT ADR word strobe
10 ADR_CL SUPPLYD Supply Voltage, Digital Circuitry
11 DVSUP SUPPLYD Ground, Digital Circuitry
12 DVSUP SUPPLYD Ground
13 DVSUP IN/OUT I 2 C Bus Clock
14 DVSS IN/OUT I 2 C Bus Data
8 ADR_DA OUT ADR data output
15 DVSS IN Reset Input, Active Low
16 DVSS IN Test Pin, connect to GND D
17 I2S_DA_IN2 IN VGAV Input
18 NC IN Y/C Output Enable Input, Active Low
19 NC OUT FIFO Input Enable
20 NC OUT FIFO Write Enable
21 RESET_Q OUT FIFO Reset Write/Read
22 NC OUT FIFO Read Enable
23 NC OUT FIFO Output Enable
24 DACA_R IN/OUT Main Clock Output 20.25 MHz
25 DACA_R SUPPLYD Ground
PinNo. Pin Name Type Short Description
26 V SUPPA SUPPLYD Supply Voltage
27 LLC2 OUT Double Clock Output
28 LLC1 IN/OUT Clock Output
29 V SUPLLCSUPPLYD Supply Voltage, LLC Circuitry
30 GND LLC SUPPLYD Ground, LLC Circuitry
31 Y7 OUT Picture Bus Luma (MSB)
32 Y6 OUT Picture Bus Luma
34 Y4 OUT Picture Bus Luma
35 GND Y SUPPLYD Ground, Luma Output Circuitry
36 V SUPY SUPPLYD Supply Voltage, Luma Output Circuitry
37 Y3 OUT Y Picture Bus Luma
33 Y5 OUT Picture Bus Luma
38 Y2 OUT Y Picture Bus Luma
39 Y1 OUT Y Picture Bus Luma
40 Y0 OUT Y Picture Bus Luma(LSB)
41 C7 OUT Picture Bus Chroma (MSB)
42 C6 OUT Picture Bus Chroma
44 C4 OUT Picture Bus Chroma
45 V SUPC SUPPLYD Supply Voltage, Chroma Output Circuitry
46 GND C SUPPLYD Ground, Chroma Output Circuitry
43 C5 OUT Picture Bus Chroma
47 C3 OUT Picture Bus Chroma
48 C2 OUT Picture Bus Chroma
50 C0 OUT Picture Bus Chroma(LSB)
49 C1 OUT Picture Bus Chroma
Audio Processing - MSP3410D
PinNo. Pin Name Type Short Description
51 GND SY SUPPLYD Ground, Sync Pad Circuitry
52 V SUPSY SUPPLYD Supply Voltage, Sync Pad Circuitry
53 INTLC OUT Interlace Output
54 AVO OUT Active Video Output
55 FSY/HC OUT Front Sync/ Horizontal Clamp Pulse
56 MSY/HS IN/OUT Main Sync/Horizontal Sync Pulse
57 SC1_in_R IN SCART 1input,right
59 NC Not connected
60 MONO_IN IN Mono input
61 AVSS Analog ground
62 AVSS Analog ground
63 NC Not connected
64 NC Not connected
58 VREFTOP Reference voltage IF A/D converter
65 AVSUP Analog power supply 5V
66 AVSUP Analog power supply 5V
67 ANA_IN+ IN IF input 1
68 ANA_IN- IN IF commoncan be left vacant,onlyif IF input1 is also not in use
69 ANA_IN2+ IN IF inputcan be left vacant,only ifIF input1 is also not in use
70 TESTEN IN Test pin
71 XTAL_IN IN Crystal oscillator
72 XTAL_OUT OUT Crystal oscillator
73 TP Test pin
74 AUD_CL_OUTOUT Audio clock output(18.432MHz)
75 NC Not connected
PinNo. Pin Name Type Short Description
76 NC Not connected
77 D_CTR_I/O_1IN/OUT D_CTR_I/O_1
78 D_CTR_I/O_0IN/OUT D_CTR_I/O_0
79 ADR_SEL IN I2C Bus address select
80 STANDBYQ IN Stand-by(low active)
Audio Processing - MSP3440G
SDA5550 MICROCONTROLLER
BLOCK DIAGRAM
L5A SPARE PART LISTPOSITION BEKO CODE PART DESCRIPTION
056T14-AU1 LCD AU OPTRONICS T140VN01 14" LCD TV056T20-AU1 LCD AU A201SN01 V.3 (20" LCD TV)8R9107-AS SPEAKER 4R 5W LCD TV8R9850-00A ACCESSORIE BOX 17" LCD TV BEKO
8R9953 POWER SWITCH LCD TVY48120 L5 CHASIS 20" DAUGHTER BOARD L5A VERY48121 L5A CHASIS 20" DAUGHTER BOARD CH CHIY48913 ADAPTOR AC 15V 4.6A 20" CLASS IIY92913 ADAPTOR AC12V/5A CLASS II
ZC5850-00A ACCESSORIE BOX 20" LCD TV BEKOZF9110 L5A CHASIS 14"TOS P/NX/1/K/S/VGA/NT A-OS
ZF9187F RC L5A TOSHIBA GRI/SHINE SI.P.ED CT-873ZG4110 L5A CHASIS 20"TOS AU P/NX/2/K/S/VGA/NT
ZG4255-01 BACK COVER TOSH.BRI.SIL.P.20" LCDTV VGAZH1183-CH1 INVERTOR 20" V201V1-T01 (PLCD0318604H)ZH6183-AU3 INVERTOR 14" AUO TAILON TLI-04-0411-A2
F600 054290 FUSE 5.0A 250V ROUNDIR1 452521-01 IR RECEIVER TSOP34838 SS1A
MENU 010844 TACT SWITCH 2 LEG (MTSB)ZC5502-AS CABLE PANEL INTERFACE LCD20" CHIMEIY56502-AS KAB.PANEL INTERFACE LCD TV 15" MOLEX L5AZC5513-AS CABLE PANEL INVERTOR LCDTV FERRIT 20 CHI8R9100-AS CABLE LCD POWER SWITCH L=350MM
S602 031274 JACK POWER HORIZONTALTU201 8R8138-PH1 TUNER FRONTEND PHILIPS FQ1216MEPT/I H-3U100 452937 IC-CHIP VPC3230D-C5 QFP80 T&RU301 453013 IC SDA5550 PLCC-84 TRAYU304 452662-02 IC-CHIP AT24C16AN 10SI2.7 TAPE&REELU400 453010 IC -CHIP M24C02 - MN6T (4.5 - 5.5V) SO8U401 453026 IC-CHIP MSP3410G PQFP80 T&RU402 453021 IC TDA1517PU403 452706-01 IC TDA1308T/N2 SO-G8 (T&R)U500 453296 IC-CHIP GM2221 208PIN PQFP TRAYU502 452662-02 IC-CHIP AT24C16AN 10SI2.7 TAPE&REELU600 453294 IC-CHIP LM2576D2TR4-005V 3A TO263 STPT&RU602 401372 TRN FDS9933AU603 453124 IC-CHIP NCP1117DT33RK TO-252 PACKAGEU604 453124 IC-CHIP NCP1117DT33RK TO-252 PACKAGEU605 453295 IC-CHIP NCP1117DT18RK TO252 (T&R)Y100 056161 CRYSTAL 20.25MHZ HC49-UY300 056953 CRYSTAL 6MHZ CL 20PFY400 056952 CRYSTAL 18.432MHZ +-30PPMY500 056119 CRYSTAL 14.31818MHz CL=18PF30/30PPMHC49U
FREQUENCY TABLE (MHz)
Channel Number BG I DK L/L'
CH 1 49.75 49.75 47.75 CH 2 48.25 59.25 59.25 55.75 CH 3 55.25 77.25 77.25 60.50 CH 4 62.25 85.25 85.25 63.75 CH 5 175.25 93.25 93.25 176.00 CH 6 182.25 175.25 175.25 184.00 CH 7 189.25 183.25 183.25 192.00 CH 8 196.25 191.25 191.25 200.00 CH 9 203.25 199.25 199.25 208.00 CH 10 210.25 207.25 207.25 216.00 CH 11 217.25 215.25 215.25 189.25 CH 12 224.25 223.25 223.25 182.25 CH 13 53.75 45.75 196.25 CH 14 62.25 53.75 210.25 CH 15 82.25 61.75 CH 16 175.25 69.75 CH 17 183.25 95.25 CH 18 192.25 CH 19 201.25 CH 20 210.25 CH 21 471.25 471.25 471.25 471.25 CH 22 479.25 479.25 479.25 479.25 CH 23 487.25 487.25 487.25 487.25 CH 24 495.25 495.25 495.25 495.25 CH 25 503.25 503.25 503.25 503.25 CH 26 511.25 511.25 511.25 511.25 CH 27 519.25 519.25 519.25 519.25 CH 28 527.25 527.25 527.25 527.25 CH 29 535.25 535.25 535.25 535.25 CH 30 543.25 543.25 543.25 543.25 CH 31 551.25 551.25 551.25 551.25 CH 32 559.25 559.25 559.25 559.25 CH 33 567.25 567.25 567.25 567.25 CH 34 575.25 575.25 575.25 575.25 CH 35 583.25 583.25 583.25 583.25 CH 36 591.25 591.25 591.25 591.25 CH 37 599.25 599.25 599.25 599.25 CH 38 607.25 607.25 607.25 607.25 CH 39 615.25 615.25 615.25 615.25 CH 40 623.25 623.25 623.25 623.25 CH 41 631.25 631.25 631.25 631.25 CH 42 639.25 639.25 639.25 639.25 CH 43 647.25 647.25 647.25 647.25 CH 44 655.25 655.25 655.25 655.25
Channel Number BG I DK L/L' CH 45 663.25 663.25 663.25 663.25 CH 46 671.25 671.25 671.25 671.25 CH 47 679.25 679.25 679.25 679.25 CH 48 687.25 687.25 687.25 687.25 CH 49 695.25 695.25 695.25 695.25 CH 50 703.25 703.25 703.25 703.25 CH 51 711.25 711.25 711.25 711.25 CH 52 719.25 719.25 719.25 719.25 CH 53 727.25 727.25 727.25 727.25 CH 54 735.25 735.25 735.25 735.25 CH 55 743.25 743.25 743.25 743.25 CH 56 751.25 751.25 751.25 751.25 CH 57 759.25 759.25 759.25 759.25 CH 58 767.25 767.25 767.25 767.25 CH 59 775.25 775.25 775.25 775.25 CH 60 783.25 783.25 783.25 783.25 CH 61 791.25 791.25 791.25 791.25 CH 62 799.25 799.25 799.25 799.25 CH 63 807.25 807.25 807.25 807.25 CH 64 815.25 815.25 815.25 815.25 CH 65 823.25 823.25 823.25 823.25 CH 66 831.25 831.25 831.25 831.25 CH 67 839.25 839.25 839.25 839.25 CH 68 847.25 847.25 847.25 847.25 CH 69 855.25 855.25 855.25 855.25 CH 70 863,25 863.25 CH 71 871,25 CH 72 879,25 CH 73 887,25 160.00
CH 74 69.25 172.00 CH 75 76.25 220.00 CH 76 83.25 232.00 CH 77 90.25 244.00 CH 78 97.25 256.00 CH 79 59.25 268.00 CH 80 93.25 280.00 S 1 105.25 103.25 103.25 116.75 S 2 112.25 111.25 111.25 128.75 S 3 119.25 119.25 119.25 140.75 S 4 126.25 127.25 127.25 152.75 S 5 133.25 135.25 135.25 164.75 S 6 140.25 143.25 143.25 176.75 S 7 147.25 151.25 151.25 188.75 S 8 154.25 159.25 159.25 200.75 S 9 161.25 167.25 167.25 212.75 S 10 168.25 231.25 231.25 224.75 S 11 231.25 239.25 239.25 236.75 S 12 238.25 247.25 247.25 248.75 S 13 245.25 255.25 255.25 260.75 S 14 252.25 263.25 263.25 272.75
Channel Number BG I DK L/L' S 15 259.25 271.25 271.25 284.75 S 16 266.25 279.25 279.25 296.75 S 17 273.25 287.25 287.25 55.75 S 18 280.25 295.25 295.25 60.50 S 19 287.25 303.25 303.25 63.75 S 20 294.25 S 21 303.25 303.25 S 22 311.25 311.25 311.25 311.25 S 23 319.25 319.25 319.25 319.25 S 24 327.25 327.25 327.25 327.25 S 25 335.25 335.25 335.25 335.25 S 26 343.25 343.25 343.25 343.25 S 27 351.25 351.25 351.25 351.25 S 28 359.25 359.25 359.25 359.25 S 29 367.25 367.25 367.25 367.25 S 30 375.25 375.25 375.25 375.25 S 31 383.25 383.25 383.25 383.25 S 32 391.25 391.25 391.25 391.25 S 33 399.25 399.25 399.25 399.25 S 34 407.25 407.25 407.25 407.25 S 35 415.25 415.25 415.25 415.25 S 36 423.25 423.25 423.25 423.25 S 37 431.25 431.25 431.25 431.25 S 38 439.25 439.25 439.25 439.25 S 39 447.25 447.25 447.25 447.25 S 40 455.25 455.25 455.25 455.25 S 41 463.25 463.25 463.25 463.25
LC CHASSIS TFT- LCD TV SERVICE MANUAL
CONTENTS
PAGES
Safety instructions 1
Technical specifications 2
Power rating and Panel Specifications 3
Remote control explanations 4
Service Menu of the TV 5
Set appearrances 9
Block diagram of the VCTI 10
Block diagram of Microcontroller (Genesis) 11
Block diagram of power supply 12
Data sheet of important IC’s 14
Service mode items and explanations 12
Replacement part List 23
Frequency list of channels
28
SAFETY PRECAUTIONS
GENERAL GUIDELINES 1. Always use the manufacturer’s replacement safety
components. The critical safety components marked
with on the schematics diagrams should not be by other substitutes. Other substitute may create the electrical shock , fire or other hazards. Take attention to replace the spacers with the originals. Furthermore where a short circuit has occurred , replace those components that indicate evidence of overheating.
2. After servicing , see that all the protective devices
such as insulation barriers, insulation papers, shields and isolation R-C combinations are correctly installed.
3. When the receiver is not being used for a long time
of period of time , unplug the power cord of the Adaptor from the AC outlet.
Color TFT LCD Module is very sensitive both electrically and physically.Users, therefore, are requested to follow the “Guidance of handling color TFT LCD Module”on the followings.
1 - Be careful not to make scratch on the polarizer.
Surface of polarizer is soft and can be physically damaged easily. Please do not touch, push or rub polarizer surface with materials over HB hardness.
2 - Keep clean the surface. Please wear rubber glove when touch the surface of LCD screen. Please use soft and anti-static material as cleaner.
3 - Keep out of water. Water on/in the LCD may cause electrical short or corrosion. Please wipe out dry or water carefully.
4 - Prevent swift Temperature & Humidity change.
Instantaneous temperature and/or humidity change can make dew or ice which cause nonconformance such as malfunction.
5 High temperature & high humidity reduce the life-time. LCD is not proper to be used at high temperature and high humidity. Please keep specified temperature and humidity condition.
6 - Keep out of Corrosive Gas.
Corrosive gas effect the polarizer and the circuit chemically and cause defects accordingly.
7 - Electrostatic discharge can make Damage
There are electro-static sensitive components such as CMOS in LCD Module. Please earth human body when handle the LCD.In addition, please do not touch the interface connector pin with bare. 8 - Do not operate for a long time under the same pattern
Operating LCD for a long time under the same pattern can cause image persistence and can damage it. Please follow following guidance. 1. Turn the power off when do not use. 2. Change the pattern periodically.
Receiving System PAL B/G+I+D/K SECAM L/L'
Tuning System PLL FST
Comb Filter Adaptive 4H\2H
LTI, CTI Filters Optional
Sync On Green (SOG) support on graphics YES
Scaling Upto SXGA at 75Hz
Stereo Decoding (German A2, Nicam, BTSC) German A2, Nicam
Virtual Dolby Optional
Subwoofer Optional
YPbPr In (Progressive) Through D-sub 15 conn. Optional
Number of speakers 2 (L+R)Level (1.5, 2.5, Teleweb) Teletext 1.5
TypeNo Text- Optional
Fast Text -OptionalTop Text&Fast-Default
List Mode Optional
Page Memory 10p
Supported Menu Languages
ENGLISH, DEUTSCH, DUTCH, FRANCAIS, ESPAÑOL, ITALIANO, PORTUGUESA,
EHΛΛNIKA, SVENSKA, NORSK, SUOMI, TÜRKÇE, POLSKI, MAGYAR, ČEŠTINA, ROMANESTE, SLOVENČINA, DANSK,
SERBIAN, PЧCCKИЙ, Bulgarian, Crotian>> 22 Languages
4:3 YES
16:9 4:3 Panels: Depends on LCD16:9 Panels: YES
14:9 4:3 Panels: NO16: 9 Panels: Depends on LCD
Panorama NO
Letterbox 4:3 Panels: NO16: 9 Panels: Depends on LCD
Subtitle 4:3 Panels: NO16: 9 Panels: Depends on LCD
Zoom NOWSS (Wide Screen Signalling) Optional
ATS (Automatic Tuning System) Frequency Search
Manual Search Frequency Search
AFT (Auto Fine Tuning) YES
Number of Program Storage 100
No Ident Timer YES
Equalizer YES
AVL (Automatic Volume Level) YES
Sound Status Memory YES
Picture Status Memory YES
Zapping\Swap Optional
Panel Lock YES
Picture Format Switching Through Scart (Pin 8) YES
Auto RGB Detect Through Scart (Pin 16) YES
Timer On\Off or Sleep Optional
Picture Smart Modes YES
Sound Smart Modes YES
Simple Hotel Mode OptionalStby to On in PC modewhen last watched is PC Optional
Stby to On automatically when PC signal is available Optional
Memory Card Reader Optional
Teletext
Picture Formats(4:3, 16:9, 14:9, Panorama, LetterBox, Subtitle)
Wake Up in PC
SPECIFICATIONS
15" 17" 20" 22W" 26" 27" 32"Adaptor Input 12V 12V 15V 24V Built-in Power Built-in Power Built-in Power
Current rating 3A 4A 4A 3A
Power consumptions 48W 60W 75W 100W 130W 130W 130WSt-By Power Consumption <3W <3W <3W <3W <3W <3W <3W
Input Range 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz 100-240V/50, 60Hz100-240V/50, 60Hz 100-240V/50, 60H100-240V/50, 60Hz
Audio Output Power (%10) THD 2X2W 2X3W 2X3W 2X7W 2X7W 2X7W
ManufacturerSamsung CMO AUO
Samsung CMO AUO SamsungSamsung LG-Philips AUO
Chimei Chimei
Interface Double TTL\Single LVDS Dual LVDS Single TTL\Single
LVDS Single LVDS Singlel LVDS Singel LVDS Singel LVDS
Resolution XGA (1024x768) SXGA (1280x1024)
SVGA (800x600)VGA (640x480)
WXGA (1280x720) WXGA (1280x768) WXGA
(1280x720) WXGA (1280x720)
Brightness (cd/m2)> 250 300 500 450 450 550 550
Contrast> 300 400 500 500 400 600 600
POWER RATING AND PANEL SPECIFICATION
1. Picture Format ( )2. Temporary mute of volume (MUTE) ( )3. Numeric buttons4. Audio/Video (AV) ( )5. PC mode transition ( )6. Teletext / MIX / TV choice buttons ( )7. Up (Menu -Teletext) ( )8. Left (Menu) ( )9. Volume UP ( )
10. Volume DOWN ( )11. Red Fastext Button12. Green Fastext Button13. Index Button (P100) ( )14. Question/Answer button (REVEAL) ( )15. UPDATE Button ( )16. SUB PAGE Button ( )17. STAND-BY Button ( )18. Return to Selected Program Button (SWAP) ( )19. TV mode transition button ( )20. Menu Button ( )21. OK Button ( )22. Right (Menu) ( )23. Down (Menu/Teletext) ( )24. Program up button (P+) ( )25. Program down button (P-) ( )26. Blue Fastext Button27. Yellow Fastext Button28. STOP Button ( )29. Teletext enlarge button (DOUBLE) ( )30. Equalizer selection button ( )31. Picture control button ( )
REMOTE CONTROL
OK
1 2 3
4 5 6
7 8 9
0AV SWAP
PC TV
TXT/MIX MENU
VOL+
X
172
1
3
4
20
5 19
6
7
8
9
2221
10
2423
25
1112 27
26
13 28
14 29
15 30
3116
18
VOL-
‹ ?
PR+
PR-
SERVICE MENU OF THE TV
ITEM NAME OPTIONS/ VALUESDEFAULT VALUES OR
SETUPOPTIONSSCART 2 ON/OFF OFF
FAV ON/OFF ON
SVHS ON/OFF ON
HOTEL MODE ON/OFF OFF
STBY RECALL ON/OFF OFF
RECALL LAST AV ON/OFF OFF
MSP CARRIER MUTE ON/OFF OFF
WSS RF ON/OFF ON
AUTO AV 16:9 ON/OFF ON
FIRST ATS ON/OFF OFF
BACKLIGHT POL ON/OFF OFF
FACTORY MODE ON/OFF OFFADJUSTMENTSWHITE R 0-255 128
WHITE G 0-255 128
WHITE B 0-255 128
BRIGHTNESS 0-255 130
CONTRAST 0-257 158
COLOR 0-255 128
PRESCALE FM 0-127 37
PRESCALE NICAM 0-127 63
PRESCALE SCART 0-127 27
HOTEL VOLUME 0-63 16
AGC 0-31 23
FACTORY RESETSW DOWNLOAD
SELECTIONS
TUNER TYPE PHILIPS , SAMSUNG PHILIPS
TELETEXT FAST&TOP , NO TEXT ,FAST FAST&TOP
TIMER MODESLEEP TIMER OFF TIMER SLEEP TIMER
MSP CLIP REDUCE VOL REDUCE VOLUME REDUCE VOL
SWAP/ZAPP ZAPPDOLBY VIRTUEL ON/OFF OFF
LC (L5C) SERVICE MENU
Service Menu is entered by pressing 9, 3, 0, 1 keys on the remote controller when the Picture icon is highlighted in the Main Menu.
