document copyrights disclaimer

Document CopyrightsCopyright 2006 by Kenwood Corporation. All rights reserved.No part of this manual may be reproduced, translated, distributed, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, for any purpose without the prior written permission of Kenwood.

DisclaimerWhile every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes.

文档版权信息Kenwood Corporation拥有版权 2006。保留所有权利。未经 Kenwood 公司预先书面同意，无论出于何种目的，均不得以任何形式或任何方式包括电子、机械、影印、录音或其他方式复制、翻译、分发或传播本手册的任何部分。

免责声明Kenwood公司在准备本文档时已采取所有必要的预防措施，恕不对错误或疏漏承担任何责任，也不对因使用本文中所含的信息而导致的损害负责。Kenwood公司保留出于改进的需要而随时对文中的产品信息做出更改的权利。

© 2005-10 PRINTED IN JAPANB51-8739-00 (N) 566

UHF FM TRANSCEIVER / UHF

TK-8100SERVICE MANUAL / !

C6 version

Panel assy(A62-1074-03)

Key top(K29-9262-01)

Modular jack(E08-0877-05)

Chassis(A10-4080-11)

RF coaxial receptacle (M)(E04-0167-05)

DC cord(E30-7552-05)

Fuse (6x30, 10A)(F51-0016-15) x 2

无铅焊接通信产品保护环境建伍领先

注意∶本产品是无铅化焊接产品在维修时请使用无铅焊锡和相应的焊接工具详细事项请访问如下网址了解∶ http://www.kenwoodhk.com.hk/

This product uses Lead Free solder.

TK-8100

2

INTRODUCTION

SCOPE OF THIS MANUALThis manual is intended for use by experienced techni-

cians familiar with similar types of commercial grade commu-nications equipment. It contains all required service informa-tion for the equipment and is current as of this publicationdate. Changes which may occur after publication are coveredby either Service Bulletins or Manual Revisions, which areissued as required.

ORDERING REPLACEMENT PARTSWhen ordering replacement parts or equipment informa-

tion, the full part identification number should be included.This applies to all parts : components, kits, and chassis. If thepart number is not known, include the chassis or kit numberof which it is a part and a sufficient description of the requiredcomponent for proper identification.

CONTENTS /

GENERAL /

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK O

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK R

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK S

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK T

==== KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK NU

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK OM

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK OP

!" KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK PN

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK PP

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK PR

!" KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK QN

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK QO

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK QQ

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK RN

m`

==afpmi^v=rkfq=EuRQJPQPMJOMF KKKKKKKKKKKKKKKK RO

==quJou=rkfq=EuRTJSVOPJMPFKKKKKKKKKKKKKKKKKKKKKK RQ

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK RU

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK SO

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK SQ

KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK ST

!"# !"#$%&'()*+,-./01234567

!"#$%&'()*+,- ./01234567

!"#$%&'()*+,-.*$/01= !"#= !"#$= !"

!"#$ !"#$%&'()*+,-./01#$23456

!"#$%&'()"*+",-./01234!" !"#$%&'(!)*+,-./012345/

!"#$%&'()*+,

GENERAL .................................................. 2

SYSTEM SET-UP ...................................... 5

OPERATING FEATURES .......................... 6

REALIGNMENT ......................................... 7

INSTALLATION ....................................... 18

DISASSEMBLY FOR REPAIR ................. 20

CIRCUIT DESCRIPTION .......................... 23

SEMICONDUCTOR DATA ...................... 31

COMPONENTS DESCRIPTION .............. 33

PARTS LIST ............................................. 35

EXPLODED VIEW.................................... 41

PACKING ................................................. 42

ADJUSTMENT ........................................ 43

TERMINAL FUNCTION ........................... 50

PC BOARD

DISPLAY UNIT (X54-3430-20) ............ 52

TX-RX UNIT (X57-6923-03) ................ 54

SCHEMATIC DIAGRAM.......................... 58

BLOCK DIAGRAM ................................... 62

LEVEL DIAGRAM .................................... 64

SPECIFICATION ...................................... 66

TK-8100

3

PERSONAL SAFETYThe following precautions are recommended for personal

safety :• DO NOT transmit if someone is within two feet (0.6

meter) of the antenna.• DO NOT transmit until all RF connectors are secure and

any open connectors are properly terminated.• SHUT OFF this equipment when near electrical blasting

caps or while in an explosive atmosphere.• All equipment should be properly grounded before power-

up for safe operation.• This equipment should be serviced by only qualified tech-

nicians.

PRE-INSTALLATION CONSIDERATIONS

1. UNPACKINGUnpack the radio from its shipping container and check for

accessory items. If any item is missing, please contactKENWOOD immediately.

2. PRE-INSTALLATION CHECKOUT

2-1. IntroductionEach radio is adjusted and tested before shipment. How-

ever, it is recommended that receiver and transmitter opera-tion be checked for proper operation before installation.

2-2. TestingThe radio should be tested complete with all cabling and

accessories as they will be connected in the final installation.Transmitter frequency, deviation, and power output shouldbe checked, as should receiver sensitivity, squelch operation,and audio output. Signaling equipment operation should beverified.

3. PLANNING THE INSTALLATION

3-1. GeneralInspect the vehicle and determine how and where the ra-

dio antenna and accessories will be mounted.Plan cable runs for protection against pinching or crushing

wiring, and radio installation to prevent overheating.

3-2. AntennaThe favored location for an antenna is in the center of a

large, flat conductive area, usually at the roof center. Thetrunk lid is preferred, bond the trunk lid and vehicle chassisusing ground straps to ensure the lid is at chassis ground.

3-3. RadioThe universal mount bracket allows the radio to be

mounted in a variety of ways. Be sure the mounting surfaceis adequate to support the radio’s weight. Allow sufficientspace around the radio for air cooling. Position the radio closeenough to the vehicle operator to permit easy access to thecontrols when driving.

! !"#$%&'()*+,-

!"#$%&'=EMKS=F= !"#$%&'()* !"#$% &'()*+, -./0123()

!"#$%&'()*+,-./01

!"#$%&'()*+,-./012-345 !"

!"#$%&'()*+,-./0123'456

!"#$%&'()*+,-./01

!"NK= !"#$%&'()*+,-./01234567

!"#$%hbktlla

OK= !"OJNK= !"#$%&'()*+,-./01234567

!"#$%&'()*+,-./0

OJOK= !"#$%& '()*+,-./0123456

!"#$%&'()*(+,-./)*01"#$%2 !"#$%&'()*+,-./012*

PK= !"PJNK= !"#$%&'()&*+,-./0.1234

!"#$%&'()*+,-./&012/!34'

!

PJOK= !"#$%&'()*+,-./012 34,56

!"#$%&'!()*+,-./01%&'!() !"#$%&'()*+,-.

PJPK= !" !"#$%&'()* !+,-./012 !3

!"#$%&'()*+,$%&'()-./012

!"#$%&'()*+,-./01234567

!"#$%&'()*+,-.

GENERAL /

TK-8100

4

3-4. DC Power and wiring1. This radio may be installed in negative ground electrical

systems only. Reverse polarity will cause the cable fuse toblow. Check the vehicle ground polarity before installationto prevent wasted time and effort.

2. Connect the positive power lead directly to the vehiclebattery positive terminal. Connecting the Positive lead toany other positive voltage source in the vehicle is not rec-ommended.

3. Connect the ground lead directly to the battery negativeterminal.

4. The cable provided with the radio is sufficient to handlethe maximum radio current demand. If the cable must beextended, be sure the additional wire is sufficient for thecurrent to be carried and length of the added lead.

4. INSTALLATION PLANNING – CONTROL STATIONS

4-1. Antenna systemControl station. The antenna system selection depends on

many factors and is beyond the scope of this manual. YourKENWOOD dealer can help you select an antenna systemthat will best serve your particular needs.

4-2. Radio locationSelect a convenient location for your control station radio

which is as close as practical to the antenna cable entry point.Secondly, use your system’s power supply (which suppliesthe voltage and current required for your system). Make suresufficient air can flow around the radio and power supply toallow adequate cooling.

SERVICEThis radio is designed for easy servicing. Refer to the

schematic diagrams, printed circuit board views, and align-ment procedures contained in this manual.

NOTEIf you do not intend to use the 3.5-mm jack for the external

speaker, fit the supplied speaker-jack cap to stop dust andsand from getting in.

PJQK= !"#$NK !"#$%&'()*+,-!./01234+5 !"#$%&'()*+,-./01234567 !"#$%&'()*+

OK !"#$%&'(')*+,!"#-./012 !"#$%&'() *+,-.

PK !"#$%&'()*+QK !"#$%&'(!)*+,-.(/0 !! !"#$%&'()*+,&-"./0123-"

!"#$%&'

QK= !J

QJNK= ! !"#$%&'()*+,-./012%34 5

hbktlla !"#$%&'()*+,%&-./ !"#$

QJOK= !" !"#$%&'()*+,-.!/012/0345

!"#$%&'()*+,,-./0"1=E !" !"#$%&$'F !"#$%&'()*+,- !"#$%&'(

! !"#$%&'()*+,"#-./0'123

!"#$%&'!()*+,-./012345

!PKRãã !"#$%&'()&*+, !"#$-./ !"#$%&'(

GENERAL /

Speakerjack cap

Power inputconnector

Antenna connector天线连接器

外置扬声器插孔盖

电源输入连接器

TK-8100

5

Merchandise received

Choose the type of transceiver

Transceiver programming

KCT-39Connection cable

KCT-18Ignition sense cable

KCT-36Extension cable

KDS-100Mobile data

terminal

KGP-2AModem GPS receiver or

KGP-2BModem GPS controller

KES-3External speaker

See page 7.A personal computer (IBM PC or compatible), programming interface (KPG-46), and programming software (KPG-80D) are required for programming.

Frequency range (MHz) RF power Type

350~390 25W C6

(Option)(Option)

(Option)

(Option)(Option)

(Option)

or

Delivery

SYSTEM SET-UP /

接收到的商品

选择车载式对讲机的类型

车载式对讲机编程

KCT-39连接电缆

KCT-18点火传感器电缆

KCT-36扩展电缆

KDS-100移动数据终端

KGP-2AModem GPS接收机或

KGP-2BModem GPS控制器

KES-3外置扬声器

参见第7页。编程时需要个人计算机(IBM PC或兼容机)，编程接口(KPG-46)以及编程软件(KPG-80D)。

频率范围 (MHz) 射频功率类型

350~390 25W C6

(可选件)(可选件)

(可选件)

(可选件)(可选件)

(可选件)

交货

或

TK-8100

6

NK= !"NJNK=

NJOK=

q w e r u

ty

i

q =EF= !"#$%& 'N !"#$%

wsli= =L= ==EF

!"#$%&'(

e !"#

r`e= =L= ==EF

!"#$%&'()

tjlk=L=p`k=L= =L= =mc=E !"F= !"#$%&'()*+

y !" !"#"$%"&'

u !"#

imqq !"#$%&'()*+,-./0123

NJPK=

!"#

!"#$%

!"#$%&'=E !F

!"#$%&'()*'(+,-.

!"#$%&'()*+,-

!"#

^ru !"#$%&'()*+,-

!"#$%&'()

!"#$%&'!"(

!"#$%&'()*+,

!"#$%&'()$*+,-.

!"#$%"#&'() !*+,-

!"#$%&'()*'(+,-

NJQK=

OPERATING FEATURES / !

天线连接器外置扬声器插孔盖

电源输入连接器

TK-8100

7

1. Modes

User mode PC mode PC programming mode

Clone mode PC testmode

PC tuningmode

Self programming mode

Mode Function

User mode For normal use.

PC mode Communication between the transceiver

and PC (IBM compatible).

PC programming Read and write frequency data and other

mode features from and to the transceiver.

PC test mode Check the transceiver using the PC.

This feature is included in the FPU.

PC tuning mode Tune the transceiver using the PC.

Clone mode Transfer programming data from one

transceiver to another.

Self programming You can program the frequency, signaling

mode and other functions using only the transceiver.

2. How to Enter Each Mode

Mode Operation

User mode Power ON

PC mode Received commands from PC

Clone mode [CH DOWN]+Power ON (Two seconds)

Self programming mode [MON]+Power ON (Two seconds)

3. PC Mode

3-1. PrefaceThe TK-8100 transceiver is programmed using a personal

computer, a programming interface (KPG-46) and program-ming software (KPG-80D).

The programming software can be used with an IBM PCor compatible. Figure 1 shows the setup of an IBM PC forprogramming.

IBM-PC / IBM计算机

KPG-46

KPG-80D

TK-8100

Fig. 1 / N

REALIGNMENT / !

NK=

! !"

!" !"#$%&'(%=Ef_j F !"#

!"#$ !"#$%&'()*+,-./

!"#$ !"#$%&

!"#cmr

!"#$ !"#$%&'()*#+

! !"#$%&'()*+,-./

!"#$%&'

!"# !"#$%&'()*+,-./

!"#$%&'(

OK= !"#$%&

! !

!" !"#$%

! x`e=altkz !=EOF !"# xjlkz !=EOF

PK= !"PJNK=

qhJUNMM !"#$%&'#()*+,=EhmdJQSF=

=EhmdJUMaF= !"f_j !"# $%&'()*+,-Nf_j !"#

用户模式计算机模式

计算机测试模式

计算机调谐模式

复制模式

自台编程模式

计算机编程模式

TK-8100

8

3-2. Connection Procedure1. Connect the TK-8100 to the personal computer with the

interface cable.2. When the Power is switched on, user mode can be en-

tered immediately. When the PC sends a command, thetransceiver enters PC mode.When data is transmitted from transceiver, the TX indica-tor blink.When data is received by the transceiver, the BUSY indi-cator blink.In the PC mode, “ PC ” is displayed on the LCD.

3-3. KPG-46 Description

(PC programming interface cable : Option)The KPG-46 is required to interface the TK-8100 to the

computer. It has a circuit in its D-sub connector (25-pin) casethat converts the RS-232C logic level to the TTL level.

The KPG-46 connects the modular microphone jack of theTK-8100 to the computers RS-232C serial port.

3-4. Programming Software DescriptionThe KPG-80D programming disk is supplied in 3-1/2" disk

format. The software on this disk allows a user to programTK-8100 transceiver via a programming interface cable (KPG-46).

4. Clone ModeProgramming data can be transferred from one trans-

ceiver to another by connecting them via their modular micro-phone jacks. The operation is as follows (the transmit trans-ceiver is the master and the receive transceiver is the slave).

Note :Clone mode should be enabled.

1. Turn the master TK-8100 power ON with the [CH DOWN]key held down (2 seconds), “ CLONE ” is displayed on theLCD.

2. Power on the slave TK-8100.3. Connect the cloning cable (No. E30-3382-05) to the modu-

lar microphone jacks on the master and slave.4. Press the [MON] key on the master TK-8100 transceiver.

The data of the master is sent to the slave. While themaster is sending data, [TX] icon blinked. While the slaveis receiving the data, “ –PC– ” is displayed and [BUSY]icon blinked. When cloning of data is completed, the mas-ter display “END”, and the master [TX] icon turned off,and the slave automatically operates in the User mode.The slave can then be operated by the same program asthe master.

5. The other slave can be continuously cloned. Carry out theoperation in step 2 to 4.

REALIGNMENT / !

PJOK= !NK !"#$qhJUNMM !"#$OK !"#$%&'()*+,-./0123456 !"#$%&'()*+',-.$/

!"#$%&'()*qu !"# !"#$%&'()*+,_rpv !"# !"#$%&=m`== !"#$%

PJPK=hmdJQS

======E !"#$%&'(F

hmdJQS qhJUNMM !"#$%&a !=EORF= !"#$%"&'("&)*+opJOPO` !"qqi

hmdJQSqhJUNMM !"#$%&'opJOPO`

PJQK= !"#hmdJUMa !"#$PJNLO ! "#$%&

!"#$%=EhmdJQSF=qhJUNMM !"#$

QK= ! !"#$%&'()*+,-./012345,-

!"#$%&'()*+,-./012=E !" !"#!$%&'() !"*!F

!"#$

NK =x`e=altkz= !"qhJUNMM =EOF=`ilkb== !"#$%

OK !qhJUNMM !PK !"#$=EkçKbPMJPPUOJMRF= !"#$%"& !"#$%

QK qhJUNMM !=xjlkz=

!"#$%&'()*$%!"+,=xquz=

!"#$%&'()*+,==m`===x_rpvz !"#$%&'()*+,-.=bka==xquz=

!"#$%&'()*+,-RK !"#$%&'()*+,-OQ !

TK-8100

9

Clone cable / 复制电缆(E30-3382-05)

4-1. Adding the Data PasswordIf the data password is set in the optional feature menu,

you must enter the password (Master transceiver) to activatea clone mode.

You can use 1, 2, 3, and 4 to configure the password. Themaximum length of the password is 6 digits.

1. [CH DOWN]+Power ON.2. “CLN LOCK” is displayed on the LCD.3. Enter the password using 1: [MON] key, 2: [SCN] key, 3:

[ ] key and 4: [ ] key.4. Press [CH DOWN] key.5. If the password matches, the transceiver enters a clone

mode and “ CLONE ” is displayed. Otherwise, trans-ceiver beeps and returns to the password input mode.

Press [CH DOWN] key+Power ON for 2 seconds

Is datapassword

set?

Yes

No Shows CLN LOCK

Input password if password is correct

Clone mode

[MON]

Start the clone function

5. Self Programming ModeWrite mode for frequency data and signaling, etc. To be

used ONLY by the authorized service person maintaining theuser’s equipment. After programming, reset the FPU to the“Self- Programming” disabled mode. Transceivers CANNOTbe delivered to the end-user in the self-programming mode.

5-1. Enter to the Self Programming ModeHold down the [MON] key and turn the power switch on.

When enter the self programming mode, “ SELF ” is dis-played.

Flow Chart (Master transceiver)

QJNK= !"# cmr= !"#= !"#$%&'()*+, !"#$%&'(=E !"#$F !"NQ !" !#$%&'S

NK=xè=altkz !"OK=ià =ìk=il`hPK !NW=xjlkz=OW=xp`kz=PW=x= =z=QW=x= z=

QK =xè=altkz=

RK !"#$%&'()*+,-./0(123== ilkb= !"#$%&'()*+,-./012345%

REALIGNMENT / !

Fig. 2 / O

!=E !"#$F

RK= !"# !"#$%&'()*+,-./01234&56

!"#$%&'()*cmr = !"#= !"#$%&'()*+,-./012

RJNK= !"#$%=xjlkz= !"#!$%&'()*+,-./01

=pbic=

按住 [CH DOWN] 键同时打开电源2秒钟

数据密码是否设置？

是

否显示CLN LOCK

输入密码，如果密码正确

复制模式

[MON]

启动复制功能

TK-8100

10

5-2. Adding the Data PasswordIf the data password is set in the optional feature menu,

you must enter the password to activate a self programmingmode.

You can use 1, 2, 3 and 4 to configure the password. Themaximum length of the password is 6 digits.

1. [MON]+Power ON.2. “SELFLOCK” is displayed on the LCD.3. Enter the password using 1 : [MON] key, 2 : [SCN] key, 3 :

[ ] key and 4 : [ ] key.4. Press [CH DOWN] key.5. If the password matches, the transceiver enters a self pro-

gramming mode and “ SELF ” is displayed. Otherwise,transceiver beeps and returns to the password inputmode.

Note :This mode (self programming mode) cannot be set when

it has been disabled with the FPU.

5-3. Channel Setting ModeEach channel can be setup in its action mode by using the

panel keys.• Pressing [MON] when “ SELF ” is displayed, sets chan-

nel setting mode.• Select an item set using [ ] then change the selection

with the [CH UP] or [CH DOWN].• The data displayed using [SCN] is stored in the memory

and then proceeds to the next item.• Pressing [ ] proceeds to the next item without storing it

in the memory.• Press [MON] to set the display to “ SELF ” and return to

reset (default) status.

The setup items for channel setting mode are listed be-low.

No. Function Choices Display Remarks

Select 1~64 key : Group/Channel

channel selection

Select 1~8 key : Group/Channel

group selection

1 RX Step 2.5kHz~ Display when an item

frequency 1MHz is selected or a step is

changed (about 0.5

seconds).

key : Select the

frequency step

Blank key : Hold 1 second

100.0000~ to frequency on/blank

550.0000MHz switching.

The right most dot

indicates 50Hz digit.

(On=5, Off=0)

1 – 1 .

1 – 6 4 .

1 . – 1

8 . – 1

S T P 2 5 0

S T P 1 M

R . – – – – – – –

R.350 .0000

RJOK= !"# cmr= !"#= !"#$%&'()*+, !"#$%&'()*+

!"NQ !" !#$%&'S

NK=xjlkz !"OK=ià =pbicil`h

PK !NW=xjlkz=OW=xp`kz=PW=x= =z=QW=x= z=

QK =xè=altkz=

RK !"#$%&'()*+,-./012(345==pbic= !"#$%&'()*+,-./012345

cmr !"#$%&'()*+,-.&'=E F

RJPK= !"# !" #$%&'()*+,-./0123456

==pbic===xjlkz !"# $%&=x z= !"#$%&'=xè=rmz==xè=altkz= !

= xp`kz= !"#$%&%'()*+,-./01

=x z= !"#$%&%'()*+,-./012=xjlkz= !"#$==pbic= !"#$%&=E

F=

!"#$ !%&'()*+

NúSQ =W=L !

NúU =W=L !

N ou OKRâeòú !"#$%

Njeò !"#$%

EMKRF

=W= !"#

=W=N NMMKMMMMú !"L RRMKMMMMjeò

!"#$

RMeò

ElåZRI=lÑÑZMF

REALIGNMENT / !

1 – 1 .

1 – 6 4 .

1 . – 1

8 . – 1

S T P 2 5 0

S T P 1 M

R . – – – – – – –

R.350.0000

TK-8100

11


2 RX Off key : Off/QT/DQT

signaling switching

QT 67.0~254.1

(0.1Hz step mode)

QT 67.0~250.3

(EIA mode)

DQT 000~777

Normal

(1 step mode)

DQT 023~754

Normal

(Standard

table mode)

DQT 000~777 key : Hold 1 second

Inverse to switch between

(1 step mode) Normal/Inverse.

DQT 023~754

Inverse

(Standard

table mode)

3 TX Step 2.5kHz~ Display when an item

frequency 1MHz is selected or a step is

changed (about 0.5

seconds).

key : Select the

frequency step

Blank key : Hold 1 second

100.0000~ to frequency on/blank

550.0000MHz switching.

The right most dot

indicates 50Hz digit.

(On=5, Off=0)

4 TX Off key : Off/QT/DQT

signaling switching

QT 67.0~254.1

(0.1Hz step mode)

QT 67.0~250.3

(EIA mode)

DQT 000~777

Normal

(1 step mode)

DQT 023~754

Normal

(Standard

table mode)

- - - - - - - -

QT 67 .0

QT 254 .1

Q T 6 7 .0

QT 250 .3

DQT000N

DQT777N

DQT023N

DQT754N

D Q T 0 0 0 Ι

D Q T 7 7 7 Ι

D Q T 0 2 3 Ι

D Q T 7 5 4 Ι

S T P 2 5 0

S T P 1 M

T . – – – – – – –

T .350 .0000

- - - - - - - -

QT 67 .0

QT 254 .1

Q T 6 7 .0

QT 250 .3

DQT000N

DQT777N

DQT023N

DQT754N

O ou lÑÑ =W=lÑÑLnqLanq

nq=STKMúORQKNEMKNeò !Fnq=STKMúORMKPEbf^Fanq=MMMúTTT

EN !Fanq=MOPúTRQ

E !"F

anq=MMMúTTT =W=N

!L EN !Fanq=MOPúTRQ

E !"F

P qu OKRâeòú !"#$%

Njeò !"#$%

EMKRF

=W= !"#

=W=N NMMKMMMMú !"L

RRMKMMMMjeò !"#$

RMeò

ElåZRI=lÑÑZMFQ qu lÑÑ =W=lÑÑLnqL

anqnq=STKMúORQKNEMKNeò !Fnq=STKMúORMKPEbf^Fanq=MMMúTTT

EN !Fanq=MOPúTRQ

E !"F

- - - - - - - -

QT 67 .0

QT 254 .1

Q T 6 7 .0

QT 250 .3

DQT000N

DQT777N

DQT023N

DQT754N

D Q T 0 0 0 Ι

D Q T 7 7 7 Ι

D Q T 0 2 3 Ι

D Q T 7 5 4 Ι

S T P 2 5 0

S T P 1 M

T . – – – – – – –

T .350 .0000

- - - - - - - -

QT 67 .0

QT 254 .1

Q T 6 7 .0

QT 250 .3

DQT000N

DQT777N

DQT023N

DQT754N

REALIGNMENT / !

TK-8100

12


DQT 000~777 key : Hold 1 second

Inverse to switch between

(1 setp mode) Normal/Inverse.

DQT 023~754

Inverse

(Standard

table mode)

5 Option Off Default

signaling DTMF

6 SP Carrier

unmute QT/DQT Not used when QT/

DQT decode is not set.

Carrier+DTMF Not used when option

signaling is none.

QT/DQT+ Not used when option

DTMF signaling is none.

7 Busy Off Default

channel Carrier

lockout QT/DQT If QT/DQT decode is

not set, it cannot be

selected.

DTMF If option signaling is

set to off, it cannot be

selected.

8 Beat No Default

shift Yes

9 RF High power Default

power Low power

10 Wide/ Wide Default

Narrow Narrow

11 Scan Delete

Del/Add Add Default

12 Priority No Default

channel Yes Not used when scan

priority is not fixed.

13 PTT ID Off Default

Begin of TX

End of TX

Both

14 Scrambler Off Default

On

15 Scrambler 1~16 Default

code

• Finish beep will sound when displayed data is stored.• The settings for scrambler and scrambler code can only be

selected when voice scrambler board is installed.

D Q T 0 0 0 Ι

D Q T 7 7 7 Ι

D Q T 0 2 3 Ι

D Q T 7 5 4 Ι

N O N E

D T M F

S.UM CARR

S.UM QTDQ

S.UM C+DT

S.UM Q+DT

B C L O F F

BCL CARR

BCL QTDQ

BCL DTMF

SHFT NO

S H F T Y E S

PWR H

P W R L

W I D E

NARROW

SCAN DEL

SCAN ADD

P.CH NO

P .CH YES

P . I D O F F

P . ID BOT

P . ID EOT

P . ID BOTH

S C R O F F

SCR ON

S C R 1

S C R 1 6

anq=MMMúTTT =W=N

!L EN !Fanq=MOPúTRQ

E !"F

R lÑÑ

aqjcS pm

nqLanq nqLanq !"#$%

Haqjc !"#$%

!"#$

nqLanqH !"#$%

aqjc !"#$

T lÑÑ

nqLanq nqLanq !"#$%

aqjc !"#$%

!"#$

U

V oc

NM L

NN

L

NO

!"#$%&

!"#$%&

NP mqq=fa lÑÑ

!

!

NQ lÑÑ

låNR NúNS

!"#$%&'() *#+",-./0

!"#$%&'()*+"#$,"#$-./0

D Q T 0 0 0 Ι

D Q T 7 7 7 Ι

D Q T 0 2 3 Ι

D Q T 7 5 4 Ι

N O N E

D T M F

S.UM CARR

S.UM QTDQ

S.UM C+DT

S.UM Q+DT

B C L O F F

BCL CARR

BCL QTDQ

BCL DTMF

SHFT NO

S H F T Y E S

PWR H

P W R L

W I D E

NARROW

SCAN DEL

SCAN ADD

P.CH NO

P .CH YES

P . I D O F F

P . ID BOT

P . ID EOT

P . ID BOTH

S C R O F F

SCR ON

S C R 1

S C R 1 6

REALIGNMENT / !

TK-8100

13

Flow Chart

Self programming mode[MON]

[MON]

[SCN]Channel setting mode Channel

selectionGroup

selection

RX frequencyChange

frequency step

Blank

Changefrequency step

Hold [ ]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

TX frequency

Blank

Off

DQT*N

DQT N

DQT*I

DQT I

TX signaling

Option signaling

Hold [ ]

Hold[ ]

Hold[ ]

Hold[ ]

Hold[ ]

QT

[MON]Off

QT*

QT*

DQT*N

DQT N

DQT*I

DQT I

RX signaling

QT

[SCN] or [ ]

SP unmute

Busy channel lockout

Beat shift

RF power

Wide/Narrow

Scan Del/Add

Priority channel

PTT ID

Scrmbler

Scrmbler code

Return to channel setting mode

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

[SCN] or [ ]

Not used when scan priority is not fixed.

