packaged l series lca/lga · e.t.l. and c.g.a. listed, efficiency rating verified by c.s.a.,...

22
GUK 360 Model 30 Ton Cooling Capacity 260,000-470,000 Btuh Gas Input Heating Cap. 76,800-409,500 Btuh Optional Electric Heat FEATURES Down flow or horizontal supply and return air configuration E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA (LGA), UL/CSA (LCA), and National and Canadian Electrical Codes, developed in accordance with ISO 9002 quality standards Bottom power entry for electric and gas Heavy gauge galvanized steel cabinet, fully insulated, powdered enamel paint finish, large removable access panels, electrical inlets in cabinet base and electric heat end panel (LCA only), easy access control area with factory installed controls, low voltage terminal strip, unit lifting holes in base rail Access panels hinged with tool-less access handles, gaskets on all edges for tight seal, filter and blower access panels have steel panel inner liner with insulation compressed in-between Coil constructed of ripple-edged enhanced aluminum fins on copper tubing, flared shoulder tubing connec- tions, silver soldered construction, factory tested, indoor coil drain connection extends outside of unit cabinet Copeland® Compliant Scroll® compressor for high efficiency, resilently mounted Integrated Modular Control (IMC) - solid sate board contains all controls and control relays to operate unit Tubual heat exchanger of aluminized steel, life cycle tested Aluminized steel inshot burners, direct spark ignition, electronic flame sensor, redundant automatic single or dual gas valve with manual shut-off, induced draft blower, flame rollout switch Outdoor coil fan - PVC coated fan guard furnished Outdoor coil fan motor-overload protected, permanently lubricated, equipped with ball bearings, shaft up, wire basket mount Supply Air Blower belt drive with ball bearings and adjustable pulley for speed change, forward curved blades, blower wheel statically and dynamically balanced Supply Air Motor - overload protected, equipped with ball bearings 70VA transformer with built-in circuit breaker Disposable 2" pleated filters furnished Refrigeration system consists of compressors, condenser coil and direct drive fan, evaporator and belt drive blower, expansion valve with replaceable thermostatic element, high capacity drier, high pressure switch, low pressure switch, full refrigerant charge, crank- case heater, freezestat (prevent coil freeze-up during low ambient operation or loss of air) 1 Year warranty on parts 5 Year warranty on compressor 10 Year warranty on heat exchanger LCA/LGA Packaged L Series

Upload: others

Post on 27-Jun-2020

4 views

Category:

Documents


0 download

TRANSCRIPT

Page 1: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

GUK

360 Model

30 Ton Cooling Capacity

260,000-470,000 Btuh Gas Input Heating Cap.

76,800-409,500 Btuh Optional Electric Heat

FEATURES◆ Down flow or horizontal supply and return air

configuration◆ E.T.L. and C.G.A. listed, efficiency rating verified by

C.S.A., components bonded for grounding to meetsafety standards for servicing required by ETL/CGA(LGA), UL/CSA (LCA), and National and CanadianElectrical Codes, developed in accordance with ISO9002 quality standards

◆ Bottom power entry for electric and gas◆ Heavy gauge galvanized steel cabinet, fully

insulated, powdered enamel paint finish, largeremovable access panels, electrical inlets in cabinetbase and electric heat end panel (LCA only), easyaccess control area with factory installed controls,low voltage terminal strip, unit lifting holes in baserail

◆ Access panels hinged with tool-less access handles,gaskets on all edges for tight seal, filter and bloweraccess panels have steel panel inner liner withinsulation compressed in-between

◆ Coil constructed of ripple-edged enhanced aluminumfins on copper tubing, flared shoulder tubing connec-tions, silver soldered construction, factory tested,indoor coil drain connection extends outside of unitcabinet

◆ Copeland® Compliant Scroll® compressor for highefficiency, resilently mounted

◆ Integrated Modular Control (IMC) - solid sate boardcontains all controls and control relays to operateunit

◆ Tubual heat exchanger of aluminized steel, life cycletested

◆ Aluminized steel inshot burners, direct sparkignition, electronic flame sensor, redundantautomatic single or dual gas valve with manualshut-off, induced draft blower, flame rolloutswitch

◆ Outdoor coil fan - PVC coated fan guard furnished◆ Outdoor coil fan motor-overload protected,

permanently lubricated, equipped with ballbearings, shaft up, wire basket mount

◆ Supply Air Blower belt drive with ball bearingsand adjustable pulley for speed change, forwardcurved blades, blower wheel statically anddynamically balanced

◆ Supply Air Motor - overload protected, equippedwith ball bearings

◆ 70VA transformer with built-in circuit breaker◆ Disposable 2" pleated filters furnished◆ Refrigeration system consists of

compressors, condenser coil and direct drive fan,evaporator and belt drive blower, expansionvalve with replaceable thermostatic element,high capacity drier, high pressure switch, lowpressure switch, full refrigerant charge, crank-case heater, freezestat (prevent coil freeze-upduring low ambient operation or loss of air)

◆ 1 Year warranty on parts◆ 5 Year warranty on compressor◆ 10 Year warranty on heat exchanger

LCA/LGAPackaged L Series

Page 2: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

22 LCA/LGA3602

Model Number Guide

Required Options - Items Must be Ordered and Factory Installed

Optional Accessories - Items Must be Ordered and Factory Installed

� � � � � ��� � � �

�������� ��� �

����������� ��� �� ������ ����������������� �!��"

#���$!������� �!��"

#�����������%�# �& � '���()(������ �!��"

������������*���� +%�����,�������& �-

.�����/�� ����01�2�

. 3���4 ����561��

& ������+5����&-

��������� � �������� �+�7-

�!�������+8�(9(- ��������,::������

&���&����,::������

������������� ������ �� ���:������"��� �����;�%��:��%�%�����;�����2 �1���

���������� ��*�;����<� � 4����=���5���:�� ���� �� 2�

� ��������������� ��*�;�����+5�>��%��4 � �� 2��:��� ���:�� ���� -?

������ ��+�#@�.�;� -���*�;����?

� �8!A<�����!�<����>�1��+$A9(�)!9���7-��������%�:�����5� �; �;�& ��# �B��1�

� ���(<����$)�<����>�1��+�A9$�8�)9)��7-��������%�C�����&����& ��# �B��1�

�� � ����������

8���������������� ��@�� �2��:�����1� �;��:�1���<� �������� ;;�% �������:������:1��� �; C �����

��������� �������� � ��88(�����1�;�: 1�������1��������1���� +#C�B-���� C �����

80��� � �� 2��:��� ��@������������;� �%����A�����8����7�������� � �9

Page 3: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

3

Field InstalledOptional Accessories�� � ����������

!������"������ ������� ��.������ �2��%����� ����<� �1� �;�%��1���� �:�2��%��: �� #$%$&

������������� ������� ��5� � � ������ 1������ ���;�� ����� �;�����:��������;����� '(�)$

���*�������������+,�� �����-����� ��@�1���1��2� ;�; ��� �������2��%�2 ��� �;��1�;���

��� ��:���� �����;1����� �::�����<�2��;� ����:1��� �;���0��%�����.���� ��5�2��%�:������;%��+�'(/'0� ������2 9� +8����-��''�11

���*�������������+,�� �����-����2��3 %��+2'(2/'0��$$�$#

+���-�4��� ��*��� ����� ��;����������1� �;� ��� �;��1�;���� ���; ��� <���1�������������� ���

1���<�������2 ���� <� ������ � <��$������:1������;1� ����� ��������1��������<� ;31 � 2�

�����1��; ������ �����<�; ���� �2��� ��; ����1���<.���� ��*1�;���� ������;��1 ��2���;�;

� � ���� + �2��%-<������� ��;�%��:��%��� �����D� 1 ��; ��� � � �� 2�� + � 2��-<��������:

������"��������� � + �2��%-

%�5+��'(/'0� ��A���2 9� +$(���-�''�1�

+���-�4��������������

#0�&0� +*1�;���-

#0�&1� +4�::���� �-

����6��������� ��C1��� �;����B.��2� �;����1���<�1 ��1�;���� ��� � ���:1��� �;�%����1���

���� 1���1�;���� ������� �1�� �;���������; ������ ������+C1��� �;-

���6��������� ��C1��� �;����B.��2� �;����1���<�1 ;�%����4�����4���� ���������� +44�-

� �� <�1 ����2 �� ��� � ��������������; ������ �����<�;����� �%������1 ��1�;���� ��

:��� ����������� ��; ���� �������1���� �����9� +C1��� �;-

� �3����+������������� ��@;31 � 2����� ���� � ��<� � ��1�;���� ������ ����:��������"���������<������8��E��1�;���� ��

������������+������������� ���%�� ���;� � ����� ���� � �� � ���%� �������2�%�

�1�;���� ��� �;���1��� ��� +%�������� ���% ����� ���-

2���4�������������+,�� �����-����� ��@�1���1��2� ;�; ��� �������2��%�2 ��� �;��1�;���

��� ��:���� �����;1������::�����<�:��;� �� � ��;������1��� ���;1��<�2��;� ����:1��� �;���0��7����

%��+�2'(/'0� ������2 9� +A���-

�''�1$

� �3����������-����������� ����� ��� �

; ��� <��� ����(E��1�;���� ��<� �� � �� � ���1���

� 2����.���� ��*1�;���� ������;��1 ��2���;�;

� � ���� + �2��%-���0��7����

� ��-�������������� ��# ��;����<� ;31 � 2��1�;���� ��<� :1������;1� ����� ��������1���; ���

�����<���1��������������

%�����'(/'0� ��!���2 9� +�)���-��''�1(

�� ������������ ������;�; ��� <� ;31 � 2�

:�D;��� �������1�;���� ��%����'(/'0� ��((��2 9� +�(���-� +''�0&

� �3��������2��3� ��/61��;�%�����@/,.4����!�,������"�<��@*@4����!� �;��@*@4.����!

*1�;����@���4 ����5����� <�:����� � 2�� �1���1��� ��:� �� ���:���� �:1��� �;���0��7����

%���2'(/'0� ��((��2 9� +�(���-�:����� �"?+(-8!�D��(�D�8� ��9� +$�!�D�!�(�D��(-

�''�1#

"�����+,�� ������ �� B� � �� �D��� �����1����:��;�%��:��%� ����� ���� ������%����������"�

������<������; �D� 1 �� ����� 1�����:<

��������;�����1��%�����1��� ���; ��� � �

��� ;� �;� 1����� ���2��%�� � ���� ����<�: �

�1� �%����1�;���� ���; ��� � ��(�E����

+ ;31 � 2�-<������� � ������ ;�������;<� ��

� 2���� �;����;�� ���;����� ����1���

.�;��01�2��+0��7����-

%�"+�'(/'0� ��AA��2 9� +$(���-���������������''�1'

$!���������''�1) ()(��������''�17

4� 9��� ��9� +��-��0�9�>� ; +�-����+(��-���(

��� �� ������1�����:��+�� - 8�<����+!�$�-�F�����9�%��+���@-

.�����&�� ��%�� +7- +�-�8���+�$A-

��� ��7 �� � B��1� 88�(

�-�8����������� �����������������<� �� � ��;��� 1����� ��� �����������1��� ��� ���������2���

�����

� ���� #0��)

5�� � #0��'

Page 4: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

44 LCA/LGA3604

Optional Accessories

���� ��������

���������� ������������ ������������� ����� � ��� ������������� ������� �������������� �� ��

���������� ������ ��� ���������������� ������� �� ���� �������� ���������� � � �� ����������������������������� ������� �������������

�� ��

����������� ����� � �� �������� ����� ����������������������� �� ��

��������� �� ���������������� ������� ��������� ������ �����������!��� ���������������������������������� �� ���� ����� ����"�����������#�� �� ������������"���� ��������� ���#������ �� ��$������������������������� ������������ �%���

���������� ������������ ������������� ���!��� ��&'(������ ")*+�,�#

"�� ��#

$���%� �� ��!���������������$���!��� ��&)&������ ")++�,�#

"�� �&#

����������"�����'���������#� ��-����� ������������ ��� ����� ������������ �������������������� ����� ��� ���������������������������� ������ ����������� ������ �

���� ��!��� ��+.������ "'*�,�#"�� ��#

(�������)�����'�"�*�#������� ��/��� �����01����������� �� �� 2� ��� ��/���������� ���� "2/�#������������ ��3�� �������������������� ���

�+,��

(�������)�����'�����������������-�.� �� ������� ����� ������� 2������ ���4���� ��5���� /�,&�

�0�!0������ ���� �� �����������������6� ���� ��������� ��������� ��6�� &1�1�� "1�,� ���7����#

�����2������3�$�4�� ��������� ���������������� �� ���� ��-�5���� ������8���������� ��� ���� ��������������,���,���������� �%���

)&������"'.9���#����� ���2$1�!���1&� ��)9:������ "('�,�#

"1� �+#

1&������"9):���#����� ���2$1�!����&

11:������ ")::�,�#�"1� ��#

�����2������3�$�4��"���5�����#� ��������� ��������������� �� ����� ������� ����� ���������������� ������� ��� "���#������������������,���,��������� ���������������� ������������� ��������������������������������87����������� ���8 ���� ��������;� ����������� %���

':������"(91���#����� � "���������������� ����#���2$���!�����

&&.������"1:1�,�#� "�� +/#

&)������"):&)���#����� � "�������� ��������� ����#���� ���� �����������������

�7����� �

���2$���!���&1(1.������"'1*�,�#� "�� �&#

�����2������3�$�4��"���5�����#� (���������� ��� ���������� � ��� ������������� ������������ ���������

':������"(91���#������ +� ��

&)������"):&)���#������ +� ��

���5���������������0����� ��� ��87��������������� ���������� ������� �������� ������������ ������������ ������������ ��� ������������������������������� ����!�� ������� ������ ��������� �������� ���� ��������������������� ������������������������� �%���

�� &�� ��&'������ "1:�,�#

6���7���6����8.�������� ��� �� ��!���� ������������ ��������������� �"6� �/�����0���# "&����#

8��7��7������"8��#� �����!������������������ ��� ��������������� �� ������� ������������� � ���� ���� ����� "&:��9:��*:�����)1:�,%#�������� ���� ������ �������������������������������7�����<�� ������ ���� ����/������=���>���,�����$�������>���,�"6� �/�����0���#

5�<�� ������ �?� ��$����

8��7��7�������������2����� ��87������� ��&.�9:��*:�����)1:�,%��� ������ ��������������� ������������� ����� ��� 6� �/�����0����5�0� �����

<�� ������ � ���������$���8��7��7������$����9��7:� ��87������� ���� ������ ������ ������������������

8��7��7������� 9�� �4�����9��7:� ��87������� ���� ������

Page 5: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

5

Specifications��� ����� �����������

��������/ ����

#�� ���������� � ����� ��>�1�� +�7- �((<���� +8�$9�-80����������� � ����� ��>�1�� +�7- ��!<���� +A�9$-

��� ������� ��%�� +�7- ��9!8,,/� +>�1��7 ��- 8�9�8B���� �;�� ��� �� ;� �1� +>�1��7 ��- 8�9$

/:���� ����� ��

C1��� �;� +&�C����-

����1��� 8 8�� �2 9����"9�+�98!���-

����1��� � 8�� �2 9����"9�+�98!���-

����1��� � 8�� �2 9����"9�+�98!���-

�%��5� ��& ����

� � ����� +0 �1� �� ��

��#����� ��# �+ ��5

���-

.�;��0�9 �#@�!�&

& �� B��1�� ��� 5� �; �;� +5- &����+&-

B��1��+��%-� ��>�1�� +�7- 8!A<���� +$A9(- ��(<���� +�A9$-

*1��1��+��%-� ��>�1�� +�7- 8�(<���� +�A9!- �$$<���� +)89(-

B��1�� +&���-� ��>�1�� +�7- �!�<���� +)!9�- $)�<���� +8�)9)-

*1��1�� +&���-� ��>�1�� +�7- ���<���� +!�9A- �)!<���� +88�9�-

@9#9@��9#9@9� ���� ��,::������ ��9�E

# �51�������������� ����� �� ��9�0 �1� �� ��� ��#����� � 8

/�����;;�# �51����

�� 1�� ��%�9� ��9� +�� -

0 �1� � )� +89)-

��#����� � 88� +�9)-

,� ��� ����>��%�� �;