Service Menu has 3 sub-menus. These are:
• Options
• Adjustments
• Selections.
Navigation through these menus can be done by pressing OK button. Every adjustment made in this menu is saved automatically.
OPTIONS Options are adjustments that the user can select On or Off.
• SCART 2 • FAV • SVHS • HOTEL MODE • STAND BY • MSP CARRIER MUTE • WSS SCART • FIRST ATS
SCART 2 / FAV / SVHS If a source is disabled in the Service Menu, it will be skipped during source switches. If SCART2 is enabled, SW assumes that the FAV source share the same path as the SVHS source on the HW. If it is disabled, it is assumed that FAV and SVHS share separate paths. TUNER and SCART1 are enabled by default.
HOTEL MODE Enabling Hotel Mode has two effects. First, SETUP menu is no longer accessible by the user. Second, maximum adjustable volume value is limited to HOTEL VOLUME value. This value can be adjusted in the ADJUSTMENTS sub-menu of the Service Menu.
STAND BY If this Option is OFF, the TV will stay in Stand By mode after a Power On. If this Option is ON, the TV will recall its last stand by status before the Power Off, and switch on from Stand By automatically, if the last state was ‘Stand by On’.
MSP CARRIER MUTE If this option is ON, sound processor’s carrier mute functionality will be enabled. The MSP will mute the sound automatically if the signal quality is bad. Setting this option Off will disable this functionality.
ATS If this option is set to ON, TV will display Country Selection menu in the next start. After some country is selected, the user will be prompted for the start of AutoProgramming process.
ADJUSTMENTS This sub-menu contains numeric adjustments. These items are:
• WHITE R • WHITE G • WHITE B • BRIGHTNESS • CONTRAST • COLOR • PRESCALE FM • PRESCALE NICAM • PRESCALE SCART • HOTEL VOLUME
WHITE R / WHITE G / WHITE B These are used for color bias adjustment. Unlike other items in the service menu, changes will take effect immediately.
PRESCALE FM / PRESCALE NICAM / PRESCALE SCART These are prescale values that will be used for the initialization of the sound processor (MSP), at the next switch on.
HOTEL VOLUME This value is used as the volume limit, when the Hotel Mode is on.
SELECTIONS This sub-menu contains selections.
• TUNER TYPE SAMSUNG / PHILIPS
• TELETEXT NO TEXT / FAST / FAST&TOP
• MSP CLIP REDUCE VOL / REDUCE TONE
TUNER TYPE One of two supported tuner can be selected from this item. System must be restarted for this change to take effect.
TELETEXT NO TEXT: Teletext is totally disabled. TXT/MIX button will not be functional. AUTO picture format mode will be disabled in RF, F-AV and SHVS modes. Naming and sorting functionality during Autoprogramming will be disabled.
FAST: TOPtext functionality will be disabled.
FAST&TOP: TOPtext functionality is enabled.
TIMER MODE If OFF TIMER is selected, the user will be able to enter time of the day info for the TV to switch off. If SLEEP TIMER is selected, the user can specify some time period, after which the TV will go to stand by automatically.
MSP CLIP This selection identifies which method will be used by the sound processor to prevent clipping effects on volume.
AUTOPROGRAMMING When the user selects the Autoprogram item in Setup menu, Country Selection menu is opened. The user must select a country before the Autoprogramming starts. Broadcast system will be selected according to the country selected.
Broadcast systems according to countries:
BELGIUM BG + L CROATIA BG CZECH REP. DK DENMARK BG FINLAND BG FRANCE L + BG GERMANY BG GREECE BG HUNGARY DK IRELAND I ITALY BG NETHERLANDS BG NORWAY BG POLAND DK PORTUGAL BG SPAIN BG SWEDEN BG SWITZERLAND BG + L TURKEY BG UNITED KINGDOM I
For countries France, Belgium and Switzerland, autoprogramming is done twice. For Belgium and Switzerland, first BG channels will be searched, after the search in BG is done, searching will restart for L standard. If the selected country is France, the sequence of standards is reversed, thus, first L then BG.
TELETEXT LANGUAGES L5C SW decides which teletext language group will be used for teletext decoding, according to the country selected for autoprogramming.Teletext languages according to countries:
EAST EUROPE:CROATIA ,CZECH_REP, POLAND
WEST EUROPE: BELGIUM ,DENMARK, FINLAND, UK, FRANCE, GERMANY, IRELAND ,ITALY ,NETHERLANDS, NORWAY, PORTUGAL,SPAIN, SWEDEN, SWITZERLAND, HUNGARY
TURKISH-GREEK:GREECE TURKEY
PC MODE PC mode can be entered by pressing PC button on the remote controller. User can return back to TV mode by pressing the PC or TV buttons.
After the switching to PC mode, VGA input will be displayed on screen, as soon as the mode (input resolution and frequency) is determined.
If there is no input from the VGA input, NO SIGNAL dialog will be displayed for 15 seconds. At the end of this period if there is no signal from VGA input, the TV will go to Sleep State. While in the sleep state, the TV will keep monitoring the VGA input. If VGA signal is detected, the TV will wake from Sleep State, to PC mode. Alternatively, the user may select to switch the TV on from Sleep State, just like switching on from Stand-by. In this case, the set will switch on from TV mode.
SET APPEARANCE OF 26-32 INCH
Back light module (Built-in Panel)
Main Chassis
Audio Amplifier Power Supply board
SET APPEARANCE OF 15-23 INCH
Main Chassis
Back light module
HEADPHONEAMPL.TDA1308
AUDIO AMPL.MAX9704
MULTISYSTEMTUNER
SAWFILTER IF INPUT
SC1-AUDIO-OUT
SC2-AUDIO-OUT
SC1 AUDIO-IN
RGB-IN
SC1-CVBS-IN
SC2-CVBS-IN
SVHS-C/Y IN
RCA-CVBS-IN
SC1-CVBS-OUT
SC2-CVBS-OUT
VCTI ICPSS DIP88
U303
Aout1 R/L
Aout2 R/L
Ain2 L/R
Ain1 L/R
VCT-R
GB-O
UT
VS-VCTHS-VC
T
SUBWOOF. SUBWOOFER AMP.MP7731
SUBWOOFERSPEAKER
RESET Q
L/R OUT
MUTE
HEADPHONEJACK
SPEAKERS
SCART 1
SCART 2
CVBSRCA-IN
SVHS IN
EEPROM24LC02
VGASOCKET
MEMORYCARD
RGB-DSUB
HS/VS-DSUB
RGB-SD
HS/VS-SD
RGBSWITCHPI3V512
PC-SD-SW
RGB-SW
HS/VS-SW
2nd RGBSWITCHPI3V512
S1-MAIN
-SW
RGB-G
HS/VS-G
AUDIO-R/LMEMORY CARD
AUDIO-R/L-RCA
CD4053
AUDIOSWITCH
MEMORY CARDRCA SWITCH
CD4053
AUDIOSWITCH
AUDIO-R/L-SC2
MR-R/L
RCA-S2-SWITCH
Ain1R
Ain1L
OPTIONAL OPTIONAL
OPTIONAL
OPTIONAL
BLOCK DIAGRAM OF VCTI AND PERIPHERALS
BLOCK DIAGRAM OF GENESIS IC AND PERIPHERALS
U20
0 G
M52
21-1
GEN
ESIS
LC
D T
V C
ON
TRO
LLER
RESET Q
RGB-G
HS/VS-G
KEYBOARD
IR INPUT
U201 EEPROM24LC16
U203SERIAL FLASH
25VF040
SCART1 PIN 8
SCART2 PIN 8
STANDBY
STANDBY 2
24 BIT RGB OUTPUTTO LVDS INTERFACE
HS/VS
PANEL CTRL
DE
CLOCK
PANEL EN
LED
LED 2
S1-MAIN-SW
PC-SD-SW
MEMORY CARD-RCA SW
RCA-S2-SW
BACKLIGHT-EN
BRT-ADJ.
PANEL PWR
BACK LIGHTCONNECTOR
MUTE S202 SWUPDATE CONN.
UART RX/TX
BLOCK DIAGRAM OF 14-23 INCH POWER SUPPLY
U602 MP1593STEP DOWNCONVERTOR
U604SI9933
MOSFETPOWERSWITCH
U603 LM1117
2 1
15"-17" 12V20" 15V
S601
INV
_PO
WA
MP
_PO
W
INV_
PO
WAM
P_PO
W
S600
F600FUSE 5A
GND
1 2 3 4 5 6 7
43
21
S602GND
24V
SUB_
POW
F601FUSE 5A
OPTIONAL FOR 14"-17"-20"
OPTIONAL FOR 20"W- 22"-23"
12V(15V) U600 MP1593
STEP DOWNCONVERTOR
U601 LM1117
1.8V STBY
3.3V STBY
5V_STBY
VOLTAGEDOUBLER
33V For Tuner
PNL_EN
STBY
U606LM1117
U605MC78L08
8V
PANEL POWER
5V
3.3V
S603
Tuner Supply
123456789
10
123
456
7
24V
GND
Stand-by 2
12V
GND
S101
JP100
U100 MP1593STEP DOWNCONVERTOR
U600 MP1593STEP DOWNCONVERTOR
Enable
U101 MC34063STEP-UP
CONVERTOR
U605 MC78L08
U604SI9933
MOSFETPOWERSWITCH
U601 LM1117
U603 LM1117
24V
12V
PNL_PWR
12V-- R101 150K R609 220K R102 10K5V-- R101 56K R609 NI R102 18K
5V _ STBY
AMP_POW_S
STBY
AMP_POW
5VU606 LM1117
3V3
8V
33V ForTuner
AM
P_P
OW
_S
INV_
PO
W
3V3_STBY
1V8_STBY
BLOCK DIAGRAM OF 26 - 32 INCH POWER SUPPLY
GENESIS GM5221 LCD TV CONTROLLERThe gm5221 is an LCD TV controller supporting resolutions up to SXGA (1280x1024). The gm5221 leverages Genesis patented advanced image-processing technology as well as a proven integrated ADC/PLL and an Ultra-Reliable DVI™ compliant digital receiver to provide excellent image quality. gm5221 also integrates a microcontroller, an OSD controller, advanced color management and dual LVDS transmitters.
1.1 gm5221 System Design Example
Figure 1 below shows a typical dual interface LCD TV system based on the gm5221. Designs based on the gm5221 have reduced system cost, simplified hardware and firmware design and increased reliability because only a minimal number of components are required in the system.
TUNERPACK
VIDEODECODER
AUDIOPROCESSOR
gm5221
LCD
DISPLAY
AUDIOAMPL
V CHIP
VGA
DVI
YPbPr
MUX
IR KEY BOARD
EEPROM
SVIDEO
CVBS
Figure 1. gm5221 System Design Example
1.2 gm5221 Family Features
• Intelligent Image Processing™ • Fully programmable zoom ratios • High-quality shrink capability from UXGA resolution • Programmable coefficients for variable sharpness control • RealRecovery™ provides full color recovery image for
refresh rates higher than those supported by the LCD panel
• Analog RGB Input Port • Supports SDTV RGB inputs in interlaced mode • Supports EDTV (480p) up to 1080i HDTV inputs • Supports mid level clamp for YPbPr inputs • Macro vision decoding • Supports up to 162 MHz (SXGA 75Hz / UXGA 60Hz) • On-chip high-performance PLLs (single reference crystal
required) • Composite-sync, Sync-on-Green (SOG) and Sync-on-Y
(SoY) support • Input format detection • Phase and image positioning
• Ultra-Reliable DVI-Compliant Input Port • Operating up to 165 MHz (up to UXGA 60Hz) • Direct connect to all DVI 1.0-compliant transmitters • High-bandwidth Digital Content Protection (HDCP)
Note: HDCP function is available H version only.
• CCIR-656 8-bit Video Input Port • Supporting NTSC / PAL interlaced and progressive • Direct connect to commercially available video decoders • Spatial de-interlacing
• Advanced Color Management • Programmable gamma correction (CLUT) • TV color controls including hue and saturation controls • Full color matrix allows end-users to experience the same
colors as viewed on CRTs and other displays (e.g. sRGB compliance)
• Advanced Active Color Management ™ (ACM-II) provide flesh-tone compensation and image enhancement for video preset modes like sport, nature .
• Adaptive Contrast and Color™ (ACC) ensures full dynamic range is used in video content
• On-chip Versatile OSD Controller • On-chip RAM for high-quality programmable menus • 1, 2 and 4-bit per pixel character cells • Horizontal and vertical stretch of OSD menus • Blinking, transparency and blending • Supports two independent OSD menu rectangles • Proportional fonts
• Embedded X86 On-chip Microcontroller • High-performance X86 MCU with on-chip RAM and ROM • External parallel ROM or serial SPI ROM interface • Unified memory architecture simplifies chip programming • 23 general-purpose inputs/outputs (GPIOs) available • 2-wire serial bus master to control NVRAM, video decoder • Two DDC2Bi ports with DMA buffer to internal RAM • Four PWM outputs for analog backlight control, audio, etc. • General-purpose ADC’s for keypad and temperature sensing • Integrated reset circuit • Slow clock mode for 50mW sleep mode power consumption • JTAG debug / ICE support for firmware debugging
• Built-in Test Pattern Generator • Simplifies manufacturing / test
• Energy Spectrum Management (ESM™) • Digital clock spectrum management • Eliminates EMI suppression components and shielding
• Built-in LVDS Transmitters • Four channel 6/8-bit LVDS transmitter • Support for 8 or 6-bit panels with high-quality dithering • Single / double wide up to SXGA 75Hz output • Pin swap, odd / even swap and red / blue group swap of RGB
outputs for flexibility in board layout
• Highly integrated System-on-a-Chip • All system clocks synthesized from a single external crystal • 50mW power saving mode • 5-Volt tolerant inputs • Two Layer PCB support • On-chip reset feature to eliminate external reset component • Integrated Schmitt trigger for HSYNC and VSYNC
PACKAGE • 208-pin PQFP • 3.3V IO and 1.8V core power supplies
2 gm5221 Pinout The gm5221 devices are packaged in a 208-pin Plastic Quad Flat Pack (PQFP).
N/C
N/C
DC
LKJT
AG_R
ESET
RES
ERVE
DR
ESER
VED
RES
ERVE
DR
ESER
VED
RES
ERVE
DR
ESER
VED
RES
ERVE
DJT
AG_T
DO
RES
ERVE
DJT
AG_T
DI
PPW
RPB
IAS
GPI
O15
RES
ERVE
DH
OST
_SC
L/U
ART_
DI
HO
ST_S
DA/
UAR
T_D
OR
VDD
_3.3
CR
VSS
CVD
D_1
.8C
RVS
SD
DC
_SC
L_VG
AD
DC
_SD
A_VG
AD
DC
_SC
L_D
VID
DC
_SD
A_D
VIG
PIO
0G
PIO
1G
PIO
2G
PIO
3G
PIO
4C
VDD
_1.8
CR
VSS
GPI
O5
GPI
O6
GPI
O7/
IRQ
inG
PIO
8/IR
Qou
tG
PIO
9/SC
LG
PIO
10/S
DA
CR
VSS
RVD
D_3
.3C
VDD
_1.8
CR
VSS
GPI
O11
/PW
M0
GPI
O12
/PW
M1
GPI
O13
/PW
M2
GPI
O14
/PW
M3
GPI
O16
/VD
ATA7
GPI
O17
/VD
ATA6 N/C
ROM_DATA3ROM_DATA2ROM_DATA1ROM_DATA0
ROM_OEnROM_WEnROM_CSn
CRVSSCVDD_1.8
RESERVEDAVDD_LV_E_3.3
AVSS_LV_ECH3P_LV_E/ER0CH3N_LV_E/ER1CLKP_LV_E/ER2CLKN_LV_E/ER3CH2P_LV_E/ER4CH2N_LV_E/ER5CH1P_LV_E/ER6CH1N_LV_E/ER7CH0P_LV_E/EG0CH0N_LV_E/EG1
AVSS_LV_EAVDD_LV_E_3..3
AVSS_LVAVDD_LV_3.3
AVDD_LV_O_3.3AVSS_LV_O
CH3P_LV_O/EG2CH3N_LV_O/EG3CLKP_LV_O/EG4CLKN_LV_O/EG5CH2P_LV_O/EG6CH2N_LV_O/EG7CH1P_LV_O/EB0CH1N_LV_O/EB1CH0P_LV_O/EB2CH0N_LV_O/EB3
AVSS_LV_OAVDD_LV_O_3..3
CVDD_1..8CVSS
EB4EB5EB6EB7DENDHSDVS
RVDD_3.3CRVSS
N/C
53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100
101
102
103
104
12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152
156155154153152151150149148147146145144143142141140139138137136135134133132131130129128127126125124123122121120119118117116115114113112111110109108107106105
AGND_ADCRESERVEDAVDD_ADC_3.3AGND_REDRED-RED+AVDD_RED_3.3AGND_GREENGREEN-GREEN+SOG_MCSSAVDD_GREEN_3.3AGND_BLUEBLUE-BLUE+AVDD_BLUE_3.3CRVSSCVDD_1.8RESERVEDVDD_RXPLL_1.8GND_RXPLLRESERVEDAVDD_RXC_3.3RXC-RXC+AGND_RXCAVDD_RX0_3.3RX0-RX0+AGND_RX0VDD_RX0_1.8AVDD_RX1_3.3RX1-RX1+AGND_RX1VDD_RX1_1.8AVDD_RX2_3.3RX2-RX2+AGND_RX2VDD_RX2_1.8AGND_IMBREXTAVDD_IMB_3.3VCLKGPIO23/VDATA0GPIO22/VDATA1GPIO21/VDATA2GPIO20/VDATA3GPIO19/VDATA4GPIO18/VDATA5N/C
208
207
206
205
204
203
202
201
200
199
198
197
196
195
194
193
192
191
190
189
188
187
186
185
184
183
182
181
180
179
178
177
176
175
174
173
172
171
170
169
168
167
166
165
164
163
162
161
160
159
158
157
RO
M_D
ATA4
RO
M_D
ATA5
CR
VSS
RVD
D_3
.3R
OM
_DAT
A6R
OM
_DAT
A7R
OM
_AD
DR
0R
OM
_AD
DR
1R
OM
_AD
DR
2R
OM
_AD
DR
3R
OM
_AD
DR
4R
OM
_AD
DR
5R
OM
_AD
DR
6R
OM
_AD
DR
7R
OM
_AD
DR
8R
OM
_AD
DR
9R
OM
_AD
DR
10C
RVS
SR
VDD
_3.3
RO
M_A
DD
R11
RO
M_A
DD
R12
RO
M_A
DD
R13
RO
M_A
DD
R14
RO
M_A
DD
R15
RO
M_A
DD
R16
RO
M_A
DD
R17
VSYN
CH
SYN
C/C
SYN
CC
RVS
SC
VDD
_1.8
RES
ETn
LBAD
C_G
ND
LBAD
C_R
ETU
RN
LBAD
C_I
N3
LBAD
C_I
N2
LBAD
C_I
N1
LBAD
C_V
DD
_3.3
AVD
D_R
PLL_
3.3
TCLK
XTAL
AGN
D_R
PLL
RES
ERVE
DVD
D_R
PLL_
1.8
GN
D_R
PLL
VDD
_AD
C_1
.8G
ND
_AD
CN
/CN
/CN
/CN
/CN
/CN
/C
Figure 2. gm5221 Pin Out Diagram
VCT 49xxIVolume 1: General Description
General Description
1. Introduction
The VCT 49xxI is an IC family of high-quality single-chip TV processors. Modular design and deep-submi-cron technology allow the economic integration of fea-tures in all classes of single-scan TV sets. TheVCT 49xxI family is based on functional blocks con-tained and approved in existing products likeDRX 396xA, MSP 34x5G, VSP 94x7B, DDP 3315C,and SDA 55xx.
Each member of the family contains the entire IF,audio, video, display, and deflection processing for 4:3and 16:9 50/60-Hz mono and stereo TV sets. The inte-grated microcontroller is supported by a powerful OSDgenerator with integrated Teletext & CC acquisitionincluding on-chip page memory.
Fig. 1–1: Single-chip VCT 49xxI
1.1. Features
The VCT 49xxI family offers a rich feature set, cover-ing the whole range of state-of-the-art 50/60-Hz TVapplications.