REALIGNMENT / !

!

自台编程模式[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[MON]

[SCN]

信道设置模式信道选择组选择

RX频率更改频率步长

空白

更改频率步长

按住 [ ]

TX频率

空白

Off

DQT*N

DQT N

DQT*I

DQT I

TX信令

可选信令

QT

Off

QT*

DQT*N

DQT N

DQT*I

DQT I

RX信令

QT

QT*

SP不静音

繁忙信道锁定

拍频偏移

RF功率

宽/窄

扫描删除/添加

优先信道

PTT ID

扰频器

扰频器代码

返回到信道设置模式

按住 [ ]

按住[ ]

按住[ ]

按住[ ]

按住[ ]

当扫描优先没有设置为固定时不能使用。

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[SCN] 或 [ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

[ ]

TK-8100

14

5-4. DTMF Setting ModeEach transceiver can be setup in its action mode by using

the panel keys.• Pressing [SCN] when “ SELF ” is displayed, sets the

DTMF setting mode.• The data displayed using [SCN] is stored in the memory.• Pressing [ ] to without storing it in the memory.• Press [ ] to default status.

Flow Chart

Self mode (Display “ SELF ”)

[SCN]

Set default ID codeDTMF setting mode[ ]

[ ]

The setup items for DTMF setting mode are listed below.


1 ID code 000~ Display when an item

9999999999 is selected (about

(Code squelch) 0.5 seconds).

Display of the current

setting (If it is 8 or

more digits, scroll it).

Display when a code

is input (Input it with

DTMF key only).

key : Set to default

data

0000~9999 Display when an item

(Selective call) is selected (about

(*1) 0.5 seconds).

Display of the current

setting (Input the code

with DTMF key only).

key : Set to default

data

• Finish beep will sound when displayed data is stored.• (*1) : ID code range is from 3 to 4 digits when selective call

is selected.

I D

1 2 3 4 5 6 7 8

– – – – – 9 8 7

– – – – – 0 0 0

I D

– – – – 1 2 3 4

(*1)

– – – – – 0 0 0

(*1)

REALIGNMENT / !

RJQK=aqjc ! !" #$%&'()*+,-./0123)456

==pbic===xp`kz aqjc !"=xp`kz= !"#$%&%'()*=x z= !"#$%$&'()=x z= !"#$%

!

aqjc !"#$%&'()

N fa MMMú !"#$%

VVVVVVVVVV EMKRFE !F

!"#=E

U !"#$ !F !"#$

E aqjcF

=W= !"

MMMMúVVVV !"#$%

E !F EMKRFEGNF

!"#

E aqjc !F

=W= !"

!"#$%&'() *#+",-./0 EGNF=W= !"#$%fa !"PQ !

自台编程模式 (显示“SELF”)

设置默认ID代码DTMF设置模式

[SCN] [ ][ ]

I D

1 2 3 4 5 6 7 8

– – – – – 9 8 7

– – – – – 0 0 0

I D

– – – – 1 2 3 4

(*1)

– – – – – 0 0 0

(*1)

TK-8100

15

6. Accessory Connection Cable (KCT-39)The KCT-39 is an accessory connection cable for connect-

ing external equipment. The connector has 15 pins and thenecessary signal lines are selected for use.

6-1. Installing the KCT-39 in the Transceiver1. Lift the DC cord bushing ( ➊ ) from the chassis. Peel the

pad as shown in Figure 3 ( ➋ ).

1

2

2. Stick the pad to the DC cord ( ➌ ) and chassis ( ➍ ), bothof which are supplied with the KCT-39.

3

4

REALIGNMENT / !

SK= !"#=Eh`qJPVF

h`qJPV !"#$%&'()!"*+,!"-./NR !"#$%&'()*+

SJNK=h`qJPV !"#$NK !"#$%&'()=E➊F P !"#=E➋F

OK h`qJPV !"#$%&'()*= E➌ F= =E➍ F

Fig. 3 / P

Fig. 4 / Q

3. Insert the KCT-39 cable ( ➎ ) into the chassis ( ➏ ). Thewire harness band ( ➐ ) must be inside the chassis andface down.

4. Connect the KCT-39 to the TX-RX unit as shown in Figure5 ( ➑ ).

线束带(塞子)

热缩管

CN2CN3

AB

7

8

6

5

Chassis

Chassis

Cushion

KCT-39sumi tube

PCB

Face down / 面向下

Avoid forming the wiring towards the shielding cover closure area.

Wire harnessband (Stopper)

End view of this area

缓冲垫

避免配线缠绕在屏蔽盖闭合区域。

底座

底座

该区域端视图

PK h`qJPV=E➎F= !=E➏F !=E➐F= ! !"#$

QK R !h`qJPV quJou=E➑F

Fig. 5 / R

TK-8100

16

5. Connect the KCT-39 to the external accessory by insertingthe crimp terminal ( ➒ ) into the square plug ( ➓ ), both ofwhich are supplied with the KCT-39.

910

1315 1

3

1471013

2581114

3691215

REALIGNMENT / !

RK !"#=E➒F= !"=E➓F=Eh`qJPVF h`qJPV !"#$%

Fig. 6 / S

No. Color Internal connector Name

1 Red CN2-1 SB

2 Pink CN3-1 IGN

3 Black CN2-3 GND

4 Brown CN3-3 DETO

5 Orange CN3-2 DATAI

6 Yellow CN2-8 FNC4

7 Green CN2-7 FNC3

8 Blue CN2-9 FNC5

9 Purple CN2-12 FNC8

10 Grey CN2-10 FNC6

11 White CN2-11 FNC7

12 NC NC

13 NC NC

14 Sky blue CN2-6 FNC2

15 Turquoise CN2-5 FNC1

Accessory Port Function / !"#

!"

N `kOJN p_O `kPJN fdkP `kOJP dkaQ `kPJP abqlR `kPJO a^q^fS `kOJU ck`QT `kOJT ck`PU `kOJV ck`RV `kOJNO ck`UNM `kOJNM ck`SNN `kOJNN ck`TNO k` k`NP k` k`NQ `kOJS ck`ONR `kOJR ck`N

TK-8100

17

7-3. Modifying the TransceiverModify the transceiver as follows to turn the power on and

off with the ignition key.

1. Remove the resistor R71 of the TX-RX unit.

Setting With the KPG-80DSelect “External Devices” from the “Edit” menu and en-

able the “Ignition Sense”.

TX-RX unitComponent side

R71

CN

2

REALIGNMENT / !

7. Ignition Sense Cable (KCT-18)The KCT-18 is an optional cable for enabling the ignition

function. The ignition function lets you turn the power to thetransceiver on and off with the car ignition key.

7-2. Connecting the KCT-18 to the Transceiver1. Install the KCT-39 in the transceiver. (See the KCT-39 sec-

tion)2. Insert the KCT-18 lead terminal ( ➊ ) into pin 2 of the KCT-

39 ( ➋ ).

2

1

1315

1

3

TK= !"#$=Eh`qJNUF

h`qJNU !"#$%&'()*!"#$+,-./ !"#$%&'()*+,-./012

TJOK=h`qJNU !"#NK !"#$%&'h`qJPVEh`qJPVFOK h`qJNU=E➊F=h`qJPV=E➋F= O

TJPK= !" !"#$%&'()*+,-./0&123456

!"#$%&'()

NK quJou !"#oTN

hmdJUMa != != !"= !"#$%&'(= !"#$%

Fig. 7 / T

Fig. 8 / U

TK-8100

18

1. Optional Board

1-1. Voice Scrambler Board Connection

Modification1. Remove the cabinet and shielding cover from the trans-

ceiver.2. Delete R202 and R267 on the TX-RX unit.

A

9

87DCBA

A12

1

3

789

101112

1

12

BA11CA10DA9E12345B56B77A88A79A310B1111B912B4E18

Voice scramblerboard

12 pins lead wirewith connector (A)

E37-1081-05CN2

12

6

5

11

10

1

45

7

9

11

1

11

11 pins lead wirewith connector (B)

E37-1080-05CN3

R267

CN3

R202

TX-RX UNITComponent side

ConnectionThe functions of pins of CN2 and CN3 on the TX-RX unit

are shown in the TERMINAL FUNCTION section (page 50).

Fig. 2

INSTALLATION /

NK= NJNK= !"#$%& NK !"#$%&'$()*+,-OK quJou !oOMOoOST

quJou `kO`kP !"#$%&'!"(

=ERNF

A

9

87DCBA

A12

1

3

789

101112

1

12

BA11CA10DA9E12345B56B77A88A79A310B1111B912B4E18

话音扰频器板

带接头(A)的12引脚线

E37-1081-05CN2

12

6

5

11

10

1

45

7

9

11

1

11

带接头(B)的11引脚线

E37-1080-05CN3

Fig. 1 / N

O

TK-8100

19

Pins Connection

Voice scrambler 12 pins lead wire 11 pins lead wire

functions with connector (A) with connector (B)

A A-12 –

B A-11 –

C A-10 –

D A-9 –

5 – B-5

6 – B-7

7 A-8 –

8 A-7 –

9 A-3 –

10 – B-11

11 – B-9

12 – B-4

Setting With the KPG-80DSelect “External Devices” from the “Edit” menu and set

the “Scrambler”.

Note :The voice scrambler board is connected subsequent to the

de-emphasis circuit.

Cushion / 缓冲垫 (G13-1963-04)

Cushion / 缓冲垫 (G13-1964-04)Voice scrambler board / 话音扰频器板

Front side / 前侧

to CN2 and CN3

to CN2and CN3

CN3Voice scrambler

board

CN2

TX-RX UNIT

Component side

话音扰频器板

INSTALLATION /

!"

!" E^F E_F

NO NN

^ ^JNO J

_ ^JNN J

` ^JNM J

a ^JV J

R J _JR

S J _JT

T ^JU J

U ^JT J

V ^JP J

NM J _JNN

NN J _JV

NO J _JQ

hmdJUMa != != !"= !"#$%&'(= !"#

!"#$%&'()*+,-./0

Fig. 3 / P

TK-8100

20

1. When you remove the panel, turn the transceiver up sidedown. Detach the panel by lifting the tabs as shown be-low.

2. To remove the cabinet, first turn the transceiver up sidedown. Detach the cabinet by prying the tabs as shownbelow.

Tabs / 翼片

Tabs / 翼片

Tabs / 翼片

3. When mounting the front panel, match the 4 tabs of thechassis with the panel, being sure they attach securely.

Tabs / 翼片

Tabs / 翼片

Open the bottom of display unit at No. 1 as indicated.如编号1所示打开显示单元底部。

4-1. Remove the display unitTo remove the display unit from the panel, follow the cor-rect procedures shown (A regular screw driver is neededas illustrated).



w

e

NK !"#$%&'()*+,-$. /012345 !

DISASSEMBLY FOR REPAIR / !

OK !"#$%&'()*+,-!$. /012345 !"

PK !"#$%&'()Q !"#$%&'()*+%

Fig. 1 / N

Fig. 2 / O

Fig. 3 / P

QJNK= !"# !"#$%&'()*+,-&./0123456E !"#$%&'()F

q

TK-8100

21

Open the top of display unit at No. 4 as indicated.如编号4所示打开显示单元顶部。

r

Lift up the display unit and remove.提起显示单元并将其取出。

t

4-2. Mount the display unitTo mount the display unit on the panel, follow the correctprocedures shown to ensure easy display unit assemblyand good fitting onto the panel.

Insert phone jack into panel first.首先将麦克风插孔插入面板。

w


QJOK= !"# !"#$%&'()*+,-./"01234567 !"#$%&'()*+,-./0

q

TK-8100

22

Snap in bottom of display unit (No. 2).咬接显示单元底部 (编号2)。

t


Ensure that display unit holes locator is properly located on the illumination guide locators as shown.

如图所示，确保显示单元定位孔正确地定位在可见的定位器上。

y

u


r


Snap in top of display unit (No. 4).咬接显示单元顶部 (编号4)。

e

TK-8100

23

Frequency ConfigurationThe receiver utilizes double conversion. The first IF is

49.95MHz and the second IF is 450kHz. The first local oscil-lator signal is supplied from the PLL circuit.

The PLL circuit in the transmitter generates the necessaryfrequencies. Figure 1 shows the frequencies.

Receiver SystemThe receiver is double conversion superheterodyne. The

frequency configuration is shown in Figure 1.

Front-end RF Amplifier CircuitAn incoming signal from the antenna is applied to an RF

amplifier (Q353) after passing through a transmit/receiveswitch circuit (D604 and D605 are off) and a BPF (L359, L358,L360, L361 and varactor diodes : D353, D354, D355). Afterthe signal is amplified (Q353), the signal is filtered by a BPF(L354, L355 and varactor diodes: D351, D352) to eliminateunwanted signals before it is passed to the first mixer.

The voltage of these diodes are controlled by tracking theCPU (IC101) center frequency of the band pass filter. (SeeFig. 2)

First Mixer CircuitThe signal from the RF amplifier is heterodyned with the

first local oscillator signal from the PLL frequency synthesizercircuit at the first mixer (Q352) to create a 49.95MHz firstintermediate frequency (1st IF) signal. The first IF signal isthen fed through one pair of monolithic crystal filter (MCF :XF351) to further remove spurious signals.

ANTSW

RFAMP

1stMIX

AFPA

TCXO

MICAMP

X3multiply

RFAMP

POWERAMP

CF 450kHz

MCF49.95MHz

IF SYSTEM

PLL/VCO

16.8MHz

50.4MHz

ANT

RX

TX

SP

MIC

Fig. 1 Frequency configuration / N !

ANTL358~361D353~355

BPFQ353

RF AMPQ351

IF AMPIC161

D/A CONVERTERQ352MIX

XF351MCF

D602D604D605ANTSW

IC161D/A

Q302X3 multiply

X401TCXO

IC301IF system

1st local OSC (VCO/PLL)

W/NO(EVOL2)

CF301 (Wide)

CF302 (Narrow)

TV

CPU

L354,355D351,352

BPF

Fig. 2 Receiver system / O !"

CIRCUIT DESCRIPTION / !

! !"#$%&'()*+,-./&0QVKVRjeò !QRMâeò !"#$%&'()*+,-. !"#$%&'()*+,-./012N !"

!" !"#$%&'()*+%,-./0N

!"#$%&' !"#$%&'()*+,-=EaSMQaSMRF= !"= EiPRViPRUiPSMiPSN !"#$aPRPaPRQaPRRF= !"#$=EnPRPF !"#=EnPRPF= !"#$%&'=EiPRQiPRR !"#$aPRNaPROF !"#$%&'()*+,-./0123

!"#$%&`mr=Ef`NMNF= !"#$%&' !"#E OF

!"#$% !"#$%&'() *+,"%=EnPROF=

!"#$%&'()*+,-."/01QVKVRjeò

=ENëí=fcF= !"#$%&'()*+,-./0=Ej`cëucPRNF= !"#$%&'

TK-8100

24

IF Amplifier CircuitThe first IF signal is amplified by Q351, and the enters

IC301 (FM processing IC). The signal is heterodyned againwith a second local oscillator signal within IC301 to create a450kHz second IF signal. The second IF signal is then fedthrough a 450kHz ceramic filter (Wide : CF301, Narrow :CF302) to further eliminate unwanted signals before it is am-plified and FM detected in IC301.

Item Rating

Nominal center frequency 49.95MHz

Pass bandwidth ±5.0kHz or more at 3dB

35dB stop bandwidth ±20.0kHz or less

Ripple 1.0dB or less

Insertion loss 5.0dB or less

Guaranteed attenuation 80dB or more at fo±1MHz

Spurious : 40dB or more within fo±1MHz

Terminal impedance 350Ω / 5.5pF

Table 1 Crystal filter (L71-0591-05) : XF351

Item Rating

Nominal center frequency 450kHz

6dB bandwidth ±6.0kHz or more

50dB bandwidth ±12.5kHz or less



Guaranteed attenuation 35.0dB or more within fo±100kHz

Terminal impedance 2.0kΩ

Table 2 Ceramic filter (L72-0993-05) : CF301

Item Rating

Nominal center frequency 450kHz

6dB bandwidth ±4.5kHz or more

50dB bandwidth ±10.0kHz or less



Guaranteed attenuation 55.0dB or more within fo±100kHz

Terminal impedance 2.0kΩ

Table 3 Ceramic filter (L72-0959-05) : CF302

!"#$% !"#$%nPRN !"#$%f`PMN=E !"

F !"#f`PMN !"#$%&'()*QRMâeò !"#$ !"#%&'()*+,QRMâeò =E`cPMN `cPMOF= !"#$%&'()*f`PMN !"#

!"# QVKVRjeò

! PÇ_RKMâeò

PRÇ_ ! OMKMâeò

NKMÇ_

! RKMÇ_

! ÑçNjeòUMÇ_

!"#ÑçNjeòQMÇ_

! PRMΩ/RKRéc

N !"=EiTNJMRVNJMRFucPRM

!"# QRMâeò

SÇ_ SKMâeò

RMÇ_ NOKRâeò

OKMÇ_

! SKMÇ_

! ÑçNMMâeòPRKMÇ_

! OKMâΩ

O !"=EiTOJMVVPJMRF`cPMN

!"# QRMâeò

SÇ_ QKRâeò

RMÇ_ NMKMâeò

OKMÇ_

! SKMÇ_

! ÑçNMMâeòRRKMÇ_

! OKMâΩ

P !"=EiTOJMVRVJMRF`cPMO


TK-8100

25

Wide/Narrow Switching CircuitThe Wide port (pin 65) and Narrow port (pin 64) of the CPU

is used to switch between ceramic filters. When the Wideport is high, the ceramic filter SW diodes (D303, D302) causeCF301 to turn on to receive a Wide signal.

When the Narrow port is high, the ceramic filter SW diodes(D303, D302) cause CF302 to turn on to receive a Narrow sig-nal.

AF Signal CircuitThe detection signal from IF IC (IC301) goes to D/A con-

verter (IC161) to adjust the gain and is output to AF filter(IC251) for characterizing the signal. The AF signal outputfrom IC251 and the DTMF signal, BEEP signal are summedand the resulting signal goes to the D/A converter (IC161).The AFO output level is adjusted by the D/A converter. Thesignal output from the D/A converter is input to the audiopower amplifier (IC252). The AF signal from IC252 switchesbetween the internal speaker and speaker jack (J1) output.

Squelch CircuitThe detection output from the FM IF IC (IC301) passes

through a noise amplifier (Q301) to detect noise. A voltage isapplied to the CPU (IC101). The CPU controls squelch ac-cording to the voltage (SQIN) level. The signal from the RSSIpin of IC301 is monitored. The electric field strength of thereceive signal can be known before the SQIN voltage is inputto the CPU, and the scan stop speed is improved.

NarrowIC101 64pin

IF_IN MIX_O

IC301IF System

CF302(Narrow)

CF301(Wide)

R32

0

R31

9

R317

R318

D303 D302

WideIC6 65pin

AFFilter

D/ACONV.

D/ACONV.

IC161 IC251 IC161W/NO(EVOL2)

AF PA

IC252 SP

IF IC

IC301

Q301NOISE AMP D301IC301 IC101

AFO

RSSI

DETCPUIF

SYSTEM

SQIN

RSSI

Fig. 3 Wide/Narrow switching circuit / P L !"

Fig. 4 AF signal circuit / Q !"#

Fig. 5 Squelch circuit / R !

!"#$%`mr !=ESRF= !=ESQF= !"#$

!"#$%&'()*+,-./012p t EaPMPaPMOF=`cPMN !"#$%&' !"#$%&'()*+,pt =EaPMPaPMOF=

`cPMO !"#$%&'

!"#$ fc=f`=Ef`PMNF= !"#$%L !=Ef`NSNF !"#$%^c =EfÒRNF= !"#$%&'f`NSN ^c aqjc _bbm !"#$%&' !"#$L !=Ef`NSNF^cl !"#L !"#L !"#$%&'"()*+,-./!EfÒROF !fÒRO^c !"#$%&#$%'(=EgNF !"#$

!" ! "#=Ef`PMNF= !"#$%&'()=EnPMNF

!"#`mr=Ef`NMNF= !"`mr !=EpnfkF= !"#$%&f`PMNoppf !"#$%&'pnfk !"#`mr !"#$%&'()*+,-./01 !"#$%


TK-8100

26

PLL Frequency SynthesizerThe PLL circuit generates the first local oscillator signal for

reception and the RF signal for transmission.

PLLThe frequency step of the PLL circuit is 5 or 6.25kHz. A

16.8MHz reference oscillator signal is divided at IC401 by afixed counter to produce the 5 or 6.25kHz reference fre-quency. The voltage controlled oscillator (VCO) output signalis buffer amplified by Q410, then divided in IC401 by a dual-module programmable counter. The divided signal is com-pared in phase with the 5 or 6.25kHz reference signal in thephase comparator in IC401. The output signal from thephase comparator is filtered through a low-pass filter andpassed to the VCO to control the oscillator frequency. (SeeFig. 6)

VCOThe operating frequency is generated by Q406 in trans-

mit mode and Q405 in receive mode. The oscillator fre-quency is controlled by applying the VCO control voltage,obtained from the phase comparator, to the varactor diodes(D405 and D406 in transmit mode and D403 and D404 inreceive mode). The TX/RX pin is set low in receive modecausing Q408 and Q407 to turn Q406 off, and turn Q405 on.The TX/RX pin is set high in transmit mode. The outputsfrom Q405 and Q406 are amplified by Q410 and sent to theRF amplifiers.

Unlock CircuitDuring reception, the 8RC signal goes high, the 8TC signal

goes low, and Q34 turns on. Q33 turns on and a voltage isapplied to the collector (8R). During transmission, the 8RCsignal goes low, the 8TC signal goes high and Q36 turns on.Q35 turns on and a voltage is applied to 8T.

The CPU in the control unit monitors the PLL (IC401) LDsignal directly. When the PLL is unlocked during transmis-sion, the PLL LD signal goes low. The CPU detects this sig-nal and makes the 8TC signal low. When the 8TC signal goeslow, no voltage is applied to 8T, and no signal is transmitted.

D405,406

Q406TX VCO

Q410BUFFAMP

D403,404

Q405RX VCO

Q407,408T/R SW

Chargepump

LPF

Phasecomparator

1/M

1/N5kHz/6.25kHz

5kHz/6.25kHz

REFOSC

16.8MHz

PLLDATA

IC401 : PLL ICQ404AMP

Fig. 6 PLL circuit / S !"

Fig. 7 Unlock circuit / T !

!"#$% !"#$%&'()*+,-./0123(345

!

!"# !"#$%&'(RSKORâeòNSKUjeò !" !"#$%&'()*+f`QMN !"#RSKORâeò !"#$%&'=Es`lF= !"#nQNM

!"#$%&f`QMN !"#$%&'()*() !"#RSKORâeò !"#$%&'"()f`QMN !"#$ %&'()*+,-./012%3405

!"# !$%&E SF

!"# !"#$%nQMS !"#$%&'()*+,

nQMR !"#$%&'()*+,-./012345E !"aQMRaQMS !"#$%aQMPaQMQF !"#$nQMUnQMTnQMS !nQMR !"L !"#$%&'()*L !"#$%&'()*+ !"#$nQMRnQMS !nQNM !"oc

!" !"#$%Uo` !"#$Uq` !"#$%&

nPQ nPP !"#$%=EUoF= !"#$%&'Uo` !"#$Uq` !"#$%&nPS nPR !Uq !" !"#`mr !"#$%&=Ef`QMNF=ia ! !"#$%&'(#)*#$%&'ia !"#$`mr !"#$Uq` !"#$%&Uq` !"# !Uq !"#$%&'()*+,


IC101CPU

Q34SW

Q33SW

IC401PLL

Q36SW

Q35SW

LD

8RC

8C

8R 8T

8TC

PLL lock: LD “H”

TK-8100

27

Transmitter System

OutlineThe transmitter circuit produces and amplifies the desired

frequency directly. It FM-modulates the carrier signal bymeans of a varicap diode.

Power Amplifier CircuitThe transmit output signal from the VCO passes through

the transmission/reception selection diode (D409) and ampli-fied by Q500, Q501 and Q502. The amplified signal goes tothe power amplifier (IC502) through a low-pass filter. Thelow-pass filter removes unwanted high-frequency harmoniccomponents, and the resulting signal is goes the antenna ter-minal.

RFAMP

RFAMP

RFAMP

Q500 Q502

POWERMODULE

IC502Q501

DCAMP

IC203

ANTSW

D602D604D605

LPF

ANT

POWERDET

D606D607IC501

APCCONTROL

D409

PCIC161

3pin

+BVg

Q411RF AMP2SC5108

(Y)F

Q500RF AMP2SC5108

(Y)F

Q501RF AMP2SC3357

-A

Q502RF AMP2SC3357

-A

IC502

ANT

POWER AMPRA30H3340M

IC161 Q406D/A

CONVERTERM62363FP

X401

TCXO16.8MHz

VCO2SK508NV

(K52)

IC401

PLLMB15A02

Q410BUFFER2SC5108

(Y)F

Q404RF AMP2SC4649

(N,P)

IC203

BUFFERNJM2902V

IC101

IC161

MIC KEYINPUT

CPU30622MAA

-B96GU

D/A CONVERTER

M62363FPIC161

D/A CONVERTER

M62363FP

IC203

SUM AMPNJM2902V

IC202IC201MIC

MIC/IDCNJM2100V

SplatterFILTER

NJM2904V

Fig. 9 APC circuit / V !"#$%

Fig. 8 Transmitter system / U !"

!" !"#$%&'()*+,-./0123456,

!"#$%&'()*+

!"#$% !"#$%&'()*+,'(L !"#$

EaQMVF= !"#$=EnRMMnRMNnRMOF= !"#$=Ef`RMOF= !"#$%&'()*+, -./0 !"#$%&'()*+,-$./012*3456 !"


APC CircuitThe automatic transmission power control (APC) circuit

detects the power amplifier (IC502) output with a diode(D606, D607) and applies a voltage to IC501. IC501 com-pares the APC control voltage (PC) generated by the D/A con-verter (IC161) and DC amplifier (IC203) with the detectionoutput voltage. IC501 generates the voltage to control IC502and stabilizes transmission output.

The APC circuit is configured to protect over current ofIC502 due to fluctuations of the load at the antenna end andto stabilize transmission output at voltage and temperaturevariations.

!"#$%& !"#$%=E^m`F= !"#$%&=EaSMSaSMTF !"#= Ef`RMOF= !"#$%&f`RMN !"f`RMNaL^ =Ef`NSNF=a` =Ef`OMPF= ^m` !=Em`F= !"#$%&'()f`RMN !"#f`RMO !"#$%& !"#$%&'()*+,-*./0123&4

!"#$%=Ef`RMOF= !"#$%&'()!*+ !"#$

TK-8100

28

Control CircuitThe CPU carries out the following tasks:

1) Controls the WIDE, NARROW, TX/RX outputs.2) Adjusts the AF signal level of the AF filter (IC251) and

turns the filter select compounder on or off.3) Controls the display unit.4) Controls the PLL (IC401).5) Controls the D/A converter (IC161) and adjusts the vol-

ume, modulation and transmission power.

IC161D/A

converter

IC401PLL

IC101CPU

LDDTCK

PLLE

EEPCK

IC101CPU

IC66EEPROM

EEPDT

EEPWP

Fig. 10 Control circuit / NM !

Fig. 11 Memory circuit / NN !"

Memory CircuitThe transceiver has a 64k-bit EEPROM (IC66). The

EEPROM contains adjustment data. The CPU (IC101) con-trols the EEPROM through three serial data lines.

Display CircuitThe CPU (IC101) controls the display LCD and LEDs.

When power is on, the CPU will use the MBL line to controlthe LCD illumination and key backlight LEDs.

The dimmer function is controlled by the switch Q11. TheLCD controller (IC2) controls the functions of the LCDthrough the CE, CK, DI lines from the CPU.

Q10SW

Q6SW

IC101CPU

D2~D5

Q9SW

D19~D26,D28~D31

Q11SW

IC2LCD

controller

CECKDI

MBL

COM0~COM3SEG0~SEG30

DIM

LCD

Fig. 12 Display circuit / NO !

