company confidential autodiagnostic july 2008 page 1 spx italia –tecnotest division ecureader 4.60...

Company Confidential

AUTODIAGNOSTIC JULY 2008

PAGE 1

SPX ITALIA –TECNOTEST DivisionECUREADER 4.60 - ENG

Autodiagnostic 2 of 4 – 2008By ATA

SPX ITALIA –TECNOTEST DivisionECUREADER 4.60 - ENG

Autodiagnostic 2 of 4 – 2008By ATA



Summary

> Welcome

> Update from 4.50 to 4.60

> Special procedures

> Q & A



The Release 4.60



Cars – News of 4.60

ALFA ROMEO

147ENGINE MANAGEMENT 1.9 JTDm 16v BOSCH EDC 16 Common Rail DPF

159CHASSIS NETWORK Proxi Alignment

BRERACHASSIS NETWORK Proxi Alignment




ALFA ROMEO

GTENGINE MANAGEMENT 1.9 JTDm 16v BOSCH EDC 16 Common Rail DPF

SPIDERCHASSIS NETWORK Proxi Alignment




BMW

1 SERIES (E87) (04-..)ABS+TRACT. CONTR. BOSCH DSCAIRBAG AirBag MSR5CLIMA Klimautomatik IHKADASHBOARD KombiinstrumentENGINE MANAGEMENT 120d (07-..) DDE




BMW

7 SERIES (E65-E66) (02-..)ABS+TRACT. CONTR. BOSCH DSC A/T EGSCLIMA IHKA KlimautomatikDASHBOARD Kombi ELECTRIC POWER STEERING CIM IMMOBILIZER SIEMENS CAS Car Access System




BMW Z4 (E85) (04-..)ABS+TRACT. CONTR. Continental Teves DSCCHASSIS NETWORK GM5 ELECTRIC POWER STEERING EPSSTEERING COLUMN MODULE KOSTAL LWS

CHEVROLET

CAPTIVAIMMOBILIZER BOSCH VTD




CITROEN

C8 (05-..)ABS BOSCH ABS/ESP 8.0AIRBAG TEMIC AirBagWARNING LIGHTS PANEL MARELLIDASHBOARD MARELLI Dashboard ELECTRIC POWER STEERING HPI EPS GEPENGINE MANAGEMENT 2.0 HDI 16v DPF SIEMENS EDC SID803 Common Rail

DACIA

LOGANENGINE MANAGEMENT 1.5 dCi (’05 ..) DELPHI LUCAS LVCR Common Rail




FIAT

BRAVO ‘07CHASSIS NETWORK Fiat Proxi AlignmentCHASSIS NETWORK Marelli Body Comp.+Key EncodingCHASSIS NETWORK Marelli Can info

CROMA ‘05CHASSIS NETWORK Fiat Proxi Alignment

MULTIPLA BIPOWER (‘99-’00)ENGINE MANAGEMENT 1.6 16V BIPOWER MARELLI IAW 4GF




FIAT

MULTIPLA ’02AIRBAG SIEMENS AirBag MY 99

PUNTO ’99ENGINE MANAGEMENT 1.9 JTD BOSCH EDC 15 Common Rail

ULISSE ’05WARNING LIGHTS PANEL MARELLI Dashboard DASHBOARD MARELLI Dashboard




FORD MONDEO ’07ABS+TRACT. CONTR. ABS/ESP CHASSIS NETWORK GEMCLIMA HVAC DASHBOARD IC ENGINE MANAGEMENT 2.0 TDCi 140cv PCM Duratorq + DPF

NEW GALAXICLIMA EATC ELECTRIC POWER STEERING PSCN




HONDA

ACCORDABS/VSA ABS/TCS AIRBAG SRS

IVECO

DAILY&TURBO DAILYENGINE MANAGEMENT 2.3 HPI16v BOSCH EDC 16 Common Rail



Cars – News of 4.60LANCIA

PHEDRA ‘05WARNING LIGHTS PANEL MARELLI DashboardDASHBOARD MARELLI Dashboard

LEXUS

RX 300 ‘04DASHBOARD Combinator Meter ENGINE MANAGEMENT 3.0 MPI ELECTRIC BACKDOOR SYSTEM BackdoorELECTRONIC SUSPENSIONS