– PSSDIP88-1/-2 package
– Submicron CMOS technology
– Low-power standby mode
– Single 20.25-MHz reference crystal
– 8-bit 8051 instruction set compatible CPU
– Up to 256 kB on-chip program ROM
– WST, PDC, VPS, and WSS acquisition
– Closed Caption and V-chip acquisition
– Up to 10 pages on-chip teletext memory
– Multi-standard QSS IF processing with single SAW
– FM Radio and RDS with standard TV tuner
– TV-sound demodulation:• all A2 standards• all NICAM standards• BTSC/SAP with MNR (DBX optional)• EIA-J
– Baseband sound processing for loudspeaker chan-nel:• volume• bass and treble• loudness• balance• spatial effect (e.g. pseudo stereo)• Micronas AROUND (virtual Dolby optional)• Micronas BASS
– CVBS, S-VHS, YCrCb and RGB inputs
– 4H adaptive comb filter (PAL/NTSC)
– multi-standard color decoder (PAL/NTSC/SECAM)
– Nonlinear horizontal scaling “panorama vision”
– Luma and chroma transient improvement (LTI, CTI)
– Non-linear color space enhancement (NCE)
– Dynamic black level expander (BLE)
– Scan velocity modulation output
– Soft start/stop of H-drive
– Vertical angle and bow correction
– Average and peak beam current limiter
– Nonlinear and dynamic EHT compensation
– Black switch off procedure (BSO)
Video & Sound IFDRX 396xA
Audio ProcessingMSP 34x5G
Video ProcessingVSP 94x7B
Control, OSD, TextSDA 55xx
Display & DeflectionDDP 3315C
VCT 49xyI
Fig. 1–2: Block diagram of the VCT 49xxI
XTAL1
IFFrontend
Slicer
VideoBackend
IFProcessor
SoundDemodulator
AudioProcessor
DisplayGenerator
BusArbiter
20kB XRAM256kB
Prog ROMClock
Generator
Reset & TestLogic
I2C Master/Slave
24kBChar ROM TEST
RESETQ
XTAL2
I2C
Pxy
CVBS in
IFIN-
IFIN+
TA
GC
SIF
YCrCb in
CVBS out
RGB in
AO
UT
SP
EA
KE
R
RGB out
SVM
RGB in
SENSE
RSW
VERT
EW
HOUT
PROT
HFLB
PanoramaScaler
Display &DeflectionProcessor
TimerCRTPWMADC
UARTWatchdog
RTC
I/O-PortsMemoryInterface
ADB, DB, PSENQ,PSWEQ, WRQ, RDQ
CPU8051
AIN
VideoFrontend
ColorDecoder
ComponentInterface
CombFilter
VC
T49
xyI
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
25
26
27
28
29
30
31
32
33
34
35
36
24
38
44
43
42
41
40
39
37
GOUT
GINBIN
SVMOUT
RINFBIN
VRDXREF
VSUP3.3BEGND
BOUT
ROUT
VSUP3.3IOGND
HFLBHOUT
SAFETY
VPROT
GNDDACVSUP3.3DAC
SDASCL
P21 / PWMV
P17P20 / DFVBL
P16P15P14P13P12
P11
VSUP3.3FEGND
GNDMSENSE
GNDVSUP5.0BE
TESTVERT+VERT-
EWRSW2RSW1
P10
88
87
86
85
84
83
82
81
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
64
63
62
61
60
59
58
57
56
55
54
53
65
51
45
46
47
48
49
50
52
SIF / AIN1R
RESETQ
TAGCVREFIF
VREFAUSPEAKERL
VSUP5.0IF
XTAL2
VSUP3.3DIGGND
IFIN-
GNDIF
VSUP1.8DIGGND
XTAL1
VIN11
VIN9VIN10
VIN7VIN8
VIN6VIN5VIN4VIN3
VIN1VIN2
P22P23
VOUT1VOUT2VOUT3VSUP1.8FEGND
SPEAKERRAOUT1L
GNDVSUP8.0AU
AIN1LAIN2RAIN2LAIN3R / AOUT2RAIN3L / AOUT2LAOUT1R
IFIN+
January 2001
2001 Fairchild Semiconductor International Si9933ADY Rev A(W)
Si9933ADYDual P-Channel PowerTrench MOSFET
General Description
This P-Channel MOSFET is a rugged gate version ofFairchild Semiconductor’s advanced PowerTrenchprocess. It has been optimized for power managementapplications with a wide range of gate drive voltage(2.5V – 12V).
Applications
• Load switch
• Motor drive
• DC/DC conversion
• Power management
Features
• –5 A, –20 V, RDS(ON) = 75 mΩ @ VGS = –4.5 V RDS(ON) = 105 mΩ @ VGS = –3.0 V RDS(ON) = 115 mΩ @ VGS = –2.7 V
• Extended VGSS range (±12V) for battery applications
• Low gate charge
• High performance trench technology for extremelylow RDS(ON)
• High power and current handling capability
4
3
2
1
5
6
7
8
Q1
Q2
Absolute Maximum Ratings T A=25oC unless otherwise noted
Symbol Parameter Ratings UnitsVDSS Drain-Source Voltage –20 V
VGSS Gate-Source Voltage ±12 V
ID Drain Current – Continuous (Note 1a) –3.4 A
– Pulsed –16
Power Dissipation for Dual Operation 2
Power Dissipation for Single Operation (Note 1a) 1.6(Note 1b) 1
PD
(Note 1c) 0.9
W
TJ, TSTG Operating and Storage Junction Temperature Range –55 to +175 °C
Thermal CharacteristicsRθJA Thermal Resistance, Junction-to-Ambient (Note 1a) 78 °C/W
RθJC Thermal Resistance, Junction-to-Case (Note 1) 40 °C/W
Package Marking and Ordering InformationDevice Marking Device Reel Size Tape width Quantity
9933A Si9933ADY 13’’ 12mm 2500 units
Si9933A
DY
MP1593 3A, 28V
Step Down Converter
PRELIMINARY
Monolithic Power Systems
General Description The MP1593 is a step-down regulator with an internal Power MOSFET. It achieves 3A continuous output current over a wide input supply range with excellent load and line regulation. Current mode operation provides fast transient response and eases loop stabilization. Fault condition protection includes cycle-by-cycle current limiting and thermal shutdown. Adjustable soft-start reduces the stress on the input source at turn-on. In shutdown mode the regulator draws 20µA of supply current. The MP1593 requires a minimum number of readily available external components to complete a 3A step down DC to DC converter solution.
Ordering Information
Part Number ∗ Package Temperature MP1593DN SOIC8 w/ Exposed
Paddle -40 to + 85°C
∗ For Tape & Reel use suffix - Z (e.g. MP1593DN-Z)
Features
3A Output Current Programmable Soft-Start 100mΩ Internal Power MOSFET Switch Stable with Low ESR Output Ceramic
Capacitors Up to 95% Efficiency 20µA Shutdown Mode Fixed 385KHz Frequency Thermal Shutdown Cycle-by-Cycle Over Current Protection Wide 4.75 to 28V Operating Input
Range Output Adjustable From 1.22 Under Voltage Lockout Available in 8 pin SOIC Package
Applications Distributed Power Systems Battery Charger Pre-Regulator for Linear Regulators
Typical Application Circuit
IN BS
SW
FBCOMPGND
EN
SS
INPUT4.75 to 28V
OUTPUT2.5V, 3AMP1593
MP1593 3A, 28V
Step Down Converter
PRELIMINARY
Monolithic Power Systems
Pin Description
Table 1: Pin Designators
# Name Description
1 BS High-Side Gate Drive Boost Input. BS supplies the drive for the high-side n-channel MOSFET switch. Connect a 10nF or greater capacitor from SW to BS to power the high side switch.
2 IN Power Input. IN supplies the power to the IC, as well as the step-down converter switches. Drive IN with a 4.75V to 28V power source. Bypass IN to GND with a suitably large capacitor to eliminate noise on the input to the IC. See Input Capacitor section.
3 SW Power Switching Output. SW is the switching node that supplies power to the output. Connect the output LC filter from SW to the output load. Note that a capacitor is required from SW to BS to power the high-side switch.
4 GND Ground. (Note: Connect the exposed pad on backside to Pin 4).
5 FB Feedback Input. FB senses the output voltage to regulate that voltage. Drive FB with a resistive voltage divider from the output voltage. The feedback threshold is 1.222V. See Setting the Output Voltage section.
6 COMP Compensation Node. COMP is used to compensate the regulation control loop. Connect a series RC network from COMP to GND to compensate the regulation control loop. In some cases, an additional capacitor from COMP to GND is required. See Compensation section.
7 EN
Enable Input. EN is a digital input that turns the regulator on or off. Drive EN high to turn on the regulator, drive EN low to turn it off. An Under Voltage Lockout (UVLO) function can be implemented by the addition of a resistor divider from VIN to GND. For complete low current shutdown its needs to be less than 0.7V. For automatic startup, leave EN unconnected.
8 SS Soft Start Control Input. SS controls the soft start period. Connect a capacitor from SS to GND to set the soft-start period. A 0.1µF capacitor sets the soft-start period to 10ms. To disable the soft-start feature, leave SS unconnected.
BS 1
2
3
4 5
6
7
8
IN
SW
GND
SS
EN
COMP
FB
Exposed Pad onBackside.
Connect to Pin 4.
POS PART NUMBER PART DESCRIPTION POS PART
NUMBER PART DESCRIPTION
X941 032150R HP JACK 17"LCD TV (OLD-8R9185) R217 172479R RC-CHIP 4.7K J 1/16W /0603 TAPEX940 031224R CONN.HOUS.3P 2317-3S JST B 3B-XH-A WHITE R222 172479R RC-CHIP 4.7K J 1/16W /0603 TAPE
Y10184 H.PHONE MOD-PN LCD TV L5A CHASIS R213 172479R RC-CHIP 4.7K J 1/16W /0603 TAPEC940 273471R C-PEM 47NF K 63V R:5 R406 170474R RC-CHIP 47R J 1/16W /0603 TAPEC941 273471R C-PEM 47NF K 63V R:5 R407 170474R RC-CHIP 47R J 1/16W /0603 TAPE
Y10187R R/C L5A SASI KUMANDA KMK-01 SILVER R408 170474R RC-CHIP 47R J 1/16W /0603 TAPEN1F110 LC SD-32W M/NX/2/K/SV/VGA/A-OSD/AU3 R409 170474R RC-CHIP 47R J 1/16W /0603 TAPE
C639 252482R EC 470UF 16V 12.5*10 R:5 R410 170474R RC-CHIP 47R J 1/16W /0603 TAPEU605 452904R IC LM78L08ACZ R411 170474R RC-CHIP 47R J 1/16W /0603 TAPEY300 056161R CRYSTAL 20.25MHZ HC49-U U402 458931R IC-CHIP PI3V512 RGB SW PERICOMS300 031224R CONN.HOUS.3P 2317-3S JST B 3B-XH-A WHITE U402 450526R IC-CHIP PI3V512QEX (QSOP24)S301 031251R SCART SOCKET 14.1 D301 303818R DIODE-CHIP BAV99LT1 SOT23 T&RY200 056119R CRYSTAL 14.31818MHz CL=18PF30/30PPMHC49U Q200 401472R TRN-CHIP 2N7002 N-CHANNEL SOT23
SW201 010844R TACT SWITCH 2 LEG (MTSB) Q201 401472R TRN-CHIP 2N7002 N-CHANNEL SOT23J310 031163R KONN. CINCH ........ WHITE HOR.14.1 R363 170754R RC-CHIP 75R J 1/16W /0603J309 031164R KONN. CINCH ........... RED HOR.14.1 R365 170754R RC-CHIP 75R J 1/16W /0603L200 053352R COIL- CHOKE 10UH R0814 14.1 R366 170754R RC-CHIP 75R J 1/16W /0603L202 053352R COIL- CHOKE 10UH R0814 14.1 R367 170754R RC-CHIP 75R J 1/16W /0603L300 053352R COIL- CHOKE 10UH R0814 14.1 R368 170754R RC-CHIP 75R J 1/16W /0603L301 053352R COIL- CHOKE 10UH R0814 14.1 R369 170754R RC-CHIP 75R J 1/16W /0603L312 053352R COIL- CHOKE 10UH R0814 14.1 R415 170754R RC-CHIP 75R J 1/16W /0603S204 031194R CONN.HOUS.4P 2317-4S JST B 4B-XH-A WHITE R416 170754R RC-CHIP 75R J 1/16W /0603S202 031194R CONN.HOUS.4P 2317-4S JST B 4B-XH-A WHITE R417 170754R RC-CHIP 75R J 1/16W /0603
SAW300 056298R SAW FILTER X6966M C413 290223R CC-CHIP 22PF J 50V /0603 NPO TAPEU303 S-SWVCTI01BG SW IC VCTI 5LC BEKO/GRUNDIG C414 290223R CC-CHIP 22PF J 50V /0603 NPO TAPEU303 S-SWVCTI01BGV SW IC VCTI 5LC BEKO/GRUNDIG VD R235 171107R RC-CHIP 100R J 1/16W /0603C629 253128R EC 1000UF 16V 20*10 R:5 LOW ESR R236 171107R RC-CHIP 100R J 1/16W /0603P400 031358R CONN. VGA B10B R341 171107R RC-CHIP 100R J 1/16W /0603R237 171250R RC-CHIP 249R F %1 / 0603 R342 171107R RC-CHIP 100R J 1/16W /0603U201 452662R-2 IC-CHIP AT24C16AN 10SU2.7 TAPE&REEL R345 171107R RC-CHIP 100R J 1/16W /0603U300 452706R-1 IC TDA1308T/N2 SO-G8 (T&R) R346 171107R RC-CHIP 100R J 1/16W /0603U200 453296R IC-CHIP GM2221-LF-BC 208PIN PQFP TRAY R257 171107R RC-CHIP 100R J 1/16W /0603R325 170225R RC-CHIP 22R J 1/10W /0603 R255 171107R RC-CHIP 100R J 1/16W /0603C371 292114R CC-CHIP 1NF K 50V /0603 X7R R347 171107R RC-CHIP 100R J 1/16W /0603C372 292114R CC-CHIP 1NF K 50V /0603 X7R R348 171107R RC-CHIP 100R J 1/16W /0603C373 292114R CC-CHIP 1NF K 50V /0603 X7R R357 171107R RC-CHIP 100R J 1/16W /0603C376 292114R CC-CHIP 1NF K 50V /0603 X7R R358 172104R RC-CHIP 1K J 1/16W /0603C377 292114R CC-CHIP 1NF K 50V /0603 X7R R607 172104R RC-CHIP 1K J 1/16W /0603C378 292114R CC-CHIP 1NF K 50V /0603 X7R R258 172104R RC-CHIP 1K J 1/16W /0603C379 292114R CC-CHIP 1NF K 50V /0603 X7R R423 172104R RC-CHIP 1K J 1/16W /0603C380 292114R CC-CHIP 1NF K 50V /0603 X7R R424 172104R RC-CHIP 1K J 1/16W /0603C381 292114R CC-CHIP 1NF K 50V /0603 X7R R418 172104R RC-CHIP 1K J 1/16W /0603C390 292114R CC-CHIP 1NF K 50V /0603 X7R R419 172104R RC-CHIP 1K J 1/16W /0603C391 292114R CC-CHIP 1NF K 50V /0603 X7R C394 292153R CC-CHIP 1.5NF K 50V /0603 X7R TAPEC392 292114R CC-CHIP 1NF K 50V /0603 X7R C395 292153R CC-CHIP 1.5NF K 50V /0603 X7R TAPEC393 292114R CC-CHIP 1NF K 50V /0603 X7R R401 171336R RC-CHIP 330R J 1/16W /0603 TAPEJ304 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE R402 171336R RC-CHIP 330R J 1/16W /0603 TAPEJ235 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE R385 172513R RC-CHIP 5.1K J 1/16W /0603J305 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE R378 172567R RC-CHIP 5.6K J 1/16W /0603 TAPEJ314 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE R379 172567R RC-CHIP 5.6K J 1/16W /0603 TAPER422 172686R RC-CHIP 6.8K J 1/16W /0603 C321 294125R CC-CHIP 100NF K 25V /0603 X7RR398 173277R RC-CHIP 27K J 1/16W /0603 TAPE C446 294125R CC-CHIP 100NF K 25V /0603 X7R
The components which are referred positions may changes by model, size, cosmetic and specification of the LCD TV. Please apply web pages for current part list. The items marked with red are safety components or need to be replaced with
original/approved parts.