!`mr !"#$

NF !"!#$=L !"OF ^c =EfÒRNF=^c !"#$%&'()* !"#

PF !"#$QF !"#$=Ef`QMNFRF L !=Ef`NSNF= !"#$ %&'()*+

!"# !"#$SQâJÄáí=bbmolj=Ef`SSFbbmolj !`mr=Ef`NMNF= !"#$%&'(bbmolj

!"`mr=Ef`NMNF= !"iàiba !"#$mr

j_i !ià !"#$iba

!"#$%nNN ià =EfÒF=`mr

`bhaf !"ià


TK-8100

29

Key Matrix CircuitThe TK-8100 front panel has function keys. Each of them

is connected to a cross point of a matrix of the KMI1 to KMO2ports of the microprocessor. The KMO1 to KMO2 ports arealways high, while the KMI1 to KMI4 ports are always low.

The microprocessor monitors the status of the KMI1 toKMO2 ports. If the state of one of the ports changes, themicroprocessor assumes that the key at the matrix point cor-responding to that port has been pressed.

EncodeThe QT and DQT signals are output from QT/DQT of the

CPU (IC101) and summed with the external pin DI line by thesumming amplifier (IC203) and the resulting signal goes tothe D/A converter (IC161). The DTMF signal is output fromDTMF of the CPU and goes to the D/A converter (IC161). Thesignal is summed with a MIC signal by the summing amplifier(IC203), and the resulting signal goes to the D/A converter(IC161).

The D/A converter (IC161) adjusts the MO level and thebalance between the MO and QT/DQT levels. Part of a QT/DQT signal is summed with MO and the resulting signal goesto the VCOMOD pin of the VCO. This signal is applied to avaricap diode in the VCO for direct FM modulation.

IC101CPU

KMI1KMI2KMI3

KMI4

KMO2KMO1

MON

SCN

VOLUP

VOLDN

CHUP

CHDN

X401TCXO

IC161D/A VCO

IC203SUMAMP

IC203SUMAMP

IC161D/A

IC401PLL

TCXOMOD

VCOMOD

HT

DI

QT/DQT

DTMF

IC101CPU

Fig. 14 Encode / NQ

DecodeThe signal (W/NO (EVOL2)) goes to SIGNAL (pin 88) of

CPU (IC101). The QT/DQT signal will pass through the low-pass filters in the CPU (IC101) and be decoded within theCPU (IC101). The DTMF signal will be decoded within theCPU (IC101).

IC101CPU

SIGNAL W/NO (EVOL2)88

Fig. 15 Decode / NR

Fig. 13 Key matrix circuit / NP !"#


!"#$qhJUNMM !"#$%&'()*+&,-./012

hjfNhjlO !"#$%&'()hjfNhjfQ !"#$%&hjlNhjlO !"#$%& !"#hjfNhjlO !"#$%&'() !"#$%&'()*+,-./01234567 !"#

`mr=Ef`NMNF=nqLanq nqanq !"#$

=EfÒMPF= !"af !"#$%&'()*+L =Ef`NSNF`mraqjc aqjc !"#L !=Ef`NSNF !"#=EfÒMPF= !"jf` !"#$%&'(L !=Ef`NSNFL !=Ef`NSNF=jl jlnqLanq

!"#$nqLanq !"#jl !"#$% !"#$%s`ljla !"#$%&'()*+, !"#$%&'()(*+

=EtLkl=EbsliOFF= `mr=Ef`NMNF=pfdkî=E

UUFnqLanq !"`mr=Ef`NMNF= !"#$%&`mr=Ef`NMNF= !"aqjc !`mr=Ef`NMNF=

TK-8100

30

Q71SW

Q31SW

Q32SW

Q61SW

IC33AVR

D61

B

IC34RST

SBC

IGN

R77

R76

R39

R40

INT

5MBATT

IC101CPU

POWERSW

POWER

RE

SE

T

5M

IC35AVR

SB

IGN

Fig. 16 Power supply circuit / N

D/A ConverterThe D/A converter (IC161) is used to adjust MO modula-

tion, AF volume, TV voltage, FC reference voltage, and PCPOWER CONTROL voltage level.

Adjustment values are sent from the CPU as serial data.The D/A converter has a resolution of 256 and the followingrelationship is valid:

D/A output = (Vin – VDAref) / 256 x n + VDArefVin: Analog inputVDAref: D/A reference voltagen: Serial data value from the microprocessor (CPU)

Power Supply CircuitWhen the power switch on the display unit is pressed, the

power port on the display unit which is connected port 17(POWER), goes low, then port 82 (SBC) goes high, Q32 turnson, SB SW (Q31) turns on and power (SB) is supplied to thetransceiver.

When the DC power supplied to the transceiver, the volt-age regulator IC (IC33) supply into the CPU VDD and resetvoltage detect IC (IC34). IC34 will generate signal (RESET) into the reset terminal on the CPU (IC101) to carry out a powerON reset. Also, CPU (IC101) is checking on port 91 (BatteryVoltage). If DC power is less than about 9.5V, the transceiveris unable to power on.

When the DC power voltage deceases from normal volt-age, the INT voltage detector IC (IC35) will set to high on CPUport 18 (INT) if B line will became less than about 9.5V. ThenCPU send to EEPROM (IC66) the backup data and go intoSTOP mode.

This circuit has an overvoltage protection circuit. If a DCvoltage of 18V or higher is applied to the base of Q61, thisvoltage turns Q61 on and turns Q32 and SB off.

L !L !=Ef`NSNF= !jl c qs c` !"m`=mltbo=`lkqoli !`mr !"#$%&!'(!)*+,-./012

ORS !"#$%&'( !"#Esáåsa^êÉÑFLORSåsa^êÉÑsáå !"sa^êÉÑ !"#$%å !"#$%=E`mrF= !"#

!"#$%mltbo !"#$%&`mrNT

EmltboF= !"#$%&'"()*+`mrUO=Ep_`F !"nPO p_=pt=EnPNF= !"#$%&'()Ep_Fa` !"#$%&'()*+,-.f`=Ef`PPF=

`mr=saa !"#$%&f`=Ef`PQF=f`PQ !"EobpbqF `mr=Ef`NMNF= !"#$%&'()* !"mr=Ef`NMNF= !VN=E F a`

!VKRs !"#$%&'()*+,a` !"# $%&fkq !f`=Ef`PRF=

`mrNU=EfkqF= !"_ !"#$VKRsmr

!"#$bbmolj=Ef`SSF !"pqlm !"#$%& '()NUs !a` !

nSN !"#$%&'(nSN nPOp_


TK-8100

31

SEMICONDUCTOR DATA / !"

Terminal Function

Pin No. Name I/O Function

1 QT/DQT O QT/DQT output

2 DTMF/MSK O DTMF/MSK/BEEP output

3 PLLE O PLL IC chip select

4,5 NC I

6 GND - GND

7 CNVSS - CNVss for flash

8 EVLLD O E-volume LD

9 BSHIFT O Beat shift

10 RESET - Reset

11 XOUT - X’tal (14.318MHz)

12 VSS - GND

13 XIN - X’tal (14.318MHz)

14 VCC - +5V

15 GND - GND (Input only)

16 NC I

17 POWER I Power key input

18 INT I µcom stop

19 NC I

20 TX/RX O TX/RX

21 UL O PLL unlock detect

22~25 NC I

26 EEPWP O EEPROM write protect

27 EEPCK O EEPROM clock (N ch open drain)

28 EEPDT I/O EEPROM data (N ch open drain)

29 FNC1 I/O Function P1/TxD for flash

30 FNC2 I/O Function P2/RxD for flash

31 CLKFLS I SCLK for flash

32 BSYFLS O Busy for flash

33 TXD O To FPU

34 RXD I From FPU

35 PTT I PTT key

36 HOOK I Hook

37,38 NC I

39 EMPFLS I/O EPM for flash

40~42 NC I

43 FNC3 I/O Function port 3

44 CEFLS I/O CE for flash

45,46 FNC4, FNC5 I/O Function port 4, 5

47,48 FNC7, FNC6 I/O Function port 7, 6

49 FNC8 I/O Function port 8

50 AFM O AF mute

Microprocessor / ! : 30622MAA-B96GU (TX-RX Unit IC101)

!

! L

N nqLanq nqLanq

O aqjcLjph aqjcLjphL_bbm

P miib f` !

QR k`

S dka J

T `kspp J `ksëë

U bsiia bJia

V _pefcq !

NM obpbq J

NN ulrq J uí~ä=ENQKPNUjeòF

NO spp J

NP ufk J uí~ä=ENQKPNUjeòF

NQ s`` J HRs

NR dka J =EF

NS k`

NT mltbo !"

NU fkq µ`lj

NV k`

OM quLou L

ON ri !"#

OOOR k`

OS bbmtm bbmolj

OT bbm`h bbmolj

OU bbmaq L bbmolj

OV ck`N L !"mNLqña

PM ckÒ L !"mOLoña

PN ìhcip pìh

PO _pvcip _ìëó

PP qua cmr

PQ oua cmr

PR mqq mqq

PS ellh

PTPU k`

PV bjmcip L bmj

QMQO k`

QP ck`P L !P

QQ `bcip L `b

QRQS ck`Qck`R L !QR

QTQU ck`Tck`S L !TS

QV ckÙ L !U

RM ^cj

TK-8100

32

Pin No. Name I/O Function

51 SPM O Speaker mute

52 AMPSW O AF AMP switch

53 DT O Common data

54 CK O Common clock

55,56 NC I

57~59 DST1~DST3 I Destination 1~3

60 VCC - +5V

61 NC I

62 VSS - GND

63 NC I

64 NARROW O

65 WIDE O

66~68 NC I

69 CL O Clock for LCD

70 CE O Chip enable for LCD

71 DI O Transfer data to LCD

72 IGN I Ignition

73 MICMT1 O Mic 1 mute

74 MICEM O Mic 2 mute

75 MICMT2 O Mic 3 mute

76 8RC O 8R control

77 8TC O 8T control

78 CM I/O Mic key check

79~81 NC I

82 SBC O Battery switch

83 KMI2 I Key matrix 2




87 NC I

88 SIGNAL I DTMF/QT/DQT input

89 TEMP2 I Temperature 2

90 TEMP1 I Temperature 1

91 BATT I Battery voltage

92 RSSI I RSSI input

93 SQIN I Squelch input

94 AVSS - GND

95 NC I

96 VREF - +5V

97 AVCC - +5V

98 NC I

99 KMO1 O Key matrix output 1


! L

RN pmj !"

RO ^jmpt !"#

RP aq !

RQ `h !

RRRS k`

RTúRV apqNapqP NP

SM s`` J HRs

SN k`

SO spp J

SP k`

SQ kôolt

SR tfab

SSSU k`

SV ì ià

TM `b ià !

TN af !"ià

TO fdk

TP jf`jqN N

TQ jf`bj O

TR jf`jqO P

TS Uo` Uo

TT Uq` Uq

TU `j L !"#

TVUN k`

UO p_` !

UP hjfO !"O

UQ hjfN !"N

UR hjfP !"P

US hjfQ !"Q

UT k`

UU pfdkî aqjcLnqLanq

UV qbjmO O

VM qbjmN N

VN _^qq

VO oppf oppf

VP pnfk !

VQ ^spp J

VR k`

VS sobc J HRs

VT ^s`` J HRs

VU k`

VV hjlN !"N

NMM hjlO !"O

SEMICONDUCTOR DATA / !"

TK-8100

33

Display Unit (X54-3430-20)

Ref. No. Parts name Description

IC2 IC LCD controller

Q6 Transistor DC switch

Q9 Transistor LCD backlit switch

Q10 Transistor Key backlit switch

Q11 Transistor Dimmer function switch

D2~5 LED Key & LCD backlit

D17 Diode DC switch

D18 Diode DC controller


D27 Diode Surge absorption


TX-RX Unit (X57-6923-03)


IC31 IC Voltage regulator (8C)

IC32 IC Voltage regulator (5C)

IC33 IC Voltage regulator (5M)

IC34 IC Voltage detector reset

IC35 IC Voltage detector int

IC66 IC EEPROM

IC101 IC CPU

IC161 IC Digital potentiometer

IC201 IC MIC amplifier / IDC

IC202 IC MIC amplifier / Splatter filter

IC203 IC Buffer amplifier / SUM amplifier /

DC amplifier / 1/2 Vcc

IC251 IC Audio filter

IC252 IC Audio amplifier

IC301 IC FM demodulation

IC401 IC PLL synthesizer

IC501 IC APC controller

IC502 IC Power module

Q1 Transistor TX AF

Q31 Transistor DC switch (SB) / Active when power is on

Q32 FET DC switch (SB) / Active when power is on

Q33,34 Transistor DC switch (8R) / Active while RX

Q35,36 Transistor DC switch (8T) / Active while TX

Q61 Transistor Over voltage detection / Active when

PS voltage is more than18V

Q71 Transistor Ignition / Ignition sense

Q86,87 Transistor Beat shift / Active while beat shift is on

Q201 Transistor AF amplifier / MIC mute / Emergency MIC mute

Q202 FET Emergency MIC mute / Active when

MICEM is H

COMPONENTS DESCRIPTION / !

!=EuRQJPQPMJOMF

! !

fÒ f` ià

nS !"#

nV ià !

nNM !"#

nNN !"#$

aOR !" ià

aNT !"#

aNU !"#$

aNVOS !" ià

aOT !

aOUPN !" ià

quJou=EuRTJSVOPJMPF

! !

f`PN f` !"=EU`F

f`PO f` !"=ER`F

f`PP f` !"=ERjF

f`PQ f` !"#$

f`PR f` !"áåí

f`SS f` bbmolj

f`NMN f` !

f`NSN f` !"

fÒMN f` !"Lfa`

fÒMO f` !"L !"#$

fÒMP f` !"L !"L !"L

NLOsÅÅ

fÒRN f` !"

fÒRO f` !"

f`PMN f` cj

f`QMN f` !"#

f`RMN f` ^m`

f`RMO f` !

nN !

nPN !=Ep_FL !"

nPO !" !=Ep_FL !"

nPPPQ !=EUoFL !

nPRPS !=EUqFL !

nSN !"L

mp !NUs

nTN L !"

nUSUT !L !"#$#%

nOMN !"L !L !"#

nOMO !" !"#L

jf`bje

TK-8100

34

COMPONENTS DESCRIPTION / !


Q251 Transistor Buffer amplifier / RX audio

Q252,253 FET AF mute / Active while AFM is H

Q254 Digital transistor AF mute / Active while SPM is H

Q255 Transistor AF mute / Active while AMPSW is H

Q301 Transistor SQL amplifier / Noise amplifier

Q302 Transistor Buffer amplifier / 16.8MHz 3rd over tone

Q351 Transistor IF amplifier

Q352 FET Mixer

Q353 FET RF amplifier / LNA

Q402,403 Transistor Charge pump

Q404 Transistor RF amplifier / PLL F in

Q405 FET RX VCO

Q406 FET TX VCO

Q407 FET T/R switch

Q408 Transistor T/R switch

Q410 Transistor Buffer amplifier / Output of VCO

Q411 Transistor RF amplifier / Output of VCO

Q440 Transistor Ripple filter

Q500 Transistor RF switch (TX/RX)

Q501,502 Transistor RF amplifier

D1 Diode Surge absorption / CM

D2 Diode Surge absorption / HOOK

D3 Diode Surge absorption / PTT

D4~11 Diode Surge absorption / FNC1~8

D31 Diode Reverse connection protection

D32 Poly switch Current protection

D61 Diode Over voltage detection

D201 Diode OR gate / MIC mute, AGC

D202 Diode AGC

D251 Diode Limiter

D301 Diode Detection

D302,303 Diode IF switch (Wide/Narrow)

D351~355 Varicap RF BPF tuning

D401 Diode Ripple filter

D402 Diode Voltage dropped

D403,404 Varicap RX VCO

D405,406 Varicap TX VCO

D407 Varicap Modulation

D408 Diode Ripple filter

D409 Diode RF switch (TX/RX)

D502 Diode Temperature compensation

D503 Diode Voltage protection

D602 Diode ANT switch

D604,605 Diode ANT switch

D606,607 Diode APC voltage detect

D608,609 Diode Temperature compensation

! !

nORN !"L !

nOROORP !" L^cje

nORQ !" Lpmje

nORR L^jmpte

nPMN !"Lpni

nPMO !"LNSKUjeò !"#$

nPRN !"

nPRO !"

nPRP !" !"Lik^

nQMOQMP !

nQMQ !"L !"#

nQMR !" !"#$

nQMS !" !"#$

nQMT !" L !

nQMU L !

nQNM !"Ls`l

nQNN !"Ls`l

nQQM !"

nRMM !=ELF

nRMNRMO !"

aN !L`j

aO !Lellh

aP !Lmqq

aQNN !Lck`NU

aPN !"#

aPO ! !

aSN !"

aOMN L !"d`

aOMO ^d`

aORN

aPMN

aPMOPMP !=ELF

aPRNPRR !" _mc

aQMN !"

aQMO !

aQMPQMQ !" !"#$

aQMRQMS !" !"#$

aQMT !"

aQMU !"

aQMV !=ELF

aRMO !

aRMP !

aSMO !

aSMQSMR !

aSMSSMT !"#$%&'

aSMUSMV !

TK-8100

35

PARTS LIST / New Parts. indicates safety critical components.Parts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.

Ref. No. Address Parts No. Description Desti-nation

Newparts Ref. No. Address Parts No. Description Desti-

nationNewparts

TK-8100 (Y51-4973-01)

DISPLAY UNIT (X54-3430-20)

TX-RX UNIT (X57-6923-03)

1 1B A01-2178-02 CABINET2 3B A10-4080-11 CHASSIS3 3A A62-1074-03 PANEL ASSY

5 3A B11-1299-02 ILLUMINATION GUIDE6 3A B38-0878-05 LCD7 1C B62-1879-00 INSTRUCTION MANUAL

10 3B E04-0167-05 RF COAXIAL RECEPTACLE (M)11 3A E29-1197-15 INTER CONNECTOR (LCD)13 2B E30-7552-05 DC CORD (RADIO)14 3A E37-0962-05 SPEAKER CABLE15 2A E37-1041-05 FLAT CABLE (TX/RX_DISPLAY)

- E37-1080-05 PROCESSED CABLE (B) 11P- E37-1081-05 PROCESSED CABLE (A) 12P- E37-1117-05 SMARTRUNK CABLE

20 2B F10-2414-03 SHIELDING PLAT E(POWER MODULE)21 2B F10-2491-12 SHIELDING COVER (TX/RX)22 2B F10-2498-03 SHIELDING CASE (POWER MODULE)23 1D F51-0016-15 FUSE (6X30 10A)

25 2B G02-0887-03 EARTH SPRING (ANTENNA TERMINAL)26 2B G10-0792-14 FIBROUS SHEET (POWER MODULE)- G13-1963-04 CUSHION (SCRAMBLER)- G13-1964-04 CUSHION (SCRAMBLER)30 3B G13-2003-04 CUSHION (DC CORD)

- G13-2005-04 CUSHION (SMARTRUNK)- G13-2006-04 CUSHION (SMARTRUNK)- G13-2007-04 CUSHION (SMARTRUNK)34 1B G53-1524-02 PACKING (CABINET)35 3B G53-1525-03 PACKING (PANEL)

36 2B G53-1542-03 PACKING (PHONE JACK)

39 1D H10-6636-13 POLYSTYRENE FOAMED FIXTURE40 2C H10-6639-03 POLYSTYRENE FOAMED FIXTURE43 2D H52-1700-12 ITEM CARTON CASE

48 3A K29-9262-01 KEY TOP

A 2B N67-3008-46 PAN HEAD SEMS SCREWB 2B,3B N87-2606-46 BRAZIER HEAD TAPTITE SCREWC 1B,2B N87-2614-46 BRAZIER HEAD TAPTITE SCREW

52 3A T07-0739-15 SPEAKER

D2-5 B30-2205-05 LED (YG)D19-26 B30-2205-05 LED (YG)D28-31 B30-2205-05 LED (YG)

C4 CC73GCH1H101J CHIP C 100PF JC6 CK73GB1H103K CHIP C 0.010UF KC15,16 CC73GCH1H101J CHIP C 100PF JC18 CK73FB1A105K CHIP C 1.0UF K

C19 CK73GB1H681K CHIP C 680PF KC22,23 CK73GB1H102K CHIP C 1000PF KC24 CK73GB1H103K CHIP C 0.010UF KC25 CK73GB1H102K CHIP C 1000PF KC27,28 CK73GB1H102K CHIP C 1000PF K

C30 CK73GB1H103K CHIP C 0.010UF KC31-33 CK73GB1H102K CHIP C 1000PF K

CN1 E40-6005-05 FLAT CABLE CONNECTORJ1 E08-0877-05 MODULAR JACK

L1 L92-0138-05 CHIP FERRITE

CP1 R90-0724-05 MULTI-COMP 1K X4R4-9 RK73GB1J102J CHIP R 1.0K J 1/16WR10,11 RK73GB1J272J CHIP R 2.7K J 1/16WR21-23 RK73GB1J103J CHIP R 10K J 1/16WR24 RK73GB1J474J CHIP R 470K J 1/16W

R25 RK73GB1J473J CHIP R 47K J 1/16WR26 RK73GB1J392J CHIP R 3.9K J 1/16WR33 RK73FB2A560J CHIP R 56 J 1/10WR34 RK73GB1J101J CHIP R 100 J 1/16WR36 RK73FB2A560J CHIP R 56 J 1/10W

R37 RK73GB1J100J CHIP R 10 J 1/16WR38,39 RK73FB2A390J CHIP R 39 J 1/10WR40 RK73FB2A473J CHIP R 47K J 1/10W

D17 MA2S111 DIODED18 DA204U DIODED27 DA221 DIODEIC2 LC75834W MOS-ICQ6 KRC102S DIGITAL TRANSISTOR

Q9 2SB1132(Q,R) TRANSISTORQ10 KRA225S DIGITAL TRANSISTORQ11 RN47A4 TRANSISTOR

C10 CK73GB1H102K CHIP C 1000PF KC13-23 CK73GB1H471K CHIP C 470PF KC26-28 CK73GB1H221K CHIP C 220PF KC29 CK73GB1H471K CHIP C 470PF KC30 CK73GB1H102K CHIP C 1000PF K

C32 CK73GB1H102K CHIP C 1000PF KC33 CK73GB1H471K CHIP C 470PF KC34 C92-0721-05 ELECTRO 330UF 25WVC35-38 CK73GB1H471K CHIP C 470PF KC39,40 CK73GB1C104K CHIP C 0.10UF K

C41 C92-0795-05 CHIP-TAN 22UF 10WVC42 CK73GB1H103K CHIP C 0.010UF KC43-45 C92-0795-05 CHIP-TAN 22UF 10WVC48-50 CK73GB1H103K CHIP C 0.010UF KC51 C92-0560-05 CHIP-TAN 10UF 6.3WV

C52,53 CK73GB1H471K CHIP C 470PF KC54,55 CK73GB1C104K CHIP C 0.10UF KC56 CK73GB1H471K CHIP C 470PF K

TK-8100


TX-RX UNIT (X57-6923-03)

TK-8100

36

PARTS LIST /



nationNewparts

C61 CK73GB1H471K CHIP C 470PF KC66 CK73GB1H471K CHIP C 470PF KC72 CK73GB1H471K CHIP C 470PF KC77 CK73GB1H471K CHIP C 470PF KC78 CK73GB1H102K CHIP C 1000PF K

C82 CK73GB1H471K CHIP C 470PF KC83 CK73GB1C104K CHIP C 0.10UF KC87 CC73GCH1H180J CHIP C 18PF JC88,89 CC73GCH1H060B CHIP C 6.0PF BC90 CC73GCH1H180J CHIP C 18PF J

C97,98 CK73GB1H471K CHIP C 470PF KC101 CK73GB1H471K CHIP C 470PF KC102 CK73GB1C104K CHIP C 0.10UF KC103 CK73GB1H102K CHIP C 1000PF KC104 CK73GB1C104K CHIP C 0.10UF K

C151 CK73GB1H182K CHIP C 1800PF KC152 CK73GB1H392K CHIP C 3900PF KC161 CK73GB1H102K CHIP C 1000PF KC162 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC163 CK73GB1H471K CHIP C 470PF K

C164 C92-0560-05 CHIP-TAN 10UF 6.3WVC201 CK73GB1C104K CHIP C 0.10UF KC202 CK73GB1H471K CHIP C 470PF KC203 CK73GB1C273K CHIP C 0.027UF KC204 C92-0514-05 CHIP-TAN 2.2UF 10WV

C205 CK73GB1C104K CHIP C 0.10UF KC206 CK73GB1H102K CHIP C 1000PF KC207 CK73GB1C223K CHIP C 0.022UF KC208 CK73GB1H103K CHIP C 0.010UF KC210 CK73GB1C104K CHIP C 0.10UF K

C211 CK73GB1H821K CHIP C 820PF KC212 CK73GB1H122K CHIP C 1200PF KC213 CK73GB1H332K CHIP C 3300PF KC214 CC73GCH1H151J CHIP C 150PF JC215 CK73GB1C104K CHIP C 0.10UF K

C217,218 C92-0560-05 CHIP-TAN 10UF 6.3WVC220 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC221 CK73GB1C104K CHIP C 0.10UF KC225 C92-0004-05 CHIP-TAN 1.0UF 16WVC226 CK73GB1H472K CHIP C 4700PF K

C227 CK73GB1E103K CHIP C 0.010UF KC228 C92-0560-05 CHIP-TAN 10UF 6.3WVC229 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC230 CK73GB1C104K CHIP C 0.10UF KC231,232 CK73GB1H471K CHIP C 470PF K

C233 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC250 CK73GB1C104K CHIP C 0.10UF KC251 C92-0714-05 CHIP-TAN 4.7UF 6.3WVC252 CC73GCH1H390J CHIP C 39PF JC253,254 CK73GB1A105K CHIP C 1.0UF K

C255 CK73GB1H822K CHIP C 8200PF KC256 CK73GB1E183K CHIP C 0.018UF KC257 CK73GB1C393K CHIP C 0.039UF KC258-261 CK73GB1H103J CHIP C 0.010UF JC262 CK73GB1H471K CHIP C 470PF K

C263,264 CK73GB1C333K CHIP C 0.033UF KC265,266 CK73GB1C104K CHIP C 0.10UF KC267 CK73GB1A474K CHIP C 0.47UF KC268 CK73GB1C104K CHIP C 0.10UF KC269 CK73GB1A105K CHIP C 1.0UF K

C270 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC271 CK73GB1H332K CHIP C 3300PF KC272 CK73GB1H102K CHIP C 1000PF KC273 CK73GB1A105K CHIP C 1.0UF KC274 CK73FB1C224K CHIP C 0.22UF K

C275 CK73GB1A105K CHIP C 1.0UF KC276,277 CK73GB1H471K CHIP C 470PF KC278 CK73GB1C104K CHIP C 0.10UF KC279 C92-0516-05 CHIP-TAN 4.7UF 16WVC280 C92-0040-05 CHIP-ELE 47UF 16WV

C281 CK73GB1H471K CHIP C 470PF KC282 C92-0722-05 ELECTRO 470UF 16WVC283 CK73GB1H102K CHIP C 1000PF KC301 C92-0507-05 CHIP-TAN 4.7UF 6.3WVC302 CK73GB1H102K CHIP C 1000PF K

C303 CK73GB1H472K CHIP C 4700PF KC304,305 CC73GCH1H221J CHIP C 220PF JC306 CK73GB1H102K CHIP C 1000PF KC307 CK73GB1E223K CHIP C 0.022UF KC308 CK73GB1H102K CHIP C 1000PF K

C309 CK73GB1E223K CHIP C 0.022UF KC310 CK73FB1C334K CHIP C 0.33UF KC311,312 CK73GB1C104K CHIP C 0.10UF KC313 C92-0662-05 CHIP-TAN 15UF 6.3WVC314 CK73GB1H103K CHIP C 0.010UF K

C315-318 CK73GB1C104K CHIP C 0.10UF KC319 CC73GCH1H101J CHIP C 100PF JC321 CC73GCH1H330J CHIP C 33PF JC322 CC73GCH1H560J CHIP C 56PF JC323 CC73GCH1H271J CHIP C 270PF J