4����5������

>��%��%��� ����� �� ;� 9� D�%�;�������9�+��- +�-� 8��G�8(� +$()�G���8-

(���� +�9)��7-�.�����H�4���

0���� ���������1��1�� �� ��� +�7- (� +�9)-

. D9� 1 2���������1��1�� �� ��� +�7- (9)(� +$9�-

��� ��H��� ��������<� $!������()(�� �� ���

+4��������I-�/�.�� �� +8-�!!���8����� +�-� ))��A!(

)9(���� +(9!��7-�.�����H�4���

0���� ����������� ��%�� +�7- )9(� +(9!-

. D9� 1 2���������1��1�� �� ��� +�7- �9!� +!9$-

��� ��H��� ��������<� $!������()(�� �� ���

+4��������I-�/�.�� �� +�-�)8(�������� +$-� ))��A!(

8����� +)9(��7-�.�����H�4���

0���� ���������1��1�� �� ��� +�7- 8�� +)9(-

. D9� 1 2���������1��1�� �� ��� +�7- 889(� +�9!-

��� ��H��� ��������<� $!������()(�� �� ���

+4��������I-�/�.�� �� +�-�)8(�������� +(-� �(��8�$(

,� ��� ��������

0��: �� � ��� 69� :�9� +��- ��9�� +�98-

�12�;� ���� �� ��9� +��-�H�0�9��:���% ����+A9(-� �� � ����+A9(-� �� �

C�� ���� ����� +�- 8$�+((8-

4� ��� ������������9�H� �"�����9� +��-�:�� +8-� 8�+�(-

,D� � ����;���� ��� ����� � ���� ,D� � ���� ��

���;� ������

0��: �� � ��� 69� :�9� +��- )�9!� +!9!-

�12�;� ���� �� ��9� +��-�H�0�9��:���% ����+A9(-� �� �

C�� ���� ����� +�- 8!�+!��-

���;� �� C �

4� ���� �� ��9� +��-�H�0�9��:�2� ; +!-� �$� +!8�-� �� �

��� ��@�����1�� ���:�� +�� - �8<(���+8�<8$(-

.����� ��� ��%�� +7- +!-� 8���+�$A-

.����� ��� 8�)(

��� ��.�����% �� �8)�

C���� �+:1��� �;-�����:� :���� 4� �� 2�<�������� ���� ;<��� �;

0�9� �;� �"�����9�+��- +8�-����D����D��� +(��� D� (��� D� (8-

,������ �� �� � ���� ��� ��������<�$!������ ()(����!�����"����� �� 8� �;� �����;����� � ����1;;���� @/B�5� �; �;��$���!�J� A(KC�+�(K�-��1�;���� ������� �1�� �;���KC�+�)K�-�;2�!)KC�+8AK�-�%2� �������� ��� ���� ��J� �����1��D��� ��;1��

� ������ 1�9�B���� �;�� ����� ;� �1�� �;� �� ��KC�+�)K�-� �1�;���� ��� ���� �1�9�� ������� �� ������1�� �;� � ��� � ������ 1���61����� � ;������:����2��%����:��� ��� � 2� ����� �;������� �1��1���61��;9�. D��1��1 2���1��1���:������

:1��� �;� �� ��%�9�B��� � ; <������ ���������1��1�� � � � ��� D��1��1 2���������1��1�9�B:������ ��:����� � 2���1��1�� �� 1 ;<�2� 1��������%��������� �����: ����

����� ���� � �1����;���� ���������� ��� �9

0*�,� �� 0��� � ���������1; �� ��� ���� 2��%��������� ��;;1�����9�#�� � � � �����;� ���������1;�� ��� ����2��%��������� ��;;1�����9

Page 6: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

66 LCA/LGA3606

Weight Data

High Altitude Derate (LGA Models)

����������� �������� ������������ ��� ����!����" ��#����$����% �� �� � % ��&��'������������"�(���������

������� �����% �!����" ��#����$)������������ �� *�� ��������('�+�������"���� * ���* ���'�&����

���� �� ��&����� ���,'�������' � ����� *������� �� *�� �"�*��' � �������

������� ���"��� #�$ ��������"����-* ���* ��� ����&�+��#.-�$

���8��������+!8����A8(- �9!� +�9A�-

���8���$����+A8(���8���- �9(� +�9�)-

$��8���(����+8������8(�(- �9$� +�9�(-

(��8���!����+8(�(���8���- �9�� +�9��-

!��8���)����+8�������8�(- �9�� +�9��-

)��8��������+�8�(����$$�- �98� +�9))-

��� ����� / �(*� ����0 �+'�

���� .+

.���9������

��@�!�& 0��%����� +> �����- ���� 8$!8

�#@�!�& 0��%����� +> �1����%���� � �; �;�:���� ��D�� ���- ���� 8(8�

��������9������

��@�!�& > �1��� �$�� 8((!

��@�.�;� ,�������& �� + ;;����> �����- )� �(

�#@�!�& > �1����%���� � �; �;�:���� ��D�� ��� �($� 8!�!

�#@�*��� &����C���& �� ,D�� ���� + ;;����> �1���- �� 8�

Page 7: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

7

Electrical Data��� ����� �����������

�������� ��; � ���!��&"������� �������� $!�� ()(�

����� ��

0�9��:������ �� �

/ �;��� ;� �� � ���+��� �- ��98� +A�9�- 8(9(� +$!9(- 8�98� +�!9�-

����;������� �� � ���+��� �- ��(9�� +!)(9�- 88$9�� +�$�9�- ��9�� +�$�9�-

���;� ��C �

.����

0�9��:������ !

C1����� ;� �� � ���+��� �- �9$� +8$9$- 89�� +)9�- 89�� +!9�-

����;������� �� � ���+��� �- $9)� +��9�- �9$� +8$9$- 89A� +889$-

,� ��� ����>��%�

.����

.����

*1��1�

�� ( )9( 8� ( )9( 8� ( )9( 8�

�7 �9) (9! )9( �9) (9! )9( �9) (9! )9(

C1��� �� ;� �� 8!9) �$9� ��9� )9! 88 8$ !98 A 88

����;������� �� 8�( 8(� 8A� $(9! !! �$ �!9! ($ !!

/�9�� D9�:1 � �"

+ �� -

7����,D� 1 ��C � 8(� 8(� 8)( �� �� A� !� !� )�

� �,D� 1 ��C � 8(� 8(� 8(� �� �� �� !� !� !�

L.����1������1��

@�� ����

7����,D� 1 ��C � 8�) 8$$ 8(8 )� )$ )) (( (� !�

� �,D� 1 ��C � 8�A 8�) 8$$ !! )� )� (� (( ()

*����� ����%�

,D� 1 ��C �

+0�9-�&�� ��%�� +7- +�-�8���+�$A-

C1����� ;� �� �+��� �- )9� �9A �9�

����;������� �� �+��� �- 8$98 )9� (9)