REPLACEMENT PART LIST
POS PART NUMBER PART DESCRIPTION POS PART
NUMBER PART DESCRIPTION
C200 294125R CC-CHIP 100NF K 25V /0603 X7R C448 294125R CC-CHIP 100NF K 25V /0603 X7RC201 294125R CC-CHIP 100NF K 25V /0603 X7R C449 294125R CC-CHIP 100NF K 25V /0603 X7RC202 294125R CC-CHIP 100NF K 25V /0603 X7R C450 294125R CC-CHIP 100NF K 25V /0603 X7RC203 294125R CC-CHIP 100NF K 25V /0603 X7R C451 294125R CC-CHIP 100NF K 25V /0603 X7RC204 294125R CC-CHIP 100NF K 25V /0603 X7R C456 294125R CC-CHIP 100NF K 25V /0603 X7RC205 294125R CC-CHIP 100NF K 25V /0603 X7R C609 294125R CC-CHIP 100NF K 25V /0603 X7RC206 294125R CC-CHIP 100NF K 25V /0603 X7R C610 294125R CC-CHIP 100NF K 25V /0603 X7RC207 294125R CC-CHIP 100NF K 25V /0603 X7R C615 294125R CC-CHIP 100NF K 25V /0603 X7RC208 294125R CC-CHIP 100NF K 25V /0603 X7R C616 294125R CC-CHIP 100NF K 25V /0603 X7RC228 294125R CC-CHIP 100NF K 25V /0603 X7R C617 294125R CC-CHIP 100NF K 25V /0603 X7RC229 294125R CC-CHIP 100NF K 25V /0603 X7R C619 294125R CC-CHIP 100NF K 25V /0603 X7RC230 294125R CC-CHIP 100NF K 25V /0603 X7R C620 294125R CC-CHIP 100NF K 25V /0603 X7RC231 294125R CC-CHIP 100NF K 25V /0603 X7R C621 294125R CC-CHIP 100NF K 25V /0603 X7RC232 294125R CC-CHIP 100NF K 25V /0603 X7R C622 294125R CC-CHIP 100NF K 25V /0603 X7RC233 294125R CC-CHIP 100NF K 25V /0603 X7R C623 294125R CC-CHIP 100NF K 25V /0603 X7RC234 294125R CC-CHIP 100NF K 25V /0603 X7R C624 294125R CC-CHIP 100NF K 25V /0603 X7RC235 294125R CC-CHIP 100NF K 25V /0603 X7R C316 294125R CC-CHIP 100NF K 25V /0603 X7RC236 294125R CC-CHIP 100NF K 25V /0603 X7R C327 294125R CC-CHIP 100NF K 25V /0603 X7RC237 294125R CC-CHIP 100NF K 25V /0603 X7R C242 294125R CC-CHIP 100NF K 25V /0603 X7RC238 294125R CC-CHIP 100NF K 25V /0603 X7R C311 294125R CC-CHIP 100NF K 25V /0603 X7RC239 294125R CC-CHIP 100NF K 25V /0603 X7R C312 294125R CC-CHIP 100NF K 25V /0603 X7RC300 294125R CC-CHIP 100NF K 25V /0603 X7R R200 173100R RC-CHIP 10K J 1/10W /0603C301 294125R CC-CHIP 100NF K 25V /0603 X7R R201 173100R RC-CHIP 10K J 1/10W /0603C302 294125R CC-CHIP 100NF K 25V /0603 X7R R202 173100R RC-CHIP 10K J 1/10W /0603C303 294125R CC-CHIP 100NF K 25V /0603 X7R R203 173100R RC-CHIP 10K J 1/10W /0603C304 294125R CC-CHIP 100NF K 25V /0603 X7R R243 173100R RC-CHIP 10K J 1/10W /0603C305 294125R CC-CHIP 100NF K 25V /0603 X7R R245 173100R RC-CHIP 10K J 1/10W /0603C306 294125R CC-CHIP 100NF K 25V /0603 X7R R300 173100R RC-CHIP 10K J 1/10W /0603C307 294125R CC-CHIP 100NF K 25V /0603 X7R R302 173100R RC-CHIP 10K J 1/10W /0603C308 294125R CC-CHIP 100NF K 25V /0603 X7R R304 173100R RC-CHIP 10K J 1/10W /0603C309 294125R CC-CHIP 100NF K 25V /0603 X7R R322 173100R RC-CHIP 10K J 1/10W /0603C310 294125R CC-CHIP 100NF K 25V /0603 X7R R323 173100R RC-CHIP 10K J 1/10W /0603C313 294125R CC-CHIP 100NF K 25V /0603 X7R R334 173100R RC-CHIP 10K J 1/10W /0603C314 294125R CC-CHIP 100NF K 25V /0603 X7R R604 173100R RC-CHIP 10K J 1/10W /0603C315 294125R CC-CHIP 100NF K 25V /0603 X7R R247 173100R RC-CHIP 10K J 1/10W /0603C317 294125R CC-CHIP 100NF K 25V /0603 X7R R248 173100R RC-CHIP 10K J 1/10W /0603C318 294125R CC-CHIP 100NF K 25V /0603 X7R R249 173100R RC-CHIP 10K J 1/10W /0603C319 294125R CC-CHIP 100NF K 25V /0603 X7R R250 173100R RC-CHIP 10K J 1/10W /0603C463 293113R CC-CHIP 10NF K 50V /0603 X7R R227 173100R RC-CHIP 10K J 1/10W /0603C405 292229R CC-CHIP 2.2NF J 50V/0603 NPO R228 173100R RC-CHIP 10K J 1/10W /0603C406 292229R CC-CHIP 2.2NF J 50V/0603 NPO R229 173100R RC-CHIP 10K J 1/10W /0603C407 292229R CC-CHIP 2.2NF J 50V/0603 NPO R246 173100R RC-CHIP 10K J 1/10W /0603C408 292229R CC-CHIP 2.2NF J 50V/0603 NPO R256 173100R RC-CHIP 10K J 1/10W /0603C251 299501R CC-CHIP 5PF J 50V /0603 NPO R230 173100R RC-CHIP 10K J 1/10W /0603C252 299501R CC-CHIP 5PF J 50V /0603 NPO R231 173100R RC-CHIP 10K J 1/10W /0603U604 401372R TRN FDS9933A R273 173100R RC-CHIP 10K J 1/10W /0603C243 291226R CC-CHIP 220PF J 50V /0603 NPO TAPE R386 173100R RC-CHIP 10K J 1/10W /0603C244 291226R CC-CHIP 220PF J 50V /0603 NPO TAPE R361 173183R RC-CHIP 18K J 1/16W /0603 TAPEC245 291226R CC-CHIP 220PF J 50V /0603 NPO TAPE C253 293113R CC-CHIP 10NF K 50V /0603 X7RC246 291226R CC-CHIP 220PF J 50V /0603 NPO TAPE C330 293113R CC-CHIP 10NF K 50V /0603 X7RC337 291476R CC-CHIP 470PF J 50V /0603 NP0 T&R C331 293113R CC-CHIP 10NF K 50V /0603 X7RC338 291476R CC-CHIP 470PF J 50V /0603 NP0 T&R C457 293113R CC-CHIP 10NF K 50V /0603 X7RC339 291476R CC-CHIP 470PF J 50V /0603 NP0 T&R C458 293113R CC-CHIP 10NF K 50V /0603 X7RC340 291476R CC-CHIP 470PF J 50V /0603 NP0 T&R C459 293113R CC-CHIP 10NF K 50V /0603 X7RC335 291561R CC-CHIP 560PF J 50V /0603 NPO TAPE C460 293113R CC-CHIP 10NF K 50V /0603 X7RC336 291561R CC-CHIP 560PF J 50V /0603 NPO TAPE C461 293113R CC-CHIP 10NF K 50V /0603 X7RC363 291561R CC-CHIP 560PF J 50V /0603 NPO TAPE C462 293113R CC-CHIP 10NF K 50V /0603 X7RQ303 401142R TRN-CHIP BC858BLT1G SOT23 L323 053804R COIL-CHIP 10UH K 0805
POS PART NUMBER PART DESCRIPTION POS PART
NUMBER PART DESCRIPTION
Q311 401142R TRN-CHIP BC858BLT1G SOT23 L324 053804R COIL-CHIP 10UH K 0805Q312 401142R TRN-CHIP BC858BLT1G SOT23 C386 290475R CC-CHIP 47PF J 50V /0603 NPO TAPEQ313 401142R TRN-CHIP BC858BLT1G SOT23 C387 290475R CC-CHIP 47PF J 50V /0603 NPO TAPER329 172276R RC-CHIP 2.7K J 1/16W /0603 D300 304412R DIODE-CHIP ZENER BZX84C33 SOT23U601 453124R IC-CHIP NCP1117DT33RK G TO-252 PACKAGE R233 172338R RC-CHIP 3.3K J 1/10W /0603U606 453124R IC-CHIP NCP1117DT33RK G TO-252 PACKAGE R234 172338R RC-CHIP 3.3K J 1/10W /0603U603 453295R IC-CHIP NCP1117DT18RK G TO252 (T&R) R337 172338R RC-CHIP 3.3K J 1/10W /0603U203 453355R IC M25P40 - VMN6T R338 172338R RC-CHIP 3.3K J 1/10W /0603R374 170154R RC-CHIP 150R J 1/16W /0603 TAPE R324 172338R RC-CHIP 3.3K J 1/10W /0603R375 170154R RC-CHIP 150R J 1/16W /0603 TAPE C638 293235R CC-CHIP 22NF J 16V /0603 X7RR330 170154R RC-CHIP 150R J 1/16W /0603 TAPE R326 170333R RC-CHIP 33R J 1/16W /0603 TAPER331 170154R RC-CHIP 150R J 1/16W /0603 TAPE R327 170333R RC-CHIP 33R J 1/16W /0603 TAPER332 170154R RC-CHIP 150R J 1/16W /0603 TAPE R328 170333R RC-CHIP 33R J 1/16W /0603 TAPEC417 291337R CC-CHIP 330PF J 50V /0603 NPO R412 171107R RC-CHIP 100R J 1/16W /0603C418 291337R CC-CHIP 330PF J 50V /0603 NPO R413 171107R RC-CHIP 100R J 1/16W /0603L309 053806R COIL-CHIP 8.2UH K /0805 R403 173100R RC-CHIP 10K J 1/10W /0603L201 053725R COIL-CHIP 10UH %20/0805 R420 173471R RC-CHIP 47K J 1/10W /0603L203 053725R COIL-CHIP 10UH %20/0805 R421 173471R RC-CHIP 47K J 1/10W /0603L302 053725R COIL-CHIP 10UH %20/0805 D400 303497R DIODE CHIP IMBD4148 SOT 23L303 053725R COIL-CHIP 10UH %20/0805 D401 303818R DIODE-CHIP BAV99LT1 SOT23 T&RL304 053725R COIL-CHIP 10UH %20/0805 D402 303818R DIODE-CHIP BAV99LT1 SOT23 T&RL305 053725R COIL-CHIP 10UH %20/0805 D403 303818R DIODE-CHIP BAV99LT1 SOT23 T&RL306 053725R COIL-CHIP 10UH %20/0805 D404 303818R DIODE-CHIP BAV99LT1 SOT23 T&RL307 053725R COIL-CHIP 10UH %20/0805 D405 303818R DIODE-CHIP BAV99LT1 SOT23 T&RL308 053725R COIL-CHIP 10UH %20/0805 U400 453010R IC-CHIP M24C02 - MN6TP SO8L310 053725R COIL-CHIP 10UH %20/0805 C627 252476R EC 470UF 25V 11*10 R:5L311 053725R COIL-CHIP 10UH %20/0805 C637 252476R EC 470UF 25V 11*10 R:5L316 053725R COIL-CHIP 10UH %20/0805 C347 251112R EC 10UF 50V RS 11*5 TAPING R=5MML400 053725R COIL-CHIP 10UH %20/0805 C361 251112R EC 10UF 50V RS 11*5 TAPING R=5MMR351 171476R RC-CHIP 470R J 1/16W /0603 C362 251112R EC 10UF 50V RS 11*5 TAPING R=5MMR353 171476R RC-CHIP 470R J 1/16W /0603 C364 251112R EC 10UF 50V RS 11*5 TAPING R=5MMR354 171476R RC-CHIP 470R J 1/16W /0603 C365 251112R EC 10UF 50V RS 11*5 TAPING R=5MMR414 171476R RC-CHIP 470R J 1/16W /0603 C366 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC256 294234R CC-CHIP 220NF K 16V /0603 X7R C367 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC396 294234R CC-CHIP 220NF K 16V /0603 X7R C441 251478R EC 47UF 16V 11*5 R:5C397 294234R CC-CHIP 220NF K 16V /0603 X7R C442 251478R EC 47UF 16V 11*5 R:5C398 294234R CC-CHIP 220NF K 16V /0603 X7R C107 252476R EC 470UF 25V 11*10 R:5C399 294234R CC-CHIP 220NF K 16V /0603 X7R C112 252105R EC 100UF 50V 12*8 R:5L317 053804R COIL-CHIP 10UH K 0805 C150 251222R EC 22UF 50V RS 11*6.3 TAPINGL319 053804R COIL-CHIP 10UH K 0805 C411 250332R EC 3.3UF 50V 11*5 R:5C350 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C443 251478R EC 47UF 16V 11*5 R:5C354 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C444 251478R EC 47UF 16V 11*5 R:5C355 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C384 251478R EC 47UF 16V 11*5 R:5C356 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C410 252105R EC 100UF 50V 12*8 R:5C357 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C368 252112R EC 100UF 16V 11*6 R:5C358 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C369 252112R EC 100UF 16V 11*6 R:5C360 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C370 252112R EC 100UF 16V 11*6 R:5C464 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C630 252112R EC 100UF 16V 11*6 R:5C346 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C631 252112R EC 100UF 16V 11*6 R:5C359 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C632 252112R EC 100UF 16V 11*6 R:5C409 251112R EC 10UF 50V RS 11*5 TAPING R=5MM C633 252112R EC 100UF 16V 11*6 R:5C247 251222R EC 22UF 50V RS 11*6.3 TAPING C634 252112R EC 100UF 16V 11*6 R:5C248 251222R EC 22UF 50V RS 11*6.3 TAPING C635 252112R EC 100UF 16V 11*6 R:5C249 251222R EC 22UF 50V RS 11*6.3 TAPING C341 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC250 251222R EC 22UF 50V RS 11*6.3 TAPING C342 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC333 251222R EC 22UF 50V RS 11*6.3 TAPING C343 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC334 251222R EC 22UF 50V RS 11*6.3 TAPING C344 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC412 250479R EC 4.7UF 50V 11*5 R:5 C345 251112R EC 10UF 50V RS 11*5 TAPING R=5MM
POS PART NUMBER PART DESCRIPTION POS PART
NUMBER PART DESCRIPTION
C403 294234R CC-CHIP 220NF K 16V /0603 X7R C348 251112R EC 10UF 50V RS 11*5 TAPING R=5MMC404 294234R CC-CHIP 220NF K 16V /0603 X7R C419 291337R CC-CHIP 330PF J 50V /0603 NPOC332 294125R CC-CHIP 100NF K 25V /0603 X7R C420 291337R CC-CHIP 330PF J 50V /0603 NPOC402 294125R CC-CHIP 100NF K 25V /0603 X7R C382 292114R CC-CHIP 1NF K 50V /0603 X7RC329 294125R CC-CHIP 100NF K 25V /0603 X7R C383 292114R CC-CHIP 1NF K 50V /0603 X7RR371 170754R RC-CHIP 75R J 1/16W /0603 C388 292114R CC-CHIP 1NF K 50V /0603 X7RR372 170754R RC-CHIP 75R J 1/16W /0603 C389 292114R CC-CHIP 1NF K 50V /0603 X7RR373 170754R RC-CHIP 75R J 1/16W /0603 C322 294125R CC-CHIP 100NF K 25V /0603 X7RC421 292114R CC-CHIP 1NF K 50V /0603 X7R C324 294125R CC-CHIP 100NF K 25V /0603 X7RC422 292114R CC-CHIP 1NF K 50V /0603 X7R C326 294125R CC-CHIP 100NF K 25V /0603 X7RR301 173100R RC-CHIP 10K J 1/10W /0603 C323 294125R CC-CHIP 100NF K 25V /0603 X7RR319 173100R RC-CHIP 10K J 1/10W /0603 L318 053804R COIL-CHIP 10UH K 0805R387 173100R RC-CHIP 10K J 1/10W /0603 L321 053804R COIL-CHIP 10UH K 0805C400 294234R CC-CHIP 220NF K 16V /0603 X7R R313 173471R RC-CHIP 47K J 1/10W /0603C401 294234R CC-CHIP 220NF K 16V /0603 X7R R314 173471R RC-CHIP 47K J 1/10W /0603Q301 401141R TRN-CHIP BC848BLT1G SOT23 R315 173471R RC-CHIP 47K J 1/10W /0603Q308 401141R TRN-CHIP BC848BLT1G SOT23 R316 173471R RC-CHIP 47K J 1/10W /0603Q304 401142R TRN-CHIP BC858BLT1G SOT23 R317 173471R RC-CHIP 47K J 1/10W /0603Q305 401142R TRN-CHIP BC858BLT1G SOT23 R318 173471R RC-CHIP 47K J 1/10W /0603Q306 401142R TRN-CHIP BC858BLT1G SOT23 R320 173471R RC-CHIP 47K J 1/10W /0603R376 170154R RC-CHIP 150R J 1/16W /0603 TAPE R321 173471R RC-CHIP 47K J 1/10W /0603R377 170154R RC-CHIP 150R J 1/16W /0603 TAPE U302 452985R IC-CHIP MC14053BDR2G SOIC16R364 170754R RC-CHIP 75R J 1/16W /0603 R335 172338R RC-CHIP 3.3K J 1/10W /0603R370 170754R RC-CHIP 75R J 1/16W /0603 R336 172338R RC-CHIP 3.3K J 1/10W /0603R343 171107R RC-CHIP 100R J 1/16W /0603 R333 172338R RC-CHIP 3.3K J 1/10W /0603R344 171107R RC-CHIP 100R J 1/16W /0603 S125 032449R KONN.MALE 2*15 30.LU SSTR399 171336R RC-CHIP 330R J 1/16W /0603 TAPE L116 053946R COIL-CHIP B82464G4223M EPCOSR400 171336R RC-CHIP 330R J 1/16W /0603 TAPE Q100 401141R TRN-CHIP BC848BLT1G SOT23R352 171476R RC-CHIP 470R J 1/16W /0603 Q101 401141R TRN-CHIP BC848BLT1G SOT23R355 171476R RC-CHIP 470R J 1/16W /0603 Q150 401141R TRN-CHIP BC848BLT1G SOT23R356 171476R RC-CHIP 470R J 1/16W /0603 Q151 401141R TRN-CHIP BC848BLT1G SOT23R359 172104R RC-CHIP 1K J 1/16W /0603 Q152 401141R TRN-CHIP BC848BLT1G SOT23R360 172104R RC-CHIP 1K J 1/16W /0603 Q208 401141R TRN-CHIP BC848BLT1G SOT23R384 172479R RC-CHIP 4.7K J 1/16W /0603 TAPE R150 172479R RC-CHIP 4.7K J 1/16W /0603 TAPER362 173183R RC-CHIP 18K J 1/16W /0603 TAPE R276 172479R RC-CHIP 4.7K J 1/16W /0603 TAPER110 173229R RC-CHIP 22K J 1/16W /0603 R277 172479R RC-CHIP 4.7K J 1/16W /0603 TAPER152 170112R RC-CHIP 2K J 1/16W /0603 TAPE D100 303867R DIODE-CHIP SL23 DO214AAR106 171184R RC-CHIP 180R J 1/16W /0603 R103 171107R RC-CHIP 100R J 1/16W /0603R153 171476R RC-CHIP 470R J 1/16W /0603 R100 173100R RC-CHIP 10K J 1/10W /0603J100 179835R RC-CHIP 0.75R %1 0805 R107 173100R RC-CHIP 10K J 1/10W /0603C113 291688R CC-CHIP 680PF J 0603 50V NPO R108 173100R RC-CHIP 10K J 1/10W /0603C101 293235R CC-CHIP 22NF J 16V /0603 X7R R151 173100R RC-CHIP 10K J 1/10W /0603U101 452667R IC-CHIP MC34063ADR2G SO8 T&R R155 173100R RC-CHIP 10K J 1/10W /0603U100 453553R IC-CHIP MP1593DN-LF-Z DC-DC CONV SOIC8N R156 173100R RC-CHIP 10K J 1/10W /0603D101 304413R DIODE-CHIP PMEG4010EH SOD123 R104 173563R RC-CHIP 56K J 1/16W /0603C100 294125R CC-CHIP 100NF K 25V /0603 X7R J200 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC102 294125R CC-CHIP 100NF K 25V /0603 X7R J201 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC106 294125R CC-CHIP 100NF K 25V /0603 X7R J202 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC151 294125R CC-CHIP 100NF K 25V /0603 X7R J203 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC103 294125R CC-CHIP 100NF K 25V /0603 X7R J204 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC109 294125R CC-CHIP 100NF K 25V /0603 X7R J205 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC115 294125R CC-CHIP 100NF K 25V /0603 X7R J206 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEJ316 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE J207 179005R RC-CHIP 0R /0603 1.6*0.8 TAPER102 173183R RC-CHIP 18K J 1/16W /0603 TAPE J208 179005R RC-CHIP 0R /0603 1.6*0.8 TAPER101 173563R RC-CHIP 56K J 1/16W /0603 J209 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC104 293113R CC-CHIP 10NF K 50V /0603 X7R J318 179005R RC-CHIP 0R /0603 1.6*0.8 TAPEC636 292153R CC-CHIP 1.5NF K 50V /0603 X7R TAPE R154 172104R RC-CHIP 1K J 1/16W /0603R615 173563R RC-CHIP 56K J 1/16W /0603 R157 172104R RC-CHIP 1K J 1/16W /0603
POS PART NUMBER PART DESCRIPTION POS PART
NUMBER PART DESCRIPTION