C324 CK73GB1H103K CHIP C 0.010UF KC326 CK73GB1H103K CHIP C 0.010UF KC351 CC73GCH1H330J CHIP C 33PF JC353 CK73GB1H103K CHIP C 0.010UF KC354 CC73GCH1H060B CHIP C 6.0PF B

C355 CC73GCH1H180J CHIP C 18PF JC356 CC73GCH1H020B CHIP C 2.0PF BC357 CK73GB1H103K CHIP C 0.010UF KC358 CK73GB1H471K CHIP C 470PF KC359 CC73GCH1H120J CHIP C 12PF J

C360 CC73GCH1H080B CHIP C 8.0PF BC361,362 CK73GB1H471K CHIP C 470PF KC363 CK73GB1H103K CHIP C 0.010UF KC364 CK73GB1H471K CHIP C 470PF KC366 CK73GB1C104K CHIP C 0.10UF K

C367 CK73GB1H471K CHIP C 470PF KC368 CC73GCH1H070B CHIP C 7.0PF BC369 CC73GCH1HR75B CHIP C 0.75PF BC370 CK73GB1H471K CHIP C 470PF KC371 CC73GCH1H0R5B CHIP C 0.5PF B

C372 CC73GCH1H150J CHIP C 15PF JC373,374 CC73GCH1H070B CHIP C 7.0PF BC375-380 CK73GB1H471K CHIP C 470PF KC381 CC73GCH1H080B CHIP C 8.0PF BC382 CK73GB1H471K CHIP C 470PF K

C383 CC73GCH1H0R5B CHIP C 0.5PF BC384 CC73GCH1H070B CHIP C 7.0PF BC385 CK73GB1H471K CHIP C 470PF KC386 CC73GCH1H010B CHIP C 1.0PF BC387 CC73GCH1H0R5B CHIP C 0.5PF B

TX-RX UNIT (X57-6923-03)

TK-8100

37

PARTS LIST /



nationNewparts

C388 CC73GCH1H070B CHIP C 7.0PF BC389 CK73GB1H103K CHIP C 0.010UF KC390 CC73GCH1H080B CHIP C 8.0PF BC391 CK73GB1H471K CHIP C 470PF KC401-403 CC73GCH1H101J CHIP C 100PF J

C404 C92-0662-05 CHIP-TAN 15UF 6.3WVC406 CK73GB1H102K CHIP C 1000PF KC408 CC73GCH1H220J CHIP C 22PF JC409 CK73GB1C104K CHIP C 0.10UF KC410 C92-0560-05 CHIP-TAN 10UF 6.3WV

C411 CK73GB1C104K CHIP C 0.10UF KC412 C92-0560-05 CHIP-TAN 10UF 6.3WVC413 CK73GB1H103K CHIP C 0.010UF KC414 CK73GB1C104K CHIP C 0.10UF KC416,417 CK73GB1H471K CHIP C 470PF K

C418 CK73GB1H102K CHIP C 1000PF KC421,422 CK73GB1H471K CHIP C 470PF KC423 C92-0555-05 CHIP-TAN 0.047UF 35WVC424 C92-0543-05 CHIP-TAN 3.3UF 10WVC425 C92-0001-05 CHIP-TAN 0.1UF 35WV

C426 CC73GCH1H100C CHIP C 10PF CC427 CC73GCH1H040B CHIP C 4.0PF BC428 CK73GB1H471K CHIP C 470PF KC429 CC73GCH1H010B CHIP C 1.0PF BC430 CC73GCH1H040B CHIP C 4.0PF B

C431 CC73GCH1H030B CHIP C 3.0PF BC432 CC73GCH1H0R5B CHIP C 0.5PF BC433 CK73GB1H471K CHIP C 470PF KC434,435 CC73GCH1H050B CHIP C 5.0PF BC436 CC73GCH1H0R5B CHIP C 0.5PF B

C437 CK73GB1H471K CHIP C 470PF KC438 CC73GCH1H020B CHIP C 2.0PF BC439 CC73GCH1H040B CHIP C 4.0PF BC440 CC73GCH1H4R5B CHIP C 4.5PF BC441 CC73GCH1H0R3B CHIP C 0.3PF B

C442 C92-0560-05 CHIP-TAN 10UF 6.3WVC444 CK73GB1H471K CHIP C 470PF KC448,449 CK73GB1H471K CHIP C 470PF KC450 C92-0568-05 CHIP-TAN 22UF 10WVC451,452 CK73GB1H471K CHIP C 470PF K

C454 CC73GCH1H060B CHIP C 6.0PF BC455 CC73GCH1H020B CHIP C 2.0PF BC456 CC73GCH1H040B CHIP C 4.0PF BC461 CK73GB1H471K CHIP C 470PF KC463,464 CK73GB1H471K CHIP C 470PF K

C466 CC73GCH1H050B CHIP C 5.0PF BC467 CK73GB1H471K CHIP C 470PF KC469 CC73GCH1H100C CHIP C 10PF CC470 CC73GCH1H050B CHIP C 5.0PF BC472 CC73GCH1H100C CHIP C 10PF C

C501 CK73GB1H471K CHIP C 470PF KC502 CC73GCH1H020B CHIP C 2.0PF BC504,505 CK73GB1H471K CHIP C 470PF KC507 CK73GB1H471K CHIP C 470PF KC509 CC73GCH1H050B CHIP C 5.0PF B

C510-515 CK73GB1H471K CHIP C 470PF KC516 CC73GCH1H080B CHIP C 8.0PF BC520-522 CK73GB1H471K CHIP C 470PF KC523 CC73GCH1H050B CHIP C 5.0PF BC527 CK73GB1H221K CHIP C 220PF K

C531 C92-0543-05 CHIP-TAN 3.3UF 10WVC532 CK73GB1H471K CHIP C 470PF KC534 CK73FB1H471K CHIP C 470PF KC537 C92-0719-05 ELECTRO 47UF 25WVC538 CK73GB1C104K CHIP C 0.10UF K

C539,540 CK73GB1H471K CHIP C 470PF KC559 CK73GB1H103K CHIP C 0.010UF KC560 CK73GB1H471K CHIP C 470PF KC571 CK73GB1H471K CHIP C 470PF KC572,573 CK73GB1H103K CHIP C 0.010UF K

C601 CC73GCH1H100C CHIP C 10PF CC602 C93-0603-05 CHIP C 1000PF KC603 CC73GCH1H0R5B CHIP C 0.5PF BC604 CC73GCH1H020B CHIP C 2.0PF BC605 C93-0555-05 CHIP C 5.0PF C

C606 C93-0554-05 CHIP C 4.0PF CC607 CC73GCH1H0R5B CHIP C 0.5PF BC608 CC73GCH1H020B CHIP C 2.0PF BC609 C93-0550-05 CHIP C 1.0PF CC610 C93-0560-05 CHIP C 10PF D

C611 C93-0555-05 CHIP C 5.0PF CC612 C93-0551-05 CHIP C 1.5PF CC613,614 CK73GB1H471K CHIP C 470PF KTC352 C05-0400-05 TRIMMER CAPACITOR (3PF)TC353 C05-0399-05 TRIMMER CAPACITOR (6PF)

TC401,402 C05-0245-05 TRIMMER CAPACITOR (10PF)

J1 E11-0425-05 3.5D PHONE JACK (3P)- E23-1278-05 TERMINAL- E41-0927-05 PIN ASSYCN1 E40-6268-05 FLAT CABLE CONNECTORCN2 E40-5702-05 PIN ASSY

CN3 E40-6292-05 PIN ASSY

- F20-3370-04 INSULATING SHEET

CF301 L72-0993-05 CERAMIC FILTERCF302 L72-0959-05 CERAMIC FILTERL101 L92-0443-05 CHIP FERRITEL201 L92-0443-05 CHIP FERRITEL301 L34-4554-05 COIL

L302 L41-3385-08 SMALL FIXED INDUCTOR (330NH)L303,304 L40-3381-86 SMALL FIXED INDUCTOR (0.33UH)L351,352 L41-4785-39 SMALL FIXED INDUCTOR (0.47UH)L354 L34-4645-05 AIR-CORE COILL355 L34-4606-05 AIR-CORE COIL

L356 L40-2775-92 SMALL FIXED INDUCTOR (27NH)L357 L40-3975-92 SMALL FIXED INDUCTOR (39NH)L358 L34-4645-05 AIR-CORE COILL359 L34-4606-05 AIR-CORE COILL360 L34-4605-05 AIR-CORE COIL

L361 L34-4604-05 AIR-CORE COILL403 L41-1005-08 SMALL FIXED INDUCTOR (10UH)L404 L92-0442-05 CHIP FERRITEL405 L92-0443-05 CHIP FERRITEL406,407 L40-2785-92 SMALL FIXED INDUCTOR (270NH)

L408 L40-8278-67 SMALL FIXED INDUCTOR (82NH)L409 L40-2285-92 SMALL FIXED INDUCTOR (220NH)L410-412 L40-2785-92 SMALL FIXED INDUCTOR (270NH)L413 L40-5678-67 SMALL FIXED INDUCTOR (56NH)L414,415 L40-2785-92 SMALL FIXED INDUCTOR (270NH)

TX-RX UNIT (X57-6923-03)

TK-8100

38

PARTS LIST /



nationNewparts

L416,417 L92-0443-05 CHIP FERRITEL418 L41-2775-06 SMALL FIXED INDUCTOR (27NH)L420 L41-2775-06 SMALL FIXED INDUCTOR (27NH)L421 L40-1875-92 SMALL FIXED INDUCTOR (18NH)L501 L41-2775-06 SMALL FIXED INDUCTOR (27NH)

L502 L41-1875-08 SMALL FIXED INDUCTOR (18NH)L504 L41-2275-08 SMALL FIXED INDUCTOR (22NH)L505 L92-0179-05 CHIP FERRITEL509 L34-4667-05 AIR-CORE COILL601 L34-4669-05 AIR-CORE COIL

L602,603 L34-1039-05 AIR-CORE COILL604 L34-4667-05 AIR-CORE COILX86 L77-1934-05 CRYSTAL RESONATOR (14.31818MHZ)X401 L77-1868-15 TCXO (16.8MHZ)XF351 L71-0591-05 MCF (49.95MHZ)

R1 RK73GB2A101J CHIP R 100 J 1/10WR2 RK73GB2A000J CHIP R 0.0 J 1/10WR3 RK73GB2A102J CHIP R 1.0K J 1/10WR4 RK73GB2A332J CHIP R 3.3K J 1/10WR5 RK73GB2A223J CHIP R 22K J 1/10W

R31 RK73GB2A472J CHIP R 4.7K J 1/10WR32 RK73RB2H221J CHIP R 220 J 1/2WR33 RK73GB2A473J CHIP R 47K J 1/10WR34 RK73GB2A472J CHIP R 4.7K J 1/10WR35 RK73GB2A473J CHIP R 47K J 1/10W

R36 RK73GB2A152J CHIP R 1.5K J 1/10WR37 RK73GB2A103J CHIP R 10K J 1/10WR38 RK73GB2A334J CHIP R 330K J 1/10WR39 RK73GB2A474J CHIP R 470K J 1/10WR40 RK73GB2A394J CHIP R 390K J 1/10W

R41 RK73GB2A334J CHIP R 330K J 1/10WR61 RK73GB2A471J CHIP R 470 J 1/10WR62 RK73GB2A102J CHIP R 1.0K J 1/10WR66,67 RK73GB2A473J CHIP R 47K J 1/10WR68,69 RK73GB2A102J CHIP R 1.0K J 1/10W

R70 RK73GB2A473J CHIP R 47K J 1/10WR71 RK73GB2A472J CHIP R 4.7K J 1/10WR72 RK73GB2A105J CHIP R 1.0M J 1/10WR73 RK73GB2A104J CHIP R 100K J 1/10WR74 RK73GB2A473J CHIP R 47K J 1/10W

R75 RK73GB2A102J CHIP R 1.0K J 1/10WR76 RK73GH2A183D CHIP R 18K D 1/10WR77 RK73GH2A134D CHIP R 130K D 1/10WR78 RK73GB2A102J CHIP R 1.0K J 1/10WR81 RK73GB2A473J CHIP R 47K J 1/10W

R82 RK73GB2A000J CHIP R 0.0 J 1/10WR86 RK73GB2A000J CHIP R 0.0 J 1/10WR87 RK73GB2A102J CHIP R 1.0K J 1/10WR91,92 RK73GB2A102J CHIP R 1.0K J 1/10WR93 RK73GB2A123J CHIP R 12K J 1/10W

R94 RK73GB2A103J CHIP R 10K J 1/10WR101,102 RK73GB2A473J CHIP R 47K J 1/10WR103-106 RK73GB2A102J CHIP R 1.0K J 1/10WR107,108 RK73GB2A473J CHIP R 47K J 1/10WR109 RK73GB2A152J CHIP R 1.5K J 1/10W

R110 RK73GB2A473J CHIP R 47K J 1/10WR111 RK73GB2A102J CHIP R 1.0K J 1/10WR112,113 RK73GB2A473J CHIP R 47K J 1/10WR114-119 RK73GB2A102J CHIP R 1.0K J 1/10WR120 RK73GB2A000J CHIP R 0.0 J 1/10W

R122,123 RK73GB2A000J CHIP R 0.0 J 1/10WR124 RK73GB2A473J CHIP R 47K J 1/10WR125-128 RK73GB2A102J CHIP R 1.0K J 1/10WR129 RK73GB2A000J CHIP R 0.0 J 1/10WR130,131 RK73GB2A102J CHIP R 1.0K J 1/10W

R151 RK73GB2A103J CHIP R 10K J 1/10WR152 RK73GB2A472J CHIP R 4.7K J 1/10WR161 RK73GB2A122J CHIP R 1.2K J 1/10WR162 RK73GB2A152J CHIP R 1.5K J 1/10WR163 RK73GB2A473J CHIP R 47K J 1/10W

R164-166 RK73GB2A102J CHIP R 1.0K J 1/10WR201 RK73GB2A681J CHIP R 680 J 1/10WR202 RK73FB2B000J CHIP R 0.0 J 1/8WR203 RK73GB2A104J CHIP R 100K J 1/10WR204 RK73GB2A183J CHIP R 18K J 1/10W

R205 RK73GB2A821J CHIP R 820 J 1/10WR206 RK73GB2A101J CHIP R 100 J 1/10WR207 RK73GB2A754J CHIP R 750K J 1/10WR208 RK73GB2A152J CHIP R 1.5K J 1/10WR209 RK73GB2A244J CHIP R 240K J 1/10W

R211,212 RK73GB2A823J CHIP R 82K J 1/10WR213 RK73GB2A334J CHIP R 330K J 1/10WR214,215 RK73GB2A683J CHIP R 68K J 1/10WR216 RK73GB2A274J CHIP R 270K J 1/10WR217 RK73GB2A224J CHIP R 220K J 1/10W

R218 RK73GB2A823J CHIP R 82K J 1/10WR219 RK73GB2A563J CHIP R 56K J 1/10WR220,221 RK73GH2A153D CHIP R 15K D 1/10WR222 RK73GB2A102J CHIP R 1.0K J 1/10WR223 RK73GB2A472J CHIP R 4.7K J 1/10W

R224 RK73GB2A102J CHIP R 1.0K J 1/10WR225 RK73GB2A154J CHIP R 150K J 1/10WR226 RK73GB2A104J CHIP R 100K J 1/10WR227 RK73GB2A223J CHIP R 22K J 1/10WR228 RK73GB2A103J CHIP R 10K J 1/10W

R229 RK73GB2A684J CHIP R 680K J 1/10WR230 RK73GB2A124J CHIP R 120K J 1/10WR231 RK73GB2A683J CHIP R 68K J 1/10WR232 RK73GB2A912J CHIP R 9.1K J 1/10WR233 RK73GB2A682J CHIP R 6.8K J 1/10W

R249-251 RK73GB2A473J CHIP R 47K J 1/10WR252 RK73GB2A474J CHIP R 470K J 1/10WR253 RK73GB2A000J CHIP R 0.0 J 1/10WR254 RK73GB2A681J CHIP R 680 J 1/10WR255,256 RK73GB2A562J CHIP R 5.6K J 1/10W

R257 RK73GB2A105J CHIP R 1.0M J 1/10WR258 RK73GB2A272J CHIP R 2.7K J 1/10WR259 RK73GB2A123J CHIP R 12K J 1/10WR260 RK73GB2A224J CHIP R 220K J 1/10WR261 RK73GB2A124J CHIP R 120K J 1/10W

R262 RK73GB2A183J CHIP R 18K J 1/10WR263 RK73GH2A913D CHIP R 91K D 1/10WR264 RK73GH2A124D CHIP R 120K D 1/10WR265 RK73GH2A562D CHIP R 5.6K D 1/10WR266 RK73GB2A562J CHIP R 5.6K J 1/10W

R267 RK73FB2B000J CHIP R 0.0 J 1/8WR268 RK73GB2A102J CHIP R 1.0K J 1/10WR269 RK73GB2A823J CHIP R 82K J 1/10WR270 RK73GB2A272J CHIP R 2.7K J 1/10WR271 RK73GB2A561J CHIP R 560 J 1/10W

TX-RX UNIT (X57-6923-03)

TK-8100

39

PARTS LIST /



nationNewparts

R272 RK73GB2A152J CHIP R 1.5K J 1/10WR273 RK73GB2A472J CHIP R 4.7K J 1/10WR274,275 RK73GB2A153J CHIP R 15K J 1/10WR276 RK73GB2A473J CHIP R 47K J 1/10WR277 RK73GB2A683J CHIP R 68K J 1/10W

R278 RK73GB2A123J CHIP R 12K J 1/10WR279 RK73GB2A472J CHIP R 4.7K J 1/10WR280 RK73GB2A391J CHIP R 390 J 1/10WR281 RK73FB2B000J CHIP R 0.0 J 1/8WR301,302 RK73GB2A472J CHIP R 4.7K J 1/10W

R303 RK73GB2A223J CHIP R 22K J 1/10WR304 RK73GB2A472J CHIP R 4.7K J 1/10WR305 RK73GB2A182J CHIP R 1.8K J 1/10WR306 RK73GB2A274J CHIP R 270K J 1/10WR308 RK73GB2A334J CHIP R 330K J 1/10W

R309 RK73GB2A332J CHIP R 3.3K J 1/10WR310 RK73GB2A102J CHIP R 1.0K J 1/10WR311 RK73GB2A333J CHIP R 33K J 1/10WR312 RK73GB2A473J CHIP R 47K J 1/10WR313 RK73GB2A104J CHIP R 100K J 1/10W

R314 RK73GB2A222J CHIP R 2.2K J 1/10WR315 RK73GB2A183J CHIP R 18K J 1/10WR316 RK73GB2A223J CHIP R 22K J 1/10WR317-320 RK73GB2A103J CHIP R 10K J 1/10WR321 RK73GB2A223J CHIP R 22K J 1/10W

R322 RK73GB2A101J CHIP R 100 J 1/10WR323 RK73GB2A104J CHIP R 100K J 1/10WR324 RK73GB2A000J CHIP R 0.0 J 1/10WR325 RK73GB2A333J CHIP R 33K J 1/10WR351 RK73GB2A471J CHIP R 470 J 1/10W

R352 RK73GB2A101J CHIP R 100 J 1/10WR353 RK73GB2A104J CHIP R 100K J 1/10WR354 RK73GB2A561J CHIP R 560 J 1/10WR355 RK73GB2A681J CHIP R 680 J 1/10WR358 RK73GB2A470J CHIP R 47 J 1/10W

R359 RK73GB2A334J CHIP R 330K J 1/10WR360 RK73GB2A474J CHIP R 470K J 1/10WR361 RK73GB2A220J CHIP R 22 J 1/10WR362 RK73GB2A474J CHIP R 470K J 1/10WR363 RK73GB2A154J CHIP R 150K J 1/10W

R364 RK73GB2A000J CHIP R 0.0 J 1/10WR365,366 RK73GB2A104J CHIP R 100K J 1/10WR367 RK73GB2A101J CHIP R 100 J 1/10WR369 RK73GB2A151J CHIP R 150 J 1/10WR370 RK73GB2A474J CHIP R 470K J 1/10W

R371 RK73GB2A394J CHIP R 390K J 1/10WR372 RK73GB2A684J CHIP R 680K J 1/10WR373 RK73GB2A184J CHIP R 180K J 1/10WR374 RK73GB2A104J CHIP R 100K J 1/10WR375 RK73GB2A000J CHIP R 0.0 J 1/10W

R376 RK73GB2A104J CHIP R 100K J 1/10WR377 RK73GB2A000J CHIP R 0.0 J 1/10WR378 RK73GB2A104J CHIP R 100K J 1/10WR380 RK73GB2A104J CHIP R 100K J 1/10WR381 RK73GB2A100J CHIP R 10 J 1/10W

R401-403 RK73GB2A102J CHIP R 1.0K J 1/10WR404 RK73GB2A103J CHIP R 10K J 1/10WR405 RK73GB2A000J CHIP R 0.0 J 1/10WR407 RK73GB2A152J CHIP R 1.5K J 1/10WR408 RK73GB2A100J CHIP R 10 J 1/10W

R409 RK73GB2A104J CHIP R 100K J 1/10WR410,411 RK73GB2A103J CHIP R 10K J 1/10WR412 RK73GB2A123J CHIP R 12K J 1/10WR413 RK73GB2A103J CHIP R 10K J 1/10WR414,415 RK73GB2A000J CHIP R 0.0 J 1/10W

R416 RK73GB2A471J CHIP R 470 J 1/10WR417 RK73GB2A224J CHIP R 220K J 1/10WR418,419 RK73GB2A102J CHIP R 1.0K J 1/10WR420 RK73GB2A222J CHIP R 2.2K J 1/10WR421 RK73GB2A152J CHIP R 1.5K J 1/10W

R422 RK73GB2A103J CHIP R 10K J 1/10WR423 RK73GB2A471J CHIP R 470 J 1/10WR424 RK73GB2A331J CHIP R 330 J 1/10WR425,426 RK73GB2A473J CHIP R 47K J 1/10WR427 RK73GB2A104J CHIP R 100K J 1/10W

R428 RK73GB2A473J CHIP R 47K J 1/10WR429,430 RK73GB2A101J CHIP R 100 J 1/10WR431 RK73GB2A104J CHIP R 100K J 1/10WR432 RK73GB2A102J CHIP R 1.0K J 1/10WR433 RK73GB2A472J CHIP R 4.7K J 1/10W

R434 RK73GB2A000J CHIP R 0.0 J 1/10WR435 RK73GB2A101J CHIP R 100 J 1/10WR436 RK73GB2A124J CHIP R 120K J 1/10WR439 RK73GB2A124J CHIP R 120K J 1/10WR440 RK73GB2A101J CHIP R 100 J 1/10W

R441 RK73GB2A102J CHIP R 1.0K J 1/10WR442 RK73GB2A101J CHIP R 100 J 1/10WR443 RK73GB2A222J CHIP R 2.2K J 1/10WR444 RK73GB2A102J CHIP R 1.0K J 1/10WR445 RK73GB2A000J CHIP R 0.0 J 1/10W

R501 RK73GB2A102J CHIP R 1.0K J 1/10WR502 RK73FB2B100J CHIP R 10 J 1/8WR506 RK73GB2A563J CHIP R 56K J 1/10WR507 RK73GB2A181J CHIP R 180 J 1/10WR509 RK73GB2A101J CHIP R 100 J 1/10W

R511 RK73GB2A471J CHIP R 470 J 1/10WR512 RK73GB2A000J CHIP R 0.0 J 1/10WR513 RK73GB2A221J CHIP R 220 J 1/10WR514 RK73GB2A681J CHIP R 680 J 1/10WR515 RK73GB2A100J CHIP R 10 J 1/10W

R516 RK73GB2A332J CHIP R 3.3K J 1/10WR517 RK73GB2A100J CHIP R 10 J 1/10WR519 RK73FB2B331J CHIP R 330 J 1/8WR520 RK73GB2A152J CHIP R 1.5K J 1/10WR521 RK73GB2A101J CHIP R 100 J 1/10W

R522 RK73RB2H220J CHIP R 22 J 1/2WR523 RK73FB2B332J CHIP R 3.3K J 1/8WR524 RK73FB2B181J CHIP R 180 J 1/8WR525 RK73FB2B330J CHIP R 33 J 1/8WR526 RK73FB2B181J CHIP R 180 J 1/8W

R527 RK73GB2A334J CHIP R 330K J 1/10WR528,529 RK73GB2A103J CHIP R 10K J 1/10WR530 RK73GB2A562J CHIP R 5.6K J 1/10WR531 RK73GB2A473J CHIP R 47K J 1/10WR532,533 RK73GB2A000J CHIP R 0.0 J 1/10W

R534 RK73GB2A822J CHIP R 8.2K J 1/10WR535 RK73GB2A102J CHIP R 1.0K J 1/10WR536 RK73EB2E470J CHIP R 47 J 1/4WR537 RK73GB2A152J CHIP R 1.5K J 1/10WR538 RK73EB2E000J CHIP R 0.0 J 1/4W

TX-RX UNIT (X57-6923-03)

TK-8100

40

PARTS LIST /



nationNewparts

R539 RK73RB2H101J CHIP R 100 J 1/2WR601,602 RK73GB2A103J CHIP R 10K J 1/10WR603 RK73GB2A473J CHIP R 47K J 1/10WR605 RK73GB2A473J CHIP R 47K J 1/10WR606 RK73GB2A102J CHIP R 1.0K J 1/10W

R800 R92-1061-05 JUMPER REST 0 OHM

D1-11 DA221 DIODED31 ZSH5MA27 SURGE ABSORBERD32 1812L110PR VARISTORD61 02DZ18F-X,Y ZENER DIODED201 DAN222 DIODE

D202 1SS372 DIODED251 MA742 DIODED301 MA742 DIODED302,303 DAN222 DIODED351-355 HVC376B VARIABLE CAPACITANCE DIODE

D401 MA2S111 DIODED402 HZU5ALL DIODED403-406 MA2S304 VARIABLE CAPACITANCE DIODED407 MA360 VARIABLE CAPACITANCE DIODED408 MA2S111 DIODE

D409 DAN235E DIODED502 DA221 DIODED503 02DZ5.1F-Y ZENER DIODED602 MA4PH633 DIODED604,605 XB15A709 DIODE

D606,607 MA742 DIODED608,609 1SS355 DIODEIC31 KIA7808AF ANALOGUE ICIC32,33 NJM78L05UA BI-POLAR ICIC34,35 PST9140NR MOS-IC

IC66 AT24C64A10SI18 ROM ICIC101 30622MAA-B96GU MICROCONTROLLER ICIC161 M62363FP MOS-ICIC201 NJM2100V MOS-ICIC202 NJM2904V MOS-IC

IC203 NJM2902V MOS-ICIC251 NJM2902V MOS-ICIC252 2B LA4600 BI-POLAR IC (TX/RX IC252)IC301 TK14489V BI-POLAR ICIC401 MB15A02 MOS-IC

IC501 TA75W01FUF MOS-ICIC502 2B RA30H3340M POWER MODULE (TX/RX IC502)Q1 2SK1824 FETQ31 2B KTA1046(Y) TRANSISTORQ32 2SK1824 FET

Q33 2SA1745(6,7) TRANSISTORQ34 KRC102S DIGITAL TRANSISTORQ35 KTA1664(Y) TRANSISTORQ36 KRC102S DIGITAL TRANSISTORQ61 KRC404RTK DIGITAL TRANSISTOR

Q71 KRC414RTK DIGITAL TRANSISTORQ86,87 2SK1824 FETQ201 2SC4919 TRANSISTORQ202 2SJ243 FETQ251 2SC4617(S) TRANSISTOR

Q252,253 2SK1824 FETQ254 DTC363EU DIGITAL TRANSISTORQ255 KRC102S DIGITAL TRANSISTOR

Q301 2SC2412K TRANSISTORQ302 2SC4649(N,P) TRANSISTORQ351 2SC5108(Y)F TRANSISTORQ352,353 3SK255 FETQ402 2SA1832(GR)F TRANSISTOR

Q403 2SC4738(GR)F TRANSISTORQ404 2SC4649(N,P) TRANSISTORQ405,406 2SK508NV(K52) FETQ407 2SJ243 FETQ408 KRX102U TRANSISTOR

Q410,411 2SC5108(Y)F TRANSISTORQ440 2SC4617(S) TRANSISTORQ500 2SC5108(Y)F TRANSISTORQ501,502 2SC3357-A TRANSISTORTH97,98 B57331V2104J THERMISTOR

TH301 B57331V2104J THERMISTORTH351 NCP18XW332J03 THERMISTOR

TX-RX UNIT (X57-6923-03)

If a part reference number is listed in a shaded box (for example, Q31), that part does not come with the PCB.