W169 A ClassA/T DELPHI EWM Selector LeverA/T TEMIC FCVTDASHBOARD BOSCH Kombi KIW + Service ENGINE MANAGEMENT A150 (04-..) SIEMENS SIM 266ENGINE MANAGEMENT A170 (04-..) SIEMENS MPI M60G70PARKING AID VALEO PTS5 SERVICE RESET Manual

W171 SLK ClassA/T SIEMENS EGS 722.6 EGS52

MERCEDES BENZ8375




W203 C ClassENGINE MANAGEMENT C180 Kompr.(..-07) SIEMENS ENGINE MANAGEMENT C240 112 (..-07) SIEMENS MPI ME SE

W209 CLK ClassABS+TRACT. CONTR. TEVES ESP AIRBAG BOSCH SRS AirBagA/T DELPHI EWM Selector LeverDASHBOARD KIW KombiinstrumentENGINE MANAGEMENT CLK 240 (..-08) SIEMENS MPI ME SE

MERCEDES BENZ8375




W211 E ClassABS+ TRACT. CONTR. BOSCH ABR-ESP-ABRAIRBAG BOSCH SRS AirBagA/T DELPHI EWM Selector LeverBRAKE POWER SUPPORT BOSCH SBC Sensotronic Brake ControlENGINE MANAGEMENT E 280 CDI (06-..) BOSCH EDC Common Rail CDI 4

MERCEDES BENZ8375 8375




W219 CLS ClassABS+ TRACT. CONTR. BOSCH ABRA/T DELPHI EWM Selector LeverENGINE MANAGEMENT E 320 CDI (06-..) BOSCH EDC Common Rail CDI 4HEADLAMP LEVELLING MODULE HELLA LWR SERVICE SYSTEM Assyst PARKING AID BOSCH PTS Parktronic systemSTEERING COLUMN MODULE BOSCH MRM

MERCEDES BENZ8375




W245 B ClassA/T DELPHI EWM Selector LeverDASHBOARD BOSCH KIW + Service ENGINE MANAGEMENT B 150 (05-..) SIEMENS SIM 266ENGINE MANAGEMENT B 170 (05-..) SIEMENS MPI M60G70SERVICE RESET Manual

NISSAN

QASHQAI ANTITHEFT Antitheft CHASSIS NETWORK IPDM

MERCEDES BENZ8375




OPEL

ANTARAIMMOBILIZER VTD

ASTRA HKEYS & REMOTES CODING Valeo CIM STEERING WHEEL ELECTRONICS Valeo CIM

CORSA DENGINE MANAGEMENT 1.7 CDTI 125cv DENSO BCM 0100

ZAFIRA BKEY CODING Valeo CIM STEERING WHEEL ELECTRONICS Valeo CIM



Cars – News of 4.60PEUGEOT

807 (05)ABS BOSCH ABS/ESP 8.0AIRBAG TEMIC AirBagWARNING LAMPS PANEL MARELLI DASHBOARD MARELLI Dashboard ELECTRIC POWER STEERING HPI EPS GEPENGINE MANAGEMENT 2.0 HDI FAP 170cv SIEMENS EDC SID803 Common rail

RENAULT

CLIO IIENGINE MANAGEMENT 1.5 DCI (07-..) DELPHI LUCAS LVCR Common RailENGINE MANAGEMENT 2.0 16v SIEMENS Sirius 32x




FORTWOENGINE MANAGEMENT 0.8 cdi 30 Kw (04-07) EDG Common Rail

NEW FORTWOENGINE MANAGEMENT 1.0 62 Kw EURO 4 (07-..) BOSCH MPI

SMART




COROLLA VERSOSERVICE RESET

YARIS ‘05ABSCLIMAELECTRIC POWER STEERING

TOYOTA




C30AIRBAG SRS AirBagCLIMA CLIMADASHBOARD DIM Driver Information Module DPF ADDITIVE MANAGEMENT ADM Additive Dosing ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING EPSENGINE MANAGEMENT 1.8 (07-..) MPI ENGINE MANAGEMENT 2.0D (07-..) ECMPARKING AID PAM Park Assist ModulePASSENGER DOOR MODULE PDM Passenger Door ModulePASSENGER SEAT MODULE PSR Power Seat Module Right