D608 303867R DIODE-CHIP SL23 DO214AA R105 172224R RC-CHIP 2.2K J 1/16W/0603 TAPEL609 053946R COIL-CHIP B82464G4223M EPCOS R109 173229R RC-CHIP 22K J 1/16W /0603U600 453553R IC-CHIP MP1593DN-LF-Z DC-DC CONV SOIC8N X52527R CABLE WITH.TERM.L=110MM YELC600 294125R CC-CHIP 100NF K 25V /0603 X7R ZF7524R CABLE HARNESS AC POW PLUG-SWC601 294125R CC-CHIP 100NF K 25V /0603 X7R L7J172 CU ASSY 32W L97. L5A (TX8193-10)C602 294125R CC-CHIP 100NF K 25V /0603 X7R CN1 038889R CONN.MALE 5 RIGHT-A 2317-5R C603 294125R CC-CHIP 100NF K 25V /0603 X7R IR1 452521R-1 IR RECEIVER TSOP34838 SS1AC604 294125R CC-CHIP 100NF K 25V /0603 X7R D1 303884R LED 3MM WHITE 3V 5MA P.LIGHTC625 293113R CC-CHIP 10NF K 50V /0603 X7R R2 101163R CFR 150R J 1/4W 26MMR601 173183R RC-CHIP 18K J 1/16W /0603 TAPE R1 101163R CFR 150R J 1/4W 26MMJ307 031795R CONN.S-VHS R4 102141R CFR 1K J 1/4W /6 26MMJ308 031163R KONN. CINCH ........ WHITE HOR.14.1 R8 101494R CFR 470R J 1/4W /6 26MMJ311 031164R KONN. CINCH ........... RED HOR.14.1 L8J172 CU ASSY 32L97 L5A VERJ312 031165R KONN. CINCH ........... YELLOW HOR.14.1 CN1 032997R CONN.HOUS.2 PIN 2317-2R S303 031251R SCART SOCKET 14.1 TX9174 CU ASSY PN 32L94 L5A VER. C110 253128R EC 1000UF 16V 20*10 R:5 LOW ESR R3 101343R CFR 330R J 1/4W /6 26MMS100 031658R CONN.HOUSING.10P 2MMM 89400-1010 MOLEX R7 101494R CFR 470R J 1/4W /6 26MMS149 031658R CONN.HOUSING.10P 2MMM 89400-1010 MOLEX R5 101189R CFR 180R J 1/4W /6 26MMC111 252112R EC 100UF 16V 11*6 R:5 R6 102141R CFR 1K J 1/4W /6 26MMC563 253227R EC 2200UF 35V 16*25 R:7.5 R9 102400R CFR 3.9K J 1/4W /6 26MMC116 253115R EC 1000UF 16V 20*10 R:5 SOURCE 010860R TACT SW LONG STENS150 031476R CONN.HOUSING.12P 2MM 89400-1210 MOLEX VOL+ 010860R TACT SW LONG STENL103 053937R BOBIN RAD. 100UH K R:5MM LHL06TB VOL- 010860R TACT SW LONG STENC105 253131R EC 1000UF 35V 20*13 R:5 PROG+ 010860R TACT SW LONG STENJP203 031281R CON.MALE 7.LI 2317-7S JST B 7B-XH-A WHIT PROG- 010860R TACT SW LONG STENTU351 QW1136RTH1 TUNER HOR. THOMSON CTF5547 MENU 010860R TACT SW LONG STENC114 253115R EC 1000UF 16V 20*10 R:5 CN2 031396R CON.CINCH SST 396G1-R 3?LU JP100 032951R CONN.HOUSING.7.LI MOLEX 89400-0710 CN3 031396R CON.CINCH SST 396G1-R 3?LU JP101 032951R CONN.HOUSING.7.LI MOLEX 89400-0710 SW1 010861R ON/OFF SWITCH BK98
KW5502R CABLE PANEL LVDS 32# AUO-VERS.V5 L=300MM TW5140 LC 26"/32" AUDIO AMPLIFIERJ451 BW9524R CABLE HARNESS DC POWER 10 PIN L5 SAMSUN C259 250115R EC 1UF 50V 11*5 R:5J450 KW3506R CON.CAB. AUDIO MODULE/L5 CHASSIS L=200 C411 250115R EC 1UF 50V 11*5 R:5S421 KW3524R CABLE HARNESS 7.LI AMP. 26"-32" L5A C460 250227R EC 2.2UF 16V 11*5 R:5
MW1504R CON.CAB. PSU/AUDIO MODULE L=380 MAKARON C484 250227R EC 2.2UF 16V 11*5 R:5031491R PLUG AC INLET TWO PHASE NOISE FILTER C250 294476R CC-CHIP 470NF K 16V /0805 X7R
R448 173228R RC-CHIP 22K J 1/10W /0603 C251 294476R CC-CHIP 470NF K 16V /0805 X7RR465 170102R RC-CHIP 10R J 1/8W /1206 C496 294476R CC-CHIP 470NF K 16V /0805 X7RR466 170102R RC-CHIP 10R J 1/8W /1206 C258 294122R CC-CHIP 100NF K 50V /0603 X7RR467 172824R RC-CHIP 8.2K J 1/16W /0603 TAPE C473 294122R CC-CHIP 100NF K 50V /0603 X7RU402 453494R IC-CHIP TRIPATH TA2024 STEREO CLAS-D T&R C493 294122R CC-CHIP 100NF K 50V /0603 X7RR468 179005R RC-CHIP 0R /0603 1.6*0.8 TAPE C254 292114R CC-CHIP 1NF K 50V /0603 X7RC471 252241R EC 220UF 35V WL 16*8 LESR/HRPL C255 292114R CC-CHIP 1NF K 50V /0603 X7RC472 252241R EC 220UF 35V WL 16*8 LESR/HRPL C256 292114R CC-CHIP 1NF K 50V /0603 X7RS409 031194R CONN.HOUS.4P 2317-4S JST B 4B-XH-A WHITE C257 292114R CC-CHIP 1NF K 50V /0603 X7RS421 032951R CONN.HOUSING.7.LI MOLEX 89400-0710 C495 292114R CC-CHIP 1NF K 50V /0603 X7RCAB1 KW3527R CAB.TERM. L5/AUDIO MODULE GROUND L=280 C422 294234R CC-CHIP 220NF K 16V /0603 X7RS422 031387R CON.MALE 8POL.250G1-V08 D407 303867R DIODE-CHIP SL23 DO214AAS423 031387R CON.MALE 8POL.250G1-V08 D408 303867R DIODE-CHIP SL23 DO214AAL412 051371R LINE FILTER 2X28MH 3A D409 303867R DIODE-CHIP SL23 DO214AA
Y56913R ADAPTOR AC12V/4A 15"CLASSII W/O GND D410 303867R DIODE-CHIP SL23 DO214AATU301 Y11137R TUNER HOR. SAMSUNG TECC2949PG39E L405 055622R FERRIT BEAD-CHIP 100MHZ 4A
C4A187F U/K L5A KUMANDA KMK-01 SILVER BEKO S.LI L406 055622R FERRIT BEAD-CHIP 100MHZ 4AY92913R ADAPTOR AC12V/5A CLASS II W/O GND UK TYPE L411 055622R FERRIT BEAD-CHIP 100MHZ 4A038948R MAIN CABLE CLSII UK TYPE R434 173228R RC-CHIP 22K J 1/10W /0603
8R9183RFJ1 INVERTOR 17"W FUJITSU PLCD0817410 R435 173228R RC-CHIP 22K J 1/10W /0603S503 Y56502R KAB.PANEL INTERFACE LCD TV 15 MOLEX L R437 173228R RC-CHIP 22K J 1/10W /0603
X60183RSS2 INVERTOR 15 LTM150XH-L06A (PLCD2615412) F600 054290R FUSE 5A/250V ROUNDZH1183RLP2 INVERTOR 20" LC201V02-A3KB (PLCD0320613)
FREQUENCY TABLE (MHz)
Channel Number BG I DK L/L'
CH 1 49.75 49.75 47.75 CH 2 48.25 59.25 59.25 55.75 CH 3 55.25 77.25 77.25 60.50 CH 4 62.25 85.25 85.25 63.75 CH 5 175.25 93.25 93.25 176.00 CH 6 182.25 175.25 175.25 184.00 CH 7 189.25 183.25 183.25 192.00 CH 8 196.25 191.25 191.25 200.00 CH 9 203.25 199.25 199.25 208.00 CH 10 210.25 207.25 207.25 216.00 CH 11 217.25 215.25 215.25 189.25 CH 12 224.25 223.25 223.25 182.25 CH 13 53.75 45.75 196.25 CH 14 62.25 53.75 210.25 CH 15 82.25 61.75 CH 16 175.25 69.75 CH 17 183.25 95.25 CH 18 192.25 CH 19 201.25 CH 20 210.25 CH 21 471.25 471.25 471.25 471.25 CH 22 479.25 479.25 479.25 479.25 CH 23 487.25 487.25 487.25 487.25 CH 24 495.25 495.25 495.25 495.25 CH 25 503.25 503.25 503.25 503.25 CH 26 511.25 511.25 511.25 511.25 CH 27 519.25 519.25 519.25 519.25 CH 28 527.25 527.25 527.25 527.25 CH 29 535.25 535.25 535.25 535.25 CH 30 543.25 543.25 543.25 543.25 CH 31 551.25 551.25 551.25 551.25 CH 32 559.25 559.25 559.25 559.25 CH 33 567.25 567.25 567.25 567.25 CH 34 575.25 575.25 575.25 575.25 CH 35 583.25 583.25 583.25 583.25 CH 36 591.25 591.25 591.25 591.25 CH 37 599.25 599.25 599.25 599.25 CH 38 607.25 607.25 607.25 607.25 CH 39 615.25 615.25 615.25 615.25 CH 40 623.25 623.25 623.25 623.25 CH 41 631.25 631.25 631.25 631.25 CH 42 639.25 639.25 639.25 639.25 CH 43 647.25 647.25 647.25 647.25 CH 44 655.25 655.25 655.25 655.25
Channel Number BG I DK L/L' CH 45 663.25 663.25 663.25 663.25 CH 46 671.25 671.25 671.25 671.25 CH 47 679.25 679.25 679.25 679.25 CH 48 687.25 687.25 687.25 687.25 CH 49 695.25 695.25 695.25 695.25 CH 50 703.25 703.25 703.25 703.25 CH 51 711.25 711.25 711.25 711.25 CH 52 719.25 719.25 719.25 719.25 CH 53 727.25 727.25 727.25 727.25 CH 54 735.25 735.25 735.25 735.25 CH 55 743.25 743.25 743.25 743.25 CH 56 751.25 751.25 751.25 751.25 CH 57 759.25 759.25 759.25 759.25 CH 58 767.25 767.25 767.25 767.25 CH 59 775.25 775.25 775.25 775.25 CH 60 783.25 783.25 783.25 783.25 CH 61 791.25 791.25 791.25 791.25 CH 62 799.25 799.25 799.25 799.25 CH 63 807.25 807.25 807.25 807.25 CH 64 815.25 815.25 815.25 815.25 CH 65 823.25 823.25 823.25 823.25 CH 66 831.25 831.25 831.25 831.25 CH 67 839.25 839.25 839.25 839.25 CH 68 847.25 847.25 847.25 847.25 CH 69 855.25 855.25 855.25 855.25 CH 70 863,25 863.25 CH 71 871,25 CH 72 879,25 CH 73 887,25 160.00
CH 74 69.25 172.00 CH 75 76.25 220.00 CH 76 83.25 232.00 CH 77 90.25 244.00 CH 78 97.25 256.00 CH 79 59.25 268.00 CH 80 93.25 280.00 S 1 105.25 103.25 103.25 116.75 S 2 112.25 111.25 111.25 128.75 S 3 119.25 119.25 119.25 140.75 S 4 126.25 127.25 127.25 152.75 S 5 133.25 135.25 135.25 164.75 S 6 140.25 143.25 143.25 176.75 S 7 147.25 151.25 151.25 188.75 S 8 154.25 159.25 159.25 200.75 S 9 161.25 167.25 167.25 212.75 S 10 168.25 231.25 231.25 224.75 S 11 231.25 239.25 239.25 236.75 S 12 238.25 247.25 247.25 248.75 S 13 245.25 255.25 255.25 260.75 S 14 252.25 263.25 263.25 272.75
Channel Number BG I DK L/L' S 15 259.25 271.25 271.25 284.75 S 16 266.25 279.25 279.25 296.75 S 17 273.25 287.25 287.25 55.75 S 18 280.25 295.25 295.25 60.50 S 19 287.25 303.25 303.25 63.75 S 20 294.25 S 21 303.25 303.25 S 22 311.25 311.25 311.25 311.25 S 23 319.25 319.25 319.25 319.25 S 24 327.25 327.25 327.25 327.25 S 25 335.25 335.25 335.25 335.25 S 26 343.25 343.25 343.25 343.25 S 27 351.25 351.25 351.25 351.25 S 28 359.25 359.25 359.25 359.25 S 29 367.25 367.25 367.25 367.25 S 30 375.25 375.25 375.25 375.25 S 31 383.25 383.25 383.25 383.25 S 32 391.25 391.25 391.25 391.25 S 33 399.25 399.25 399.25 399.25 S 34 407.25 407.25 407.25 407.25 S 35 415.25 415.25 415.25 415.25 S 36 423.25 423.25 423.25 423.25 S 37 431.25 431.25 431.25 431.25 S 38 439.25 439.25 439.25 439.25 S 39 447.25 447.25 447.25 447.25 S 40 455.25 455.25 455.25 455.25 S 41 463.25 463.25 463.25 463.25
3.3V_DVDD3.3V_AVDD
GND
12
Y50014.318MHz
C548
5P
C549
5P
+5V_STBY
GND
R505
10K
R504
10K
DDC_SCL_VGA
DDC_SDA_VGA BLUE+BLUE-
GREEN+GREEN-RED+RED-HS_PCVS_PC
R539
250R%1
RMADDR0RMADDR1RMADDR2RMADDR3RMADDR4RMADDR5RMADDR6RMADDR7RMADDR8RMADDR9RMADDR10RMADDR11RMADDR12RMADDR13RMADDR14RMADDR15RMADDR16RMADDR17
RMDATA0RMDATA1RMDATA2RMDATA3RMDATA4RMDATA5RMDATA6RMDATA7
RMADDR0RMADDR1RMADDR2RMADDR3RMADDR4RMADDR5RMADDR6RMADDR7RMADDR8RMADDR9RMADDR10RMADDR11RMADDR12RMADDR13RMADDR14RMADDR15RMADDR16RMADDR17
GND
RMDATA0RMDATA1RMDATA2RMDATA3RMDATA4RMDATA5RMDATA6RMDATA7
C535
100NGND
+3.3V_DVDD
J507
0R
J508
0R
GND
+3.3V_DVDD
R525
10K
R526
10K
R527
10KGND
+3.3V_DVDD
+3.3V_DVDD
YUV[0..7]
VCLK
GND
GND
3.3V_DVDD AVDD_1.8 CVDD_1.8 123456789
1011121314151617181920
S503
DF14 A-20P-1.25C
123456789
101112131415161718192021222324252627282930
S502
DF14 A-30P-1.25C
GNDGND
GND
GND
GND
GND
GND RG500
RG47RRG501
RG47R
RG502
RG47R
RG504RG47R
RG503 RG47R
ER0ER1ER2ER3
ER4ER5ER6ER7
EG0EG1EG2EG3
EG4EG5EG6EG7
RG505
RG47R
EB0EB1EB2EB3
EB4EB5EB6EB7
R50047R
+3.3V_STBY 3.3V_AVDD
3.3V_DVDD+3.3V_STBY
+1.8V_STBY CVDD_1.8
AVDD_1.8+1.8V_STBY
C53722U
C53822U
C539
22U
C54022U
C500100N
C505100N
C506100N
C511100N
C507100N
C508100N
C509100N
C513100N
C514100N
C515100N
C516100N
C519100N
C520100N
C521
100N
C522
100N
C523
100N
C524
100N
C525
100N
C526
100N
C527
100N
C529100N
C530100N
C531100N
C532100N
C533100N
C543220P
C544
220P
C545
220P
C546220P
C547220P
GND
GND
GND
GND
GND4
VCC 8A01
A12
A23 WP 7
SCL 6
SDA 5
U502
24C16
GND
+3.3V_STBYGND R502
100R
R503
100R
3.3V_AVDD
C534
100NGND
+3.3V_STBY
GND
GND
LED_RED
IR
R530
1K
KEYBOARD
3.3V_AVDD
R501
100R
2.LED
VGACONYCOE
ST_BY
SCL3VSDA3V
PNL_EN
SC1_PIN8SC2_PIN8
Q501
2N7002
Q5022N7002
+3.3V_STBY+5V_STBY
R534
3K3
R535
3K3
MUTE
R511
10K
R538
4K7
Q500BC848B
+5V_STBY
GND
RESET
J505
0R
EB7 EB6EB5 EB4
EB3 EB2EB1 EB0
ER0ER1ER2ER3ER4ER5ER6ER7EG0EG1EG2EG3EG4EG5EG6EG7
DEHSVSCLK
SCL5V
SDA5V
SDA3V
SCL3V
RMDATA0..7
RM
DA
TA
[0..7
]
RMADDR[0..17]
3.3V_AVDD
R519
10KRMADDR12+5V_STBY
J504
0R
J506
0R
L500
10uH
L501
10uH
L502
10uH
L503
10uH
L504
10uH
SOG_MCSS
YU
V0
YU
V1
YU
V2
YU
V3
YU
V4
YU
V5
YU
V6
YU
V7
GND
GND
GND
GND
GNDGND
GND
GND
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 40
S506
HEADER2X20
+3.3V
GND
5221_IO15221_IO2
ROM_DATA31
ROM_DATA22
ROM_DATA13
ROM_DATA04
ROM_OEn5
ROM_WEn6
ROM_CSn7
CRVSS 8
CV
DD
_1.8
9
VCO_LV/RESERVED 10AVDD_LV_E_3.311
AVSS_LV_E12
CH3P_LV_E/ER0 13
CH3N_LV_E/ER1 14
CLKP_LV_E/ER2 15
CLKN_LV_E/ER3 16
CH2P_LV_E/ER4 17
CH2N_LV_E/ER5 18
CH1P_LV_E/ER6 19
CH1N_LV_E/ER7 20
CH0P_LV_E/EG0 21
CH0N_LV_E/EG1 22
AVSS_LV_E23
AVDD_LV_E_3.324
AVSS_LV25
AVDD_lv_3.326
AVDD_LV_O_3.327
AVSS_LV_O28
CH3P_LV_O/EG2 29
CH3N_LV_O/EG3 30
CLKP_LV_O/EG4 31
CLKN_LV_O/EG5 32
CH2P_LV_O/EG6 33
CH2N_LV_O/EG7 34
CH1P_LV_O/EB0 35
CH1N_LV_O/EB1 36
CH0P_LV_O/EB2 37
CH0N_LV_O/EB3 38AVSS_LV_O39
AVDD_LV_O_3.340
CV
DD
_1.8
41
CVSS 42
EB4 43
EB5 44
EB6 45
EB7 46
DEN 47
DHS 48
DVS 49
RV
DD
_3.3
50
CRVSS 51
N/C
52
N/C
53
N/C
54
DCLK 55
OR0/JTAG_RESET 56
OR1/RESERVED 57
OR2/RESERVED 58
OR3/RESERVED 59
OR4/RESERVED 60
OR5/RESERVED 61
OR6/RESERVED 62
OR7/RESERVED 63
OG0/JTAG_TDO 64
OG1/RESERVED 65
OG5/JTAG_TDI 66
PPWR 67
PBIAS 68
GPIO15 69
STI_TM2/RESERVED 70
HOST_SDA/UART_DO72
RV
DD
_3.3
73
CRVSS 74
CV
DD
_1.8
75
CRVSS 76
HOST_SCL/UART_DI71
DDC_SCL_VGA77
DDC_SDA_VGA78
DDC_SCL_DVI79
DDC_SDA_DVI80
GPIO0 81
GPIO1 82
GPIO2 83
GPIO3 84
GPIO4 85
GPIO5 88
GPIO6 89
GPIO7/IRQin 90
GPIO8/IRQout 91
GPIO9/SCL 92
GPIO10/SDA 93
CV
DD
_1.8
86
CRVSS 87
CRVSS 94
RV
DD
_3.3
95
CV
DD
_1.8
96
CRVSS 97
GPIO11/PWM0 98
GPIO12/PWM1 99
GPIO13/PWM2 100
GPIO14/PWM3 101
GPI
O16
/VD
AT
A7
102
GPI
O17
/VD
AT
A6
103
N/C
104
N/C
105
GPI
O18
/VD
AT
A5
106
GPI
O19
/VD
AT
A4
107
GPI
O20
/VD
AT
A3
108
GPI
O21
/VD
AT
A2
109
GPI
O22
/VD
AT
A1
110
GPI
O23
/VD
AT
A0
111
VC
LK
112
AVDD_IMB_3.3113
REXT114
AGND_IMB115
VD
D_R
X2_
1.8
116
AGND_RX2117
RX2+118
RX2-119
AVDD_RX2_3.3120
VD
D_R
X1_
1.8
121
AGND_RX1122
RX1+123
RX1-124
AVDD_RX1_3.3125
VD
D_R
X0_
1.8
126
AGND_RX0127
RX0+128
RX0-129
AVDD_RX0_3.3130
AGND_RXC131
RXC+132
RXC-133
AVDD_RXC_3.3134
VBUFC_DVI/RESERVED 135
GND_RXPLL136
VD
D_R
XPL
L_1
.813
7
CLKOUT/RESERVED138
CV
DD
_1.8
139
CRVSS 140
AVDD_BLUE_3.3141
BLUE+142
BLUE-143
AGND_BLUE144
AVDD_GREEN_3.3145
SOG_MCSS146
GREEN+147
GREEN-148
AGND_GREEN149
AVDD_RED_3.3150
RED+151
RED-152
AGND_RED153
AVDD_ADC_3.3154
ADC_TEST/RESERVED155
AGND_ADC156
N/C
157
N/C
158
N/C
159
N/C
160
N/C
161
N/C
162
GND_ADC 163
VD
D_A
DC
_1.8
164
GND_RPLL 165
VD
D_R
PLL
_1.8
166
RESERVED/VBUFC_RPLL 167
AGND_RPLL168
XTAL169 TCLK170
AVDD_RPLL_3.3171 LBADC_VDD_3.3172
LBADC_IN1 173
LBADC_IN2 174
LBADC_IN3 175
LBADC_RETURN 176
LBADC_GND177
RESETn178
CV
DD
_1.8
179
CRVSS 180
HSYNC/CSYNC181
VSYNC182
ROM_ADDR17183
ROM_ADDR16184
ROM_ADDR15185
ROM_ADDR14186
ROM_ADDR13187
ROM_ADDR12188
ROM_ADDR11189
RV
DD
_3.3
190
CRVSS 191
ROM_ADDR10192
ROM_ADDR9193
ROM_ADDR8194
ROM_ADDR7195
ROM_ADDR6196
ROM_ADDR5197
ROM_ADDR4198
ROM_ADDR3199
ROM_ADDR2200
ROM_ADDR1201
ROM_ADDR0202
ROM_DATA7203
ROM_DATA6204
RV
DD
_3.3
205
CRVSS 206
ROM_DATA5207
ROM_DATA4208
U500GM5221
BRT_ADJ
BLK_EN
PANEL_POWER
PANEL_POWER
RESET
SCL3V
SDA3V
SCL3VSDA3V
DEHSVSCLK
+5V
PANEL_POWER
+3.3V+5V
1
2
3
4
S505
MTA100_4
R518
10K
R517
10K
R516
10K
R515
10K
R514
10K
R513
10K
R512
10K
R510
10K
R509
10K
R508
10K
R507
10K
R506
10K
R520
10KR521
10KR522
10KR523
10KR524
10K
RMADDR0
RMADDR1
RMADDR2
RMADDR3
RMADDR4
RMADDR5
RMADDR6
RMADDR7
RMADDR8
RMADDR9
RMADDR10
RMADDR11
RMADDR13
RMADDR14
RMADDR15
RMADDR16
RMADDR17
SCL5V
SDA5V
CE1
SO2
WP3
VSS4
VCC 8
HOLD 7
SCK 6
SI 5
U503
25VF040
DQ013
DQ114
DQ215
DQ317
DQ418
DQ519
DQ620
DQ721
A0 12
A1 11
A2 10
A3 9
A4 8
A5 7
A6 6
A7 5
A8 27
A9 26
A10 23
A11 25
A12 4
A13 28
A14 29
A15 3
A16 2
A17 30
A18 1
G 24
WE 31
E 22
VSS
16V
CC
32 U501M29W040B70K1
ROM_CSNROM_WENROM_OEN
GND
3.3V_DVDD
C550
100N
GND
RMADDR17RMADDR16
RMADDR15ROM_CSN
R543
10K3.3V_DVDDSPI_WER544
10K3.3V_DVDD
SPI_WEIR_INV
3. LED
Q506BC848B
GND
IR
R542
10K
+3.3V_STBY
R545
100RIR_INV
J500
0R
FB_SCR546100R
R547
1K
TP563TP564TP565TP566
R5484K7
+3.3V_STBY
PANEL_POWER
12345678
S509
MOLCON8
+5V +3.3V
J5360R
J5370R
EB0EB1EB2EB3EB4EB5EB6EB7EG0EG1EG2EG3EG4EG5EG6EG7ER0ER1ER2ER3ER4ER5ER6ER7CLKVSHSDE
J5120RJ5130RJ5140RJ5150RJ5160RJ5170RJ5180RJ5190RJ5200RJ5210R
J5220RJ5230RJ5240RJ5250RJ5260RJ5270RJ5280RJ5290RJ5300RJ5310R
J5320RJ5330RJ5340RJ5350R
R549100R
R53710K
R53610K
SCALER
TUNER
1
2
S700
41792-2
PGN
D1
PGN
D2
VD
D3
VD
D4
C1N 5
C1P 6
CH
OLD
7
REG9
AGND10
IN+11
IN-12
SS13
SHDN14
G115
G216
NC
17
FS118
FS219
NC
20
VD
D21
VD
D22
PGN
D23
PGN
D24
NC
25
NC
26
OUT- 27
OUT- 28
OUT+ 29
OUT+ 30
NC
31
NC
32
NC
8
U700MAX9703
C700
100N
C701
100N
+12V
C7091U50V
C702
100N
SWIN
C703100U16V
L700BK1608HM601
L701BK1608HM601
C705100P R700
10K
+5V_STBY
Q700BC848B
R701
4K7ST_BY
C714
220N
C711
220N
C708
220N
C707
220N+5V_STBY
GND
SUBWOOFER
Y56.820
14’’, 20’’LCD TV
Subject to change without notice
S602
CONN-POWER
F600
FUSE 5AVIN1
ON/OFF5 VOUT 2
GN
D3
FBK 4U600 LM2576
S11
G12
S23
G24
D1 8
D1 7
D2 6
D2 5
U602
SI9933ADY
12
S60041792-2
C600100N
C601100N
D6011N5820
L602 PE-54040
GND GND
GND
GND +5V_STBY
+5V_STBY
R60010K
ST_BY
C602100N
GND
GND
+5V
+5V_STBY
+3.3V_STBY
GND
PNL_EN
PANEL_POWER
GND
+12V
POWER
GND
R603
10K
Q601BC848B
R60110K
J603
0RJ600
0RJ601
0RC603100N
L603100uH C6171000U16V
C626100N
C627100N
R602
1K
L601
3.3uHC6051000U16V
C6041000U16V
L600
3.3uH
+12V
POWER
IN3
GN
D2
OUT 1
U606
78L08
+5V_STBY
C619100U16V
C621100U16V
C622100U16V
C607100N
C609100N
C611100N
C610100N
C608100N
C606100N
+5V_STBY
GND
GND
GND
+12V
+3.3V_STBY
+1.8V_STBY
+8V
IN3
1
OUT 2
ADJ
U603 LM1117 3.3V
IN3
1
OUT 2
ADJ
U605 LM1117 1.8V
C620470U
C615100U
IN3
1
OUT 2
ADJU604
LM1117-3.3V
C623100U16V
C612100N
C613100N
+5V +3.3V
GND
AKD600*
1N4148
+2.5V
C628100U16V
SDA 5
AS 6
SIF 11
CVBS 12
5V 13
AF 14
SCL 4
NC 1
NC 2
+5V 3
NC 9
NC 10
GN
D15
GN
D16
GN
D17
GN
D18
TU201
TUN
ER_P
HIL
IPS
GND
R204
100R
R203
100RSCL5V
SDA5V
+5V
C200
100NGND GND
J200
0RGND
SIF
AM
_MO
NO
C201
220N
R205
220R
R207
220R
R208
470R
Q200BC848B
Q201BC848B
GND
R200
470R
R202
470R
R201470R
GND
CVBS_IF
SC1_OUT_V
L200
10uH
N.C
1
5V2
SCL
3
SDA
4
SAS
5
AFT
6
SIF_
OU
T7
VID
EO_O
UT
8
5V9
AU
DIO
_OU
T10
GND 11GND 12GND 13GND 14
TU200 TCPQ9091PD28A
GND
C205100N
C206100N
GND
GND
C204470U16V
C207100U16V
GND
SCL5V
SDA5V
L201
10uH +5VC203100N
C208100U16V
+5V
Q202BC858B
+5V
R206820R
123456789101112
S508
53398-1290
GND
GND
GNDGND
GNDGND
R531
1K
R540
2KR541
470R
C541
22U
C536
100N
GND
GND GND
+5V
R533
1K
R532
1K
R529
10K
R528
10K
+5V
+5V
GND
GND
J509
0R
Q504BC848B
Q505BC848B
TP534
Q503BC848BLT1
BRT_ADJ
BLK_EN
J501
0R
1234567
S500
MOLCON7
GND
+12V
+12V
GND
Components designated by the safety symbol should only be replac ed by original parts produced and proofed by the manufacturer.