TK-8100

41

A B

1

2

3

C

C

C

C

C

A

A

AA

BB

B

BB

BB

TX-RX unit

BB

Part namelabel face down

Display unit

A M3 x 8 : N67-3008-46B M2.6 x 6 (Br-Tap) : N87-2606-46C M2.6 x 14 (Br-Tap) : N87-2614-46

1

34

21

22

26

IC502

20

13

36

25

10

2

30

15

48

14

52

353

6

115

Q31

IC252

701S/No. label

703

702Model name plate

Note:

If a part reference number is listed in a box on

the exploded view of the PCB (for example, Q31),

that part does not come with the PCB.

These parts must be ordered separately.

Parts with the exploded numbers larger than 700 are not supplied.

EXPLODED VIEW / !"

TK-8100

42 Parts with the exploded numbers larger than 700 are not supplied.

PACKING / C D

1

2

3

Screw set(N99-0395-05)

Protection bag(H25-0103-04)

DC cord(E30-3339-05)

Fuse(F51-0017-15) x 2

23 Fuse (6x30, 10A) (F51-0016-15) x 2

7 Instruction manual (B62-1879-00)

40 Polystyrene foamed fixture (H10-6639-03)

39 Polystyrene foamed fixture (H10-6636-13)

704 Protection bag

43 Item carton case (H52-1700-12)

KMB-19 (Option installation kit)

Bracket(J29-0662-03)

Packing case(H52-1710-02)

TK-8100

43

Test Equipment Required for Alignment

Test Equipment Major Specifications

1. Standard Signal Generator Frequency Range 350 to 390MHz(SSG) Modulation Frequency modulation and external modulation

Output –127dBm/0.1µV to greater than –7dBm/100mV2. Power Meter Input Impedance 50Ω

Operation Frequency 350 to 390MHz or moreMeasurement Capability Vicinity of 100W

3. Deviation Meter Frequency Range 350 to 390MHz4. Digital Volt Meter Measuring Range 1 to 20V DC

(DVM) Accuracy High input impedance for minimum circuit loading5. Oscilloscope DC through 30MHz6. High Sensitivity Frequency Range 10Hz to 1000MHz

Frequency Counter Frequency Stability 0.2ppm or less7. Ammeter 20A8. AF Volt Meter Frequency Range 50Hz to 10kHz

(AF VTVM) Voltage Range 1mV to 3V9. Audio Generator (AG) Frequency Range 20Hz to 20kHz or more

Output 0 to 1V10. Distortion Meter Capability 3% or less at 1kHz

Input Level 50mV to 10Vrms11. 4Ω Dummy Load Approx. 4Ω, 10W or more12. Regulated Power Supply 13.6V, approx. 20A (adjustable from 9 to 17V)

Useful if ammeter equipped13. Spectrum Analyzer Center frequency 50kHz to 600MHz14. Tracking Generator Output Voltage 100mV or more

Tuning cable (E30-3383-05)Adapter cable (E30-3383-05) is required for in-jecting an audio if PC tuning is used.See “PC Mode” section for the connection.

MIC connector

(Front view)

Test cable for microphone input (E30-3360-08)

1 : BLC2 : PSB3 : E4 : PTT5 : ME6 : MIC7 : HOOK8 : CM

ADJUSTMENT

Lead wire +

MICShield wire –

3

2

4

5

6

7

8

3

1

2

4

5

6

7

8

1GREEN

RED

BLACK

BLUE

SHIELD

WHITE

GRAY

YELLOW

PTT

E

MIC-E

MIC

HK

18

Test Frequency (MHz)

Channel TX RX

1 : Center 370.100 370.050

2 : Low 350.100 350.050

3 : High 389.900 389.950

4 370.000 370.000

5 370.200 370.200

6 370.400 370.400

TK-8100

44

1 : BLC2 : PSB3 : E4 : PTT5 : ME6 : MIC7 : HOOK8 : CM

!=EbPMJPPUPJMRF

!"#$%&'()*+=EbPMJPPUPJMRF !"#$%&'

= !"#$= !"#$%&'

!"=EF

!"#$%&'()=EbPMJPPSMJMUF

麦克风屏蔽线

引线 +–

18

3

2

4

5

6

7

8

3

1

2

4

5

6

7

8

1GREEN

RED

BLACK

BLUE

SHIELD

WHITE

GRAY

YELLOW

PTT

E

MIC-E

MIC

HK

!"#$ %&'(

NK !"#$=EppdF ! PRMPVMjeò !"#

JNOTÇ_ãLMKNµs !TÇ_ãLNMMãsOK ! RMΩ

! PRMPVMjeò ! NMMt

PK ! PRMPVMjeòQK !"=EasjF ! NsOMs

! !"#$%&'()*

RK PMjeòSK !"#$%& ! NMeòNMMMjeò

!" MKOééã TK OM^UK !"=E^c=sqsjF ! RMeòNMâeò

! NãsPsVK !"=E^dF ! OMeòOMâeò

MNsNMK !" ! NâeòP !

! RMãsNMsêãëNNK QΩ QΩNMt NOK ! NPKSs OM^=E~Çàìëí~ÄäÉ=Ñêçã=V=íç=NTsF

!"#$

NPK !" ! RMâeòSMMjeòNQK !" ! NMMãs

!=EjeòF

N=W= PTMKNMM PTMKMRMO=W= PRMKNMM PRMKMRMP=W= PUVKVMM PUVKVRMQ PTMKMMM PTMKMMMR PTMKOMM PTMKOMMS PTMKQMM PTMKQMM

TK-8100

45

Adjustment Location / ! Switch /

Adjustment Points /

Notes

• EEPROMThe tuning data (Deviation, Squelch, etc.) for the EEP-

ROM, is stored in memory. When parts are changed, re-adjust the transceiver.

• Speaker CableThe speaker cable should be formed before mounting the

shield cover as below.

Locator

Speakercable

This side up / 该面向上 This side up / 该面向上

Cable terminal / 电缆终端

Cable terminal / 电缆终端

Fuse / 熔丝

Pin 1 marker


IC25

2

Part name label face down / 部件名称标签向下

PowerVolumeup/down

DisplayChannelup/down Speaker

MIC jack MON/SCN/ / keys

电源

音量高/低信道上/下

显示

扬声器

话筒插座


8T

RESET

CNVSS

5M

+BE

TEMP2

POWERRXD

TXDCV

BPFIGN

AFV

TEMP1

R800ANT

TC401

TC402L301

TC352TC353

BPF

+B E

TX-RX unitFoil side

ADJUSTMENT /

bbmolj

bbmolj !"=E !"##F= ! "#$ !"#$%&'()*+,-.

!"#=Ef`OROF

f`ORO !"

!"# !"#$%&'()*+,-./01

!"#$%&'()*+,-./0

• AF PA IC (IC252)How to mounting the IC252.

• FuseTo mount the fuse, the cable terminal direction must be as

follows.

TK-8100

46

Atten 0 dBRef –30 dBmPeakLog10dB/

V1 V2V3 FC

AA

Center 370.1 MHz#Res BW 30 kHz VBW 30 kHz

Span 140 MHzSweep 388.9 ms (401 pts)

389.9MHz–38.49dBm

370.1MHz–41.15dBm350.1MHz

–45.75dBm

ADJUSTMENT

Receiver Section

1. Sensitivity 1) CH : RX low (Wide/Narrow) SSG ANT Check SINADCH : RX center (Wide/Narrow) Oscilloscope EXT. SP : 12dB or higherCH : RX high (Wide/Narrow) AF V.M

2) SSG output Distortion meter: –118dBm (0.28µV) (Wide): –116dBm (0.35µV) (Narrow)Mod : 1kHzDev : ±3.0kHz (Wide)Dev : ±1.5kHz (Narrow)

2. Squelch 9 1) CH : RX low (Wide) PC key Adjust to open the squelchCH : RX center (Wide/Narrow)CH : RX high (Wide)

2) SSG output: –115dBm (0.4µV) (Wide): –114dBm (0.45µV) (Narrow)Mod : 1kHzDev : ±3.0kHz (Wide)Dev : ±1.5kHz (Narrow)

PCB Section

1. Setting 1) Power supply voltageDC Power supply terminal : 13.6V

2. VCO lock 1) CH : TX high Digital voltmeter CV TC402 5.5V ±0.1Vvoltage 2) CH : RX high TC401 5.5V ±0.1V

3) CH : TX low Check 0.7V or more4) CH : RX low 0.5V or more

3. IF coil 1) CH : RX center (Wide) SSG AFV L301 3.25~3.35V (DC)2) SSG output : –53dBm (501µV) Digital voltmeter

Mod : 1kHzDev : 3kHz

4. RF 1) CH : RX center (Wide) Tracking generator ANT TC352 Adjust the BPF waveformbandpass CH : RX low (Wide) Spectrum analyzer BPF TC353 to Fig. 1filter CH : RX high (Wide)

2) Track generator output : –30dBmConnect the spectrum analyzerto BPF terminal

Item ConditionTest equipment Terminal Parts Method

Specifications/

Remarks

Measurement Adjustment


Specifications/

Remarks


Fig. 1

TK-8100

47

Atten 0 dBRef –30 dBmPeakLog10dB/

V1 V2V3 FC

AA

Center 370.1 MHz#Res BW 30 kHz VBW 30 kHz

Span 140 MHzSweep 388.9 ms (401 pts)

389.9MHz–38.49dBm

370.1MHz–41.15dBm350.1MHz

–45.75dBm

m`_

NK NF !"#$NPKSs

OK ! NF è !"# !" `s q`QMO RKRs MKNs OF è !"# q`QMN RKRs MKNs

PF è !"# MKTs QF è !"# MKRs

PK fc=Åçáä NF !"=EF ppd ^cs iPMN PKORPKPRs=Ea`FOF !"#$%& !"

JRPÇ_ã=ERMNµsF Nâeò Pâeò

QK oc NF è !"#=EF !" q`PRN N_mc

! è !"#=EF !" _mc q`PROè !"#=EF

OF !"#$%JPMÇ_ã !"#$%_mc

L

!

NK NF è !"=ELF ppd pfkâè !"#=ELF !" NOÇ_ è !"=ELF ^c=sKj

OF !"#$%& !"

NNUÇ_ã=EMKOUµsF=EFNNSÇ_ã=EMKPRµsF=EFNâeòPKMâeò=EFNKRâeò=EF

OK ! NF è !"=EF m` !"#$

V è !"#=ELFè !"=EF

OF= !"#$%&NNRÇ_ã=EMKQµsF=EFNNQÇ_ã=EMKQRµsF=EFNâeòPKMâeò=EFNKRâeò=EF

L

N

TK-8100

48

Transmitter Section

1. Frequency 1) CH : TX center Frequency counter ANT PC key Adjust to center frequency Within ±100Hz2) Transmit

2. Maximum 1) CH : TX high Power meter Hex data : 255 28W or morepower 2) Transmitcheck

3. High 1) CH : TX low 25W ±1.0Wpower CH : TX low’

CH : TX centerCH : TX high’CH : TX high

2) Transmit

4. Low 1) CH : TX low 5W ±1.0Wpower CH : TX low’

CH : TX centerCH : TX high’CH : TX high

2) Transmit

5. DQT 1) CH : TX low (Wide) Modulation analyzer Adjust the waveform as belowbalance CH : TX center (Wide/Narrow) or Linear detector

CH : TX high (Wide) (LPF : 3kHz)2) Transmit Oscilloscope

6. MAX 1) CH : TX low (Wide) Modulation analyzer ANT ±4.0kHz (Wide) ±50Hzdeviation CH : TX center (Wide/Narrow) or Linear detector MIC ±2.0kHz (Narrow)

CH : TX high (Wide) (LPF : 15kHz) Adjust to the larger value of2) AG : 1kHz/50mV Oscilloscope + or – deviation.3) Transmit AG

AF V.M7. MIC 1) CH : TX center (Wide/Narrow) Check ±3kHz±0.2kHz

sensitivity 2) AG : 1kHz/5mV (Wide)3) Transmit ±1.5kHz±0.1kHz

(Narrow)

8. DQT 1) CH : TX low (Wide) Modulation analyzer ±0.75kHz (Wide) ±0.05kHzdeviation CH : TX center (Wide/Narrow) or Linear detector ±0.35kHz (Narrow)

CH : TX high (Wide) (LPF : 3kHz)2) Transmit Oscilloscope

9. QT 1) CH : TX low (Wide) ±0.75kHz (Wide) ±0.05kHzdeviation CH : TX center (Wide/Narrow) ±0.35kHz (Narrow)

CH : TX high (Wide)2) Transmit

10. DTMF 1) CH : TX center (Wide/Narrow) ±3.0kHz (Wide) ±0.2kHzdeviation 2) Transmit ±1.5kHz (Narrow)


Specifications/

Remarks


ADJUSTMENT


Specifications/

Remarks


3. Squelch 1 1) CH : RX low (Wide) PC key Adjust to open the squelchCH : RX center (Wide/Narrow)CH : RX high (Wide)

2) SSG output: –120dBm (0.22µV) (Wide): –119dBm (0.25µV) (Narrow)Mod : 1kHzDev : ±3.0kHz (Wide)Dev : ±1.5kHz (Narrow)

TK-8100

49

PK ! NF è !"=EF m` !"#$

N è !"#=ELFè !"=EF

OF !"#$%&NOMÇ_ã=EMKOOµsF=EFNNVÇ_ã=EMKORµsF=EFNâeòPKMâeò=EFNKRâeò=EF

!

NK NF è !"# !" m` !"# NMMeò

OF

OK ! NF è !" eÉñ=Ç~í~=ORR OUt OF

PK NF è !" ORt NKMtè !"#

è !"#

è !"#

è !"

OF

QK NF è !" Rt NKMtè !"#

è !"#

è !"#

è !"

OF

RK anq NF è !"=EF !" !"#è !"#=ELF !"#

è !"=EF EimcPâeòFOF

SK NF è !"=EF !" QKMâeò=EF RMeò è !"#=ELF !"# jf` OKMâeò=EF

è !"=EF EimcNRâeòF !"#$%&'()OF ^dNâeòLRMãs

PF ^d^c=sKj

TK NF è !"#=ELF PâeòMKOâeò OF ^d=W=NâeòLRãs =EF

PF NKRâeòMKNâeò=EF

UK anq NF è !"=EF !" MKTRâeò=EF MKMRâeò è !"#=ELF !"# MKPRâeò=EF

è !"=EF EimcPâeòFOF

VK nq NF è !"=EF MKTRâeò=EF MKMRâeò è !"#=ELF MKPRâeò=EF

è !"=EFOF

NMK=aqjc NF è !"#=ELF PKMâeò=EF MKOâeò OF NKRâeò=EF

L

L

TK-8100

50

TERMINAL FUNCTION

CN2

No. Name I/O Function

1 SB O Battery voltage DC supply

2 NC - -

3 GND O Ground

4 DETO2 O FM detector output

5 FNC1 I/O Programable I/O (programmed by FPU)








Function Port Assignment

KDS-100, KGP-2A/2B

Name I/O

FNC1 - -

FNC2 - -

FNC3 Data Channel I

FNC4 PTT I

FNC5 Carrier Operated Relay O

FNC6 Audio Mute I

FNC7 Mic Mute I

FNC8 TX Relay O

Scrambler

Name I/O

FNC1 - -

FNC2 - -

FNC3 TX Relay O

FNC4 Scrambler O

FNC5 Scrambler Code1 (1) O




Port Function is Low Active. (Exclude : Scrambler Code)

CN3


1 IGN I Ignition sens input

2 DATAI I External transmit signal input

3 DETO O FM detector output

4 TXAFI I TX audio input from scrambler board

5 TXAFO O TX audio output to scrambler board

6 EMGMIC I Emergency MIC input (1kHz/1.2mVrms)

7 RXAFO O RX audio output to scrambler board

8 ALTI I External alert tone signal input

9 RXAFI I RX audio input from scrambler board

10 5C O 5V DC power supply (50mA MAX)

11 8C O 8V DC power supply (50mA MAX)

CN1


1 DI Data

2 CL Clock

3 CE Chip enable

4 5C 5V

5 SB Switched B


7 KMI4 I Key matrix input 4




11 CM MIC data detection


13 HOOK Hook detection/RXD

14 ME MIC ground

15 POWER Power switch

16 MIC I MIC signal input

17 PTT PTT/TXD

18 GND Ground

TK-8100

51

!

`kO

kçK fLl

N p_ l a`

O k` J J

P dka l

Q abqlO l cj !"

R ck`N fLl !fLl=EcmrF

S ckÒ fLl !fLl=EcmrF

T ck`P fLl !fLl=EcmrF

U ck`Q fLl !fLl=EcmrF

V ck`R fLl !fLl=EcmrF

NM ck`S fLl !fLl=EcmrF

NN ck`T fLl !fLl=EcmrF

NO ckÙ fLl !fLl=EcmrF

!"#$

hapJNMMI=hdmJO^LO_

fLl

ck`N J J

ckÒ J J

ck`P ! f

ck`Q mqq f

ck`R !"# l

ck`S f

ck`T !" f

ckÙ qu ! l

fLl

ck`N J J

ckÒ J J

ck`P qu ! l

ck`Q l

ck`R !"N=ENF l

ck`S !"O=EOF l

ck`T !"P=EQF l

ckÙ !"Q=EUF l

!"#$%&'(E !"#$F

`kP

kçK fLl

N fdk f !"#$%&

O a^q^f f !"#$%&'

P abql l cj !"

Q qu^cf f !"#$%qu

R qu^cl l qu !"#$%

S bjdjf` f !jf`=ENâeòLNKOãsêãëF

T ou^cl l ou !"#$%

U îqf f !"#$%&

V ou^cf f !"#$%ou

NM R` l Rs=a`=ERMã^F

NN U` l Us=a`=ERMã^F

`kN

kçK fLl

N af

O ì

P `b !

Q R` Rs

R p_ _

S hjlO l !O

T hjfQ f !Q

U hjlN l !N

V hjfP f !P

NM hjfN f !N

NN `j !"#$

NO hjfO f !O

NP ellh Loua

NQ jb

NR mltbo !

NS jf` f !

NT mqq mqqLqua

NU dka

52

JIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

D3POWER

MON SCN

VOL UP

VOL DN

D5

D19 D20 D21

D23

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

D24 D25

D28

D29 D30

D31

J1

LCD

C22

C23C24

C25

C30

C31

Q10

Q1113

4 5

C6

D

D18

D27

IC2

R11

R21

R22

R23

R24

R25

R26

Q6

Q9B

C

E

R33

R34

R36

R37

R38

R39

R40

CP1

C15 C16

C18

C19

HOOK

CM PTTMIC SB

MBLGNDME

1

121324

25

3637 48

DISPLAY UNIT (X54-3430-20) Component side view (J72-0885-09)

DISPLAY UNIT (X54-3430-20) Foil side view (J72-0885-09)

TK-8100 PC BOARD / PC板

53

J K L M N O P Q R S

1

2

3

4

5

6

7

8

9

10

11

12

13

14

D2

CH UP

CH DN

D4

D21 D22

SE

G6

SE

G5

SE

G4

SE

G3

SE

G2

SE

G1

SE

G0

CO

M3

CO

M2

CO

M1

CO

M0

D25 D26

J72-0885-09

J72-0885-09

DICLCE5CSB

KMO2KMI4

KMO1KMI3KMI1

CMKMI2

HOOKME

POWERMICPTT

GND

C27

C28

C31 C32

C33

C4

D17

L1R10

R24

R4

R5

R6

R7

R8

R9

CN

1

CP1

1

18

DISPLAY UNIT (X54-3430-20) Component side view (J72-0885-09)

DISPLAY UNIT (X54-3430-20) Foil side view (J72-0885-09)

Ref. No. Address

D2 3N

D3 3C

D4 7K

D5 7G

D19 3H

D20 3I

D21 3J

D22 3K

Ref. No. Address

D23 4H

D24 4I

D25 4J

D26 4K

D28 3F

D29 4F

D30 4G

D31 3G

Ref. No. Address

IC2 11I

Q6 11C

Q9 11F

Q10 11C

Ref. No. Address

Q11 12E

D17 12J

D18 12D

D27 11B

PC BOARD / PC板 TK-8100

Component side

Foil side

Layer 1Layer 2

Component side

Foil side

Layer 1Layer 2

J K L M N O P Q R SIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

1

2

3

4

5

6

7

8

9

10

11

12

13

14

D2

D3POWER

MON SCN

VOL UP CH UP

CH DNVOL DN

D4D5

D19 D20 D21 D22

D23

SE

G30

SE

G29

SE

G28

SE

G27

SE

G26

SE

G25

SE

G24

SE

G23

SE

G22

SE

G21

SE

G20

SE

G19

SE

G18

SE

G17

SE

G16

SE

G15

SE

G14

SE

G13

SE

G12

SE

G11

SE

G10

SE

G9

SE

G8

SE

G7

SE

G6

SE

G5

SE

G4

SE

G3

SE

G2

SE

G1

SE

G0

CO

M3

CO

M2

CO

M1

CO

M0

D24 D25 D26

D28

D29 D30

D31

J1

LCD

J72-0885-09

J72-0885-09

DICLCE5CSB

KMO2KMI4

KMO1KMI3KMI1

CMKMI2

HOOKME

POWERMICPTT

GND

C22

C23C24

C25

C27

C28C30

C31 C32

C33

Q10

Q1113

4 5

C4

C6

D17

D18

D27

L1

IC2

R10

R11

R21

R22

R23

R24

R25

R26

Q6

Q9B

C

E

R33

R34

R36

R37

R38

R4

R39

R5

R6

R7

R8

R9

R40

CN

1

CP1

C15 C16

C18

C19

HOOK

CM PTTMIC SB

MBLGNDME

1

121324

25

3637 48

1

18

DISPLAY UNIT (X54-3430-20) Component side view (J72-0885-09) DISPLAY UNIT (X54-3430-20) Component side view (J72-0885-09)

DISPLAY UNIT (X54-3430-20) Foil side view (J72-0885-09) DISPLAY UNIT (X54-3430-20) Foil side view (J72-0885-09)

Ref. No. Address

D2 3N

D3 3C

D4 7K

D5 7G

D19 3H

D20 3I

D21 3J

D22 3K

Ref. No. Address

D23 4H

D24 4I

D25 4J

D26 4K

D28 3F

D29 4F

D30 4G

D31 3G

Ref. No. Address

IC2 11I

Q6 11C

Q9 11F

Q10 11C

Ref. No. Address

Q11 12E

D17 12J

D18 12D

D27 11B

TK-8100 PC BOARD / PC板 PC BOARD / PC板 TK-8100

Component side

Foil side

Layer 1Layer 2

Component side

Foil side

Layer 1Layer 2

54

JIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

S

C20

R40

1

R40

2

R40

3

C23

C26

C27

C28

C29

R41

0R

411

C32

R412

C33

R41

3

R41

4

C35

R222

C36

R223

C37

R418

C38

R41

9

IC33

R42

0

R421

R422C44

C45

C48

C49

C50

C51

C52

R24

9

C401

C402

C403

C61

R250

C72

C416

C41

7

C77C78

R267

R268

R26

9

C422

C42

3

C424

C425

C82

C83

R270

R271

R272

Q32

R273

R274

R275

Q35

Q36

R27

6

R277

R27

8R

279

R28

0

C25

0

D1

D2

D3

D4

D5

D6

D7

D8

D9

Q61

C26

7

C26

8

C269

D402

C270

C271

C272

C27

3

C274

Q71

C27

5

C276

C27

7C

278

C28

1

D251

R101

R105R106

R10

7

D10

R10

8

D11

R11

2

R11

3

R114 R115

R11

6

R11

7

R118

R119

R12

0

R12

2

R12

4D32

C103

R151

R152

D61

Q1C

522

R31

R32

R1

R35

R2

R36

R3

R37

R5

C15

1

C152

Q20

2

R61

Q40

2

R62

Q403

L201

R71

R72

R73

R74

R75

R76

R77

R78

R81

R82

CN1

CN3

8TQ

252

Q253

Q254

Q25

5

C10

C13

C14C15

R201

R202C16 C17

C18

C19

J1EXT. SP

Q31

B

C

E

IC252

1

10

+

+

O G BCEI

+

1DI CE SB

KMI4

KMI3

CMHO

OK

POW

ER PTT

CL 5C KMO

2KM

O1

KMI1

KMI2

E MIC

E

2 1817

RESET

CNVSS

5M

SGD

CN5E SP

+BE

TEMP2

GD

+POWER

1

12

CN

2

SBNC

EDETO2

FNC1FNC2FNC3FNC4FNC5FNC6FNC7FNC8

RXD

TXD

SG DSG

D

+

+

+

CV

8C 5C RX

AFI

ALT

I

RX

AFO

EMG

MIC

TXA

FO

TXA

FI

DET

O

DAT

AI

11

S GD11

20

1 2


TX-RX UNIT (X57-6923-03)Component side view (J79-0030-09)