5�����*1���� +�-�88(������#C�B� + ���� ����- 8(

L/:�����0 ���� �� ���� � ;� ��,������ ����;�� �1 �� ��� ;������%��<� :1 � �;�;� ������� �"� �61����� 9

0*�,���,D��� ��:���� ����� � ��� ����1 � �;����1 �8�E��:��������� �9

0*�,� ��7����1����� ;� �����D�;�8��� �� <�&@�/� ��������1��� 2� ���� ��2�1 ;���� �� ���:� :1 � +�959�����-9

Page 8: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

88 LCA/LGA3608

Optional Electric Heat Accessories - LCA Models�������� ����� �������

,�������& �.�;��0�9 ,&@�+ �,�������& ��4 � �� 2� �:��� ;;����� �� ��:��� ����-

�7�B��1��/ �� ���$(�!��A��8��

,�������& ����������.�;1��+$(<�!�<�A��H�8����7- 8(=8��+��������-<�8(=A��+$!��-<� 8(=A��+()(�-

�����C1 �>����

+���� -

9������%�

,D� 1 ��C �

�����������(����+�9)��7- �(=�8

$!�����(����+�9)��7- �(=�$

()(����(����+�9)��7- �(=8$

�����������)9(����+(9!��7- �(=�8

$!�����)9(����+(9!��7- �(=�$

()(����)9(����+(9!��7- �(=8$

�����������8�����+)9(��7- �(=��

$!�����8�����+)9(��7- $��!�

()(����8�����+)9(��7- �(=��

9���� ����%�

,D� 1 ��C �

�����������(����+�9)��7- �(=�8

$!�����(����+�9)��7- �(=�$

()(����(����+�9)��7- �(=8$

�����������)9(����+(9!��7- �(=�8

$!�����)9(����+(9!��7- �(=�$

()(����)9(����+(9!��7- �(=8$

�����������8�����+)9(��7- �(=�8

$!�����8�����+)9(��7- �(=�$

()(����8�����+)9(��7- �(=8$

%:!��+%+:5��2+�:�:+5��.�%�!%��� ����>��8)(� �'(�17 �8)(� �� <���>����(��'(�10 ���(� �� �+/61��;�:������� �7B�&*��

;� �����������1���2� ���21��7B�&� �������������%�� �1��-

��>������� �

>����� +���� -

�����.�;��0�9 ��@�!�&

����7�L���������

���

(����+�9)��7- ��=)(

)9(����+(9!��7- ��=)(

8�����+)9(��7- ��=)(

$(��7�L���������

���

(����+�9)��7- ��=)(

)9(����+(9!��7- ��=)(

8�����+)9(��7- ��=)!

!���7�L���������

���

(����+�9)��7- ��=)(

)9(����+(9!��7- ��=)!

8�����+)9(��7- ��=)!

A���7�L���������

���

(����+�9)��7- ��=)!

)9(����+(9!��7- ��=)!

8�����+)9(��7- ��=)!

8����7

L������������

(����+�9)��7- ��=)!

)9(����+(9!��7- ��=)!

8�����+)9(��7- ��=)!

L0*�,� ��@��� $!��@04�()(��0B��*��@#,5��5,���>��8)(� +��=)(-��,/.B0@��>�*�=9

Page 9: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

9

Optional Electric Heat Data - LCA Model(Requires unit fuse block, terminal block and sub-fuse box)

.0�1�2

3 4��* �

5� (�*�(�� ��

��� �����

#� �"������ $�6

� ��0 �+'�

���

�"�1� �

7����

�� ��

.0

�� ��

8��'

9�� ��

,���������)�-�& *�5:'�����;�������

5� (�*�(�� ���<����������*(������ �(���

=�'

#��>�.0$

>�=�'

#=���.0$

��'

#>�=�.0$

����7

+8-�+2�'0(*#7����������&&;��

$!��� �&&;�) ()(�� �&&;�0

�;�+8-�+2�'0(�*#7����������&&;�'

$!��� �&&;�7 ()(�� �&&;�1 (A��2 9� +�)���-

+��� ��%����-

8 ��� ��9( )!<���

8�) 8$$ 8(88 ��� �(9� �!<���

8 ��� �)9( A�<A��

8 �$� ��9� 8��<$��

8 $$� �(9� �!<���

)� )$ ))8 $!� �)9( A�<A��

8 $�� ��9� 8��<$��

8 ((� �(9� �!<���

(( (� !�8 ()( �)9( A�<A��

8 !�� ��9� 8��<$��

$(��7

+�-+2�'0(*��<7��������� �&&;�$

$!��� �&&;�& ()(�� �&&;'( )!��2 9� +�(���-

+��� ��%����-

LL� ��� ��9� 88(<��� 8$) 8() 8!(

LL� ��� �)9� 8�A<���

8!( 8)( 8��LL� ��� $89� 8$8<���

LL� �$� $(9� 8(�<!��

LL� $$� �)9� 8�A<���

�� �! A�LL� $!� $89� 8$8<���

LL� $�� $(9� 8(�<!��

LL� ((� �)9� 8�A<���

!! !A )�LL� ()( $89� 8$8<���

LL� !�� $(9� 8(�<!��

!���7

+�-+2�#7(*'(��������� �&&;(1

$!��� �&&;($ ()(�� �&&;(& )!��2 9� +�(���-

+��� ��%����-

LL� ��� $(9� 8(�<!�� 8(( 8!$ 8)�

LL� ��� (�9$ 8)�<���

8)$ 8�$ 8A�LL� ��� ((98 8��<���

LL� �$� !�9� ��$<���

LL� $$� (�9$ 8)�<���

�) A8 A(LL� $!� ((98 8��<���

LL� $�� !�9� ��$<���

LL� ((� (�9$ 8)�<���

!A )� )(LL� ()( ((98 8��<���

LL� !�� !�9� ��$<���

0*�,� ��*�;�� +8-� �:� ���� ��� ��%������ ��1��� ��� �"� �61��;9

0*�,� ��*�;�� +�-� �:� ���� ��� ��%������ ��1��� ��� �"� �61��;9

L/:�� ���0 ���� �� ���� � ;� ��,������ ����;�� �1 �����;������%��<�:1 � �;�;� ������� �"��61����� 9�� �%�� � 1�� 2�� :��� �� � ��8!)KC� +)(K�-9

LL. ��2�1 ;�%���� �%�� � ���������9

0*�,� �� �,�������& ����������.�;1���61��;����$(<�!�<� A��H�8����7� �" � ����9

0*�,� �� C1 �2������1 ��2���;�;�D�� 9� C1 �2������1 ��2��� � ��;� ���:��;� �� � ��;� � �� 9�@� �� �61�� ���>������� ��>����9�5�*����� �� ,������

& ��@�� ��� � � 2� 9

Page 10: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

1010 LCA/LGA36010

(Requires unit fuse block, terminal block and sub-fuse box)

Optional Electric Heat Data - LCA Model

.0�1�2

3 4��* �

5� (�*�(�� ��

��� �����

#� �"������ $

6�� ��0 �+'�

�����"

1� �

7����

�� ��

.0

�� ��

8��'

9�� ��

,���������)�-�& *�5:'�����;�������

5� (�*�(�� ���<����������*(������ �(���

=�'

#��>�.0$

>�=�'

#=���.0$

��'

#>�=�.0$

A���7

+�-+2�#7(*)7��������� �&&;#(

$!��� �&&;## ()(�� �&&;#� �$��2 9� +�����-

+��� ��%����-

LL� ��� !)9! ���<)�� �8� ��) ��(

LL� ��� )(9! �(�<���

�$! �(! �!$LL� ��� ��9) ���<���

LL� �$� A�9� ��)<8��

LL� $$� )(9! �(�<���

8�� 8�) 8�8LL� $!� ��9) ���<���

LL� $�� A�9� ��)<8��

LL� ((� )(9! �(�<���

A� 8�� 8�$LL� ()( ��9) ���<���

LL� !�� A�9� ��)<8��

8����7

+�-+2�#7(*0(��������� �&&;#'

$!��� �&&;#) ()(�� �&&;#7 A���2 9� +$(���-

+��� ��%����-

LL� ��� A�9� ��)<��� ��� ��A �A�

LL� ��� 8��9� �$$<���

�8� ��� ��(LL� ��� 88�9� �)!<8��

LL� �$� 8��9� $�A<(��

LL� $$� 8��9� �$$<���

8(A 8!� 8!)LL� $!� 88�9� �)!<8��

LL� $�� 8��9� $�A<(��

LL� ((� 8��9� �$$<���

8�) 8�� 8��LL� ()( 88�9� �)!<8��

LL� !�� 8��9� $�A<(��

0*�,� ��*�;�� +8-� �:� ���� ��� ��%������ ��1��� ��� �"� �61��;9

0*�,� ��*�;�� +�-� �:� ���� ��� ��%������ ��1��� ��� �"� �61��;9

L/:�� ���0 ���� �� ���� � ;� ��,������ ����;�� �1 �����;������%��<�:1 � �;�;� ������� �"��61����� 9�� �%�� � 1�� 2�� :��� �� � ��8!)KC� +)(K�-9