Sicherheitsbautelle im Sinn der sicherheitsbestimmung. Diese Teile durfen nur durch Originalteile ersetzt werden.
Contrassegno di sicurezza. I componenti devono, corrispondere a ricambi originali e devono essere montati a regola d’arte.
Y56.820
14’’, 20’’LCD TV
VIN172
VIN273
VIN475
CIN71
VIN374
Y7 31
Y6 32
Y5 33
Y4 34
Y3 37
Y2 38
Y1 39
Y0 40
NC61 NC8
VRT66
TEST16
SCL13
SDA14
I2CSEL67
XTAL263
XTAL162
RESQ15
C7 41
C6 42
C5 43
C4 44
C3 47
C2 48
C1 49
C0 50
LLC2 27
LLC1 28
VS 57
MSY/HS 56AVO 54
INTLC 53
VSU
PCA
P9
VSU
PAI
76V
SUPF
69V
STB
Y59
VSU
PLLC
29
VSU
PSY
52V
SUPC
45V
SUPY
36
VSU
PA26
VSU
PD10
ASG
F7
ASG
F64
GN
DD
11
GN
DC
AP
12
GN
DPA
25
GN
DLL
C30
GN
DY
35
GN
DC
46
GN
DSY
51
GN
DF
65
ISG
ND
68
GN
DA
I77
AIS
GN
D80
B1/CB1IN1
G1/Y1IN2
R1/CR1IN3
B2/CB2IN4
G2/Y2IN5
R2/CR2IN6
VGAV17
YCOEQ18
FFIE 19FFWE 20FFRSTW 21FFRE 22FFOE 23
CLK20 24
FSY/HC 55
FPDAT 58
CLK5 60
VOUT70
VREF78
FB1IN79
U100
VPC3230D
+5V C101
100N
C102
100N
C103
100N
C127
220P
C125
100U16V
GND
C104100N
C105100N
C106100N
C107100N
C108100N
C109100N
C110100N
C128220P
C126
100U16V
+3.3V
GND
RG100 47R
RG101 47R
YUV0YUV1YUV2YUV3YUV4YUV5YUV6YUV7
YUV[0..7]
GND
GND
O_VS
O_HS
GND
GND
R108
100RR109
100R
SCL5V
SDA5V
12
Y100
20.25MHz
GND
GND
C118
100N
R119
220R
GND
RESET
R118
220R
C117
100NGND
YCOE
C140
47N
C139
47N
GNDGND
C137
22U50V
R12112K
R11722K
R12022R
R1111K
R102
75R
R101
75RQ100
BC848B
GNDGND GND
SC2_OUT_V
CVBS_TXT
C116
100N
C114
100N
C112
100N
C115
100N
C113
100N
C111
100NB_TXT
G_TXT
R_TXT
SC_B
SC_G
SC_R
FB_TXT
C129470N63V
C130470N63V
C131470N63V
C132 470N63V
C10010N
SVHS_Y
SVHS_C
SC2_IN_VCVBS_IF
SC1_IN_V
J100
0RR110
10K
GND
+5V
L101
10uH
L100
10uH
C119
220NC1211N5C135
390P
GNDGNDGND
C136390P
C120220N
C1221N5
GND GND GND
C133
3P363VC134
3P3
VCLK_INV
1
2
3
4
5
U101
GND
+3.3V
C141100N
GND
VCLK_INV C14222P
GND
VCLK
TP100
R113
100RR114
100R
R112680R
R11510K
R11610K
C12410U
C12310U
J102
0RC14310P
GND
L103BK1608HM601
L102
10uH +3.3VC144100N
C145100U16V
VIDEO
Subject to change without notice
EB7 EB6EB5 EB4
EB3 EB2EB1 EB0
ER0ER1ER2ER3ER4ER5ER6ER7EG0EG1EG2EG3EG4EG5EG6EG7
DEHSVS
CLK
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 40
S2
HEADER2X20
+3.3V
GND
PANEL_POWER
+5V
PANEL_POWER
+3.3V+5V
123456789
1011121314151617181920212223242526272829303132333435363738394041424344454647484950
S1
FH12-50S-0.5S-top contact
R147R
C222P
GND
GNDL1
FERRITE BEADPANEL_POWER
C1220N
GND GND
GND
GND
GNDRG1
47RRG2
47RRG3
47RRG4
47RRG5
47RRG6
47R
GND
GND
GND
GND
GND
GNDGND
HSVS
DE
CLK
ER0ER1ER2ER3
ER4ER5ER6ER7
EG0EG1EG2EG3
EG4EG5EG6EG7
EB0EB1EB2EB3
EB4EB5EB6EB7
DAUGTHER BOARD
A020
A119
A218
A317
A416
A515
A614
A713
A83
A92
A1031
A111
A1212
A134
A1411
A157
A1610
CS130
OE32
WE5
IO1 21
IO2 22
IO3 23
IO4 25
IO5 26
IO6 27
IO7 28
IO8 29
VC
C8
VSS
24
NC 9
CS26
U302K6T1008V2E-TB A020
A119
A218
A317
A416
A515
A614
A713
A83
A92
A1031
A111
A1212
A134
A145
A1511
A1610
CE30
OE32
WE7
DQ0 21
DQ1 22
DQ2 23
DQ3 25
DQ4 26
DQ5 27
DQ6 28
DQ7 29
VC
C8
VSS
24
A176
A189
U30029LV040
12345678910111213141516 17
181920212223242526272829303132
S300
HEADER2X16
GND
GND
A0A1A2A3A4A5A6A7
A8A9A10A11A12A13A14A15A16
A17A18
D0D1D2D3D4D5D6D7
A0A1A2A3A4A5A6A7A8A9A10A11A12A13A14
A15
A16A17
D0D1D2D3D4D5D6D7
A0A1A2A3A4A5A6A7A8A9A10A11A12A13A14A15A16A17A18
D0D1D2D3D4D5D6D7
A0A1
A2A3A4A5A6
A7
A8A9
A10
A11
A12 A13A14
A15
A16A17A18
D0D1D2D3
D4D5D6D7
/RST
WE
GND
/PSEN
GND/PSEN
R307
1K
WE
C306
100NGND
C305
100NGND
/RAMRD/RAMWR
/RAMRD/RAMWR
O_VS
CVBS_TXTO_HS
12
Y300
6MHz
C31733P C318
33PGND
R306
100R
R304
100RR305
100R
R_TXT
G_TXT
B_TXT
FB_TXT
GND
GND
GND
GND
/PSEN
3.3V_M3.3V_M
3.3V_M
3.3V_M
A2.5V_M
D2.5V_M
3.3V_M
RESET
+3.3V
+2.5V
+2.5V
C310
22U
C311
22U
C312
22U
C300
100N
C301
100N
C302
100N
C303
100N
C304
100N
C307
100N
C308
100N
GND GND GND GND
GND GND GND
GND GND GND
R308
1K
Q300BC858B
R301
47R
R300
47R
R315
180R
C315470P
+5V
GND
GND
C313
22UGND
GND
C309
100NGND
R314
4K7
R313
2K2/RST
D0..7 D0..7
D0.
.7
A0.
.18
A0..18
A0..18
A0.
.18
L300
10uH
L301
10uH
L302
10uH
P1.044
P1.347
P1.650
P1.145
P1.448
A7 74
A6 76
A5 78
A4 80
A3 82
A2 2
A1 3
A0 5
P0.118 P0.017
P4.352
BLANK/COR61
CVBS25
HS/SC32
P4.7/VS/OE33
XTAL254
XTAL155
RST53
A15 67
A14 71
A13 73
A12 72
A11 79
A10 83
A9 77
A8 75
D7 4
D6 6
D4 10
D1 9D2 11
D5 8
VD
D2.
568
VD
D2.
514
VD
DA
2.5
57V
DD
A2.
526
VD
D3.
316
VD
D3.
370
VD
D3.
343
VD
D3.
31
VSS
A27
VSS
A56
VSS
15
VSS
42
VSS
69
VSS
84
P3.034
P3.135
P3.236
P3.337
P3.438
P3.539
P3.741
P4.251
PSEN 81
XROM 13
D0 7
P0.724
P3.640
P1.762
A19/P4.4 63
A18/P4.1 64
A17/P4.0 66
A16 65
D3 12
P0.219
P0.320
P0.421
P0.522
P0.623
P1.246
P1.549
P2.028
P2.129
P2.230
P2.331
R58
G59
B60
U301SDA5550
SDA3VSCL3V
R316100R
R311 100R5221_IO15221_IO2
VCC 8
WP 7
SCL 6
SDA 5
A01
A12
A23
GND4
U304
24LC16
R321
4K7
R320
4K7
3.3V_M
3.3V_M
GND
R_TXT
G_TXT
B_TXT
FB_TXT
C314
470N63V
J303
0RGND
+3.3V
SDASCL
SCLSDA
J304
0R
A18
J306
0R
A19
A19
J3050R
J3070RA18
R31747K
3.3V_M
C319220P
C320220P
C321220P
L3034.7uH
R302 1K
R303 1K
C316
100P
GND
GND
GNDGND
R322
10K
R323 10K
R32410K
R32510K
J3090R
J3100R
GND
GND+3.3V
3.3V_M
3.3V_M
TELETEXT
GND
GNDKEY_DRLKEY_PMUIRLED_RED
3.3V
GND
GND
OUTGNDVs
GND
S2P+
S5P-
S1MENU
S4V+
S3V-
R5
180R
R3
330R
R7
470R
R6
1K1234567
CN1
7 HEADER
R1150R
12
C110uF/10V
R2150R
Out1
GND2
Vs3
IR1
IR
R8
270R
R4470R
D1LED
GND
S6AV/TV
R9
3K9
KEYBOARD MODULE
SW1
SW-SPST
1234
P2
4 HEADER
POWER
R910K
R1010K
GND
C210uF/16V
SW1
SW SPST
1234567
P2
7 HEADERGND
S1
S2
S3
G4 D 5D 6D 7D 8U1
FDS6675A
1234
P3
SPEAKER
OPTION POWER
GND
IRLED_RED
3.3V
GND
OUTGNDVs
GND
12
C110uF/10V
Out1
GND2
Vs3
IR1
IR
D1
LED_RED
GND
123456
CN1
MOLCON6
R1150R
R2150R
R3
4K7
Q1BC848B
LED_GREEN
R4100R
GND
R5
4K7
R6
100R
Q2BC848B
GND
D3
LED_BLUE
GND
D2
LED_GREEN
GND
LED_BLUE
OPTION
HEAD PHONE MODULE
1
2
3
X940
R943
R942R940
R941
R
GND
L
X941
C940
C94139R
39R
47n/100V
47n/100V
330R
330R
HEAD
PHON
E
HEAD
PHON
E JA
CK
11
33
55
77
99
1111
1313
1515
1717
1919
22
44
66
88
1010
1212
1414
1616
1818
2020
2121
P400SCART 1
11
33
55
77
99
1111
1313
1515
1717
1919
22
44
66
88
1010
1212
1414
1616
1818
2020
2121
P402SCART 1
1
2
S400
RCA VIDEO
NC
1
I2C
_CL
2
I2C
_DA
3
I2S_
CL
4
I2S_
WS
5
I2S_
DA
_OU
T6
I2S_
DA
_IN
17
AD
R_D
A8
AD
R_W
S9
AD
R_C
L10
DV
SUP
11
DV
SUP
12
DV
SUP
13
DV
SS14
DV
SS15
DV
SS16
I2S_
DA
_IN
217
NC
18
NC
19
NC
20
RES
ETQ
21
NC
22
NC
23
DA
CA
_R24
DACA_L 25VREF2 26DACM_R 27DACM_L 28NC 29DACM_SUB 30NC 31NC 32SC2_OUT_R 33SC2_OUT_L 34VREF1 35SC1_OUT_R 36SC1_OUT_L 37CAPL_A 38AHVSUP 39CAPL_M 40
NC
41N
C42
AH
VSS
43A
HV
SS44
AG
ND
C45
NC
46SC
4_IN
_L47
SC4_
IN_R
48A
SG49
SC3_
IN_L
50SC
3_IN
_R51
ASG
52SC
2_IN
_L53
SC2_
IN_R
54A
SG55
SC1_
IN_L
56SC
1_IN
_R57
VFE
RTO
P58
NC
59M
ON
O_I
N60
AVSS
61AV
SS62
NC
63N
C64
AVSUP65
AVSUP66
ANA_IN1+67
ANA_IN-68
ANA_IN2+69
TESTEN70
XTAL_IN71
XTAL_OUT72
TP73
AUD_CL_OUT74
NC75
NC76
D_CTR_I/O_177
D_CTR_I/O_078
ADR_SEL79
STBYQ80
U401MSP-PQFP80
-INV11
SGND2
SVRR3
OUT14
PGND5
OUT26
VP7
M/SS8
-INV29 GND 10
GND 11
GND 12
GND 13
GND 14
GND 15
GND 16
GND 17
GND 18
U402
TDA1517P
162738495
11
12
13
14
1510
1617
Shell
Shell
P401DB15 HD_SH
VCC 8
WP 7
SCL 6
SDA 5
A01
A12
A23
GND4
U400
24LC02
R421
100RR422
100R
SCL5V
SDA5V
GND
C4481N
C47610P
C412
100N
RES
ET
R464220R
GND
GND
1
2
3
S401
To Headphone
GND
GND
C4461N
GND
C4471N
C4421N
C4431N
R458
2K2
R457
2K2
GND GND
GND
C4441N
C4401N
C4411N
C4451N
1
2
S407RCA JACK
1
2
S408
RCA JACK
GND GNDGND
GNDGNDGND
C4371N
C4351N
GND
GND
R453
330R
R454
330R
R452
330R
R449
330R
C408
100NGND
C439
1N
C438
1N
GND
GND
R450330R
R451
330R
GND
C453
3.3U50VC409
100NGNDGNDGND
C415
220N
C419
220N
C414
220N
C417
220N
C416
220N
C418
220N
C4331N
C4251N
C4301N
C4311N
C4281N
C4271N
R441
1K
R442
1K
R446
1K
R444
1K
R443
R445GND
GND
GND
GND
GND
GND
1
2
S405RCA JACK
1
2
S406RCA JACK
GND
GND
C407
100N
C410
100N
GND
GND
+5V
SIF
C46656P
C467
56PC468
56PGND
GNDGND
GND
12
Y40018.432MHz
C4691P8
C470
1P8GND
GND
C4241N
C4261N
C4291N
C4321N
GND
GND
GND
GND
SC_B
SC_G
SC_R
SC1_
PIN
8
SC1_
OU
T_V
SC1_
IN_V
R41475R
R415
75R
R41675R
GND GND GND
GND
FB_SC
R40975R
GND
R427
10K
GND
GND
R41775R
GND
SC2_
OU
T_V
R433
10K
GND
SC2_PIN8
R43410K
C420
220N
GND
GND
C471
1000U16VC472
1000U16V
1234
S409
to s
peak
ers
GND
C4731000U16V
C411100N
GND GND
R425
47K
R46527K
R437
10K
Q402BC848B
MUTE
GNDGND
R43510K
C422
220N
GND
J401
0RJ402
0R
GND
R40875R
R41175R
SVHS_C
SVHS_Y
GND
GND
GND
AKD400
1N4148
AKD4011N4148
C406100N
GND
R42347K
R42447K
GND
GND
R419
100R
R420
100R
R412
75RR413
75RR43210K
R43110K
GND
GND
C45222P
C45122P
GND
HS_PC
VS_PC
GND
R41075R
R40675R
R40775R
R400
47R
R402
47R
R404
47R
C400
10NC401
10N
C402
10N
C403
10N
C404
10NC405
10N
RED+
RED-
GREEN+
GREEN-
BLUE+
BLUE-
GND
GND
GND
GND
DDC_SDA_VGA
DDC_SCL_VGA
GND
23 4
14321 S404
CONN-DIN4
AM_MONO
+5V
+8V
+5V
VGA_5V
VGA_5V
+12V
OU
TA1
INA
(NEG
)2
INA
(PO
S)3
VSS
4IN
B(P
OS)
5
INB
(NEG
)6
OU
TB7
VD
D8
U403TDA1308
C421
220N
C423
220N
R460
4K7
R461
4K7
C4792N2
C4812N2
C4822N2
C4802N2
GND
GND
GND
C413100N
GND
+5V_AUDR436
10K R43810K
GND GNDR463
5K6
R462
5K6
C474
1N5
C475
1N5
C4491N
C4501N
C477
100U16V
C478
100U16V
GND
GND
GND
R42910K
R42810K
R43010K VGACON
GND
L400
10uH
L401
10uH
+5VL402
10uHC485100N
GND GND
+5V_AUD
GND
C4361N
C4341N
GND
GND
R44775R
GND
MAIN_L
MAIN_R
MAIN_L
MAIN_R
SC2_OUT_R
SC2_OUT_L SC2_OUT_R
SC2_OUT_L
SC2_IN_L
SC2_IN_R
SC1_IN_L
SC1_IN_R
SC2_IN_R
SC2_IN_L
SC1_OUT_L
SC1_OUT_R
SC1_OUT_R
SC1_IN_R
SC1_OUT_L
SC1_IN_L
SC2_IN_V
SC2_IN_V
C487
1NC4881N
GND GND
R401
R403
84R5
C489
10NSOG_MCSS
R426
470R
R44810K
POWER
12
3
D402BAV99L
12
3
D403BAV99L
12
3
D404BAV99L
R405
GND
GND
GND
VGA_5V
VGA_5V
VGA_5V
12
3D405BAV99L
12
3
D406BAV99L
VGA_5V
VGA_5V
R455
100R
R456
47K
GND
R466
fuse direnç
R43910K
R44010K
C461
10U63V
C486100U16V
C483100U16V
C462
100U16V
C465100U16V
C46310U50V C464
10U50V
C45647U16V
C45747U16V
C454
47U16V
C455
47U16V
C458
47U16V
C459
47U16V
C460
47U16V
C48447U16V
SWIN
Q403BC848B
GND
R467100R
R468
39K
GND
R46975R
GND
R418
10K
Q404BC848B
GND
R470
10K3.3V_M
C490100N
GND
AUDIO
Components designated by the safety symbol should only be replac ed by original parts produced and proofed by the manufacturer.
Sicherheitsbautelle im Sinn der sicherheitsbestimmung. Diese Teile durfen nur durch Originalteile ersetzt werden.
Contrassegno di sicurezza. I componenti devono, corrispondere a ricambi originali e devono essere montati a regola d’arte.