Ref. No. Address

IC33 10B

IC161 8O

IC201 8R

IC202 8R

IC203 10R

IC252 8B

IC401 10J

IC501 6R

Ref. No. Address

IC502 4K

Q1 7G

Q31 5B

Q32 5D

Q35 10C

Q36 10C

Q61 6D

Q71 8G

Ref. No. Address

Q201 8Q

Q202 9J

Q252 9G

Q253 10G

Q254 8D

Q255 7D

Q302 11L

Q351 10O

Ref. No. Address

Q402 10I

Q403 10I

D1 10D

D2 10F

D3 10G

D4 8F

D5 8F

D6 9F

Ref. No. Address

D7 9F

D8 9F

D9 10F

D10 10F

D11 10F

D32 4D

D61 6D

D201 8P

Ref. No. Address

D202 7P

D251 7E

D302 10P

D303 9Q

D401 10J

D402 10J

D606 5P

D607 4P

Ref. No. Address

D608 5Q

D609 6S

55

J K L M N O P Q R S

1

2

3

4

5

6

7

8

9

10

11

12

13

14

C20

C21

R40

2

C22

R40

3

R40

4

R405

R21

1R

212

R407

R21

3

R408R

214

R409

R21

5

R21

6

R21

7

R218R219

R60

1

R60

2

R60

3

R605

R412

R606

R22

0

R221

R223

R224

R22

5

R226

R227 R228

R22

9

R23

0

R23

1

R232

R233

C201

C202 C20

3C204

C205 C20

6

C207

C208

C401

C402

C403

C404

C210

C21

1

C406

C212

C21

3

C40

8

C21

4

C409

C21

5

C217

C218

C603

C41

0

C604

C411

C605

X40

1

C41

2

C41

3

C60

7

C220

C414

C60

8C

609

C221

C225

C22

6

C22

7

C61

0

C22

8

C22

9

C611

C612

C61

3

C614

C23

0

C231

C232

C233

C97

C98

C442

D20

1D202

Q302

D40

1

402

L302

L303

L304

D606

D60

7

D608

D60

9

L505

Q351

R302

R30

3

R304

R30

5

R30

6

R311

R31

2 R313

R314

R315

R316

R31

7

R318

R31

9

R51

2

R32

0

R32

1

R322

R323

R32

4

R527

R528

R52

9R

530

R531R532

R53

3C303

C304

C305

TH30

1

R538

R53

9

C310

C311

C312

C31

3 C31

4

R351 C315

R35

2

C316C317

R35

3

R354

C318

R161

R35

5

C31

9

R162

R163

R164

R165

R166

C32

1

C32

2

C323 C324

C527

C538

R380

C539

C351

C35

3

C354

TH35

1

C35

5

C16

1

C162

C356

C163C164

Q201

Q20

2

D30

2

D303

C559

C56

0

L403

L404

C57

1

C57

2

C573

IC50

1

C391TH97

TH98

C14 R202

R203

R204

R205

C19

R206

R20

7 R208

R20

9

J79-0030-09

TXA

FO

TXA

FI

DET

O

DAT

AI

IGN

1

S GD

IC401

1

1011

20

+

+

+

+

+

+

+

+

+

+

+

+

+

+

+

BPF

IGN

AFV

IC16

1

1 121324

TEMP1PC

1 458

IC201

IC202

1

4 5

8

1

4 5

8

IC20

3

178 14

IC502

3 4

Scrambler



Component side

Foil side

Layer 1Layer 2Layer 3Layer 4


1

2

3

4

5

6

7

8

9

10

11

12

13

14

1

2

3

4

5

6

7

8

9

10

11

12

13

14

S

C20

R40

1

C21

R40

2

C22

R40

3

C23

R40

4

R405

R21

1

C26

R21

2

C27

R407

R21

3

C28

R408

R21

4

C29

R409

R21

5

R21

6

R21

7

R218R219

R60

1

R60

2

R60

3

R41

0

R605

R41

1

C32

R412

R606

C33

R41

3

R22

0

R41

4

C35

R221

R222

C36

R223

C37

R224

R418

C38

R41

9

R22

5

R226

IC33

R227 R228

R22

9

R42

0

R421

R422

R23

0

C44

R23

1

C45

R232

R233

C48

C49

C50

C51

C201

C202

C52

C20

3C204

C205 C20

6

C207

C208

R24

9

C401

C402

C403

C404

C210

C61

C21

1

C406

C212

C21

3

R250

C40

8

C21

4

C409

C21

5

C217

C218

C603

C41

0

C604

C411

C605

X40

1

C41

2

C41

3

C60

7

C220

C414

C60

8C

609

C221

C72

C416

C41

7

C225

C22

6

C77

C22

7C78

C61

0

C22

8

C22

9

C611

C612

C61

3

R267

C614

R268

R26

9

C422

C42

3

C23

0

C424

C231

C425

C82

C232

C83

C233

R270

R271

R272

Q32

R273

R274

R275

Q35

Q36

R27

6

R277

R27

8R

279

R28

0

C97

C98

C442

C25

0

D1

D2

D3

D4

D5

D6

D7

D8

D9

D20

1

D202

Q61

Q302

C26

7

C26

8

C269

D40

1D402

C270

C271

C272

C27

3

C274

Q71

C27

5

C276

C27

7C

278

L302

L303

L304

D606

D60

7

D608

D60

9

C28

1

L505

D251

Q351

R101

R105R106

R10

7

D10

R10

8

D11

R302

R30

3

R304

R30

5

R30

6

R11

2

R11

3

R114 R115

R11

6

R11

7

R118

R119

R311

R31

2 R313

R314

R12

0

R315

R12

2

R316

R31

7R12

4

R318

R31

9

R51

2

D32

R32

0

R32

1

R322

R323

R32

4

R527

C103

R528

R52

9R

530

R531R532

R53

3

C303C304

C305

TH30

1

R538

R151

R53

9

R152

C310

C311

D61

C312

C31

3 C31

4

R351 C315

R35

2

C316C317

R35

3

R354

C318

R161

R35

5

C31

9

R162

R163

R164

R165

R166

C32

1

C32

2

C323 C324

Q1C

522

C527

R31

R32

R1

R35

R2

R36

R3

R37

R5

C538

R380

C539

C15

1

C152

C351

C35

3

C354

TH35

1

C35

5

C16

1

C162

C356

C163C164

Q201

Q20

2

D30

2

D303

C559

R61

Q40

2

R62

Q403

C56

0

L201

R71

R72

R73

R74

R75

R76

R77

L403

R78

L404

C57

1

C57

2

C573

R81

R82

IC50

1

CN1

C391

CN3

8T

TH97

TH98

Q25

2

Q253

Q254

Q25

5

C10

C13

C14C15

R201

R202C16

R203

C17

R204

C18

R205

C19

R206

R20

7 R208

R20

9

J79-0030-09

J1EXT. SP

Q31

B

C

E

IC252

1

10

+

+

O G BCEI

+

1DI CE SB

KMI4

KMI3

CMHO

OK

POW

ER PTT

CL 5C KMO

2KM

O1

KMI1

KMI2

E MIC

E

2 1817

RESET

CNVSS

5M

SGD

CN5E SP

+BE

TEMP2

GD

+POWER

1

12

CN

2

SBNC

EDETO2

FNC1FNC2FNC3FNC4FNC5FNC6FNC7FNC8

RXD

TXD

SG DSG

D

+

+

+

CV

8C 5C RX

AFI

ALT

I

RX

AFO

EMG

MIC

TXA

FO

TXA

FI

DET

O

DAT

AI

IGN

111

S GD

IC401

1

1011

20

+

+

+

+

+

+

+

+

+

+

+

+

+

+

+

BPF

IGN

AFV

IC16

1

1 121324

TEMP1PC

1 458

IC201

IC202

1

4 5

8

1

4 5

8

IC20

3

178 14

IC502

1 2 3 4

Scrambler




Component side

Foil side


Ref. No. Address

IC33 10B

IC161 8O

IC201 8R

IC202 8R

IC203 10R

IC252 8B

IC401 10J

IC501 6R

Ref. No. Address

IC502 4K

Q1 7G

Q31 5B

Q32 5D

Q35 10C

Q36 10C

Q61 6D

Q71 8G

Ref. No. Address

Q201 8Q

Q202 9J

Q252 9G

Q253 10G

Q254 8D

Q255 7D

Q302 11L

Q351 10O

Ref. No. Address

Q402 10I

Q403 10I

D1 10D

D2 10F

D3 10G

D4 8F

D5 8F

D6 9F

Ref. No. Address

D7 9F

D8 9F

D9 10F

D10 10F

D11 10F

D32 4D

D61 6D

D201 8P

Ref. No. Address

D202 7P

D251 7E

D302 10P

D303 9Q

D401 10J

D402 10J

D606 5P

D607 4P

Ref. No. Address

D608 5Q

D609 6S

56

JIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

CF3

01

CF302R

415R41

6

R417R

423

R42

5R

430

R43

1

R43

2

R43

3

R800ANT

R434

R435

R43

6

R439R440

R44

1

R44

2

R443

R444

R25

1

R44

5

R252

L421

R253

R25

4

R255R256

C60

2

R25

7

R258

R25

9

C606

R260

C418

R261

R262

R263

R26

4

R26

5R26

6

C42

1

C42

9

C430

C431

C43

2

C251

C252C25

3

C254

C44

8

C44

9

C255C256

C257

C258 C25

9 C450

C451

C454

C260

C45

5

C261

C45

6C26

2

C26

3

C264

Q301

C26

5

C26

6

C461

C46

3

Q500

C464

Q50

1

C46

6C

467

D40

8

D40

9

L301

D60

2

D604

D605

L501

L509

Q35

2

Q353

R30

1

L351

L352L3

54

R30

8

R309

L355

L356

L357L358

L359

R50

1

R310

R50

6

R50

7

L360

L361

R509

CN301

R51

1

CN

302

CN

303

R51

3

CN304

R51

4

R325

CCN503

C30

1

C302

R53

6

C306

R53

7

C307

C308

C309

C501

C502

C50

4

C505C507

C509

R358

C51

0

R359

C51

1

C51

5

C47

2

C46

9R360

XF351

R36

1

R362

C326

R36

3

R36

4

R36

5

R36

6

R367

R36

9

R370

R371

R37

2

R373

R374

R375

R37

6

R37

7

R37

8

C53

4

C537

R38

1

C35

7

C35

8

C359

C36

0

D30

1

C36

1

C36

2

C36

3

C364

C366

C470

C36

7

Q404

C368

Q40

5

C36

9

TC352

Q40

7

TC353

Q408

C370

C371

C37

2

C37

3

Q410

C374

Q411

C37

5 C376

C37

7

C378

C379

C380

L4

C38

1

C382C383

C38

4

L601

C385

L602

C38

6

L603

L604

L410

C38

8

C389

C387

L417

L418

C390

C601

L420

Q44

0

Q25

1

D351D352

D353

D354

D355

J79-0030-09

1

23

4

IC251

1

78

14

+

BPF

1

1011

20

IC301

1 234

+

B C

123

5

GS D

S GD

+


TX-RX UNIT (X57-6923-03)Foil side view (J79-0030-09)

Ref. No. Address

IC31 10R

IC32 11Q

IC34 11N

IC35 10M

IC66 9M

IC101 9O

IC251 10B

IC301 10F

Ref. No. Address

Q33 10Q

Q34 10Q

Q86 8O

Q87 8P

Q251 9B

Q301 11F

Q352 7G

Q353 8B

Ref. No. Address

Q404 10I

Q405 9J

Q406 10K

Q407 9I

Q408 9I

Q410 10J

Q411 9H

Q440 10I

Ref. No. Address

Q500 8I

Q501 7J

Q502 8L

D31 4O

D301 10G

D351 8D

D352 7C

D353 7A

Ref. No. Address

D354 6C

D355 7B

D403 9L

D404 9K

D405 10L

D406 10L

D407 10L

D408 10I

Ref. No. Address

D409 8H

D502 8K

D503 6K

D602 6C

D604 5B

D605 5B

57

J K L M N O P Q R S

1

2

3

4

5

6

7

8

9

10

11

12

13

14

C30

C34

IC31

C39

IC32

IC34

IC35

C40

C41

C42 C43

R42

4R

425

R42

6

R427

R428

R42

9

R43

0

C53

C54R434

R435

C55

R43

6 C56

C66

TC40

1

TC40

2

C426

C42

7

C42

8

C42

9

Q33

C87

C88

Q34

C89

C430

C431

C43

2

C43

3

C90

C43

4C

435

C436

C437

C438

R281

C43

9

C440

C441

C44

4

C452

C454

L101

D40

3

D404

D40

5

Q50

1

Q502

D406

D407

C279

C28

0

C28

2

C283

L502

L504

Q86 Q87

R102R103

R10

4

R10

9

R110

R11

1

R50

2

R123

R125

R126

R127R128

R129

D31

R51

1R

513

R51

4

R51

5

R51

6

R517

R130

R51

9

R131

CN501CN502

R520

R52

1

R52

2

R523

R524

R52

5

C101C102

R526

C104

R53

4

R535

R53

6

9

C51

1

C51

2C51

3

C51

4

C516

C520 C52

1

C523

R33

R34

R4

R38

C531

R39

C53

2

C53

4

R40 R

41

C540

Q40

5

Q406

R66

R67 R68

R69

D502

D50

3

Q410

R70

IC101

L405

L406

L407

L408

L409

L411

R86

L412

R87

L413

L414

L415

L416

L418

R91

R92R93

R94

X86

B C E

GS D

GS

D

B

C

E

+

IC66

1

4 5

8

1 345

1 345

5051

2526

S GD S GD

+B E

+

+

+

+1

100

7576

I

G

O

+

+

I

O

G



Component side

Foil side



1

2

3

4

5

6

7

8

9

10

11

12

13

14

1

2

3

4

5

6

7

8

9

10

11

12

13

14

CF3

01

CF302

C30

C34

R41

5R41

6

R417 IC31

C39

IC32

IC34

IC35

C40

C41

C42 C43

R42

3

R42

4R

425

R42

6

R427

R428

R42

9

R43

0

R43

1

R43

2

C53

R43

3

R800ANT

C54R434

R435

C55

R43

6 C56

R439R440

R44

1

R44

2

R443

R444

R25

1

R44

5

R252

L421

C66R253

R25

4

R255R256

C60

2

R25

7

R258

R25

9

C606

R260

C418

R261TC

401

TC40

2

R262

R263

R26

4

R26

5R26

6

C42

1

C426

C42

7

C42

8

C42

9

Q33

C87

C88

Q34

C89

C430

C431

C43

2

C43

3

C90

C43

4C

435

C436

C437

C438

R281

C43

9

C440

C441

C44

4

C251

C252C25

3

C254

C44

8

C44

9

C255C256

C257

C258 C25

9 C450

C451 C452

C454

C260

C45

5

C261

C45

6C26

2

C26

3

C264

Q301

C26

5

C26

6

L101C461

C46

3

D40

3

D404

Q500

C464

D40

5

Q50

1

Q502

D406

C46

6

D407

C46

7

D40

8

D40

9 C279

L301

D60

2

D604

D605

C28

0

C28

2

C283

L501 L5

02

L504

Q86 Q87

L509

Q35

2

Q353

R102R103

R10

4

R10

9

R30

1

R110

L351

R11

1

L352L3

54

R30

8

R309

L355

L356

L357L358

L359

R50

1

R50

2

R310

R50

6

R50

7

L360

L361

R509

R123

R125

R126

R127R128

CN301

R129

D31

R51

1

CN

302

CN

303

R51

3

CN304

R51

4

R51

5

R51

6

R517

R130

R51

9

R325

R131

CN501CN502CN503

R520

R52

1

R52

2

R523

R524

R52

5

C101C102

R526

C104

C30

1

C302

R53

4

R535

R53

6

C306

R53

7

C307

C308

C309

C501

C502

C50

4

C505C507

C509

R358

C51

0

R359

C51

1

C51

2C51

3

C51

4

C51

5

C47

2

C46

9

C516

R360

XF351

R36

1

R362

C326

R36

3

R36

4

R36

5

R36

6

R367

C520 C52

1R36

9

C523

R370

R371

R37

2

R33

R373

R374

R34

R375

R37

6

R37

7

R4

R37

8

R38

C531

R39

C53

2

C53

4

C537

R40 R

41

R38

1

C540

C35

7

C35

8

C359

C36

0

D30

1

C36

1

C36

2

C36

3

C364

C366

C470

C36

7

Q404

C368

Q40

5

C36

9

Q406

R66

TC352

Q40

7

TC353

R67

Q408

R68

R69

D502

D50

3

C370

C371

C37

2

C37

3

Q410

R70C374

IC101Q411

C37

5 C376

C37

7

C378

C379

L405

L406

L407

C380

L408

L409

C38

1

C382C383

C38

4

L601

C385

L602

C38

6

L603

L604

L410

C38

8

C389

C387

L411

R86

L412

R87

L413

L414

L415

L416

L417

L418

C390

C601

R91

R92R93

L420

R94

Q44

0

Q25

1

X86

D351D352

D353

D354

D355

J79-0030-09

1

23

4

IC251

1

78

14

+

BPF

1

1011

20

IC301

1 234

+

B C E

123

5

GS D

S GD

+

GS

D

B

C

E

+

IC66

1

4 5

8

1 345

1 345

5051

2526

S GD S GD

+B E

+

+

+

+1

100

7576

I

G

O

+

+

I

O

G




Component side

Foil side


Ref. No. Address

IC31 10R

IC32 11Q

IC34 11N

IC35 10M

IC66 9M

IC101 9O

IC251 10B

IC301 10F

Ref. No. Address

Q33 10Q

Q34 10Q

Q86 8O

Q87 8P

Q251 9B

Q301 11F

Q352 7G

Q353 8B

Ref. No. Address

Q404 10I

Q405 9J

Q406 10K

Q407 9I

Q408 9I

Q410 10J

Q411 9H

Q440 10I

Ref. No. Address

Q500 8I

Q501 7J

Q502 8L

D31 4O

D301 10G

D351 8D

D352 7C

D353 7A

Ref. No. Address

D354 6C

D355 7B

D403 9L

D404 9K

D405 10L

D406 10L

D407 10L

D408 10I

Ref. No. Address

D409 8H

D502 8K

D503 6K

D602 6C

D604 5B

D605 5B

TK-8100 SCHEMATIC DIAGRAM /

58

7

6

5

4

3

2

1

A B C D E

X57-692 1/3

FNC4

FNC6

FNC1

FNC2

FNC5

FNC8

FNC3

FNC7

8

R20

3

100k

C21

50.

1u

C20

2

470p

9

R77

130k(D)SB

C78

1000

p

R42

0

2.2k

C23

3

4.7u

6.3

C42

1

470p

C22

1

0.1u

R414

0

C22

7

0.01

u

R40

7

1.5k

C19

470p

5C

R21

6

270k

5C

C40

3

100p

X401

L77-1868-15

VC

GND XOUT

5C

IC202NJM2904V

12345 6 7 8

V+

C21

4

150p

X86

C21

8

10u6

.3

R42

4

330

C77

470p

R22

1

15k

D406MA2S304

R42

7

100k

C23

1

470p

R402 1k

R76

18k(

D)

R205

820

3

R215

68k

L407

270n

R42

2

10k

R16

2

1.5k

R403 1k

2SC4738(GR)FQ403

C17

470p

L412

270n

R22

5

150k

L410

270n

R41

1

10k

D10

DA

221

C20

4

2.2u

10

45

5M

C43

13p

L414

270n

IC161M62363FP

1 2 3 4 5 6 7 8 9

10 11 12131415161718192021222324

R22

6

100k

C430

4pC426

10p

2SK1824Q1

R211

82k

R222 1k

R23

3

6.8k

C432

0.5p

C40

2

100p

R421

1.5k

L201

C40

6

1000

p

C206

1000p

R428

47k

1

C411

0.1u

R43

1

100k

R412

12k

R415

0

C42

4

3.3u

10

R40

5

0

R16

1

1.2k

D201DAN222

R40

810

R165 1k

C90

18p

D8

DA

221

C16

470p

D402

HZU5ALL

R409

100k

C20

8

0.01

u

46

C13

470p

R207

750k

8C

TC

402

10p

C40

9

0.1u

29

C418

1000p

R86

0

C42

2

470p

1 2 3 45678

V+

R208

1.5k

C41

7

470pR401 1k

C44

8

470p

R87 1k

C41

6

470p

R40

4

10k

C40

8

22p

C22

6

4700

p

D404

MA2S304

C21

2

1200

p

R41

3

10k

1

2

3

4

5

6

7 8

9

10

11

12

13

14

2SK508NV(K52)Q405

R21

3

330k

R22

0

15k

R410

10k

C22

9

4.7u

6.3

R164 1k

C42

9

1p

D11

DA

221

C441

0.3p

C42

8

470p

D2021SS372

C14

470p

R23

0

120k

C42

5

0.1u

35

R21

9

56k

R228

10k

R418

1k

R22

9

680k

C44

04.

5p

L41356n

R425

47k

R212

82k

L403

10u

L409

220n

C42

7

4p

C41

4

0.1u

R419

1k

C41

010

u6.3

C43

6

0.5p

C21

1

820p

R20

4

18k

C205

0.1u

R21

8

82k

R23

2

9.1k

R217

220k

L404

D40

7

MA

360

R214

68k

C412

10u6.3

C43

7

470p

R429

100

R41

7

220k

2SK1824Q86

R78

1k

C23

470p

C4345p

D9

DA

221

1O

SC

IN2

NC

13

OS

CO

UT

4V

P5

VC

C6

DO

7G

ND

8LD

9N

C2

10F

IN11121314151617181920

7

SB

D7

DA

221

8C

C89 6p

R430

100

D5

DA

221

2SJ243Q202

R223

4.7k

C203

0.027u

C43

8

2p

C41

3

0.01

u

L408

82n

C40

1

100p

5C

L406

270n

C23

0

0.1u

2SA1832(GR)FQ402

47

C88 6p

R41

6

470

C20

470p

C21

470p

43

R227

22k

C210

0.1u

C20

7

0.02

2u

C44

4

470p

C15

470p

C22

8

10u6

.3

C20

1

0.1u

C22

0

4.7u

6.3

L411

270n

C16

3

470p

L415

270n

D40

1

MA

2S11

1

L416

2SC4919Q201

R42647k

C44

2

10u6

.3

C213

3300p

49

C43

5

5p

C22

5

1u16

R22

4

1k

TC

401

10p

R23

1

68k

C4394p

R20

1

680

30

D6

DA

221

C23

2

470p

C16

1

1000

p

C22

470p

5C

C217

10u6.3

C18

470p

R42

3

470

48

C42

3

0.04

7u35

C87

18p

C43

3

470p

C16

4

10u6

.3

R166 1k

R20

2

0

C16

2

4.7u

6.3

R206

100

8C

5C

L405

R163 47k8C

D4

DA

221

C40

4

15u6

.3

R209

240k

CN2 E40-5702-051

2

3

4

5

6

7

8

9

10

11

12

CN3 E40-6292-051 IGN

2 DATAI

3 DETO

4 TXAFI

5 TXAFO

6 EMGMIC

7 RXAFO

8 ALTI

9 RXAFI

10 5C

11 8C

SPLATTER FILTER

PLL IC

Q402,403

BEATSHIFT

+

8C

PC

/TV

O

RX VCO

BUFFER AMP

AGC

-

-

PC

/TV

I

AF

I

LD

KDC

AF

O

TCXO

PLL SYNTHESIZER

VOTAGEDROPPED

CV

CLK

DCAMP

+

5C

VD

D

8C

MO

DO

DIGITALPOTENTIOMETER

DAT

OR GATE

1/2Vcc

1/2Vcc

D407

TX-RX UNIT (X57-6923-03)

MO

DI

T/R SW

SUM AMP

MOD BUFF

CV

W/N

I(E

VO

L1)

CHARGE PUMP

HPF

TX VCO

MODULATION

1/2V

cc

IDC

AF AMP

MIC AMP

AFO(EVOL11)

+

-

MIC MUTE

ScramblerAFI(EVOL12)

W/N

O

RIPPLEFILTER

TX AF

RX VCO

W/N

O(E

VO

L2)

+

W/N

I

16.8MHz

-

D403,404

RF AMP

PLL

E(C

PU

3)

FR

OO

(EV

OL2

3)

DT

(CP

U53

)

CK

(CP

U54

)

MO

D

CLK

NC

3

DAT

ALEFC

NC

4

FO

UTP

NC

5R

IC401MB15A02

2SC4649(N,P)Q404

2SK508NV(K52)Q406

PLLE(CPU3)

8CL

DT(CPU53)

UL(CPU21)

W/NI(EVOL1)

MIC

MOD

CK(CPU54)

W/NO(EVOL2)

OU

T

RE

SE

T

DT

MI

DO

DT

MO

VD

Fref

GN

D

FR

QI

FR

QO INBLI

BLO

2SK1824Q87

BEATSHIFT

IC203NJM2902V

2SJ243Q407

SURGE ABSORPTION

D4-11

IC201NJM2100VMIC AMP

MO

D

EV

LLD

(CP

U8)

MO

DI(

EV

OL9

)

MO

DO

(EV

OL1

0)

PLL

E(C

PU

3)

DT

MO

(EV

OL1

5)

PC

/TV

O(E

VO

L3)

UL(

CP

U21

)

DT

MI(

EV

OL1

6)

TX

/RX

(C

PU

20)

PC

/TV

V+ GND

D40

3

MA

2S30

4

D40

5

MA

2S30

4

D405,406

TX VCO

MICEM(CPU74)

MICMT1(CPU73)

0.7V

T:1.1V

LOCK:5.0V

2.4V

R:1.0V

R:1.2mV

6.9V

4.9V1.6V

R:6.6V

T:6.4V

T:7.9V

4.8V

4.9V

5.0V

3.42V

8.0V

4.9V

SCHEMATIC DIAGRAM / TK-8100

59

JIHGF

X57-692 2/3

-t

-t

-t

C97

470p

C50

7

470p

C102

0.1u

43

5M

78

5M

R73

100k

R129

0

C46

7

470pR44

2

100

17

D502DA221

C51

5

470p

R118 1k

R52

6

180

C31

7

0.1u

CN

301

C367

470p

D409DAN235E

C51

2

470p

2SK1824Q252

R36

9

150

3SK255Q352

G1

D

S

G2

R432

1k

5M

R74

47k

C523

5p

R112 47k

C35

4

6p

C37

7

470p

C37

2

15p

L101

5M

R31

6

22k

R60

3

47k

D40

8

MA

2S11

1

R10

3

1k

C52

1

470p

R68 1k

C268

0.1u

8R

CN

303

R36

7

100

R1230

B

R35

2

100

TH

98

100k

L417

R268

1k

C502

2p

R25

0

47k

R32

0

10k

C37

3

7pR36

1

22

47

R50

7

180

C46

4

470p

R117 1k

R50

1

1k

C37

5

470p

R11047k

R71

4.7k

R32

1

22k

L357

39n

C72

470p

70

CN

304

C10

4

0.1u

CNVSS

L304

330n

C45

5

2p

C32

4

0.01

u

C51

0

470p

9

Q408KRX102U

R131 1kR

525

33

R43

9

120k

R36

6

100k

TH

97

100k

C371

0.5p

C51

4

470p

R31

810

k

C36

1

470p

D302DAN222

C15

1

1800

p

C50

4

470p

R31

9

10k

CN

502

5M

35

36

C46

3

470p

46

C36

3

0.01

u

R130 1k

5M

R44

32.

