encompass 2015 building facade restoration project
TRANSCRIPT
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
TITLE SHEET
11 8
1. TITLE SHEET2. KEY PLAN VIEW3. NORTH & NW ELEVATION VIEWS4. SE & NE ELEVATION VIEWS5. SOUTH & SW ELEVATION VIEWS6. SENIOR CENTER ELEVATION VIEWS7. DETAILS8. DETAILS
DRAWING INDEX
2015 BUILDING FACADE RESTORATION PROJECT
1. RIGGINGCONTRACTOR TO PROVIDE ALL LABOR, MATERIAL, PLANT, EQUIPMENT, RENTAL AND ALL ELSENECESSARY FOR THE COMPLETE INSTALLATION OF A TEMPORARY SYSTEM OF SWING STAGESCAFFOLDING, HIGH-LIFT, AND/OR OTHER SUITABLE MEANS NECESSARY TO ACCESS THEBUILDING FACADE AND TO EXECUTE THE WORK ACTIVITIES REQUIRED IN THE SCOPE OF THEPROJECT. CONTRACTOR SHALL HAVE THE FULL RESPONSIBILITY FOR THE DESIGN, SAFETY,INSTALLATION, OPERATION, RELOCATION, FINAL REMOVAL AND ALL ELSE REQUIRED FOR THECOMPLETE EXECUTION OF THE PROJECT. THE CONTRACTOR SHALL PROVIDE THE ENGINEERWITH ACCESS TO THE BUILDING VIA THE CONTRACTOR'S SWING-STAGE, AT TIMES DESIGNATEDIN THE PROJECT MANUAL THROUGHOUT THE DURATION OF WORK.
2. MOBILIZATION/DEMOBILIZATION:PROVIDE ALL LABOR, MATERIAL, PLANT, EQUIPMENT, PERMITS, TEMPORARY UTILITIES ANDFACILITIES, HEALTH AND SAFETY DEVICES AND PROCEDURES, WASTE STORAGE AND DISPOSALFACILITIES AND ALL ELSE REQUIRED AND NECESSARY TO COMPLETE THE WORKCONTEMPLATED HEREIN. WHEN THE PROJECT IS COMPLETED, REMOVE ALL TEMPORARYEQUIPMENT, FACILITIES AND DEVICES FROM THE STRUCTURE AND SITE. RESTORE THESTRUCTURE AND SITE TO ITS ORIGINAL CONDITION TO THE SATISFACTION OF THE OWNER ANDENGINEER.
3. CONTRACTOR IS RESPONSIBLE FOR FIELD VERIFYING ALL DIMENSIONS AND EXISTING CONDITIONSPRIOR TO BIDDING AND/OR PERFORMING WORK.
4. IN THE CASE OF AMBIGUITIES, DISCREPANCIES OR IRREGULARITIES IN THE DRAWINGS, PROJECTMANUAL, MANUFACTURER'S INSTRUCTIONS, SITE CONDITIONS OR APPLICABLE CODES ANDSTANDARDS, CONTRACTOR SHALL REQUEST CLARIFICATION FROM THE ENGINEER BEFOREPROCEEDING.
5. CONTRACTOR SHALL PROVIDE, ERECT, AND MAINTAIN TEMPORARY PEDESTRIAN WALKWAYPROTECTION ON ALL WALKWAYS BELOW WHICH OVERHEAD WORK IS OCCURRING. ALL BUILDINGEGRESSES SHALL REMAIN OPEN & PROTECTED THROUGH THE FULL DURATION OF THE PROJECT.
6. CONTRACTOR SHALL LIMIT STAGING AND STORAGE AREAS TO THOSEAPPROVED BY OWNER. CONTRACTOR SHALL PROTECT ALL PORTIONS OF THE BUILDING,LANDSCAPING, AND PROPERTY IN STAGING AND STORAGE AREAS, AND SHALL REPAIR ALL DAMAGEDCAUSED BY STAGING AND STORAGE TO THE OWNERS SATISFACTION.