LL. ��2�1 ;�%���� �%�� � ���������9

0*�,� ��,�������& ����������.�;1���61��;����$(<�!�<� A��H�8����7� �" � ����9

0*�,� �� C1 �2������1 ��2���;�;�D�� 9� C1 �2������1 ��2��� � ��;� ���:��;� �� � ��;� � �� 9�@� �� �61�� ���>������� ��>����9�5�*����� �� ,������

& ��@�� ��� � � 2� 9

Page 11: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

11

Cooling Ratings

5�� *��+

0 �

8���

, � �

,�������*

7����

9�����*���*�, � *���* �5�� *��+�9�����*�����

�=?;�#@?�$ >=?;�#!A?�$ @=?;�#!B?�$ B=?;�#�=?�$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

4���>1�2 4���>1�2 4���>1�2 4���>1�2

("� ��� �>�1� �7)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK�

!�KC

+8)K�-

A��� $�(� ��$9( !�9) 8�9�) 9!( 9)A 9A� ��)9� !!9� 8$98A 9!( 9�� 9A( ���9� !$9) 8(9!� 9!! 9�� 9A! �8�9� !�9( 8)9�A 9!) 9�� 9A�

88��� (��( �$�98 )89� 8�9�( 9!A 9�) 89�� ��!98 !A9� 8$9�� 9)� 9�� 89�� ���9) !)9� 8(9�( 9)� 9A� 89�� ���9A !$9) 8)9(( 9)� 9A� 89��

8�$�� !��( �$A9A )�9� 8�9�8 9)( 9A$ 89�� �$�9� )89� 8$9(� 9)! 9A( 89�� ��(9� !�9A 8!9�8 9)� 9A) 89�� ��)9$ !!9! 8)9)� 9)A 9A� 89��

!)KC

+8AK�-

A��� $�(� �$�9� )�9A 8�98) 9(8 9!� 9)( �$89( )�9� 8$9$� 9(8 9!� 9)! ���9A !�9( 8(9A) 9(� 9!$ 9)� ��(9) !!98 8)9!� 9(� 9!( 9��

88��� (��( �(!9( )(9� 8�9�( 9($ 9!) 9�� �$�9) )�9A 8$9!! 9($ 9!� 9�( �$�9! )�9( 8!98( 9(( 9!A 9�! ���9� !�98 8)9�( 9(( 9)8 9��

8�$�� !��( �!89� )!9) 8�9$� 9(! 9)� 9A� �(�9A )$9$ 8$9)� 9() 9)$ 9A� �$(9! )�9� 8!9�! 9(� 9)( 9A$ ��!9� !A9$ 8)9A! 9(� 9)) 9A!

)8KC

+��K�-

A��� $�(� �!$9$ ))9( 8�9(� 9�A 9(� 9!� �(!9) )(9� 8$9�$ 9�A 9(� 9!8 �$�9( )�9� 8!9�$ 9�A 9(� 9!� ��A9� )�9� 8�9�$ 9�A 9(8 9!�

88��� (��( �)�9� )A9) 8�9)� 9$� 9(� 9!( �!�9� ))9� 8(9�� 9$� 9(� 9!! �((98 )$9� 8!9(� 9$� 9(� 9!) �$(9A )�98 8�9�� 9$� 9($ 9!�

8�$�� !��( �))98 �89� 8�9�� 9$8 9(( 9)� �!�9( )�9) 8(98! 9$8 9(! 9)8 �(A9) )!98 8!9!$ 9$8 9() 9)� �(�9� )�9$ 8�9�� 9$� 9(� 9)(

LCA/LGA360 - High Efficiency - Two Compressors Operating

LCA/LGA360 - High Efficiency - All Compressors Operating

5�� *��+

0 �

8���

, � �

,�������*

7����

9�����*���*�, � *���* �5�� *��+�9�����*�����

@=�;�#!B��$ B=�;�#�=��$ �=�;�#A��$ =�;�#A���$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

,����

������+

�� �(���

���

����*

.0

�� ��

1 ����� � ��

,�����3����

#1�,$

4���>1�2 4���>1�2 4���>1�2 4���>1�2

("� ��� �>�1� �7)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK��>�1� �7

)(KC

�$K�

��KC

�)K�

�(KC

�AK�

!�KC

+8)K�-

A��� $�(� ��)9! A�9A ��9(A 9!A 9�� 9A) ��!9� A(9( �!98) 9)� 9�( 9A� �8�9) A89A �A9�) 9)8 9�) 89�� ���9$ ��9� ��9�! 9)� 9�A 89��

88��� (��( �$A9) 8��9( ��9�! 9)$ 9A8 89�� ��)9) AA9� �!9$8 9)( 9A� 89�� ��$9A A(9� �A9�� 9)) 9A( 89�� �889� A89� ��9!! 9)A 9A) 89��

8�$�� !��( �(A9! 8�(9$ �$9�A 9)A 9A) 89�� �$)9) 8�89A �!9!$ 9�8 9AA 89�� ��(9� A�9� �A9(A 9�� 89�� 89�� ��89� A$9� ��9A$ 9�( 89�� 89��

!)KC

+8AK�-

A��� $�(� �()9! 8�$9� �$9�$ 9($ 9!! 9�� �$(98 8�898 �!9!8 9($ 9!) 9�8 ��89) A)9� �A9($ 9(( 9!� 9�� �8)9$ A�9� ��9�� 9(! 9)� 9�(

88��� (��( �!)9A 8�)9� �$9�8 9() 9)8 9�� �((9� 8�$9� �!9�) 9() 9)� 9�A �$898 8��9� �A9)! 9(� 9)$ 9A� ��(9A A(9( ��9�� 9(A 9)! 9A$

8�$�� !��( �)(9! 88�98 �$9$� 9!� 9)) 9A( �!�98 8�!98 �)9�� 9!8 9)A 9A! �$)9� 8�89A �A9A) 9!� 9�8 9A� ���9� A)9$ ��9�� 9!� 9�� 89��

)8KC

+��K�-

A��� $�(� ���9� 8889$ �$9!� 9$� 9(� 9!$ �!!9) 8�)9( �)98! 9$8 9(� 9!( �(�9( 8��9� ��98� 9$8 9($ 9!! ��)9� A�9� ��9$8 9$8 9($ 9!�

88��� (��( �A�98 88$9� �$9�! 9$8 9(( 9!A �)!9� 88�9� �)9$� 9$� 9(! 9)8 �!89$ 8�(9A ��9�8 9$� 9() 9)� �$(9$ 8�89� ��9!8 9$� 9(� 9)$

8�$�� !��( �A)98 88!9$ �(9�! 9$� 9(A 9)( ���9) 88�9� �)9(A 9$� 9!� 9)) �!)9� 8�)9! ��9(� 9$� 9!8 9)A �(�9( 8��9) ��9�� 9$$ 9!� 9�8

Page 12: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

1212 LCA/LGA36012

Blower DataBLOWER TABLE INCLUDES RESISTANCE FOR BASE UNIT ONLY WITH DRY INDOOR COIL &

AIR FILTERS IN PLACE.

FOR ALL UNITS ADD:

1 - Wet indoor coil air resistance of selected unit.

2 - Any factory installed options air resistance (heat section, economizer, etc.)

3 - Any field installed accessories air resistance (duct resistance, diffuser, etc.)

Then determine from blower table motor output and drive required.

See page 14 for wet coil and option/accessory air resistance data.