2k

C35

6

2p

R751k

C37

0

470p

84

R108

L303

330n

R44

1

1k

C50

5

470p

R1091.5k

R12

20

R53

7

1.5k

99

C351

33p

R124

47k

R106

29

R94

10k

8T

C37

6

470p

R35

9

330k

C269

1u

L418

27n

C37

8

470p

C374

7p

8R

L501

27n

71

L351

470n

C98

470p

C32

3

270p

C31

6

0.1u

D303DAN222

CN

302

69

C66 470p

R353

100k

L356

27n

2SK1824Q253

R51

9

330R

511

470

8R

TH351

3.3k

R125 1k

R36

3

150k

R50

9

100

83

R50

6

56k

R105R

523

3.3k

R107

R93

12k

8

R10

2

47k

R114 1k

R35

8

47

L504

22n

C36

6

0.1u

C25

0

0.1u

30

CN

503

R36

2

470k

R115 1k

R119 1k

R323

100k

R66

47k

C82

470p

C31

8

0.1u

C35

8

470p

R10

4

1k

R444

1k

R44

0

100

C44

9

470p

C454

6p

R50

2

10

8C

R70

47k

R128 1k85

C35

3

0.01

u

R51

7

10

C35

7

0.01

u

R43

4

0

CN

501

C359

12p

C83

0.1u

R445

0

R51

3

220

86

8R

8C

5M

R364

0

R269

82k

C45

2

470p

R52

2

22

R43

5

100

C26

7

0.47

u

C51

3

470p

1

QT

/DQ

T2

DT

MF

/MS

K3

PLL

E4

NC

5N

C6

GN

D7

CN

VS

S8

EV

LLD

9B

SH

IFT

10R

ES

ET

11X

OU

T12

VS

S13

XIN

14V

CC

15G

ND

16N

C17

PO

WE

R18

INT

19N

C20

TX

/RX

21U

L22

NC

23N

C24

NC

25N

C

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51525354555657585960616263646566676869707172737475

768RC

778TC

78CM

79NC

80NC

81NC

82SBC

83KMI1

84KMI2

85KMI3

86KMI4

87PWRPRCT

88SIGNAL

89TEMP2

90TEMP1

91BATT

92RSSI

93SQIN

94AVSS

95NC

96VREF

97AVCC

98NC

99KMO1

100KMO2

48

R116 1k

R37

0

470k

R111 1k

R12

00

R91 1kL3

55

18n

C516

8p

C36

2

470p

R126 1k

R113 47k

C35

5

18p

5M

R6747k

L502

18n

R151

10k

C54

0

470p

R31

710

k

R267

0

R35

1

470

R127 1k

R52

4

180

C101

470p

R72

1M

R82 0

C466

5p

C51

1

470p

C45

1

470p

C36

8

7p

R355

680

R354

560

R152

4.7k

45

R51

5

10

C36

0

8p

R322

100

C46

1

470p

R92 1k

R51

4

680

R51

6

3.3k

49

1

R36

5

100k

R10

1

47k

C52

2

470p

5M

3SK255Q353

G1

D

S

G2R43

3

4.7k

R36

0

470k

C50

1

470p

R270

2.7k

L420

27n

C456

4p

R69 1k

C509

5p

R37

1

390k

8C

R24

9

47k

1A0

2A1

3A2

4GND

5

6

7

8

8T

5C

C103

1000p

R81

47k

L352

470n

8R

C36

4

470p

C15

2

3900

p

100

C46

9

10p

C47

2

10p

C470

5pL421

18n

5M

DTMI(EVOL16)

EVLLD(CPU8)

AFM(CPU50)

RSSI(CPU92)

T/R SW

AF MUTE

TEMPERATURECOMPENSATION

PLLE(CPU3)

SQIN(CPU93)

8CL

RSSI(CPU92)

TV

5M

DRIVE

TP

RXD

IF SWITCH

SB

C(C

PU

82)

RIPPLEFILTER

IGN

(CP

U72

)

RIPPLEFILTER

8TC(CPU77)

AFI(EVOL12)

EEPROM

QT/DQT(CPU1)

RESET(CPU10)

WIDE

IGN(CPU72)

MIXER

INT(CPU18)

8R

SBC(CPU82)

RF AMP

IF SWITCH

8RC(CPU76)

1/2Vcc

NARROW

AF MUTE

UL(CPU21)

DTMI(EVOL16)

RF SWITCH

8R

KEC

RSSI(CPU92)

TX/RX(CPU20)

W/NI(EVOL1)

Scrambler

IGNITION

TXD

2SC5108(Y)FQ410

BUFFER AMP

2SC4617(S)Q440

C45

022

u10

2SC5108(Y)FQ411

RF AMPPRE DRIVE AMP

2SC5108(Y)FQ500

D351,352

RF BPF TUNING

XF351

49.95ML71-0591-05

2SC5108(Y)FQ351

IF AMP

8RC(CPU76)

W/NO(EVOL2)

SMP(CPU51)

AMPSW(CPU52)

PC/TV

AFO(EVOL11)

8TC(CPU77)

MIC

2SC4649(N,P)Q302

BUFFER AMP

CF302L72-0959-05

CF301L72-0993-05

EEPWP

EEPSCK

EEPSDT

FNC1

FNC2

CLKFLS

BSYFLS

TXD

RXD

PTT

HOOK

NC

NC

EMPFLS

NC

NC

NC

FNC3

CEFLS

FNC4

FNC5

FNC7

FNC6

FNC8

AFM

SP

M

AM

PS

WDT

CK

NC

NC

DS

T1

DS

T2

DS

T3

VC

C

NC

VS

S

NC

NA

RR

OW

WID

E

NC

NC

NCCL

CEDI

IGN

MIC

MT

1

MIC

EM

MIC

MT

2

IC10130622MAA-B96GU

CPU

SDA

SCL

WP

VCC

IC66AT24C64A10SI18

D35

1

HV

C37

6B

D35

2

HV

C37

6BL354

14n

C36

9

0.75

p

2SC3357-AQ502PRE DRIVE AMP

2SC3357-AQ501

R52

0

1.5k

C52

0

470p

PC/TVW/NO(EVOL2)

TX/RX(CPU20)

CK(CPU54)

DT(CPU53)

AFO(EVOL11)

MIC

W/NI(EVOL1)

5M

AFI(EVOL12)

MICEM(CPU74)

MICMT1(CPU73)

R43

612

0k

Q71KRC414RTK

SQIN(CPU93)

1/2Vcc

SBC(CPU82)

RESET(CPU10)

INT(CPU18)

WIDE(CPU65)

AMPSW(CPU52)

AFI(EVOL12)

SMP(CPU51)

NARROW(CPU64)

47k

1k

1k

47k

7.0V

T:5.6V

5.0V

T:6.8V T:0.29V

T:1.6V

T:1.10V T:7.3V6.1V

R:7.0V

0.74V

W:4.9VN:0V

R:7.5V

R:5.7V

4.87V

R:1.9V

T:0.97V

R:0.6V

R:7.3V

R:7.9V

7.2V1.51V

T:6.0V

R:3.2V

T:1.8V

R:0V

R:4.6V

4.9V

R:4.9VT:0V

7.7V

W:0VN:4.9V

R:0.9V

0.8V

R:0.76V

R:1.6V

R:3.6V

0.4V

5.0V

TX-RX UNIT (X57-6923-03)

TK-8100 SCHEMATIC DIAGRAM /

60

K L M N O

X57-692 3/3

-t

C60

3

0.5p

C60

5

5p

R31

2

47k

R27

6

47k

7

Q34KRC102S

C26

6

0.1u

C54

0.1u

L358

14n

C319

100p

C386

1p

R26

1

120k

C30

4

220p

C55

0.1u

R41

330k

C60

6

4p

R28

0

390

R27

2

1.5k

TC

352

3P

IC34PST9140NR

1NC

2VEE1

3VEE2

4OUT

5VCC

R25

2

470k

R31

0

1k

C26

5

0.1u

R27

4

15k

R35

47k

R259

12k

R31

1

33k

C27

0

4.7u

6.3

R30

8

330k

R315 18k

D607MA742

R538

0

100

D35

4

HV

C37

6B

C28

2

470u

16

C55

9

0.1u

C38

1

8p

8T

C48

0.01

u

R27

3

4.7k

Q254DTC363EU

C40

0.1u

C30

2

1000

p

C35

470p

C609

1p

R25

7

1M

C45

22u1

0

C311 0.1u

84

78

C56

470p

R52

1

100

5C

D602MA4PH633

R258

2.7k

R277

68k

C27

2

1000

p

R34

4.7k

R26

3

91k

IC35PST9140NR

1NC

2VEE1

3VEE2

4OUT

5VCC

C390

8p

C312 0.1u

C28

R30

3

22k

C30

1

4.7u

6.3

R25

5

5.6k

R37

10k

R26

0

220k

C38

9

0.01

u

2SK1824Q32

R37

3

180k

2

COM

1IN

3OUT

R30

1

4.7k

L604

9.5T

B

SB

C39

1

470p

R377

0

C60

8

2p

C32

C26

2

470p

R36

1.5k

R60

6

1k

8R

R306

270k

R380

100k

BS

B

5C

R38

330k

3

R33

47k

L601

3.5T

POWER

C61

4

470p

C50

0.01

u

C306

1000p

C56

0

470p

2SC4617(S)Q251

C30

7

0.02

2u

C37

470p

L302

330n

C25

9

0.01

u

R53

3

0

C602

1000p

IC252LA4600

12345678910

1

2

3

4V+

5

6

7 8

9

10

11GND

12

13

14

C53

470p

1

2

3

4

5

6

7

8

9

10 11

12

13

14

15

16

17

18

19

20

C251

4.7u6.3

C29

R53

6

47L603

1.5T

C39

0.1u

5C

IC32NJM78L05UA

2

COM

3IN

1OUT

83

R264

120k R62

1k

C27

1

3300

p

C41

22u1

0

TC

353

6P

C42

0.01

u

R53

0

5.6k

R26

2

18k

R265

5.6k

C28

1

470p

R32

4

0

BS

B

R25

4

680

C26

1

0.01

u

R31

4.7k

R52

7

330k

99

R1 100

C60

7

0.5p

C61

470p

D35

3

HV

C37

6B

R512

0

C10

1000

p

C38

470p

C53

7

47u2

5

C30

C27

6

470p

IC33NJM78L05UA

2

COM

3IN

1OUT

C37

9

470p

TH

301

100k

R30

2

4.7k

C27

5

1u

L301L34-4797-05

C36

470p

R27

1

560

C44

22u1

0

R37

2

680k

C32

6

0.01

u

Q61KRC404RTK

C315

0.1u

D60

9

1SS

355

5M

C27

94.

7u16

R53

1

47k

R251

47k

69

5C

C383

0.5p 35

C43

22u1

0

L361 8n

C264

0.033u

R605

47k

R28

1

0

L602

1.5T

C25

4

1u

R275

15k

C612

1.5p

Q255KRC102S

R40

390k

8T

R30

9

3.3k

R53

2

0

86

C38

5

470p

SB

C28

3

1000

p

R279

4.7k

R39

470k

R32

220

C30

3

4700

p

R61

470

C34

330u

25

C27

80.

1u

C61

3

470p

36

C31

0

0.33

u

C61

1

5p

R314 2.2k

C61

0

10p

D251MA742

C30

5

220p

5M

C30

8

1000

p

R278

12k

C27

5C

85

R32

5

33k

C26

3

0.03

3u

17

D31

ZS

H5M

A27

R3 1k

L359

18n

R26

6

5.6k

C51

10u6

.3

C26

0

0.01

u

12.5

n

L360

R4 3.3k

C38

4

7p

R60

2

10k

1

2

3

4VEE

5

6

7

8VCC

L509

9.5T

C26

8C

D2

DA

221

C32

2

56p

R253

0

R375

0

R5

22k

C25

2

39p

C258

0.01u

2SC2412KQ301

D606MA742

70

C60

4

2p

C380

470p

C28

047

u16

C38

8

7p

D321812L110PR

C274

0.22u

R529

10

C253

1u C52

470p

C256

0.018u

R2 0

C57

3

0.01

u

C321

33p

R256

5.6k

8C

R313

100k

8R

R528

10k

R60

1

10k

C25

7

0.03

9u

R381

10

C27

7

470p

71

C49

0.01

u

B

C273

1u

D6081SS355

D35

5

HV

C37

6B

B

C38

2

470p

C33

C25

5

8200

p

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

J1

C38

7

0.5p

CN5E41-0927-05

OVER VOLTAGE

AF MUTE

POWER MODULE

KEC

MIC

CURRENTPROTECTION8T

KEC

D32

DC SWITCH

D606,607

PC

SQL AMP

AMPSW(CPU52)

VOLTAGEPROTECTION

DC SWITCH

AFO(EVOL11)

B

AF MUTE

VOLTAGEDETECTORRESET

KEC

BUFFERAMP

AUDIO AMP

DCSWITCH

RSSI(CPU92)

SPM(CPU51)

REVERSECONNECTIONPROTECTION


W/N

O(E

VO

L2)

VOLTAGE REGULATOR5C

SQ

IN(C

PU

93)

8TC

+

5M

Q35,36

VOLTAGEDETECTORINT

E

1/2Vcc

DETECTION

AUDIOFILTER

DC SWITCH

Q33,34

SURGE ABSORPTION

SBC(CPU82)

1,1A

AFV

UHF

APC VOLTAGEDETECT

8R

W/NI(EVOL1)

D1-3

TV

RESET(CPU10)

KEC

8RC(CPU76)

RX

KEC

D31

+-

INT(CPU18)

-

SB

50,4

MH

z

8TC(CPU77)

ANT SW

LIMITER

SMP(CPU51)

AMPSW(CPU52)

PC/TVW/NO(EVOL2)

8TC(CPU77)

AFO(EVOL11)

8RC(CPU76)

MIC

RA30H3340MIC502

C53

1

3.3u

10

D50

3

02D

Z5.

1F-Y

C53

2

470p

D60

4

XB

15A

709

D60

5

XB

15A

709

C60

1

10p

D604,605ANT SW

R800R92-1061-05

D353,354,355

RF BPF TUNING

C309

0.022u

D301MA742

DETECTION

RSSI

SCAN

SCAN

RFIN

FLAMPO

SQLIN

Hy_C

GND

FLAMPI

AFO

PH_S

DEC2

DEC1

IF_IN

MIX_O

VCC

OSC(E)

NC

OSC(B)

QUCO

IC251NJM2902V

D1

DA

221

D3

DA

221

CL

SB

KMO2

KMO1

KMI4

KMI3

KMI1

KMI2

CM

MIC

HOOK

POWER

CE

PTT

5C

DI

CN1E40-6268-05

Q36KRC102S

IC501TA75W01FUF

APC CONTROLLER

IC301TK14489V

FM DEMODULATION

D61

02DZ18F-X,YOVER VOLTAGE

DETECTION

IC31KIA7808AF

8C

VOLTAGEREGULATOR

R37

6

100k

R37

8

100k

R37

4

100k

C31

4

0.01

uC

313

15u6

.3

RESET(CPU10)

SBC(CPU82)

SQIN(CPU93)

INT(CPU18)

1/2Vcc

R30

5

1.8k

R30

4

4.7k

VOLTAGEREGULATOR

KTA1046(Y)Q31

220p

1000

p

470p

1000

p

220p

220p

470p

R53

5

1k

R53

4

8.2k

C53

9

470p

C53

4

470p

L505

C52

7

220p

C53

8

0.1u

C57

2

0.01

uR

539

100

C57

1

470p

2SA1745(6,7)Q33

KTA1664(Y)Q35

7.9V

R:13.5VT:13.0V

R:7.9V

T:7.9V

3.1V

R:4.9V

T-Hi:9.0V Lo:3.6V

T-Hi:4.5V Lo:2.6V

4.9V

T:7.9V

2.7V

3.3V

3.3V

5.6V

R:4.6V

R:2.4V

T:12.9V

7.9V

R:7.9V

7.9V

R:1.0V

R:13.5V

R:12.8V

T:0.99V

R:1.48V

TX-RX UNIT (X57-6923-03)

SCHEMATIC DIAGRAM / TK-8100

61

7

6

5

4

3

2

1

TSRQP

X54-343 1/1

C16

100p

C22

1000

p

D28

B30-2205-05

R34

100

1D

IM

2N

C

3M

BL

4S

EG

0

5S

EG

1

6S

EG

2

7S

EG

3

8S

EG

4

9S

EG

5

10S

EG

6

11S

EG

7

12S

EG

8

13

14

15

16

17

18

19

20

21

22

23

24

252627282930313233343536

37COM2

38COM3

39VDD

40VLCD

41VLCD1

42VLCD2

43VSS

44OSC

45INH

46CE

47CL

48DI

R8 1k

R5 1k

Q6KRC102S

R33 56

R10

2.7k

C24

0.01

u

C30

0.01

u

D22

B30-2205-05

R6 1k

D23

B30-2205-05

R21

10k

D21

B30-2205-05

R4 1k

C25

1000

p

D2

B30-2205-05

D25

B30-2205-05

R24

470k

L1

Q10KRA225S

D4

B30-2205-05

D17

MA

2S11

1

R26

3.9k

R9 1k

D5

B30-2205-05

C23 1000p

D3

B30-2205-05

R22

10k

C4

100p

D29

B30-2205-05

C15

100p

R40

47k

R37 10

R7 1k

R23

10k

D24

B30-2205-05

R25

47k

D31

B30-2205-05

C18 1u

C19

680p

Q11

RN47A4D20

B30-2205-05

C6

0.01

u

R11

2.7k

R36 56

D26

B30-2205-05

D30

B30-2205-05

D19

B30-2205-05

D18DA204U

J1 E08-0877-05

CN1 E40-6005-05

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

KEY BACKLIT

SE

G3

KMO2

KEY BACKLIT SWITCH

CM

KMO1

MBL

CO

M2

DC SWITCH

KMI1

SE

G13

ME

SE

G21

POWERSWITCH

PTT

SE

G6

SE

G11

HOOK

CM

KM

I4

SE

G26

KM

I3

CE

SE

G9

SE

G28

VOL

DC CONTROLLER

POWER

SE

G15

SE

G12

Q10

SE

G29

5C

DI

SE

G18

SE

G23

SB

CO

M0

SCN

DN

DC SWITCH

LCD ILLUMINATION

SE

G16

SE

G0

MIC

SE

G27

KMI3

Q9

MIC

VOL

SE

G20

SE

G17

KMO1

KMI2

LCD BACKLIT SWITCH

CL

DN

SE

G30

KM

I2

SE

G24

SE

G22

PTT

CH

SE

G2


SE

G5

SE

G4

CO

M1

SE

G1

SE

G25

MON

KMI4

SE

G19

SE

G7

SURGEABSORPTION

SE

G8

KM

I1

SE

G14

Q11

SE

G10

CH

GND

ME

CO

M3

GND

DIMMER FUNCTION SWITCH

HOOK

UP

SB

UP

KMO2

D27DA221

CP1R90-0724-05

C31

1000

pC

32

1000

pC

33

1000

p

SEG9

SEG10

SEG11

SEG12

SEG13

SEG14

SEG15

SEG16

SEG17

SEG18

SEG19

SEG20

SE

G21

SE

G22

SE

G23

SE

G24

SE

G25

SE

G26

SE

G27

SE

G28

SE

G29

SE

G30

CO

M0

CO

M1

2SB1132(Q,R)Q9

KEY & LCD BACKLIT

D2-4

1000

p

C27

C28

1000

p

IC2LC75834W

LCD CONTROLLER

KEY & LCD BACKLIT

D19-26,28-31

R38 39 R39 39

12.0V

0.125V

4.9V

13.5V

4.7V

4.9V

13.5V12.7V

12.7V

4.9V

8.9V

Note : The components marked with a dot (•) are parts of layer 1.

-t

-t

-t

-t

FNC4

FNC6

FNC1

FNC2

FNC5

FNC8

FNC3

FNC7

C97

470p

8

C50

7

470p

C60

3

0.5p

C60

5

5p

C102

0.1u

R31

2

47k

R27

6

47k

7

43

Q34KRC102S

C16

100p

5M

C26

6

0.1u

78

R20

3

100k

5M

C21

50.

1u

R73

100k

R129

0

C46

7

470p

C20

2

470p

R44

2

100

17

C54

0.1u

9

R77

130k(D)

C22

1000

p

SB

L358

14n

C78

1000

p

D502DA221

C319

100p

C386

1p

R26

1

120k

C30

4

220p

R42

0

2.2k

C55

0.1u

C23

3

4.7u

6.3

C42

1

470p

R41

330k

C60

6

4p

C51

5

470p

R118 1k

R28

0

390

C22

1

0.1u

R414

0

R27

2

1.5k

R52

6

180

C22

7

0.01

u

R40

7

1.5k

D28

B30-2205-05

C19

470p

C31

7

0.1u

TC

352

3P

CN

301

R34

100

C367

470p

IC34PST9140NR

1NC

2VEE1

3VEE2

4OUT

5VCC

D409DAN235E

5C

R21

6

270k

5C

C51

2

470p

R25

2

470k

2SK1824Q252

R31

0

1k

R36

9

150

C26

5

0.1u

1D

IM

2N

C

3M

BL

4S

EG

0

5S

EG

1

6S

EG

2

7S

EG

3

8S

EG

4

9S

EG

5

10S

EG

6

11S

EG

7

12S

EG

8

13

14

15

16

17

18

19

20

21

22

23

24

252627282930313233343536

37COM2

38COM3

39VDD

40VLCD

41VLCD1

42VLCD2

43VSS

44OSC

45INH

46CE

47CL

48DI

R27

4

15k

R35

47k

R8 1k

R259

12k

R31

1

33k

3SK255Q352

G1

D

S

G2

C40

3

100p

R432

1k

R5 1k

X401

L77-1868-15

VC

GND XOUT

5C

C27

0

4.7u

6.3

R30

8

330k

Q6KRC102S

R315 18k

IC202NJM2904V

12345 6 7 8

V+

5M

D607MA742

R74

47k

C523

5p

R112 47k

R538

0

100

C35

4

6p

R33 56

C37

7

470p

R10

2.7k

C24

0.01

u

C37

2

15p

L101

5M

R31

6

22k

D35

4

HV

C37

6B

C21

4

150p

R60

3

47k

X86

D40

8

MA

2S11

1

C28

2

470u

16

C55

9

0.1u

C21

8

10u6

.3

R10

3

1k

C52

1

470p

R68 1k

R42

4

330

C268

0.1u

C38

1

8p

8R

8T

C48

0.01

u

R27

3

4.7k

C30

0.01

u

CN

303

R36

7

100

R1230

B

C77

470p

R22

1

15k

R35

2

100

TH

98

100k

Q254DTC363EU

C40

0.1u

D406MA2S304

R42

7

100k

L417

R268

1k

D22

B30-2205-05

C502

2p

C23

1

470p

R402 1k

C30

2

1000

p

C35

470p

R25

0

47k

R76

18k(

D)

R205

820

R32

0

10k

C609

1p

3

R215

68k

L407

270n

R42

2

10k

R16

2

1.5k

C37

3

7p

R403 1k

R36

1

22

47

R6 1k

R50

7

180

2SC4738(GR)FQ403

C46

4

470p

R117 1k

R25

7

1M

C17

470p

R50

1

1k

L412

270n

C45

22u1

0

R22

5

150k

L410

270n

R41

1

10k

D10

DA

221

C20

4

2.2u

10

45

C311 0.1u

84

5M

C37

5

470p

R11047k

R71

4.7k

78

C43

13p

R32

1

22k

L414

270n

IC161M62363FP

1 2 3 4 5 6 7 8 9

10 11 12131415161718192021222324

R22

6

100k

C430

4p

D23

B30-2205-05

C56

470p

R52

1

100

5C

C426

10p

2SK1824Q1

L357

39n

D602MA4PH633

R211

82k

C72

470p

R222 1k

R23

3

6.8k

R258

2.7k

70

R277

68k

CN

304

C27

2

1000

p

R34

4.7k

R26

3

91k

IC35PST9140NR

1NC

2VEE1

3VEE2

4OUT

5VCC

C10

4

0.1u

C432

0.5p

C390

8p

C312 0.1u

CNVSS

C28

R30

3

22k

C40

2

100p

C30

1

4.7u

6.3

R25

5

5.6k

L304

330n

R37

10k

C45

5

2p

C32

4

0.01

u

R26

0

220k

C51

0

470p

R21

10k

9

C38

9

0.01

u

D21

B30-2205-05

2SK1824Q32

R37

3

180k

R421

1.5k

L201

C40

6

1000

p

C206

1000p

R428

47k

Q408KRX102U

R131 1k

R52

5

33

2

COM

1IN

3OUT

R43

9

120k

R36

6

100k

TH

97

100k

1

C411

0.1u

C371

0.5p

R30

1

4.7k

C51

4

470p

R4 1k

R43

1

100k

L604

9.5T

B

SB

R412

12k

C39

1

470p

R415

0

C42

4

3.3u

10

R31

810

k

R377

0

R40

5

0

C36

1

470p

D302DAN222

C15

1

1800

p

C60

8

2p

C50

4

470p

R16

1

1.2k

D201DAN222

C32

R31

9

10k

CN

502

5M

35

C26

2

470p

R40

810

R36

1.5k

R60

6

1k

C25

1000

p

36

8R

D2

B30-2205-05

C46

3

470p

46 D25

B30-2205-05

R165 1k

C90

18p

D8

DA

221

R306

270k

R380

100k

C16

470p

C36

3

0.01

u

BS

B

R130 1k

5C

D402

HZU5ALL

5M

R44

32.

2k

R38

330k

3

R409

100k

R33

47k

C35

6

2p

L601

3.5T

C20

8

0.01

u

R751k

POWER

C37

0

470p

C61

4

470p

84

R108

46

C50

0.01

u

C13

470p

L303

330n

R44

1

1k

R207

750k

C50

5

470p

C306

1000p

R1091.5k

C56

0

470p

8C

2SC4617(S)Q251

C30

7

0.02

2u

TC

402

10p

C37

470p

R12

20

L302

330n

C40

9

0.1u

29

C418

1000p

C25

9

0.01

u

R24

470k

R53

3

0

R53

7

1.5k

R86

0

C42

2

470p

1 2 3 45678

V+

C602

1000p

IC252LA4600

12345678910

R208

1.5k

99

1

2

3

4V+

5

6

7 8

9

10

11GND

12

13

14

C53

470p

C351

33p

C41

7

470p

R124

47k

1

2

3

4

5

6

7

8

9

10 11

12

13

14

15

16

17

18

19

20

C251

4.7u6.3

C29

R53

6

47

L603

1.5T

C39

0.1u

L1

R106

Q10KRA225S

29

5C

IC32NJM78L05UA

2

COM

3IN

1OUT

R401 1k

R94

10k

83

R264

120k

C44

8

470p

R87 1k

8T

C37

6

470p

C41

6

470p

R62

1k

C27

1

3300

p

R40

4

10k

R35

9

330k

C40

8

22p

C269

1u

C22

6

4700

p

C41

22u1

0

D404

MA2S304

TC

353

6P

C42

0.01

u

C21

2

1200

p

L418

27n

C37

8

470p

R41

3

10k

R53

0

5.6k

C374

7p

8R

R26

2

18k

D4

B30-2205-05

1

2

3

4

5

6

7 8

9

10

11

12

13

14

R265

5.6k

C28

1

470p

L501

27n2SK508NV(K52)

Q405

R21

3

330k

R32

4

0

71

R22

0

15k

R410

10k

BS

B

R25

4

680

C22

9

4.7u

6.3

C26

1

0.01

u

R31

4.7k

D17

MA

2S11

1

L351

470n

R26

3.9k

R164 1k

C98

470p

C42

9

1p

C32

3

270p

D11

DA

221

R9 1k

R52

7

330k

C31

6

0.1u

C441

0.3p

C42

8

470p

99

R1 100

D303DAN222

CN

302

69

C66 470p

D2021SS372

R353

100k

L356

27n

2SK1824Q253

C14

470p

R51

9

330

C60

7

0.5p

D5

B30-2205-05

C61

470p

R23

0

120k

C42

5

0.1u

35

R21

9

56k

R228

10k

R418

1k

R22

9

680k

C44

04.

5p

L41356n

D35

3

HV

C37

6B

R512

0

C10

1000

p

C38

470p

C53

7

47u2

5

R425

47k

R51

1

470

8R

TH351

3.3k

R212

82k

R125 1k

L403

10u

C30

R36

3

150k

R50

9

100

C27

6

470p

IC33NJM78L05UA

2

COM

3IN

1OUT

C37

9

470p

L409

220n

83

R50

6

56k

TH

301

100k

C42

7

4p

C23 1000p

R30

2

4.7k

R105

C27

5

1u

C41

4

0.1u

R52

3

3.3k

R419

1k

C41

010

u6.3

C43

6

0.5p

L301L34-4797-05

C21

1

820p

R20

4

18k

C205

0.1u

R107

C36

470p

R27

1

560

R21

8

82k

R93

12k

C44

22u1

0

R23

2

9.1k

R37

2

680k

R217

220k

L404

8

C32

6

0.01

u

R10

2

47k

D40

7

MA

360

R214

68k

R114 1k

R35

8

47

Q61KRC404RTK

C315

0.1u

C412

10u6.3

C43

7

470p

D60

9

1SS

355

R429

100

R41

7

220k

5M

2SK1824Q86

R78

1k

C23

470p

C27

94.

7u16

L504

22n

R53

1

47k

R251

47k

C4345p

D3

B30-2205-05

D9

DA

221

69

5C

1O

SC

IN2

NC

13

OS

CO

UT

4V

P5

VC

C6

DO

7G

ND

8LD

9N

C2

10F

IN11121314151617181920

7

C383

0.5p

R22

10k

SB

C36

6

0.1u

35

C25

0

0.1u C

43

22u1

0

D7

DA

221

8C

30

CN

503

C89 6p

R36

2

470k

R115 1k

R430

100

D5

DA

221

L361 8n

C264

0.033u

R605

47k

2SJ243Q202

R28

1

0

R223

4.7k

L602

1.5T

C203

0.027u

C25

4

1u

R119 1k

R275

15k

C43

8

2p

C41

3

0.01

u

C612

1.5p

R323

100k

R66

47k

L408

82n

C82

470p

Q255KRC102S

C31

8

0.1u

C40

1

100p

C4

100p

C35

8

470p

5C

R10

4

1k

R40

390k

8T

R444

1k

R30

9

3.3k

L406

270n

R53

2

0

R44

0

100

86

C44

9

470p

C23

0

0.1u

C454

6p

R50

2

10

8C

2SA1832(GR)FQ402

R70

47k

R128 1k

C38

5

470p

47

SB

85

C35

3

0.01

u

C28

3

1000

p

R51

7

10

D29

B30-2205-05

R279

4.7k

C35

7

0.01

u

C88 6p

R43

4

0

R39

470k

CN

501

R32

220

R41

6

470

C20

470p

C30

3

4700

p

C15

100p

C21

470p

C359

12p

C83

0.1u

R61

470

R445

0

43

C34

330u

25

R51

3

220

R227

22k

C27

80.