VOLVO




C30RADIO CD ACM Audio ModuleRADIO CD IAM Integrated Audio ModuleSERVICERESET DIM VISUAL/TELEMATICS ICM Infotainment Control Module

C70SUN ROOF CRM Convertible Roof ModuleDASHBOARD DIM Driver Information ModuleELECTRIC POWER STEERING EPSGEAR MANAGEMENT TCM Trasmission Control ModulePARKING AID PAM Park Assist ModulePASSENGER SEAT MODULE PSR Power Seat Module Right

VOLVO




S40CLIMA CLIMA DASHBOARD DIM Driver Information ModuleDPF ADDITIVE MANAGEMENT ADM Additive Dosing Module DIFFERENTIAL ELECTRONIC MODULE DEM Differential Electronic ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING EPSENGINE MANAGEMENT 1.8 (04-..) MPI ENGINE MANAGEMENT 2.0 D (04-..) ECMGEAR MANAGEMENT TCM Trasmission Control ModulePARKING AID PAM Park Assist Module PASSENGER DOOR MODULE PDM Passenger Door ModulePASSENGER SEAT MODULE PSR Power Seat Module Right

VOLVO




S40RADIO CD IAM Integrated Audio Module VISUAL. TELEMATICS ICM Infotainment Control Module

S60ABS BCM Brake Control ModuleAIRBAG SRS AirBagCHASSIS NETWORK CEM Central Electronic ModuleCHASSIS NETWORK REM Rear Electronic ModuleCLIMA CCM Climate Control UnitPOWER SEAT MODULE PSM Power Seat ModuleSUN ROOF UEM Upper Electronic Module

VOLVO




S60DASHBOARD DIM Driver Information ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING SAS Steering Angle SensorGEAR MANAGEMENT TCM Trasmission Control ModuleGPS NAVIGATOR RTI Road Traffic InformationPASSENGER DOOR MODULE PDM Passenger Door ModuleSTEERING WHEEL ELECTRONIC SWM Steering Wheel ModuleRADIO CD ACM Audio ModuleSTEERING WHEEL ELECTRONIC SWM Steering Wheel ModuleVISUAL./TELEMATICS ICM Infotainment Control Module

VOLVO




S80ABS BCM Brake Control ModuleAIRBAG SRS AirBagCHASSIS NETWORK CEM Central Electronic ModuleCHASSIS NETWORK REM Rear Electronic ModuleCLIMA CCM Climate Control UnitPOWER SEAT MODULE PSM Power Seat ModuleSUN ROOF UEM Upper Electronic ModuleDASHBOARD DIM Driver Information ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING SAS Steering Angle SensorGEAR MANAGEMENT TCM Trasmission Control ModuleGPS NAVIGATOR RTI Road Traffic Information

VOLVO




S80PASSENGER DOOR MODULE PDM Passenger Door ModuleRADIO CD AUM Audio ModuleSTEERING WHEEL ELECTRONIC SWM Steering wheel moduleVISUAL. TELEMATICS ICM Infotainment Control Module

V50AIRBAG SRS AirBagCLIMA CLIMA DASHBOARD DIM Driver Information ModuleDPF ADDITIVE MANAGEMENT ADM Additive Dosing ModuleDIFFERENTIAL ELECTRONIC MODULE DEM Differenzial Electronic ModuleDRIVER DOOR MODULE DDM Driver Door Module

VOLVO




V50ELECTRIC POWER STEERING EPSGEAR MANAGEMENT TCM Trasmission Control ModulePARKING PAM Park Assist ModulePASSENGER DOOR MODULE PDM Passenger Door ModulePASSENGER SEAT MODULE PSR Power Seat Module RightRADIO CD ACM Audio ModuleRADIO CD IAM Integrated Audio ModuleVISUAL. TELEMATICS ICM Infotainment Control ModuleENGINE MANAGEMENT 1.8i MPIENGINE MANAGEMENT 2.0 D ECM Common Rail