MINIMUM AIR VOLUME REQUIRED FOR USE WITH OPTIONAL ELECTRIC HEAT - 10,500 cfm (4955 L/S)

��*

7����

("�

#���$

1����(�-* ���* �5:� *�������������� ��(' ��0�� *����+ �#-�$

�!��#=�$ �A��#��$ ����#=�$ �@��#!��$ ����#!=�$ �!��#���$ �A��#�=�$ ����#A��$ �@��#A=�$ !����#AB=$ !�!��#=A=$ !�A��#=B=$ !����#�A=$

3-�8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$3-�

8�-

#.0$

)(��

+�($�-���

����

������

����

�������

�� �

�������

����

�����!!�

�9)�

+�9�8-)8(

�98(

+�9�(-)!(

�9!�

+�9!A-�8�

$9�

+�9A�-�((

$9$(

+�9��-�A(

$9A�

+�9!!-A�(

(9�(

+�9AA-A)(

(9�(

+$9�(-8�8�

!9��

+$9)�-

����

+�))(-� �

����

�� ���

����

�������

����

��������

����

��� �!!(

�9A(

+�9��-)��

�9$(

+�9()-))�

�9A�

+�9A8-�8(

$9�(

+�9�(-�!�

$9�(

+�9!�-A��

(9��

+�9A(-A$�

(9)(

+$9�A-A��

!9��

+$9)�-8�8(

!9)(

+(9�$-

�(��

+$�8�-��

���

������

�� �

�������

����

��������

����

���� !)(

�9��

+�9$!-)�(

�9)(

+�9��-))(

$9��

+�98�-���

$9)�

+�9(8-�!(

(9��

+�9��-A�(

(9)�

+$9�(-A$(

!9��

+$9!�-A�(

!9)(

+(9�$-8���

)9�(

+(9$8-

A���

+$�$(-��

����

���� �

����

��������

����

��� ���

����

�����!�(

�9!�

+�9!A-)�(

$98�

+�9�!-)�(

$9!�

+�9$�-���

(98�

+�9��-�)�

(9!�

+$98�-A8(

!98(

+$9(A-A((

!9)�

+(9��-AA�

)9��

+(9�)-8��(

)9)�

+(9)$-

A(��

+$$�(-��

����

��������

����

��������

�� �

��������

���

����!A�

�9A�

+�9A8-)$(

$9(�

+�9�!-)A�

$9A(

+�9!A-��(

(9(�

+$98�-���

!9�(

+$9(8-A��

!9!�

+$9A�-A!�

)98(

+(9��-AA(

)9)�

+(9)$-8��(

�9��

+!98A-

8�<���

+$)��-�

����

��������

����

��� ����

����

���� ��

����

�����)��

$9��

+�9�8-)(�

$9�(

+!9$A-���

(9$�

+$9��-�$(

(9A(

+$9$$-��(

!9(�

+$9�(-A�(

)9�(

+(9�!-A!(

)9!(

+(9)8-8���

�9��

+!98�-8�$�

�9�(

+!9!�-

8�<(��

+$A((-��

����

��������

�� �

������ �

����

��������

���

�����)8�

$9)�

+�9��-)!�

(9�(

+�9A�-��(

(9��

+$9��-�(�

!9$�

+$9))-�A(

)9��

+(9��-A�(

)9!�

+(9!)-A)�

�98(

+!9��-8�8�

�9��

+!9(!-8�$(

A9$�

+)9�8-

88<���

+(8A�-��

����

��� ��

����

�������

����

��� �!!(

$9$(

+�9��-)��

(98�

+�9��-)!(

(9!!

+$9��-�8(

!9��

+$9)�-�!�

!9A�

+(98(-A��

)9(�

+(9!�-A$�

�98�

+!9�$-A��

�9)(

+!9(�-8�8(

A9�(

+!9A�-�� ��

88<(��

+($�(-��

�� �

��������

����

���� ���

���

�����!)(

$9�(

+�9!�-)��

(9((

+$98$-))(

(98�

+$9((-���

!9)�

+(9��-�!(

)9$�

+(9(�-A8�

�9�(

+!9�8-A$(

�9!(

+!9$(-A�(

A9��

+!9A$-8���

A9A(

+)9$�-�� ��

8�<���

+(!!(-���

����

�������

���

��� ����

���

����!�(

(9��

+�9A(-)$�

!9��

+$9$�-)�(

!9!�

+$9A�-���

)9�(

+(9$8-�)(

)9A(

+(9A�-A8(

�9!�

+!9$�-A((

A9�(

+!9A�-AA(

A9A(

+)9$�-8���

8�9!�

+)9A8-�� ��

8�<(��

+(A��-���

����

��������

���

�������

����

�����!A(

(9)(

+$9�A-)(�

!9(�

+$9�(-)A(

)98�

+(9��-�$�

)9��

+(9��-��(

�9((

+!9��-A�(

A9��

+!9�!-A!(

A9A�

+)9�A-8���

8�9((

+)9�)-8��(

889�(

+�9�A-�� ��

8�<���

+!8�(-���

���

������ �

���

��������

����

���)8�

!9�(

+$9!!-)!�

)9��

+(9��-��(

)9!(

+(9)8-�(�

�9(�

+!9�)-�A�

A9�(

+!9)(-A��

A9)(

+)9�)-A)�

8�9(�

+)9��-8�8�

889��

+�9$�-�� �� �� ��

8�<(��

+!�)�-��

��

��������

����

��� �!!(

!9��

+$9$�-)��

!9)(

+(9�$-))�

)9(�

+(9!�-�8(

�9�(

+!98(-�!�

A9��

+!9)8-A��

A9)�

+)9�$-A$�

8�9$(

+)9��-A��

889��

+�9�!-�� �� �� �� �� ��

8$<���

+!!�(-���

� �

��������

����

����!��

!9((

+$9�A-)��

)9��

+(9$(-)��

�98�

+!9�$-��(

�9�(

+!9!�-�)�

A9!(

+)9��-A8�

8�9$�

+)9)!-A(�

8898(

+�9�8-�� �� �� �� �� �� �� ��

8$<(��

+!�$(-���

���

�������

����

����!A�

)9�(

+(9�!-)$(

)9A�

+(9�A-)A�

�9!(

+!9$(-��(

A9$(

+)9�(-���

8�9��

+)9!�-A��

8898�

+�9��-�� �� �� �� �� �� �� �� �� ��

8(<���

+)���-� �

�� �

������

����

�����)�(

)9!(

+(9)8-)((

�9(�

+!9�$-���

A9��

+!9A$-�$(

8�98�

+)9(�-�A�

889��

+�9�8-�� �� �� �� �� �� �� �� �� �� �� ��

BOLD ITALIC INDICATES FIELD FURNISHED DRIVE

Page 13: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

13

Guide SpecificationsGeneral - Furnish and install single package air to air DX

mechanical cooling system or cooling and gas fired heating system,complete with automatic controls. The single package unit shall be astandard product of a firm regularly engaged in the manufacture of heating-cooling equipment. The manufacturer shall have parts and service availablethroughout the U.S. and Canada. The equipment shall be shipped completelyfactory assembled, precharged, piped and wired internally ready for fieldconnections. The manufacturer shall test operate system at the factory beforeshipment.

Air Distribution - Equipment shall be capable of bottom (down-flow) or side (horizontal) handling of conditioned air. Horizontal air shallrequire optional horizontal conversion kit.

Approvals - All electrical components shall have ETL and C.G.A.Listing. All wiring shall be in compliance with NEC and CEC.

Equipment Warranty - Aluminized steel heat exchangers shallhave a limited warranty for a full ten years. (LGA Models). Compressorshave a limited warranty for a full five years. All other components have alimited warranty for one year.

Heating System (LGA Models) - Tubular heat exchanger andinshot type gas burners shall be constructed of aluminized steel. Controlsshall consist of direct spark ignition, electronic flame sensor controls, flamerollout switch, limit controls and automatic redundant dual gas valve withstaging control and combusiton air proving switch on induced draft blower.Unit shall be available for use with LPG/propane as an option. Heatexchanger shall be removable for servicing. Complete service access shallbe provided for controls and wiring. Shall be ETL/C.G.A. design certified foroutdoor installation.

Cooling System - The coils shall be nonferrous constructionwith aluminum fins mechanically bonded to durable copper tubes. Coils shallbe pressure leak tested. Compressor shall be resiliently mounted, haveoverload protection and crankcase heater(s). The refrigeration system shallhave discharge, suction and liquid line service gauge ports, high pressureswitch(es), low pressure switch(es) driers, freezestats, and full refrigerantcharge. All models shall have low ambient operation down to 0oF (-17.7oC).All models shall be rated in accordance with ARI Standard 340-360-93.

Cabinet - Shall be galvanized steel with a powdered enamel paintfinish electrostatically bonded to the metal. Cabinet panels where condi-tioned air is handled shall be fully insulated to prevent sweating andminimize sound. Openings shall be provided for power connection entry.Indoor coil condensate drain extended outside cabinet shall be provided.Lifting holes shall be provided for rigging. Bottom power and gas entry shallbe provided.