POWER
12VC627470U25V
3.3uH
L600
GND
TP600C602100N
GND
C638
22N
GND
C600
100NC601
100N
GND
GND
GNDR600
10K
GND
C637470U25V
GND
C62610N D608
MBRS130LTR
R605
100R
C6281000U16V
C603100N
3.3uH
L601
TP602
C6291000U16V
C604100N
C625
10N
C636
1N5GND
5V_STBY
GND
GND GND GND GND
TUNER_SU10uH
L603
BS1
VIN2
OUT3
GND4 FB 5
COMP 6
EN 7
SS 8
U600
MP1593
C611
220N
C605
220N
R603
10K
J600
0RJ601
0RJ602
0R
R60210K
Q600BC848B
C618100N
GND
GND
5V_STBY
3V3_STBY
12V
TP605
C609100N
C610100N
C630100U16V
C639470U16V
IN3
1
OUT 2
ADJ
U601 LM1117 3V3
5V_STBY 3V3_STBY
GNDGND GNDGND GND
S11
G12
S23
G24
D1 8
D1 7
D2 6
D2 5
U604
SI9933ADY
C622100N
GND
R60410K
C617100N
GND
GND
5VC621100N
TP604
C615100N
C616100N
C631100U16V
IN3
1
OUT 2
ADJ
U603 LM1117 1V8
5V_STBY 1V8_STBY
GNDGND GNDGND GND
C632100U16V
C619100N
C633100U16V
C620100N
12V 8VTP603
GND GND GNDGND
C623100N
C624100N
C634100U16V
5V 3V3
GNDGND GNDGND GND
C635100U16V
TP6061K
R607
TP607
GND
TUNER_SU
1K
R606
REGULATORS
33V 33V
PANELPWR PANELPWR
PNL_ENPNL_EN
STBYSTBY
5V_STBY
12
3
D600BAV99L
12
3
D601BAV99L
12
3
D602BAV99L
12
3D603BAV99L
C606
220N
C607
220N
C608
220NC612
220N
C613
220N
C614
220N
IN3
2
OUT 1
GND
U605
MC78L08CP
12V INV_POW4.7uH
L605
IN3
1
OUT 2
ADJ
U606 LM1117 3V3
R601
18K
R608
56K
L609
22uH - CDRH104R
TP274STBY2STBY2
Significant for 26"-27"-30" chassis
4.7uH
L60212V AMP_POW
GND1
VSUP8.0AU2
VREFAU3
SPEAKERL4
SPEAKERR5
AOUT1L6
AOUT1R7
AIN3L/AOUT2L8
AIN3R/AOUT2R9
AIN2L10
AIN2R11
AIN1L12
SIF/AIN1R13
TAGC14
VREFIF15
IFIN-16
IFIN+17
RESETQ18
VSUP5.0FE19
VSUP5.0IF20
VSUP3.3DIG21
GND22
GND23
VSUP1.8DIG24
XTAL125
XTAL226
P2227
P2328
VIN1129
VIN1030
VIN931
VIN832
VIN733
VIN634
VIN535
VIN436
VIN337
VIN238
VIN139
VOUT140
VOUT241
VOUT342
VSUP1.8FE43
GND44 GND 45VSUP3.3VFE 46P10 47P11 48P12 49P13 50P14 51P15 52P16 53P17 54P20 55P21 56SCL 57SDA 58VPROT 59HOUT 60HFLB 61SAFETY 62GNDDAC 63VSUP3.3DAC 64VSUP3.3IO 65GND 66GND 67VSUP3.3BE 68XREF 69VRD 70BOUT 71GOUT 72ROUT 73SVMOUT 74BIN 75GIN 76RIN 77FBIN 78GNDM 79SENSE 80RSW1 81RSW2 82EW 83VERT- 84VERT+ 85TEST/SUBW 86VSUP5.0BE 87GND 88
U303
VCT-IF PSSDIP88(2)
VDD1V8D1V8_STBY
1V8_STBY VDD1V8FE
3V3_STBY VDD3V3FE
3V3_STBY VDD3V3IO
3V3
3V3
VDD3V3D
VDD3V3BE
5V VDD5VFE
5V VDD5VIF
5V VDD5VBE
3V3 VDD3V3DAC
C308100N
C4113.3U50V
1K R358 GND
GND
12
Y30020.25MHz
C41322P
C41422P
GND
GNDGND
GND
GND
GND GND
GND
GND
L300
10uH
L301
10uH
L310
10uH
L302
10uH
L303
10uH
L304
10uH
L306
10uH
L305
10uH
L307
10uH
L308
10uH
C34110U25V
C300100N
C337470P
GND
VDD1V8D
C34210U25V
C301100N
C3711N
GND
VDD1V8FE
C34410U25V
C338470P
GND
VDD3V3FE
C34510U25V
C303100N
GND
VDD3V3IO
GND
GND
GND
GND
GND
C34610U25V
C304100N
VDD3V3D
C34810U25V
C339470P
VDD3V3BE
C305100N
VDD5VFE
C35010U25V
C306100N
VDD5VIF
C35410U25V
C307100N VDD5VBE
8V
C35810U25V
C340470P
GND
VDD3V3DAC
C310100NGND
VC
T-IF
R345
100R
R346
100R
C334
22U50V
C333
22U50VC3781N
C3801N
C3791N
C3811N
GND
GNDGND
GND
SC1_OUT_L
SC1_OUT_R
AOUT1L
AOUT1R
AOUT1RAOUT1L
C3771N
R354
470R C418330P
C399
220N
C3761N
R353
470R C417330P
C398
220N
GND GND
GND GND
SC1_IN_L
SC1_IN_R AIN2R
AIN2L
AIN2LAIN2R
SPEAKERLSPEAKERR
RINGINBIN
C332100N
C402
100N
SVHS_CSVHS_Y
GND
R37375R
GNDGND
R37175R
R37275R
GND
GND
SVHS_C
SVHS_Y
TP311
TP312
GND
C329
100N
RCA_CVBS
RCA_CVBS
FBLIN
SC1_CVBS_INSC2_CVBS_IN
AIN1LAIN1R
AOUT2LAOUT2R
C3831N
R356
470R C420330P
C401
220N
C3821N
R355
470R C419330P
C400
220N
GND GND
GND GND
SC2_IN_L
SC2_IN_R
GND
C4211N
C4221N
C403
220N
C404
220N
RCA_LEFT
RCA_RIGHT
VOUT1VOUT2
SC2_I_L
SC2_I_R
C444
47U16VC3921N
C3931N
R402
330R
1KR360
Q306BC858B
R336
3K3
C442
47U16V
R400
330R C3891N
GNDGNDGND
GND
8V
GND
AOUT2L
SC2_OUT_L
C443
47U16VC3901N
C3911N
R401
330R
1KR359
Q305BC858B
R335
3K3
C441
47U16V
R399
330R C3881N
GNDGNDGND
GND
8V
GND
AOUT2R
SC2_OUT_R
TP313
TP316
TP314
TP315
GND
UART_RX
UART_RXVS_VCT
HS_VCT
C313100N
C4124.7U50V
GND GND
VDD5VBEGNDGNDGNDGND
GND
GNDGND
GND
GND GND
GND
GND
5V VDD5VAUDL311
10uH
GND
C314100N
C36010U25V
VCT-IF AND PERIPHERALS
SDA3V3SCL3V3
UART_TX
R3373K3
R3383K3
3V3_STBY
UART_TXUART_RX
HS_VCTVS_VCT
RESETQRESETQ BLUEGREENRED
BLUE_VCT GREEN_VCT RED_VCT
SUBWOOFER SUBWOOFER
Q2012N7002
Q200
2N7002R2333K3
R2343K3
R20210K
R20310K
J224
0R
J225
0R
3V3_STBY5V_STBY
SCL3V3
SDA3V3SDA5V
SCL5V SCL3V3
SDA3V3
TP321
SDA5V
SCL5V
R4226K8
VDD5VFE
175mA
225mA
48mA
11mA
95mA
25mA
65mA
18mA
26mA
150mA
SPEAKERLSPEAKERR
C316100N
C322100N
C35610U25V
C309100N
GND GND
GND
Q311BC858ALT1
Q310
BC848
8V
GND
C327100N
R325
22RR329
2K7 12
3D301BAV99L
R32633R
C335560P
BLUE
R330150R
VDD5VBEVDD5VBE
R347270R
GND
BLUE_VCT
Q312BC858ALT1
R32733R
C336560P
GREEN
R331150R
VDD5VBER348270R
GND
Q313BC858ALT1
R32833R
C363560P
RED
R332150R
VDD5VBER357270R
GND
GREEN_VCT RED_VCT
TP309TP306
TP317
TP319
TP320
J3140RJ3150R
J3050R
TP322GND
C38547U16V
GND
IFIN+IFIN-
AGC
R363
75R
R374
180R R375150R
R351470R
R30010K
R36118K
Q303BC858B
Q307BC848
5V
GND
GND
C343
10U25V
VOUT1
SC1_CVBS_OUT
C323100N
R364
75R
R376
180R R377150R
R352470R
R30110K
R36218K
Q304BC858B
Q308BC848
5V
GND
GND
SC2_CVBS_OUT
C324100N
C347
10U25V
VOUT2
L309
8.2uH
R36575R
R36775R
R36875R
R36975R
C318
100N
C319
100N
C320
100N
SC1_BLUE
SC1_RED
SC1_GREEN
BIN
GIN
RIN
GND
GND
GND
GND
SC1_FBL R323
10K
R322
10K
Q309BC848
VDD3V3D
GND
C321100N
GND
FBLIN
J306 0R FBLINSC1_FBL
Optional
L317
10uH
L319
10uH
C38647P
C38747P
GND
GND
Close to VCTi
Close to VCTi
L318
10uH
L321
10uH
A connector for theLight Sensor option.
L314 Ferrite Bead
L315Ferrite Bead
L323
10uH
L324
10uH
1234567
JP300
MOLCON7
Option for Side AV
SVHS_C_AVSVHS_Y_AV
GNDCVBS_AVRIGHT_AV
GNDLEFT_AV
1
2
S304
CVBS_AV
LEFT_AV
RIGHT_AV
SC1_FBL
SC1_CVBS_INSC2_CVBS_IN
SC1_CVBS_OUT
SC1_RED
SC1_GREEN
SC1_BLUE
SC1_IN_L
SC1_IN_R
SC1_OUT_L
SC1_OUT_R
SC2_CVBS_OUT
SC2_IN_L
SC2_IN_R SC2_OUT_L
SC2_OUT_R
3
4
1
2
Signal
Gnd
Gnd
Gnd J312
3
4
1
2
Signal
Gnd
Gnd
GndJ308
3
4
1
2
Signal
Gnd
Gnd
Gnd
J311
GND
GND
GND
GND
GND
GND
3
4
1
2
Signal
Gnd
Gnd
Gnd
J310
3
4
1
2
Signal
Gnd
Gnd
Gnd
J309GND
GND
GND
GND
234
1 4321
Gnd0
J307
CONN-DIN4
GND1K
R423
1K
R424
SAFETY SAFETY
C470
470P
C471
470P
C42333P
GND
SVHS_Y_AV
SVHS_C_AV
ROM_DATA31
ROM_DATA22
ROM_DATA13
ROM_DATA04
ROM_OEn5
ROM_WEn6
ROM_CSn7
CRVSS 8
CV
DD
_1.8
9
VCO_LV/RESERVED 10AVDD_LV_E_3.311
AVSS_LV_E12
CH3P_LV_E/ER0 13
CH3N_LV_E/ER1 14
CLKP_LV_E/ER2 15
CLKN_LV_E/ER3 16
CH2P_LV_E/ER4 17
CH2N_LV_E/ER5 18
CH1P_LV_E/ER6 19
CH1N_LV_E/ER7 20
CH0P_LV_E/EG0 21
CH0N_LV_E/EG1 22
AVSS_LV_E23
AVDD_LV_E_3.324
AVSS_LV25
AVDD_lv_3.326
AVDD_LV_O_3.327
AVSS_LV_O28
CH3P_LV_O/EG2 29
CH3N_LV_O/EG3 30
CLKP_LV_O/EG4 31
CLKN_LV_O/EG5 32
CH2P_LV_O/EG6 33
CH2N_LV_O/EG7 34
CH1P_LV_O/EB0 35
CH1N_LV_O/EB1 36
CH0P_LV_O/EB2 37
CH0N_LV_O/EB3 38AVSS_LV_O39
AVDD_LV_O_3.340
CV
DD
_1.8
41
CVSS 42
EB4 43
EB5 44
EB6 45
EB7 46
DEN 47
DHS 48
DVS 49
RV
DD
_3.3
50
CRVSS 51
N/C
52
N/C
53
N/C
54
DCLK 55
OR0/JTAG_RESET 56
OR1/RESERVED 57
OR2/RESERVED 58
OR3/RESERVED 59
OR4/RESERVED 60
OR5/RESERVED 61
OR6/RESERVED 62
OR7/RESERVED 63
OG0/JTAG_TDO 64
OG1/RESERVED 65
OG5/JTAG_TDI 66
PPWR 67
PBIAS 68
GPIO15 69
STI_TM2/RESERVED 70
HOST_SDA/UART_DO72
RV
DD
_3.3
73
CRVSS 74
CV
DD
_1.8
75
CRVSS 76
HOST_SCL/UART_DI71
DDC_SCL_VGA77
DDC_SDA_VGA78
DDC_SCL_DVI79
DDC_SDA_DVI80
GPIO0 81
GPIO1 82
GPIO2 83
GPIO3 84
GPIO4 85
GPIO5 88
GPIO6 89
GPIO7/IRQin 90
GPIO8/IRQout 91
GPIO9/SCL 92
GPIO10/SDA 93
CV
DD
_1.8
86
CRVSS 87
CRVSS 94
RV
DD
_3.3
95
CV
DD
_1.8
96
CRVSS 97
GPIO11/PWM0 98
GPIO12/PWM1 99
GPIO13/PWM2 100
GPIO14/PWM3 101
GPI
O16
/VD
AT
A7
102
GPI
O17
/VD
AT
A6
103
N/C
104
N/C
105
GPI
O18
/VD
AT
A5
106
GPI
O19
/VD
AT
A4
107
GPI
O20
/VD
AT
A3
108
GPI
O21
/VD
AT
A2
109
GPI
O22
/VD
AT
A1
110
GPI
O23
/VD
AT
A0
111
VC
LK
112
AVDD_IMB_3.3113
REXT114
AGND_IMB115
VD
D_R
X2_
1.8
116
AGND_RX2117
RX2+118
RX2-119
AVDD_RX2_3.3120
VD
D_R
X1_
1.8
121
AGND_RX1122
RX1+123
RX1-124
AVDD_RX1_3.3125
VD
D_R
X0_
1.8
126
AGND_RX0127
RX0+128
RX0-129
AVDD_RX0_3.3130
AGND_RXC131
RXC+132
RXC-133
AVDD_RXC_3.3134
VBUFC_DVI/RESERVED 135
GND_RXPLL136
VD
D_R
XPL
L_1
.813
7
CLKOUT/RESERVED138
CV
DD
_1.8
139
CRVSS 140
AVDD_BLUE_3.3141
BLUE+142
BLUE-143
AGND_BLUE144
AVDD_GREEN_3.3145
SOG_MCSS146
GREEN+147
GREEN-148
AGND_GREEN149
AVDD_RED_3.3150
RED+151
RED-152
AGND_RED153
AVDD_ADC_3.3154
ADC_TEST/RESERVED155
AGND_ADC156
N/C
157
N/C
158
N/C
159
N/C
160
N/C
161
N/C
162
GND_ADC 163
VD
D_A
DC
_1.8
164
GND_RPLL 165
VD
D_R
PLL
_1.8
166
RESERVED/VBUFC_RPLL 167
AGND_RPLL168
XTAL169 TCLK170
AVDD_RPLL_3.3171 LBADC_VDD_3.3172
LBADC_IN1 173
LBADC_IN2 174
LBADC_IN3 175
LBADC_RETURN 176
LBADC_GND177
RESETn178
CV
DD
_1.8
179
CRVSS 180
HSYNC/CSYNC181
VSYNC182
ROM_ADDR17183
ROM_ADDR16184
ROM_ADDR15185
ROM_ADDR14186
ROM_ADDR13187
ROM_ADDR12188
ROM_ADDR11189
RV
DD
_3.3
190
CRVSS 191
ROM_ADDR10192
ROM_ADDR9193
ROM_ADDR8194
ROM_ADDR7195
ROM_ADDR6196
ROM_ADDR5197
ROM_ADDR4198
ROM_ADDR3199
ROM_ADDR2200
ROM_ADDR1201
ROM_ADDR0202
ROM_DATA7203
ROM_DATA6204
RV
DD
_3.3
205
CRVSS 206
ROM_DATA5207
ROM_DATA4208
U200GM5221_1
12
Y20014.318MHz
C251
5PF
C252
5PF
ROM_ADDR0ROM_ADDR1ROM_ADDR2ROM_ADDR3ROM_ADDR4ROM_ADDR5ROM_ADDR6ROM_ADDR7ROM_ADDR8ROM_ADDR9ROM_ADDR10ROM_ADDR11ROM_ADDR12ROM_ADDR13ROM_ADDR14ROM_ADDR15ROM_ADDR16ROM_ADDR17
R20410K
R20510K
R20610K
R20710K
R20810K
R20910K
R21010K
R21110K
R21310K
R21410K
R21510K
R21610K
R21710K
R21910K
R22010K
R22210K
R22410K
ROM_ADDR0
ROM_ADDR1
ROM_ADDR2
ROM_ADDR3
ROM_ADDR4
ROM_ADDR5
ROM_ADDR6
ROM_ADDR7
ROM_ADDR8
ROM_ADDR9
ROM_ADDR10
ROM_ADDR11
ROM_ADDR12
ROM_ADDR13
ROM_ADDR14
ROM_ADDR15
ROM_ADDR16
R22510K ROM_ADDR17
3V3AVDD
3V3DVDD 1V8AVDD 1V8CVDD
3V3DVDD
CE1
SO2
WP3
VSS4
VCC 8
HOLD 7
SCK 6
SI 5
U203
25VF040
R231
10K3V3DVDD
ROMCSROMWEROMWOE
ROM_ADDR15ROMCS
3V3DVDDR230
10K
C242100N
GND
ROM_ADDR16ROM_ADDR17
R22710K
R22810K
R22910K
3V3DVDD
250R%1R237
3V3AVDD
TP241
3V3AVDD
R23247R
CLKVSHSDE
3V3_STBY
C24722U50V
C212100N
L200
10uH
3V3AVDD
C200100N
C201100N
C202100N
C203100N
C204100N
C205100N
C206100N
C207100N
C208100N
C209100N
C210100N
C211100N
C243220P
3V3_STBY
C24822U50V
C222100N
L201
10uH
3V3DVDD
C213100N
C214100N
C215100N
C216100N
C217100N
C218100N
C219100N
C220100N
C221100N
1V8_STBY
C24922U50V
C232100N
L202
10uH
1V8CVDD
C223100N
C224100N
C225100N
C226100N
C227100N
C228100N
C229100N
C230100N
C231100N
C244220P
1V8_STBY
C25022U50V
C238100N
L203
10uH
1V8AVDD
C233100N
C234100N
C235100N
C236100N
C237100N
C245220P
C246220P
TP200
TP201
TP204
TP211
5V_STBY
GM2221
L5C - SCALER
1
2
3
4
S202
MTA100_4
5V_STBY
R20110K
R20010K
TP226
TP227
SDA3V3
SCL3V3
TP228
TP229
TP258
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
R235100R
R236100R
VCC8
WP7
SCL6
SDA5
A0 1
A1 2
A2 3
GND 4
U201
24LC16
GND
3V3_STBYC239
100N
BRT_ADJ
BKL_EN
BOOTSTRAP CONFIGURATION
SPI FLASH
NVRAM
C25310N
GND
GND
PNL_EN PNL_EN
S1_MAIN_SW S1_MAIN_SW
PC_SD_SW PC_SD_SW
LED1
LED2
MEMCRD_RCA_S MEMCRD_RCA_SRCA_S2_S RCA_S2_S
UART_TXUART_RXDDC_SCL_VGADDC_SDA_VGA
UART_TXUART_RX
DDC_SCL_VGADDC_SDA_VGA
RESETQRESETQ
BLUE+BLUE-SOG_MCSSGREEN+GREEN-RED+RED-HS_PCVS_PC
BLUE+BLUE-
SOG_MCSSGREEN+GREEN-
RED+RED-
HS_PCVS_PC
SCL3V3
SDA3V3
TP263
TP262
GND
Q2062N7002
Q2052N7002
CLKOUT
DATA
5V_STBY
5V_STBY
R24210K
R24410K
J2310RSC_UPDT_CTR
SC_UPDT_CTR
SC_UPDT_CTR
SCL5V
SDA5V
SCL5V
SDA5V
5V_STBY
R24310K
5V_STBY
R24510K
1234
S204
MOLCON4
SCL3V3SDA3V3
5V
GND
C256220N
GND
Should be close to VCT-IF
R247
10K
R248
10K
R249
10K
R250
10K
R251
10K R25210K
GND GND GND GND GND
GND
R2534K7
R2544K7
3V3_STBY
TP267
TP266
21SW201
12345678
JP202
MOLCON8
1234567
JP203
MOLCON7
J2340R
J233100R3V3_STBY
GND GNDLED1IR
1KR258
3V3_STBY
KEYBOARD
GND GND
LED2
KEYBOARD I/F
R257100R
STBYSTBY
R256
10K
R255
100R
R24610K
Q207BC848B
GND
J227
0R
3V3_STBY
IR
IR_INV
IR_INV
KEYBOARD
Q302
BC848B
R398
27K
R334
10K
GND
AMP_EN
MUTE
AMP_EN5V
MUTE
SC1_PIN8SC2_PIN8 SC1_PIN8
SC2_PIN8
RESETQOptionalJ235
0R
J232
0R
Optional
R260
10K3V3_STBY
R261
10K3V3_STBY 3V3_STBY 3V3_STBY 3V3_STBY
R262
10K
R263
10K
R264
10K
R265
10K
TP271
TP270 BKL_EN
BRT_ADJ
GND
GND
12
3D201
BAV99L
12
3
D200BAV99L
R273
10K
GND
PANELCTRL PANELCTRL
DEHSVS
PIN29_APIN30_APIN31_APIN32_APIN33_APIN34_APIN35_APIN36_APIN37_APIN38_A
PIN43_APIN44_APIN45_APIN46_A
TO
TH
E L
VD
S IN
TE
RFA
CE
PIN13PIN14PIN15PIN16PIN17PIN18PIN19PIN20PIN21PIN22
FID1
Fiducial
FID2
Fiducial
FID3
Fiducial
FID4
Fiducial
FID5
Fiducial
J2380R
SAFETY
J237
0R
SAFETY SAFETYTP273
C25722P
GND
C25822P
GND
STBY2
R2744K7
R276
4K7
Q208BC848
R2774K7
J236
0R
3V3_STBY
GND
C258_A22P
GND
C257_A22P
GND
3V3 5V
123456789
V1
VIDA
123456789
V2
VIDA
123456789
V3
VIDA
123456789
V4
VIDA
GND GND GND GND
Subject to change without notice
QW
2.820
L5C LCD TV 14’’,20’’
AGC 1
TU 2
ADD 3
SCL 4
SDA 5
NC 6
VCC+5V 7
NC/ADC 8
VST 9
IF2/NC 10
IF1 11
TU300
ENV57K##08G3F
AGC 1
TU 2
AS 3
SCL 4
SDA 5
NC 6
VCC+5V 7
NC/ADC 8
VST 9
NC 10
IF1 11
TU301
DTQS441IH241C
J3180R
J3170R L313 1uH
X6966D
1
2
3
4
5
SAW300IF1
IF2
GND
C33110N
C33010N
R385
5K1
GND GND
TP30233V
R341100R
R342100R
J3040RGND
No longer needed
J313
0R
IFIN-
IFIN+
AGCSDA5V
SCL5V
GND
5V
L312
coilrad10C410100U10V
C317100N
GNDGND
AGC 1
TU 2
AS 3
SCL 4
SDA 5
UB 6
VCC+5V 7
NC 8
VT 9
IF2 10
IF1 11
TU351
CTF5540
TUNERSR388
56RGND
D300
GND
33V33V
C409CAP100U50V
C503100N
5V
C523470N
C524
470N
C5321UF25V AUVDD
053516
L504
22UH
053516
L505
22UH
C51822N
C51622N
C52022N
C504100N
C51722N
C51922N
R504100R
R503100R
C51322N
C51122N
C51522N
C502100N
C51222N
C51422N
R502100R
R501100R
053516
L502
22UH
053516
L503
22UH
L500
BK1608HM601
12V
C500100N
C501100N
C507100U50V
C508100U50V
C521
470NC522
470N
C525
470NC526
470N
C530100P
C531100P
1234
S500
MOLCON4
SPEAKERL
SPEAKERR
AMP_EN AMP_EN
AUVDD
TP502
TP500
TP503
TP505
TP504
TP501
PGN
D1
PGN
D2
VDD
3VD
D4
CIN 5
CIP 6
CHOLD 7
NC
8
INL-9
INL+10
SHDN11
SS 12
AGND13
REG14
INR-15
INR+16
GAIN117
GAIN218
FS119
FS220
VDD
21VD
D22
PGN
D23
PGN
D24
OUTR- 25
OUTR- 26
OUTR+ 27
OUTR+ 28
OUTL- 29
OUTL- 30
OUTL+ 31
OUTL+ 32
U501MAX9704
5V
J500 0RJ501 0R
J502 0RJ503 0R
5V
5V
GND
GND
GND GND GND GND
GND
GND
GND
GND
GNDGND
GND
GND
GND
GNDGND
GND
GND
GND
AUDIO AMP
SUBWOOFER
NC1
PIN12
NIN13
AGND14
NC5
EN16
NIN27
PIN28
AGND29
EN210 NC 11
BS2 12
VPP2 13
SW2 14
PGND2 15
NC 16
BS1 17
VPP1 18
SW1 19
PGND1 20
U500
MP7731
L501BK1608HM601
C5351UF25V
C5361UF25V
13
D502BZX84C6V2
13
D503BZX84C6V2
D501
IMBD4148
D500IMBD4148
R50720K
R50820K
SUBVCC
C5091000U25V
C5101000U25V
R51010R
SUBVCC
R51110R
C539390P
C540390P
D504MBRS130LTR
D505MBRS130LTR
10uH
L506
10uH
L507
C527470N
C529470N
C537
15P
C538
15P
R505
150K
R506
150K
C528470N
C534
1UF25V
C5331UF25V
R509180K
R500
10KSUBWOOFER
AMP_EN
C5062N2
C5052N2
1
2
S501
MOLCON2
TP507
TP509
TP508
TP506
GND
GND
GND
GND
R513100K %1
R512100K %1C541
CAP4.7U50V
GNDGND
SUBVCC
REF
REF
REF
AMP_POW
GNDGND
GND
GND GND
GND GND
GND
GND
AO_R 1AIN_R 2AO_LM 3AGND 4B_GND 5AIN_L 6B 7SWTCH 8G_GND 9CLKOUT 10G 11DATA 12R_GND 13D_GND 14R 15BLNK 16V_GND 17BL_GND 18VOUT 19VIN 20SHIELD 21
S301
SCART1
AO_R 1AIN_R 2AO_LM 3AGND 4B_GND 5AIN_L 6B 7SWTCH 8G_GND 9CLKOUT 10G 11DATA 12R_GND 13D_GND 14R 15BLNK 16V_GND 17BL_GND 18VOUT 19VIN 20SHIELD 21
S303
SCART2
GND
SC1_OUT_RSC1_IN_RSC1_OUT_L GND
GND
SC1_IN_LSC1_BLUE
SC1_GREEN
SC1_RED
R3243K3
TP305
GND
GND
GNDGND
GNDGND TP304
SC1_CVBS_OUT
R36675R
GND
TP303SC1_CVBS_IN
GND
GNDGND
GNDGND
GND
GNDGND
R37075R
GND
TP307SC2_CVBS_IN
TP308
SC2_CVBS_OUT
SC2_IN_L
SC2_IN_RSC2_OUT_R
SC2_OUT_LR3333K3
TP310
GND
SC1_PIN8
SC1_FBL
R38610K
SC2_PIN8
R38710K
CLKOUT
DATA DATA
CLKOUT
SC1_PIN8
SC2_PIN8
SC1_CVBS_INSC1_CVBS_OUT
SC1_FBLSC1_RED
SC1_GREEN
SC2_CVBS_IN
SC1_BLUE
SC1_IN_R
SC1_IN_L
SC1_OUT_R
SC1_OUT_L
SC2_CVBS_OUT
SC2_IN_L
SC2_IN_RSC2_OUT_L
SC2_OUT_R
SCART INTERFACE
12V 12V-AC35910U25V
GND
C311100N
C312100N
L316
10uH125mA Q314
BC337-16
R383
220R
J316
0R
C38447U16V
GND
D302BZX84C12 SOT23
GND
This circuit is used for 15V panels. Otherwise the jumper is mounted.