VOLVO




V70ABS BCM Brake Control ModuleAIRBAG SRS AirBagCHASSIS NETWORK CEM Central Electronic ModuleCHASSIS NETWORK REM Rear Electronic ModuleCLIMA CCM Climate Control UnitPASSENGER SEAT MODULE PSM Power Seat ModuleSUN ROOF UEM Upper Electronic ModuleDASHBOARD DIM Driver Information ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING SAS Steering Angle SensorGEAR MANAGEMENT TCM Trasmission Control ModuleGPS NAVIGATOR RTI Road Traffic Information

VOLVO




V70PASSENGER DOOR MODULE PDM Passenger Door ModuleRADIO CD AUM Audio ModuleSTEERING WHEEL ELECTRONIC SWM Steering wheel moduleVISUAL./TELEMATICS ICM Infotainment Control Module

XC70ABS BCM Brake Control ModuleAIRBAG SRS AirBagCHASSIS NETWORK CEM Central Electronic ModuleCHASSIS NETWORK REM Rear Electronic ModuleCLIMA CCM Climate Control UnitPOWER SEAT MODULE PSM Power Seat Module

VOLVO




XC70SUN ROOF UEM Upper Electronic ModuleDASHBOARD DIM Driver Information ModuleDRIVER DOOR MODULE DDM Driver Door ModuleELECTRIC POWER STEERING SAS Steering Angle SensorGEAR MANAGEMENT TCM Trasmission Control ModuleGPS NAVIGATOR RTI Road Traffic InformationPASSENGER DOOR MODULE PDM Passenger Door ModuleRADIO CD ACM Audio ModuleSTEERING WHEEL ELECTRONIC SWM Steering Wheel ModuleVISUAL. TELEMATICS ICM Infotainment Control ModuleENGINE MANAGEMENT 2.4 D5 ECM Common Rail

VOLVO




XC90ABS BCM Brake Control ModuleAIRBAG SRS AirBagCHASSISNETWORK CEM Central Electronic ModuleCHASSISNETWORK REM Rear Electronic ModuleCLIMA CCM Climate Control UnitPOWER SEAT MODULE PSM Power Seat ModuleSUN ROOF UEM Upper Electronic ModuleDASHBOARD DIM Driver Information ModuleDIFFERENTIAL ELECTRONIC MODULE DEM Differential Electronic ModuleDRIVER DOOR MODULE DDM Driver Door Module

VOLVO




XC90ELECTRIC POWER STEERING SAS Steering Angle SensorENGINE MANAGEMENT 2.4 D5 (08-..) ECM GEAR MANAGEMENT TCM Trasmission Control ModuleNAVIGATOR RTI Road Traffic InformationPASSENGER DOOR MODULE PDM Passenger Door ModuleRADIO CD ACM Audio ModuleSTEERING WHEEL ELECTRONIC SWM Steering Wheel ModuleVISUAL. TELEMATICS ICM Infotainment Control Module

VOLVO




PHAETON (02-06)ABS NO CANAIRBAG NO CANAUTOMATIC TRASMISSION NO CANCENTRAL ELECTRONIC SYSTEM NO CANCLIMA NO CANDASHBOARD NO CANDIFFERENTIAL ELECTRONIC MODULE NO CANELECTRONIC CAR SETUP NO CANENGINE MANAGEMENT (all present on Phaeton) NO CANXENON LIGHT LEFT SIDE NO CAN

VOLKSWAGEN




PHAETON (02-06)GPS NAVIGATOR NO CANPARKING AID NO CANRADIO CD NO CANXENON LIGHT RIGHT SIDE NO CANSERVICE RESET NO CANSTABILIZERS NO CANSTEERING WHEEL ELECTRONICS NO CANTIRE PRESSURE NO CAN

VOLKSWAGEN



Bikes – News of 4.60

ER-6FENGINE MANAGEMENT 650 EFI

ER-6NENGINE MANAGEMENT 650 EFI

VERSYSENGINE MANAGEMENT 650 EFI

KAWASAKI



Special Procedures



Special Procedures

MERCEDES W219CLS 500Headlights Levelling System

This function permits setting the levelling sensors zero point, for managing the headlights level properly.