Service Access - Cabinet panels shall be hinged with tool-lessaccess for compressor/heating/controls, blower and air filter/economizercompartments.

Supply Air Blowers - Centrifugal supply air blower shall bedriven by a belt drive motor with ball bearings and adjustable drive. Blowerassembly shall be accessible for servicing. Belt drive motor mount baseshall permit ease of motor changeover and belt tension adjustment. Blowerwheel shall be statically and dynamically balanced.

Outdoor Coil Fan - Direct drive propeller type outdoor coil fanshall discharge vertically and be direct driven. Fan motor shall have ballbearings and be permanently lubricated and inherently protected. Fan shallhave a safety guard.

Air Filters - Disposable 2 inch (51 mm) thick pleated filters shallbe furnished.

Optional AccessoriesAdditive Electric Heaters - (LCA Models) Electric heaters shall

be available for field installation. Heating elements shall be nichrome barewire exposed directly to the air stream. Time delays shall bring the elementson and off in sequence with a time delay between each element. Limitcontrols shall provide overload and short circuit protection.

Ceiling Diffusers - Furnish and install a (flush orstepdown) optional combination ceiling supply and return air diffuser.Supply and return transitions shall be available, for field installationin the roof mounting frame, to provide duct connections to thediffuser.

Coil Guards - Furnish and install galvanized steel coilguards.

Dirty Filter Switch - Furnish and install pressure switchthat indicates dirty filter.

Disconnect - Furnish and factory install unit disconnectswitch.

Economizer Section - Furnish and install economizercomplete with recirculated air dampers, outside air dampers andcontrols. Low leakage dampers shall ride in nylon bearings. Theeconomizer section shall provide for the introduction of outdoor air forminimum ventilation and free cooling. Integrated economizer controlshall allow compressors to cycle for additional cooling, as needed.Damper actuator shall be opposing gear driven, 24 volt, fullymodulating design. Plug-in control board (IMC) shall consist ofadjustable minimum positioner, enthalpy setpoint and DIP switchesfor setting type of control log used. Economizer control options shallconsist of sensible temperature, global, outdoor enthalpy anddifferential enthalpy (outdoor and return air). Optional outdoor air hood(required) with filters shall be galvanized steel with a powderedenamel paint finish electrostatically bonded to the metal. Economizershall be available for field installation.

Gravity Exhaust Dampers - Pressure operated dampersshall be available for field installation. Extruded aluminum dampersshall prevent blow-back and outdoor air infiltration during off cycle.

Hail Guards - Furnish and install heavy gauge, paintedsteel hail guards.

Horizontal Gravity Exhaust Dampers - Pressureoperated dampers shall be available for field installation in the returnair duct. Extruded aluminum dampers shall prevent blow-back andoutdoor air infiltration during off cycle.

Indoor Air Quality Sensor - Furnish and field installsensor to monitor CO2 levels, relays information to IntegratedModule Control which adjusts economizer dampers proportionately tothe pollutant level.

Outdoor Air Damper Section - Optional outdoordampers shall be available to provide outdoor air requirements of upto 25%. Models shall be available for manual or automatic operation.Dampers shall be opposing gear driven design. Motorized dampersection shall install internal to the unit. Optional outdoor air hood(required) with filters shall be galvanized steel with a powderedenamel paint finish electrostatically bonded to the metal. Dampersshall be available for field installation.

Power Exhaust Fan - Shall be available for all modelswith economizer (down-flow applications only). Direct drive propellertype fan shall exhaust air through optional gravity exhaust damper(required). Motor shall be overload protected. Fan shall be fieldinstalled between economizer and gravity exhaust dampers.

Page 14: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

1414 LCA/LGA36014

Factory Installed Drive Kit Specifications

Field/Factory Installed Accessory Air Resistance

��*�7����

,�����3 ������( ��� ��(' ��&�� *�+��+ �#-�$

0 �

�����*�����

����� ���5:('��+ *�#���

��� ��$5� (�*�(�� ��

#������� ��$5(�����2 *

��*�2������3��"

�������+

;*�� ("� ��� 1�����*��� �� ��+'�� ��

)(�� �($� 9�)�+8)- 98(�+�)- 9�(�+!�- 9��� +)- 9��� +(- 988�+�)-

���� �))( 9���+��- 98)�+$�- 9���+)�- 9��� +)- 9��� +(- 98��+��-

�(�� $�8� 9���+��- 9���+(�- 9�8�+))- 9�$�+8�- 9��� +)- 98(�+�)-

A��� $�$( 9�A�+��- 9���+((- 9�$�+�(- 9�$�+8�- 9�$�+8�- 98)�+$�-

A(�� $$�( 98��+�(- 9�$�+!�- 9���+A$- 9�(�+8�- 9�$�+8�- 98A�+$)-

8�<��� $)�� 988�+�)- 9�)�+!)- 9$��+8�$- 9�(�+8�- 9�(�+8�- 9�8�+(�-

8�<(�� $A(( 98��+��- 9���+)(- 9$!�+88$- 9�!�+8(- 9�!�+8(- 9�$�+!�-

88<��� (8A� 98��+��- 9���+A�- 9(��+8�)- 9�!�+8(- 9�)�+8)- 9�)�+!)-

88<(�� ($�( 98��+��- 9�)�+A�- 9((�+8�)- 9�)�+8)- 9���+��- 9���+)(-

8�<��� (!!( 98$�+�(- 9$��+AA- 9!��+8$A- 9�)�+8)- 98��+�(- 9���+��-

8�<(�� (A�� 98(�+�)- 9$$�+8�A- 9!(�+8!�- 9���+��- 988�+�)- 9�)�+A�-

8�<��� !8�( 98!�+$�- 9$��+88A- 9)��+8)$- 9���+��- 98��+��- 9$��+AA-

8�<(�� !�)� 98)�+$�- 9(��+8��- 9)!�+8�A- 9�A�+��- 98$�+�(- 9$$�+8�A-

8$<��� !!�( 98��+$(- 9()�+8$�- 9���+��$- 98��+�(- 98!�+$�- 9$A�+8��-

8$<(�� !�$( 98A�+$)- 9!��+8($- 9�A�+��8- 98��+�(- 98��+$(- 9(��+8��-

8(<��� )��� 9���+(�- 9!��+8!A- 9A(�+��!- 988�+�)- 9�8�+(�- 9(��+8$$-

����*�9�� ��� 3-��3��+

��������' ��:����

'

�������

.0

��:����

.0/*�% � /*�% �! /*�% �� /*�% �A /*�% �=

5� �; �;���( (9)( �9) $9� !!�����8� ))����A!( M M M

LL5� �; �;���)9( )9( (9! !9$ M M )8(������ LL))����A!( M

5� �; �;��� 8� 889( )9( �9! M M )8(������ M �(����8�$(

L� ������� �� ��� ���1�� �;� � ��� � ���� �� 1�� �61����� � ;������ :����2��%����:��� ��� � 2� ����� �;������� �1��1�� �61��;9�. D��1��1 2�

�1��1�� �:������ �:1��� �;� �� ��%�9�B:� � � ; <� ����� �������� �1��1��� � � ��� D��1��1 2�������� �1��1�9�B:������ ��:����� � 2���1��1�� ��1 ;<�2

1�� ��� ���%��������� ����� : ����� ����� ���� � �1����;���� ��������� � ��� �9

LL> �1���

Page 15: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

15

Guide Specifications

Ceiling Diffuser Air Resistance

�����1�2

��*�7���� ,�����3 ������( ��� ��(' ��&�� *�+��+ �#-�$

��3,/������1� �/�&��/�""�� *��;/������;���'