L5C LCD TV 14’’,20’’
123456789
1011121314151617181920
S201
20 PIN LVDS
GND
GND
GND
GND
GND
GNDGND
TP202
RG200
RG47RRG201
RG47RRG202
RG47R
RG203RG47R
RG204RG47R
123456789
1011121314151617181920212223242526272829303132333435363738394041424344454647484950
S200
FH12-50S-0.5SH
GND
TP215
GND
GND
GND
GND
GND
GND
GND
GND
GND
GNDGND
ER0ER1ER2ER3
ER4ER5ER6ER7
EG0EG1EG2EG3
EG4EG5EG6EG7
EB0EB1EB2EB3 EB0
EB1EB2EB3
EB4EB5EB6EB7
EG0EG1EG2EG3
EG4EG5EG6EG7
ER0ER1ER2ER3
ER4ER5ER6ER7
CLK
DE
VSHS
PANELPWR
TP272PANELCTRL PANELCTRL
VSHSDEDE
HSVS TXE_3P
TXE_3N
TXCLKEPTXCLKEN
TXE_2PTXE_2N
TXE_1PTXE_1N
TXE_0PTXE_0N
PANELPWR PANELPWR
PANELPWR
PIN29_APIN30_APIN31_APIN32_APIN33_APIN34_APIN35_APIN36_APIN37_APIN38_A
TP222TP216TP217TP218TP219TP220TP221TP223TP224TP225
PIN29PIN30
PIN31PIN32PIN33PIN34
PIN35PIN36PIN37PIN38
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 40
JP200
HEADER2X20
PANELPWR PANELPWRER0ER1ER2ER3ER4ER5ER6ER7EG0EG1EG2EG3EG4EG5EG6EG7EB0EB1EB2EB3
EB4EB5EB6EB7
DEHSVSCLK
GND
3V3 3V35V 5V
EB4EB5EB6EB7
RG205RG47R
PIN43_APIN44_APIN45_APIN46_A
PIN43PIN44PIN45PIN46
LVDS INTERFACE
ER0ER1ER2ER3ER4ER5ER6ER7EB0EB1EB2EB3EB4EB5EB6EB7EG0EG1EG2EG3EG4EG5EG6EG7CLKVSHSDE
TP230TP231TP232TP233TP234TP235TP236TP237TP238TP239TP240TP242TP243TP244TP245TP246TP247TP248TP249TP250TP251TP252TP253TP254TP255TP256TP257TP259
J2100RJ2110RJ2120RJ2130RJ2140RJ2150RJ2160RJ2170RJ2180RJ2190R
J2200R J2210R J2220R J2230R
PIN29PIN30PIN31PIN32PIN33PIN34PIN35PIN36PIN37PIN38
PIN43PIN44PIN45PIN46
TP203TP205TP206TP207TP208TP209TP210TP212TP213TP214
J2010RJ2000R
J2020RJ2030RJ2040RJ2050RJ2060RJ2070RJ2080RJ2090R
TXE_3PTXE_3NTXCLKEPTXCLKENTXE_2PTXE_2NTXE_1PTXE_1NTXE_0PTXE_0N
PIN13PIN14PIN15PIN16PIN17PIN18PIN19PIN20PIN21PIN22
EB7 EB6EB5 EB4
EB3 EB2EB1 EB0
ER0ER1ER2ER3ER4ER5ER6ER7EG0EG1EG2EG3EG4EG5EG6EG7
DEHSVS
CLK
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 40
S2
HEADER2X20
+3.3V
GND
PANEL_POWER
+5V
PANEL_POWER
+3.3V+5VR1
47R
C222P
GND L1
FERRITE
C1
220N
GND
GND
GND
GND
GND
HSVS
DE
CLK
ER0 ER1_SER3_SER4
ER5 ER6ER7_S EG0EG1EG2 EG3EG4
EG5 EG6EG7 EB0EB1EB2 EB3EB4
EB5 EB6_SEB7
TP1TP2TP3TP4TP5TP6TP7TP8TP9
TP10
TP11 TP12TP13TP14TP15TP16 TP17
TP18
TP19TP20TP21TP22TP23TP24TP25TP26TP27TP28
TP29
TP30
C5100N
C3100N
GND
IN3
1
OUT 2
ADJU1
LM1117 12VPANEL_POWER +12V
+12V
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 4041
S1
DF9-41P-1V
GND
GND
GND
GND
GND
RG147R
RG247R
RG347R
RG447R
RG547R
RG6 47R ER1_SER3_SER7_SEB6_S
ER1ER3ER7EB6
C410U50V
IN1
2
OUT 3
GND
U2MC7812K
GND
ER2
LG PL DAUGTHER BOARD
GND
GNDKEY_DRLKEY_PMUIRLED_RED
3.3V
GND
GND
OUTGNDVs
GND
S2
P+
S5P-
S1MENU
S4V+
S3V-
R5
180R
R3
330R
R7
470R
R6
1K1234567
CN1
7 HEADER
R1150R
12
C110uF/10V
R2150R
Out1
GND2
Vs3
IR1
IR
R8
270R
R4470R
D1LED
GND
S6AV/TV
R9
3K9
KEYBOARD MODULE
SW1
SW-SPST
1234
P2
4 HEADER
POWER
R910K
R1010K
GND
C210uF/16V
SW1
SW SPST
1234567
P2
7 HEADERGND
S1
S2
S3
G4 D 5D 6D 7D 8U1
FDS6675A
1234
P3
SPEAKER
OPTION POWER
GND
IRLED_RED
3.3V
GND
OUTGNDVs
GND
12
C110uF/10V
Out1
GND2
Vs3
IR1
IR
D1
LED_RED
GND
123456
CN1
MOLCON6
R1150R
R2150R
R3
4K7
Q1BC848B
LED_GREEN
R4100R
GND
R5
4K7
R6
100R
Q2BC848B
GND
D3
LED_BLUE
GND
D2
LED_GREEN
GND
LED_BLUE
OPTION
HEAD PHONE MODULE
1
2
3
X940
R943
R942R940
R941
R
GND
L
X941
C940
C94139R
39R
47n/100V
47n/100V
330R
330RHEAD
PHON
E
HEAD
PHON
E JAC
K
2Y11 2Y02
3Y13
3Z 4
3Y05
E6
VEE
7
GN
D8
S3 9S2 10S1 11
1Y012
1Y113 1Z 14
2Z 15
VC
C16
U301
CD
4053
GND GND GND
12V-A
C349
10U25VC352
10U25V
R305 10K
R303
10K12V-A
GND
R307
10K
R306
10K12V-A
GND
GNDGND
R309
10K
R308
10K12V-A
GND
R312
10K
R311
10K12V-A
GND
C355
10U25V
C357
10U25V
C353
10U25V
C351
10U25V
R339
100R
R340
100R
R310
10K12V-A
Q300BC848B
GND
MR_R
MR_L
J302
0RJ303
0R
MR_L
MR_R
RCA_LEFT
2Y11 2Y02
3Y13
3Z 4
3Y05
E6
VEE
7
GN
D8
S3 9S2 10S1 11
1Y012
1Y113 1Z 14
2Z 15
VC
C16
U302
CD
4053
GND GND GND
12V-A
C361
10U25V
C364
10U25V
R314
10K
R313
10K12V-A
GND
MR_R
R316
10K
R315
10K12V-A
GND
GNDGND
R318
10K
R317
10K12V-A
GND
R321
10K
R320
10K12V-A
GND
C366
10U25V
C367
10U25V
MR_L
C365
10U25V
C362
10U25V
R343
100R
R344
100R
R319
10K12V-A
Q301
BC848B
GND
AIN1L
AIN1R
SC2_I_L
Optional
R382
4K7
R384
4K7
MEMCRD_RCA_S
RCA_S2_S
RCA_S2_S
C325100N
C326100N
GND
GND
SC2_I_R
RCA_RIGHT
RCA_LEFT
AUDIO_L_SD
AUDIO_L_SD
AUDIO_R_SD
AUDIO_R_SD
Optional
MEMCRD_RCA_S
J300
0RJ301
0R
MR_R
MR_L
AIN1R
AIN1L
AUDIO SWITCHES
DAUGTHER BOARD
EB7 EB6EB5 EB4
EB3 EB2EB1 EB0
ER0ER1ER2ER3ER4ER5ER6ER7EG0EG1EG2EG3EG4EG5EG6EG7
DEHSVS
CLK
1 23 45 67 89 1011 1213 1415 1617 1819 2021 2223 2425 2627 2829 3031 3233 3435 3637 3839 40
S2
HEADER2X20
+3.3V
GND
PANEL_POWER
+5V
PANEL_POWER
+3.3V+5V
123456789
1011121314151617181920212223242526272829303132333435363738394041424344454647484950
S1
FH12-50S-0.5S-top contact
R147R
C222P
GND
GNDL1
FERRITE BEADPANEL_POWER
C1220N
GND GND
GND
GND
GNDRG1
47RRG2
47RRG3
47RRG4
47RRG5
47RRG6
47R
GND
GND
GND
GND
GND
GNDGND
HSVS
DE
CLK
ER0ER1ER2ER3
ER4ER5ER6ER7
EG0EG1EG2EG3
EG4EG5EG6EG7
EB0EB1EB2EB3
EB4EB5EB6EB7
POWER INPUT FOR 14-20
12
S600MOLCON2
S601
CO
NN
-PO
WER
GND
TP601
12V INPUTF600
FUSE 5A12V
l'invertitore e il pannello sono identificati anche dal simbolo di sicurezza e devonoessere sostituiti solo con parti originali prodotte e verificate dal produttore.
123456789101112
S203
MOLCON12
1234567
JP201
MOLCON7
GND
4.7uHL205
C2551000U16V
C25422U50V
C241100N
TP260
R238
470R
R21210K
1K
R239 Q202BC848B
GND
5V
GND GND
J226
0R
BRT_ADJ
R22310K
R22610K
1K
R2411K
R240
J2280R
Q203BC848B
Q204BC848B
TP261
GND
5V
5V
GND
BKL_EN
TP264
TP265
INV_POW
BKL_EN
BRT_ADJ
INVERTER INTERFACE FOR 14-20
GND
12
3
D404BAV99L
12
3
D402BAV99L
GND
GND
GNDA01 A12 A23 VSS4 SDA 5
SCL 6
WP 7
VCC 8
U400
HT24LC02
1N4148
D400
5V_STBY
5V
5V
C446100N
GND
R42047K
R42147K
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1617
P400
DB15HF
R412
100R
R413
100R
TP400
TP402
GND
12
3
D405BAV99L
12
3
D401BAV99L
12
3
D403BAV99L
J402
0R
J401
0R
J400
0R
J406
0R
J403
0R
TP405R41775R
R41575R
R41675R
R408
47R
R406
47R
R410
47R
C462
10N
GND GND
5V
RED_DSUB RED_SW
GND
5V
TP404
GND
GREEN_SWGREEN_DSUB
GND
5V
TP403
GND
BLUE_DSUB BLUE_SW
R414
470R
C46010N
C459
10N
C457
10NR403
10K TP401
TP407
TP406
VS_DSUB
HS_DSUBR418
75R
R419
75R
R40410K
R40510K
GND
GND
HS_SW
VS_SW
C46522P
C46622P
GND
GND
R407
47R
R409
47R
R411
47R
GND
C458
10N
C461
10N
C463
10N
VDD 1YA 2GND 3VDD 4YB 5YC 6GND 7YD 8VDD 9GND 10YE 11SEL 12E113
E014
D115
C116
D017
C018
VDD19
GND20
B121
B022
A123
A024
U401
PI3V512
VDD 1YA 2GND 3VDD 4YB 5YC 6GND 7YD 8VDD 9GND 10YE 11SEL 12E113
E014
D115
C116
D017
C018
VDD19
GND20
B121
B022
A123
A024
U402
PI3V512
123456789
101112131415
S400
5V_STBY
GND
AUDIO_R_SDAUDIO_L_SD
BLUE_SDGREEN_SDRED_SD
HS_SDVS_SD
GND
3V3_STBYL400
10uH3V3_RGB
C448100N
GND
C46410U25V
GND
3V3_RGB
GND
GND
GND
RED_SDRED_DSUBGREEN_SDGREEN_DSUB
BLUE_SD
BLUE_DSUBHS_SD
HS_DSUBVS_SDVS_DSUB
C447100N
GND
VS_SW
C449100N
C450100N
C451100N
GND GND GND
3V3_RGB
3V3_RGB
3V3_RGB
HS_SW
BLUE_SWGREEN_SW
RED_SW
C456100N
GND
C452100N
C453100N
C454100N
C455100N
GND GND GND GNDOptional for 2nd RGB switch.
RED_SW
GREEN_SW
BLUE_SWHS_SW
VS_SW
GND
GND
GND
GND
3V3_RGB
3V3_RGB
3V3_RGB
3V3_RGB
VS_G
HS_G
BLUE_GGREEN_G
RED_G
VS_VCT
HS_VCT
VS_G
HS_G
BLUE_G
GREEN_G
RED_G
TO GENESIS
GRAPHICS
RGB SWITCHES
EDID VGA
2nd RGB Switch
AUDIO_R_SDAUDIO_L_SD
DDC_SCL_VGA
DDC_SDA_VGA
DDC_SDA_VGA
DDC_SCL_VGA
VS_VCT
HS_VCT
BLUE_VCT
GREEN_VCT
RED_VCT
S1_MAIN_SW
S1_MAIN_SW
PC_SD_SW PC_SD_SW
HS_PC HS_PC
VS_PC VS_PC
RED-
RED+
GREEN-
GREEN+
SOG_MCSS
BLUE+
BLUE-
BLUE+
BLUE-
SOG_MCSS
GREEN+
GREEN-
RED+
RED-
UART_TXUART_RX
GND
J407
0R
J404
0R
J409
0R
J408
0R
J405
0R
VS_SD VS_SW
HS_SD HS_SW
RED_SD RED_SW
GREEN_SD GREEN_SW
BLUE_SD BLUE_SW
L401
3.3uH
R425
75R C467330P
GNDL402
3.3uH
R426
75R C468330P
GNDL403
3.3uH
R427
75R C469330P
GND
GND
C4062N2
GND
R381
4K7C4072N2
C4082N2
C397
220N
GND GND
C368
100U16V
C369
100U16V
C3721N
C3731N
GNDGND 1
2
3
S300
GND
TP300
TP301
SPEAKERL
GND
OUTA1
INA(NEG)2
INA(POS)3
VSS4 INB(POS) 5
INB(NEG) 6
OUTB 7
VDD 8
U300
TDA1308
GND
C315100N
VDD5VAUD
C302100N
GND
VDD5VAUDR302
10K R30410K
C370100U16V
GND
C3941N5
R3785K6
C3951N5
R3795K6
R380
4K7C4052N2
C396
220N
GND
SPEAKERR
SPEAKERL
SPEAKERR
HEADPHONE
Der Inverter und das Panel sind ebenfalls mit dem Sicherheitssymbol gekennzeichnet und sollten nur durchOriginalersatzteile, die vom Hersteller erzeugt und genehmigt wurden, ersetzt werden.
Inverter and panel are also designed by the safety symbol and should only be replacedby orginal parts produced and proofed by manufacturer.
Note:
Components designated by the safety symbol should only be replac ed by original parts produced and proofed by the manufacturer.
Sicherheitsbautelle im Sinn der sicherheitsbestimmung. Diese Teile durfen nur durch Originalteile ersetzt werden.
Contrassegno di sicurezza. I componenti devono, corrispondere a ricambi originali e devono essere montati a regola d’arte.
Subject to change without notice