Please proceed as per the following steps:1.Vehicle must be placed on a flat surface without any load on2.If equipped by AIRMATIC ( pneumatic suspensions), pay attention to set the level to “standard”3.Switch lights on, then proceed



Special Procedures

MERCEDES W219CLS 320 CDIEngine ManagementAir Filters initialization

This function allows resetting the air filters inizialization value to the factory defaults, once replaced.Picture displays the sensor which surveys the 2 filters status: please note that in case of clogged up or too dirty air filters, the MIL lamp will be switched on. Replace air filters, erase the fault memory, and perform “air filter inizialization” in the adjustments page.



Special Procedures

MERCEDES W219CLS 320 CDIEngine managementSelf-adaptation values

Should some components need replacing such as idle actuator or Rail Pressure Sensor, this function resets the learnt values to the factory defaults to manage the new components properly.



Special Procedures

This function allows carrying out the electronic throttle body self-learning, in case of its replacement.The values will be stored in the ECU defining the working range (min., max. and intermediate position) for managing the new component properly.Before starting the procedure, follow the steps below :•Engine off•Coolant temperature up to 10°C•Air temperature up to 10°C•Gas Pedal RELEASED

MERCEDES W169A Class 170ENGINE MANAGEMENTElectronic throttle body self-learning



Special Procedures

This function allows the air filter box flap actuator’s basic setting.To do it, engine must be OFF.First the tool will ask for ignition off and waiting time for 10 seconds approx., then to switch ON ignition again.At this point the setting will be executed.

MERCEDES W209 CLK 180 Kompressor ENGINE MANAGEMENTAir filter box FLAP basic setting



Special Procedures

This function allows carrying out the electronic throttle body self-learning, in case of its replacement.The values will be stored in the ECU defining the working range (min., max. and intermediate position) for managing the new component properly.Before starting the procedure, follow the steps below :•Engine off•Coolant temperature up to 10°C•Air temperature up to 10°C•Gas Pedal RELEASED

MERCEDES W209 CLK 180 Kompressor ENGINE MANAGEMENTElectronic throttle body self-learning



Special Procedures

BMW 745i (E65-E66) (02-..) ENGINE MANAGEMENT Idle rpm setting with A/C OFF

Through this function it’s possible to set the engine idle withA/C off.To carry out this procedure properly, these conditionsmust be followed:• Coolant temperature sensor has to work properly without

any fault; check it in case of doubts.• Engine temperature over 80°C• A gear inserted (in case of A/T, selector lever in D) • Engine at idle speed



Special Procedures

BMW 745i (E65-E66) (02-..) ENGINE MANAGEMENT Idle rpm setting with A/C ON

Through this function it’s possible to set the engine idle withA/C on.To carry out this procedure properly, these conditionsmust be followed:•Coolant temperature sensor has to work properly without any fault; check it in case of doubts.•Engine temperature over 80°C•A gear inserted (in case of A/T, selector lever in D) •Engine at idle speed



Special Procedures

BMW 745i (E65-E66) (02-..) ENGINE MANAGEMENT Intake valves low-lift setting (Valvetronic)

In normal driving, the "gas pedal" controls the Valvetronic hardware rather than the throttle plate (http://en.wikipedia.org/wiki/Valvetronic).This function allows setting the low-lift value, that can be fixed to 0,3mm or 0,8mm.Please note, choosing 0,8mm could cause the following effects:• it can improve idle quality• it can increase fuel consumption• it can reduce torque, accelerating hard• it can reduce torque, in some engine load conditions



This operation allows storing in the ECU each individual cylinder injector’s code in case of replacement.In this way, the ECU can manage at its best the injection time according to the new injectors.The tool will show the ECU stored values (22 digits), and from then on, the new one can be inserted. Please note:Once completed, it will also be necessary to carry out“ Small injections quantity setting “ (see dedicated help)

Special Procedures

OPEL CORSA D 1.7 CDTI 125CVENGINE MANAGEMENTInjectors Code Storing



This procedure permits to set/adapt the amount of each individual injection pulse (pre, pilot, main).This is needed in case of injector/s replacement ( and after its consequent Injectors Code Storing ).

Special Procedures

OPEL CORSA D 1.7 CDTI 125CVENGINE MANAGEMENTSmall injections quantity setting



The following procedure allows component adaptation in case of its replacement.