1u

86

C61

3

470p

8R

C210

0.1u

36

C31

0

0.33

u

8C

C61

1

5p

R314 2.2k

C20

7

0.02

2u

R40

47k

R37 10

5M

R364

0

R269

82k

C44

4

470p

C61

0

10pC45

2

470p

D251MA742

C15

470p

R52

2

22

R43

5

100

C26

7

0.47

u

C22

8

10u6

.3

C30

5

220p

C51

3

470p

1

QT

/DQ

T2

DT

MF

/MS

K3

PLL

E4

NC

5N

C6

GN

D7

CN

VS

S8

EV

LLD

9B

SH

IFT

10R

ES

ET

11X

OU

T12

VS

S13

XIN

14V

CC

15G

ND

16N

C17

PO

WE

R18

INT

19N

C20

TX

/RX

21U

L22

NC

23N

C24

NC

25N

C

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51525354555657585960616263646566676869707172737475

768RC

778TC

78CM

79NC

80NC

81NC

82SBC

83KMI1

84KMI2

85KMI3

86KMI4

87PWRPRCT

88SIGNAL

89TEMP2

90TEMP1

91BATT

92RSSI

93SQIN

94AVSS

95NC

96VREF

97AVCC

98NC

99KMO1

100KMO2

48

5M

C30

8

1000

p

R116 1k

R37

0

470k

R111 1k

R278

12k

R12

00

R7 1k

C27

R23

10kC20

1

0.1u

R91 1k

L355

18n

5C

C516

8p

C22

0

4.7u

6.3

85

R32

5

33k

C36

2

470p

D24

B30-2205-05

L411

270n

C16

3

470p

L415

270n

R126 1k

C26

3

0.03

3u

17

R113 47k

C35

5

18p

5M

D40

1

MA

2S11

1

L416

D31

ZS

H5M

A27

R6747k

L502

18n

2SC4919Q201

R42647k

R3 1k

L359

18n

R151

10k

C44

2

10u6

.3

R26

6

5.6k

C51

10u6

.3

C26

0

0.01

u

C54

0

470p

R25

47k

D31

B30-2205-05C213

3300p

49

R31

710

k

C43

5

5p

R267

0

R35

1

470

12.5

n

L360

C22

5

1u16

R127 1k

R22

4

1k

R52

4

180

C101

470p

R72

1M

TC

401

10p

R4 3.3k

C38

4

7p

R23

1

68k

C4394p

R60

2

10k

R20

1

680

1

2

3

4VEE

5

6

7

8VCC

R82 0

L509

9.5T

30

C466

5p

C51

1

470p

C26

8C

C45

1

470p

D2

DA

221

C36

8

7p

D6

DA

221

R355

680

C23

2

470p

R354

560

R152

4.7k

C32

2

56p

R253

0

R375

0

R5

22k

C16

1

1000

p

C25

2

39p

C258

0.01u

45

2SC2412KQ301

D606MA742

R51

5

10

C36

0

8p

70

R322

100

C46

1

470p

C18 1u

C22

470p

R92 1k

R51

4

680

R51

6

3.3k

C60

4

2p

5C

49

C217

10u6.3

1

C19

680p

C18

470p

C380

470p

C28

047

u16

Q11

RN47A4

R36

5

100k

R42

3

470

C38

8

7p

D20

B30-2205-05

R10

1

47k

C52

2

470p

48

D321812L110PR

5M

3SK255Q353

G1

D

S

G2

C274

0.22u

R529

10

C253

1u

R43

3

4.7k

C52

470p

C42

3

0.04

7u35

C87

18p

C43

3

470p

C16

4

10u6

.3

R36

0

470k

C256

0.018u

R166 1k

C6

0.01

u

R2 0

C57

3

0.01

u

R20

2

0

C321

33p

C50

1

470p

R256

5.6k

R11

2.7k

C16

2

4.7u

6.3

R206

100

R270

2.7k

8C

L420

27n

5C

8C

C456

4p

R313

100k

8R

R36 56

R69 1k

C509

5p

R37

1

390k

R528

10k

L405

8C

R60

1

10k

C25

7

0.03

9u

R24

9

47k

R381

10

C27

7

470p

D26

B30-2205-05

71

C49

0.01

u

1A0

2A1

3A2

4GND

5

6

7

8

8T

R163 47k8C

B

C273

1u

5C

D6081SS355

D35

5

HV

C37

6B

B

C103

1000p

D4

DA

221

R81

47k

L352

470n

8R

C38

2

470p

C33

C36

4

470p

C25

5

8200

p

C15

2

3900

p

C40

4

15u6

.3

R209

240k

D30

B30-2205-05

D19

B30-2205-05

100

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

J1

CN2 E40-5702-051

2

3

4

5

6

7

8

9

10

11

12

CN3 E40-6292-051 IGN

2 DATAI

3 DETO

4 TXAFI

5 TXAFO

6 EMGMIC

7 RXAFO

8 ALTI

9 RXAFI

10 5C

11 8C

D18DA204U

J1 E08-0877-05

CN1 E40-6005-05

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

C38

7

0.5p

C46

9

10p

C47

2

10p

C470

5pL421

18n

CN5E41-0927-05

KEY BACKLIT

5M

SPLATTER FILTER

SE

G3

OVER VOLTAGE

KMO2

DTMI(EVOL16)

KEY BACKLIT SWITCH

CM

KMO1

MBL

AF MUTE

CO

M2PLL IC

POWER MODULE

EVLLD(CPU8)

DC SWITCH

KEC

Q402,403

KMI1

SE

G13

BEATSHIFT

MIC

ME

SE

G21

+

AFM(CPU50)

POWERSWITCH

PTT

8C

RSSI(CPU92)

SE

G6

SE

G11

HOOK

CM

T/R SW

KM

I4

CURRENTPROTECTION

SE

G26

AF MUTE

8T

KM

I3

KEC


PLLE(CPU3)

CE

D32

SQIN(CPU93)

SE

G9

DC SWITCH

SE

G28

8CL

VOL

D606,607

DC CONTROLLER

PC

SQL AMP

POWER

PC

/TV

O

SE

G15

RX VCO

SE

G12

BUFFER AMP

AMPSW(CPU52)

VOLTAGEPROTECTION

Q10

DC SWITCH

AFO(EVOL11)

B

AGC

SE

G29

AF MUTE

VOLTAGEDETECTORRESET

-

-

5C

PC

/TV

I

AF

I

DI

KEC

BUFFERAMP

SE

G18

AUDIO AMP

DCSWITCH

SE

G23

RSSI(CPU92)RSSI(CPU92)

SPM(CPU51)

REVERSECONNECTIONPROTECTION

LD

SB

TV

KDC

AF

O

CO

M0

TCXO

SCN

DN

PLL SYNTHESIZER

5M

DC SWITCH

LCD ILLUMINATION

SE

G16


VOTAGEDROPPED

SE

G0

CV

CLK

DRIVE

MIC

DCAMP

W/N

O(E

VO

L2)

SE

G27

TP

KMI3

VOLTAGE REGULATOR5C

SQ

IN(C

PU

93)

8TC

Q9

MIC

+

5C

VD

D

VOL

RXD

8C

SE

G20

IF SWITCH

SE

G17

+

KMO1

SB

C(C

PU

82)

KMI2

5M

LCD BACKLIT SWITCH

Q35,36

VOLTAGEDETECTORINT

RIPPLEFILTER

IGN

(CP

U72

)

RIPPLEFILTER

E

MO

DO

1/2Vcc

8TC(CPU77) CL

DETECTION

AUDIOFILTER

DIGITAL

DC SWITCH

DN

AFI(EVOL12)

SE

G30

Q33,34

EEPROM

QT/DQT(CPU1)

KM

I2

RESET(CPU10)

SURGE ABSORPTION

SE

G24

POTENTIOMETER

WIDE

IGN(CPU72)

SBC(CPU82)

DAT

OR GATE

1/2Vcc

SE

G22

PTT

MIXER

1/2Vcc

1,1A

D407

AFV

CH

TX-RX UNIT (X57-6923-03)

MO

DI

SE

G2


UHF

SE

G5

T/R SW

INT(CPU18)

8R

SE

G4

SUM AMP

APC VOLTAGEDETECT

CO

M1

SE

G1

8R

W/NI(EVOL1)

D1-3

MOD BUFF

CV

W/N

I(E

VO

L1)

SBC(CPU82)

RF AMP

IF SWITCH

CHARGE PUMP

TV

SE

G25

HPF

MON

8RC(CPU76)

1/2Vcc

KMI4

TX VCO

SE

G19

NARROW

RESET(CPU10)

SE

G7

KEC

MODULATION

1/2V

cc

SURGEABSORPTION

SE

G8

AF MUTE

IDC

KM

I1

AF AMP

8RC(CPU76)

SE

G14

MIC AMP

RX

AFO(EVOL11)

+

KEC

D31

+

-

Q11

MIC MUTE

Scrambler

SE

G10

UL(CPU21)

DTMI(EVOL16)

AFI(EVOL12)

CH

GND

-

ME

RF SWITCH

CO

M3

8R

W/N

O

INT(CPU18)

RIPPLEFILTER

-

GND

KEC

TX AF

SB

RX VCO

RSSI(CPU92)

W/N

O(E

VO

L2)

DIMMER FUNCTION SWITCH

TX/RX(CPU20)

+

W/N

I

W/NI(EVOL1)

HOOK

50,4

MH

z

Scrambler

16.8MHz

UP

-

8TC(CPU77)

SB

ANT SW

D403,404

IGNITION

RF AMP

UP

TXD

LIMITER

KMO2

PLL

E(C

PU

3)

FR

OO

(EV

OL2

3)

DT

(CP

U53

)

CK

(CP

U54

)

MO

D

CLK

NC

3

DAT

ALEFC

NC

4

FO

UTP

NC

5R

IC401MB15A02

2SC4649(N,P)Q404

2SK508NV(K52)Q406

PLLE(CPU3)

8CL

DT(CPU53)

UL(CPU21)

W/NI(EVOL1)

MIC

MOD

CK(CPU54)

W/NO(EVOL2)

OU

T

RE

SE

T

DT

MI

DO

DT

MO

VD

Fref

GN

D

FR

QI

FR

QO INBLI

BLO

2SK1824Q87

BEATSHIFT

IC203NJM2902V

2SJ243Q407

2SC5108(Y)FQ410

BUFFER AMP

2SC4617(S)Q440

C45

022

u10

2SC5108(Y)FQ411

RF AMPPRE DRIVE AMP

2SC5108(Y)FQ500

D351,352

RF BPF TUNING

XF351

49.95ML71-0591-05

2SC5108(Y)FQ351

IF AMP

8RC(CPU76)

W/NO(EVOL2)

SMP(CPU51)

AMPSW(CPU52)

PC/TV

AFO(EVOL11)

8TC(CPU77)

MIC

SMP(CPU51)

AMPSW(CPU52)

PC/TVW/NO(EVOL2)

8TC(CPU77)

AFO(EVOL11)

8RC(CPU76)

MIC

2SC4649(N,P)Q302

BUFFER AMP

CF302L72-0959-05

CF301L72-0993-05

EEPWP

EEPSCK

EEPSDT

FNC1

FNC2

CLKFLS

BSYFLS

TXD

RXD

PTT

HOOK

NC

NC

EMPFLS

NC

NC

NC

FNC3

CEFLS

FNC4

FNC5

FNC7

FNC6

FNC8

AFM

SP

M

AM

PS

WDT

CK

NC

NC

DS

T1

DS

T2

DS

T3

VC

C

NC

VS

S

NC

NA

RR

OW

WID

E

NC

NC

NCCL

CEDI

IGN

MIC

MT

1

MIC

EM

MIC

MT

2

IC10130622MAA-B96GU

CPU

SDA

SCL

WP

VCC

IC66AT24C64A10SI18

RA30H3340MIC502

C53

1

3.3u

10

D50

3

02D

Z5.

1F-Y

C53

2

470p

D60

4

XB

15A

709

D60

5

XB

15A

709

C60

1

10p

D604,605ANT SW

R800R92-1061-05

D353,354,355

RF BPF TUNING

C309

0.022u

D301MA742

DETECTION

RSSI

SCAN

SCAN

RFIN

FLAMPO

SQLIN

Hy_C

GND

FLAMPI

AFO

PH_S

DEC2

DEC1

IF_IN

MIX_O

VCC

OSC(E)

NC

OSC(B)

QUCO

IC251NJM2902V

D1

DA

221

D3

DA

221

CL

SB

KMO2

KMO1

KMI4

KMI3

KMI1

KMI2

CM

MIC

HOOK

POWER

CE

PTT

5C

DI

CN1E40-6268-05

Q36KRC102S

SURGE ABSORPTION

D4-11

IC201NJM2100VMIC AMP

D35

1

HV

C37

6B

D35

2

HV

C37

6BL354

14n

C36

9

0.75

p

IC501TA75W01FUF

APC CONTROLLER

IC301TK14489V

FM DEMODULATION

D61

02DZ18F-X,YOVER VOLTAGE

DETECTION

IC31KIA7808AF

8C

VOLTAGEREGULATOR

D27DA221

CP1R90-0724-05

C31

1000

pC

32

1000

pC

33

1000

p

SEG9

SEG10

SEG11

SEG12

SEG13

SEG14

SEG15

SEG16

SEG17

SEG18

SEG19

SEG20

SE

G21

SE

G22

SE

G23

SE

G24

SE

G25

SE

G26

SE

G27

SE

G28

SE

G29

SE

G30

CO

M0

CO

M1

2SB1132(Q,R)Q9

KEY & LCD BACKLIT

D2-4

1000

p

C27

C28

1000

p

2SC3357-AQ502PRE DRIVE AMP

2SC3357-AQ501

R52

0

1.5k

C52

0

470p

MO

D

EV

LLD

(CP

U8)

MO

DI(

EV

OL9

)

MO

DO

(EV

OL1

0)

PLL

E(C

PU

3)

DT

MO

(EV

OL1

5)

PC

/TV

O(E

VO

L3)

UL(

CP

U21

)

DT

MI(

EV

OL1

6)

TX

/RX

(C

PU

20)

PC

/TV

V+ GND

PC/TVW/NO(EVOL2)

TX/RX(CPU20)

CK(CPU54)

DT(CPU53)

AFO(EVOL11)

MIC

W/NI(EVOL1)

5M

AFI(EVOL12)

MICEM(CPU74)

MICMT1(CPU73)

D40

3

MA

2S30

4

D40

5

MA

2S30

4

D405,406

TX VCO

R43

612

0k

Q71KRC414RTK

SQIN(CPU93)

1/2Vcc

SBC(CPU82)

RESET(CPU10)

INT(CPU18)

R37

6

100k

R37

8

100k

R37

4

100k

C31

4

0.01

uC

313

15u6

.3

RESET(CPU10)

SBC(CPU82)

SQIN(CPU93)

INT(CPU18)

1/2Vcc

R30

5

1.8k

R30

4

4.7k

VOLTAGEREGULATOR

KTA1046(Y)Q31

220p

1000

p

470p

1000

p

220p

220p

470p

R53

5

1k

R53

4

8.2k

C53

9

470p

C53

4

470p

L505

C52

7

220p

C53

8

0.1u

C57

2

0.01

uR

539

100

C57

1

470p

IC2LC75834W

LCD CONTROLLER

KEY & LCD BACKLIT

D19-26,28-31

MICEM(CPU74)

MICMT1(CPU73)

WIDE(CPU65)

AMPSW(CPU52)

AFI(EVOL12)

SMP(CPU51)

NARROW(CPU64)

47k

1k

1k

47k

2SA1745(6,7)Q33

KTA1664(Y)Q35

R38 39 R39 39

0.7V

T:1.1V

7.0V

T:5.6V

5.0V

7.9V

T:6.8V

LOCK:5.0V

T:0.29V

T:1.6V

R:13.5VT:13.0V

12.0V2.4V

R:1.0V

0.125V

R:7.9V

T:1.10V T:7.3V

4.9V

R:1.2mV

T:7.9V

6.1V

3.1V

R:7.0V

6.9V

4.9V

R:4.9V

0.74V

W:4.9VN:0V

R:7.5V

13.5V

R:5.7V

4.7V

4.87V

T-Hi:9.0V Lo:3.6V

T-Hi:4.5V Lo:2.6V

4.9V

4.9V

T:7.9V

13.5V

R:1.9V

2.7V

T:0.97V

3.3V

1.6V

3.3V

R:0.6V

5.6V

R:6.6V

R:7.3V

R:4.6V

T:6.4V

R:7.9V

T:7.9V

R:2.4V

7.2V

4.8V

1.51V

4.9V

5.0V

T:12.9V

T:6.0V

R:3.2V

T:1.8V

R:0V

R:4.6V

7.9V

3.42V

12.7V

R:7.9V

7.9V

4.9V

R:4.9VT:0V

7.7V

8.0VW:0VN:4.9V

R:1.0V

R:0.9V

R:13.5V

R:12.8V

0.8V

R:0.76V

R:1.6V

12.7V4.9V

R:3.6V

4.9V

T:0.99V

R:1.48V

8.9V

0.4V

5.0V

TK-8100

62

BLOCK DIAGRAM /

Q4402SC4617(S)

DT

CHARGEPUMP

CHARGEPUMP

MIC

IC202NJM2904V

SB

D201DAN222

D2021SS372

KMI4

IC203NJM2902V

(3/4)

IC203NJM2902V

(1/4)

KMO1

POWER

IGN

Q71KRC414RTK

M

PLL

TCXOMOD

AGCDET

KMI1

KMO2

TX-RX UNIT X57-6923-03

CK

SW

LOOPFILTER

KMO1

8C

ELV

SW

POWER

BUFFMIC

MUTE

OVERVOLTAGE

DET

HOOK

8CL

IC201NJM2100V

PLL IC

8RC

CK

RF

SBC

SUM

SW

KMI1

CM

KEY

MIC

ME

TVC

MIC

MIC

SW

BSH

KMO2

SW

KMO2

HOOK(RXD)

AGC

RESET

DTMF

B

Q2012SC4919

VCO

Q4032SC4738(GR)F

TCXO

WIDE

KMI4

NARROW

KMI3

MIC

MON

16.8MHz

IC161M62363FP(8/8)

IC161M62363FP

(3/8)

IC161M62363FP(6/8)

8TC

SB

SQIN

8C

PTTSPLATTER

FILTER

KMI3

PTT(TXD)

8C

MBL

MIC/IDC

Q4042SC4649(N,P)

16.8MHz

MIC

PTT(TXD)

CM

GND

KMI2

ME

Q4072SJ243

IC401MB15A02

RIPPLEFILTER

LD

Q61KRC404RTK

DT

KMI1

INT

KMI4

KMO1

SCN

HOOK(RXD)

KMI2

TC

D/ACONV

D/ACONV

D/ACONV

CM

CV

5C

Q4022SA1832(GR)F

KMI2

KMI3

SB

DTMF

Q10KRA225S

5C

Q6KRC102S

RVC

PLLE

DISPLAY UNIT X54-3430-20

Q42SK508

MICMT

LCD BACK LIGHT

D19~26,28~31B30-2205-05

SW SW

Q11RN47A4

MBL

DIM

D18DA204U

Q92SB1132(Q,R)

LCD DRIVER

IC2LC75834W

CLCE

DICOM0~3

SEG0~30

MBLDIM

INH

LCD

VOLUP

VOLDN

CHUP

CHDN

POWER

5CCECLDI

D2~5B30-2205-05

Q12SK1824

X401

QT/DQT

TX/R

SPMAFM

AM

CLCEDI

5C

TXAFI

IGN

5C

TXAFO

ALTI

FNC2(RXD)

EMGMIC

FNC1(TXD)

DATAIDETO2

FNC3(RESET)

DETO

RXAFO

8C

SB

GND

DATAI

FNC1~FNC8

RXAFIALTI

TK-8100

63

BLOCK DIAGRAM /

Q332SA1745(6,7)BATT

CF302(NARROW)

PREDRIVEAMP

D303DAN222

MICMT2

SW

POW.DET

POW.DET

8TC

AVR5V

XF35149.95MHz

8RC

IC66AT24C64A10SI18

RF

D302DAN222

PC

ANT

Q872SK1824

IC203NJM2902V

(3/4)

1

BUFF

Vg

BATT

BUFFER

D301MA742

PLLE

INT

Vg

2

450kHz

SW

BPF

IC252LA4600

NOISE

D/ACONV

D/ACONV

IC501TA75W01FUF(1/2)

IC501TA75W01FUF(2/2)

WIDE

ANT SW

ELVLLD

ER

RF

BUFF

Q3512SC5108(Y)F

VCOMOD

L

SW

CF301(WIDE)

D351,352HVC376B

8RC

IC251NJM2902V

Q3533SK255

SBC

TXRX

8C

IC31KIA7808AF

AVR8V

TEMP2

MICMT1

MIX

SW

5M

AFFILTER

TXVCO

SW

IGN

Q4112SC5108(Y)F

Q4102SC5108(Y)F

SW

8T8CL

D353~355HVC376B

5CBSHIFT

T/RSW

BSHIFT

8R

SW

SW

E

D606MA742

D607MA742

T

Q35KTA1664(Y)

50.4MHz

DTMF

DET

SW

8R

IC32NJM78L05UA

5M

SW

VCOMOD

F

E

NARROW

EEPROM

Q252,2532SK1824

8R

RESET

ROW

IC33NJM78L05UACPU

IC10130622MAA-B96GU

AVR

BPF

Q36KRC102S

Q254DTC363EU

IC161M62363FP(3/8)

IC161M62363FP

(4/8)

8T

Q4062SK508NV(K52)

IC35PST9140NR

RESET

X86

IC161M62363FP

(1/8)

IC161M62363FP

(7/8)P

/8)

IC34PST9140NR

DTMF/BEEP

8TC

SQIN

Q322SK1824

SBC

Q2512SC4617(S)

TXD)

8C

SPM

MICEM

SIGNALQ34

KRC102S

8T

SB

+B

IFDEMODULATOR

AF PA

AFM

SW

MCF

INT

Q4072SJ243

D602MA4PH633

SW

8T

8T

Q3022SC4649(N,P)TRIPLER

TEMP1

APCCONTROL

SW

K(RXD)

TCXOMOD

D/ACONV

D/ACONV

CV

F LPF

8R

SW

RF

Q408KRX102U

Q862SK1824

HPF

F

5M

Q3012SC2412K

IF

Q5002SC5108(Y)F

D409DAN235E

EXT.SP

16.8MHz

Q3523SK255

Q31KTA1046(Y)

RXVCO

RF BPFTUNE

RF BPFTUNE

8R

SP

Q5012SC3357-A

Q4052SK508NV(K52)

OVERVOLTAGE

DET

EEPWPEEPCKEEPDT

IC301

SWQ255KRC102S

AMPSWQT

TX/RX

FNC2FNC3 FNC4FNC5 FNC6FNC7 FNC8

FNC1

SPMAFM

AMPSW

PWRPRCT

RSSI

SQIN

DRIVEAMP

Q5022SK3357-A

8C

8T

IC502 RA30H3340M

POWERMODULE

B

TK-8100

64

LEVEL DIAGRAM /

To m

G2Q351

3

IC201 IC203

Q353 XF1

7

IC202 IC202

BPF BPF

6 8Q40

ANT

X54-343

G2

91

To make measurements in the RF section, connect the RF level meter.In the RF section, use a 0.01µF coupling capacitor.(The display shows the SSG input value required to obtain 12dB SINA

1

G1

2 2

S

Q352

10

DisplayUnit

D

IC161

TX-

MIC

To make measurements in the AF section, connect the AC level meter.AG is set so that MIC input becomes 3kHz/1.5kHz (Wide/Narrow) DEV at 1kHz MOD.

D

CF1/CF2

450kHz

7

IC203

TX-RX Unit

S

IC301

5

49.95MHz

9

IC201

G1

20

1

Center Frequency

W : –121.0dBmN : –120.5dBm

W : –119.0dBmN : –118.5dBm

W : –105.5dBmN : –105.5dBm

W : –106.0dBmN : –105.0dBm

W : 1.05VrmsN : 0.44Vrms

W : 0.49VrmsN : 0.20Vrms

W : –117.5dBmN : –117.0dBm

W : –103.0dBmN : –101.5dBm

W : –85.0dBmN : –80.5dBm

W/N5.0mVrms

W/N0.10Vrms

W/N1.40Vrms

W/N1.16Vrms

W/N1.26Vrms

W/N1.04Vrms

如在RF部分进行测量，请连接RF电平表。在RF部分，请使用0.01μF耦合电容。(图中显示获得12dB SINAD所需的SSG输入。)

如在AF部分进行测量，请连接交流电平表。AG被设置成MIC输入从而在1kHz MOD时为3kHz/1.5kHz (宽/窄) DEV。

如在R

Receiver Section /

Transmitter Section /

TK-8100

65

LEVEL DIAGRAM /

To make measurements in the RF section, connect the RF Wattmeter (50Ω).

To make measurements in the AF section, connect the AC level meter.(ANT input : –53dBm, 1kHz FM, 3kHz DEV (Wide)/1.5kHz DEV (Narrow))The AF output level is adjusted for a 0.45V/4Ω by the front panel AF VOL control.

Q406

vel meter.

2dB SINAD.)

TX-RX Unit

Q410

11

Q411

PowerModule

D409

TX-RX Unit

IC502

Audio Frequency

Q500

TX-RX Unit (VCO)

CF1/CF2

450kHz

Q501

IC301

D602 ANT

–5.0dBm 17dBm0dBm 11.5dBm7dBm 25W

W : –93.0dBmN : –91.0dBm

W/N0.34Vrms

W/N0.33Vrms

W/N0.27Vrms

W/N0.31Vrms

W/N0.33Vrms

W/N10mVrms

W/N0.55Vrms

W/N0.45Vrms

14 J1

IC161

12Q251

89 12

4oh

m

10

IC251

7

IC252IC251

5 1

IC251IC251

1113

Q502

21dBm

如在AF部分进行测量，请连接交流电平表。(ANT输入：-53dBm，1kHz FM，3kHz DEV (宽)/1.5kHz DEV (窄))通过前面板AF VOL控制，AF输出电平调节为0.45V/4Ω。

如在RF部分进行测量，请连接RF功率表 (50Ω)。

TK-8100

66

GENERAL

Frequency Range ........................................... 350 to 390MHz

Channels / Groups .......................................... 64CH / 8GRP

Channel Spacing ............................................. Wide : 25kHz Narrow : 12.5kHz

PLL Channel Stepping .................................... 5.0, 6.25kHz

Operating Voltage ........................................... 13.6V DC ±15%

Current Drain .................................................. Less than 0.4A on standby

Less than 1.0A on receive

Less than 8.0A on transmit

Operating Temperature Range ....................... –30°C to +60°CDimensions & Weight .................................... 160 W x 43 H x 107 D mm, 1.0kg

Channel Frequency Spread ............................ 40MHz

RECEIVER (Measurements made per EIA standard EIA/TIA-603)

Sensitivity (12dB SINAD) ................................ Wide : 0.28µV Narrow : 0.35µV

Selectivity ....................................................... Wide : 75dB Narrow : 65dB

Intermodulation............................................... Wide : 70dB Narrow : 60dB

Spurious Response ......................................... 75dB

Audio Output (4Ω, 5% distortion) .................. 4.0W

Frequency Stability ......................................... ±2.5ppm

TRANSMITTER (Measurements made per EIA standard EIA/TIA-603)

RF Power Output ............................................ High : 25W Low : 5W

Spurious and Harmonics................................. 70dB

Modulation ...................................................... Wide : 16K0F3E Narrow : 11K0F3E

FM Noise ........................................................ Wide : 45dB Narrow : 40dB

Audio Distortion .............................................. Less than 3%

Frequency Stability ......................................... ±2.5ppm

SPECIFICATIONS

TK-8100

67

! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK PRMPVMjeò L KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK SQLU ! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKORâeò NOKRâeò !"#$%& KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK RSKORâeò ! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK NPKSs NRB ! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK !"#MKQ^

!"#NKM^ !"#UKM^

!"# KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKPM SM !" KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK NSM=EFQP=EFNMT=EF= =NKMâÖ !"# KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK QMjeò

=Ebf^bf^Lqf^JSMP !F =ENOÇ_=pfk^aF KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKMKOUµs MKPRµs KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKTRÇ_ SRÇ_ KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKTMÇ_ SMÇ_ !"#$ KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK TRÇ_ !"#=EQΩI= !RBF KKKKKKKKKKKKKKKKKKKKKK QKMt !" KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKOKRééã

=Ebf^bf^Lqf^JSMP !F !"# KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKORt Rt !"# KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKK TMÇ_ KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKNShMcPb NNhMcPb !"# KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKQRÇ_ QMÇ_ ! KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKPB !" KKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKKOKRééã

TK-8100TK-8100

2967-3, Ishikawa-machi, Hachioji-shi, Tokyo, 192-8525 Japan

P.O. BOX 22745, 2201 East Dominguez Street, Long Beach,

6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8

Rembrücker Str. 15, 63150 Heusenstamm, Germany

Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium

13, Boulevard Ney, 75018 Paris, France

KENWOOD House, Dwight Road, Watford, Herts.,

Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands

Via G. Sirtori, 7/9 20129 Milano, Italy

Bolivia, 239-08020 Barcelona, Spain

(A.C.N. 001 499 074)16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113 Australia

Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road,

1 Ang Mo Kio Street 63, Singapore 569110

CA 90801-5745, U.S.A.

Kwai Fong, N.T., Hong Kong

WD18 9EB United Kingdom

document copyrights disclaimer

Documents