7. PARTIAL STRUCTURAL AND ARCHITECTURAL DRAWINGS PERTAINING TO ORIGINALCONSTRUCTION ARE AVAILABLE FOR VIEWING AT ENCOMPASS, INC.
8. ALL WORK SHALL BE PERFORMED IN ACCORDANCE WITH 2007 MINNESOTA STATE BUILDING CODEREQUIREMENTS.
GENERAL NOTES
1515 PARK AVENUE SOUTHMINNEAPOLIS, MN
1. SEALANT REPLACEMENT: EXAMINE ALL SEALANT AND REPLACE DETERIORATED OR FAILED SEALANT JOINTS IN THE FOLLOWINGAREAS: WINDOW PERIMETERS; AROUND METAL PANEL PERIMETERS; AIR CONDITIONING UNIT PERIMETERS; DOOR PERIMETERS;VENT & WALL PENETRATION PERIMETERS; CONTROL JOINTS IN BRICK; JOINTS BETWEEN BRICK & CONCRETE; & ROOF COUNTERFLASHING. REFER TO SHEET 3-6 FOR TYPICAL LOCATIONS OF SEALANT. REFER TO SPECIFICATION FOR BASE BID QUANTITIES &FURTHER INFORMATION. SEE DETAILS 1 & 2 ON SHEET 7
2. INSTALL VERTICAL CONTROL JOINT: SAWCUT BRICK AND INSTALL SEALANT CONTROL JOINT IN THE FOLLOWING LOCATIONS: ATTOPS OF WINDOW BANDS; AT CORNERS OF PENTHOUSE; AT INSIDE CORNER OF GROUND FLOOR ADDITION. REFER TO SHEETS 3-6FOR LOCATIONS OF NEW CONTROL JOINTS. REFER TO SPECIFICATION FOR BASE FOR BASE BID QUANTITIES & FURTHERINFORMATION. SEE DETAIL 4 ON SHEET 7.
3. WIDEN HORIZONTAL JOINTS: REMOVE EXISTING SEALANT, SAWCUT JOINT IN BRICK BELOW SHELF ANGLE, CLEAN ANGLE, ANDINSTALL SEALANT, BACKER ROD, & METAL FLASHING. REFER TO SHEETS 3-5 FOR LOCATIONS. REFER TO SPECIFICATION FOR BASEBID QUANTITIES & FURTHER INFORMATION. SEE DETAIL 5 ON SHEET 7.
4. REPLACE CRACKED BRICK: REMOVE AND REPLACE DAMAGED OR CRACKED BRICKS. SEE SHEETS 3-5 FOR TYPICAL LOCATIONS.REFER TO SPECIFICATION FOR BASE BID QUANTITIES & FURTHER INFORMATION. SEE DETAIL 6 ON SHEET 7.
5. CLEAN AND PAINT LINTEL ANGLES: CLEAN AND PAINT WINDOW LINTELS. SEE SHEET 2-3 FOR TYPICAL LOCATIONS. REFER TOSPECIFICATION FOR BASE BID QUANTITIES & FURTHER INFORMATION. SEE DETAIL 1 ON SHEET 8.
6. BALCONY GUARDRAIL REPAIR: CLEAN & PAINT STEEL GUARDRAIL ASSEMBLIES AT BALCONIES. INSTALL SEALANT COVE JOINT ANDTRAFFIC COATING AT BALCONY EDGE. SEE SHEET 3-5 FOR TYPICAL LOCATIONS. REFER TO SPECIFICATION FOR BASE BIDQUANTITIES & FURTHER INFORMATION. SEE DETAILS 2 & 3 ON SHEET 8.
7. PATCH CONCRETE: REMOVE LOOSE CONCRETE, PREPARE SUBSTRATES, PATCH CONCRETE AND PAINT TO MATCH SURROUNDINGCONCRETE AT THE UNDERSIDE OF BALCONIES AND AT PENTHOUSE FACADES. SEE SHEET 3-5 FOR TYPICAL LOCATIONS. REFER TOSPECIFICATION FOR BASE BID QUANTITIES & FURTHER INFORMATION. SEE DETAIL 4 ON SHEET 8.