To complete the operation, follow carefully the instructions shown by the tool.

Special Procedures

OPEL CORSA D 1.7 CDTI 125CVENGINE MANAGEMENTMAF Sensor Adaptation



Special Procedures

VOLVO C30 Service Reset

This function allows resetting to the factory default the dashboard maintenance/service indications.



Special Procedures

This operation allows storing in the ECU each individual cylinder injector’s code in case of replacement.In this way, the ECU can manage at its best the injection time according to the new injectors.The class of injectors must be written down, and it must be THE SAME for all of them.Admitted values are 4, 5 or 6, can be found on the top of each injector’s head.

FORD MONDEO 07 2.0 TDCIENGINE MANAGEMENTInjectors Code Storing



Special Procedures

FORD MONDEO 07 2.0 TDCIENGINE MANAGEMENT DPF Static Regeneration GIRI MOTORE

This procedure allows forced particle filter regeneration andmust be carried out if the warning light is on (this means a fault or a reduction in efficiency). Should the procedure be necessary, please proceed in this

way:1. Vehicle must be stopped2. Time involved: 16 minutes approx3. During this time, engine will run at high RPMs4. Please be careful: the exausts extraction pipes must be

resistant to HIGH TEMPERATURES !

Note: once started, the tool will not permit proceeding till engine starts and coolant temperature goes above 80°C



Special Procedures

FORD MONDEO 07ABS/ESPBrakes hydraulic pressure sensor calibration

This function allows the ECU adaptation concerning the calibration of the mentioned sensor.It is necessary in case of ECU or sensor replacing.Procedure must be executed with vehicle stopped and positioned on a flat surface.



Special Procedures

FORD MONDEO 07ABS/ESPLateral Sensor Calibration

This function allows the ECU adaptation concerning the calibration of the mentioned sensor.It is necessary in case of ECU or sensor replacing.Procedure must be executed with vehicle stopped and positioned on a flat surface



Special Procedures

FORD MONDEO 07 ABS/ESPSteering wheel sensor calibration GIRI MOTORE

Through this procedure, it’s possible to calibrate thementioned sensor, and it must be done each time in case ofsensor replacement, wheel alignment or any intervention onthe Directional Tread.To do it, please carry out the following steps:1. the steering wheel and steering system must be set in its

center position (the steering wheel is in its center position and the front wheels are pointing straight ahead)

2. Now run the procedure3. The tool will ask to center the steering wheel, then to

move it 10° approx. to both sidesOnce completed, the sensor calibration is stored.



Special Procedures

FIAT /ALFACROMA ; 159 ; SPIDER ; BRERA Proxy Alignment (CAN autosetup)

In case of any ECU replacement (engine, abs, steering, and so on..), this procedure must be executed, to “align” the new ECU to the network and to the Body Computer.Run it and wait for the message: “procedure completed”.If procedure is not necessary, a related message will be shown by the tool.



Special Procedures

DACIA LOGAN 1.5 DCiENGINE MANAGEMENTNew High Pressure Pump Refilling / BleedingThis function must be used in case of HP pump replacement or interventions on fuel lines, to prevent damages and will help subsequent engine cranking.Through this function a bleeding strategy will be run the first time the cranking will be attempted (using the integrated low pressure pump). Procedure:• Run the function• Leave the diagnostic communication• Ignition off, then wait for immobilizer warning light ON• Ask for engine cranking ( by key or button ) and wait for the effective cranking, that will be executed after 20 seconds approx.



Special Procedures

DACIA LOGAN 1.5 DCiENGINE MANAGEMENTElectric devices Disabling: enabled – disabled

Through this procedure all electric devices can be stopped, to preserve the battery.Please note:Function ENABLED: all consumers OFFFunction DISABLED: all consumers ON ( standard )



Special Procedures

DACIA LOGAN 1.5 DCiENGINE MANAGEMENTInjectors Code Storing

This operation allows storing in the ECU each individual cylinder injector’s code in case of replacement.In this way, the ECU can manage at its best the injection time according to the new injectors.Generally the codes are supplied with the injectors and in any case are printed on each body.



Questions & Answers

company confidential autodiagnostic july 2008 page 1 spx italia –tecnotest division ecureader 4.60...

Documents