/�""�� *("� ��� !�5����9 ��1�� �!�5���

9 �

����5����6�1�� �

9 �

�!��.�;�

)(�� �($� 9�)�+A�- 9�8�+))- 9�(�+!�- 9�A�+)�-

���� �))( 9$��+8�$- 9�!�+A�- 9�A�+)�- 9�$�+�(-

�(�� $�8� 9$��+88A- 9$8�+8��- 9�$�+�(- 9�A�+A)-

A��� $�$( 9((�+8�)- 9$)�+88)- 9�A�+A)- 9$$�+8�A-

A(�� $$�( 9!��+8($- 9(��+8��- 9$(�+88�- 9(8�+8�)-

8�<��� $)�� 9)��+8)$- 9!��+8$A- 9(8�+8�)- 9()�+8$�-

8�<(�� $A(( 9)��+8A$- 9!��+8!A- 9(��+8$$- 9!(�+8!�-

88<��� (8A� 9�)�+�8!- 9)!�+8A�- 9!(�+8!�- 9)��+8)A-

88<(�� ($�( 9A)�+�$8- 9�(�+�88- 9)��+8��- 9�8�+��8-

8�<��� (!!( 89���+�!A- 9A$�+��$- 9���+��$- 9A��+���-

8�<(�� (A�� 898A�+�A!- 89�$�+�(A- 9A8�+��!- 9AA�+�$!-

8�<��� !8�( 89���+���- 898(�+��!- 89���+�$A- 898��+�)$-

8�<(�� !�)� 89$��+�(!- 89�!�+�8�- 898��+�)$- 89���+�A�-

8$<��� !!�( 89(!�+���- 89���+�$�- 89���+�A�- 89�8�+��!-

8$<(�� !�$( 89!A�+$��- 89(��+�)�- 89�8�+��!- 89$��+�(!-

8(<��� )��� 89�$�+$()- 89!��+$�(- 89$��+�(!- 89(!�+���-

3 ��*����*�1��� ��1����(

-* ���* ��*�7���� �5:'���� �

����&�+� -� ("� ���

� � 8�<��� !<�$�

9�( 8� 8�<��� (<)!�

98� �( 88<(�� (<$��

98( �) 8�<��� (<8��

9�� (� A<A�� $<!)�

9�( !� A<��� $<�(�

9�� )( )<A�� �<)��

9�( �) !<)(� �<8A�

9$� 8�� (<$(� �<()�

9$( 88� $<8(� 8<A!�

9(� 8�( �<A�� 8<�)�

��� �

���

��*�7����

<5"" (��% �,'*�&�3��+

��3,/�����

1� �/�&�

��;/�����

;���'

("� ��� "�� � "�� �

�!�

.�;�

A<��� $�$( $����$) 8����8$ �A����( ����88

A<(�� $$�( $����(� 8����8( �����$8 8����8�

8�<��� $)�� $!���($ 8$���8! �)���$! 88���8$

8�<(�� $A(( (����(� 8(���8� $����(8 8����8(

88<��� $8A� (����!8 8!���8A $!���(! 8$���8)

88<(�� ($�( ((���!$ 8)����� (����!8 8(���8A

8�<��� (!!( (����!) 8������ ($���!! 8!�����

8�<(�� (A�� !8���)8 8A����� (����)8 8������

8�<��� !8�( !$���)$ ������� !����)( 8A�����

8�<(�� !�)� !)���)) ������� !!���)A ������$

L����%� � � ����"��� ���������� �� ;� � ��� �� �� �� �� �� �� � ��� � ����

����1�������;�::1 ��2:��� ���� D��1����������� � �;1�;� ���(�� :�9

+8(��-�������1�9� C�1�� �; � ���9

Power Exhaust Fans Performance Ceiling Diffuser Air Throw Data

Roof Mounting Frame - Furnish and install a steel roof mounting frame for bottom discharge and return air duct connection. It shall mate to thebottom discharge and return air duct connection. It shall mate to the bottom perimeter of the equipment. When flashed into the roof it shall make a unitmounting curb and provide weatherproof duct connection and entry into the conditioned air. Flashing shall be the responsibility of the roofing contractor. Frameshall be approved by U.S. National Roofing Contractors Association.

Service Outlets - Furnish and factory install dual 115 volt, 15 amp GFCI type service outlets. Wiring shall be field provided.Smoke Detectors - Furnish and field install photoelectric type smoke detector in either or both return air section and supply air section.Terminal Block - Shall be required for units without disconnect switch but with single point power supply and electric heat.

Page 16: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

1616 LCA/LGA36016

Corner Weights - lbs. (kg)

Dimensions - LCA Model - inches (mm)

Center of Gravity - inches (mm)

Shown with Electric Heat, Economizer Dampers, Power Exhaust Fan, Convenience Outlet, Disconnect

Belt Drive Blower

������������ �� ��

��� �� ��� �� ��� �� ��� ������������ � �� ��� ��� ��� ��� ��� ��� ��� ���

������� ���� � �� ��� ��� ��� ��� ���� ��� ���� ���

����� ������������ �� ��������������������

����������������� �� ����� ����������������������� �������� �!��"������

������� #���"�$�%����&��$����%� �� � '������(

������������ ��

���� ����

����� ����� � �� �� ���� ���� �� ���

������� ���� � �� �� ���� ���� �� ���� ���

����� ������������ �� ��������������������

����������������� �� ����� ����������������������� �������� �!��"������

������� #���"�$�%����&��$����%� �� � '������(

Page 17: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

17

Corner Weights - lbs. (kg)

Dimensions - LGA Model - inches (mm)

Center of Gravity - inches (mm)

Shown with Electric Heat, Economizer Dampers, Power Exhaust Fan, Convenience Outlet, Disconnect

Belt Drive Blower

������������ �� ��

��� �� ��� �� ��� �� ��� ������������ � �� ��� ��� ��� ��� ���� ��� ���� ���

������� ����� �� ��� ��� ��� ��� ���� ��� ���� ���

����� ������������ �� ��������������������

����������������� �� ����� ����������������������� �������� �!��"������

������� #���"�$�%����&��$����%� �� � '������(

������������ ��

���� ����

����������� �� ������ ���� ������ ���

������������ �� ������ ���� ������ ���

����� ������������ �� ��������������������

����������������� �� ����� ����������������������� �������� �!��"������

������� #���"�$�%����&��$����%� �� � '������(

Page 18: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

1818 LCA/LGA36018

Typical Flashing Detail for

LARMF18/36 Roof Mounting

Frame

Accessory Dimensions - inches (mm)LARMF18/36-14 & LARMF18/36-24 - Roof Mounting Frame (Double Duct

Opening)

Roof Mounting Frame Specifications

/��:�.�1������:� ��� �����;���1������2� � ��;����� �� ������ �����

���� ������;��:� 1�����;����2���� �; ��:�������:��� ����9

5������ �������-� %�5��#$/'0*#) %�5��#$/'0*�)

L.������:� ����� � +B-� +��9$-� +��$- �A�+8!�$- 8!��+!!�A-

L5��������;1�1 � B���+��9�-� +���- (9(� +A�- 8�98� +(8�-

C� ��%����� +�2�:�-� +����-��:� ����� (9(� +�9�- �9(� +8�9)-

4 ���� �������+� �-� +�� - ��<����+8�)<A��-

LB���1; �2���� �; � �:� :� �

Page 19: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

19

LARMF18/36-14 and LARMF18/36-24 Roof Mounting Frames with

LASRT36 Supply & Return Air Transitions for LARTD30/36 &

LAFD30/36 Ceiling Diffusers

Accessory Dimensions - inches (mm)

LARMFH30/36-30 & LARMFH30/36-41 Horizontal Roof Mounting

Frames (Requires Optional Horizontal Return Air Panel Kit)

Page 20: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

Accessory Dimensions - inches (mm)LARTD30/36

Step-Down Ceiling Diffuser

LAFD30/36

Flush Ceiling Diffuser

LAGEDH30/36 Horizontal Gravity Exhaust Dampers Field Installed in

Return Air Duct (two furnished per order no.)

Page 21: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

Installation Cearances - inches (mm)Unit With Economizer

Unit With Horizontal Gravity Exhaust Dampers

Page 22: Packaged L Series LCA/LGA · E.T.L. and C.G.A. listed, efficiency rating verified by C.S.A., components bonded for grounding to meet safety standards for servicing required by ETL/CGA

All specifications are subject to changewithout notice.

Armstrong Air Conditioning Inc.A Lennox International Inc. Company

421 Monroe Street • Bellevue, OH 44811(419) 483-4840

Form #LCA/LGA360-100 (4/01) ©Armstrong Air Conditioning Inc. 2001Printed in U.S.A.

*LCA-LGA360-100-4-01*