8. REPAIR CONCRETE SILLS: INJECT EPOXY AT CRACKS. SEE SHEET 3-6 FOR TYPICAL LOCATIONS. REFER TO SPECIFICATION FOR BASEBID QUANTITIES & FURTHER INFORMATION.
9. REPLACE MISSING METAL SILLS: INSTALL NEW METAL SILLS TO MATCH EXISTING SILLS AT THE LOCATIONS SHOWN ON SHEET 5.REFER TO SPECIFICATION FOR BASE BID QUANTITIES & FURTHER INFORMATION.
10. REPLACE CONCRETE SILLS: REPLACE SILLS AT GROUND FLOOR WINDOWS THAT HAVE MISSING CONCRETE OR SPALLING AREAS.SEE SHEET 6 FOR TYPICAL LOCATIONS. REFER TO SPECIFICATION FOR BASE BID QUANTITIES & FURTHER INFORMATION.
11. TUCKPOINT: TUCKPOINT CRACKED MORTAR JOINTS; REFER TO SPECIFICATION FOR BASE BID QUANTITIES & FURTHERINFORMATION. SEE DETAIL 3 ON SHEET 7.
12. SHELF ANGLE REPLACEMENT: AT DIRECTION OF ENGINEER REMOVE BRICK ABOVE EXISTING DAMAGED SHELF ANGLESIDENTIFIED DURING WORK ITEM #3, SUPPORT BRICK ABOVE, REPLACE DAMAGED ANGLE AS NEEDED, INSTALL FLASHING ANDDRIP EDGE. SEE SHEETS 3-5 FOR JOINT LOCATIONS. REFER TO SPECIFICATION FOR BASE BID QUANTITIES & FURTHERINFORMATION. SEE DETAIL 7 ON SHEET 7.
1. ALTERNATE BID ITEM #1: COMPLETE SEALANT REPLACEMENT: REPLACE ALL SEALANT JOINTS ON THE BUILDING. SEE BASE BIDITEM #1 FOR LOCATIONS AND DETAILS. REFER TO SPECIFICATION FOR BID QUANTITIES & FURTHER INFORMATION.
2. ALTERNATE BID ITEM #2: BALCONY GUARDRAIL REINFORCEMENT: AT DIRECTION OF ENGINEER, WELD STEEL PATCH ONTOSTEEL CHANNEL. REFER TO SPECIFICATION FOR BID QUANTITIES & FURTHER INFORMATION. SEE DETAIL 2 ON SHEET 8.
BASE BID ITEMS
ALTERNATE BID ITEMSA
A
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
KEY PLAN VIEW
22 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
NORTH & NW ELEVATION VIEWS
33 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
SE & NE ELEVATION VIEWS
44 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
SOUTH & SW ELEVATION VIEWS
55 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
SENIOR CENTERELEVATION VIEWS
66 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
DETAILS
77 8
Fax: (952) 854-3126www.encompassinc.com
engineering consultantsforensic analysis
Encompass
Eden Prairie, MN 5534414850 Martin Drive
Tel: (952) 854-4511
CONSULTANTS:
I hereby certify that this drawing was prepared by me or under my direct
Licensed Professional Engineer under the laws of the State of Minnesota.
CERTIFICATION:
Registration Number
Date
supervision and that I am a duly
Signature
Name
Project Number:
Date:
Drawn:
Checked:
Scale:
REVISIONS:
PROJECT:
SHEET TITLE:
SHEET NUMBER:
SHEET OF
03/20/2015
MDT
EKMS
AS NOTED
2015 BUILDING FACADE
RESTORATION PROJECT
1515 PARK AVENUE SOUTH
MINNEAPOLIS, MN
DETAILS
88 8